www.macair1.comSetting a new standard in Quality and Reliability

PA SeriesDigital Programmable Energy SavingRefrigerated Air Dryers(10 - 3000 SCFM)

***NEW***EASYAIRTM energy saving compressed air treatment system provides everything needed to deliver clean dry compressed air to your facility’s air pipes while making the install and maintenance process easy!

(See page 7)

2017 Price Book

Featuring the PCT digital timer control Reduces energy costs and wear and tear up to 66% or more Maintenance due monitor

2 www.macair1.com

Water, dirt and oil MUST be removed from your compressed air systemAs your air compressor produces compressed air there is moisture, dirt and oil present in the air stream. Untreated compressed air is the unseen killer in all compressed air systems. Premature tool failure, product spoilage, failed instrumentation, damaged actuators and cylinders, are only part of the long list of casualties in the battle for increased productivity. Without proper treatment of your compressed air this vital source of work turns into a wet, gritty, acidic brew, silently destroying all that it comes into contact with.

www.macair1.com2

Long-lasting Peace of Mind

10 Year warranty Major components that are covered:

Warranty only applies to UA Series dryers shipped after January 1, 2017.

MACAIR air dryers, filters and drains are key components to

solving the contamination problem in your compressed air

system. Your investment in MACAIR air treatment products will

have a very quick payback period in the form of high productivity

and less downtime. You can not afford to operate your air system

without MACAIR air treatment products.

All dryers are handcrafted by

dedicated skilled craftsman in

Walled Lake, MI USA.

All components are sourced from

only the best North American

suppliers.

Energy Efficiency-PA Series dryers can reduce energy costs and wear and tear up to 66% or more UA Series digital programmable energy saving refrigerated air dryers vs Competitive Non-Cycling refrigerated air dryers.

Typical non-cycling refrigerated air dryers operate at full power and remain on until they are manually switched off. Thus they are referred to as NON-CYCLING.They operate at full power when they are turned on and stay on even if no compressed air is flowing and your air compressor is turned off. It is common for users to leave the dryer on 24 hours a day, 7 days a week even when they are only operating one 8 to 10 hour shift. While the dryer is on during downtimes it unnecessarily consumes energy and causes wear and tear on the dryer.

PA Series energy saving programmable refrigerated air dryers featuring the PCT digital programmable timer.

PA series dryers are completely programmable to automatically turn ON andOFF as needed based on the end users hours of operation. Example: If the end user operates 1 shift per day 8 am to 5 pm, the dryer can be programmed to automatically turn on at 7:30 am and turn off at 5 pm Monday through Friday. For a system operating a 500 SCFM dryer the annual electrical costs savings would be $2658 plus the wear and tear on the dryer. Additionally the need to service the dryer is reduced.

www.macair1.com2

Long-lasting Peace of Mind

10 Year warranty Major components that are covered:

Warranty only applies to UA Series dryers shipped after January 1, 2017.

Water, dirt and oil MUST be removed from your compressed air system

MACAIR air dryers, filters and drains are key components to

solving the contamination problem in your compressed air

system. Your investment in MACAIR air treatment products will

have a very quick payback period in the form of high productivity

and less downtime. You can not afford to operate your air system

with out MACAIR air treatment products.

Energy Efficiency

All dryers are handcrafted by

dedicated skilled craftsman in

Walled Lake, MI USA.

All components sourced from

only the best North American

supplier.

3www.macair1.com

PCT - DIGITAL PROGRAMMABLE CONTROL TIMERA series dryers come standard with the PCT programmable control timer feature that enables the owner exact control over the time of day the dryer will turn on and off. This feature can reduce energy costs and wear on the dryer up to 66% or more PA series reduces energy and wear vs a competitive non-cycling dryer by:

· 1 shift operation……………………………..66%· 2 shift operation……………………………..33%

MAINTENANCE DUE LIGHT & TIMERThe key to years of reliable & trouble free dryer operation is regular maintenance. PA series dryers are equipped with a maintenance due reminder light and re-set button. After every 1000 hours of operation the maintenance due light illuminates alerting the end user that it is time to service their dryer. The re-set button automatically resets the timer and the light will light again in 1000 hours.

www.macair1.com2

Long-lasting Peace of Mind

10 Year warranty Major components that are covered:

Warranty only applies to UA Series dryers shipped after January 1, 2017.

MACAIR air dryers, filters and drains are key components to

solving the contamination problem in your compressed air

system. Your investment in MACAIR air treatment products will

have a very quick payback period in the form of high productivity

and less downtime. You can not afford to operate your air system

without MACAIR air treatment products.

All dryers are handcrafted by

dedicated skilled craftsman in

Walled Lake, MI USA.

All components are sourced from

only the best North American

suppliers.

Energy Effi ciency-PA Series dryers can reduce energy costs and wear and tear up to 66% or more UA Series digital programmable energy saving refrigerated air dryers vs Competitive Non-Cycling refrigerated air dryers.

Typical non-cycling refrigerated air dryers operate at full power and remain onuntil they are manually switched off. Thus they are referred to as NON-CYCLING.They operate at full power when they are turned on and stay on even if no compressed air is fl owing and your air compressor is turned off. It is common for users to leave the dryer on 24 hours a day, 7 days a week even when they are only operating one 8 to 10 hour shift. While the dryer is on during downtimes it unnecessarily consumes energy and causes wear and tear on the dryer.

PA Series energy saving programmable refrigerated air dryers featuring the PCT digital programmable timer.

PA series dryers are completely programmable to automatically turn ON andOFF as needed based on the end users hours of operation. Example: If the end user operates 1 shift per day 8 am to 5 pm, the dryer can be programmed to automatically turn on at 7:30 am and turn off at 5 pm Monday through Friday. For a system operating a 500 SCFM dryer the annual electrical costs savings would be $2658 plus the wear and tear on the dryer. Additionally the need to service the dryer is reduced.

DRYER SIZE

(SCFM)

POWER USED

(WATTS)

10 260 $74 $149 $227

25 316 $92 $184 $279

40 389 $112 $224 $339

55 570 $164 $328 $532

75 768 $221 $442 $670

100 768 $221 $442 $670

125 1,047 $301 $603 $914

150 1,047 $329 $658 $997

200 1,360 $392 $784 $1,188

250 2,039 $587 $1,175 $1,781

300 2,142 $624 $1,248 $1,891

400 2,600 $921 $1,842 $2,792

500 2,980 $1,309 $2,618 $3,967

625 4,028 $1,492 $2,985 $4,523

800 6,884 $2,092 $4,185 $6,342

1,000 7,197 $2,336 $4,672 $7,079

1,200 7,669 $2,440 $4,881 $7,396

1,400 8,104 $2,490 $4,980 $7,546

1,600 8,500 $2,490 $4,980 $7,546

2,000 10,840 $3,125 $6,250 $9,192

2,500 13,550 $3,265 $6,531 $9,895

3,000 15,595 $4,596 $9,192 $13,788

ANNUAL ELECTRICAL COSTSBASED ON $.10 PER KW/HR

2 SHIFTS (16 HRS) 3 SHIFTS (24 HRS)1 SHIFT (8 HRS)

MORE ENERGY SAVING EXAMPLES

MAINTENANCE DUE LIGHT & TIMER

SET YOUR PROGRAM AND SAVEPCT Programmable control timer set for a 1 shift operation example: A PA500A programmed to run as per the example below:

DAY DRYER ON DRYER OFF

Monday 7 am 5 pm

Tuesday 7 am 5 pm

Wednesday 7 am 5 pm

Thursday 7 am 5 pm

Friday 7 am 5 pm

Saturday OFF OFF

Sunday OFF OFF

Will save the end user approximately $2658.00 per year vs a competitive NON-CYCLING dryer.

PCT - DIGITAL PROGRAMMABLE CONTROL TIMER

Program Your PA Series Dryer To Save $$$

4 www.macair1.com

PA Series Quality Features - Built To Last

Mac-Pak Filtration System

Nema 4 Electrics

Water-Cooled Condenser

Zero Air Loss Drains

Dryer On Hour Meter

Low Ambient Shutdown

Digital Dew Point Indicator

Fused Disconnect Switch

High or Low Temp Warning Light

Additional Temp & Pressure Gauges

Available Options

Heat exchanger module contains the air to air heat exchanger. The air to refrigerant heat exchanger and the moisture separator.

Heavy gauge steel cabinet with corrosion proof powder coat coating.

Programmable electronic auto-drain with Y-Strainer and isolation valve.

Hot gas bypass valve prevents freeze ups and maintains a low and constant dew point.

Over-sized air-cooled condenser and industrial duty fan motor with thermal overload.

Industrial duty Tecumseh & Copeland refrigeration compressor.

Suction Pressure Gauge: Monitors the low side of the refrigeration system (PA75 and up).

Discharge Pressure Gauge: Monitors the low side of the refrigeration system (PA400 and up).

Dew Point Indicator: (PA10—PA55).

Dryer Running Indicating Light: Illuminates when the dryer is operating (PA75 and up).

Maintenance Due Indicating Light and Re-set Button: After every 1000 hours of operation light turns on alerting customer dryer needs maintenance (PA75 and up).

Suction Accumulator (PA400 And Up): Prevents liquid refrigerant from migrating into the compressors suction port causing damage.

8 Foot Power Cord & Plug: Allows for quick and easy hook up. (UA10A—UA150A).

High & Low Refrigerant Pressure Shut Down: Protects the compressor in the event of system failure or lack of maintenance.

Cleanable & Ambient Air Filter: The filter is attached to the dryer with magnets and made from a washable fiber. Protects the air-cooled condenser from dirt and debris.

www.macair1.com6

Selection Guide and Correction FactorsP

Determine the following operating conditions and use the correction

factors and formula below to select the right dryer for your application.

CORRECTION FACTOR 1 1.24 1.29

INLET PRESSURE

CORRECTION FACTOR

INLET TEMP 80 90 100 110

CORRECTION FACTOR .61 .79 1.0 1.23

6

�

������

INLET PRESSURE 50 80 100 150

CORRECTION FACTOR .85 .95 1.0 1.13

125

1.07

175

1.18

200

1.20

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR 1.50 1.21 1 .72 .61 .53

CORRECTION FACTOR 1.1 1.07 1.05 1 .94�DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

SELECTION GUIDE & CORRECTION FACTORS����

www.macair1.com6

Selection Guide and Correction Factors

Determine the following operating conditions and use the correction

factors and formula below to select the right dryer for your application.

DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

UA75A, UA100A, UA125A

UA400A, UA500A, UA625A

UA2500A, UA3000AUA800A, UA1000A, UA1200A

INLET PRESSURE 50 75 100 120 150 250

CORRECTION FACTOR 1.30 1.10 1.0 .93 .86 .79

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR .61 .79 1.0 1.23 1.51

AMBIENT TEMP 80 90 100 110 115

CORRECTION FACTOR .80 .89 1 1.16 1.31

Example

6

���

��

������

INLET PRESSURE 50 60 70 80 100

CORRECTION FACTOR .80 .84 .88 .92 1.00

90

.96

110

1.02

120

1.04

130

1.06

140

1.08

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR 1.30 1.15 1.0 .83 .70

130

.60

AMBIENT TEMP 80 90 100 110

CORRECTION FACTOR 1.10 1.05 1.00 .90

DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

SELECTION GUIDE & CORRECTION FACTORS����

www.macair1.com6

Selection Guide and Correction Factors

Determine the following operating conditions and use the correction

factors and formula below to select the right dryer for your application.

DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

UA10A, UA20A, UA25A, UA40A, UA55A

UA75A, UA100A, UA125AUA2500A, UA3000AUA800A, UA1000A, UA1200A

INLET PRESSURE 50 75 100 120 150 250

CORRECTION FACTOR 1.30 1.10 1.0 .93 .86 .79

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR .61 .79 1.0 1.23 1.51

AMBIENT TEMP 80 90 100 110 115

CORRECTION FACTOR .80 .89 1 1.16 1.31

Example

140

.53

160

Example: What is the right dryer for the following conditions?Out put from the air compressor: 150 SCFM, Intel Air Pressure: 80 PSIG, Intel Air Temp: 110 F, Ambient Temp:110 F, Dew point temp: 38 F.Inlet Air Flow Rate 150A:(Nominal Capacity) 150 SCFM .95 x .72 x .94 x 1 = 96 SCFM (Corrected Capacity) Based on the correction factors the UA150A would be to small for this application. Try the UA250A(Nominal Capacity) 250 SCFM .95 x .72 x .94 x 1 = 160 SCFM (Corrected Capacity) For this application the UA250A would be the correct choice. For assistance in choosing the correct dryer call your distributor or MACAIR at 248-624-6300.

AMBIENT TEMP 70 80 90 100 110

5www.macair1.com

PA Series Selection Guide and Correction Factors

www.macair1.com6

Selection Guide and Correction FactorsP

Determine the following operating conditions and use the correction

factors and formula below to select the right dryer for your application.

CORRECTION FACTOR 1 1.24 1.29

INLET PRESSURE

CORRECTION FACTOR

INLET TEMP 80 90 100 110

CORRECTION FACTOR .61 .79 1.0 1.23

6

�

������

INLET PRESSURE 50 80 100 150

CORRECTION FACTOR .85 .95 1.0 1.13

125

1.07

175

1.18

200

1.20

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR 1.50 1.21 1 .72 .61 .53

CORRECTION FACTOR 1.1 1.07 1.05 1 .94�DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

SELECTION GUIDE & CORRECTION FACTORS����

www.macair1.com6

Selection Guide and Correction Factors

Determine the following operating conditions and use the correction

factors and formula below to select the right dryer for your application.

DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

UA75A, UA100A, UA125A

UA400A, UA500A, UA625A

UA2500A, UA3000AUA800A, UA1000A, UA1200A

INLET PRESSURE 50 75 100 120 150 250

CORRECTION FACTOR 1.30 1.10 1.0 .93 .86 .79

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR .61 .79 1.0 1.23 1.51

AMBIENT TEMP 80 90 100 110 115

CORRECTION FACTOR .80 .89 1 1.16 1.31

Example

6

���

��

������

INLET PRESSURE 50 60 70 80 100

CORRECTION FACTOR .80 .84 .88 .92 1.00

90

.96

110

1.02

120

1.04

130

1.06

140

1.08

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR 1.30 1.15 1.0 .83 .70

130

.60

AMBIENT TEMP 80 90 100 110

CORRECTION FACTOR 1.10 1.05 1.00 .90

DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

SELECTION GUIDE & CORRECTION FACTORS����

www.macair1.com6

Selection Guide and Correction Factors

Determine the following operating conditions and use the correction

factors and formula below to select the right dryer for your application.

DEWPOINT TEMP 38 45 50

CORRECTION FACTOR 1 1.24 1.29

UA10A, UA20A, UA25A, UA40A, UA55A

UA75A, UA100A, UA125AUA2500A, UA3000AUA800A, UA1000A, UA1200A

INLET PRESSURE 50 75 100 120 150 250

CORRECTION FACTOR 1.30 1.10 1.0 .93 .86 .79

INLET TEMP 80 90 100 110 120

CORRECTION FACTOR .61 .79 1.0 1.23 1.51

AMBIENT TEMP 80 90 100 110 115

CORRECTION FACTOR .80 .89 1 1.16 1.31

Example

140

.53

160

Example: What is the right dryer for the following conditions?Out put from the air compressor: 150 SCFM, Intel Air Pressure: 80 PSIG, Intel Air Temp: 110 F, Ambient Temp:110 F, Dew point temp: 38 F.Inlet Air Flow Rate 150A:(Nominal Capacity) 150 SCFM .95 x .72 x .94 x 1 = 96 SCFM (Corrected Capacity) Based on the correction factors the UA150A would be to small for this application. Try the UA250A(Nominal Capacity) 250 SCFM .95 x .72 x .94 x 1 = 160 SCFM (Corrected Capacity) For this application the UA250A would be the correct choice. For assistance in choosing the correct dryer call your distributor or MACAIR at 248-624-6300.

AMBIENT TEMP 70 80 90 100 110

INLET PRESSURE 50 60 70 80 90 100 110 120 130 140

CORRECTION FACTOR .80 .84 .88 .92 .96 1.0 1.02 1.04 1.06 1.08

INLET TEMP 80 90 100 110 120 130

CORRECTION FACTOR 1.30 1.15 1.0 .83 .70 .60

AMBIENT TEMP 80 90 100 110 115

CORRECTION FACTOR 1.10 1.05 1.0 .90 .80

DEW POINT TEMP 38 45 50

CORRECTION FACTOR 1.0 1.24 1.29

Example: What is the right dryer for the following conditions?Output from the air compressor: 150 SCFM at the following operating conditions: Inlet Air Pressure: 60 PSIG, Inlet Air Temp: 110 F, Ambient Temp: 110 F, Dew point Temp: 38 F. To find the proper dryer start with the rated capacity and apply the multipliers listed above to match the compressors output: Dryer Inlet Air Flow Rate 250 SCFM x .84 x .83 x .90 x 1 = 156.87 SCFM (Corrected Capacity)Based on the operating conditions listed above for this application the UA250A would be the correct choice.

DEW POINT - the temperature at which air is saturated with water vapor, which is the gaseous state of water.

PA40A & PA55A

6 www.macair1.com

7www.macair1.com

MODEL 38 F 50 F

PRESSURE DROP PSID W D H

SHIP WGT

IN/OUT CONN

REF COMP

HP DRAIN CONN

POWER Kw

REF TYPE

MAX PRESSURE

PA10A 10 12 1.2 13 20 15 70 1/2 1/6 1/4 .22

R134a

232

PA20A 20 25 1.3 13 20 15 75 1/2 1/5 1/4 .26

PA25A 25 31 1.4 13 20 15 80 1/2 1/4 1/4 .39

PA40A 40 50 1.2 14 21 21 95 3/4 1/4 1/4 .39

PA55A 55 69 1.9 14 21 21 98 3/4 1/3 1/4 .50

PA75A 75 103 1.3 18 26 26 165 1 1/2 1/4 .94

PA100A 100 136 1.5 18 26 26 169 1 1/2 1/4 .94

PA125A 125 171 1.8 18 26 26 205 11/2 3/4 1/4 1.04

PA150A 150 204 1.95 18 26 26 210 11/2 3/4 1/4 1.04

PA200A 200 275 1.6 23 33 32 250 2 1 1/4 1.36

PA250A 250 350 2.0 23 33 32 295 2 11/2 1/4 2.03

PA300A 300 425 2.3 23 33 32 310 2 11/2 1/4 2.03

R404a

PA400A 400 525 2.85 29 46 33 486 2 2 3/8 4.54

PA500A 500 700 2.25 29 46 33 526 2 3 3/8 4.99

PA625A 625 799 3.0 29 46 33 549 2 3 3/8 4.99

PA700A 700 875 3.0 38 55 57 825 21/2 4 3/8 5.00

PA800A 800 1005 3.2 38 55 57 855 3 4 3/8 5.00

PA1000A 1000 1375 3.0 38 55 57 875 3 5 1/2 7.26

PA1200A 1200 1640 3.2 38 55 57 900 3 6 1/2 7.9

PA1600A 1600 2103 3.1 40 56 72 1400 4 8 1/2 8.5

PA2000A 2000 2650 3.5 40 56 72 1595 4 10 1/2 10.8

PA2500A 2500 3300 3.6 40 62 68 1755 4 12 1/2 12.2

PA3000A 3000 3750 3.8 40 62 68 1945 6 15 1/2 15.9

Notes

Specifications and Dimensions

UA40A, UA55AUA200A,UA250A, UA300A

WITH AMBIENT FILTER

UA200A, UA250A, UA300A

7www.macair1.com

MODEL 38 F 50 F

PRESSURE DROP PSID W D H

SHIP WGT

IN/OUT CONN

REF COMP

HP DRAIN CONN

POWER Kw

REF TYPE

MAX PRESSURE

PA10A 10 12 1.2 13 20 15 70 1/2 1/6 1/4 .22

R134a

232

PA20A 20 25 1.3 13 20 15 75 1/2 1/5 1/4 .26

PA25A 25 31 1.4 13 20 15 80 1/2 1/4 1/4 .39

PA40A 40 50 1.2 14 21 21 95 3/4 1/4 1/4 .39

PA55A 55 69 1.9 14 21 21 98 3/4 1/3 1/4 .50

PA75A 75 103 1.3 18 26 26 165 1 1/2 1/4 .94

PA100A 100 136 1.5 18 26 26 169 1 1/2 1/4 .94

PA125A 125 171 1.8 18 26 26 205 11/2 3/4 1/4 1.04

PA150A 150 204 1.95 18 26 26 210 11/2 3/4 1/4 1.04

PA200A 200 275 1.6 23 33 32 250 2 1 1/4 1.36

PA250A 250 350 2.0 23 33 32 295 2 11/2 1/4 2.03

PA300A 300 425 2.3 23 33 32 310 2 11/2 1/4 2.03

R404a

PA400A 400 525 2.85 29 46 33 486 2 2 3/8 4.54

PA500A 500 700 2.25 29 46 33 526 2 3 3/8 4.99

PA625A 625 799 3.0 29 46 33 549 2 3 3/8 4.99

PA700A 700 875 3.0 38 55 57 825 21/2 4 3/8 5.00

PA800A 800 1005 3.2 38 55 57 855 3 4 3/8 5.00

PA1000A 1000 1375 3.0 38 55 57 875 3 5 1/2 7.26

PA1200A 1200 1640 3.2 38 55 57 900 3 6 1/2 7.9

PA1600A 1600 2103 3.1 40 56 72 1400 4 8 1/2 8.5

PA2000A 2000 2650 3.5 40 56 72 1595 4 10 1/2 10.8

PA2500A 2500 3300 3.6 40 62 68 1755 4 12 1/2 12.2

PA3000A 3000 3750 3.8 40 62 68 1945 6 15 1/2 15.9

Notes

Specifications and Dimensions

UA40A, UA55AUA200A,UA250A, UA300A

WITH AMBIENT FILTER

UA200A, UA250A, UA300A

PA75A, PA100A, PA125A, PA150A, PA200A, PA250A, PA300A

Specifications and Dimensions

7www.macair1.com

MODEL 38 F 50 F

PRESSURE DROP PSID W D H

SHIP WGT

IN/OUT CONN

REF COMP

HP DRAIN CONN

POWER Kw

REF TYPE

MAX PRESSURE

PA10A 10 12 1.2 13 20 15 70 1/2 1/6 1/4 .22

R134a

232

PA20A 20 25 1.3 13 20 15 75 1/2 1/5 1/4 .26

PA25A 25 31 1.4 13 20 15 80 1/2 1/4 1/4 .39

PA40A 40 50 1.2 14 21 21 95 3/4 1/4 1/4 .39

PA55A 55 69 1.9 14 21 21 98 3/4 1/3 1/4 .50

PA75A 75 103 1.3 18 26 26 165 1 1/2 1/4 .94

PA100A 100 136 1.5 18 26 26 169 1 1/2 1/4 .94

PA125A 125 171 1.8 18 26 26 205 11/2 3/4 1/4 1.04

PA150A 150 204 1.95 18 26 26 210 11/2 3/4 1/4 1.04

PA200A 200 275 1.6 23 33 32 250 2 1 1/4 1.36

PA250A 250 350 2.0 23 33 32 295 2 11/2 1/4 2.03

PA300A 300 425 2.3 23 33 32 310 2 11/2 1/4 2.03

R404a

PA400A 400 525 2.85 29 46 33 486 2 2 3/8 4.54

PA500A 500 700 2.25 29 46 33 526 2 3 3/8 4.99

PA625A 625 799 3.0 29 46 33 549 2 3 3/8 4.99

PA700A 700 875 3.0 38 55 57 825 21/2 4 3/8 5.00

PA800A 800 1005 3.2 38 55 57 855 3 4 3/8 5.00

PA1000A 1000 1375 3.0 38 55 57 875 3 5 1/2 7.26

PA1200A 1200 1640 3.2 38 55 57 900 3 6 1/2 7.9

PA1600A 1600 2103 3.1 40 56 72 1400 4 8 1/2 8.5

PA2000A 2000 2650 3.5 40 56 72 1595 4 10 1/2 10.8

PA2500A 2500 3300 3.6 40 62 68 1755 4 12 1/2 12.2

PA3000A 3000 3750 3.8 40 62 68 1945 6 15 1/2 15.9

Notes

Specifications and Dimensions

UA40A, UA55AUA200A,UA250A, UA300A

WITH AMBIENT FILTER

UA200A, UA250A, UA300A

5. H Series pre-filters are recommended before the UA Series dryers.

7www.macair1.com

EASYAIR TM 4 STEP INSTALLATION PROCESS IS AS FOLLOWS:

1. Connect Air Inlet2. Connect Air Outlet3. Connect Condensate Drain4. Connect Electrical Feed

DONE!

EASY AIR MODEL

FILTER MODEL

IN & OUT SIZE

EA10A H40C 1/2

EA20A H40C 1/2

EA25A H40C 1/2

EA40A H40C 3/4

EA55A H60C 3/4

EA75A H60C 1

EA100A H100C 1

EA125A H175C 1

EA150A H175C 1

EA200A H250C 1 1/2

EA250A H250C 1 1/2

EA300A H385C 2

EA375A H385C 2

EA400A H385C 2

EA500A H635C 2

EA625A H635C 2

EA800A H1000C 3

EA1000A H1000C 3

EA1200A H1300C 3

EASYAIR TM Makes installation and maintenance easy

It’s a Compressed air treatment system that provides everything needed to deliver clean dry compressed air to your facility’s air pipes EASY!!

Standard features include: UA or MHT Series Refrigerated Air Dryer equivalent H series general purpose coalescing pre-filter Three valve bypass Single point condensate drain connection Maintenance Due Indicator light Magnetic, cleanable ambient air filter

WHY CHOOSE EASYAIR TM?A compressed air system includes many parts and components. Procuring, coordinating and installing all these parts and components into a workable compressed air system takes expertise and experience and is a time consuming job. Any service manger knows when mistakes are made it costs time and money. High paid service and installation techs can spend many hours and days driving around town looking for the right fitting, valve or component to finish the job. The MACAIR EASYAIR TM compressed air system simplifies the installation process by providing everything needed, pre-piped, plumbed and wired into one easy to install system that will deliver clean dry compressed air to your facility’s air pipes.

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A PA400A, PA500A, PA65A

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A PA1600A, PA2000A, PA2500A

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A PA800A, PA1000A, PA1200A

The following are a few companies that have chosen MACAIR equipment to protect their compressed air systems from moisture and contaminates:Federal Aviation AssociationFord Motor CompanyGeneral MotorsChrysler CorporationCopeland CorporationFederal ReserveU.S. Air ForceWhirlpool Corporation

MeijerDetroit ChromeJiffy Mix (Chelsea Milling Company)AmtrakDana Corp3MWalmartU.S. Navy

Distributed by:

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A

H Series Filters

Other products available from MACAIR:

MHT SeriesHigh Temp Dryers

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A

H Series Filters

MHT SeriesHigh Temp Dryers

8

DISTRIBUTED BY:

OTHER PRODUCTS AVAILABLE FROM MACAIRMHR HEATLESS H SERIES UA SERIES MHT SERIESDRYERS FILTERS HIGH CAPACITY HIGH TEMP DRYERS

4123 PIONEER DR WALLED LAKE, MI 48390248-624-6300 248-624-0622 FAX sales@macair1.com

www.macair1.com

FEDERAL AVIATION ASSOCIATIONFORD MOTOR CO.GENRAL MOTORSCHRYSLER CORPCOPELAND CORP

FEDERAL RESERVE U.S. AIR FORCE

WHIRPOOL CORP

MEIJERSDETROIT CHROME

JIFFY MIX (CHELSEA MILLING CO)AMTRAK

DANA CORP3 M

WALMARTUS NAVY

The following are a few companies that have chosen MACAIR equipment to protect there compressed air systems from moisture and contaminates.

UA400A, UA500A , UA625A UA800A, UA1000A , UA1200A UA1600A, UA2000A , UA2500A

www.macair1.com12

4123 Pioneer Drive

Walled Lake, MI 48390

248-624-6300

248-624-0622 FAX

sales@macair1.com

www.macair1.com

The following are a few companies that have chosen

MACAIR equipment to protect their compressed air

systems from moisture and contaminates:

Other products available from MACAIR:

WAS 360

2017 Price Book

MHR Heatless Dryers

www.macair1.com12

4123 Pioneer Drive

Walled Lake, MI 48390

248-624-6300

248-624-0622 FAX

sales@macair1.com

www.macair1.com

The following are a few companies that have chosen

MACAIR equipment to protect their compressed air

systems from moisture and contaminates:

Other products available from MACAIR:

WAS 360

www.macair1.com12

4123 Pioneer Drive

Walled Lake, MI 48390

248-624-6300

248-624-0622 FAX

sales@macair1.com

www.macair1.com

The following are a few companies that have chosen

MACAIR equipment to protect their compressed air

systems from moisture and contaminates:

Other products available from MACAIR:

WAS 360

PA Series High Capacity