of 1300
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
1/1296
TM 55-1520-210-23-1
TECHNICAL MANUAL
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONSARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
This manual supersedes TM 55-1520-210-23-1, 20 February 1979, including all changes.
HEADQUARTERS, DEPARTMENT OF THE ARMY30 SEPTEMBER 1987
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
2/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
3/1296
TM 55-1520-210-23-1
Personnel performing operations, procedures,
and practices which are included or implied in thistechnical manual shall observe the following warnings.
Disregard of these warnings and precautionaryinformation can cause serious injury, or death.
Warnings, cautions, and notes are used to emphasize
important and critical instructions and are used for
the following conditions:
An operating procedure, practice, etc., which,
if not correctly followed, could result in personal
injury or loss of life.
An operating procedure, practice, etc., which, if notstrictly observed, could result in damage to or destruction
of equipment.
NOTE
An operating procedure, condition, etc., whichit is essential to highlight.
NOISE
Sound pressure levels in this helicopter during some operating conditions exceed the Surgeon General hearingconservation criteria, as defined in TB MED 501. Hearing protection devices, such as aviator helmet or ear plugs
are required to be worn by all personnel in and around the helicopter during its operation.
ELECTROLYTE
Corrosive Battery Electrolyte (Potassium Hydroxide). Wear rubber gloves, apron, and face shield when handling
leaking batteries. If potassium hydroxide is spilled on clothing, or other material wash immediately with cleanwater. If spilled on personnel immediately start flushing the affected area with clean water. Continue washinguntil medical assistance arrives.
TOXIC POISONS
Turbine fuels and lubricating oils contain additives which are poisonous and readily absorbed through
the skin. Do not allow them to remain on skin longer than necessary.
HANDLING HYDRAULIC FLUID (MIL-H-83282
Prolonged contact with liquid or mist can irritate eyes and skin. After any prolonged contact with skin,
immediately wash contacted area with soap and water. If liquid contacts eyes, flush immediately with
clear water. If liquid is swallowed, do not induce vomiting; get immediate medical attention. Wear rub-
ber gloves when handling liquid. If prolonged contact with mist is likely, wear an apporopriate
respirator. When fluid is decomposed by heating, toxic gases are released.
a
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
4/1296
TM 55-1520-210-23-1
STARTING HELICOPTER
Starting and operation of the helicopter will be performed only by authorized personnel in accordancewith AR 95-1.
GROUNDING HELICOPTER
The helicopter should be electrically grounded when parked. Turn off all power switches beforemaking electrical connections or disconnections. Serious burns and electrical shock can result from
contact with exposed electrical wires or connectors.Before removing any engine ignition system component, ground the leads to dissipate any storedvoltage in ignition unit.
FIRE EXTINGUISHER
Exposure to high concentrations of monobromotrifluoromethane (CF3BR) extinguishing agent ordecomposition products should be avoided. The liquid should not be allowed to come into contactwith the skin, as it may cause frost bite or low temperature burns.
ARMAMENT
Loaded weapons, or weapons being loaded or unloaded, shall be pointed in a direction which offersthe least exposure to personnel or property in the event of accidental firing. Personnel shall remain
clear of hazardous area of all loaded weapons.
ANY ROTATION OF THE GUN ARMAMENT SUBSYSTEM BARRELS WILL CAUSE THE GUN TO FIRE.Upon landing, immediately alert personnel to probable presence of live rounds in the gun. Summonarmament repairman to clear weapon.
FUELING AND DEFUELING
When refueling helicopter, the refueling vehicle or forward air refueling unit must be parked aminimum of 20 feet from the helicopter. Before starting the fueling operation, always insert fuelingnozzle grounding chain of fuel truck ground wire into GROUND HERE receptacle located on the rightside of the helicopter aft of the cabin area. Refer to FM 10-68.
When defueling, turn off all electrical switches and disconnect external power from the helicopter. The
helicopter must be electrically grounded prior to defueling.
RADIOACTIVE MATERIALS
Self-luminous dials and ignition units may contain radioactive materials. if such an instrument or unit isbroken or becomes unsealed, avoid personal contact. Use forceps or gloves made of rubber orpolyethylene to pick up contaminated material. Place materials and gloves in a plastic bag. Seal bagand dispose of it as radioactive waste in accordance with AR755-15 and TM 3-261 (Refer to TB43-0108). Repair procedures shall conform to requirements in AR700-52.
CLEANING SOLVENTS
Cleaning solvents may be flammable and toxic. Use only in well ventilated areas. Avoid inhalation ofvapor and skin contact. Do not use solvents near open flame or in areas where very high temperaturesprevail.
ROTOR BLADES
Personnel will stay clear of rotor blades during operation. Refer to Chapter 1 for rotor bladedimensions and clearances.
b
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
5/1296
TM 55-1520-210-23-1
TOOLS
Use only chrome plated steel or unplated steel tools for disassembly or reassembly procedures.Because the platings are prone to chipping and flaking, the use of cadmium or zink plated tools is notpermitted. If these chips or flakes become embedded in aircraft parts, galvanic corrosion will result. Ifthese chips or flakes enter fuel or oil wetted components, they may eventually clog the filter orproduce intergranular attack of nickel or titanium base alloys at elevated temperatures. Regardless of
the type of plating, all tools must be serviceable and free of chipping.
c
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
6/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
7/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
8/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
9/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
10/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
11/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
12/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
13/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
14/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
15/1296
CHANGE
NO. 43
C43
TM 55-1520-210-23-1
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 22 December 2003
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, dated 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical barin the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
A through H A through H
1-17 through 1-22 1-17 through 1-22
1-25 through 1-30 1-25 through 1-30
1-45 and 1-46 1-45 and 1-46
1-111 and 1-112 1-111 and 1-1122-149 and 2-150 2-149 and 2-150
2-154.5 and 2-154.6 2-154.5 and 2-154.6
5-33 and 5-34 5-33 and 5-34
5-83 and 5-84 5-83 and 5-84
6-87 through 6-90 6-87 through 6-90
6-138.1/(6-138.2 blank) 6-138.1 /(6-138.2 blank)
6-165 and 6-166 6-165 and 6-166
2. Retain this sheet in front of manual for reference purposes.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
16/1296
By Order of the Secretary of the Army:
Official:
PETER J. SCHOOMAKER
General, United States Army
Chief of Staff
JOEL B. HUDSON
Administrative Assistant to theSecretary of the Army
0331605
TM 55-1520-210-23-1C43
DISTRIBUTION:
To be distributed in accordance with initial distribution number (IDN) 311408, requirements for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
17/1296
CHANGE
NO. 42
C 42
TM 55-1520-210-23-1
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 14 April 2003
AviationUnitandIntermediate
Maintenance Instructions
ARMYMODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTIONSTATEMENTA: Approved forpublic release; distribution is unlimited.
TM 55-1520-210-23-1, dated30 September 1987, is changed as follows:1. Removeandinsertpages as indicatedbelow. Neworchangedtextmaterial is indicatedbya verticalbar
in the margin. An illustrationchange is indicated bya miniature pointing hand.
Remove pages Insert pages
A through H A through H
P-1 and P-2 P-1 and P-2
i and ii i and ii
1-21 and 1-22 1-21 and 1-22
1-30.3 and 1-30.4 1-30.3 and 1-30.4
1-37 and 1-38 1-37 and 1-381-105 and 1-106 1-105 and 1-106
1-111 and 1-112 1-111 and 1-112
2-119 and 2-120 2-119 and 2-120
2-154.5/(2-154.6 blank) 2-154.5 and 2-154.6
3-14.1 and 3-14.2 3-14.1 and 3-14.2
4-42.3 and 4-42.4 4-42.3 and 4-42.4
4-43 through 4-46 4-43 through 4-46
4-57 and 4-58 4-57 and 4-58
4-73 and 4-74 4-73 and 4-74
4-93 and 4-94 4-93 and 4-94
5-9 and 5-10 5-9 and 5-10
5-15 and 5-16 5-15 and 5-165-25 through 5-28 5-25 through 5-28
5-33 and 5-34 5-33 and 5-34
5-67 and 5-68 5-67 and 5-68
5-68.1 and 5-68.2 5-68.1 and 5-68.2
5-69 and 5-70 5-69 and 5-70
5-85 and 5-86 5-85 and 5-86
5-91 and 5-92 5-91 and 5-92
5-103 and 5-104 5-103 and 5-1045-109 and 5-110 5-109 and 5-1106-23 and 6-24 6-23 and 6-24
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
18/1296
TM 55-1520-210-23-1.
To be distributed in accordance with Initial Distribution Number (IDN) 311408, requirements for
Distribution:
Secretary of the Army
Administrative Assistant to the
JOEL B. HUDSON
Chief of StaffOfficial:
General, United States Army
ERIC K. SHINSEKI
By Order of the Secretary of the Army:
2. Retain this sheet in front of manual for reference purposes.
TM 55-1520-210-23-1
C 42
Remove pages Insert pages
6-43 and 6-44 6-43 and 6-446-44.1 through 6-44.4 6-44.1 through 6-44.4
6-49 and 6-50 6-49 and 6-50
6-60.1/(6.60.2 blank) 6-60.1/(6.60.2 blank)
6-89 through 6-92 6-89 through 6-92
6-101 and 6-102 6-101 and 6-1026-116.5 and 6-116.6 6-116.5 and 6-116.66-137 and 6-138 6-137 and 6-138
6-138.1 through 6-138.3/(6-138.4 blank) 6-138.1 through 6-138.3/(6-138.4 blank)
6-139 and 6-140 6-139 and 6-140
6-147 and 6-148 6-147 and 6-1486-165 and 6-166 6-165 and 6-1666-166.5/(6-166.6 blank) 6-166.5/(6-166.6 blank)
Index-13 and Index-14 Index-13 and Index-14
0307107
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
19/1296
CHANGE
NO. 41
C41
TM55-1520-210-23-1
URGENT
URGENT
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 1 J uly 2002
AviationUnitandIntermediate
Maintenance Instructions
ARMYMODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTIONSTATEMENTA: Approved forpublic release; distribution is unlimited.
TM 55-1520-210-23-1, dated30 September 1987, is changed as follows:1. Removeandinsertpages as indicatedbelow. Neworchangedtextmaterial is indicatedbya verticalbar
in the margin. An illustrationchange is indicated bya miniature pointing hand.
Remove pages Insert pages
A through H A through H
1-109 through 1-114 1-109 through 1-114
6-137 through 6-140 6-137 through 6-140
6-146.1 and 6-146.2 6-146.1 and 6-146.2
6-147/(6-148 blank) 6-147 and 6-148
6-151 and 6-152 6-151 and 6-1526-165 and 6-166 6-165 and 6-166
6-166.3 through6-166.5/(6-166.6blank) 6-166.3 through6-166.5/(6-166.6blank)
2. Pages 1-111 through 1-114correct errors associatedwith urgentchange 40.
3. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Distribution: To be distributed inaccordance with Initial Distribution Number (IDN) 311408, requirements for TM 55-1520-210-23-1.
ERIC K. SHINSEKIGeneral, United States Army
Chief of StaffOfficial:
JOEL B. HUDSON Administrative Assistant to the
Secretary of the Army0216807
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
20/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
21/1296
URGENT
URGENT
TM 55--1520--210--23--1C 40
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 40 WASHINGTON, D.C., 19 April 2002
Aviation UnitandIntermediateMaintenance Instructions
ARMY MODEL UH--1H/V/EH--1H/X
HELICOPTERS
DISTRIBUTION STATEMENT A: Approvedfor public release; distribution is unlimited
TM 55--1520--210--23--1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed textmaterial is indicated bya verticalbar inthe margin. An illustrationchange is indicated bya miniature pointing hand.
Remove pages Insertpages
A through H A through H1--113 and 1--114 1--113 and 1--1146--137 and 6--138 6--137 and 6--1386--147/(6--148blank) 6--147/(6--148blank)
2. Retainthis sheetin frontof manual for referencepurposes.
By Order of the Secretary of the Army:
DISTRIBUTION To be distributed inaccordance with Initial Distribution Number 311408, requirements for TM 55--1520--210--23--1
ERIC K. SHINSEKIGeneral, United States Army
Chief of StaffOfficial:
JOEL B. HUDSON Administrative Assistant to the
Secretary of the Army
0210202
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
22/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
23/1296
CHANGE
NO. 39 }
C39
TM 55-1520-210-23-1URGENT
URGENT
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 15 October 2001
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited
TM 55-1520-210-23-1, dated 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical barin the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
A through H A through H
1-111 through 1-114 1-111 through 1-114
5-54.45 and 5-54.46 5-54.45 and 5-54.46
5-65 and 5-66 5-65 and 5-66
5-72.5 and 5-72.6 5-72.5 and 5-72.6
5-87 and 5-88 5-87 and 5-88
5-101 through 5-104 5-101 through 5-104
6-105 and 6-106 6-105 and 6-106
– – – – – – 6-106.1/(6-106.2 blank)
2. Retain these sheets in front of manual for reference purposes.
By Order of the Secretary of the Army:
Distribution:To be distributed in accordance with Initial Distribution Number (IDN) 311408, requirements forTM 55-1520-210-23-1.
ERC K. SHINSEKI
General, United States ArmyChief of Staff
Official:
JOEL B. HUDSON
Administrative Assistant to theSecretary of the Army
0127504
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
24/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
25/1296
URGENT
URGENT
TM 55-1520-210-23-1C 38
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 38 WASHINGTON, D.C., 6 J uly 2001
AviationUnitand IntermediateMaintenance Instructions
ARMYMODEL UH--1H/V/EH--1H/XHELICOPTERS
DISTRIBUTIONSTATEMENT A: Approved for public release; distribution is unlimited
TM 55-1520-210-23-1, 30 September1987, is changedas follows:
1. Remove and insert pages as indicatedbelow. New orchanged text material is indicatedby a verticalbar inthe margin. An illustrationchange is indicated bya miniature pointing hand.
Remove pages Insert pages
A through H A through HP--1 and P--2 P--1 and P--21--113 and 1--114 1--113 and 1--1142--153and2--154 2--153through2--154.5/(2--154.6blank)
2. Retain this sheet in front of manual for referencepurposes.
By Order of the Secretary of the Army:
ERIC K. SHINSEKIGeneral, United States Army
Chief of StaffOFFICIAL:
JOEL B. HUDSON
DISTRIBUTIONTo be distributed in accordance with Initial Distribution Number 311408, requirements for TM 55-1520-210-23-1.
Administrative Assistant to the
Secretary of the Army 0117207
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
26/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
27/1296
TM 55-1520-210-23-1
C37
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 37 WASHINGTON, D.C. 15 January 2001
Aviation Unit And Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, dated 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar in the margin. Anillustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
A through G / (H blank) A through Hi and ii i and ii
1-1 and 1-2 1-1 and 1-2
1-5 through 1-8 1-5 through 1-8
1-15 through 1-18 1-15 through 1-18
1-30.1 through 1-30.4 1-30.1 through 1-30.4
1-95 and 1-96 1-95 and 1-96
1-105 through 1-110 1-105 through 1-110
2-1 and 2-2 2-1 and 2-2
2-31 and 2-32 2-31 and 2-32
2-53 and 2-54 2-53 and 2-54
2-59 and 2-60 2-59 and 2-60
2-63 through 2-68 2-63 through 2-68
2-73 and 2-74 2-73 and 2-74
2-79 and 2-80 2-79 and 2-80
2-83 through 2-88.2 2-83 through 2-88.2
2-91 through 2-94 2-91 through 2-94
2-103 and 2-104 2-103 and 2-104
2-107 and 2-108 2-107 and 2-108
2-115 and 2-116 2-115 and 2-116
2-119 and 2-120 2-119 and 2-120
2-130.1 / (2-130.2 blank) 2-130.1 / (2-130.2 blank)
2-147 through 2-150 2-147 through 2-150
2-153 and 2-154 2-153 and 2-154
2-157 and 2-158 2-157 and 2-158
2-181 and 2-182 2-181 and 2-182
2-183 through 2-188 2-183 through 2-188
2-197 and 2-198 2-197 and 2-198
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
28/1296
TM 55-1520-210-23-1
C37
Remove pages Insert pages
2-207 and 2-208 2-207 and 2-208
2-227 through 2-230 2-227 through 2-230
2-247 and 2-248 2-247 and 2-248
2-255 and 2-256 2-255 and 2-256
3-1 through 3-4 3-1 through 3-4
3-7 and 3-8 3-7 and 3-8
3-14.1 and 3-14.2 3-14.1 and 3-14.2
3-15 and 3-16 3-15 and 3-16
4-13 and 4-14 4-13 and 4-14
4-17 and 4-18 4-17 and 4-18
4-23 and 4-24 4-23 and 4-24
4-29 and 4-30 4-29 and 4-30
4-35 and 4-36 4-35 and 4-36
4-42.1 through 4-42.4 4-42.1 through 4-42.4
4-42.5 through / (4-42.8 blank) 4-42.5 through / (4-42.8 blank)
4-43 through 4-46 4-43 through 4-46
4-47 and 4-48 4-47 and 4-48
4-53 and 4-54 4-53 and 4-544-57 through 4-60.4 4-57 through 4-60.4
4-60.4.1 / (4-60.4.2 blank)
4-60.5 through 4-60.8 4-60.5 through 4-60.12
4-67 and 4-68 4-67 and 4-68
4-71 through 4-74 4-71 through 4-74
4-79 and 4-80 4-79 and 4-80
4-87 and 4-88 4-87 and 4-88
4-107 and 4-108 4-107 and 4-108
5-21 and 5-22 5-21 and 5-22
5-29 and 5-30 5-29 and 5-30
5-32.1 and 5-32.2 5-32.1 and 5-32.2
5-39 and 5-40 5-39 and 5-405-40.1 / (5-40.2 blank) 5-40.1 / (5-40.2 blank)
5-41 through 5-44 5-41 through 5-44
5-54.45 and 5-54.46 5-54.45 and 5-54.46
5-54.49 / (5-54.50 blank) 5-54.49 / (5-54.50 blank)
5-68.1 and 5-68.2 5-68.1 and 5-68.2
5-71 and 5-72 5-71 and 5-72
5-73 and 5-74 5-73 and 5-74
5-79 and 5-80 5-79 and 5-80
5-83 and 5-84 5-83 and 5-84
5-93 and 5-94 5-93 and 5-94
5-99 through 5-102 5-99 through 5-102
5-107 through 5-110 5-107 through 5-110
5-121 and 5-122 5-121 and 5-122
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
29/1296
TM 55-1520-210-23-1
C37
Remove pages Insert pages
5-124.1 / (5-124.2 blank) 5-124.1 / (5-124.2 blank)
5-131 and 5-132 5-131 and 5-132
6-7 through 6-10 6-7 through 6-10
6-13 and 6-14 6-13 and 6-14
6-21 and 6-22 6-21 and 6-22
6-25 and 6-26 6-25 and 6-26
6-39 and 6-44 6-39 and 6-44
6-44.1 and 6-44.2 6-44.1 and 6-44.2
6-47 and 6-48 6-47 and 6-48
6-60.1 / (6-60.2 blank) 6-60.1 / (6-60.2 blank)
6-61 and 6-62 6-61 and 6-62
6-65 and 6-66 6-65 and 6-66
6-71 and 6-72 6-71 and 6-72
6-79 through 6-84 6-79 through 6-84
6-87 and 6-88 6-87 and 6-88
6-93 through 6-98 6-93 through 6-98
6-113 through 6-116.4 6-113 through 6-116.4
6-127 and 6-128 6-127 and 6-128
6-129 and 6-130 6-129 and 6-130
6-133 and 6-134 6-133 and 6-134
6-137 and 6-138 6-137 and 6-138
6-138.1 / (6-138.2 blank) 6-138.1 / (6-138.2 blank)
6-141 and 6-142 6-141 and 6-142
6-146.1 and 6-146.2 6-146.1 and 6-146.2
6-147 / (6-148 blank) 6-147 / (6-148 blank)
6-149 and 6-150 6-149 and 6-150
6-153 and 6-154 6-153 and 6-154
6-161 and 6-162 6-161 and 6-162
6-165 through 6-166.2 6-165 through 6-166.2
6-171 through 6-172.2 6-171 through 6-172.2Index-5 and Index-6 Index-5 and Index-6
2. Retain these sheets in front of manual for reference purposes.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
30/1296
TM 55-1520-210-23-1
C37
By Order of the Secretary of the Army:
ERIC K. SHINSEKIGeneral, United States Army Chief of Staff
OFFICIAL:
JOEL B. HUDSON Administrative Assistant to the
Secretary of the Army 0030716
DISTRIBUTION:To be distributed in accordance with Initial Distribution Number 311408, requirements for TM 55-1520-210-23-1.
SIGN
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
31/1296
URGENT
TM 55- 1520- 210- 23- 1C36
CHANGE
NO. 36
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHI NGTON, D. C. , 19 Nov 1999
Avi ati on Unit and I ntermedi ateMai ntenance I nstructi ons
ARMY MODEL UH- 1 H/ V/ EH-1 H/ XHELI COPTERS
DI STRI BUTI ON STATEMENT A: Approved for publ i c r el ease; di str i buti on i s unl i mi ted
TM 55- 1520- 21O- 23- 1, 30 September 1987, i s changed as f ol l ows:
I . Remove and i nsert pages as i ndi cated bel ow. New or changed text materi al i s i ndi cated by a verti cal bar i n
the margin. An i l l ustrati on change i s i ndi cated by a mi ni ature pointi ng hand.
Remove pages I nsert pages
P- l and P-21-115 and 1-1161-123 and 1-1244-45 and 4- 46
A through GP-1 and P- 21-115 and 1-1161-123 and 1- 1244-45 and 4-464- 46. 1/ (4- 46. 2 bl ank)
2. Retai n this sheet i n front of manual for reference purposes.
By Order of the Secr etary of the Army:
ERI C K. SHI NSEKIGene r a l , Un i t e d St a t e s Ar my
Ch i e f o f St a f f
Admi ni strati ve Assi stant to theSecretary of the Army
9931901
DI STRI BUTI ONTo be di stri buted i n accordance wi th Ini ti al Di stri buti on Number 311408, requi rements f or TM 55-1520-210-23-1
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
32/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
33/1296
URGENTTM 55-1520-210-23-1
C35
CHANGE
NO. 35
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 22 January 1998
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indited by
vertical bar in the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
i and ii i and ii
1-111 and 1-112 1-111 and 1-112
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Administrative Assistant to the
Secretary of the Army03861
DENNIS J. REIMERGeneral, United States Arm
Chief of Staff
DISTRIBUTION:To be distributed in accordance with Initial Distribution Number 1408, requirements for TM 55-
1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
34/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
35/1296
URGENT
TM 55-1520-210-23-1C 34
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 34 WASHINGTON, D.C., 7 October 1996
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1HNIEH-1H/XHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited
TM 55-1520-210-23-1,30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar in themargin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
1-109 and 1-110 1-109 and 1-110
5-135 and 5-136 5-135 and 5-136
5-136.1/(5-136.2 blank)
6-39 and 6-40 6-39 and 6-40
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
DENNIS J. REIMERGeneral, United States Army
Official: Chief of Staff
JOEL B. HUDSONAdministrative Assistant to the
Secretary of the Army 02679
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for TM 55-1520-210-23-1.
SIGN
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
36/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
37/1296
TM 55-1520-210-23-1C33
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 33 WASHINGTON, D.C., 28 September 1996
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1HNIEH-1HIXHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar inthe margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
i and ii i and ii
1-5 and 1-6 1-5 and 1-61-15 and 1-16 1-15 and 1-161-25 and 1-26 1-25 and 1-261-30.3 and 1-30.4 1-30.3 and 1-30.41-51 and 1-52 1-51 and 1-521-67 and 1-68 1-67 and 1-68
1-68.1 and 1-68.21-97 and 1-98 1-97 and 1-981-107 and 1-108 1-107 and 1-1081-111 and 1-112 1-111 and 1-1122-33 and 2-34 2-33 and 2-342-43 and 2-44 2-43 and 2-44
2-44.1/(2-44.2 blank)
2-45 and 2-46 2-45 and 2-462-67 through 2-70 2-67 through 2-702-91 and 2-92 2-91 and 2-922-101 2-101/(2-102 blank)2-109 2-109/(2-110 blank)2-115 and 2-116 2-115 and 2-1162-119 and 2-120 2-119 and 2-1202-120.1 and 2-120.2 2-120.1 and 2-120.22-121 through 2-124 2-121 through 2-1242-131 and 2-132 2-131 and 2-1322-151 through 2-154 2-151 through 2-1542-185 and 2-186 2-185 and 2-1862-197 and 2-198 2-197 and 2-1982-207 through 2-210 2-207 through 2-2102-255 and 2-256 2-255 and 2-2563-14.1 and 3-14.2 3-14.1 and 3-14.24-9 and 4-10 4-9 and 4-104-13 and 4-14 4-13 and 4-144-42.3 and 4-42.4 4-42.3 and 4-42.4
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
38/1296
TM 55-1520-210-23-1C33
Remove pages Insert pages
4-49 and 4-50 4-49 and 4-504-73 and 4-74 4-73 and 4-744-78.1/(4-78.2 blank) 4-78.1/(4-78.2 blank)4-85 and 4-86 4-85 and 4-864-93 and 4-94 4-93 and 4-944-97 and 4-98 4-97 and 4-985-9 and 5-10 5-9 and 5-105-40.1/(5-40.2 blank) 5-40.1/(5-40.2 blank)5-41 and 5-42 5-41 and 5-425-51 and 5-52 5-51 and 5-525-57 through 5-60 5-57 through 5-60
5-60.1/(5-60.2 blank)5-65 and 5-66 5-65 and 5-665-83 and 5-84 5-83 and 5-845-103 and 5-104 5-103 and 5-1045-121 and 5-122 5-121 and 5-1225-124.1/(5-124.2 blank) 5-124.1/(5-124.2 blank)5-147 through 5-150 5-147 through 5-150
5-158.1 and 5-158.2 5-158.1 and 5-158.25-159 and 5-160 5-159 and 5-1606-1 and 6-2 6-1 and 6-26-37 and 6-38 6-37 and 6-386-51 and 6-52 6-51 and 6-526-59 and 6-60 6-59 and 6-606-93 and 6-94 6-93 and 6-946-99 through 6-102 6-99 through 6-1026-115 and 6-116 6-115 and 6-1166-116.3 and 6-116.4 6-116.3 and 6-116.46-121 and 6-122 6-121 and 6-1226-128.11/(6-128.2 blank)6-129 and 6-130 6-129 and 6-130
6-141 and 6-142 6-141 and 6-1426-147 and 6-148 6-147/(6-148 blank)6-149 through 6-152 6-149 through 6-1526-159 and 6-160 6-159 and 6-1606-165 and 6-166 6-165 and 6-1666-166.1 and 6-166.2 6-166.1 and 6-166.2
Electronic 2028 Instructions
2. Retain these sheets in front of manual for reference purposes.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
39/1296
TM 55-1520-210-23-1C33
By Order of the Secretary of the Army:
DENNIS J. REIMERGeneral, United States Army
Official: Chief of Staff
JOEL B. HUDSONAdministrative Assistant to the
Secretary of the Army 02663
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for TM 55-1520-210-23-1.
SIGN
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
40/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
41/1296
URGENTTM 55-1520-210-23-1
C32
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 32 WASHINGTON, D.C., 12 August 1996
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1HNIEH-1H/XHELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimitedTM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar in themargin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
1-99 and 1-100 1-99 and 1-100
5-109 and 5-110 5-109 and 5-110
5-135 and 5-136 5-135 and 5-136
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:DENNIS J. REIMER
General, United States Army Official: Chief of Staff
JOEL B. HUDSONAdministrative Assistant to the
Secretary of the Army 02157
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for TM 55-1520-210-23-1.
SIGN
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
42/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
43/1296
TM 55-1520-210-23-1C31
U R G E N T
CHANGE
NO. 31
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 1 January 1996
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X HELlCOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar inthe margin. An illustration change is indicated by a miniature pointing hand.
Remove pages
i and ii1-105 through 1-110
4-13 and 4-144-43 and 4-44
4-60.1 through 4-60.7/(4-60.8 blank)4-97 and 4-985-91 and 5-925-103 and 5-1046-29 and 6-306-41 through 6-446-44.1 through 6-44.46-167 and 6-1686-171 and 6-172Index-5 and Index-6
Insert pages
i and ii1-105 through 1-110
1-115 through 1-125/(1-126 blank)4-13 and 4-144-43 and 4-444-44.1/(4-44.2 blank)4-60.1 through 4-60.84-97 and 4-985-91 and 5-925-103 and 5-1046-29 and 6-306-41 through 6-446-44.1 through 6-44.5/(6-44.6 blank)6-167 and 6-1686-171 and 6-172Index-5 and Index-6
2. Retain this sheet in front of manual for reference purposes.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
44/1296
TM 55-1520-210-23-1
By Order of the Secretary of the Army:
DENNIS J. REIMERGeneral, United States Army
Official: Chief of Staff
JOEL B. HUDSONAdministrative Assistant to the
Secretary of the Army 01331
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for TM 55-1520-210-23-1.
SIGN
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
45/1296
TM 55-1520-210-23-1
C 30
CHANGE
NO. 30
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 31 July 1995
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELlCOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical barin the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
1-33 and 1-34 1-33 and 1-34
Index 5 and Index 6 Index 5 and Index 6
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Acting Administrative Assistant to the
Secretary of the Army 00362
DENNIS J. REIMER
General, United States Amy Chief of Staff
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for
TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
46/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
47/1296
URGENT
CHANGE
NO. 29
TM 55-1520-210-23-1
C 2 9
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D. C., 12 December 1994
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELICOPTERS
DISTRIBUTlON STATEMENT A: Approved for PUNIC release; distribution is unlimited.
TM 55-1520-210-23-1,30 September 1987, is changed as follows
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar
in the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
1-109 and 1-110 1-109 and 1-110
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
GORDON R. SULLIVANGeneral, United States Army
Chief of Staff Official:
Administrative Assistant to the
Secretary of the Army 07781
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for
TM 55-1520-210-23-1.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
48/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
49/1296
URGENTTM 55-1520-210-23-1
C 28
CHANGE
NO. 28
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 23 September 1994
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V /EH-1H/X
H E L l C O P T E R S
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited
TM 55-1520-210-23-1,30 September 1994, is changed as follows
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar
in the margin. An illustration change is indicated by a miniature pointing hand.
Remove pages
1-109 and 1-110
4-83 through 4-66
5-13 and 5-14
5-21 and 5-22
5-32.1 and 5-32.2
5-33 and 5-34
5-37 and 5-38
5-85 and 5-86
Insert pages
1-109 and 1-110
4-83 through 4-86
5-13 and 5-14
5-21 and 5-22
5-32.1 through 5-32.3/(5-32.4 blank)
5-33 and 5-34
5-37 and 5-38
5-85 and 5-86
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
Administrative Assistant to the
Secretary of the Army
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
0 6 7 5 4
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for
TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
50/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
51/1296
URGENTNOTICE : THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE, ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
RENT PAGE.
TM 55-1520-210-23-1
C 27
CHANGE
NO. 27
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 2 June 1993
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is
indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
1-99 and 1-100 1-99 and 1-100
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
MILTON H. HAMILTON
Administrative Assistant to the
Secretary of the Army 03959
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, require-
ments for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
52/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
53/1296
URGENT
NOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULDBE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCEDCHANGE ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
RENT PAGE.
CHANGE
NO. 26
TM 55-1520-210-23-1C 26
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 15 January 1993
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is
indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
P-1 and P-2 P-1 and P-2
i and ii i and ii
1-111 through 1-114 1-111 through 1-114
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
MILTON H. HAMILTON
Administrative Assistant to the
Secretary of the Army 02942
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, require-
ments for TM 55-1520-210-23-1.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
54/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
55/1296
URGENTTM 55-1520-210-23-1
C 25
NOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. ITSHOULD BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THEEARLIER SEQUENCED CHANGE ENSURE A MORE CURRENT CHANGE PAGE IS NOTREPLACED WITH A LESS CURRENT PAGE.
C H A N G E
NO. 25
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 15 December 1992
Aviation Unit and Intermediate
Maintenance Instructions
Army Model UH-1H/V/EH-1H/X
DISTRIBUTION STATEMENT A.
Helicopters
Approved for public release; distribution is unlimited
TM 55-1520-210-23-1,30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is indicated by a vertical bar in themargin. An illustration change is indicated by a miniature pointing hand.
Remove pages Insert pages
1-109 and 1-110 1-109 and 1-1101-111 and 1-112 1-111 and 1-1121-113 and 1-114 1-113 and 1-114
4-78.1/(4-78.2 Blank)4-79 and 4-80 4-79 and 4-802028’s and Envelopes 2028’s and Envelopes
2. Retain this sheet in front of manual for reference purposes.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
56/1296
TM 55-1520-210-23-1C 25
By Order of the Secretary of the Army:
Official:
MILTON H. HAMILTON
Administrative Assistant to the
Secretary of the Army 02983
GORDON R. SULLIVAN
General, United States Army Chief of Staff
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, requirements for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
57/1296
TM 55-1520-210-23-1
C 24
CHANGE
NO. 24
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 30 NOVEMBER 1992
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material is
indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
1-5 through 1-10----
1-11 through 1-14
1-17 and 1-18
1-21 and 1-22
1-27 through 1-30
1-30.1 through 1-30.4
1-31 through 1-36
1-81 and 1-82
1-82.1 and 1-82.2
1-103 and 1-104
1-107 and 1-108
2-53 and 2-54
2-115 and 2-116
2-185 and 2-186
2-233 and 2-234
2-255 and 2-256
3-14.1/(3-14.2 blank)
3-15 and 3-16
4-42.1 and 4-42.2
4-42.4.1 and 4-42.4.2
4-42.5 and 4-42.6
4-53 through 4-56
4-57 through 4-60
4-60.1 through 4-60.64-71 and 4-72
4-97 and 4-98
5-38.1 and 5-38.2
5-53 and 5-54
1-5 through 1-10
1-10.1/(1-10.2 blank)
1-11 through 1-14
1-17 and 1-18
1-21 and 1-22
1-27 through 1-30
1-30.1 through 1-30.4
1-31 through 1-36
1-81 and 1-82
1-82.1 and 1-82.2
1-103 and 1-104
1-107 and 1-108
2-53 and 2-54
2-115 and 2-116
2-185 and 2-186
2-233 and 2-234
2-255 and 2-256
3-14.1 and 3-14.2
3-15 and 3-16
4-42.1 and 4-42.2
4-42.4.1 and 4-42.4.2
4-42.5 and 4-42.6
4-53 through 4-56
4-57 through 4-60
4-60.1 through 4-60.64-71 and 4-72
4-85 and 4-86
4-97 and 4-98
5-38.1 and 5-38.2
5-53 and 5-54
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
58/1296
TM 55-1520-210-23-1
C 24
Remove pages Insert pages
5-65 and 5-66
5-81 and 5-82
5-121 and 5-122
5-127 and 5-128
5-130.1/(5-130.2 blank)
6-47 and 6-48
6-51 and 6-52
6-55 through 6-58
6-83 and 6-84
6-84.1 and 6-84.2
6-85 and 6-86
6-93 and 6-94
6-103 through 6-106
6-115 and 6-116
6-116.1 and 6-116.2
6-127 and 6-128
6-141 and 6-142
6-149 through 6-152----
6-159 and 6-160
6-163 and 6-164
6-167 and 6-168
6-171 and 6-172
6-172.1 through 6-172.3/
(6-172.4 blank)
5-65 and 5-66
5-81 and 5-82
5-121 and 5-122
5-127 and 5-128
5-130.1/(5-130.2 blank)
6-47 and 6-48
6-51 and 6-52
6-55 through 6-58
6-83 and 6-84
6-84.1 and 6-84.2
6-85 and 6-86
6-93 and 6-94
6-103 through 6-106
6-115 and 6-116
6-116.1 and 6-116.2
6-127 and 6-128
6-141 and 6-142
6-149 through 6-152
6-158.1/(6-158.2 blank)
6-159 and 6-160
6-163 and 6-164
6-167 and 6-168
6-171 and 6-1726-172.1 through 6-172.3/
(6-172.4 blank)
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Arrny:
Official:
Administrative-Assistant to the
Secretary of the Army
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
07327
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, require-
ments for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
59/1296
URGENT
CHANGE
NO. 23
NOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULDBE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
RENT PAGE.
TM 55-1520-210-23-1
C 23
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 15 October 1992
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages
2-233 and 2-234- - - -
2-255 and 2-256
4-53 and 4-54
5-81 and 5-82
6-127 and 6-128- - - -
6-141 and 6-142
6-165 and 6-166
2. Retain this sheet in
By Order of the Secretary of the Army:
Insert pages
2-233 and 2-234
2-234.1/2-234.2
2-255 and 2-256
4-53 and 4-54
5-81 and 5-82
6-127 and 6-128
6-128.1/6-128.2
6-141 and 6-142
6-165 and 6-166
front of manual for reference purposes.
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
MILTON H. HAMILTONAdministrative Assistant to the
Secretary of the Army 02517
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, require-
ments for TM 55-1520-210-23-1.
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
60/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
61/1296
CHANGE
NO. 22
TM 55-1520-210-23-1C 22
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 31 MARCH 1993
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
DISTRIBUTION STATEMENT A: Approved
HELICOPTERS
for public release; distribution is unlimited.
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material isindicated by a vertical bar in the margin. An illustration change is indicatedby a miniature pointing hand.
Remove pages Insert pages
1-5 through 1-10
1-15 through 1-181-23 and 1-241-29 and 1-301-30.1 through 1-30.41-41 and 1-421-51 and 1-521-65 and 1-661-95 and 1-961-99 and 1-1001-105 and 1-1062-15 through 2-202-23 and 2-242-33 and 2-34
2-53 and 2-542-69 and 2-702-99 and 2-1002-103 and 2-1042-143 and 2-1442-149 through 2-1522-195 and 2-196
2-213 and 2-2142-253 and 2-2543-3 and 3-43-4.1/(3–4.2 blank)3-5 and 3-64-27 and 4-284-42.5 and 4-42.64-49 and 4-504-53 through 4-564-57 and 4-584-61 and 4-624-71 through 4-74
1-5 through 1-10
1-15 through 1-181-23 and 1-241-29 and 1-301-30.1 through 1-30.41-41 and 1-421-51 and 1-521-65 and 1-661-95 and 1-961-99 and 1-1001-105 and 1-1062-15 through 2-202-23 and 2-242-33 and 2-34
2-53 and 2-542-69 and 2-702-99 and 2-1002-103 and 2-1042-143 and 2-1442-149 through 2-1522-195 and 2-1962-213 and 2-2142-253 and 2-2543-3 and 3-43-4.1/(3-4.2 blank)3–5 and 3-64-27 and 4-284-42.5 and 4-42.64-49 and 4-504-53 through 4-564-57 and 4-584-61 and 4-624-71 through 4-74
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
62/1296
TM 55-1520-210-23-1C 22
Remove pages Insert pages
4-77 and 4-784-85 and 4-864-97 and 4-985-5 and 5-65-19 through 5-225-29 and 5-305-30.1/(5-30.2 blank)5-31 and 5-325-54.13 and 5-54.145-67 and 5-685-69 through 5-725-75 and 5-765-83 and 5-845-101 and 5-1025-109 and 5-1105-113 and 5-1145-117 and 5-1185-123 and 5-1245-125 through 5-130
5-131 and 5-1325-153 and 5-1545-158.1 and 5-158.25-159 and 5-1606-9 and 6-106-13 and 6-146-17 through 6-226-29 and 6-30
—---
6-35 through 6-386-41 and 6-426-44.3/(6-44.4 blank)6-47 and 6-48
6-55 through 6-586-65 and 6-666-73 through 6-84
----
6-85 through 6-906-93 through 6-1046-115 and 6-1166-116.1 and 6-116.26-116.5 and 6-116.66-123 and 6-1246-139 and 6-1406-145 and 6-1466-147 and 6-148
6-148.1/(6-148.2 blank)6-149 through 6-1566-161 through 6-1646-166.1 and 6-166.26-169 and 6-170
4-77 and 4-784-85 and 4-864-97 and 4-985-5 and 5-65-19 through 5-225-29 and 5-305-30.1/(5-30.2 blank)5-31 and 5-325-54.13 and 5-54.145-67 and 5-685-69 through 5-725-75 and 5-765-83 and 5-845-101 and 5-1025-109 and 5-1105-113 and 5-1145-117 and 5-1185-123 and 5-1245-125 through 5-130
5-131 and 5-1325-153 and 5-1545-158.1 and 5-158.25-159 and 5-1606-9 and 6-106-13 and 6-146-17 through 6-226-29 and 6-306-34.1/(6-34.2 blank)6-35 through 6-386-41 and 6-426-44.3 and 6-44.46-47 and 6-48
6-55 through 6-586-65 and 6-666-73 through 6-846-84.1 and 6-84.26-85 through 6-906-93 through 6-1046-115 and 6-1166-116.1 and 6-116.26-116.5 and 6-116.66-123 and 6-1246-139 and 6-1406-145 and 6-1466-147 and 6-148
----
6-149 through 6-1566-161 through 6-1646-166.1 and 6-166.26-169 and 6-170
2. Retain these sheets in front of manual for reference purposes.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
63/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
64/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
65/1296
URGENTNOTICE : THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE ENSURE
RENT PAGE.
A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
CHANGE
NO. 21
TM 55-1520-210-23-1
C21
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 15 JANUARY 1992
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text materialis indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert Pages
1-35 and 1-36 1-35 and 1-36
6-97 and 6-98 6-97 and 6-98
6-129 and 6-130 6-129 and 6-130
6-133 and 6-134 6-133 and 6-134
6-137 and 6-138 6-137 and 6-138- - - - 6-138.1/6-138.2
6-141 and 6-142 6-141 and 6-142
6-147 and 6-148 6-147 and 6-148- - - - 6-148.1/6-148.2
6-161 and 6-162 6-161 and 6-162
6-165/6-166 6-165 and 6-166- - - - 6-166.1 through 6-166.3/
6-166.4
2. Retain this sheet in front of manual for reference purposes.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
66/1296
TM 55-1520-210-23-1
C21
By Order of the Secretary of the Army:
MILTON H. HAMILTON
Administrative Assistant to the
Secretary of the Army 00359
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
DISTRIBUTION
To be distributed in accordance with DA Form 12-31-E, block no, 1408, AVUM and
AVIM maintenance requirements for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
67/1296
URGENT
NOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE ENSURE
RENT PAGE.
A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
CHANGE
NO. 20
TM 55-1520-210-23-1
C 20
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 1 July 1991
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text materialis indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
4-85 and 4-86 4-85 and 4-86
5-4.1 and 5-4.2 5-4.1 and 5-4.2
2* Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
PATRICIA P. HICKERSONColonel, United States Army
The Adjutant General
CARL E. VUONOGeneral, United States Army
Chief of Staff
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, AVUM and
AVIM maintenance requirements for TM 55-1520-210-23-1.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
68/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
69/1296
TM 55-1520-210-23-1
C 19
CHANGE
NO. 19
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 14 June 1991
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
1-3 and 1-41-15 through 1-18
1-30.3 and 1-30.4
1-33 and 1-341-55 and 1-56
1-60.1 and 1-60.2
1-61 and 1-62
1-75 through 1-82
1-82.1 and 1-82.2
1-87 and 1-881-99 and 1-100
1-105 through 1-108
2-9 and 2-10
2-107 and 2-108
2-120.1/2-120.2
2-121 and 2-122
2-129 and 2-130- - - -
2-145 and 2-146
2-151 and 2-152
2-179 and 2-180
2-197 and 2-198
2-209 through 2-212
3-4.1/3-4.2
4-3 through 4-6
4-13 and 4-14
4-41 and 4-42
4-42.3 and 4-42.4
4-43 through 4-46
4-57 through 4-60- - - -
4-73 and 4-74
4-77 and 4-78
4-97 through 4-1004-111 and 4-112
1-3 and 1-4
1-15 through 1-18
1-30.3 and 1-30.4
1-33 and 1-341-55 and 1-561-60.1 and 1-60.2
1-61 and 1-621-75 through 1-82
1-82.1 and 1-82.21-87 and 1-881-99 and 1-100
1-105 through 1-108
2-9 and 2-10
2-107 and 2-108
2-120.1 and 2-120.2
2-121 and 2-122
2-129 and 2-1302-130.1/2-130.2
2-145 and 2-146
2-151 and 2-152
2-179 and 2-180
2-197 and 2-198
2-209 through 2-212
3-4.1/3-4.24-3 through 4-6
4-13 and 4-14
4-41 and 4-42
4-42.3 and 4-42.4
4-43 through 4-46
4-57 through 4-604-60.1 through 4-60.7/4-60.8
4-73 and 4-74
4-77 and 4-78
4-97 through 4-100
4-111 and 4-112
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
70/1296
TM 55-1520-210-23-1
C 19
Remove pages Insert pages
5-15 and 5-16
5-32.1 and 5-32.2
5-33 and 5-34
5-43 and 5-44
5-79 through 5-82
5-101 through 5-1045-115 through 5-118
5-155 and 5-156
5-158.1/5-158.2
6-29 and 6-30
6-37 through 6-44--- -
6-45 through 6-48
6-55 through 6-58
6-59 and 6-60--- --
6-67 and 6-68
6-71 through 6-74
6-79 through 6-866-97 through 6-100
6-103 through 6-108
6-115 and 6-116
6-116.3 and 6-116.4
6-137 and 6-138
6-138.1/6-138.2
6-139 through 6-142
6-145 and 6-146- - - -
6-147 and 6-148
6-149 through 6-154
6-163 and 6-164
6-167 through 6-172- - - -
6-173/6-174Index 1 through Index 14
5-15 and 5-16
5-32.1 and 5-32.2
5-33 and 5-34
5-43 and 5-44
5-79 through 5-82
5-101 through 5-1045-115 through 5-118
5-155 and 5-156
5-158.1 and 5-158.2
6-29 and 6-30
6-37 through 6-44
6-44.1 through 6-44.3/6-44.4
6-45 through 6-48
6-55 through 6-58
6-59 and 6-60
6-60.1/6-60.2
6-67 and 6-68
6-71 through 6-74
6-79 through 6-86
6-97 through 6-100
6-103 through 6-108
6-115 and 6-116
6-116.3 and 6-116.4
6-138 and 6-1386-138.1 through 6-138.3/
6-138.46-139 through 6-142
6-145 and 6-146
6-146.1 and 6-146.2
6-147 and 6-148
6-149 through 6-154
6-163 and 6-164
6-167 through 6-172
6-172.1 through 6-172.3/
6-172.46-173 and 6-174
Index 1 through Index 14
2. Retain these sheets in front of manual for reference purposes.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
71/1296
TM 55-1520-210-23-1
C 19
By Order of the Secretary of the Army:
MILTON H. HAMILTON
Administrative Assistant to the
Secretary of the Army
01748
GORDON R. SULLIVAN
General, United States Army
Chief of Staff
DISTRIBUTION:To be distributed in accordance with DA Form 12-31-E, block no. 1408, AVUM and
AVIM maintenance requirements for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
72/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
73/1296
URGENT
CHANGE
NO. 18
TM 55-1520-210-23-1
C 18
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 14 May 1991
AVIATION UNIT AND INTERMEDIATEMAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change
by a miniature pointing hand.
is indicated
Remove pages
1-109 through 1-1
5-147 and 5-148
5-159 and 5-160
2. Retain this sheet
Insert pages
1414 1-109 through 1-
5-147 and 5-148
5-159 and 5-160
in front of manual for reference purposes.
By order of the Secretary of the Army:
CARL E. VUONOGeneral, United States Army
Official: Chief of Staff
PATRICIA P. HICKERSONColonel, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, AVUM
and AVIM maintenance requirements for TM 55-1520-210-23-1.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
74/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
75/1296
URGENTNOTICE : THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
RENT PAGE.
TM 55-1520-210-23-1
C 17
CHANGE HEADQUARTERS
DEPARTMENT OF THE ARMY
NO. 17 WASHINGTON, D.C., 28 February 1991
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text materialis indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
4-41 and 4-42 4-41 and 4-42
4-42.3 and 4-42.4 4.42.3 and 4-42.4
4-42.4.1 and 4-42.4.2 4-42.4.1 and 4-42.4.2
4-42.5 and 4-42.6 4-42.5 and 4-42.6
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
THOMAS F. SIKORA Brigadier General, United States Army
The Adjutant General
CARL E. VUONOGeneral, United States Army
Chief of Staff
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no 1408, AVUM and
AVIM maintenance requirements for TM 55-1520-210-23-1.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
76/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
77/1296
URGENT
NOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
RENT PAGE.
TM 55-1520-210-23-1
C 16
CHANGE
NO. 16
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 11 December 1990
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text materialis indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
4-42.3 and 4-42.4 4-42.3 and 4-42.4
4-42.4.1 and 4-42.4.2 4-42.4.1 and 4-42.4.2
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
official:
CARL E. VUONOGeneral, United States Army
Chief of Staff
THOMAS F. SIKORA
Brigadier General, United States Army The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
requirements for UH-1H, UH-1V Helicopter, Utility, EH-1H Helicopter, Electronic
Countermeasure, and EH-1X Helicopter, Electronic Countermeasure and Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
78/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
79/1296
URGENT
NOTICE : THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULDBE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED CHANGE
ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CURRENT PAGE.
TM 55-1520-210-23-1C 15
CHANGE HEADQUARTERSDEPARTMENT OF THE ARMY
NO. 15 WASHINGTON, D.C., 1 SEPTEMBER 1990
AVIATION UNIT AND INTERMEDIATE
MAINTENANCE INSTRUCTIONS
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed
is indicated by a vertical bar in the margin. An illustration changeby a miniature pointing hand.
Remove pages Insert pages
text material
is indicated
5-91 and 5-92 5-91 and 5-92
5-103 and 5-104 5-103 and 5-104
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
official:
THOMAS F. SIKORA Brigadier General, United States Army
The Adjutant General
CARL E. VUONO
General,United States Army Chief of Staff
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
requirements for UH-1H, UH-1V Helicopter, Utility and EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
80/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
81/1296
URGENT
NOTICE : THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULDBE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED CHANGE
ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CURRENT PAGE.
TM 55-1520-210-23-1
C 14
CHANGE HEADQUARTERS
DEPARTMENT OF THE ARMY
No. 14 WASHINGTON, D.C., 1 August 1990
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
1-113 and 1-114 1-113 and 1-114
4-42.1 through 4-42.4 4-42.1 through 4-42.4--- - 4-42.4.1 through 4-42.4.4
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
CARL E. VUONO
General, United States Army
Official: Chief of Staff
THOMAS F. SIKORA
Brigadier General, United States Army The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
requirements for UH-1H, UH-1V Helicopter, Utility and EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
82/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
83/1296
URGENTTM 55-1520-210-23-1
C 13
CHANGE
NO. 13
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 1 August 1990
Aviation Unit and IntermediateMaintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
P-1 and P-2 P-1 and P-2
1-11 through 1-22 1-11 through 1-221-25 through 1-30 1-25 through 1-30
1-30.1 through 1-30.5 1-30.1 through 1-30.5/
1-30.6 1-30.6
1-35
1-531-631-751-79
1-83
1-91
1-95
1-99
through 1-38
through 1-56
through 166and 1-76
and 1-80
through 1-86through 1-94
and 1-96
through 1-110
2-1 and 2-22-17 through 2-20
2-31 through 2-36
2-45 and 2-46
2-53 through 2-56
2-69 and 2-70
2-83 through 2-88
2-88.1 and 2-88.2
2-89 and 2-90
2-115 and 2-116
2-119 and 2-120
2-121 and 2-122
2-135 and 2-136
2-139 and 2-1402-143 and 2-144- - - - -
2-151 through 2-154- - - -
2-185 and 2-186
2-193 through 2-1982-205 through 2-218
1-35 through 1-38
1-53 through 1-56
1-63 through 1-66
1-75 and 1-76
1-79 and 1-80
1-83 through 1-86
1-91 through 1-94
1-95 and 1-96
1-99 through 1-110
2-1 and 2-22-17 through 2-20
2-31 through 2-36
2-45 and 2-46
2-53 through 2-56
2-69 and 2-70
2-83 through 2-88
2-88.1 and 2-88.2
2-89 and 2-90
2-115 and 2-116
2-119 and 2-120
2-121 and 2-122
2-135 and 2-136
2-139 and 2-1402-143 and 2-144
2-144.1/2-144.2
2-151 through 2-154
2-182.1/2-182.2
2-185 and 2-186
2-193 through 2-198
2-205 through 2-218
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
84/1296
TM 55-1520-210-23-1
C 13
Remove pages Insert pages
2-229 and 2-230
2-233 and 2-234
2-247 and 2-248
2-255 and 2-256
2-261 and 2-262
2-269 through 2-2723-1 through 3-4- - - - - -
3-5 through 3-8
3-13 and 3-14---- - -
3-17 and 3-18
3-23 and 3-24
4-1 through 4-6
4-13 and 4-14
4-17 and 4-18
4-45 and 4-46
4-53 through 4-56
- - - -4-57 through 4-62
4-67 and 4-68
4-71 through 4-82
4-85 and 4-86
4-89 and 4-90
4-93 through 4-98
4-107 through 4-112
5-1 and 5-2
5-3 and 5-4
5-4.1 and 5-4.2
5-5 and 5-6
5-6.1/5-6.2
5-18.1/5-18.2
5-21 and 5-22
5-32.1 and 5-32.2
5-33 and 5-34
5-38.1 through 548.3/
5 - 3 8 . 45-39 and 5-40
5-40.1/5-40.2
5-41 and 5-42
5-45 through 5-48
5-51 through 5-54
5-54.1 through 5-54.48
5-57 and 5-58
5-61 and 5-62
5-62.15-63 and 5-64
5-64.1/5-64.2
5-65 and 5-66
5-68.1 and 5-68/2
5-71 and 5-72
5-85 and 5-865-103 and 5-104
2-229 and 2-230
2-233 and 2-234
2-247 and 2-248
2-255 and 2-256
2-261 and 2-262
2-269 through 2-272
3-1 through 3-4
3-4.1/3-4.2
3-5 through 3-8
3-13 and 3-14
3-14.1/3-14.2
3-17 and 3-18
3-23 and 3-24
4-1 through 4-6
4-13 and 4-14
4-17 and 4-18
4-45 and 4-46
4-53 through 4-56
4-56.1/4-56.2
4-57 through 4-62
4-67 and 4-68
4-71 through 4-82
4-85 and 4-86
4-89 and 4-90
4-93 through 4-98
4-107 through 4-112
5-1 and 5-2
5-3 and 5-4
5-4.1 and 5-4.2
5-5 and 5-6
5-6.1 and 5-6.2
5-18.1/5-18.2
5-21 and 5-22
5-32.1 and 5-32.2
5-33 and 5-34
5-38.1 through 5-38.3/
5-38.4
5-39 and 5-40
5-40.1/5-40.2
5-41 and 5-42
5-45 through 5-48
5-51 through 5-54
5-54.1 through
5-54.49/5-54.505-57 and 5-58
5-61 and 5-62
5-62.1 and 5-62.2
5-63 and 5-64
5-64.1 and 5-64.2
5-65 and 5-66
5-68.1 and 5-68.2
5-71 and 5-72
5-85 and 5-865-103 and 5-104
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
85/1296
TM 55-1520-210-23-1
C 13
Remove pages Insert pages
5-107 through 5-110
5-113 through 5-116
5-121 through 5-124- - - -
5-125 and 5-126
5-130.1/5-130.25-141 and 5-142
5-147 and 5-148
5-151 and 5-152- - - - -
5-153 and 5-154--- -- -
5-155 through 5-158
5-158.1 and 5-158.2- - - -
5-173 and 5-174
5-183 and 5-184
5-184.1 through 5-184.3/
5-184.4
6-23 through 6-26
6-29 and 6-30--- - -
6-31 and 6-32
6-35 through 6-44
6-47 through 6-58- - — -
6-59 through 6-62
6-71 and 6-72
6-75 and 6-76
6-79 through 6-82
6-85 through 6-88
6-91 through 6-1006-103 and 6-104
6-111 through 6-1166-116.1 through 6-116.5/
6-116.6
6-127 through 6-130
6-133 through 6-138
6-141 through 6-156
6-159 through 6-165/6-166- - - -
5-107 through 5-110
5-113 through 5-116
5-121 through 5-124
5-124.1/5-124.2
5-125 and 5-126
5-130.1/5-130.25-141/5-142
5-147 and 5-148
5-151 and 5-152
5-152.1 and 5-152.2
5-153 and 5-154
5-154.1 and 5-154.2
5-155 through 5-158
5-158.1/5-158.2
5-164.1/5-164.2
5-173 and 5-174
5-183 and 5-184
5-184.1 through 5-184.3/
5-184.4
6-23 through 6-26
6-29 and 6-30
6-30.1/6-30.2
6-31 and 6-32
6-35 through 6-44
6-47 through 6-58
6-58.1/6-58.2
6-59 through 6-62
6-71 and 6-72
6-75 and 6-76
6-79 through 6-82
6-85 through 6-88
6-91 through 6-100
6-103 and 6-104
6-111 through 6-116
6-116.1 through 6-116.6
6-127 through 6-130
6-133 through 6-138
6-141 through 6-156
6-159 through 6-165/6-166
Index 1 through Index 14
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
86/1296
TM 55-1520-210-23-1
C 13
By Order of the Secretary of the Army:
Official:
CARL E. VUONO
General, United States Army Chief of Staff
THOMAS F. SIKORA Brigadier General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31-E, block no. 1408, AVUM and
AVIM maintenance requirements for TM 55-1520-210-23-1.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
87/1296
URGENT
CHANGE
NO. 12
TM 55-1520-210-23-1C 12
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 12 April 1990
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/XHELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
1-99 and 1-100 1-99 and 1-100
1-103 and 1-104 1-103 and 1-104
1-111 through 1-114 1-111 through 1-114----- 5-18.1/5-18.22. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
CARL E. VUONO
General, United States Army Chief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States Army The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
instructions for UH-1H, UH-1V Helicopter, Utility and EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
88/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
89/1296
URGENTNOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULDBE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED CHANGEENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CURRENT PAGE.
TM 55-1520-210-23-1
C 11
CHANGE
NO. 11
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 1 March 1990
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text materialis indicated by a vertical bar in the margin. An illustration change is indicatedby a miniature pointing hand.
Remove pages Insert pages
5-17 through 5-20 5-17 through 5-205-31 and 5-32 5-31 and 5-32
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
CARL E. VUONOGeneral, United States Army
Chief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States Army The Adjutant General
DISTRIBUTION:To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
instructions for UH-1H, UH-1V Helicopter, Utility and EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
90/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
91/1296
URGENTNOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED
CHANGE ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CUR-
RENT PAGE.
TM 55-1520-210-23-1
C 10
CHANGE
NO. 10
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 31 January 1990
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text materialis indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
5-72.5 and 5-72.6 5-72.5 and 5-72.6
5-73 and 5-74 5-73 and 5-74
5-103 through 5-106 5-103 through 5-106
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
CARL E. VUONO
General, United States Army Chief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenanceinstructions for UH-1H, UH-1V Helicopter, Utility, EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
92/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
93/1296
URGENT
NOTICE: THIS CHANGE HAS BEEN PRINTED AND DISTRIBUTED OUT OF SEQUENCE. IT SHOULD
BE INSERTED IN THE MANUAL AND USED. UPON RECEIPT OF THE EARLIER SEQUENCED CHANGE
ENSURE A MORE CURRENT CHANGE PAGE IS NOT REPLACED WITH A LESS CURRENT PAGE.
CHANGE
NO. 9
TM 55-1520-210-23-1
C 9
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 31 January 1990
Aviation Unit and intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
5-21 and 5-22 5-21 and 5-22
5-31 and 5-32 5-31 and 5-32
5-32.1 and 5-32.2 5-32.1 and 5-32.25-33 and 5-34 5-33 and 5-34----- 5-34.1/5-34.2
5-63 and 5-64 5-63 and 5-64
5-65 and 5-66 5-64 and 5-66
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
CARL E. VUONO
General, United States Army
Chief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
requirements for UH-1H, UH-1V Helicopter? Utility and EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
94/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
95/1296
TM 55-1520-210-23-1
C 8
CHANGE
NO. 8
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 2 January 1990
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
i through iii iv
P-1 and P-2
1-9 and 1-10
1-13 through 1-30- - - -
1-37 through 1-40- - - -
1-51 and 1-52
1-55 and 1-56
1-59 and 1-60- - - -
1-61 and 1-62
1-65 and 1-661-69 and 1-70
1-105 and 1-106
1-109 and 1-1105-1 and 5-2
5-3 and 5-4
5-4.1 and 5-4 2
5-5 and 5-6
5-9 through 5-12
5-15 and 5-16/
5-22.1 and 5-22.25-23 through 5-28
5-28.3/5-28.4
5-29 and 5-30
5-30.1/5-30.2
5-35 and 5-365-40.1/5-40.2
5-41 through 5-44
5-47 through 5-50
5-53 and 5-54
5-54.1/5-54.2
5-55 through 5-62
i through iii/iv
P-1 and P-2
1-9 and 1-10
1-13 through 1-30
1-30.1 through 1-30.5/1-30.6
1-37 through 1-40
1-42.1/1-42.2
1-51 and 1-52
1-55 and 1-56
1-59 and 1-60
1-60.1 and 1-60.2
1-61 and 1-62
1-65 and 1-66
1-69 and 1-70
1-105 and 1-106
1-109 and 1-1105-1 and 5-2
5-3 and 5-4
5-4.1 and 5-4.2
5-5 and 5-6
5-6.1/5-6.2
5-9 through 5-12
5-15 and 5-16
5-22.1 and 5-22.2
5-23 through 5-28
5-28.3/5-28.4
5-29 and 5-30
5-30.1 and 5-30.2
5-35 and 5-365-40.1/5-40.2
5-41 through 5-44
5-47 and 5-48
5-53 and 5-54
5-54.1 through 5-54.48
5-55 through 5-62
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
96/1296
Remove pages Insert pages
5-65 through 5-68
5-68.1 and 5-68.2
5-69 through 5-72
5-79 and 5-80
5-87 and 5-88
5-97 through 5-1005-107 and 5-108
5-113 through 5-118
5-118.1/5-118.2 ,
5-119 and 5-120
5-127 through 5-130 ‘
5-130.1/5-130.2-
5-135 through 5-138
5-141 and 5-142
5-151 through 5-158- - - -
5-183 and 5-184- - - -
5-65 through 5-68
5-68.1 and 5-68.2
5-69 through 5-72
5-79 and 5-80
5-87 and 5-88
5-97 through 5-1005-107 and 5-108
5-113 through 5-118--- -
5-119 and 5-120
5-127 through 5-130
5-130.1/5-130.2
5-135 through 5-138
5-141 and 5-142
5-151 through 5-158
5-158.1 and 5-158.2
5-183 and 5-184
5-184.1 through 5-184.3/5-184.4
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
WILLIAM J. MEEHAN 11
Brigadier General, United States Army
The Adjutant General
CARL E. VUONO
General, United States ArmyChief of Staff
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
requirements for JH-1H, UH-1V Helicopter, Utility and EH-1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure and Intercept.
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
97/1296
CHANGE
NO. 7
Official:
TM 55-1520-210-23-1
C 7
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 30 November 1989
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
5-85 and 5-86 5-85 and 5-86
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
CARL E. VUONO
General, United States ArmyChief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States Army
The Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenance
Requirements for UH-1H, UH-1V Helicopter, Utility and EH-1H Helicopter,
Electronic Countermeasure and EH-1X Helicopter, Electronic Countermeasure and
Intercept.
U R G E N T
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
98/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
99/1296
CHANGE
NO. 6
URGENT TM 55-1520-210-23-1C 6
HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 17 November 1989
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM 55-1520-210-23-1, 30 September 1987, is changed as follows:
1. Remove and insert pages as indicated below. New or changed text material
is indicated by a vertical bar in the margin. An illustration change is indicated
by a miniature pointing hand.
Remove pages Insert pages
5-83 and 5-84 5-83 and 5-84---- 5-84.1/5-84.2
2. Retain this sheet in front of manual for reference purposes.
By Order of the Secretary of the Army:
Official:
CARL E. VUONO
General, United States ArmyChief of Staff
WILLIAM J. MEEHAN II
Brigadier General, United States ArmyThe Adjutant General
DISTRIBUTION:
To be distributed in accordance with DA Form 12-31, AVUM and AVIM Maintenanceinstructions for UH-1H, UH-1V Helicopter, Utility and EH–1H Helicopter, Electronic
Countermeasure and EH-1X Helicopter, Electronic Countermeasure & Intercept.
URGENT
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
100/1296
8/16/2019 57700507-TM-55-1520-210-23-1.pdf
101/1296
CHANGE
NO. 5
URGENT TM 55-1520-210-23-1c 5
HEADQUARTERSDEPARTMENT OF THE ARMY
WASHINGTON, D.C., 06 October 1989
Aviation Unit and Intermediate
Maintenance Instructions
ARMY MODEL UH-1H/V/EH-1H/X
HELICOPTERS
TM