7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 1/43
DLP Projection TVSERVICE MANUAL
CAUTIONBEFORE SERVICING THE CHASSIS,
READ THE SAFETY PRECAUTIONS IN THIS MANUAL.
CHASSIS : NB-03JC
MODEL : RU-44SZ61D RU-52SZ61D
website:http://biz.LGservice.come-mail:http://www.LGEservice.com/techsup.html
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 2/43
SAFETY PRECAUTIONS
1. Before returning an instrument to the customer, always make a safetycheck of the entire instrument, including, but not limited to, thefollowing items:
a. Be sure that no built-in protective devices are defective and/or havebeen defeated during servicing. (1) Protective shields are provided onthis chassis to protect both the technician and the customer. Correctlyreplace all missing protective shields, including any removed forservicing convenience. (2) When reinstalling the chassis and/or otherassemblies in the cabinet, be sure to put back in place all protectivedevices, including, but not limited to, nonmetallic control knobs,insulating fishpapers, adjustment and compartment covers/shields, andisolation resistor/capacitor networks. Do not operate this instrumentor permit it to be operated without all protective devices correctlyinstalled and functioning.
b. Be sure that there are no cabinet openings through which an adult orchild might be able to insert their fingers and contact a hazardousvoltage. Such openings include, but are not limited to, (1) spacingbetween the picture tube and the cabinet back, (2) excessively widecabinet ventilation slots, and (3) an improperly fitted and/or incorrectlysecured cabinet back cover.
c. Antenna Cold Check-With the instrument AC plug removed from anyAC source, connect an electrical jumper across the two AC plug prongs.Place the instrument AC switch in the on position. Connect one lead ofan ohmmeter to the AC plug prongs tied together and touch the otherohmmeter lead in turn to each tuner antenna input exposed terminalscrew and, if applicable, to the coaxial connector. If the measuredresistance is less than 1.0 megohm or greater than 5.2 megohm, anabnormality exists that must be corrected before the instrument isreturned to the customer. Repeat this test with the instrument ACswitch in the off position.
d. Leakage Current Hot Check-With the instrument completelyreassembled, plug the AC line cord directly into a 120 V AC outlet.
(Do not use an isolation transformer during this test.) Use a leakagecurrent tester or a metering system that complies with AmericanNational Standards Institute (ANSI) C101.1 Leakage Current forAppliances and Underwriters Laboratories (UL) 1410, (50.7). With theinstrument AC switch first in the on position and then in the off position,measure from a known earth ground (metal waterpipe, conduit, etc.) toall exposed metal parts of the instrument (antennas, handle bracket,metal cabinet, screwheads, metallic overlays, control shafts, etc.),especially any exposed metal parts that offer an electrical return path tothe chassis. Any current measured must not exceed 0.5 milliamp.Reverse the instrument power cord plug in the outlet and repeat thetest.ANY MEASUREMENTS NOT WITHIN THE LIMITS SPECIFIED HEREIN
INDICATE A POTENTIAL SHOCK HAZARD THAT MUST BEELIMINATED BEFORE RETURNING THE INSTRUMENT TO THECUSTOMER.
they are serviced. (X-radiation protection circuits also may be called"horizontal disable" or "hold-down.") Read and apply the high voltagelimits and, if the chassis is so equipped, the X-radiation protection circuitspecifications given on instrument labels and in the Product Safety & X-
radiation Warning note on the service data chassis schematic.High voltage is maintained within specified limits by close-tolerancesafety-related components/adjustments in the high-voltage circuit.If high voltage exceeds specified limits, check each componentspecified on the chassis schematic and take corrective action.
2. Read and comply with all caution and safety-related notes on or insidethe receiver cabinet, on the receiver chassis, or on the picture tube.
3. Design Alteration Warning- Do not alter or add to the mechanical orelectrical design of this TV receiver. Design alterations and additions,including, but not limited to, circuit modifications and the addition ofitems such as auxiliary audio and/or video output connections, mightalter the safety characteristics of this receiver and create a hazard tothe user. Any design alterations or additions will void the manufacturer'swarranty and will make you, the servicer responsible for personal injuryor property damage resulting therefrom.
4. Picture Tube Implosion Protection Warning-The picture tube in thisreceiver employs integral implosion protection. For continued implosionprotection, replace the picture tube only with one of the same type andnumber. Do not remove, install, or otherwise handle the picture tube inany manner without first putting on shatterproof goggles equipped withside shields. People not so equipped must be kept safely away whilepicture tubes are handled. Keep the picture tube away from your body.Do not handle the picture tube by its neck. Some "in-line" picture tubesare equipped with a permanently attached deflection yoke; because ofpotential hazard, do not try to remove such "permanently attached"yokes from the picture tube.
5. Hot Chassis Warning-a. Some TV receiver chassis are electrically
connected directly to one conductor of the AC power cord and may besafely serviced without an isolation transformer only if the AC powerplug is inserted so that the chassis is connected to the ground side ofthe AC power source. To confirm that the AC power plug is insertedcorrectly, with an AC voltmeter measure between the chassis and aknown earth ground. If a voltage reading in excess of 1.0 V is obtained,remove and reinsert the AC power plug in the opposite polarity andagain measure the voltage potential between the chassis and a knownearth ground. b. Some TV receiver chassis normally have 85 V AC (RMS)between chassis and earth ground regardless of the AC plug polarity.These chassis can be safely serviced only with an isolation transformerinserted in the power line between the receiver and the AC powersource, for both personnel and test equipment protection. c. Some TV
receiver chassis have a secondary ground system in addition to the mainchassis ground. This secondary ground system is isolated from the ACpower line. The two ground systems are electrically separated byinsulating material that must not be defeated or altered.
6. Observe original lead dress. Take extra care to assure correct leaddress in the following areas: a. near sharp edges, b. near thermally hotparts- be sure that leads and components do not touch, c. the ACsupply, d. high voltage, and e.antenna wiring. Always inspect in all areasfor pinched, out-of-place, or frayed wiring. Do not change spacing
DEVICEUNDERTEST
LEAKAGECURRENTTESTER
(READING SHOULDNOT BE ABOVE
0.5mA)
+
AC Leakage Test
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 3/43
SPECIFICATIONS.................................................................4
DESCRIPTION OF CONTROLS...........................................5
ADJUSTMENT INSTRUCTION...........................................13
BLOCK DIAGRAM...............................................................19
EXPLODED VIEW..........................................................24,26
EXPLODED VIEW PARTS LIST ....................................25,27
REPLACEMENT PARTS LIST............................................28
SCHEMATIC DIAGRAM..........................................................
PRINTED CIRCUIT BOARDS.................................................
TABLE OF CONTENTS
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 4/43
SPECIFICATIONS
Models
RU-44SZ61D Horizontal Size (Inches) 41.7Height (Inches) 30.1Depth (Inches) 14Weight (lbs.) 64
RU-52SZ61D Horizontal Size (Inches) 48.6Height (Inches) 35.1Depth (Inches) 15.3Weight (lbs.) 80
Power Requirement AC 120V, 60Hz
Television System American TV Standard, NTSC, ATSC with STB
Television Channels VHF: 2 - 13UHF: 14 - 69CATV: 1 - 125
Power Consumption (W) 270W
Antenna 75 ohm External Terminal for VHF/UHF
Audio Output (W) 15W x 2
Supplied Accessories Remote control, 2 size AA batteries.
External Input/Output Ports Video input (3 set)Video output (1 set)S-Video input (2)
Component input (2 set)RGB input (1)DVI input (1)RGB/DVI audio input (1 set)Variable audio output (1 set)Audio center mode input (1)Calibration port (1)
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 5/43
DESCRIPTION OF CONTROLS
Function Status Indicators
Lamp indicator, operation indicator, and temperature indicator located below the front panel
controls, reveal the operating status of the DLP projection TV.
Operation Indicator
Lamp Indicator
Temperature Indicator
Off Power cord is not connected.
Red Power Cord is connected, TV is in standby mode.
Green OnOrange (flashing) Preparing operation in standby mode.
Orange Projection lamp is reaching the end of its life and needs to
be replaced with a new lamp.
Red (flashing) There is a problem with the lamp or around it. Contact an
authorized service center.
Operation Indicator
Lamp Indicator
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 6/43
DESCRIPTION OF CONTROLS
Rear Connections Panel
CALIBRA TION
PC/DTV(XGA/480p/720p/1080i)
AUDIOCENTERMODE IN
PR
DVI INPUT
DTV/ DVD INPUT
COMPONENT
INPUT2 INPUT1
PB
Y
PC/DTV(XGA/480p/720p/1080i)
RGB INPUT
RGB/DVI INPUT
(R)
(L)
AUDIO
(R)
(L)
AUDIO
(R)
(L)
AUDIO
V
ARIABLE
A
UDIO
OU T
MONITOROUT
VIDEOINPUT 2
VIDEOINPUT 1
S-VIDEO
(R)
(L)
AUDIO
VIDEO
MONO
+75 Ω
ANT IN
S-VIDEO In
A connection available with
some high-end equipment
that provides even better pic-
ture quality for Video 2.
V i bl A di O t
RF Connector: AntennaUsed to connect analog
cable or antenna signals
to the television, either
directly or through your
cable box.
Video 1 or 2
Connects the video sig-
nals from various types
of equipment.
Y, Pb, Pr
Connecting cables and external equipment to your
TV.
This manual explains the features available
on the RU-52SZ61D TVs.
Monitor Out
Connects to a second TV
or Monitor.
Left/Right Audio
Used for stereo sound
from various types of
equipment.
PC and HD-STB Input
Used to connect from a
PC source or HD-STB
Satellite system.
PC and HD STB Audio
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 7/43
DESCRIPTION OF CONTROLS
Front Connection Panel
Front A/V Panel
S-VIDEO
VIDEO
FRONT A/V
AUDIO
(R)
(L) /MONO
There are four jacks on the left front side behind the screenon your projection TV that make connecting Audio/Video
devices like video games and camcorders very simple.
The jacks are like those found on the back jack connection
panel. This means that most equipment that connects to
those types of jacks on the rear jackpack, may be connect-
ed to the front connection panel.
To use the front jacks as the signal source, select them
using Main Input menu as described on page 25. They will
be named “Front Video” in the Main Input menu.
Left/Right Audio
Used for stereo
sound from various
types of equipment.
Video
Connects the video
signals from any
piece of equipment.S-Video
A connection available on
some very high-end equip-
ment that provides betterpicture quality than video
input.
If you select either Front Video or
Front S-Video, the Front audio
inputs are automatically selected
as well.
If you’re connecting a video gamedevice, make sure to change the
picture settings with the EZ
Picture option in the Video menu.
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 8/43
DESCRIPTION OF CONTROLS
ANT / Cable Service Hookup
1Connect an antenna and/or cable ser-
vice to your TV as shown.
Turn to page 22 to do a channel search
with EZ Scan for Ant/Cable
connection(s).
2
If you receive your RF signal
through an antenna that is sev-
eral years old and connectswith two small prongs, you will
need to purchase a 300 to 75
ohm adapter. It should be
available from your local
electronics dealer.
We recommend using a 75
MONITOROUT
VIDEOINPUT 2
VIDEOINPUT 1
S-VIDEO
(R)
(L)
AUDIO
VIDEO
MONO
+75 Ω
ANT IN
MONITOROUT
VIDEOINPUT 2
VIDEOINPUT 1
S-VIDEO
(R)
(L)
AUDIO
VIDEO
MONO
+75 Ω
ANT IN
Antenna
Cable TVWall Jack Panel
RF CoaxialWire(75 ohm)
RF Coaxial
Wire(75 ohm)
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 9/43
DESCRIPTION OF CONTROLS
Remote Control Functions in TV Mode
1 2 3
4 5 6
7 8 9
0
TV
MODE LIGHT POWER
TV/VIDEO DVI
RGB
VCR CABLE DVDSAT
MUTE
SWAPPIPCH- PIPCH+PIP
RATIO
MENU EXIT
CC FREEZE PIP INPUT
VOL CH
SURF
SAP VIDEO
COMP2COMP1
FRONT
ENTER FLASHBK
SURFScrolls the Surf channel list.
MENUBrings up the main
EXITClears all on-screen dis-
FREEZECaptures and freezes the currently-viewed main picture in PIP mode.
VIDEOAdjusts the factory preset pic-
ture according to the room.
PIPCH+Changes to next higher PIPchannel.
SWAPSwitches the picture fromPIP, POP, or twin picture tothe main screen.
MUTESwitches the sound on or off
THUMBSTICKAllows you to navigate the on-screenmenus and to adjust the system set-tings and preferences, by moving to
an option withF G and selecting thehighlighted option with .
TV/VIDEOSelects: Analog, Video1,
Video2, Front video,Component1-2, RGB, and DVI
input sources.
MODE
Selects the remote operatingmode: TV, VCR, Cable, DVD
and Satellite. Select other oper-ating modes, for the remote to
control external devices.
FRONTSelects the front video signal ifa device, such as a camcorder
or game player, is connectedto the front video input jack.
DVI
Selects: DVI-DTV and DVI-PC input sources.
SAPSelects: Mono, Stereo, and
SAP.
PIPCH-Changes to next
lower PIP channel
PIPToggles between PIP, POP(Picture-out-of-Picture) and
Twin picture mode.
LIGHTIlluminates the remote con-trol keys.
INDICATOR LIGHTSShow active remote modeevery time any button ispressed.
DE
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 10/43
DESCRIPTION OF CONTROLS
Remote Control Functions in TV Mode
1 2 3
4 5 6
7 8 9
0
TV
MODE LIGHT POWER
TV/VIDEO DVI
RGB
VCR CABLE DVDSAT
MUTE
SWAPPIPCH- PIPCH+PIP
RATIO
MENU EXIT
CC FREEZE PIP INPUT
VOL CH
SURF
SAP VIDEO
COMP2COMP1
FRONT
ENTER FLASHBK
POWERTurns your TV or any otherprogrammed equipment on
or off, depending on mode.
CHANNEL UP/DOWNScrolls through availablechannels in EZ Scan memo-
NUMBER KEYPADFor direct channel selection and
programming functions.
ENTERWhen in the menu systemand other on-screen dis-plays, selects highlightedoptions.
VOLUME UP/DOWNIncreases/decreases the sound
level.
RATIOChanges the screen format or
aspect ratio.
COMPONENT 1, 2Selects component signal sources,
such as DVD or HD receiver.
ENTERWhen in the menu system and
other on-screen displays,selects highlighted options.
FLASHBKTunes to the last channelviewed.
CCSelects a closed caption modefor displaying captioning infor-
mation if available on program.
PIP INPUT
Selects the input source for thesub picture.
RGBSelects: RGB-DTV andRGB-PC input sources.
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 11/43
DESCRIPTION OF CONTROLS
On-Screen Displays
This page describes your on-screen display and information banner options.
10
AM 03:00
TV 13
MONO
TV 6
Main Channel DisplayDisplays current channel number.
Channel Label
If a channel label has beenset, then it will appear here.
PIP DisplayThis displayappears whenPIP is active.ABC
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 12/43
DESCRIPTION OF CONTROLS
Front Panel Controls
POWER MENU ENTER VOL CH
1 2 43 67
85
POWER
MENU
ENTER (Same as ENTER button on your
remote control)
VOLUME UP / DOWN
CHANNEL UP / DOWN
Operation indicator.
1
2
34
5
6S f i t ti i th
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 13/43
1. Application ObjectThis instruction is for the application to the DLP Projection
TV(Chassis: NB-03JC).
2. Notes(1) The power source insulation of this DLP Projection is not
charging type and you may not use the transformer for
insulation. But you’d better adjust the set after operating it
with insulation transformer between power supply cable
and input part of the set for protecting the adjusting
equipments.
(2) The adjustment must be performed under the correct
sequence.
(3) The adjustment must be performed in the circumstance of
25¡ 5°C of temperature and 65¡ 10% of relative humidity
if there is no specific designation.
(4) The input voltage of the receiver must keep 110V, 60Hz in
adjusting.
(5) The set must be operated for 5 minutes preliminarily
before adjustment if there is no specific designation.
The preliminary operation must be performed after
receiving 100% white pattern,but reception of the moving
picture may also be possible in unavoidable case.
3. Composition of Adjustment Mode(1) All adjustment mode are entered by pressing the ADJ key
on the remore control,after adjustment pess the ADJ key to
come out.
(2) Below picture is screen composition when press the first
ADJ key.
(4) Adjust the value of adjustment with using the volume
+(F),volume -(G) key.
(5) Press the ADJ key to come out after adjustment.
(6) Preparation for Adjustment
1) Connect the power to TV Set and set the status of
“Power on”.
2) Heat-Run must operate over 5 minitues before
adjustment.
4. Driver Board Bin SettingSee Bias Voltage Bin on the DMD as shown Fig 2 and adjust
the switch on the lower Driver Board as shown Fig 3.
5. Adjustment the optical engine
ADJUSTMENT INSTRUCTIONS
<Fig 2> DMD Marking Locations
<Fig 3> Driver Board Bin Setting
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 14/43
ADJUSTMENT INSTRUCTIONS
1) The screen change when adjusting the A
- When fasten the screw: Fall out the upper/right
illuminator
- When loosen the screw: Fall out the lower/left illuminator
2) The screen change when adjusting the B
- When fasten the screw: Fall out the lower illuminator
- When loosen the screw: Fall out the upper illuminator
3) The screen change when adjusting the C
- When fasten the screw: Fall out the upper/left illuminator
- When loosen the screw: Fall out the lower/right
illuminator
Check the spot (phenomenon such as Light tunnel exit) on the
edge of the white screen as shown Fig 5.
(2) After adjustment the illuminator, adjust the focus using the
focus adjustment screw of projection lens. After fasten the
nut tightenly, inject the resilock. (Fig. 6)
1) The pattern when adjustment
2) Adjust the 4 gold ellipse to focus as same level.
3) If you can’t check the DMD cell bourder at red center position
after adjustment, regard as NG.
4) The magnified pattern for checking the focus adjustment
6. Caution for DMD(Digital Micro-mirror Device)
6-1. Caution for DMD ESD(1) You connect the grounding to prevent ESD (Electrostatic
Discharge) when handing the DMD.
(2) The worker have to wear wrist strap that connect to
ground.
<Fig 5>
<Fig 7.>
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 15/43
ADJUSTMENT INSTRUCTIONS
6-2. Caution(1) Keep the procedure and caution to prevent the screen
strange phenomenon. Don’t make a scratch.
(2) When DMD stains with dust, polish the front and back
DMD with soft wiper. Then, polish the front and back DMD
after rotating 180 degree the DMD. If necessary, take a
inspection.
(3) Don’t clean the DMD with the high pressure. Because the
electric static and pollution influence to DMD.
7. EDID Data Input
7-1. Required Test Equipment(1) A jig for adjusting PC, DDC.
(PC serial to D-sub. Connection equipment)
(2) S/W for writing DDC (EDID data write & read)
(3) D-sub terminal
7-2. Setting of Devices
7-3. Preparation for Adjustment(1) Set devices as above and turn the PC, jig on.
(2) Put the S/W for writing DDC (EDID data write & read) into
operation.
7-4. Sequence of Adjustment(1) Put the SET(or Digital Board) on the table and turn the
power on.
(2) Input the product code, production week / year, serialnumber (if it is not input, write “01”) to the S/W for writing
DDC.
(3) Put the EDID write instruction into operation.
C
8-2. Adjustment Sequence(1) After program running, displayed [OPTION MODE
SELECTION] window.
Check the “Load configuration File(.cdf, .pdr)” in this
window and click the finish button
(2) When the screen displays the open window, select the
suitable file(*.cdf) according to model.
(3) IC figure is change to green by clicking it. (Fig. 9)
PC
DLP PJTV SET(or Digital Board)
JIG
<Fig 8> How to connect the MEMORY JIG and PC
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 16/43
9. Component AD9883A Offset/GainAdjustment
9-1. Required Test EquipmentsRemote control for adjustment, 801GF or 802F
9-2. Preparation for Adjustment(1) Connect a power source with TV Set and turn TV set on.
(2) Do Heat-Run for 5 minutes and over before adjustment.
(3) Receive the Component 1 or 2.
(4) Receive the 720P/50Hz, HozTVBar Pattern of 801GF
/802F. (Fig. 11)
9-3. Offset/ Gain Adjustment(1) Press Adjust key on the remote control to enter the
adjustment mode after more than 10 seconds of receiving
the signals
(2) Select menu with using Volume- (F) key or Volume+ (G)
key on the Country. (USA/CA.)
11. Screen Position Adjustment
11-1. Required Test EquipmentsRemote control of adjustment
11-2. Horizontal Position Adjustment(1) Press ADJ key on the remote control to enter the
adjustment mode.
(2) Select the POSITION of the adjustment menu. (H: 200)
(3) Select the H_position of the Adjust Mode.
(4) Adjust data with using the left/right key on the remote
control in order to be left/right semmetry screen.
(5) After adjustment over, recieve PAL-B/G Digital and chedk
the adjusmen level.
11-3. Vertical Position Adjustment(1) Select V-position. (V: 15)
(2) Change the data to symmetrized upper and down ofscreen (refer to Fig12) and then press the Volume key on
Remote control to get out of adjustment mode.
Adjustment 31 Line
ADJUSTMENT INSTRUCTIONS
<Fig 10>
<Fig11> 720P/50Hz HozTVBar Pattern
<Fig 12> Pattern for screen adjustment
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 17/43
ADJUSTMENT INSTRUCTIONS
12. White Balance Adjustment(Day Light Mode) : R fixation
12-1. Required Test EquipmentsCA100 or CA210
12-2. White basse balue(Medium)x = 0.283¡ 0.01, y = 0.297¡ 0.01
12-3. Adjustment Sequence(1) Install the equipment(CA110 or CA210) be 20cm away
from screen center.(2) Select White balance by pressing ADJ Mode Key on
Remote control.(3) Warm(6500cK) : x = 0.313, y = 0.329
1) R Gain 120 fixation
2) Adjust white balance changing G, B gain.(Gain default: R-120, G-110, B-100)
3) Offset fixation R/G/B --> -29, -28, -24
(4) Medium(9300cK) : x = 0.283, y = 0.297
1) R Gain 110 fixation
2) Adjust white balance changing G, B gain.
(Gain default: All 110)
3) Offset fixation R/G/B --> -26, -25, -24
(5) Cool(12000c
K) : x = 0.275, y = 0.2771) R Gain 110 fixation
2) Adjust white balance changing G, B gain.
(Gain default: R-110, G-110, B-120)
3) Offset fixation R/G/B --> -25, -24, -24
* Reference : Gamma table -> 2
Brightness -> 200Level
Spoke Func. -> 0
R/G/B offset -> It has each color temperature
fixation price
13. CWI Adjustment
13-1. Required Test Equipments
(4) Check the RED Pattern to uniform. After checking unless
abnormality do OK.
(color wheel index)
CWI 160
<Fig 14> TEST Pattern(Lamp Gray Pattern)
(color wheel index)
CWI 162starting point of noise(appearance GREEN)
(color wheel index)
CWI 160
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 18/43
ADJUSTMENT INSTRUCTIONS
14. Main/Sub Contrast AdjustmentAdjust which it sees last prosecuting attorney time the screen
contrast difference.
Basically the letter does with the fact that the character and
distinction become.
14-1. Preparation for Adjustment(1) Receive signal(RF 06Ch.) on the Main/Sub screen in the
twin picture.
(2) Confirms picture probably is the normal.
14-2. Adjustment Sequence
(1) Main Screen Adjustment1) Select the VPX3226 by pressing “ADJ” key on the
remote control for adjustment.
2) Select the Contrast(m) of adjustment item using CH +/-
key and revises using VOL +/- key. (Initial data: 32)
(2) Sub Screen Adjustment1) Select the VPX3226 by pressing “ADJ” key on the
remote control for adjustment.
2) Select the Contrast(s) of adjustment item using CH +/-
key and revises using VOL +/- key. (Initial data: 32)
* When revising, the case above ¡ 2 being changed from
initial data requests Irrigation.
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 24/43
EXPLODED VIEW(44”)
3 1
0
3 0 8
3 0 9
3 1 1
6 6 0
1 2 1
4 1 0
4 3 0
4 3 1
4 3 2
4 3 3
4 3 4
4 0 0
6 8 0
6 8 1
4 0 1
4 1 1
4 0 3
6 7 0
4 0 2
6 4 0
6 4 1
6 0 2
6 2 2
6 2 3
1 7 4
5 0 2
5 3 0
5 9 0
6 0 1
6 0 0
5 7 0
5 7 2
5 7 1
6 1 2
6 2 0
6 1 0
6 1 1
6 2 1
7 2 0
6 3 0
4 2 0
4 0 4
7 0 0
5 2 0
5 0 3
5 4 0
5 0 1
5 5 0
5 6 0
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 25/43
EXPLODED VIEW PARTS LIST
120 6400WESC01A SPEAKER,WOOFER C080P23K1450 ESTEC WOOFER 8OHM 15/25W 84DB 80 NON
121 6400DESA01A SPEAKER,TWEETER D016D01K1450 ESTEC TWEETER(DOME) 8HMOHM 15/25W 85DB
174 6410VUH004A POWER CORD,UL/CSA3000MM 3P HUG BLACK VOLEX CSA 3000MM HUG BLACK 500MH 7A
300 3091V00582B CABINET ASSEMBLY,RU-44SZ61D MONO NB03JC FRONT TOTAL
301 5020V00870B BUTTON,CONTROL
302 4811V00070C BRACKET ASSEMBLY,SPEAKER RU-44SZ61D NB03JC GRILLE BLACK
303 3550V00348B COVER,NON DN-44SZ60H EGI PLATE
304 3550V00350A COVER,NON RN044SZ50H EGI PLATE C/A RIGHT
305 3351V00009A SCREEN ASSEMBLY,TOPPAN NON RN-44SZ50H 1000*570*3.15 LCD TYPE
308 4980V00822B SUPPORTER,SCREEN EGI RIGHT, DN-44SZ60D
309 4980V00820B SUPPORTER,SCREEN EGI BOTTOM, DN-44SZ60H
310 4980V00820A SUPPORTER,SCREEN EGI TOP,RN-44SZ50H
311 4980V00823B SUPPORTER,SCREEN EGI LEFT, DN-44SZ60D
400 3809V00356D BACK COVER ASSEMBLY,RU-44SZ51D NON UPPER
401 3550V00269C COVER,NON RU-44SZ61D ABS, AF-303S LAMP FAN
402 3550V00311C COVER,REAR RU-44SZ61D PC-ABS .
403 4810V00815B BRACKET,COVER DN-44SZ51H/60H NB03KB ABS, AF-303S LAMP SIDE DUCT
404 4980V00814B SUPPORTER,ENGINE EGI DN-44SZ60H
410 3809V00355D BACK COVER ASSEMBLY,RU-44SZ61D NON LOWER
411 3550V00310B COVER,NON RU-44SZ61D ABS, AF-303S BACK LOWER
420 3550V00356A COVER,MIDDLE RN-44SZ50H ABS DUST
430 5018V00066A MIRROR,NON SSC(SAMSUNG CORNING) Mirror : RN-44SZ50/60H BACK MIRROR
431 4810V00819B BRACKET,NON MIRROR LEFT,RN-52SZ50H NB03JA PC-ABS .
432 4980V00808B SUPPORTER,MIRROR AL DN-44SZ60D
433 4980V00809A SUPPORTER,MIRROR AL LOWER,RN-44SZ50H
434 4810V00818B BRACKET,NON MIRROR RIGHT,RN-52SZ50 NB03JA PC-ABS .
501 3210V00165B FRAME,ABS AF-303S RN-48SZ40H MAIN CHASSIS
502 3210V00191A FRAME,CHASSIS HIPS 40AF DN-44SZ60D SMPS
503 4810V00713K BRACKET,REAR AV RU-44SZ61D NB03JC ABS, AF-303S .
520 6871VMMR92A PCB ASSEMBLY,MAIN NB-03JC BOTTOM M/I ASSY FOR N.A.
530 6871VPMA55A PCB ASSEMBLY,POWER SMPS NB-03JC M/I ASSY FOR N.A.
540 6871VSMY73A PCB ASSEMBLY,SUB TUNER NB03JC M/I ASSY FOR N.A.
550 6871VSMY72A PCB ASSEMBLY,SUB DIGITAL NB03JC M/I ASSY FOR N.A.
560 6871VSMU24B PCB ASSEMBLY,SUB NB03KB COMP M/I
570 6871VSME80A PCB ASSEMBLY,SUB CRM MB03CB DRIVE M/I ASSY FOR 720P DLP
571 4814V00434A SHIELD ASSY,DN-52SZ60H NB03KB SUS ,SHIELD CASE DRIVE BOTTOM
572 4814V00394A SHIELD,COVER RN-52SZ50H NB03JA SECC(EGI) DRIVE FRONT DLP 720P
590 6871VSME87A PCB ASSEMBLY,SUB AC NB03JC LINE FILTER FOR N.A.
600 3141VSN918B CHASSIS ASSEMBLY,SUB NB03JC FOR N.A.
601 4980V00886B SUPPORTER,SMPS SECC(EGI) DLP
602 4980V00817A SUPPORTER,OPTICAL EGI ENGINE DLP,RN-44SZ50H
610 6912B22002C LAMP,HIGH PRESSURE MECURY P-VIP 120/1.3 E23H OSRAM 120V 0.4A 120W 15KV
611 4814V00396A SHIELD,COVER RN-52SZ50H NB03JA SECC(EGI) COVER,LAMP.DLP720P-ENGINE
No. Part No. Description
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 26/43
EXPLODED VIEW(52”)
3
1 0
3 0 8
3 0 9
6 6 0
1 2 1
4 1 0
4 3 0
4 3 1
4 3 2
4 3 3
4 3 4
4 0 0
6 8 0
6 8 1
4 0 1
4 0 3
6 7 0
4 0 2
4 0 4
7 0 0
6 3 0
4 2 0
6 4 0
6 4 1
6 0 2
6 2 2
6 2 3
1 7 4
5 0 2
5 3 0
5 9 0
6 0 1
6 0 0
5 7 0
5 7 2
5 7 1
6 1 2
6 2 0
6 1 0
6 1 1
6 2 1
7 2 0
4 1 1
5 2 0
5 0 3
5 4 0
5 0 1
5 5 0
5
6 0
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 27/43
EXPLODED VIEW PARTS LIST
120 6400WESC01A SPEAKER,WOOFER C080P23K1450 ESTEC WOOFER 8OHM 15/25W 84DB 80 NON
121 6400DESA01A SPEAKER,TWEETER D016D01K1450 ESTEC TWEETER(DOME) 8HMOHM 15/25W 85DB
174 6410VUH004A POWER CORD,UL/CSA3000MM 3P HUG BLACK VOLEX CSA 3000MM HUG BLACK 500MH 7A
300 3091V00552D CABINET ASSEMBLY,RU-52SZ61D NON NB03JC FULL
301 5020V00870B BUTTON,CONTROL DN-52SZ60D ABS, HF-380 7KEY .
302 4811V00049C BRACKET ASSEMBLY,SPEAKER DU-52SZ61D NB04AA GRILLE,LG BRAND
304 3550V00382A COVER,FRONT ,DN-52SZ60H SECC(EGI) ,MIDDLE
305 3351V00007A SCREEN ASSEMBLY,SHIINSUNG NON RN-52SZ30H 1178*670*3.6 LCD TYPE
306 3550V00387A COVER,FRONT DN-52SZ60H SPCC(CR) ,C/A RIGHT
308 4980V00890B SUPPORTER,SCREEN SECC(EGI) SIDE(CUSHION),RN-52SZ50H
309 4980V00889B SUPPORTER,SCREEN EGI BOTTOM(CUSHION),RN-52SZ50H
310 4980V00888B SUPPORTER,SCREEN SECC(EGI) TOP
400 3809V00361F BACK COVER ASSEMBLY,RU-52SZ61D NON ZENITH
401 3550V00269D COVER,LAMP RU-44SZ51D PC-ABS FAN 7S00115A
402 3550V00322D COVER,LAMP RU-52SZ51D HIPS 40AF SIDE
403 3110V00307B CASE,NON LAMP DUCT DLP 52SZ60H PC-ABS .
404 4980V00885B SUPPORTER,BACK COVER SECC(EGI) RN-52SZ50H410 3809V00362F BACK COVER ASSEMBLY,RU-52SZ51D NON ZENITH
411 3550V00321C COVER,LAMP RU-52SZ51D HIPS 40AF ZENITH
420 3550V00365C COVER ASSY,RU-52SZ51D ABS, AF-303S DUST
430 5018V00067D MIRROR,REFLECTION SSC(SAMSUNG CORNING) 0000 1172(H1)*590(H2)*604(V1)*3T .
431 4810V00819B BRACKET,NON MIRROR LEFT,RN-52SZ50H NB03JA PC-ABS .
432 4980V00883A SUPPORTER,MIRROR AL TOP,52SZ50H
433 4980V00884A SUPPORTER,MIRROR AL BOTTOM 52SZ50H
434 4810V00818B BRACKET,NON MIRROR RIGHT,RN-52SZ50 NB03JA PC-ABS .
501 3210V00165A FRAME,HIPS 40AF RN-48SZ40 SMPS CHASSIS
502 3210V00191A FRAME,CHASSIS HIPS 40AF DN-44SZ60D SMPS503 4811V00055C BRACKET ASSEMBLY,REAR AV RU-52SZ51D NB03JC ZENITH
520 6871VMMR92A PCB ASSEMBLY,MAIN NB-03JC BOTTOM M/I ASSY FOR N.A.
530 6871VPMA55A PCB ASSEMBLY,POWER SMPS NB-03JC M/I ASSY FOR N.A.
540 6871VSMY73A PCB ASSEMBLY,SUB TUNER NB03JC M/I ASSY FOR N.A.
550 6871VSMY72A PCB ASSEMBLY,SUB DIGITAL NB03JC M/I ASSY FOR N.A.
560 6871VSMU24B PCB ASSEMBLY,SUB NB03KB COMP M/I
570 6871VSME80A PCB ASSEMBLY,SUB CRM MB03CB DRIVE M/I ASSY FOR 720P DLP
571 4814V00434A SHIELD ASSY,DN-52SZ60H NB03KB SUS ,SHIELD CASE DRIVE BOTTOM
572 4814V00394A SHIELD,COVER RN-52SZ50H NB03JA SECC(EGI) DRIVE FRONT DLP 720P
590 6871VSME87A PCB ASSEMBLY,SUB AC NB03JC LINE FILTER FOR N.A.
600 3141VSN918A CHASSIS ASSEMBLY,SUB NB03JC OPTICS ENGINE ASSY FOR N.A.
601 4980V00886B SUPPORTER,SMPS SECC(EGI) DLP
602 4980V00817A SUPPORTER,OPTICAL EGI ENGINE DLP,RN-44SZ50H
610 6912B22002C LAMP,HIGH PRESSURE MECURY P-VIP 120/1.3 E23H 120V 0.4A 120W DN52SZ51H 15KV
611 4814V00396A SHIELD,COVER RN-52SZ50H NB03JA SECC(EGI) COVER,LAMP.DLP720P-ENGINE
612 4930V00301A HOLDER,PC+GF30% LAMP
No. Part No. Description
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 28/43
REPLACEMENT PARTS LIST
LOCA. NO PART NO DESCRIPTION
IC602
IC603
IC700
IC701
IC702
IC705
IC800
IC800
IC801
IC802
IC802
IC803
IC804IC804
IC805
IC806
IC806
IC807
IC807
IC808
IC808
IC810
IC811
IC820
IC831
IC832
IC841
IC845
IC900
IC901
IC906
IC907
IC908
IC909
IC910
0IFA754207A
0ISS455880A
0IMCRTI011A
0IMMRAL015A
0IMCRFA003A
0IMCRAL006A
0IMMRSS053A
0IPH741400E
0IMCRTI014A
0IMCRSG007A
0IKE702700D
0IMCRSG008A
0IMCRSG008A0ITI740000Q
0IMCRMX001A
0IMCRSG008A
0IIC271600A
0IMCRMX001A
0IMCRSG010A
0IMCRSG008A
0IMP242560A
0IMCRSJ001A
0IMCRON002A
0IMCRSK002A
0ISK615311B
0ISH817300B
0ISH817300B
0ISS781200H
0IMCRTI012A
0IMCRTI013A
0IMCRSG007A
0IMCRSG008A
0IMCRSG008A
0IMCRSG008B
0IMCRSG007A
KA75420ZTA 3P,TO92 TP 4.2V
KA4558D 8SOP OP AMP
2503227001(DDP1010) 529P
AT49LV8192A90TC 48P 8MBIT
KA2903 8SOP R/TP AMPLIFIER
AT24C16AN10SI2.7 8P SOIC R/TP EEPROM
K4R271669ETCS8 54P 128MBIT
74HC14D 14SOP TP SHITTER TRIGGER
CDCR83 24P DIRECT RANBUS CLOCK
74VIT125CTR 5P S0T3235L
KIA7027AF 3, SOT89 TP RESET IC 2.7V
74LX1G14CTR 5P SOT3235L
74LX1G14CTR 5P SOT3235LSN74LVC00AD 14SOP R/TP LOGIC DTV
MAX708SCSA 8P SOP R/TP RESET
74LX1G14CTR 5P SOT3235L
MK2716STR 8P
MAX708SCSA 8P SOP R/TP RESET
ST3232CDR SOP16 R/TP RS232
74LX1G14CTR 5P SOT3235L
24LC256I/SM 8P
SC1565IST1.8 3P SOT223
MC33262P ON SEMI 8P
STRF6467 5P T0220(LB)
STRG6153T(LF1101) 5PIN BK STR
PC817XF3 4D PHOTO COUPLER
PC817XF3 4D PHOTO COUPLER
KA78R12 4P,TO220F BK LOW DROP 12V
2503252002(DAD1000) 80P
SNSH6742CFA0PA(P32J6742PAG) 64P
74VIT125CTR 5P S0T3235L
74LX1G14CTR 5P SOT3235L
74LX1G14CTR 5P SOT3235L
74LX1G07CTR 5P SOT3235L
74VIT125CTR 5P S0T3235L
LOCA. NO PART NO DESCRIPTION
IC1
IC1
IC1
IC100
IC1000
IC1001
IC1002
IC1004
IC1008
IC101
IC101
IC102
IC1200
IC1202
IC1602
IC2
IC200
IC208
IC301
IC303IC304
IC305
IC4
IC400
IC401
IC402
IC403
IC404
IC405
IC406
IC407
IC409
IC409
IC410
0IMCRSH003A
0IPRPTO002A
0IZZVC0051J
0IMCRS5003A
0IMI623200B
0IPRPFA006A
0IPRPFA007A
0IMMRNE002A
0IMI623200B
0IPH827150A
0ITK118100B
0IMMRAL014B
0IMCRSO008A
0IMO744053B
0ISH052100C
0IFA754207A
0IMCRAD002A
0ISO206900A
0ICTMLG003C
0ITI740000Q0IMMRHY033A
0IMMRHY033A
0IMCRAL006A
0ICTMMI038B
0IMCRTI019A
0ISH122100B
0ISH302122A
0ISH052100C
0ISH323422A
0ISH323422A
0ISJ156612A
0IKE780500P
0IKE781200P
0ISH052100C
GP2S40 SHARP 4P
TC7S14F(T5L,T) 5P SCHMITT INVERTER
M37272E8A(OTP) DIP 42P BK MICOM
SIL169 CL100 100P
M62320FP 16P SOP TP I/O EXPANDER
RC1117S33T SOT223 R/TP 3.3VOLT
RC1117S25T SOT223 R/TP 2.5VOLT
UPD64083GF3BA 100 QFP ST 3D YC
M62320FP,I/O EXPANDER 16P
P82B715T 8SOP R/TP IIC EXTENDER
TK11840L 8P SOT23L DCDC CONVERTER
AT24C02N10SI2.7 8P SOIC R/TP 2K(256X8)
CXA2151Q SONY 48P 60LCD
MC74HC4053DW 16SOP 3*2CH.MUX
PQ05RD21 4SIP ST REGULATOR
KA75420ZTA 3P,TO92 TP 4.2V
AD9883AKST110 80P DIGITAL BOARD
CXA2069Q QFP64 BK I2C BUS AV S/W
LGDT1502M 304P READY2 AMKOR
SN74LVC00AD 14SOP R/TP LOGIC DTVHY57V643220C(L)T6 86P 64M
HY57V643220C(L)T6 86P 64M
AT24C16AN10SI2.7 8P SOIC R/TP EEPROM
COPY M306V3FGFP 100P 16BIT
TFP410 64P TRANSMITTER PANEL BUS 165MHZ
PQ12RD21 4SIP ST REGULATOR
PQ30RV21 TO220
PQ05RD21 4SIP ST REGULATOR
PQ3RF23 4P(TO220) 3.3V
PQ3RF23 4P(TO220) 3.3V
SC15661T2.5TR 3P TO2203L
KIA78L05BP(AT) 3P 5V,150MA
KIA7812API TO220 ST 3P 12V
PQ05RD21 4SIP ST REGULATOR
IC
RUN DATE : 2004.1.19
For Capacitor & Resistors, thecharactors at 2nd and 3rd digitin the P/No. means as follows;
CC, CX, CK, CN : CeramicCQ : PolyestorCE : Electrolytic
RD : Carbon FilmRS : Metal Oxide FilmRN : Metal FilmRF : Fusible
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 29/43
LOCA. NO PART NO DESCRIPTION
Q1004
Q1004
Q1005
Q1005
Q1006
Q1007
Q1008Q1009
Q101
Q1010
Q1011
Q1012
Q1013
Q1014
Q1015
Q1016
Q1017
Q102
Q103
Q107
Q109
Q1200
Q1201
Q1202
Q1203
Q1204
Q1205
Q1206
Q1207
Q1208
Q1209
Q1210
Q1213
Q1214
Q1215
Q1216
Q1217
Q1218
Q1219
0TR387500AA
0TR150400BA
0TR387500AA
0TR150400BA
0TR387500AA
0TR150400BA
0TR150400BA0TR387500AA
0TR830009BA
0TR150400BA
0TR150400BA
0TR150400BA
0TR150400BA
0TR387500AA
0TR150400BA
0TR387500AA
0TR150400BA
0TRKE80038A
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR150400BA
0TR102009AG
0TR387500AA
0TR387500AA
0TR150400BA
0TR150400BA
0TR387500AA
0TR387500AA
0TR387500AA
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SA1504S(ASY) KECCHIP 2SC3875S(ALY) KEC
BSS83
CHIP 2SA1504S(ASY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
KTC3552TRTK SOT23F 50V 3A
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP KRC102S KEC TP SOT23
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SA1504S(ASY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
LOCA. NO PART NO DESCRIPTION
Q500
Q501
Q501
Q502
Q502
Q504
Q601Q601
Q602
Q602
Q603
Q605
Q605
Q614
Q615
Q616
Q617
Q618
Q801
Q802
Q810
Q841
Q842
Q851
D1
D100
D101
D2
D3
D300
D403
D404
D431
D432
D433
D434
D435
0TR150400BA
0TR830009BA
0TR830009BA
0TR830009BA
0TR830009BA
0TR102009AG
0TR387500AA0TR387500AA
0TR387500AA
0TR387500AA
0TR322709AA
0TR387500AA
0TR150400BA
0TR102008AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TR387500AA
0TF283700AA
0TR945009AA
0TR322709AA
0TR945009AA
0DD184009AA
0DD184009AA
0DD184009AA
0DD184009AA
0DD226239AA
0DL233309AC
0DS113379BA
0DD184009AA
0DS113379BA
0DS113379BA
0DS113379BA
0DS113379BA
0DS113379BA
CHIP 2SA1504S(ASY) KEC
BSS83
BSS83
BSS83
BSS83
CHIP KRC102S KEC TP SOT23
CHIP 2SC3875S(ALY) KECCHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
KTC3227Y,TP(KTC1627A),KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SA1504S(ASY) KEC
KRA102S R/TP KEC SOT23 CHIP TR
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
CHIP 2SC3875S(ALY) KEC
2SK2837 500V 20A TO3P
KSC945CY TO92 50V 150MA
KTC3227Y,TP(KTC1627A),KEC
KSC945CY TO92 50V 150MA
KDS184S CHIP 85V 300MA KEC TP
KDS184S CHIP 85V 300MA KEC TP
KDS184S CHIP 85V 300MA KEC TP
KDS184S CHIP 85V 300MA KEC TP
CHIP KDS226 SOT23
LED,SAM2333
1SS133 T72 DO34 90V
KDS184S CHIP 85V 300MA KEC TP
1SS133 T72 DO34 90V
1SS133 T72 DO34 90V
1SS133 T72 DO34 90V
1SS133 T72 DO34 90V
1SS133 T72 DO34 90V
REPLACEMENT PARTS LIST
DIODE
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 30/43
LOCA. NO PART NO DESCRIPTION
D801
D802
D803
D804
D805
D806
D810D820
D821
D822
D832
D833
D834
D841
D845
D881
D881
D881
D891
D901
D902
D903
D904
D905
D906
D907
D908
D909
Q810
ZD01
ZD1
ZD10
ZD2
ZD201
ZD202
ZD203
ZD204
ZD3
ZD4
0DR050008AA
0DR050008AA
0DR050008AA
0DR050008AA
0DRSE00038A
0DRSE00038A
0DD100009AM0DD100009AM
0DD100009AM
0DD100009AM
0DR010009AA
0DD100009AM
0DD260000BB
0DD100009AP
0DD414809ED
0DRSA00170A
0DD120000BB
0DD420000BB
0DD220000AC
0DRON00088A
0DRON00088A
0DRON00088A
0DRON00088A
0DRON00088A
0DSON00028A
0DRON00098A
0DZGS00108A
0DRGS00328A
0DR260001AA
0DR050008AA
0DZ620009BB
0DZ620009BB
0DZ620009BB
0DZ560009CF
0DZ560009CF
0DZ560009CF
0DZ560009CF
0DZ620009BB
0DZ620009BB
SD05.TC SOD323 5V 5A 15A
SD05.TC SOD323 5V 5A 15A
SD05.TC SOD323 5V 5A 15A
SD05.TC SOD323 5V 5A 15A
SDC15 TVS SOT23 12.8V
SDC15 TVS SOT23 12.8V
EU1ZV(1) TP SANKENEU1ZV(1) TP SANKEN
EU1ZV(1) TP SANKEN
EU1ZV(1) TP SANKEN
EG01C 1000V 0.5A 10A 100NSEC 50UA
EU1ZV(1) TP SANKEN
BRIDGE D2SBA60(STK) SHINDENKEN
EG1ZV(1) TP SANKEN TP SANKEN
1N4148 TP GRANDE
FMLG14S TO220 400V 5A 70A
FMLG12S
D4L20U SHINDENGEN
FMLG22S TO220 200V 10A 150A
BAT54SWT1 60V 3A 4A .SEC .A
BAT54SWT1 60V 3A 4A .SEC .A
BAT54SWT1 60V 3A 4A .SEC .A
BAT54SWT1 60V 3A 4A .SEC .A
BAT54SWT1 60V 3A 4A .SEC .A
BAV99RWT1 70V 215MA 500MA .SEC .A
MBRD320RL 30V 150MA 200MA .SEC .A
ZENERS,SMZJ3793B
SS26 GENERAL DO214AC 60V
FMG26S TO220 600V 6A 50A
SD05.TC SOD323 5V 5A 15A
ZENERS,MTZJ6.2B
ZENERS,MTZJ6.2B
ZENERS,MTZJ6.2B
ZENERS,MTZJ5.6B
ZENERS,MTZJ5.6B
ZENERS,MTZJ5.6B
ZENERS,MTZJ5.6B
ZENERS,MTZJ6.2B
ZENERS MTZJ6 2B
LOCA. NO PART NO DESCRIPTION
C1
C100
C101
C1011
C1013
C1019
C1020C1023
C103
C1035
C1036
C1039
C1042
C1049
C105
C1055
C106
C1060
C108
C11
C110
C111
C112
C112
C117
C1201
C1202
C1204
C1205
C1206
C1207
C1208
C1209
C1216
C1217
C1218
C1234
C1237
C124
0CH3104K566
0CE226SF6DC
0CE106VF6DC
0CE476VF6DC
0CE476VF6DC
0CE105VK6DC
0CE476VF6DC0CE476VF6DC
0CE475VK6DC
0CE106VF6DC
0CE106VF6DC
0CE476VF6DC
0CE106VF6DC
0CE106VF6DC
0CE476SF6DC
0CE106VF6DC
0CE476VK6DC
0CE476SF6DC
0CE106VF6DC
0CE226VF6DC
0CE476VK6DC
0CE476VF6DC
0CE475VK6DC
0CE106SF6DC
0CQ2231N509
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE106VF6DC
0CE476VF6DC
0CE105VK6DC
0CQ2231N509
0.1UF 50V 10%
22UF MVG 16V M
10UF MV 16V 20%
47UF MV 16V 20%
47UF MV 16V 20%
1UF MV 50V 20%
47UF MV 16V 20%47UF MV 16V 20%
4.7UF MV 50V 20%
10UF MV 16V 20%
10UF MV 16V 20%
47UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
47UF MVG 16V M
10UF MV 16V 20%
47UF MV 50V 20%
47UF MVG 16V M
10UF MV 16V 20%
22UF MV 16V 20%
47UF MV 50V 20%
47UF MV 16V 20%
4.7UF MV 50V 20%
10UF MVG 16V 20%
0.022UF D 100V 10%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
10UF MV 16V 20%
47UF MV 16V 20%
1UF MV 50V 20%
0 022UF D 100V 10%
REPLACEMENT PARTS LIST
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 31/43
LOCA. NO PART NO DESCRIPTION
C146
C149
C15
C152
C16
C1620
C1621C2
C2
C20
C200
C202
C202
C203
C204
C205
C205
C206
C208
C209
C210
C212
C215
C216
C217
C218
C222
C223
C227
C228
C231
C236
C245
C246
C247
C247
C248
C250
C252
0CE106SF6DC
0CE106SF6DC
0CE105VK6DC
0CE106SF6DC
0CE476VF6DC
0CE107VF6DC
0CE107VF6DC0CN1030F679
0CH3104K566
0CE105VK6DC
0CE226SF6DC
0CK105DF64A
0CE106SF6DC
0CK105DF64A
0CE105VK6DC
0CE105VK6DC
0CE106SF6DC
0CE106SF6DC
0CK105DF64A
0CE105VK6DC
0CK105DF64A
0CE105VK6DC
0CK105DF64A
0CE105VK6DC
0CK105DF64A
0CE105VK6DC
0CE105VK6DC
0CE105VK6DC
0CE226VF6DC
0CK823DK56A
0CE107SF6DC
0CK105DF64A
0CE106SF6DC
0CE226SF6DC
0CE227VF6DC
0CE106SF6DC
0CE226SF6DC
0CE106SF6DC
0CE226SF6DC
10UF MVG 16V 20%
10UF MVG 16V 20%
1UF MV 50V 20%
10UF MVG 16V 20%
47UF MV 16V 20%
100UF MV 16V 20%
100UF MV 16V 20%10000P 16V M Y
0.1UF 50V 10%
1UF MV 50V 20%
22UF MVG 16V M
1UF 2012 16V 20%
10UF MVG 16V 20%
1UF 2012 16V 20%
1UF MV 50V 20%
1UF MV 50V 20%
10UF MVG 16V 20%
10UF MVG 16V 20%
1UF 2012 16V 20%
1UF MV 50V 20%
1UF 2012 16V 20%
1UF MV 50V 20%
1UF 2012 16V 20%
1UF MV 50V 20%
1UF 2012 16V 20%
1UF MV 50V 20%
1UF MV 50V 20%
1UF MV 50V 20%
22UF MV 16V 20%
82000PF 2012 50V 10%
100UF MVG 16V M
1UF 2012 16V 20%
10UF MVG 16V 20%
22UF MVG 16V M
220UF MV 16V 20%
10UF MVG 16V 20%
22UF MVG 16V M
10UF MVG 16V 20%
22UF MVG 16V M
LOCA. NO PART NO DESCRIPTION
C410
C411
C412
C425
C426
C427
C428C431
C432
C433
C434
C435
C437
C438
C451
C453
C454
C456
C456
C462
C480
C482
C50
C500
C501
C503
C505
C514
C515
C516
C517
C518
C519
C519
C520
C521
C522
C522
C523
0CE107SF6DC
0CE107SF6DC
0CE476VF6DC
0CE227DD618
0CE227DD618
0CE227DD618
0CE227DD6180CE107DH618
0CE107DD618
0CE107DD618
0CE227DD618
0CE227DD618
0CE227DD618
0CE107DH618
0CE107DD618
0CE107DD618
0CE336SC6DC
0CE107VH6DC
0CK105DF64A
0CE227DF618
0CE227DH618
0CE107DF618
0CE227SC6DC
0CE106SF6DC
0CE226SF6DC
0CE106SF6DC
0CE226SF6DC
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CE106SF6DC
0CK104CF56A
0CE226SF6DC
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CE106SF6DC
0CK104CF56A
100UF MVG 16V M
100UF MVG 16V M
47UF MV 16V 20%
220UF STD 10V M
220UF STD 10V M
220UF STD 10V M
220UF STD 10V M100UF STD 25V M
100UF STD 10V M
100UF STD 10V M
220UF STD 10V M
220UF STD 10V M
220UF STD 10V M
100UF STD 25V M
100UF STD 10V M
100UF STD 10V M
33UF MVG 6.3V M
100UF MV 25V 20%
1UF 2012 16V 20%
220UF STD 16V M
220UF STD 25V M
100UF STD 16V M
220UF MVG 6.3V M
10UF MVG 16V 20%
22UF MVG 16V M
10UF MVG 16V 20%
22UF MVG 16V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
10UF MVG 16V 20%
0.1UF 1608 16V 10%
22UF MVG 16V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
10UF MVG 16V 20%
0 1UF 1608 16V 10%
REPLACEMENT PARTS LIST
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 32/43
LOCA. NO PART NO DESCRIPTION
C601
C602
C603
C604
C606
C609
C610C611
C611
C612
C612
C614
C615
C616
C616
C616
C617
C617
C618
C619
C619
C620
C621
C621
C622
C622
C623
C623
C624
C624
C625
C626
C627
C627
C628
C628
C628
C629
C629
0CQ1831N509
0CQ1831N509
0CE106DK618
0CE106DK618
0CE107SF6DC
0CK104CF56A
0CK104CF56A0CK104CF56A
0CE226DK618
0CK104CF56A
0CE226DK618
0CK104CF56A
0CK104CF56A
0CE107SF6DC
0CK104CF56A
0CE475DK618
0CK104CF56A
181-442Z
0CK104CF56A
0CE335VK6DC
0CK104CF56A
0CK104CF56A
0CE106VF6DC
0CK104CF56A
0CE106VF6DC
0CK104CF56A
0CK104CF56A
0CE108DF618
0CK104CF56A
0CE106DF618
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CE228DK650
0CE106VF6DC
0CK104CF56A
181-442Z
0CK104CF56A
0CE475DK618
0.018UF D 100V 10%
0.018UF D 100V 10%
10UF STD 50V M
10UF STD 50V M
100UF MVG 16V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%0.1UF 1608 16V 10%
22UF STD 50V M
0.1UF 1608 16V 10%
22UF STD 50V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
100UF MVG 16V M
0.1UF 1608 16V 10%
4.7UF STD 50V 20%
0.1UF 1608 16V 10%
PE,ECQB1H104KF3(TR)
0.1UF 1608 16V 10%
3.3UF MV 50V 20%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
10UF MV 16V 20%
0.1UF 1608 16V 10%
10UF MV 16V 20%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
1000UF STD 16V M
0.1UF 1608 16V 10%
10UF STD 16V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
2200UF STD 50V M
10UF MV 16V 20%
0.1UF 1608 16V 10%
PE,ECQB1H104KF3(TR)
0.1UF 1608 16V 10%
4 7UF STD 50V 20%
LOCA. NO PART NO DESCRIPTION
C638
C639
C640
C641
C642
C643
C643C643
C644
C644
C645
C645
C646
C646
C647
C647
C648
C648
C649
C650
C651
C652
C653
C654
C655
C664
C668
C669
C700
C701
C702
C704
C706
C707
C710
C711
C712
C713
C714
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CE476VF6DC
0CK104CF56A0CE226DK618
0CK104CF56A
181-442Z
0CK104CF56A
181-442Z
0CK104CF56A
0CE108DK61A
0CK104CF56A
0CE108DK61A
0CE335VK6DC
0CK104CF56A
0CK104CF56A
0CC270CK41A
0CC270CK41A
0CC270CK41A
0CC270CK41A
0CK104CF56A
0CK104CF56A
0CE335VK6DC
0CE105VK6DC
0CE105VK6DC
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
47UF MV 16V 20%
0.1UF 1608 16V 10%22UF STD 50V M
0.1UF 1608 16V 10%
PE,ECQB1H104KF3(TR)
0.1UF 1608 16V 10%
PE,ECQB1H104KF3(TR)
0.1UF 1608 16V 10%
1000UF STD 50V M
0.1UF 1608 16V 10%
1000UF STD 50V M
3.3UF MV 50V 20%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
27PF 1608 50V 5%
27PF 1608 50V 5%
27PF 1608 50V 5%
27PF 1608 50V 5%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
3.3UF MV 50V 20%
1UF MV 50V 20%
1UF MV 50V 20%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0 1UF 1608 16V 10%
REPLACEMENT PARTS LIST
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 33/43
LOCA. NO PART NO DESCRIPTION
C729
C730
C731
C732
C733
C734
C735
C736
C737
C738
C739
C740
C741
C742
C743
C744
C745
C746
C747
C748
C749
C750
C751
C752
C753
C754
C755
C756
C757
C758
C759
C760
C761
C762
C763
C764
C765
C766
C767
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0 1UF 1608 16V 10%
LOCA. NO PART NO DESCRIPTION
C780
C781
C782
C783
C800
C800
C801
C801
C801
C802
C802
C803
C804
C804
C805
C805
C806
C806
C806
C807
C807
C807
C808
C808
C809
C809
C810
C811
C812
C813
C814
C814
C814
C815
C816
C817
C818
C818
C818
0CK104CF56A
0CC270CK41A
0CC270CK41A
0CK104CF56A
0CK104CF56A
0CE106SF6DC
0CQZVBK002B
0CK104CF56A
0CK105DF64A
0CQZVBK002C
0CK104CF56A
0CK104CF56A
0CF1050W470
0CE106SF6DC
0CK10202510
0CK104CF56A
0CK10202510
0CK104CF56A
0CE226SF6DC
0CK104CF56A
0CK1020K515
0CE336SC6DC
0CQ1021N519
0CC680CK41A
0CC680CK41A
181-007J
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CC680CK41A
0CC680CK41A
0CE107BK618
0CE106SF6DC
0CK104CF56A
0CC100CK11A
0CK104CF56A
0CK104CF56A
181-091R
0CE226SF6DC
0.1UF 1608 16V 10%
27PF 1608 50V 5%
27PF 1608 50V 5%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
10UF MVG 16V 20%
A.C 275V 0.15UF K (S=22.5)
0.1UF 1608 16V 10%
1UF 2012 16V 20%
A.C 275V 0.22UF K (S=22.5)
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
1UF 0 500V 5%
10UF MVG 16V 20%
1000P 2KV K B S
0.1UF 1608 16V 10%
1000P 2KV K B S
0.1UF 1608 16V 10%
22UF MVG 16V M
0.1UF 1608 16V 10%
1000P 50V K
33UF MVG 6.3V M
0.001U 100V K
68PF 1608 50V 5%
68PF 1608 50V 5%
MPE ECQV1H564JL3(TR), 50V 0.56UF J
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
68PF 1608 50V 5%
68PF 1608 50V 5%
100UF KME 50V M
10UF MVG 16V 20%
0.1UF 1608 16V 10%
10PF 1608 50V 0.5 PF
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
R 1000PF 1KV 10%,10%
22UF MVG 16V M
REPLACEMENT PARTS LIST
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 34/43
LOCA. NO PART NO DESCRIPTION
C825
C826
C828
C829
C831
C832
C832
C833
C833
C834
C835
C835
C836
C836
C837
C837C838
C839
C840
C841
C841
C842
C843
C843
C844
C845
C845
C846
C847
C853
C855
C856
C858
C859
C862
C865
C873
C876
C881
0CE107BK618
0CK104CF56A
0CC471CK41A
181-120L
181-035N
0CK104CF56A
0CQ1021N509
0CK104CF56A
0CE107BH618
0CK104CF56A
181-010K
0CK104CF56A
0CE476EU61A
0CK104CF56A
0CK104CF56A
0CK1040K9450CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CE108BF618
0CK104CF56A
0CK104CF56A
0CK1040K945
0CK104CF56A
0CK104CF56A
0CE107BF618
0CK104CF56A
0CK104CF56A
0CE108BF618
0CE228BF618
0CK1040K945
0CE477DF618
181-091Q
0CE228BF618
181-091Q
0CE108BK61A
0CE227DK618
0CE227BH618
100UF KME 50V M
0.1UF 1608 16V 10%
470PF 1608 50V 5%
3300PF 4KV M E
DE1010B471KACT4KKD 470 PF 250V 10%
0.1UF 1608 16V 10%
0.001UF D 100V 10%
0.1UF 1608 16V 10%
100UF KME 25V M
0.1UF 1608 16V 10%
PP 0.01UF 630V 5%
0.1UF 1608 16V 10%
47UF KMG 400V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 50V Z F TR0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
1000UF KME 16V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 50V Z F TR
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
100UF KME 16V M
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
1000UF KME 16V M
2200UF KME 16V M
0.1UF 50V Z F TR
470UF STD 16V 20%
R 470PF 1KV 10%,10%
2200UF KME 16V M
R 470PF 1KV 10%,10%
1000UF KME 50V M
220UF STD 50V M
220UF KME 25V M
LOCA. NO PART NO DESCRIPTION
C909
C910
C911
C912
C913
C919
C920
C921
C922
C924
C926
C927
C929
C930
C931
C932C933
C934
C936
C937
C938
C939
C940
C941
C942
C943
C944
C945
C946
C947
C949
C950
JA1201
JA1202
JA201
JA202
JA204
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CS226GJ6DC
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CC471CK41A
0CK271CK46A
0CK272CK46A0CK104CF56A
0CK104CF56A
0CC101CK41A
0CK121CK46A
0CK103CK56A
0CK104CF56A
0CK103CK56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
0CK104CF56A
6613V00013G
6612VJH006C
6613V00010B
6613V00013B
380 404A
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
22UF 7343 35V 20%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
470PF 1608 50V 5%
270PF 1608 50V 5%
2700PF 1608 50V 5%0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
100PF 1608 50V 5%
120PF 1608 50V 5%
0.01UF 1608 50V 10%
0.1UF 1608 16V 10%
0.01UF 1608 50V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
0.1UF 1608 16V 10%
JACK ASSEMBLY,PMJ021G 9P
JACK,RCA PJ6061E 6P
JACK ASSY,PMJ016B 3P
JACK ASSY,PMJ021B 9P
JACK DIN PHSJ9504 HOSIDEN
REPLACEMENT PARTS LIST
JACK
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 35/43
LOCA. NO PART NO DESCRIPTION
L861
L871
L891
L903
L904
T801
T810
T830
JA1200
P100
P101A
P102A
P103A
P201AP202A
P800
AR106
AR301
AR302
AR303
AR304
AR305
AR306
R1
R1253
R2
R3
R4
R5
R556
R557
R558
R559
R56
R560
150-C02F
150-C02F
150-C02F
6140VR0007A
6140VR0007A
6170VMCA03F
6170VMCA37B
6170VS0001B
6630VGA001B
6630GZ00724
6932V25004A
6932V25004A
6932V25004A
6932V25004A6932V25004A
6630VGA004A
0RRZVTA001A
0RRZVTA001D
0RRZVTA001D
0RRZVTA001D
0RRZVTA001D
0RRZVTA001D
0RRZVTA001D
0RD0752F609
0RN1002F409
0RD4703F609
0RD4703F609
0RD0752F609
0RD0752F609
0RRZVTA001D
0RRZVTA001D
0RRZVTA001D
0RRZVTA001D
0RD0472F609
0RRZVTA001D
COIL,CHOKE 82UH
COIL,CHOKE 82UH
COIL,CHOKE 82UH
COIL,DT1608C223 COILCRAFT 22UF+20%
COIL,DT1608C223 COILCRAFT 22UF+20%
TRANSFORMER,SMPS[COIL] EER4942 1200UH
TRANSFORMER,SMPS[COIL] PQ3535 310UH
TRANSFORMER,STANDBY EE1927 2200UH
CONNECTOR,DSUB 15PIN 2.29MM
CONNECTOR,DSUB 24P 1.91MM
CONNECTOR,HOUSING 365120098
CONNECTOR,HOUSING 365120098
CONNECTOR,HOUSING 365120098
CONNECTOR,HOUSING 365120098CONNECTOR,HOUSING 365120098
CONNECTOR,DSUB 9PIN 2.77MM
MNR14E0AJ101 R OHM 100 OHM 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
75 OHM 1/6 W 5.00%
10K OHM 1/6 W 1.00%
470K OHM 1/6 W 5.00%
470K OHM 1/6 W 5.00%
75 OHM 1/6 W 5.00%
75 OHM 1/6 W 5.00%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
22 OHM 1 / 16 W 1608 5%
47 OHM 1/6 W 5%
22 OHM 1 / 16 W 1608 5%
LOCA. NO PART NO DESCRIPTION
R808
R809
R810
R811
R812
R813
R814
R815
R816
R817
R818
R819
R820
R821
R822
R823R824
R825
R826
R827
R828
R829
R830
R831
R832
R833
R834
R835
R840
R841
R842
R843
R844
R845
R846
R851
R852
R853
R854
0RS8201K607
0RD0152F609
0RD0332H609
180-A01B
0RN3903F409
0RN3903F409
0RN3903F409
0RD1203F609
0RD2202F609
0RD1202F609
0RD2200F609
0RN1002F409
0RD1001F609
180-A01H
0RD1001F609
0RD2701F6090RD0332H609
0RD4701F609
0RS2202K607
0RS1202K607
0RD3603F609
0RKZVTA001B
0RKZVTA001B
0RS1203K607
0RD0302A609
0RS0161K607
0RS1203K607
0RF0221H609
0RD1601F609
0RD1501F609
0RD3001F609
0RN1801F409
0RD3601F609
0RD3901F609
0RD3902F609
0RN1801F409
0RN2201F409
0RN2201F409
0RN3901F409
8.2K OHM 2 W 5.00%
15 OHM 1/6 W 5.00%
33 OHM 1/2 W 5.00%
RW ROUND G 2W 0.11 K
390K 1/6W 1%
390K 1/6W 1%
390K 1/6W 1%
120K OHM 1/6 W 5.00%
22K OHM 1/6 W 5%
12K OHM 1/6 W 5%
220 OHM 1/6 W 5.00%
10K OHM 1/6 W 1.00%
1K OHM 1/6 W 5%
2 W RW ROUND G 0.27 J
1K OHM 1/6 W 5%
2.7K OHM 1/6 W 5%33 OHM 1/2 W 5.00%
4.7K OHM 1/6 W 5%
22K OHM 2 W 5.00%
12K OHM 2 W 5.00%
360K 1/6W 5
4.7M OHM 1/2 W 5%
4.7M OHM 1/2 W 5%
120K OHM 2 W 5.00%
30 OHM 1/2 W(7.0) 5.00%
1.6 OHM 2 W 5.00%
120K OHM 2 W 5.00%
2.2 OHM 1/2 W 5.00%
1.6K OHM 1/6 W 5.00%
1.5K OHM 1/6 W 5%
3K OHM 1/6 W 5.00%
1.8K OHM 1/6 W 1.00%
3.6K OHM 1/6 W 5.00%
3.9K OHM 1/6 W 5%
39K OHM 1/6 W 5.00%
1.8K OHM 1/6 W 1.00%
2.2K OHM 1/6 W 1.00%
2.2K OHM 1/6 W 1.00%
3 9K OHM 1/6 W 1 00%
REPLACEMENT PARTS LIST
CONNECTOR
RESISTOR
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 36/43
LOCA. NO PART NO DESCRIPTION
SW701
FB819
FB823
FB861
FB871
FB872
FB881
FB891
IC502
L1005
L1006
L1007
L1013
L801L802
L804
T1001
T1002
T1004
T1013
T200
T3
T400
T400
T401
T401
T402
T402
T403
T403
T404
T409
T410
T411
T412
T413
T418
6600DU2093H
125-123A
125-022K
125-123A
125-022K
125-022K
125-022K
125-022K
6200C000009
6210TCE001G
6210TCE001G
6210TCE001G
6210TCE001G
6200JB8012T6200JB8012T
150-F06T
6200C000009
6200C000009
6200C000010
6200C000010
0IZZVF0022C
6200VJT001B
6200QJ3001A
6200VJT006A
6200QJ3001A
6200VJT006A
6200QJ3001A
6200VJT006A
6200QJ3001A
6200VJT006A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200VJT006A
SWITCH,DIP 23902332
FILTER,EMC FERRITE BFD3565R2F
FILTER,EMC 62MM 1UH
FILTER,EMC FERRITE BFD3565R2F
FILTER,EMC 62MM 1UH
FILTER,EMC 62MM 1UH
FILTER,EMC 62MM 1UH
FILTER,EMC 62MM 1UH
FILTER,B.P. H354LAIK5225
FILTER,EMC HH1M3216501
FILTER,EMC HH1M3216501
FILTER,EMC HH1M3216501
FILTER,EMC HH1M3216501
FILTER,EMC SQE2828 17.2MHFILTER,EMC SQE2828 17.2MH
FILTER,EMC SQE3535 20MH
FILTER,B.P. H354LAIK5225
FILTER,B.P. H354LAIK5225
FILTER,B.P. H354LAIK5202
FILTER,B.P. H354LAIK5202
FILTER,B.P. AFM730F6M00X3(AF9397A)
FILTER,EMC BMK800 50VOLT 1A REEL
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER EMC STC222D 50VOLT 4A 2200PF
LOCA. NO PART NO DESCRIPTION
T5
T501
T502
T504
T509
T511
T512
T513
T514
T515
T6
T601
T602
T605
T606
T7T9
X1
X1001
X1200
X401
X500
X501
X601
F401
F800
IC704
NTC801
NTC802
PA1
RL831
TU101
TU102
VA800
X800
6200VJT001B
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200VJT006A
6200VJT006A
6200VJT006A
6200VJT006A
6200VJT001B
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200QJ3001A
6200VJT001B6200VJT001B
156-A01P
156-A02Z
156-A01E
6212AB2015D
6202VDT002E
6202VDT002E
156-A02R
0FS5000B84B
0FS5001B51D
6204B47985C
163-048D
163-048D
6712SCA228A
141-018E
6700VNF019A
6700VNF019C
164-003K
6204B60001B
FILTER,EMC BMK800 50VOLT 1A REEL
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC STC222D 50VOLT 4A 2200PF
FILTER,EMC BMK800 50VOLT 1A REEL
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMS400 NIGATA 25V 200MA
FILTER,EMC BMK800 50VOLT 1A REELFILTER,EMC BMK800 50VOLT 1A REEL
RESONATOR,CRYSTAL HC49U 8.000MHZ
RESONATOR,CRYSTAL HC49/U 20.000MHZ
RESONATOR,CRYSTAL HC49U 4.000MHZ
RESONATOR,CRYSTAL HC49/SM 16MHZ
RESONATOR,CRYSTAL SX1SMD 20250000HZ
RESONATOR,CRYSTAL SX1SMD 20250000HZ
RESONATOR,CRYSTAL HC49U 18.432MHZ
FUSE,SLOW BLOW 500MA 250V
FUSE,SLOW BLOW 5000MA 250V
OSCILLATOR,SCO103 100MHZ
THERMISTOR,NTC KL15L2R5 +/ 15% 125V
THERMISTOR,NTC KL15L2R5 +/ 15% 125V
REMOTE CONTROLLER RECEIVER,38KHZ
RELAY,DG12D10(M)2
TUNER,TAFCH001F
TUNER,TAFCH101P
VARISTOR,SVC621D14A 620V 0%
OSCILLATOR,VCXO 27MHZ
REPLACEMENT PARTS LIST
FILTER & CRYSTAL
MISCELLANEOUS
ACCESSORIES
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 37/43
Jan., 2004Printed in KoreaP/NO : 3828VD0148T
7/29/2019 3828VD0148T
http://slidepdf.com/reader/full/3828vd0148t 42/43
PRINTED CIRCUIT BOARD
MAIN(TOP) MAIN(BOTTOM)
TUNER(TOP) COMPONENT(TOP) DIGITAL(TOP)