Optra Manual de Electricidad

transcript

Diagramas ElectricosChevtolet Optra motor 1.4, 1.6 y 1.8 litrosEngine Control Module: MR-140, HV-240 Y SIRIUS D4

chirinosca @ gmail.com

- Ubicación de Conectores

- Ubicación de Sensores y Actuadores

- Ubicación de Pin en la UCE

- Ubicación de Tierra

- Color de Cableado y Numero de Cable

Todos los Sistemas Electricos

SECTION 1

HOW TO READ ELECTRICAL WIRING DIAGRAM

1. HOW TO READ ELECTRIC WIRING DIAGRAM

1) CONTENTS OF ELECTRICAL WIRING DIAGRAM (CIRCUIT)POSITION EXPLANATION

A- Upper horizontal lines : Power supply lines- Power supply lines : 30, 15, 15A, 15C, 58

B- Ef20 or F2 : Fuse Number

• Ef20 : Fuse No #20 in engine room fuse box• F2 : Fuse No #2 in passenger room fuse box

C - Connector (C101~C902)• Connector No C203 terminal No1

POSITION EXPLANATION

• Refer to Major Connector Position (Section 2)

D- S201 : Splice pack (S101~S303)

• Refer to Major Splice Pack Position (Section2)

E- Internal circuit of component (Relay)(Component Name and Terminal Number)

F- Internal circuit of component (switch)(Component Name, Terminal Number and Connecting Wiring Circuit)

G- Wiring Harness Color

• Refer to Wiring Harness Color Abbreviation

- Lower horizontal line : Ground line• Ground position(G101~G401)• B : Body Ground• Refer to Major Ground Position (Section2)

2. CIRCUIT IDENTIFICATION SYMBOLIDENTIFICATION

SYMBOLMEANING

C ConnectorD DiodeEf Fuse in engine room fuse boxF Fuse in passenger room fuse boxG GroundS Splice pack(Junction connector)

3. FUNCTION OF POWER SUPPLY LINE (NUMBER)

Power supply No

Power supply condition

15Battery Voltage(B+) supply in Ignition Switch "ON" and "ST" (IGN 1)

15A Battery Voltage(B+) supply in Ignition Switch "ON" (IGN 2)

15CBattery Voltage(B+) supply in Ignition Switch "ON" and "ACC"

30Battery Voltage(B+) supply directly regardless of Ignition Switch

31 Ground connected to battery(–)

58Battery Voltage(B+) supply in Head Lamp Switch 1st and 2nd step (Illumination circuit)

4. WIRING HARNESS COLOR IDENTIFICATIONAbbreviation Color Abbreviation Color

Br Brown Sb Sky BlueG Green R RedV Violet L BlueP Pink Y YellowW White Gr GrayOr Orange B BlackLg Light Green . .

5. HOW TO CHECK TERMINAL NUMBER OF CONNECTOR

- Terminal number is given based on Female Terminal Connectorex) Terminal Number 4 of C901 connection

SECTION 2

POSITION OF CONNECTORS AND GROUNDS

1.CONNECTOR, GROUND AND SPLICE PACK INFORMATION1) WIRING HARNESS, GROUND & SPLICE PACK LOCATION

2) CONNECTOR INFORMATIONConnector

NumberTerminal Number

ColorConnecting Wiring

HarnessConnector Position

C101 21 Pin WhiteBody – Engine Fuse Block

Engine Fuse Block

C103 10 Pin WhiteEngine – Engine Fuse Block

Engine Fuse Block

C104 24 Pin WhiteFront – Engine Fuse Block

Engine Fuse Block

C106 20 Pin WhiteEngine – Engine Fuse Block

Engine Fuse Block

C107 2 Pin WhiteABS – Engine Fuse Block

Engine Fuse Block

C108 24 Pin Black Body – EngineLeft Engine Fuse Block

C109 4 Pin White Engine – FrontUnder Engine Fuse Block

C110 12 Pin White ABS – BodyBelow Engine Fuse Block

C111 2 Pin Black ABS – FrontBelow Engine Fuse Block

C112 2 Pin Black Front - HornCenter Cross Member Panel

C113 16 Pin Black Body – Front Behind ECM BracketC201 76 Pin Black I.P – I.P Fuse Block I.P Fuse BlockC202 89 Pin White I.P – Body Left Driver Leg Room

C204 8 Pin WhiteRoof – Body (W/O Rain Sensor)

Left Driver Leg Room

C204 14 Pin WhiteRoof – Body(W/ Rain Sensor)

C206 22 Pin White I.P – TCMUpper Driver Leg Room

C207 6 Pin White Air Bag – I.PUpper Right Driver Leg Room

C208 15 Pin White I.P – FATC Behind Glove Box

C209 20 Pin Black FATC – FATC.AuxBetween Heater Core and Evaporator Core

C301 8 Pin White Air Bag – Body Front SDMC302 6 Pin White I.P – Console Below Console Box

C351 33 Pin GrayBody – Front Light Door

Under Driver A Pillar

Connector Number

Terminal Number

ColorConnecting Wiring

HarnessConnector Position

C361 33 Pin GrayBody – Front Right Door

Under Co-Driver A Pillar

C371 12 Pin WhiteBody – Rear Light Door

Under Left B Pillar

C381 12 Pin WhiteBody – Rear Right Door

Under Right B Pillar

C401 8 Pin White Trunk – BodyInside Right Trunk Side Cover

C402 6 Pin White Trunk LID – BodyInside Right Trunk Side Cover

C403 (H/B) 6 Pin White T/Gate. EXT. - Body Inside Left C PillarC403 (S/W)

4 Pin White T/Gate. EXT. - Body Inside Left C Pillar

C404 8 Pin White T/Gate. EXT. - Body Inside Left C Pillar

C405 8 Pin White T/Gate. EXT. - T/GateBeside Left Rear Wiper Motor

C406 (H/B) 6 Pin White T/Gate. EXT. - T/GateBeside Left Rear Wiper Motor

C406 (S/W)

4 Pin White T/Gate. EXT. - T/GateBeside Left Rear Wiper Motor

C901 4 Pin Black RR. ABS – BodyCenter Rear Cross Member

3) GROUND INFORMATIONGround Number Wiring Harness Ground Position

G101 Front Behind Left Head LampG102 Front Behind Right Head LampG103 Battery Left BatteryG104 Engine Under Start MotorG105 Battery Under Start MotorG106 ABS Below EBCMG107 Engine(MR-140/HV-240) Under Start MotorG201 I.P Left I/P Fuse BlockG202 Air Bag Behind Left Audio BracketG203 I.P Behind Left Audio BracketG204 Body Below Left Driver Leg RoomG205 Roof Inside Driver A Pillar

G301 BodyBelow Co-Driver Cross Member Floor Panel

G302 Body Below Left C PillarG303 Body Below Right Rear Combination

Ground Number Wiring Harness Ground PositionLamp

G304 BodyBelow Left Rear Combination Lamp

G401 Trunk Center Trunk Lower Back PanelG402 T/Gate. EXT. Inside Driver C Pillar

4) SPLICE PACK INFORMATIONSplice Pack

NumberColor Wiring Harness Ground Position

S101 BlackEngine(MR-140/HV-240)

Upper Transmission

S201 Black I.P Behind ClusterS202 Black I.P Behind ClusterS203 Red I.P Behind Audio MountingS204 Magenta I.P Behind Audio Mounting

S205 OrangeTCM (MR-140/HV-

240)Upper Driver Leg Room

S301 Blue Body Left Driver Leg RoomS302 Brown Body Left Driver Leg Room

2. WIRING HARNESS, CONNECTOR & GROUND LOCATION

1) W/H INSTRUMENT PANEL

2) W/H BODY

3) W/H FRONT

4) W/H ENGINE- SIRIUS D4

- MR-140 / HV-240

5) W/H BATTERY- SIRIUS D4

- MR-140 / HV-240

6) W/H ABS

7) W/H REAR ABS

8) W/H TCM- SIRIUS D4

- MR-140 / HV-240

9) W/H ROOF

10) W/H DRIVE DOOR

11) W/H REAR DOOR

12) W/H TRUNK (N/B)

13) W/H TRUNK (H/B)

14) W/H TRUNK LID

15) W/H TRUNK LID

16) W/H AIR BAG

17) SPLICE PACKS101 (BLACK) : MR-140

S101 (BLACK) : HV-240

S201 (BLACK)

S202 (BLACK)

S203 (RED)

S204 (MAGENTA)

S205 (ORANGE) : MR-140/HV-240

S301 (BLUE) : NOTCH BACK

S301 (BLUE) : HATCH BACK

S301 (BLUE) : STATION WAGON

S302 (BROWN) : NOTCH BACK

S302 (BROWN) : HATCH BACK

S302 (BROWN) : STATION WAGON

SECTION 3

WIRING DIAGRAM FOR POWER SUPPLIES

1. IGNITION SWITCH CIRCUIT

2. 30 TER "BAT+" POWER SUPPLY CIRCUIT (I.P FUSE BLOCK)

3. 15 TER "IGN1" POWER SUPPLY CIRCUIT (I.P FUSE BLOCK)

4. 15A TER "IGN2", 15C TER "ACC" POWER SUPPLY CIRCUIT (I.P FUSE BLOCK)

5. ENGINE FUSE BLOCK & RELAY CIRCUIT

SECTION 4

USAGE AND CAPACITY OF FUSES IN FUSE BLOCK

1. ENGINE ROOM RELAY AND FUSE BLOCK1) POSITION OF RELAY AND FUSE

2) USAGE OF FUSE IN ENGINE FUSE BLOCKPower Supply

ClassificationFuse No

Capacity Usage

. . Ef1 30ABattery Main(F13~F16, F21~F24)

. . Ef2 60A EBCM, Oil Feeding Conenctor

. . Ef3 30A Blower Relay30 SB Ef4 30A Ignition Switch-2

BAT (+) (Slow-Blown Ef5 30A Ignition Switch-1. Fuse) Ef6 20A Cooling Fan Low Relay. . Ef7 30A Defog Relay. . Ef8 30A Cooling Fan HI Relay

IGN2 (15A)

. Ef9 20A Power Window Switch

IGN1 (15) . Ef10 15AFuel Connector, ECM (MR-140), LEGR, EI System

30 . Ef11 10A ECM, Main Relay (Sirius D4)BAT(+) . Ef12 25A Head lamp Relay, ILLUM. Relay

. . Ef13 15A Brake SwitchIGN2 (15A)

. Ef14 20A Power Window Switch

56 LIGHT . Ef15 15A Head Lamp HI

30 . Ef16 15AHorn Relay, siren, Hood Contact Switch

BAT(+) . Ef17 10A A/C Comp. RelayIGN1 (15) . Ef18 15A Fuel Pump

30 BAT(+) . Ef19 15A

Cluster, Key Remind S/W, Folding Mirror Unit, MAP Lamp, Room Lamp, Trunk Open lamp, Trunk Open S/W

56 LIGHT Blade Type Ef20 10A Head Lamp Low

IGN1 (15)/ Fuse Ef21 15AEVAP Canister Purge Solenoid, HO2S, Cooling Fan Relay

30 BAT(+) . Ef22 15A injector, EGR, EEGRILLUM.

(58). Ef23 10A

License Plate Lamp, Chime Bell, Tail Lamp, Head Lamp

30 BAT (+)

. Ef24 15A Fog Lamp Relay

IGN2 (15A)

. Ef25 10A Electric OSRV Mirror

30 BAT (+)

. Ef26 15A Central Door Lock Unit

56 LIGHT . Ef27 10A Head Lamp Low

Power Supply

Capacity Usage

ILLUM. (58)

. Ef28 10AILLUM. Circuit, Head Lamp, Tail Lamp

SPARE. Ef29 10A Not Used. Ef30 15A Not Used. Ef31 25A Not Used

2. I.P FUSE BLOCK1) POSITION OF FUSE AND RELAY

2) USAGE OF FUSE IN I.P FUSE BLOCKPower Supply

Capacity Usage

IGN1 (15)

Blade Type F1 10A SDM

Fuse F2 10ATCM, ECM, Generator, VGIS,VSS

. F3 15A Hazard Switch

. F4 10ACluster, DRL Module, Chime Bell, Brake Switch, SSPS Module, A/C Control Switch

- . F5 - -

IGN2 (15A)

. F6 10AA/C Comp. Relay, Defog Relay, Power Window Relay, Head Lamp Relay

. F7 20ABlower Relay, A/C Control Switch, FATC

. F8 15AElectric Mirror Switch, Folding Mirror, Sun Roof Module

IGN1 (15) . F9 25A Wiper Motor, Wiper Switch- . F10 - -

IGN1 (15). F11 10A EBCM, Oil Feeding Connector

. F12 10AImmobilizer, Anti Theft Control Unit, Rain Sensor Unit

30 BAT(+)

. F13 10A TCM

. F14 15A Hazard Switch

. F15 15A Anti Theft Control Unit

. F16 10A DLC

ACC (15C)

. F17 10A Audio, Clock

. F18 15A Extra Power Jack

. F19 15A Cigar Lighter

IGN1 (15) . F20 10AReverse Lamp Switch, PNP Switch

30 BAT(+)

. F21 15A Rear Fog Relay

. F22 15A Clock, FATC, A/C Control Switch

. F23 15A Audio

. F24 10A Immobilizer

3. POSITION OF CONTROL UNIT, RELAY AND PART NUMBER

1) ENGINE FUSE BLOCKPart Name Part No. Remarks

Front Fog Relay 96190187 .ILLUM. Relay 96190187 .Cooling Fan Low Relay 96190189 .Cooling Fan HI Relay 96190189 .A/C Comp. Relay 96190187 .Horn Relay 96190187 .Defog Relay 96190189 .Fuel Relay 96190189 .Main/Ignition Relay 96190189 .Power Window Relay 96190189 .Head Lamp Relay 96190189 .

2) BEHIND DRIVER LEG ROOM CONNECTOR HOLDERPart Name Part No. Remarks

Rear Fog Relay 96344573 .PNP Relay 96190189 .Blink Unit 96312545 .Blower Relay 96190189 .DRL Relay 96190189 .

3) DRIVER LEG ROOMPart Name Part No. Remarks

Chime Bell 96459510 .TCM (MR-140/HV-240) 96342619 .TCM (SIRIUS D4) 96497032 .

4) BEHIND LEFT HEAD LAMPPart Name Part No. Remarks

Cooling Fan Control Relay 96251271 .

5) UNDER LEFT PASSENGER LEG ROOMPart Name Part No. Remarks

Central Door Lock Unit 96552824 .

6) BEHIND I.P FUSE BLOCKPart Name Part No. Remarks

DRL Module 90414786 .

7) FLOOR PANEL BELOW CONSOLEPart Name Part No. Remarks

Anti Theft Control Unit 96407681 West Euro. 96404668 General

Part Name Part No. RemarksSDM 96406712 .

8) BESIDE ENGINE FUSE BLOCKPart Name Part No. Remarks

EBCM 96549742 .

SECTION 5

ELECTRICAL WIRING DIAGRAMS

1. STARTING & CHARGING SYSTEM1) BATTERY, IGNITION SWITCH, STARTER MOTOR, GENERATOR & PNP SWITCH CIRCUIT

a. CONNECTOR INFORMATIONCONNECTOR NO(PIN NO, COLOR)

CONNECTING WIRING HARNESS

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse Block

C106 (20 Pin, White)Engine – Engine Fuse Block

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse Block

CONNECTOR NO(PIN NO, COLOR)

CONNECTOR POSITION

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS205 (Orange) TCM Upper Driver Leg RoomG103 Battery Left BatteryG105 Battery Under Start MotorG201 I.P Left I.P Fuse Block

b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION

c. POSITION OF CONNECTORS AND GROUNDS• W/H BATTERY

MR-140/HV-240

Sirius D4

d. SPLICE PACK

S205 : MR-140/HV-240

2. ECM (ENGINE CONTROL MODULE) : MR - 1401) BATTERY POWER SUPPLY, GROUND, EI SYSTEM & CKP SENSOR CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse Block

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS101 (Black) Engine (MR-140/HV-240) Upper TransmissionG104 Engine Under Start MotorG107 Engine (MR-140/HV-240) Under Start Motor

c. POSITION OF CONNECTORS AND GROUNDS• W/H ENGINE

W/H FRONT

d. SPLICE PACKS101

2) FUEL PUMP, INJECTOR & HEATED O2 SENSOR CIRCUIT

a. CONNECTOR INFORMATION

CONNECTOR POSITION

Engine Fuse Block

C109 (4 Pin, White) Engine – Front Under Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG107 Engine (MR-140/HV-240) Under Start MotorG302 Body Below Left C Pillar

W/H INSTRUMENT PANEL

3) IAC, SENSOR (MAP, ECT, TP, IAT, KNOCK, ACP & ROUGH ROAD) & LEGR CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

S101 (Black) Engine (MR-140/HV-240) Upper TransmissionG107 Engine (MR-140/HV-240) Under Start Motor

c. POSITION OF CONNECTORS AND GROUNDS

• W/H ENGINE

d. SPLICE PACKS101

4) EVAP CANISTER PURGE SOLENOID, CMP SENSOR, CLUSTER & VSS CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS202 (Black) I.P Behind ClusterG104 Engine Under Start MotorG107 Engine (MR-140/HV-240) Under Start MotorG201 I.P Left I.P Fuse Block

W/H FRONT

d. SPLICE PACKS202

5) CLUSTER, FUEL PUMP & TCM CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

C209 (20 Pin, Black) FATC – FATC.AuxBetween Heater Core and Evaporator Core

G201 I.P Left I.P Fuse Block

W/H TCM

6) DLC, MIL LAMP & IMMOBILIZER CONTROL CIRCUIT: W/ IMMOBILIZER

CONNECTOR POSITION

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg Room

C207 (6 Pin, White) Air Bag – I.PUpper Right Driver Leg Room

• W/H ENGINE

7) DLC & MIL LAMP CIRCUIT: W/O IMMOBILIZER

CONNECTOR POSITION

3. ECM (ENGINE CONTROL MODULE) : HV - 240

1) BATTERY POWER SUPPLY, GROUND, EI SYSTEM & CKP SENSOR CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS101 (Black) Engine (MR-140/HV-240) Upper TransmissionG104 Engine Under Start MotorG107 Engine (MR-140/HV-240) Under Start Motor

W/H FRONT

d. SPLICE PACKS101

2) FUEL PUMP, INJECTOR & O2 SENSOR CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS101 (Black) Engine (MR-140/HV-240) Upper TransmissionG107 Engine (MR-140/HV-240) Under Start MotorG302 Body Below Left C Pillar

d. SPLICE PACKS101

3) IAC, SENSOR (MAP, ECT, TP, IAT, KNOCK & ACP) & EGR VALVE CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS101 (Black) Engine (MR-140/HV-240) Upper TransmissionG107 Engine (MR-140/HV-240) Under Start Motor

d. SPLICE PACKS101

4) EVAP CANISTER PURGE SOLENOID, CMP SENSOR, CLUSTER & VSS CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS202 (Black) I.P Behind ClusterG104 Engine Under Start MotorG107 Engine (MR-140/HV-240) Under Start MotorG201 I.P Left I.P Fuse Block

• W/H FRONT

d. SPLICE PACKS202

5) CLUSTER, FUEL PUMP & TCM CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

S101 (Black) Engine (MR-140/HV-240) Upper TransmissionG201 I.P Left I.P Fuse Block

W/H TCM

d. SPLICE PACKS101

6) DLC, MIL LAMP, IMMOBILIZER & RON SWITCH CIRCUIT: W/ IMMOBILIZER

CONNECTOR POSITION

G104 Engine Under Start MotorG201 I.P Left I.P Fuse Block

7) DLC, MIL LAMP & RON SWITCH CIRCUIT: W/O IMMOBILIZER

CONNECTOR POSITION

G104 Engine Under Start MotorG201 I.P Left I.P Fuse Block

4. ECM (ENGINE CONTROL MODULE) : SIRIUS D4

1) BATTERY POWER SUPPLY, GROUND, EI SYSTEM & CKP SENSOR CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG104 Engine Under Start Motor

2) FUEL PUMP, INJECTOR, FUEL CONNECTOR & CMP SENSOR CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

G302 Body Below Left C Pillar

W/H FRONT

3) MTIA, SENSOR (ECT, KNOCK, IAT, MAP, ACP & HO2S) & POWER STEERING PRESSURE SWITCH CIRCUIT : EOBD

CONNECTOR POSITION

C104 (24 Pin, White)Front – Engine Fuse Block

Engine Fuse Block

C109 (4 Pin, White) Engine – Front Under Engine Fuse Block

4) MTIA, SENSOR (ECT, KNOCK, IAT, MAP, ACP & O2) & POWER STEERING PRESSURE SWITCH CIRCUIT : NON EOBD

CONNECTOR POSITION

Engine Fuse Block

• W/H ENGINE

5) EEGR VALVE, VR SENSOR, CLUSTER & FUEL PUMP CIRCUIT : EOBD

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG201 I.P Left I.P Fuse Block

6) EGR VALVE, CLUSTER & FUEL PUMP CIRCUIT : NON EOBD

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG201 I.P Left I.P Fuse Block

7) EVAP CANISTER PURGE SOLENOID, VGIS, CLUSTER, VSS, TCM & RON SWITCH CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS202 (Black) I.P Behind ClusterG104 Engine Under Start MotorG201 I.P Left I.P Fuse Block

d. SPLICE PACKS202

8) DLC MIL LAMP & IMMOBILIZER CONTROL CIRCUIT: W/ IMMOBILIZER

CONNECTOR POSITION

• W/H ENGINE

9) DLC & MIL LAMP CIRCUIT: W/O IMMOBILIZER

CONNECTOR POSITION

5. TCM (TRANSMISSION CONTROL MODULE) : MR-140/HV-2401) POWER SUPPLY, GROUND, PNP SWITCH, BRAKE SWITCH & SOLENOID VALVE CIRCUIT

CONNECTOR POSITION

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS205 (Orange) TCM Upper Driver Leg RoomG201 I.P Left I.P Fuse Block

c. POSITION OF CONNECTORS AND GROUNDS• W/H TCM

d. SPLICE PACKS205

2) SENSOR (INPUT SPEED, OUTPUT SPEED & TRANSMISSION FLUID TEMP.), CLUSTER, DLC, ECM & HOLD MODE SWITCH CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC302 (6 Pin, White) I.P – Console Below Console BoxS202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS202

3) PNP SWITCH & CLUSTER CIRCUIT

CONNECTOR POSITION

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS205 (Orange) TCM Upper Driver Leg Room

• W/H INSTRUMENT PANEL

d. SPLICE PACKS205

6. TCM (TRANSMISSION CONTROL MODULE) : SIRIUS D4

1) POWER SUPPLY, GROUND, PNP SWITCH, CLUSTER & ECM CIRCUIT : NOTCH BACK

CONNECTOR POSITION

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg Room

C401 (8 Pin, White) Trunk – BodyInside Right Trunk Side Cover

G401 TrunkCenter Trunk Lower Back Panel

2) POWER SUPPLY, GROUND, PNP SWITCH, CLUSTER & ECM CIRCUIT : HATCH BACK

CONNECTOR POSITION

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC403 (6 Pin, White) T/Gate. EXT. - Body Inside Left C Pillar

C405 (8 Pin, White) T/Gate. EXT. - T.GateBeside Left Rear Wiper Motor

G201 I.P Left I.P Fuse BlockG402 T/Gate. EXT. Inside Driver C Pillar

3) POWER SUPPLY, GROUND, PNP SWITCH, CLUSTER & ECM CIRCUIT : STATION WAGON

CONNECTOR POSITION

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomG201 I.P Left I.P Fuse Block

G303 BodyBelow Right Rear Combination Lamp

4) BRAKE SWITCH, BTSI SOLENOID, ISS SENSOR & TRANSAXLE CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomG201 I.P Left I.P Fuse Block

5) HOLD MODE SWITCH, VSS & DLC CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC302 (6 Pin, White) I.P – Console Below Console BoxS202 (Black) I.P Behind ClusterS203 (RED) I.P Behind Audio MountingG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

• W/H TCM

d. SPLICE PACKS202

7. AIR CONDITIONER

1) AIR CONDITIONER CONTROL SWITCH, BLOWER MOTOR RESISTER & BLOWER MOTOR CIRCUIT

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

c. POSITION OF CONNECTORS AND GROUNDS• W/H INSTRUMENT PANEL

d. SPLICE PACKS203

2) AIR CONDITIONER CONTROL SWITCH, INTAKE MOTOR & AIR CONDITIONER COMPRESSOR CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS203 (Red) I.P Behind Audio MountingG102 Front Behind Right Head LampG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

8. FATC (FULL AUTOMATIC TEMPERATURE CONTROL)1) BLOWER MOTOR, INTAKE MOTOR, MODE MOTOR, MAX HIGH RELAY & POWER TR CIRCUIT

CONNECTOR POSITION

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

G201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

2) SENSOR (AMBIENT, INCAR, SUN & WATER), AIR MIX DOOR MOTOR, A/C COMPRESSOR & ECM CIRCUIT2-1) MR-140/HV-240

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

S202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG102 Front Behind Right Head LampG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS202

2-2) SIRIUS D4

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

S202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG102 Front Behind Right Head LampG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS202

9. RADIATOR COOLING FAN CIRCUIT1) COOLING FAN CIRCUIT (MR-140/HV-240) : DUAL

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG101 Front Behind Left Head LampG102 Front Behind Right Head LampG107 Engine (MR-140/HV-240) Under Start Motor

W/H FRONT

2) COOLING FAN CIRCUIT (MR-140/HV-240) : SINGLE

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG101 Front Behind Left Head LampG107 Engine (MR-140/HV-240) Under Start Motor

W/H FRONT

3) COOLIING FAN CIRCUIT (SIRIUS D4) : DUAL

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketG101 Front Behind Left Head LampG102 Front Behind Right Head Lamp

W/H FRONT

4) COOLIING FAN CIRCUIT (SIRIUS D4) : SINGLE

CONNECTOR POSITION

Engine Fuse Block

G101 Front Behind Left Head Lamp

W/H FRONT

10. HEAD LAMP & HEAD LAMP LEVELING DEVICE (HLLD) CIRCUIT1) NOTCH BACK, STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

C113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS201 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

c. POSITION OF CONNECTORS AND GROUNDS• W/H FRONT

d. SPLICE PACKS201

2) HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS201 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS201

11. DRL (DAY TIME RUNNING LIGHT) CIRCUIT

1) NOTCH BACK, STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS201 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG202 Air Bag Behind Left Audio Bracket

d. SPLICE PACKS201

2) HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS201 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG202 Air Bag Behind Left Audio Bracket

d. SPLICE PACKS201

12. ILLUMINATION CIRCUIT1) ILLUMINATION CIRCUIT - W/O DIMMER CONTROL

CONNECTOR POSITION

C302 (6 Pin, White) I.P – Console Below Console BoxS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

2) ILLUMINATION CIRCUIT - W/ DIMMER CONTROL

CONNECTOR POSITION

C302 (6 Pin, White) I.P – Console Below Console BoxS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

3) LAMP (LICENSE PLATE & FRONT/REAR POSITION) CIRCUIT : NOTCH BACK

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

C402 (6 Pin, White) Trunk LID – BodyInside Right Trunk Side Cover

G101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG302 Body Below Left C Pillar

W/H TRUNK

• W/H BODY

4) LAMP (LICENSE PLATE & FRONT/REAR POSITION) CIRCUIT : HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C403 (6 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

C405 (8 Pin, White) T/Gate. EXT. – T/GateBeside Left Rear Wiper Motor

G101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG302 Body Below Left C Pillar

G402 T/Gate. EXT Inside Driver C Pillar

• W/H FRONT

W/H TAIL GATE

W/H TRUNK (H/B)

• W/H BODY

5) LAMP (LICENSE PLATE & FRONT/REAR POSITION) CIRCUIT : STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

G101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse Block

13. FRONT & REAR FOG LAMP CIRCUIT1) NOTCH BACK

CONNECTOR POSITION

Engine Fuse Block

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

S201 (Black) I.P Behind ClusterS202 (Black) I.P Behind ClusterS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse Block

c. POSITION OF CONNECTORS AND GROUNDS• W/H TRUNK LID

d. SPLICE PACKS201

2) HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC403 (6 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

S201 (Black) I.P Behind ClusterS202 (Black) I.P Behind ClusterS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG402 T/Gate. EXT Inside Driver C Pillar

W/H TAIL GATE

d. SPLICE PACKS201

3) STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS201 (Black) I.P Behind ClusterS202 (Black) I.P Behind ClusterS204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse Block

d. SPLICE PACKS201

4. HAZARD & TURN SIGNAL LAMP CIRCUIT1) NOTCH BACK

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

S202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingS302 (Brown) Body Left Driver Leg RoomG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

G204 BodyBelow Left Driver Leg Room

d. SPLICE PACKS202

2) HATCH BACK

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

S202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingS302 (Brown) Body Left Driver Leg RoomG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS202

3) STATION WAGON

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingS302 (Brown) Body Left Driver Leg RoomG101 Front Behind Left Head LampG102 Front Behind Right Head LampG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS202

15. STOP LAMP, CENTER HIGH MOUNT STOP LAMP (CHMSL) & REVERSE LAMP CIRCUIT1) MR-140/HV-240 : NOTCH BACK

CONNECTOR POSITION

S203 (Red) I.P Behind Audio MountingS205 (Orange) TCM Upper Driver Leg RoomS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio BracketG302 Body Below Left C Pillar

. POSITION OF CONNECTORS AND GROUNDS

• W/H BODY

d. SPLICE PACKS203

2) MR-140/HV-240 : HATCH BACK

CONNECTOR POSITION

S203 (Red) I.P Behind Audio MountingS205 (Orange) TCM Upper Driver Leg RoomS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

• W/H TAIL GATE

d. SPLICE PACKS203

3) MR-140/HV-240 : STATION WAGON

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

S203 (Red) I.P Behind Audio MountingS205 (Orange) TCM Upper Driver Leg RoomS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

4) SIRIUS D4 : NOTCH BACK

CONNECTOR POSITION

S203 (Red) I.P Behind Audio MountingS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio BracketG302 Body Below Left C Pillar

• W/H BODY

d. SPLICE PACKS203

5) SIRIUS D4 : HATCH BACK

CONNECTOR POSITION

S203 (Red) I.P Behind Audio MountingS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio BracketG302 Body Below Left C Pillar

c. POSITION OF CONNECTORS AND GROUNDS• W/H TAIL GATE

d. SPLICE PACKS203

6) SIRIUS D4 : STATION WAGON

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomC403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

S203 (Red) I.P Behind Audio MountingS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

• W/H TCM

d. SPLICE PACKS203

16.TRUNK/TAIL GATE OPEN SWITCH, TRUNK LATCH SWITCH, TRUNK ROOM LAMP & HORN CIRCUIT1) DUAL HORN: NOTCH BACK

CONNECTOR POSITION

Engine Fuse Block

C112 (2 Pin, Black) Front – HornCenter Cross Member Panel

C202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A Pillar

G101 Front Behind Left Head LampG302 Body Below Left C Pillar

c. POSITION OF CONNECTORS AND GROUNDS• W/H TRUNK

• W/H FRONT

• W/H DRIVE DOOR

2) SINGLE HORN: NOTCH BACK

CONNECTOR POSITION

Engine Fuse Block

C202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A Pillar

G101 Front Behind Left Head LampG302 Body Below Left C Pillar

c. POSITION OF CONNECTORS AND GROUNDS• W/H TRUNK

W/H FRONT

• W/H DRIVE DOOR

3) DUAL HORN: HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C202 (89 Pin, White) I.P – Body Left Driver Leg Room

C204 (8 Pin, White)Roof – Body (W/O Rain Sensor)

C204 (14Pin, White)Roof – Body (W/ Rain Sensor)

C405 (8 Pin, White) T/Gate. EXT. – BodyBeside Left Rear Wiper Motor

S301 (Blue) Body Left Driver Leg RoomG101 Front Behind Left Head LampG402 T/Gate. EXT Inside Driver C Pillar

W/H DRIVE DOOR

d. SPLICE PACKS301

4) SINGLE HORN: HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C405 (8 Pin, White) T/Gate. EXT. – BodyBeside left Rear Wiper Motor

S301 (Blue) Body Left Driver Leg RoomG101 Front Behind Left Head LampG402 T/Gate. EXT Inside Driver C Pillar

W/H DRIVE DOOR

d. SPLICE PACKS301

5) DUAL HORN: STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

C403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

S301 (Blue) Body Left Driver Leg RoomG101 Front Behind Left Head Lamp

• W/H FRONT

W/H DRIVE DOOR

d. SPLICE PACKS301

6) SINGLE HORN: STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

S301 (Blue) Body Left Driver Leg RoomG101 Front Behind Left Head Lamp

• W/H FRONT

W/H DRIVE DOOR

d. SPLICE PACKS301

17. LAMP (MAP & ROOM) CIRCUIT1) W/O SUN ROOF & W/ DECAY

CONNECTOR POSITION

C204 (14 Pin, White)Roof – Body (W/ Rain Sensor)

C404 (8 Pin, White) T/Gate. EXT. - Body Inside Left C PillarC405 (8 Pin, White) T/Gate. EXT. - Body Inside Left C Pillar

C406 (6 Pin, White) T/Gate. EXT. - T/GateBeside Left Rear Wiper Motor

S301 (Blue) Body Left Driver Leg RoomG205 Roof Inside Driver A Pillar

c. POSITION OF CONNECTORS AND GROUNDS• W/H ROOF

d. SPLICE PACKS301 (NOTCH BACK)

S301 (HATCH BACK)

S301 (STATION WAGON)

2) W/ SUN ROOF & W/ DECAY

CONNECTOR POSITION

d. SPLICE PACK

S301 (NOTCH BACK)

S301 (HATCH BACK)

3) W/O SUN ROOF & W/O DECAY

CONNECTOR POSITION

S301 (HATCH BACK)

4) W/ SUN ROOF & W/O DECAY

CONNECTOR POSITION

S301 (HATCH BACK)

18. CLOCK, CIGAR LIGHTER, ASHTRAY ILLUM. LAMP, GLOVE BOX LAMP & EXTRA POWER JACK CIRCUIT

1) M/T: NOTCH BACK, HATCH BACK

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

2) M/T: STATION WAGON

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

3) A/T: NOTCH BACK, HATCH BACK

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC302 (6 Pin, White) I.P – Console Below Console BoxS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

4) A/T: STATION WAGON

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC302 (6 Pin, White) I.P – Console Below Console BoxS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

19. CHIME BELL, SEAT BELT & KEY REMIND SWITCH CIRCUIT

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

S203 (Red) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

20. WIPER CIRCUIT1) W/O RAIN SENSOR & AIR CONDITIONER : NOTCH BACK

CONNECTOR POSITION

C113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomG101 Front Behind Left Head Lamp

W/H BODY

2) W/O RAIN SENSOR & AIR CONDITIONER : HATCH BACK

CONNECTOR POSITION

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

• W/H TAIL GATE

• W/H BODY

3) W/O RAIN SENSOR & AIR CONDITIONER : STATION WAGON

CONNECTOR POSITION

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

• W/H BODY

4) W/ RAIN SENSOR & AIR CONDITIONER : NOTCH BACK

CONNECTOR POSITION

C113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

G101 Front Behind Left Head Lamp

G205 Roof Inside Driver A Pillar

• W/H BODY

5) W/ RAIN SENSOR & AIR CONDITIONER : HATCH BACK

CONNECTOR POSITION

G205 Roof Inside Driver A PillarG402 T/Gate. EXT Inside Driver C Pillar

• W/H TAIL GATE

• W/H BODY

6) W/ RAIN SENSOR & AIR CONDITIONER : STATION WAGON

CONNECTOR POSITION

• W/H BODY

7) W/O RAIN SENSOR & FATC : NOTCH BACK

CONNECTOR POSITION

C113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

S204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head Lamp

d. SPLICE PACKS204

8) W/O RAIN SENSOR & FATC : HATCH BACK

CONNECTOR POSITION

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

S204 (Magenta) I.P Behind Audio Mounting

• W/H TAIL GATE

d. SPLICE PACKS204

9) W/O RAIN SENSOR & FATC : STATION WAGON

CONNECTOR POSITION

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

d. SPLICE PACKS204

10) W/ RAIN SENSOR & FATC : NOTCH BACK

CONNECTOR POSITION

C113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

C208 (15 Pin, White) I.P – FATC Behind Glove Box

S204 (Magenta) I.P Behind Audio MountingG101 Front Behind Left Head Lamp

d. SPLICE PACK

11) W/ RAIN SENSOR & FATC : HATCH BACK

CONNECTOR POSITION

G205 Roof Inside Driver A PillarG402 T/Gate. EXT Inside Driver C Pillar

• W/H TAIL GATE

d. SPLICE PACKS204

12) W/ RAIN SENSOR & FATC : STATION WAGON

CONNECTOR POSITION

d. SPLICE PACKS204

21. REAR WINDOW DEFROSTER & OSRV MIRROR HEATING SYSTEM CIRCUIT1) NOTCH BACK, HATCH BACK

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

C351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarS302 (Brown) Body Left Driver Leg Room

• W/H DRIVE DOOR

S302 (HATCH BACK)

2) STATION WAGON

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC208 (15 Pin, White) I.P – FATC Behind Glove Box

C351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

S302 (Brown) Body Left Driver Leg Room

W/H DRIVE DOOR

d. SPLICE PACKS302 (STATION WAGON)

22. ELECTRIC OSRV (OUTSIDE REAR VIEW) MIRROR CIRCUIT

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarS302 (Brown) Body Left Driver Leg Room

• W/H DRIVE DOOR

S302 (HATCH BACK)

23. FOLDING MIRROR UNIT CIRCUIT

CONNECTOR POSITION

C351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A Pillar

W/H DRIVE DOOR

24. POWER WINDOW CIRCUIT1) ONLY FRONT POWER WINDOW CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C107 (2 Pin, White) ABS – Engine Fuse Block Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarG101 Front Behind Left Head Lamp

W/H DRIVE DOOR

2) FRONT & REAR POWER WINDOW CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC371 (12 Pin, White) Body – Rear Light Door Under Left B PillarC381 (12 Pin, White) Body – Rear Right Door Under Right B PillarS301 (Blue) Body Left Driver Leg RoomG101 Front Behind Left Head Lamp

c. POSITION OF CONNECTORS AND GROUNDS• W/H DRIVE DOOR

W/H REAR DOOR

S301 (HATCH BACK)

25. CENTRAL DOOR LOCKING SYSTEM CIRCUIT

1) NOTCH BACK

CONNECTOR POSITION

C102 (11 Pin, White) Body - Engine Fuse Block Engine Fuse BlockC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC371 (12 Pin, White) Body – Rear Light Door Under Left B PillarC381 (12 Pin, White) Body – Rear Right Door Under Right B PillarS302 (Brown) Body Left Driver Leg Room

• W/H DRIVE DOOR

• W/H REAR DOOR

d. SPLICE PACKS302

2) HATCH BACK

CONNECTOR POSITION

C102 (11 Pin, White) Body - Engine Fuse Block Engine Fuse BlockC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC371 (12 Pin, White) Body – Rear Light Door Under Left B PillarC381 (12 Pin, White) Body – Rear Right Door Under Right B PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

• W/H DRIVE DOOR

• W/H REAR DOOR

d. SPLICE PACKS302

3) STATION WAGON

CONNECTOR POSITION

C102 (11 Pin, White) Body - Engine Fuse Block Engine Fuse BlockC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC371 (12 Pin, White) Body – Rear Light Door Under Left B PillarC381 (12 Pin, White) Body – Rear Right Door Under Right B PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

• W/H DRIVE DOOR

W/H REAR DOOR

d. SPLICE PACKS302

26. CLUSTER

1) TEMPERATURE GAUGE, TACHOMETER, FUEL GAUGE, ODDOMETER, SPEEDOMETER & FUEL WARNING LAMP CIRCUIT: MR-140/HV-240

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS202 (Black) I.P Behind ClusterG201 I.P Left I.P Fuse BlockG302 Body Below Left C Pillar

d. SPLICE PACKS202

2) TEMPERATURE GAUGE, TACHOMETER, FUEL GAUGE, ODDOMETER, SPEEDOMETER & FUEL WARNING LAMP CIRCUIT: SIRIUS D4

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS202 (Black) I.P Behind ClusterG201 I.P Left I.P Fuse BlockG302 Body Below Left C Pillar

d. SPLICE PACKS202

3) WARNING (MIL, ABS, TCS, PARKING BRAKE & CHARGING) LAMP CIRCUIT

CONNECTOR POSITION

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS301 (Blue) Body Left Driver Leg Room

W/H ABS

S301 (HATCH BACK)

4) WARNING (SSPS, AIR BAG, OIL PRESSURE & SEAT BELT) LAMP & HOLD MODE LAMP CIRCUIT

CONNECTOR POSITION

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg Room

W/H BODY

5) INDICATOR (FRONT & REAR FOG) LAMP & DOOR OPENING WARNING LAMP CIRCUIT

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

S202 (Black) I.P Behind ClusterS301 (Blue) Body Left Driver Leg RoomG201 I.P Left I.P Fuse BlockG302 Body Below Left C Pillar

• W/H BODY

d. SPLICE PACKS202

S301 (NOTCH BACK)

S301 (HATCH BACK)

6) INDICATOR (TURN SIGNAL, HIGH BEAM & HAZARD) LAMP & ILLUMINTION LAMP CIRCUIT

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG201 I.P Left I.P Fuse BlockG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS202

27. AUDIO CIRCUIT1) NOTCH BACK

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC371 (12 Pin, White) Body – Rear Light Door Under Left B PillarC381 (12 Pin, White) Body – Rear Right Door Under Right B PillarS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

2) HATCH BACK, STATION WAGON

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

C204 (14 Pin, White)Roof - Body (W/ Rain Sensor)

C351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC371 (12 Pin, White) Body – Rear Light Door Under Left B PillarC381 (12 Pin, White) Body – Rear Right Door Under Right B PillarS203 (Red) I.P Behind Audio MountingS204 (Magenta) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

W/H DRIVE DORR

d. SPLICE PACKS203

28. ABS (ANTILOCK BRAKE SYSTEM)

1) POWER SUPPLY, WHEEL SPEED SENSOR & BRAKE SWITCH CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC107 (2 Pin, White) ABS – Engine Fuse Block Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC111 (2 Pin, Black) ABS – Front Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

C901 (4 Pin, Black) RR. ABS – BodyCenter Rear Cross member

S301 (Blue) Body Left Driver Leg RoomG106 ABS Below EBCM

c. POSITION OF CONNECTORS AND GROUNDS• W/H ABS

• W/H REAR ABS

S301 (HATCH BACK)

2) OIL FEEDING CONNECTOR, WARNING (ABS, TCS & BRAKE) LAMP & DLC CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C107 (2 Pin, White) ABS – Engine Fuse Block Engine Fuse BlockC110 (12 Pin, White) ABS – Body Below Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS301 (Blue) Body Left Driver Leg RoomG106 ABS Below EBCM

• W/H ABS

S301 (HATCH BACK)

29. AIR BAG (SDM: SENSING & DIAGNOSTIC MODULE) CIRCUIT

CONNECTOR POSITION

C301 (8 Pin, White) Air Bag – Body Front SDMG202 Air Bag Behind Left Audio Bracket

• W/H AIR BAG

30. SUN ROOF CIRCUIT

CONNECTOR POSITION

• W/H ROOF

31. SSPS (SPEED SENSITIVE POWER STEERING) CIRCUIT

CONNECTOR POSITION

Engine Fuse Block

C108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC206 (22 Pin, White) I.P – TCM Upper Driver Leg RoomS202 (Black) I.P Behind ClusterS203 (Red) I.P Behind Audio MountingG104 Engine Under Start MotorG203 I.P Behind Left Audio Bracket

d. SPLICE PACK

32. IMMOBILIZER SYSTEM CIRCUIT

CONNECTOR POSITION

C102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC108 (24 Pin, Black) Body – Engine Left Engine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarS203 (Red) I.P Behind Audio MountingG203 I.P Behind Left Audio Bracket

d. SPLICE PACKS203

33. ANTI THEFT CONTROL SYSTEM CIRCUIT1) NOTCH BACK

CONNECTOR POSITION

Engine Fuse Block

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A Pillar

S202 (Black) I.P Behind ClusterS301 (Blue) Body Left Driver Leg RoomS302 (Brown) Body Left Driver Leg Room

c. POSITION OF CONNECTORS AND GROUNDS• W/H BODY

d. SPLICE PACKS202

2) HATCH BACK

CONNECTOR POSITION

Engine Fuse Block

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomC351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

c. POSITION OF CONNECTORS AND GROUNDS• W/H BODY

d. SPLICE PACKS202

3) STATION WAGON

CONNECTOR POSITION

Engine Fuse Block

C105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC113 (16 Pin, Black) Body – Front Behind ECM BracketC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg Room

C351 (33 Pin, Gray) Body – Front Light Door Under Driver A PillarC361 (33 Pin, Gray) Body – Front Right Door Under Co-Driver A PillarC403 (4 Pin, White) T/Gate. EXT. – Body Inside Left C PillarC404 (8 Pin, White) T/Gate. EXT. – Body Inside Left C Pillar

d. SPLICE PACKS202

34. BATTERY SAVER CIRCUIT

CONNECTOR POSITION

C101 (21 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC102 (11 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC105 (4 Pin, White) Body – Engine Fuse BlockEngine Fuse BlockC201 (76 Pin, Black) I.P – I.P Fuse Block I.P Fuse BlockC202 (89 Pin, White) I.P – Body Left Driver Leg RoomS203 (Red) I.P Behind Audio MountingG201 I.P Left I/P Fuse BlockG203 I.P Behind Left Audio Bracket

• W/H BODY

d. SPLICE PACKS203

Optra Manual de Electricidad

Documents