Post on 15-Jan-2016
transcript
1
Implementation of the Programof Energy Efficiency of
Kiev region
2
Investment project
“Organization of the manufacture of
heat pumps, calculation and regulation units for heat energy and hot water supply,
module resource-saving boiler systems on the base of condensation boilers
for modernization of the heating system of housing and communal services”
33
Enabled to spare: Gas tо 40 %
Electricity to 50%
Enabled to reduce:
Heating and hot water supply cost by 35-40%
Cost price of equipment maintenance by 50 %
4
Advantages: Possibility to change the heat power of the condensation
boiler system with invariable efficiency factor (98%) subject to the ambient temperature.
The module installation construction enables to repair the equipment without heating boiler system stopping to increase the safety and reduce the repair cost.
The equipment ease enables to mount it without special lifting equipment. The roof location excludes costs for the boiler foundation and enables to reduce the flue height.
Low emissions:СО – 50 mg/m3, NOx – 15 mg/m3.
5
Implementation:
4700 heating boiler systems “Ukrinterm” are regularly working
on the territory of Ukraine.
6
The investment project features:The whole amount – 25,3 million UAHFunding sources:- Own funds – 14 million UAH - Credit funds – 10,3 million UAHProject terms – II quarter of 2008 – II quarter 2013
Project efficiency Saving rate (profit) – 22,2 million UAH Production – 195,6 million UAH Budget efficiency – 9,1 million UAH Social efficiency – reduction of the high reacting fuel import, using working places –
215, new - 57, high service quality (heating and hot water supply) Ecological efficiency:
- No pollution of sewage- No waste products- NOx reduction- Heat loss reduction in process of heat transportation to consumer- Natural gas consumption reduction.
7
Investment project execution “UKRINTERM” provides 55% project execution on the state of the
1st of January 2011 at the expense of own funds, notably:
The engineering building of “UKRINTERM” for heat pump production (at the address 307a, P.Zaporozhtsya str., Bila Tserkva, Kiev region) is set in operation
DSTU “Design of the heatingsystems with heat pumps” Б В.2.5.-44:2010 (EN 15450:2007, MN-240 patentMOD) is developed and approved
8
New working area (2,5 thousand m²)
Investment project “UKRINTERM”
9
Environmental features of “Ukrinterm” equipment used in the investment project
Harmful substances content in combustion materials
120
240
50
15
0
50
100
150
200
250
300
Carbon monoxide CO Nitric oxides Nox
мg
/м3
, no
t m
ore
Normative document demands
МN-240, МN-500
1010
Heat pumps Heating and conditioning costs
are reduced considerably
No need in gas or the other inflammable type of energy resources
Using of the renewable energy resources
Environmentally safe
1111
Calculation and regulation units for heat energy and hot water supply
Heat supply of the building provided by a heat generator (for example, module heating boiler system “Ukrinterm”) simplifies the system maintenance, raises its reliability and safety, minimizes costs for system control and makes it more efficient.
The units allow to organize the assessment of consumed heating and cold water by a separate flat.
The units give the ability to turn off the heating and water supply to non-payer's flats.
The whole pipeline system of the building is reduced.
1212
Module boiler systems “Ukrinterm” based on the condensation heating modules
MN-240 and МN-500
Module heating boiler system Heating module Heating module fragment МN-240 МN-500
13
The positive experience of the co-operation in investment project implementation
Co-operation memorandumBetween JV “Ukrinterm”, company “TEDOM” (Czech Republic) and
Chamber of Commerce and Industry (Ivano-Frankivsk) :
Manufacture of the cogeneration units on the base of “JV “Ukrinterm”; Implementation of the new energy saving measures to produce the energy
efficient equipment and technologies; Establishment of the joint venture to sale the heat energy and electricity; Planner specialist training in cogeneration using; Technical assistance and consultations in cogeneration equipment
selection.