Post on 11-Nov-2020
transcript
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 10
1.0 EXECUTIVE SUMMARY
This is a fresh mining lease for mineral Masonry Stone located near Village-
Becha Wali Ki Dhani, Tehsil – Khetri, District – Jhunjhunun, Rajasthan.
Lease is granted in favour of Shri Arihant Murdia S/o Shri Vinod Singh
Murdia, R/o- 4, Mysure House, Civil Lines, Jaipur, (Rajasthan) for mineral
Masonry Stone over an area of 1.00 hectares by lease agreement order No. –
[kv@lhdj@fj@viz@[ki&197@06. (Copy of lease agreement is enclosed as
annexure No-1).
This area is 1.00 Ha. hence it come under jurisdiction of State Government i.e.
SEAC (State Level Expert Appraisal Committee). The Masonry Stone mining
projects with mining lease < 25 ha will be categorized as 'B2'. So this is
Category “B2” mining project under office Memorandum of MOEF vide no.
J-13012/12/2013-IA-1I(I) dated 24th
December 2013. Lessee applies for
environment clearance under aforesaid Office Memorandum dated 24th
December, 2013.
The mining area is of 1.00 Ha. Located near Village – Becha Wali Ki Dhani
(Tan Pratappura), Tehsil – Khetri, District – Jhunjhunun, Rajasthan. Total land
of mining lease comes under Government Land (Gair Mumkin Pahar). No forest
land is involved in this area. Topographically, the area is gently sloped. Khasra
no 1541/657 of revenue Village – Becha Wali Ki Dhani (Tan Pratappura),
Tehsil–Khetri, District – Jhunjhunun which is Government land, List of relevant
Khasra is given in table 1.1 below and forms the part of Toposheet, 45M/13.
Table 1.1 Salient Features of the Mine Site & Surrounding Details
S.No. Particulars Details
1. M.L. No. 197/2006
2. Name of Mineral Masonry Stone
3. Khasra Nos. Details of village wise Khasra details are as:
S.No. Name of Village Khasra
No.
Total Area
in Hectare
1 Becha Wali Ki Dhani
(Tan Pratappura) 1541/657 1.00
4. Status of Khasra Land in
revenue record
Govt. land (Gair Mumkin pahar)
5. Area 1.00 Ha.
6. Latitude & Longitude Pillars Latitude Longitude
FRP 27° 52' 47.4000" N 75° 47' 41.9000" E
X 27° 52' 24.7548" N 75° 47' 38.2997" E
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 11
A 27° 52' 25.5044" N 75° 47' 32.2658" E
B 27° 52' 26.2540" N 75° 47' 26.2319" E
C 27° 52' 24.3240" N 75° 47' 25.9251" E
D 27° 52' 23.5744" N 75° 47' 31.9589" E
7. Near Village Becha Wali Ki Dhani (Tan Pratappura)
8. Tehsil Khetri
9. District Jhunjhunun
10. State Rajasthan
11. Toposheet No. 45M/13
12. Description report of
Lease area From To Bearing Distance (Meters)
FRP X 188o00’00” 704 m
X A 278o00’00” 166.66 m
A B 278o00’00” 166.66 m
B C 188o00’00” 60 m
C D 98o00’00” 166.66 m
D A 08°00’00” 60 m
13. Nearest Railway Station Nearest railway station is Mavanda at a distance of 7.8
km in SSE direction of the mine site.
14. National Park There is no National Park in the 10 km radii of lease
area.
15. Biosphere Reserve There is no Biosphere Reserve in the 10 km radii of
lease area.
16. Heritage There is no heritage located in 10 km radii of lease
area.
17. Reserve Forest S.No. Particulars Distance Direction
1. Bansiyal PF 6.4km NE
2. Khetri PF 3.1km NW
3. Madhogarh Block PF 7.3km WNW
4. PF N/v Pratappura 0.85km NW
5. Dokan PF 9.4km ESE
18. National Highway/State
Highway
State Highway SH-13 is located at a distance of 2.5
km in SW direction of the mine site.
19. Water Bodies S.No. Particulars Distance Direction
1. Dongar Nala 3.7km NE
2. Tikaria Dam 8.25km ENE
3. Khakli Nala 9.0km SSW
4. Dohan Nala 4.4km ESE
5. Mansagar Nala 9.9km North
6. Deharwala Dam 2.4km NE
7. Dogarwala Dam 3.5km NNW
8. Karmeri Dam 5.15km North
20. Population and Distance
of nearest village Village Population Male Female SC ST
Pratappura 2591 1329 1262 5 2
2.0 Introduction of the project/background Information
(i) Identification of Project Proponent. In case of mining project, a copy of
mining lease /letter of intent should be given.
Project Proponent- Shri Arihant Murdia is an individual, it is an ownership
project.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 12
Address of the Lessee:
Shri Arihant Murdia
S/o Shri Vinod Singh Murdia,
4, Mysure House, Civil Lines, Jaipur (Rajasthan)
(ii) Brief Description of Nature of Project:
Mining lease is granted in khasra no. 1541/657 in revenue village - Becha
Wali Ki Dhani (Tan Pratappura) of Tehsil - Khetri, District Jhunjhunu,
Rajasthan, lease area 1.00 Ha. (Enclosed copy of lease agreement as
annexure no.-1). Khasra wise details of area proposed to be granted for
mining lease is enclosed as annexure no-4). This mining Lease is situated in
Becha Wali Ki Dhani (Tan Pratappura) of Tehsil Khetri, District Jhunjhunun
(Rajasthan) over an area of 1.00 Ha. It is proposed for mining of mineral
Masonry Stone. Mining of Masonry Stone would be carried out by open cast
benching method. The bench height will be kept up to 3 meters the width of
the bench will be always more than the height. The mining will start from
top towards bottom. Mining will be semi-mechanized.
(iii) Need for the project and its importance to the country and region
The state of Rajasthan is endowed with minor and major mineral resources.
Minor mineral is playing a pivotal role in economy of Rajasthan. Masonry
stone (Cheja Patthar) mining in the allotted area is feasible. Mineral masonry
stone (Cheja patthar) is extensively used in construction and infrastructure
projects. Proposed project of masonry stone (Cheja patthar) has the
indigenous demand. By this proposed project of masonry stone mining in the
area local people will get employment & thus will make their better living
standards, provide basic facilities such as drinking water, road, education
and medical etc. in its close vicinity. The state government will get revenue
in the form of royalty, taxes etc. and thus contribute to regional and national
economy.
(iv) Demand and Supply Gap
There is large demand of masonry stone for road, railway track, building
construction etc. In past, demand was not too much but at this time demand of
Masonry stone is increasing. At present, there is constant demand of masonry
stone in the area.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 13
(v) Imports v/s Indigenous Production
As the mineral in abundance is available indigenously so the import of the
same is not required nor economically feasible being a low cast mineral.
(vi) Export possibility
Export of mineral masonry stone is not feasible. Masonry Stone can be
sufficiently absorbed in the local market, it will not be exported.
(vii) Domestic/Exports Markets
There is always an increasing demand of masonry stone in domestic markets.
(viii) Employment generation (Direct & Indirect) due to the project
By this mining project of Masonry Stone in the area, peoples will get
employment. The project directly generates the employment for the local
people and indirectly for the others. Also the marketing of the product
generates the employment for peoples. By this project, approximately 10
persons will get direct and indirect employment from the Masonry Stone
mining project.
Fig. No. 1.1
3.0 Project Description
(i) Type of Project including interlinked and interdependent projects, if any.
This is a masonry stone mining project. No other project is interlinked with
this mining work.
Mining Engineer/Mine Manager
Mining Foreman/Mine Mate/Blaster
Supervisor
Mine Labourers Clerk Watchman
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 14
(ii) Location (map showing general location, specific location, and project
Boundary & project site layout) with coordinates.
Location map of the study area is as under:
Fig. 1. Location map of Lease Area
The area has been marked on Toposheet No. 45M/13 including the mining
lease location. This comprises the mining location of near village Becha Wali
ki Dhani falling in Tehsil – Khetri, District – Jhunjhunun of Rajasthan state.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 15
(iii) Details of alternate sites considered and the basis of selecting the proposed
site, particularly the environmental considerations gone into should be
highlighted.
No other site has been considered for the proposed project. The land has been
allocated by government for the mining only. Site is adequate for Masonry
Stone mining.
(iv) Size and Magnitude of Operation
The proposed capacity of the project is as: The total amount of Masonry Stone
is 296659 Tonne under proved category reserves, 831179 Tonne under
probable category reserves. Total reserves = 1127838 Tonne of Masonry
Stone. Total area of mining lease is 1.00 Ha. Proposed maximum annual
targeted production of Masonry Stone from the mine will be 1,10,400 TPA.
(v) Project description with process details (a schematic diagram/flow chart
showing the project layout, components of the project etc. should be
given)
A. Method of Mining
A haul road of gradient maintained 1 in 16 as per MMR 1961 is exists in the
mine. Approach roads are provided upto the working pit for movements of
labourers and vehicles.
Hydraulic dumpers and tippers will be deployed for transportation of masonry
stone (Cheja Pathar) form working to consumers. It is an existing mining lease
of Cheja pathar and presently mining is being done adopting opencast method.
The existing production capacity of the lease is 200 TPD. The mining is
proposed to be done in combination with hydraulic excavator, Compressor
with 100-115 mm dia drill and dumpers. The height of the bench is kept
limited to 6 meter and width of the bench shall not be less than the bench
height. Face slope is 85°, whereas ultimate pit slope is proposed 45°.
Following machineries will be used for mining of Masonry stone:
Table 1.2 Showing Details of machinery proposed to be used at mine
S.No Item Capacity Quantity
1 Hydraulic Excavator Tata 220 2
2 Compressor 400-450 CFM 1
3 Ingersoll-Rand Drill machine 100-115 mm Dia 1
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 16
4 Rear Hydraulic Tippers/dumpers 20-25 MT 4
5 Water Tanker 3000 Liter 1
B. Regional Geology
The area covers part of Jhunjhunun and Sikar districts of Rajasthan and a
small part in the northeast falls in Mahendragarh district of the Haryana State.
The area is well connected by roads and railway line. The Phulera – Rewari
railway line passes through the area. The area exhibits semi-arid climate with
average annual rainfall of 460mm. the area is drained by Northerly – flowing
Chandrawati River with its tributaries. Besides, a number of ephemeral
streams showing dendritic to sub-dendritic pattern present in the area, which
either join the Chandrawati River or die out in the sandy terrain. The meta-
sedimentary rocks exposed in the area comprise meta-areanites, meta-argillites
with intercalated calcareous rocks. These belong to the Delhi Super Group
(Palaeo to meso Proterozoic). The arenaceous rocks are grouped under the
Alwar group and meta-argillites with calcareous rocks are grouped under the
Ajabgarh Group. Granite, amphibolites and other intrusive rocks are also
found in the area. The Alwar group comprises mainly massive quartzites
which are exposed in the hills in Southeastern part of the area. The quartzite’s
are massive, fine to medium grained and grey, buff or brown colour and
belongs to the Pratapgarh formation of the Alwar group. The quartzites are
showing NE-SW strike with 65 to 75 dip easterly. Amphibolite intrudes most
of rocks of the Delhi Super Group in the area and is of wide distribution, but it
is prominently seen in the vicinity of Khetri and north of Papurna. These are
two types: coarse to medium grained and massive ones generally occurring in
pellitic rocks as large bodies, roughly parallel to regional strike and rocks. The
other type is confined to the arenaceous rocks as thin, cross-cutting dykes
trending NNW-SSE or NW-SE. these are fine grained and more closely
fractured. The amphibolites are steeply dipping to near – vertical and represent
metamorphosed basic intrusive.
Delhi Super Group Ajabgarh Group Khushalgarh
Formation Calc gneiss and Quartzite
C. Local Geology of the area
Geologically, the rocks in the lease area are mainly Calc-gneiss Quartzite,
belonging to Ajabgarh group of Delhi Super Group.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 17
D. Yearwise annual production of masonry stone for next five years
Table 1.3 The details of production are as follows
Year Masonry Stone (Cheja Pathar) in MT
I 1,10,400
II 1,10,400
III 1,10,400
IV 1,10,400
V 1,10,400
Total 5,52,000
E. Mineable Reserves and Anticipated Life of the Mine
All in situ reserves will not be possible to mined out as there will be some
mineral will be left un-mined i.e. in road barrier, ramp etc. it is assumed about
10% so net mineable reserve will be:
Total mineable reserves = 1127838 Tonne
The proposed rate of production for the first five years is 1,10,400 Tonne per
annum. Expected life of mine on the basis of proved & probable category of
reserves from the present targeted rate of production: 1127838/1,10,400 =
10.21years or say 10 years.
F. Conceptual Mining Plan
Conceptual Simplified Mining Scheme is necessary to know the ultimate limit
of the pit crust at surface at the end of lease period. It is also necessary to
select the sites for waste dump, site service, plantation etc. in such a place that
these sites should not get any disturbance during the life of mine. Considering
the aforesaid aspects the conceptual plan as follow:
Ultimate extent and size of the pit
The ultimate extent and size of the pit will be as follows:
Length of the working 151.66 meters
Width of the working 45 meters
Depth of the working 25 meters
The final Slope angle adopted
Considering the stability of rocks the final slope angle or says ultimate pit
slope is proposed 45°. This slope angle will remain quite safe for these
deposits.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 18
Ultimate capacity of dumps: It is a masonry stone (Cheja Pathar) mine. The
maximum quantity of stone, like lump, grit etc has market. The waste will
come around 8% towards maximum in the form of powder and weathered
stone. This waste will be used for construction and maintenance of kucha
approach road time to time. Thus, no waste will be left at site and thus waste is
not proposed to dump in the applied lease area. However a site of 0.01 hectare
will be provided for temporary dump.
Stabilization of dumps: The waste dump will be stabilized by constructing a
rubble stone wall of 0.5X0.5 meters in width and height towards lower altitude
side of the dumps.
Ultimate pit limit: The general ground level outside the lease area is around
400 mRL. Proposed deepest working will be far above the ground water table.
It will be up to 414 mRL, which is far above the level of ground water table.
Thus ground water will not encounter in the workings.
G. Raw material required along with estimated quantity, likely source,
marketing area of final products/s, Mode of transport of raw Material
and Finished Product.
About 4.5 KLD water will be required for Masonry Stone mining which will
be arranged from PHED supply from village Becha Wali ki Dhani (Tan
Pratappura). About 500 liter diesel will be required daily for JCB &
Trucks/Dumpers which will be arranged from nearby petrol pumps. Masonry
Stone mined out will be transported through trucks & trolley.
H. Resource optimization/recycling and reuse envisaged in the project, if
any, should be briefly outlined.
Water will be accumulated in the excavated mine out pit area during rains and
pits serve as a natural ground water recharge structure. As a result of
extraction of mineral, the rate of charging of ground water is likely to be
increased considerably. Water collected in the sump will be used in various
purposes at mine viz. plantation, dust suppression etc.
I. Availability of water its source, Energy/power requirement and source
should be given.
Total water requirement in the mine will be about 4.5 KLD for drinking &
domestic use, dust suppression and plantation. Drinking water will be brought by
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 19
water tanker from nearby villages. Diesel will be used in compressor, JCB and
dumpers and tractors. About 500 liter per day is assumed to be consumed. Diesel
will be outsourced from nearby diesel pumps. Nearby villages is well electrified.
Fig. 1.3 Water requirement during various purposes at Mine Site
(ix) Quantity of wastes to be generated (liquid and solid) and scheme for their
management/disposal
It is a masonry stone (Cheja Pathar) mine. The maximum quantity of stone,
like lump, grit etc has market. The waste will come around 8% towards
maximum in the form of powder and weathered stone. This waste will be used
for construction and maintenance of kucha approach road time to time.
However a site of 0.15 hectare will be provided for temporary dump.
(x) Schematic representations of the feasibility drawing which give
information of EIA purpose
Proposed project is of B2 category mining project in the light of MOEF office
memorandum no. J-13012/12/13-IA-II(1) dated 24th December, 2013. B2
category mining projects are required to obtain EC from SEAC (State level expert
appraisal committee) before commencement of the project in lieu of MOEF,
however half yearly monitoring of Air, Water & Noise environment would be
periodically carried out and monitoring report would be submitted to MOEF &
State Pollution Control Board.
4.0 Site Analysis
(i) Connectivity
The lease area is located near village – Becha wali Dhani in tehsil – Khetri of
district – Jhunjhunun of Rajasthan State. The lease area is situated about
1.0km towards SE side of the village Becha wali Dhani. Nearest town and
tehsil headquarter khetri is about 14 km NW of the applied area. Jaipur to
Drinking (1.0 KLD)
PHED supply from
nearby villages
through tankers
Water Sprinkling (2.0 KLD)
Mine sump water
In Plantation (1.5 KLD)
Mine sump water
Soak Pit
Normal
Demand
(4.5 KLD)
Consumption
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 20
Jhunjhunun is 170 km via Sikar-Nawalgarh. Nearest railway station is
Mavanda at a distance of 7.8 km in SSE direction of the mine site.
(ii) Land Form, Land use and Land ownership
The area of lease is 1.00 Ha. Land is Government land. The lease area forms
part of G.T. Sheet No. 45M/13. No forest land is involved in leased area.
Details are given in table below:
Table 1.4 Land Status of Lease Area
Location
Near Village Tehsil
District &
State
Status of
Land
Total No. of
Revenue Khasra
Total Lease
Area (Ha.)
Period
(Year)
Becha wali
Dhani Khetri
Jhunjhunun
Rajasthan
Govt.
land
(Kasra no
1541/657) 1.00 20
(iii) Topography (Along with map)
The lease area comprises undulated terrains. The highest altitude is of 408
mRL and lowest is of 380 mRL. Maximum part of the applied area is covered
masonry stone (Cheja Pathar). Drainage in the lease area is along slope of the
area. General drainage in surroundings is SSE to NNW. No habitation located
near the lease area. Nearest habitation is located in houses in agriculture lands.
Nearest village is Becha Wali Dhani towords NW side and Gadrata West of
the existing area.
(iv) Existing land use pattern (agriculture, non-agriculture, forest, water
bodies (including area under CRZ), shortest distances from the periphery
of the project to periphery of the forests, national park, wild life
sanctuary, eco sensitive areas, water bodies (distance from the HFL of the
Bajri), CRZ. In case of notified industrial area, a copy of the Gazette
notification should be given.
The lease area comes under Government land (Gair mumkin Pahar).
Table 1.5 Existing Land Use Pattern
S.No. Land use Category Present
1 Top Soil Dump 0.02 Ha.
2 Waste Dump (External) 0.15 Ha.
3 Excavation (Voids Only) 0.245 Ha.
4 Road 0.01 Ha.
5 Built Up Area 0.01 Ha.
6 Township Area -
7 Afforestation 0.008 Ha.
8 Reclamation (Backfilled) -
9 Mineral Storage -
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 21
10 Processing (Crushing) -
11 Undisturbed Area 0.557 Ha.
Total 1.0 Ha.
There is no eco-sensitive areas such as National Park, Wildlife Sanctuaries etc.
present around lease area.
(v) Existing Infrastructure
Presently there is no infrastructure in lease area.
(vi) Soil Classification
Fine sand fraction constitutes 76 to 84 percent; the rest 10-18 percent is made
up of medium sand. The accumulative interdune soils have appreciably more
of clay, silt and free lime. In the western parts, the dune soils are pale brown
and weakly calcarious in Nagaur, Jhunjhunu and Sikar districts. These soils
are mostly non-calcarious and yellowish brown.The associated soils in the
western part are also sandy, though these have a little more of silt and clay.
(vii) Climatic data from secondary sources
The climate of the district can be classified as semi-arid. It is characterized by
very hot summers and very cold winters with poor rainfall during South-west
monsoon period. In May and June, the maximum temperature may sometimes
goes up to 48oC. The potential evaporation rates are quite high, especially
during May and June. The total annual potential evaporation is 581.8mm.
Table 1.6 Rainfall in Tehsil-Khetri, District-Jhunjhunun, Rajasthan
S.No. Year Rainfall in mm.
1 1990 419.0
2 1991 400.0
3 1992 529.0
4 1993 770.0
5 1994 675.0
6 1995 837.0
7 1996 1115.0
8 1997 628.0
9 1998 461.0
10 1999 471.0
11 2000 400.0
12 2001 621.0
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 22
13 2002 234.0
14 2003 693.0
15 2004 370.0
16 2005 447.0
17 2006 433.0
18 2007 413.0
19 2008 800.0
20 2009 557.0
21 2010 944.0
22 2011 645.0
23 2012 519.0
Annual Average Rainfall in mm. 581.8
(Source: waterresources.rajasthan.gov.in)
(viii) Social Infrastructure Available
In District Jhunjhunu, There are six sub-division, Khetri, Chirawa, Jhunjhunu,
Nawalgarh, Udaipurwati, Buhanu. Eight tehsils - Khetri, Chirawa, Surajgarh
(Sub), Jhunjhunu, Malsisar (Sub), Nawalgarh, Udaipurwati, Buhana, There are
eight panchayat samities, 13 towns and 1,063 villages in the district. It
promotes good industrial growth via provides better infrastructure facilities.
(A.) Electricity
There is no source of electricity generation in the district. In the Jhunjhunu
District, There are 12 Towns and 865 Villages electrified. Electricity facilities
are available at Tehsil Headquarter Khetri, Nawalagrh, Udaipurwati and
Gudha Gourji.
(B.) Water
Drinking water is available in hand pump and wells located near by the lease
area and around 0.5 kms away near a temple near tar road. The water will
brought from villages in tanks.
(C.) Road Transport
The applied lease area is about 0.8 kms from tar road and kuchcha rasta is
available up to the applied lease area.
(D.) Rail Transport
Nearest railway station is Neem Ka Thana around 25 km from the mine site.
This station as located on Broad gauge line of between Fulera-Rewari section
railway (Broad gauge). Many up and down trains are running on this back.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 23
(E.) Air Transport
Air transport facility is not available in the district. The nearest air port is at
Jaipur (115 km).
(ix) Health and Educational facilities
Dispensary is available at Papurna and Hospital facility is available at Khetri.
Senior Secondary school is available at Tehsil - Khetri. Schools are available
in all prominent villages. College facility is also available at Khetri and
Jhunjhunun.
5.0 Planning Brief
(i) Planning Concept (type of industries, facilities, transportation etc.) Town
and country Planning/Development authority Classification
This is a mining project. Facilities includes such as office building, first aid
center, rest shelter, vocational training center, godown, workshop, are
proposed in the area. The infrastructures, which are not available, will be used
for the entire life of the mine. Open cast methods of mining will be adopted.
Transportation of mineral shall be done through road by dumpers, trucks.
Other facilities such as power, transportation and communication, social
infrastructure facilities are locally available near project site. Nearest village is
Papurna at a distance of 3.0 km, facilities like dispensary, post office are
available in this village.
(ii) Population Projections
The project will employ most of the workers from nearby areas. Local people
from nearby villages will be give preference. Thus there will no chance to
increase population due to proposed project of masonry stone mining in the
area.
(iii) Land Use planning (breakup along with greenbelt etc.). Approximate
land use is as following for life of Mine
Table 1.7 Land use plan of Lease area at the end of the life of mine (Area in Ha.)
S.No. Land use Category Present 5th
Year End of life of mine
1 Top Soil Dump 0.02 0.02 -
2 Waste Dump (External) 0.15 0.15 0.15
3 Excavation (Voids Only) 0.245 0.367 0.683
4 Road 0.01 0.01 -
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 24
5 Built Up Area 0.01 0.01 -
6 Township Area - - -
7 Afforestation 0.008 0.1 0.167
8 Reclamation (Backfilled) - - -
9 Mineral Storage - - -
10 Processing (Crushing) - - -
11 Undisturbed Area 0.557 0.343 -
Total 1.00 1.00 1.00
(iv) Assessment of Infrastructure Demand (Physical & Social)
The road facility is already available which shall be used and properly
maintained. Preference will be given to local labor from nearby villages. Other
requisite infrastructure as transport of mine labours is available by way of
jeep; two-wheelers.
(v) Social Infrastructure
Proposed project will provide employment for about 10 people directly and
indirectly providing for about 40 which are Shopkeepers, Mechanic, drivers
and transporter.
Table 1.8 Demographic Profile of nearby villages
S.No. Village Population Male Female SC ST
1. Pratappura 2591 1329 1262 5 2
(Source: Census, 2011)
(vi) Amenities/Facilities
Basic amenities/facilities available in nearby villages and towns are such as
road, power supply, communication, water supply, medical and health etc. Site
is well connected with road and other infrastructure facilities. Nearest post
office, telegram and telephone facilities are available at village Papurna about
3.0 kms in North direction from the applied lease area.
6.0 PROPOSED INFRASTRUCTURE
(i). Industrial Area (Processing Area)
Facilities includes such as. Site Office, First Aid, Toilet, Rest Shelter are
proposed in the lease area.
(ii). Resident Area (Non Processing Area)
No residential area is proposed.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 25
(iii). Green Belt: To improve the environment of the area it is proposed to plant
along the lease boundary, waste dump and other un worked area outside the
lease area. Around 33% plantation will be carried out during life of mine.
During plantation preference will be given to local species of plant. Proper
care will be taken during plantation such as watering, manuring & fencing.
Plant such as Acacia senegal (safed khair), Azadirachta indica (Neem), Cassia
fistula (Amaltas) etc will be planted.
(iv). Social Infrastructure: In social infrastructure, house is made of pucca and
kaccha both of type. Tar road is available in near villages. By this proposed
Masonry Stone mining in the area, provides employment opportunities in the
area and this helps to control migration of people of one place to other.
(v). Connectivity (Traffic and transportation Road/Rail/Metro/Water ways etc.)
The lease area is located near village – Becha wali Dhani in tehsil – Khetri of
district – Jhunjhunun of Rajasthan State. The lease area is situated about
1.0km towards SE side of the village Becha wali Dhani. Nearest town and
tehsil headquarter khetri is about 15 km NW of the applied area. Jaipur to
Jhunjhunun is 170 km via Sikar-Nawalgarh. Nearest railway station is
Mavanda at a distance of 7.8 km in SSE direction of the mine site.
(vi). Drinking Water Management (Source & supply of water)
Water requirement of 4.5 KLD will be met from nearby villages.
(vii). Sewerage System
No sewerage shall be generated from the project area.
(viii). Industrial Waste Management
No Industrial waste will be generated from the project.
(ix). Solid waste Management
There is no top soil in the area thus dumping yards is not required for separate
stacking of top soil. Further if any top soil found in the area can be utilized as
morrum and can be used for maintaining un-metalled road and plantations.
Depending upon the volume of generation of sub-grade mineral, arrangement
for separate dumping will be done. However in case of cheja pathar all
excavated rocks are consumed in forming grits and dust for construction.
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 26
(x). Power Requirement
Nearby village’s area is well electrified, mining machinery will be driven by
diesel power for which estimated requirement of diesel will be about 500 liters
per day which will be procured from nearby petrol pumps.
7.0 REHABILITATION AND RESETTLEMENT(R&R PLAN)
A. (Policy to adopted (Central State) in respect of the project affected
person including home oustees, land oustees and landless labour (A brief
outline to be given).
Mining will be carried out in lease area only so no need of rehabilitation and
resettlement plan so far.
8.0 PROJECT SCHEDULE AND COST ESTIMATES
(i). (Likely date of start of construction and likely date of completion (time
schedule for the project to be given)
Project will commence within 30 days after getting the environmental clearance.
It is estimated that about Rs. 20 Lakh will be required for mining machineries,
vehicle and infrastructure development etc.
The profit will depend upon the actual production obtained from the mine,
which may vary due to demand in market.
POPULATION BENEFITED
About 10 peoples including labours benefited directly and 40 persons will be
benefited indirectly.
GOVERNMENT REVENUE
The State Government will get revenue as royalty from selling of mineral,
Land Tax/surface rent, Sales Tax/VAT; Income Tax etc. will be addition.
9.0 ANALYSIS OF PROPOSAL (FINAL RECOMMENDATION)
CONCLUSION
Masonry Stone mining project of Shri Arihant Murdia at near village Becha
Wali ki Dhani, Tehsil–Khetri, District–Jhunjhunun, Rajasthan is of utmost
importance to the area for interest of mineral development and improves the
socio-economic conditions of the local habitants. The operation of the
proposed project of Masonry Stone mining will pass on various social and
economic benefits to the local communities of the area in addition to the
Prefeasibility Report of Masonry Stone Mining N/v– Becha Wali Ki Dhani (Tan Pratappura), Tehsil – Khetri, District –Jhunjhunun (Rajasthan) ML.No- 197/2006, Lease area – 1.00Ha.
Project Proponent: Shri Arihant Murdia Page - 27
existing benefits due to provide better employment opportunities and
improvement in social infrastructure of the area, apart from increased financial
benefits accruing to state and central agencies by ways of taxes, royalty, cess
etc.