2009 ZEECO, INC.
Zeeco ProductsProcess Burners
Flare SystemsIncineration Systems
Flare Gas Recovery Boiler & Duct BurnersAftermarket
2009 ZEECO, INC.
3 Generations of Combustion Leadership
John Steele Zink John Smith Zink Darton J. Zink
2009 ZEECO, INC.
Zeeco Company Profile Zeeco incorporated in 1979
Privately held by a family that has been involved in combustion technology for over 80 years.
No Debt
Headquarters in Broken Arrow, OK USA
Subsidiary Companies/Offices: Houston, Texas USA Stamford, UK Al-Khobar, KSA Mumbai, India
Seoul, Korea Calgary, Alberta, Canada Milan, Italy Sydney, Australia São Paulo, Brazil Tokyo, Japan
2009 ZEECO, INC.
Zeeco’s Global PresenceInstallations in over 62 Countries
46 International and 10 Domestic U.S. Locations1000+ Total Employees ▪ 800+ Engineering & Design Staff
2009 ZEECO, INC.
Zeeco Employees+750 Worldwide
Flare Team
Incineration Team
Aftermarket Support Team
Process Burner Team
Power Burner Team
2009 ZEECO, INC.
Quality Control / Philosophies ISO 9001:2008 Accredited Engineering, Manufacturing and Testing facility
ASME Section VIII Code Shop; U, R & S Stamps
CSA Certified
UL Certified
All inspection personnel are AWS/CWI certified and ASNT Level II in RT, PT
and MT
Lean Manufacturing Philosophies – 5S, Kaizen
2009 ZEECO, INC.
Zeeco Flare Products Management Department
Scot Smith Director, Flare Products
Applications Engineering
Chad Goodman
(Donna Murry)
Inquiries, Sales Questions
Project Engineering & Execution
Byron Criner
(Kathleen Moody)
Project Status Questions
Design & Engineering Support
Doug Allen
(Glenna Jumper)
Technical Questions
Rental / Portable / Bullet Group Applications Engineering
Kyle Shotts
(Beth Conover)
Sales & Project Status Questions
Biogas Applications Engineering
Mark Wampler
(Beth Conover)
Sales & Project Status Questions
2009 ZEECO, INC.
Merriam Webster Dictionary:
A fire or blaze of light used especially to signal, illuminate, or attract attention
API-521/537 – Industry Standards:
A device or system used to safely dispose of relief gases from a process in an environmentally compliant manner through the use of combustion
WHAT IS A FLARE? – Flare Definitions:
2009 ZEECO, INC.
General Flare Equipment
> Elevated Flares> Ground Flares> Vapor Controls> Common Flare Equipment> Flare Ancillary Equipment
2009 ZEECO, INC.
Standard Utility Tip (UF) Series
Sonic Utility Tip (UFX) Series
Severe Duty Utility Tip (UF-SD) Series
Un-assisted Utility Flare Tip Types
2009 ZEECO, INC.
Low Capital Cost
Sizes from 2 inch to 120 inch
No Moving Parts
310SS in High Heat Areas
Minimal Utility Consumption
High Flame Stability / Reliability from Purge to Sonic Velocity
Low or High Pressure Gases
Low BTU Gases
Minimum 98.5% Hydrocarbon Destruction Efficiency
WINDSHIELD (OPTIONAL)
FLAME STABILIZERPILOT BURNER
MIXER ASSEMBLY
FFG IGNITION GAS INLET
PILOT GAS MANIFOLD (OPTIONAL)
PILOT GAS INLET
VELOCITY SEAL (OPTIONAL) (NOT SHOWN)MAIN GAS INLET
LIFTING LUGS (OPTIONAL)
UF Series Un-assisted Flare Tips
2009 ZEECO, INC.
Self-Support
Heights to 300 Feet (92 Meters)
Moderate Capital Cost
Moderate Installation Cost
Small Plot Space Requirement
No Process Temp Limits
Guy-Support
Heights to 600 Feet (183 Meters) Plus
Low Capital Cost
Low Installation Cost
Large Plot Space Requirement
Process Temp Limits
Maintenance Requirements
Derrick-Support
Heights to 655 Feet (200 Meters) Plus
Can Be Demountable Type
High Capital Cost
High Installation Cost
Small Plot Space Requirement
No Process Temp Limits
Multiple Risers Possible
UF Series Un-assisted Flare Systems
SELF-SUPPORTED & GUYED FLARES; ALGERIA (BP AMACO / INSALAH GAS)
2009 ZEECO, INC.
Self-Supported Flare; Bolivia
Derrick-Supported Flare; Korea (KOGAS)
UF Series Un-assisted Flare Systems
Self-Supported Flares; Middle East
2009 ZEECO, INC.
Steam Injection for Smoke Control
Two Types of Single Point Steam Tips & One Multi-Nozzle Type Tip Available
Different Levels of Noise Generation
Different Steam Injection Efficiency
QFS Series
HCL Series
MJ-S Series
Steam-assisted Flare Tip Types
2009 ZEECO, INC.
QFS Series HCL Series Sonic Multi-Jet Steam-assisted (MJ-S) Series
Steam-assisted Flare Tip Types
2009 ZEECO, INC.
Lower Capital Cost Than Other Assist Methods
Sizes from 2 inch to 120 inch
No Moving Parts
310SS in High Heat Areas
High Flame Stability / Reliability from Purge to Sonic Velocity
Low or High Pressure Gases
Minimum 98.5% Hydrocarbon Destruction Efficiency
High Smokeless Range
Smokeless Combustion of a Wide Variety of Waste Gas Streams
PILOT BURNER
UPPER STEAM RING
FLAME STABILIZER
PILOT GAS MANIFOLD (OPTIONAL)
FFG IGNITION GAS INLET
MIXER ASSEMBLY
VELOCITY SEAL
(OPTIONAL) (NOT SHOWN)MAIN GAS INLET
CAST STEAM INJECTION SPIDER
UPPER STEAM INLET
CENTER STEAM INLET
QFS & QFSC Series Steam-assisted Flare Tips
2009 ZEECO, INC.
steamand air
flaregas
steam
air
top view
UPPER STEAM INJECTION FEATURES AND DESIGN
Steam injection nozzles positioned around the perimeter of the flare tip
Steam induces air and promotes turbulent mixing
Steam-Air Jet is Formed
Air Flows into the Vacuum
Vacuum Forms around high
velocity Steam Jet
Steam Pressure is converted to
velocity
Typical Steam Port or Orifice
Ste
am F
low
Ste
am F
low
Ste
am F
low
Vac
uu
m Z
one
Vac
uu
m Z
one
How steam draws in the air
Ste
am /
Air
2009 ZEECO, INC.
Upper Steam Injection from External Manifold at Perimeter of Flare Tip Exit Point
Steam Must Penetrate Gas Bundle
Center Steam Injection to Improve Flare Tip Life
For Xylene, 1.0 lb Steam Per lb Smokeless Flare Gas
QFS & QFSC Series Steam-assisted Flare Tips
2009 ZEECO, INC.
Derrick-Supported Flare; Saudi Arabia
(Sipchem)
Demountable-Derrick; India
(Reliance India / Jamnagar)
Demountable Derrick; Saudi Arabia
(Chevron Phillips / JCP)
QFS & QFSC Series Steam-assisted Flare Systems
2009 ZEECO, INC.
Demountable-Derrick; Saudi Arabia (Saudi Aramco / Petrorabigh)
QFS & QFSC Series Steam-assisted Flare Systems
2009 ZEECO, INC.
Guyed Flare; Oman (Sohar Aromatics)
Guyed Flare; Saudi Arabia (Gulf Farabi)
Derrick-Supported Flare; Qatar (Dolphin Energy)
QFS/QFSC & MJ-S Series Steam-assisted Flare Systems
2009 ZEECO, INC.
Sizes from 12 inch to 120 inch
No Moving Parts
310SS in High Heat Areas
High Flame Stability / Reliability from Purge to Sonic Velocity
Low or High Pressure Gases
Minimum 98.5% Hydrocarbon Destruction Efficiency
Highest Smokeless Range
Smokeless Combustion of a Wide Variety of Waste Streams
PILOT BURNER
UPPER STEAM RING
PILOT GAS MANIFOLD (OPTIONAL)
FFG IGNITION GAS INLET
MIXER ASSEMBLY
VELOCITY SEAL
(OPTIONAL) (NOT SHOWN)
MAIN GAS INLET
CAST STEAM INJECTION SPIDER
UPPER STEAM INLET (OPTIONAL)
CENTER STEAM INLET
LOWER STEAM RING
INTERNAL STEAM / AIR
TUBES
STAINLESS STEEL NOISE
SHROUD
HCL Series Steam-assisted Flare Tips
2009 ZEECO, INC.
UPPER AND LOWER STEAM INJECTION FEATURES AND DESIGN Lower steam nozzles deliver air and steam to the center of the flare tip Better smokeless performance than upper steam injection design Design of lower steam nozzles and tubes allows muffling
steamand air
flaregas
steam
airtop view
steamair
2009 ZEECO, INC.
Reduced Noise from Steam, Using Muffler Assembly
Higher Steam Efficiency
Injects Air Mixture Directly into Gas Bundle
Higher Cost Steam Flare Tip
Center Steam Injection to Improve Flare Tip Life
For Xylene, 0.70 lb Steam Per lb Smokeless Flare Gas
HCL Series Steam-assisted Flare Tips
2009 ZEECO, INC.
Demountable-Derrick; Qatar (Qatar Gas / QGII)
HCL Series Steam-assisted Flare System
2009 ZEECO, INC.
Flare Tip / Structures Types
> Un-assisted Utility (Pipe)> Steam-assisted> Air-assisted
2009 ZEECO, INC.
Air Injection for Smoke Control
Various Types of Tip Designs Available to Meet Customers Smokeless Requirements
Various Types of Blowers Available to Produce Necessary Air for Smokeless Flaring
Different Blower Arrangements & Control Systems for Meeting Customers Smokeless Requirements
Guyed Flare; Ecuador (OXY)
Air-assisted Flare Tips
2009 ZEECO, INC.
Lower Utility Costs Than Other Assist Methods
Sizes from 2 inch to 120 inch
No Moving Parts
310SS in High Heat Areas
High Flame Stability / Reliability from Purge to Sonic Velocity
Low or High Pressure Gases
Minimum 98.5% Hydrocarbon Destruction Efficiency
High Smokeless Range
Smokeless Combustion of a Wide Variety of Waste Gas Streams
Used in Arctic Environments Where Steam Could Freeze
Used in Desert Environments Where Water is Scarce
MAIN GAS INLET
PILOT BURNER
OUTER AIR PLENUM
FFG IGNITION GAS INLET
PILOT GAS MANIFOLD (OPTIONAL)
PILOT GAS INLET
INNER GAS TIP
MIXER ASSEMBLY
AF Series Air-assisted Flare Tips
2009 ZEECO, INC.
Gas in Center Riser
Air in Outer Riser
Mixes at Tip Exit
Shorter Flame Than Conventional Flare Tip
Longer Flare Tip Life Due to Continual Cooling by Forced Air Flow
Variable Speed Fans May Be Used For Staging
Where Smokeless Flaring is Desired and Steam or Assist Gas is Not Available or Cost Effective
Lower Radiation Due to More Aerated Flame
Lower Noise Than Similar Sized Steam Flares
AF Series Air-assisted Flare Tips
2009 ZEECO, INC.
Without HPAAS Air-assist With HPAAS Air-assist
HPAAS Series Air-assisted Flare Tips
2009 ZEECO, INC.
Engine Driven Type
Centrifugal Type
Vaneaxial Type
AF Series Air-assisted Blower Types
2009 ZEECO, INC.
Aramco (Khurais); Saudi Arabia
KOC Flare; Kuwait
KOC; Kuwait
ETP Godley; Texas, USA OCN / ExxonMobil; Venezuela
Blower Arrangement Examples (Vaneaxial Blowers)
2009 ZEECO, INC.
Atlas Pipeline; Western Oklahoma Conoco Phillips; Pasadena, Texas
Aramco (Khurais); Saudi Arabia
AF Series Air-assisted Flare Systems
2009 ZEECO, INC.
Flare Tip / Structure Types
> Un-assisted Utility (Pipe)> Steam-assisted> Air-assisted> Sonic
2009 ZEECO, INC.
Proprietary Jet Nozzles
Jet Action Entrains Air For Smokeless Combustion
Recommended Pressures >14 PSIG
High Capacity
SONIC NOZZLES
PILOT GAS MANIFOLD (OPTIONAL)
MAIN GAS INLET
PILOT GAS MIXER
PILOT GAS INLET
PILOT BURNER
FFG IGNITION GAS INLET
MJ Series Sonic Flare Tips
2009 ZEECO, INC.
Derrick-Supported Flare; Offshore Qatar (SMOE/OXY <Occidental Petroleum Of Qatar>)
MJ Series Sonic Flare Tips
2009 ZEECO, INC.
Self-Supported Flare; Korea (SK Corp.)
Demountable-Derrick; India (Reliance India / Kalkinada)
MJ Series Sonic Flare Tips
2009 ZEECO, INC.
Flare Tip / Structure Types
> Un-assisted Utility (Pipe)> Steam-assisted> Air-assisted> Sonic> Gas-assisted
2009 ZEECO, INC.
HP Gas-assist Injection for Smoke Control
Two Types of Single Point Gas-assist Tips & One Multi-Nozzle Type Tip Available
Gas-assisted Flare Tips
2009 ZEECO, INC.
Flare Tip / Structure Types > Un-assisted Utility (Pipe)> Steam-assisted> Air-assisted> Sonic> Gas-assist> Liquid
2009 ZEECO, INC.
Smokeless Capacity
Variety of Atomizing Media
High Flow Rates
No Detectable Fallout
Onshore and Offshore
Liquid Flare Tips
2009 ZEECO, INC.
Dubai Water & Energy Authority; Dubai
Total; Offshore Indonesia
ZLF Series Flare Tips
2009 ZEECO, INC.
Integral Piece of Equipment Within the Flare Tip
Does NOT Require a Dedicated Drain Line
Ensures O2 Level Does Not Reach Over 6-8% Below the Velocity Seal Device
Velocity (Dynamic / Fluidic / Arrestor) Seals
2009 ZEECO, INC.
Velocity Seal
nozzle-like restriction in
flare stack
increased velocity in
throat reduces air
infiltration
2009 ZEECO, INC.
Airrestor air
purge gas
Airrestor Seal is a velocity seal. As the air comes down the seal inner walls the seal breaks the flow attachment.
2009 ZEECO, INC.
Separate Piece of Equipment Below Flare Tip
Requires a Dedicated Drain Line
Ensures O2 Level Does Not Reach Over 0% Below the Gas Seal Device
Gas (Molecular / Labyrinth / Buoyancy / Density) Seals
2009 ZEECO, INC.
Buoyancy Seal
consists of two annular flow
reversals
separates purge gas from air due
to buoyancy difference, similar to
the P-trap under a sink
2009 ZEECO, INC.
Molecular Sealair
purge gasdrain
Molecular Seal is a density seal and relies on the differencein density between airand purge gas.
2009 ZEECO, INC.
Some companies may opt to locate a liquid seal drum in the stack base to prevent a flashback from entering the piping upstream of the flare and design the stack / riser system for some larger design pressure to withstand a flashback thus eliminating any need for purge requirements
Liquid Seal Drums
2009 ZEECO, INC.
LIQUID SEAL DRUMS
Create positive header pressure
Fail-safe flashback protection
Can act as a staging device
2009 ZEECO, INC.
Consists of Rows of Multiple Burners
Wide Pressure Ranges
Low Radiation
High Turndown
Wide Variety of Waste Gas Streams
May Be Used in Combination with Utility or Air or Steam-assisted Flares
High Destruction Efficiency
High Reliability
Multi-Point Ground Flares (MPGF)
Marathon Alba; Equatorial Guinea
2009 ZEECO, INC.
ExxonMobil; Bonny Nigeria RAS Laffan Olefins; Qatar
Multi-Point Ground Flares (MPGF)
2009 ZEECO, INC.
Wide Pressure Ranges
Very Low Thermal Radiation
High Turndown
Wide Variety of Waste Gas Streams No Visible Flame
Low Noise
High Destruction Efficiency
High Reliability
Enclosed Ground Flares (EGF)
BHP Billiton Petroleum; Australia
2009 ZEECO, INC.
Zeeco Design
Variable Arm Area
Investment Cast
310 SS Equivalent
Cast Material
Pressure Tested at
Factory
Common MPGF & EGF Burners
2009 ZEECO, INC.
Most Ground Flares (Multi-Point or Enclosed) Consist of a Staging Skid
Staging Valves Ensure the Flare Operates at Some Minimum Pressure for Optimal Performance
Bypass Device Required
Common MPGF & EGF Staging
2009 ZEECO, INC.
Disposal of Two-Phase Flow, Gas and Liquids, or Just Liquids
Liquid Collected Within a Pit
Typically a Non-Smokeless System
Burn Pits
2009 ZEECO, INC.
Common Flare Equipment> Ignition System Types> Pilot Types> Knock-Out Drums> Liquid Seal Drums
2009 ZEECO, INC.
Ignition System Types> Flame Front Generator (FFG)> High-Energy Electronic Spark (HEI)> Continuous / Sparks Every Time (SETZ)> Piezo-Electric> Pellet Ignition> Ability To Meet All Hazardous Areas
2009 ZEECO, INC.
Flame Front Generator
Typical P&ID Arrangement Basic Components
Instrument Air Line Fuel Gas Line Pilot Gas Line[s] Ignition Gas Line[s] Pilots Etc.
Considerations Basic Engineering Design and
Data (BEDD) Temperatures Pressures Flow Ambient Conditions
Customer Specifications Zeeco Turnover Packet/Quote
File
2009 ZEECO, INC.
Pilot Ignition - OperationFlame Front Generator
Pilot
ignition box
air inlet
fuel inlet
FFG1-inchignition line
drainvalve
Drain liquid from ignition line and close valve.
15
15 sparkgenerated
Depress AND release ignition button (creates fireball).
fireball
2009 ZEECO, INC.
High Energy Ignition
Spark ignition tip installed
on the pilot itself
No air supply required
Ignite multiple pilots at once
Typically all HEI systems
are both auto/man
Less equipment, costly
maintenance
2009 ZEECO, INC.
pilot
Pilot Ignition - OperationElectronic Ignition
high V DC
ignition wire
sparkprobe
ignition box
2009 ZEECO, INC.
Flame Front Generator (FFG)
High Energy Electronic Spark (HEI)
Continuous Sparking (SETZ)
Ignition Systems
2009 ZEECO, INC.
Flame Front Generators (FFG)
Requires Continual Supply of Fuel Gas
Requires Ignition Gas and Ignition Air Supplies During Ignition Sequencing
Can be Supplied with Manual, Automatic or a Combination (Auto/Man) Mode
High Energy Electronic Ignition (HEI)
Requires Continual Supply of Fuel Gas
Consists of High Energy Ignition Module and Ignition Probe (On Pilot)
Reliable / Non-Fouling Direct Ignition
General Data
Can Meet Any Hazardous Area Classification
Multiple Ignition Systems can be Supplied on Same Ignition Rack
Ignition Systems
2009 ZEECO, INC.
Pilot Types> HSLF Series> CFP Series> Continuous Sparking> Retractable (EGF)> Pilot Retraction Systems> Pilot Options
2009 ZEECO, INC.
HSLF (High-stability, Low Fuel Consumption) Series
CFP Series
Continuous Sparking (SETZ) Series
Pilots
2009 ZEECO, INC.
Model HSLF
65,000 BTU/hr
High Stability with High MW Gases to High Hydrogen Gases
Flame Front Generator and / or
Electric Ignition
1 or 2 Thermocouples
Retractable Thermocouple
Pilots
2009 ZEECO, INC.
Model CFP
250,000 BTU/hr
High Stability with High MW
Gases to High Hydrogen Gases
Flame Front Generator and / or
Electric Ignition
1 or 2 Thermocouples
Retractable Thermocouple
Pilots
2009 ZEECO, INC.
Over 150 mph (242 kph)
Wind Speed
Over 50 inch (127 cm) per hour Rainfall
Wind at 90 Degrees to Pilot
Wind Into FACE of Pilot
HEI and FFG Re-Ignition
Confirmation
Hurricane Test Video is Part
of Zeeco’s WebsiteZeeco Pilot Hurricane Test Video
Pilot Stability Testing
2009 ZEECO, INC.
> Pilot Thermocouples for Pilot Flame Detection> Pilot Flame Ionization for Pilot Flame Detection
Pilot Options
2009 ZEECO, INC.
Horizontal Settling Drum
flare gas in flare gas out
liquid out
liquid levelcontrol
Must have time for droplets to fall through vapour space Large, separate, horizontal drum Low pressure drop
2009 ZEECO, INC.
Vertical Separation Drum
Droplet removal by inertial, not gravitational separation Can be incorporated into stack base Smaller diameter than vertical settling drum High removal efficiency High pressure drop
flare gas in
flare gas out
liquid out
liquid levelcontrol
2009 ZEECO, INC.
Used to Collect any Liquid Entrained in a Waste Gas Stream
Improperly Sized Could Result in Liquid Carryover Out of the Flare Tip
Types Include Separate / Stand-Alone (Horizontal or Vertical) or Integral in Stack Base (Vertical)
Knock-Out Drums
2009 ZEECO, INC.
Used to Produce Back-Pressure on Flare Header / Systems Upstream of Flare
Can Collect any Liquids Entrained in a Waste Gas Stream
Acts as a Protection Barrier from Flashback Between Flare and Header Piping / Equipment Upstream of Flare
Types Include Separate / Stand-Alone (Horizontal or Vertical) or Integral in Stack Base (Vertical)
May be Designed as Deep Seal Type for Staging of Flares or Use with Flare Gas Recovery Systems
Liquid Seal Drums
2009 ZEECO, INC.
Can Design for any Regulatory Body (FAA, ICAO, etc.)
Consists of the Supply of Warning Lights or Obstruction Beacons and / or Marking (Red / White Painted Bands) of the Equipment
When Painted Red / White Bands are Required, High Temperature Paint is Required for Upper Bands
Upper Level of Lights Require Heat Shield (Stainless Steel Type is Standard)
Aircraft Warning Lighting / Marking
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly
Flare Ancillary Equipment
2009 ZEECO, INC.
Retractable Type
Requires Small Manual Winch
to Extend / Retract Davit
Assembly
Carbon Steel Construction with
Stainless Steel Heat Shield
Can Lower / Raise Flare Tip
Assembly to / From Grade
Grade-Mounted Winch
Required
Flare Tip Davit Assemblies
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems
Flare Ancillary Equipment
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors
Flare Ancillary Equipment
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors > Staging / Isolation Valves
Flare Ancillary Equipment
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors > Staging / Isolation Valves> Staging Bypass Devices
Flare Ancillary Equipment
2009 ZEECO, INC.
Rupture Disc for High Pressures
Spring Type Relief Valves
Liquid Seal Drum
Rupture Pin Valve
Bursting Pin Relief Valve
Piloted Rupture Pin Valve
Pilot Operated Relief Valve
Staging Bypass Devices
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors > Staging / Isolation Valves> Staging Bypass Devices> LPG Fuel Gas Back-up / CO2 Snuffing System Skids
Flare Ancillary Equipment
2009 ZEECO, INC.
Lpg Fuel Back-up System CO2 Snuffing System
LPG Fuel Gas Back-Up / CO2 Snuffing System Skids
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors > Staging / Isolation Valves> Staging Bypass Devices> LPG Fuel Gas Back-up / CO2 Snuffing System Skids> Flame / Smoke Monitors
Flare Ancillary Equipment
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors > Staging / Isolation Valves> Staging Bypass Devices> LPG Fuel Gas Back-up / CO2 Snuffing System Skids> Flame / Smoke Monitors > Automatic Steam Control Systems
Flare Ancillary Equipment
2009 ZEECO, INC.
> Aircraft Warning Lighting / Marking> Flare Tip Lifting Davit Assembly> Winch Systems> Flame Arrestors > Staging / Isolation Valves> Staging Bypass Devices> LPG Fuel Gas Back-up / CO2 Snuffing System Skids> Flame / Smoke Monitors > Automatic Steam Control Systems> Automatic Blower Control Systems> KO / LS Drum Controls / Instrumentation
Flare Ancillary Equipment
2009 ZEECO, INC.
Supply list in Korea after 2010No. SO# Final Equipment End User Location Tip Type Tip Size Flare Tip Support Type Supply Date Remark
1 14615 Samsung Fine Chemical Ulsan QFSC 30" Derrick, 69M 30-Nov-04 2015년 1월 pilot burner 교체함.
2 18176 KOGAS Tongyoung UFW 36" T.Derrick, 45M 22-Jun-09
3 18216 Hyundai Oilbank, Daesan Daesan QFSC 72" Derrick 17-Apr-10
4 18743 LG petrochemical Daesan HSLF-Z-HEI UA-811 16-Mar-10
5 19049 LG Chem, Daesan Daesan QFS 20" Derrick 31-Jan-11
6 20126 Hyundai Oilbank, Daesan Daesan QFSC 54" Derrick, 120M 15-Jul-11
7 20738 LG Chem, Daesan Daesan QFSC 48" Derrick 12-Jan-12
8 21978 KOGAS, SamCheok Samcheok UFW 40", 50M T.Derrick, 50M 01-Oct-13
9 21979 SMP, Ulsan Ulsan QFS/UFW 20"/14" Self 2014
10 22083 Western Power, Taean IGCC Taean UFW/UFW 76"/16" Derrick 28-Feb-14
11 22114 Kolon Ind, Daesan Daesan QFSC 48" Self 05-Nov-13
12 22521 POSCO, SNG Proj. Gwangyang QFSC 56" Self, 49M 09-May-14
2009 ZEECO, INC.
Supply list in Korea after 2010No. SO# Final Equipment End User Location Tip Type Tip Size Flare Tip Support Type Supply Date Remark
13 22563 LG chemical/OXO Yeosu Flare tip package 48"/8" Derrick, 70M 12-Sep-131995년 설치, 2014년 flare tip
교체.
14 22768 Deokyang Ulsan QFSC 36" Self, 35M 01-Jan-14
15 23399 Hyosung Etylene terminal Ulsan AFDS-8/18 18" Self, 35M 30-Mar-14
16 23619 Hyosung, DH2 Ulsan QFSC 52" Derrick, 88M 30-Sep-14
17 23683 Taekwang Ind. Ulsan HCS-30, UFS-18 30", 18" Derrick, 70M 01-Mar-141996년 설치, 2014년 pilot burner
교체함.
18 24286 LG Chem BPA Yeosu QFSC 38" self, 50M 30-Oct-14 2014년 flare tip capa. up 함.
19 24347 Hyosung POK-1 Ulsan AFTA-28/50 50" Self, 30M 06-Jan-15
20 25046 Boryeong LNG Terminal Boryeong AFTA 30/44" Derrick, 56M 15-Jul-15
21 25850 Samsung Fine Chemical Ulsan QFSC 30" Derrick, 69M 10-Mar-152004년 설치. 2015년 1월 pilot
burner 교체함.
22 26075 Gwangyang LNG terminal Gwangyang Ground flare system 6.1M d x 25M L 16-Nov-15
23 26223 YNCC Yeosu QFSC 38" Derrick, 70M 20-Oct-15
24 26388 LG Chem, LDPE (Applicot) Yeosu AES 16" self, 32M 2002 2015년 5월 pilot burner 교체함.