Post on 28-Dec-2015
description
transcript
SERVICE Whirlpool EMEACustomer Services
AWE 6416
Service InformationToploader Washing machineAWE 64168593 641 10060Last Modification: 06/07/08Creation Date: 06/07/08
Spare Part List 2
Technical Data 4
Exploded View 11
Wiring Diagram 13
Circuit Diagram 14
Program Chart 15
Text legend 23
Service Bulletin 4812 712 40355 27
Service Bulletin 4812 712 40354 29
Service Bulletin 4812 712 40300 31
Service Bulletin 4812 712 40317 32
Service Bulletin 4812 712 40313 33
Service Bulletin 4812 712 40319 34
Service Bulletin 4812 712 40321 36
Service Bulletin 4812 712 40315 38
This document is only intended for qualified technicans who are aware of therespective safety regulations.Subject to modifications
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 2 of 38
Spare Part List
Pos 12NC Description
002 0 4812 459 38057 Flap round GW002 1 4812 459 38058 Hinge flap GW004 0 4812 440 19625 Drip tray assy010 0 4812 459 48175 Door frame inner GW010 1 4812 440 11637 Frame Top+nozzle box KIT
011 0 4812 462 48054 Foot012 7 4812 310 18497 Trolley kit front012 8 4812 528 78075 Foot rear021 0 4812 440 10838 Front panel WH GW022 0 4812 440 10839 Side panel right GW
022 1 4812 440 10841 Side panel left GW024 0 4812 440 11638 Rear panel040 0 4812 417 19155 Hinge bolt lid GW061 0 4812 466 88489 Counter weight061 1 4812 466 88491 Counter weight front
061 2 4812 466 88492 Counter weight bottom081 4 4812 529 18043 Shock absorber086 4 4812 529 18045 Pin f. Shock absorber086 5 4812 529 18052 Damper f. Shock absorber100 1 4812 440 10842 Lid outer GW
100 3 4812 440 10843 Lid inner GW100 5 4812 440 10845 Lid assembly WH GW110 4 4812 498 18249 Handle cpl. WH GW130 0 4812 417 19193 Door latch GW191 0 4812 466 68596 Door bellow
191 1 4812 492 98037 Strap f. bellow200 0 4812 418 18242 Tub201 0 4812 440 19644 Cover cpl.220 0 4812 418 18557 Drum soft op., 1000223 0 4812 418 48725 641m lifter
271 0 4812 358 18204 Belt PV 1207 J4 EL272 0 4812 528 88083 Pulley 298 mm290 0 4812 532 68078 Gasket301 0 4812 452 17689 Control panel AWE 6416331 0 4812 414 58306 Knob timer
331 2 4812 414 58307 Spring Knob timer332 0 4812 410 29501 Push button 4 Opt.333 0 4812 410 29503 Push button start/reset333 1 4812 410 29504 Push button option400 0 4812 361 58364 Motor MCA 45/64-148/ALB1
421 0 4812 121 18285 Interf.filter421 2 4812 404 38679 Holder RFI430 0 4812 360 18577 SPump,draining451 0 4812 259 28919 Heating element 2050W, 230V + NTC490 0 4819 321 18136 Cable mains 2m SA
490 1 4812 321 28367 Strain relief521 0 4812 214 70147 Control unit DOMINO, programmed521 0 4812 214 70092 Control unit C1 DOMINO FULL Class B571 0 4812 281 28468 Valve magnet 1 inlet, 2 outlets571 1 4812 281 18069 Cover for top frame
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 3 of 38
Pos 12NC Description
581 0 4812 271 28585 Pressostat 50/25 INVENS.620 0 4812 239 58046 Module E3/4 Opt.630 0 4812 271 38519 Door lock653 0 4812 134 18077 Light guide PR.FLOW-FULL653 1 4812 134 18078 Light guide 4 Opt.
691 0 4812 282 19485 Sensor NTC701 0 4812 530 29329 Hose, inlet; EN 11770 Reflex702 2 4812 530 29453 Hose valve-dispenser707 0 4812 526 48242 Nozzle box cold cpl.707 1 4812 526 48049 Clamp f. nozzle box
712 4 4812 418 68302 Siphon f. softener712 6 4812 418 68164 Clip soap dispenser712 9 4812 418 68404 Soap dispenser753 0 4812 418 68187 Chamber,air754 0 4812 530 28938 Drainhose
754 1 4812 530 28832 Lock eco760 0 4812 480 58089 Filter, pump - 6257.69359 ( 69402)781 0 4819 530 29035 Hose draining782 0 4812 530 28941 Hose Pressostat787 0 4812 530 29309 Hose Air Exaust
787 1 4812 530 29311 Cover of hose794 0 4812 530 58098 Gasket900 0 4819 401 18686 Clamp hose900 1 4812 401 18431 Clamp to pump900 2 4812 255 18304 Holder hose
900 3 4819 401 18529 Clamp hose901 0 4812 401 18462 Clamp drain hose; drain hose910 0 4812 502 48347 Screw,selftap 3,5x14910 1 4812 502 38151 Screw 4x14910 3 4812 502 18404 Hex flange bolt M6x16
910 4 4812 502 18423 Screw PT 7x15910 5 4812 502 18705 Screw M8x35910 6 4812 502 18399 Nut Push in M 8; Push in M 8921 0 4812 400 18047 Washer930 1 4812 492 48171 Torsions spring
930 2 4812 492 48162 Spring941 0 4812 310 18578 Bearing Kit953 0 4812 325 68001 Shaft seal962 0 4812 440 98142 Cover for Motor AC962 2 4812 440 11424 Spacer
965 0 4812 462 79974 Cap Transport blocking990 0 4812 310 18504 Fixing mat.set990 2 4812 310 18506 Fixing mat.set bottom993 0 4819 530 29028 U Curve for outlet hose993 1 4812 290 18025 Clamp heating element
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 4 of 38
Technical Data
Dimensions + Weight
Product dimensionsHeight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85 cmWidth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40 cmDepth . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 cm
WeightGross . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ~66 kgnet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ~63 kg
Electrical base data
Voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 - 240 V ± 10%min. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 10%max. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 240 V ± 10%
Frequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 HzFuse . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10 APower Consumption . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ~2.3 kW
Drum data
Volume . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 lWash speed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 52 rpmSpinning speed
max. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 960 rpm
Capacity of dry laundry
Cotton . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.0 kg
95°C-60°C-40°C
Synthetics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.5 kg
60/40/30 °C
Delicate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40/30 °C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.5 kgChrono . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40°C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3.0 kgQuick Wash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30 °C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3.0 kgWool . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.0 kgHandwash . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40/30 °C . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1.0 kgRinse & Spin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.0 kgSpin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.0 kgGentle Spin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.0 kgJeans . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.0 kg
Pressostat
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .B1 - 250Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 VWater Level
Level1
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 5 of 38
(11 - 12/14)
Switching point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 ± 5 mmWcSwitching back point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 ± 5 mmWc
Switching point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 ± 5 mmWcSwitching back point . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .25 ± 5 mmWcOverflow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (11 - 16) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .300 ± 20 mmWc
Nominal currentContacts
11 - 12 4 (4)A
11 - 14 16 (4)A
11 - 16 1 (1)A
Nominal current
Contacts
11 - 12 4 (4)A
11 - 14 16 (4)A
11 - 16 1 (1)A
Door lock
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . BP P/5 DAKind of switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Switch with PTC heater of bimetal
Switch with PTC heater of bimetal
Locking timemax. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6"
Unlock time . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37 - 65"Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 (90 - 264) V
min. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .230 (90 Vmax. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 264) V
Nominal currentContact . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16 (6) A
4 - 5 (250 V)
Heating element
Kind of heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Tubular heating element with NTC - sensorTubular heating element with NTC - sensor
Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 230 + 10%, -15% Vmin. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .230 + 10%, Vmax. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15% V
Total power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2050 W ± 5%Resistance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (20 °c) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23.9 Ω ± 5%Resistance (20 °C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23.9 Ω ± 5%
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 6 of 38
Thermo-fuse (switch OFF temperature) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .152 °CLeakage current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (<99°C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .mANTC sensor
Resistance NTC
0 °C 35.9 kΩ ±5.8%
30 °C 9.8 kΩ ±3.7%
40 °C 6.6 kΩ ±3.1%
50 °C 4.6 kΩ ±2.6%
60 °C 3.2 kΩ ±2.0%
70 °C 2.3 kΩ ±2.5%
95 °C 1.1 kΩ ±3.7%
0 °C 35.9 kΩ ±5.8%
30 °C 9.8 kΩ ±3.7%
40 °C 6.6 kΩ ±3.1%
50 °C 4.6 kΩ ±2.6%
60 °C 3.2 kΩ ±2.0%
70 °C 2.3 kΩ ±2.5%
95 °C 1.1 kΩ ±3.7%
Electronic
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .DOMINO . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .DOMINOBasic . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4619 714 03655Programmed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4619 751 56611Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220 V - 240 VFrequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 - 60 Hz
min. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 Hzmax. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60 Hz
Ambient temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0 to 70 °CStorage temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . -35 to 70 °COutput control unit
Motor M7.6 - DSS3.2 >40 V
Aquastop AQ2.2 - DSS3.2 230 V
in pump step AQ2.1 - DSS3.2 230 V
NTC not measurable
Pump DP2.1 - DP2.2 230 V
Doorlock DSS3.1 - DSS3.3 230 V
Pressostat E4 - E2 230 V
- empty PR2.1 - E2 230 V
- full PR2.2 - E2 230 V
Valve (Rast 2.5) V2.1 - V2.2 >170 V
Options not measurable
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 7 of 38
Inlet valve
Type
1-way valvefor cold water
Water temperature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 - 90 °Cmin. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 °Cmax. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 90 °C
Rated flow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8 l/min Ω ± 8%
(1 - 1.5 bar)
Pressure range . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.3 bar - 10 barNominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220 V - 240 VFrequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 HzNominal current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35 mANominal resistance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (20 °C) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3.8
k Ω ± 10%Total power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6 W ± 10%
Drain pump
(synchronous)
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .292079Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220 V - 240 VNominal current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .0.2/0.22 ANominal consumption . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 WTotal power . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26 WRotations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3000 rpmFrequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50 HzResistor (coil) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224 Ω ± 5%Motor protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . noCapacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14 ± 2 l/min
(1.25m height)
Position of draining hose outlet . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0.9 m - 1.25 m
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 8 of 38
Output control unit
Motor M7.6 - DSS3.2 >40 V
Aquastop AQ2.2 - DSS3.2 230 V
in pump step AQ2.1 - DSS3.2 230 V
NTC not measurable
Pump DP2.1 - DP2.2 230 V
Doorlock DSS3.1 - DSS3.3 230 V
Pressostat E4 - E2 230 V
- empty PR2.1 - E2 230 V
- full PR2.2 - E2 230 V
Valve (Rast 2.5) V2.1 - V2.2 >170 V
Options not measurable
Display module
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DOMINO E3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . DOMINO E3Nominal voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5 ± 0.5 VNominal current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .mA
4 - 5 (5 V) 60
Programs
1. Cotton 95 °C
2. Cotton 60 °C
3. Cotton 40 °C
4. Synthetics 60 °C
5. Synthetics 40 °C
6. Synthetics 30 °C
7. Delicate 40 °C
8. Delicate 30 °C
9. Daily 40°
10. Quick wash
11. Wool 40 °C
12. Woll cold
13. Handwash 40 °C
14. Handwash 30 °C
15. Rinse & Spin
16. Spin
17. Gentle spin
18. Spin Drain
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 9 of 38
Motor
Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . MCA 45/64 - 148/ ALB1Belt ratio . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . i = 1:15.9Resistance contacts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (20 °C)
Stator (full field) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1.8 Ω ± 7%Rotor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2.0 Ω ± 7%Tacho generator . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 68.7 Ω ± 7%
Input powerWashing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (230 V AC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 220 W ± 7%Rinsing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 315 W ± 7%Spinning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 405 W ± 10%
(full field)
Radio interference filter
Rated voltage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90 - 250 Vmin. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .90 Vmax. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250 V
Rated current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 AFrequency . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50/60 HzNominal capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 470 nF X1 + 2 x 22 nF Y ± 20%Nominal resistance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 680 K Ω ± 10%Derivation current . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .≤ 4.15 (2 x 2.075) mA
(u = 250 V AC)
Push button switch
StartResetSwitch Start delaySwitch EcoSpin speed reduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . (960, 760, 600, 400, 0)
(960, 760, 600, 400, 0)
Switch Rinse intensiveSwitch Rinse holdSwitch Pre wash
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 10 of 38
Programs
1. Cotton 95 °C
2. Cotton 60 °C
3. Cotton 40 °C
4. Synthetics 60 °C
5. Synthetics 40 °C
6. Synthetics 30 °C
7. Delicate 40 °C
8. Delicate 30 °C
9. Daily 40°
10. Quick wash
11. Wool 40 °C
12. Woll cold
13. Handwash 40 °C
14. Handwash 30 °C
15. Rinse & Spin
16. Spin
17. Gentle spin
18. Spin Drain
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 11 of 38
Exploded View
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 12 of 38
Exploded View
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 13 of 38
Wiring Diagram
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 14 of 38
Circuit Diagram
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 15 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 16 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 17 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 18 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 19 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 20 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 21 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 22 of 38
Program Chart
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 23 of 38
Text legend
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 24 of 38
Text legend
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 25 of 38
Text legend
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 26 of 38
Text legend
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 27 of 38
Service Bulletin 4812 712 40355
AUTHOR: Ronny SchurichtLast Update: 05/11/11VERSION: 1.0TITLE: Water dripping from lid onto side panels.SUBJECT: In rare cases, when the lid is opened after a washing cycle, water drips down the side panels.
REMEDIAL ACTION
If customer claims wet side panels, remove the lid and put some silicon in the area of the frame like shown in the pictures.
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 28 of 38
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 29 of 38
Service Bulletin 4812 712 40354
AUTHOR: Ronny SchurichtLast Update: 02/07/11VERSION: 1.0TITLE: new fixation pin for shock absorberSUBJECT: Since 8th dec. 2010 a new pin fixing the shock absorber to the tub is used in production .
REMEDIAL ACTION
The new pin is interchangeable with the old version. In SPC the old pins will be replaced by the new version.
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 30 of 38
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 31 of 38
Service Bulletin 4812 712 40300
AUTHOR: Ronny SchurrichtLast Update: 04/29/08VERSION: 1.0TITLE: No possibility to push button of drum door.SUBJECT: We have some drum exchanges in the field related to the button on the drum door that is not flexible anymore.
REMEDIAL ACTION
Since week 40/2007 there is used in production modified drum door where the plastic button of drum door is fixed. Thatmeans if the button is pushed, there is no movement visible of the button itself. This is correct.In case of exchanging drums it is possible that the original drum in the appliance has got a movable button, but the sparepart drum has got the fixed button.Following drums are concerned:4812 418 185564812 418 185574812 418 18635
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 32 of 38
Service Bulletin 4812 712 40317
AUTHOR: Ronny SchurrichtLast Update: 07/01/09VERSION: 1.0TITLE: Heating Element alternative solution.SUBJECT: In special conditions it can occur that the heating element after a short period gets broken caused by very hardwater (limestone) or variations in power supply.
REMEDIAL ACTION
If the heating element gets broken under mentioned conditions we recommend using the alternative heating element that isnickel treated and usable for power supply up to 240V.
According to SPC 600 pieces will be on stock from week 52 onwards.
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 33 of 38
Service Bulletin 4812 712 40313
AUTHOR: Juergen ReinhardtLast Update: 11/17/09VERSION: 1.0TITLE: F06 randomly displayed in Domino controls
CAUSE
Sensible failure detection in drive system for safety reasons
REMEDIAL ACTION
Please check the following points:
Load:
Was there bulky load in the drum or was the machine overloaded ?
Drive system:
Please check the tacho generator (resistance and cable).
Please guarantee a proper and tight seat of the belt on drive shaft and pulley.
Please check the electrical connections between controls and motor.
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 34 of 38
Service Bulletin 4812 712 40319
AUTHOR: Ronny SchurrichtLast Update: 03/27/09VERSION: 1.0TITLE: Avoiding F13 in the field.SUBJECT: In the field we have a few cases of F13 caused by leakage due to water flowing into the electrical contacts ofdoor lock during final spin.
REMEDIAL ACTION
In order to avoid water leakage in production (week 10/2009) an insulation tape was implemented, stacked on the upperpart of door lock. (see the picture)The application of insulation tape by serviceman is always necessary, when water leaks between lid of machine and frontpanel.Insulation tape: dimensions: 9 x 2 x max. 20 mm, material: Polyethylene foam.
The usage of insulation tape is a temporary solution.In order to solve this problem in the future the door lock will be modified in the critical area and a new service bulletin will beissued.
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 35 of 38
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 36 of 38
Service Bulletin 4812 712 40321
AUTHOR: Ronny SchurichtLast Update: 10/14/10VERSION: 3.0TITLE: Drum with improved pulley fixation and drum opening.SUBJECT: There were made some modifications on Alliance drums in production (7.4.2009):1. Change of hole for pulley screw in the hub from M6 to M8 to improve connection drum pulley. (LR+HR)2. New hinge of drum door with thickness 1,8 mm (before 1,5 mm) and rivets with diameter 4 mm (before 3 mm). (HR with210 mm door).3. New shape of drum door for new hinge of drum. (HR with 210 mm door)Also the heating element holder (HR), is replaced by a new one with lower shape.(pls find Service Bulletin 481271240318)
Update 19.07.20104. Change of hole in the hub (opposite side of pulley) from M6 to M8. Machines from serial number 341029..... onwardsare equipped with the new screw M8x18 and accordingly modified drum. The washer is cancelled.
Update 08.10.20105. Substitution of LR drum 4801 111 02217 by LR drum 4801 111 02218 equipped with drum opening of the HR drum, thatis more stable.
REMEDIAL ACTION
We introduced new spare parts: drum kits with pulley screw M8x23. In the case of HR also with heating element holder +screw.The drum with new hinge (1,8 mm) has got a bigger diameter. In order to avoid contact of the drum with the old heatingelement holder it’s necessary to exchange it by the new one when the drum is replaced. In LR machines it is not necessarybecause of enough space between drum and heating element holder.
Update 19.07.2010As spare parts the drum kits mentioned in the table below are equipped with the fitting screws. Service codes remain thesame like before.
Update 08.10.2010If the drum of a 5kg LR machine needs to be exchanged the LR drum with 210mm drum opening will be send as spare part.Repair is exactly the same. The drum will fit without any problems.
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 37 of 38
© Whirlpool EMEA www.scc-service.com
SERVICE Whirlpool EMEACustomer Services
8593 641 10060, 06/07/08page 38 of 38
Service Bulletin 4812 712 40315
AUTHOR: Ronny SchurrichtLast Update: 07/01/09VERSION: 1.0TITLE: Bearing kit does not fit.
REMEDIAL ACTION
We have some claims about spare part bearing kits, that doesn’t fit in the tub. Reason is a material change in productionthat causes slightly different measures.In Alliance LR machines the new bearing kit is used since week 49/2007.
In case of exchanging the bearing kits, it’s important to take care about the correct bearing kit according to Service Info.
© Whirlpool EMEA www.scc-service.com