2
1. INSPECTION PROTOCOL
To ensure a standard, objective inspection procedure, we have developed an inspection protocol to provide institutions with a risk management tool based on preventive maintenance. This protocol covers Physio-Trace Inc. slings and was developed based on the requirements and recommendations in the following norms and standards:
• CSA/ISO1 10535: 2006 (Canadian Standards Association or CSA Group) • OSHA 29 CFR 1910.184 (Occupational Safety and Health Administration) • ANSl2/ASME B30.9 (American Society of Mechanical Engineers) • WSTDA-WS-1 (Web Sling & Tie Down Association) • BS 3481 (British Standard) ___________________
(1) International Organization for Standardization
(2) American National Standards lnstitute
DO NOT PULLthe handles and straps in the opposite direction.
CORRECT WAYto verify handles and straps.
2. INPSECTION METHODOLOGY
The following steps are required for a complete inspection:
• Lay out the sling on a flat surface in a well-lit area.
• Inspect both sides of the sling.
• Inspect all of the seams.
• Inspect every strap. (1) • Inspect every handle. (2) • Inspect the fabric and netting. (3) • Inspect the leg supports. (4) • Inspect the label. (5)
1
1
1
1
4
2
3
3
5
2
2
3
EXAMPLES OF DEFECTS
FABRIC
STRAPS
Worn or ripped seams
Worn or ripped seams
Fading
Deterioration or snags
Fraying
Abrasive wear
Holes
Illegible label
Frayed edges
4
This sling must be tested (inspect the sling, straps, and handles) before being used by a patient. Do not use if fabric is torn or shows excessive ware.
The fabric should be inspected every 6 months to ensure its stability & durability.Write the inspection dates in the space above.
PREVENTIVE INSPECTION
Name of institution:
Name of patient:
Serial number: Date of initial use:
Date: By:
INC.
Inspect both sides of the sling
Inspect all of the seams
Inspect every strap (1)
Inspect every handle (2)
Inspect the fabric and netting (3)
Inspect the leg supports (4)
Inspect the label (legible) (5)
No tearing
No excessive wear
No fraying
No shrinkage
No fading
No changes in texture(e.g. roughness, brittleness, stiffness)
No weakened areas
COMPLIANT NON-COMPLIANT
If you have CHECKED ANY NON-COMPLIANT BOXES, stop using this sling, remove it from use, and notify
your supervisor.
1
1
1
1
4
2
3
3
5
2
2
DLCANA.com
Numéro série: Date: Mise en service: Par: Nom patient: Nom institution: Check Box 1: OffCheck Box 15: OffCheck Box 18: OffCheck Box 19: OffCheck Box 20: OffCheck Box 21: OffCheck Box 22: OffCheck Box 23: OffCheck Box 24: OffCheck Box 25: OffCheck Box 26: OffCheck Box 27: OffCheck Box 28: OffCheck Box 29: OffCheck Box 30: OffCheck Box 31: OffCheck Box 32: OffCheck Box 33: OffCheck Box 34: OffCheck Box 35: OffCheck Box 36: OffCheck Box 37: OffCheck Box 38: OffCheck Box 39: OffCheck Box 40: OffCheck Box 41: OffCheck Box 42: OffCheck Box 43: OffChiffre: Courriel : Imprimer: Reset: Sauvegarde: Fermer: Bloc blanc: