Post on 08-Oct-2020
transcript
2018-10-29
1
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
ADVANCED ANALYTICAL METHODS
SAMPLE PREPARATION
ANALYTICAL PROCESS
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
OBJECT OF MESUREMENT
SAMPLE
SIGNAL
RESULT OF MEASUREMENT
RESULT OFANALYSIS
INFORMATION
HIDDENVARIABLES
OBJECT OFINVESTIGATION PROBLEM
STRATEGY OF SAMPLINGSAMPLING
SAMPLE PREPARATION
MEASUREMENT
REGISTRATION/EVALUATION
CALIBRATION
INTERPRETATION
PERCEPTION SOLUTION OF
THE PROBLEM
MEASURINGSYSTEM
CHEMOMETRICMETHODS
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
SAMPLE PREPARATION
• Homogenization
• Reduction of bulk samples
• Mineralisation
• Dissolution/Digestion/Fusion
• Separation
• Accumulation
• Weighting/Mesurement
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
SAMPLE MINERALISATION AND DIGESTION
Dry mineralisation (ashing)
OPEN SYSTEM – heating sample in muffle furnace or onburner up to 450 - 550°C (sometimes up to 1000 °C) incrucible (porcelain, quartz, platinum) till all organic matter isdecomposed. Usually proccess takes 3 – 4 hours.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Adventages: method is simple, low blank, unrestrictedsample size
Disadventages: losses of volatile components, possiblemechanical losses, long proccess duration, proccess istwo-stages (ash must be digested/dissolute)
• CLOSED SYSTEM – oxygen bombMethod consisit in deflagration of small amount of organic matter (less than 20
mg) in closed flask with oxygen. Gas products of combustion are absorbed insolution presented in the flask.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
2018-10-29
2
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Modern oxygen bombs (Parr)
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
WET MINERALIZATION
Open system
Mineralization/digestion in acids – heating the sample in oxidatingacids. During proccess inorganic components are digested and organicmatter is oxidized to carbon dioxide, water and other volatile products.Most often are used acids or their mixtures:
HNO3 + H2O2 - biological samplesHNO3 + H2SO4 - universalHNO3 + HCl - aqua regia - universalHNO3 + HClO4 - biological samples, explosiveHF - inorganic samplesHNO3 + HF - universalHClO4 - biological samples, explosive
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
UV mineralisation – is applicated toliquid samples which contain smallamount of organic matter. Liquidsample is irradiated with UVradiation (quartz lamp usually λ =250 nm, P = 150 W). In most casesthe oxidant (H2O2, K2S2O8, HNO3) isadded to sample in order to facilitatethe process.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Microwave assisted digestion andmineralisation – microwaves arenonionizing irradiation which causemolecular movements such as ionsmigration and dipol rotation. They donot change directly molecular structure.Full frequency range of microwaves is300 - 300000 MHz. However fordigestion and mineralisation applied isfrequency 2450 MHz (the same as inmicrowave oven for kitchen purpose)and source power of 600 - 700 W.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
During penetration of the sample by microwave irradiation itis adsorbed in the degree which depends on dissipationfactor. The dissipation factor defines the ability of a mediumto convert electromagnetic energy into heat for a givenfrequency and temperature.Some approximate dissipation factors:0.6 quartz1.5 teflon10 glass1600 waterIn comparison with wet digestion at the heating plate, themicrowave assisted digestion is much faster, becauseenergy is supplied directly to the sample (not through thewalls of container).Applications: biological, geological, environmental andmetalurgical samples.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
2018-10-29
3
MICROWAVE DIGESTION SYSTEM
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
DIGESTION / MINERALISATION INCLOSED SYSTEM is performed inpressure vassels (bombs orautoclaves) in higher temperature(~125°C) and higher pressure (~0,15MPa). Due to these conditionsproccess is more efficient and faster.Heating may be conventional ormicrowave.Adventages: faster and more efficientproccess. There is no loss of volatilecompounds.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Pressure bomb
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Autoclave
FUSION
Some materials are particularly resistant to acid digestion,for example: certain rocks, mineral oxides, phosphates,silicates and some iron alloys. For these samples, high-temperature fusion with an acidic or basic flux in themelted state can be used to render such materials to besoluble in water or dilute acid. Fusion decompositions arethe most rigorous methods available and all silicatematerials, including refractory substances like zircon andcassiterite, can be dissolved completely when fused withan appropriate flux.Disadvantages: contamination because of introduction oflarge amount (10-15 times more than the sample itself) ofsalt (flux).
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Pt
Ni
Fe
Au
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
2018-10-29
4
SEPARATION AND ACCUMULATION METHODS
Mixed substances may be separate if they differ at least in one physicochemicalproperty.
Basic of separation Method
Volatility DistillationRefining
Partition coefficient (Nernstian)
Chromatography gas-liquidPartition chromatographyExtraction
Equilibrium of exchange Ionic exchange
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Surface activity Adsorption chromatographyChromatography gas-solidFoam refining
Molecular geometry Molecular sivesGel filtration/permationGas diffusionInclusion compexesUltrafiltrationDialysis, electrodialysis
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Migration Elektrophoresis
Solubility PrecipitationZone refining
Decomposition potential Electrolysis
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
SEPARATION METHODS
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
EXTRACTION
Process of mass exchange between two phases:- phase (solid or liquid) from which substance is extracted;- phase (most often liquid called extrahent) to whichsubstance is extracted;performed in the multicomponent system of restrictedsolubility.
Common liquid-liquid extraction system
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
As the result of the proccess extracted component passes to extrahent in degree described by Nernst division coefficient:
To intensify proccess the complexing agent is added to extrahent phase. In such case the division coefficient is defined as:
Most often extraction is performed in liquid-liquid or solid-liquid system. Recently, especially for chromatography applied is extaction to the solid phase (SPE).
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
2018-10-29
5
Extractor (separation funnel) Soxlet apparatus Syringe for SPE
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
IONIC EXCHANGEReaction A1A2+B1B2=A1B2+B1A2 which is performed at ionexchange resins. They are insoluble in waterpolyelectrolytes (~90% are polystyrenic matrix).Cation exhangers – functional groups -SO3H; -COOHAnion exhangers - functional groups –NH2; =NHGood ion exhange resin should be:chemically resistant,have large exhange capacityreaction of exhange should be fast.Stages of the proccess:
- Exhange metal ions by H+
- Exhange anions by OH-
pure water
- Relase metal ions purging column with acid
- Relase anions purging column with base
Separation
Accumulation
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Kolumna jonitowa Ion exhange resin
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Laboratory and industrial ion-exhange column
Leakage of column (exceeding capacity of column)
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
MEMBRANE SEPARATION
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
2018-10-29
6
ULTRAFILTRATIONProccess in which solution under high pressure permatethrough the membrane. Depending on size of membranepores the solvent molecules and small ions permatethrough the membrane, whereas particles, colloids andlarge molecules remain on the membrane. In ultrafiltrationthe pores diameters are 0.2 - 0.45 µm and the appliedpressure is 10 - 30 MPa.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Membrane and seperated latex particles
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
DIALYSISRemoval of small ions and particles from colloidal solutionsby semipermable membrane. Proccess is much faster whenelectrical field is applied (electrodialysis).
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
ELECTROPHORESISCharged colloidal particles migrate in electric field. Velocity ofmigration depends on charge, magnitude and shape of theparticles. It allows to separate different particles.Electrophoresis is performed on substrates such as celluloseacetate, agarose, polyacrylic gels etc. If capillaryelectrophoresis is used there is possibility to separate ions.
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS
Apparatus for electrophoresisElectrophoresis of peptides from several animal meats
W.W.KUBIAK - ADVANCED ANALYTICAL METHODS