Post on 29-Apr-2018
transcript
FILE NO. A90-9503
AIR-CONDITIONER
TOSHIBA
SERVICE MANUAL
RAV-162BH-PE/162AH-PERAV-262BH-PE/262AH-PERAV-262BH-PE/262AH8-PERAV-362BH-PE/362AH8-PERAV-462BH-PE/462AH8-PE
SPLIT BUILT-IN DUCT TYPE, HEAT PUMP
SPLIT CEILING TYPE, HEAT PUMPRAV-162CH-PE/RAV-162AH-PERAV-262CH-PE/RAV-262AH-PERAV-262CH-PE/RAV-262AH8-PERAV-362CH-PE/RAV-362AH8-PERAV-462CH-PE/RAV-462AH8-PE
SPLIT WALL TYPE, HEAT PUMP
RAV-162KH(W)-PE/RAV-162AH-PERAV-262KH(W)-PE/RAV-262AH-PERAV-262KH(W)-PE/RAV-262AH8-PE
SPLIT CASSETTE TYPE, HEAT PUMPRAV-132UH-PERAV-162UH-PE/162AH-PERAV-262UH-PE/262AH-PERAV-262UH-PE/262AH8-PERAV-362UH-PE/362AH8-PERAV-462UH-PE/462AH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-2-
CONTENTS
1. SPECIFICATIONS ............................................................................................................................................................... 3
2. CONSTRUCTION VIEWS ................................................................................................................................................ 15
3. WIRING DIAGRAM ........................................................................................................................................................... 22
4. SPECIFICATIONS OF ELECTRICAL PARTS ................................................................................................................. 32
5. REFRIGERANT PIPING DIAGRAM ................................................................................................................................ 41
6. REMOTE CONTROLLER ................................................................................................................................................. 46
7. OUTLINE OF CONTROL CIRCUIT ................................................................................................................................. 59
8. DESCRIPTION OF INDOOR UNIT CONTROL CIRCUIT ............................................................................................. 62
9. DESCRIPTION OF OUTDOOR UNIT CONTROL CIRCUIT ......................................................................................... 68
10. OPERATION OF AIR CONDITIONER FROM OUTDOOR UNIT .................................................................................. 73
11. EMERGENCY OPERATION............................................................................................................................................. 74
12. APPLIED CIRCUIT ............................................................................................................................................................ 75
13. WIRING FOR GROUP OPERATION .............................................................................................................................. 75
14. PERFORMANCE CHARACTER ...................................................................................................................................... 76
15. EXPLODED VIEWS AND PARTS LISTS ........................................................................................................................ 79
SUMMARY
• The units referred to within this manual conform with the protection requirements of Directives 89/336/EECElectromagnetic Compatibility and 73/23/EEC Low Voltage.
• Operating conditions of units are as follows:
Note 1 : Cooling Capacity is based on the following temperature conditions:Indoor air inlet temperature 27°C DB, 19°C WB.Outdoor air inlet temperature 35°C DB.
Note 2: Heating Capacity is based on the following temperature conditions:Indoor air inlet temperature 20°C DB.Outdoor air inlet temperature 7°C DB, 6°C WB.
TEMPERATURE
OUTDOOR TEMPERATURE -2 TO 43°C (COOL)
-10 TO 21°C (HEAT)
ROOM TEMPERATURE 18 TO 32°C (COOL)
15 TO 29°C (HEAT)
ROOM HUMIDITY LESS THAN 80% (COOL)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-3-
1. SPECIFICATIONS
5.0
1
220 -240
50
HEATINGC O O L I N G
2.3 2.2
P o w e r s o u r c e
P o w e r c o n s u m p t i o n
P o w e r f a c t o r 90 90
Runn ing cu r ren t 11.1 10 .6
Star t ing cur ren t
Opera t i ng no i se (SPL)
Ref r igerant
60
42/39 /36
R - 2 2
1.635
Ref r igeran t con t ro l
I n te rconnec t i on p ipe
Ø12 .7
F lare
Ø 6.4
F lare7 .5
k W
VH z
P h a s e
k W
%
A
A
dB(A )
dB (A )
k g
g / m
m m
m
I n d o o r u n i t (High, Med, Low)
Outdoor un i t
Name o f r e f r i ge ran t
C h a r g e v o l u m e
A d d . v o l u m e ( 2 0 - 3 0 m )
Larger s ide s ize
Coup le r s t y le
Sma l l e r s i de s i ze
Coup le r s t y leS tandard l eng th
M a x i m u m l e n g t h(o f one way ) * 1 m
30
M a x i m u m h e i g h t
Indoor un i t he igh t m 15
Outdoor un i t he igh t m 30
C o n d e n s a t e d r a i n p i p e d i a m e t e r m mI N D O O R U N I T M o d e l RAV-162BH-PE
A p p e a r a n c e c o l o u r B lack (Z inc ga lvan ized s tee l + the rma l i nsu la to r )
Cap i l l a ry tube & Expans ion va l ve
50
D i m e n s i o n s
He igh t m m 3 4 5
7 0 0W i d t h m m
D e p t h m m 8 0 0
N e t w e i g h t k g 39
Hea t exchanger t ype F inned t ube
Indoor fan type Mul t i -b lade fan
A i r v o l u m e m 3/h 8 4 0
W 60
Ø 3 2 ( O D )
m m
H e a t i n g c a p a c i t y
Coo l i ng capac i t y k W 4.5
MODELITEM RAV-162BH-PE
Fan mo to r ou tpu t
10
O U T D O O R U N I T M o d e l RAV-162AH-PEA p p e a r a n c e c o l o u r B ronze wh i te (Munse l l 6Y7 .5 /1 )
D i m e n s i o n s W i d t h m m
D e p t h m m
Heigh t m m 7 4 0
8 8 0
3 1 0
N e t w e i g h t k g 61Hea t exchanger t ype F inned t ube
Outdoor fan type Prope l le r fan
A i r f l o w v o l u m e m 3/h 2 ,700
Fan mo to r ou tpu t W 39
P H 2 5 0 X 3 - 4 L SC o m p r e s s o r
M o d e l
Outpu t k W 2.0
Pro tec t ive dev ice H igh p ressu re sw i t ch , Fuse , C rankcase hea te r , Ove r load re lay , B ime ta l t he rmos ta t
Externa l s ta t icp ressure
S tanda rd
M a x . m o t o r
m m A q
m m A q
4
C E I L I N G P A N E L M o d e l RBC-B161PE(W)
Si l ky m is t (Munse l l 1Y8 .9 /0 .5 )
D i m e n s i o n s W i d t h
D e p t h
He igh t
m m
m m
m m
40
5 0 0
7 8 0
k gN e t w e i g h t
W a s h a b l eAir f i l ter
R B C - F D 2 0 2 EFlex ib le duc t
R B C - B U 1 E ( W )B l o w o u t u n i t
R B C - C A 1 6 1 B ESuc t i on canvas
R B C - L K 1 6 1 B ELong-l i fe f i l ter k i t
Bui l t - in duct f i l ter k i t R B C - D K 1 6 1 B E - P
A p p e a r a n c e c o l o u r
4
Spec i f i ca t i ons a re sub jec t t o change w i t hou t no t i ce .
* N o t e 1 : T h e s e m e a n a c t u a l l e n g t h .
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-4-
ITEM MODEL RAV-262BH-PE RAV-262BH-PE
k W 7.1Coo l i ng capac i t y
k W 7.9
P o w e r s o u r c e
P h a s e
VH z
1 3
220 -240 380 -41550
C O O L I N G HEATING C O O L I N G HEATING
3.0 2 .75 2.8
88 87 86 85
14 .8 13 .8 4 .7 4 .6
P o w e r c o n s u m p t i o n k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur ren t 25
Opera t ingn o i s e ( S P L )
I n d o o r u n i t (High, Med, Low) dB (A ) 43 /40 /37
53
R - 2 22 .35
60
Outdoor un i t dB (A )
Ref r igerant
Name o f r e f r i ge ran t
C h a r g e v o l u m e k g
A d d . v o l u m e ( 2 0 - 3 0 m ) g / m
Cap i l l a ry tube & Expans ion va l ve
In terconnect ionp ipe
Larger s ide s ize m m ø 15 .9
Coup le r s t y le F lare
Sma l l e r s i de s i ze m m ø 9 . 5
Coup le r s t y le F lareS tandard l eng th m 7.5
M a x i m u m l e n g t h(o f one way ) * 1 m 30
15m
m 30
ø 3 2 ( O D )
I N D O O R U N I T M o d e l RAV-262BH-PE
A p p e a r a n c e c o l o u r B lack (z inc ga lvan ized s tee l + the rma l i nsu la to r )
D i m e n s i o n s
He igh t m m 3 4 5
W i d t h m m 1,000
D e p t h m m 8 0 0
N e t w e i g h t k g 53Hea t exchanger t ype F inned t ubeIndoor fan type Mul t i -b lade fan
A i r v o l u m e m 3/h 1 ,140
Fan mo to r ou tpu t W 1 0 0
4
80
Ref r igeran t con t ro l
A
Externa l s ta t icp ressure
S tanda rd
M a x . m o t o r
m m A q
m m A q 10
2.7
H e a t i n g c a p a c i t y
C o n d e n s a t e d r a i n p i p e d i a m e t e r m m
M a x i m u m h e i g h t
Indoor un i t he igh t
Ou tdoor un i t he igh t
B ronze wh i te (Munse l l 6Y7 .5 /1 )
7 9 0
8 8 0
3 1 0
80F inned t ubePrope l le r fan
3 ,000
63
P H 3 3 0 X 3 - 4 M S Y H 3 3 0 X 3 - M S
2.2 2.2
A p p e a r a n c e c o l o u r
D i m e n s i o n s
He igh t m m
W i d t h m m
D e p t h m m
Heat exchanger t ype
N e t w e i g h t
Outdoor fan type
A i r f l o w v o l u m e
Fan mo to r ou tpu t
C o m p r e s s o rM o d e l
Outpu t
Sa fe ty dev ice
k g
m 3/h
k W
W
High p ressu re sw i t ch , Fuse , B ime ta l t he rmos ta t ,C rankcase hea te r , I nne r ove r load re lay
H igh p ressure sw i t ch , Fuse , Overcu r ren t re lay ,Crankcase hea te r , Thermos ta t , Re tu rn -Lock
C E I L I N G P A N E L M o d e l
He igh t m m
D i m e n s i o n s
D e p t h m m
A p p e a r a n c e c o l o u r
W i d t h m m
N e t w e i g h t
Air f i l ter
F lex ib le duc t
B l o w o u t u n i t
Suc t i on canvas
Long-l i fe f i l ter k i t
Bui l t - in duct f i l ter k i t
k g
RBC-B260PE(W)
Si l ky m is t (Munse l l 1Y8 .9 /0 .5 )40
1 ,080
5 0 0
6
W a s h a b l e
R B C - F D 2 0 2 E
R B C - B U 1 E ( W )
R B C - C A 2 6 0 B E
R B C - L K 2 6 0 B E
R B C - D K 2 6 1 B E - P
Spec i f i ca t i ons a re sub jec t t o change w i t hou t no t i ce .
* N o t e 1 : T h e s e m e a n a c t u a l l e n g t h .
O U T D O O R U N I T M o d e l RAV-262AH-PE RAV-262AH8-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-5-
MODELITEM RAV-362BH-PE RAV-462BH-PE
k WCoo l i ng capac i t y 10 .0 12 .5
Ref r igeran t con t ro l
k W
P o w e r s o u r c e
P h a s e
VH z
P o w e r c o n s u m p t i o n k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur ren t
I n d o o r u n i t (High, Med, Low) dB (A )Outdoor un i t dB (A )Name o f r e f r i ge ran t
Ref r igerant k g
A d d . v o l u m e ( 2 0 - 5 0 m ) g / m
In terconnect ionp ipe
Larger s ide s ize * 2 m m
Coup le r s t y le
Sma l l e r s i de s i ze m m
Coup le r s t y leS tandard l eng th m
M a x i m u m l e n g t h(o f one way ) * 1 m
Outdoor un i t he igh t
m
m
C o n d e n s a t e d r a i n p i p e d i a m e t e r
I N D O O R U N I T M o d e l
A p p e a r a n c e c o l o u r
D i m e n s i o n s
He igh t
m m
m m
W i d t h m m
D e p t h m m
N e t w e i g h t k g
Hea t exchanger t ypeIndoor fan type
A i r v o l u m e m 3/h
Fan mo to r ou tpu t W
380 -415
C O O L I N G HEATINGC O O L I N G HEATING
4.2
89
6.8
3 .6
87
6.0
5 .15
87
8.5
4 .9
88
8.0
42
45/42 /39
55
R - 2 2
3.4
50
Cap i l l a ry tube & Expans ion va l ve
ø 1 9 ( ø 2 2 )
F lareø 9 . 5
F lare7 .5
50
46/43 /40
55
R - 2 2
3.9
50
Cap i l l a ry tube & Expans ion va l ve
ø 1 9 ( ø 2 2 )
F lareø 9 . 5
F lare7 .5
Indoor un i t he igh t 20 20
50 50
B lack (z inc ga lvan ized s tee l + the rma l i nsu la to r )
RAV-362BH-PE RAV-462BH-PE
ø 3 2 ( O D ) ø 3 2 ( O D )
50 50
3 4 5 3 4 5
1,350 1 ,350
8 0 0 8 0 0
58 62
F inned t ube F inned t ube
Mul t i -b lade fan Mul t i -b lade fan
1 ,820 2 ,100
1 2 0 1 4 0
4 4
A
m m
Opera t ingn o i s e ( S P L )
C h a r g e v o l u m e
M a x i m u m h e i g h t
H e a t i n g c a p a c i t y
3
380 -415
50
3
13 .8
50
Externa l s ta t icp ressure
S tanda rd
M a x . m o t o r 10 10O U T D O O R U N I T M o d e l
A p p e a r a n c e c o l o u r
D i m e n s i o n s
He igh t m m
W i d t h m m
D e p t h m m
Heat exchanger t ype
N e t w e i g h t
Outdoor fan type
A i r f l o w v o l u m e
Fan mo to r ou tpu t
C o m p r e s s o rM o d e l
Outpu t
Sa fe ty dev ice
RAV-362AH8-PE RAV-462AH8-PE
Bronze wh i te (Munse l l 6Y7 .5 /1 ) B ronze wh i te (Munse l l 6Y7 .5 /1 )
1 ,240 1 ,240
9 3 0 9 3 0
3 8 5 3 8 5
1 0 7 115
F inned t ube F inned t ubePrope l le r fan Prope l le r fan
6 ,000 6 ,000
39+63 39+63
Y H 4 0 6 J A Y H 5 0 6 J A
3.0 3 .75
H igh p ressu re sw i t ch , Fuse , Ove r load re lay ,Crankcase hea te r , I nne r ove r load re lay
H igh p ressu re sw i t ch , Fuse , Ove r load re lay ,Crankcase hea te r , I nne r ove r load re lay
k g
m 3/h
k W
W
C E I L I N G P A N E L M o d e l
A p p e a r a n c e c o l o u r
D i m e n s i o n sHe igh t
W i d t h
m m
m m
D e p t h m m
k gN e t w e i g h t
Air f i l ter
F lex ib le duc t
B l o w o u t u n i t
Suc t i on canvas
Long-l i fe f i l ter k i t
Bui l t - in duct f i l ter k i t
RBC-B460PE(W) RBC-B460PE(W)
Si l ky m is t (Munse l l 1Y8 .9 /0 .5 ) S i l ky m is t (Munse l l 1Y8 .9 /0 .5 )
40
1 ,4301 ,430
5 0 0 5 0 0
7
W a s h a b l e W a s h a b l e
7
R B C - F D 2 0 2 E
R B C - B Ú 1 E ( W )
R B C - C A 4 6 0 B E
R B C - L K 4 6 0 B E
R B C - D K 4 6 1 B E - P
Spec i f i ca t i ons a re sub jec t t o change w i t hou t no t i ce .
* N o t e 1 : T h e s e m e a n a c t u a l l e n g t h .
* N o t e 2 : ( ø 2 2 ) s h o u l d b e u s e d w h e n l e n g t h o f p i p e e x c e e d s 3 0 m .
40
m m A q
m m A q
10 .8
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-6-
MODELITEM RAV-162CH-PE
4.5Coo l ing capac i ty k W
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
50
H E A T I N GC O O L I N G
2.3 2.2
P o w e r s o u r c e
Power consumpt ion
P o w e r f a c t o r 90 90
Runn ing cu r ren t 11.1 10.6
Star t ing cur rent
Opera t ing no ise (SPL)
Refr igerant
60
42/39 /36
R - 2 2
1.635
Refr igerant cont ro l
In terconnect ion p ipe
Ø12.7
F lare
Ø 6.4
F lare
7 .5
H z
k W
%
A
A
dB(A )dB (A )
k g
g / m
m m
m
Indoor unit (High, Med, Low)
Outdoor un i t
Name o f re f r igeran t
Cha rge vo lume
Add. vo lume (20 -30m)
Larger s ide s ize
Coup ler s ty le
Smal le r s ide s ize
Coup ler s ty le
S tandard l eng th
M a x i m u m l e n g t h(o f one way) *1 m
30
M a x i m u m h e i g h t
Indoor un i t he ight m 15
Outdoor un i t he igh t m 30
Condensa te d ra in p ipe d iamete r m m
I N D O O R U N I T M o d e l RAV-162CH-PE
Appearance co lour Si lky mist
Cap i l l a ry tube & Expans ion va lve
50
Dimens ions
He igh t m m 1 8 8
1,030Width m m
D e p t h m m 6 4 0
Net we igh t k g 24
Heat exchanger type F inned tube
Indoor fan type Mul t i -b lade fan
A i r vo lume m 3/h 7 8 0
Fan mo to r ou tpu t W 34Air f i l ter Washab le
O U T D O O R U N I T M o d e l RAV-162AH-PEAppearance co lour Bronze wh i te (Munse l l 6Y7.5 /1 )
D imens ions Width m m
D e p t h m m
Heigh t m m 7 4 0
8 8 0
3 1 0
Net we igh t k g 61
Heat exchanger type
Ø 20 ( ID)
F inned tubeOutdoor fan type Propel ler fan
A i r f l ow vo lume m 3/h 2 ,700
Fan mo to r ou tpu t W 39
P H 2 5 0 X 3 - 4 L SCompresso r
Mode l
Outpu t k W 2.0
Pro tec t ive dev ice H igh p ressure sw i t ch , Fuse , Crankcase hea te r , Over load re lay , B imeta l the rmos ta t
m m
Heat ing capac i t y 5 .0k W
1Phase
V 220-240
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-7-
ITEM MODEL RAV-262CH-PE RAV-262CH-PE
M a x i m u m h e i g h t
Indoor un i t he ight
k W 7.1Coo l ing capac i tyHea t ing capac i t y k W 7.9
P o w e r s o u r c e
Phase
VH z
1 3
220-240 380-415
50
C O O L I N G H E A T I N G C O O L I N G H E A T I N G
3.0 2.75 2.8 2 .7
88 87 86 85
14.8 13.8 4 .7 4 .6
Power consumpt ion k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur rent 25
Opera t ingno ise (SPL)
Indoor un i t dB (A ) 45 /41 /37
53
R - 2 22.35
60
Outdoor un i t dB (A )
Refr igerant
Name o f re f r igeran t
Cha rge vo lume k g
Add . vo lume (20 -30m) g / m
Cap i l l a ry tube & Expans ion va lve
Interconnect ionp ipe
Larger s ide s ize m m ø 15 .9
Coup ler s ty le F lare
Smal le r s ide s ize m m ø 9 . 5
Coup ler s ty le F lareS tandard l eng th m 7.5
M a x i m u m l e n g t h(o f one way) *1 m 30
15
Outdoor un i t he igh t
m
m 30
Condensa te d ra in p ipe d iamete r ø 20 ( ID)
I N D O O R U N I T M o d e l RAV-262CH-PE
Appearance co lour Si lky mist
D imens ions
He igh t
m m
m m 1 8 8
Width m m 1,230
D e p t h m m 6 4 0
Net we igh t k g 28Heat exchanger type F inned tubeIndoor fan type Mul t i -b lade fan
A i r vo lume m 3/h 1 ,200
Fan mo to r ou tpu t W 34
Washab le
80
Air f i l ter
Ref r igerant cont ro l
RAV-262AH-PE RAV-262AH8-PE
Bronze wh i te (Munse l l 6Y7.5 /1 )
7 9 0
8 8 0
3 1 0
80F inned tubePropel ler fan
3 ,000
63
P H 3 3 0 X 3 - 4 M S Y H 3 3 0 X 3 - M S
2.2 2.2
High p ressure sw i tch , Fuse , B imeta l thermosta t ,Crankcase heater , Inner over load re lay
High pressure swi tch , Fuse, Overcur ren t re lay ,Crankcase heater , Thermosta t , Return-Lock
O U T D O O R U N I T M o d e l
Appearance co lour
D imens ions
He igh t m m
Width m m
D e p t h m m
Heat exchanger type
Ne t we igh t
Outdoor fan type
A i r f l ow vo lume
Fan mo to r ou tpu t
Compresso rMode l
Outpu t
Safe ty dev ice
A
k g
m 3/h
k W
W
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-8-
MODELITEM RAV-362CH-PE RAV-462CH-PE
k W 10.5 13.0
Refr igerant cont ro l
Phase
VH z
Power consumpt ion k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur rent
Indoor uni t (High, Med, Low) dB (A )Outdoor un i t dB (A )Name o f re f r igeran t
Refr igerant k g
Add . vo lume (20 -50m) g / m
Interconnect ionp ipe
Larger s ide s ize *2 m m
Coup ler s ty le
Smal le r s ide s ize m m
Coup ler s ty leS tandard l eng th m
M a x i m u m l e n g t h(o f one way) *1 m
Outdoor un i t he igh t
m
m
Condensa te d ra in p ipe d iamete r
I N D O O R U N I T M o d e l
Appearance co lour
D imens ions
He igh t
m m
m m
Width m m
D e p t h m m
Net we igh t k g
Heat exchanger typeIndoor fan type
A i r vo lume m 3/h
Fan mo to r ou tpu t W
Air f i l ter
O U T D O O R U N I T M o d e l
Appearance co lour
D imens ions
He igh t m m
Width m m
D e p t h m m
Heat exchanger type
Ne t we igh t
Outdoor fan type
A i r f l ow vo lume
Fan mo to r ou tpu t
Compresso rMode l
Outpu t
Safe ty dev ice
3
380-415
3
380-415
C O O L I N G H E A T I N GC O O L I N G H E A T I N G
4.2
89
6.8
3 .6
87
6.0
5.15
87
8.5
4 .9
88
8.0
42
47/43 /40
55
R - 2 2
3.4
50
Cap i l l a ry tube & Expans ion va lve
ø 1 9 ( ø 2 2 )
F lareø 9 . 5
F lare7 .5
50
49/45 /41
55
R - 2 2
3.9
50
Cap i l l a ry tube & Expans ion va lve
ø 1 9 ( ø 2 2 )
F lareø 9 . 5
F lare7 .5
Indoor un i t he ight 20 20
50 50
Si lky mist Si lky mist
RAV-362CH-PE RAV-462CH-PE
ø 20 ( ID) ø 20 ( ID)
50 50
2 4 0 2 4 0
1,430 1 ,630
6 4 0 6 4 0
39 44
F inned tube F inned tube
Mul t i -b lade fan Mul t i -b lade fan1 ,680 2 ,100
75 75Washab le Washab le
RAV-362AH8-PE RAV-462AH8-PE
Bronze wh i te (Munse l l 6Y7.5 /1 ) Bronze wh i te (Munse l l 6Y7.5 /1 )
1 ,240 1 ,240
9 3 0 9 3 0
3 8 5 3 8 5
1 0 7 115
F inned tube F inned tubePropel ler fan Propel ler fan
6 ,000 6 ,000
39+63 39+63
Y H 4 0 6 J A Y H 5 0 6 J A
3.0 3.75
High pressure swi tch , Fuse, Over load re lay ,Crankcase heater , Inner over load re lay
High pressure swi tch , Fuse, Over load re lay ,Crankcase heater , Inner over load re lay
A
m m
k g
m 3/h
k W
Opera t ingno ise (SPL)
Cha rge vo lume
M a x i m u m h e i g h t
W
P o w e r s o u r c e
Coo l ing capac i ty
Hea t ing capac i t y
50 50
k W 10.8 13.8
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
* N o t e 2 : ( ø 2 2 ) s h o u l d b e u s e d w h e n t h e l e n g t h o f p i p e e x c e e d s 3 0 m .
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-9-
MODELITEM RAV-162KH(W)-PE
4.5k W
k W 5.0Heat ing capac i t y
Coo l ing capac i ty
1
50
H E A T I N GC O O L I N G
2.3 2.2
P o w e r s o u r c e
Power consumpt ion
P o w e r f a c t o r 90 90
Runn ing cu r ren t 11.1 10.6
Star t ing cur rent
Opera t ing no ise (SPL)
Refr igerant
60
45/40 /38
R - 2 2
1.635
Refr igerant cont ro l
In terconnect ion p ipe
Ø12.7
F lare
Ø 6.4
F lare7 .5
H z
k W
%
A
A
dB(A )dB (A )
k g
g / m
m m
m
Indoor unit (High, Med, Low)
Outdoor un i t
Name o f re f r igeran t
Cha rge vo lume
Add. vo lume (20 -30m)
Larger s ide s ize
Coup ler s ty le
Smal le r s ide s ize
Coup ler s ty leS tandard l eng th
M a x i m u m l e n g t h(o f one way) *1 m
30
M a x i m u m h e i g h t
Indoor un i t he ight m 15
Outdoor un i t he igh t m 30
Condensa te d ra in p ipe d iamete r m mI N D O O R U N I T M o d e l RAV-162KH(W)-PE
Appearance co lour Si lky mist
Cap i l l a ry tube & Expans ion va lve
50
Dimens ions
He igh t m m 3 7 0
1,020Width m m
D e p t h m m 2 0 0
Net we igh t k g 19
Heat exchanger type F inned tubeTransverse f low fan
A i r vo lume m 3/h 7 8 0
W 27
Washab le
O U T D O O R U N I T M o d e l RAV-162AH-PE
Appearance co lour Bronze wh i te (Munse l l 6Y7.5 /1 )
Width m m
D e p t h m m
Heigh t m m 7 4 0
8 8 0
3 1 0
Net we igh t k g 61
Ø 20 ( ID)
Outdoor fan type Propel ler fan
A i r f l ow vo lume m 3/h 2 ,700
Fan mo to r ou tpu t W 39
P H 2 5 0 X 3 - 4 L SCompresso r
Mode l
Outpu t k W 2.0
Pro tec t ive dev ice H igh p ressure sw i t ch , Fuse , Crankcase hea te r , Over load re lay , B imeta l the rmos ta t
m m
220-240
F inned tube
Indoor fan type
Fan mo to r ou tpu t
Air f i l ter
D imens ions
Heat exchanger type
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
Phase
V
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-10-
ITEM MODEL RAV-262KH(W)-PE RAV-262KH(W)-PE
Indoor un i t he ight
Coo l ing capac i ty
Hea t ing capac i t y
k W
k W
7.1
7.9
P o w e r s o u r c e
Phase
V
1 3
220-240 380-415
C O O L I N G H E A T I N G C O O L I N G H E A T I N G
3.0 2.75 2.8 2 .7
88 87 86 85
14.8 13.8 4 .7 4 .6
Power consumpt ion k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur rent 25
Indoor un i t dB (A ) 46 /42 /38
53
R - 2 22.35
60
Outdoor un i t
Refr igerant
Name o f re f r igeran t
Cha rge vo lume k g
Add . vo lume (20 -30m) g / m
Cap i l l a ry tube & Expans ion va lve
Interconnect ionp ipe
Larger s ide s ize m m ø 15 .9
Coup ler s ty le F lare
Smal le r s ide s ize m m ø 9 . 5
Coup ler s ty le F lare
S tandard l eng th m 7.5
M a x i m u m l e n g t h(o f one way) *1 m 30
15
Outdoor un i t he igh t
m
m 30
Condensa te d ra in p ipe d iamete r ø 20 ( ID)
I N D O O R U N I T M o d e l RAV-262KH(W)-PE
Appearance co lour Si lky mist
D imens ions
He igh t
m m
m m 3 7 0
Width m m 1,350
D e p t h m m 2 0 0
Net we igh t k g 25
Heat exchanger type F inned tubeIndoor fan type Transverse f low fan
A i r vo lume m 3/h 1 ,200
Fan mo to r ou tpu t W 27
80
Air f i l ter
Ref r igerant cont ro l
RAV-262AH-PE RAV-262AH8-PE
7 9 0
8 8 0
3 1 0
80F inned tube
Propel ler fan
3 ,000
63
P H 3 3 0 X 3 - 4 M S Y H 3 3 0 X 3 - M S
2.2 2.2
High p ressure sw i tch , Fuse , B imeta l thermosta t ,Crankcase heater , Inner over load re lay
High pressure swi tch , Fuse, Overcur ren t re lay ,Crankcase heater , Thermosta t , Return-Lock
O U T D O O R U N I T M o d e l
Appearance co lour
D imens ions
He igh t m m
Width m m
D e p t h m m
Heat exchanger type
Ne t we igh t
Outdoor fan type
A i r f l ow vo lume
Fan mo to r ou tpu t
Compresso rMode l
Outpu t
Safe ty dev ice
A
k g
m 3/h
k W
W
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
Opera t ingno ise (SPL) dB (A )
M a x i m u m h e i g h t
Bronze wh i te (Munse l l 6Y7.5 /1 )
Washab le
H z 50
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-11-
MODEL
Power source
ITEM
Starting current
Power consumption
Running current
Power factor
Operating noise (SPL) (High, Med, Low)
Refrigerant
Phase
Hz
V
kW
%
A
A
dB(A)
Name of refrigerant
Interconnectionpipe
Larger side size
Coupler style
Smaller side size
Coupler style
mm
mm
Condensate drain pipe diameter
Appearance colour
Dimensions
Net weight
Heat exchanger type
Indoor fan type
Air volume
Fan motor output
Appearance colour
CEILING PANEL Model
Height
Width
Depth
mm
mm
mm
kg
m3/h
Net weight
Height
Depth
mm
mm
mm
kg
Dimensions Width
Air filter
Specifications are subject to change without notice.
RAV-132UH-PE
1
220-240
50
0.066
93
0.31
0.6
R-22
Ø12.7
Flare
Ø6.4
Flare
Ø32(OD)mm
Black (zinc galvanized steel+ Thermal insulator)
RBC-U262PG(W)-PE
Silky mist (Munsell 1Y8.9/0.5)
28
1000
840
7
Washable
Finned tube
Radial fan
630
25
300
840
740
28
W
41/38/35
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-12-
MODELITEM RAV-162UH-PE
4.5k W
k W 5.0Heat ing capac i t y
Coo l ing capac i ty
1
50
H E A T I N GC O O L I N G
2.3 2.2
P o w e r s o u r c e
Power consumpt ion
P o w e r f a c t o r 90 90
Runn ing cu r ren t 11.1 10.6
Star t ing cur rent
Opera t ing no ise (SPL)
Refr igerant
60
44/40 /37
R - 2 2
1.635
Refr igerant cont ro l
In terconnect ion p ipe
Ø12.7
F lare
Ø 6.4
F lare7 .5
H z
Phase
k W
%
A
A
dB(A )dB (A )
k g
g / m
m m
m
Indoor unit (High, Med, Low)
Outdoor un i t
Name o f re f r igeran t
Cha rge vo lume
Add. vo lume (20 -30m)
Larger s ide s ize
Coup ler s ty le
Smal le r s ide s ize
Coup ler s ty leS tandard l eng th
M a x i m u m l e n g t h(o f one way) *1 m
30
M a x i m u m h e i g h t
Indoor un i t he ight m 15
Outdoor un i t he igh t m 30
Condensa te d ra in p ipe d iamete r m mI N D O O R U N I T M o d e l RAV-162UH-PE
Appearance co lour B lack (z inc ga lvan ized s tee l + the rma l i nsu la to r )
Cap i l l a ry tube & Expans ion va lve
50
Dimens ions
He igh t m m 3 0 0
8 4 0Width m m
D e p t h m m 7 4 0
Net we igh t k g 29
Heat exchanger type F inned tubeIndoor fan type Rad ia l f an
A i r vo lume m 3/h 9 8 0Fan mo to r ou tpu t W 30
Air f i l ter Washab le
O U T D O O R U N I T M o d e l RAV-162AH-PE
Appearance co lour Bronze wh i te (Munse l l 6Y7.5 /1 )
D imens ions Width m m
D e p t h m m
Heigh t m m 7 4 0
8 8 0
3 1 0
Net we igh t k g 61
Ø 3 2 ( O D )
Outdoor fan type Propel ler fan
A i r f l ow vo lume m 3/h 2 ,700
Fan mo to r ou tpu t W 39
P H 2 5 0 X 3 - 4 L SCompresso r
Mode l
2 .0
Pro tec t ive dev ice H igh p ressure sw i t ch , Fuse , Crankcase hea te r , Over load re lay , B imeta l the rmos ta t
m m
220-240
F inned tube
Appearance co lour S i lky mis t (Munse l l 1Y8.9 /0 .5)
D imens ions Width m m
D e p t h m m
Heigh t m m 28
1,000
8 4 0
Net we igh t k g 8.5
Washab le
C E I L I N G P A N E L M o d e l
Air f i l ter
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
RBC-U262PG(W)-PE
Heat exchanger type
Outpu t k W
V
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-13-
ITEM MODEL RAV-262UH-PE RAV-262UH-PE
Cool ing capac i ty k W
k W
7.1
7.9
P o w e r s o u r c e V
1 3
220-240 380-415
50
C O O L I N G H E A T I N G C O O L I N G H E A T I N G
3.0 2.75 2.8 2 .7
88 87 86 85
14.8 13.8 4 .7 4 .6
Power consumpt ion k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur rent 25
Opera t ingno ise (SPL)
Indoor un i t dB (A ) 45 /41 /37
53
R - 2 2
60
Outdoor un i t dB (A )
Refr igerant
Name o f re f r igeran t
Cha rge vo lume k g
Add . vo lume (20 -30m) g / m
Cap i l l a ry tube & Expans ion va lve
Interconnect ionp ipe
Larger s ide s ize m m ø 15 .9
F lare
m m ø 9 . 5
Coup ler s ty le F lare
S tandard l eng th m 7.5
M a x i m u m l e n g t h(o f one way) *1 m 30
15
Outdoor un i t he igh t
m
m 30
Condensa te d ra in p ipe d iamete r ø 3 2 ( O D )
RAV-262UH-PE
Appearance co lour B lack (z inc ga lvan ized s tee l + the rma l i nsu la to r )
D imens ions
He igh t
m m
m m 3 0 0
Width m m 8 4 0
D e p t h m m 7 4 0
Net we igh t k g 29
Heat exchanger type F inned tubeRad ia l f an
1 ,260
Fan mo to r ou tpu t 45
80
Air f i l ter
Ref r igerant cont ro l
RAV-262AH-PE RAV-262AH8-PE
8 8 0
3 1 0
80F inned tube
Propel ler fan
3 ,000
63
2.2 2 .2
High p ressure sw i tch , Fuse , B imeta l thermosta t ,Crankcase heater , Inner over load re lay
High pressure swi tch , Fuse, Overcur ren t re lay ,Crankcase heater , Thermosta t , Return-Lock
D imens ions
He igh t m m
Width m m
D e p t h m m
Heat exchanger type
Ne t we igh t
Outdoor fan type
A i r f l ow vo lume
Fan mo to r ou tpu t
Compresso rMode l
Outpu t
Safe ty dev ice
A
k g
m 3/h
k W
W
H z
Bronze wh i te (Munse l l 6Y7.5 /1 )
7 9 0
Appearance co lour S i lky mis t (Munse l l 1Y8.9 /0 .5)
D imens ions Width m m
D e p t h m m
Heigh t m m 28
1,000
8 4 0
Net we igh t k g 8.5
C E I L I N G P A N E L M o d e l
I N D O O R U N I T M o d e l M a x i m u m h e i g h t
Hea t ing capac i t y
Smal le r s ide s ize
Coup ler s ty le
Phase
Indoor un i t he ight
Indoor fan type
A i r vo lume
O U T D O O R U N I T M o d e l
Appearance co lour
W
m 3/h
Washab le
RBC-U262PG(W)-PE
P H 3 3 0 X 3 - 4 M S Y H 3 3 0 X 3 - M S
Washab le
2.35
Air f i l ter
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-14-
MODELITEM RAV-362UH-PE RAV-462UH-PE
k W 10.0 12.5Coo l ing capac i ty
Hea t ing capac i t y k W 10.8 13.8
P o w e r s o u r c e
Phase
VH z
Power consumpt ion k W
P o w e r f a c t o r %
Runn ing cu r ren t A
Star t ing cur rent
Indoor un i t dB (A )
Outdoor un i t dB (A )Name o f re f r igeran t
Refr igerant k g
Add . vo lume (20 -50m) g / m
Interconnect ionp ipe
Larger s ide s ize *2 m m
Coup ler s ty le
Smal le r s ide s ize m m
Coup ler s ty leS tandard l eng th m
M a x i m u m l e n g t h(o f one way) *1 m
Outdoor un i t he igh t
m
m
Condensa te d ra in p ipe d iamete r
I N D O O R U N I T M o d e l
Appearance co lour
D imens ions
He igh t
m m
m m
Width m m
D e p t h m m
Net we igh t k g
Heat exchanger typeIndoor fan type
A i r vo lume
Fan mo to r ou tpu t W
Air f i l ter
Appearance co lour
D imens ions
He igh t m m
Width m m
D e p t h m m
Heat exchanger type
Ne t we igh t
Outdoor fan type
A i r f l ow vo lume
Fan mo to r ou tpu t
Compresso rMode l
Outpu t
Safe ty dev ice
3
380-41550
3
380-41550
C O O L I N G H E A T I N GC O O L I N G H E A T I N G
4.2
89
6.8
3 .6
87
6.0
5.15
87
8.5
4 .9
88
8.0
42
50/45 /42
55
R - 2 2
3.4
50
Cap i l l a ry tube & Expans ion va lve
ø 1 9 ( ø 2 2 )
F lareø 9 . 5
F lare7 .5
50
52/47 /44
55
R - 2 2
3.9
50
Cap i l l a ry tube & Expans ion va lve
ø 1 9 ( ø 2 2 )
F lareø 9 . 5
F lare7 .5
Indoor un i t he ight 20 20
50 50
RAV-362UH-PE RAV-462UH-PE
ø 3 2 ( O D ) ø 3 2 ( O D )
50 50
3 5 0 3 5 0
1,130 1 ,130
7 4 0 7 4 0
53 53
F inned tube F inned tube
Cent r i fuga l fan Cent r i fuga l fan
80 90
Washab le Washab le
RAV-362AH8-PE RAV-462AH8-PE
Bronze wh i te (Munse l l 6Y7.5 /1 ) Bronze wh i te (Munse l l 6Y7.5 /1 )
1 ,240 1 ,240
9 3 0 9 3 0
3 8 5 3 8 5
1 0 7 115
F inned tube F inned tube
39+63 39+63
3.0 3.75
High pressure swi tch , Fuse, Over load re lay ,Crankcase heater , Inner over load re lay
High pressure swi tch , Fuse, Over load re lay ,Crankcase heater , Inner over load re lay
A
m m
k g
k W
Opera t ingno ise (SPL)
Cha rge vo lume
M a x i m u m h e i g h t
W
Black (z inc ga lvan ized s tee l + the rma l i nsu la to r )
1 ,8601 ,680m 3/h
Propel ler fan Propel ler fan6 ,000m 3/h
Y H 5 0 6 J AY H 4 0 6 J A
6,000
O U T D O O R U N I T M o d e l
Appearance co lour
D imens ions Width m m
D e p t h m m
Heigh t m m
Net we igh t k g
C E I L I N G P A N E L M o d e l
Air f i l ter
S i lky mis t (Munse l l 1Y8.9 /0 .5)
28
8 4 0
10
Washab le
RBC-U462PG(W)-PE
1,290
Si lky mis t (Munse l l 1Y8.9 /0 .5)
28
8 4 0
10
Washab le
RBC-U462PG(W)-PE
1,290
Spec i f i ca t ions a re sub jec t to change w i thou t no t i ce .
* N o t e 1 : These mean ac tua l l eng th .
* No te 2 : ( ø 2 2 ) s h o u l d b e u s e d w h e n t h e l e n g t h o f p i p e e x c e e d s 3 0 m .
Refr igerant cont ro l
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-15-
2. CONSTRUCTION VIEWS
2.1 Indoor unit2.1 RAV-162BH-PE2.1 RAV-262BH-PE2.1 RAV-362BH-PE2.1 RAV-462BH-PE
Thermal insulator height 11mmaround supply air port
Un i t d imens ion : 800
6 - ø 4 M o u n t i n g s c r e w h o l e ø 1 6 0
ø 1 2 5 K n o c k o u tho le ( rear )
(Fresh a i r in let )
(Opt ion)
Long-l i fe f i l ter k i t
Suc t ion canvas
(Opt ion)Cei l ing panel
(Opt ion)
Cei l ing opening: 470
Pane l ou te r d imens ion : 500
Wi r ing connec t ion por t
(Por t d iamete r : 25 nomina l ,f o r PVC p ipes )
Dra in p ipe connec t ion por t( Inner d iameter : 32)
(Smal le r s ide øG)
Ref r ige ran t p ipeconnec t ion por t
Prov ided at s i te
Hang ing bo l t p i t ch : 565A i r ou le t
Un i t d imens ion : A
Hang ing bo l t p i t ch : B
Cei l ing open ing: D
Pane l ou te r d imens ion : E
Model A B F G H J K M NRAV-162BH-PE 700 750 12.7 6.4 252 280 280 1 2RAV-262BH-PE 10001050 15.9 9.5 252 580 290 2 3
RAV-362/462BH-P 13501400 19.0 9.5 252 930 310 3 4
(Unit: mm)
[Indoor unit]
Prov ide an inspec t ionho le a round here .
Inspec t ion ho le
Ensure that there is sufficient space around theindoor units for installation and servicing.
Hang ing bo l t
(La rger s ide øF)
Re f r ige ran t p ipeconnec t ion por t
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-16-
2.2 Indoor unitRAV-162CH-PERAV-262CH-PERAV-362CH-PERAV-462CH-PE
Greater than
400
Minim
umM
inimum
Door
Remote controller
Location slots
2-(4.5x9)
Air inlet
(Horizontal installation)
Air filter
Space required for service and installation
Right - side panelknock - out forpiping and wiring
Hanging plate(Right)
Outer hanging bolt pitch
Refrigerant piping joint (Gas øG
)
Hang ing bo l tL e s s t h a n 4 0
Knock - out holes forpiping and wiring
Hard vinyl chloride pipe inner dia. 20mm
Drain piping joint
Refrigerant piping joint (Liquid øF)
Inner hanging bolt pitch
(Hanging bolt pitch)
Greater than 500
Hanging bo l t p i tch
Hang ing bo l tL e s s t h a n 4 0
Hanging bolt hole4 - (12x25) Slot
AlternativeKnock - out holefor drain piping
Hanging plate(Left)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-17-
Ai r ou le t
(4-way ad jus tab le)
Refr igerant p ip ing jo in t
(Sma l le r s ide ø C)
Refr igerant p ip ing jo in t
(Longer S ide ø B )
Dra in p ipe(Bo th s ides )P ip ing ho le
(Knockou thole)
Long ho le
D o o r
Remote cont ro l le r
M o r e t h a n 3 0
M o r e t h a n 3 0 0 M o r e t h a n 3 0 0
Space required for service
Anchor bo l t ho le
4-10x20 long ho le
Long ho le
RAV-262KH(W)-PE
RAV-162KH(W)-PE
Long ho le
Anchor bo l t ho le
4-10x20 long ho le
P ip ing ho le
(Knockou t ho le )
Model A B C
RAV-162KH(W)-P 1020 12.7 6.4
RAV-262KH(W)-P 1350 15.9 9.5
Installation board mounting bolt hole location
2.3 Indoor UnitRAV-162KH(W)-PERAV-262KH(W)-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-18-
N V
iew
Pane l ou te r d imens ion : 840
Cei l ing opening: 780
Pane
l out
er d
imen
sion:
100
0
Ceilin
g op
enin
g: 9
40
Long
hol
e
Rem
ote
cont
rolle
r
Hang
ing
bolt
Wat
er s
uppl
ych
eck
port
Drai
n pi
pe c
onne
ctio
n po
rt
Powe
r sup
ply
conn
ectio
n po
rt
Smal
ler s
ide
B
Refri
gera
nt p
ipe
conn
ectio
n po
rt(L
arge
r sid
e A)
Refri
gera
nt p
ipe
conn
ectio
n po
rt
M o r e t h a n 1 5
2.4 Indoor UnitUnit modelRAV-132UH-PERAV-162UH-PERAV-262UH-PEPanel modelRBC-262PG(W)-PE
2Ce
iling
pane
l
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-19-
2.5 Indoor UnitUnit modelRAV-362UH-PERAV-462UH-PEPanel modelRBC-U462PG(W)-PE
M o r e t h a n 1 5
Refri
gera
nt p
ipe
conn
ectio
n po
rt
(Sm
alle
r sid
e ø9
.5)
Refri
gera
nt p
ipe
conn
ectio
n po
rt
(Lar
ger s
ide
ø19)
Powe
r sup
ply
conn
ectio
n po
rt
Drai
n pi
pe c
onne
ctio
n po
rt
Wat
er s
uppl
ych
eck
port
Hang
ing
bolt
Rem
ote
cont
rolle
r
Long
hol
e
Door
Ceilin
g pa
nel
Ceilin
g op
enin
g: 1
230
Pane
l out
er d
imen
sion:
129
0
Z V
iew
Pane l ou te r d imens ion : 840
Cei l ing opening: 780Z
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-20-
Model
RAV-162AH-PE
RAV-262AH-PERAV-262AH8-PE
A
740
790
B
380
430
C
ø6.4
ø9.5
D
ø12.7
ø15.9
2.6 Outdoor unitRAV-162AH-PERAV-262AH-PERAV-262AH8-PE
(2 -20 x 60 long ho le )
Ho le fo r d ra in
(2 -ø19 ho le )
Knock - ou t ho le fo r d ra in
(Smal le r s ide C)
Refr igerant p ip ing jo in t
( la rger s ide D)Refr igerant p ip ing jo in t
Anchor bo l t ho le
B low ou t gu idemount ing ho le
(4 -ø3 emboss ing )
(Space for wi r ingand p ip ing)
Out le t
(Space for wi r ingand p ip ing)
Out le t
Space required for service
When installed with theoutlet faced to the wall side
When installed with theinlet faced to the wall side
(Unit: mm)
(4 -12 x 18 long ho le ) Air out le t
(Bo th s ides )
Car ry ing hand leElectr ic par tsbox
Ear th sc rew
Termina l cover( M 6 )
A
B
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-21-
B low ou t gu ide moun t i ng ho le(8 - ø3 emboss ing )
Knock-ou t ho le (Bot tom)
(2 -30 x 80 long ho le fo r d ra in d isposa l )
Air in let
Air in let
(La rger s ide ø 19)
Refr igerant p ip ing jo in t
Ref r igerant p ip ing jo in t connect ion por t
(Smal le r s ide ø 9 .5 )
(4 - 12 x 18 long ho le )
Anchor bo l t ho le
Car ry ing hand le(Bo th s ides )
Termina l coverCar ry ing hand le(Front s ide on ly) Ai r out le t
Ai r out le t
Knock -ou t ho le
(ø 40)B low ou t gu ide moun t i ng ho le(8 -ø3 emboss ing )
Out le t (Space for wi r ingand p ip ing)
(Space for wi r ingand p ip ing)
Out le t
When installed with theinlet faced to the wall side
When installed with theoutlet faced to the wall side
Space required for service
2.7 Outdoor UnitRAV-362AH8-PERAV-462AH8-PE
Ear th sc rew
( M 6 )
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-22-
Sho
ws
term
inal
blo
ck a
nd f
igur
es s
how
ter
min
al n
umbe
rs.
Bro
ken
lines
sho
w w
iring
at
site
.
D
o no
t op
erat
e th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
3.1 RAV-162BH-PE/RAV-262BH-PERAV-362BH-PE/RAV-462BH-PE
Rem
ote
Con
trol
ler
Indo
or u
nit
Out
door
uni
t (3 P
hase
mod
el)
(1 P
hase
mod
el)
CN
10
(PU
MP
)
(L1)
(N) C
N0
3(S
ER
IAL)
CN
11(F
LOA
T)
K14
K1
TR
CN
12
RE
MO
CO
NT
A
TC
K4
K3
K
2
UL
L
M
H
CN
07
(FA
N)
(
)K
1ou
tput
FM
FM
BLK
YELBLU
REDBRW
GR
N/Y
EL
GR
YR
CWH
I
RE
D(F
an s
peed
incr
ease
opt
ion)
Con
nect
oras
sem
bly
(acc
esso
ry)
YELBLU
ORN
ORN
REDBLK
RED
ORN
BRW
YELBLU
BLK
Ear
thS
crew
Ear
thS
crew
CN
01
(TR
AN
S)
CN
04
(TA
)
CN
05
(TC
)
YEL
BLU
BLK
ORN
F2
F2
F
Pow
erS
uppl
y38
0/41
5V3
N
50H
z
Sym
bol
Nam
eS
ymbo
lN
ame
FM
Fan
Mot
orK
1~14
Rel
ay
RC
Run
ning
Cap
acito
rT
CS
enso
r
TR
Tra
nsfo
rmer
TA
Sen
sor
F
Fus
e (P
CB
)
Pow
erS
uppl
y22
0/24
0V
50H
z
3. WIRING DIAGRAM
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-23-
Sho
ws
term
inal
blo
ck a
nd f
igur
es s
how
ter
min
al n
umbe
rs.
Bro
ken
lines
sho
w w
iring
at
site
.
D
o no
t op
erat
e th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
3.2 RAV-162CH-PE/RAV-262CH-PERAV-362CH-PE/RAV-462CH-PE
Rem
ote
Con
trol
ler
Indo
or u
nit
Out
door
uni
t (3 P
hase
mod
el)
(1 P
hase
mod
el)
F2
K14
CN
12
RE
MO
CO
NT
A
TC
K4
K3
K
2
UL
L
M
H
CN
07
(FA
N)
(
)K
1ou
tput
CN
01
(TR
AN
S)
CN
04
(TA
)
CN
05
(TC
)
F
(LI)
TR
YEL
BLU
ORN
BLK
GR
N/Y
EL
FM
RE
D
GM
K11
CN
09(L
OU
VE
R)
CN
11(F
LOA
T)
CN
03
(SE
RIA
L)
(N)
F2
Pow
erS
uppl
y38
0/41
5V3
N
50H
z
GR
YW
HI
RC
Ear
thS
crew
Ear
thS
crew
Sym
bol
Nam
eS
ymbo
lN
ame
FM
Fan
Mot
orT
AS
enso
r
RC
Run
ning
Cap
acito
rT
CS
enso
r
TR
Tra
nsfo
rmer
GM
Gea
red
Mot
or
F
Fus
e (P
CB
)K
1~K
14R
elay
K1
Pow
erS
uppl
y22
0/24
0V
50H
z
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-24-
Sho
ws
term
inal
blo
ck a
nd f
igur
es s
how
ter
min
al n
umbe
rs.
Bro
ken
lines
sho
w w
iring
at
site
.
D
o no
t op
erat
e th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
TC
3.3 RAV-162KH(W)-PERAV-262KH(W)-PE
Rem
ote
Con
trol
ler
Indo
or u
nit
Out
door
uni
t (3 P
hase
mod
el)
Ear
thS
crew
Ear
thS
crew
(1 P
hase
mod
el)
F2
F2
(N) C
N0
3(S
ER
IAL)
CN
11(F
LOA
T)
(
)K
1ou
tput
TR
CN
12
CN
01
(TR
AN
S)
RE
MO
CO
N
TA
CN
04
(TA
)
CN
05
(TC
)
K4
K3
K
2
UL
L
M
H
YEL
RED
WHI
FM
GR
N/Y
EL
RC
K1
K14
CN
10
(PU
MP
)
F
CN
07
(FA
N)
(L1)
Pow
erS
uppl
y22
0/24
0V
50H
z
BLUORN
WHI
RED
TC
Sym
bol
Nam
eS
ymbo
lN
ame
FM
Fan
Mot
orT
AS
enso
r
RC
Run
ning
Cap
acito
rT
CS
enso
r
TR
Tra
nsfo
rmer
K1~
K14
Rel
ay
F
Fus
e (P
CB
)
BLK
Pow
erS
uppl
y38
0/41
5V3
N
50H
z
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-25-
Sho
ws
term
inal
blo
ck a
nd f
igur
es s
how
ter
min
al n
umbe
rs.
Bro
ken
lines
sho
w w
iring
at
site
.
D
o no
t op
erat
e th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
3.4 RAV-132UH-PE
Rem
ote
Con
trol
ler
Indo
or u
nit
Out
door
uni
t
(1 P
hase
mod
el)
F2
Spa
rkK
iller
Ear
thS
crew
Pow
erS
uppl
y22
0/24
0V
50H
zC
N03
(SE
RIA
L)
K14
K4
K3
K
2C
N1
0(P
UM
P)
(L1)
(N) CN
11(F
LOAT
)
F
K1
CN
01
(TR
AN
S)
RE
MO
CO
N
CN
12
CN
04
(TA
)
CN
05
(TC
)
TA
CN
07
(FA
N)
TC
UL
L
M
H
VIO
YEL
BL
U O
RN
(
)K
1ou
tput
FM
GM
CN
09(L
OU
VE
R)
GR
N/Y
EL
WHI
BLU
OR
N
BLK
VIO
WH
I
RC
DM
43
CS
43
K11
RE
D
RED
YEL
TR
Sym
bol
Nam
eS
ymbo
lN
ame
FM
Fan
Mot
or43
Rel
ay
RCR
unni
ng C
apac
itor
K1~
K14
Rel
ay
TRT
rans
form
erG
MG
eare
d M
otor
TAS
enso
rCS
Flo
at S
witc
h
TCS
enso
rD
MD
rain
Mot
or
F
Fus
e (P
CB
)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-26-
Sho
ws
term
inal
blo
ck a
nd f
igur
es s
how
ter
min
al n
umbe
rs.
Bro
ken
lines
sho
w w
iring
at
site
.
D
o no
t op
erat
e th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
3.5 RAV-162UH-PERAV-262UH-PE
F
Rem
ote
Con
trol
ler
Indo
or u
nit
Out
door
uni
t
Pow
erS
uppl
y22
0/24
0V
50H
z
Pow
erS
uppl
y38
0/41
5V3
N
50H
z
Ear
thS
crew
Ear
thS
crew
(3 P
hase
mod
el)
(1 P
hase
mod
el)
F2
F2
Spa
rkK
iller
DM
43
43C
N09
(LO
UV
ER
)
(L1)
(N) C
N0
3(S
ER
IAL)
CN
11(F
LOA
T)
GM
(
)K
1ou
tput
CN
10
(PU
MP
)
K14
K1
TR
CN
01
(TR
AN
S)
RE
MO
CO
N
CN
12
CN
04
(TA
)
CN
05
(TC
)
TA
TC
K4
K3
K
2
UL
L
M
H
RE
DW
HI
RC
WHI
GR
N/Y
EL
FM
BLU
OR
N
BLK
VIO
K11
CS
FYE
L B
LU O
RN B
LK
CN
07
(FA
N)
RED
YEL
Sym
bol
Nam
eS
ymbo
lN
ame
FM
Fan
Mot
or43
Rel
ay
RC
Run
ning
Cap
acito
rK
1~K
14R
elay
TR
Tra
nsfo
rmer
GM
Gea
red
Mot
or
TA
Sen
sor
CS
Flo
at S
witc
h
TC
Sen
sor
DM
Dra
in M
otor
F
Fus
e (P
CB
)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-27-
Sho
ws
term
inal
blo
ck a
nd f
igur
es s
how
ter
min
al n
umbe
rs.
Bro
ken
lines
sho
w w
iring
at
site
.
D
o no
t op
erat
e th
e un
its w
ith m
agne
tic c
onta
ctor
pus
hed
in.
3.6 RAV-362UH-PERAV-462UH-PE
Rem
ote
Con
trol
ler
Indo
or u
nit
Out
door
uni
t
Ear
thS
crew
(3 P
hase
mod
el)
Pow
erS
uppl
y38
0/41
5V3
N
50H
z
F2
TR
CN
01
(TR
AN
S)
(
)K
1ou
tputK
4
K
3
K2
RE
MO
CO
N
CN
12
CN
04
(TA
)
CN
05
(TC
)
TA
TC
UL
L
M
H BL
KO
RN
FM
RE
D
GM
RCW
HI
CN
11(F
LOA
T)
CN
03
(SE
RIA
L)
F
CN
10
(PU
MP
)
K11
43
43C
S
Spa
rkK
iller
DM
CN
07
(FA
N)
K1
K14
CN
09(L
OU
VE
R)
GR
Y
Sym
bol
Nam
eS
ymbo
lN
ame
FM
Fan
Mot
or43
Rel
ay
RC
Run
ning
Cap
acito
rK
1~K
14R
elay
TR
Tra
nsfo
rmer
GM
Gea
red
Mot
or
TA
Sen
sor
CS
Flo
at S
witc
h
TC
Sen
sor
DM
Dra
in M
otor
F
Fus
e (P
CB
)
(LI)
(N)
BLU
YEL
GR
N/Y
EL
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-28-
3.7 RAV-162AH-PE
Indoor unit
Outdoor unit
EarthScrew
WaveControlCircuit
F2
Power Supply 220/240V 50Hz
TR
Ear th
R Y 0 5
R Y 0 7
B L K W H I W H I
52C
20SF 20SR
26HD
52C RCC
CH
51C
CM
F
R E D
B L K
G R Y
63H
R E D
W H I W H I
R E D
FM0
B L K
B L K
B L U
T E
T L
RCO
1. Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Don't operate the units with magnetic contactor pushed.
Symbol Name Symbol Name Symbol Name
20SF Solenoid Coil (4 Way Valve) CM Compressor F2 Fuse (T5A)
RY05, 07 Relay 52C Magnetic Contactor 63H High Pressure Switch
51C Overload Relay FMo Fan Motor (Out door) CH Crank Case Heater
20SR Solenoid Coil (2 Way Valve) TL Sensor F Fuse (on PCB)
RCc Running Capacitor (Compressor) TE Sensor TR Transformer
RCo Running Capacitor (Fan motor) 26HD Bimetal Thermostat
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-29-
3.8 RAV-262AH-PE
Indoor unit
Outdoor unit
EarthScrew
WaveControlCircuit
F2
Power Supply 220/240V 50Hz
Ear th
R Y 0 5
R Y 0 7
B L K W H I W H I
52C
20SF 20SR
52C
F
R E D
B L K
W H I
FM0
B L K
B L U
T E
T L
TR
R E D R E D
G R Y W H I
B L K
RCO
RCC
CM
49C
CH
26HD
63H
1. Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Don't operate the units with magnetic contactor pushed.
Symbol Name Symbol Name Symbol Name
20SF Solenoid Coil (4 Way Valve) CM Compressor F2 Fuse (T5A)
RY05, 07 Relay 52C Magnetic Contactor 63H High Pressure Switch
49C Inner Overload Relay FMo Fan Motor (Out door) CH Crank Case Heater
20SR Solenoid Coil (2 Way Valve) TL Sensor F Fuse (on PCB)
RCc Running Capacitor (Compressor) TE Sensor TR Transformer
RCo Running Capacitor (Fan motor) 26HD Bimetal Thermostat
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-30-
3.9 RAV-262AH8-PE
EarthScrew
Indoor unit
Outdoor unit
TR
WaveControlCircuit
B L K
B L U
T E
T L
R E D
B L K B L K
R E D R E D
W H IG R Y W H I
RCO
47C
CH51C
47C
49C
51C
20SF
B L K W H I W H I
R Y 0 7
R Y 0 5F
F2
52C
Earth
FM0
CM
Power Supply 380-415V 3N 50Hz
63H
52C 1. Shows terminal block and figures show terminal numbers.
Broken lines show wiring at site.
2. When the three phases are not connected correctly, the reverse phase protectoroperates and the unit will not start. In this case check the three phase wiring.
Don't operate the units with magnetic contactor pushed.
Symbol Name Symbol Name Symbol Name
20SF Solenoid Coil CM Compressor F2 Fuse (T5A)
RY05, 07 Relay 52C Magnetic Contactor 63H High Pressure Switch
49C Inner Overload Relay FMo Fan Motor (Out door) CH Crank Case Heater
51C Overload Relay TL Sensor F Fuse (on PCB)
47C Reverse Phase Protector TE Sensor TR Transformer
RCo Running Capacitor
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-31-
3.10 RAV-362AH8-PERAV-462AH8-PE
EarthScrew
Indoor unit
Outdoor unit
Earth
F2
R Y 0 5F
52C
20SF
51C
49C
63H
CM
CH51C
52C
FM02
FM01
R E DR E D
W H IW H IG R Y
RC01
RC02
W H IW H I
R E D R E D
B L K B L K
G R Y
R E D
B L K B L K
B L U
T E
T L
WaveControlCircuit
TR
B L K W H I W H I
R Y 0 7
B L K
Power Supply 380-415V 3N 50Hz
1. Shows terminal block and figures show terminal numbers.Broken lines show wiring at site.
Don't operate the units with magnetic contactor pushed.
Symbol Name Symbol Name Symbol Name
20SF Solenoid Coil CM Compressor 63H High Pressure Switch
RY05, 07 Relay 52C Magnetic Contactor CH Crank Case Heater
49C Inner Overload Relay FM01, 02 Fan Motor (Out door) F Fuse (on PCB)
51C Overload Relay TL Sensor TR Transformer
RC01, 02 Running Capacitor TE Sensor F2 Fuse (T5A)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-32-
4. SPECIFICATIONS OF ELECTRICAL PARTS
4.1 RAV-162BH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-60-4A Output (Rated) 60W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EEP2G405HQA AC 400V, 4µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
5 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.2 RAV-262BH-PE
4.3 RAV-362BH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor STF-200-120-4 Output (Rated) 120W, 4 pole, 200V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EAG40M505UF AC 400V, 5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
5 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.4 RAV-462BH-PE
KW
KW
KW
KW
KW
KW
KW
KW
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor STF-200-100-4 Output (Rated) 100W, 4 pole, 200V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EAG40M505UF AC 400V, 5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
5 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor STF-200-140-4F Output (Rated) 140W, 4 pole, 200V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EAG40M106UF AC 400V, 10µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
5 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-33-
4.5 RAV-162CH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-34-4E Output (Rated) 34W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EEP2W255HQ AC 400V, 2.5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Geared motor MT8-3-6 AC 240V, 3W
5 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
6 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.6 RAV-262CH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-34-4D Output (Rated) 34W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EEP2W255HQ AC 400V, 2.5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Geared motor MT8-3-6 AC 240V, 3W
5 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
6 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.7 RAV-362CH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-75-4U Output (Rated) 75W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EEP2W255HQ AC 400V, 2.5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Geared motor MT8-3-6 AC 240V, 3W
5 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
6 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.8 RAV-462CH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-75-4B Output (Rated) 75W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EVM45M305UF AC 400V, 3µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Geared motor MT8-3-6 AC 240V, 3W
5 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
6 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
KW
KW
KW
KW
KW
KW
KW
KW
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-34-
4.9 RAV-162KH(W)-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor AF-230-27-4P Output (Rated) 27W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EEP2H155HQA AC 400V, 1.5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
5 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.10 RAV-262KH(W)-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor AF-230-27-4R Output (Rated) 27W, 4 pole, 230V, 1 phase, 50Hz
2 Running capacitor for indoorfan motor EEP2H155HQA AC 400V, 1.5µF
3 Transformer(Indoor unit) ST-9586 187~264V
4 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
5 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
KW
KW
KW
KW
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-35-
4.11 RAV-132UH-PE, RAV-162UH-PE, RAV-262UH-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-45A Output (Rated) 45W, 6 pole, 1 phase, 230V, 50Hz
2 Running capacitor for indoorfan motor EVM45M305UF AC 400V, 2.5µF
3 Transformer forIndoor unit ST-9586 AC187~264V
4 Relay LY2F AC240V, 2ab
5 Geared motor MT8-3-3 AC 240V, 3W
6 Drain pump PAD-416A34TF AC230V, 0.2A
7 Float switch FS-085-003B AC230V, 0.5A
8 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
9 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
4.12 RAV-362UH-PE
4.13 RAV-462UH-PE
KW
KW
KW
KW
KW
KW
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-90-4A Output (Rated) 90W, 6 pole, 1 phase, 230V, 50Hz
2 Running capacitor for indoorfan motor EEP2G405HQ1 AC 400V, 4µF
3 Transformer forIndoor unit ST-9586 AC187~264V
4 Relay LY2F AC240V, 2ab
5 Geared motor MT8-3-3 AC 240V, 3W
6 Drain pump PAD-416A34TF AC230V, 0.2A
7 Float switch FS-085-003B AC230V, 0.5A
8 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
9 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
No. PARTS NAME TYPE SPECIFICATIONS
1 Indoor unit fan motor SMF-230-90-4A Output (Rated) 90W, 6 pole, 1 phase, 230V, 50Hz
2 Running capacitor for indoorfan motor EVM45M305UF AC 450V, 3µF
3 Transformer forIndoor unit ST-9586 AC187~264V
4 Relay LY2F AC240V, 2ab
5 Geared motor MT8-3-3 AC 240V, 3W
6 Drain pump PAD-416A34TF AC230V, 0.2A
7 Float switch FS-085-003B AC230V, 0.5A
8 Sensor for room temperature Maximum input38mA
°C 15 20 25 30 40
16.1 12.6 10.0 8.0 5.2
9 Indoor unit sensor for heat-exchanger temp. DTN-C103J40 Maximum input
34mA
°C –12 0 25 50
62.29 32.82 10.0 3.59
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-36-
4.14 RAV-162AH-PE
KW
KW
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor PH250X3-4LS Output (Rated) 2.0 kW, 2 pole, 220/240V, 1 phase,50Hz
2 Outdoor unit fan motor SMF-230-39N-2 Output (Rated) 39W, 6 pole, 230V, 1 phase, 50Hz
3 Running capacitor foroutdoor fan motor EEP2G405HQ AC 400V, 4 µF
4 Magnetic contactor FMca-1S AC 220-240V, 50Hz
5 High pressure switch ACB-2TBO4W Tripping pressure 30kg/cm²G Resettingpressure 23kg/cm²G
6 Soleniod coil for four-wayvalve CHV-AC240V AC 220-240V
7 Crankcase heater AC 240V, 28W
8 Sensor for defrosting Maximum input 15.5mA°C –12 10
67.5 21.3
9 Fuse 5A
10 Sensor for cooling operationin low ambient temperature
Maximum input15.5mA
°C –12 10
67.5 21.3
11 Soleniod coil for two-wayvalve NEV AC 240V AC 220-240V, 50Hz
12 Running capacitor forcompressor MT-44MP456W AC 440V 45µF
13 Transformer(Outdoor unit) FT-67 187-264V
14 Overload relay OL-177GM15 AC 240V, Tripping temp: 165°C, Resetting temp: 80°C
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-37-
4.15 RAV-262AH-PE
KW
KW
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor PH330X3-4MS Output (Rated) 2.2 kW, 2 pole, 3 phase, 220/240V,50Hz
2 Outdoor unit fan motor SMF-230-63N-2 Output (Rated) 63W, 6 pole, 1 phase, 230V, 50Hz
3 Running capacitor foroutdoor fan motor EEP2G405HQ AC 400V, 4µF
4 Magnetic contactor FMca-1S AC 220~240V, 50Hz
5 High pressure switch ACB-2TBO4W Tripping pressure 30kg/cm²G Resettingpressure 23kg/cm²G
6 Soleniod coil for four-wayvalve CHV-AC240V AC 220~240V
7 Crankcase heater AC 240V, 28W
8 Sensor for defrosting Maximum input 15.5mA°C –12 10
67.5 21.3
9 Fuse 5A
10 Sensor for cooling operationin low ambient temperature
Maximum input15.5mA
°C –12 10
67.5 21.3
11 Bimetal thermostat CS-7 Tripping temp: 110°C Resetting temp:90°C
12 Solenoid coil for two-wayvalve NEV202DXF AC 220-240V, 50Hz
13 Transformer for outdoor unit FT-67 AC 187~264V
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-38-
4.16 RAV-262AH8-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor YH330X3-MS Output (Rated) 2.2kW, 2 pole, 380~415V, 3 phase,50Hz
2 Outdoor unit fan motor SMF-230-63N-2 Output (Rated) 39W, 6 pole, 230V, 1 phase, 50Hz
3 Running capacitor foroutdoor fan motor EEP2G405HQ AC 400V, 4 µF
4 Magnetic contactor FMSA-1 AC 220V~240V, 50Hz, Tripping current: 7.5A, Resetting manual
5 High pressure switch ACB-2TBO4W Tripping pressure 30kg/cm²G Resettingpressure 23kg/cm²G
6 Soleniod coil for four-wayvalve CHV-AC240V AC 220~240V
7 Crankcase heater AC 240V, 28W
8 Sensor for defrosting Maximum input 15.5mA°C –12 10
67.5 21.3
9 Fuse 5A
10 Sensor for cooling operationin low ambient temperature
Maximum input15.5mA
°C –12 10
67.5 21.3
11 Thermostat CS-7 Tripping temp: 120°C, Resetting temp: 90°C
12 Transformer FT-67 AC 187~264V
13 R t l k STR 4AB AC 400/440V
KW
KW
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-39-
4.17 RAV-362AH8-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor YH406JAOutput (Rated) 3.0 kW, 2 pole, 3 phase 380/415V, 50Hz
Winding resistance 2.88 , at 20°C
2 Outdoor unit fan motorSMF-230-63N-2 Output (Rated) 63W, 6 pole, 1 phase, 230V, 50Hz
SMF-230-39N-2 Output (Rated) 39W, 6 pole, 1 phase, 230V, 50Hz
3 Running capacitor foroutdoor fan motor EEP2G405HQA114 AC 400V, 4 µF
4 Magnetic contactor FMSA-1 AC 230V, 50Hz, Tripping current 9A, Resetting manual
5 High pressure switch ACB-2TBO4WTripping pressure 30kg/cm²G Resettingpressure 23kg/cm²G
6 Soleniod coil CHV-AC240V AC 220~240V
7 Crankcase heater AC 240V, 58W
8 Outdoor unit sensor forheat-exchanger temp. Maximum input 15.5mA
°C –12 10
67.5 21.3
9 Transformer for outdoor unit FT-67 AC 187~264V
10 Fuse 5A
11 Sensor for cooling operationin low ambient temperature Maximum input 15.5mA
°C –12 10
67.5 21.3
KW
KW
W
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-40-
4.18 RAV-462AH8-PE
No. PARTS NAME TYPE SPECIFICATIONS
1 Compressor YH506JAOutput (Rated) 3.75kW, 2 pole, 3 phase, 380/415V, 50Hz
Winding resistance 2.29 at 20°C
2 Outdoor unit fan motorSMF-230-63N-2 Output (Rated) 63W, 6 pole, 1 phase, 230V, 50Hz
SMF-230-39N-2 Output (Rated) 39W, 6 pole, 1 phase, 230V, 50Hz
3Running capacitor for outdoorfan motor
EEP2G405HQA114 AC 400V, 4 µF
4 Magnetic contactor FMSA-1 AC 230V, 50Hz, Tripping current 12A, Resetting manual
5 High pressure switch ACB-2TBO4WTripping pressure 30kg/cm²G Resettingpressure 23kg/cm²G
6 Soleniod coil CHV-AC240V AC 220~240V
7 Crankcase heater AC 240V, 58W
8Outdoor unit sensor forheat-exchanger temp.
Maximum input 15.5mA°C –12 10
67.5 21.3
9 Transformer for outdoor unit FT-67 AC 187~264V
10 Fuse 5A
11Sensor for cooling operation in lowambient temperature
Maximum input 15.5mA°C –12 10
67.5 21.3KW
KW
W
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-41-
Cooling
Heating
5. REFRIGERANT PIPING DIAGRAM
Refrigerant pipe (Smaller side)ø6.4mm (1/4" )
Strainer
Heat exchanger
Indoor unit
Distributor strainercapillary tubeø2.0 x 200l x 2P
Refrigerant pipe (Larger side)ø12.7mm (1/2" )
5.1 Indoor unitRAV-132UH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-42-
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAINCAPILLARY
BYPASSCAPILLARY
RAV-162BH-PE IDø 2x200 x3P
RAV-162AH-P IDø 2.4x500 x1P IDø 0.8x1000 x1PRAV-162CH-PE IDø 1.7x400 x4P
RAV-162KH(W)- IDø 1.7x200 x2P
RAV-162UH-PE IDø 2x200 x2P
Cooling
Heating
Packed valvePacked valve
Strainer
Capillary tubeø2.4 x 500l x 1P
Dryer
Expansionvalve Check valve
TL sensor
TE sensor Check joint
Capillary tubeø0.8 x 1000l x 1P
High pressure switch
Refrigerant pipe (Smaller side)ø6.4mm (1/4")
Outdoor unit
Strainer
Heat exchanger
Indoor unit
Distributor2-wayvalve
Heat exchanger
StrainerFour-way valve
AccumulatorCompressor
Refrigerant pipe (Larger side)ø12.7mm (1/2")
5.2 Indoor unitRAV-162BH-PERAV-162CH-PERAV-162KH(W)-PERAV-162UH-PE
Outdoor unitRAV-162AH-PE
Distributor strainercapillary tube
Cooling Heating
P1 Highpressure
Lowpressure
Low
Line Pressure
l
l
l
l
ll
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-43-
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAINCAPILLARY
BYPASSCAPILLARY
RAV-262BH-PE IDø 2x200 x4P
RAV-262AH-P IDø 2.6x900 x1P IDø 1x500 x1PRAV-262CH-PE IDø 2.2x200 x6P
RAV-262KH(W)- IDø 1.7x150 x3P
RAV-262UH-PE IDø 1.7x400 x4P
5.3 Indoor unitRAV-262BH-PERAV-262CH-PERAV-262KH(W)-PERAV-262UH-PE
Packed valve
Check valve
TL sensor
Cooling
Heating
Packed valve
Strainer
Capillary tube
Dryer
Expansion valve
TE sensor Check joint
Four-way valve
High pressure switch
CompressorAccumulator
Strainer
Outdoor unit
Heat exchanger
Indoor unit
Strainer
TC Sensor
Refrigerant pipe (Smaller side)ø9.5mm (3/8" )
Refrigerant pipe (Larger side)ø15.9mm (5/8" )
CheckValve
2-wayvalve
Distributor
Heat exchanger
Bypasscapillarytube
l
Outdoor unitRAV-262AH-PE
Distributor strainercapillary tube
l
l
l
l l
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-44-
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL CAPILLARY
RAV-262BH-PE IDø 2x200 x4P
RAV-262AH8- IDø 2.6x700 x1PRAV-262CH-PE IDø 2.2x200 x6P
RAV-262KH(W)- IDø 1.7x150 x3P
RAV-262UH-PE IDø 1.7x400 x4P
5.4 Indoor unitRAV-262BH-PERAV-262CH-PERAV-262KH(W)-PERAV-262UH-PE
Outdoor unitRAV-262AH8-PE
Packed valve
Refrigerant pipe (Smaller side)ø9.5mm (3/8")
Packed valve
Strainer
Capillary tubeø2.6 x 700l x 1P
Dryer
Expansionvalve
Checkvalve
Check valve
TE sensor Check joint
Four-way valve
High pressure switch
Strainer
Outdoor unit
Indoor unit
Heat exchanger
TC Sensor
Strainer
Cooling
Heating
Refrigerant pipe (Larger side)ø15.9mm (5/8")
Distributor
TL sensor
Heat exchanger
Compressor
Accumulator Muffler
Distributor strainercapillary tube
l
Cooling Heating
P1 Highpressure
Lowpressure
Low
Line Pressure
l
l
l
l
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-45-
INDOOR UNIT OUTDOOR UNIT
MODEL CAPILLARY MODEL MAINCAPILLARY
BYPASSCAPILLARY
RAV-362BH-PE IDø 2x400 x6P
RAV-362AH8- IDø 2.4x650 x1P IDø 1.7x1000 x1PRAV-362CH-PE IDø 2x300 x7P
RAV-362UH-PE IDø 2x300 x8P
RAV-462BH-PE IDø 2.2x200 x6P
RAV-462AH8- IDø 3x600 x1P IDø 2x1000 x1PRAV-462CH-PE IDø 2x200 x8P
RAV-462UH-PE IDø 2x300 x8P
Packed valve
Refrigerant pipe (Smaller side)ø9.5mm (3/8")
Packed valve
Strainer
Expansionvalve
Check valve
Check joint
Four-way valve
High pressure switch
Outdoor unit
Indoor unit
Capillary tubeDryer
BypassCapillarytube
Heat exchanger
Distributor strainercapillary tube
Strainer
TC Sensor
Cooling
Heating
Refrigerant pipe (Larger side)ø19mm (3/4")
Distributor
TL sensorHeat exchanger
Accumulator
CompressorMuffler
5.5 Indoor unitRAV-362BH-PERAV-362CH-PERAV-362UH-PERAV-462BH-PERAV-462CH-PERAV-462UH-PE
Outdoor unitRAV-362AH8-PERAV-462AH8-PE
Cooling Heating P1 High
pressureLow
pressureLow
Line Pressure
TE sensor
l
Strainer
l
ll
l
l
l
l
l
l
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-46-
BUTTON INDICATOR OPERATIONON/OFF
MODE SELECT
TIME ADJUST
TIMER SELECT
-46--46-
6. REMOTE CONTROLLER6.1 Remote controller
ON TimerOFF Timer
ON → OFF Timer
OFF → ON Timer24H CYCLE Timer
ON
OFF
ON → OFF
ON ← OFF
CYCLE
(1) CLOCK
(2) ON TIME
(3) OFF TIME
Temperature setting
AUTO
LOW
MED
HIGH
Auto Fan Speed ControlLow Fan SpeedMed. Fan SpeedHigh Fan Speed
AUTO
COOL
HEAT 1
HEAT 2
FAN ONLY
LED (RED)
MODE
FAN
TIME
TIMER
Auto ChangeoverCoolingHeatingHeating(with indoor fan operation at defrost)Fan only
(1) Present Time Adjust(2) ON Time setting(3) OFF Time setting
Run/Stop
TEMP.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-47-
6.2 Outline of remote controller's functions
[ON/OFF]When this button is pushed once, the air conditioner is turned on,with the operation lamp coming on.
If pushed once more, it will be turned off, the operation lamp going off.
If pushed for 5 sec. in the mode of turning on the air conditioner, goes into test run mode.
Each time this button is pushed, the [MODE] setting is changed overcyclically, [AUTO] Þ [COOL] Þ [HEAT1] Þ [HEAT2] Þ[FAN ONLY] Þ [AUTO].
If pushed continuously, the setting will be changed in one stepevery 0.5 sec.
Each time this button is pushed, the [FAN] setting is changed overcyclically, [AUTO] Þ [LOW] Þ [MED] Þ [HIGH] Þ [AUTO].
If pushed continuously, the setting will be changed in one stepevery 0.5 sec.
Each time [TIME ADJUST] button is pushed, the [TIME] display ischanged cyclically. The time can be changed while the TIME displaystays flashing.
(flashing) (flashing) (flashing)[CLOCK] Þ [CLOCK] Þ [ON TIME] Þ [OFF TIME][12:00] [12:00] [6:00] [18:00]
While the TIME display stays flashing, the time gains one minuteupon each pressing of [+].
If [+] is pushed continuously, the time gains 10 minutes every 0.25 sec.
While the TIME display stays flashing, the time goes back oneminute upon each pressing of [– ].
If [– ] is pushed continuously the time goes back 10 minutes every0.25 sec.
Each time the [TIMER SELECT] button is pushed, timer modechanges over cyclically, [ ] (CONTINUE) Þ [ON] Þ [OFF] Þ[ON Þ OFF] Þ [ON OFF] Þ [CYCLE] Þ [ ].
If pushed continuously, the timer mode will be changed in one stopevery 0.5 sec.
Pressing this key for 0.5 sec. provides [MALFUNCTION CHECK],indicating on liquid crystal the contents of inspection in the sequenceof (times of compressor-on) Þ (contents of malfunction for #1 unit) Þ(contents of malfunction for #2 unit) Þ .......
Pressing this key for 5 sec. gives “Indoor microcomputer reset mode”to reset the indoor microcomputer by way of hardware.
Pressing this key for 10 sec. gives “Check contents clear mode” toclear the contents of inspection stored in the remote controllerprovided, however, times of compressor-on is not cleared.
MODESELECT
TIMEADJUST
+
TIMEADJUST
Reset
The indication of theindoor unit which has notany malfunction content isskipped.
By pressing the reset key, the remote controller is reset by way ofhardware. (The setting/display are in initial values with the checkmemory cleared.)
If time is not set,12:0016:0018:00
are set automatically.
In the 18-29°Control range
Fan speed
–
Þ
Each time [+] this button is pushed, the [TEMP] setting oftemperature is raised by 1°C.
If [+] is pushed continuously, the setting will be raised by 1°Cevery 0.5 sec.
Each time [– ] button is pushed, the setting of temperature is loweredby 1°C.
If [– ] is pushed continuously, the setting will be lowered by 1°Cevery 0.5 sec.
+
–
NO KEY SWITCH OUTLINE OF SPECIFICATION REMARKS1
2
3
4
5
6
7
CHECK
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-48-
How to set the present time
1)
2) Time is set by Time setting switch (–) or (+). The setting is finished when (–) or (+) buttons are released. Pressing [TIMEADJUST] three times gives the display of the present time.(If left as it is, after 15 sec. the display will go back to the present time).
How to set ON TIME
1)
2) Time is set by Time setting switch (–) or (+). The setting is finished when (–) or (+) buttons are released. Pressing [TIMEADJUST] twice gives the display of the present time.(If left as it is, after 15 sec. the display will go back to the present time).
How to set OFF TIME
1)
2) Time is set by Time setting switch (–) or (+). The setting is finished when (–) or (+) buttons are released. Pressing [TIMEADJUST] gives the display of the present time.(If left as it is, after 15 sec. the display will go back to the present time).
6.3 Timer operation
Continuous operation and timer operations are available. The setting of timer operation can be done as follows:ON, OFF, ON Þ OFF, OFF Þ ON, ON Þ OFF CYCLE.
6.3.1 Time display
The present time is always displayed
The display of the ON/OFF time is only in setting the time.
Once set, it will not change even after carrying out the timer operation until the timer is reset
Initial set time The present time 12:00The time of ON 16:00The time of OFF 18:00
6.3.2 How to set the time
Liquid crystal
Þ
As to (– ) and (+), change takes placeby one minute by pressing once and10 min./0.25 sec. by pressing continuously.
[TIME ADJUST] switch is pressed.[CLOCK] and Time figures flash.
[TIME ADJUST] switch is pressed twice.[ON TIME] and Time figures flash.
[TIME ADJUST] switch is pressed three times.[OFF TIME] and Time figures flash.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-49-
The following can be chosen sequentially bypressing [TIMER SELECT] switch:1) [TIMER] ON2) [TIMER] OFF3) [TIMER] ON OFF4) [TIMER] ON OFF5) [TIMER] CYCLE
Þ
Þ
Þ
Þ
ON
OFFPresent time ON TIME OFF TIME
[TIMER] OFF [TIMER] ON Þ OFFON
OFF
Presenttime
Display
Display[TIMER] ON Þ OFF
[TIMER] ON OFFON TIME [TIMER] ON OFFOFF TIME
Þ
Þ
Pressing ON/OFF key[TIMER] ON
6.3.3 How to set the timer operation
Timer mode display
l Be sure to set the present time.
l In case of reoperating after finishing timer operation. If [TIMER SELECT] is not altered, the timer operation will beperformed again.
Timer ON operation
1) [TIMER] ON is applied.
2) ON/OFF key is pressed. Then LED is lighted. When the set [ON TIME] comes, the operation starts and OPERATIONdisplay appears on the liquid crystal, and the [TIMER] ON display goes off.
3) LED and OPERATION display goes off upon pressing ON/OFF key for stopping and [TIMER] ON is displayed.
Timer OFF operation
1) [TIMER ] OFF is applied.
2) ON/OFF key is pressed. Then LED is lighted and the operation starts with OPERATION displayed on the liquid crystal.
3) When the set [OFF TIME] comes, the operation stops and the LED, OPERATION display goes off with [TIMER] OFFdisplayed.
ON OFF timer operation
1) [TIMER] ON Þ OFF or [TIMER] ON OFF is applied.
2) ON/OFF key is pressed. LED comes on and the operation is performed as below:
[TIMER] ON Þ OFF
Repeated operation
1) [TIMER] CYCLE is applied.
2) ON/OFF key is pressed. Then LED is lighted and ON OFF timer operation is repeated according to the ON timeand OFF time (repeating every day as it is a 24-hour timer).
3) The operation key is pressed. LED goes off and operation stops.
Timer stand-by display and operation display
Waiting on the timer is displayed by LED lighting while the actualoperation is displayed by OPERATION on liquid crystal.
OPERA-TION Displaying
actualoption
Þ
[TIMER] ON OFF
Þ
HIGH
MODESELECT
FANSELECT
COOL
Þ
Þ
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-50-
6.4 Malfunction check monitor
6.4.1 The times of compressor ON as well as the check code are displayed on the time display area bypressing CHECK key.
Judgement from operation status
(a)
Unit No. Check code
[CHECK] switch
Provides check code display bypressing for one second and indoormicrocomputer reset by pressingfor 5 seconds.
* Remote controller clear by press-ing the key for 10 sec. Check codeis cleared (normally not used).
(a) Reset key (pushed by a needle andthe like). Resetting remote controller(to the initial setting).
* With drain pump units only
Note : If the red LED on the remote controller does not flash when the system is switched on, then the wiring to the outdoor unit needs to bechecked to ensure that the three phases are wired in the correct sequence. (RAV-262AH8 unit only.)
OPERATION STATUS COD CAUSE
1.Compressor stays off in cooling: it is not turned off inheating. 0C
Open-circuit in room temperaturesensor.
Compressor stays off in heating: it is not turned off incooling.
Short-circuit in room temperaturesensor.
2Indoor fan stays off in heating.
0dOpen-ciruit in indoor heat-exchangersensor.
Outdoor fan continues ON-OFF operation inheating.
Short-circuit in indoor heat-exchangersensor.
3. Though indoor unit operates, outdoor unit remainsoff. 04 Abnormality in connecting cable
between indoor and outdoor units.
4. Indoor fan does not work in heating operation.Warm air comes out in cooling operation. 08
4-way valve coil burnt out, pipeclogged, abnormality in indoorheat-exchange sensor.
5. Indoor fan at LOW speed in cooling operation withthe outdoor remaining in stoppage. 09
Refridgerant gas in shortage.abnormality in indoor heat-exchangesensor.
6. Full stop 18 Open or short-circuit in outdoor TEsensor.
7. Full stop 19 Open or short-circuit in indoor TLsensor.
8. Full stop 21 Pressure switch does not reset withinthe set time.
9 I d it d t t t ll 99Abnormality in connecting cableb t t t ll d i d
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-51-
6.4.2 How to read malfunction check monitor display
By pressing [CHECK] key, times of No. 1 unit compressor-ON actuations as well as the check code information of 2 faults x 16units are displayed on the time display area. (2 sec. per one phenomenon)
< Times of compressor-ON >
Display in 4 digits of hexadecimal notation 163 x 0 + 162 x 0 + 16 x 10 + 4 = 164
Display in 7 segments
< Check code information >
No display is made if there is no fault.
Ex. in case of the number of times ofcompressor actuations of 164.
Unit number Check code
The first detectedThe last detected
Ex. In case of room temperature sensor of No. 1 unit in trouble.
For No. 15 unit, firstly heat exchanger temperature sensor andsecondly float switch circuit are faulty.
hexadecimal digitdecimal digit
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-52-
6.4.3 List of Check Codes
Out of place, break,short-circuit.
Operationcontinuing
1. Check the indoor temp. sensor.2. Check the indoor PC board.
INDOORHEAT-EXCHANGERSENSOR (TC).
Out of place, break,short-circuit.
Operationcontinuing
1. Check the indoor heat-exchanger sensor.2. Check the indoor PC board.
RETURN SIGNALNOT COMING TOINDOOR
Operationcontinuing
1) Wrong wiring in connectingcable (serial signal).
4-WAY VALVESYSTEM
1) Indoor heat-exchangertemperature rises, afterstarting cooling operation.
2) Indoor heat-exchangertemperature drops afterstarting heating operation.
Operationcontinuing
1. Check the 4-way valve.2. Check the 2-way valve and check valve.3. Fault with indoor heat exchanger sensor.4. Check the indoor PC board.
OTHER CYCLESYSTEM
1) Indoor heat exchangetemperature does notchange after startingcooling/heating operation.
2) When transmittinginstruction for stoppingcompressor by freezepreventing control.
Operationcontinuing
1. Compressor case thermostat, IOL, OL operation.(contactor OFF, compressor stops: AH8 Models)(contactor ON, compressor stops: AH Models)
2. Indoor heat-exchange sensor out of place.3. Check the indoor PC board.4. Check that service valves are OPEN.
Outdoor unit stops(indoor fan L)
1. Check the charged amount of refrigerant gas.(Gas shortage → gas supplement, check for gas leaks)
2. Indoor fan locked.
DEFROST SENSOR(TE)
Full stop 1. Check the defrosting sensor.2. Check the outdoor PC board.
ROOM TEMP.SENSOR (TA).
Out of place, break, short-circuit.
1. If outdoor unit does not work at all.(1) Check the connecting cable correct wrong wiring.(2) Check the outdoor PC board.
2. If operates normally.Between indoor terminal plates 2 and 3, return signal is:Available: Check the indoor PC board.Not available: Check the outdoor PC board.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-53-
OUTDOORHEAT-EXCHANGERSENSOR (TL)
Out of place, break,short-circuit.
Full stop 1. Check the outdoor heat-exchanger sensor.2. Check the outdoor PC board.
HIGH PRESSURESWITCH
High pressure switch does notreset.
5 sec in cooling30 sec in heating
Full stop 1. Check the high pressure switch.2. Check the outdoor PC board.
Compressor does not operate.Start once, but soon after stopby OCR
OTHERABNORMALITY OFOUTDOOR UNIT
Full stop 1. Check the compressor.2. Check the wiring of compressor.
(lack of phase, short circuit)3. Check the voltage.4. Check the outdoor PC board.
WRONG WIRING OFREMOTE CONTROLUNIT
Indoor unit does not operateat all.
Full stop 1. Check the wiring between remote control unit and indoorunit.
2. Check the indoor unit PC board.
FLOAT SWITCH
Float circuit out of position,break.
Outdoor unitstops
1. Fault in drain pump.2. Drain pipe clogged.3. Check for indoor PC board.
* With drain pump unit only.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-54-
Dip switchsettings
(DSW01)LED
1 (RED) 2 (YELLOW) 3 (YELLOW) 4 (YELLOW) Table-1
Table-2 Number of protective deviceoperations
Table-3 Serial input data
Table-4 Serial output data
6.5 Malfunction check
6.5.1 Using LED display on outdoor PC board
LED display vs. check code
POSITIONS OF DIP SWITCH AND LED
Dip Switch (SW01)
LED D04 (orn)Serial input
D05 (grn)Serial output
PC Board
18 Temp. sensor (TE)faulty
19 Temperaturesensors TD/TLopen/short circuit.
21 High pressureswitch fault
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-55-
Dip switchsettings
LEDJudgement
1 2 3 4
Normal operation
Timer short
Fullstop
21 High pressure switch fault
18, 19 Fault codes (Refer to Table-2)
Dip switchsettings
LEDJudgement
1 2 3 4
Normal operation
Number of protective device operations: one
Number of protective device operations: two
Number of protective device operations: three
LEDs 3 & 4flashing (1Hz)faults shownbelow.
Number of protective device operations: four
Fullstop
18 Temperature sensor (TE) faulty19 Temperature sensors (TD/TL) open/shortcircuit
21 Hi h ressure switch fault
<Table-1>
<Table-2>
LED Status
: on
: :5Hz flash
: :1Hz flash
: off
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-56-
Dip switchsettings
LEDStatus of compressor
1 2 3 4
Stop
Operating
Dip switchsettings
LEDStatus of compressor
1 2 3 4
Stop
Operating
<Table-3>
<Table-4>
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-57-
NO ITEM OUTLINE OF SPECIFICATIONS REMARKS1 Discrimination
2
REMOTECONTROLLERINSTRUCTION
OUTLINE OF CONTROL
StopAutoCool
Heat 1
Heat 2
Fan only
3
In cooling In heating
ONON
ONOFF
OFFON
OFFOFF
0 deg 2 deg 4 deg 6 deg
7. OUTLINE OF CONTROL CIRCUIT
3-2 Operating point is compressor - off.3-3 Operating temperature accuracy: ± 1°C3-4 Differential: 1 deg
Ts (Max) = 35°C
Discrimination of outdoor unit is performed either in the reset of power source orwhen stopping from operating condition, and the controlling is changed over inaccordance with the result of discrimination.
Operation mode is changed over according to operation mode select instructionfrom the remote controller.
Operationchange-over
Stopping air conditioner
Performing automatic change-over
Performing cooling operation
Performing heating operation
Performing heating operation withindoor fan operation at defrosting
Performing fan only operation
Controlling roomtemperature
3-1 Adjusting range (°C)
Remote controllersetting temperature
Operating temperature
Dip switch 1Setting 2
Control temperaturecompensation
Correctingtemperaturecompensation
3-5 Room temperature controlled in the heating operation can be corrected by3-5 dip switch of indoor microcomputer.
18 ~ 29 18 ~ 29
18 ~ 29 20 ~ 31
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-58-
4-1 [HIGH], [MED], [LOW] and [AUTO] are available.4-2 [Ultra low] or [Stop] when compressor is turned off while heating is being4-2 performed.4-3 In the auto fan, the fan speed is changed by the difference between Ta and Ts,4-2 as shown below.
[Stop] is cold draftprevented by Tc.
When performing heating operation,indoor fan control is carried out asfollows based on temperature detectionof Tc sensor.
C zone: Depending upon fanspeed setting of theremote controller
B zone: Indoor fan at “L”
A zone: Fan stop
When performing cooling operation, thefollowing control is done based on temperature detection of Tc sensor.
When starting the operation, the pointP is made +3°C.When [J] zone is detected, timer counting starts.When [K] zone is detected,timer counting is discontinuedand held on.When [I] zone is detected, timer iscleareed for returning back toordinary operation.When timer counting becomes full time, the ourdooor unit stops and the point Pis changed to +12°C to be covered by check display.When [I] zone is reached, the temperature is returned back to +3°C. Full Time
MIN 7 min.MAX 20 min.
5 Cold draftpreventing control
6 Freeze preventingcontrol(Low temp. release)
4 Fan speed control
NO. ITEM OUTLINE OF SPECIFICATIONS REMARKS
-Cooling- -Heating- -Auto-changeover-
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-59-
When the high temperature release is received, the release control continues for 3minutes at least even if release is performed on the way, and H-1 is performed for20 minutes and the machine returns to normal operation. When the release signalcontinues for more than 3 minutes, H-1 operation of outdoor fan control isperformed at the same time as releasing the release and the machine returns tonormal operation.When the high temperature release is received during operation of H-1 for 20minutes, operation of the previous time –1 of reset operation is performed for 20minutes after release operation.If the release signal is not received during reset operation for 20 minutes, resetoperation of +1 per 20 minutes is performed and the machine returns to normaloperation.The high temperature release control is ignored during defrosting operation.
Release of H–α discontinued:-When stopping operationWhen changingover operation
When performing heating operation, the following control is done based ontemperature detection of Tc sensor.
In [M] zone, release signal istransmitted.Outdoor fan is controlled inaccordance with the diagramsbelowThe control point for A and C canbe chosen from the below table:
R e l e a s e O N R e l e a s e O F F
O NRelease signal OFF
For 3 m inu tes Fo r 20 m inu tes
Reset opera t ion
Outdoor fan HH-1H-2H-3
L – α
Outdoor fan
L – α
R e l e a s e O N R e l e a s e O F F
O NRelease signal OFF
For 3 m inu tes For 20 minutesor less
Single release
Duplicate release
R e l e a s e O N R e l e a s e O F F
Reset operation
O NRelease signal OFF
Outdoor fan HH-1H-2H-3
L – α
F o r 2 0minu tes
F o r 2 0minu tes
F o r 2 0minu tes
HH-1
For 20 minutesor less
F o r 2 0minu tes
Norma loperat ion
L–α=0(fan stop)
7 High temperaturerelease control
NO. ITEM OUTLINE OF SPECIFICATIONS REMARKS
Dip Switch 3Setting 4
ON ON ON OFFOFFON
OFFOFF
A/C (°C) 54/52 58/56 60/58 -
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-60-
L–α=0 (fan stops)
2 m i n u t e s a n d2 0 s e c .
1 2 0 s e c . 3 0 s e c .
C o m p r e s s o r O NO F F
O u t d o o r f a n H
L – α
* W h e n t h e o u t d o o r f a n H i s r e s t r i c t e d t o ( H – α) i n t he h i gh* t e m p e r a t u r e r e l e a s e , H i n t h e a b o v e f i g u r e i s ( H – α).
<Outdoor unitcontrol>LED lamp comes onin abnormalcondition, withabnormal codetransmitted to indoorunit.
When stoppage takes place in [HEAT 2] operation, indoor fan is operated in[LOW] for 30 sec.
If Remote controller's ON/OFF switch is pressed 5 seconds continuously, theunit goes into test run mode with the indoor fan in the [HIGH].
The following control is performed when high pressure switch of the outdoor unit is actuated.
In cooling operationCompressor is turned off and if the high pressure switch does not reset for 5seconds continuously thereafter, it is judged abnormal.In heating operationCompressor is turned off and if the high pressure switch does not reset for30 seconds continuously thereafter, it is judged abnormal. If the switchresets within 30 sec., the compressor restarts 2 minutes and 20 sec. laterand operates according to the diagram below.
In defrosting operationCompressor is turned off, the operation returning back to heating operation.
12-1 In heating operation, defrosting12-1 is made based on outdoor heat12-1 exchange temperature Te.12-2 When cumulative working time12-2 of the compressor in [A] zone12-2 has amounted to 55 minutes,12-2 defrosting operation starts.12-2 (25 minutes initially)12-3 The longest defrosting time is12-3 12 minutes, 60 sec. in the case12-3 of turning into [B] zone, and12-3 immediate returning back when12-3 [C] zone is reached
If the high pressure SW continues to operate for 5 seconds while thecompressor is stopping, fusing of Mg-SW is detected and the outdoor fanis controlled as described below.
When the four-way valve is OFF (including during defrosting operation)Turn ON the outdoor fan using “H”.When the four-way valve is ONTurn OFF the outdoor fan.(When the compressor is stopping, the outdoor fan should be OFF)
The following control shall be performed when the compressor stops:The 4-way valve in the hold state shall be reversed 10 seconds before the restartdelay timer counts the maximum count (2 minutes 20 seconds).After the restart delay timer counts the maximum value, the specified mode shallbe selected.
<Outdoor unitcontrol>
NO. ITEM OUTLINE OF SPECIFICATIONS REMARKS
8 Residual heatremoval
9 Test operation
10 High pressurerelease
11 Protection at the timeof Mg-SW fusing
12 Defrosting
13 Four-way valvereversal control
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-61-
N ITEM OUTLINE OF SPECIFICATIONS REMARKS14 Low ambient
cooling<Outdoor unitcontrol>
15 Check display See other item:Using [TIME]display
16 Anti-restart timer
17 Groupoperationcontrol
- 1 0
TL sensor
+1 wave,–1 wave is(current number of waves)± (1 wave)
Air quantity “M”automatic control
Timer accuracy: 20 sec.+0
1 minute and 30 sec.- 1 0
+0
Fault diagnosis is carried out by check for serial transmission and receptionwith outdoor unit as well as the self check by indoor microcomputer. And checkcode is transmitted to protective operation/remote controller based on thecontents of it.In the remote controller, check code is displayed on the liquid crystal bypressing [CHECK] key.
Up to 16 units can be controlled in same setting condition by one remotecontroller.However, thermo-control function is independent.Respective delayed start time for preventing simultaneous large starting currentcan be obtained by different setting of the unit No. switch on the indoor PCboard.
Air quantity
A Zone H
B Zone Per 1 minute and 30sec. +1 wave
C Zone Maintain
DZone Per 20 sec. 1 wave–
14-1 Control on outdoor fan is made14-1 to meet with cooling at low outdoor14-1 temperature based on outdoor heat14-1 exchange temperature TL.
14-2 Control by outdoor heat14-2 exchange temperature TL14-2 is illustrated on the right.
14-3 For first 2 minutes after starting14-3 cooling operation the fan(s)14-3 operate in “H” speed.
The outdoor unit delays restarting for 2 mins 20s to prevent short cyclingcompressor operation.
Unit NO. Checkcode
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-62-
8. DESCRIPTION OF INDOOR UNIT CONTROL CIRCUIT
/ ... are measurement points on the printed circuit board.provides flashing (orange) on LED in the serial input.
8.2 Float switch circuit
In normal condition in which float switch is not operated,230V is applied across the pins 1 and 2. At this time, point
is at the GND level. If the float switch is operated, willbe at the level of 5V.
8.1 Serial signal circuit (between outdoor andindoor units)
This is a circuit for transmitting and receiving the signalsbetween the indoor and outdoor units in serial signal. As230V is used for transmitting the signal, the microcomputersection is insulated by means of photo-coupler with thevoltage reduced to 5V.
With AC interrupt, judgement is made as to the presence orabsence of serial signal based on the reference pulse takenout from the voltage across R and S.
AC interrupt
Serial signal
AC interrupt
Serial input
C N 0 3W H I
Serial input Serial outputAC interrupt
Float switchBlk
SERIAL/COMP
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-63-
8.3 Sensor circuit
This circuit detects the temperature by dividing voltagewith resistance and sensor and bringing the voltage valueinto CPU, using the characteristics of the sensor thatresistance varies with different temperatures. TA and TChave the /same circuit composition.
When TA and TC are at 25°C approximately, the voltage level is some 2V both at points and . If / are at GND or 5V,abnormal condition prevails such as opening or short-circuit of the sensor.
8.4 12V power source circuit
Full-wave rectification by diode bridge (DB01) of alter-nate current supplied from power transformer followed bythe provision of transistor (Q01) gives DC12V powersource ( ).
8.5 5V watchdog timer circuit
Built-in IC (TA8000S) is used to produce 5V power source( ). Also, i t sends signals to reset port ( ) ofmicrocomputer which is in stand-by at 0V and starts itsoperation with the signal of 5V.
Watchdog timer output ( ) gives the signal frommicrocomputer as illustrated below. This indicates thatthe microcomputer is working in normal routine. For ex-ample if the microcomputer is straying due to noise andso on, this waveform is not produced. In case there is nowaveform, it plays the role of restoring normal conditionby inputting the resetting “0V”+ to the microcomputer.
5V
Watchdogtimeroutput 0V
2~10m sec.
8.6 Reset circuit
This circuit makes indoor microcomputer reset by way ofhardware when you keep pressing the check key ofremote controller for longer than a predetermined period.It plays the role of resetting microcomputer from theremote controller when it strays. The point ( ), which isnormally at the level of 5V drops down to the GND level inthe reset operation.
TC sensor
TA sensor
S e r i a l i n p u t f r o mr e m o t e c o n t r o l l e r
T o m i c r o p r o c e s s o r
R e s e t i n p u t
W a t c h d o g o u t p u t
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-64-
8.7 Serial signal circuit(Between remote controller and indoor unit)
This is the circuit for transmitting and receiving thesignals between the remote controller and indoor unit inserial signal.Point is a LED (green) which flashes when there are
signals from the remote controller. At and , the signalsas illustrated below are output.
8.8 Optional circuit
A circuit which allows for the take-out of the signals ofabnormal, operation and Compressor-ON. Point is aLED which lights at abnormal.The connector pin 4 outputs 12V. When you want tosee the signal of compressor-ON, you can do it simplywith the circuit below.
Comp
Compressor ONAbnormal Operation
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-65-
8.10 Switch circuit
TA shift, TC shift and unit No. are changed over by theswitch.
TA shift and TC shift are set in factory with unit No. at “1”.
In servicing, the setting should be made to the sameTA/TC shift as the PC board attached originally.In case of operating one single unit, unit No. “1” will do.With the operation of many units (multi units control) theunit No. should be adjusted in such a way as 1, 2, 3 ........
8.9 Relay circuit
The relay circuit consists of the diagram above.The relay performs the following functions:RY01 : Main switching relayRY02 : Changing over H/M of fan
RY03 : L tap of fanRY04 : UL tap of fanRY11 : Turning louver on and off
RY14 : Turning drain pump on and off( - )
Fan Control Output Heater Louver Output Drain pump
To CPU
To CPU
Model Change
TAShift
TCShift
Unit Number
R Y 0 3A J E 6 4 1 2
R Y 0 1A J E 6 4 1 2
R Y 1 3G 4 U - 1
R Y 1 1G 4 U - 1
R Y 0 7G 4 U - 1
R Y 1 4G 4 U - 1
D 1 51 5 5 1 7 6
R Y 0 2A J E 6 4 1 2
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-70-
9.5 Sensor circuitThis circuit detects the temperature by dividing voltagewith resistance and sensor and bringing the voltage valueinto CPU, using the characteristics of the sensor thatresistance varies with different temperatures.TE is for defrosting, while TL is for low ambient coolingoperation.The following voltages are produced at each of the tem-peratures.
00 C 250 C
TE 2.3V 3.8V
TL 2.3V 3.8V
When / are at GND or 5V, the sensors are eitheropen or short-circuited.
9.3 12V power source circuitOutdoor PC board produces full-wave rectification bydiode bridge (DB50) followed by the provision of tran-sistor (Q50) produces DC power source ( ) at 12V.
9.4 5V watchdog timer circuit
Basically, the same description as the indoor PC boardapplies, provided, however, that the reset circuit is notadded to the outdoor side.
W a t c h d o gt imer ou tpu t
Rese t i npu t
T o C P U
A C 2 4 0 V
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-71-
9.6 Serial signal circuit (between indoor and outdoorunits)Transmits and receives the signals between indoor andoutdoor units in serial signals. As 230V is used fortransmitting the signal, the microcomputer section isinsulated with photo-coupler with 5V being supplied.
Input 5V
0
Output 5V
0
9.7 Abnormality-detecting circuitWhen high pressure switch is operated, abnormality isdetected to stop the compressor.
9.8 Relay circuitThe relay circuit consists of the diagram on theright-hand side.
RY05 : 4-way valve ON/OFFRY07 : Magnetic switch ON/OFF
abno rma linput
(N)
Abnormal input
H i g hPressureSwi tch
Ser ia l
(L)
Ser ia lou tpu t
A C
Ser ia linput
Re lay con t ro lcircuit
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-72-
9.9 Fan speed control circuitThe fan speeds are controlled by triac IC07. This allows the fanto operate at any one of 16 speeds. This function onlyoccurs when the unit is in the cooling mode, zero wavesequates to fan stop.
16 waves
9.10 Lightning surge protection circuitThe circuit on the right, protects the PCB from damagecaused by a lightning surge. Varistors are connectedbetween the live and neutral and live and earth lines toprotect against voltage surges.
Waveform obtained between and T. Example shown is for 4 waves.
T o C P U
(Wi r ing fo r 2 fan moto rs )
R E D
W H I
W H I
N
I
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-73-
10. OPERATION OF AIR CONDITIONER FROM OUTDOOR UNIT
It is possible to operate the air conditioner from the outdoor unit using switches provided on the outdoor PCB.
� Set dip-switch (DSW01) bits 1 & 2 to ON position.
� STOP 10 OPERATION(orange LED off → orange LED flashing)
Apply Short a short across CN28 and CN29 until D08 Led illuminate, remove the short. The led will thenextinguish and the indoor unit will start. After a couple of minutes the outdoor unit will start, LEDs D07and D10 will illuminate.
OPERATION STOP(orange LED flashing → orange LED off)
Short pins CN28 with CN29, LEDs D08 and D10 will extinguish. After indoor unit has stopped D07will extinguish.
� Reset DSW01 bits 1 & 2 to OFF position for normal operation.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-74-
11. EMERGENCY OPERATION
If the air conditioner develops a fault which stops it from operating normally, it is possible to operate the air conditioner using change-overconnectors incorporated into the units. In this case, operation of the air conditioner is controlled by switching on and off the power supply.Details of how to change-over the units to operate in the emergency mode are shown below:
� Switch off the power supply to the outdoor unit.
� Remove the electrical parts cover from the indoor unit. Pull out the connector of R phase (red) lead wire from terminal � and
connect it with the connector of lead wire for fan motor K1 output (red).
Note : If the indoor unit is a cassette model, the float switch connector must be removed from the PCB. Replace the electricalparts cover on the indoor unit. On the outdoor unit PCB, change the switch settings on dip switch DSW01 as follows:
Cooling Mode Heating Mode
� Switch on the power supply to the outdoor unit.
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-75-
12. APPLIED CIRCUIT
An auxiliary display output circuit (+12V) is available at CN13 on the Indoor PC Board to display theoperation for compressor, operation (Fan only) and abnormality.
(1) Display output
CN13
Remote controller
Make sure of correspondence of terminal marks.
� Remove the CN12-connector on the indoor PC board of No. 2 unit and up to No. 16 unit to prevent malfunction.
� Set each unit No. rotary switch on the indoor PC board. The unit connected to the remote controller should be set as No. 1 unit.
Then set No. 2 and up to No. 16 so that start time of each unit is respectively delayed to prevent simultaneous starting current.
13. WIRING FOR GROUP OPERATION
Up to 16 units can be controlled as a group by one remote controller.
� Align the phase sequence of the power supply to all outdoor units.
� Connect the terminals A, B, C on both of the remote controller and the indoor unit of No. 1 unit.
� Connect terminals B, C on both indoor units of No. 1 and No. 2 unit. Then connect in the same way No. 2 and No. 3, No. 3 and
No. 4 .... up to No. 16 unit.
Compressor
Operation (Fan only)
AbnormalityLED
(Provide Locally)
Indoor unitNo. 3
Indoor unitNo. 16
Indoor unitNo. 2
Indoor unitNo. 1
Rotary switch
CN 12 CN01
CN 12
SW 02 SW 01
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-76-
14. PERFORMANCE CHARACTER
14.1 Cooling capacity
14.2 Heating capacity
Capacity Ratio (%)
Am
bien
t Tem
p. (
Dry
Bul
b) (
o C)
Capacity Ratio (%)
Am
bien
t Tem
p. (
Wet
Bul
b) (
o C)
Room Temp. (Wet Bulb) (oC)
Room Temp. (Dry Bulb) (oC)
(KW)RAV-162AH-PE RAV-262AH-PE
RAV-262AH8-PERAV-362AH8-PE RAV-462AH8-PE
3.60 5.68 8.00 10.003.82 6.04 8.50 10.634.05 6.39 9.00 11.254.28 6.75 9.50 11.884.50 7.10 10.00 12.504.73 7.46 10.50 13.134.95 7.81 11.00 13.755.18 8.17 11.50 14.385.40 8.52 12.00 15.00
(KW)RAV-162AH-PE RAV-262AH-PE
RAV-262AH8-PERAV-362AH8-PE RAV-462AH8-PE
6.00 9.48 12.96 16.565.75 9.09 12.42 15.875.50 8.69 11.88 15.185.25 8.30 11.34 14.495.00 7.90 10.80 13.804.75 7.51 10.26 13.114.50 7.11 9.72 12.424.25 6.72 9.18 11.734.00 6.32 8.64 11.033.75 5.93 4.10 10.353.50 5.53 7.56 9.663.25 5.14 7.02 8.973.00 4.74 6.48 8.282.75 4.35 5.94 7.59
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-77-
14.1 Cooling capacity
RAV-162AH-PERAV-262AH-PERAV-262AH8-PE
Out
door
Uni
t Hei
ght H
(m
)
RAV-362AH8-PERAV-462AH8-PE
Out
door
Uni
t Hei
ght H
(m
)
Out
door
Uni
t Hei
ght H
(m
)
Cooling Capacity Ratio Heating Capacity Ratio
Out
door
Uni
t Hei
ght H
(m
)
Cooling Capacity Ratio Heating Capacity Ratio
Piping Length (m)Piping Length (m)
Indoor Unit
Outdoor Unit
The broken line shows in case the piping length is 30m or less.
Piping Length (m)Piping Length (m)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-78-
14.4 Piping length/additional refrigerant volume
14.5 Air flow distribution
RAV-132UH-PERAV-162UH-PERAV-262UH-PERAV-362UH-PERAV-462UH-PE
l The amount of refrigerant put into the outdoor unit at the factory is equivalent to the one that fills up 20m length of refrigerant pipe.
l If the length of refrigerant pipe is 20m or less, addition of refrigerant at the installation site is unnecessary. If the length of the pipeexceeds 20m, add the refrigerant R-22.
l Overcharge or undercharge of refrigerant in the outdoor unit will cause malfunction of the compressor. The prescribed amount ofthe replenishment of the refrigerant is shown in the table above.The permissible amount of refrigerant is the prescribed amount ±50g.
l For RAV-362AH8-PE and RAV-462AH8-PE, the length of pipe exceeds 30m the size of pipe at the gas side must be raisedone rank (eq 19.0 → 22.2).
MODEL No. of discharge way 4-way 3-way 2-wayAir flow direction A B C D A B C A B
RAV-132/162/262UH-PE Air volume ratio (%) 30 30 30 10 33 33 33 50 50RAV-362/462UH-PE Air volume ratio (%) 40 40 10 10 40 40 20 50 50
Piping joint
Ceilling panel
Not to block the A and Bdirection (longer side).
Air flow direction & volume ratio
5 m(Note)When installing more than one unit in the sameroom keep a 5m distance between each unit.
Top view
IndoorUnit
Piping lengthless than (m)
20
Additional amount of refrigerantat installation site (kg) Recharge amount of interchange time (kg)
Model (RAV-) 25 30 35 40 45 50 5 10 15 20 25 30 35 40 45 50
162AH-PE
Filled atfactory
0.15 0.35 1.35 1.45 1.5 1.6 1.75 1.95
262AH-PE262AH8-PE 0.3 0.6 2.2 2.25 2.3 2.35 2.65 2.95
362AH8-PE 0.25 0.5 0.75 1.0 1.25 1.5 3.0 3.15 3.25 3.4 3.65 3.9 4.15 4.4 4.65 4.9
462AH8-PE 0.25 0.5 0.75 1.0 1.25 1.5 3.6 3.7 3.8 3.9 4.15 4.4 4.65 4.9 5.15 5.4
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-79-
15. EXPLODED VIEWS AND PARTS LISTS
15.1 Indoor Unit
RAV-162BH-PERAV-262BH-PERAV-362BH-PERAV-462BH-PE
LocationNo.
Part No. Description
210 43155080 Capacitor, Electrolytic (RAV-162BH-PE)
43155096 Capacitor, Electrolytic (RAV-262/362BH-PE)
43155097 Capacitor, Electrolytic (RAV-462BH-PE)
211 43A58002 Transtormer, Power
212 43A60001 Terminal, 4P
213 43A62001 Cover, Remocon
214 43A69002 PC, Board
215 43A60002 Terminal, 3P
216 43191304 Drain Pan (RAV-162BH-PE)
43191305 Drain Pan (RAV-262BH-PE)
43191310 Drain Pan (RAV-362/462BH-PE)
217 43047527 Capillary Tube. 2.0DIA (RAV-162/262/362BH-PE)
43146432 Capillary Tube. (RAV-462BH-PE)
218 42125135 Bearing
219 43125137 Coupling
220 43A88002 Manual
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 01 4 3 1 6 0 3 9 4 C o n n e c t o r - 9 P
2 0 2 4 3 0 1 9 6 0 4 H o l d e r , S e n s o r
2 0 3 4 31 2 01 4 9 F a n , M u l t i - B l a d e
2 0 4 4 3 A 2 1 0 0 9 M o tor, F a n (R AV -16 2 BH -PE )
4 312 151 6 M o to r, Fa n (R AV -2 62 B H -P E )
4 31 2 15 2 8 M o to r, Fa n (R AV -3 62 B H -P E )
4 31 2 15 3 5 M o to r, Fa n (R AV -4 62 B H -P E )
2 0 5 4 3 A 4 4 0 0 2 Eva p ora to r (R AV -1 62 B H -P E )
4 3 1 4 4 6 7 9 Eva p ora tor (R AV -2 62 B H -P E )
4 3 1 4 4 6 9 2 Eva p ora tor (R AV -3 62 B H -P E )
4 3 1 4 4 6 9 3 Eva p ora tor (R AV -4 62 B H -P E )
2 0 6 4 3 A 4 7 0 0 1 D is t r ibu to r (s t ra iner ) (RAV-162BH-PE)
4 3 1 4 7 4 4 3 D is t r ibu to r (s t ra iner ) (RAV-262BH-PE)
4 3 1 4 7 5 3 2 D is t r ibu to r (s t ra iner ) (RAV-362BH-PE)
4 3 1 4 7 5 3 3 D is t r ibu to r (s t ra iner ) (RAV-462BH-PE)
2 0 7 4 3 0 5 0 3 7 7 S e n so r (T A )
2 0 8 4 31 5 01 9 9 S e n so r (T C )
2 0 9 4 3 A 6 9 0 0 4 R e m o t e C o n t r o l l e r
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-80-
L o c a t i o nN o .
P a r t N o . Descr ip t ion
201 4 3 10 7 21 4 H i n g e
2 0 2 4 3 10 7 21 5 S e n s o r F i x P l a t e
2 0 3 4 3 10 7 21 6 S p r i n g
2 0 4 4 3 1 0 7 2 2 3 Gr i l l e Sha f t Le f t
2 0 5 4 3 1 0 7 2 2 2 Gr i l l e Sha f t R igh t
2 0 6 4 3 1 0 7 2 2 4 Gr i l l e Suppo r t Cen t re ( R A V - 3 6 2 / 4 6 2 C H - P E )
2 0 7 4 3 10 9 32 1 In le t G rille L a rg e
2 0 8 4 3 1 0 9 3 2 2 In le t G rille S m a ll
2 0 9 4 3 1 0 9 3 2 4 H G rille A sm ( R A V - 1 6 2 C H - P E )
2 0 9 4 3 1 0 9 3 2 0 H G rille A sm ( R A V - 2 6 2 C H - P E )
2 0 9 4 3 1 0 9 3 2 7 H G rille A sm ( R A V - 3 6 2 C H - P E )
2 0 9 4 3 1 0 9 3 2 8 H G rille A sm ( R A V - 4 6 2 C H - P E )
210 4 3 1 0 9 3 2 9 Vert ical Gr i l le
211 4 3 11 9 37 3 Bo l t Cove r
212 4 3 11 9 39 3 S h a f t H o l d e r
213 4 3 11 9 39 4 L e v e r
214 4 3 12 0 17 2 F a n , S i r o c c o ( R A V - 1 6 2 / 2 6 2 C H - P E )
214 4 3 12 0 17 4 M u lt i B la d e F a n ( R A V - 3 6 2 / 4 6 2 C H - P E )
215 4 3 A 2 1 0 0 4 F a n M oto r ( R A V - 1 6 2 C H - P E )
215 4 3 A 2 1 0 0 5 F a n M oto r ( R A V - 2 6 2 C H - P E )
215 4 3 A 2 1 0 0 6 F a n M oto r ( R A V - 3 6 2 C H - P E )
215 4 3 A 2 1 0 0 7 F a n M oto r ( R A V - 4 6 2 C H - P E )
216 4 31 251 31 B e a r i n g
217 4 3 12 5 14 2 C o u p l i n g
218 4 3 12 5 14 3 S h a f t S S ( R A V - 1 6 2 C H - P E )
218 4 31 251 41 S h a f t S S ( R A V - 2 6 2 C H - P E )
218 4 3 12 5 14 5 S h a f t S S ( R A V - 3 6 2 C H - P E )
218 4 3 12 5 14 4 S h a f t S S ( R A V - 4 6 2 C H - P E )
219 4 3 12 6 12 7 F a n Ca se L o w er ( R A V - 1 6 2 / 2 6 2 C H - P E )
219 4 3 12 6 12 9 F a n Ca se L o w er ( R A V - 3 6 2 / 4 6 2 C H - P E )
2 2 0 4 3 12 6 12 8 F a n C a s e U p p e r ( R A V - 1 6 2 / 2 6 2 C H - P E )
2 2 0 4 3 12 6 13 0 F a n C a s e U p p e r ( R A V - 3 6 2 / 4 6 2 C H - P E )
221 4 3 1 3 9 0 9 8 C o n n e c t B a r
2 2 2 4 3 A 3 9 0 0 1 C o n n e c t B a r
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 2 3 4 3 1 4 4 6 3 9 A sm E va p o ra tor ( R A V - 1 6 2 C H - P E )
2 2 3 4 3 A 4 4 0 0 4 A sm E va p o ra tor ( R A V - 2 6 2 C H - P E )
2 2 3 4 3 1 A 4 0 0 5 A sm E va p o ra tor ( R A V - 3 6 2 C H - P E )
2 2 3 4 3 1 4 4 6 5 0 A sm E va p o ra tor ( R A V - 4 6 2 C H - P E )
2 2 4 4 3 15 5 13 8 M F C a p a c i t o r ( R A V - 1 6 2 / 2 6 2 / 3 6 2 C H - P E )
2 2 4 4 3 15 5 12 0 M F C a p a c i t o r ( R A V - 4 6 2 C H - P E )
2 2 5 4 3 A 6 9 0 0 4 R e m o t e C o n t r o l
2 2 6 4 3 17 0 19 7 A sm H ose
2 2 7 4 31 721 21 A sm D ra in P a n ( R A V - 1 6 2 C H - P E )
2 2 7 4 31 721 19 A sm D ra in P a n ( R A V - 2 6 2 C H - P E )
2 2 7 4 3 17 2 12 2 A sm D ra in P a n ( R A V - 3 6 2 C H - P E )
2 2 7 4 3 17 2 12 3 A sm D ra in P a n ( R A V - 4 6 2 C H - P E )
2 2 8 4 3 17 9 10 7 P l u g
2 2 9 4 3 1 8 0 2 8 3 A ir F ilte r S m a ll
2 3 0 4 3 1 8 0 2 8 4 A i r F i l te r Large
231 4 3 A 8 8 0 0 2 M a n u a l
2 3 2 4 3 A 2 1 0 0 8 G e a r e d M o t o r
2 3 3 4 3 A 6 2 0 0 1 C o v e r , R e m o c o n
2 3 4 4 3 15 0 14 8 T A S e nso r
2 3 5 4 3 A 5 0 0 0 2 T C S e nso r
2 3 6 4 3 1 0 2 6 2 4 S id e C o ve r R ig h t A sm
2 3 7 4 3 1 0 2 6 2 5 S id e C o ve r L eft A sm
2 3 8 4 31 178 12 H P l a t e
2 3 9 4 3 A 5 8 0 0 2 T ra n s fo rm e r
2 4 0 4 3 A 6 0 0 0 2 T e rm in a l 3 P
241 4 3 A 6 0 0 0 1 T e rm in a l 4 P
2 4 2 4 3 A 6 9 0 0 2 P C B o a r d
2 4 3 4 3 A 4 7 0 0 4 Asm D is t r i bu to r ( R A V - 1 6 2 C H - P E )
2 4 3 4 3 0 4 7 4 9 2 Asm D is t r i bu to r ( R A V - 2 6 2 C H - P E )
2 4 3 4 3 A 4 7 0 0 6 Asm D is t r i bu to r ( R A V - 3 6 2 C H - P E )
2 4 3 4 3 A 4 7 0 0 7 Asm D is t r i bu to r ( R A V - 4 6 2 C H - P E )
2 4 4 4 3 0 4 7 4 9 2 C a p illa ry T u b e 1 .7 D ia ( R A V - 1 6 2 C H - P E )
2 4 4 4 3 1 4 6 4 3 2 C a p illa ry T u be 2 .2 D ia ( R A V - 2 6 2 C H - P E )
2 4 4 4 3 0 4 7 5 2 7 C a p illa ry T u be 2 .0 D ia ( R A V - 3 6 2 / 4 6 2 C H - P E )
15.2 Indoor Unit
RAV-162CH-PERAV-262CH-PERAV-362CH-PERAV-462CH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-81-
15.3 Indoor Unit
RAV-162KH(W)-PE/RAV-262KH(W)-PE
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 15 4 3 1 0 9 3 6 4 Gri l le (RAV-262KH(W) -PE)
2 16 4 3 1 0 9 2 8 0 Gr i l le , Vert ical
2 17 4 3 1 3 9 0 9 8 C o n n e c t i o n R o d
2 18 4 3 0 2 2 1 8 9 B e a r i n g
2 19 4 3 1 9 6 0 8 3 B u s h i n g
2 2 0 4 31 2 01 3 5 F an , C ro ss F lo w (RAV-162KH(W) -PE)
2 2 0 4 31 2 01 3 6 F an , C ro ss F lo w (RAV-262KH(W) -PE)
2 21 4 31 0 93 6 1 G rille , In le t
2 2 2 4 3 1 0 9 3 6 2 G rille , In le t
2 2 3 4 3 1 8 0 2 9 0 Air-Fil ter
2 2 4 4 3 1 0 2 6 2 9 C a b i n e t , S i d e , L e f t
2 2 5 4 3 1 0 2 6 2 8 C a b i n e t , S i d e , R i g h t
2 2 6 4 3 0 6 3 1 7 5 H o l d e r , S e n s o r
2 2 7 4 3 0 1 9 6 0 4 H o l d e r , S e n s o r
2 2 9 4 3 1 0 7 2 3 4 Holder , Gr i l le (RAV-262KH(W) -PE)
2 3 0 4 3 A 6 2 0 0 1 C o v e r R e m o c o n
2 31 4 3 A 8 8 0 0 2 M a n u a l
L o c a t i o nN o .
P a r t N o . Descr ip t ion
201 4 3 A 6 9 0 0 4 R e m o t e C o n t r o l l e r
2 0 3 4 3 12 1 47 4 M o tor (RAV-162KH(W) -PE)
2 0 3 4 31 214 91 M o tor (RAV-262KH(W) -PE)
2 0 4 4 3 A 6 9 0 0 2 P C B o a r d
2 0 5 4 3 A 5 8 0 0 2 T ra n sfo rm e r, P o w e r
2 0 6 4 3 A 6 0 0 0 1 T e rm ina l, 4 P
2 0 7 4 31 551 01 Capac i to r , E lec t ro ly t i c
2 0 8 4 3 A 6 0 0 0 2 T e rm im a l, 3 P
2 0 9 4 3 1 2 2 0 2 8 N o s e , F a n C a s e (RAV-162KH(W) -PE)
2 0 9 4 3 1 2 2 0 2 9 N o s e , F a n C a s e (RAV-262KH(W) -PE)
210 4 31 501 18 S e n so r, R o o m T e m p .
211 4 31 501 16 S e n s o r , H e a t E x c h .
212 4 3 1 4 4 6 6 7 E v a p o r a t o r (RAV-162KH(W) -PE)
212 4 3 1 4 4 6 6 6 E v a p o r a t o r (RAV-262KH(W) -PE)
213 4 31 721 12 D r a i n P a n (RAV-162KH(W) -PE)
213 4 31 721 14 D r a i n P a n (RAV-262KH(W) -PE)
214 4 3 17 0 18 2 Hose , D ra i n
215 4 3 1 0 9 3 6 3 Gri l le (RAV-162KH(W) -PE)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-82-
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 0 2 4 3 0 1 9 6 0 4 Ho lde r , Senso r (TC)
2 0 4 4 31 541 41 Re lay
2 0 5 4 3 0 5 5 2 7 5 Capac i to r , E lec t ro ly t i c
2 0 6 4 3 0 7 0 1 4 6 Hose , D ra i n
2 0 7 4 3 0 9 7 1 6 6 N u t
221 4 3 12 0 16 6 R a d i a l F a n
2 2 2 4 3 12 1 62 7 D r a i n , P u m p
2 2 3 43 A 21 0 01 M o to r, F a n
2 2 5 4 3 13 9 10 3 R u b b e r , B u f f e r
2 2 6 4 3 A 4 4 0 0 1 E v a p o r a t o r ( R A V - 1 3 2 U H - P E )
4 3 1 4 4 6 6 5 E v a p o r a t o r ( R A V - 1 6 2 U H - P E )
4 3 1 4 4 6 6 4 E v a p o r a t o r ( R A V - 2 6 2 U H - P E )
2 2 7 4 3 1 4 6 4 3 2 C a p i l l a r y T u b e ( R A V - 1 3 2 U H - P E )
4 3 0 4 7 5 2 7 C a p i l l a r y T u b e ( R A V - 1 6 2 U H - P E )
4 3 0 4 7 4 9 2 C a p i l l a r y T u b e ( R A V - 2 6 2 U H - P E )
2 2 8 4 31 501 18 S e n so r (T A )
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 2 9 4 3 15 0 19 9 S e n so r (T C )
2 3 0 4 31 512 17 F l o a t S w i t c h
2 3 3 4 3 A 5 8 0 0 2 T ra n sfo rm e r, P o w e r
2 3 5 4 3 16 0 25 1 Te rm ina l B l ock
2 3 6 4 3 A 6 0 0 0 1 T e rm in a l 4 P
2 3 7 4 3 A 6 0 0 0 2 T e rm in a l 3 P
2 3 9 4 3 A 6 2 0 0 1 C o v e r , R e m o c o n
2 4 0 4 3 A 6 9 0 0 2 P C B o a r d
241 4 31 721 18 D r a i n P a n ( R A V - 1 3 2 U H - P E )
4 31 721 17 D r a i n P a n ( R A V - 1 6 2 / 2 6 2 U H - P E )
2 4 2 4 3 17 9 10 4 Drain Fi l ter
2 4 3 4 3 17 9 10 5 P l u g
2 4 5 4 3 A 8 8 0 0 2 M a n u a l
2 4 9 4 3 10 7 21 2 Bo l t
2 5 0 4 3 13 9 10 5 W a s h e r
251 4 3 A 6 9 0 0 4 R e m o t e C o n t r o l l e r
2 5 2 4 3 0 3 3 0 8 4 Spark-kil ler
15.4 Indoor Unit
RAV-132UH-PERAV-162UH-PERAV-262UH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-83-
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 01 4 3 A 6 9 0 0 4 R e m o t e C o n t r o l l e r
2 0 2 4 3 A 6 2 0 0 1 C o v e r , R e m o c o n
2 0 3 4 3 0 1 9 6 0 4 H o l d e r , S e n s o r
2 0 4 43 15 4141 Re lay
2 0 5 4 3 0 7 0 1 4 6 Hose , D ra i n
2 18 4 31 2 01 6 4 F a n , M u l t i - b l a d e
2 19 43 A 21 0 10 M o to r, F a n
2 2 2 4 31 2 16 2 7 D ra in, P u m p
2 2 3 4 31 2 61 2 5 F an C a se Lo w e r
2 2 4 4 31 2 61 2 6 F a n C a s e U p p e r
2 2 5 4 31 4 46 6 1 E v a p o r a t o r , R i g h t ( R A V - 3 6 2 U H - P E )
2 2 5 4 3 1 4 4 6 6 0 E v a p o r a t o r , R i g h t ( R A V - 4 6 2 U H - P E )
2 2 6 4 3 1 4 4 6 6 3 E v a p o r a t o r , L e f t ( R A V - 3 6 2 U H - P E )
2 2 6 4 3 1 4 4 6 6 2 E v a p o r a t o r , L e f t ( R A V - 4 6 2 U H - P E )
2 31 4 3 0 4 7 5 2 7 C a p illa ry T u b e 2 .0 D IA
2 3 3 43150 111 S e n s o r
2 3 4 4 31 5 01 4 8 S e n s o r
L o c a t i o nN o .
P a r t N o . Descr ip t ion
2 3 5 4 3 15 1 20 3 F l o a t S w i t c h
2 3 7 4 3 0 5 5 2 9 2 Capac i to r , E lec t ro ly t i c ( R A V - 3 6 2 U H - P E )
2 3 7 4 3 1 5 5 0 8 0 Capac i to r , E lec t ro ly t i c ( R A V - 4 6 2 U H - P E )
2 3 9 4 3 A 5 8 0 0 2 T ra n sfo rm e r, P o w e r
2 4 0 4 3 A 6 0 0 0 1 T e rm ina l, 4 P
241 4 3 A 6 0 0 0 2 T e rm ina l, 3 P
2 4 4 4 3 17 0 19 2 Hose , D ra i n
2 4 6 4 31 721 16 D r a i n P a n
2 4 7 4 3 17 9 10 4 Drain Fi l ter
2 4 8 4 3 17 9 10 5 P l u g
2 5 0 4 3 A 8 8 0 0 2 M a n u a l
2 5 2 4 3 A 6 9 0 0 2 P C B o a r d
2 5 3 4 3 0 3 3 0 8 4 Spark-kil ler
15.5 Indoor Unit
RAV-362UH-PERAV-462UH-PE
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-84-
15.6 Ceiling panel
RBC-U262PG(W)-PERBC-U462PG(W)-PE
LocationNo.
Part No. Description
202 43407009 Grille, Catch
206 43407024 Cam
207 43407014 Slider
208 43407015 Lever
209 37507500 Lever
210 43409063 Intake-Grill Assy (RBC-U262PG(W)-PE)
43409059 Intake-Grill Assy (RBC-U462PG(W)-PE)
211 43409067 Holder. Shaft
LocationNo.
Part No. Description
214 43121550 Geared-Motor
215 43480533 Air-Filter (RBC-U262PG(W)-PE)
43480531 Air-Filter (RBC-U462PG(W)-PE)
217 43409070 Grille, Outlet (RBC-U262PG(W)-PE)
43409069 Grille, Outlet (RBC-U462PG(W)-PE)
220 43409075 Grille, Outlet, Small
227 43497009 Spring Holder (RBC-U462PG(W)-PE)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-85-
15.7 Outdoor unit
RAV-162AH-PE
LocationNo.
Part No. Description
1 43120156 Fan, Propeller
2 43A21003 Motor, Fan, AC230V, 50Hz
3 43A43001 Condenser
4 43149212 Base, Spring, A
5 43049132 Spring, Buffer
6 43049132 Base, Spring, B
7 43A69003 PC Board
8 43A49001 Switch, High-Pressure
9 43060479 Terminal, 4P
10 43A60003 Terminal, 2P
11 43A60001 Terminal, 4P
12 43152334 Magnetic Contactor
13 43054286 Relay, Overload
14 43A19001 Guard, Fan
15 43119368 Hanger
16 43A46004 Solenoid Coil
17 43162027 Cover, Electric Parts
18 43155115 Capacitor, Plastic Film, 45MFD, 440V
20 43107215 Holder, Sensor (TE)
21 43169600 Holder
22 43148105 Accumulator
LocationNo.
Part No. Description
23 43145082 Dryer
24 43155080 Capacitor, Electrolytic
25 43041845 Compressor, AC220/240V, 50Hz, PH250X3-4LS
26 43146454 Packed Valve (1/4")
27 43146406 Packed Valve (1/2")
28 43147321 Check Joint
29 43146424 Expansion Valve
30 43046198 Coil, 2-Way Valve
31 43146283 Checked Valve
33 43A58003 Transforrmer, Power
34 43046151 Valve, 2-Way
35 43193043 Spring
36 43A50001 Sensor, Cond. Out (TL)
37 43150196 Sensor, Heat Exch. (TE)
38 43146418 Valve 4-Way
39 43157167 Heater, Crankcase
41 43146459 Capillary Tube
42 44246235 Capillary Tube
43 43150122 Thermostat, Bimetal
44 43107215 Holder, Sensor (TL)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-86-
RAV-262AH-PE
LocationNo.
Part No. Description
1 43120156 Fan, Propeller
2 43A21002 Motor, Fan, AC 230V, 50Hz
3 43A43002 Condenser
4 43049132 Base, Spring, B
5 43149198 Spring, Buffer
6 43149212 Base, Spring, A
7 43A69003 PC Board
8 43A49001 Switch, High-Pressure
9 43060479 Terminal, 4P
10 43A60004 Terminal, 2P
11 43A60001 Terminal, 4P
12 43152334 Magnetic Contactor
13 43150122 Thermostat, Bimetal
14 43A19001 Guard, Fan
15 43119368 Hanger
16 43A46004 Solenoid Coil
17 43162027 Cover, Electric Parts
18 43146418 Valve, 4-Way
20 43107215 Holder, Sensor (TE)
21 43169600 Holder
22 43148114 Accumulator
LocationNo.
Part No. Description
23 43145082 Dryer
24 43155080 Capacitor,Plastic Film
25 43140318 Compressor, PH330X3-4MS
26 43146451 Packed Valve (3/8")
27 43146417 Packed Valve (5/8")
28 43147321 Check Joint
29 43146433 Expansion Valve
30 43046156 Checked Valve
31 43146283 Checked Valve
33 43A58003 Transforrmer, Power
34 43046151 Valve, 2-Way
35 43046198 Coil, 2-Way Valve
36 43A50001 Sensor, Cond. Out (TL)
37 43150196 Sensor, Heat Exch. (TE)
38 43193043 Spring
39 43157167 Heater, Crankcase
40 44246236 Capillary Tube
41 43055379 Capillary, Electrolytic
43 43146459 Capillary Tube
44 43107215 Holder, Sensor (TL)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-87-
RAV-262AH8-PE
LocationNo.
Part No. Description
22 43148114 Accumulator
23 43145082 Dryer
24 43155080 Capacitor, Plastic Film
25 43141302 Compressor, AC 380/415V, 50Hz, YH330X3-MS
26 43146451 Packed Valve (3/8")
27 43146417 Packed Valve (5/8")
28 43147321 Check Joint
29 43146433 Expansion Valve
30 43046156 Checked Valve
31 43146283 Checked Valve
33 43A58003 Transforrmer, Power
34 43154148 Return Lock STR-4AB
36 43A50001 Sensor, Cond. Out (TL)
37 43150196 Sensor, Heat Exch. (TE)
38 43193043 Spring
39 43157167 Heater, Crankcase
41 43063195 Holder Thermostat, Bimetal
43 43146459 Capillary Tube
44 43107215 Holder, Sensor (TL)
LocationNo.
Part No. Description
1 43120156 Fan, Propeller
2 43A21002 Motor, Fan, AC 230V, 50Hz
3 43A43002 Condenser
4 43049132 Base, Spring, B
5 43149198 Spring, Buffer
6 43149212 Base, Spring, A
7 43A69003 PC Board
8 43A49001 Switch, High-Pressure
9 43060479 Terminal, 4P
10 43A60005 Terminal, 4P
11 43A60001 Terminal, 4P
12 43152345 Magnetic Contactor
13 43050277 Thermostat, Bimetal
14 43A19001 Guard, Fan
15 43119368 Hanger
16 43A46004 Solenoid Coil
17 43162027 Cover, Electric Parts
18 43146418 Valve, 4-Way
20 43107215 Holder, Sensor (For TE)
21 43169600 Holder
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-88-
RAV-362AH8-PERAV-462AH8-PE
LocationNo. Part No. Description
19 43146283 Checked Valve20 43145092 Dryer21 43148096 Accumulator (RAV-362AH8-PE)21 43148114 Accumulator (RAV-462AH8-PE)22 43155080 Capacitor, Plastic Film23 43060479 Terminal, 4P24 43A60005 Terminal, 4P25 43A60001 Terminal, 4P26 43107215 Holder, Sensor (TL)27 43152342 Magnetic Contactor (RAV-362AH8-PE)27 43152343 Magnetic Contactor (RAV-462AH8-PE)28 43150196 Sensor, Heat Exch. (TE)29 43A50001 Sensor, Cond. OUt (TL)30 43A69003 PC Board32 43A46004 Solenoid Coil33 43169600 Holder34 43163016 Support35 43A49001 Switch, High-Pressure36 43157140 Heater, Crankcase37 43146430 Capillary Tube (RAV-362AH8-PE)37 43146431 Capillary Tube (RAV-462AH8-PE)38 43107215 Holder, Sensor (TE)39 43A58003 Transformer, Power
LocationNo. Part No. Description
1 43A21002 Motor, AC 230V, 50Hz, Fan2 43A21003 Motor, AC 230V, 50Hz, Fan3 43120156 Fan, Propeller4 43A19001 Guard, Fan5 43143638 Condenser, Lower (RAV-362AH8-PE)5 43143636 Condenser, Lower (RAV-462AH8-PE)6 43143639 Condenser, Upper (RAV-362AH8-PE)6 43143637 Condenser, Upper (RAV-462AH8-PE)7 43047492 Capillary Tube (RAV-362AH8-PE)7 43047527 Capillary Tube (RAV-462AH8-PE)8 43119368 Hanger9 43162027 Cover, Electric Parts10 43140404 Compressor, YH406JA (RAV-362AH8-PE)10 43140506 Compressor, YH506JA (RAV-462AH8-PE)11 43149198 Spring, Buffer12 43149212 Base, Spring, A13 43049132 Base, Spring, B14 43146362 Expansion Valve (RAV-362AH8-PE)14 43146438 Expansion Valve (RAV-462AH8-PE)15 43146451 Packed Valve (3/8")16 43146416 Packed Valve (3/4")17 43147321 Check Joint18 43146498 Valve, 4-Way (RAV-362AH8-PE)18 43146499 Valve, 4-Way (RAV-462AH8-PE)
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807
-89-
Heronhill - for all your Toshiba requirements
Tel: 01823 665660 www.heronhill.co.uk Fax: 01823 665807