.. Parts List Karmann...Karmann Ghia Type 3 / No longer available: superseded by: 311 2551al no...

.. ... ..,. ''--..

Parts List

VOLKSWAGEN

MOOEL343

MOOEL344

MOOEL345

MOOEL346

DECEMBER 1963

2 Seater Coupe

2 Seater Coupe

2 Seater Coupe

2 Seater Coupe

1500 1600 1600L

LHO

RHO

LHO with sliding rool

RHO with sliding rool

.. ~

,4 ,

~~·('Jf4,: ¥¥:P$'4.h11~,fJB·l:~_·JI!,,·~·~··-.... \""!';tA!II.1IP.,l1li',*l1li, ,,,,g"'.!4l"'I!'!J~,R"L"iWl'I! ... ;;;~. -_"7'5">~'~~ •. iIl!,~:,!\'i.\ill .• ~~;,ij;!I'5h"'!l!!QI!!I, __ ..,!I •• j!l!l}IIl!P~'!!!~%!!l!:·iJi'\f!l!:"'':iC~·:..-'t!!.~!ll~§F''J!·!II·''·'.II!!!~!)!!-!,!%![I-J~""'-"'l'J[I!.I!! .. I!!I~WII.I",,!!!£IJ!.IE.$I;III:r.'"A4!!1~"I .. II!>.p.!II~I.,;,,!I!;~'i!!\lil'l!·\.!l'!.~o*"~!!!li!!!.MII!.¥!l' .. I!!}'.~~~%!I!~,~!!I?I!l.'·~!!l:~#iM,.I'J!II!"'l . . ' '...' '. .: - ':;;{':~"'ir. ~,' .... -~. "'"

2

The unit numbers are found on the foHowilng 'Iocaiions:

Type Number:

On theidenNlicaNon plate in f,rontluggage comparlmelni ibes'ide the fuell tank

HI,ler neck.

Chassis Number:

On frame tunnel under the emergency seat.

Edition 9480 Printed by: H. Osterwald. Hanover· Printed in Germany

All rights reserved· May not be reproduced or translated in whole or in part without written consent from Volkswagenwerk.

This Parts List is only meant for use within the VW Organization.

~t is not to be regarded as advertising material and it is meant to facilitate the smooth running of the Parts Service.

2

Supplements 1-34

have already been Incorporated

in this Parts List.

If you require Parts Lists as well as individual index pages or covers please

quote the following numbers in your orders:

73500420

.73501420

73502420

Edition: 15450

Complete Parts List

Index Pages

Cover

PrInted by: H. Oaterwald. Hanover. PrInted In Germany All rIghts r_rved • May not be reproduced or translated In whole or In pm wIthout written consent from Volkllwagenwerk. This Parts List Is only meant for use wIthin the VW Organization. It Is not to be regarded as advertising material and It la meant to facilItate the smooth running of the Parts Service.

-~.\

< •

"'

Supplement 8S to Parts List

Kormann Ghio Type 1 ond Type 3

Pages with Roman numerals have been replaced by pages with Arabic numerals.

Please remove all the pages with Roman numerals from the Parts List.

Karmann Ghia Type 1

New part$.:

141 945 131

141 945 133

No longer available:

141 809417

141809418

143809 452 A

K 35713

P 23715

U 126 14

V 115

Delete:

142857121 A

14'3919031 B

lens Reflector (M 11)

lens Reflector (M 11) (for USA only)

superseded by:

141809417A

141809418A

143809 452 B

no longer ava,ilable

no longer avaHable

U 133 11

no 10llger ava,ilable

superseded by:

142857121 B

141 919025

VOLKSWAGENWEBK AKTIENGESELLSCHAFT • WOLFSBUBG December 1970

Karmann Ghia Type 3

/

No longer

available: superseded by:

311 2551al no longer ava,i·lable

311255182 no longer ava,Hable

311 255201 A no 'Ionger avaiHable

311255209 A no longer ava,i·l·able

311 255387 E no longer avalil>able

311 255388 F no longer ava,ilab'le

311 25'S 389 C no 'longer avalilable

311255390 C no langler avaii'l,able

311701447 311 701 4w:1IJ ,,343 70s 481 B 3437'05481 C 3117'05761 311 705761 A

3438001'01 no longer avalilable

344 800 101 no longer aValil>ab'le

345800101 no 'longer aValilable

346 800 101 no lo'nger avalHable

343800401 E no longer avaHable

344 800 401 D no loniger avaHable

345800401 E no longer avalHable

346 800401 D no longer available

343813161 B 343813 161 C

343857101 343857101 A

343857121 343857121 A

343 867011 (875) no longer aV13lilable (880) no longer ava'ilable ..-.., (879) no longer ava'j'lable (856) no longer avalNable (041) 343867 ON (172)

343867011 A (041) 343 867 011 A (172)

343867012 (878) no longer ava,ilable

343 867 012 A (041) 343 867012 A (172)

343867 '035 A (163) 343867 '035 A (176) rj .~

343 867 036 ('041) 343867036 (172)

343867287 no longer aVillilable

343867 SCI (466) 343 867 SOl (581)

311 881 155 (043) . 311 881 161 C ('043)

,311941583 A 11194158.3A

311 941 583 B 111 941 583

http:11194158.3A

in various

the

Extras or

3

Observe .he following when ordering:

o Innumerate the items requi.red in parts list sequence with the exception of standard paris and lacquers which should be shown in' numerical sequence

at the end- of the order.

8 In case of doubt always indicate: Type, Chassis and Engine Numbers.

e Always state the color code of all parts which are supplied colours.

o In case of orders by telephone, correct supply cannot be guaranteed. e Designations such as front - rear - left - right are determined from

driving seat facing fOJward.

o Orders for bodies should be submitted on special orders.

X in the "Quantity" column indicates: as required,

.. in the "Quantity" column indicates: running meters,

.. in front of the pari no. indicates: part also supplied in an Repair ,kit,

M ... in the Type and Model column indicates: Optional

Deletions, no entry in the "Type and Model" column indicates for all

models .

• in front of color code indicates: pari no longer available; the replace

ment is given after the color designation.

VOLKSWAGENWERK AKTIENGESELLSCHAFT . WOLFS BURG

Ghla Typ 1-35

..

Introduetion

This' parts IilSJt contains an the spare parts fo.r +he Volkswageln Karmann Ghia Type 1 a'nd Type 3. Pa'rts of the individua,! malin or sl.lb groups which -are not shown in this Palds List a...e '10 be found in the Parts Lis1 f« the Volkswagen Type 1 alnd Type 3. Modilf.iI

_

Export markets (Germany: standard eqUipment)

Export markets (Germany: standard equipment)

5

List of Optional Extras (M) shown In the Parts List

.. Model

M5 .Saxomat 34 b.h.p. engine from Engine No.5 000 001 up to 9 800 000 141-144 from Engine No. DO 000 001 up to DO 095 049 141-144

M9 Yellow taillights 141-144 Australia, Italy up to Chassis No. 1461021 300

Automatic transmission 141-144 from Chassis No. 148 071 440

M 11 Sealed Beam headlights, flashing Indicators with side 141,143 USA, Canada marking lights, red taillights, emergency lights, dual circuit brake warning light, back up lamp, without head-lamp flasher, parking lamps and steering lock (from Chassis No. 149 000 001 without emergency light) from Chassis No. 148 000 001 up to 1491200000 Sealed beam headlights, flashing indicators with side

marker light, red taillights. buzzer for ignition-starter

switch, side marker reflectors. back-up lamps in

taillights, dual olrcult bmke warning light. but without

head lamp flasher parking lamps and steering lock

from Chasis No. 140 2000 001

M14 Inscription "Volkswagen"lnstead of VW 1300, VW 1500 141-144 Export markets and VW 1600 up to Chassis No. 349 500 000 343-346

M 17 With mounting points for lap safety belts 141-144 up to Chassis No. 1461021300

M 19 Without headlamp flasher from Chassis No. 148 000 001 141-144 from Chassis No. 348 000 001 up to 349 500 000 343-346

M20 Speedometer in miles 141-144 Export markets up to Chassis No. 349 500 000 343-346

M26 With activated carbon container for absorbing 141-144 CalHornla fuel vapour from Chassis No. 140 2000 001

M27 With lap belt reel flxture 141-144 USA, Canada from Chassis No. 147000001 up to 147999000

Mao With head lamp flasher and simultaneous license plate 141,143 Austria illumination up to ChaSSis No. 349 500 000 343,345

M34 Parking light warning lamp, side-mounted 141-144 Italy flashing Indicators. Flashing Indicators, front (white-yellow) and with Italy additional rear reflectors up to ChassiS No. 349 SOO 000 343-346

M37 Without emergency light system 141-144 Franca and Italy up to Chassis No. 349 500 000 ~-346

M48 Side-mounted flashing indicators 141-144 Denmark

M47 With back up lamp from Chassis No. 147000001 up to 149 1200 000 141-144 from Chassis No. 347000001 up to 349500000 343-346

MSO Dual circuit brake warning light 141-144 from Chassis No. 148 000 001

M54 Lockable glove compartment lid 143,144 from Chassis No. 149000001

M55 Steering lock with Ignition-starter switch 141-144 from Chassis No. 147000 001 up to 1491200 000

Gearshift lock with Ignition-starter switch 141-144

up to Chassis No. 1461Q,21 300

'"":. 'f'4 ~", f..' -'T

M59

/ GttIa~1·M . ~ ~'-

- -

, ,

..,,--~ Model

:~ M 59 Thermostat-controlled carburetor pre-heating 141-144 Export markets

40 b.h.p. engine .,J

from Engine No. F 1 380778

M 62 Water container with smaller air chamber 141-144 Sweden

and additional air hose;

from Chassis No. 149000001 141,143

from Chassis No. 349000 001 up to 349 500 000 343,345

additional rear view mirror, outer, right, "convex"

(LHD only)

M74 Mug flaps

up to Chassis No. 349 500 000 343-346

"

M 82 Mounting parts for first aid kit 141-144

from Chassis No. 141 2000001

M89 Laminated windshield 141-144 Export markets

up to Chassis No. 349500 000 343-346

M 102 Rear window glass (heatable)

from Chassis No. 145000001 143,144

from Chassis No. 149862321 141, 142

from Chassis No. 345 000 001 up to 349500000 343-346

'"' " M 107 Bumper guards 141-144

M 124 Yellow headlight bulbs 141-144 France

M 138 With Sealed-Beam headlights, red taillights, emergency 141-144 Export markets

light, but without headlamp flasher

up to Chassis No. 147999000

Sealed Beam headlights, red taillights,

but without headlamp flasher

from Chassis No. 148 000 001 up to 1491200000

Sealed-beam headlights, front flashing indicators with

side marker lights, back-up lamps in brake/indicator

lights, side flashing indicators in front

from ChaSSis No. 1402000 001

M 185 Three-point safety belt - Front seat 141-144 USA, Canada from Chassis No. 148000 001

M 187 Headlamps for left-hand traffic 141-144 Left-hand traffic

up to Chassis No. 349500000 343-346

M 206

M227

M 228

M246

M248

M249

M259

M 261

M274

6

Rear view mirror, inner, anti-dazzle 141-144

up to Chassis No. 349500 000 343-346

Higher front seat backrest (headrest) 141-144


Padded strip - Instrument panel 141,143


Eberspacher heater 343-346

up to Chassis No. 345220 883

Ignition/starter switch without steering-ignition lock 343-346 Export markets


Automatic transmission 343-346

from ChaSSis No. 348 015226 up to 349500000

With mounting points for lap safety belts 343-346 Export markets


Additional outer rear view mirror, right, plane 141,143

from Chassis No. 148 000 001

With Sealed-Beam headlights, red taillights, emergency 343-346 Export markets

light, but without head lamp flasher

up to ChaSsis No. 347 500 000

Sealed-Beam headlights, red taillights, ~,~. but without head lamp flasher and parking lamp .,',':-:'" ~ ;

from Chassis No. 348000001 up to 349 500 000 ~.'

, ,(

'~ . '.

~ .. ; • ' ~

' M 275 Cover - Fog lamp up to Chalisls No. 349500 000 Model

343-346 Benelux countries '. , , (

M282 Yellow headlight bulbs 343-346 France up to Chassis No. 346 500 000 {~

t

... .; 3

M528 Additional outer rear view mirror. right, convex from Chassis No. 149 000 001 141.143

from Chassis No. 349 000 001 up to 349 500 000 343,345

M601 Special equipment package from Chassis No. 148 000 001 up to 148 999 000 141-144 from Chassis No. 348 000 001 up to 348 500 000 343-346 comprising: M 47: Back up lamp.

M 102: Heatakte rear window

(only for 143, 144, 343-346).

emergency light system, dual circuit brake warning light.

padded strip for instrument panel (LHD only: 141. 143)

M602 Special equipment package from Chassis No. 148 000 001 up to 148 999 000 141-144 from Chassis No. 348 000 001 up to 348 500 000 343-346 comprising: '~', '\ emergency light system, dual circuit brake 1

-"warning light, padded strip for instrument panel (LHD only: 141. 143) ~

;!l

M610 12 Volt system 141-144 up to Chassis No. 147999 000 ~

~ M616 Back-up in brake/Indicator light 141-144

I~ "

from Chassis No. 140 2000 001 t.

M617 Water container with decreased air capacity 141-144 and additional air hose from Chassis No. 148 000 001

'\ '1'''' -~~ ~-

t·, '. r .~.• Ohla Typ 1 .. M

fl 43 ~

MAIN GROUPS

41 (I

~ 4 4 cD

ADDENDUM ~ 4

Ghla Typ 3·35

.{4!!'O .Q. At Pt¥' M .

Production Su",ey

\'

The following list gives a survey of the chassis produced up to the end of each year and of dates when substantial technical innovations were introduced.

Year Chassis

Sept. 1961 00269 Type 343 introduced

Dec. 1961 10550

July 1962 50282 Type 345 introduced

Aug. 1962 64916

Dec. 1962 138774

Aug. 1963 221 975 ~- '

Dec. 1963 321 076 ::,',

Jan. 1964 341 651 Type 344 introduced

Feb. 1964 342081 Type 346 introduced

~" " July 1964 483592

Aug. 1964 345000001 L I Dec. 1964 345087857

July 1965 345220883

Aug. 1965 346000001

Dec. 1965 346140226

July 1966 346500000

Aug. 1966 347000001

Dec. 1966 347134254

July 1967 347500000

Aug. 1967 348000001

~,~ Dec. 1967 348079424 L July 1968 348500000 t, I j" '

~ .. Aug. 1968 349000 001

r Dez. 1968 349108899

July 1969 349500000 , [

~;... 4

i\, '

L_~ ______

w CD .... Ghia Typ 3 - 35

""5" " .. S:O:- *'>" Wt -

Color Combinations Karmann-Ghia Type 3

up to July 1967 - Chassis No. 347500 000

5

Model 343-346

September 1961 up to July 1962, from introduction up to Chassis No. 64915

Car finish L 41 (10) black L 87 (13) pearl white

Upholstery combination (cloth) 57 red/si Iver beige 57 red/silver beige

Upholstery combination (Ieatherette) 75 true red/silver beige 75 true red/si Iver beige

Wheel disc L 87 pearl white L 87 pearl white

Hand brake lever L 469 anthracite L 469 anthracite

Seat frame L 466si Iver beige L 466 silver beige

Car finish L 469 (18) anthracite L 360 (12) sea blue

Upholstery combination (cloth) 59 silver/silver beige 58 cerulean blue/ice blue

Upholstery combination (Ieatherette) 76 derby grey/silver beige 77 ~ea blue/ice blue

Wheel disc L 87 pearl white L 289 blue-white

Hand brake lever L 469 anthracite L 290 satin blue

Seat frame L 466 silver beige • ice blue

Steering column tube L 43 grey-black; rim L 41 black

August 1962 up to July 1964, from Chassis No. 64916 up to 483592

Car finish L 41 (10) black L 456 (11) ruby red

Upholstery combination (cloth) 61 red/silver beige 57 silver/silver beige

Upholstery combination (cloth)

Upholstery combination (Ieatherette) 76 brick red 75 silver beige

Upholstery combination (Ieatherette) 79 black 79 black

Upholstery combination (Ieatherette)

Car finish L 87 (13) pearl white L 469 (18) anthracite

Upholstery combination (cloth) 61 red/silver beige 57 silver/silver beige

Upholstery combination (cloth) 61 red/silver beige

Upholstery combination (Ieatherette) 76 brick red 75 silver beige

Upholstery combination (Ieatherette) 79 black 76 brick red

Upholstery combination (Ieatherette) 79 black

Car finish L 571 (23) terra brown L 560 (24) manila yellow

Upholstery combination (cloth) 59 beige/light beige 60 manila/black

Upholstery combination (cloih)

Upholstery combination (Ieatherette) 78 light beige 79 black



Car finish L 398 (26) pacific

Upholstery combination (cloth) 58 turquoise/ice blue

Upholstery combination (cloth)

Upholstery combination (Ieatherette) 77 ice blue



Wheel disc, rim L 41 black; steering column tube, hand brake lever L 43 grey-black; seat frame L 469 anthracite Remarks: Index a and b for door trim panels only

6

1",0-"." 1

L 456 (11) ruby red

59 silver/silver beige

76 derby grey/silver beige

L 87 pearl wh ite

L 469 anthracite

L 466 silver beige

L 398 (26) pacific

62 turquoise/ice blue


L 289 blue-white

• hydrate green

• ice blue

Remark: • no longer available

L 360 (12) sea blue

62 cerulean blue/ice blue

77 a ice blue

79 black

L 532 (22) polar blue


77 b ice blue

79 black

L 514 (25) emerald

57 silver/silver beige

75 silver beige

79 black

· fl"f, ",'HR,,*, ¥J}, 4k 4-; ;ttl- 4., f~ 'S. 2#

Model 343-346

August 1964 up to July 1965, from Chassis No. 345 000 001 up to 345220883

Car finish L 288 (01) bermuda L 594 (02) smoke grey L 554 (03) cherry red

Upholstery combination (cloth), standard 69 marine 65 silver 68 slate

Upholstery combination (cloth), optional 68 slate 61 brick red 65 silver

Upholstery combination (cloth), optional 66 beige

Upholstery combination (cloth), optional


Upholstery combination (Ieatherette), standard 92 aero blue 88 aero grey 93 aero black

Upholstery combination (Ieatherette), optional 93 aero black 89 aero beige 88 aero grey

Upholstery combination (Ieatherette), optional 91 aero red

Upholstery combination (Ieatherette), optional

I Upholstery combination (Ieatherette), optional

Car finish L 553 (04) henna red L 544 (05) roulette green L 582 (06) arcona white

Upholstery combination (cloth), standard 68 slate 66 beige 66 beige

Upholstery combination (cloth), optional 65 silver 61 brick red 61 brick red

Upholstery combination (cloth), optional 65 silver 67 brown

Upholstery combination (cloth), optional 67 brown 68 slate

Upholstery combination (cloth), optional 66 slate

Upholstery combination (Ieatherette), standard 93 aero black 89 aero beige 89 aero beige

Upholstery combination (Ieatherette), optional 88 aero grey 88 aero grey 90 aero brown

Upholstery combination (Ieatherette), optional 90 aero brown 91 aero red

Upholstery combination (Ieatherette), optional 91 aero red 93 aero black

Upholstery combination (Ieatherette), optional 93 aero black

Car finish L 595 (09) fontana grey L 360 (12) sea blue L 560 (24) manila yellow

Upholstery combination (cloth), standard 68 slate 65 silver 68 slate

Upholstery combination (cloth), optional 61 brick red 68 slate 67 brown

Upholstery combination (cloth), optional 67 brown

Upholstery combination (cloth), optional 69 marine


Upholstery combination (Ieatherette), standard 93 aero black 88 aero grey 93 aero black

Upholstery combination (Ieatherette), optional 90 aero brown 93 aero black 88 aero grey

Upholstery combination (Ieatherette), optional 91 aero red

Upholstery combination (Ieatherette), optional 92 aero blue


Car finish L 568 (37) sea sand

Upholstery combination (cloth), standard 67 brown

Upholstery combination (cloth), optional 68 slate




Upholstery combination (Ieatherette), standard 90 aero brown

Upholstery combination (Ieatherette), optional 93 aero black




Wheel disc, rim L 41 black; steering column tube L 43 grey-black; hand brake lever, seat frame L 469 anthracite

Ghia Typ 3-35 7

Model 343-346

August 1965 up to July 1966, from Chassis No. 346000001 up to 346500 000

Car finish L 288 (01) bermuda L 554 (03) cherry red L 553 (04) henna red

Upholstery combination (cloth), standard 54 azure repp. 50 platinum repp. 50 platinum repp.

Upholstery combination (cloth), optional 63 platinum repp.lblack 63 platinum repp.lblack

Upholstery combination (Ieatherette), standard 80 black 78 platinum 78 platinum

Upholstery combination (Ieatherette), optional 80 black 80 black

Upholstery combination (Ieatherette), optional 81 Balearic beige

up to Chassis from Chassis No. 346 147 892 No. 346 147 893

Car finish L 544 (05) roulette green L 582 (06) arcona white L 282 (06) lotus white

Upholstery combination (cloth), standard 50 platinum repp. 51 Teak repp. 51 Teak repp.

Upholstery combination (cloth), optional 63 platinum repp.lblack

Upholstery combination (Jeatherette), standard 78 platinum 79 pigalle 79 pigalle

Upholstery combination (Ieatherette), optional 80 black 80 black 80 black

Upholstery combination (Ieatherette), optional 81 Balearic beige 81 Balearic beige 81 Balearic beige

Car finish L 41 (10) black L 360 (12) sea blue L 560 (24) manila yellow

Upholstery combination (cloth), standard 50 platinum repp. 50 platinum repp. 63 platinum repp.lblack

Upholstery combination (cloth), optional 63 platinum repp.lblack

Upholstery combination (Ieatherette), standard 78 platinum 78 pigalle 80 black

Upholstery combination (Ieatherette), optional 79 pigalle 80 black

Upholstery combination (Ieatherette), optional 80 black

Car finish L 568 (37) sea sand

Upholstery combination (cloth), standard 51 Teak repp.


Upholstery combination (Ieatherette), standard 79 pigalle

Upholstery combination (Ieatherette), optional 80 black

Upholstery combination (Ieatherette), optional 81 Balearic beige

Wheel disc, rim L 41 black; seat frame, gearshift and hand brake lever L 43 grey-black; • Steering column tube: L 43 grey-black - 50, 54, 63, 78, 80, 81; L 672 rust - 51; L 652 scarlet -79 Remark: • see combination

August 1966 up to July 1967, from Chassis No. 347000001 up to 347500000

Car finish L 288 (01) bermuda L 620 (02) savanna beige L 70 K (45) Vulcan grey

Upholstery combination (cloth) 67 blue 66 68 khaki brown 66 68 khaki brown 66

Upholstery combination (Ieatherette) 84 black 74 khaki brown 73 light sand 66


Car finish L 554 (03) cherry red L 50 K (47) Neptune blue L 10K(24) Castilian yellow

Upholstery combination (cloth) 66 platinum 66 66 platinum 66 66 platinum 66

Upholstery combination (Ieatherette) 84 black 84 black 84 black


Car finish L 544 (05) roulette green L 282 (42) lotus white L 41 (10) black

Upholstery combination (cloth) 68 khaki brown 66 68 khaki brown 66

Upholstery combination (Ieatherette) 73 light sand 66 91 Indian red 73 light sand 66

Upholstery combination (Ieatherette) 74 khaki brown 91 Indian red

Wheel disc, rim L 41 black; steering column tube, seat frame, hand brake lever L 43 grey-black

8

_..._-....... '\*.,"'"".''*'''' .............. ~. '-', "...-. ~~ ....... "",",.H ,_'" ...... -.... __ .,... • ...--. .. """q:.,..... "..........,._ ........... ··--r- - ----- -- ','" ,

Color Combinations Karmann Ghia Type 3

from August 1967 - Chassis No. 348000001

Ghia Typ 3·35 9

Model 343-346 . .

August 1967 up to July 1968, from Chassis No. 348 000 001 up to 348500 000

Car finish L 30 K (16) velour red L 041 (10) black L 50 F (23) regatta blue

Upholstery combination (cloth) 10 dogtooth platinum 68 12 dogtooth khaki 68 10 dogtooth platinum 68

Upholstery combination (Ieatherette) 43 bl·ack 68 42 Indian red 68 43 bl·ack 68

Upholstery combination (Ieatherette) 31 light sand 68 31 light sand 68 31 light sand 68

Car finish L 61 K (04) pine green L 70 F (19) chinchilla L 80 K (06) Gobi beige

Upholstery combination (cloth) 12 do'gtooth khaki 68 12 dogtooth khaki 68 12 dogtooth khaki 68

Upholstery combination (Ieatherette) 32 khaki brown 68 32 khaki brown 68 32 khaki brown 68

Upholstery combination (Ieatherette) 31 light sand 68 43 bl'ack 68 43 black 68

Car finish L 28e (42) lotus white L 288 (01) bermuda L 554 (03) cherry red

Upholstery combination (cloth) 10 dogtooth platinum 68 10 dog,tooth platinum 68 10 dogtooth platinum 68

Upholstery combination (Ieatherette) 42 Indian red 68 43 black 68 43 black 68

Upholstery combination (Ieatherette) 43 bl'ack 68 42 Indian red 68 31 I,ight sand 68

Wheel disc, rim L 41 black; steering column tube, seat frame, hand brake lever L 43 grey-black

August 1968 up to July 1969, from Chassis No. 349 000 001 up to 349 500 000

Car finish L 11 K (64) oriole yellow L 31 K (65) sunset L 51 K (66) chrome blue

Upholstery combination (cloth) 10 dogtooth platinum 68 10 dogtooth platinum 68 10 dogtooth platinum 68

Upholstery combination (Ieatherette) 32 khaki brown 68 31 light sand 68 40 black 68

Upholstery combination (Ieatherette) 40 black 68 40 black 68

Car finish L 62 K (69) cypress green L 90 C (63) toga white L 554 (03) cherry red

Upholstery combination (cloth) 12 dogtooth khaki 68 10 dogtooth platinum 68 10 dogtooth platinum 68

Upholstery combination (Ieatherette) 31 light sand 68 40 black 68 31 light sand 68

UphOlstery combination (Ieatherette) 32 khaki brown 68 47 gala red 69 40 black 68

Wheel disc, rim L 41 black; hand brake lever, steering column tube, seat frame L 43 grey-black

10

· . i

1

2

L

MAIN GROUP

FUEL TANK EXHAUST SYSTEM HEATING SYSTEM

55 Heating system

59 Fresh air control

61 Eberspacher Stationary Heater

for all parts not listed

see Parts list Volkswagen 1500

Illustration

1+A1

2

B1

Ohla Typ 3 '0/68 2-1

..;

FUEL TANK MAIN GROUP ~ EXHAUST SymM HeatIng system

HEADNG SYSTEM

~.--

~--

~ "

Genuine VW Parts

rigidly factory inspected

Ghla Typ 3 2-2a

FUEL TANK MAIN GROUP EXHAUST SYSTEM HeaHng system

HEATING SYSTEM

~«

:;;:,-_~ «

Illustration A 1 2-2b

Key Quan-No. Part No. Description tity Type and model

1 311 255103 F

A1 311 255103 E

2 311 255104 F

A 2 311 255104 K

3 N 11 6521

4 N 107101

311255113

311 255117

A3 311 255141 B

A4 311 255142 C

AS N 138361

5 311 255 145

HEATER

Heal exchanger .. left .........••.•.•••...•....• up 10 Engine No. 713 138 up to Engine No. 367 830 the following parts are addilionally required: 311 255357 0 Flexible pipe 311 255113 Adapter ring

1

Heat exthanger front left ........ . from Engine No. 713 139

Heal exchanger, right .•..............•••.•.... up to Engine No. 713 138 up to Engine No. 367 830 the following parts are additionally required: 311 255 358 E Flexible pipe 311 255113 Adapter ring

Heat exchanger, front right ................. .. 'rom Engine No. 713 139 (Seal off carburetor pre-heating opening with 311 255 117 from Engine No. 713 139 up to TO 222 424

Washer 7 .......................•...••••.. 4

Screw, cheese head AM 6 X 10 ..•..•......•••. 4

Adapter ring - Flexible pipe ................•. x

Plug fo.r pre-heater pipe in heat exchanger .•... 1

Heat exchanger rear left ..................... . from Engine No. 713 139

Heat exchanger rear right .................... . from Engine No. 713139

1

Sealing washer C 36X42 .................... . 2

Protection plate - Heat exchanger, left ; ....•••.. 1

Ghla Typ 3-.

Illustration 1+A 1 2-3

~; ,

~. &: ~ .. ',

r ~~-,- ....

~,:: § / .. ~ .. ~-!'1' -.,"-Il. ~; (,

·I~·" .. ~ ,

",.' I !j, ,

it,· t

t. ~, < ' " ~ , )

FUEL TANK MAIN GROUP 4 EXHAUST SYSTEM Key No.

10

11

12

13

A9

A 10

A 11

A 12

A 13

A14

A 15

A 16

A17

HEATER PIPES

Part No. Description

311 255217 A Mounting bracket - Insulation ................ .

311255219 Seal - Heat control box ... " ........... '" ... . up to Chassis No. 345048 101

N 102107 Bolf, hex. head M 6X10 ..................... . up to Chassis No. 349 154 531

N 12 226 2 Spring washer B 6 .......................... .

N 13 9741

311255219 A


Tapping screw, fillister head B 5.5X19 ......... . from Chassis No. 349 154 532

Gasket - Warm air mixing box from Chassis No. 345 048 102

311 255 257 Thermostat ................................. . from Chassis No. 345 048 102

N 111181 Nut, hex. BM 8 ............................. .

311 255259 Flap - Warm air mixer ....................... . from Chassis No. 345 048 102

311 255287 A Elbow - Fresh air duct ...................... . from Chassis No. 345 048 102

N 11 372 3 Tapping screw, cheese head B 3,9X6,5

311 255 291 A Fresh air hose .............................. . from Chassis No. 345 048 102

311 255 295 A Hose retainer ............................... . from Chassis No. 345 048 102

N 107101 Screw, cheese head AM 6X10

A 18 N 11 6521 Washer 7 .................................. .

14 111 255309 B

15 111 255 311

16 N 12 4341

Ghla Typ 3-31

Illustration 1 + A 1

Link - Heating control cable ................. .

Pin - Link ............... " ................. .

Spring washer 4 ............................ .

Heater pipes

Quan- Type and model tlty

4

2

6

6

6

2

2

2

2

2

2

2

2

2

2

2

2

2

2-5

GROUP fl FUEL TANK MAIN EXHAUST SYSTEM Heater pipes HEATER PIPES Key

Part No. Description Quan- Type and model No. tlty

111298101 1 set of mounting components for heater control .. 2 cable up to Chassis No. 346087039

111298101 A set of mounting components for heater control 2 cable from Chassis No. 346 087 040

17 311129777 Swivel pin rear - Heating control cable ......... 2 from Chassis No. 346087 040

18 N 102052 Bolt, hex. head M 5 X 10 ...................... 2 from Chassis No. 346 087 040

311 255317 Elbow, left between fan housing and exhaust muffler from Engine No. 713139

A 19 311255318 Elbow, right between fan housing and exhaust muffler from Engine No. 713 139

19 311 255321 Elbow between fan housing and exhaust muffler 2 up to Engine No. 713 138

311 255327 A Pipe left - Fresh air ........................... from Engine No. 713 139

A 20 311 255328 A Pipe right - Fresh air ........................ 1 from Engine No. 713 139

A 21 N 107101 Screw, cheese head AM 6 X 10 ................ 2

A22 N 11 6521 Washer 7 ................................... 2

A 23 311 255333 Clip - Fresh air pipe ......................... 2 from Engine No. 713 139

20 311 255341 A Clip - Heat exchanger ........................ 2

21 111 501159 B Clip - Elbow ................................ 2

22 311 255353 B Connection hose - Elbow ..................... 2

Illustration 1 + A 1 2-6

-

---

1&1 01 ,.-

Key No. Part No.

311 255355 B

311 255356 B

311 255357 D

311255357 E

23 311 255358 E

311 255359 A

211255359

111 501159 B

24 311 255299 C

25 311 255379 B

26

A24

27

Ghia Typ 3-35


EXHAUSl SysTEM .' ...... -plpes HEATER PIPES

Quan-Description tlty Type and model

Muffler - Heater between engine and heat control 1 box, left up to Chassis No. 282077

Muffler - Heater between engine and heat control box, right up to Chassis No. 282077

Flexible pipe 65 mm dia. between engine ....... 1 and heat control box, left from Chassis No. 282078 up to 345048101

Flexible pipe 65 mm dia. between engine 1 and warm air mixing box, left from Chassis No. 345048 102

Flexible pipe 65 mm dia. between engine and heat control box, right from Chassis No. 282 078

Connection pipe (length 330 mm) - Carburetor .. 1 pre-heating up to Engine No. TO 222 424

Connection pipe (length 900 mm) - Carburetor 1 It pre-heating (shorten 770 mm) from Engine No. TO 222 425

,Retaining clip 44-64 mm dia .................... 2 up to Chassis No. 282 077

Clip - Flexible pipe 65 mm dia. ............... 4 from Chassis No. 282 078

Insulating ring - Heat exchanger ............... 2 up to Engine No. 255 339

no longer available

no longel' avaHable

no longer available

2-7

Key No.

A25

28

-

29

30

31 .

Part No.

311 255411 B

311 255412 B

311 255413

311255421

311255421 B

311255422

311 255422 B

311255455

311255429

343255429 A

343255429 B

311255430

343255430A

343255430 B

343255455 A

,UListration 1 + A 1

Description Quan-tity Type and model

no longer ava+lable

Flange - Heat control box, left ................. 1 up to Chassis No. 345 048 101

Flange - Heat control box, right .............. up to Chassis No. 345 048 101

Adapter - Heating pipe ...... " ................ 2

Insulation - Heating pipe, left ................. up to Chassis No. 282 077

Insulation - Hea.ting pipe, left ................. from Chassis No. 282 078

Insulation - Heating pipe, right ................ 1 up to Chassis No. 282 077

Insulation - Heating pipe, right ................ from Chassis No. 282 07]3

Spring clip - Insulation ....................... 2 up to Chassis No. 282 077

Muffler - Heater, left .......................... up to Chassis No. 106 699

Muffler - Heater, left ......................... 1 from Chassis No. 106 700 up to 221 974

Muffler - Heater, left ......................... from Chassis No. 221 975

Muffler - Heater, right ........................ up to Chassis No.1 06 699

Muffler - Heater, right ....................... 1 from Chassis No. 106 700 up to 221 974

Muffler - Heater, right ........................ from Chassis No. 221 975

Heater pipe - Defroster vent, left and right ..... 2

2-8

'-

... =w:

MAIN GROUP

Key No.

32

33

34

35

36

37

38

39

40

41

42

43

Part No.

343255459

343255509

343255461

N 140591

N 140799

343255515

343255515 A

343255516 A

N 140872

113255529 B

113255541

113255547

311255547

311 255551

311 255563 A

N 174710

143255651

Ghla Typ 3 'D 188

illustration 1 + A 1

FUEL TA.NK EXHA.UST SYSTEM HEATER PIPES

Description

Heater pipe - Defroster vent, center ............. up to Chassis No. 483 592

Heater pipe rear right - Defroster vent, center .... up to Chassis No. 483 592

Heater pipe - Defroster vent, center ............ from Chassis No. 345 000 001

Fastener B 9 galvanized - Hose connection strip ..

Strip - Hose connection C 9 galvanized .........

Heater vent - Foot well heating, rear ........... from Chassis No.1 06700 up to 221 974

Heater vent - Foot well heating, rear, left ........ from Chassis No. 221 975

Heater vent - Foot well heating, rear, right ....... from Chassis No. 221 975

Tapping screw, countersunk raised head ........ B 3.5 X 16 DIN 7983 chromium plated

Flap - Foot well heating, rear .................. from Chassis No. 106700 up to 221 974

Knob - Flap ................................ from Chassis No. 106700 up to 221 974

Spring clip - Flap ............................ from Chassis No. 106700 up to 221974

Cable - Flap ................................ from Chassis No. 221 975

Flap - Foot well heating, rear .................. from Chassis No. 221 975

Spring clip - Flap ............................ from Chassis No. 221 975

Connector DIN 72 586 ...................•....

Deflector - Defroster vent, rear window ..•......

Quan-tity

1

1

2

4

4

2

4

2

2

2

2

2

2

2

1

Heater pipes

Type and model

2-aa

MAIN GROUP FUEL TANK EXHAUST SYSTEM HEATER PIPES

Key No.

44

45

46

A26

47

A27

Part No.

N 11 4561

343255655

311 255719 A

311 255720 A

311255737

311 255961

9161 - 7162

8162 - 7163

8/63 - 10/64

311255961 A

311255962

9161 - 7162

8/62 - 7163

8/63 - 10/64

311 255962 A


Description

Tapping screw, countersunk raised head B 2.9X16 DIN 7973 chromium plated

Heater pipe - Rear window ...................

Insulation - Flexible pipe, left ................. from Chassis No. 221 975

Insulation - Flexible pipe, right ................ from Chassis No. 221 975

no longe'r available

Slide - Heate'r opening, left .................... up to Chassis No. 345 048 101 469 anthracite 043 grey-black 469 anthracite

Slide - Heater opening, left ................... from Chassis No. 345 048 102

Slide - Heater opening, right .................. up to Chassis No. 345 048 101 469 anthracite 043 grey-black 469 anthracite

Slide - Heater opening, right .................. from Chassis No. 345 048 102

Quan-tity

2

1

Heater pipes

Type and model

2-Sb

-----------~---- -~-~~,.---------------------------

Ghla Typ 3

Genuine YW Parts

rigidly faetory inspeeted

2-9

MAIN GROUP FUEL TANK EXHAUST SYSTEM HEATER PIPES

Illustration 2

N r--_~A~ __ ~

:2 1

Fresh air control

y//~---~

...:.-----;:Q

I---------Q

----;::

2-10

"----

'---

au ~

MAIN GROUP -fl FUEL TANK EXHAUST SYSTEM HEATER PIPES

Key No.

2

3

4

5

6

7

8

9

10

11

12

13

14

15

Part No.

343259103 A

343259104 A

N 107021

N 11 5233

N 107221

343259141

311259149 A

343259151 B

N 162151

343259175

343259199

345259199

345259200

343259305 A

N 102123

N122262

343259375

Ghla Typ 3 27/68

Illustration 2

Description

FRESH AIR CONTROL

Fresh ai'r control box,lef.t .....................

Fresh air contro,1 box, right ...................

Screw, cheese head AM 5 X 15 DIN 84 ........

Washer A 5.3 DIN 125 galvanized .............

Screw, oheese head AM 5X35 DIN 84 .........

Grille - Fresh air control box .................

Seal - Fresh air control box ...................

Flap - Fresh air control box 343259103 Al104A

Tubula,r 'rivet AK 3.2x9.3 ......•..............

Cable - Fresh air control ....................

Drain hose ..................................

Drain hose,le.ft .......................•......

Drai,n hose, right ......................•......

Fresh a!i'r ,regulator ...............•.•.........

Bolt, hex. head M 6X12 DIN 933 galvanized ....

Spr,ing washer B 6 DIN 137 galvanized ••• 0 ••••

Escutcheon haU, upper - Fresh air regulator " ... up fo Chass'is No. 64 915

Quan-tity

2

2

4

2

2

2

4

2

2

2

2

Fresh air control

Type and model

343. 344

345.346

345.346

2-11

M,AIN GROUP

Key No.

16

17

18

19

20

Part No.

343259375 A

343259376

343259379

343259379 A

343259380

343259380 A

113853615

Illustration 2

FUEL TANK EXHAUST SYSTEM HEATER PIPES

Description

Escutcheon - Fresh air regulator ............... from Chassis No. 64 916

Escutcheon half, lower - Fresh air regulator up to Chas'sis No. 64 915

Button left - Fresh air regulator ................ from Chassis No. 64 916 up to 345215000

Button - Fresh air regulator .,', ............... from Chassis No. 346000001

Button right - Fresh air regulator ............... from Chassis No. 64 916 up to 345 215000

discontinued superseded by: 343259379 A

Seal - Escutcheon •••••••• 4·· ••••••••• 0 ••••• •

Quan-tity

4

Fresh air control

Type and model

2-12

Ghia Typ 3

Genuine VW Parts

rigidly factory inspected

2 -13

'~

~

-82 %

" ::a 0 C

~-80 'V 37 ('i)-79

81

6 72'---;--

::em "II m>

MAIN GROUP FUEL TANK EXHAUST SYSTEM HEATING SYSTEM

Key No.

1


EBERSPXCHER STATIONARY HEATER

from Chassis No. 345070051 up to 345 220 883

311 261101 A Heater .................................... .

2 311261135 B Hose - Combustion air pipe ................. .

3 311261141 A Heat exchanger ............................ .

4 311 261185 B Sealing ring lower - Exhaust pipe ............ .

5 311261187 Sealing ring upper - Exhaust pipe ............ .

6 343261189 Sealing ring - Exhaust pipe - Spare wheel well ...

7 311 261 317 Casing ..................................... .

8 311 261 323 Terminal ................................... .

9 311 261 325 Bonded rubber mounting .................... .

10 N 11 5244 Washer A 6.4 .............................. .

11 N 12 006 2 Spring washer B 6 .......................... .

12 N110062 Nut, hex. M 6 .............................. .

13 N122262 Spring washer B 6 .......................... .

14 311261 389 A Radial blower wheel ........................ .

15 311 261 395 A Motor locating housing ...................... .

16 311 261 397 A Clip - Motor ............................... .

Ghia Typ 3·30

Illustration B 1

Quan-tity

1

1

1

2

4

2

6

2

Stationary Heater

Type and model

M246

2-15


Key No.

17

Part No.

311 261 399

Description

Clip - Motor locating housing

18 311261 401 A Motor ................................. , ... .

19 311 261 451 B Grommet - Cable .......................... . from Chassis No. 346 120001

20 311 261 453 A Rubber seat - Motor ........................ .

21 311 261 455 Gasket - Motor locating housing .............. .

22 311261457 A Axial blower

23 311 261 465 A Fuel pump ................................. .

24 311261473 A Red bakelite cap - Fuel pump

25 311 261 485 A Diaphragm - Fuel pump ..................... .

26 N 139711 Tapping screw, fillister head B 4.SX22

27 N 154211 Speed nut B 4.S ............................ .

28 341127561 AT-piece - Fuel line .......................... .

29 311 261 491 A Suction line from "V" piece to fuel filter ....... .

30 311941189 Grommet .................................. .

31 311 261 495 Fuel filler .................................. . (use: 311 261 513 Band 147261 509)

32 111209129 Sealing washer - Filter bowl ...............••..

147261 509 Nut, hex. M 12Xl.5 ......................... .

33 311 261 513 B Suction pipe from filter to pump .............. .

34 N 138071 Sealing washer AS X 11.5 .................... .

35 N 21 0551 Union screw - A 2/3 ........................ .

Illustration B 1

Quan-tity

1

1

1

2

1

StaHonary Heater

Type and model

2-16


Key No. Part No. Description

36 311 261 515 Connecting elbow - Pump pressure line ....... .

37 311.261 517 A Pump pressure pipe ......................... .

38 311261 519 Pressure regulator .......................... .

39 311 261 533 Strainer - Pressure regulator .................. .

40 311 261 537 A Hose connection on pressure regulator ........ .

41 311 261 539 B Fuel hose from pressure regulator to jet carrier "

42 311 261 541 A Packing piece under fuel jet .................. .

43 311 261 543 Jet carrier

44 311 261 545 Fuel jet 0.3 ................................. .

45 N 138071 Sealing washer A ax 11.5 .................... .

46 311 261 571 A Thermo switch .............................. .

Quan-tity

1

1

3

47 311 261 575 Quartz bar .................................. 1

48 311 261 581 A Safety switch ................................ 1

49 311 261 595 A

50 311 261 597

51 343261 617

52 N 102154

53 N 115244

54 N122262

Ghla Typ 3 - 31

Illustration B 1

Protective cap .............................. .

Retaining spring - Protective cap 1

Exhaust pipe ............................... .

Bolt, hex. head M 6 X 15

Washer A 6.4 .............................. . 2

Spring washer B 6 .......................... . 2

Stationary Heater

Type and model

2-17


Key No.

55

56

57

58

Part No.

N 11 0062

311261627

343261647

N 102107

Description

Nut hex. M 6 ............................... .

Protective plate - Exhaust pipe ............... .

Combustion air pipe ......................... .

Bolt, hex. head M 6X10 ..................... .

59 N 120062 Lock washer B 6 ............................ .

60 N 11 0062 Nut hex. M 6 ............................... .

61 N 11 3672 Tapping screw, cheese head B 3.5X9.5 ........ .

62 N 11 5211 Washer A 3.7 .............................. .

63 311 261 651 B Hose - Fuel overflow ........................ .

64 311 261 671 Bracket - Fuel filter ......................... .

65 311 261 675 Mounting - Fuel pump ...................... .

66 343261 685 Bracket - Heater ........................... .

67 N 102154 Bolt, hex. head M 6 X 15 ..................... .

68 N 11 5244 Washer A 6.4 .............................. .

69 N 122262 Spring washer B 6 .......................... .

7Q N 11 0062 Nut hex. M 6 ............................... .

71 343261705 Heater pipe, left, with hose .................. .

72 343261706 Heater pipe, right, with hose

73 no longer available

Illustration B 1

Quan-tity

2

1

1

2

4

4

4

4

Stationary Heater

Type and model

2-18


Key No.

74

75


111501157 B Retaining clip 85-103 mm dia ................. .

311261727 Gasket, front - Heater pipe

Quan-tity

2

2

76 N 11 0052 Nut, hex. M 5 ............................... 12

n N 122251 Spring washer B 5 ........................... 12

78 343261731 Gasket, rear - Heater pipe .................... 2

79 N 11 5244 Washer A 6.4 ... '.' . . . .. . . . ... . . . . . . . . . . . .. . . 8

80 N 11 0062 Nut, hex. M 6 ............................... 8

81 343261 743 Grille - Heater pipe, left .................... .

82 343261 747 Air outlet - Heater pipe, right ................ .

83 311 261 995 Instruction cover - Filler cap ................. .

84 111 937 093 A Connectol' with fuse 8 ....................... . (Replace the fuse by N 17 121 5 up to Chassis No. 346 500 000 and by N 17 121 4 from Chassis No. 347000001)

85 N 17121 5 Fuse 25 ................................... .

86 N 171211 Fuse 8 .................................... .

N 17121 4

87 311 963091 B

88 311 963105

89 311 963109

90 311963111

91 311 963113

Ghla Typ 3·31

Illustration B 1

Fuse 16 ................................... .

Heater plug 6 V

Push-pull switch ............................ .

Intermediate piece - Push-pull switch ......... .

Escutcheon - Push-pull switch ................. .

Switch spindle with knob ..................... . 1

Stationary Heater

Type and model

2-19

MAIN GROUP FUEL TANK' EXHAUST SYSTEM HEATING SYSTEM

Key No.

92

93

94

Part No.

311 963129

311963133

N 177221

111 971 511

Illustration B 1

Description

Lens - Knob

Retaining spring - Bulb ...................... .

Bulb J 6 V 1.2 W

Connector ................................. .

Quan-tity

1

1

2

. - ' , !

StatlOnal'y"lIeeter

Type and model

2-20

3

4

5

6

< ,R

7

(' MAIN GROUP

,*",

FRAME HAND LEVER SYSTEM PEDAL CLUSTER

Illustration

05 Frame 3

07 Bumpers 3

for all parts not listed

see Parts list Volkswagen 1500

Ghla Typ 3 27/68 7-1

---

c: !!l. p:; e; 0 :::J

W 64 67 53 19 18 16 17

LJ~~[ r I' 22 5 29

.......

I

r-J

I

63

" 1"r'34~l~LLfll) 2 b

75

(ij)---7

1---8 Q-41

27 G

~ 37{50~ C

40 @o@-42 ~l 39 --, '-43(.-1 I 38 ~ ---' 33 32 30 31

I

86

78

82

,. ~ z Q,.,

0 C ."

'6

'V:Z:""m,...., Oz~~Om nl;;1""

..,.,....... tEVER. St~EM '.. CLUSTER

Key Quan

No. Part No. Description tity Type and model

FRAME

341 700021 Frame without sub-frame ..................... . 343,345 and wHhout sound absorbers up 10 Chassis No. 54 087

the following parts are additionally required:

311 798011 A 1 set of insf,allation parts for hea·ter operation

143255655 A Healer pipe 141 255927 Rubber adaptor 111 701 535 A Bracket - Accelerator pedal 113 721205 L Push rod N 123291 Lock plate 113 721 305 B Shaft - Clutch peda!1 343805350 Heate'r flange 4'11 857781 Escutcheon (043)

Safety belt mounting 111857785 Cover bush (043) - 2

Safely belt moun1ing

343 700021 N Frame without sub-frame and without sound .... 1 M 249: 343, 345 absorbers from Chassis No. 348000001 up to 348 500 000

343700027 Frame wilhout sub-f.rame .. . . . . . . . . . . . . . . . . . . . . 343, 345 and willhoul sound abso·rbers fram Chassis No. 54 088

additionally required are:

up to Chassis No. 483 592 143255 655 A Heate'r pipe 1 141 255927 Rubber adaptor 2 111 701 535 A Bracket - Accelerator pedal ~ 1 113721 205 L Pushrod 1 113721 305 B Shaft - Clutch pedal 1 343 805 350 Heater flange 2 N 12 329 1 Lock plale 1 411 857 781 EscUlkheon (043) - 2

Safely belt mounting 111 857 785 Cover bush (043) - 2

Safety belt mounting

from Chassis No. 345 000001 up to 346 500 000 311 798011 A 1 seat of installation parts

for heal'er operation up to Chassis No. 347 500000

311 711 251 Cover plate


311 201 221 E/235 AIN 20357 11

111 209189 B/315 127521 A

Ghla Typ 3 - 35

Illustration 3

Key Quan-No. Part No. Description tlty Type and model

'--./

344 700027 Frame without sub-frame and without sound ••... 1 344. 346 absorbers '(RHO) from Cna'Ssis No. 54 088 additionally required are: up to Chassis No. 483 592 143255655 A Heaier pi'Pe 1 141 255927 Rubber adaptor 2 111701535 A Bracket - Accelerator pedal 1 113 721205 L Push,roci 1 112721315A Pedal- Clutch 1 343805350 Heater flange 2 N 123291 Lock plate 1 411 857781 EscUitcheon (043) 2

Safety belt mounting 111857785 Cover bush (043) 2

Safety belt mounting from Chassis No. 345 000 001 up to 346500 000 311798011 A 1 seat of installation parts

for healer operation up to Chassis No. 347 500 000 311 711 251 Cover plate f'rom Chassis No. 348 000 001 up to 348 500 000 M 249: 344. 346

from Chassis No. 348000 001 3'11 201 221 E/235 AiN 20357 1/ 111 209 189 B/315 127 521 A

2 3617000410 Sub.frame 0; ,. 5 • ~ •• ,. •• " " ,. " .. 0; 0; .............................. up to Chassis No. 348 500 000

311 700 041 0 Sub-frame ......................... ~ ................................. f·rom Chassis No. 348 000 001 up to 348 500 000 M249 from Chassis No. 349000001

3 N 144991 Stud AM 10 BX28 .......................... 2

111 701 309 Water drain valve - Tunnel plate ...... , ....... ' 1 'from Chassis No. 347 000001

311705127 Threaded plate Safety belt mounting ...•....•. 2 M2S9 on floor plate from Chassis No. 466 250

311701449 Threaded plate - Safety belt mounting .......... 2 M259 on floor plate up to Chassis No. 466249

311705037 ,Frame head ................................. 343.345

312 70S 037 Frame head (RHO) ....................•...... 1 344.346

'. 4 311 70S OS7 Floor plate, left ...........••.•....•..••.....• 343.345

312705057 Floor plate, ,left ,(RHO) ........................ 1 344.346

5 311 70S 058 Floor plate, right .........•..........•....... 1 343.345

312705 058 Floor plate, right (RHO) ....................... 1 344.346

'-"'"

Illustration 3 7-4

FRAME MAIN GROUP HAND LEVER SYSTEM Frame

PEDAL CLUSTER


6

7

8

9

10

11

12

13

14

15

16

17

18

19

311705221

311 705 221 A

N 122262

N 102101

311 705 237 B

N 12 231 1

311705246

N 100232

311705243

N 120102

N 100631

311705253

311 705253 A

311705257

311 705257 A

N 122262

N 10 212 3

Cover plate - Master cylinder ............... . up to Chassis No. 346 500 000

1

Cover plate Master cylinder ................. from Chassis No. 347 000 001

1

Spring washer B 6 DIN 137 galvanized ......... . 2

Bolt, hex. head M 6X10 DIN 933 galvanized ..... 2

Bracket Front axle ...................•...•.. 2

Spring washer A 10 DIN 137 ................ . 4

Packing - Front axle bracket mounting ......... . 4

Bolt, hex. head M 10X45/25 DIN 70613 ..•...... galvanized

4

Spacer - Front axle mount,jng 2

Lock washer B 10 DIN 127 galvanized ........ . 2

Bolt. hex. head M 10X30 DIN 70614 .......•... 2

Cover Frame head ........................•• up to Chassis No. 346 116999

Cover Frame head ......................... . from Chassis No. 346 117 000

1

Gasket Frame head cover .............•..... up to Chassis No. 346 116999

1

Gasket Frame head cover .............•..... from Chassis No. 346 117 000

1

Splling was:her B 6 DIN 137 galvanized ....... . 2

Bolt. hex. head M 6 X 12 DIN 933 galvanized .... 2

Ghla Typ 3 25/88

Illustration 3 7-5

FRAME. HAND LEVER SYSTEM Fr.... PEDAL CLUSTER

MAIM GROUP


20

21

22

23

24

25

26

27

28

29

30

31

32

33

111 701 255 B

111701259 A

111 701 263

311 705261 A

311705263

311705263 A

311705264

311705345

111 701 415

311 705431

341705441

341705442

311 705445 A

311705449

N139583

N 12131 2

341705453

341705454

311705469

311 827181

Guide Gears'hift rod ...................... .

Bush - Gearshift rod guide

Retaining ring - Bush .......•••••••••••••••••

Rubber collar, upper Front axle ............. . 2

Rubber collar, lower Front axle up to Chassis No. 347 181 001

2

Rubber collar, lower, left Front axle from Chassis No. 347 181 002

1

Rubber collar, lower, right - Front axle from Chassis No. 347181 002

1

Boot - Cable guide ......................... . 1

Bolt - Battery mounting 1

Socket - Jack .............................. . 2

Runners - Front seat, left ..................... . from Chassis No. 54 088

Runners - Front seat, right from Chassis No. 54 088

1

Cover plate Shift rod coupling .............. . 1

Gasket - Cover plate 1

Tapping screw, B 3.5X13 DIN 7981 galvanized ... 3

Shake-proof washer J 3.7 DIN 6797 galvanized ... 3

Runner, outer - F'ront seat, left up to Chassis No. 54087

1

Runner, outer - Front seat, right ............•.. up to Chassis No. 54 087

1

Retaining clamp - Plastic battery .......•....... from Chassis No. 347000 001

Washer 8.3 ........................•...•..... from Chassis No. 347000001

illustration 3 7-6

Key QuanPart No. Description Type and modelNo. tity

N 11 0083

343705481 A

34 343705481 C

35 111 701 495 A

36 111701 535 A

37 311705679

38 N 102383

39 N 120082

40 N 11 5262

41 311705683

42 N120102

43 N 102524

44 311 705 687

45 311 705 689

46 311 705 691

47 311 705695

48 N 104451

49 N 120102

50 311 705 761 A

51 311705901 A

52 111701625

Nut hex. M 8 ................•.......•.....•. 1

Kick plate ...............•...•...........•.•. 1 up to Chassis No. 346 500 000

Kick plate ..........•.................••..••• 1 from Chassis No. 347 000 001

Retaining cap Floor mat ................... . 8

Bracket for accelerator pedal on Moor plate .... 1

Reinforcement plate Sub-frame mounting, front 1

BOIIt, hex. head M 8X 15 .................... . 4

Lock washer B 8 4

Washer B 8.4 4

Rubber bush Sub-frame mounting, front ..... 2

Lock washer B 10 ........................... .

Bolt, hex. head M 10X20 ................... .

Rubber bush - Sub-frame mounting, rear •...••• 2

Thrust ring - Sub-frame mounting, rear ••••..... 2

Spacer sleeve Sub-frame mounting, rear ...... . 2

Washer - Sub-frame mounting, rear....... ••• •• 2

BOllf, hex. head M 10X45 ..................... 2

Lock washer B10 ..... . . . .• . . . . . . . . . . . . . . . . . . 2

Rub!;>er washer - Reinforcement plate ••••..•••• 4

Weatherstrip between body and frame ••••.•••.

Tack ..•.....................•.....•.••..••. x

Ghla T,yp 3-35

Illustration 3 7-7

," .!

- '," -..(..

• Key QuenPart No. Description Type and model No. tity

BUMPERS

53 343707109 Bumper - Front, center palrl ........•.......... 1

54 343707113 Bumber - Front, outer part, left ...........•••.•.

55 343707114 Bumper - Front; outer part, right .......••••••••

56 343707127 Bracket - Horn, left ...•............•••.•.....


343707128 Bracket - Horn, right ........................ . 1


57 113707191 C Screw M aX:15 Bumper .................... . 4

58 N 12 228 2 Sp.ring wltther B a .......................... . 4

59 N 11 0083 Nut, hex. M a .............................. . 4

60 343707 135 Bracket - Bumper (front) .....•.......•.••••••. 2

61 N 102383 Bol1, hex. head M aX15 ................... .. 2

62 N 122282 Spring wa5ner B a .......................... . 2

63 343 707 137 Cover - Bumber bracket, front ........•.••..•••• 2

64 343 707 155 A Overrider - Bumper (front left) ............... . 1

343707156 A Overrider - Bumper (front right) ..•.•........•• 1

65 N 122282 Spring wa.sner B a ........................... . 2

66 N 103701 Boll, hex. head BM aX70 .............•....... 2

67 141707241 B Beading - Overrider, front .....•.......•.•...•• 4

68 N 102392 Bolt, hex. head M aXla ...•.................. 4

69 N122282 Spring washer B a .......................... . 4

70 141 707253 Rubber cushion, front (shorten to 20 mm) •....... 2

71 . N 103354 BoH, hex. head M 8 X 35 .................... . 2

72 N 11 6701 Washer 8.1 ............••.....•...•..•••.... 2

Illustration 3 7-8

• 0

.':cF~,,:i,,;{~. , .7",;t;..~,~~~~ _ '.<

',t '"

';~ , " , " ~:;~trs, ",

Key No. Part No. , Description

Quantity Type and model

73

74

7S

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

343 707 309

343707313 A

34a 707 314 A

113 707191 C

N 122282

N110083

343 707 335

N 102383

N122282

343707337 A

343707355 A

343707356 A

N 122282

N 103701

141707241 B

N102404

N 122282

141 707253

N 103354

N 116701

Bumper - Rear, center part , ..............•.•.• 1

Bumper - Rear, outer part, left ..............•.. 1

Bumper - Rear, outer part, right ......•........ 1

Screw M 8X 15 - Bumper .................... . 4

Sprlhlg walSher '8 8 4

Nut, hex. M 8 4

Bracket - Bumper, rear 2

Boll'!, hex. head M 8 X 15 ................... .. 2

Spr!fng w'asher B 8 .......................... . 2

Cover - Bumper bracket, rear 26 ...... '" .. ~ ..... " • " " ~ ....

Ovel'rider - Bumper, rear left ..................

Overrider - Bumper, rear right ........ ., ............... 1

Spring wa,sher '8 8 .............. * ......... 5 ~ " 2~ .... " '5

BoIl~, hex. head 8M 8 X 70 .. '................... 2

................ ...... 'O 'OBeading - Overrider 'O ....... ..... 4

Bol!t, hex. head M 8X20 ...................... 4

Sprin9 washer B 8 .. * •• * .............. • * ~ .. ........... 4~ a•

Rubber cushion, rear (shorten to 20 mm) .•...... 2

BO'lt, hex. head M 8X35 .................... . 2

Washer 8.1 ....................•.......•..... 2

",-" Ghia Typ 3-35

. Illustration 3 7-9

,

MAIN GROUP

BODY

Illustration

01 Side member 4

05 Front portion 4

...

09 Side panel 4

13 Rear portion 4

17 Roof 4

21 Mud flaps

23 Front hood 5

27 Rear hood 5

99 Body to chassis securing parts 5

31 Doors 6

37 Door components 6

45 Window glasses and weatherstrips 7

47 Quarter window parts 7

53 Moldings 8

57 Instrument panel fiffings, rear view mirror 9

63 Front panel lining and floor covering 10

67 Interior trim 10

77 Sliding roof 11

81 Front seat 12

1285 Emergency seat

99 Body to chassis securing paris

C')

w Ghla Typ 3 27168 8-1---------~.'"-.--.

Genuine YW Part.

rigidly faetory in.peeted

Ghla Typ 3 8-3

. MAIN GROUP BODY Body bare·

illustratIon 4 8-4

--~ ~

,c

,..,.,.. '''i'''~~

MAIN GROUP 4 BODY

8 28

23 24

22_~

25 ~================~~.

7 16 3 2 5

Illustration 4

34

80dybare

77

80

52 35

/' -----:----! 37

30

56

~-.L..J'----73

76

64

34

29 40 41

36 51 50 44

8-4

345800401

345800401 A

345800401 B

Ghla Typ 3-35

Illustration 4

Description

BODY

Body bare, prime coated .................................. up to Chassis No. 221974

Body bare, prime coated ...................... from Chassis No. 221 975 up to 483 592

Body ba're, prime coated ...................... from Chassi~ No. 345000 001

9aantHy Type and model

1 345

1 345

1 345

"

";. I

Qu8n-. Part No: D~scription tity Type and modE!!

1 343801045 A

343801046 A

1 343 801 04}

343801048

>, ,

;. 3 343801049 A

4 343801050 A

5 343801 131

343801132'

.~

343805019

344 80S 019

". 343805051 E

6 343805 051 F

SIDE MEMBER

Side member, inner left ..........•.........•.. 1

Side member, inner right •...•........ : ••.•....

Side member, outer left .....••..•..••.•.•••...

Side member, outer right ..••••...•.•...•...... 1

Side member, front, left • ~ ~ ................... 9 ... ,.

Side member, front, right .............. ,. ........ 1

Reinforcement - Side member, left, •••.•.•..•••. with warm air duct

1

Reinforcement - Side member, right, •..••....... with warm air duct

FRONT PORTION

Panel, outer - Front portion 1

Panel, outer - Front portion 1

Instrument panel ........••........•...••.•••. up to Chassis No. 347500000

Instrument panel •••••••••.....••.••••.....•.. from Chassis No. 348 000 001

1

343,345

344,346

343. 345

343,345

344 805 051 Instrument panel (RHD) ...............•.••.... 1 344. 346 up to Chassis No. 423 139

illustration 4 8-6

.'"

_ ww; '_¥

MAIM GROUP BODY Front portion


344 805 051 A Instrument panel (RHO) ...................... . 344.346

from Chassis No. 423140 up to 345020907

344 805051 C Instrument panel (RHO) ...................... . 344. 346

from Chassis No. 345 020 908 up to 346 500 000

344 805 051 0 Instrument panel (RHO) ...................... . 344, 346


344 805 051 E Instrument panel (RHO) ......................• 344, 346


7 343805071 C Wheel housing, inner, front, left .............. . 1


8 343805072 B Wheel housing, inner, front, right ..•..........•. 1

9 343805095 Frame - Windshield, outer ....•....•..........• 1 343, 345

344805095 Frame Windshield, outer ..................•• 344, 346

10 343805111 Frame Windshield, inner ................... . 1 343. 344

345805111 Frame - Windshield, inner ................... . 1 345, 346

111805169 C Clinch bolt - Hinge, outer..... ... ...... ... .... 1

111805170 A Clinch bolt - Hinge, inner.................... 1

11 343 805 341 A Hinge pillar, left ............................ . 1

343805342 Hinge pillar, right ........................... .

up to Chassis No. 346 500 000

343805342 A Hinge pillar, right ............................ 1


12 343805345 A Cover plate Hinge pillar, left 1

343805346 Cover plate Hinge pillar, right .............. . 1


343805346 A Cover plate - Hinge pillar, right


Ghia Trp 3 27/68

Illustration 4 8-7

BODY Front portion MAIN GROUP


343805350 Heater flange - Hinge pillar ................... 2

13 343805391 B Carrier - Spare wheel well ....•...........•... 1

14 343805395 A Well - Spare wheel .............•..•...•..... 1

N 139583 Tapping 'Screw, fillister head B 3.5X 13 DIN 7981 .. 8

galvanized


N 122241 Spring washer S 4 DIN 137 .................... 8


N 102052 Bolt, hex. head M 5 X 10 DIN 933 galvanized .... 8


N 122251 Spring washer B 5 DIN 137 galvanized .......... 8


N 115233 Washer A 5.3 DIN 125 galvanized .............. 8


343805405 A luggage compartment, front ................... 1 343.345


15 343805405 B luggage compartment, front ......•....•...... 1 343,345


343805405 C lugagge compartment well ................... 1 343. 345


344805405 luggage compartment, front (RHO) ............ .... 344.346


~

344805405 A luggage compartment, front (RHO) .................... 344. 346

from Chassis No. 345 000001 up to 347 500 000

344 805 405 B luggage compartment, front (RHO) ...••....•.. ~ 1 344. 346


344 805 405 C luggage compartment well (RHO) .............. 1 344:346


343805451 Cross panel, front ............................ 1 343


343805451 A Cross panel. Nont ..................... '....... 343.345


16 343805451 B Cross panel, front ............................ 343, 345


344 805 451 Cross panel, front (RHO) ...................... 1 344,346


Illustration 4 8-8

BODY Front portionMAIN GROUP·' Side panel Key Quan-

No. Part No. Description tity Type and model

344805451 A Cross panel, front (RHO) .••.••..••...........• from Chassis No. 348 000 001

1 344.346

17 343805509 A Panel Spare wheel compartment ..............

18 343805513 Rubber buffer Panel ........................ 2

19 N 107191 Screw, cheese head AM 6X20 ............... 2

20 343805565 Lock carrier - Front lid •..............•....•..

21 343805591 B Front panel ..................................

22 343805641 Conduit tube - Front lid lock cable ••.•........• up to Chassis No. 347 156379

343823549 Conduit tube 1390 mm - Front lid lock cable .•.. from Chassis No. 347 156380 up to 348500000

1

141 823547 Sleeve Guide tube ..•.•......•...•.•.•••••• from Chassis No. 347 156 380 up to 348 500 000

1

412823557 A Guide tube 2940 mm F'ront hood lock cable •... from Chassis No. 349000 001 (for model 343, 345 shorten to 2070 mm) '(for model 344, 346 shorten to 1610 mm)

23 343805657 Cover Front panel .......................... from Chassis No. 345031 101

1

24 343805659 Seal - Support ........... " .................... from Chassis No. 345031 101

1

25 141 805753 A Rubber seal, lenght 940 mm, .................. side panel to wheel housing

X

26 343805761 Seal- Spare wheel well ..........•.•.••••••••.

SIDE PANEL

27 343 809 021 Side panel, left .. ~ ... ~ ....................................... " ... " 1

28 343809022 Side panel, right ........................ " ....

019 Plastic sealing strip - Side panel ................ X

N 13 9741 Tapping screw, fillisfer head B 5.5X19 .......... 12

Ghia Typ 3·30

Illustration 4 8-9

BODY Side panelMAIN GROUP


29

30

31

32

33

34

35

36

37

38

39

40

41

N 122262

N 116952

343809087

343809088

343809145 A

343809153

111 809371 B

343809395 A

343809396 A

343809405 C

343 809 406 C

343809451

343809452

141809631

141809633

N 122251

N 11 0052

Spring washer B 6 12

Washer 6.1 ................................ . 4

Quarter panel, left ........•.••..•..•..•.•••.. 1

Quarter panel, right ......................... .

Headlamp housing ••.•............•.•.••..... 2

Fog lamp housing ...........••••..•....••... 2

Bracket Jack .............•.......•••...... 1

Door lock pillar, left ..........•••••.........•• 1

Door lock pillar, right ...................•.....

Quarter panel, inner, left ..•........•.•..•..... 1

Quarter panel, inner, right ........•............ 1

Support, left - Emergency seat ............•...

Support, right Emergency seat ..•••.••..•...• 1

Inspection cover, outer - Torsion bar ......... . 2

Inspection cover, inner - Torsion bar .......... . 2

Spring washer B 5 .......................... . 2

Nut, hex. M 5 ............................. . 2

Illustration 4 8-10

BODY Real portion MAIN GROUP


42 343813073 A

361813073 E

43 343813 074 A

361813074 E

44

45

343813075 A

343813076 A

343813101

343813101 A

46 343813 101 B

N 10212 3

N 122262

N 11 0062

343813107

REAR PORTIOM

Support, left Body mounting, rear on sub-frame from Chassis No. 348 000 001

1

Support, left - Body mounting, rear on sub-frame up to Chassis No. 347 500 000

1

Support, right - Body mounting, rear on sub-frame from Chassis No. 348000001

1

Support, right - Body mounting, rear on sub-frame up to Chassis No. 347 500 000

1

Wheel housing, rear, outer, left ................ 1

Wheel housing, rear, outer, right ............... 1

Cross reinforcement and support, front Emergency seat up to Chassis No. 106 699

Cross reinforcement and support, front Emergency seat from Chassis No. 106700 up to 221 974

Cross reinforcement and support, front Emergency seat from Chassis No. 221 975

Bolt, hex. head M 6 X 12 ......................

Spring washer B 6 ........................... 10

Nut, hex. M 6 ............................... 10

Support, rear - Emergency seat "' ., ;0 ........... .... ..... up to Chassis No. 347 500 000

........

........

. .. ... 1~ ~

10

343813107 A Support, rear - Emergency seat ..............•. from Chassis No. 348000 001

Ghla Typ 3-31

illustration 4 8-11

47

MAIN GROUP BODY

Key No.

48

49

50

51

52

53

54

55

56

57

58

Part No.

343813111 A

343813111 C

311 813 103 A

343813123

343813124

343813127

343813 131

311813133A

311 813151 D

343 813 161

343813161 B

343813161 C

343813 162

343813 162 C

311 813 191

311813192

311 813 223

311813223A

Illustration 4

Description

Floor plate - Luggage compartment, rear ........ up to Chassis No. 345048 101

Floor plate - Luggage compartment, rear from Chassis No. 345 048 102

Reinforcement, center for luggage compartment .. floor

Abutment plate between wheel hOllS'ing, outer and quarter panel, left

Abutment plate between wheel housing, outer and quarter panel, right

Rubber seal 280 mm - Abutment plate .........

Frame outer - Rear window ...................

Seal - Engine compartment lid ................

Cover plate - Engine, front ....................

Cover plate, left - Engine compartment ......... up to Chassis No. 221 974

Cover plate, left - Engine compartment ......... up to Chassis No. 347 500 000

Cover plate, left - Engine compartment ......... from Chassis No. 348 000 001

Cover plate, right - Engine compartment up to Chassis No. 221 974

Cover plate, right - Engine compartment from Chassis No. 221 975

Screen plate - Luggage compartment floor plate, left

Screen plate - Luggage compartment floor plate, right

Lid with insulation - Engine compartment up to Chassis No. 282 077

Lid with insulation - Engine compartment from Chassis No. 282078

Quan-tity

2

Rear portion

Type and model

8-12

BODY Rear portionMAIM GROUP

Key Quan~

No. Part No. Description tlty Type and model

59 311 813295

60 311813297

343 813 301 C

61 343 813 301 D

62 343813313

N 102123

N 122262

63 343813345

64 343813 369 A

343813370 A

65 343813411

66 343813421

67 343813425

68 343813427

69 343813435

70 343813 436

71 N 11 5551

72 N113672

73 311 813453

74 343813 651

Lock - Engine compartment lid ............... . 2

Retaining plate - Lock 2

Rear apron ......•••........••....••..•..... 1


Rear apron .............•.................... 1

from Chassis No. 349000001

OU filler neck .............................. .

Bolt, hex. head M 6 X 12 DIN 933 galvanized .•... 2

Spring washer B 6 DIN 137 galvanized ......... . 2

Cr,oss panel, rear ............................ . 1

Water drain, rear, left ...•..............••..•.

Water drain, rear, right ...................... .

Air deflector plate. rear ........•.............

Water drain plate - Air deflector plate, rear ....•. 1

Drain hose Oil filler neck .................. .

Protective grille - Water drain .............. . 2

Protective grille left Water drain plate ....... .

Protective grille right - Water drain plate ...... .

Washer 4.3 DIN 433 ......................... . 5

Tapping screw, cheese head B3.SX9.5 DIN 7971 5

galvanized

Rubber ring - Oil filler neck ................•.. 1

Parcel shelf. rear ...........................••

Ghla Typ 3 '0/68

Illustration 4 8-12a

BODY Rear portion Roof

MAIN GROUP


75 311813789 A Catch - Lock . ~ .............. ~ .......... " " " ...................... 2

343813797 Plug - Luggage compartment floor ...••........ from Chassis No. 347080749

2

76 343813991

343813995

N 142331

Bracket - Licence plate .......................

Packing - Bracket ...•......•..•.....•...•...•

Screw countersunk AM 6X25 DIN 7987 galvanized

1

2

2

ROOF

77

78

79

80

343817021

345817021

343817159

345817161

343817535

345817535

343817536

345817536

Roof .............. " .............................................. " ........

Roof (sliding roof) .....................................................

Frame inner - Rear window ....................

Cross member - Sliding roof ........... " ........... "" ....

Frame - Roof, left .................•........•.

Frame Roof, left ...........•.......•,.......•

Frame - Roof, right ...••.............••..•....

Frame - Roof, right .....•...•...•.............

1

1

1

1

1

343.344

345,346

345. 346

343,344

345. 346

343, 344

345, 346

illustration 4 8-12b

Genuine JlW Parts

rigidly faetory inspeeted

Ghla Typ 3 8-13

2_I 11 17 j ~~9 18~ ~3 21_' 1'W ~i . \ 620~: I I ~I -; 19 /' 5 "..-----'----./ !1P 4 10 @12~~r§fj::::=--25 ~.---13~ @ ..;!!!£~~~""""""""""""""""""~=#@_ 24 &7 14~,~1I~1OIII@ 23~.,,- -16 28~ '."" . 15

22

~e\51_~

53_8 J c 54_® /J @ @ ::==i it;\I

26 57 58 60 61 59

27

29

46

~ - ~~==!60_~ 70_@ ~= 61_~ 68_9

62~ ~(~963_. 66_* 65-*

64---' 50 33

~

30

T

E ~

~ ~ 0''"

CD .... "'"

l: ~

z

~ " 0 C

,. 'V ! 1:1 -<

~

I49 .J.• ~-48 0

g.

~ §!i. if11

BODY Mud ..aps . Front hoodMAIN GROUP


343821805

141821805 B

343821 805 A

141821805 C

343821811

1 141 821 811 B

343821811 A

141 821 811 C

343821812

141 821 812 B

343821812 A

141821812 C

2 343823031

343823301

3 343823301 A

343823302

4 N 102392

5 N 122282

MUD FLAPS

1 set of mud flaps black with brackets .••....... up to Chassis No. 346500000

1

1 set of mud flaps black with brackets .......... from Chassis No. 347000001

1

1 set of mud flaps white with brackets .......... up to Chassis No. 346 500 000

1

1 set of mud flaps white with brackets ...•...... from Chassis No. 347 000 001

Mud flap, left black with bracket ............... up to Chassis No. 346 500 000

1

Mud flap, left black with bracket ............... from Chassis No. 347 000 001

1

Mud flap, left white with bracket ........•...... up to Chassis No. 346500000

1

Mud flap, left white with bracket ............... 1 from Chassis No. 347000001

Mud flap, right black with bracket up to Chassis No. 346 500 000

Mud flap, right black with bracket from Chassis No. 347 000 001

Mud flap, right white with bracket up to Chassis No. 346 500 000

Mud flap, right white with bracket from Chassis No. 347 000 001

FRONT HOOD

Hood, fron,t .................................

Hood hinge .......•.......•..•.•.•••..•.•.•• 2 up to Chassis No. 348003 627

Hood hinge, left ............................. 1 from Chassis No. 348 003 628

Hood hinge, right ......................•••... 1 from Chassis No. 348 003 628

Bolt, hex. head M 8X18 DIN 933 ............... 4

Spring washer B 8 DIN 137 galvanized .......... 4

M74

M74

M74

M74

M74

M 74

...... ,. .......

....... ,. ........

.............

............... ,. .... 1

1

Ghia Typ 3 27/68

Illustration 5 8-15

BODY Front hoodMAIN GROUP

Key QuanPart No. Description Type and model No. tity

6 343823331 Spring Hood, front ........................ . 2

DIN 7988 chromium plated

DIN 7973 chromium plated

7 N 102711 Bolt, hex. head M ax 70 DIN 933 ............. . 2

8 N 11 5262 Washer B 8.4 DIN 125 high-polish galvanized ... 2

343823345 Bolt - Hood hinge ......................... . 2


9 343 823 345 A Bolt - Hood hinge .......................... . 2


10 N 124081 Lockring 8xO.8 DIN 471 ...........•.......... 4

11 141837491 Rubber stop - Hood hinge 2

12 343823485 Catch - Front hood .......•..............••.. 1

13 N 142761 Screw, countersunk raised head AM 6x 12 ..... . 2

14 343823491 Deflector - Hook ..............•...•.•....•.

15 343831 741 Washer 3, countersunk ........•..•........... 2

16 N 11 4561 Tapping screw, countersunk raised head B 2.9X16 2

17 343823503 Spacer Lock ca~rjer with pin ................ . 1

18 343823507 Lock pin carrier Hood lock ................. . 1

19 N 102154 Bolt, hex. head M 6X 15 DIN 933 galvanized .... 2

20 N 122262 Spring washer B 6 DIN 137 galvanized ......... . 2

21 N 116952 Washer 6.1 galvall!ized ...................... . 2

22 343823509 Lock - Panel ............................... .

23 N 116952 Washer 6.1 galvan1ized ......................• 4

24 N 122262 Spring washer B 6 DIN 137 galvanized ......... . 4

25 N102123 Bolt, hex. head M 6 X 12 DIN 933 galvanized ...• 4

illustration 5 8-16

BODY Front hood Rear hood

MAIN GROUP

Key OuanPart No. Description Type and model No. tity

26 343823531 A

343823531 B

N 13 3302

343823 549

141823547

412823557 A

27

28

411 823665

343823703

343823715

313 877 233 C

29

30

31

32

33

34

343827025 A

343827071

N 11 3672

141 871 749

343 827081 A

343823301

343 823 301 A

343823302

Cable - Front hood lock (length 1690 mm) up to Chassis No. 348500 000

..... 1

Cable Front hood lock 2170 mm ............. from Chassis No. 349000001 (for model 344, 346 short

Date post:	25-Aug-2020
Category:	Documents
Upload:	others
View:	5 times
Download:	0 times

.. Parts List Karmann...Karmann Ghia Type 3 / No longer available: superseded by: 311 2551al no...

Documents