CRTEN by Prof. AmenAllah Guizani - Maghrenov workshop on research infrastructures for renewable...

transcript

Center of Research and Energy Technologies www.crten.rnrt.tn

Prof. AmenAllah GUIZANI

MAGHRENOV Workshop on Research Infrastructures RE&EE in EU-MPC countries

Local needs of infrastructure for RE implementa;on

Marrakech, January 16th 2015

Outline

• INTRODUCTION

• CRTENn BRIEFLY

• INFRASTRUCTURE

• CONCLUSION

�  - Solar Energy (Thermal, PV, CSP, applications) �  - Wind Energy �  - Hydropower �  - Biomass �  - Bio fuel �  - Geothermal Energy

Material Component System

•Absorber •nano composite •Fluid •Thin film •Storage Material

•Solar cell •Inverter •Blade •Subassemblies •Controls

•PV Panel •Tower •Application unit (Desalination, A/C, pumping station…) •Power plant

Characterisation •Mechanical •Electrical •Optical •Thermal

Overall Efficiency •Effectiveness • Conformity to standards

Performance •Mechanical •Electrical… •Conformity to standards

20/01/15 5

Meteorological Data

20/01/15 8

Main objec;ves : Ø  R&D in RE systems and integra5on in economic world

Ø  Science & Technology survey Ø  Training of competencies

Creation 2005

R&D Structure

3 Laboratories

Laboratory of Wind Power Control and Energy Valorization

of Waste (LMEEVED)

Photovoltaic Laboratory (LPV)

Thermal Processes Laboratory (LPT)

Renewable Energies, EE

Staff: 200 Technology Transfer

OfLice (TTO)

Brie%ly the CRTEn

Training of experts, able to give fast answers to the national energy requirements in short and medium terms.

Development and exploitation of renewable energies (thermal, photovoltaic and wind) and other forms of clean energies by searching low cost solution.

Technological survey, development, characterization and application of advanced materials having high added value in energy management and power consumption.

The creation of adequate synergies between R&D in the Lield of energy and the structures of Technology Transfer and Innovation in the Ecopark.

The creation of a good R&D environment, favorable to the attraction of foreign investors and their establishment in the Ecopark …

RECEMIS Preparatory Meeting Barcelona May 5th 2014

Butt Offer

Our partners/Network

RECEMIS Preparatory Meeting Barcelona May 5th 2014

20/01/15 14

Three laboratories cons;tute CRTEn

-‐  Laboratory of Thermal process LPT;

-‐  Laboratory of photovoltaic LPV;

The Laboratory of Wind Power Control and Energy Valoriza;on of Waste;

Laboratory of Thermal Process (LPT) facili;es

20/01/15 15

• Solar thermal conversion

• Energy storage and recupera;on • Modeling and numerical simula;on of HMT

• Energy efficiency in building

• Fluid-‐solid separa;on • Condi;oning of agricultural greenhouses

• Absorber • HTFluid •PCM •Storage Medium • Insulation • Glass • Mirror

•Flat plate solar collectot •Air collector •PTC / Fresnel •Solar •Tower/receiver •Storage tank • Sun tracker / Heliostat

•SDHW •Solar dryer • CSP plant • A/C solar driven •Thermal Desalination unit •Process heat unit

PARABOLIC TROUGH CONCENTRATOR Collector length /module 5.970 mm Number of modules 3 Aperture 2.300 mm Focal length 800 mm Concentra5on factor C= 20 Temperature range 100 ….200 °C Medium Water / Thermal oil Traking type One axis Reflector Coated Aluminium

Photogrammetry

20/01/15 18 Contribution to the control of solar concentration technology

Solar collector test facility

‎- Performance test of solar thermal collectors : NT 67-04 equivalent to EN 12975.‎ ‎- Determination of the heat loss rate of hot water stores : NT 167-08.‎ ‎- Performance test of solar thermal systems : ISO 9459-5 (DST-method).‎

Not Available: ‎- Test facility for testing the durability and reliability of solar thermal collectors

20/01/15 20

Photovoltaic Laboratory (LPV)

ü silicon based materials and devices.

ü  Technologies of photovoltaic solar cells . ü Development of PV systems applied to ligh;ng, water

pumping, desalina;on and grid

ü Study and development of gas sensors and photonic

devices.

ü  Development of new organic and inorganic nano

composites for solar photocatalysis.

Silicon (# types) •nano composite (organic non org.) •Oxides •Thin films

• Solar cell • PV panels •Batteries •Controls •Inverters

• PV power generator •PV pumping station • PV lighting

�Laboratory of Photovoltaic: � R&D related to PV materials and technologies�

Laboratory of Wind Energy and Energe;c Valoriza;on of Waste

20/01/15 26

•  Design, realiza;on and experimenta;on of the small power

wind turbine and accessories

• Study of the systems of high power wind turbine

•  Conversion of biogases for power produc;on of electricity •  Thermo-‐chemical valoriza;on of solid waste

•  Produc;on of fuels star;ng from used oils and fats

• Blades • Turbine • Shaft • pilons •Batteries •Controls •Inverters

• Composite • # metals

• Wind farms

Wind tunnel facility

Characteris5cs Vmax = 30m/s

Vein =‎1 m x 800 cm² ‎

Features - PIV

-  Ta

- Open/close loop ‎

Wind tunnel facility

L’intitulé de ce projet :

Renforcement de l’infrastructure qualité pour l’énergie solaire aux

pays du Maghreb

§  A été lancé en Février 2012 à Casablanca

§  En Avril 2013 la soufflerie du CRTEn a été choisi pour être accrédité dans ce projet

• The technology platform

• A set of equipment and test tools to

• Technological platform where will be housed the large equipment CRTEn

•  Support the research Labs activities

•  Support companies operating in advanced energy technologies

•  Support the training centers

Planned R&D and test infrastructure

General considera;ons: na;onal level

20/01/15 32

• Need of mapping exis;ng equipment

• Need of sharing equipment

• Need of cer;fica;on bodies for RE EE equipment

• Take into account O&M for R&D equipment

General considera;ons : mul;lateral level

20/01/15 33

• Agreements for mul;lateral use of heavy equipment

• Implementa;on of projects for staff exchange using exis;ng

equipment

20/01/15 34

CRTEN by Prof. AmenAllah Guizani - Maghrenov workshop on research infrastructures for renewable...

Environment