How to Order Kwik-Raze Lighting.................................3 Kwik-Raze® Magnafire 3000®...

transcript

How to Order Kwik-Raze Lighting.................................3 Kwik-Raze®Magnafire 3000® Mounts..................................4,5 Fixtures.................................6,7Stonco Series..........................8,9FX-Series.................................10Options/ Accessories................11Collins Dynamics® Handheld lights.....................12 Deck lights............................12 Pole mounts .........................13 Questar® spotlight................14 Portable lights.......................14 Fixed-mount & magnetic- mount lights..........................15 Accessories, Replacement parts, switches................................16Warranty.................................16

Table of Contents

Glossary of Lighting Terms

• Amps: Unit of current draw of a lamp. Sometimes referred to as amperage.

• Volts: Unit of electric potential of a power source. Sometimes referred to as voltage.

• Watts: Unit of power consumption of a lamp (light bulb). Sometimes referred to as wattage. Eachlamp is rated to operate at a specific voltage and wattage. To figure out the current draw (amperage)of a light fixture, divide the total wattage by the rated voltage. For example, a 2,000 watt halogen lampoperating at 240 volts draws 8.33 amps. (2,000 watts / 240 volts = 8.33 amps)

• Ballast: An electrical device used with all gas-discharge lamps (HID, fluorescent, and others) to controlthe lamp. A ballast normally works in conjunction with a starter (sometimes called an igniter) to lightthe lamp, then works to regulate the power by limiting the voltage and current draw of the lamp whileit is lighted. In many cases, the starter and the ballast are combined together into one electrical component.

EQUIPMENT

• Lamp: A light source. Sometimes referred to as a light bulb. Halogen lamps are connected directlyto a power source of rated voltage and wattage. HID lamps require a ballast to power the lamp, andcannot be connected directly to a power line.

• Reflector: A device used to control the light output of a fixture by reflecting light rays in a specificdirection. The shape of the reflector determines the direction of the reflected light. Reflectors are usedfor precise control of light output.

• Diffuser: A device used to scatter light in many directions to reduce its intensity or smooth the pattern.

• Lamp Life: The lamp manufacturer's rating of average life expectancy, rated in hours. This rating doesnot take into account the application in which the lamp is used, nor does it consider manufacturingvariations. Vibration, shock, and other application considerations can negatively affect lamp life.

PERFORMANCE MEASURES

• Lumen: Unit of the total amount of light emitted by a lamp. The lumen output of a lamp is a measure of the total quantityof light produced by the lamp, not the intensity of light on a surface. A lumen rating does not take into account the designof the light fixture or effects of a reflector or lens. Due to manufacturing variations, any given lamp may vary in truelumen output by as much as 10-20% from its rated output.

• Candela: Unit of the amount of light produced by a light fixture, taking into account the reflector, lamp, and lens as acombined light fixture. Candela ratings are not units of illuminance because they do not take into account the distanceof the light fixture to the surface being illuminated. Candlepower is a general term used to define the peak (candela)output of a light fixture, and is ordinarily applied only to spotlights.

• Footcandle: Unit of intensity of light on a surface (illuminance.) One footcandle is defined as the illumination presenton a surface exactly one foot away from a standardized candle. It is also defined as one lumen of light distributed overone square foot. Since the footcandle is a measure of illuminance, it will vary depending on how close or far themeasurement is taken from the light source. Light meters generally measure in footcandles (or sometimes the metricequivalent, lux.)

• Color Temperature: Color temperature is a simplified way to characterize the color of a light source. It is measuredin degrees Kelvin. True white is about 3,500K, lower color temperatures are called "warm white" and appear reddish,and higher color temperatures are called "cool white" and appear bluish. Sunlight is generally cool white; at noon it isabout 5,500K. The human eye is much more sensitive to cool white light than warm white light under low light levels.Color temperatures are as follows:Incandescent: 2,700K • Halogen: 3,000K • Halogen HIR: 3,000K • Metal Halide H.I.D: 4,200K • Xenon: 5,000K

LAMP TECHNOLOGIES

• Halogen Lamp: An incandescent lamp technology. Incandescent lamps have a tungsten filament that is heatedso hot it glows white. Halogen lamps also have inert gases inside the lamp which change the heating characteristicsof the lamp so it glows brighter and operates more efficiently than non-halogen incandescent lamps. Mosthalogen incandescent lamps produce 2,700K to 3,000K warm white light.

• HID Lamp: High Intensity Discharge (HID) lamps have much longer life and much higher efficiency (efficiency,measured in lumens per watt) than most other lamp technologies.

• Metal Halide Lamp: An HID lamp technology. HID lamps produce light by passing electricity throughvaporized metal salts under high pressure. Metal halide is a specific type of HID lamp designed to producethe highest quality light in the most efficient manner, and like all HID lighting, metal halide lamps require aballast to operate. Most metal halide lamps are cool white, producing light ranging from 4000K to 5000K, sothey are particularly well suited to producing light that is easy to see and looks like natural daylight.

• Xenon HID Lamp: Another HID lamp technology. Xenon HID lamps produce light in a manner very similarto metal halide, and require a similar type of ballast to operate. Xenon HID lamps are specifically designed toreach full brightness far more rapidly than any other HID source. Xenon HID lamps also can be relit almostinstantly after being turned off.

Lighting Mounting & Options Chart

Mounting

Available Options

Available Lightheads

LengthMount

S= Standard O= Optional*Please note: Concealed wires are optional with Stonco® Fixtures and standard on all others.

Please see page L22 for recessed mounts available lightheads and options.

Lighting Mounting & Options Chart

When you need high-intensity vehicle auxiliary lighting, Havis-Shields' Kwik-Raze and CollinsDynamics divisions manufacture the largest selection of fixtures, mounting brackets, andbases. Telescoping, fixed-mounted, handheld, or portable / rechargeable fixtures and spot,flood, or combination spot/flood beam patterns are all available for your vehicles.

S po t/F lo odCo mbo

Questar

Knight Star

Floo dS p ot

Magnafire

Stonco

Lighthead Beam Patterns

Page L4

Brow Mount

Willburt Lightower

Magnafire

Magnafire 3000® Specs and Application chart

100 Series 200 Series 300 Series 400 Series 500 Series900 Series1400 Series

1300 Series

600 Series

Part # Part # Part #Pole/Mount Page #

Quartz Halogen12 Volt H.I.D.

Magnafire 3000® Series

Top Raising Pole

100 Flush Mount

200-W/2 2” Offset

200-W/4 4” Offset

200-W/7 7” Offset

300 Thru body

900 Thru body

Bottom Raising Pole

400 Thru body

500-W/2 2” Offset

500-W/4 4” Offset

500-W/7 7” Offset

Non-Telescoping Mount

600 Series

1300 Series

1400 Series

Portable Tripod

700 Series

800 Series

Remote Bottom Raising

1100 4” Offset

1100 7” Offset

1200 Thru-body

KR-131

KR-231-W/2

KR-231-W/4

KR-231-W/7

KR-331

KR-931

KR-431

KR-531-W/2

KR-531-W/4

KR-531-W/7

KR-631

KR-1331

KR-1431

KR-731

KR-831

KR-1131

KR-1131-W/7

KR-1231

KR-31(12 Volt)Page L11

KR-33(350 Watt)Page L11

KR-133

KR-233-W/2

KR-233-W/4

KR-233-W/7

KR-333

KR-933

KR-433

KR-533-W/2

KR-533-W/4

KR-533-W/7

KR-633

KR-1333

KR-1433

KR-733

KR-833

KR-1133

KR-1133-W/7

KR-1233

KR-136

KR-236-W/2

KR-236-W/4

KR-236-W/7

KR-336

KR-936

KR-436

KR-536-W/2

KR-536-W/4

KR-536-W/7

KR-636

KR-1336

KR-1436

KR-736

KR-836

KR-1136

KR-1136-W/7

KR-1236

KR-31-2(Dual 12 Volt)

Page L12

KR-131-2

KR-231-2-W/2

KR-231-2-W/4

KR-231-2-W/7

KR-331-2

KR-431-2

KR-531-2-W/2

KR-531-2-W/4

KR-531-2-W/7

KR-631-2

KR-831-2

Part # Part #

KR-137

KR-237-W/2

KR-237-W/4

KR-237-W/7

KR-337

KR-937

KR-437

KR-537-W/2

KR-537-W/4

KR-537-W/7

KR-637

KR-1337

KR-1437

KR-737

KR-837

KR-1137

KR-1137-W/7

KR-1237

Part #

KR-139

KR-239-W/2

KR-239-W/4

KR-239-W/7

KR-339

KR-939

KR-439

KR-539-W/2

KR-539-W/4

KR-539-W/7

KR-639

KR-1339

KR-1439

KR-739

KR-839

KR-1139

KR-1139-W/7

KR-1239

Part #

KR-131DM

KR-231DM-W/2

KR-231DM-W/4

KR-231DM-W/7

KR-331DM

KR-431DM

KR-531DM-W/2

KR-531DM-W/4

KR-531DM-W/7

KR-831DM

KR-31DM(12 Volt Portable

Demountable)Page L11

Page L5

Aerial Application

Magnafire 3000®

Features

Page L10

Magnafire 3000® provides a smooth beam pattern with NO hot spots!

• Magnafire’s reflector’s optimum size and shape, rounded parabolic corners, and patented mirror finish projectsthe most intense, brightest, and smoothest beam pattern available.

• Bulb changes are easier than ever with the ability to re-lamp from the front (see figure A). Unlike extrudedlight fixtures, the Magnafire also has a modular field replaceable reflector.

• The Magnafire’s superior die cast design eliminates many parts needed in an extruded fixture which makes itmore affordable.

• With the lower wattage and subsequent low amp draw of the Magnafire, you have the ability to add more toyour apparatus and still have the power for operating other equipment.

• Get two lights in one! All Magnafire fixtures come with a standard diffuser installed which can be removed tocreate two beam patterns from just one light! (see figure B)

StandardRemovable Diffuser

Reflector

Easy Bulb Change!In case of a broken bulb, theone-piece lens assembly makesbulb change quick and easy,especially in hard to reachlocations.

150 Watt, 12VDC Metal Halide HID

• Fastest HID light on the market to reach full intensity

• Interchangeable with all other Magnafire fixtures

• Lasts up to 10,000 hours

• Provides 3x to 4x more light than standard halogen lamps.

• Eliminates the need for costly generators!

• Interchangeable with all other Magnafire fixtures; identical size and appearance with all internal, potted electronics

Magnafire 3000® (KR-731)

Magnafire 3000®

Page L10

The Leader in 12- Volt HID Lighting Technology

Scene lighting without a generator!Havis-Shields is pleased to introduce the next generation of emergency scene lighting technology: The 70-watt MetalHalide HID Magnafire 3000®

light fixture. This new floodlight now makes it possible to light up your night time work scene directly from your 12 volt battery, eliminating theneed for costly generators or inverters.

HID technology, nearly 4 times more efficientOur HID fixtures feature Havis-Shields quality and reliability. They’re highly efficient light sources, offering more light per watt than traditional quartzhalogen fixtures. Our HID technology has been proven in the field for quality and reliability.

FX-Series

Page L14

FX-Series & Magnafire 3000®

Aerial Application

KR Poles & Mounts

Page L18

Bomb Truck

KR Poles & Mounts

Page L18

Silver Billet

Tripod

Brow Mount

Recessed Mounts

Kwik Strike 4000

Kwik Strike

Collins FX

Handhelds

Collins Dynamics®

Page L25

Xenon Application

The Xenon Can be used in many different markets:

• Police• Security• Fire• Utility• Marine

Xenon Handheld Spotlight

Page L25

Questar

Questar® Models and Ordering Info

Page L30

Questar® Application Info

Page L31

C-D Series Console

VS Series Consoles

2006 Ford Explorer Vehicle Specific Console

(C-VS-1600-EXPL)

Heavy-Duty Computer Mount

Cold Cathode

Dome Light

Map Light

Quotewriter

Price GuideVisit this hidden link

www.havis.com/priceguide.html

For Current MSRP

Parts Breakdown link

• The Parts Breakdown is accessible via www.havis.com

• http://www.havis.com/Installation/LightingInstallation/KRInstall/KRinstallation.html

How to Order Kwik-Raze Lighting.................................3 Kwik-Raze® Magnafire 3000®...

Documents