Post on 14-May-2020
transcript
Hino Motors,Ltd. TOKYO,JAPAN
Spec. No. SS-FS314Drawing No. CDRFS340
RATINGS & AXLE LOAD LIMIT (kg) ( ) Maker design
RatingsFront: 315/80R22.5-156/153Rear : 295/80R22.5-153/150Front: 12R22.5-16PRRear : 11R22.5-16PR
CHASSIS DIMENSIONS (mm) : All dimensions are to standard specifications and unladen chassisModelProduction Code FS1EMKD FS1EMKM FS1ETKAApplication For dump For mixer For cargoWheelbase 3,920 + 1,310 5,075 + 1,310Overall length 8,040 10,760Overall widthOverall HeightCab to rear axle centerRear overhang (at frame end) 1,290Front Chassis Height 1,090Rear Chassis HeightRoad clearance (at diff. case) 245Front Tread 2,035Rear Tread 1,855Turning radius on tire 8,500 10,300Turning radius on wall to wall 9,200 11,100
CHASSIS MASS (kg) : Chassis mass quoted is to standard specifications without spare tire & std. tool set(Total)(Front)(Rear)
PERFORMANCE & GEAR RATIOS : Calculations based on 26.0 ton GVM, 295/80R22.5 tireMax. Speed (km/h)Gradeability tanθ (%)
Model1st2nd3rd4th
Transmission Gear Ratio 5th6th7th8th
Rev.ModelGear Ratio
- 1 -
CAOH
HR 1,110
Below 90 (controlled by speed limiter)
4,5603,955
HF1,070
SPECIFICATIONS
HHIINNOO 770000 SSeerriieess6x4, Truck Chassis
- RHD- 380 PS (Euro-4)- 28.3 ton GVMR
Rear AxleFront AxleGVM
2,490
6,500
7,500
HINO 72638
60.0
4.565 / 3.8163.023 / 2.527
ZF 16S22113.804 / 11.5399.487 / 7.9306.529 / 5.458
12.923 / 10.803
4.100
3,095
2.078 / 1.7371.430 / 1.1951.000 / 0.835
ROH
(Low/High)
FT
21,800
21,800
26,000 (28,300)
(STD)
(OPT)
8,515
Axle Load Limit
3,8652,915
WBOL
7,500
Chassis Mass
5,020
8,1854,6503,530
8,2004,6653,535
Rear AxleTHD17
EQUIPMENTS SS-FS314 ENGINE SERVICE BRAKE
1.Model HINO E13C UK 1.Type 2.Max. output;(Net) 279 kW {380 PS} at 1,800
r/min 3.Max. torque;(Net) 1,814 N-m {185 kgf-m} at 2.Wheel brake ass'y
1,100 r/min Drum diameter x Lining 4.Max. engine speed 2,000 r/min width 5.Type Front 406.4 x 152 mm
Rear 406.4 x 216 mm 3.Air drier Equipped 4.ABS system Equipped
6.Combustion system Direct injection type 5.Auto brake shoes adjuster Equipped 7.Bore and stroke 137 x 146 mm SECONDARY AND PARKING BRAKE 8.Piston displacement 12.913 L 1.Type, for FS1EMKD/MKM Spring brake acting on front 9.Compression ratio 17.0 and rear frontward wheels,10.Engine oil capacity 37.0 L for emergency and parking11.Engine coolant capacity 28.5 L purpose, manual control12.Fuel injection pump for FS1ETKA Type
Governor Electric governor13.Intake system STEERING Air cleaner Dual paper elements 1.Type14.Air compressor Type Single cylinder, water-
cooled Bore and stroke 85 x 60 mm15.Fly wheel P.T.O. 2.Gear ratio 21.4 - 23.816.Engine control link Equipped RETARDER17. Insect protection Equipped 1.Type Hino engine retarder
CLUTCH FRONT SUSPENSION 1.Type Dry single plate with damper 1.Type Semi-elliptic tapered leaf
springs springs with shock 2.Clutch disc ass'y CS-430 series absorbers and stabilizer 3.Facing material Semi-mold 2.Dimensions of springs 4.Facing outside diameter 430 mm Span 1,500 mm 5.Clutch cover ass'y DSP-430 series Width 90 mm 6.Control Hydraulic with air booster REAR SUSPENSION
TRANSMISSION 1.Type Semi-elliptic leaf springs 1.Type 16S221 with torque rods
2.Dimensions of springs Span 1,310 mm
2.Control Width 90 mmWHEEL AND TIRE
PROPELLER SHAFT 1.Wheel type 1.Propeller shaft ass'y T/M R/A Tube type 2.Rim size, front 22.5 x 9.00 - offset 175 mm R/A R/A Solid type rear 22.5 x 8.25 - offset 165 mm 2.Universal joints Round bearing type 3.Tire size, front 315/80R22.5-156/153 3.Center bearing 1-piece rear 295/80R22.5-153/150
FRONT AXLE 4.Number of tires Ten (10) numbers 1.Front axle ass'y MF78 series FUEL TANK 2.Type Reversed Elliot, " " section 1.Capacity
beam 2.Fuel pre-filter and Equipped REAR AXLE sedimenter
1.Type 3.Fuel tank cap key Equipped
- 2 -
ZF, sixteen forward and tworeverse speeds, overdrive,synchromesh 1st - 16th
Tandem axle,dual drive withinter axle differential, full flotingsingle reduction, single speedby hypoid gearings with interaxle differetial lock, "No SPIN"
Mechanical control withpower shift
300 L
Full air, dual circuit, taperroller type, leading & trailingshoes for front and rear
Diesel, turbo chargedintercooled, 4-cy., vertical,6-cyl., in-line, overheadcamshaft, water cooled
Electronic control commonrail type
Spring brake acting on rearwheels, for emergency andparking purpose, manualcontrol
Telescopic and tilt steeringcolumn with locking deviceRecirculating ball withhydraulic booster integraltype
10-stud disc wheels (ISOtype)
Equipped(for FS1EMKM only)
413SF-SS CHASSIS FRAME Fuel gauge
1.Type Ladder-shaped channel Coolant temperature gaugesection side rails Air pressure gauge
2.Rear chassis width 850 mm 2.Warning, pilot lamps and buzzers 3.Max. section (depth x 300 x 88 x 8.0 mm Engine oil pressure warning lamp and buzzer flange x thickness) (for FS1EMKD/MKM) Air pressure warning lamp and buzzer
302 x 88 x 9.0 mm Buck-up warning buzzer(for FS1ETKA) Charging warning lamp
4.Tensile strength 540 N/m?キ {55 kgf/m?キ} Beam indicator lamp 5. Hooks Equipped for front and rear Turn signal indicator lamp
CAB Parking brake indicator lamp 1. Type Coolant level warring lamp and buzzer
Differential lock indicator lampEngine over-run warning buzzerFuel level warning lampBattery charging pilot lampABS warning lamp
2. Seating capacity Two Engine retarder indicator lamp 3. Driver's seat Sedimenter water level warning lamp
Transmission splitter range indicator lamp 4. Side passenger's seat Urethane foam pads, high- 3.Switches
back and reclining seat with Lighting switchfabric cover and under tray Directional indicator, dimmer and passing switch
5. Center console Equipped Wiper and washer switch 6. Seat belts 3-point type on driver's & Hazard lamp switch
side passenger's seat Fog lamp switch Dome lamp switch
8. Windshield wipers Electric, triple, intermittent Warning lamp check switchand 2-speed Map lamp switch
9. Sun visor and Differential lock switchover-head console 4.Others
10.Center over-head console Equipped One-key starting-stopping11.Cigarette lighter Equipped Throttle control knob12.Ventilator Forced type by electric Horn button
blower ELECTRICAL EQUIPMENT13.Car heater and defroster Equipped 1.Type 24 volt, negative earth14.Sleeping bed Equipped 2.Batteries15.Car audio AM/FM radio with cassette Number per vehicle 12 V x 2, series-connection
tape and CD player Capacity 432 kC {120 A/h} at 20-16.Floor mat Vinyl type hour rate17.Front air spoiler Equipped(for FS1ETKA) 3.Alternator18.Cab step Equipped Type With built-in rectifier and 19.Trim voltage regulator
Capacity 24 V, 90 A20.Electrical power window Equipped with both side 4.Starter21.Electrical door lock Equipped Type Pinion shift22.Door pockets Equipped at both door side Capacity 24 V, 6.0 kW23.Tire inflator Not Equipped 5.Lamps Headlamps24. Fog lamps
License plate lamp25.Exterior Sunvisor Stop/Tail lamps26.Cushioned Rear Lamps Back-up lamp27.Speaker28.Ashtray29.Power window
INSTRUMENTS 1.Meter and gauges km-kg system
Speedometer with trip meterOdometerTachometer
- 3 -
Two, for driver and sidepassenger
Reading lamp (Fluorescentlamp)Map lampFront end outline markerlamps
Equipped with front 3
Driver and assistant
Transmission P.T.O.and P.T.O. control
Equipped(for FS1EMKD only)
Forward control, all steelwelded construction, fullfloating cab (front:air,rear:air)with electrical oil-pumptilting mechanism
Driver and assistant
EquippedEquipped
Full trim type (side, roof andback)
Directional indicator andhazard lamps (front, sideand rear)
Air Suspension seat
7. Rear view mirrors Electrically adjustable & heated
Note: All specifications of the products are with normal manufacturing allowances and tolerances.Hino Motors, Ltd. reserve the right to alter specifications at any time without previous notice.Figures of axle capacity can be changed by the operating conditions and specifications of equipments concerned.When selecting optional equipment, consult Hino technical staff as the adaptation of some of the optional equipment on production line may require an extra lead time.
- 4 -
SS-FS314 OPTIONAL EQUIPMENT
12.
.Reversing Camera System
1. 14.15.
2. Alloy Road Wheels Alcoa forged alluminium alloy roadwheels.
16.
( 22.5X8.25 rim and or 22.5X9.00 rim )
17
.
.Muckaway Steel or Hardox TipperTipper GrabAlloy AggregateAlloy InsulatedHookloaderConcrete MixerBlock/Brick Carrier
18..
Bodies: 3. Central Chssis lubrication System
5. Illuminated Headboard 6. 7. Air conditioner 8. Sleeping bed curtain 9. Night Heater10. Comfort Matress
Front Roof spoiler11.Hi-Roof Conversion
Visible “Diff Lock engaged” warning lampStainless Steel Lighting Bars: Roof and Front mount
“Handbrake not applied” audible warningVertical Exhuast in stainless steel incorporating O.EM. Muffler
4. Alloy Fuel Tank 300Ltrs
Rotating Beacons roof mounted
13.
Lighting options: Work Lamps Spot Lamps Lightbars
Cheese Wedge
.
19. Onboard Weighing Systems20. Air Horns
FOH
OW
FW
CDRFS340
FS1EMKD/MKM/TKA