Post on 27-Nov-2021
transcript
Turbo Air Speed up the Pace of Innovation
CommercialPizza Prep TablesService Manual
CAUTION!PLEASE KEEP POWERSWITCH ON BEFORE
OPERATING THIS EQUIPMENT
Please read this manual completely before attempting to install or operate this equipment!
www.turboairinc.com
TPR-44SDTPR-67SDTPR-93SD
Super Deluxe Series
6-1. REPLACING DOOR
4. TEMPERATURE CONTROL INSTRUCTION
5. PARTS LIST
TABLE OF CONTENTS
3. MAIN COMPONENTS
1. EXPLODED VIEW 1-1. TPR-44SD EXPLODED VIEW
1-2. TPR-67SD EXPLODED VIEW
1-3. TPR-93SD EXPLODED VIEW
2. WIRING DIAGRAMS 2-1. TPR-44SD
2-2. TPR-67SD / 93SD
6. REPLACEMENT OF MAIN COMPONENTS
6- 2. REFRIGERATION COMPARTMENT
6-3. COMPRESSOR COMPARTMENT PARTS
6-4. REPLACING THE EVAPORATOR & EVAPORATOR FAN MOTOR
1-1. TPR-44SD EXPLODED VIEW
1. EXPLODED VIEW
20
19
1817
16
15
1413
1211
10
8
7
9
6
5
4
3
2
1
21
22
23
24
25
26
27
2829
30
121112221232313
FLEHS42414)L(EGNIH MOTTOB52515
)L(EGNIH POT62616)L( YLBMESSA ROOD72717
REYRD EROC DRAH82818ROSSRPMOC92919
RESNEDNOC030201
UNIT SIDE COVER
THERMOSTAT PANEL
UNIT FRONT COVER
Part Name
HOOD LID HINGE (R)HOOD LID ASSEMBLY (B)HOOD LID HINGE (L)
A/S COVER ASSEMBLY
MECH COVEREVAP FRONT DUCT PANEL
COOLING MOTOR COVER
PAN DUCT COVERPAN DUCT
AIR GUIDE (L)
BOARD KITCHEN BRACKET
EVA TOP COVERAIR GUIDE (R)
COUNTER TOP ASSEMBLYSHELLF STANDARD
AIR DUCT PANELEVA FAN MOTOR ASSEMBL Y
EVAPORATOR
CABINET ASSEMBLYCASTER
1817 122
23
24
25
26
27
2829
30
Y
1817 22
16
2630
33
3132
1
2
3
4
5
6
7
89
10
11
12
13
14
15
17
18
19
20
21
22
23
24
523116241272513826149271503816139172302833129
22013211
4221
A/S COVER ASSEMBLYEVAPORATOR TOP COVER COUNTER TOP ASSEMBLY
REVOC TCUD NAP)L( EDIUG RIAEVAPORATOR MOTOR ASS
UNIT SIDE COVER HOOD LID ASSEMBLY (B)UNIT FRONT COVER HOOD LID ASSEMBLY (S)
BOARD KITCHEN BRACKET
Part Name
AIR GUIDE (R)
COOLING MOTOR COVER EVAPORATOR ASSEMBLY
EVAPORATOR FRONT DUCT AIR DUCT PANELTHERMOSTAT PANEL MECH COVER
PAN DUCT
HOOD LID HINGE (R)
HOOD LID HINGE (M)
SHELF STANDARD
CASTER
COMPRESSORHARD CORE DRYER
CONDENSER
HOOD LID HINGE (L)
BOTTOM HINGE (L)DOOR ASSEMBLY (R)
CABINET ASSENBLYTOP HINGE (L)DOOR ASSEMBLY (L)
SHELF
27
28
29
3332
25
1-2. TPR-67SD EXPLODED VIEW
1-3. TPR-93SD EXPLODED VIEW
2-1. TPR-44SD 2. WIRING DIAGRAMS
2-2. TPR-67/93SD
3.MAIN COMPONENTS
1.COMPRESSOR
TPR-93SD
PART NAME PART NO. POLE
~ ~
IS-4420DWSG
-1
160V/315uF ~ 230V/10uF ~
TECUMSHE
160V/315uF ~
TECUMSHE
MODEL PART NAME
NOTE~~
~ ~STARTING PART NO. RUNNING PART NO.MODEL
~3ARR12
NOTE
MST16AGZ-3240D5AP3ARR1212KP*483 MST16AHN
TPR-44SDTPR-67SD
EDALBTUPNI TYPE
MAKER200V/100uF ~
MAKER
PART NO. HORSE CAPACITY INPUT MAKER
TPR-44SD HBL-27YE-1 M369700100 1/4HP
TPR-67SD ~CAE4456Y M729700100 1/2HP
TYPE OF
DAEWOOMAKER
~ CSR 110-115V 60Hz
CSIR
TPR-93SD 1/2HP
TPR-44SD GSR SO68 E03 03 783RHBZZ-52RELAY OVERLOAD
~G2F5700100CAE2420Z
DAEWOO
TECUMSHE
TECUMSHE
TPR-67SDTPR-93SD
CSIR 115V 60Hz
115V 60Hz
MODEL
TPR-67SD
MODEL
AL 4115V 60HzTPR-93SD
TPR-44SDSUNGSHIN4P
SHADEDPOLE
INDUCTIONG8F6600100
~~~
~~~
Z960300300THERMOSTAT
MAKER
RANCOK55Q-5608,16A
3963328120
MODEL PART NAME PART NO. POLE INPUT TYPE(NUMBER)
NO
TPR-44SD4P 115V 60Hz
SHADEDPOLE
INDUCTIONAL 5 1
BLADE
IS-4420DWSN
-2ATPR-67SDTPR-93SD
PART NAME PART NO. RATING
- Factory setting is at "NORMAL" Settings can be changed by Dial Knob.
4.TEMPERATURE CONTROL INSTRUCTION - Temperature can be controlled by the user.
44 67 93krameRnoitpircseDedoC traP
ModelPart Name
5. PARTS LIST
44 67 93krameRnoitpircseDedoC traP
ModelPart Name
5. PARTS LIST
6-2. REFRIGERATION COMPARTMENT PARTS
6. REPLACEMENT OF MAIN COMPONENTS 6-1. REPLACING DOOR
A. Unscrew the top hinge B. Lift the door
A.Disassemble the a/s cover assembly B.Disassemble the evaporator front duct panel
C.Remove the themostat&sensor
D.Disassemble the evaprator fan motor
E.Remove the evaporator coil
eit elbac eht elbmessasiD.B llirg raer eht elbmessasiD.A
6-3. COMPRESSOR COMPARTMENT PARTS
C.Remove the unit front cover D.Disassemble the condesing unit
E.Disassemble the condenser fan motor
6-4. REPLACING THE EVAPORATOR & EVAPORATOR FAN MOTOR