Post on 07-Sep-2018
transcript
March 2009 ISA Newsletters, Southern District 11 1
March 2009
www.isa.org/~oranc
Editor’s Note: The Marchmeeting notice was sent to allOrange County Section membersearlier in a separate mailing.
Romel Bhullar, TechnicalDirector and Technical Fellow atFluor, gave a presentation on themyriad of choices, technologies,
standards and practices facing controlprofessionals today for design and systemintegration of their projects involving automationnetworks. Poor choices or selection can make a
Technical Education
Upcoming Regional Events
So. San Joaquin ValleyGolf, Tabletop & FeastThurs-Fri May 14-15For more information, callBob Jackson (661) 331-4719
ISALA Golf EventFriday, June 5For more information, callKandace Peterson (323) 274-5353
INSIDE THIS ISSUE…
ISASD Tabletop ShowSummer 2009For more information, seewww.icexpo09.com
“In winter I get up at night and dress by yellow candlelight. In summer quite the other way, I have to go to bed by day.”
— Robert Louis Stevenson on Daylight Savings Time
2 - President’s Message 3 - SSJV Golf Tournament
Tabletop, Cajun Feast 4 - ISA International
Student GamesBiomass Project
6 - Instrumentation2009 7 - ISA Training 8 - Local Section Meetings 9 - Regional Events 12 - Valve Facility Tour
Bakersfield College
14 - Job Shop
Process control & automation network selectiondifference between the success and failure ofa project and can be very expensive to getback on the right track, if one makesmistakes.
This “un-biased” presentation clarifiedsome issues, concerns and basic criteria tohelp select the “best” network solution foryour industrial controls applications.
Emerging trends, technologies, andsecurity issues were also discussed. Romelcan be reached at romel.bhullar@fluor.com.
The Orange County Sanitation District hastwo operating facilities that treat wastewaterfrom residential, commercial and industrialsources in central and northwest Orange County,California. Service area is471 square miles, 21cities, 3 special districts,2.5 million residents andhas 581 miles of sewerlines and 16 off-sitepumping stations. OCSDhas 644 full time autho-rized staff.
OCSD releasestreated water into theocean through a 120-inchdiameter offshore pipelinethat extends five milesfrom shore to the dis-charge point approximately 200 feet below theocean surface. An emergency standby 78-inchdiameter pipeline stretches one mile from shore.The one-mile-long diffuser section of our five-mile ocean pipeline contains 503 portholesthrough which treated wastewater is slowlyreleased. An abundance of marine life has takenup residence along both pipelines.
ISA Orange County March Presentation
ISA Orange County April Section Meeting
Orange County Sanitation DistrictProgram and Tour
OCSD also reclaims up to 10 milliongallons of treated wastewater every day, whichis sent for further processing to the OrangeCounty Water District and then used for
landscape irrigationand for injection intothe groundwaterseawater intrusionbarrier. Biosolidsproduced by thewastewater treatmentprocess are recycled asa soil amendment onfarm land or furtherprocessed as a earth-like product forcommercial and homegardens to improve andmaintain fertile soil
and stimulate plant growth. OCSD generates adaily average of 14,000 kilowatts of energyfrom burning natural gas and methane gas(biogas), which is a byproduct of the wastewa-ter treatment process.
To ensure that the marine environmentand public health are protected, the OrangeCounty Sanitation District has maintained an
OCSD photo courtesy of APG Analyzer Systems.
The monthly ISA Section Newsletters and annual Regional Membership Directory and Buyers’ Guide are mailed to all ISA section members in Southern California and SouthernNevada and to ISA student affiliates at Cal Poly Pomona, Long Beach State University and Bakersfield College. Newsletters include the Southern San Joaquin Valley Alarm, LosAngeles Annunciator, Orange County Chart, San Diego Signal and Las Vegas Experience. Changes of address can only be processed by ISA by at (919) 549-8411 or www.isa.org.For editorial submissions and feedback, please contact the newsletter editor. Advertising rates, circulation information and style guide is posted at www.TechPubs.net. Billing andpublishing correspondence may be addressed to TechPubs Communications, PO Box 1605, Costa Mesa, California 92628. Submissions are copyright by the authors with all rightsreserved. Copyright (C) 2008 TechPubs Communications. All Rights Reserved.
Orange County SectionOfficers 2008-2009www.isa.org/~oranc/
President — Sebastian ZielonkaFluor Enterprises, (949) 349-8773sebatian.zielonka@fluor.com
Past President — Craig LanternierFluor Enterprises, (949) 349-4371craig.lanternier@fluor.com
President Elect — Alan Szarowiczjacobs Engineering, (714)503-3706AlanSzarowicz@jacobs.com
Secretary — Gautam ParikhFluor Enterprises, (949) 349-2709Gautam.Parikh@fluor.com
Treasurer — Jesus MoncayoSouth Coast Systems, Inc. (714) 834-0232Jesus.Moncayo@southcoastsystems.com
Delegate — Christine DorganDisneyland Scientific Systems(714) 781-1699christine.dorgan@disney.com
Alternate Delegate — Romel BhullarFluor Enterprises, (949) 349-6762Romel.Bhullar@fluor.com
Arrangements Chair — Bis MitraFluor Enterprises, (949) 349-3270biswajit.mitra@fluor.com
Historian — John QueridoJontec Systems, (949) 581-7072jontec@msn.com
Past President,Honors & Awards ChairCraig LanternierFluor Enterprises, (949) 349-4371Craig.Lanternier@fluor.com
Publicity Chair— Sergei SeleznevCaltrol, (702) 966-1901Sergei_Seleznev@caltrol.com
Membership Chair — Don Zee,Don Zee Associates (949) 499-0917don@donzeeassociates.com
Newsletter Editor — John PrinceAPG Analyzer Systems (714) 968-5501jprince@CalCEMS.com
Nominations Chair — Raj AdaniEmerson Process Mgmt (800) 999-9307raj.adani@emersonprocess.com
Program Chair — Rafael AgrazsanchezFluor Enterprises, (949) 349-2304RafaelAgrazsanchez@fluor.com
Program Co-Chair — Hiten DalalNewtech Resources, (714) 500-1018hitend@ntrcal.com
OCC Liaison — Robert CastañoOrange Coast College, (714) 432-5745R.Castano@ieee.org
CSULB Advisor — Walter Martinez(562) 577-3605 wmartinz@csulb.edu
Cal State Long Beach StudentSection Co-Presidents —Justin Lanza, Andrew Moseley
Webmaster — Bob HarrisonConex Systems (714) 968-1369robert_w_harrison@member.isa.org
President’s messageBy Sebastian Zielonka, Section President○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○ ○
Income Actual BudgetArrangements $2,250.00 $6,000.00Dues/Membership Rebate $2,226.60 $6,749.00Education $0.00 $750.00Interest Income $252.16 $1,000.00X-MAS Party 2008 $2,880.00 $1,500.00Student Section $0.00 $1,500.00Society Income $0.00 $0.00*Income from Reserve Funds $2,000.00 $5,401.00
Total Income $9,608.76 $22,900.00
Expenses Actual BudgetArrangements $1,635.09 $4,000.00Membership/Mkg $598.71 $1,200.00Programs $0.00 $400.00Education $0.00 $750.00Insurance $550.00 $900.00Honors Awards $0.00 $200.00Student Competition $0.00 $500.00President $0.00 $400.00President's Meeting $2,043.79 $2,000.00Society Delegate $2,128.26 $2,000.00President Elect $110.42 $1,500.00X-MAS Party $3,480.00 $1,500.00DLC $0.00 $2,500.00Planning Meeting $1,680.02 $1,500.00Student Section $1,500.00 $2,500.00CLCPE $0.00 $900.00Treasurer $41.84 $150.00
Total Expenses $13,768.13 $22,900.00TOTAL ($4,159.37) $0.00
Reserve Funds * as of 12/10/08. $45,713.64
Treasurer's ReportOrange County Section
Budget FY 2008/2009 (July '08 June '09)November, 2008
We are extremely fortunate to have such an active neighboring LA ISA section.For those of you who attended Instrumentation 2009 you understand what I mean.An impressive event filled with many exhibits, training classes, networking andfood (and this was all FREE) was seamlessly organized by John Prince and the LAstaff. I was thoroughly impressed with the turnout and saw many familiar faces. Ilook forward to seeing this event continue to grow from year to year.
Our March presentation was be by our very own board member RomelBhullar. You may have also seen him during one of his two training classes(Process Control for Dummies or Safety Instrumented Level Training) atInstrumentation 2009. His presentation earlier this month was on IndustrialEthernet, an integral part of control systems these days. Romel is very well versed
and holsters over 38 years of invaluable experience. It was good to see you all who made the trip out forthe snacks, socializing, and this interesting topic.
Finally, I would like to bring to your attention next months tour of the Orange County SanitationDistrict. This should be a very informative tour of the third largest wastewater agency west of theMississippi River. I strongly encourage you to bring family members and friends interested in seeingwhere we safely collect, treat, and dispose of wastewater generated by 2.5 million people living incentral and northwestern Orange County. Sebastian Zielonka, President
ISA Orange County Section
District VP — Brad RupertCaltrol (925) 226-0216Bradley_Rupert@Caltrol.com
District VP ElectGary Campbell, CCST IIIM+W Zander (480) 319-1479gcampbellisa@cox.net
April Meeting at OCSD, continued from front page
extensive ocean monitoring program for over 25 years. The award-winning ocean monitoring programmonitors and evaluates water quality, sediment quality and sea life from Seal Beach to Corona Del Mar.
Meeting DetailsMeet in the OCSD Control Room Wednesday, April 8, 2009, at 5:30 for the program with tour to follow.The address is 10844 Ellis Avenue, Fountain Valley. Park at the Administration Building and walk to theControl Center across the street. RSVP to RafaelAgrazsanchez at Rafael.Agrazsanchez@Fluor.com or 949-349-2304. Mapquest: http://tinyurl.com/ISAOC-OCSD
March 2009 ISA Newsletters, Southern District 11 3
AES · Analyzer Improvement Resources · BHP Petroleum · Camp Dresser
McKee · Cenco Oil · ConocoPhillips · Coors Brewing Co · Edison
International · ExxonMobil Oil Corp · Flex Products USA · Flex Products
China · Fluid Data Japan · Frontier Refining Co · H-Ion · Industrial Systems
K&T Electric · KTI Los Angeles World Airports · MAS · Mitsubishi · Mobil
Oil · Optical Coating Laboratories · Paramount Petroleum · Powerine Oil
Shannon Filtration · Sinclair Oil Co · Solar Turbines · Southern California
Edison · Syntech Automation · Technip USA · Tesoro Refining · Tosco
Chemical Co · Tosco Corp · Toyota · University of California · University of
Colorado · Unocal Products Co · US Postal Service LAX · Viking
International Services · Worldwide Medical Corp.
Analyzer Products GroupPO Box 8241
Huntington Beach, CA 92615
(714) 968-5501 - Fax 964-8982
www.CalCEMS.com
As APG begins our tenth year in business providing
continuous process analytical & CalCEMS emissions
monitoring systems, field service & consulting, and
on-site system upgrading, we would like to thank all of
our dependable suppliers, our dedicated support staff,
and our tireless subcontractors for contributing to our
success and for your continuing support and friendship.
And most of all, a sincere thank you to our loyal
customers, some of whom are listed below...
APG Analyzer Systems
& Stack Monitoring SystemsThird Party Service & UpgradingOnSite Evaluation & Training
Continuous Analytical Process
Pls update toPls update toPls update toPls update toPls update to15th year.15th year.15th year.15th year.15th year.
No otherNo otherNo otherNo otherNo otherchanges.changes.changes.changes.changes.
Thanks Thanks Thanks Thanks Thanks
ISA So San Joaquin Valley Section
Golf Tournament, Tabletop, Technical Training andCajun Feast Scholarship Fundraiser May 14-15
The annual Golf Tournament, Tabletop, Technical Training and Cajun FeastScholarship Fundraiser will be held Thursday and Friday, May 14-15, 2009.Registration form can be downloaded at www.isa.org/~ssjv.
The golf tournament will be held Thursday, May 14, 2009, at Rio BravoCountry Club with a 1:00 pm shotgun start. This event was sold out last year, sobe sure and sign up early.
The Tabletop Show, Technical Training and Cajun Feast will be held Friday,May 15, 2009, with exhibits open 10:00am to 3:00pm. This year there will be freeCajun food starting at 11:30. Golf awards and raffle prizes will be awarded Fridayafternoon. The Grand Raffle prize is a $400 value Rio Bravo Country Club greenfee for a foursome.
To sign up for the golf tournament, go to www.isa.org/~ssjv and download theregistration form. For more information or to sign up, please contact Bob Jacksonat jacksonb@chevron.com or (661) 331-4719.
I / C E x p o 0 9w w w . I C E x p o 0 9 . c o m
“San Diego’s Only Process Instrumentation and Controls Exhibition”Coming this Summer
4 ISA Newsletters, Southern District 11 March 2009
Represented by
Bakersfield . Mill Valley . Newport BeachContact us: 1-888-ASK-SAGE www.SageDesignsInc.com
CONTROLMICROSYSTEMSSCADA products... for the distance
ElectronicGas Flow ComputersMade to Measure
w w w . c o n t r o l m i c r o s y s t e m s . c o m
The 2009 International Student Games are scheduled for 6October 2009 at the Reliant Center in Houston, Texas.
Teams are composed of 4 undergraduate students. Teams mustattend an equipment orientation on Monday, October 5, 2009, and willalso attend the ISA Honors and Awards Banquet that evening. The2009 International Games will take place on Tuesday, October 6, 2009,at EXPO 2009 in the Reliant Center, Houston, Texas.
“Each District must determine who will be their representative atthe International Student Games. That nomination/commitment mustbe submitted to ISA by May 15, 2009,” writes Dianna Noyes of ISA.“The Commitment form will be sent to the District Vice Presidents byApril 3, 2009. It is up to each District to determine the deadline forinterest, application, or results of any competition that will be held todetermine which team will represent the District. I would suggest thatyou check with your District Vice President for the deadline and/orcriteria in your District.”
Each team will receive $1,000 and each team member will receivea certificate from ISA. The three top teams will receive Gold, Silver,and Bronze medals. Each team member of the Gold medal team willalso receive a $100 ISA publication coupon. Immediately after theGames, students will attend YAPFest, already in progress, to networkand interact with other “Young Automation Professionals.”
Your school’s team must be selected by the ISA District in whichyou are located in order to participate in this prestigious event. Only
International StudentGames registration
one team is selected to represent the District, so don’t delay incontacting your District Vice President to find out how your studentsmay be eligible to participate.
To obtain the manual and more information, follow this path:www.isa.org - Left navigation bar: Membership>Students>StudentGames. For more information contact Dianna Noyes at (919) 990-9234or Dnoyes@isa.org.
Biomass: pilot plant tocommercial scale
ISA Student Section News ISA Orange County Section
BlueFire Ethanol, Inc., has been awarded funding from the U.S.Department of Energy to construct a commercial scale cellulosic ethanolproduction facility. Its biorefineries will be located in markets with thehighest demand for renewable transportation fuels thereby dramaticallyreducing delivery costs while simultaneously increasing the areasbiofuel supply and reducing the waste streams sent to landfills.
A presentation made to the OC Section last month included adescription of the Bluefire/Arkenol Acid Hydrolysis process for theconversion of biomass materials to fermentable sugars and higher valuechemicals. The conversion technologies of thermochemical, enzymaticand chemical hydrolysis conversion technologies was described anddiscussed, along with pilot plant unit operations and commercial scale-up, typical commercial plant layout and requirements and a comparisonof the economics of current to future cellulosic ethanol production.
Continued on next page
March 2009 ISA Newsletters, Southern District 11 5
Need sulfur inert or passivated steel
sample system components?
We can provide Silcosteel® or
Sulfinert® pressure regulators and
other analyzer sample system components. Call us for more information.
Distributors of Pressure and Flow Controls:
Pressure regulators, pressure indicators, flowmeters, filters, separators, thermometers, and enclosures
13413 Benson Ave., Chino CA 91710
TEL: (909) 590-0408 FAX: (909)590-4146 www.precinstr.com
John E. Cuzens, Bluefire Ethanol Chief Technology Officer and Senior Vice President, is co-inventor on nine of Arkenol’s ten U.S. founda-tion patents for the conversion of cellulosic materials into fermentable sugar products and chemicals using a concentrated acid hydrolysis process.He has more than thirty years of project and executive management experience in process, engineering, energy, technology and fabricationindustries. Mr. Cuzens has a B.S. Chemical Engineering degree from the University of California at Berkeley. He is also a State of California,Registered Professional Mechanical Engineer and Responsible Managing Employee for ARK Energy’s State of California, Contractor’s “A”License. Chuck Diamond, Bluefire Ethanol Senior Controls Supervisor, has more than 40 years of process controls experience in industrial,process, and power industries. He has supervised engineering, construction, and operations projects and managed several control system retrofitengineering and design projects. Chuck has presented a successful Sliding Pressure Controls upgrade project to the Los Angeles chapter of ASMEPower Division. He presented a successful life cycle improvement project for severe service control valves to the Valve Manufacturers Associa-tion. Chuck has a B.S. in Applied Physics from West Coast University and a Registered Professional Control Systems Engineer in California.
Bluefire Ethanol, Inc., is ranked number 13 in the 2008-2009 Fifty Hottest Companies in Bioenergy List by Biofuels Digest, and is located at31 Musick, Irvine, CA 92618, at (949) 588-3767. For more information, see the company website at www.bluefireethanol.com.
Continued from page 4 Photos courtesy of John Querido
6 ISA Newsletters, Southern District 11 March 2009
Tunable Diode Laser Analyzers:Low-maintenance and results in seconds!
SS2100 TDL Analyzers measure H2O, H2S, CO2, HCl and more at ppm and ppb levels.
SpectraSensors process analyzers utilize proven spectroscopy techniques with a new advancement in light source design: drift-free laser diodes ensure robustness and maintenance-free use for many years.
www.spectrasensors.com 800.619.2861sales@spectrasensors.com
©2008 SpectraSensors
INSTRUMENTATION 2009 huge success!Thurs, Feb. 19, 2009 at the Carson Center Instrumentation 2009, the largest technicaltraining and exhibition of process instrumenta-tion and control technologies on the west coast,was held this year during Engineers Week, onThursday, February 19 at the Carson Center inCarson, California. Some photos are on page 10. More photosand videos, along with a final list of exhibitorsare posted at the event website,www.instrumentation2009.com.
This year’s show had over 500 registeredattendees and 75 exhibits with state-of-the-artI&C products & services and a 25 well-attendeed technical training sessions. TheCareer Fair was an addition this year, alongwith CCST and CAP training sessions.
Industry Exhibition, Technical Training, Career Fair
Exhibitors and sponsors interested inparticipating in next year’s event should signup early for the info list. For more informationor to give feedback about this year’s event,please contact John Prince at (714) 968-5501 orjprince@calcems.com.
I / C E x p o 0 9www.ICExpo09.com
”San Diego’s Only Process Instrumentation and Controls Exhibition”Coming this Summer
March 2009 ISA Newsletters, Southern District 11 7
14978 Sand Canyon Ave., Suite C
Irvine, CA 92618
Office: 949-559-1941
Fax: 949-653-2420
www.goldenstatecontrols.com
Instrumentation and
Control Systems for
Southern California,
Nevada and Hawaii
Golden State Controls and Invensys FoxboroWe are the authorized Representative for the Foxboro Systems
group. We now support the full range of Foxboro control systems
including IA and A Squared. Please call us for information, support
and service.
Control Systems
Golden State Controls is affiliated with Western States Controls’
Professional Services Group that provides engineering and technical
solutions to process control systems and instrumentation.
Instrumentation
Rotameters
Sub-Distributor for
G M Cooke, Inc.
Distributor
_______________________________
Control Valves
ISA training continues in BurbankThe following ISA training courses are scheduled to be held at Pickwick Gardens Conference Center, 1001 W. Riverside Drive, Burbank. To
register for any course or for more information contact ISA by telephone at (919) 549-8411. Advance registration is typically required 2-4 weeksprior to the course date. Before you make travel plans, be sure to ask ISA to explain their policy of canceling courses if sufficient number ofstudents do not register in advance.
Training and Career
04/21/2009 Safety Instrumented Systems05/11/2009 Advanced SIL Determination (EC52)05/14/2009 Understanding and Tuning Control Loops (TC05)06/01/2009 Troubleshooting Instrumentation and Control Systems06/04/2009 Installing, Calib & Maintaining Instruments (TI25)06/08/2009 Understanding and Tuning Control Loops (TC05)07/06/2009 Troubleshooting Instrumentation and Control Systems07/09/2009 Industrial Data Communications (TS05)08/10/2009 Industrial Data Communications, Part II (TS10)
GOLF TOURNAMENT -- TABLETOP SHOWTRAINING -- CAJUN FEAST -- AWARDS
SCHOLARSHIP FUNDRAISER Thurs-Fri, May 14-15, 2009. Info: Bob Jackson at (661) 331-4719
ISA Southern San Joaquin Valley Section
08/13/2009 Control Systems Engineering (CSE) PE Exam Review09/01/2009 Advanced SIS Hardware Design & Analysis (EC54)09/09/2009 Installing, Calibrating and Maintaining Instruments (TI25)09/14/2009 Advanced Operation of Smart Field Devices (TS15)10/01/2009 Understanding Electrical Systems (TI15)11/02/2009 Industrial Electronics (TI20)11/05/2009 Introduction to Building Automation Systems (EA15)11/10/2009 Grounding and Noise Considerations
8 ISA Newsletters, Southern District 11 March 2009
Local section meetingsFor more details about any of the section meetings, please contact the section president, website or read each section’s completenewsletter online at www.techpubs.net/isanews.
PROCESS MEASUREMENT & CONTROL SOLUTIONS
Process Level Measurement
Industrial Flowmeters
Gas & Liquid Analyzers
Pipeline Strainers & Bag Filters Gas/Liquid Separators
TeledyneAnalytical Instruments
Gas Mass Flowmeters
Ultrasonic Flowmeters
Gas & Flame Detection
BAKERSFIELD BRANCHTel 661.391.1000 ✦ Fax 661.391.0990
ANAHEIM HILLS CORPORATETel 714.282.5600 ✦ Fax 714.282.7874
info@jprsi.com ✦ www.jprsi.com
Tank Gauging & Systems
V-Cone & Process Flowmeters
Measurement & Instruments
Invensys
Instrumentation Products
Heat Tracing Products & Services
Thermal Controls
Coriolis Mass Flowmeters
Flow/Level/Temp Switches
714. 674. 714. 674.
day
bsite
ke
3,it
site
ay
ofeld.tailsbsite:
ite
on
sen
on.
ion
Celebrating 25 years in Southern California
Trimax Systems, Inc.
565 Explorer St., Brea, CA 92821
Phone: 714.255.8590 Fax: 714.255.1922
www.trimaxsystems.com
Full-Service Systems Integration
Custom UL Control Panel Shop (UL-508, 698a/b)
PLC, DCS, HMI, SCADA, Motor Control
Field Services and Maintenance
Control and Power Distribution Design
Process Instrumentation Specialists
and Electrical Engineering
Orange County Section Wed, Apr 8 Sebastian Zielonka, (949) 349-8773 sebatian.zielonka@fluor.com
Orange County Sanitation District Plant Tour. Technical program tobegin at 5:30 with pizza, followed by a plant tour at 6:00. OCSD islocated in Fountain Valley off the 405 at Euclid. RSVP to RafaelAgrazsanchez at Rafael.Agrazsanchez@Fluor.com or (949) 349-2304.Website: www.isa.org/~oranc.
Las Vegas Section Thurs, Apr 16 Jeff Blue, (702) 249-1156 or Jeff.Blue@lvvwd.com
ISA Cyber U Web-Based Training. Tom Stephenson has been withISA Cyber U for some time and will explain ISA web training on ISACyber U — how to get there, what is available, costs etc. To be held at6:30pm at the Grand Cafe inside the Palace Station Hotel. RSVP to JeffBlue at 702 249-1156 or Jeff.Blue@lvvwd.com. Website: www.isalv.org.
Los Angeles Section Tues, Apr 21 Neil Finch, (951) 675-3395, nfinch@yahoo.com
Matheson Tri-Gas Plant Tour. A technical overview about industrialair separation and control will be followed by a plant tour of this largeindustrial air separation plant in Vernon. 3:30 refreshments, 4:00program and tour. RSVP to Bill Campbell at willcampbell@ca.rr.com or(562) 533-0188. Cost: $25 to non-members; free to ISA members andthose who join at the meeting. Meetings are held on the 3rd Tuesday ofeach month. Website: www.isala.org.
San Diego Section Thurs, Apr 23 Jim Van de Wetering, (858) 208-9713, jvan@blairmartin.com
Impact of the Drought on Local Water Supplies. San Diego CoWater Authority speaker will explain the impact of the drought on localwater supplies; upcoming capital improvements; and an overview of theSD Emergency Storage Project. SD City Metro Operations Center, 9192Topaz Way. 5:00 networking and refreshments, 6:00 presentation. RSVPto Mike Wallace at MWallace@sdcwa.org. Website: www.isasd.com.
So San Joaquin Valley Section See Website Scott Bender, (661) 392-3784, sbendesr@chevron.com
Bakersfield Golf Tournament & Expo Coming on May 14-15. Makeyour plans to participate in the annual golf tournament. For more infoabout Golf & Expo, contact Bob Jackson at jacksonb@chevron.com.Website: www.isa.org/~ssjv.
Cal Poly Pomona Thurs, Apr 16 E J Ramos, (626) 475 3660, ejaramos@gmail.com
Cal Poly Pomona Job Fair. For more information, contact E. J. Ramosat (626) 475 3660 or Jasen Shorter at (619) 709-1490. Website:www.isacalpoly.org.
Cal State Long Beach No Information Walter Martinez at (562) 577-3605.
No information was available at press time.Website: www.isacsulb.org. Continued on next page
March 2009 ISA Newsletters, Southern District 11 9
Regional training & eventsDates subject to change. Always contact the sponsoring party beforemaking your final plans to attend. To include an ISA or non-ISAevent, please contact the editor.
April 16, 2009Cal Poly Pomona Job Fairwww.csupomona.edu
April 17-18, 2009ISA District 11 LeadershipConference, Scottsdale, AZContact the section president formore informatoin.
April 25, 2009California 2009 EIT Exam,www.pe-exam.net
May 14-15, 2009ISA-SSJV Golf Tournament,Tabletop Show, Training andCajun Feast, Bakersfieldwww.isa.org/~ssjv
May 17-20, 2009Int’l Biotech Conv & ExpoSan Diego, www.bio.org
June 5, 2009ISALA Golf EventDiamond Bar, www.isala.org
June 10-11, 2009West Coast Energy MgmtCongress, Long Beachwww.evergyevent.com
June 13-16, 20092009 Spring Leaders MeetingIndianapolis, www.isa.org
July or August 2009I/C Expo 09ISA San Diego Sectionwww.icexpo09.com
July 2009American Association forClinical Chemistry
July 2009Protein Society Meetingproteinsociety.org
July 2009Nuclear Detection &Measurement ConferenceLas Vegas
July 2009Semicon West, San Francisco
Aug 2009International Congress onRheologyhttp://www.rheology.org/
Aug 25, 2009ESRI Survey & EngineeringGIS SummitSan Diego Convention Centerwww.esri.com
Oct 2009ISA Expo 2009 and FallLeaders MeetingHouston, www.isa.org
Featured Product… Jamesbury® CINTAC Advanced Automation System
Products, knowledge, and quality. Products, knowledge, and quality. Valin delivers. Valin delivers.
VALIN Corporation
NELES
Brands you trust:
Call Valin today at 1-877-442-4422 or email more-info@valin.com to find out how to improve your process uptime and quality while lowering operation and maintenance costs.
ValiValin Sn Southeruthern Cali Califorfornia 1701 E Edinger Ave. Building J Santa Ana, CA 92705 phone: 714.953.2450 fax: 714.571.5390
Simplify and reduce the cost of automating rotary on-off valves by eliminating the need to engineer, procure and assemble separate rack and pinion actuators, switches, solenoid valves, linkages, tubes, and fittings. CINTAC is designed to support future growth and includes:
Cost effective platform with field-proven components
Integrated automation pack-age - plug and play installation
Advanced diagnostics
Digital bus communication capabilities
Automated online emergency shutdown testing
Rugged and compact design
GOLF TOURNAMENT -- TABLETOPTRAINING -- CAJUN FEAST -- AWARDS
SCHOLARSHIP FUNDRAISERMay 14-15, 2009
Thurs-Fri, May 14-15, 2009 -- www.isa.org/~ssjvInfo: Bob Jackson, jacksonb@chevron.com or (661) 331-4719
ISA Southern San Joaquin Valley Section
I / C E x p o 0 9w w w . I C E x p o 0 9 . c o m
“San Diego’s Only Process Instrumentationand Controls Exhibition”
Bakersfield College No Information Sean Caras, (661) 395-4393, scaras@bakersfieldcollege.edu
No information was available at press time. No website.
Continued from page 8
10 ISA Newsletters, Southern District 11 March 2009
21955 Plummer Street Chatsworth, CA 91311
(800) 266-2046
(818) 885-5855 fax
sales@donwolf.com www.donwolf.com
We also offer: Annual Maintenance Quick Repair &
Calibration Engineering & Design High quality & Low
prices Technical Information/
Advocacy & much more!
Honeywell Analytics, Inc.
Analyzers and Instruments: Combustion/ Emissions Analyzers Toxic Gas, IAQ, LEL & Radiation
Detectors Calibration Gases, Kits &
Accessories Components for Automation:
Fluid Controls/Pressure Regulators
Miniature Pumps Solenoid Valves
AUTOMATION & INSTRUMENTATION SPECIALISTS
GOLF TOURNAMENTTABLETOP SHOW -- TRAINING
CAJUN FEAST -- AWARDSSCHOLARSHIP FUNDRAISER
Thurs-Fri, May 14-15, 2009Info: Bob Jackson at jacksonb@chevron.com
ISA Southern San Joaquin Valley Section
INSTRUMENTATION 2009 EXPO,Continued from page 6. More photos and videos at www.instrumentation2009.com.
March 2009 ISA Newsletters, Southern District 11 11
The event would not have been possible withoutthe support of ISA Cal Poly Pomona and ISACal State Long Beach Student Sections.
12 ISA Newsletters, Southern District 11 March 2009
Bakersfield Student Section
Control Microsystems,Sage Designscontribute toBakersfield Collegeby Sean Caras, Associate Professor, Electronics Technology,Bakersfield College
Thanks to a generous donation fromControl Microsystems, and facilitated bySage Designs, Inc., a new generation oftrained automation technicians will utilizecurrent SCADA technology. BakersfieldCollege, a community college of almost17,000 students in Bakersfield California,is the recipient of six SCADAPack 32RTU’s, software, and instructor training.
Our Electronics, Instrumentation, and Automation program has anenrollment of approximately 170 students per semester, many of whomare seeking certification and degrees in Electronics Technology, or areindustry professionals seeking skills updating. While we are well-equipped in the areas of industrial electronics, motors and controls,instrumentation and process control, and radio/telecommunications, theSCADAPack controllers will meet an industry-critical need.
Our Instrumentation/Process Control Trainers are currently stand-alone systems, utilizing simple PID controllers. The SCADAPacks willbe interfaced to the process control trainers, allowing more advanced
process control functions to be simulated with our trainers in anadvanced-level course. We hope to purchase radios for each of thedonated SCADAPacks, and set up a SCADA system utilizing our fiveprocess control trainers to simulate an industrial environment. Inaddition, we are hoping to purchase additional SCADAPack RTU’s andradios to interface to variable frequency drive units in our motorcontrols lab, allowing a wider range of devices to be included in theSCADA system.
Through industry surveys we have taken with members of ourlocal ISA (International Society of Automation) section, three-fourthsof the respondents believed that Bakersfield College should expose ourstudents to several different manufacturers for PLC’s and controllers.PLC’s and controllers will eventually be deployed in most of ourclasses in some form or another. Our PLC stock was previouslydominated by one manufacturer.
The SCADA software from Control Microsystems was highlyrecommended to us by one of our industry advisors, because it was feltthat the software’s learning curve and user features would allowstudents to implement more advanced functions in a quicker timeframe.
An additional advantage of the SCADAPack product has been theprovided interface board that we will be able to use with our students.With every other industrial product we have deployed in our labs, ithas been necessary to build input and output simulators and otheritems necessary for students to work with the product. With theSCADAPacks, we were provided with a complete setup that a studentcould use right from the box.
We, at Bakersfield College, are excited to have this currenttechnology available to our students! Thanks to the generosity ofControl Microsystems, and the support of Sage Designs, Inc., ourstudents will soon be able to set up and manage a simulated industrialenvironment within our electronics labs using SCADA RTU’s andsoftware.
Tom Burdi of Advanced Process Services, right, gives a presentation on valves followed by a tour of their facility and cookout.
ISA Los Angeles Section, January Tour of Advanced Process Services
March 2009 ISA Newsletters, Southern District 11 13
pH measurement hasn’t
changed for the last
40 years -
until now.• No metal to metal
contacts eliminate
ground loops and
moisture or corrosion
• Memosens pH
sensors use digital
signal processing, eliminating long cable runs, high
impedance issues and noisy signal transmissions
• Memosens stores calibration information directly
in the sensor which allows for considerable cost
savings and increased process uptime
Go to www.us.endress.com/memosens
or call 888-ENDRESS to learn more
The Los Angeles Section was treatedto a tour of Advanced Process Services’valve service facility in the City ofCommerce, plus an excellent barbequedinner and technical presentation ofmany aspects of valve design, function,maintenance and servicing.
Photos courtesy of Advanced ProcessServices.
14 ISA Newsletters, Southern District 11 March 2009
Job ShopCirculation is 1400-1500 ISA members and other industry personnel in California, Nevada and Hawaii. To place an ad, call (714) 968-5501.The cost to place a job ad is $25 per block of 25 words. First 75 words free for ISA members.
Instrumentation & Analyzer Technicians. Perform field repairs,calibration, preventative maintenance with a minimum of supervisionon all types of electrical, instrumentation, and plant analyticalequipment. Field installation of signal wiring, instrumentation andcontrol system equipment. Experience with PLC programming,graphical interface software desirable but not required. Ability to workfrom schematics & mechanical drawings. Will cover So California.Full-time, part-time or contract openings. Please contact John Prince atAPG Analyzer Systems, at (714) 968-5501.
GOLF TOURNAMENT -- TABLETOP -- TRAININGCAJUN FEAST -- AWARDS -- SCHOLARSHIP FUNDRAISER
Thurs-Fri, May 14-15, 2009. Info: Bob Jackson at jacksonb@chevron.com
ISA Southern San Joaquin Valley Section
Outside Sales Representative. Applied Valves and Controls is thefastest growing distributor in Southern California specializing invalves, valve automation and process control products. We have animmediate opening for an Outside Sales Rep in the greater LA/OCarea. This position requires selling into the biopharm, commercialHVAC, industrial process, and water/waste industries. Applicant mustbe highly motivated with a positive attitude and have excellentcommunication and organizational skills. Minimum 3 years salesexperience. Engineering degree preferred, but not required. We offeran exciting compensation package including a base salary pluscommissions, benefits, and a fun professionally encouragingenvironment. For immediate consideration please contact Ray Herreraat 760-438-4840 or email your resume to rherrera@appliedvalves.com
March 2009 ISA Newsletters, Southern District 11 15
Glass-Trac / Steam-Trac / Level-Trac / Mag-Trac
Level / Steam Gauges
INGOLDLeading Process AnalyticspH/DO/O2/Conductivity/Resistivity/Turbidty
Nuclear Level & Density - TN & Kay-RayDensity & Spec. Gravity - SarasotaUltrasonic Flow - Polysonics, M-PULSeFlow Computers - AutoEXECData Recorders - WestronicsAir Flow Sensors - Brandt
Instrumentation & Controls
ADVERTISERS INDEX
Process Control and Distributed I/O
Signal Transmitters and Converters
Isolators, Splitters and Repeaters
Temperature Sensors and Transmitters
Limit Alarms, Trips and Switches
Process Controllers, Monitors and Backup Stations
Smart HART® Loop Monitors and Interfaces
I/P and P/I Pneumatic Converters
AC Power Transducers and Monitors
Indicators and Displays
Instrument Power Supplies
Enclosure Systems, Racks and Rails
Complementary Accessories
The Interface Solution ExpertsWhen you need to interface field processes with computer-based systems,readout equipment and other instrumentation... our technology, service andexpertise help you do it efficiently, safely and cost-effectively.
Temperature • Level • FlowPressure • Status
Monitor • Display • AlarmRecord • Control
Represented By: Patten Systems, Inc.Tel: (714) 799-5656 • FAX: (714) 799-5353E-mail: jcapitano@pattensystems.com
APG Analyzer Systems ....................................... 3Applied Valves & Controls .................................. 5Blair-Martin Company ...................................... 14Caltrol, Inc ........................................................... 4Capital Westward Systems & Controls ............... 7Dahl-Vaughn, Inc. ................................................ 9Don Wolf & Associates, Inc. ............................. 10Electrical Systems Limited .................................. 6Emerson Process Management .......................... 14Endress+Hauser ................................................. 13Golden State Controls .......................................... 7Jensen Instrument Company .............................. 15JPR Systems ........................................................ 8MCR Technologies ............................................ 13Moore Industries ..................................... Insert, 15PR Electronics .............................................. InsertPrecision Instrumentation Co. .............................. 5RA Safety Consulting, LLC .............................. 11Sage Designs, Inc. ............................................... 4SpectraSensors. .................................................... 6Trimax Systems, Inc. ........................................... 8Valin Corporation ................................................ 9WestMark Sales, Inc. .......................... Back Cover