1980/89 SECTION 103LIGHT TRUCK
2A452 ADJ. ARM - Refer to group I0A313
8A652 SPACER - Refer to group 10A313
9B450 BRACKET - Refer to group 10A313
10044-120 Refer to group 11001 - 2 for Starter Parts List Instructions
10094 BEARING - Refer to Parts List Section 103
10145 ADJ. ARM - Refer to woup 10*313
10156 BRACKET ALT, - Refer to soup 10A313
10300 ALTERNATOR ASSY. - Refer to group 10346
109301 BOARD ALT CIRCUIT - Refer to Parts List Section 103
10A303-10A304 Refer to group 10346 for Alternator Parts List instructions
10304 RECTIFIER - Refer to Parts List Section 103
10*304 BEARING REAR - Refer to Pans Ust Section 103
10*313 BRACKET ALT. - Refer to goup 10A313
10316 REGULATOR - Refer to Parts Ust Section 103
10320 BRUSH HOLDER - Refer to Parts List Section 103
10328 RING ROTOR SLIP - Refer to Parts List SectIon 103
10329 iNSULATOR - Refer to Pads Ust Section 103
10330 SHAFT - Refer to Parts List Section 103
10333 HOUSING - Refer to Parts List Section 103
10334 HOUSING REAR - Refer to Pans List Section 103
10335 ROTOR - Refer to Parts Ust SectIon 103
10336 STATOR - Refer to Parts List Section 103
10336 BRACKET ALT. - Refer to group 10*313
10347 BRUSH & TERMINAL SET - Refer to Parts List SectIon 103
10349 SPRING BRUSH - Refer to Pads Ust Section 103
10351 HOLDER BRUSH - Refer to Parts List SectIon 103
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
2 SECTION 103 1980/89LIGHTTRUCK
10355 RETAINER FRONT BEARING - Refer to Parts List Section 103
10360 STOP ROTOR - Refer to Parts List Section 103
10310 RING ROTOR STOPI - Refer to Pads List Section 10310370 SPACER - Refer to arouo 10*313
10374 DIODE POS. - Refer to Pads List Section 103
10378 DIODE NEG. - Refer to Parts List Section 103
10383 INSULATOR KIT - Refer to Parts List Section 103
10827 CAPACITOR RADIO - Refer to Parts List Section 103
YEAR MODEL/RESTRICTIONSENGINE
CYL. C.l.D.C.C.D
AllAll
PART NUMBER
IOA3IO FAN ALTERNATOR - Also refer to group 10346Notes: A-M-Motorcraft
eo/85/80/83/84
E-P-UIOO/35OB-PE-F-LI100/35OB-R
6&84&66&84&6
AllAll
E5SZ 1OA31O-A
D9AZ 1OA3IO-A
MAKEA
M
MM
AMP
40,60,6570,10040.60
DESCRIPTION
GP-618
0P-602
OTY.
10*313 ALTERNATOR MOUNTING PARTSAlternator mounting parts are listed in chart orm following the illustration below. Refer to theillustration to determine the name of the part required. Refer to the chart to select the appropriatepart number. The chart is listed by year, model, engine and alternator make and amperage.Attaching parts such as bolts, nuts etc. are listed by code number. A listing of the code numbersand their corresponding part numbers and descriptions appears at the end of the chart.
p.4513
1980/89 SECTION 103 3LIGHT TRUCK
MOUNTING BRACKETSALTERNATOR ADJUSTMENT ARM FRONT SIDE
MODEL A AMP. ‘NUTS, ‘NUTS, ‘NUTSMAKE PART NUMBER BOLTS, PART NUMBER BOLTS, PART NUMBER BOLTS,- - ETC. ETC. ETC.
A M-Motorcraft, t Cut to lengtheBEFER TO HARDWARE LISTING AT END OF CHART FOR NUMBER SHOWN IN THIS COLUMN
10A313 ALTERNATOR MOUNTING PARTS
1980/4 CYL. 2.OL 122 C.l.Dj, 2.3L 140 CJ&J..
R - - without P/S - 1983/87A - - without P/S
MAll
40,60All
E3TZ 10145-A 42 E3TZ 10A313-A 63
R - - with p/S - 1983/87A - - with P/S
MAll
40,60All
E5TZ 10145-C 42 E3TZ 10A313-A 63
R - - 1988 M At E8TZ 10145-A E3TZ 10A313-AP - - 1989 M At E8TZ 10145-A E9TZ 10A313-A
4 CYL. 2.2L 134 C.I.D. - DieselR M QQ E3TZ 2A452-A 42 E3TZ 10A313-D 65
4 CYL. 2.3L 140 C.l.D. - TC Djpi_B-R M All E5TZ 10145-B
Arm &E5TZ 10B315-ABrace
E5TZ 10A313-B
6 CYL 2.BL 171 CJ.D.QQB-P M E3TZ 10145-F E3TZ 10A313-F
A All All * E69Z 10145-AArm &E69Z 10B315-ABrace
*E69Z 10A313-ANot replaced
67
6 CYL. 2.9L 177 C.I.D.AllB-R M E8TZ 10145-B I______ E6TZ 10A313-A
6 CYL. 3.OL 183 C.l.D.A M All E69Z 10145-B
Arm &E69Z 10B315-BBrace
E69Z 10A313-B
6 CYL. 3.8L 230 C.l.D.F100 - 1982/83-Before 3/83" M * E2SZ 10A313-B 6tF100 - 1983-From 3/83" M .4QQQ. E75Z 10A313-A 6t
6 CYL. 4.9L 300 C.l.D. -
40,60
40,60
40,60
40,60
40,60
40,60
E100/350 - - unleaded fuel -
1960/84F-UtOO/t50 - - unleaded tuel -
1980/84F250 - - 2/W/D - -
unleaded fuel - 1980/84F250 - - 4/W/D - -
unleaded fuel - 1984F350 - - w/single r/wheeis - -
unleaded fuel - 1980/84F350 - - w/dual r/wheels andAfT-unleaded fuel-1981/84
M
M
M
M
M
M
C9AZ 10145-C 22,42 *D9TZ 10A313-Ar/bE5TZ 10A313-A
50,51,60
60
F250 - - 4/W/D - -
unleaded fuel - 1980/83F350 - - w/dual r/wheels - -
unleaded fuel-1980F350 - - w/duai r/wheels andM/T-unleaded fuel-1981/84
M
M
M
40,60
40,60
40,60
* D2TZ 10145-C 22,42 *D9TZ 10A313-Ar/bE5TZ 10A313-A
50,51,60
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
4 SECTION 103 1980/89
LIGHT TRUCK
MODELALTERNATOR ADJUSTMENT ARM
MOUNTING BRACKETSFRONT SIDE
AMAKE
AMP.PART NUMBER
‘NUTS,BOLTS,
ETC.PART NUMBER
‘NUTS,BOLTS,
ETC.
‘NUTSPART NUMBER BOLTS,
ETC.- -
A MMotorcraft, * Cut to lengtheREFER TO HARDWARE LISTING AT END OF CHART FOR NUMBER SHOWN IN THIS COLUMN
10A313 ALTERNATOR MOUNTING PARTS - Cont’d
1980/6 CYL. 4,9L flOO CJ.D. -
E-FIOO/25O - - 2/W/D - - M 70,100 D7TZ 10145-A 22,42 *D9TZ 10A313-A 50,51,unleaded fuel - 1980/84 r/bE5TZ 10A313-A 60F250--4/W/D-- M 70unleaded fuel - 1984E350 - - unleaded fuel - 1980/84 M 70,100F-U150--4/W/D-- H 70unleaded fuel - 1980/84P350 - - w/single r/wheels - - M 70unleaded_fuel_-_1980/84F250 - - 4/W/D - -
unleaded fuel - 1980/83P350 - - w/dual r/wheeis - -
unleaded fuel - 1980/84
M
M
70
70
* D7TZ 10145-B 22,42 E5TZ 10A313-A 50,51,60
E100/350 - - leaded fuel-Canada - 1980/84p-uioo/iso - - leaded fuel-Canada - 1980/84F250 - - 2/W/D - - leadedfuel-Canada - 1980/84P350 - - w/single r/wheets-leaded fuel-Canada - 1980/84
M
M
M
H
40,60
40,60
40,60
40,60
C9AZ 10145-C 22,42 C9AZ 10A313-A 50,51,60
F250 - - 4/W/D-ieaded fuel-Canada - 1980/84P350 - - w/dual r/wheels-leaded_fuel-Canada_-_1980/84
M
M
40,60
40,60
* D2TZ 10145-C 22,42 C9AZ 10A313-A 50,51,60
E-F100/250 - - 2/W/D-leadedfuel-Canada - 1980/845350 - - leaded fuel-Canada - 1980/84F-U150 - - 4/W/D-leadedfuel-Canada - 1980/84F3SO - - w/single r/wheels-leaded_fuel-Canada_-_1980/84
M
M
M
M
70,100
70,100
70
70
D7TZ 10145-A 22,42 C9AZ 10A313-A 50,51,60
P250 - - 4/W/D - - leadedfuel-CanadaF350 - - w/dual r/wheels-leaded_fuel-Canada_-_1980/84
M
M
70
70
* D7TZ 10145-B 22,42 C9AZ 10A313-A 50,51,60
F-U150/250 - - 1985/88E150/350 - - 1985/86F350 - - w/singte r/wheels - 1985/86
HMM
40,6040,60QJQ
C9AZ 10145-c 22,42 E5TZ 10A313-A 51,60
F350 - - w/dual r/wheels - 1985/86 M iQáQ * D2TZ 10145-c 22.42 ESTZ 10A313-A 51.60E-F-U15O/350 - - 1985/86 JL 7O.j D7TZ 10145-A 22,42 E5TZ 10A313-A 51,60E-F-U150/35O - - 1987/ AlL ..AlL EBTZ 10A313-C
8 CYL._4.2L_255_C.I.D.iQâQFl® M D9LJZ 10145-A 42,57 EOTZ 9B450-C 24.63
F100 M 10jQQ * DØUZ 10145-B 42.57 EOTZ 9B450-C 24.638 CYL_5.OL_302_C.LD.
E100/250 - - 1980/85 i1I0F-U100/250 - - w/unieaded M 40,60fuel
D9UZ 10145-A 42,57 EOTZ 9B450-C 24,63
1980/89 SECTION 103 5LIGHTTRUCK
MOUNTING BRACKETSALTERNATOR ADJUSTMENT ARM FRONT SIDE
MODEL A AMP. ‘NUTS, ‘NUTS, ‘NUTSMAKE PART NUMBER BOLTS, PART NUMBER BOLTS, PART NUMBER BOLTS,
ETC. ETC. ETC.A M-Motorcraft, * Cut to length
‘REFER TO HARDWARE LISTING AT END OF CHART FOR NUMBER SHOWN IN THIS COLUMN10A313 ALTERNATOR MOUNTING PARTS - Cont’d
1980/8 CYL._5.01_302_C.I.D.
E100/250 - - 1980/85F-U100/250 - - w/unleadedfuel_- -_1980/86
MH
70,10070,100
* D9UZ 10145-B 42,57 EOTZ 98450-C 24,63
E150/250 - - 1986 M All D9UZ 10145-A E6U2 9B450-AE-F-Ul00/250 - - w/leadedfuel-Canada
M 40,60 D3AZ 10145-C 42 D4AZ 10156-A &EIAZ 10A336-Aadapter &
* DIAZ 8*652-Asoacer
16,39
E-F-Ul0O/250 - - w/leadedfuel-Canada
H 70,100 * D4AZ 10145-A 42 D4AZ 10156-A &EIAZ 10A336-Aadapter &
* D1AZ 8A652-Aspacer
16,39
U150E15O/350 - - 1987
HM
100100
ESAZ 10A313-A
E-F-U150/350 M j99 E7TZ 10A313-BEI5O/350 M !QjQ0 E8TZ 1OA313-A
8 CYL._5.8L_351_C.I.Dj-ME-F-U150/350 - - 1980/81 H 40,60 * EOTZ 10145-B 42,57,
59EOTZ 9B450-A
E-P-U150/350 - - 1980/81 H 70,100 EOTZ 10145-A 42,57,59
EOTZ 9B450-A
8 CYL._5.8L_351_C.l.D.-WE100/350 "Before 11/83"F-U150/350 - - w/unleaded fuel
‘Before 11/83"
HH
40,6040,60
DSUZ 10145-C 42,57,59
EOUZ 9B450-A 58
E100/350 "Before 11/83"F-U150/350 - - w/unleaded fuel
"Before 11/83"
HH
70,10070,100
D5UZ 10145-B 42,57,59
EOUZ 9B450-A 58
5150/350 "From 11/83"F-U150/350 - - w/unleaded fuel
"Prom 11/83"
HH
40,6040,60
DSUZ 10145-CArm &E4TZ 10N345-DBrace
EOUZ 9B450-A
E150/350 - - 1984/87"From 11/83"
F-U150/350 - - 1984/87w/unleaded fuel "From 11/83"
H
H
70.100
70,100
D5UZ 10145-B
Arm &* E4TZ 10N345-E
Brace
EOUZ 9B450-A
E-F-U150/35O - - 1988/w/unleaded_luel
H 70,100 E8TZ 10A313-A
E-F-U150/350 - - Canadaw/Ieaded fuel
H 40,60 D3AZ 10145-C D4AZ 10156-A &DIAZ 8A652-Aspacer &E1AZ 10A336-Aadapter
62
MARCH, 1994 COPYRIGHT © 1094 - FORD MCTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
6 SECTION 103 1980/89LIGHTTRUCK
MOUNTING BRACKETSALTERNATOR ADJUSTMENT ARM FRONT SIDE
MODEL A AMP. SNUTS, ‘NUTS, ‘NUTSMAKE PART NUMBER I BOLTS, PART NUMBER BOLTS, PART NUMBER BOLTS,- - LflIC. ETC. ETC.
A H-Motorcraft, * Cut to length‘REFER TO HARDWARE LISTING AT END OF CHART FOR NUMBER SHOWN IN THIS COLUMN
10A313 ALTERNATOR MOUNTING PARTS - Cont’d
1980/8 CYL. 5.8L 351 C.l.Dj-W - -
E-F-U150/350 - - Canada H 70,100 D202 10145-B D4AZ 10156-A & 62w/Ieaded fuel D1AZ 8A652-A
spacer &E1AZ 10A336-Aadapter
8 CYL 6.6L 400 c.LD.2JQQ.E-F250/350 [Jj. * EOTZ 10145-BJ 42 EOTZ 9B450-A
E-F25O/350 jjj, yQJflQ EOTZ 10145-A J 42 [ EOTZ 9B450-A8 CYL. 6.9L 420 C.l.D., 7.3L 4jCJpj..- DIESEL
F250/350,FSuper Duty-
- w/o Ambulance prep packageH All E3TZ 10145-E
ArmE4TZ 10N345-Csupport
E4TZ 10A313-A
E250/350 - - w/o Ambulanceprep package
H All E3TZ 10145--EArmE4TZ 10N345-Csupport
E4UZ 10A313-A
E250/350 - - w/Ambulanceprep package
L/N 165
165
E8UZ 10145-AArm &E8UZ 10C343-AblockE4TZ 10N345-Csupport
E4UZ 10A313-ABracket &E9UZ 1OA370-Aspacer
P250/350,FSuper Duty- - w/Ambulance prep package
L/N E8UZ 10145-AArm &E8UZ 10C343-AblockE4TZ 10N345-Csupport
E4TZ 10A313-ABracket &E9UZ 10A370-Aspacer
8 CYL._7.5L_460_C.l.D.E-P250/350 - 1980/82 M jQQ * D5TZ 10145-A 42 * D5UZ 9B450-B 46E-F250/350 - 1980/82 ..,.. QjQQ * DSUZ 10145-A 42 * DSUZ 9B450-B 46E-P250/350 - 1983/87-w/o E.F.I. M QJQ. E3TZ 10145-G 42 E3TZ 9B450-D 66g-F250/350 - 1983/87-w/o E.P.l. M 70,j E3TZ 10145-H 42 E3TZ 9B450-D 66E-P250/350,PSuper Duty - -
with_E.F.I.M 60 E7TZ 10156-A E7TZ 10A313-C
E-F250/350,FSuper Duty - -
with E.F,I.F53 - - Stripped Chassis
H
M
100
100
E7TZ 10156-B E7TZ 10A313-C
1980/89 SECTION 103 7LIGHTTRUCK
CODE NUMBER TO PART NUMBER LISTING - Quantity As RequiredCODE PART NUMBER DESCRIPTION CODE PART NUMBER DESCRIPTIONNa
22 * 42961-57-8B-227-E
Bolt-hex. hd. locking-5/16"-18 x1 5/8"
NO.60 * 371741-S
BB-160BoIt-3/8"-16 x 2 1/2" hex. head
40 * 383963-S36BB-545-BE
Bolt-hex. washer head- 5/16-18 x2.91"
61 389483-S36BB-187-EC
Bolt-7/16"-14 x 5" hex. head
42 381649-S2BB-563-AH
Bolt-hex. head-3/8"-18 x 1" 62 56530-S36B-319-N
Bolt-5/16"-18 x 3"
46 385306-S36BB-191-AA
Bolt-hex. hd. 7/16-14 x 6 1/4" 63 N800161-S1O1 Bolt-M8 x 30-hex head64 N802176-52
AB-38-BBolt-Mb x 1.50 x 22.6 hexflange lock50 * 383273-S2
BB-552-CCBolt-3/8"-16 x 5"r/b 389012-S2 65 * 389363-536
BB-187-EDBolt - hex. hd. - 7/16-14 x 49/16"
51
57
* 372305-SBB-429-A
Bolt-3/8"-16 x 1 3/4"66 389762-S36 Bolt - hex. hd. - 7/18-14 x 1 3/16"
* 383969-536BB-545-DD
Bolt - s/ia-is x 5" hexwasher hd.
67 * N803519-S2AB-175-YD
Bolt - M8 x 1.25 x 125.0hex flange head
59 * 57494-S36B-33O
Screw & washer - 3/8-16 x 7/8"
YEAR MODEL/RESTRICTIONS[ ENGINEYL. C.f.D.
C.C.D.PART NUMBER DESCRIPTION OTY.
I0B315 BRACE ALTERNATORL Also refe r to group 10A31385/8785/81
U1501J150
88
302 E.P.I.302 E.P.I.
* E5TZ 10B315-B* E5TZ 10B315-C Attaches from exh. manifold stud to air pump
II
87 A-R 4 140 * E7TZ 10B315-A 1888888
AR--P/S-4x2R--4x4
444
140140140
* E8TZ 10B315-B 111
88/ R - - exc. P/S - 4x2 4 140 E8TZ 10B315-A 11 0316 REGULATOR ASSY. ALTERNA1’OR - Also refer to group 10346
80/81 All 658 All * D9PZ 10316-Arr/E2PZ 10316-A9/83
GR-54O-#D9PF 10316-AAr/b FOPZ 10316-A
1
82/83/84/
All - - w/o IRA alt.R - - gasB
6&84&64&6
AllAllAll
* E2PZ 10316-Ar/bFOPZ 10316-A
9GR54OA #E2PF 10316-AA, E4PE 10316-AA 111
83/84 R - - diesel 4 134 * E3TZ 10316-A *GR_782_ #E3TP 10316-AA, E4TF 10316-BA 1ss/ All - - w/IRA alt. 456 All * E6TZ 10316-A
r/bE73Z 1O316-A11188GR-784-A - use with IRA alt. I
88/ E-F350 - - w/ambulanceprep package
8 446 D8HZ 10316-D *GR_544 1
80/ All 688 All * 31497-S8r/b55981-S2
U-254-screw-hex. head-No. 14-14 x 1/2" I
80/ All 6&8 All 42143-SB U-255-screw-hex. head-No. 14-10 x 3/4" 280/ F-U100/350 658 All N610957-536 AU-4-TT screw-hex. hd. lap - H6 x 13mm 483/ R 4 All N610959-S36 AU-3-RA Screw-hex washer head AR
10317 SHIELD ALTERNATOR SPLASH80/ Eb00/350 - - gas 6&8 All E3UZ 10317-A Rubber 180/ E100/350 6&8 All 385228-S GG-383 Clip-shield to frame 7
10N319 SCREW ALTERNATOR REGULATOR TERMINAL88/ F150/350,PSuper Duty - - 6&8 All E8TZ 10N319-A 10-32 x .37
w/ambulance prep oka.10328-9 Refer to group 10346 for Alternator Parts LIst Instructions10330 Refer to group 10346 for Alternator Parts List Instructions10B33O Refer to group 10346 for Alternator Parts List Instructions10331-6 Refer to group 10346 for Alternator Parts List Instructions10A336 Refer to group 10A313-
10K340 WASHER ALTERNATOR MOUNTING BRACKET83/87 I E-F250/350 - diesel I 8 I 420 I * E3TZ 10K340-A I 3/8" AR
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN, MICHIGAN
COMPANY FINAL ISSUE
1980/89 SECTION 103 9LIGHTTRUCK
MODEL IDENTIFICATIONTV APE
B C D E F 0 AMAKE
AMP. PART NUMBER
NOTE: M-Motorcraft10344 PULLEY ALTERNATOR-AIso refer to group 10346 Ident flcatlon chart______________________________________
1980/4 CYL. 2.01 122 C.l.D., 2.3L 1 40 C.I.D.R - - 4 x 2-6 groove D9AF 10A352-M 0
E2AF 10A352-CAM 40,60 D9AZ 10344-A
GP-599R - - 4 x 4B
E37F 10A352-AA H 40,60 E3TZ 10344-BGP610
8-R E87F 10A352-AA oFI7U 10A352-kA
M 60 E8TZ 10344-AGP-652
4 CYL. 2.2L 134 C.l.D. DIESELR - - diesel D2AF I0A352-AA 6 3.15 .670 .36 1.49 .64 M 70 D2AZ 10344-A
GP-5786 CYL. 2.8L 171 CJ.D., 2.9L 177 C.LD.A - - 4 x 2-6 groove D9AF i0A352- o
E2AF 10A352-CAH 40,60 D9AZ 10344-A
GP-599B-R E87F 10A352-AA 0
FI7U 10A352-AAH 60 E8TZ 10344-A
GP-652A - - 4 x 4B
E37F 10A352-AA M 40,60 E3TZ 10344-BGP-610
6 CYL_3.8L_230_C.l.D.F100 D9ZF 1OA352-AA J
I IM 40,60 E6SZ 10344-B
*Gp_6276CYL4.9L300C.I.D.E-F-Ub00/350 - - w/o hang-onA/C
C9AF 10A352-Aor B
3 2.84 .670 .38 1.02 M 40,60 CSAZ 10344-K*Qp493
E-F-U100/350 - - w/o hang-onA/CEi00/350,F-U100/250 - - w/hang-on A/C
C9AF 10A352-C 6 2.84 .670 38 1.40 .64 H 40,60,70
C5AZ 10344-1GP-494D2OZ 10344-BGP-573
E150/350 - - 6 groove E7LF 10A352-AIA M 70 E7LZ 10344-AGP-637
E150/350 - - 6 groove E37F l0A352-A2A - M 100 E3TZ 10344-BGP-610
F150/350,FSuper Duty,UlSO - - 6 groove
D9ZF 10A352-AA M 60,75 E6SZ 10344-BGP627
8CYL4.2L255C.l.D. -
1.02 MF100 C9AF 10A352-Aor B
3 2.84 .670 .38 40,60,70
C5AZ 10344-KGP-493
8CYL5.OL302C.l.D. -
E-F-U100/250 C9AF 10A352-AorB
3 2.84 .670 .38 1.02 M 40,60,§VP
C5AZ 10344-KGP-493
Ei50/350 - - 6 groove E37F 10A352-A2A H boo E3TZ 10344-BGP-610
E150/250 - - 6 groove D9ZF 10A352-AA H 60 E6SZ 10344-B*Gp_627
F150/350,FSuper Duty,U150 --6 groove
E2AF 10A352-CAorD9AF 10A352-AA
H 75 D9AZ 10344A*GP_599
MARCH, 1994 COPYRIGHT © 1E94 - FORD MOTOR -DEARBORN, MICHIGAN
COMPANY FINAL ISSUE
10 SECTION 103 1980/89LIGHTTRUCK
MODEL IDENTIFICATION
I
JJ__
NOTE: M-Motorcraft - -
AMP. PART NUMBER
10344 PULLEY L*1LTERNATOR-Also reter to wouP 10346 Identification chart - Cont’d
1980/8CYL.5.8L351C.i.D. -
E-F-U100/350 C9AF 10A352-Aor B
2.84 .670 .38 1.02 H 40,60,65
C5AZ 10344-KGP493
E-F-Ui00/350
Ei00/350
C9AF 10A352-C 6 2.84 .670 .38 1.40 .64 M 70 C5AZ 10344-LGP-494
D2AF 10A352-AA 3.15 .670 .36 1.49 .64 H 100 D2AZ 10344-AGP-578
E-F-U150/350 C5TF 10A352-K2 2.75 .67 .38 1.49 .64.
H 70 E4TZ 10344-BGP-617
E150/350 - - 6 groove E37P 10A352-A2A . 100 E3TZ 10344-BGP-610
E150/35o - - 6 groove D9ZF 10A352-AA 60 E6SZ 10344-B*GP_627
F150/350,FSuper Duty1150 --6 groove
E2AF 10A352-CAorDBAF 10A352-AA -
-
75 D9AZ 10344-AGP-599
8CYL.6.6L400C.l.D,E-F250/350 C9AF 10A352-A
or B3 2.84 .670 .38 1.02 H 40,60,
65C5AZ 10344-KGP-494
E-F250/350 C9AF 10A352-C 6 2.84 .670 .38 1.40 .64 H 70 C5AZ 10344-LGP-494
E250/350 D2AF 1OA352-AA 6 3.15 .670 .36 1.49 .64 M 100 D2AZ 10344-AGP-578
8 CYL 6.9L 420 C.LD., 7.3L 44 6 C.LD. - DIESEL70,100
E-F250/350,FSuper Duty E3TF 10A352-AA, 6or E9TF 10A352-AA
M E9TZ 10344-AGP-6O9-A
E-F350 - - 7.3L Diesel-w/Ambulance orep. option
None L/N 165 EBUZ 10344-AGP-656
8 CYL 1.5L 460 C.l.D.-
-
-
E-F350,FSuper Duty CBAF 10A352-AorB
3 2.84-
.670 .38 1.02 H 40,60,65j99
C5AZ 10344-KGP-493
E-F350,FSuper Duty C9AF 10A352-C 2.84 .670 .38 1.40 .64 M 70 C5AZ 10344-1GP-494
E250/350 - - 6 groove E37F 10A352-A 100 E3TZ 10344-BGP-599
E25o/350 - - 6 groove E2AF 10A352-CAprD9AF 10A352-AA -
PART NUMBER MAKEA
60,75 D9AZ 10344-AGP-599 -
DESCRIPTION OTY.YEARENGINE
MODEL/RESTRICTIONS CYL. C.I,D.C.C.D.
AMP
10A344 SPACER ALTERNATOR FAN OR PULLEYNotes: A M-Motorcraft
so/ E-F-U100/350,FSuper Duty 658 All C5AZ 10A344-B M 40,60 GY-808-1l/16" ID. x60, 65 7/8" O.D. x 5/32" thick
ao/ E-F-Ub0O/350,FSuper Duly 6&8 All D2OZ 1OA344-A H 70,100 llllf"I.D. x 7/SOD, x 5/16" thk. 110N345 Refer to group 10A313
1980/89 SECTION 103LIGHTTRUCK
10346 ALTERNATOR ASSY.
HOW TO FIND ALTERNATORS and COMPONENTSBy IDENTIFICATION on ALTERNATOR By MODEL APPLICATION.
1. Locate marking on alternator housing. 1. Refer to Model Application Chart beginning on2. Check marking listed under Identification page 9.
number below to find part number of service 2. Refer to appropriate year, model and engine,alternator, pulley and spacer.
3. Select and refer to appropriate Parts LisI Section and Number,4. If basic number ia not known refer to Illustration Page shown, or to Index
following the General Information Section of this Catalog.5. Select part number shown for affecled Parts List. If more than one part
number is shown refer to Description and Restrictions for clarification,6. Quantity of parts shown in columns A, B or C etc.7. Parts are listed numerically.
IDENTIFICATION EXAMPLE - D9UF 10300-BA is listed in Parts List Section 103.1 Column IA.MODEL APPLICATION EXAMPLE - 1980 Eb00/35O uses 60 amp. D9YY 10348-A
Internal parts for this alternator are listedin Parts List Section 103.1 Column 1A
IDENTIFICATION CHART
IDENTIFICATIONPARTS
LISTSECTION
&NO.
AHAKE
AMRPART NUMBER ILLIJS.
SEC.103
PAGE
ALTERNATOR PULLEY FAN SPACER
NOTE: A M-Motorcraft10346 ALTERNATOR A SSY.
D8BF 10300-CA 1O3.1D H 60 EIBZ 10346-BGL-198-A
C5AZ 10344-KGP-493
ESSZ 10A310-AGP-618
C5AZ 10A344-BGY-808
1
D8BF 10300-DA 103.2B H 70 FOP! 10346-CGL-286
C5AZ 10344-LGP-494
D9AZ 10A310-AGP602
D20Z 10A344-A 2
D8VF 10300-BA 1O3.3C H 100 FOP! 10346-CGL-286
CSAZ 10344-KGP-493
D9AZ 10A310-AGP-602
D2OZ 10A344-A 3
D8VF 10300-CA 1O3.2A H 70 FOP! 10346-CGL-286
C5AZ 10344-KGP-493
D9AZ 10A310-AGP-602
D2OZ 10A344-A 2
D8ZF 10300-AA 103.1C H 40 E1BZ 10346-BGL-198-A
C5AZ 10344-KGP-493
E5SZ 10A310-AGP-618
C5AZ 10A344-B*GY_808
1
D8ZE 10300-CA 103.1D H 60 E1BZ 10346-BGL-198-A
C5AZ 10344-KGP-493
E5SZ 10A310-AGP-618
C5AZ 10A344-B‘GY-808
1
D8ZF 10300-EA 1O3.1C H 40 EIBZ 10346-BGL-198-A
C5AZ 10344-LGP-494
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
1
D9OF 10300-AA 103.2B H 70 FOPZ 10346-CGL-286
C5AZ 10344-KGP-493
D9AZ 10A310-AGP-602
D2OZ 10A344-A 2
D9TF 10300-AA 103.2A H 70 FOPZ 10346-CGL-286
C5AZ 10344-LGP-494
D9AZ 1OA31O-AGP-602
D2OZ 10A344-A 2
D9UF b0300-AA 103.1C H 40 E1BZ 10346-BGL-198-A
D2AZ 10344-AGP-578
E5SZ 10A310-AGP-618
C5AZ 10A344-BGY-808
1
D9UF 10300-BA 103.IA H 60 * D9VY 10346-AGL-200
C5AZ 10344-KGP-493
E5SZ 10A310-A0P-618
C5AZ 10A344-B0Y-808
1
D9UF 10300-CA 103.IA H 60 * D9VY 10346-AGL-200
C5AZ 10344-LGP-494
E5SZ 10A310-AGP-618
C5AZ 10A344-BGY-808
1
D9UF 10300-DA 103.1A H 60 * D9VY 10346-AGL-200
D2AZ 10344-AtGP-578
E5SZ 1OA31O-AGP-618
CSAZ 1OA344-B‘GY-808
I
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
12 SECTION 103 1980/89LIGHTTRUCK
IDENTIFICATION CHART
IDENTIFICATIONPARTS
LISTSECTION&Na
AMAKE
AMR-- PART NUMBER U,LUS.
SEC.103
E6QL
ALTERNATOR PULLEY FAN SPACER
NOTE:-
A M-Motorcraft10346 ALTERNATOR ASSY.- Cont’d
D9UF 10300-EA 103.2A M 70 FOPZ 10346-CGL-286
CSAZ 10344-KGP-493
D9AZ 10A310-AGP-602
D2OZ 10A344-A 2
D9UF 10300-FA 103.3A M 100 FOPZ 10346-CGL-286
D2AZ 10344-A0P-578
D9AZ 10A310-AGP-602
D202 10A344-A 3
D9UF 10300-GA 103.3A H 100 FOPZ 10346-CGL-286
C5AZ 10344-L0P-494
DGAZ 10A310-AGP-602
D2OZ 10A344-A 3
D94F 10300-AA 103.1B M 65 E1BZ 10346-B‘GL-198-A
C5AZ 10344-K5GP-493
E5SZ 1OA31O-AGP-618
C5AZ 10A344-BGY-808
1
EOTF 10300-AA 103.1D M 60 EIBZ 10346-B‘GL-19B-A
CSAZ 10344-LGP-494
E5SZ 10A310-A‘GP-618
C5AZ 10A36O-A 1
E1BF 10300-BA 103.2C.
M 70 FOPZ 10346-CGL-286
E4TZ 10344-B0P-617
D9AZ 10A310-AGP-602
D2OZ 10A344-A 2
E1TF 10300-AA 103.1F H 60 E1BZ 10346-B‘GL-198-A
C5AZ 10344-LGP-494
E5SZ 10A310-A‘GP-618
C5AZ 1OA360-A 1
E1TF 10300-BA 103.2C H 70 FOPZ 10346-C5GL-286
C5AZ 10344-KGP-493
D9AZ 10A310-A0P-602
D202 10A344-A 2
E1UF 10300-AA 103.3B H 100 FOP! 10346-CGL-286
CSAZ 10344-LGP-494
DBAZ 10A310-AGP-602
D2OZ 10A344-A 3
E1VF 10300-AA 103.3B H 100 FOPZ 10346-CGL-266
C5AZ 10344-KGP-493
D9AZ 10A310-AGP-602
D2OZ 10A344-A 3
E1ZF 10300-AA 103.1E M 40 E1BZ 10346-B‘GL-198-A
C5AZ 10344-KGP-493
E5SZ 10A310-AGP-618
CSAZ 10A344-B I
EIZF 10300-CA 103.IF H 60 E1BZ 10346-BGL-196-A
C5AZ 10344-K‘GP-493
E5SZ 10A310-AGP-618
C5AZ 10A344-B 1
E1ZF 10300-DA 103.1E H 40 E1BZ 10346-BGL-198-A
C5AZ 10344-LGP-494
E5SZ 10A310-AOP-618
CM! 10A344-B 1
E2DF 10300-AA 103.111 H 40
60
E202 10346-BGL-2l1
D9AZ 10344-AGP-599
ECU 10A310-A‘GP-618
C5AZ 10A344-BGY-808
I
1E25F 10300-BA 103.10 M E2GZ 10346-B*_fl
D9AZ 10344-A‘GP-599
E5SZ 10A310-AGP-618
C5AZ 1OA344-BGY-606
E27F 1O300-AA 103.1E H 40 EIBZ 10346-BGL- 198-A
D9AZ 10344-A50P-599
D9AZ 10A310-AGP-602
1
E27F 10300-BA 103.1F H 60 E1BZ 10346-B‘CL- 198-A
D9AZ 10344-A‘GP-599
D9AZ 10A310-A‘CP-602
I
E3TF 10300-AS 103.2C H 70 FOP! 10346-C‘GL-286
E9TZ 10344-A‘GP-609-A
D9AZ 10A310-A‘GP-6O2
D2OZ 10A344-A 2
E3TF 10300-BA 103.bF M 60 EIBZ 10346-B‘GL-196-A
E9TZ 10344-A‘GP-609-A
E5SZ 10A310-A‘GP-618
CSAZ 10A360-A 1
E3UF 10300-AB 103.3B M 100 FOP! 10346-C‘GL-286
E9TZ 10344-A*CP-609-A
D9AZ 10A310-A*GP-602
D2OZ 10A344-A 3
E37F 10300-AA 103.2C H 70 FOP! 10346-C‘GL-266
D2AZ 10344-A‘GP-578
D9AZ lOA3lO-A‘GP-602
D2OZ 10A344-A 2
E37F 10300-BA 103.1F M 60 E1BZ 10346-B‘OL-198-A
C5AZ 10344-K‘GP-493
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
I
E37F 10300-CA 103.1E H 40 E1BZ 10346-B‘GL-198-A
C5AZ 10344-K‘GP-493
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
1
IE37F 10300-DA balE M
M
40
60
EIBZ 10346-B‘GL-lOa-A
E3TZ 10344-B‘GP-610
ECU 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
E37F 10300-EA 103,IF EIBZ 10346-BOL-198-A
E3TZ 10344-B‘GP-610
ESSZ 10A310-AGP-618
CM! 10A344-B‘GY-608
1
1980/89LIGHTTRUCK
SECTION 103 13
IDENTIFICATJON CHARTIDENTIFICATION
PARTSLIST
SECTION&NO.
AMAKE
AMP.PART NUMBER ILLUS.
SEC.103
PAGE
ALTERNATOR PULLEY FAN I SPACER
NOTE: A M*Mot orcraft10346 ALTERNATOR ASSY.- Cont’d
E4TF 10300-AA 103.1E H 40 E1BZ 10346-B‘OL-198-A
C5AZ 10344-L‘GP-494
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
I
E4TF 10300-BA 103.1E M 40 E1BZ 10346-B‘GL-198-A
E4TZ 10344-B‘GP-617
E5SZ 10A310-AGP-618
C5AZ 10A344-BCY-808
1
E4TF 10300-CA 103.IF H 60 EIBZ 10346-B‘OL-198-A
E4TZ 10344-B‘GP-617
E5SZ 10A310-A‘GP-618
C5AZ 10A344-BGY-808
1
E4UF 10300-AA I03.IE M 40 E1BZ 10346-B‘GL-198-A
C5AZ 10344-K‘OP-493
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
I
E47F 10300-AA 103.1F H 60 E1BZ 10346-B‘OL-198-A
D2AZ 10344-A‘OP-5i8
E5SZ 10A310-A,GP-618
C5AZ 10A344-B‘GY-808
1
E47F 10300-BA 103,IE H 40 EIBZ 10346-B‘GL-198-A
E3TZ 10344-B0P-6l0
ESS! 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
I
E47F 10300-CA 103.IE M 40 EIBZ 10346-B‘GL-198-A
E4TZ 10344-A‘GP-616
E5SZ 10A310-A‘OP-618
C5AZ 10A344-B‘GY-808
1
E57F 10300-AA 103.4A M 40 E9PZ 10346-A‘GL-263
D9AZ 10344-A‘GP-599
E5SZ 10A310-A0P-618
C5AZ 10A344-B‘GY-BOS
I
EDE57F 10300-AA 103.4A H 40 E9PZ 10346-A‘GL-263
D9AZ 10344-A‘OP-599
ESSZ 10A310-A‘GP-618
CSAZ 10A344-B‘GY-808
I
E57F 10300-BA 103.4B M 60 E9PZ 10346-A‘01-263
D9AZ 10344-A‘GP-599
ESSZ 1OA3IO-A‘OP-618
CSAZ 10A344-B‘OY-808
I
EDE57F 10300-BA 103.4B H 60 E9PZ 10346-A‘OL-263
D9AZ 10344-AOP-599
E5SZ 10A310-A‘OP-618
C5AZ 10A344-B‘GY-BOS
1
E6TF 10300-AA 103.IL H
H
60
60
E9PZ 10346-A‘GL-263
C5AZ 10344-L‘OP-494
ECU 10A310-A‘OP-618
C5AZ 10A344-B‘GY-BOB
15
E6TF 10300-BA 103.1L E9PZ 10346-A‘GL-263
C5AZ 10344-K‘GP-493
ECU 10A310-A‘OP-618
C5AZ 10A344-B‘GY-808
IS
E6TF 10300-CA balL H 60 E9PZ 10346-A‘GL-263
E4TZ 10344-B‘GP-61i
E5SZ 1OA3IO-A‘GP-618
C5AZ 1OA344-B‘GY-808
IS
E6TF 10300-DA 103.IL H
H
60
60
E9PZ 10346-A‘GL-263
C5TZ 10344-J‘GP-466
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-808
IS
E6UF 10300-AA 103.1L E9PZ 10346-A‘GL-263
E9TZ 10344-A‘GP-609-A
E5SZ 10A310-A‘GP-618
CSAZ 1OA344-B‘GY-806
15
E67F 10300-CA 103.IH M 40 E9PZ 10346-A‘01-263
E4TZ 10344-A‘OP-616
E5SZ 10A310-A‘GP-618
C5AZ 1OA344-B‘GY-808
15
E67F 10300-DA 103.1L M 60 E9PZ 10346-A‘GL-263
D9AZ 10344-A‘GP-SgG
ECU 10A310-A‘GP-616
C5AZ 10A344-B‘GY-808
15
E67F 10300-EA 103.1J M 40 E8PZ 10346-C‘GL-260
E4TZ 10344-A‘OP-616
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-BOB
15
E67F 10300-FA 103.1K M 60 E8PZ 10346-C‘OL-260
E4TZ 10344-A‘GP-616
E5SZ 10A310-A‘GP-618
C5AZ 10A344-B‘GY-BOB
15
E69F 10300-AA 103.IJ M 40 E8PZ 10346-C‘OP-260
D9AZ 10344-A*Qp.599
E5SZ 10A310-A‘GP-616
C5AZ 10A344-B‘GY-808
15
ISE69F 10300-BA 103.1K H 60 EBPZ 10346-C‘GL-26O
D9AZ 10344-A‘GP-599
E5SZ 10A310-A‘GP-618
C5AZ 1OA344-B‘GY-BOB
EDE7DF 10300-BA 103.2D H 70 POP! 10346-C‘GL-286
E7LZ 10344-A‘GP-63i
E6DZ 10A310-C‘OP-626
D20Z 10A344-A 2
E7TF 10300-BA balL M 60 E9PZ 10346-A‘GL-263
E4TZ 10344-A‘GP-616
E73Z 1OA31O-A‘GP-624-A
C5AZ 10A344-B‘GY-808
15
E7TF 10300-GA b03.3C H 100 FOP! 10346-C‘OL-286
E4TZ 10344-A‘GP-616
E6DZ 10A310-C‘OP-626
D2OZ 10A344-A 3
MARCH, 1994 COPYRIGHT @ 994 - FORD MOTOR
COMPANY
-DEARBORN, MICHIGAN
FINAL ISSUE
14 SECTION 103 1980/89LIGHTTRUCK
IDENTIFICATION CHART
IDENTIFICATIONPARTS
LISTSECTION
& NO.
IA I AHP.
MAKE I,J,,,,,,,
PART NUMBER ILLUS.ALTERNATOR PULLEY FAN SPACER SEC.
103PAGE
NOTE: A M-Motorcraft10346 ALTERNATOR AS
E7TF bO300-JA I03.3C MSY.-
100Cont’d
FOP! 10346-C‘GL-286
E9TZ 10344-A‘GP-609-A
E6D! l0A310-C‘GP-626
D20! 1OA344-A 3
E7TF 10300-LA 103.IL M 60 E9PZ 10346-A‘GL-283
E65Z 10344-B‘GP-62i
E5SZ 10A310-A‘GP-618
CM! 10A344-B‘GY-SOB
IS
E7TF 10300-MA 103,1K M 60 E8P! 10346-C‘GL-260
E6S! 10344-B‘OP-62i
E5S! 10A310-A‘OP-618
CSA! 10A344-B‘GY-BOB
15
E7TF 10300-NA 103.3C H 100
60
70
FOP! 10346-C‘OL-286
E3T! 10344-B‘GP-610
D9A! 10A310-A‘GP-602
D2O! 10A344-A 3
E71ff 10300-SA b03.1P M
H
EBP! 10346-C‘GL-26O
E6S! 10344-B‘GP-62i
E5S! 10A310-A‘GP-618
CSA! 1OA344-B‘GY-BOB
15
E7IJF b0300-AA 103.2D FOP! 10346-C‘01-286
EiL! 10344-A‘GP-63i
E6D! 10A310-C‘GP-626
D20! 10A344-A 2
E79F 10300-BA 103. iN H
M
75
75
75
E9P! 10346-A‘GL-263
D9A! 10344-A‘GP-599
ECS! 10A310-A‘GP-618
C5A! 1OA344-B‘GY-808
15
E8TF 10300-BA 103.IN E9P! 10346-A‘GL-263
E6S! 10344-B‘GP-62i
E5S! 10A310-A‘OP-BIB
CM! 10A344-B‘GY-808
15
E8TF 10300-CA 103.IR H EBP! 10346-C‘GL-26O
E65! 10344-B‘GP-62i
E5S! IOA31O-A‘GP-618
C5A! 10A344-B‘GY-808
15
E8US b0300-AA 103.5A L/N 165 E8U! 10346-A‘GL-266
E8U! 10344-A‘GP-656
EBP! 10A310-A‘OP-657
C5T! 10A344-A A
EB7F 10300-AA 103.1Q H 75 E8P! 10346-C‘OL-260
E4T! 10344-AGP-616
E5S! 10A310-A‘GP-618
C5A! 10A344-B 15
E87F 10300-BA 103.IQ H 75 E8P! 10346-C‘GL-260
E8T! 10344-A‘GP-652
E6SZ lOA3lO-A‘GP-628
C5AZ 10A344-B IS
E87F 10300-CA 103.1K H
H
H
80
70
too
EBPZ 10346-C‘GL-260
EBTZ 10344-A‘GP-652
E6S! 10A310-A‘GP-626
CSA! 10A344-B‘GY-BOB
15
E9TF 10300-AA 103.2D FOP! 10346-C‘GL-286
E9T! 10344-A‘GP-609-A
E6DZ lOA3lO-C‘GP-626
D2O! 10A344-A 2
EgUF fO300-AA 103.30 FOPZ t0346-C‘GL-286
E?LZ 10344-A‘GP-63i
E60Z 10A310-C‘GP-626
020! 10A344-A 3
E9UF 10300-BA 103.1N H 75 E9P! 10346-A‘OL-283
E6SZ 10344-B‘GP-62i
E6SZ 10A310-A‘GP-629
C5A! 10A344-B‘GY-BOB
IS
E9UF 10300-CA 103.3C H 100 FOP! 10346-C‘OL-286
EQT! 10344-A‘GP-609-A
E6D! 10A310-C‘OP-626
D20Z 10A344-A 3
E9UF 10300-DA 103.1L H 60 E9PZ 10346-A‘GL-263
E6S! 10344-B‘OP-62i
E6S! 10A310-A‘OP-Sn
CSAZ 10A344-B‘GY-8O8
15
E9US 10300-AA 103.SA L/N
H
165
sO
E9U! 10346-A‘GL-210
EBU! 10344-A‘GP-656
EBP! 10A310-A‘GP-657
CST! 10A344-A
E97F 10300-AB 103.1T E9P! 10346-C‘OL-268
E8T! 10344-A‘GP-652
EBF! 10A310-A‘GP-655
C5A! 10A344-B‘GY-808
IS
15E97F 10300-BA 103.IL H 60 EOP! 10346-A‘GL-263
E6D! 10344-C‘GP-625
E6S! 10A31O-A‘GP-628
CSAZ 1OA344-B‘GY-808
E99F 10300-AB 103.1S H 80 E9PZ 10346-B‘OL-26i
E6DZ 10344-C‘GP-625
E8F! 10A310-A‘OP-658
C5A! 10A344-B 15
E99F 10300-BA 103.1N H 75 * ETPZ 10346-C‘GL-246
r/bE9PZ 10346-A0L-263
E6DZ 10344-C‘GP-625
E6U 10A310-A‘GP-628
C5AZ 10A344-B‘GY-808
15
D8BF 10346-AA 103.1D H 60 * E20! 10346-C‘01-212
r/bE1BZ 10346-B‘CL- 198-A
1
1980/89 SECTION 103 15LIGHTTRUCK
IDENTIFICATION CHARTIDENTIFICATION
NOTE:
PARTSLIST A
SECTION MAKE&NO, -
A M-Motorcraft
AMP.PART NUMBER ILLU5.
SEC.103
PAGE
ALTERNATOR PULLEY FAN SPACER
10346 ALTERNATOR A SSY. - Cont’d0BVF 10346-AA 103.IA H 60 * D9VY 10346-A
‘GL-2001
D8VF 10346-BA 103.3A M 100 * ElY! 10346-A‘GL-203-A
r/bFOPZ 10346-C‘GL-286
3
D8VF 10346-CA 103.2A H 70 * D9VY 10346-C‘GL-2O2
rIbFOP! 10346-C‘GL-286
2
D8ZF 10346-AA 103.1C 11 40 * El!! 10346-A‘GL-204-A
r/bE1B! 10346-B‘GL-lgB-A
1
D9VF 10346-AA 103.1B H 65 * D9VY 10346-B‘GL-201
r/bE1BZ 10346-B‘GL- 198-A
1
E1BF 10346-AA 103.1F H 60 * E2GZ 10346-C‘OL-212
r/bE1B! 10346-B‘GL- 198-A
1
E1BF 10346-CA b03.2C M 70 * E7P! 10346-B‘GL-199-C
r/bFOP! 10346-C‘OL-286
2
E1EF 10346-CA 103.10 M 60 * E2F! 10346-B‘GL-21 1
1
EIVF 10346-AA 103.38 M 100 * EIV! 10346-A‘GL-203-A
r/bFOP! 10346-C‘GL-286
3
E1ZF b0346-AA 103.1E M 40 * El!! 10346-A‘GL-204-A
r/bElB! 10346-B‘GL-198-A
I
E2DF 10346-AA 103.111 M 40 E2G! 10346-B‘GL-211
1
E3EF 10348-BA 103.1E M 40 * El!! 10346-A‘GL-204-A
r/bEIBZ 10346-B‘GL-198-A
1
ES7F 10346-BA 103.4B M 60 * EST! 10346-A‘GL-224--A
rIbE9P! 10346-A‘OL-263
1
E6TF 10346-AA 103.1L H 60 *E6T! 10346-A‘GL-231
r/bE9P! 10346-A‘GL-263
15
MARCH, 1994 FORD MOTORCOPYRIGHT ® T994 -
C OMFA N V
-DEARBORN. MICHIGAN
FINAL ISSUE
16 SECTION 103 1980/89LIGHTTRUCK
IDENTIFICATION CHART
IDENTIFICATIONPARTS
LISTSECTION
&NO.
AMAKE
AHP.PART NUMBER ILLUS.
SEC.103
ALTERNATOR PULLEY FAN SPACER
NOTE: A M-Motorcraff10346 ALTERNATOR ASSY. - Cont’d
E67F 10346-AA 103.1H H 40 * E6T! 10346-B‘GL-238
rib E9P! 10346-A‘GL-263
IS
E67F 10346-CA 103.IL H 60 * E6T! 10346-C‘GL-244
r/bE9P! 10346-A‘GL-263
IS
E69F 10346-AA I03.1J H 40 * E6QZ 10346-A‘OL-234
ribE8P! 10346-C‘OL-260
15
E69F 10346-BA 103.1K H 60 * E63! 10346-A‘GL-236
r1bEBP! 10346-C‘GL-260
15
E7PF 10346-AA 103.1H H 40 * EiP! 10346-H‘GL-238-A
r/bE9P! 10346-A‘GL-263
15
E7PF 10346-BA 103.1J M 40 * EiP! 1O346-J‘GL-234-A
rib EBP! 10346-C‘GL-260
IS
E7PF 10346-CA 103.IL H 60 * E7P! 10346-K‘GL-244-A
r/bESP! 10346-A‘GL-263
IS
E7PF 10346-DA 103.1L M 60 * EiPZ 10346-K‘GL-244-A
r/bE9P! 10346-A‘01-263
15
E7PF 10346-LA 103.1N H 75 *EiP! 10346-C‘GL-246
r/bE9P! 10346-A‘OL-263
15
E7PF 10346-MA 103,IN H 75 * E7P! 10346-C‘GL-246
r/bE9P! 10346-A‘GL-263
15
E7PF 10346-PA 103.2D H 70 * EiPZ 10346-B‘GL-l99-C
ribFOP! 10346-C‘GL-286
2
E7PF 10346-RA 103.3C H 100 * EiPZ 10346-A‘GL-203-B
r/bFOPZ 10346-C‘OL-2B6
3
E7PF 10346-XA 103.1P H 60 * EiP! 10346-N‘GL-258
r/bEBP! 10346-C‘OL-260
15
1980/89 SECTION 103 17LIGHTTRUCK
IDENTIFICATION CHART
IDENTIFICATIONPARTS
LIST ASECTION MAKE
&NO. -
A M-Motorcratt
AMRPART NUMBER ILLUS.
ALTERNATOR PULLEY FAN SPACER SEC.103
PAGE
ConEd -
E8P! 10346-C 15‘OL-260E9P! 10346-B 15‘OL-267E9P! 10346-C 15‘OL-268
APPLICATION_CHARTPARTS PART NUHBER ILLUS.
A AMP REHARKS LIST SEC.MAKE SEC. ALTERNATOR REGULATOR 103- - &NO. PAGE
ansistorlzed, t TransIstorized
NOTE:10346 ALTERNATOR A SSY. -
E8PF 10346-DA l03.1R H 75
E9PF 10346-AB 103.IS H 60
E9PF 10346-CB b03.IT H 80
MODELENGINE
CYL. C.I.D.C.C.D.
NOTE: M-Motorcraft, t Non-tr10346 ALTERNATOR ASSY.
1980 /E-F-U100/350-
"Before 12/8011
6&8 Alt M 40 103.1C * D9!! 10346-A‘GL-204
*r/bElZZ 10346-Ar/bE1B! 10346-B
‘GL-198-A
* D9PZ 10316-A I‘GR-540
ribFOPZ 10316-A‘GR-540-B
E150/350- "Before 12/80’ 8 All M 60 Std. temp. alt. 1O3.1D * D9B! 10346-A‘GL-19i
*rfbE2G! 10346-C9/81r/bE1BZ 10346-B
‘OL-198-A
* D9P! 10316-A I‘OR-540
r/bFOPZ 10316-A‘OR-540-B
E-F-Ub00/350-Betore 12/80’
6&8 All H 60 Hi temp. all. 103.1A * 09W 10346-A‘OL-200
* D9P! 10316-A 1‘GR-540
ribFOP! 10316-A‘GR-540-B
E-Fl00/350 6&8 All M 65 Hi temp. alt. 103.1B * D9VY 10346-B‘GL-201
r/bEIB! 10346-B‘GL-lgB-A
* D9P! 10316-A I‘GR-540
r/bFOPZ 10316-A‘OR-Mo-B
E-F-U1001350-"Before 12/80’
6&8 All M 70 Hi temp. alt. 103.2A * D9YY 10346-C‘GL-202
r/bFOP! 10346-C‘OL-286
* D9P! 10316-A 2‘OR-540
r/bFOPZ 10316-A‘OR-Mo-B
E100i3SO- "Before 12/801 6&8 All M 100 103.3A * 09W 10346-D‘OL-203
*r/bE1V! 10346-A9/B1r/bFOPZ 10346-C
‘OL-286
* D9P! 10316-A 3‘OR-MO
r/bFOP! 10316-A‘OR-540-B
E-F-Ub00/350-"From 12/80"
B-R - - w/o integral regulator
6&B
4&6
All exo.230All
M
M
40
40
103.1E * El!! 10346-A‘GL-204-A
r/bE1B! 10346-B‘GL-lgB-A
* D9P! 10316-A I‘GR-540
r/bFOP! 10316-A 1‘OR-540-B
B-R - - w/integral regulator-1986
4&6 All H 40 103.1M * E6TZ 10346-B‘GL-238
r/bE9P! 10346-A‘GL-263
E732 10316-A‘OR-784-B
MARCH, 1994 COPYRiGHT © 1994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
18 SECTION 103 1980/89LIGHTTRUCK
-
HODELENGINE
JYL. C.I.D.C.C.D.
AHAKE
AHP REMARKSPARTS
LISTSEC.
& NO.
PART NUMBER LIUS.SEC.
ALTERNATOR REGULATOR 103PAGE
NOTE: M-Motorcraft. t Non-trnsIstorIzed t Transistorized10346 ALTERNATQ&ASSY. - Cont’d
1980/A-B-R 4 All H 40 103.1H * E7PZ 10346-H
‘01-238-Ar/bE9P! 10346-A
‘GL-263
E73! 10316-A IS‘GR-784-B
FlOG 6 230 H 40 103.111 *E2DZ 10346-A‘GL-219
r/bE2G! 10346-B
*D9P! 10316-A 1‘OR-MO
ribFOP! 10316-A‘GR-540-B
E-F-Ul00/350 - - w/ointegral regulator "From 12/80"B-R
6&8
4
All exc.230All
H
H
60
60
103.IF * E2GZ 10346-C‘OL-212
r/bE1B! 10346-B‘01-198-A
* D9P! 10316-A 1‘GR-540
r/bFOP! 10316-A I‘GR-540-B
E-F-U150/350 - - w/integralregulator
6&8 All M 60 103.1L * E6T! 10346-A‘OL-237
r/bE9PZ 10346-A‘GL-263
E73! 10316-A IS‘GR-784-B
F-U150/350 6 300 H 60 Special balance 103.1P E7PZ 10346-N‘GL-258
ET3Z 10316-A 15‘CR-764-B
F100 6 230 H 60 103.10 * ElF! 10346-B‘GL-209-A
r/bE2GZ 10346-B‘OL-211
*D9PZ 10316-A 1‘GR-540
r/bFOP! 10316-A‘GR-540-B
E-F-UlOO/350-FSuper Duty"From 12/80"
6&8 All M 70 103.2C * E1P! 10346-B‘GL-199-C
r/bFOP! 10346-C‘OL-286
* D9P! 10316-A 2‘GR-540
r/bFOP! 10316-A‘OR-540-B
E100/350 ‘From 12/80 to 1986F53 - - Stripped Chassis-diesel
6&88
All446
HH
100100
103.36 * Ely! 10346-A‘OL-203-A
ribFOP! 10346-C‘GL-286
* D9P! 10316-A 3‘OR-540
ribFOP! 10316-A‘OR-540-B
B-R - - diesel-1985 4 14OTC H 60 also used to service40 amp
103.4B * E5TZ 10346-A‘GL-224
*r/bETP! 10346-Kr/bE9P! 10346-A
‘OL-263
E73! 10316-A‘GR-784-B
A - - 2.8L eng. 6 171 M 40 103.1J * E69Z 10346-A‘GL-234
r/bE8P! 10346-C‘01-260
E73! 10316-A 15‘GR-784-B
B-R 6 All H 40 103.lj * E7P! 10346-.‘GL-234-A
r/bE8P! 10346-C‘OL-260
E73Z 10316-A 15‘OR-184-B
A - - 2.8L eng.-l986B-R - - 2.9L eng.-1986
66
171177
H 60 103.1K * E63! 10346-A‘GL-236
r/bE8P! 10346-C‘01-260
6732 10316-A 15‘GR-784-B
1980/89 SECTION 103 19LIGHTTRUCK
APPLICATION CHARTENGINE - 1ATS I PART NUMBER
MODEL YL. C.I.D. A AMP REHARKS LIST SEC.C.C.D. MAKE SEC. ALTERNATOR REGULATOR 103
NOTE: M-Motorcrafl t Non-transIstorlj Transistorized10346 ALTERNATOR ASSY. - Cont’d
1 980/A-B-R 6 All H 60 103.1K * E7P! 10346-0 E73! 10316-A 15
‘GL-236-A ‘GR-784-BribE8PZ 10346-C
‘OL-260A - - 2.3L, 3.OL eng. 4&6 All M 40 103.1H * E6TZ 10346-B E73! 10316-A 15
‘GL-238 ‘OR-784-Br/bE9PZ 10346-A
‘OL-263A - - 2.3L, aOL eng.-1986 4&6 All H 60 103.1L * E7P! 10346-K E732 10316-A 15A - - 3.OL-1987/ ‘GL-244 ‘GR-784-B
r/bE9PZ 10346-A‘01-263
A-B-R - - gas-1987/ 4&6 All M 60 103.1L * E7P! 10346-K E132 10316-A 15R - - diesel-1987/ 4 All H 60 ‘OL-244-A ‘OR-784-B
r/bE9P! 10346-A‘GL-263
A 6 183 H 75 l03.1N *E7PZ 10346-C E73! 10316-A 15E-F150/350,FSuper Duty 8 All ‘GL-246 ‘OR-784-B
r/bE9P! 10346-A‘GL-263
A 6 183 H 80 103.1S E9P! 10346-B 15‘GL-261
B All All H 80 103.1T E9P! 10346-C‘GL-268
15
Ul50 All All M All l03.1R E8P! 10346-C‘OL-260
E732 10316-A 15‘GR-784-B
E150/350 - - 1987/ All All M 100 103.3C * E7PZ 10346-A‘GL-203-C
r/bFOPZ 10346-C‘OL-286
* E2P! 10316-A‘OR-54O-A
r/bFOPZ 10316-A‘GR-540-B
E-F350 - - 7.3L diesel wiAmbulance prep. option-1988
8 446 1/N 165 1035A E8U! 10346-A‘01-266
D8HZ 10316-0 -
‘GR-544E-F350 - - 7.3L diesel w/ 8 446 LiN 165 103.5A E9U! 10346-A D8H! 10316-DAmbulance rep, option-1989
YEAR MODEL/RESTRICTIONS ‘}cii.10A346 SHIELD ALTERNATOR HEAT
PART NUHBER
‘GL-270 ‘OR-M4
- DESCRIPTION
80/83 E-F-U100/350 6 300 * D8TZ 10A346-A j 110C346 RESISTOR ASSY. ALTERNATOR WARNING LAMP SHUNT
80/83/84/86
E-F-U100/350,FSuper Duty 6&8 All * D8BZ 1OC346-AA 4&6 All r/bE8OZ 10C346-AB All AllA - - */0 electronic instrument cluster 4&6 All
Use on instrument cluster w/charge indicator 1and oil pressure warning Iights-500 ohms Iresistance I
1
MARCH, 1994 COPYRIGHT © 994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
20 SECTION 103 1980/89LIGHTTRUCK
YEAR MODEL/RESTRICTIONSENGINE
CYL. C.I.D. PART NUMBERC.C.DJL
DESCRIPTION QTY.
10C348 SHIELD ALTERNATO A FAN85/8786/8?
8885/8687/a?8788
B-RA
AE-F 250/350F-U150/350F150/350,FSuiper DutyF250/350 - - dieselF250/350.FSuper Duty - -
diesel
44&6
68
6&8888
140140, t83
E.F.I.183,E,F.l.351,460300,302
460420446
* E5TZ 10C348-Ar/bF1TZ 10C348-A
#E47F 10C348-AA 1t
111111
8686/
AB-F
66
170177
E43! 10C348-A 11
68/88/
E-150/35O,FSuper DutyA-B-R
6684
All140,E.F.l.
* EBS! 10C348-Ar/bFIT! 10C348-A
#E8SF 10C348-AA 11
10C349 CLIP ALTERNATOR FAN SHIELD85/86/
86/85/8687/
8788/
B-RA
AE-F250/350F-U 150/350
F250/350 - - dieselF150/350,FSuper Duty - -
diesel
44
68
668
88
All140EEl.183
351460300,302,
460420446
E5TZ 10C349-A 11
1I1
11
8686/
AB-F
66
170177
E43! 10C349-A 1i
10350-108368 Refer to group 10346 for Alternator Parts List Instructions
1OA37O Refer to group 10A313
108371-10374 Refer to group 10346 for Alternator Parts List Instructions
10374 DIODE ASSEMBLY81/89 R 6 177 E5RY 10374-A #78GG 10374-BA-diode assy. 3 amps., 1
also part of 9A451 asev.10378-10A396 Refer to group 10346 for Alternator Parts List Instructions
10A506 SHIELD ALTERNATOR REGULATOR SPLASH81/85 I Fl00/350.U150 16681 All 1* EITZ 10A506-A I I I
10A545 WIRE ASSY. ALTERNATOR REOULATOR EXTENSION - Improvise
10A568 CONNECTOR ASSY. ALTERNATOR REGULATOR84! E-F-U150/350,FSuper Duty 6&8 All ElF! 10A568-A #E7EB 10A568-AA 184/ B-R 4&6 All 1
1980/89 SECTION 103 21LIGHTTRUCK
I ENGINEYEAR I MODEL
I CYL. C.I.D,- C.C.D.
10653-5 BATTERY CHART
MOTOR-CRAFTGROUP
NO.
DIMENSIONS_INCHESTYPE COLD
CRANKINGAMPS
HOTORCRAFTSALES NUMBERWIDTH LENGTH
AT TOPHEIGHT
80 688 All 22FC 6 27/32 9 13/32 8 3/16 Super HO 400 BX-22-F80 688 6 27/32 9 11/32 8 3/16 Premium lID 340 BR-22-F8o/ 688 All 24F 627/32 10 1/4 8 11/16 Super lID 525 BX-24-F80/ 688 All 24F 6 27/32 10 1/4 8 11/16 Super HD 575 BTT-24-F83/ E-F250/35O - -
diesel8 420 27 6 27/32 12 5/32 8 21/32 Commercial 715 BH-21-A
80/84 All All All 56 6 1/32 10 8 1/4 Premium 370 BA-5680/84 All AN All 56 6 1/32 10 8 1/4 Premium H/D 450 BR-56-A80/84 All All All 56 6 1/32 10 8 1/4 Super H/D 535 BX-5689 R All All 58 7 7/32 9 7/16 6 31/32 Maintenance free 540 BK-SB-C80/ All 688 All 61 6 3/8 7 19/32 8 7/8 Maintenance
free-wet310 BR-61
80/ All 6&8 All 62 6 3/8 8 15/1 6 8 7/8 Maintenancefree-wet
380 BR-62
80/ All 688 All 63 6 3/8 10 3/16 8 7/8 Haintenancefree-wet
450 BX-63
80/81 All 688 All 64 63/8 11 glie 8718 Mainienancefree-wet
475 BX-64
eo/s3/86/
F-U100/350B-AA
688All
4&6
AllAllAll
64 63/8 11 9/16 87/8 Super HD BTT-64
80/
83/8486/
F-U100/350 -
RBA
688
AllAll
486
All
AllAllAll
64A 63/8 11 9/16 87/8 Maintenancefree-wet
535 BX-64-A
87/8889
F-U150/350FSuper DutyF53/59 - - StrippedChassis
6&88
All
AllAllAll
65 73/16 111/8 79/16 Maintenancefree-wet
850 BX-65
69 F-ulSo/3s0 All All 65 7 3/16 ii i/s 7 a/is Maintenance free 650 BXT-65-65088/ A-B-R All All 65 73/16 11 i/s 79/16 Maintenance free 850 BXT-65-85088/YEAR
F-U150/350 ...811_ AllMODEL/RESTRICTIONS PART NUMBER DESCRIPTION I QTY.
10655 BATTERY ASSY. RECHAR GEABLE TELEPHONE POWER PACK88/ All - - w/cellular telechone * E8LY 10655-A I I
10656 ELECTROLYTE BATTERY80! ‘88 14 s gallons-w/attached dispenser hose80/ ‘BB 16 6 uart-w/aftached dispenser hose 1
YEAR MODEL/RESTRICTIONS
-
ENGINECYL1 C.I.D.
I C.C.D.PART NUMBER DESCRIPTION WY.
10t1661 CLIP BAtTERY CABLE RETAINING82 P100 I 61 230 I*E2TZ 10N661-A I I
10662 PLATE ASSY. BATTERY TRAY ATTACHMENT83/ IA--dieset 41 All I E3T! 10662-A I I 2
10A665 WIRING ASSY. ACCESSORY FEED FROM IGNITION SWITCH RESISTOR80/ I ni I All I All I Dan 101.665-A I D9AB 14A407-A.A-8 12 OHMS-circuit 429Th I
10K676 REINFORCEMENT BATTERY TRAY86/88 A 486 All E69Z 10K676-A Front 186/88 A 486 All E69Z 10K676-C Rear 1
10677 SHIELD PuSSY. BATTERY CABLE86/ P250/350,FSuper Duty - - 8 All E6T! 10677-B md. N6t1213-S2 screw
diesel10A691 BRACKET BATTERY CLAMP BOLT - refer to group t0732
MARCH, 1994 COPYRIOH1 0 1994 -_ FORD MOTOR DEAREOAN, MICHIGAN
COMFANY FINAL ISSUE
22 SECTION 103 1980/89LIGHTTRUCK
I ENGINEYEAR I MODEL/RESTRICTIONS YL. C.I.D.
L J C.C.D.PART NUMBER DESCRIPTION
IOTY.
J10N697 BRACE BATTERY TR AY
87/ j150/350,FSuper Duty87/ U150
All AllAll All
E7TZ 10N697-A 1 used for gas engines-2 usedfor diesel engines
Tlor2f
10K699 WIRE ASSY. AUXILIARY BATTERY FEED86/67 E150/350 686 All * E6U! 10K699-A #E6UB 10K699-AA 188/89 5150/350 - - w/trailer tow-
w/o dual batteries‘Before 11/88’
688 All E8U! 10K699-A #E8UB 1OK699-&A I
89 E15O/350 - - w/trailer tow-w/o dual batteries
"From 11/88"
688 All E9U! 101699-A #E9UB 10K699-AA 1
86/ 5150/350 - - w/trailer tow andw/du& batteries
688 All EBU! 101699-B #E8UB I0K6998A 1
10A705 BRACKET BATTERY HOLD DOWN CLAMP - refer to group 10732
10A717 WASHER BATTERY TERMINAL CORROSION ARRESTOR80/ I All 16881 All I CIA! IOA71T-A I 11/16" ID-felt-oil impregnated I 2
10N717 STARTER CORD80/89 I All --gas& 12 volts I All I All 1* E6P! 1ON117-A I Connects from cigar lighter I 1
10718 CLAMP BATTERY HOLD DOWN-AIso refer to group 1073280/ All 688 All AOA 1OTIB-B Adjustable from 5 1/2" x 9" to 7 1/4" x
14 1/4"Consists of2-C5RA 10716-A Clamp 2-C2RA 10755-A Bracket 4-379179-S2 Fastener-stud2-C5RA 10716-B Clamp 1-Instruction sheet
1980/89LIGHTTRUCK
SECTION 103 23
10732 BATTERY MOUNTING PARTS
Battery mounting parts are listed in chart form following the illustration below, Refer to theillustration to determine the name of the part required. Refer to the chart to select appropriatepart number. The chart is listed by year, model and amperage of battery,
Attaching parts such as bolts, nuts, etc. are listed by code number. A listing of code numbersand their corresponding part numbers and descriptions appears at the end of the chart.
CARRIEROR TRAY
CLAMP
BOLT
COVER TOP
COVER SIDE
P.165 35
- 1980/ TYPICAL BATTERY SUPPORT AND CARRIER INSTALLATIONS
MODEL AMP.MRS.
BOLT-CLAMP I CARRIER OR TRAY CLAMP-HOLD DOWN BRACE OR BRACKET
PART NUMBER.NUTS,JBOLTSII PART NUMBERIc..L
*NUTS,BOLTS,Em
PART NUMBERINUTS,BOLTS,
ETC.PART NUMBER
* NUTS,BOLTS,
ETC.* Refer to Hardware Ilstlaflp nd of chart for numbe!Jf9_wn In this column
10732 BATTERY MOUNTING PARTS - QuantIty 1 except where IndicatedNOTE 1- Refer to AfOUD 16C186
1980E100/350-R.H. AN
ext 68* D7A! 10756-C2 22 C6T! 10732-F * D9D! 10718-A 22 D5U! 10741-B 20
E100/350-R.H. 68 * D7AZ I0756-2 22 C6T! 10732-F D4MY 10718-A 22 D5UZ 10741-B 20EI350 - -
w/duelbattery-L.H.
All * DiM 10756-C2r/bE1T! 10756-C
22 E7U! 10732-B D4MY 10718-A 22
22
D8U! 10141-B 20
F-U100/350-R.H."Before 6/80"
All * D7AZ 10756-C42 22 Note 1 EOT! 10718-B EOT! 10A691-A 21
F-U100/350-R.H.-’From 6/80"
All * EITZ 10756-A2r/bE1T! 10756-C
22 Note 1 EOT! 10718-B 22 EOT! 10A691-A 21
F-lJiOO/350 - -
w/dualbattery-L.H.
AN * D7A! 10756-C2/bEIT! 10756-C
22 EOT! 10732-A 10,13,21,23
/
D4MY 10718-A 22 * EOT! 10A705-A 13,26
1981A - 1986/88A - 1989
AllAll
E69! 10756-AE6FZ 10756-A
E69Z 10732-A* E99! 10732-A 33
569! 10118-AE43! 10718-C 31
E69! 10A705-AE69! 10A705-A
‘Before 11/88" r/bFI9Z 10732-BA - 1989
‘From 11/88"All N803471-536 F19! 10732-B 33 E43! 10718-C 31 E69! 10A705-A
COFYRIGHT 0 1994 - FORD MOTOR - DEARBORN, MICHIGANMARCH, 1994COMFANY FINAL ISSUE
24 SECTION 103 1980/89LIGHTTRUCK
MODEL AMRHRS.
BOLT-CLAMP
PART NUMBER* NUTS,BOLTS,
ETC.PART NUMBER
* NUTS,BOLTS,
ETC.
je NUTS,PART NUMBER IBOLTS,
ETC.PART NUMBER
e NUTS,BOLTS,
ETC.* Refer to Hardware Iisj!j nd of chart for numbç r shown in this column
10732 BATTERY MOUNTING PARTS - Quantity 1 except where indicated - Cont’dNOTE I- Refer to oup 16C186
1981/E100/350-R.I4. -
gas - - exc.stripped chassis-1981/87
Alletc. 68
EIT! 10756-C2 22 C6T! 10732-F * D9DZ 10718-A 22 D5UZ 10741-B 20
E150/350-R.H. -
gas - - exo.
stripped chassis-_1981/88
Alletc. 68
E1TZ 10756-C2 22 C6TZ 10732-F EOT! 10718-B 22 D5UZ 10741-B 20
El00/350-R.H.-exc. strippedchassis-1981/87
68 E1TZ 10756-C2 22 C6TZ 10132-F D4MY 10718-A 22 D5U! 10741-B 20
E150/350-R.H.-gas - exc.stripped chassis-1989
Allext. 68
E1T! 10756-C2 22 E8UZ 10732-B EOTZ 10718-B 22 DSU! 10741-B 20
E150/350-R.H.-exc. strippedchassis-1988/
68 E1T! 10756-C2 22 C6TZ 10732-F,1988E8UZ 10732-B,1989
D4MY 10718-A 22 D5UZ 10741-B 20
E350-R.H.-gas-stripped_chassis
ext. 68 E1T! 10756-C2 22 E8UZ 10732-A * D9DZ 10718-A 22 D5U! 10741-B 20
E350-R.H.-strippedchassis
68 E1T! 10756-C2 22 E8U! 10732-A D4MY 1071BA 22 D5U! 10741-B 20
EltO/350 - - v/dualbattery-1.H. - gas198 1/86
All E1TZ 10756-C2 22 E7UZ 10732-B D4MY 10718-A 22 DBUZ 10141-B 20
5150/350- - v/dualbattery_gas-1987/
All E1TZ 10756-C2 22 E7U! 10132-B D4MY 10718-A 22 D8U! 10741-B 20
E150/350 - -
diesel_-_RH.All E1TZ I0756-C2 E4U! 10732-C E3TZ 10718-A E3U! 10741-B
E150/350 - -
diesel_-_L.H.All EITZ 10756-C2 E4UZ 10732-C E3TZ 10718-A E3U! 10141-A
F-U100/350-RH-gas-198 1/86
All E1TZ 10756-C2 22 Note 1 EOTZ 10718-B 22 EOT! 10A691-A 21
F-U100/350 - -
w/dualbattery-L.H.-gas-198 1/86
All Eli! 10756-C2 22 EOT! 10732-A 10,13,21,23
D4MY 10718-A 22 EIT! 10A705-A 13,26
F250/350 - -
diesel-RH.-1981/86
All
..
All
EITZ 10756-C2 28
....
28
Note 1 E3T! 10718-ACLAMP &DOHZ 10741-BSPACER
28 EOT! lOA69l-A 29
F2501350 - -
diesel-L.H.-1981/86
* EITZ 10756-A2r/bEliZ 10756-C
7/B4
E3TZ 10732-B 30
27
E3T! 10718-BCLAMP &DOH! 10747-BSPACER
28 EIT! 10A705-A 29
F-U150/350,FSuper Duty - -
RH.- 1987/89
All * Eli! 10732-Ar/bF4T! 10732-B
E7TZ 10718-B 31
1980/89 SECTION 103 25LIGHTTRUCK
MODEL AMP.MRS.
BOLT-CLAMPe NUTS.
PART NUMBER BOLTS,ETC.
CARRIER OR TRAY CLAMP-HOLD DOWN BRACE OR BRACKET
PART NUMBERe NUTS,BOLTS,
ETC.
e NUTS,PART NUMBER BOLTS,
ETC.PART NUMBER
e NUTS,BOLTS,
ETC.* Refer to Hardware Iisti aj_end of chart for numberehown in this column
10732 BATTERY MOUNTING PARTS - QuantIty 1 except where indicated - Cont’dNOTE 1- Refer to group 16C186
1981 /F-U150/350,FSuper Duty - -
R.H.-1989
A11 * E9T! 10732-8 27rr/bFITZ 10732-B10/9lr/bF4TZ 10732-B* E7TZ 10732-B 32rr/bFITZ 10732-0/6/91r/bF4T! 10732-A
E1TZ 10718-B 31
F250/350, FSuperDuty - - dieselL.H.-1987/88
All E7TZ 10718-B 31
F250/350, FSuperDuty - - dieselL.H.-t989
All * E9T! 10732-C 32rr/bF1T! 10732-Cr/bF4T! 10732-A* E9T! 10732-Brr/bF1TZ 10732-Bl0/91r/bF4TZ 10732-C* E9T! 10132-82rr/bFITZ 10732-810191r/bF4TZ 10732-C
E7TZ 10718-B 31
F53/59 - -
StrippedChassis-gas
A11
All
Eli! 10756-C2 E43! 10718-C
F53/59 - -
StrippedChassis-diesel
E1T! 10756-CM E43! 10718-C2
B-R - - gas4 oyl.-1983/88R - - diesel-R.H.-1983/88
All
All
E1T! 10756-C2 E3T! 10732DTrayE3T! 10762-Asupçort
* E9TZ 10732-ATray
r/bF2T! 10732-CE3T! 10762-A
E7T! 10718-A E3T! 10A705A
B-R - - gas4 cyl.-1989
All E1T! 10756-C2 E7T! 10718-B E3i! 1OA705-A
B-R - - 8 oyl.gas-1983/88
All
All
E1T! 10756-02 28 E3TZ 10732-D,E3TZ 10762-AE9TZ 10732-A
E7T! 10718-A.....,
E3T! 10A7O5-D
B-R - - 6 cyl.gas- 1989
E1T! l0756-C2 28 E1T! 10718-B E3TZ 10A705-D
R - - diesel L.H. All E1T! 10756-C2 28 E3T! 10132-C * E3T! 10718-D E3TZ 10A705-DTray r/bE7T! 10718-AE3TZ 10769-B
-- support -
CODE NUMBER TO PART NUMBER LISTING_- Quantity As RequiredCODENO.
PART NUMBER DESCRIPTION CODE PART NUMBERNO.
DESCRIPTION
10 379930-SMM-173-M
Nut-washer Iook-5/16"-18 24 * 379351-S2 Nut & retainer assy.25 -.383278-52 Nut & washer assy.-
MM-296-AG 1/4-2013 384931-S36BB-867-k
Screw & washer-5/16"-’18 x 11/16"26 N623332-S100 Nut-M6 x 1-spring "U"
AM-58-E21 384931-536BB-867-K
Screw & washer-5/16" - 18 x 11/16"27 N606689-S03 Screw & washer-M8 x 1.25 x 25
AB-187-EA hex. hd.22 * 55134-S2 Nut-hex flange hd lock-1/4"-2023 45338-S2
M-89-PNut-5/16"-lB bolt 28 N8O1521-S2 Hex. Locknut
- AM-18-MD
MARCH, 1994 COPYRIGHT® 1994 - FORD MOTOF -DEARBORN, MICHIGAN
COMPANY FINAL ISSUE
26 SECTION 103 1980/89LIGHTTRUCK
CODE NUMBER TO PART NUMBER LISTING - Quantity As RequiredCODE
NO.PART NUMBER DESCRIPTION CODE
.±iP:.PART NUMBER DESCRIPTION
29 N606677-S43B Screw & washer assy. 32 N6O6675-S36 Screw & washer assy.- AB-181-G - AB-149-H
30 N606690-S2 Screw & washer assy. 33 W6l1105-S36 Screw & washer assy.- AB-118-EL AU-50-J
31 N803471-S36 Screw & washer assy.- AB-116-S -
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRIPTION I OTY.10141 Refer to group 10732
10156 Refer to group 10732
10769 BRACE BATTERY SUPPORT80/
80/
Eloo/350 - - w/dualbatteryE100/35O - - with HID jack
E3U! 10769-A L.H. battery
Use as brace for jack carrier
1
180/ E100/350 D9U! 10769-A I80/86 F-U100/350 - - w/dual
battery-gasEOT! 10769-A L.H. battery 1
87/ F-Ut50/350,FSuper Duty * E7TZ 10769-Ar/bF4TZ 10769-A
RH. battery 1
83/88/
F250/350 - - dieselFSuper Duty - - diesel
* E7T! 10769-Br/bF4T! 10769-B
LEd. battery 11
eo/ F-U100/350 - - w/dualbatteries-gas
N605B92-S2 AB-116-G bolt-brace to tray-M6-lx2O
6
10 804 REGULATOR INSTRUMEN T CLUSTER VOLTAGEeo/80/8683/8564/8586
EtOO/350F1001350,U15ORBA - - w/o electronic instrumentcluster
D1A! 10804rA *GR_513 I1t11
86/88 B-R C9A! 10804-A GR-512 I80/86 F100/350 *314080-Si® Clip use at reilator AR
10817 WIRING ASSY. flNSTRUMENT CLUSTER FEED - Improvls $ from bulk wIre 14296
10 B838 PANEL SWITCH83/ B-R - - console E3T! 10B838-A 1
10 D840 CHIME ASSY. SEAT BELT WARNING - Also refef to group 10B92486/
87/87/
AVan - - w/conveniencegroup-exc. camper conversionF-U150/350,FSuper Duty8-R - - v/decor 9roup
* E6A! 10D840-A*r/bFOA! 10D84O-A
r/bF2T! 1OD84O-A
SW-2059 #E2AB 10D840-AA, E6AB 10D840-AA,E9EB 10D840-AA
1
11
86/86/
AWagonAVan - - w/camper conversi
* E6AZ IODB4O-Br/bFOVY lOD84O-A
SW-2060 #E45B t0D840-AIA,A2A,E6AB 10D84O-BA
1..J........
10 K843 CIRCUIT ASSY. INSTRUM ENT CLUSTER PRINTED80/ E100/350 - - exc. stripped
chassisD6TZ 1OK843-B #D6TF 10C956-BA-use on instrument
cluster v/ammeter and oil pressureQaus
I
80/86 E100/350 - - exc. strippedchassis
D9T! 1OK843-A #D9TF t0C956-AA-use on instrumentcluster w/charge indicator and oilpressure warning lights
1
84/88 E350 - - stripped chassis 0814! 10K843-H 189 E350 - - stripped ohassis * FOU! 10KB43-A
r/bFOO! 10K843-B#E9US 10C956-BA, FOUS 10C956-BA - 1
1980/89 SECTION 103 27LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRIPTION OTY.101843 CIRCUIT ASSY. INSTRUMENT CLUSTER PRINTED - Cont’d
80 F100/350,U150 - - w/tachometer EOTZ 101843-B #EOTF 10C956-BB-use on instrumentcluster w/ammeter and oil pressure gauges
1
80 F100/350,U150 * EOT! 101843-A #EOTF 10C956-AA-use on instrumentcluster v/charge indicator and oil pressurewarning lights
I
80 F100/350,U150 - - w/otachometer
EOT! 101843-C #E0TF t0C956-CB-use on instrumentcluster w/ammeter and oil pressure gauges
1
si/se FIOO/350,Ut50 E1TZ 101843-A #E1TF 10C956-AA-use on instrumentcluster w/oharge indicator and oil pressurewarning lights
t
81/86 Fi00/35O,U150 - - w/tachometer EIT! 10K843-B #E1TF I0C956-BA-use on instrumentcluster w/ammeter and oil pressure gauges
1
81/86 F100/350,U150 - - v/ctachometer
EIT! 101843-C #E1TF 10C956-CA-use on instrumentcluster v/ammeter and oil pressuregauges
I
87/88 F150/350,U150 - - w/o tachometer E8T! 101843-C #E7TF t0K843-AA, E8TF t0C956-AA 189 F150/350,U150 - - w/o tachometer E9TZ 101843-A #E9TF 10C956-AA I87/88 F150/350,U150 - - w/tachometer E8TZ 101843-B #E7TF, E8TF 10C956-BA 189/ F150/350,U150 - - w/tachometer * E9T! 101843-B
r/bFOTZ 101843-B#E9TF 1OC956-BA 1
83 R "Before 1/83’ * E3TZ 101843-A #E27F tOC956-AA-use on instrument clusterv/charge indicator and oil pressure warning lights
1
83 R "Before 1/83" * E3T! 1OK843-B #E27F 10C956-BA-use on instrumentcluster w/ammeter and oil pressure gauges
1
83/8584/85
R "From 1/83’B
* E3T! 101843-C #E37F 10C956-AA-use on instrument clusterw/charge indicator and oil pressure lights
11
83/8584/85
R ‘From 1/83’B
* E3TZ 10K843-D #E37F 10C956-BA-use on instrument clusterv/ammeter and oil pressure gauges
11
86/87 B-R - - w/o tachometer E6T! 1OK843-D #E67F 1OC958-AA,AB-use on instrument clusterw/charge indicator and oil pressure lights
1
88 R * E8T! 101843-A #E87F 10C956-AA-use on instrument clusterv/charge indicator and oil pressure lights
1
86/88 B-R - - yb tachometer E6T! 10K843-E #E67F 10C956-BA,BB-use on instrument clusterv/ammeter and oil pressure gauges
1
89/ B-R - - v/c tachometer E9T! 101843-C #E97F 10C956-BA-use on instrument clusterw/ammeter and oil pressure gauges
1
86/88 B-A - - w/tachometer E8TZ 10K843-D #E67F t0C956-CB, E87F 10C956-BB I89 B-R - - w/tachometer E9TZ 10K843-D #E97F 10C956-AC,AD 186/87 A - - w/electrcnic instrument
cluster "Before 11/86"669! 101843-A #E59F 10K843-AC 1
87/ A - - w/electronic instrumentcluster "From 11/86"
E79! 101843-B #E79F 1OC956-AA 1
86 A - - w/c electronic instrumentcluster
* E692 101843-CNot replaced 1/84
#E59F t0C956-CBCC-use on instrument clusterv/ammeter and cii pressure warning tights
1
86/87 A - - v/c electronic instrumentcluster
E69! 10K843-E #E69F 10K843-AD-use on instrument clusterw/ammeter and oil pressure gauges
1
88/89 A - - w/o electronic instrumentcluster
E89Z 101843-A #E79F 1OK843-CA, E89F 1OC956-AA,AB -
6 openings RH. side has cii sender on engineNote: w/o 20 OHM resistor detail, coordinateddesign change
1
89
8989
A - - w/o electronic instrumentcluster w/20 OHM resistor detailF53/59 - - stripped chassisE35O - - stricoed chassis
E99! 101843-A #E79F 101843-CA, 5 openings R.H. sideE99F 10C956-AA-blue-used on instrumentcluster w/fuel gauge amplitier
1
1t
10B847 WIRING ASSY. LOW VACUUM WARNING INDICATOR JUMPER84/85 I B-R I * E4T! 108841-A I #E47B 10B847-AA I 1
10848 PLATE INSTRUMENT CLUSTER BACK80 Ei00/350 * D8TZ 10848-A Use on instrument cluster w/ammeter and oil
r/bE1P! 10848-A9/81 pressure gauges
MARCH, 1994 COPYRIGHT 10 1994 - P090 MOTOR -DEARBORN, MICHIGAN
COMPANY FINAL ISSUE
28 SECTION 103 1980/89LIGHT TRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRIPTION I on’.10848 PLATE NSTRUMENT CLUSTER BACK - Cont’d
81/89 E100/350 - - exc. strippedchassis
EIPZ 10848-A Use on instrument cluster v/ammeter and oilpressure gauges-mcI. 1 EIUF 10848-AA plate,.12]J9AZ 10B870 litter and 1 PK-178-M instr. sheet
I
80/86 E100/350 - - exc. strppedchassis
E1P! 10848-B #D9LIF 10848-use on instrument cluster v/chargeindicator and oil pressure warning lights-mcI. 1E1UF 10848-BA plate, 2 D9AZ 10B870-A filter andiiLEi-178-M instr. sheet
1
84/88 E350 - - stripped chassis E2TZ 10848-B #E2TF 10848-BA 180/88 F100/350,U150 * EDT! 10848-A
r/bE7KZ 10848-AUse on instrument cluster v/chargeindicator and oil pressure warning tights
1
80/86 F100/350, U150 E2TZ 10848-A #E2TF 10848-AA-use on instrument clusterv/ammeter and oil pressure gauges - with orwithout tach,
I
87188 F150/350,FSuper Duty,U150 - -
w/o tachometer "Before 11/87"* E7TZ 10848-A #E7TF 10848-AB I
88 F150/350,FSuper Duty,U150 - -
v/c tachometer "From ii/ei’* E8TZ 10848-A #E8TF 10848-AB 1
-
89 F150/350,FSuper Duty,U150 - -
w/o tachometerE9TZ 10848-C #E9TF 10848-AA 1
87/89 F150/350,FSuper Duty,U15O - -
v/tachometerE9TZ 10848-D #E9TF 10848-BA, E7TF-8B, E8TF-B8
#E37F 10848-AA-use on instrument clusterv/charge indicator and oil pressure warning liits
I
1I
83/8584/85
RB
* E3TZ 10848-C
83/8584/85
RB
* E3T! 10848-0 #E37F 10848-BA-use on instrument clusterv/ammeter and oil p’essure gauges
1I
86 A - - v/c electronic instrumentcluster
* E69Z 10848-A Use on instrument cluster v/chargeindicator and oil pressure warning lights
1
86/88
89
A - - w/o electronic instrumentcluster "Before 6/88’F53/59 - - stripped chassis
"Before li/Be’
* E69Z 10848-Cr/bFO9Z 10848-A
Use on instrument cluster v/ammeterand oil pressure gauges
1
I
88/89
89
A - - v/c electronic instrumentcluster "From 6/88 to 11/88’E350 - - stripped chassis
* E89Z 10848-Ar/bFO9Z 10848-A
Use on instrument cluster v/ammeterand oil pressure gauge
Use on instrument cluster v/slosh module
t
188/89
8989
.4 - - yb electronic instrumentclusterF53/59 - - stripped chassisE350 - - stripped chassis
* E9OZ 10848-Ar/bFO9Z 10848-A9/91
1
11
86/ A - - v/electronic instrumentcluster
E79Z 10848-A 1
86 R * E6TZ 10848-A #E67F 10848-AA-use on instrument clusterw/charge indicator and oil pressure warning lights
1
1se/se 8-R - - w/o tachometer E6TZ 10848-B #E67F 10848-BA-use on instrument clusterv/ammeter and oil p’essure gauges
89/ B-R - - v/o tachometer E9TZ 10848-A #E97F 10848-AB-use on instrument clusterw/ammeter and oil pressure gauges
1
86/88 B-R - - w/tachometer E6TZ 10848-C #E6YF 10848-CA-use on instrument clusterv/ammeter and oil pressure gauges
I
189/ B-R - - v/tachometer E9TZ 10848-B #E9ZF 1O848-8B-use on instrument clusterv/ammeter and oil p’essure gauges
aol Etoo/350 * 383938-$2 jjfr52-V screw Piate 10 mask- Nc. 8-12 x 1/2"10E848 DISPLAY ASSY. FUEL COMPUTER-Remanufactured .
._.
1
86/89 A E99Z 10E848-ARID
89E849 AMPLIFIER ASSY. INSTRUMENT CLUSTER FUEL GAUGE
A - - w/o low fuel warning J E9D! 10E849-A8989
F53/59 - - stripped chassisB-R E9SZ 10E849-A
.....L.....1
1980/89 SECTION 103 29LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRFTLOW I on’.10850 AMMETER ONSTRUMENT CLUSTER - Also refer to ou 10883
80/ 6150/350 - - exc. stripped chassis - E8UZ 10850-A i84/68 EISa - - stripped chassis 61HZ 10850-A "0-C-lea, symbol
180/86 P1001350,U150 6011 10850-A White swnboI83/8584/8588/88
RBB-B - - v/c tachometer
6311 10850-A
* ESQZ 10850-Ar/bFI9Z 10850-A8/91
I1i1t1
ee/8989
A - - v/o electronic instr. clusterF53/59 - - stripped chassis6350 - - stripped chassis
#E8SF 10176-AA - use v/pal nuts to attach terminalsto threaded studs
60! 6100350 383367-SlOD MM-291-EA Nut ammeter to back plate-No.10-32 washer head
2
10 6850 CONTROL ASSY. INDICATOR WARNING MULTIPLE FUNCTIONei/6787/8989
A J ETTZ IOEB5O-B8-BF-U150/350,FSuper Duty I6350 - - stripped chassisP53/59 - - stripped chflsis
#E7TF 10E850-AA,AB, FOTF 10E850-AA I111t
10852 BEZEL ASSY. LIGHT SWI TCHsosi EI0O/350 D8UZ 10852-A J Used between 11654 switch and 11661 knob-plastic f 1
I 1I
88/89
6150/350P53/59 - - Stripped Chassis
E8UZ *0852-A TBlack
83/88 B-R E3T! 10852-B #E27B t1A656-AB,AC89 B-B ill! 10852-A flI
*080/84
A860 PLATE ADIO MOUNTING6100/350 D5UZ IOASSO-’A 1
85 6150/350 * ESUZ 1OA860-A RH, #E5UF 18K631-AA86 6150/350 * E5UZ 10A860-8 LII. #E5UF 19K838-A,4861 6150350 68132 10A860-C RH. #E6UF 18K837-A0,ACee/ 6150/350 E6UZ 10A860-D L,H. #EBUF 18K838-AC,A0 1
I8084 Fl00/350,U150 EOTZ IOA86O-A #E0TF 19A179-AAAB85/86 F-tJt5O/350 - - v/o electronic radio E5TZ 1OA860-A RH. #E5TF 18XB43-AA
L.H. #EBTF 18K844AA6566 F-uiSO350 - - vie electronic radio ES’TZ 104860-B 181/ F-U150/350Super Duty ETTZ IOASSO-A RH. #67W 161643-AS 187/ F-U150/350,PlSuper Duty - E1TZ 10A860-B L.H. #E7TF 18K844-AB i85/ F-Ut50/350 - - c/electronic radio ESTZ 10A860-C Upper #ESTF 19e102-AA,AB I85/ F-tJtSO/350 - - v/electronic radio E5TZ 10A860-’D Lower #E5TF 196105-AA,AB 183/8484
RB
0942 104860-B #D9AF 19A179-BA Ii
8588
B-B - - v/a electronic radioA - - v/a electronic radio-
"Before 8/85"
ESAZ 10A860-A RH. #ESAF 18K843-AA 11
8586
8-P - - w/o electronic radioA - - v/c electronic radio-
‘Before 8/85"
E5AZ 104860-B LII. #E5AF 18K844-AA I1
66/8686/
B-BA "From 8/85"
E6’TZ 10A860-C RH. #E67F 1BX843-AB,AC, E7AF 18K843-AA I.-J.-......
86/8886?
B-RA "From 8/85"
E6T! 104860-0 L.H. #E67F 18K844-AB,AC, ETAF 18K844-AA II
ss/ A EBB! 104860-A RH-use for equalizer I86/ A E$92 104860-B L.H,-uae for equalizer I
10 4861 GASKET WARNING INDICATOR LAMP LENS87/ F1501350.FSuDer Duty E7T! 10fl1867-A J 2
IOBBTO FILTER INSTRUMENT CLUSTER LAMP80/81 E100/350 * 0142 108810-4 280/8682/8683/8884/86
F1001350,U 150E100/350RB
* D9AZ 10B810-A 5ARARp
86/ A - - c/electronic inslrurnent thster E69Z 108810-A 2
MARCH, 1994 COPYRIGHT 10 1994 - PORD uoiop -DEARBORN, MICHIGAN
COMPANY FINAL ISSUE
30 SECTION 103 1980/89LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRIPTION I QTY.108870 FILTER INSTRUMENT CLUSTER LAMP - Cont’d
87/ E150/350 E7UZ 10B870-A Green 287/ B-A AR
10876 BEZEL INSTRUMENT CLUSTER - Also refer to group 04407080 E100/350 * EOUZ 10816-A Woodgrain finish I81 6100/350 * E1UZ 10876-A Woodgrain finish I82 E100/350 * E2UZ 10876-A Woodgrain finish 182/87 6100/350 E2UZ 10876-B Black finish t80/81 E100/350 * 60th! 10876-B Black finish 183/87 6100350 - - exc. stripped chassis E3UZ 10876-A Brown leather finish I84/88 E350 - - stripped chassis * E4UZ 10876-A I89 F53/59 - - stripped Chassis
6350 - - stripped chassisE9TZ 10876-A I
iso E100/350 - - v/gauges * 52445-S13 1.1-317-screw bezel to panel-No. 8-18 x 1" 880/ E100/350 - - w/warning lights * 53049-S13 U-281-screv bezel to panel-Nc. 3-15 x 7/6" 6
100876 BRACKET SEAT BELT WARNING CHIME87/ [ F-U150/350,FSuper Duty * E7TZ 10D876-A i87/88 [s-n * E1TZ 10D876-C 189 JB-R - - v/Hi level trim E9TZ 10D876-A88 P - - w/std. trim L E9TZ 10D876-$
1.J....
10880 GLASS INSTRUMENT CLUSTERao/ El0O/350 - - ext. strped chassis D3TZ 10860-A T84/88 E350 - - stripped chassis C7TZ 10880-A .._.L...ao/ EI00/350 379663-SBJ HH-6-R Clip glass to n,ask-5/8" .....I....._
10883 GAUGE INSTRUMENT CLUSTER TEMPERATUREao/ E150/350 - - exc. stripped chassis E8UZ 10883-A
I84/88 E350 - - stripped chassis 61HZ 10883-6 "C-H-also has symbol80/86 FI00/350,U150 E3TZ 10883-B "C-NORMAL-H" I87/89 FlSo/350,FSuper Duty,U150 - -
w/o tachometer* E7TZ 10883-Ar/bFOTZ 10883-C
Battery symbol - 8-18 "C-NORMAL-H" v/symbol‘BRAKE"
I
83/8584/8586/88
RBB-R - - v/o tachometer
E3TZ 10883-C III
86/88 B-R - - w/tachometer E6TZ 10883-A "C Normal H-also has symbol It86 A - - yb electronic instrument
cluster* E69Z 10883-A Use on instrument cluster v/anuneter
and oil pressure warning lights86/
8989
A - - v/c electronic instrumentclusterP53/59 - - stripped chassis6350 - - stripped chassis
* E79Z 10883-Ar/bE89Z 10883-A
Use on instrument cluster v/ammeterand oil pressure
I
I1
80/ EI00/350 38336?-5100 MM-291-EA Nut gauge to back plate-No.10-32 washer_head
2
*0883 GAUGE ASSY. INSTRUMENT CLUSTER WATER TEMPERATURE and AMMETER87 P-U150/350 - - w/o
tachometerE7TZ 10883-E Battery symbol-8-18-C-normat H
with symbol - "EMISS-BRAKE’I
88/ F150/350,FSuper Duty,U150 - -
v/c tachometer* E7TZ 10883-A
r/bPOTZ 10883-C9/91Battery symbol-8-18-C-normal Hwith symbol - "BRAKE"
I
87 F15o/350,FSuper Duty,U150 - -
v/tachometer v/unleaded tuelE7TZ 10883-B Battery symbol-8-18-C-normal H
"UNLEADED"1
ai/
88/
F150/35O,FSuper Duty,U150 - -
v/tachometerF250/350 - - diesel
E8TZ 10883-A Battery symbol-8-18-C-normal H 1
18789/89/
F250/350 - - dieselB-R - - w/o tachometerB-B - - w/tachometer
E7TZ 10883-0E9TZ 10883-C
"DIESEL"Battery and temp symbol-8-18-C-normal H
I1
E9TZ 10883-D Battery and temp symbol-8-18-C-normal H I
1980/89 SECTION 103 31LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS PART NUMBER DESCRIPTION I orv.10884 SENDER WATER TEMPERATURE INDICATOR ENGINE UNIT
eo/80/83/8584/8583/8886/86/
E100/350 - - gasF-U100/350 - - gasR - - w/gauges - - gasB - - v/gauges - - gasE-F250/350 - - dieselB-R--6cyLgasA - - v/o elect. instr. cluster-B cyl,
* DOWY 10884-Ar/bFISZ 10884-A6/92
*5W_924_#270_incl. green insulator
Water temp. indicator
1It1I11
83/ E-F250/350 - - diesel * E3TZ 10884-Ar/bF3TZ 10884-A
*SW_t784_#E3TF 10B843-AAWater temp. indicator lamp
1
83/8684/87
B - - w/warning lights - - gasB - - v/yarning lights - - gas
643! 10884-A SW-1344A-1 contact-red insulator-25/16" long
1I
83/84 R - - diesel E3TZ 10884-B *SW_ 1795 185 B-A - - diesel E5TZ 10884-A *5W_1936 186/88 R - - diesel E6TZ 10884-B SWE-2080 186/86/87/
A - - 4 cyl. gasB-R--4cyigasE-F250/350,F53/59 - - StrippedChassis-diesel
DOZZ 10884-A II1I
86/ A - - w/elect. inst./clstr. * Refer to t2A648 110884 SWITCH ASSY. WATER TEMPERATURE
86/ I R - - diesel I E6TZ 10884-A I *SWE_2077 I 1104885 PLATE INSTRUMENT CLUSTER CONTROL MOUNTING
80/81 EtOO/350 I D5UZ 10A885-A I Por ignition switch I1OB886 WIRE ASSY. WATER TEMPERATURE INDICATOR - Unless listed improvise from bulk wire 14296
83 I E250/350 - - diesel I * E3UZ 10B886-B I #E3UB 108886-AAAB I 110887 LENS INSTRUMENT CLUSTER MAIN
80/86 F100/350,U150 - - w/tripodometer
EOTZ 10887-B Inch reset knob 1
80/86 Fl00/350,U150 - - w/otripodometer
EOTZ 10887-A t
87/ F15O/350,FSuper Duty,Ut50 - -
w/o tripodometerE9TZ 10887-B #E7TF 10B885-AA, E8TF 10B885-AB 1
87/89 Ft50/350,FSuper Duty,U150 - -
v/tripodometer* E9TZ 10887-Cr/bE9TZ 10887-F
#E8TF 10B885-BB - for reset knobrefer to t7A381 - #E9TF 10B885-BA
1
83/88 B-P - - w/o tripodometer E5TZ 10887-A #E67P 10B885-AA 183/88 B-A - - v/tripodometer E5TZ 10887-B #E67F 105685-BA-has hole for reset knob I89 B-R E9TZ 1O881-E #E97F 10B885-AA,AC 18687/
AA - - w/electronic instrumentcluster
E69Z 10887-A #E59F 10B885-AA-use on instrument clusterv/ammeter and oil pressure lights
1t
86/ A - - v/o electronic instrumentcluster
E69Z 10887-B #E69P 10B885-AA-use on instrument clusterw/ammeter and oil pressure gauges
1
8989
F53/59 - - stripped chassisE350 - - stripped chassis
E9TZ 10887-A 11
10 890 MASK INSTRUMENT CLU STER80/88 6100/350 - - exc. stripped
chassisE1UZ 10890-A #E1UF 10894-AA-use on instrument cluster
v/ammeter and oil pressure gauges1
89 6150/350 - - exc. strippedchassis
FOUZ 10890-A #E9UF 10894-AA I
80/86 El00/350 - - exc. strippedchassis
* E1UZ 10890-B #E1UF 10894-BA-use on instrument clusterw/charga indicator and oil pressure yarning lights
I
84/8889
6350 - - stripped chassisE350 - - stripped chassis
EIHZ 10890-4E9TZ 10890-A
11
8980/86
F53/59 - - stripped chassisFl00/350,UtBO - - w/unteaded gas EOTZ 10890-A
11
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN MICHIGAN
OOMPANY FINAL ISSUE
32 SECTION 103 1980/89LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER DESCRIPTION I QTY.10890 MASK INSTRUMENT CLUSTER - Cont’d
80/86 F100/350,U150 - - v/leaded ps-Canada
EOTZ 10890-B 1
83/86 F250/350 - - diesel E3TZ 10890-C #E3TF 10894-AA 187/88 F150/350,FSuper Duty,U150 * E7TZ 10890-A
r/bE9TZ 10890-B#E7TF 10894-AB. outer I
87/88 F150/350,UI50 - - v/otachometer
* E7TZ 10890-B Inner steel-#E7TF 10894-BA 1
69 F150/350,U150 - - v/otachometer
E9TZ 10890-B #E8TF 10894-AB I
87/88 F150/350,U150 - - v/tachometer * E7TZ 10890-C Inner steel-#E7TF 10894-CA I89/ F150/350,U150 - - v/tachometer E9TZ 10890-C #EBTF 10894-BA 183/8584/8586/88
A - - gasBB-A - - v/o tachometer
* E3TZ 10890-B #E2YF 10894-BA-use on instrumentcluster with ammeter and oil pressure gauges
I1I
83/85 P - - diesel * E3TZ 10890-D #E37F 10894-AA-use on instrumentcluster vith ammeter and oil pressure uges
I
86/88 B-R - - v/tachometer * E6TZ 10890-A #E87F 10894-AA-use on instrument clusterv/ammeter and oil pressure gaugas
1
83/88 B-A E6TZ 10890-B #E27F 10894-AA, E67F 10894-BA -
use on speedometer1
1
1
89 B-A * E9TZ 10890-Dr/bE9TZ 10890-E
#E97F 10894-AB#E97F 10894-AA
86 A - - w/o electronicinstrument cluster
* E69Z 10890-A Use on instrument cluster v/ammeterand oil pessure warning lijits
86/89 A - - w/o electronic instrumentcluster
* E99Z 10890-Br/bF1TZ 10890-A
Use on instrument cluster w/ammeterand oil pressure gauges
1
86/87 A - - v/electronic instrumentcluster "Before 11/86"
* E69Z 10890-C IncI. turn signal jewel 1
87/89 A - - v/electronic instrumentcluster "From 11/86 to 11/88"
* E89Z 10890-A md, turn signal jewel-also lettered"CHECK ENGINE - UNLEADED FUEL ONLY"
1
89 A - - v/electronic instrumentcluster "From 11/88"
E99Z 10890-A IncI, turn signal jewel-also lettered "UNLEADEDFUEL ONLY - CHECK ENGINE -
ANTILOCK BAAKE"
1
10 D898 INDICATOR ASSY. MESSA GE CENTER-RemanufacturedI86/87 A - - v/electronic instrument
cluster-2,3L, 2.8L eng.* E69! 10D898-Ar/bE79Z 10D898-A
Tach and fuel gauge-also has symbols forbsttery-temp-oil-6000 rri
86/89 A - - v/electronic instrumentcluster-2.3L, 2.8L, 3,OL eng,
"Before 11/88’
E79Z 10D898-A Tach and fuel gauge-also has symbols forbattery-temp-oil-6500 rpm-6000 rpm
1
89 A - - v/electronic instrument * E99Z 100898-A Tach and fuel gauge-also has symbols for battery- 1cluster "From 11/88’ r/bFO9Z 10D898-A temp-oil-6500 rr-used v/21 gal, fuel tank
10C912 DIODE ASSY. 0.AMP FAILURE INDICATOR86/ All E8DZ 10C912-A #D6AB 1OC912-AA,BA, E9DB 14A604-EA -
1 amp-use for clock10C914 INSULATOR AMMETER
80/ EI0O/350 I C922 10C914-A I I 110C915 LAMP ASSY. WARNING INDICATOR
83/64 A - - diesel * E3TZ 10C915-A #E27B 10C915-BA 182/86 E350 School Bus * E2UZ 100915-A "PARK BRAKE" I
10B923 WIRING ASSY. WARNING LAMP INDICATOR PANEL8484/8885/97
R - - v/consoleB - - w/consoleP - - v/console-w/o electronicradio and p’emium sound amifier
* E3T! 10B923-A*r/bE7TZ 10B923-A
#E47B 10B923-AAAC#E77B 108923-AA
1
I
85/86 A - - v/console-v/electronicradio and emium sound amifier
* ESTZ 10B923-A #E57B 10B923-AA 1
10B924 SWITCH ASSY. SEAT BELT WARNING INDICATOR - Also refer to group 10084080/83 E-F-U100/35O D6AZ 108924-B ‘SW-1387-#D7AB 10B924-A1A,-A2A 183 A I
1980/89 SECTION 103LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRIPTION I art’.10B924 SWITCH ASSY. SEAT BELT WARNING INDICATOR - Also refer to oup 100840 - Cont’d
84/8884/86/8889
B,RE-F-U150/350ARSuper Cab
E4TZ 10B924-A SW-1822 - #E43B 108924-AA,AB-AIso used for 1headlamps on warning-also used to service IE3EB 1O6924-AA, E9EE 10B924-AA 1
t10C924 LAMP AND WIRE ASSY. WARNING INDICATOR
87/88 E350 - - stripped chassis * E7UZ 10C924-A "EMISS"88/ E350 - - stripped chassis E8UZ 10C924-A "CHECK ENGINE"
100924 SENSOR ASSY. FUEL FLOW86 A - - v/roof console- E69Z 100924-B #E59F 100924-AB, ED E59F 10D924-AB 1
with 2.8L eng.10D925 BRACKET FUEL FLOW SENSOR
86 A - - v/roof console- * E69Z 10D925-Awith 2.8L eng.
10927 TERMINAL INDICATOR86/ A-B-A E6DZ 10927-A Use on instrument cluster with 4 gauges AR87/ F-U150/350,FSuper Duty AR
108930 RETAINER INSTRUMENT CLUSTER GASKET83/86 P - - w/tripodometer * E3TZ 10B930-A 184 B - - v/tripodometer 1
1OC935 BRACKET INSTRUMENT PANEL CONTROL87/ F-U150/350,FSuper Duty * E7TZ 10C935-A 1
r/bFOTZ 10C935-A10A936-7 LENS INSTRUMENT CLUSTER WARNING LAMP
80/ ElcO/35o - - exc. stripped chassis D3TZ 10A936-A #Green-turn signal jevel 284 E350 - - stripped chassis DIr! 10A938-C Turn si,al jevel 280/89 El00/350 * D6TZ 10A936-C "BRAKE" - rectangular - red 180/83 E100/350 - - w/o A/C "Before 10/83’ * EOUZ 10A936-A "WIPE - WASH" 180/83 EtOO/350 - - v/A/C "Before 10/82’
"Before 10/82"* EOUZ 10A936-C Lettering & graphics-WIPE-WASH" 1
83/ EtOO/350 - - v/NC"From 10/82"
* Lettering & graphics-"WIPE-WASH"-serv. in044D70 assy.
1
83/ E100/350 - - wIAJC"From 10/82"
* Lettering & graphics-"WIPE-WASH"-serv. in044D70 assy,
1
88/ E150/350 - - gas * "CHECK ENGINE-LIGHTS-servicedin 044D71
I
88/ E250/350 - - gas * "WAIT TO START-ENGINE TEMP-WATER IN FUEL-FUEL FILTER-servicedin 044D71
1
80 Et00/350 - - Canada * D5TZ 10A936-C High beam jewel-blue80/86 6100/350 * EIUZ 10A936-A Alt-red-use on instrument cluster v/charge
indicator and oil pressure warning lights1
80/ ElOo/350 E1UZ 10A936-B Fasten belts-red I80/86 E100/350 * E1UZ 10A936-C Oil-red-use on instrument cluster v/charge indicator
and oil pressure warning lights1
80/ EtOO/350 - - exc. stripped chassis E1UZ 10A936-D Hi beam 180/86 FloO/350,U150 EOTZ 10A936-A #E0TF 10A936-AA-Graphics for OIL and ALT.-
use on instrument cluster v/charge indicator andoil pressure warning lights
1
187/ F-U150/35O * E7TZ 10A936-D RH. ‘ANTILOCK BRAKES - 4 x 4 -
LOW RANGE" also has RH. turn siial arrow87/ F-U150/35o * E7TZ 10A936-E Lii. "CHECK ENGINE - ENGINE" also symbol
for battery and L.H. turn signal arrov1
87/ U15o E7TZ 10A936-F "REAR WINDOW" 187/ F-Ut50/350 E7TZ 10A936-G Windshield washer switch 183/8584/8586
ABB-A - - w/o tachometer
* E3TZ 10A936-A #E27F 10A936-AA-use on instrumentcluster w/varning lights-symbol for oil & temp.
I11
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN MICHIGAN
COMPANY FINAL ISSUE
34 SECTION 103 1980/89LIGHTTRUCK
YEAR I MODELIAESTRICTIONS I PART NUMBER I DESCRIPTION I pm’.10A936-7 LENS INSTRUMENT CLUSTER WARNING LAMP - Cont’d
83/84/
R "From 1/83"8
E3TZ 10A936-C Symbol for hi beam 1i
86 A - - v/o electronic instrumentcluster
* E69Z 10A936-A #E59F 10A938-AB-AC-"FASTEN BELTS-BRAKE-HIGH BEAM-EMISS-SHIFT-AMP-OIU’-use on instrument cluster v/ammeterand oil pressure warning lights
I
86/87 A - - w/o electronic instrumenlcluster
* E69Z 10A936F #E69F 10A936-AB-R.H.-use on instrument clusterv/ammeter and oil pressure gauges
I
88/89 A - - w/o electronic instrumentcluster "Before 11/88"
* E89Z 10A936A #E89F 10A936BA-R.H.-symbol for hi beamand fasten seat belts-lettered "BRAKE-CHECK ENGINE"
I
89 A - - w/o electronic instrumentcluster "From 11/88’
E99Z 10A936-B #E99F I0A936-CA-R.H. 1
86/89 A - - w/o electronic instrumentcluster "Before 11/88’
* E69! 10A936-G #E69F 10A936-BB-L.H.-use on instrument clusterv/ammeter and oil pressure gauges
1
89 A - - v/o electronic instrumentcluster "From 1 i/se"
* E992 10A936-C #E99F 10A936-DA-L,H. 1
86/88 A - - v/o electronic instrumentcluster
* ES9Z 10A936-Br/bE99Z 10A936-A
#Green-turn signal jewel 2.._..
89 A - - v/c electronic instrumentcluster
E99Z 10A936-A #Green-turn signal jewel I
86 A - - v/electronic instrumentcluster
* E69Z 10A936-C #E59P 1oA936-ED-"HIGH BEAM-BRAKE-SHIFT-SEAT BELTS-WIPER-DOOR AJAR"
I
86
87/
B-A * ESTZ 10A936-A "BRAKE-LOW RANGE-4 x 4-WATER INFUEL-EMISS.-CHECK OIL"
f
B-A E7TZ 10A936-H "BRAKE-LOW RANGE-4 x 4-WATER INFUEL-EMISS.-CHECK OIL-CHECK ENGINE-REAR ANTILOCK"
I
86/ 8-R - - v/tachometer * UT! 10A936-8 for oil and battery 18989
F53/59 - - stripped chassisE350 - - stripped chassis
* E9TZ 10A936-Ar/bE9TZ 10A936-C
RH. 11
8989
F53/59 - - stripped chassisE350 - - stripped chassis
E9TZ 10A936-B L.H. 11
10A936 LAMP ASSY. DIESEL WARNING MODULE8387
E-F250/35o - - dieselE250/350 - - diesel
E3TZ 10A936-B #E3TE 10D843-AA-"WAIT TO START -
ENG TEMP - WATER IN FUEL" - md. bulbs11
84/86 E-F25o/350 - - diesel E4TZ 10A936-A #E4TB 10D843-AA-"GLOW PLUG-WATERIN FUEL-ENGINE TEMP’ - md. bulbs
1
87/88/
F250/350 - - dieselFSuper Duty - - diesel
E7TZ 10A936-J #E7TB 10C915-AA,AB-"WAIT TO START-WATER IN FUEL-md. bulbs
11
88/ Et50/350 - - diesel E8UZ 10A936-B #E8UB 1OD843-BA-"WAIT TO START-ENGINETEMP-WATER IN FUEL-FUEL FILTER-Owl, bulbs
1
10A936 LAMP ASSY. EMISSION WARNING MODULE85/87 I EI50/250 - - gas-exc. Calif. I E5UZ 10A936-A I #E5UB I0D843-AA-"EMISSION" md. bulb I 1
10A936 LENS ASSY. 1EADLAMP SWITCH87/ I FI5O/350FSuoer Duty I E7TZ 10A936-C I "LIGHTS" I
108942 WIRING ASSY. ONSTRUMENT CLUSTER89 I F53/59 - - stripped chassis I E9TZ 108942-A I 500 OHM-S watt resister I
10A949 GASKET INSTRUMENT CLUSTER WARNING CENTER LENSse/ A - - w/efectronic instrument E592 10A949-A Used behind E69Z tQA935-C lens
cluster100955 WIRING ASSY. TRIPMINDER EXTENSION
86/89
8687
A - - w/o illuminated vanity visors"Before 10/88"
* E792 10D955-C #E598 100955-AG, E79B 10D955-AA,AB I
A - - v/illuminated vanity visors * E79Z 100955-B #E69B 100955-AA, E79B 100955-BA 188/ A - - w/illuminated vanity visors * E79Z 100955-0 #E79B 1OD955-BB 189 AXL - - v/roof console
"From 10/88"* E99Z 100955-A #E9BB 10D955-AB,AC,AD,AE 1
1980/89 SECTION 103 35LIGHTTRUCK
YEAR I MODEL/RESTRICTIONS I PART NUMBER I DESCRIPTION I QTY.10D955 WIRING ASSY. TRIPMINDER EXTENSION - Cont’d
89 AXLT - - v/roof console * E99Z 10D955-B #E99B 10D955-BBBC,BD,BE 1‘From 10/88"
100951 BOLT FUEL FLOW SENSOR CONNECTOR86 IA I *E25Z 100957-A I I I
10D958 CONNECTOR FUEL FLOW SENSOR86 IA I *E25Z 100958-A I 1
100959 GASKET KIT FUEL FLOW SENSOR86 IA I *E2PZ 100959-A I 1
10960 DIAL INSTRUMENT CLUSTER WARNING LAMP80/86 I F100/350U150 I EOTZ 10960-A I Graphics for OIL and ALT. 1
10A962 LAMP ASSY. PARKING BRAKE82/86 E35O school bus * E2UZ 10A962-A IncI. bracket-br lamp only refer to 10C9t5 184/88 E350 - - stripped chassis E4HZ 10A962-F #D5HB 2B318-AB, E4HT 2B318-FA-"BRAKES" 1
108987 PANEL ASSY. WARNING INDICAThR83/ R - - v/console E3TZ 108987-A #6278 10B987-BA,BB - graphic display module 1
for taillamp - vasher fluid - brake lamp -
headlamp84/ 8 - - v/console E4TZ 10B987-A #E47B 10B987-BABB I
10A995 GASKET INSTRUMENT CLUSTER83/86 A - - v/tripodometer * E3TZ 10A995-A84/88 B - - w/tripodometer
10D996 SWITCH ASSY, INSTRUMENT INDICATOR86/89 A - - v/electronic instrument * E69Z 100996-A "EXPAND FUEL-ENGLISH METRIC- 1
cluster r/bE99Z 10D996-A TRIP DIST-TRIP RESET-GAUGE SELECT"108999 RELAY ASSY. ALTERNATOR WARNING LIGHT
ss/ F350 - - w/ambulance E8TZ 108999-A #E8TS 10B999-AAprep. option
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
1980/89 SECTION 103.1
MOTORCRAFT 40, 60, 65, 75 and 80 AMP. LIGHTTRUCKDESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS 1A THRU 1M
BOARDKITPRINTEDCIRCUIT I DOAZ 105301-A IA lB IC ID I El FIG I I I PConsists of:1-C8AF 108301-A Board assy-circuit 2-374412-S100 Washer9-C9AF I0B306-A Ring-solder 2-383255-88 Nut and Washer
2-383758-S8B ScrewBEARINGR0NT 10A303
C9ZZ 10094-AGE-21
A B C D E F G H J K L M
RECTIFIER KIT D6AZ 10304-AGY-1306-A
A C D E F G H
Consists of:I-DOZF 10304-B Rectifier assy, 6-383255-S8 or S36 Nut & washerI-C7AF 10A383-A Insulator 2-3$325$-S8 or S36 Nut & washer1-DOAF 1OA383-A Insulator 2-383758-S8B Screw2-374412-5100 Washer
* E43Z 10304-AGY- 1351
r/b E6DZ 10304-A
J K L M
Screw rectifier to housing * N803090S7Mr/b N803090-S7M
Screw-No. 10-24 x 37/64" * 383758-S SB-all-CE 2 2 2 2 2 2Washer-l/4" conical * 374412-S100 IXX-388 2 2 2 2 2 2BEARINGREAR D2OZ 10A304-A
GE-31A B C 0 E F G H J K L M
REGULATOR ASSY. * E6TZ 10316-AGR-784-A
r/b E13Z 10316-A
J K L M
SCREW Attaches regulator N803090-57M AU-64-C 4 4 4 4HOLDER ASSY BRUSH AND TERMINAL -
md. brushesE43Z 10320-A J K L M
SCREW BRUSH AND TERMINAL * N803706-S36 AU-64-Jrib N805249-S36
2 2 2 2
NUT AND WASHER WRUSH AND TERMINAL N621900-S36 AM-29-H 2 2 2 2RING ROTOR SLIP * C3SZ 10328-A A B C E F G HINSULATOR TERMINAL - Orange-9/32"ID. x 5/8" 0.D. x 1/4" thick
CSAZ 10329-0GY-912
A B C D E F 0
Approx. 1/16" x 3/4" x I" C5AZ 10329-CGY-91 1
A B C D E F 0
SHAFT ROTOR C5AZ 10330-A A B C E F 0 HHOUSING FRONT 10333
* ElF! 10333-AGD-359
rib E6DZ 10333-C
G
E6DZ 10333-C‘GD-359-B
J K
E6AZ 10333-AGD-364
A B C D E F LM
HOUSING REAR D7AZ 10334-AGH-317-A
B 0 E H
D7ZZ 10334-AGH-318-A
A C F G
E6FZ 10334-AGH-369
J K L M
Bolt-hex. washer head-No. tO-24 x 2 1/8" 378466-S100BB-550-D 3 3 3 3 3 3 3 3 3 3
MARCH, 1994 COPYRIGHT © 1994 - FORD MOTOR -DEARBORN. MICHIGAN - -
COMPANY FINAL ISSUE
2 SECTION 103.1 1980/89LIGHTTRUCK MOTORCRAFT 40, 60, 65, 75 and 80 AMP.
DESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS IA THRU tM
ROTOR_ASSY. 10335* El!! 10335-A j C
....._
F‘. ‘
H‘ .
GM-465-Ar/b F21Z 10335-A*E55Z 10335-A
GM-473rib F272 10335-A
A B D F
J
G
LJ
F FFJ]K
!
M
IL
*E43Z 10335-CGM-471
FJ
I-
r/bF2DZ 10335-ASTATOR ASSY. * D8ZZ 10336-A
*GC_358A
B
C
D
E
F 0
Hj,
II
L
M
E3FZ 10336-A4GC-374E43Z 10336-AGC-375
E6DZ 10336-CGC-384
E69Z 10336-B9GC-383
J
K
BRUSH and TERMINAL SET C6VY 10347-AGB-111
A B C C E F 0
Consists of:t-C6VF 10A367-A Brush and termina I l-C6VF 1 0A36 7-B - Brush and terminal
Screw-No. 10-24 x .65-brush terminal * 383757-S BR-Mi-A A B D E F 0Nut-No. 10-24 terminal 383255-S IMM-296-AC .1. .1.. 1 1.. .L. ..Q... .11.. - -
SPRINGBRUSH C5AZ 10349-AGY-913
2 2 2 2 2 2 2 2 2 2 2 2
HOLDER BRUSH C5AZ 10351-A9GY- 1011
A B C U E F G H
*E43Z 10351-AG0-364
r/bE43Z 10320-AI I
J K L M
Screw & washer rush holder-No. 6-32 x 1/2" * 377284-Sl OJU-52-TH 2 2 2 2 2 2 2 -
RETAINER FRONT BEARING D2OZ 10A355-AGY-693
A B C U E F G H J K-
L M
- -Screw-hex head-No, 10-32 x 3/8" * 379201-S100 3 3 3 3 3 3STOP OTOR CSAZ bASSO-A £ .1. S. - £ .L I IL £ .L £ A.RING ROTOR STOP E6AZ 10370-A
GY-13610 H J K L M
DIODE ASSY. POSITIVE 02HZ 10374-A 3 3 3 3DIODE ASSY. NEGA11VE 02HZ 10378-A 3 3 3 3 -
- -
INSULATOR KIT TERMINAL 095! 10A383-AGY-937
A B C D E F 0
Consists of:1-C7AF 1O329’D Insulator-terminal I-C9SF 10A883-A Insulator-diode platel-C7AF 10A383-A Insulator-diode r4ate
BOLT THRU 10A396Bolt-hex. head-No, 10-24 x 2 1/8" 378466-S100SB-550-D 3 3CAPACITOR RADIO C6AZ 16827-A A B C D E F 0 H
NOTICE: When the parts list suffix is shown in the quantity required column, the quantity is one t.
1980/89 SECTION 103.1 3MOTORCRAFT 40, 60, 65, 75 and 80 AMP. LIGHTTRUCK
DESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS iN ThRU 1!
BEARING FRONT C9ZZ 10094-AGE-21
N P 0 S T
RECTIFIER ASSY. E60Z 10304-A0Y- 1360
N 0 R S T
* E43Z 10304-A9GYI35i
r/b E6DZ 10304-A
P
Screw attaches rectifier assy,BEARING REAR
* N803090-S7MAIAU-64-CD2OZ 10A304-AGE-31
4N
4P
40
4 45
4T
- -
REGULATOR ASSY. E73Z 10316-AGR-784-B
N P 0 R S T
Screw attaches regulatorHOLDER ASSY. BRUSH & TERMINAL
* N803090-57MA 4U-64-CE43Z 10320-A
4N
4P
40
4R S T
- -
GC-402Screw brush & terminal * N803706-536AU-64-J 2 2 2 2 2 2Nut & Washer brush & terminalHOUSING FRONT
N621900-536AM-29-HE6AZ 10333-A‘00-364
2N
2 2 2 2 2-
-
E6DZ 10333-CGD-359-8
P 0 R
E99! 10333-A‘00-377
S
EBFZ 10333-A‘00-373
T
HOUSING REAR E6FZ 10334-A‘011-369
N P 0
E7ZZ 10334-A‘GH377
R
E99Z 10334-A‘GH-391
S T
Bolt-hex.head-No.tO-24x21/8" 378466-S100BB-550-D .i_ .1. J_ROTOR ASSY. E6DZ 10335-A
‘GM476N 0
60 amp. special balance * E7TZ 10335-A‘GM-485
rib F2DZ 10335-A
P
E9SZ 10335-A‘GM-488
R
E9FZ 10335-A‘GM-487-A
S T-
STATOR ASSY. E6DZ 10336-A‘00-385
N 0 R
E69Z 10336-BGC-383
P
EBFZ 10336-A‘GC-394
5 T-
SPRING BRUSH.
C5AZ 10349-A‘GY-913
2 2 2 2 2 2-
RETAINER FRONT BEARING 020! 10A355-A N P 0 .1. .1. .1..Screw hex. head No, 6-32 x 1/2" * 379201 3 3 3 -
STOP ROTOR CS?.! 10A360-A N P Q R S T -
RING ROTOR STOP E6A! 10370-A*Gy_1361
N P 0
Bolt-hex, head-No. 10-24 x 2 i/a" 378466-Sl00BB-550-D 3 3 3 3 3 3
MARCH, 1994 COPYRIGHT © 994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
1980/89 SECTION 103.2MOTORCRAFT 70 AMP. LIGHTTRUCK
DESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS 2A THRU 2M
Notes: Refer to group 10346 In Section 103 for ALTERNATOR COMPONENT INFORMATIONBOARD ASSY ALTERNATOR CIRCUIT D20! 108301-A A B C 0
‘GY-1025BEARING FRONT iOA3O3
C9ZZ 10094-A A B C U‘GE-21
RECTIFIER ASSY. 10304* D4VY 10304-A
GY-1302-AE9DZ 10304-A
A
* 020! 10304-A‘GY-1026FOT! 10304-A
B C D
Bolt - No. 6-32 x 3/16" 3M279-S1--541-CX A B C DBoIt-swage-1/4" - 20 x 61/64" * 383760-S A B C DNut-1/4"-20Ierminal * 383256-5MM-296-AE A C DNut- hex-No. 10-24 * 383255-S8MM-296-AC A CScrew rectifier to rr. hsgj-No.8-32 x 7/8" * 384756-SUU-S2-AR .... ...4. .... IBoIt-swage-No. 10-24 x 11/16" * 384753-S88fB8-390-JX A B C 0BEARING REAR 020! 10A304-A
‘OE-31A B C D
WIRE ASSY. ALTERNATOR-2 1/2"Iong 020! 100307-A A B C D ]RING ROTOR SLIP 10328
1*020! 10328-A IAIBICJDI I I I I IINSULATOR TERMINAL 10329Red-5/8" ID. x 21/64" thick * OOAZ 10329-A A B C D
r/b D1A! 10A383-AROUSING FRONT 10333
03W 10333-A A B C D‘00-323-A
HOUSING REAR-incl. bearing 10334--D7V! 10334-A A B C D
‘011-314-BROTOR ASSY. 10335
*09!! 10335-B A B C DGM-462
E6OZ 10335-CSTATOR and COIL ASSY. 10336
D20! 10336-A A B C D‘OC-31 I
BRUSH SET 10347020! 10347-B A B C D‘GB- 128-A
Consists of:l-D2OF 1026O-AA Holder 2-C5AZ 10349-A Spring 2-D2OF 1OA367-BB Terminal
SPRING BRUSH 10349C5A! 10349-A 2 2 2 2GY-913
HOLDER BRUSH 10351Screw holder to rr. hsg-No.-32 x 5/8" * 384755-S2UU-5-DA 2STOPROTOR C5AZ 10A360-A A B C DTERMINAL STATOR D2QZ 10383-A 3 3 3 3INSULATOR DIODE PLATE 10A383
D3VY 10A3B3-A‘GY- 1301
2 2 2 2
TERMINAL KIT ALTERNATOR Dl?.! 1OA3B3-A A B C DConsists of:1-DOAZ 10329-A Insulator 1-DOAF 10A383-A Insulator
MARCH, 1994 COPYRIGHT © 994 - PORD MOTOR -DEARBORN MICHIGAN
COMPANY FINAL ISSUE
1980/89LIGHTTRUCK
PART NUMBER
2 SECTION 103.2MOTORCRAFT 70 AMP.
DESCRIPTION/RESTRICTIONS ALTERNATOR PARTS LISTS 2A THRU 2M
Notes: Refer to group 10346 In Section 103 for ALTERNATOR COMPONENT INFORMATIONBOLT TfIRU 10A396Hex.hd-1/4"-20x2" I 020Z 10A396’-A 141414t41 t I ICAPACITOR RADIO 18827
020! 18827-A A B C 0Screw capacitor to hsg-Nc. 6-32 x 1/4" * 384754-S7-8UU-51-CX A B C 0
NOTICE: When the parts list suffix is shown in the quantity required column, the quantity is one I.
MOTORCRAFT 1980/89 SECTION 103.3100 AMP. LIGHTTRUCK
DESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS 3A THRU 3M
NOTES: e MOTOR RECONDITIONER ONLYBOARD ASSY. ALTERNATOR CIRCUIT 020! 108301-A
GY-1025A B C
Pin - 3/32" x 7/16" * 384758-SNN-124-!A 2BEARING FRONT 10A303
0922 10094-A‘GE-21
A B C
RECTIFIER ASSY. 10304* 04W 10304-A
‘GY-1302-Ar/b E90! 10304-A
A B C
BoIt-swage-Nc, 10-24 x 11/16" * 384753-S88BB-390-JX A B CBoIt-swage-1/4"-20 x61/64" * 383760-S A B CBoIt-No.6-32 x3/16" * 384279-57-8BB-541-CX A B CNut-t/4"-20 terminal * 383256-SMM-296-AE A B CScrew rectifier to hsgj-No. 6-32 x7/8" * 384756-S2UU-52-AR 4 4 4BEARING REAR 020! 1OA3O4-A
9GE31A B C
WIRE ASSY. ALTERNATOR - 2 1/2" long 020! 100301-A A B C - -
RING ROTOR SLIP * D2O! 10328-A A B CINSULATOR TERMINAL - Red * DOA! 10329-A
r/b D1AZ 10A383-AA B C
HOUSING and BEARING FRONT D3VY 10333-AGD-323-A
A B C
HOUSING and BEARING REAR 10334D7V! 10334-AGH-3 14-B
A B C
Nut-No.10-24 terminal * 383255-SMM-296-AC A -
ROTOR ASSY. * D9VY 10335-A‘GM-463
r/b E6D! 10335-B
A B C
STATOR and COIL ASSY. D3VY 10336-AGC-312
A B C
BRUSH SET 020! 10347-8 A B CConsists of:1-D2OF 10260-AA Holder 2-C5AZ-1O349-A Spring 2-D2OF tOA367-BB Terminal & bearings
Screw-No, 8-32 x 5/8" * 384755-SIJU-51-DA 2 2 2SPRING BRUSH C5A! 10349-A A B CRETAINER FRONT BEARING 10A355Refer to group 10A303 in this parts listROTOR STOP C5A! 10A360-A A B CTERMINAL KIT DIA! 10A383-A A B C
Consists of:1-DOAZ 10329-A Insulator 1-DOAF 10A363-A Insulator
DIODE POSITIVE * D214! 10374-A 3 3DIODE NEGATIVE S D2H! 10378-A 3 3INSULATOR DIODE PLATE 03W 10A383-A 2 2 2
‘GY-1301BOLT ThRU-hex. head-l/4"-20 x 2" D20! 10A396-A 4 4 4CAPACITOR RADIO 18827Internal 020! 18827-A A B CScrew capacitor to hsgj- No, 8-32 xl/4" * 384754-S7-8UU-51-CX A B C
MARCH, 1994 COPYRIGHT © 994 FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
40, 60 AMP. INTEGRAL 1980/89 SECTION 103.4ALTERNATOR/REGULATOR LIGHT TRUCK
DESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS IA THRU 1M
BEARING FRONT C922 10094-A‘GE-21
A B
RECTIFIER ASSY. * E43Z 10304-A‘GY-1351
r/b E6D! 10304-A
A B
Screw attaches rectifier assy. * N803090-S7MAIAU-64-C 4 4BEARING REAR 020! 10A304-A
‘GE3lA B
REGULATOR ASSY. * E6T! 10316-A%R-784-A
rib E73! 10316-A
A B
Screw attaches regulator * N803090-57MAAU-64-C ..i. ..i.HOLDER ASSY. BRUSH & TERMINAL 843! 10320-A A B
-
Screw rush and terminal * N803706-536AlJ-64-B 2 2Nut & washer brush and terminalHOUSING FRONT
N62190O-S36AM-29-HE6A! 10333-A0D-364
2A
2B
-
HOUSING REAR * E43! 10334-A‘GH-368
r/b E6D! 10334-A
A B
BoIt-hex.head-No.l0-24x21/8" 37$466-51BB-55O-D 3 3 -
ROTOR ASSY. 10335
.
* E43! 10335-A‘GM469
r/b F2DZ 10335-A
B
* E432 10335-C‘CM -47 1
A
STATOR ASSY. 10336E6D! 10336-C‘GC-384
A
E69! 10336-B‘00-383
B
SPRINGifiRUSH C5AZ 10349-A 2 2RETAINER FRONT BEARING 0202 1OA355-A A BScrew hex. head No. 6-32 x 1/2" * 379201 3 3STOPROTOR C5AZ 10A360-A A BRING ROTOR STOP E6A! 10370-A
GY-l361A B
BOLT ThRU 10A396Bolt hex. head-No. 10-24 x 2 1/8" I 378466-Sl00B-550-D I 3 I 3 I I I I I I
MARCH. 1994 COPYRIGHT © 994 - FORD MOTOR -DEARBORN. MICHIGAN
COMPANY FINAL ISSUE
1980/89 SECTION 103.5
LEECE NEVILLE 165 AMP. LIGHTTRUCKDESCRIPTION/RESTRICTIONS PART NUMBER ALTERNATOR PARTS LISTS 1A THRU 1M
HIJKLM
BEARING FRONT B9AZ 10A303-A4GE-8
A
BEARING REAR 08HZ 1OA3O4-EAGE_So
A
REGULATOR ASSY. 08HZ 10316-D*GR_544
A
RING ASSY. SLIP D8HZ 10328-A*GY_ 1331
A
INSULATOR TERMINAL C4TZ 10329-A A -
HOUSING ASSY. FRONT E8PZ 10333-C*GD_374
A
HOUSING ASSY, REAR-incl. "0" ring 08HZ 10334-E4GH359
A
ROTOR ASSY.-inol, slip ring E8PZ 10335-B*GM_489
A
STATOR & TERMINAL ASSY. E8PZ 10336-B4GC-396
A
BRUSH ASSY. DIHZ 10347-AIB-124
A
HOLDER BRUSH E8PZ 10351-A*GY_ 1384
A
PLATE & DIODE ASSY. POSITIVE D8HZ 10373-04GY 1332
A
PLATE & DIODE ASSY. NEGATIVE D8HZ 10377-B4GY 1333
A
BUSHING RECTIFIER INSULATOR 10A3811/4" ID. x 13/16" 0.0. x 7/32" thick C5TZ 10A381-A 2 -
5/16" ID. x 13/16" O.D. x 7/32" thick C5TZ 10A381-B 2INSULATOR DIODE PLATE 0517 10A3B3-A 2DIODE TRiO * 08HZ 10A550-C A
March, 1994 COPYRIGHT © 1994- FORO MOTOR - DEARBORN, MCHIGAN
COMPANY Final Issue