Post on 07-Apr-2018
transcript
8/3/2019 ECU Remapping Solution
1/19
The Need for Power .. Economy .And Emission!
EUROChip Tuning of Indonesia
8/3/2019 ECU Remapping Solution
2/19
What is OBD-I / OBD-II?
What Does OBD-II Controls?
What is ECU Remapping?
ECU Tuning Methods Technologies Involved
Whats the benefit of ECU Remap?
What kind of Performance Gain Can I Expect? What cars / ECU can be remapped?
FAQs on ECU Remapping
Q&A
8/3/2019 ECU Remapping Solution
3/19
Standard for Better Emission
8/3/2019 ECU Remapping Solution
4/19
OBD = On Board Diagnostic Reporting System
OBD-I = Level 1 Std => Not really a standard,each manufacturer had different method of
reporting system and different DiagnosticConnectors.
OBD-II = Level 2 Std => Std Diagnostic Port,Full Control for Engine Ops, Chassis, andaccessories.
8/3/2019 ECU Remapping Solution
5/19
8/3/2019 ECU Remapping Solution
6/19
1. (Reserved)
2. SAE-J1850 (+) => Ford, GM.3. (Reserved)
4. Chassis Ground5. Signal Ground
6. CAN (high) => New Standards in 2008 for all.7. K-Line => Chrysler, European, Asian.8. (Reserved)
9. (Reserved)
10. SAE-J1850 (-)11. (Reserved)
12. (Reserved)13. (Reserved)
14. CAN (low)15. L-Line16. Battery (+)
8/3/2019 ECU Remapping Solution
7/19
STRINGENT EMISSION CONTROL
Catalytic Converter efficiency (2 Oxygen Sensors)
Engine misfire
Electrical Integrity Idle Control
Throttle Position Sensors
Transmission actuators
.. Many more .
8/3/2019 ECU Remapping Solution
8/19
The Quest for POWER
8/3/2019 ECU Remapping Solution
9/19
Optimizing A/F ratio and ignition timing for part andfull throttle acceleration.
Optimizing A/F ratio for Cruising. Remove Flat Spots (Smoothing Drivability).
Slightly Increase RPM Limiter. Remove Speed Limiter. Optimize Torque Limiter. Adjust Ignition Timing. Adjust Fuel Compensator. Adjust Boost (for Turbo / SC applications). AFM Calibration Throttle Position vs Fuel Enrichment Many many more.
8/3/2019 ECU Remapping Solution
10/19
Pre-OBD => Re-chipping.
OBD-I => Re-chipping or Re-flashing thruProprietary Diagnostic Connector (Serial
Programming). OBD-II => Re-chipping or Re-flashing thru
OBD-II port (Serial Programming), orprogramming using BDM Tool (Specific toMotorola MPC5XX based Processors).
8/3/2019 ECU Remapping Solution
11/19
8/3/2019 ECU Remapping Solution
12/19
8/3/2019 ECU Remapping Solution
13/19
8/3/2019 ECU Remapping Solution
14/19
OBD-II Standards (and Future Standards).
OBD / II to ECU Protocol Interfacing andProgramming.
ECU Technology => More Stringent Controlover Emission, thus tighter engine operationtolerance.
ECU Maps scrambling. Checksum algorithm.
8/3/2019 ECU Remapping Solution
15/19
More efficient engine operation, thus more fuelefficient => For normal driving behavior, fuelconsumption is LESS.
More power => Engine is tuned to within itsmechanical potential => More power isavailable when needed.
In plain term: YOUR CAR IS MORE FUN TODRIVE!!! .. And MORE DRIVABLE.
8/3/2019 ECU Remapping Solution
16/19
7% - 15% Horsepower Increase for normally aspirated(N/A) engine (Depending on how optimized the stockengine is).
10% - 15% Torque Increase for N/A engine.
10% - 50% Horsepower Increase for Forced Induction(FI) engines, depending on boost level, gasoline orDiesel engines.
30% - 75% Torque increase for FI engines, gasoline orDiesel engines.
Much better part throttle operations, remove flat spots. More torque below peak torque => better drivability. Much better passing power from peak torque to
redline.
8/3/2019 ECU Remapping Solution
17/19
Most Cars whose ECUs have separate DataChips.
Usually Bosch and Siemens based and
licensees. Additionally: Delphi, Sagem, Marelli, VDO,
etc.
8/3/2019 ECU Remapping Solution
18/19
Why did manufacturers NOT optimize theECU in the first Place?
Will my car consume more fuel?
Will it void my car warranty? Will it shorten the life of my engine?
Will it have long term negative effect on my
car?
8/3/2019 ECU Remapping Solution
19/19