Smart Solar Pump MPPT

- Market and Installation -

Solar 5HP Pump Installation, Sidhpur, Gujarat

MPPT Controller

VFD – Variable

Frequency Drive

Pump R, Y, B

Solar, Grid, Wind and DG Set

Parts

DC Energy

Meter for

measuring

monthly savings

Through

cumulative

units generated

by Solar

One of the 170+ sites present

Solar Energy Meter

Combining 2 Critical Needs

Power Water

Solar Pump Controller (Compatible with any standard pump)

Reducing Cost by 30% by eliminating need of battery

A solution which meets the real needs of society

Installed where DG sets are used due to inconsistent power

Ground Water Map of India

Rainshadow Map of India

Solar Irradiation Map of India

Juxtaposing all the maps.

- Multiple Pumps can be run on a single

controller

Example – 10HP Solar Pump Controller can be

used with 5 numbers of 2HP pumps

All Protections

- Dry Run Protection

- Continuous oscillation prevention

- Tank Level Control

- Reverse Polarity protection

Seamless transition from Solar To Grid when sun goes

down for applications where pump has to be run 24

hours

Example – At 6pm if solar is able to supply 20% of

power, then it will take 80% from grid and run pump at

full flow.

No Battery

Use any existing 3 phase Pump

- No need to change pump

- Saves time and money

- DC pump cost very high

- Servicing can be done locally unlike DC pump

- Can also be used with Grid

- We need to check current drawn by pump

HP = kW of PV Panels

Decision of how many kW PV modules to use?

Number'of'PV'panels'in'series'of'suitable'wattages'such'that'Vmp'should'be'within'range'of'510;580V'and'Voc'does'not'exceed'750V'

DC#Energy#Meter

Dry#Run#Protection

*'PV'Panels,'Pump';;'not'in'our'scope'of'work,'we'will'supply'only'pump'controller

*'PV'panels'erection'and'wiring'not'in'our'scope'of'work.

YES

YESYES

YES YES YES YES YES YES

YES

YES

To'read'PV'voltage,'current'&''power''(Power'generated'by'Pv'panels)

YES

510;580V 510;580V 510;580V 510;580V 510;580V

750V 750V 750V 750V 750V750V

510;580V 510;580V

YES

1#HP

1000W

2#HP 4.6HP#/#5HP

4800W'/5000W2000W

MODEL

ENCLOSURE#

WEIGHT

500'(W)'X''300'(D)'X''500'(H)'mm

'OR'3'Phase'415V'AC'Supply'from'grid'(if'wish'to'run'in'solar'preferetional'logic'or'without'solar)

3HP 7.5#HP 10#HP 15#HP

3000W 7500W 10000W 15000W

suitable'to'3'Phase'415V'AC''motor

YES

YES

YES

YES

OPERATING#TEMP

Over#Load#(O/P)

Max#PV#Volt#(Voc)

MPPT#Range#(Vmp)

OUTPUT#

INPUTQARRAY#OF#PV#PANEL#

DIMENSION

Over#Voltage

PROTECTIONS

Lightning(MOV)

Panel#Reverse#Polarity#(PV)

Short#Circuit#(PV)

Total#Panel#Wattage#Wp#(approx)

YESYES YESYES YES

YES

YES YES

YES

YES

YES

YES YES

YES

YES

YES

SOLAR#PUMP#CONTROLLER

0;50'DEG'C

MS'Powder'Coated'box

YES

YES

YES

YES

YES

YES

YES

YES

YES

750V

Solar Panel Configuration-

We require Panels to be series to around 560Vmpp

With Voc not exceeding 750VDC

3HP – 180W panels, 18 nos. in series

5HP – 250W panels, 20 nos. on series

10HP – 250W panels , 40 nos., 2 parallel strings of

20 nos. in series

PV

Solar Pump Controller MPPT

Pump

Solar Charger MPPT

Battery 12V, 24V, 48V

Lights

Solar Pump + Battery Charging

Preferential System

PRIORITY

WHEN EXCESS SOLAR POWER IS PRESENT OR PUMP SWITCHED OFF

Applications –

(1)Agriculture pumps

(2)Green Building, Hotels

(3)Salt Farms

(4)Geothermal Heat exchangers

(5)Fisheries

(6)Leather Factory

(7)Dairy

More Than 170 Solar pumps installed all over India

Solar Rooftop Solutions

Solar Chargers MPPT

Inverter

www.kbelectronics.co.in