Post on 22-Mar-2021
transcript
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 1
CONF ALLAIRBUS2, ROND POINT EMILE DEWOITINE31700 BLAGNACFRANCE The content of this document is the property of Airbus.It is supplied in confidence and commercial security on its contents must be maintained.It must not be used for any purpose other than that for which it is supplied, nor may informationcontained in it be disclosed to unauthorized persons.It must not be reproduced in whole or in part without permission in writing from the owners of thecopyright. Requests for reproduction of any data in this document and the media authorized for it mustbe addressed to Airbus.
ATA SYSTEM: 27
TITLE: FLIGHT CONTROLS - FLIGHT CONTROL PRIMARY COMPUTER (FCPC)-REPLACE 2K0 AND 2K1 FCPC HARDWARE BY 2K2 FCPC HARDWARE
MODIFICATION No.:208335S34936
A330SERVICE BULLETIN
SUMMARY
REV 00 May 21/19 A330-27-3235Page 2
ATA SYSTEM: 27
TITLE: FLIGHT CONTROLS - FLIGHT CONTROL PRIMARY COMPUTER (FCPC)-REPLACE 2K0 AND 2K1 FCPC HARDWARE BY 2K2 FCPC HARDWARE
SUMMARYThis summary is for information only and is not approved for modification of the aircraft.A. MODIFICATIONS
CONF 001
MODIFICATION CLASSIFICATIONMAJOR NoneMINOR 208335S34936
NOTE: As per EASA IR 21, a minor change is one that has no appreciable effect on themass, balance, structural strength, reliability, operational characteristics affectingthe airworthiness of the product. All other changes are major changes.
CONF 002
MODIFICATION CLASSIFICATIONMAJOR NoneMINOR 208335S34936
NOTE: As per EASA IR 21, a minor change is one that has no appreciable effect on themass, balance, structural strength, reliability, operational characteristics affectingthe airworthiness of the product. All other changes are major changes.
CONF ALLB. REASON
(1) HistoryAn Airworthiness Directive (AD) is anticipated on “Stop Rudder Input Warning” function(SRIW) applicable to A330-200 and A330-300 models aircraft with mechanical ruddercontrol (MOD No. 49144S16279 is not embodied).As mentioned by OIT 999.0020/16–01 and by Ref. ISI 27.90.00045, this anticipated ADon SRIW will entail the replacement of 2K0 and 2K1 Flight Control Primary Computer(FCPC) hardware by 2K2 FCPC hardware.Airbus recommends operators to initiate this FCPC 2K0/2K1 hardware replacementas soon as possible by contacting equipment supplier (refer to paragraph 2.D of thisService Bulletin).
(2) Objective/ActionThis Service Bulletin enables the replacement of FCPC standards M25 (2K0 hardware)and P16/M25 (2K1 hardware) by FCPC P15/M24 (2K2 hardware).To accomplish this Service Bulletin, FCPCs have to be replaced on aircraft.
(3) AdvantagesAccomplishment of this Service Bulletin introduces FCPC 2K2 hardware (FCPC P15/M24(2K2) standard) in order to:
A330SERVICE BULLETIN
SUMMARY
REV 00 May 21/19 A330-27-3235Page 3
- Enable compliance with expected AD on SRIW function (refer to OIT 999.0020/16Rev 01 and Ref. ISI 27.90.00045)
- Take benefits of the improved reliability of 2K2 FCPC hardware- Enable the implementation of future FCPC software evolutions (refer to Ref. ISI
27.93.00007).(4) Operational/Maintenance Consequences
NoneC. GENERAL EVALUATION
EVALUATION TABLECOMPLIANCE RECOMMENDED COST SAVING NOA/C OPERATIONAFFECTED
NO VENDOR SB NO
CANCELS INSPECTION SB NO ETOPS AFFECTED NOPAX COMFORT AFFECTED NO POTENTIAL AD NORELIABILITY AFFECTED YES STRUCTURAL LIFE EXTENSION NOLIFE LIMIT NO LINE MAINTENANCE AFFECTED YES
NOTE: Service Bulletin recommended to be accomplished to prevent significantoperational disruptions.
D. MAINTENANCE CONFIGURATIONCONF 001
No specific aircraft maintenance configuration required.CONF 002
No specific aircraft maintenance configuration required.CONF ALL
E. MATERIAL PRICE INFORMATIONCONF 001
(1) Modification(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
MATERIAL PRICE INFORMATION TABLE
MATERIAL SET QTYPER A/C PRICE PER A/C MAIN PARTS
Equipment See SB See Note FCPCs
NOTE: Price information to be obtained from the given supplier.
CONF 002(1) Modification
A330SERVICE BULLETIN
SUMMARY
REV 00 May 21/19 A330-27-3235Page 4
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
MATERIAL PRICE INFORMATION TABLE
MATERIAL SET QTYPER A/C PRICE PER A/C MAIN PARTS
Equipment See SB See Note FCPCs
NOTE: Price information to be obtained from the given supplier.
CONF ALLF. APPLICABILITY
This Service Bulletin is applicable to this (these) operator(s):38W 39N 39V 57L 77L 83V 98W AAF AAL ABR ACA ACI AEA AFR ALK ARG AZA AZU BEL CPACRK CRL CSA DGA EIN F2I FWI G8E GFA GIA GRL HDA HFM HFY ISS JAV KAL MLM OHY PLMQAF QFA QTR RSY SAS SXD TAM TAP TCX THA TSC U6A UAE VIR VKG WRC XLF
G. CONCURRENT REQUIREMENTSAccomplishment of this Service Bulletin requires the prior or simultaneous accomplishmentof the following Service Bulletin(s).
Service Bulletin(s) Modification(s)Ref. SB A330-27-3223 206412S33844 206413S33845
H. NATURE OF THE WORKCONF 001
(1) Modification(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
AIRCRAFT NOEQUIPMENT YES
CONF 002(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
AIRCRAFT NOEQUIPMENT YES
CONF ALLI. MANPOWER
CONF 001(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
MANPOWERTOTAL MAN-HOURS 2.50 hELAPSED TIME (HOURS) 2.50 h
CONF 002
A330SERVICE BULLETIN
SUMMARY
REV 00 May 21/19 A330-27-3235Page 5
(1) Modification(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
MANPOWERTOTAL MAN-HOURS 2.50 hELAPSED TIME (HOURS) 2.50 h
A330SERVICE BULLETIN
SUMMARY
Figure ICN-A330-A-27XX3235-A-FAPE3-000C8-A-001-01 SHEET 1/1REV 00 May 21/19 A330-27-3235General overview
Page 6
CONF ALLJ. GENERAL OVERVIEW
CONF ALL
Z120
FR20
FR1
B800VU
915VU
A
MODIFICATION OF THE FCPCB
A
2CE1
MODIFICATION OF THE FCPC
MODIFICATION OF THE FCPC
2CE2
2CE3
ICN-A330-A-27XX3235-A-FAPE3-000C8-A-001-01
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 7
ATA SYSTEM: 27
TITLE: FLIGHT CONTROLS - FLIGHT CONTROL PRIMARY COMPUTER (FCPC)-REPLACE 2K0 AND 2K1 FCPC HARDWARE BY 2K2 FCPC HARDWARE
1. PLANNING INFORMATIONA. APPLICABILITY
NOTE: This modification is applicable by Service Bulletin only.
NOTE: This Service Bulletin is only applicable to aircraft on which FCPC 2K2 hardwarehas not been introduced through the application of SB A330-27-3222 (MOD No.206414S33846 - FCPC P15/M24 (2K2)) and on which FCPC M25 (2K0) or FCPC P16/M25 (2K1) standards were introduced through the application of SB A330-27-3223(MOD No. 206412S33844 or MOD No. 206413S33845).
(1) ModelsON A/C 0211, 0269, 0272, 0330, 0339, 0397, 0441, 0473, 0487, 0489, 0506-0508, 0510,0511, 0513, 0521, 0522
330-202ON A/C 0422, 0443, 0448, 0458, 0463, 0465, 0466, 0472, 0477, 0481, 0486, 0498, 0500,0502-0504, 0516, 0519, 0530, 0535, 0567, 0584, 0657
330-203ON A/C 0181, 0195, 0222, 0223, 0226, 0229, 0230, 0232, 0238, 0240, 0247, 0249, 0253,0255, 0258, 0259, 0262, 0275, 0288, 0290, 0291, 0296, 0300, 0305, 0308, 0312, 0317,0322, 0324, 0343, 0353, 0358, 0361, 0362, 0364, 0366, 0403, 0432, 0444, 0454, 0469,0476, 0493
330-223ON A/C 0248, 0250, 0251, 0254, 0261, 0265, 0266, 0271, 0276, 0281, 0283, 0285-0287,0293, 0295, 0301, 0303, 0306, 0309, 0311, 0313, 0314, 0316, 0320, 0326, 0328, 0334,0340, 0345, 0348, 0365, 0369, 0372, 0382, 0384, 0392, 0396, 0398, 0401, 0404, 0409,0427, 0437, 0451, 0452, 0455, 0456, 0461, 0462, 0480, 0491, 0494, 0501, 0505, 0509,0518, 0525-0527, 0529, 0532, 0536, 0551, 0597, 0627, 0635
330-243ON A/C 0030, 0037, 0045, 0054, 0055, 0070, 0086, 0200
330-301ON A/C 0050, 0060, 0062, 0065, 0112, 0122
330-321ON A/C 0072, 0082, 0087, 0095, 0096, 0116, 0120, 0127, 0143, 0162, 0171, 0172, 0206,0209, 0219, 0224, 0231, 0241
330-322ON A/C 0256, 0267, 0315, 0323, 0333, 0337, 0338, 0342, 0346, 0350, 0351, 0368, 0370,0375, 0380, 0388, 0425, 0428, 0484, 0490, 0550
330-323ON A/C 0138, 0140, 0144, 0148, 0153, 0165
330-341ON A/C 0012, 0017, 0071, 0083, 0099, 0102, 0106, 0109, 0111, 0113, 0118, 0121, 0132,0155, 0177, 0234, 0244
330-342
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 8
ON A/C 0277, 0279, 0284, 0344, 0349, 0356, 0357, 0386, 0389, 0393, 0400, 0405, 0407,0408, 0412, 0418-0421, 0423, 0439, 0479, 0496, 0497, 0512, 0515, 0539, 0548, 0565, 0568,0581
330-343CONF ALL
(2) Applicability by MSN0012 0017 0030 0037 0045 0050 0054 0055 0060 0062 0065 0070-0072 0082 00830086 0087 0095 0096 0099 0102 0106 0109 0111-0113 0116 0118 0120-0122 01270132 0138 0140 0143 0144 0148 0153 0155 0162 0165 0171 0172 0177 0181 01950200 0206 0209 0211 0219 0222-0224 0226 0229-0232 0234 0238 0240 0241 02440247-0251 0253-0256 0258 0259 0261 0262 0265-0267 0269 0271 0272 0275-02770279 0281 0283-0288 0290 0291 0293 0295 0296 0300 0301 0303 0305 0306 03080309 0311-0317 0320 0322-0324 0326 0328 0330 0333 0334 0337-0340 0342-03460348-0351 0353 0356-0358 0361 0362 0364-0366 0368-0370 0372 0375 03800382 0384 0386 0388 0389 0392 0393 0396-0398 0400 0401 0403-0405 0407-04090412 0418-0423 0425 0427 0428 0432 0437 0439 0441 0443 0444 0448 0451 04520454-0456 0458 0461-0463 0465 0466 0469 0472 0473 0476 0477 0479-0481 04840486 0487 0489-0491 0493 0494 0496-0498 0500-0513 0515 0516 0518 0519 05210522 0525-0527 0529 0530 0532 0535 0536 0539 0548 0550 0551 0565 0567 05680581 0584 0597 0627 0635 0657
(3) MSN by configurationCONF 001
MSN CONFIGURATION0012 0017 0030 0037 0045 0050 0054 0055 0060 0062 00650070 0071 0072 0082 0083 0086 0087 0095 0096 0099 01020106 0109 0111 0112 0113 0116 0118 0120 0121 0122 01270132 0138 0140 0143 0144 0148 0153 0155 0162 0165 01710172 0177 0181 0195 0200 0206 0209 0211 0219 0222 02230224 0226 0229 0230 0231 0232 0234 0238 0240 0241 02440247 0248 0249 0250 0251 0253 0254 0255 0256 0258 02590261 0262 0265 0266 0267 0269 0271 0272 0275 0276 02770279 0281 0283 0284 0285 0286 0287 0288 0290 0291 02930295 0296 0300 0301 0303 0305 0306 0308 0309 0311 03120313 0314 0315 0316 0317 0320 0322 0323 0324 0326 03280330 0333 0334 0337 0338 0339 0340 0342 0343 0344 03450346 0348 0349 0350 0351 0353 0356 0357 0358 0361 03620364 0365 0366 0368 0369 0370 0372 0375 0380 0382 03840386 0388 0389 0392 0393 0396 0397 0398 0400 0401 04030404 0405 0407 0408 0409 0412 0418 0419 0420 0421 04220423 0425 0427 0428 0432 0437 0439 0441 0443 0444 04480451 0452 0454 0455 0456 0458 0461 0462 0463 0465 04660469 0472 0473 0476 0477 0479 0480 0481 0484 0486 04870489 0490 0491 0493 0494 0496 0497 0498 0500 0501 05020503 0504 0505 0506 0507 0508 0509 0510 0511 0512 05130515 0516 0518 0519 0521 0522 0525 0526 0527 0529 05300532 0535 0536 0539 0548 0550 0551 0565 0567 0568 05810584 0597 0627 0635 0657
001
CONF 002
MSN CONFIGURATION0012 0017 0030 0037 0045 0050 0054 0055 0060 0062 00650070 0071 0072 0082 0083 0086 0087 0095 0096 0099 0102
002
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 9
MSN CONFIGURATION0106 0109 0111 0112 0113 0116 0118 0120 0121 0122 01270132 0138 0140 0143 0144 0148 0153 0155 0162 0165 01710172 0177 0181 0195 0200 0206 0209 0211 0219 0222 02230224 0226 0229 0230 0231 0232 0234 0238 0240 0241 02440247 0248 0249 0250 0251 0253 0254 0255 0256 0258 02590261 0262 0265 0266 0267 0269 0271 0272 0275 0276 02770279 0281 0283 0284 0285 0286 0287 0288 0290 0291 02930295 0296 0300 0301 0303 0305 0306 0308 0309 0311 03120313 0314 0315 0316 0317 0320 0322 0323 0324 0326 03280330 0333 0334 0337 0338 0339 0340 0342 0343 0344 03450346 0348 0349 0350 0351 0353 0356 0357 0358 0361 03620364 0365 0366 0368 0369 0370 0372 0375 0380 0382 03840386 0388 0389 0392 0393 0396 0397 0398 0400 0401 04030404 0405 0407 0408 0409 0412 0418 0419 0420 0421 04220423 0425 0427 0428 0432 0437 0439 0441 0443 0444 04480451 0452 0454 0455 0456 0458 0461 0462 0463 0465 04660469 0472 0473 0476 0477 0479 0480 0481 0484 0486 04870489 0490 0491 0493 0494 0496 0497 0498 0500 0501 05020503 0504 0505 0506 0507 0508 0509 0510 0511 0512 05130515 0516 0518 0519 0521 0522 0525 0526 0527 0529 05300532 0535 0536 0539 0548 0550 0551 0565 0567 0568 05810584 0597 0627 0635 0657
CONF ALL(4) Configuration definition
CONF 001Configuration 001
CONF 001 is applicable for all the aircraft on which MOD No. 206412S33844 isembodied (FCPC standard M25 (2K0 hardware) installed).CONF 001 retrofits following modifications: 208335S34936.
CONF 002Configuration 002
CONF 002 is applicable for all the aircraft on which MOD No. 206413S33845 isembodied (FCPC standard P16/M25 (2K1 hardware) installed).CONF 002 retrofits following modifications: 208335S34936.
CONF ALLB. CONCURRENT REQUIREMENTS
Accomplishment of this Service Bulletin requires the prior or simultaneous accomplishmentof the following Service Bulletin(s).
Service Bulletin(s) Modification(s)Ref. SB A330-27-3223 206412S33844 206413S33845
C. REASON
(1) HistoryAn Airworthiness Directive (AD) is anticipated on “Stop Rudder Input Warning” function(SRIW) applicable to A330-200 and A330-300 models aircraft with mechanical ruddercontrol (MOD No. 49144S16279 is not embodied).
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 10
As mentioned by OIT 999.0020/16–01 and by Ref. ISI 27.90.00045, this anticipated ADon SRIW will entail the replacement of 2K0 and 2K1 Flight Control Primary Computer(FCPC) hardware by 2K2 FCPC hardware.Airbus recommends operators to initiate this FCPC 2K0/2K1 hardware replacementas soon as possible by contacting equipment supplier (refer to paragraph 2.D of thisService Bulletin).
(2) Objective/ActionThis Service Bulletin enables the replacement of FCPC standards M25 (2K0 hardware)and P16/M25 (2K1 hardware) by FCPC P15/M24 (2K2 hardware).To accomplish this Service Bulletin, FCPCs have to be replaced on aircraft.
(3) AdvantagesAccomplishment of this Service Bulletin introduces FCPC 2K2 hardware (FCPC P15/M24(2K2) standard) in order to:
- Enable compliance with expected AD on SRIW function (refer to OIT 999.0020/16Rev 01 and Ref. ISI 27.90.00045)
- Take benefits of the improved reliability of 2K2 FCPC hardware- Enable the implementation of future FCPC software evolutions (refer to Ref. ISI
27.93.00007).(4) Operational/Maintenance Consequences
NoneD. DESCRIPTION
To accomplish this Service Bulletin it is necessary to:(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A ModificationCONF 001
1 Replace the FCPCs in Avionics CompartmentCONF 002
1 Replace the FCPCs in Avionics CompartmentCONF ALL
E. COMPLIANCE
(1) ClassificationRECOMMENDED: Service Bulletin recommended to be accomplished to preventsignificant operational disruptions.
(2) Accomplishment TimescaleAccomplishment of this Service Bulletin is recommended at the earliest opportunitywhere manpower and facilities are available.
F. APPROVALThe technical content of this document is approved under the authority of DesignOrganization Approval No. EASA.21J.031.If an aircraft listed in the applicability has a modification or repair embodied that is notof AIRBUS origin, and which affects the content of this Service Bulletin, the operatoris responsible for obtaining approval by its airworthiness authority for any adaptationnecessary before incorporation of the Service Bulletin.
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 11
G. MANPOWERCONF 001
The manpower estimates given in this Service Bulletin are based on the direct labor cost todo the work. These estimates assume that the work will be done by experienced personnel,and may need to be revised upwards to suit operator’s circumstances. The estimates do notinclude the time to prepare, plan or inspect the work. Manufacture and procurement of partsand tools, drying times for paints, sealants, etc., and general administration work are alsonot included.(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
PREPARATIONJob Set-up 0.50 h
PROCEDUREReplace the FCPCs in Avionics Compartment 1.00 h
PREPARATION FOR TESTTest Set-up 0.10 h
TESTTesting 0.40 h
CLOSE-UPClose-up 0.50 h
TOTAL MAN-HOURS 2.50 hELAPSED TIME (HOURS) 2.50 h
CONF 002The manpower estimates given in this Service Bulletin are based on the direct labor cost todo the work. These estimates assume that the work will be done by experienced personnel,and may need to be revised upwards to suit operator’s circumstances. The estimates do notinclude the time to prepare, plan or inspect the work. Manufacture and procurement of partsand tools, drying times for paints, sealants, etc., and general administration work are alsonot included.(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
PREPARATIONJob Set-up 0.50 h
PROCEDUREReplace the FCPCs in Avionics Compartment 1.00 h
PREPARATION FOR TESTTest Set-up 0.10 h
TESTTesting 0.40 h
CLOSE-UPClose-up 0.50 h
TOTAL MAN-HOURS 2.50 hELAPSED TIME (HOURS) 2.50 h
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 12
CONF ALLH. WEIGHT AND BALANCE
Not changedI. ELECTRICAL LOAD DATA
Not changedJ. REFERENCES
CONCURRENT SERVICE BULLETIN (SB)A330-27-3223
CONF 001(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
AIRCRAFT MAINTENANCE MANUAL (AMM)06-20-00, Page Block 001 06-31-53, Page Block 00106-41-53, Page Block 001 Task 12-34-24-860-802Task 27-93-34-000-801Task 27-93-34-400-801
ELECTRICAL STANDARD PRACTICES MANUAL (ESPM)20-55-00
IN SERVICE INFORMATION (ISI)27.90.00045 27.93.00007
OPERATOR INFORMATION TELEX (OIT)999.0020/16-01
CONF 002(1) Modification
(a) Task set A330-A-27-XX-3235-01000-93AA-A Modification
AIRCRAFT MAINTENANCE MANUAL (AMM)06-20-00, Page Block 001 06-31-53, Page Block 00106-41-53, Page Block 001 Task 12-34-24-860-802Task 27-93-34-000-801Task 27-93-34-400-801
ELECTRICAL STANDARD PRACTICES MANUAL (ESPM)20-55-00
IN SERVICE INFORMATION (ISI)27.90.00045 27.93.00007
OPERATOR INFORMATION TELEX (OIT)999.0020/16-01
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 13
CONF ALLK. PUBLICATION AFFECTED
ILLUSTRATED PARTS CATALOG (IPC)TROUBLE SHOOTING MANUAL (TSM)
L. INDUSTRY SUPPORT INFORMATIONIndustry support terms for the equipment must be negotiated with the equipment supplier.As per OIT 999.0020/16–01, Airbus recommends to initiate FCPC 2K0/2K1 hardwarereplacement as soon as possible by contacting equipment supplier. Please refer to OIT999.0020/16–01 for further information on FCPC 2K0/2K1 hardware replacement campaign.
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 14
2. MATERIAL INFORMATIONA. MATERIAL APPLICABILITY
CONF 001Material for task set A330-A-27-XX-3235-01000-93AA-A Modification
MATERIAL QTY SEE NOTESEquipment See SB (1)Interchangeable parts See SBNOTE(S)(1): Procurement terms for the equipment must be negotiated with the equipment
supplier.
CONF 002Material for task set A330-A-27-XX-3235-01000-93AA-A Modification
MATERIAL QTY SEE NOTESEquipment See SB (1)Interchangeable parts See SBNOTE(S)(1): Procurement terms for the equipment must be negotiated with the equipment
supplier.
CONF ALLB. TOOLING
No toolsC. CONSUMABLES
No consumablesD. LIST OF NEW PARTS
CONF 001Equipment for task set A330-A-27-XX-3235-01000-93AA-A Modification
Procurement address F6198
AIRBUS OPERATIONS SASAVIONICS & SIMULATION PRODUCTS316 ROUTE DE BAYONNE31060 TOULOUSE CEDEX 09FRANCEPhone: 561957534Fax: 561180494E-mail: systems.support@airbus.com.
NOTE(S)Vendor parts are to be procured from the address given above.
ITEM PART No. QTY (UM) KEYWORD DRAWING SEE NOTESLA2K2B100DH0000(F6198) 3 FCPC (1)
NOTE(S)(1): The components listed above are not an AIRBUS Kit, the required parts must be
ordered as necessary through the given channel.
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 15
CONF 002Equipment for task set A330-A-27-XX-3235-01000-93AA-A Modification
Procurement address F6198
AIRBUS OPERATIONS SASAVIONICS & SIMULATION PRODUCTS316 ROUTE DE BAYONNE31060 TOULOUSE CEDEX 09FRANCEPhone: 561957534Fax: 561180494E-mail: systems.support@airbus.com.
NOTE(S)Vendor parts are to be procured from the address given above.
ITEM PART No. QTY (UM) KEYWORD DRAWING SEE NOTESLA2K2B100DH0000(F6198) 3 FCPC (1)
NOTE(S)(1): The components listed above are not an AIRBUS Kit, the required parts must be
ordered as necessary through the given channel.
CONF ALLE. LIST OF EXISTING PARTS
CONF 001Interchangeable parts for task set A330-A-27-XX-3235-01000-93AA-A Modification
DESCRIPTION OLD PART No. NEW PART No. INT SEE NOTESFCPC-FLIGHTCONTROL PRIMARYCOMPUTER
LA2K01500AG0000 LA2K2B100DH0000 02 (1) (2) (3)
NOTE(S)For definitions of interchangeability codes in column INT. refer to ATA (CSDD Chapter2).Only the mixability configuration(s) and condition(s) stated in this Service Bulletin areapproved.
(1): The interchangeability possibilities are for new or modified parts introduced by theaccomplishment of this Service Bulletin.
(2): On A330-300 with mechanical rudder (not having MOD No. 49144S16279 installed),the new Part Number (PN) LA2K2B100DH0000 is two way interchangeableand mixable with FCPC P16M25 PN LA2K1A100DG0000 (installed by MOD No.206413S33845) and FCPC M25 PN LA2K01500AG0000 (installed by MOD No.206412S33844).
(3): On A330-200 with mechanical rudder (not having MOD No. 49144S16279 installed),the new PN LA2K2B100DH0000 is two way interchangeable and mixable with FCPCP16M25 PN LA2K1A100DG0000 (installed by MOD No. 206413S33845).
CONF 002Interchangeable parts for task set A330-A-27-XX-3235-01000-93AA-A Modification
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 16
DESCRIPTION OLD PART No. NEW PART No. INT SEE NOTESFCPC-FLIGHTCONTROL PRIMARYCOMPUTER
LA2K1A100DG0000 LA2K2B100DH0000 02 (1) (2) (3)
NOTE(S)For definitions of interchangeability codes in column INT. refer to ATA (CSDD Chapter2).Only the mixability configuration(s) and condition(s) stated in this Service Bulletin areapproved.
(1): The interchangeability possibilities are for new or modified parts introduced by theaccomplishment of this Service Bulletin.
(2): On A330-300 with mechanical rudder (not having MOD No. 49144S16279 installed),the new Part Number (PN) LA2K2B100DH0000 is two way interchangeableand mixable with FCPC P16M25 PN LA2K1A100DG0000 (installed by MOD No.206413S33845) and FCPC M25 PN LA2K01500AG0000 (installed by MOD No.206412S33844).
(3): On A330-200 with mechanical rudder (not having MOD No. 49144S16279 installed),the new PN LA2K2B100DH0000 is two way interchangeable and mixable with FCPCP16M25 PN LA2K1A100DG0000 (installed by MOD No. 206413S33845).
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 17
CONF ALL3. ACCOMPLISHMENT INSTRUCTIONS
Task set A330-A-27-XX-3235-01000-93AA-AModification
WARNING: MAKE SURE THAT YOU OBEY ALL THE WARNINGS AND ALL THE CAUTIONSINCLUDED IN THE REFERENCED PROCEDURES.
CAUTION: ALWAYS OBEY THE PRECAUTIONS THAT FOLLOW TO KEEP ELECTRICALWIRING IN A SATISFACTORY CONDITION (ELECTRICALLY AND MECHANICALLYSERVICEABLE). WHEN YOU DO MAINTENANCE WORK, REPAIRS ORMODIFICATIONS, ALWAYS KEEP ELECTRICAL WIRING, COMPONENTS ANDTHE WORK AREA AS CLEAN AS POSSIBLE. TO DO THIS:- PUT PROTECTION, SUCH AS PLASTIC SHEETING, CLOTHS, ETC., AS
NECESSARY ON WIRING AND COMPONENTS.- REGULARLY REMOVE ALL SHAVINGS, UNWANTED MATERIAL AND
OTHER CONTAMINATION.THESE PRECAUTIONS WILL DECREASE THE RISK OF CONTAMINATION ANDDAMAGE TO THE ELECTRICAL WIRING INSTALLATION.IF THERE IS CONTAMINATION, REFER TO Ref. ESPM 20-55-00.
NOTE: The accomplishment instructions of this Service Bulletin include procedures given inother documents or in other sections of the Service Bulletin. When the words “refer to”are used and the operator has a procedure accepted by the local authority he belongs to,the accepted alternative procedure can be used. When the words “in accordance with”are used then the given procedure must be followed.
NOTE: The access and close-up instructions, not comprising return to service tests, in thisService Bulletin do not constitute or affect the technical intent of the Service Bulletin.Operators can therefore, as deemed necessary, omit or add access and/or close-up stepsto add flexibility to their maintenance operations as long as the technical intent of theService Bulletin is met within the set parameters.
NOTE: Manual titles given in the accomplishment instructions are referred to by acronyms. Referto paragraph 1.J., References, for the definition of acronyms.
NOTE: This Service Bulletin contains the instructions for the on-aircraft maintenance necessaryto ensure the continued airworthiness of the aircraft.For any deviations to the instructions, including RC paragraph contained herein, contactAIRBUS for further instructions and approval.
NOTE: Discarded parts must be managed at the operator's discretion.
A. TASK SET ASSOCIATED INFORMATIONTask Manpower
CONF 001TOTAL MAN-HOURS 2.50 h
CONF 002TOTAL MAN-HOURS 2.50 h
CONF 001ELAPSED TIME (HOURS) 2.50 h
CONF 002ELAPSED TIME (HOURS) 2.50 h
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 18
CONF ALLB. PREPARATION
(1) Task A330-A-27-XX-3235-01001-540A-A - Job Set-upJob Set-Up Information
Manpower/Resources/Skills
Man-hours 0.50 hMinimum Number of person 1Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/Sheets
AMM Task 12-34-24-860-802Task 27-93-34-000-801
Procedure
NOTE: For the basic Aircraft configuration, refer to AMM Chapter "Introduction -Aircraft status for maintenance" in Manual Front Matter section.
(a) Make sure that the aircraft is electrically grounded, refer to Ref. AMM Task12-34-24-860-802.
(b) Do the job set-up procedure as specified in the removal of the FCPCs ( FIN 2CE1FIN 2CE2 and FIN 2CE3), refer to Ref. AMM Task 27-93-34-000-801.
C. PROCEDURECONF 001
(1) Task A330-A-27-XX-3235-02001-920A-A - Replace the FCPCs in AvionicsCompartmentJob Set-Up Information
Working Area
Impacted Zone Access / Work LocationAccess Door 811
120Work location Electrical Panel 800VU
Electrical Panel 915VU
Manpower/Resources/Skills
Man-hours 1.00 hMinimum Number of person 1Elapsed Time 1.00 h
Material necessary to do the jobEquipmentITEM PART No. QTY (UM) KEYWORD DRAWING SEE NOTES
LA2K2B100DH0000 3 FCPC (1)NOTE(S)(1): The components listed above are not an AIRBUS Kit, the required parts must be
ordered as necessary through the given channel.
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 19
Referenced Information
Manuals/Drawings References/Sheets
AMM
06-20-00, Page Block 00106-31-53, Page Block 00106-41-53, Page Block 001Task 27-93-34-000-801Task 27-93-34-400-801
Procedure(a) Standard Practices:
1 For the identification of zones, refer to Ref. AMM 06-20-00, Page Block 001.2 For the Frame (FR) identification, refer to Ref. AMM 06-31-53, Page Block
001.3 For the identification of access panels, refer to Ref. AMM 06-41-53, Page
Block 001.(b) Remove the FCPCs ( FIN 2CE1 FIN 2CE2 and FIN 2CE3), refer to Ref. AMM Task
27-93-34-000-801:
FIN 2CE11 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K01500AG0000 Discard
and
FIN 2CE21 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K01500AG0000 Discard
and
FIN 2CE31 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K01500AG0000 Discard
(c) Install the FCPCs ( FIN 2CE1 FIN 2CE2 and FIN 2CE3), refer to Ref. AMM Task27-93-34-400-801:
FIN 2CE11 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K2B100DH0000
and
FIN 2CE21 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K2B100DH0000
and
FIN 2CE31 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K2B100DH0000
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 20
CONF 002(1) Task A330-A-27-XX-3235-02002-920A-A - Replace the FCPCs in Avionics
CompartmentJob Set-Up Information
Working Area
Impacted Zone Access / Work LocationAccess Door 811
120Work location Electrical Panel 800VU
Electrical Panel 915VU
Manpower/Resources/Skills
Man-hours 1.00 hMinimum Number of person 1Elapsed Time 1.00 h
Material necessary to do the jobEquipmentITEM PART No. QTY (UM) KEYWORD DRAWING SEE NOTES
LA2K2B100DH0000 3 FCPC (1)NOTE(S)(1): The components listed above are not an AIRBUS Kit, the required parts must be
ordered as necessary through the given channel.
Referenced Information
Manuals/Drawings References/Sheets
AMM
06-20-00, Page Block 00106-31-53, Page Block 00106-41-53, Page Block 001Task 27-93-34-000-801Task 27-93-34-400-801
Procedure(a) Standard Practices:
1 For the identification of zones, refer to Ref. AMM 06-20-00, Page Block 001.2 For the Frame (FR) identification, refer to Ref. AMM 06-31-53, Page Block
001.3 For the identification of access panels, refer to Ref. AMM 06-41-53, Page
Block 001.(b) Remove the FCPCs ( FIN 2CE1 FIN 2CE2 and FIN 2CE3), refer to Ref. AMM Task
27-93-34-000-801:
FIN 2CE11 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K1A100DG0000 Discard
and
FIN 2CE21 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K1A100DG0000 Discard
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 21
and
FIN 2CE31 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K1A100DG0000 Discard
(c) Install the FCPCs ( FIN 2CE1 FIN 2CE2 and FIN 2CE3), refer to Ref. AMM Task27-93-34-400-801:
FIN 2CE11 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K2B100DH0000
and
FIN 2CE21 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K2B100DH0000
and
FIN 2CE31 FCPC-FLIGHT CONTROL
PRIMARY COMPUTERLA2K2B100DH0000
CONF ALLD. PREPARATION FOR TEST
(1) Task A330-A-27-XX-3235-02001-520A-A - Test Set-upJob Set-Up Information
Manpower/Resources/Skills
Man-hours 0.10 hMinimum Number of person 1Elapsed Time 0.10 h
Referenced Information
Manuals/Drawings References/SheetsAMM Task 27-93-34-400-801
Procedure(a) Remove the safety clips and tags and close the circuit breakers as specified after
the installation of the FCPCs ( FIN 2CE1 FIN 2CE2 and FIN 2CE3), refer to Ref.AMM Task 27-93-34-400-801.
E. TEST(1) Task A330-A-27-XX-3235-01001-300A-A - Testing
Job Set-Up InformationManpower/Resources/Skills
Man-hours 0.40 hMinimum Number of person 1Elapsed Time 0.40 h
A330SERVICE BULLETIN
REV 00 May 21/19 A330-27-3235Page 22
Referenced Information
Manuals/Drawings References/SheetsAMM Task 27-93-34-400-801
Procedure(a) Do the test after the installation of the FCPCs ( FIN 2CE1 FIN 2CE2 and FIN
2CE3), refer to Ref. AMM Task 27-93-34-400-801.F. CLOSE-UP
(1) Task A330-A-27-XX-3235-01001-740A-A - Close-upJob Set-Up Information
Manpower/Resources/Skills
Man-hours 0.50 hMinimum Number of person 1Elapsed Time 0.50 h
Referenced Information
Manuals/Drawings References/SheetsAMM Task 27-93-34-400-801
Procedure(a) Make sure that the work areas are clean and clear of tools and other items of
equipment.(b) Do the close-up procedure as specified in the installation of the FCPCs ( FIN 2CE1
FIN 2CE2 and FIN 2CE3), refer to Ref. AMM Task 27-93-34-400-801.(c) Put the aircraft back to its initial configuration.
G. ADMINISTRATIVE(1) Task A330-A-27-XX-3235-01001-90AA-A - Administrative
ProcedureConfirm in the applicable aircraft records that you have completed all the work definedin this Service Bulletin task set as required.
A330SERVICE BULLETIN
APPENDIX
REV 00 May 21/19 A330-27-3235Page 23
APPENDIXA. REPORTING SHEET
TITLE: FLIGHT CONTROLS - FLIGHT CONTROL PRIMARY COMPUTER (FCPC)-REPLACE 2K0 AND 2K1 FCPC HARDWARE BY 2K2 FCPC HARDWARE
MODIFICATION No.: 208335S34936
(1) SB Reporting statusThis Service Bulletin will only be incorporated into affected customized Maintenanceand Flight Operations Products if it is duly reported to Airbus.
(2) GENERAL informationThe SB Reporting policy is published in ISI 00.00.00135. This document providesinformation regarding: the SB Reporting means and benefits, the update ofcustomized Maintenance Products and customized Flight Operations Products.If this Service Bulletin has an operational impact, refer to paragraph "Flight OperationsProducts" for further information on the update of affected Flight Operations Products.
(3) SB Reporting procedureStandard practice to report SB is to use the online reporting application onAirbusWorld.Refer to ISI 00.00.00179:
- For complete information on reporting means to Airbus, Question 2 "What arethe standard practices for SB Reporting?"
- If this SB requires previous or simultaneous accomplishment of other SBs,Question 3 "What about the reporting of prerequisite Service Bulletins?"
NOTE: ISI 00.00.00179 covers all the frequently asked questions about SB Reporting.It is revised on a regular basis.
A330SERVICE BULLETIN
APPENDIX
REV 00 May 21/19 A330-27-3235Page 24
B. QUALITY PERCEPTION FORMUse this form to tell us what is your perception of the quality of this Service Bulletin.The reported data that you provide us will be used to analyse areas of difficulties and totake corrective action to further improve the quality of our Service Bulletin.We thank you for the time you have taken in completing this form.
Quality rating of this SB 4 3 2 1Quality rating of the Accomplishment Instructions 4 3 2 1Quality rating of the Illustrations 4 3 2 1Is this SB easy to understand ? Y / N
NOTE: Please rate on a scale of 1 to 4, with 4 being the highest score
If you have difficulties in the accomplishment of this SB please quote below the area(s) andgive a short description of the issue.
Planning Material InstructionsX Applicability X Tooling X PreparationX Reason X List of Materials
Operator SuppliedX Mod/Inspection
X Manpower X Kit content X TestX References X Re-identification X Close-upX Publication X IllustrationsX Industry Support
Comments :
Operator : Date :Name/TitlePlease return this form to :AIRBUS2, ROND POINT EMILE DEWOITINE31700 BLAGNACFRANCEOr via your Resident Customer Support Office.