Date post: | 07-Nov-2015 |
Category: |
Documents |
Upload: | zilfianaelzhar |
View: | 54 times |
Download: | 4 times |
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 1 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
WRITTEN PRACTICE FOR QUALIFICATION &
CERTIFICATION OF NDE PERSONNEL
DOCUMENT : VPS - WP - 01 REVISION NO. : 00
Prepared by Reviewed by Reviewed and Approved by
Name : Eldi Misroza Name : Alamsyah Name : Adi Padmo
Position : Operation Manager Position : General Manager Position : ASNT NDT LEVEL III
Cert. No. 126596
Date : 31 May, 2013 Date : 31 May, 2013 Date : 31 May, 2013
TonnyStamp
TonnyStamp
TonnyStamp
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 2 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
SUMMARY OF REVISION SHEET
This page is a record of all revisions of the written practice and the following revision (s) has (have) been
made to this written practice.
REV.
DATE
PAGE
BRIEF OF REVISION
00 31 May, 2013 All pages First Issue
-
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 3 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
Daftar Isi / Table of Content Par. Uraian Par. Description Page
1 Tujuan 1 Purpose 4
2 Ruang Lingkup 2 Scope 4
3 Reference Documen 3 Reference Documents 4
4 Definisi Definisi 4 Definitions 4
5 Tingkat Kualifikasi dan Tanggung
Jawab
5 Levels of Qualification and
Responsibility
6
6 Persyaratan Pendidikan, Training
dan Pengalaman
6 Education, Training and
Experience Requirements
7
7 Program Pelatihan 7 Training Program 9
8 Pengujian 8 Examinations 10
8.1 Administrasi dan penilaian 8.1 Administration and Grading 10
8.2 Pengujian Penglihatan 8.2 Vision Acuity Examination 11
8.3 Rincian dari Pengujian 8.3 Detail of Examinations 11
8.3.1 Ujian General Level I dan Level II
(tertulis)
8.3.1 General Examination Level I and
II (written )
11
8.3.2 Ujian Spesifik Examination Level I
dan Level II (Tertulis)
8.3.2 Specific Examination Level I and
Level II ( Written )
12
8.3.3 Ujian Praktek Level I dan Level II
8.3.3 Practical Examination Level I &
Level II
12
8.3.4 Pengujian untuk Level III 8.3.4 Examination for Level III 12
8.4 Ujian - ulang 8.4 Re-examination 13
9 Sertifikasi 9 Certification 14
10 Technical Performance Evaluation
10 Technical Performance
Evaluation
15
11 Interupsi Pelaksanaan 11 Interrupted Service 15
12 Re-sertifikasi 12 Re-certification 16
13 Pemutusan 13 Termination 16
14 Pembaruan 14 Reinstatement 17
Table 1A Initial Training and Experinces
Table 1A Initial Training and Experinces
18
Table 1B Training Awal dan Pengalaman untuk NDT Level II
Limited Certification
Table 1B - Initial Training and
Experience Level for NDT
Level II Limited Certification
19
Table II - Jumlah Minimum
Pertanyaan Ujian
Table II - Minimum Number of
Examination Questions
19
Exhibit - A - Eye Examination
Record
Exhibit - A - Eye Examination
Record
20
Exhibit B NDE Personnel Certificate
Exhibit B NDE Personnel Certificate
21
Exhibit C Training Course Syllabus
Exhibit C Training Course Syllabus
22 ~ 28
Shade Gray chart Shade Gray chart 29
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 4 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
1 Tujuan 1 Purpose
a. Written practice ini menetapkan cara
mengontrol dan persyaratan administrasi
untuk kualifikasi dan sertifikasi personnel
NDE. Semua level personnel dalam NDE
harus dikualifikasi dengan written practice
ini.
a. This written practice establishes the
control and administrative requirements
for the qualification and certification of
NDE personnel. All levels of NDE
personnel shall be qualified in accordance
with this written practice.
b. Procedure ini terdiri dari versi Enggris dan
Indonesia, jika ada konflik antara keduanya
maka versi Enggris yang dipakai.
b. This procedure consists of English and
Indonesian versions, shall there is conflict
between these versions the English
version shall govern.
2 Ruang Lingkup 2 Scope
a. Qualifikasi dan sertifikasi ditujukan untuk
semua Personnel NDE yang bekerja untuk
PT. VERONIKA PRIMA SANITA.
a. Qualifications and certifications are
addressed to all NDE personnel working
for PT. VERONIKA PRIMA SANITA.
b. Sertifikasi NDE Personnel untuk PT.
VERONIKA PRIMA SANITA berlaku
hanya jika personnel masih dipekerjakan
oleh PT. VERONIKA PRIMA SANITA
saja.
b. NDE Personnel certifications for the PT.
VERONIKA PRIMA SANITA are valid
only when the personnel being employed
by PT. VERONIKA PRIMA SANITA.
c. Metode yang termasuk dalam Written
practice adalah PT, MT , UT dan RT
c. The methods included in this Written
practice are PT, MT , UT and RT.
3 Reference Documen 3 Reference Documents
The ASNT Recommended Practice No.
SNT-TC-1A, 2011 edition.
The ASNT Recommended Practice No.
SNT-TC-1A, 2011 edition.
4 Definisi Definisi 4 Definition
4.1 ASNT: American Society for
Nondestructive Testing
4.1 ASNT: American Society for
Nondestructive Testing
4.2 Certification: Bukti tertulis dari
kualifikasi tersebut. 4.2 Certification: written testimony of
qualification.
4.3 Certifying Authority: GENERAL
MANAGER dari PT. VERONIKA PRIMA
SANITA
4.3 Certifying Authority: GENERAL
MANAGER of PT. VERONIKA PRIMA
SANITA
4.4 Certifying Agency: The PT. VERONIKA
PRIMA SANITA.
4.4 Certifying Agency: The PT. VERONIKA
PRIMA SANITA.
4.5 Closed Book Examination: Ujian yang
dilaksanakan tanpa adanya materi referensi
kecuali materi tersebut memang disediakan
atau untuk ujian.
4.5 Closed Book Examination: an examination
administrated without access to reference
material except for material supplied with
or in the examination.
4.6 Comparable: Persamaan atau ekivalensi
level dari tanggung jawab dan tingkat
kesulitan NDE yang ditentukan oleh
Level III PT. VERONIKA PRIMA
SANITA.
4.6 Comparable: being at an equivalent or
similar level of NDE responsibility and
difficulty as determined by PT.
VERONIKA PRIMA SANITA Level III
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 5 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
4.7 Documented : Kondisi yang ditulis dalam
suatu format. 4.7 Documented: the condition of being in
written form.
4.8 Employer : PT. VERONIKA PRIMA
SANITA. 4.8 Employer : PT. VERONIKA PRIMA
SANITA.
4.9 Experience: aktifitas - aktifitas
pekerjaan yang dilaksanakan pada
metode NDE tertentu dibawah
pengarahan supervisi yang berkualifikasi
termasuk performance metode NDE dan
berhubungan dengan aktivitas2, tetapi
tidak termasuk waktu mengatur program
training.
4.9 Experience: work activities
accomplished in specific NDE method
under the direction of qualified
supervision including the performance
of NDE method and related activities,
but does not include time spent
organizing the training program.
4.10 Certifikasi terbatas : Nondestructive test
method bisa di kelompokkan lebih kecil
kedalam disiplin atau tehnik tertentu untuk
memenuhi kebutuhan spesifikasi dari PT.
VERONIKA PRIMA SANITA; ini juga
Level II, tapi dengan scope terbatas.
4.10 Limited Certification: Nondestructive test
method may be further subdivided into
limited disciplines or techniques to meet
specific PT. VERONIKA PRIMA
SANITAs needs; these are Level II certifications, but to limited scope.
4.11 Non-destructive Testing (NDT): Proses
yang melibatkan kegiatan inspeksi,
pengujian, atau pengevaluasian dari cacat
material, properti dan masalah
permesinan tanpa harus merusak ataupun
menghancurkan kegunaannya.
4.11 Non-destructive Testing (NDT): a
process that involves the inspection,
testing, or evaluation of materials
discontinuities, properties and machine
problem without further impairing or
destroying the parts serviceability.
4.12 Outside Agency: Perusahaan atau
personnel yang menyediakan jasa NDE
Level III dan yang kualifikasinya untuk
jasa ini telah direview dan disetujui oleh
GENERAL MANAGER dari PT.
VERONIKA PRIMA SANITA.
4.12 Outside Agency: a company or
personnel who provides NDE Level III
service and whose qualifications to
provide these services have been
reviewed and approved by the PT.
VERONIKA PRIMA SANITAs GENERAL MANAGER.
4.13 Kualifikasi: Demonstrasi keahlian dan
pengetahuan, disertai pelatihan dan
pengalaman yang disyaratkan sehingga
personal mampu melakukan tugas pada
kerjaan yang spesifik dengan benar.
4.13 Qualification: demonstrated skill and
knowledge, along with documented
training and experience required for
personnel to properly perform the duties of
specific job.
4.14 Tehnik : adalah katagori dalam metode
NDT; misalnya, ultrasonic, ultrasonic
thickness testing.
4.14 Technique: A category within an NDT
method; for example, ultrasonic,
ultrasonic thickness testing.
4.15 Training: Program yang terorganisasi
untuk memberi pengetahuan dan keahlian
yang dibutuhkan untuk kualifikasi.
4.15 Training: an organized program
developed to impart the knowledge and
skills necessary for qualification.
4.16 Written Practice: Prosedur tertulis yang
disusun oleh PT. VERONIKA PRIMA
SANITA secara detail tentang
persyaratannya untuk kualifikasi dan
sertifikasi Personnel NDE.
4.16 Written Practice: a written procedure
developed by the PT. VERONIKA
PRIMA SANITA that details the
requirements for qualification and
certification of NDE Personnel.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 6 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
5 Tingkat Kualifikasi dan Tanggung
Jawab
5 Levels of Qualification and
Responsibility
5.1 Hak untuk menentukan tingkat penerimaan
dari material atau item yang diuji harus
dilaksanakan oleh Level II atau Level III
NDE
5.1 Authorization for determining the
acceptability of materials or items tested
shall be performed by Level II or Level III
5.2 Trainee 5.2 Trainee
a. Seorang yang dalam proses awal di
training, di qualifikasi, dan di sertifikasi. a. An individual in the process of being
initially trained, qualified, and certified.
b. Seorang trainee diijinkan bekerja dengan
atau membantu personnel yang telah
qualified tetapi tidak diperkenankan
secara mandiri melakukan, interpret,
evaluasi atau membuat report dari NDT
b. An Trainee is allowed to work with or
assist a certified individual but shall not
be allowed to independently conduct,
interpret, evaluate or report the result of
any NDT Test.
5.3 NDE Level I 5.3 NDE Level I
a. Level I NDE harus dikualifikasi untuk bisa
dengan benar melakukan kalibrasi,
examination khusus, dan evaluasi khusus
sesuai dengan instruksi tertulis dan
merecord hasilnya.
a. An NDE Level I personnel shall be
qualified to properly perform specific
calibrations, specific test, and specific
evaluations according to written
instructions and to record the results.
b. Dia harus menerima panduan atau
supervisi dari personnel yang memiliki
sertifikat NDE Level II atau Level III.
b. He shall receive the necessary guidance
or supervision from a certified NDE
Level II or III personnel.
5.4 NDE Level II 5.4 NDE Level II
a. Level NDE II harus dikualifikasi untuk
mensetup dan mengkalibrasi peralatan dan
menginterpretasikan dan mengevaluasi
hasil examination dengan mengacu Code,
Standard dan Specifikasi yang berlaku.
a. An NDE Level II personnel shall be
qualified to set up and calibrate equipment
and to interpret and evaluate test result
with respect to applicable codes, standards
and specifications.
b. Dia harus familiar dengan intrumentasi,
peralatan dan keterbatasan dari metodenya
dan harus bertanggung jawab bila diminta
membimbing saat on-the-job training
personnel yang sedang training dan
personnel NDE Level I.
b. An NDE Level II shall be thoroughly
familiar with the instruments, equipment
and limitations of the method and shall
exercise assigned responsibility for on-the-
job training and guidance of trainees and
NDE level I personnel.
c. Dia harus dapat menyiapkan instruksi
tertulis dan mengaturnya dan melaporkan
investigasi dari pelaksanaan uji tak
merusak.
c. An NDE Level II shall be able to prepare
written instructions and to organize and
report nondestructive testing
investigations.
d. Seorang personnel NDE Level II untuk
Radiographic Interpreter harus qualified
untuk mengeset dan mengkalibrasi
peralatan dan menginterpret, mengevaluasi
qualitas film radiograpy dan evaluasi
indikasi atau cacat dengan pedoman Code
d. NDE Level II personnel for interpreter
shall be qualified to set up and calibrate
equipment and to interpret, evaluate the
quality of film radiographs and evaluate
indications or defects with respect to
applicable codes, standards and
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 7 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
yang berlaku, Standard dan Spesifikasi. specifications.
e. Seorang personnel NDE Level II thickness
gauging harus familiar dengan
intrumentasi, peralatan dan keterbatasan
dari metodenya dan harus qualified untuk
mengeset dan mengkalibrasi peralatan dan
menginterpret, mengevaluasi hasil
examination dengan pedoman Code yang
berlaku, Standard dan Spesifikasi.
e. NDE Level II personnel for thickness
gauging shall be thoroughly familiar with
the instruments, equipment and limitations
of the method and shall be qualified to set
up and calibrate equipment and to
interpret, evaluate test results with respect
to applicable Codes, Standards and
Specifications.
5.5 NDE Level III 5.5 NDE Level III
a. Level III NDE harus bisa membuat,
mengqualifikasi, dan mengesahkan
prosedur, menetapkan dan mengesahkan
teknik pelaksanaan, menginterpretasikan
Code, Standard, specifikasi dan dan
prosedur; dan merencanakan metode NDE
yang penting, teknik dan prosedur yang
dipakai.
a. An NDE Level III personnel shall be
capable of developing, qualifying, and
approving procedures, establishing and
approving techniques, interpreting Codes,
Standards, Specifications and Procedures;
and designating the particular NDE
methods, technique and procedure to be
used.
b. Dia harus bertanggung jawab terhadap
terselesaikannya operasi NDE sesuai
kualifikasi dan penugasannya dan harus
bisa interpretasi dan mengevaluasi hasil
sesuai dengan Code, Standard, dan
Sesifikasi yang berlaku.
b. NDE Level III personnel shall be
responsible for the NDE operations for
which qualified and assigned to which he
is assigned and shall be capable of
interpreting and evaluating results in terms
of existing Codes, Standards, and
Specifications.
c. Dia harus memiliki latar belakang praktis
tentang material, fabrikasi atau produk
teknologi untuk menyediakan teknik yang
sesuai dan membantu menetapkan kriteria
penerimaan bila tidak tersedia.
c. NDE Level III personnel shall have
sufficient practical background in
applicable materials, fabrication or product
technology to establish techniques and to
assist in establishing acceptance criteria
where none are otherwise available.
d. Dia harus mengenal secara umum dengan
metode-metode NDE lain yang digunakan. d. An NDE Level III personnel shall have
general familiarity with other commonly
used in NDE methods.
e. Dia, dengan metode yang disertifikasi,
harus mampu melatih dan menguji Level I
NDE dan Level II NDE personnel untuk
sertifikasi pada method nya.
e. An NDE Level III personnel, in the
methods in which certified, shall be
capable of training and examining of NDE
Level I and Level II personnel for
certification in those method.
f. Dia harus diberi wewenang untuk
menyelenggarakan program pelatihan dan
sertifikasi sesuai dengan prosedure ini.
f. NDE Level III personnel shall be
authorized to administer the training and
certification program in accordance with
this written practice.
6. Pendidikan, Training dan Pengalaman 6. Education, Training and Experience
Requirements
6.1 Calon NDE sertifikasi harus mempunyai 6.1 Candidates for certification in NDE shall
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 8 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
cukup pendidikan, training, dan
pengalaman untuk meyakinkan qualifikasi
pada NDE method. Dokumentasi sebelum
certifikasi dianggap sebagai bukti dari
qualifikasi untuk level yang setara dari
certifikasi.
have sufficient education, training, and
experience to ensure qualification in those
NDE methods. Documentation of prior
certification is considered as evidence of
qualification for comparable levels of
certification.
6.2 Training dan / atau pengalaman yang
didokumentasikan yang didapat pada
posisi dan aktivitas yang setara dengan
level I, II dan / atau III sebelum pembuatan
written practice bisa dianggap memenuhi
kriteria daro par. 6.3.
6.2 Documented training and / or esperience
gained in positions and activities
comparable to those of levels I, II and / or
III prior to establishment of written
practice is considered in satisfying the
criteria of par. 6.3.
6.3 Calon NDE Level I dan II harus memenuhi
salah satu dari kriteria berikut: 6.3 An NDE Level I and II Candidate shall
satisfy one of the following criteria :
a. Personnel yang bersertifikasi NDE Level I
and II harus memiliki pendidikan,
pengalaman dan pelatihan sesuai dengan Table 1 A dan Table 1 B
a. NDE Level I and II certified personnel
shall satisfy the education, experience and
training requirements of Table 1 A and
Table 1 B
b. Untuk kualifikasi langsung ke Level II,
jam pelatihan harus sedikitnya adalah
kombinasi jam yang dipersyaratkan untuk
Level I dan II pada metode yang berlaku,
terkecuali bila calon tersebut telah
terkualifikasi sebelumnya, atau memiliki
persamaan posisi sesuai dengan Level II,
dalam kasus ini persyaratan untuk
pelatihan dinyatakan telah terpenuhi.
b. For Level II direct qualification with no
time at level I, the training hours shall
consist of at least the combined required
hours for Level I and II in the applicable
method, except when the candidate has
either been previously qualified to, or has
held a position equivalent to that of a
Level II, in which case, the requirement for
training may be considered met.
6.4 Calon NDE Level III harus mengikuti item
a dan salah satu kriteria pendidikan
ataupun pengalaman (b, c atau d):
6.4 An NDE Level III candidate shall satisfy below item a and one of the following
education and experience criteria ( b, c or d):
a. Memiliki jam training minimum jumlah
dari level I dan level II sesuai metode,
seperti yang tercantum dalam Table 1 A.
a. Have the training hours minimum the sum of Level I and Level II in applicable method, as
stated in the Table 1 A.
b. Lulus dalam 4 tahun di perguruan tinggi
atau Universitas dengan tingkat sarjana
atau science , plus 1 tahun pengalaman
melebihi syarat2 Level II NDE dalam
penugasan yang minimum sebanding
dengan Level II NDE pada metode yang
digunakan, atau:
b. Have graduated of four (4) year college or
university with degree in engineering or
science , plus one (1) additional year of
experience beyond the level II
requirements in NDE in an assignment at
least comparable to that of an NDE Level
II in the applicable method(s), or :
c. Telah lulus, tidak kurang dari dua tahun
belajar di bidang engineering atau science
pada universitas yang terakreditasi,
perguruan tinggi atau sekolah teknik
ditambah 2 tahun pengalaman melebihi
syarat2 Level II NDE dalam penugasan
yang minimum sebanding dengan Level II
NDE pada metode yang digunakan, atau:
c. Have Completed with passing grades at
least two years of engineering or science
study at an accredited university, college,
or technical school, plus two (2)
additional years of experience beyond the
level II requirements in NDE in an
assignment at least comparable to that of
an NDE Level II in the applicable
method(s), or :
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 9 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
d. Telah mempunyai pengalaman empat (4)
tahun melebihi syarat2 Level II NDE dalam
penugasan yang minimum sebanding
dengan Level II NDE pada metode yang
digunakan.
d. Have four (4) years of experience beyond
the level II requirements in NDE in an
assignment at least comparable to that of
an NDE Level II in the applicable
method(s).
7 Program Pelatihan 7 Training Program
7.1 Personel yang terpilih (trainee) harus
diberikan pelatihan yang terorganisir untuk
meyakinkan trainee benar-benar terbiasa
dengan prinsip dan praktek dari NDE
tertentu sehubungan dengan level dari
sertifikasi yang diinginkan dan proses yang
digunakan dan produk yang di uji.
Training harus termasuk teori, praktek,
program pengembangan dan perlakuan
pada pengujian tak merusak dan untuk
memenuhi pengalaman yang cukup untuk
memenuhi waktu yang disyaratkan pada
spesifik teknik, trainee kemudian
dikembalikan ke NDE Level III. Pada saat
ini, trainee akan diberikan kelas pelatihan
untuk metode dimana dia akan
dikualifikasikan (Kelas pelatihan dapat
bersamaan dengan trainee mendapatkan
pengalamannya). Semua program training
harus di aprove oleh NDE Level III yang
bertanggung jawab.
7.1 Personnel selected (trainee) are given
organized training for ensuring the trainee
is thoroughly familiar with the principles
and practices of specified NDE method
related to the level of certification desired
and applicable processes to be used and
product to be tested. The training shall
include theory, practical training,
development and aptitude in
nondestructive examination, and gain
experience for the appropriate time for
meeting the general time guide in the
specific technique; the trainees will be
referred back to the NDE Level III. At this
time, trainees will be given the classroom
training (classroom training may also be
given simultaneously as the trainee gains
practical experience) for the method in
which he will qualify.
All training programs shall be approved by
the responsible DNE Level III.
7.2 Procedur diatas diikuti dalam pemilihan,
training dan kualifikasi personel yang tidak
memiliki pengalaman pengujian tak
merusak sebelumnya. Setelah
menunjukkan bukti training sebelumnya
dan/atau kualifikasi, NDE level III dapat
melakukan penilaian terhaddap program
training untuk latar belakang dan
pengalaman personel. Tipe pengujian
specific yang didefinisikan untuk setiap
NDE teknik akan diikuti dalam semua
kasus.
7.2 The above procedure will be followed in
selecting, training and qualifying personnel
with no previous experience in
nondestructive examination. Upon
presentation of proof of prior training and /
or qualification, the NDE Level III may
exercise judgement in tailoring the training
program to personnels background and experience. The specific types of
qualification testing as defined for each
NDE technique will be followed in all
cases.
7.3 Jika PT. VERONIKA PRIMA SANITA
memakai jasa training service dari luar,
GENERAL MANAGER harus
bertanggung jawab untuk memastikan
bahwa training dari luar tersebut
memenuhi persyaratan dari written practice
ini.
7.3 When PT. VERONIKA PRIMA SANITA
phurchase outside training services, the
GENERAL MANAGER shall be
responsible for ensuring that such services
meet the requirements of this written
practice
7.4 Program pelatihan harus sesuai dengan
Written Practice ini dan Program Pelatihan 7.4 Training outline shall be as per this
Written Practice and NDE Training
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 10 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
NDE ANSI/ASNT CP-105 untuk sesuai
dengan masing masing metodenya
minimum harus digunakan sebagai acuan
Program ANSI / ASNT CP - 105 for the
applicable method as a minimum shall be
used as technical source materials.
8 Pengujian 8 Examinations
8.1 Administrasi dan penilaian 8.1 Administration and Grading
8.1.1 NDE Level III harus bertanggung jawab
melakukan pengujian dan pembobotan
NDE Level I, II atau personnel Level III
lainnya.
8.1.1 The NDE Level III shall be responsible for
administration and grading the NDE Level
I, II or other Level III personnel.
8.1.2 Semua ujian tertulis harus closed book,
kecuali data yang diperlukan seperti grafik,
table, spesifikasi, procedure, Code boleh
disediakan selama dalam waktu ujian.
8.1.2 All written examinations shall be closed
book, except the necessary data such as
graphs, tables, specifications, procedures,
Codes may be provided with during
examination.
8.1.3 Level III harus bertanggung jawab untuk
memilih dan approve semua pertanyaan
ujian.
8.1.3 The Level III shall be responsible to select
and approve all the examination questions
8.1.4 Untuk personnel Level I dan II, hasil grade
harus ditentukan dengan rata2 sederhana
dari hasil ujian general, spesifik, dan ujian
praktek, untuk personnel Level III , hasil
grade harus ditentukan dengan rata2
sederhana dari hasil ujian basic, methode
dan ujian spesifik; seperti contoh dibawah
ini.
8.1.4 For Level I and II personnel, a composite
grade shall be determined by simple
averaging of the results of the general,
specific and practical examinations, for
Level III personnel a composite grade shall
be determined by simple averaging of the
results of the basic, method and specific
examination; as example below.
Susunan grade diatur sebagai berikut:
(Contoh Level II )
Examination Actual Grade
General 70 %
Specific 84 %
Practical 90 %
Composite Grade = (70+84+90)/3 = 81.33
%
The composite grade is determined as
follows : ( Example for Level II )
Examination Actual Grade
General 70 %
Specific 84 %
Practical 90 %
Composite Grade = (70+84+90)/3 = 81.33
%
8.1.5 Hasil ujian kualifikasi harus lulus dengan
nilai rata rata gabungan minimum 80 %, dengan nilai minimum 70 % untuk masing-
masing pengujian.
8.1.5 Examinations administered for
qualification shall result in a passing
composite grade of at least 80 %, with no
individual examination having a passing
grade less than 70 %.
8.1.6 Bila ujian dilaksanakan oleh badan atau
agensi diluar PT. VERONIKA PRIMA
SANITA dan hanya menyatakan lulus
atau tidak lulus, pada sertifikatnya, maka
PT. VERONIKA PRIMA SANITA bisa
menerima kelulusannya dengan nilai 80 %
untuk ujian tersebut.
8.1.6 When an examination is administrated and
graded for the by an outside agency and
issues grades of pass or fail only, on a
certified report, then PT. VERONIKA
PRIMA SANITA may accept the pass
grade as 80 % for that particular
examination.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 11 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
8.2 Pengujian penglihatan jarak dekat: 8.2 Near Vision Acuity Examination :
8.2.1 Penglihatan jarak dekat harus dilaksanakan
setiap tahun oleh Level III atau Dokter,
habis masa berlaku pada tanggal terakhir
pada bulan jatuh tempo nya.
8.2.1 Near Vision Acuity shall be administered
annually by Level III or Medical Doctor,
the examination expire on the last day of
month of expire.
8.2.2 Pengujian diperlukan untuk meyakinkan
penglihatan dekat baik normal ataupun
dengan kaca mata ninimum satu mata bisa
membaca tulisan huruf J-2 atau tipe dan
ukuran yang setara dengan jarak minimum
30 cm pada Tes Chart Standar Jaeger.
8.2.2 An examination is required to assure
natural or corrected near vision in at least
one eye by reading J-2 letters or equivalent
type and size at a distance not less than 12
inches on a standard Jaeger test chart
8.2.3 Sebagai tambahan NDE Level III harus
yakin bahwa kandidat tersebut memiliki
kemampuan untuk membedakan kontras
diantara warna2, menggunakan Ishiharas
Test Plates ( minimum 14 plates ).
8.2.3 In addition the NDE Level III shall satisfy
himself of the candidates ability to distinguish and differentiating contrasts
among colours, using Ishiharas Test Plates (minimum 14 plates).
8.2.4 Untuk personnel RT dan MT harus bisa
membedakan bayangan kelabu,
menggunakan copy atau computer dari
Shade Grey Test Plates dengan jarak 30 ~
40 cm. dengan pencahayaan kondisi kerja
normal pada computer. Syarat kelulusan,
minimum 20 pembacaan harus benar.
8.2.4 For NDE personnel on RT and MT, they
shall be able to distinguish and
differentiating shades of grey, using a hard
copy or on computer screen of Shade Grey
Test Plates at a distance of 30 ~ 40 cm.
under normal desktop working light
condition. Passing grade, minimum 20
correct readings required.
8.2.5 Hasil tes mata ini harus didokumentasikan
dalam Exhibit A atau form yang serupa. 8.2.5 The eye exam results shall be documented
in Exhibit A or similar form.
8.3 Detail dari Pengujian 8.3 Detail of Examinations
8.3.1 Ujian General Level I dan Level II
(tertulis):
8.3.1 General Examination Level I and II
(written ):
a. Ujian general harus melingkupi ujian dasar
yang berhubungan dengan metode yang
diaplikasikan.
a. The general examination shall cover the
basic test principles relative to the
applicable method.
b. Pertanyaan ujian harus meliputi metode
yang digunakan drajat yang diperlukan
pada written practice dan NDE Training
Program ANSI / ASNT CP 105 sebagai panduan untuk metode RT, UT, MT dan
PT.
b. The examination questions shall covers
the applicable methods to the degree
required by this written practice and NDE
Training Program ANSI / ASNT CP
105 as a guide for RT, UT, MT and PT.
c. Minimum jumlah pertanyaan harus sesuai
dengan Table II c. The minimum number of questions shall
be as in Table II
d. Certifikat ACCP Level II yang masih
berlaku memenuhi kriteria ujian General
dan Praktek pada setiap method yang
tersebut.
d. A valid endorsement on an ACCP Level II
certificate fulfills the corresponding
criteria General examination and Practical
examination for each applicable method.
e. Certifikat ASNT Level II yang masih
berlaku memenuhi kriteria ujian General
pada setiap method yang tersebut.
e. A valid ASNT NDE Level II certificate
fulfills the corresponding General
examination for each applicable method.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 12 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
8.3.2 Ujian Spesifik Examination Level I dan
Level II (Tertulis):
8.3.2 Specific Examination Level I and Level
II ( Written ) :
a. Pengujian spesifik harus melingkupi
peralatan, prosedur operasi dan teknik uji.
Selain itu juga harus melingkupi
spesifikasi atau Code dan kriteria
penerimaan untuk prosedur NDE yang
dipakai.
a. The specific examination shall cover the
equipment, operating procedures and test
techniques. It shall also cover
specifications or Codes and acceptance
criteria for the applicable NDE procedure.
b. Minimum jumlah pertanyaan harus sesuai
dengan Table II
b. The minimum number of questions shall
be as in Table II
c. Ujian spesific bisa ditiadakan, jika calon
mempunyai sertifikat yang masih berlaku
dari ACCP atau ASNT NDE Level II pada
method / sektor industri dan jika
pengalaman yang ada didokumentasikan.
c. The specific examination may be deleted,
if candidate has a valid ACCP or ASNT
NDE Level II certificate in the method /
industrial sector and if documented
experience exists to permit such.
8.3.3 Ujian Praktek Level I dan Level II 8.3.3 Practical Examination Level I & Level
II
a. Ujian praktek harus termasuk
pendemonstrasian kemampuan dalam
pelaksanaan metode uji tak merusak yang
digunakan dan evaluasi hasil yang didapat.
The practical examination shall comprise
demonstrated proficiency in performing
the applicable nondestructive examinations
and evaluations of the results obtained.
b. Satu atau lebih sampel cacat untuk ujian
RT, UT, MT dan PT harus di setujui oleh
NDE Level III. Hasil ujian praktek ini
harus didokumentasikan kedalam record
pengujian dengan harus dimasukkan
minimum 10 poin checklist tentang
pemahaman variabel dan persyaratan persyaratan prosedur yang ada dalam PT.
VERONIKA PRIMA SANITA, harus
termasuk dalam ujian.
One or more flawed specimen for
examination of RT, UT, MT and PT shall
be approved by the NDE Level III. The
practical examination results shall be
documented on an examination record
with at least 10 check points requiring an
understanding of examination variables
and PT. VERONIKA PRIMA SANITAs procedure requirements shall be included
for examination.
c. Untuk Radiographic Interpreter, minimum
10 (sepuluh) sample film harus digunakan
untuk ujian praktek dengan menjawab
minimum 10 checkpoints.
For Radiographic Interpreter, a minimum
10 (ten) sample of films shall be used for
practical examination with at least 10
checkpoints.
8.3.4 Pengujian untuk Level III 8.3.4 Examination for Level III
a. Ujian Basic (disyaratkan hanya sekali
ketika mengambil lebih dari satu metode): a. Basic Examination ( required only once
when more than one method examination
is taken ) :
Limabelas (15) pertanyaan berkaitan
dengan pengertian dari dokumen SNT-TC-
1A.
Dua puluh (20) pertanyaan berkaitan
dengan material, proses fabrikasi dan
teknologi produksi yang biasa dipakai.
Dua puluh (20) pertanyaan yang dipilih
Fifteen (15) questions relating to
understanding of the SNT-TC-1A
document.
Twenty (20) questions relative to
applicable materials, fabrication and
product technology.
Twenty (20) questions selected from or
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 13 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
dari pertanyaan yang sama dengan
pertanyaan Level II pada metode NDE
tersebut.
similar to the published Level II questions
of other appropriate NDE methods.
b. Pengujian Metode (untuk setiap metode): b. Method Examination ( each method ) :
Tiga puluh (30) pertanyaan berkaitan
dengan pemahaman dasar, yang diambil
dari atau yang sama dengan pertanyaan
dari ASNT Level III untuk setiap
metodenya.
Lima belas (15) pertanyaan berkaitan
dengan aplikasinya dan penentuan teknik
dan prosedur yang diambil dari dan atau
yang sama dengan pertanyaan yang ada
dari ASNT Level III untuk setiap
metodenya.
Dua puluh (20) pertanyaan untuk
interpretasi Code, Standard dan spesifikasi
yang berkaitan terhadap metode tersebut.
Thirty (30) questions relating to
fundamentals and principles, which are
selected from or are similar to the
published ASNT Level III questions for
each method.
Fifteen (15) questions relating to the
application and the establishment of
techniques and procedures which are
selected from or are similar to the
published ASNT Level III questions for
each method.
Twenty (20) questions relating to the
interpretation of Codes, Standards and
Specifications related to the method.
Pemegang sertifikat yang masih berlaku
dari ASNT Level III or ACCP Professional
Level III telah memenuhi persyaratan yang
di par. 8.3.4 (a) dan 8.3.4 (b).
A valid endorsement on an ASNT Level
III or ACCP Professional Level III
certificate fulfils the examnation criteria
described in par. 8.3.4 ( a ) and 8.3.4 (b)
for each applicable method.
c. Ujian Spesifik (untuk setiap metode) c. Specific Examination ( for each method )
Dua puluh (20) pertanyaan tentang
spesifikasi, peralatan, teknik dan prosedure
tertulis yang diaplikasikan pada produk
dan metode yang dilaksanakan di PT.
VERONIKA PRIMA SANITA dan yang
ditulis dalam prosedur qualifikasi PT.
VERONIKA PRIMA SANITA.
Twenty (20) questions relating to
specifications, equipment, techniques and
procedures applicable to PT. VERONIKA
PRIMA SANITAs product (s) and methods employed and to the
administration of the PT. VERONIKA
PRIMA SANITAs written practice.
Ujian specific dari method yang terkait
bisa diabaikan untuk calon yang
pemegang sertifikat yang masih berlaku
dari ASNT Level III atau ACCP
Professional Level III dan jika di
dokumentasikan bukti dari pengalaman
nya, termasuk persiapan pembuatan
prosedur yang mengacu ke Codes,
Standards, atau Specification dan evaluasi
dari hasil ujian.
The specific examination in the applicable
method may be deleted for a candidate
who has a valid endorsement on an ASNT
Level III or ACCP Professional Level III
certificate in the method and if
documented evidence of experience exists,
including preparation of procedures to
Codes, Standards, or Specifications and
evaluation of the test results.
8.4 Ujian - ulang 8.4 Re-examination
a. Batasan dibawah ini harus dipakai syarat
ujian ulang dari personnel dalam
kualifikasi uji nondestructive:
a. The following limitations shall be applied
on re-examination of personnel for
qualification in non-destructive
examination :
b. Personnel gagal memenuhi grade yang b. Personnel failing to attain the required
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 14 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
dibutuhkan harus menunggu paling sedikit
30 hari atau menerima tambahan training
yang cocok ditentukan oleh Level III
penguji sebelum dilakukan pengujian
kembali.
grade must wait at least 30 days or receive
suitable additional training as discretion by
the Level III examiner prior to being re-
examined.
9 Sertifikasi 9 Certification
9.1 Setelah berhasil melewati ujian kualifikasi
, personnel tersebut harus disertifikasi
sesuai dengan metode dan level untuk
kualifikasinya.
Sertifikat qualifikasi untuk RT, UT, PT,
MT harus di tanda tangani oleh
GENERAL MANAGER dan diverifikasi
oleh NDE Level III metode yang terkait.
Sertifikasi (Exhibit B atau form serupa)
harus disimpan kedalam file
nondestructive
9.1 Upon successful completion of
qualification examination, the personnel
shall be certified in the method and to the
level for which he is qualified.
The qualification certificate for RT, UT,
PT, MT shall be verified by the NDE
Level III in applicable method and shall be
certified by the GENERAL MANAGER.
The certification record (Exhibit B or
similar form) shall be maintained in the
nondestructive examination personnel
records file.
9.2 Personnel NDE Level I or II for PT, MT,
UT dan RT yang bergabung keperusahaan
yang telah dikualifikasi oleh Institusi
diluar dan dapat menunjukkan sertifikat
authentic telah memenuhi persyaratan
qualifikasi dari PT. VERONIKA PRIMA
SANITA written practice dan bisa
disertifikasi setelah lulus ujian general,
specific dan praktek yang ditentukan oleh
NDE Level III.
9.2 NDE Personnel Level I or II for PT, MT,
UT & RT joining the company who have
been qualified by Outside Agencies or
Government qualification (i.e. BATAN for
RT) and can provide authentic certificates
or License fulfils the qualification
requirements of PT. VERONIKA PRIMA
SANITAs written practice and shall be certified after have passed general, specific
and practical examination at the discretion
of the NDE level III.
9.3 NDE Level III akan menyimpan semua
record sertifikasi. Bila NDE level III dari
subkontrak, GENERAL MANAGER
harus menyimpan record sertifikasi.
Record personnel yang qualified akan
termasuk tersebut dibawah ini:
9.3 The NDE Level III shall maintain the
certification records. If NDE Level III
Services are subcontracted, the
GENERAL MANAGER shall maintain
records of certification. Personnel records
of certified personnel will include the
followings :
1. Nama dari personnel tersebut.
2. Level dari sertifikasi dan metode examinationnya
3. Latar belakang pendidikan dan pengalaman kerjanya.
4. Pernyataan memuaskan penyelesaian complete training.
5. Hasil dari examination mata yang berlaku
6. Copy dari ujian atau bukti kesuksesan komplet ujian
1. Name of certified personnel. 2. Level of certification and test
method.
3. Education background and experience of certified personnel.
4. Statement indicating satisfactory completion of training.
5. Result of current eye examination 6. Current examination copy(ies) or
evidence of successful completion of
examinations.
7. Other suitable evidences of
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 15 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
7. Bukti lain untuk kecukupan qualifikasi bila kualifikasi digunakan
sebagai pengganti ujian specific sesuai
par. 8.3.5 (b).
8. Bobot persen rata rata atau bukti bobot yang sesuai.
9. Tanda tangan Level III yang memverifikasi qualifikasi dari calon
untuk sertifikasi. Untuk sertifikasi
level III, harus diverifikasi oleh
GENERAL MANAGER.
10. Tanggal sertifikasi dan/atau resertifikasi dan penunjukkan untuk
NDE.
11. Tanggal berlakunya sertifikat.
12. Tanda tangan employer berwenang yang mensertifikasi sertifikasi (
GENERAL MANAGER PT.
VERONIKA PRIMA SANITA)
satisfactory qualifications when such
qualifications are used in lieu of the
specific examination prescribed in
par. 8.3.5 ( b ).
8. Composite grade(s) or suitable evidence of grade.
9. Signature of Level III that verified qualifications of candidate for
certification. For level III
certification, it shall be verified by
GENERAL MANAGER
10. Date of certification and / or re-certification and date of assignments
to NDT.
11. Certification expiration date. 12. Signature of PT. VERONIKA
PRIMA SANITAs certifying authority (GENERAL MANAGER )
9.4 Interval sertifikasi tidak boleh melebihi
ketentuan ini :
Level I , II dan III = 5 tahun
Habis masa berlaku sertifikat pada tanggal
terakhir pada bulan jatuh tempo nya.
9.4 Certification shall not exceed the following
intervals :
Level I , II and III = 5 years
The certifications expire on the last day of
the month of expire.
10 Technical Performance Evaluation 10 Technical Performance Evaluation
a. Personnel NDE bisa diuji setiap saat dan
sertifikat yang dimiliki bisa diperpanjang
atau dicabut sesuai kebijaksanaan level III
a. NDT personnel may be re-examined any
time and have their certificates extended or
revoked as discretion by Level III
b. Technical performance harus dilaksanakan
setiap tahun menggunakan pertanyaan2
(minimum 10 check point) yang
berhubungan NDE methodenya oleh Level
III. Evaluasi dan dokumentasi mengikuti
format dan petunjuk sesuai paragraph
8.3.3.
b. Technical performance evaluation shall be conducted annually using practical method
questions (with at least 10 check points)
related to the applicable NDE method by the
Level III. The evaluation and documentation
shall follow the format and guidelines
described in paragraph 8.3.3.
c. Sebagai ganti dari Technical performance
evaluation, ujian harus dilaksanakan pada
general, specific dan practical.
c. In lieu of the above Technical performance
evaluation, the examinations shall be
conducted in general, specific and
practical.
11 Interupsi Pelaksanaan 11 Interrupted Service
11.2 Demonstrasi yang tidak berlanjut terhadap
service, pengetahuan atau performance
keterlambatan dalam sertifikat
perpanjangan waktu kualifikasi (Table 1 A
dan 1 B). Dalam keadaan yang serupa atau
sama diatas terjadi, NDE level III akan
11.1 Lack of continued demonstration of
satisfactory service, knowledge or
performance and delays in certification due
to extended experience qualifying time
(Table IA and 1B). In the event that
circumstances similar to or the same as
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 16 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
mereview secara detail keadaan secara
specific dan menentukan kursus yang
diperlukan atau mencabut sertifikat, ujian
ulang atau melakukan evaluasi lanjuta
terhadap performance praktek personel.
above arise, the NDE level III will review
in detail the specific circumstances and
determine the necessary course or action to
revoke certification, required re-
examination or conduct extended
evaluation of the personnels practical performance.
11.2 Tidak dalam kondisi yang sesuai 8.4 (re-
examination), periode dimana terdapat
interupsi pelaksanaan yang lebih dari 6
bulan harus diadakan evaluasi ulang
terhadap kompetensi seseorang oleh NDE
Level III.
11.2 Not withstanding the provisions of 8.4 (Re-examination), any period of interrupted
service more than 6 months shall require re evaluation of the personnels competence by the NDE Level III.
12 Re-sertifikasi 12 Re-certification
Semua level dari personnel NDE harus
disertifikasi ulang sesuai dengan salah satu
dari kriteria-kriteria berikut ini:
All levels of NDE personnel shall be re-
certified in accordance with one of the
following criteria :
a. Adanya bukti kontinyuitas evaluasi tehnik
kinerja yang memuaskan untuk level I dan
II sesuai paragraph 10. Hasil yang tidak
memuaskan dari technical performance,
personel NDE harus direview untuk
evaluasi lebih lanjut oleh level III dan
GENERAL MANAGER. Tindakan
koreksi bisa dengan ujian tambahan, ujian
ulang atau pencabutan sertikat NDE.
a. Evidence of continuing satisfactory technical performance of NDE personnel level I and II
as described in paragraph 10. Unsatisfactory
results of technical performance, the NDE
personnel shall be reviewed for further
evaluation by the Level III and the
GENERAL MANAGER. The corrective
action may be additional test, re-examination
or revoke of the NDE certificate.
b. Bukti kontinyuitas kinerja yang
memuaskan dari NDE Level III seuai
tugasnya, seperti yang ditentukan oleh
GENERAL MANAGER, boleh
digunakan sebagai dasar sertifikasi ulang
NDE Level III.
b. Evidence of continued satisfactory
performance of the NDE Level III duties,
as determined by the GENERAL
MANAGER, may be used as the basis for
re-certification of the NDE Level III.
13 Pemutusan 13 Termination
Personnel yang disertifikasi dengan
prosedur ini, sertifikatnya tidak berlaku
lagi dengan berakhirnya hubungan kerja
mereka di PT. VERONIKA PRIMA
SANITA.
13.1 Personnel certified under this procedure
shall have their certification revoked upon
termination of employment with PT.
VERONIKA PRIMA SANITA.
Personnel yang sertifikasinya berakhir,
boleh disertifikasi ulang sebagai level
NDE seperti yang lalu oleh PT.
VERONIKA PRIMA SANITA
berdasarkan pada ujian, sesuai paragraf 8,
asalkan semua persyaratan seperti berikut
bisa terpenuhi:
13.2 Personnel whose certification has been
terminated may be re-certified to the
former NDE level by PT. VERONIKA
PRIMA SANITA based on examination as
described in par. 8, provided all of the
following conditions are met :
a. Personnel telah menyetujui sebelum a. The personnel has proof of prior
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 17 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
adanya sertifikasi certification
b. Terus bekerja dalam kapasitasnya sesuai
sertifikatnya dalam waktu enam (6) bulan
setelah masa berhentinya.
b. The personnel was working in the capacity
to which certified within six (6) months
of termination.
c. Personnel disertifikasi ulang dalam waktu
enam (6) bulan setelah masa berhentinya c. The personnel is being re-certified within
six ( 6 ) months of termination
d. Sebelum pengujian untuk sertifikasi,
personnel yang tidak memenuhi
persyaratan tersebut diatas harus
mendapatkan tambahan pelatihan yang
cukup dari NDE Level III.
d. Prior to being examined for certification, personnel do not meet the above
requirements shall receive additional training
at the discretion of the NDE level III.
14 Pembaruan 14 Reinstatement
Personnel yang sertifikasinya telah habis,
bisa diperbarui sesuai NDE level awalnya,
tanpa adanya ujian baru, asalkan semua
persyaratan berikut terpenuhi:
Personnel whose certification has been
terminated may be reinstated to the former
NDE level, without new examination,
provided all the following conditions are
met:
a. PT. VERONIKA PRIMA SANITA telah
menyimpan record sertifikat personnel
yang dibutuhkan di paragraph 9.3
a. PT. VERONIKA PRIMA SANITA has
maintained the personnel certification
records as required in par. 9.3
b. Sertifikat dari personnel belum habis masa
berlakunya. b. Personnel certification did not expire
during termination.
c. Pembaruan sertifikat dalam kurun waktu
enam (6) bulan sebelum habis masa
berlakunya.
c. Personnel are being reinstated within six
(6) months of termination.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 18 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
Table I. A
Initial Training and Experience Level
Examination
Method
NDT
Level Technique
Training
Hours
Experience
Remarks Minimum Hours
in Method Total Hours
in NDT
Liquid
Penetrant
I 4 70 130
II 8 140 270
Magnetic
Particle
I 12 70 130
II 8 210 400
Radiological I
Radiographic 40 210 400
II 40 630 1200
Ultrasonics
I 40 210 400
II 40 630 1200
II Time of Flight
Diffraction 40
160 NA Starting Point,
UT - II
II Phased Array 80 160 NA Starting Point,
UT - II
Note:
1. For Level II certification, the experience shall consist of time at Level I or equivalent. If person is being qualified directly to Level II with no time at Level I, the required experience shall consist of the sum of the times required
for Level I and Level II and the required training shall consist of the sum of the hours required for Level I and
Level II.
2. For Level III certification, the required experience shall consist of the sum of time required for Level I and Level II, plus additional time in par. 6.2 as applicable. The required formal training shall consist of the Level I and
Level II training plus additional formal training of product knowledge training, auditor training or other suitable
training at the discretion by GENERAL MANAGER
3. While fulfiling total NDT experience requirement, experience may be gained in more than ( 1 ) method, however, the minimum hours shall be met for each method.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 19 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
Table I. B
Initial Training and Experience Level for
NDT Level II Limited Certification
Examination
Method Limited Certification
Technicians Starting Point
Formal
Training
Minimum Required Work
Experience in Method
(hours)
Radiographic Film Interpretation Non-
Radiographer 40 220
1
Film Interpretation Level I 24 2201
Ultrasonic Digital Thickness
Measurement ( numeric
output only )
Trainee 8 40
A-Scan Thickness
Measuremen
Trainee 24 175
1 Require practical review of 1000 radiographs.
Table II
Minimum Number of Examination Questions
Method General Specific
Level I Level II Level I Level II
Magnetic Particle Testing 40 40 20 20
Liquid Penetrant Testing 40 40 20 20
Radiography Testing 40 40 20 20
Radiographic Interpreter Non Radiographer
NA 40 NA 20
Radiographic Interpreter Radiographer ( Certified RT - I )
NA 20 NA 15
Ultrasonic Testing : 40 40 20 20
- Time of Flight Diffraction NA NA NA 30
- Phased Array NA NA NA 30
- Digital Thickness Measurement ( numeric output only )
NA 20 NA 10
- A-Scan Thickness Measurement NA 30 NA 15
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 20 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
EXHIBIT A
EYE EXAMINATION RECORD
Employee Name :
Company :
Near Vision Natural Corrected
Jaeger, with min.
distance 304 mm
Left Right Both Left Right Both
______
_______
______
_______
______
_______
Results of
Near Vision Acuity :
Colour Contrast Differentiation
(Colour Blindness Ishiharas Test )
:
1, 2, 3, 4, 4, 5, 6, 8, 9, 10, 11, 12, 13, 14
Shade of Gray
( Shade of Gray Chart )
:
; Read ____ of 25 plates
Examination administered by : Signature
T i t l e :
Exam. D a t e :
Re-exam Date :
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 21 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
EXHIBIT B
NDE PERSONNEL CERTIFICATION RECORD
Name : ID No. :
Education :
Experiences :
Training : Training courses listed bellows were satisfactorily completed in accordance with VERONIKA
PRIMA SANITAs Written Practice
Training Course Dates Instructor
Method &
Level Examination Results Composite
Grade
Training
Hours
Certification
Date
Expiration Date
General Specific Practical
Date of Assignment :
Technique :
Sector :
Material :
Certification based on satisfactorily passing examinations.
This to certify that the above training, experiences, qualification and certification meets the requirements of Greatways engineering
services Written Practice for Qualification and Certification of NDE Personnel Procedure No : VPS-WP-01 , Revision : 00
Batam, Verified by, Certified by,
NDE Level III GENERAL
MANAGER Note :
PT. : Liquid Penetrant Testing
MT. : Magnetic Particle Testing
RT. : Radiographic Testing
UT. : Ultrasonic Testing
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 22 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
EXHIBIT C TRAINING COURSE SYLLABUS
APPENDIX I
C1. LIQUID PENETRANT TESTING : LEVEL I
TRAINING
HOURS
Introduction : History and Purpose
Liquid Penetrant Processing
Various Penetrant Testing Methods
Liquid Penetrant Testing Equipment and Testing Aids
4
TOTAL HOURS
4
C2. LIQUID PENETRANT TESTING : LEVEL II
TRAINING
HOURS
Review of Basic Principles and Method
Selection of Appropriate Penetrant Testing Method
Inspection and Evaluation of Indications
Inspection Procedure and Standards
Basic Methods of Instruction
8
TOTAL HOURS 8
TRAINING
HOURS
C3. MACNETIC PARTICLE TESTING : LEVEL I
Theory and Principles of Magnet and Magnetic Fields
Characteristics of Magnetic Fields
Effects of Discontinuities of Material
Magnetization by Means of Electric Current
Selecting the Proper Method of Magnetization
Inspection Medium / Materials
Principles of Demagnetization
Magnetic Particle Testing Equipment
Types of Discontinuities Detected by Magnetic Particle Testing
Magnetic Particle Test Indications and Interpretations
12
TOTAL HOURS 12
C4. MACNETIC PARTICLE TESTING : LEVEL II
TRAINING
HOURS
Theory and Principles :
Flux Strength and Patterns
Material Hardness and Heat Effects
Flux Field :
Direct Current
Rectified Direct Current
Alternating Current
Permanent Magnets
8
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 23 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
Effects of Discontinuities of Material
Magnetization by Means of Electric Current
Selecting the Proper Method of Magnetization
Demagnetization Procedures
Types of Equipment and Testing Medium
Types of Discontinuities
Evaluation Techniques and Standards
Equipment Maintenance, Check and Process
TOTAL HOURS 8
C5. RADIOGRAPHIC TESTING : LEVEL I
TRAINING
HOURS
1. Radiographic Equipment Operating and Instruction Course 5
Personnel Monitoring Devices Usage
Survey Instrument Usage
Leak Testing of Sealed Radioactive Sources
Radiation Survey Report
Radiographic Work Practices
Exposure Devices
Emergency Procedure
Storage and Shipment of Exposure Devices and Sources
National Regulation
2. Basic Radiographic Physic Course 20
Introduction : History of Radioactive Materials
Industrial Radiography
Radiation Protection
Basic Mathematics
Fundamental of Matter
Radioactive Materials
Types of Radiation
Interaction of Radiation with Matter
Biological Effects of Radiation
Exposure Devices and Radiation Sources
3. Radiographic Technique Course 15
Introduction : Radiographic Processes
Electromagnetic Spectrum
Types of Radiation Sources
Basic Principles of Radiography
Film and Radiographs
Radiographic Image Quality
Film Handling, Loading and Processing
Radiographic Exposure Techniques
Fluoroscopic Technique
TOTAL HOURS
40
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 24 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
C6. RADIOGRAPHIC TESTING : LEVEL II
1. Film quality and Manufacturing Processes Course
20
Review of Basic Radiographic Principles
Darkroom Facilities, Technique and Processing
Indication, Discontinuities and Defects
Manufacturing Processes and Associated Discontinuities
Radiological Safety Principles Review
2. Radiographic Evaluation and Interpretation Course
20
Radiographic Viewing
Application Techniques
Evaluation of Castings
Evaluation of Weldments
Standards, Codes and Procedures for Radiography
TOTAL HOURS 40
C7. ULTRASONIC TESTING : LEVEL I TRAINING
HOURS
1. Basic Ultrasonic Course 20
Introduction
Basic Principles of Acoustics
Equipment
Basic Testing Methods
2. Ultrasonic Technique Course 20
Testing Methods
Calibration ( Electronic and Functional )
Straight Beam Examination to Specific Procedures
Angle Beam Examination to Specific Procedures
TOTAL HOURS 40
C8. ULTRASONIC TESTING : LEVEL II
TRAINING
HOURS
Ultrasonic Evaluation Course 40
Review of Ultrasonic Techniques Course
Evaluation of Base Material Product Forms
Evaluation of Weldments
Evaluation of Bonded Structure
Discontinuity Detection
Evaluation
TOTAL HOURS 40
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 25 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
C9. PHASED ARRAY ( PA )ULTRASONIC TESTING : LEVEL II
TRAINING
HOURS
Introduction
Basic Principles o PA
Equipment ( Computer based systems, focal law, generation, probes, wedges, scanners)
Testing Technique
Calibration
Data Collection
Procedures
Data Presentation
Data Evaluation
Reporting
80
TOTAL HOURS 80
C10. TIME OF FILGHT DIFFRACTION ( TOFD ) : LEVEL II
TRAINING
HOURS
Introduction
Basic Principles of TOFD
Equipment ( Computer based systems, beam profile, probes, wedges, scanner )
Testing Technique
Calibration
Data Collection
Procedures ( specific applications )
Data Presentation
Data Evaluation
Parabolic cursor(s)
Reporting
40
TOTAL HOURS 40
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 26 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
APPENDIX II
GRADING PRACTICAL EXAMINATION
RADIOGRAPHIC TESTING
1. All individual shall demonstrate his proficiency in producing radiographs in at least two different techniques. At least one radiograph to be produced for each technique inclusive of processing.
2. This examination will be graded for the following items.
Exposure time calculation.
Quality of radiographs.
Compliance with testing procedure / technique sheet provided.
Knowledge on equipment and materials used where the individual is requested to fill in a format on equipment / material used and reporting.
3. All radiographs will be interpreted and sensitivity calculated by the individual being qualified. The individuals comment on the qualities of weldment and radiographs shall be considered. No major indications shall be missed. ( For Level II only )
4. At least ten check points prepared and approved by the NDT Level III shall be used as a basis in grading of practical examination.
5. With adequate experience and written proof of certification by an audited outside agency or national certifying body, i.e. Indonesia Atomic Energy commission ( BATAN ), the NDT Level III may waive
examinations for radiographic testing personnel. This clause is applicable only for radiographic inspection
personnel operating radiation sources with a detailed operating procedure under the local statutory
requirements inside Indonesia
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 27 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
APPENDIX III
GRADING PRACTICAL EXAMINATION
ULTRASONIC TESTING
1. Categories of Qualification: Ultrasonic testing certification shall be categorized according to weld joint configuration. If none is specified in the certificate, it shall mean the individual is qualified for all
configurations or materials.
CATEGORY NO. OF SPECIMEN DESCRIPTION
Constant Configuration
Variable Configuration
1
1
One (1) in-line butt joint or one (1)
Tee/nozzle-type joint, full or partial
penetration joint.
One (1) node-type ( TKY ) joint
Test specimens may or may not contain material discontinuities.
2. The individual being examined shall submit a written report in a standard format, of ultrasonic test with a sketch containing the nature, size (length and width), location along the weld and position within the weld
cross section, of all reportable indications.
3. The individuals performance rating shall be calculated in accordance with the following formula :
P = (Lc / La) x 100
R = (Lc / Li) x (1 (Lf / Li) x 100
Where :
P = Percentage of reflector correctly detected and
sized.
R = Passing grade 70%overall rating including
penalty for false alarms.
La = Passing grade 50% the length of actual reflector
contained in the specimen
Lc = The sum of indicated length of reflectors that
have been correctly sized and located.( Credit is given
for the lesser of the reported length or actual length of
the reflector)
Li = The total length of reflectors reported by the
candidate, right or wrong.
Lf = The total length of reported indications where no
reflectors exist
4. Additionally, the individual shall be subjected to oral test where knowledge on equipment check and calibration, flaw sizing technique, codes/standard, practical problem likely to be encountered, limitations of
the test system, will be assessed.
5. At least ten check points prepared and approved by the NDT Level III shall be used as basis in grading of practical examination.
6. Practical examination may be carried out on production welds counter checked by the NDT Level III or his designee.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 28 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
APPENDIX IV
GRADING OF PRACTICAL EXAMINATION
MAGNETIC PARTICAL OR LIQUID PENETRANT TESTING
1. At least one ( 1 ) specimen shall be used for examination.
2. All indications, relevant or non-relevant shall be reported, on a standards report format including comments on indications found.
3. Oral test shall be conducted to assess the individuals knowledge on the limitation of the test system, techniques and procedures used, code / standard, and equipment sensitivity calibration.
4. In cases where test specimens containing known discontinuities are not available, specimens without discontinuity may be used where the test technique will be assessed.
5. At least ten check point prepared and approved by the NDT Level III shall be used as a basis in grading of practical examination.
6. Practical examination may be carried out on production welds witnessed by the NDT Level III or his designed examiner.
PT. VERONIKA PRIMA SANITA
Procedure no. : VPS WP - 01
Revision no. : 00
Date : 31 May, 2013
Page : 29 of 29
WRITTEN PRACTICE FOR QUALIFICATION & CERTIFICATION OF NDE PERSONNEL
APPENDIX V
Eye Examination: Shades of Gray
Instructions: Use as a hardcopy or on the Computer screen at a distance of 30-50 cm under
normal desktop working light conditions.
Passing grade: min.20 correct readings required.
6
9
4
1
3
33
7
2
22
11
18
12
67
39
26
1
84
34
101
68
44
88
45
73
91