12VDC LED POWER SUPPLYSPEC SHEET DIGEST
LTH-2
LTH-4
LTH-8
LTH-16
LTH-25
LTP-2
LTP-6
LTP-2 and -6 Wiring Instructions
LTP-2 and LTP-6 Plug-in Power Supply Installation Instructions LTP-2 = 25w max. LTP-6 = 60w max.
For GM Lighting LEDTask™ High Output and Standard Output Flexible LED Linear Ribbon and LED Rigid and
Aluminum LightBar
Before wiring to the power supply please determine the wattage of the LEDTask lighting that you are about to
energize (i.e. LTR300-WW High Output Ribbon is 48-watts per reel, LTR300-SO-WW Standard Output Ribbon is 24-
watts per reel, LTB-8, LTAB-N-8 is 1.92-watts each and LTB-16, LTAB-N-16 is 3.84-watts each).
Each plug-in power supply comes with a power cord/ switch/plug, a 120vac/12vdc power supply and a DC Jack.
1) Connect the female end of the power cord to the recessed male contacts on the power supply. 2) Next connect the
female end of the DC Jack to the male end of the DC cord from the power supply. 3) Finally connect the wire leads from
the LTW / LTW-WP Series Connectors to the wire leads from the DC Jack; making sure that the positive (+) lead from the
LTW / LTW-WP is connected to the positive (+) lead of the DC Jack (smooth wire w/white letters) and the negative (-)
lead from the LTW / LTW-WP is connected to the negative (-) lead of the DJ Jack (ribbed wire). Please plug-in the power
supply at this time. If the ribbon does not light up, please check that the in-line switch is turned ‘on’ and that all
connections have correct polarity. Use these guidelines for LTB and LTAB-N LED LightBar installations.
9830 W. 190th St. • Unit F • Mokena, IL 60448 • Toll-Free: (866) 671-0811 • FAX: (708) 478-2640 • www.gmlighting.net
Power Cord
Power Supply
DC Jack
1
2
3
In-line Switch
Project:
Type:
Location:
Contact Phone:
LED ELECTRONIC25W POWER SUPPLYby
PRODUCT DESCRIPTIONUniversal AC input / full range electronic power supply that features short circuit, overload, and over voltage protection. 12VDC output. 88 - 264 VAC input. 47 - 63Hz frequency range at 79% typical efficiency. 2.1 Amps. 25 Watts.
PRODUCT SPECIFICATIONS
Construction: Construction: Sturdy ventilated full metal enclosure for maximum circuit board cooling. No external fusing required. LED indicator for power on. High operating temperature up to 70°C (158°F). Screw terminals.
Electrical: Output voltage 12VDC. 110 - 180% rated output power overload protection. Overload recovers automatically after fault condition is removed. Withstands 300VAC surge input for 5 seconds. Utilizes 105°C (221°F) long life electro-lytic capacitors.
Label: UL recognized.
Not rated for outdoor use.
Catalog Max. Input Output Weight Dimensions Number Wattage Voltage Voltage L W H
LTH-2 25W 120V 12 VDC 6.9 oz. 3-3/16” 2” 1-1/8”
NOTE: For 12V Voltage Drop - Please see our website
L
H
W
1
2
3
4
5
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net e-mail: [email protected] • Specifications subject to change without notice. LTH2_103013
Project:
Type:
Location:
Contact Phone:
LED ELECTRONIC50W POWER SUPPLYby
PRODUCT DESCRIPTIONUniversal AC input / full range electronic power supply that features short circuit, overload, and over voltage protection. 12VDC output. 88 - 264 VAC input. 47 - 63Hz frequency range at 81% typical efficiency. 4.2 Amps. 50 Watts.
PRODUCT SPECIFICATIONS
Construction: Construction: Sturdy ventilated full metal enclosure for maximum circuit board cooling. No external fusing required. LED indicator for power on. High operating temperature up to 70°C (158°F). Screw terminals.
Electrical: Output voltage 12VDC. 110 - 150% rated output power overload protection. Overload recovers automatically after fault condition is removed. Withstands 300VAC surge input for 5 seconds. Utilizes 105°C (221°F) long life electro-lytic capacitors.
Label: ETL listed.
Not rated for outdoor use.
Catalog Max. Input Weight Output Dimensions Number Wattage Voltage Voltage L W H
LTH-4 50W 120V 14.3 oz. 12 VDC 3-7/8” 3-13/16” 1-1/2 ”
NOTE: For 12V Voltage Drop - Please see our website.
L
H
W
1
2
3
4
5
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net e-mail: [email protected] • Specifications subject to change without notice. LTH4_103013
Project:
Type:
Location:
Contact Phone:
LED ELECTRONIC100W POWER SUPPLYby
PRODUCT DESCRIPTIONUniversal AC input / full range electronic power supply that features short circuit, overload, and over voltage protection. 12VDC output. 88 - 264 VAC input. 47 - 63Hz frequency range at 81% typical efficiency. 8.5 Amps. 100 Watts.
PRODUCT SPECIFICATIONS
Construction: Construction: Sturdy ventilated full metal enclosure for maximum circuit board cooling. No external fusing required. LED indicator for power on. High operating temperature up to 70°C (158°F). Screw terminals.
Electrical: Output voltage 12VDC. 110 - 150% rated output power overload protection. Overload recovers automatically after fault condition is removed. Withstands 300VAC surge input for 5 seconds. Utilizes 105°C (221°F) long life elec-trolytic capacitors. Built-in constant current limiting circuit. 100% full load burn-in test. Fixed switching frequency at PFC:67KHz, PWM:134KHz.
Label: ETL listed.
Not rated for outdoor use.
Catalog Max. Input Weight Output Dimensions Number Wattage Voltage Voltage L W H
LTH-8 100W 120V 1.8 lb. 12 VDC 7-1/2” 4” 1-3/4 ”
NOTE: For 12V Voltage Drop - Please see our website.
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net e-mail: [email protected] • Specifications subject to change without notice. LTH8_103013
L
H
W
Project:
Type:
Location:
Contact Phone:
LED ELECTRONIC200W POWER SUPPLYby
PRODUCT DESCRIPTIONUniversal AC input / full range electronic power supply that features short circuit, overload, and over voltage protection. 12VDC output. 88 - 264 VAC input. 47 - 63Hz frequency range at 81% typical efficiency. 16.7 Amps. 200 Watts. Fan cooled.
PRODUCT SPECIFICATIONS
Construction: Construction: Sturdy ventilated full metal enclosure for maximum circuit board cooling. No external fusing required. LED indicator for power on. High operating temperature up to 70°C (158°F). Screw terminals.
Electrical: Output voltage 12VDC. 110 - 150% rated output power overload protection. Overload recovers automatically after fault condition is removed. Withstands 300VAC surge input for 5 seconds. Utilizes 105°C (221°F) long life elec-trolytic capacitors. Built-in constant current limiting circuit. 100% full load burn-in test. Fixed switching frequency at PFC:67KHz, PWM:134KHz.
Label: ETL listed.
Not rated for outdoor use.
Catalog Max. Input Weight Output Dimensions Number Wattage Voltage Voltage L W H
LTH-16 200W 120V 1.15 lb. 12 VDC 8-1/4” 4” 2 ”
NOTE: For 12V Voltage Drop - Please see our website.
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net e-mail: [email protected] • Specifications subject to change without notice. LTH16_103013
L
H
W
Project:
Type:
Location:
Contact Phone:
LED ELECTRONIC320W POWER SUPPLYby
PRODUCT DESCRIPTIONUniversal AC input / full range electronic power supply that features short circuit, overload, and over voltage protection. 12VDC output. 88 - 264 VAC input. 47 - 63Hz frequency range at 79% typical efficiency. 25 Amps. 320 Watts. Fan cooled.
PRODUCT SPECIFICATIONS
Construction: Construction: Sturdy ventilated full metal enclosure for maximum circuit board cooling. No external fusing required. LED indicator for power on. High operating temperature up to 70°C (158°F). Screw terminals.
Electrical: Output voltage 12VDC. 110 - 180% rated output power overload protection. Overload recovers automatically after fault condition is removed. Withstands 300VAC surge input for 5 seconds. Utilizes 105°C (221°F) long life electro-lytic capacitors.
Label: ETL listed.
Not rated for outdoor use.
Catalog Max. Input Output Dimensions Number Wattage Voltage Voltage L W H
LTH-25 320W 120V 12 VDC 9” 4.5” 2”
NOTE: For 12V Voltage Drop - Please see our website.
L
H
W
1
2
3
4
5
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net e-mail: [email protected] • Specifications subject to change without notice. LTH25_103013
Project:
Type:
Location:
Contact Phone:
12VDC LED ELECTRONIC25W PLUG-IN POWER SUPPLYby
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net Specifications subject to change without notice. LTP-2_090213
1-3/4”
1-1/4”
3-1/4 ”
48”
126”
18” DC JACK
PRODUCT DESCRIPTIONLED electronic Class II power supply with 2 prong cord and plug with inline on/off switch. 12 VDC output. 120 AC input. Includes 18” DC jack.
PRODUCT SPECIFICATIONS
Construction: Power supply is in a fully enclosed plastic case. Standard type P1M plug. LED indicator for power on.
Electrical: Output voltage 12 VDC. Short circuit, overload, over voltage and over temperature protections. 126” 2 prong cord and plug with inline on/off switch. 2 amps
Label: ETL listed.
Not rated for outdoor use.
Catalog Max. Input Amps Output Weight Dimensions Number Wattage Voltage Voltage L W H
LTP-2 25W 120V 2.0 12 VDC 10.4 oz. 3-1/4” 1-3/4” 1-1/4”
NOTE: For 12V Voltage Drop - Please see our website: http://www.gmlighting.net/products/12vdc-electronic-led-power-supplies and click on 12VDC Voltage Drop Chart on the left sidebar, or see page 67 in GM Lighting’s 2013 Product Catalog
Project:
Type:
Location:
Contact Phone:
12VDC LED ELECTRONIC50W PLUG-IN POWER SUPPLYby
GM Lighting, LLC • 9830 W. 190th St. • Unit F • Mokena, IL 60448Toll-Free: (866) 671-0811 FAX: (708) 478-2640 • www.gmlighting.net Specifications subject to change without notice. LTP-6_090213
2-3/8”
1-1/4”
5-1/2 ”
48”
126”
18” DC JACK
PRODUCT DESCRIPTIONLED electronic Class II power supply with 2 prong cord and plug with inline on/off switch. 12 VDC output. 120 AC input. Includes 18” DC jack.
PRODUCT SPECIFICATIONS
Construction: Power supply is in a fully enclosed plastic case. Standard type P1M plug. LED indicator for power on.
Electrical: Output voltage 12 VDC. Short circuit, overload, over voltage and over temperature protections. 126” 2 prong cord and plug with inline on/off switch. 5 amps.
Label: ETL listed.
Not rated for outdoor use.
Catalog Max. Input Amps Output Weight Dimensions Number Wattage Voltage Voltage L W H
LTP-6 50W 120V 5.0 12 VDC 14.8 oz. 5-1/2” 2-1/4” 1-1/4”
NOTE: For 12V Voltage Drop - Please see our website: http://www.gmlighting.net/products/12vdc-electronic-led-power-supplies and click on 12VDC Voltage Drop Chart on the left sidebar, or see page 67 in GM Lighting’s 2013 Product Catalog