750
721D : CASE WHEEL LOADER (NORTH AMERICA) 02-01 - MOUNTING, ENGINE Page 1 of 2
| Date post: | 06-Nov-2015 |
| Category: |
Documents |
| Upload: | johannaquevedo79 |
| View: | 513 times |
| Download: | 19 times |
721D : CASE WHEEL LOADER (NORTH AMERICA)02-01 - MOUNTING, ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-01 - MOUNTING, ENGINE
Page 2 of 2
2 2 8602302 ENGINE MOUNT 17,5 x 30 x 4 mm; Front
3 1 8602303 ENGINE MOUNT Right Rear
4 1 8602304 ENGINE MOUNT M16 x 110; 10.9; Left Rear
5 14 896-11012 WASHER M13.5 x 24.5 x 3, HT,
6 14 627-12045 BOLT Hex, M12 x 45, 10.9, Full Thd,
7 4 361811A1 ISOLATOR Rear
8 8 496-81025 WASHER 21/32" x 2 1/2" x .188", HDN,
9 4 827-16120 BOLT Hex, M16 x 120, 10.9,
10 4 896-11016 WASHER M17.5 x 30 x 4, HT, 17.5 x 16.7 x 4.8 mm
11 4 829-1416 NUT M16, Cl 10, No Longer Used For This Application
11 4 832-10416 LOCK NUT M16 x 2, Cl 8,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-02 - RADIATOR - MOUNTING
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)02-02 - RADIATOR - MOUNTING
Page 2 of 3
1 1 8602421 RADIATOR
1A 1 A170241 RADIATOR CAP
2 5 627-8025 BOLT Hex, M8 x 25, 10.9,
3 9 892-11008 LOCK WASHER M8,
4 1 515-22190 CLAMP 3/4", Insul, 5/16" Bolt,
5 5 833-40408 NUT M8, U,
6 5 214-1436 HOSE CLAMP #36, 1.81/2.75 Type F Worm,
6A 1 254026A1 HOSE CLAMP
7 1 8500083 RADIATOR HOSE 44.50 mm ID x 165,105,79,61 mm, SAE 20R4 CLASS D1, Top
8 1 8602655 TUBE Top; If Used
9 3 382189A1 CLAMP
10 1 217-292 FITTING 90, 1/4" Hose x 1/8" NPTF, Barbed,
11 2 214-1704 HOSE CLAMP #4, 0.25/0.62 Type M Worm,
12 3 L18331 CABLE STRAP
13 1 320374A1 HOSE 925 mm ( 36 7/16 in.); Coolant Breather
14 1 8501025 FLEXIBLE HOSE 44.50 mm ID x 110.00 mm, SAE 20R4 Class D1, If Used
15 1 8602661 TUBE Top
16 2 381232A1 HOSE 44.50 mm ID x 87.00 mm, SAE J20R4 Class D1, Elbow
17 3 L115548 CLAMP
18 1 8500907 RADIATOR HOSE 57.20 mm ID x 300,275,95 mm, SAE 20 R4 CLASS D1, Bottom
19 2 393632A1 CLAMP
20 1 8500079 TUBE Bottom; Coolant
21 1 217-152 FITTING 1/2" Hose X 3/8" NPTF Beaded,
22 1 214-1410 HOSE CLAMP #10, 0.56/1.06 Type F Worm,
23 1 217-407 PLUG Hex Hd, 3/8"-18, Used on Models without Heater
24 1 8500085 HOSE 318 mm ( 12 1/2 in.); Remote Coolant Drain
25 1 218-1255 LOCK NUT Blkhd, 3/4"-16, 1/2 Tube
26 1 218-755 CAP 37, 3/4"-16, 1/2" tube
27 1 8500084 HOSE 48.00 mm ID, 57.20 mm ID x 235.00 mm, SAE 20R4 Class D1, Bottom
28 1 217-191 FITTING 1/4" Hose x 1/8" NPTF, Fem, Barbed,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-02 - RADIATOR - MOUNTING
Page 3 of 3
29 1 J911901 VALVE, CHECK
30 1 217-1035 REDUCER FITTING 1/2"-14 Male NPTF x 3/8"-18 Female NPTF,
31 X 345-87 LOCTITE Sealant 592; Used with Items 21, 30
32 1 8500820 PLATE Radiator Drain Back
33 1 382188A2 PLATE Spacer; If Used
34 1 419792A2 SENSOR Coolant Level
35 1 87446948 TUBE Top
36 1 87446950 TUBE Top
37 1 87338366 PLATE Guard; Right
38 5 895-15008 WASHER M8 x 20 x 1.6,
39 4 627-8030 BOLT Hex, M8 x 30, 10.9,
40 1 627-8035 BOLT Hex, M8 x 35, 10.9,
41 1 515-22127 CLAMP 1/2", Insul, 5/16" Bolt, (12.7 mm; M8 Bolt)
42 1 627-8020 BOLT Hex, M8 x 20, 10.9,
43 1 895-11008 WASHER M8 x 16 x 1.6,
44 1 829-1408 NUT M8, Cl 10,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-03 - FAN - BELT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-03 - FAN - BELT
Page 2 of 2
1 1 8500471 FAN Incl. 1A - 1E
1A 4 614-10025 BOLT Hex, M10 x 25, 8.8, Full Thd,
1B 1 8602420 FAN 32 in. Blade
1C 1 8602953 DECAL Engine Side; Not Illustrated
1D 4 8602955 WASHER
1E 1 8604700 HUB
2 1 8602679 BELT 1688.00 mm L, With Air Conditioning
3 1 8602680 BELT 1230.00 mm L, Without Air Conditioning
721D : CASE WHEEL LOADER (NORTH AMERICA)02-04 - COOLANT RECOVERY SYSTEM
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-04 - COOLANT RECOVERY SYSTEM
Page 2 of 2
1 1 A184395 RESERVOIR
2 1 1547924C1 CAP
3 4 627-8025 BOLT Hex, M8 x 25, 10.9,
4 12 895-15008 WASHER M8 x 20 x 1.6,
5 4 832-10408 LOCK NUT M8 x 1.25, Cl 8,
6 1 8602470 PLATE Fan; Left
1 REF INSTRUCTION Guard Fan; Right; See Figure 02-02A
7 3 A171099 HOSE CLAMP
8 1 87541330 HOSE 7.90 mm ID x 695.00 mm, Cut from 31-2855; Reservoir, Drain; Replaces 396120A1 495 mm (19-1/2")
9 4 515-23143 CLAMP 9/16", Insul, 3/8" Bolt,
10 1 8500318 HOSE 2260 mm (89 in); Cut from 31-2855; Coolant Recovery
11 1 198824C1 GROMMET 1/2" ID
12 4 627-8030 BOLT Hex, M8 x 30, 10.9,
13 4 892-11008 LOCK WASHER M8,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-05 - COOLING SYSTEM - MOTOR, DRIVE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-05 - COOLING SYSTEM - MOTOR, DRIVE
Page 2 of 2
STANDARD FAN DRIVE
1 1 400336A1 HYDRAULIC MOTOR
2 1 700-326 ELBOW 90, 13/16"-18 ORFS x M22 x 1.5 ORB, Incl. 3, 4
3 1 238-6014 O-RING -014, 90 Duro, .489" ID x .070" Thk, Face Seal
4 1 637-63153 O-RING Cl 6, 15.3MM ID x 2.2 Thk,
5 1 367870A1 FLEXIBLE HOSE 2327 mm; Brake to Fan Drive
6 1 238-6014 O-RING -014, 90 Duro, .489" ID x .070" Thk, Face Seal
721D : CASE WHEEL LOADER (NORTH AMERICA)02-06 - COOLING SYSTEM - MOTOR, DRIVE
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)02-06 - COOLING SYSTEM - MOTOR, DRIVE
Page 2 of 3
REF INSTRUCTION REVERSIBLE FAN DRIVE
1 1 8500105 HYDRAULIC MOTOR Reversible Fan; Incl. 1A
1A 1 86991683 SEAL KIT Seal; Not Illustrated
2 1 8500471 FAN
3 1 496-21053 WASHER 17/32" x 1 1/16" x .134", (M13.5 x 27 x 3.4)
4 1 232-2448 LOCK NUT 1/2"-20, GC,
5 2 627-12040 BOLT Hex, M12 x 40, 10.9, Full Thd,
6 4 896-11012 WASHER M13.5 x 24.5 x 3, HT,
7 2 832-10412 LOCK NUT M12 x 1.75, Cl 8,
8 1 700-107 HYD CONNECTOR 1 3/16"-12 ORFS x M22 x 1.5 ORB, Incl. 9, 10
9 1 238-6018 O-RING -018, 90 Duro, .739" ID x .070" Thk, Face Seal
10 1 637-63193 O-RING Cl 6, 19.3MM ID x 2.2 Thk, Boss Seal
11 1 8605293 FLEXIBLE HOSE 1140 mm; Fan Forward
12 2 8500186 GROMMET
18 1 700-104 HYD CONNECTOR 1 3/16"-12 ORFS x M27 x 2 ORB, Incl. 19, 20
19 1 238-6018 O-RING -018, 90 Duro, .739" ID x .070" Thk, Face Seal
20 1 637-64236 O-RING Cl 6, 23.6MM ID x 2.9 Thk, Boss Seal
21 1 8605292 FLEXIBLE HOSE 880 mm; Fan Reverse
22 1 700-101 HYD CONNECTOR 11/16"-16 ORFS x M14 x 1.5 ORB, Incl. 23, 24
23 1 238-6012 O-RING -012, 90 Duro, .364" ID x .070" Thk, Face Seal
24 1 637-63113 O-RING Cl 6, 11.3MM ID x 2.2 Thk,
25 1 701-319 ELBOW 90, 11/16"-16 ORFS x 11/16"-16 Fem Sw, Incl. 26
26 1 238-6012 O-RING -012, 90 Duro, .364" ID x .070" Thk, Face Seal
27 1 8500183 FLEXIBLE HOSE 309 mm; Drain
28 1 700-304 ELBOW 90, 11/16"-18 ORFS x M14 x 1.5 ORB, Incl. 29, 30
29 1 238-6012 O-RING -012, 90 Duro, .364" ID x .070" Thk, Face Seal
721D : CASE WHEEL LOADER (NORTH AMERICA)02-06 - COOLING SYSTEM - MOTOR, DRIVE
Page 3 of 3
30 1 637-63113 O-RING Cl 6, 11.3MM ID x 2.2 Thk,
REF INSTRUCTION Fan Relief Valve - If Used
31 1 8500562 HYDRAULIC VALVE Fan Relief; If Used; See Figure 08-09
32 2 827-8090 BOLT Hex, M8 x 90, 10.9,
REF INSTRUCTION Fan Reverser Valve - If Used
33 1 8500563 HYDRAULIC VALVE Fan Reverser; If Used; See Figure 08-09
34 4 814-8140 BOLT Hex, M8 x 140, 8.8,
35 2-4 895-15008 WASHER M8 x 20 x 1.6,
36 2-4 832-10408 LOCK NUT M8 x 1.25, Cl 8,
37 2 700-307 ELBOW 90, 1 3/16"-12 ORFS x M27 x 2 ORB, Incl. 38, 39
38 1 637-64236 O-RING Cl 6, 23.6MM ID x 2.9 Thk, Boss
39 1 238-6018 O-RING -018, 90 Duro, .739" ID x .070" Thk, Face Seal
40 1 701-342 ELBOW 90, 1 3/16"-12 ORFS x 1 3/16"-12 Fem Sw, Incl. 39
721D : CASE WHEEL LOADER (NORTH AMERICA)02-07 - TURBO OUTLET
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-07 - TURBO OUTLET
Page 2 of 2
1 1 4895141 ELBOW Turbo Outlet Air Transfer
2 1 4899087 O-RING Turbo Outlet
3 1 2852407 COLLAR CLAMP Turbo Outlet
4 1 4895098 PLUG 1/8-27 NPTF
721D : CASE WHEEL LOADER (NORTH AMERICA)02-08 - AIR CLEANER - AIR INTAKE PARTS
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-08 - AIR CLEANER - AIR INTAKE PARTS
Page 2 of 2
2 1 8500068 AIR CLEANER See Figure 02-09
3 3 8605331 CLAMP
4 10 896-11010 WASHER M10 x 21.5 x 2.5, HT,
5 8 832-10410 LOCK NUT M10 x 1.5, Cl 8,
6 10 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
7 1 896-11012 WASHER M13.5 x 24.5 x 3, HT,
8 1 627-12030 BOLT Hex, M12 x 30, 10.9,
9 1 8500383 PIPE Intake
10 1 8500403 SEAL
11 1 8501205 INTAKE AIR HOSE 101.60 mm ID x 73.00 mm, SAE J200, 73 mm (2 7/8 in); Air Cleaner
12 1 8602473 TUBE Air Cleaner Intake
13 1 8501206 HOSE 19.05 mm ID x 1050.00 mm, SAE 30R2 Type 1, Crankcase Ventilation
14 4 L127771 CLAMP
15 1 8602478 INTAKE AIR HOSE 101.60 mm ID x 100.00 mm, SAE J200, 100 mm (4 in); Air Cleaner
16 2 214-1416 HOSE CLAMP #16, 0.81/1.50 Type F Worm,
17 2 896-11008 WASHER M8 x 17.5 x 2, HT,
18 2 627-8025 BOLT Hex, M8 x 25, 10.9,
19 1 214-3188 HOSE CLAMP 4.75/5.625 HD Worm,
20 1 L18331 CABLE STRAP
21 896-15010 WASHER M10 x 24.5 x 3, HT,
22 1 8604733 BRACKET Muffler, Air Cleaner; If Used
22 1 87446946 BRACKET Muffler, Air Cleaner; If Used
23 1 87437892 BRACKET Air Cleaner; Replaces 8605495, 8605863, 87433055
1 258541A1 PRECLEANER Air Inlet; Incl. 24-27
24 1 NSS NOT SERVICED SEPARATELY Sleeve Assy.
25 1 L30671 HOUSING
26 1 214-1480 HOSE CLAMP #80, 4.62/5.50 Type F Worm,
27 1 L30669 COVER
721D : CASE WHEEL LOADER (NORTH AMERICA)02-09 - AIR CLEANER ASSY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-09 - AIR CLEANER ASSY
Page 2 of 2
1 8500068 AIR CLEANER Incl. 1 - 6
1 NSS NOT SERVICED SEPARATELY Body
2 1 8605140 AIR FILTER Secondary
3 1 8605139 AIR FILTER Primary
4 1 8605078 O-RING
5 1 8605079 COVER
6 1 8604231 DUST VALVE
7 1 217-1227 ELBOW 90, 1/8"-27 Male,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-10 - MUFFLER - EXHAUST AND INTAKE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-10 - MUFFLER - EXHAUST AND INTAKE
Page 2 of 2
1 8500155 MUFFLER Standard; Replaced By 87454006
1 87454006 MUFFLER Standard; Replaces 8500155
1 1 87319273 MUFFLER Standard; Replaces 87454006
2 8500087 TUBE
2 87363782 TUBE Exhaust; Replaces 8500087
2 1 87516045 TUBE Exhaust; With Flex; Replaces 87363782
3 8 896-11012 WASHER M13.5 x 24.5 x 3, HT,
4 4 627-12035 BOLT Hex, M12 x 35, 10.9,
5 1 J903652 CLAMP
6 1 299456A1 COLLAR CLAMP
7 4 829-1412 NUT M12, Cl 10,
8 1 8500375 EXHAUST SYSTEM PIPE
9 8 895-18010 WASHER M10 x 18 x 1.6,
10 8 832-10410 LOCK NUT M10 x 1.5, Cl 8,
11 1 8500379 PIPE Intake
12 1 8501036 CAP Rain
13 1 408196A1 PLATE Exhaust Backing
14 1 8500382 PLATE Intake Backing
721D : CASE WHEEL LOADER (NORTH AMERICA)02-11 - MUFFLER - EXHAUST SYSTEM
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-11 - MUFFLER - EXHAUST SYSTEM
Page 2 of 2
1 1 8602052 MUFFLER Spark Arresting
2 8500087 TUBE Exhaust
2 87363782 TUBE Exhaust; Replaces 8500087
2 1 87516045 TUBE Exhaust; With Flex; Replaces 87363782
3 8 896-11012 WASHER M13.5 x 24.5 x 3, HT,
4 4 627-12035 BOLT Hex, M12 x 35, 10.9,
5 1 J903652 CLAMP
6 1 299456A1 COLLAR CLAMP
7 4 829-1412 NUT M12, Cl 10,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-12 - ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-12 - ENGINE
Page 2 of 2
1 1 8500044 ENGINE Iveco (504067837); 6.8 L, 6 Cylinder, Tier II; No Longer Available, Order P/N 87433689
1 1 87433689 ENGINE CDC, (604736101); 6.8 L, 6 Cylinder, Tier II; See Figure 02-45 For Engine Block Heater
AR 87433689C CORE-EPA ENGINE Return Number, ENGINE - for N.A. Only
721D : CASE WHEEL LOADER (NORTH AMERICA)02-13 - OIL FILL, ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-13 - OIL FILL, ENGINE
Page 2 of 2
1 1 2852122 TUBE Replaces 504011329
2 1 2852464 DIPSTICK Replaces 504069039
3 1 4899036 PLUG
4 1 4897330 HEX SOCKET PLUG M12 x 1.5, - Assy
5 1 4895610 O-RING M9.3 ID x 2.2 Thk,
6 1 2852377 NECK FILLER
7 2 2852134 FLANGE BOLT Hex, M12 x 1.75 x 25,
8 1 2852135 GASKET
9 1 2852136 CAP Replaces 98429552
721D : CASE WHEEL LOADER (NORTH AMERICA)02-14 - OIL PUMP - ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-14 - OIL PUMP - ENGINE
Page 2 of 2
1 1 4897481 ENGINE OIL PUMP
2 4 4899090 SCREW Hex Flg, M8 x 1.25 x 30,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-15 - OIL FILTER - ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-15 - OIL FILTER - ENGINE
Page 2 of 2
1 1 87803261 ENGINE OIL FILTER
721D : CASE WHEEL LOADER (NORTH AMERICA)02-16 - OIL FILTER AND COOLER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-16 - OIL FILTER AND COOLER
Page 2 of 2
1 15 4899019 SCREW Hex Flg, M8 x 1.25 x 35,
2 1 2853780 ENGINE OIL FILTER Housing Assembly
3 1 2853781 PLUG
4 1 4896404 PLUNGER Plug Pressure Reg.
5 1 4895045 SPRING
6 1 4899035 O-RING M18.39 ID x 2.69 Thk,
7 1 4896410 PRESSURE RELIEF VALVE
8 1 4893391 ADAPTER M24 x 2 x M27 x 2,
9 1 4896407 OIL COOLER If Used
9 1 2853604 OIL COOLER If Used; Radiator
10 1 2830559 GASKET
11 1 4896409 GASKET
721D : CASE WHEEL LOADER (NORTH AMERICA)02-17 - OIL PUMP, PAN
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-17 - OIL PUMP, PAN
Page 2 of 2
1 2 18138424 SCREW Hex Flg, M8 x 1.25 x 20, M8X25
2 32 4899019 SCREW Hex Flg, M8 x 1.25 x 35,
3 1 4898301 GASKET
4 1 2852419 ENGINE OIL PAN
5 1 4894139 PLUG Hex Soc, M22 x 1.5,
6 1 2852420 GASKET
7 1 2852421 STRAINER ELEMENT 207mm from Oil Suction Rose to Top of Bracket
7 1 2852770 STRAINER ELEMENT 215mm from Oil Suction Rose to Top of Bracket
8 1 4895584 O-RING .924" ID x .103" Thk,
9 1 4897330 HEX SOCKET PLUG M12 x 1.5, - Assy; Incl. Ref 10
10 1 4895610 O-RING M9.3 ID x 2.2 Thk,
11 1 2852237 GASKET 26.64 ID x 2.62
12 1 2852238 ELBOW
721D : CASE WHEEL LOADER (NORTH AMERICA)02-18 - OIL PUMP, PAN - DRAIN LINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-18 - OIL PUMP, PAN - DRAIN LINE
Page 2 of 2
1 1 87426452 FITTING 90 deg; Incl. 2, 3
2 1 238-6016 O-RING -016, 90 Duro, .614" ID x .070" Thk, Face Seal
3 1 637-63193 O-RING Cl 6, 19.3MM ID x 2.2 Thk, Boss Seal
4 1 397437A1 FLEXIBLE HOSE 1250 mm (49-1/2 in); Drain
5 1 218-1251 LOCK NUT Blkhd, 7/8"-14,
6 1 218-756 CAP 37, 7/8"-14,
7 1 8602337 COVER Remote Drain; If Used
8 2 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
9 4 895-15010 WASHER M11 x 24 x 2,
10 2 832-10410 LOCK NUT M10 x 1.5, Cl 8,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-19 - BREATHER - ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-19 - BREATHER - ENGINE
Page 2 of 2
1 1 4897534 TUBE
2 1 4897546 RUBBER SLEEVE
3 1 4897547 TUBE
4 1 4897537 SCREW
5 1 4897536 BRACKET
6 2 2852772 BANJO BOLT M12X1.5X30
7 4 4899926 SEALING WASHER
8 1 4899219 TUBE - ASSY
9 1 4898439 O-RING D20.2 SP=2.62
10 3 4899092 SCREW Hex Flg, M6 x 1 x 25,
11 1 4892871 BREATHER
2830592 AIR FILTER Breather
12 2 4893234 HOSE CLAMP
721D : CASE WHEEL LOADER (NORTH AMERICA)02-20 - TURBOCHARGER SYSTEM
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-20 - TURBOCHARGER SYSTEM
Page 2 of 2
1 1 347613A1 AFTERCOOLER
2 1 8605799 TUBE Turbo To Air Cooler; Replaces 8602657
3 1 8605800 TUBE Air Cooler To Intake; Replaces 8500077
4 1 87572378 HOSE Air Intake Hose, 89mm (3 1/2 in), Replaces 87340629, 329736A1
4A 1 87572375 HOSE Air Intake Hose, 89mm (3 1/2 in), Replaces 87340628, 329736A1
5 2 8501051 AIR HOSE 76.20 mm ID x 140.00 mm, Charge Air
6 2 561-703 HEX SOC SCREW M8 x 32.4, 10 x 16mm shldr, Cl 12.9, Elbow
8 1 8602508 MOUNTING PLATE
9 2 8500167 SEAL Air Tubes
10 2 8500144 SEAL
11 2 8500143 SEAL
12 6 892-11008 LOCK WASHER M8,
13 2 627-8016 BOLT Hex, M8 x 16, 10.9,
14 4 627-8025 BOLT Hex, M8 x 25, 10.9,
15 2 386040R1 SPRING Poppet Return
16 6 895-15010 WASHER M11 x 24 x 2,
17 8 L115549 CLAMP
721D : CASE WHEEL LOADER (NORTH AMERICA)02-21 - TURBOCHARGER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-21 - TURBOCHARGER
Page 2 of 2
1 1 2852461 TURBOCHARGER Replaces 504065474
1 2852461R REMAN-TURBOCHARGER Remanufactured TURBOCHARGER, For N.A. Only
1 2852461C CORE-TURBOCHARGER Return Number, For N.A. Only
2 1 4895132 GASKET
3 4 4899086 NUT
4 1 4895098 PLUG
5 1 4899087 O-RING
6 1 4895141 ELBOW
7 1 4899098 NUT M6
8 1 2852407 COLLAR CLAMP
721D : CASE WHEEL LOADER (NORTH AMERICA)02-22 - WATER PUMP
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-22 - WATER PUMP
Page 2 of 2
1 1 4891252 WATER PUMP
2 1 2852047 SEALRING
3 2 4899031 SCREW Hex Flg, M8 x 1.25 x 25,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-23 - WATER PUMP - CONTROL
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-23 - WATER PUMP - CONTROL
Page 2 of 2
1 1 2852398 BELT TENSIONER
2 1 2852396 BELT TENSIONER
3 1 2852397 IDLER
721D : CASE WHEEL LOADER (NORTH AMERICA)02-24 - CYLINDER BLOCK
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-24 - CYLINDER BLOCK
Page 2 of 2
1 1 2830076 CYLINDER BLOCK - ASSY
2 14 4899026 DOWEL M18 x 10 L,
3 3 4895039 EXPANSION PLUG M17.73,
4 6 4895038 EXPANSION PLUG M58.06,
5 3 4895228 EXPANSION PLUG 35.23mm,
6 14 4891353 SCREW Flg Hd, M12 x 1.5 x 120,
7 1 4895040 BUSHING
721D : CASE WHEEL LOADER (NORTH AMERICA)02-25 - CYLINDER BLOCK - PLUG ASSY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-25 - CYLINDER BLOCK - PLUG ASSY
Page 2 of 2
1 6 4896153 PLUG
2 2 4895605 HEX SOCKET PLUG M14 x 1.5, - Assy
3 1 4899115 O-RING M11.3 ID x 2.2 Thk,
4 2 4899009 PLUG M10 x 1.5,
5 1 4899072 O-RING M8.1 ID x 1.6 Thk,
6 2 4895392 HEX SOCKET PLUG M18 x 1.5, - Assy
7 1 4895393 O-RING M15.3 ID x 2.2 Thk,
8 2 4895049 DOWEL M16.05 x 10 L,
9 12 4899803 TAPPET
10 6 2852202 PISTON COOLING NOZZLE
11 6 4894218 SCREW Special, M8 x 20,
12 REF INSTRUCTION Piston; See Figure 02-40
13 REF INSTRUCTION Camshaft; See Figure 02-35
721D : CASE WHEEL LOADER (NORTH AMERICA)02-26 - CYLINDER BLOCK
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-26 - CYLINDER BLOCK
Page 2 of 2
1 14 4899032 SCREW Hex Flg, M10 x 1.5 x 25,
2 1 2852729 STIFFENER
721D : CASE WHEEL LOADER (NORTH AMERICA)02-27 - FLYWHEEL HOUSING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-27 - FLYWHEEL HOUSING
Page 2 of 2
1 2 4899026 DOWEL M18 x 10 L,
2 2 4899109 SCREW Hex, M10 x 1.5 x 80,
2 10 4899075 SCREW Hex Flg, M10 x 1.5 x 40, If Used
2 10 4892915 FLANGE BOLT Hex, M10 x 1.5 x 40, If used
2 6 4899076 SCREW Hex Flg, M12 x 1.75 x 80,
2 2 2852426 SCREW M12 X 110; If Used
2 2 4897499 SCREW M12 X 110; If Used
3 1 4895155 COVER
4 1 4895378 BUTTON PLUG M29.2,
5 1 4895379 O-RING M21.82 ID x 3.53 Thk,
6 1 2852425 HOUSING
7 2 4899068 SCREW Hex Flg, M8 x 1.25 x 16,
8 1 4890833 OIL SEAL M130 x 155 x 12.5/16,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-28 - GEAR COVER - REAR HOUSING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-28 - GEAR COVER - REAR HOUSING
Page 2 of 2
1 2 4899026 DOWEL M18 x 10 L,
2 4 4899078 SCREW Hex Flg, M8 x 1.25 x 45,
3 2 4899093 SCREW Hex Flg, M10 x 1.5 x 30,
3 1 4899073 SCREW Hex Flg, M12 x 1.75 x 30,
4 3 4896939 SCREW
5 1 4899679 HOUSING
721D : CASE WHEEL LOADER (NORTH AMERICA)02-29 - FRONT GEAR COVER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-29 - FRONT GEAR COVER
Page 2 of 2
1 1 4897024 COVER
2 5 4899078 SCREW Hex Flg, M8 x 1.25 x 45,
3 8 4899063 SCREW Hex Flg, M8 x 1.25 x 30,
4 1 4890832 OIL SEAL M70 x 100 x 12.5/16,
5 2 4891209 DOWEL M13 x 8 L,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-29A - GEAR COVER - PLATE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-29A - GEAR COVER - PLATE
Page 2 of 2
1 1 2852175 COVER
2 1 4896897 GASKET
3 2 16677734 BOLT Hex Flg, M12 x 1.75 x 25,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-30 - CYLINDER HEAD - COVERS
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-30 - CYLINDER HEAD - COVERS
Page 2 of 2
1 1 4895910 VALVE COVER - ASSY
2 1 2852773 CAP - ASSY
3 1 2852774 GASKET Cap
4 6 4896991 SCREW
5 6 4893936 NUT M8X1.25
6 1 4899226 GASKET Replaced By 2853784
6 1 2853784 GASKET
7 6 4899239 SILENTBLOC
8 1 4898283 PLUG If Used
721D : CASE WHEEL LOADER (NORTH AMERICA)02-31 - CYLINDER HEAD - VALVE MECHANISM
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-31 - CYLINDER HEAD - VALVE MECHANISM
Page 2 of 2
1 5 4895432 SCREW M8 x 1.25 x 70
2 6 4898717 ROCKER ARM Kit
3 2 4897248 RETAINER
4 2 4897245 SOCKET
5 1 4895068 ROCKER ARM Kit
6 2 4895198 NUT 3/8"-24, Heavy,
7 2 2830222 ADJUSTMENT SCREW
8 2 4895065 SPACER
9 3 4895421 WASHER Replaces 2852776
10 6 2852428 CLIP
11 1 4895067 ROCKER ARM Kit
12 5 4899245 SLEEVE
13 1 4899257 HOUSING Assy; Rocker Lever
14 3 2852427 WIRE HARNESS Replaces 4896052
15 2 2830434 SCREW
16 1 4893487 SUPPORT
17 12 4895031 PUSH ROD
18 12 4895076 BRIDGE
19 1 4899231 GASKET
20 3 16689121 SCREW M6 X 16
21 2 4899089 SCREW Hex Flg, M8 x 1.25 x 50,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-32 - CYLINDER HEAD
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-32 - CYLINDER HEAD
Page 2 of 2
1 12 4891024 SCREW M12 x 130
1 14 4891025 SCREW Hex Flange Hd Cap, M12 x 150
3 1 2831274 CYLINDER HEAD Assy
4 48 4899081 ROCKER ARM COTTER Assy
5 12 4895051 STD ENGINE EXHAUST VALVE
6 12 4895052 STD ENGINE INLET VALVE
7 12 4895072 GASKET
8 24 4895073 VALVE SPRING
9 24 4895074 CUP
10 12 4895411 CUP
11 13 4895085 EXPANSION PLUG 25.74mm,
11 2 4895408 PLUG .511" OD
12 11 4895089 PLUG .886" OD
13 7 4895406 EXPANSION PLUG 9.8mm OD,
14 2 4895407 PLUG 38.28mm OD
15 1 2830705 CYLINDER HEAD GASKET SP=1.25
16 12 4897106 VALVE SEAT
18 12 4897578 VALVE SEAT
721D : CASE WHEEL LOADER (NORTH AMERICA)02-33 - MANIFOLD - INTAKE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-33 - MANIFOLD - INTAKE
Page 2 of 2
1 1 2852811 MANIFOLD Manifold Intake
2 3 4895432 SCREW M8 x 1.25 x 70
3 7 4899039 SCREW Hex Flg, M8 x 1.25 x 25,
4 1 4894727 HEATER
5 1 4894048 WASHER D=6
6 2 4897765 RETAINER
7 4 2852812 NUT M6
8 1 4895424 INLET MANIFOLD
9 1 4899921 GASKET
10 2 4895079 PIPE PLUG 3/4"-14,
11 4 2852212 FLANGE BOLT Hex, M8 x 1.25 x 25,
12 1 2852814 STUD M6 X 12 X 20
13 1 4897766 GROUND CABLE
14 1 4896263 BOOT
721D : CASE WHEEL LOADER (NORTH AMERICA)02-34 - MANIFOLD - EXHAUST
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-34 - MANIFOLD - EXHAUST
Page 2 of 2
1 1 4896651 EXHAUST MANIFOLD
2 1 4896650 EXHAUST MANIFOLD
3 6 2830444 GASKET Replaces 4896350
4 12 4895336 SPACER
5 2 4895219 STUD
6 10 4895174 SCREW Flg Hd, M10 x 1.5 x 65,
7 4 4899085 STUD
721D : CASE WHEEL LOADER (NORTH AMERICA)02-35 - CAMSHAFT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-35 - CAMSHAFT
Page 2 of 2
1 6 4899079 SCREW Hex Flg, M8 x 1.25 x 25,
2 1 4896380 DRIVEN GEAR
3 2 4899068 SCREW Hex Flg, M8 x 1.25 x 16,
4 1 4897457 SUPPORT
5 1 4896421 CAMSHAFT Assy
6 1 4899080 DOWEL M6 x 8 L,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-36 - CRANKSHAFT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-36 - CRANKSHAFT
Page 2 of 2
1 1 2852305 CRANKSHAFT Assy, Incl 2, 3
AR 2852305C CORE-CRANKSHAFT Return Number, CRANKSHAFT - for N.A. Only
2 1 4893386 GEAR 36 T,
3 1 4899046 DOWEL M6 x 9 L,
4 6 4895017 CRANKSHAFT BEARING Main, Std.
4 6 4895013 CRANKSHAFT BEARING Main, Std., Replaced By 2853815
4 6 2853815 BEARING ASSY Bearing; Crankshaft
5 1 2992153 CAP If Used; Replaces 4895414
5 1 2853816 BEARING ASSY Thrust; If Used
5 1 4895015 CRANKSHAFT BEARING Thrust; If Used
721D : CASE WHEEL LOADER (NORTH AMERICA)02-37 - CRANKSHAFT - PULLEY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-37 - CRANKSHAFT - PULLEY
Page 2 of 2
1 1 4896773 PULLEY
2 6 4892867 SCREW Torx Wash Hd, M12 x 1.25 x 78.5,
3 1 4892893 DAMPER
721D : CASE WHEEL LOADER (NORTH AMERICA)02-38 - FLYWHEEL - ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-38 - FLYWHEEL - ENGINE
Page 2 of 2
1 1 2852219 ENGINE FLYWHEEL Assy
2 1 2852221 RING GEAR
3 8 4894641 SCREW Wash Hd, M12 x 1.25 x 31,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-39 - CONNECTING ROD
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-39 - CONNECTING ROD
Page 2 of 2
1 6 2831298 CONNECTING ROD Assy, Replaces 4895748
2 1 4892708 BUSHING
3 2 2831297 FLANGE BOLT Hex, M10 x 1.25 x 52, Replaces 4892707
4 6 4892714 BEARING, CON. ROD
4 6 4892715 BEARING, CON. ROD
721D : CASE WHEEL LOADER (NORTH AMERICA)02-40 - PISTONS
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-40 - PISTONS
Page 2 of 2
1931222 PISTON ASSY Incl. Ref 1 - 4
1 6 4898076 PISTON No Longer Available For Service, Order 1931222
2 1 4892712 PISTON PIN
3 2 4892713 SNAP RING Int, M26.4, Replaced by 2854030
3 2 2854030 SNAP RING M40.8 OD,
4 1 2852036 PISTON RING
4 1 2830158 PISTON RING
4 1 2852037 PISTON RING
721D : CASE WHEEL LOADER (NORTH AMERICA)02-41 - COOLING SYSTEM - ENGINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-41 - COOLING SYSTEM - ENGINE
Page 2 of 2
3 2852803 SCREW M10 x 45; Not Illustrated; If Used
1 2852480 SUPPORT Compressor; Not Illustrated; If Used
2 2852481 DOWEL Not Illustrated; If Used
1 3 2852325 SCREW M10X80
2 2 4895121 GASKET
3 1 2852392 SUPPORT Assy
4 2 4895576 DOWEL
5 1 2852468 TUBE
6 1 4895392 HEX SOCKET PLUG M18 x 1.5, - Assy; If Used
7 1 4895393 O-RING M15.3 ID x 2.2 Thk,
8 1 4895623 HEX SOCKET PLUG M16 x 1.5, - Assy
9 1 4895625 O-RING M13.3 ID x 2.2 Thk,
10 2 2852496 PLUG
11 2 4899824 SEALING WASHER
12 2 4895079 PIPE PLUG 3/4"-14,
13 4 4895078 PIPE PLUG 1/2"-14, If Used
14 1 4895080 HEX SOCKET PLUG M22 x 1.5, - Assy, If Used
15 1 4895082 O-RING M19.3 ID x 2.2 Thk, If Used
721D : CASE WHEEL LOADER (NORTH AMERICA)02-42 - THERMOSTAT - ENGINE COOLING SYSTEM
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-42 - THERMOSTAT - ENGINE COOLING SYSTEM
Page 2 of 2
1 3 4899110 SCREW Hex Flg, M6 x 1 x 20,
2 1 4895131 HOUSING
3 1 2852471 THERMOSTAT Assy
4 1 2852473 GASKET
5 1 4892762 PLUG If Used
721D : CASE WHEEL LOADER (NORTH AMERICA)02-43 - TURBOCHARGER DRAIN LINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-43 - TURBOCHARGER DRAIN LINE
Page 2 of 2
1 2 4899031 SCREW Hex Flg, M8 x 1.25 x 25,
2 1 4895107 HYD CONNECTOR 11/16"-16 x M12, Assy
3 1 4899107 O-RING .414" ID x .072" Thk,
4 1 4899108 O-RING .364" ID x .070" Thk,
5 1 4891288 GASKET
6 1 4899436 CLAMP
7 1 2853606 HYD. TUBE
8 1 4899377 HOSE
9 1 4896991 SCREW
10 1 4899003 FLANGE NUT M8 x 1.25,
11 2 2852801 O-RING
721D : CASE WHEEL LOADER (NORTH AMERICA)02-44 - ENGINE - LIFT HOOKS
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-44 - ENGINE - LIFT HOOKS
Page 2 of 2
1 1 4894100 LIFTING EYE
2 1 4894410 LIFTING EYE
2 2 16677734 BOLT Hex Flg, M12 x 1.75 x 25,
4 4 4899079 SCREW Hex Flg, M8 x 1.25 x 25,
721D : CASE WHEEL LOADER (NORTH AMERICA)02-45 - ENGINE - BLOCK HEATER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)02-45 - ENGINE - BLOCK HEATER
Page 2 of 2
1 1 8602005 HEATER 750W, 120V
2 1 8602004 HEATER 750W, 240V
3 1 196466A1 ELECTRIC CABLE 120V; Engine Heater
4 1 J905114 ELECTRIC CABLE 240V; Engine Heater
5 2 896-11008 WASHER M8 x 17.5 x 2, HT,
6 2 627-8020 BOLT Hex, M8 x 20, 10.9,
7 1 L18331 CABLE STRAP
721D : CASE WHEEL LOADER (NORTH AMERICA)03-01 - CONTROLS - THROTTLE, FOOT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-01 - CONTROLS - THROTTLE, FOOT
Page 2 of 2
REF INSTRUCTION See Figure 04-14
1 8500677 THROTTLE CONTROL Analog; Component Parts Not Serviced Separately; Includes Kits Listed Below, Ref 1 - 3
1 1 8603127 REPAIR KIT E-Pedal Sensor, Requires 8602793 Harness For Servicing
2 1 8603128 REPAIR KIT E-Pedal Spring
3 1 8603129 REPAIR KIT E-Pedal Bellows
721D : CASE WHEEL LOADER (NORTH AMERICA)03-02 - FUEL LINES
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)03-02 - FUEL LINES
Page 2 of 3
1 1 86601756 HYD CONNECTOR 246NG8 - 1/4 NPTF
2 1 8602556 TUBE 800 mm (31 1/2 in.); Breather
2 1 87445405 O-RING Not Shown
3 1 8602539 FLEXIBLE HOSE 650 mm (25 5/8 in.); Prefilter to Engine
3 2 87445405 O-RING Not Shown
4 1 8602543 FITTING 246 NG12 to 1/4 NPTF
5 1 L18331 CABLE STRAP
6 1 504030790 HEAD Fuel Pre-Filter and Water Separator; Used With 8500044 (504067837) Iveco Engine
6A 1 87803182 FUEL FILTER Used with 504030790 Head
1 99483892 HEATER Used With 504030790 Head
6B 1 2830419 SENSOR Used With 504030790 Head
6 1 87435522 FILTER ASSY Water Separator w/ Heater; If Used; Incl. 6A, 6B; Used With 87433689 CDC Engine
6A 1 87435526 FUEL FILTER Cartridge
1 87803182 FUEL FILTER If Used
6B 1 87438159 SENSOR Water in Fuel w/ Heater
7 1 87435523 FILTER ASSY Water Separator w/o Heater; If Used; Incl. 7A, 7B; Used With 87433689 CDC Engine
7A 1 87435526 FUEL FILTER Cartridge
1 87803182 FUEL FILTER If Used
7B 1 87438159 SENSOR Water in Fuel w/o Heater
8 1 87438588 BRACKET Prefilter; Replaces 8501284
9 2 627-16050 BOLT Hex, M16 x 50, 10.9,
10 2 896-15016 WASHER M17.5 x 34 x 5, HT,
11 2 832-10416 LOCK NUT M16 x 2, Cl 8,
12 2 827-10040 BOLT Hex, M10 x 40, 10.9, Full Thd,
13 2 896-11010 WASHER M10 x 21.5 x 2.5, HT,
14 2 832-10410 LOCK NUT M10 x 1.5, Cl 8,
15 1 8602540 FLEXIBLE HOSE 1725 mm (68 in.); Engine To Tank
15 2 87445405 O-RING Not Shown
16 2 515-2595 CLAMP 3/8", Insul, 1/2" Bolt,
17 1 214-1406 HOSE CLAMP #06, .44/.78 Type F Worm,
721D : CASE WHEEL LOADER (NORTH AMERICA)03-02 - FUEL LINES
Page 3 of 3
18 2 8602542 ADAPTER 246 NG12 to M14 x 1.5; Incl. 19
19 1 NSS NOT SERVICED SEPARATELY Copper Washer; Replaces O-Ring 637-63113
20 1 8602538 TUBE 1350 mm (53 5/32); Tank To Prefilter
20 2 87445405 O-RING Not Shown
21 1 8602537 TUBE Tank Draw; 171mm (6 3/4 in.)
22 1 515-25127 CLAMP 1/2", Insul, 1/2" Bolt,
23 1 217-92 COCK
24 1 627-8020 BOLT Hex, M8 x 20, 10.9,
25 1 T103750 VENT
26 1 186814A1 CAP
27 2 895-15008 WASHER M8 x 20 x 1.6,
28 1 832-10408 LOCK NUT M8 x 1.25, Cl 8,
721D : CASE WHEEL LOADER (NORTH AMERICA)03-03 - FUEL TANK FILLER - SENDER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-03 - FUEL TANK FILLER - SENDER
Page 2 of 2
1 1 8500909 FUEL TANK Incl. 2 - 4C
2 1 8604443 FILLER CAP Replaces 405112A1
3 1 8604441 FITTING O-Ring Seal 3/8 NPTF; Incls. 3A,3B; Replaces 405109A1
3A 1 8604450 FITTING O-Ring Seal 3/8 NPTF; Nut & Bolt/A; Replaces 405427A1
3B 1 8604446 O-RING 3/8 NPTF Fitting; Replaces 405423A1
3 1 87707148 FITTING Bolt, 3/8-18 NPT; Replaces 8604441, 87435224
3A 1 282709A1 NUT 1-14 UNS-2B; LH Thread
3B 1 238-5214 O-RING -214, 70 Duro, .984" ID x .139" Thk,
4 3 8604442 FITTING O-Ring Seal 1/4 NPTF; Incl. 4A-4C; Replaces 405111A1
4A 1 8604447 FITTING Bolt; Replaces 405424A1
4B 1 8604448 NUT O-Ring Fitting; Replaces 405425A1
4C 1 8604449 O-RING Seal 1/4 NPTF; Replaces 405426A1
4A 1 87694594 BOLT Bolt; Replaces 8604442, 87435505
4B 1 1251791C1 NUT 3/4-16 UNF-2A; LH Thread
4C 1 238-5210 O-RING -210, 70 Duro, .734" ID x .139" Thk,
6 1 328870A1 SENDER UNIT Fuel Level
7 5 814-5030 BOLT Hex, M5 x 30, 8.8,
8 5 895-11005 WASHER M5 x 10 x 1,
9 1 8602250 PLATE Fuel Tank; If Used
9A 1 87449519 PLATE Fuel Tank; If Used
10 6-10 627-12040 BOLT Hex, M12 x 40, 10.9, Full Thd,
11 6-10 896-15012 WASHER M12 x 28.5 x 4, HT,
12 2 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
13 2 895-18010 WASHER M10 x 18 x 1.6,
14 2 832-10410 LOCK NUT M10 x 1.5, Cl 8,
15 2 366905A1 SECURING STRAP Fuel Tank; Short
16 2 366904A1 SECURING STRAP Fuel Tank; Long
17 1 87450971 PLATE Tank, LH
18 1 87450970 PLATE Tank, RH
19 4 829-1412 NUT M12, Cl 10,
721D : CASE WHEEL LOADER (NORTH AMERICA)03-04 - FUEL INJECTION PUMP
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-04 - FUEL INJECTION PUMP
Page 2 of 2
1 3 4899003 FLANGE NUT M8 x 1.25,
2 1 4896952 COVER
3 3 2852488 STUD M8 x 1.25 x 50
4 1 4890700 GASKET
5 1 4898921 FUEL INJECTION PUMP
5 1 4898921R REMAN-INJECTION PUMP 721D, Use w/ Eng. P/N 87433689 N.A. Only
5 1 4898921C CORE-INJECTION PUMP Return Number, For N.A. Only
6 1 4890088 O-RING
7 1 4890634 NUT M18 x 1.5
8 4 4891385 GASKET
9 4 4893962 QUICK MALE COUPLING
10 1 2852804 HUB Includes 11
11 1 2852805 O-RING
12 1 4893389 DRIVEN GEAR
13 2 2852234 SCREW Hex Flg, M8 x 1.25 x 20,
14 1 4890635 WASHER
15 1 42541851 SOLENOID
16 1 42541850 O-RING
17 1 42541849 O-RING
18 1 42550486 VALVE
19 1 42547619 FUEL PUMP
20 4 42550487 SCREW
21 1 42550488 O-RING
22 1 42548060 O-RING
23 3 42550932 SCREW
721D : CASE WHEEL LOADER (NORTH AMERICA)03-05 - FUEL INJECTION SYSTEM - INJECTOR
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-05 - FUEL INJECTION SYSTEM - INJECTOR
Page 2 of 2
1 12 4899092 SCREW Hex Flg, M6 x 1 x 25,
2 6 4897114 FITTING Assy
3 1 4890929 O-RING
4 6 4893739 TUBE NUT
5 6 2830957 FUEL SYSTEM INJECTOR Assy
6 1 4899689 SEALING WASHER
7 1 4890926 O-RING
721D : CASE WHEEL LOADER (NORTH AMERICA)03-06 - FUEL INJECTION SYSTEM - FUEL, SUPPLY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-06 - FUEL INJECTION SYSTEM - FUEL, SUPPLY
Page 2 of 2
1 2852778 Manifold Assy; Incl 1 - 5
1 1 2852779 ACCUMULATOR Manifold
1 4899831 VALVE, CUSHION Assy, Incl. 2, 3, 4
2 1 4899828 FITTING
3 1 4899824 SEALING WASHER D=18X22 SP=1.5
4 1 4899804 VALVE
5 1 2852780 SENSOR Pressure
8 3 2852781 PIPE Fuel Supply
9 3 2852784 PIPE Fuel Supply
10 1 2852787 PIPE Assy, Incl. 11, 12
11 1 4897270 BRACKET
12 1 4898352 COLLAR CLAMP Coller Clamp
13 1 2852100 FLANGE BOLT Hex, M8 x 1.25 x 16,
2852434 SPACER Not Illustrated
14 4 2852100 FLANGE BOLT Hex, M8 x 1.25 x 16,
721D : CASE WHEEL LOADER (NORTH AMERICA)03-07 - FUEL INJECTION SYSTEM - MODULE, ENGINE CONTROL
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-07 - FUEL INJECTION SYSTEM - MODULE, ENGINE CONTROL
Page 2 of 2
1 2 4899124 WASHER
2 1 4899068 SCREW Hex Flg, M8 x 1.25 x 16, M6X1X20
3 1 2852817 O-RING M23.52 ID x 1.78 Thk
4 3 2852826 STUD
5 3 2852197 FLANGE NUT M6 x 1,
6 5 2852818 SCREW M6X30
7 4 4899110 SCREW Hex Flg, M6 x 1 x 20,
8 1 4890189 SENSOR Speed
9 1 4890190 SENSOR
10 1 2852820 O-RING 17.17X1.78MM
11 1 4890193 SENSOR Oil Pressure & Temp.
12 1 4895477 O-RING
13 1 4897224 SENSOR Temperature
14 1 4892255 HOUSING Sensor
15 1 2852821 SENSOR ECM; Boost/Air Temperature
16 1 2852824 BRACKET
17 1 4895157 STUD
18 1 4898111 CONTROL UNIT
19 1 4897682 COOLER
20 1 4896811 GASKET
21 1 4896542 HYD CONNECTOR M12 x 1.5
22 2 4891385 GASKET
23 3 4899791 ISOLATOR
24 1 4890964 FITTING M12 x 1.5, Quick Disconnect
25 1 4897685 SUPPORT
26 3 2852822 SCREW M6 x 25
27 3 2852823 WASHER M6 x 11.8
28 3 2852827 LOCK WASHER M6 x 12 x 1.6
29 1 2852825 PLUG Rubber
30 1 2852819 CLAMP
31 1 4899082 SCREW Hex Soc Hd, M6 x 1 x 20,
32 1 2852484 NUT M6
33 1 4895817 SCREW Hex Flg, M6 x 1 x 20,
721D : CASE WHEEL LOADER (NORTH AMERICA)03-08 - FUEL INJECTION SYSTEM
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-08 - FUEL INJECTION SYSTEM
Page 2 of 2
1 1 2852440 TUBE - ASSY; Replaces 504034214
2 8 4894095 O-RING M8 ID x 2.5 Thk,
3 1 2852443 TUBE - ASSY; Replaces 504034215
4 1 2852446 TUBE - ASSY; Replaces 504034216
5 2 2852449 CLIP Replaces 99434055
6 1 2852450 CLAMP Replaces 500368357
7 1 2852451 BRACKET
8 2 17869380 CLIP Cable
9 1 4897277 SCREW
10 1 4897817 TUBE - ASSY
11 1 4895462 CLAMP
12 1 4899103 SCREW Hex Flg, M8 x 1.25 x 12,
13 1 4896996 CLAMP
721D : CASE WHEEL LOADER (NORTH AMERICA)03-09 - FUEL INJECTION SYSTEM - DRAIN LINE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-09 - FUEL INJECTION SYSTEM - DRAIN LINE
Page 2 of 2
1 1 2852454 HYD. TUBE - ASSY; Replaces 504023173
2 3 4894095 O-RING M8 ID x 2.5 Thk,
3 1 4896329 PRESSURE RELIEF VALVE
4 1 2852457 CLAMP
5 1 2852458 CLIP Cable
6 1 2852100 FLANGE BOLT Hex, M8 x 1.25 x 16,
721D : CASE WHEEL LOADER (NORTH AMERICA)03-10 - FUEL FILTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)03-10 - FUEL FILTER
Page 2 of 2
REF INSTRUCTION Prefilter/ Water Seperator; See Figure 03-02
1 1 2852438 SUPPORT If Used; Replaces 504015265
2 1 2830733 SCREW M8 x 25
3 1 2852436 FUEL FILTER Replaces 504033395
4 1 4898758 ADAPTER
5 1 4897224 SENSOR Temperature
6 6 4894721 SEALING WASHER M12.2 x 17 x 1.5 Thk,
7 1 4893464 PLUG
8 4 4890964 FITTING M12 x 1.5,
9 1 4896543 FITTING
10 1 4897838 HEATER
11 1 87803200 FUEL FILTER
12 2 87803136 SCREW M8X20; Replaces 16586324
13 1 4898876 O-RING
14 2 2830711 WASHER
721D : CASE WHEEL LOADER (NORTH AMERICA)04-01 - ALTERNATOR
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-01 - ALTERNATOR
Page 2 of 2
1 1 4892318 ALTERNATOR - ASSY, See Figure 04-01A
1 1 4892318R REMAN-ALTERNATOR For N.A. only
1 1 4892318C CORE-ALTERNATOR Return number - For N.A. only
2 1 8602679 BELT 1688.00 mm L, Used with Air Conditioning
3 1 8602680 BELT 1230.00 mm L, Used Without Air Conditioning
4 1 4899122 SCREW Hex Flg, M10 x 1.5 x 110, Replaced By 854-10110
4 1 854-10110 BOLT Hex Flg, M10 x 110, 10.9, Replaces 4899122
5 REF INSTRUCTION IDLER SUPPLIED WITH ENGINE See Fig. 02-23
6 1 896-11010 WASHER M10 x 21.5 x 2.5, HT,
7 1 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-01A - ALTERNATOR
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-01A - ALTERNATOR
Page 2 of 2
1 4892318 ALTERNATOR Incl. 1-22
1 4892318R REMAN-ALTERNATOR For N.A. only
1 4892318C CORE-ALTERNATOR Return number - For N.A. only
1 1 1113178 NUT M16X1.5
2 1 2991636 BEARING
3 1 2991637 BEARING
4 1 42537056 HOUSING
5 1 42537057 RETAINING PLATE
6 4 42537058 SCREW
7 1 42533805 SPACER
8 1 42537670 HOUSING
9 1 42533807 CAP
10 2 42537051 BUSHING
11 1 42537060 ROTOR - ASSY
12 1 42537061 STATOR
13 1 42537054 RECTIFIER
14 3 42537878 SCREW
15 1 42537055 VOLTAGE REGULATOR
16 1 42536305 SCREW
17 2 42536304 SCREW
18 1 42533816 COVER
19 2 42533817 NUT
20 4 42533819 SCREW
21 1 42535631 PULLEY
22 1 42531183 WASHER
721D : CASE WHEEL LOADER (NORTH AMERICA)04-02 - STARTER - BOSCH
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-02 - STARTER - BOSCH
Page 2 of 2
1 1 2852478 STARTER MOTOR Bosch
AR 2852478C Return Number, STARTER - for N.A. Only
2 3 829-2410 NUT M10 x 1.5, Flg, Cl 10,
3 3 504069214 STUD
721D : CASE WHEEL LOADER (NORTH AMERICA)04-02A - STARTER - DENSO
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-02A - STARTER - DENSO
Page 2 of 2
1 1 8605784 STARTING MOTOR Denso
AR 8605784C CORE-STARTER Return Number, STARTER - for N.A. Only
2 3 829-2310 NUT M10 x 1.5, Flg, Cl 10,
3 3 2852476 STUD Starter; 10mm
4 X 345-62 LOCTITE 747
5 X 345-75 LOCTITE 271 Thread Adhesive
721D : CASE WHEEL LOADER (NORTH AMERICA)04-03 - PANEL, CONTROL - CAB HEATER/HEATER AND AIR CONDITIONING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-03 - PANEL, CONTROL - CAB HEATER/HEATER AND AIR CONDITIONING
Page 2 of 2
REF INSTRUCTION CAB WITH HEAT OR HEAT AND A/C
1 1 197377A2 CONTROL PANEL
2 1 283423A1 DECAL Cab Switches, With Heat; See Figure 09-59; Item 6
2A 1 283424A1 DECAL Cab Switches; With Heat And A/C; See Figure 09-59; Item 5
3 4 239225A1 SCREW Cross Pan Hd, M4 x 12,
4 1 REF INSTRUCTION HARNESS, MAIN CAB SEE FIG 04-09
5 1 374421A4 SWITCH Declutch
6 1 374422A2 SWITCH Detent
7 1 374427A2 SWITCH Return To Travel
8 1 374431A2 SWITCH Trans. Auto
9 1 374429A2 WINDSHIELD WIPER SWITCH Rear Wiper and Washer
10 4-6 86000535 PLUG 1.427" x .62", Plastic, Switch Opening
11 1 1994716C1 ASSEMBLY Lamp; 5 Positions
12 1 197952A1 SWITCH Windshield Wiper Front
13 1 92100C2 SWITCH Blower Motor
14 1 A187954 SWITCH SWITCH - Thermostat; Cab with Heat and A/C
1 250742A1 ELECTRIC CABLE Incl. 15, 16
15 1 1954651C2 CONTROL
16 1 250739A1 CABLE
17 5 495-11053 WASHER 1/2", SAE,
18 5 1994720C1 KNOB Control
19 1 109311H NUT 7/16 NF
20 1 400834A1 SWITCH Transmission
21 1 L18331 CABLE STRAP
22 1 374425A2 SWITCH Ride Control; If Used
23 1 382375A2 SWITCH Fan Reversing; If Used
24 1 374433A3 SWITCH Disable Backup Alarm; Europe Only
25 1 A149801 FUSE 15 AMP; Light Blue
26 2 A149800 FUSE 10 AMP; Red
721D : CASE WHEEL LOADER (NORTH AMERICA)04-03A - PANEL, CONTROL - CANOPY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-03A - PANEL, CONTROL - CANOPY
Page 2 of 2
1 1 197377A2 CONTROL PANEL
2 1 283426A1 DECAL Canopy Switches
3 4 239225A1 SCREW Cross Pan Hd, M4 x 12,
4 1 REF INSTRUCTION HARNESS MAIN CAB; SEE FIG 04-09
5 1 374421A4 SWITCH Declutch
6 1 374422A2 SWITCH Detent
7 1 374427A2 SWITCH Return To Travel
8 1 374431A2 SWITCH Trans. Auto
9 6 86000535 PLUG 1.427" x .62", Plastic, Switch Opening
10 1 1994716C1 ASSEMBLY Lamp
11 2 495-11053 WASHER 1/2", SAE,
12 1 1994720C1 KNOB Control
13 1 400834A1 SWITCH Transmission Enable
721D : CASE WHEEL LOADER (NORTH AMERICA)04-04 - HARNESS, AIR CONDITIONING DIODE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-04 - HARNESS, AIR CONDITIONING DIODE
Page 2 of 2
1 1 433263A2 HARNESS Air Conditioning Diode
2 2 L18337 CABLE STRAP 9.95"-12.1" lg,
3 1 406567A1 DIODE Module
4 1 245485C1 ELEC CONNECTOR Diode Module
5 1 245480C1 ELEC CONNECTOR Compressor Clutch
6 1 245481C1 CONNECTION,ELECTRIC Compressor Clutch
7 1 1964712C1 TERMINAL CONNECTOR Ground
721D : CASE WHEEL LOADER (NORTH AMERICA)04-05 - HARNESS, FRONT
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)04-05 - HARNESS, FRONT
Page 2 of 3
1 1 87443383 WIRE HARNESS Front; Replaces 8602938
1A 1 373358A1 CONNECTOR,ELECTRIC Cab, Front
2 1 251444A1 ASSEMBLY Horn Assembly, 300 HZ
3 4 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
4 8 895-11010 WASHER M10 x 20 x 2, 11 x 18 x 1,6 mm
5 4 832-10410 LOCK NUT M10 x 1.5, Cl 8,
6 1 245483C1 ELEC CONNECTOR Engine Harness
7 3 1964718C1 TERMINAL CONNECTOR Grounds
9 2 253347A1 NUT M10 - 1,5; Brass; Grounds
10 2 L127554 WASHER Brass; Grounds
11 7 19-135 CABLE STRAP 15 in
12 1 87549589 SWITCH Brake Declutch; Replaces 377898A3
12A 1 245482C1 ELEC CONNECTOR Brake Declutch
13 1 390431A2 SWITCH Pressure; Brake Light; Replaced By 87307240
13A 1 222136A1 ELEC CONNECTOR Switch, Pressure; Brake Light
13B 1 396471A1 SEAL Switch, Pressure; Brake Light; No Longer Required For Use With Brake Light Pressure Switch 87307240
13 1 87307240 PRESSURE SWITCH Brake Light; Incl. O-Ring; Replaces 390431A2
13 1 84177015 PRESSURE SWITCH Brake Light; Replaces 87307240 Pressure Switch Used On Some Models
14 1 8605738 PRESSURE SWITCH Warning; Brake
14A 1 396471A1 SEAL Warning; Brake
14B 1 225316C1 ELEC CONNECTOR Switch Pressure; Brake Warning
15 1 245482C1 ELEC CONNECTOR Pin Engage Option; If Used
15A 1 245483C1 ELEC CONNECTOR Plug; Pin Engage Option; If Not Used
18 1 291718A1 ELEC CONNECTOR Solenoid, Float
19 1 291718A1 ELEC CONNECTOR Ride Control; If Used
721D : CASE WHEEL LOADER (NORTH AMERICA)04-05 - HARNESS, FRONT
Page 3 of 3
19A 1 291717A1 ELEC CONNECTOR Ride Control; Plugged Connector; If Not Used
22 1 245485C1 ELEC CONNECTOR Return To Dig
23 1 245488C1 ELEC CONNECTOR Diode; Ride Control - Float Solenoid
24 1 A187813 DIODE Ride Control - Float Solenoid
25 2 225351C1 ELEC CONNECTOR Lights; LH, RH
28 1 245484C1 ELEC CONNECTOR Height Control - Return To Travel
29 2 515-24349 CLAMP 1 3/8", Insul, 7/16" Bolt, (34.9 mm - ID)
30 1 515-24302 CLAMP 1 3/16", Insul, 7/16" Bolt, (30.2 mm ID)
31 2 282459A1 TERMINAL CONNECTOR Horn; Power; Ground
32 16 L18331 CABLE STRAP Not Illustrated
33 1 245483C1 ELEC CONNECTOR Jumper Harness; Rollback Pressure Switch; XT Models Only
34 1 8602937 WIRE HARNESS Jumper; Rollback Pressure Switch; XT Models Only
721D : CASE WHEEL LOADER (NORTH AMERICA)04-05A - HARNESS - RTD/RTT/HGT - XT LOADER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-05A - HARNESS - RTD/RTT/HGT - XT LOADER
Page 2 of 2
REF INSTRUCTION XT LOADER
1 1 396585A1 WIRE HARNESS RTD-RTT-HGT
2 9 L18331 CABLE STRAP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-06 - LIGHTS - SIDE MARKER WARNING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-06 - LIGHTS - SIDE MARKER WARNING
Page 2 of 2
1 2 443446A1 BRACKET Marker Lights
2 2 E133249 LIGHT Front and Rear Clearance
3 8 895-25008 WASHER M8 x 20 x 1.6, 9 x 24 x 2 mm
4 4 627-8030 BOLT Hex, M8 x 30, 10.9,
5 4 832-10408 LOCK NUT M8 x 1.25, Cl 8,
6 2 L18331 CABLE STRAP
7 2 445679A1 WIRE HARNESS Italian Marker Lights
8 2 86530079 GUARD Side Panel
9 2 426-616 BOLT Hex, 3/8"-16 x 1", G8, Full Thd,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-07 - HARNESS - PEDESTAL
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)04-07 - HARNESS - PEDESTAL
Page 2 of 3
1 399236A2R CLUSTER, INSTRUMENT Remanufactured; North America Only
1 399236A2C CLUSTER, INSTRUMENT
1 1 399236A2 CLUSTER, INSTRUMENT
1 399236A3R CLUSTER, INSTRUMENT Remanufactured; North America Only
1 399236A3C CLUSTER, INSTRUMENT
1 1 399236A3 CLUSTER, INSTRUMENT Replaces 399236A2
1 87710744R REMAN-INSTRUMENT CLUSTER Reman Replacement For 399236A3R, 721D, Start Yr. 1/03, N.A. Only
87710744C CORE Return Number, N.A. Only
1A 1 8501175 HARNESS Front Pedestal
1A 1 87319818 WIRE HARNESS Front Pedestal; Replaces 8501175; Used with Main Cab Harness 87319954 and Turn Switch 389487A1
1A 1 87340746 WIRE HARNESS Front Pedestal
2 1 238270A1 CONTROL Incl. 2A - 2B; Shifter
2A 1 NSS NOT SERVICED SEPARATELY COVER
2B 1 NSS NOT SERVICED SEPARATELY SEAL
3 2 864-5020 SCREW Hex Soc Hd, M5 x 20, 8.8,
4 2 892-11005 LOCK WASHER M5,
5 2 824-1405 NUT M5, Cl 5,
6 1 1987555C1 SWITCH Turn Signal and Dimmer
6 1 389487A1 LIGHT SWITCH Replaces 1987555C1
7 2 239225A1 SCREW Cross Pan Hd, M4 x 12, Special; Turn Signal Mounting
8 1 282775A1 IGNITION SWITCH Incl. 9
9 1 1964831C2 SET OF 2 KEYS Padded
10 1 374426A2 SWITCH Hazard Warning
11 1 374434A2 SWITCH Pilot Control
12 1 374424A2 PARK BRAKE SWITCH Parking
13 1 374428A2 SWITCH Up/Down Count
14 1 374423A2 SWITCH Program Reset
15 1 8500822 SWITCH Diagnostic
18 2 239105A1 SCREW Cross Pan Hd, M6 x 20, Special
721D : CASE WHEEL LOADER (NORTH AMERICA)04-07 - HARNESS - PEDESTAL
Page 3 of 3
19 4 896-11012 WASHER M13.5 x 24.5 x 3, HT,
20 4 895-15006 WASHER M6 x 25 x 1.6,
21 4 829-1406 NUT M6, Cl 10,
22 3 515-24222 CLAMP 7/8", Insul, 7/16" Bolt,
23 2 895-18010 WASHER M10 x 18 x 1.6,
24 2 896-11012 WASHER M13.5 x 24.5 x 3, HT,
25 2 829-1410 NUT M10, Cl 10,
26 1 614-8025 BOLT Hex, M8 x 25, 8.8,
27 1 895-11008 WASHER M8 x 16 x 1.6,
28 1 829-1408 NUT M8, Cl 10,
29 3 1990502C1 WASHER 1/4 x 13/16 x 1/16 in
30 3 832-10406 NUT M6 x 1, Cl 8,
31 1 A135520 SWITCH Cold Start
32 1 425-1110 NUT 5/8"-18, G5,
33 4 893-11012 LOCK WASHER Ext Tooth, M12,
34 1 495-81072 WASHER 1 1/32" x 1 3/4" x .030", (26.02 x 44.5 x 0.8 mm)
35 1 283095A2 BALL KNOB Steering Tilt
36 1 349372A1 GROUND CABLE Ground
37 2 353169A1 SCREW 1/4 x 3/4
38 1 8602742 INDICATOR LIGHT Amber Indicator; Water In Fuel
721D : CASE WHEEL LOADER (NORTH AMERICA)04-08 - HARNESS - CAB ROOF
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-08 - HARNESS - CAB ROOF
Page 2 of 2
1 1 238764A2 WIRE HARNESS Cab Roof
2 4 A187520 LIGHT ASSY. Flood; See Figure 04-22
3 2 495-11053 WASHER 1/2", SAE,
4 4 131-1402 LOCK NUT 1/2"-13, GB, Thin,
5 2 515-21127 CLAMP 1/2", Insul, 1/4" Bolt,
6 2 829-1406 NUT M6, Cl 10,
7 4 248-1237 GROMMET 1/4" ID x 1" Groove Dia, Diag Cut,
8 1 394799A1 LIGHT ASSY. 24V; Dome; Incl. 9
9 2 395185A1 BULB 24V
10 1 388482A1 WIRE HARNESS Domelight
1 241521A1 DOME LIGHT Courtesy; Incl. 12 - 14
12 1 NSS NOT SERVICED SEPARATELY Body
13 1 107329C1 WIRE HARNESS
14 1 27727R1 BULB C2F, #464, 28V,
15 3 1270741C1 SELF-TAP SCREW Cross Pan Hd, #8 x 1",
16 1 353-403 PLUG Dome, .437" hole, Nylon,
17 1 353-421 PLUG Dome, .187" hole, Nylon,
18 2 169850C2 CABLE CLIP
19 4 L18331 CABLE STRAP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-09 - HARNESS - CAB, MAIN
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)04-09 - HARNESS - CAB, MAIN
Page 2 of 3
REF INSTRUCTION POWER DISTRIBUTION CENTER
1 1 8501182 WIRE HARNESS Cab Main; Incl. 1A, 45, 46, 47; Used with Pedestal Harness 8501175 and Turn Switch 1987555C1
1 1 87319954 WIRE HARNESS Main Cab; Replaces 8501182; Used with Front Pedestal Harness 87319818 and Turn Switch 389487A1
1A 1 A187813 DIODE
2 3 840-1660 SCREW Cross Pan Hd, M6 x 60,
5 12 A149798 FUSE 5 amp; Tan
5A 7 A149799 FUSE 7.5 amp; Brown
6 5 A149800 FUSE 10 amp; Red
7 1 434230A1 PLATE
8 13 326845A1 RELAY 24V
8A 1 A187938 RELAY Used with Cab Harness 8501182; Pedestal Harness 8501175 and Turn Switch 1987555C1
9 2 S243558 CIRCUIT-BREAKER
10 7 760-14325 SELF-TAP SCREW Pan Hd, M4.2 x 25, M4 x 19
11 1 249152A3 BRACKET Module Mounting
12 1 515-23254 CLAMP 1", Insul, 3/8" Bolt,
13 1 627-10020 BOLT Hex, M10 x 20, 10.9, Full Thd,
14 5 895-18010 WASHER M10 x 18 x 1.6,
15 1 832-10410 LOCK NUT M10 x 1.5, Cl 8,
16 1 431023A1 MODULE Power Off Timer
16 1 232363A1 MODULE Power Off Timer
17 1 232364A1 FLASHER UNIT No. 10
18 8 840-1616 SCREW Cross Pan Hd, M6 x 16,
19 8 895-11006 WASHER M6,
19A 2 832-10406 NUT M6 x 1, Cl 8,
20 1 515-23190 CLAMP 3/4", Insul, 3/8" Bolt,
21 1 896-11012 WASHER M13.5 x 24.5 x 3, HT,
22 5 895-18010 WASHER M10 x 18 x 1.6,
23 2 829-1410 NUT M10, Cl 10,
24 1 F22316 RESISTOR 75 ohm
25 1 760-14325 SELF-TAP SCREW Pan Hd, M4.2 x 25,
26 1 895-25005 WASHER M5 x 15 x 1.6,
27 1 87427310 MODULE Transmission Control; Replaces 8602878
721D : CASE WHEEL LOADER (NORTH AMERICA)04-09 - HARNESS - CAB, MAIN
Page 3 of 3
28 4 840-1416 SCREW Cross Pan Hd, M4 x 16,
29 1 253347A1 NUT M10 - 1,5; Brass
30 1 L127554 WASHER Brass
31 4 840-1420 SCREW Cross Pan Hd, M4 x 20,
32 8 892-11004 LOCK WASHER M4,
33 2 D39696 CLAMP
34 1 895-15006 WASHER M6 x 25 x 1.6,
35 1 614-6020 BOLT Hex, M6 x 20, 8.8,
36 X L18331 CABLE STRAP 15"
37 1 357906A1 BOOT
38 8 824-1404 NUT M4, Cl 5,
39 2 22-824 CABLE STRAP 3/16" x 7 1/4",
40 1 895-15008 WASHER M8 x 20 x 1.6,
41 1 832-10408 LOCK NUT M8 x 1.25, Cl 8,
42 2 840-1516 SCREW Cross Pan Hd, M5 x 16, 4.8,
43 4 895-11005 WASHER M5 x 10 x 1,
44 2 832-10405 LOCK NUT M5 x .8, Cl 8,
45 1 406567A1 DIODE
46 1 245485C1 ELEC CONNECTOR
47 1 245488C1 ELEC CONNECTOR
48 2 319055A1 JUNCTION BLOCK Assy
721D : CASE WHEEL LOADER (NORTH AMERICA)04-10 - HARNESS - CANOPY ROOF
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-10 - HARNESS - CANOPY ROOF
Page 2 of 2
1 1 238764A2 WIRE HARNESS Canopy Roof
2 4 A187520 LIGHT ASSY. Flood; See Figure 04-22
3 2 495-11053 WASHER 1/2", SAE,
4 4 131-1402 LOCK NUT 1/2"-13, GB, Thin,
5 4 248-1237 GROMMET 1/4" ID x 1" Groove Dia, Diag Cut,
6 9 L18331 CABLE STRAP
7 2 169850C2 CABLE CLIP Adhesive Back
721D : CASE WHEEL LOADER (NORTH AMERICA)04-11 - HARNESS - CANOPY, MAIN
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)04-11 - HARNESS - CANOPY, MAIN
Page 2 of 3
REF INSTRUCTION POWER DISTRIBUTION CENTER
1 1 8501182 WIRE HARNESS Cab Main; Incl. 1A, 45, 46, 47; Used with Pedestal Harness 8501175 and Turn Switch 1987555C1
1 1 87319954 WIRE HARNESS Main Cab; Replaces 8501182; Used with Front Pedestal Harness 87319818 and Turn Switch 389487A1
1A 1 A187813 DIODE
2 3 840-1660 SCREW Cross Pan Hd, M6 x 60,
3 1 895-15008 WASHER M8 x 20 x 1.6,
4 1 832-10408 LOCK NUT M8 x 1.25, Cl 8,
5 12 A149798 FUSE 5 amp; Tan
6 5 A149800 FUSE 10 amp; Red
7 7 A149799 FUSE 7.5 amp; Brown
8 13 326845A1 RELAY 24V
8A 1 A187938 RELAY Used with Cab Harness 8501182; Pedestal Harness 8501175 and Turn Switch 1987555C1
9 2 S243558 CIRCUIT-BREAKER
11 1 249152A3 BRACKET Module Mounting
12 1 515-23254 CLAMP 1", Insul, 3/8" Bolt,
13 1 627-10020 BOLT Hex, M10 x 20, 10.9, Full Thd,
14 5 895-18010 WASHER M10 x 18 x 1.6,
15 1 832-10410 LOCK NUT M10 x 1.5, Cl 8,
16 1 431023A1 MODULE Power Off Timer
17 1 232364A1 FLASHER UNIT No. 10
18 8 840-1616 SCREW Cross Pan Hd, M6 x 16,
19 8 895-11006 WASHER M6,
19A 2 832-10406 NUT M6 x 1, Cl 8,
20 1 515-23190 CLAMP 3/4", Insul, 3/8" Bolt,
21 1 896-11012 WASHER M13.5 x 24.5 x 3, HT,
22 5 895-18010 WASHER M10 x 18 x 1.6,
23 2 829-1410 NUT M10, Cl 10,
24 1 F22316 RESISTOR 75 ohm
25 7 760-14325 SELF-TAP SCREW Pan Hd, M4.2 x 25,
26 1 895-25005 WASHER M5 x 15 x 1.6,
27 1 87427310 MODULE Transmission Control; Replaces 8602878
28 4 840-1416 SCREW Cross Pan Hd, M4 x 16,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-11 - HARNESS - CANOPY, MAIN
Page 3 of 3
29 1 253347A1 NUT M10 - 1,5; Brass
30 1 L127554 WASHER Brass
31 4 840-1420 SCREW Cross Pan Hd, M4 x 20,
32 8 892-11004 LOCK WASHER M4,
33 2 D39696 CLAMP
34 1 895-15006 WASHER M6 x 25 x 1.6,
35 2 829-1410 NUT M10, Cl 10,
36 X L18331 CABLE STRAP 15"
37 X 22-824 CABLE STRAP 3/16" x 7 1/4",
38 1 357906A1 BOOT
39 1 614-6020 BOLT Hex, M6 x 20, 8.8,
40 8 824-1404 NUT M4, Cl 5,
41 2 840-1516 SCREW Cross Pan Hd, M5 x 16, 4.8,
42 2 832-10405 LOCK NUT M5 x .8, Cl 8,
43 4 895-11005 WASHER M5 x 10 x 1,
44 1 406567A1 DIODE
45 1 245485C1 ELEC CONNECTOR
46 1 245488C1 ELEC CONNECTOR
47 2 319055A1 JUNCTION BLOCK
48 1 434230A1 PLATE
721D : CASE WHEEL LOADER (NORTH AMERICA)04-12 - HARNESS - TRANSMISSION
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-12 - HARNESS - TRANSMISSION
Page 2 of 2
1 1 8602682 WIRE HARNESS Transmission; Use Existing Hardware
2 2 L18331 CABLE STRAP 15"
3 1 198823C1 GROMMET
4 1 445786A1 WIRE HARNESS
5 2 377899A1 SWITCH Redundant Brake
6 1 321446A1 SENDER UNIT Engine Coolant
721D : CASE WHEEL LOADER (NORTH AMERICA)04-13 - HARNESS - ENGINE - WITH BOSCH STARTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-13 - HARNESS - ENGINE - WITH BOSCH STARTER
Page 2 of 2
1 1 8605184 WIRE HARNESS Engine; With Bosch Starter
2 1 328870A1 SENDER UNIT Fuel Level
3 1 279492A1 RESTRICTION SWITCH Air Restriction
4 1 321446A1 SENDER UNIT Engine Coolant
5 1 8500758 HYD CONNECTOR
6 1 404224A1 SENDER EOP
7 5 895-18010 WASHER M10 x 18 x 1.6,
8 1 L127553 STUD Brass
9 1 L127554 WASHER Brass
10 1 L127555 NUT 3/8; Brass
11 1 8501299 BRACKET Harness
12 1 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
13 1 627-10020 BOLT Hex, M10 x 20, 10.9, Full Thd,
14 2 832-10410 LOCK NUT M10 x 1.5, Cl 8,
15 2 627-12025 BOLT Hex, M12 x 1.75 x 25, 10.9, Full Thd,
16 5 814-5030 BOLT Hex, M5 x 30, 8.8,
17 4 840-1316 SCREW Cross Pan Hd, M3 x 16,
18 4 893-11003 LOCK WASHER Ext Tooth, M3,
19 4 824-1403 NUT M3, Cl 5,
20 1 8501337 GROUND CABLE
21 4 L18331 CABLE STRAP
22 2 896-11012 WASHER M13.5 x 24.5 x 3, HT,
23 4 895-11006 WASHER M6,
24 2 627-6020 BOLT Hex, M6 x 20, 10.9, Full Thd,
25 5 895-11005 WASHER M5 x 10 x 1,
30 1 832-10406 NUT M6 x 1, Cl 8,
31 1 8602758 SWITCH Hood Lift
31 1 87350087 SWITCH Hood Lift; Replaces 8602758
32 3 895-11008 WASHER M8 x 16 x 1.6,
33 1 627-8025 BOLT Hex, M8 x 25, 10.9,
34 2 832-10408 LOCK NUT M8 x 1.25, Cl 8,
35 1 L126713 BOOT Electrical
36 1 L126936 SPACER
37 1 827-10060 BOLT Hex, M10 x 60, 10.9,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-13A - HARNESS - ENGINE - WITH DENSO STARTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-13A - HARNESS - ENGINE - WITH DENSO STARTER
Page 2 of 2
1 1 87439024 WIRE HARNESS Engine; With Denso Starter; Replaces 8605184
1 1 87450578 WIRE HARNESS Engine; With Denso Starter; Used with Lights Mounted in Grill
2 1 328870A1 SENDER UNIT Fuel Level
3 1 279492A1 RESTRICTION SWITCH Air Restriction
4 1 321446A1 SENDER UNIT Engine Coolant
5 1 8500758 HYD CONNECTOR
6 1 404224A1 SENDER EOP
7 5 895-18010 WASHER M10 x 18 x 1.6,
8 1 L127553 STUD Brass
9 1 L127554 WASHER Brass
10 1 L127555 NUT 3/8; Brass
11 1 8501299 BRACKET Harness
12 1 627-10030 BOLT Hex, M10 x 30, 10.9, Full Thd,
13 1 627-10020 BOLT Hex, M10 x 20, 10.9, Full Thd,
14 2 832-10410 LOCK NUT M10 x 1.5, Cl 8,
15 2 627-12025 BOLT Hex, M12 x 1.75 x 25, 10.9, Full Thd,
16 5 814-5030 BOLT Hex, M5 x 30, 8.8,
17 4 840-1316 SCREW Cross Pan Hd, M3 x 16,
18 4 893-11003 LOCK WASHER Ext Tooth, M3,
19 4 824-1403 NUT M3, Cl 5,
20 1 8501337 GROUND CABLE
21 4 L18331 CABLE STRAP
22 2 896-11012 WASHER M13.5 x 24.5 x 3, HT,
23 4 895-11006 WASHER M6,
24 2 627-6020 BOLT Hex, M6 x 20, 10.9, Full Thd,
25 5 895-11005 WASHER M5 x 10 x 1,
30 1 832-10406 NUT M6 x 1, Cl 8,
31 1 8602758 SWITCH Hood Lift
31 1 87350087 SWITCH Hood Lift; Replaces 8602758
32 3 895-11008 WASHER M8 x 16 x 1.6,
33 1 627-8025 BOLT Hex, M8 x 25, 10.9,
34 2 832-10408 LOCK NUT M8 x 1.25, Cl 8,
35 1 L126713 BOOT Electrical
36 1 L126936 SPACER
37 1 827-10060 BOLT Hex, M10 x 60, 10.9,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-13B - ENGINE HARNESS MOUNTING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-13B - ENGINE HARNESS MOUNTING
Page 2 of 2
1 1 504011726 WIRE HARNESS
2 1 17315190 CLAMP
3 1 17315390 CLAMP
4 1 17315690 CLAMP
5 3 17044621 NUT M6
6 3 4899091 SCREW Hex Flg, M8 x 1.25 x 40,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-14 - HARNESS, REAR CHASSIS - HARNESS, THROTTLE CONTROL
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-14 - HARNESS, REAR CHASSIS - HARNESS, THROTTLE CONTROL
Page 2 of 2
Used with Bosch Starter
1 1 8605184 WIRE HARNESS Engine; See Figure 04-13 For Continuation of Harness
2 1 895-11008 WASHER M8 x 16 x 1.6,
3 3 827-6040 BOLT Hex, M6 x 40, 10.9,
4 1 832-10408 LOCK NUT M8 x 1.25, Cl 8,
5 1 896-11012 WASHER M13.5 x 24.5 x 3, HT,
6 1 8500677 THROTTLE CONTROL Analog; Includes Services Kits, Ref 7 - 9
7 X 8603127 REPAIR KIT E-Pedal Sensor, Not Illustrated
8 X 8603128 REPAIR KIT E-Pedal Spring; Not Illustrated
9 X 8603129 REPAIR KIT E-Pedal Bellows; Not Illustrated
10 1 L126713 BOOT
11 3 895-11006 WASHER M6,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-14A - HARNESS, REAR CHASSIS - HARNESS, THROTTLE CONTROL
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-14A - HARNESS, REAR CHASSIS - HARNESS, THROTTLE CONTROL
Page 2 of 2
With Denso Starter
1 1 87439024 WIRE HARNESS Engine; See Figure 04-?? For Continuation of Harness; Replaces 8605184
1 1 87450578 WIRE HARNESS Engine; See Figure 04-?? For Continuation of Harness; Replaces 87439024
2 1 895-11008 WASHER M8 x 16 x 1.6,
3 3 827-6040 BOLT Hex, M6 x 40, 10.9,
4 1 832-10408 LOCK NUT M8 x 1.25, Cl 8,
5 1 896-11012 WASHER M13.5 x 24.5 x 3, HT,
6 1 8500677 THROTTLE CONTROL Analog; Includes Services Kits, Ref 7 - 9
7 X 8603127 REPAIR KIT E-Pedal Sensor, Not Illustrated
8 X 8603128 REPAIR KIT E-Pedal Spring; Not Illustrated
9 X 8603129 REPAIR KIT E-Pedal Bellows; Not Illustrated
10 1 L126713 BOOT
11 3 895-11006 WASHER M6,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-14B - HARNESS, REAR - RELAY PANEL WITH BOSCH OR DENSO STARTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-14B - HARNESS, REAR - RELAY PANEL WITH BOSCH OR DENSO STARTER
Page 2 of 2
1 1 120398A1 RELAY Starter
3 4 895-11008 WASHER M8 x 16 x 1.6,
4 2 627-8025 BOLT Hex, M8 x 25, 10.9,
5 2 832-10408 LOCK NUT M8 x 1.25, Cl 8,
6 1 319055A1 JUNCTION BLOCK Assy
7 1 440038A1 JUNCTION BLOCK Block; Fuse
8 1 8500911 FUSE HOLDER Midifuse; Replaced By 87404860
8 1 87404860 FUSE HOLDER Midifuse;
9 1 8602731 WIRE HARNESS Relay Box
10 1 8602665 WIRE Megafuse To Relay
11 1 8602172 WIRE CONNECTOR Junction Block To Relay
12 1 8602173 WIRE CONNECTOR Junction Block To Midifuse
13 1 8602174 WIRE CONNECTOR Junction Block To Relay
14 16 895-11006 WASHER M6,
15 8 627-6020 BOLT Hex, M6 x 20, 10.9, Full Thd,
16 2 892-11008 LOCK WASHER M8,
17 2 829-1408 NUT M8, Cl 10,
18 1 8501314 FUSE 40 Amp
19 1 8501311 FUSE 150 Amp
20 2 L126713 BOOT
21 1 1546485C1 RELAY Power
22 2 840-1516 SCREW Cross Pan Hd, M5 x 16, 4.8,
23 10 832-10406 NUT M6 x 1, Cl 8,
24 4 326845A1 RELAY
25 1 8602175 COVER
26 2 895-11005 WASHER M5 x 10 x 1,
27 2 832-10405 LOCK NUT M5 x .8, Cl 8,
28 4 895-11003 WASHER M3,
29 6 840-1316 SCREW Cross Pan Hd, M3 x 16,
30 6 824-1403 NUT M3, Cl 5,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-15 - HARNESS - HOOD - IF USED
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-15 - HARNESS - HOOD - IF USED
Page 2 of 2
1 1 8602806 WIRE HARNESS Hood
2 6 895-11008 WASHER M8 x 16 x 1.6,
3 3 627-8025 BOLT Hex, M8 x 25, 10.9,
4 3 832-10408 LOCK NUT M8 x 1.25, Cl 8,
5 4 832-10406 NUT M6 x 1, Cl 8,
6 4 L18331 CABLE STRAP 15"
7 8 895-11006 WASHER M6,
8 1 L126051 GROUND STRAP
9 2 253347A1 NUT Brass
10 2 L127554 WASHER Brass
11 1 D121972 ALARM Backup
12 4 627-6020 BOLT Hex, M6 x 20, 10.9, Full Thd,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-15A - HARNESS, HOOD - BACKUP ALARM/ LIGHTS/LICENSE PLATE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-15A - HARNESS, HOOD - BACKUP ALARM/ LIGHTS/LICENSE PLATE
Page 2 of 2
1 1 8602806 WIRE HARNESS Hood
1 1 87450580 WIRE HARNESS Hood; Used with Lights Mounted in Grille
2 1 D121972 ALARM Backup
3 4 627-6020 BOLT Hex, M6 x 20, 10.9, Full Thd,
4 8 895-11006 WASHER M6,
5 4 832-10406 NUT M6 x 1, Cl 8,
6 3 627-8025 BOLT Hex, M8 x 25, 10.9,
7 6 895-11008 WASHER M8 x 16 x 1.6,
8 3 832-10408 LOCK NUT M8 x 1.25, Cl 8,
9 1 L126936 SPACER
10 1 827-8060 BOLT Hex, M8 x 60, 10.9,
11 2 L127554 WASHER Brass
12 2 253347A1 NUT Brass
13 1 L126051 GROUND STRAP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-16 - ELECTRICAL - STEERING, AUXILIARY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-16 - ELECTRICAL - STEERING, AUXILIARY
Page 2 of 2
1 1 87581480 ELECTRIC PUMP Auxiliary Steering; Replaces 380013A1; See Figure 05-09
2 1 8500605 HARNESS Auxiliary Steering; Incl. 3 - 8
3 1 245487C1 ELEC CONNECTOR
4 2 1964712C1 TERMINAL CONNECTOR
5 1 1964704C1 TERMINAL CONNECTOR
6 1 225389C1 CONNECTOR Secondary Steering Module
7 1 225316C1 ELEC CONNECTOR Secondary Steering Solenoid
8 1 245485C1 ELEC CONNECTOR Secondary Steering Pressure Switch
9 2 627-8025 BOLT Hex, M8 x 25, 10.9,
10 1 8603171 MODULE Auxiliary Steering
11 2 832-10408 LOCK NUT M8 x 1.25, Cl 8,
12 4 895-11008 WASHER M8 x 16 x 1.6,
13 1 L129707 NEG BATTERY CABLE
14 2 L127554 WASHER
15 2 253347A1 NUT M10 - 1.5; Brass
16 1 8501228 WIRE HARNESS Auxiliary Steering
17 6 L18331 CABLE STRAP
18 1 L126713 BOOT Electrical
721D : CASE WHEEL LOADER (NORTH AMERICA)04-17 - BATTERY - CABLES WITH BOSCH STARTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-17 - BATTERY - CABLES WITH BOSCH STARTER
Page 2 of 2
2 1 L126256 SWITCH Master Disconnect
3 1 8602881 GROUND CABLE
4 1 87403980 ELECTRIC CABLE Crossover
5 1 435686A2 NEG BATTERY CABLE
6 1 8602636 CABLE Positive
7 2 L126713 BOOT
8 1 L126051 GROUND STRAP Engine Block
9 3 L127554 WASHER
10 3 253347A1 NUT 3/8
11 1 L127676 WIRE HARNESS Disconnect
12 2 515-22159 CLAMP 5/8", Insul, 5/16" Bolt,
13 9 895-11008 WASHER M8 x 16 x 1.6,
14 2 398771A1 CONDUIT Battery Cable
15 3 627-8025 BOLT Hex, M8 x 25, 10.9,
16 2 A176482 BATTERY WET 700Amp / 12V; BMF31EW; If Used
17 2 L51769 BATTERY WET 900 Amp / 12V; If Used; Not Illustrated
18 2 L124221 SUPPORT Used with 900 Amp Battery; Not Illustrated
18A 2 365191A1 STRAP Used with 700 Amp Battery
19 4 365357A1 ROD Hold Down
20 4 895-15008 WASHER M8 x 20 x 1.6,
21 10 832-10408 LOCK NUT M8 x 1.25, Cl 8,
22 3 R54363 CLAMP
23 4 L18331 CABLE STRAP
24 5 896-11012 WASHER M13.5 x 24.5 x 3, HT,
25 3 L111928 CLAMP
26 1 627-12025 BOLT Hex, M12 x 1.75 x 25, 10.9, Full Thd,
27 2 D39696 CLAMP
28 1 82009428 KIT Solenoid Seal
721D : CASE WHEEL LOADER (NORTH AMERICA)04-17A - BATTERY - CABLES WITH DENSO STARTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-17A - BATTERY - CABLES WITH DENSO STARTER
Page 2 of 2
2 1 L126256 SWITCH Master Disconnect
3 1 8602881 GROUND CABLE
4 1 87403980 ELECTRIC CABLE Crossover
5 1 435686A2 NEG BATTERY CABLE
6 1 87439026 ELECTRIC CABLE Positive; Replaces 8602636
7 3 L126713 BOOT
8 1 L126051 GROUND STRAP Engine Block
9 3 L127554 WASHER Brass
10 3 253347A1 NUT 3/8; Brass
11 1 L127676 WIRE HARNESS Disconnect
12 3 515-22159 CLAMP 5/8", Insul, 5/16" Bolt,
13 9 895-11008 WASHER M8 x 16 x 1.6,
14 2 398771A1 CONDUIT Battery Cable
15 3 627-8025 BOLT Hex, M8 x 25, 10.9,
16 2 A176482 BATTERY WET 700Amp / 12V; BMF31EW; If Used
17 2 L51769 BATTERY WET 900 Amp / 12V; If Used; Not Illustrated
18 2 L124221 SUPPORT Used with 900 Amp Battery; Not Illustrated
18A 2 365191A1 STRAP Used with 700 Amp Battery
19 4 365357A1 ROD Hold Down
20 13 895-15008 WASHER M8 x 20 x 1.6,
21 10 832-10408 LOCK NUT M8 x 1.25, Cl 8,
22 3 R54363 CLAMP
23 4 L18331 CABLE STRAP
24 5 896-11012 WASHER M13.5 x 24.5 x 3, HT,
25 3 L111928 CLAMP
26 1 627-12025 BOLT Hex, M12 x 1.75 x 25, 10.9, Full Thd,
27 1 D39696 CLAMP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-18 - MOUNTING - LAMP, FRONT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-18 - MOUNTING - LAMP, FRONT
Page 2 of 2
1 1 380897A1 BRACKET RH
2 1 380898A1 BRACKET LH
3 4 627-12040 BOLT Hex, M12 x 40, 10.9, Full Thd,
4 4 896-11012 WASHER M13.5 x 24.5 x 3, HT,
5 1 368055A1 LIGHT Combination; RH; Includes Hardware; See Figure 04-19
6 1 368056A1 LIGHT Combination; LH; Includes Hardware; See Figure 04-19
7 1 407442A1 PLATE Support For License Plate
721D : CASE WHEEL LOADER (NORTH AMERICA)04-19 - LAMP ASSY - LAMP, FRONT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-19 - LAMP ASSY - LAMP, FRONT
Page 2 of 2
1 368055A1 LIGHT Combination; RH; Includes Hardware; Incl. 1 - 7
1 368056A1 LIGHT Combination; LH; Includes Hardware; Incl. 1 - 7
1 1 NSS NOT SERVICED SEPARATELY Housing
2 1 408142A1 LENS Turn Signal and Flasher
3 1 408143A1 LENS Head Light
4 1 410939A1 BULB 24V; Turn Signal and Flasher
5 1 410940A1 BULB 24V; Position
6 1 410942A1 BULB 24V; High Beam
7 1 410941A1 BULB 24V; Low Beam
721D : CASE WHEEL LOADER (NORTH AMERICA)04-20 - LAMP ASSY- REAR LIGHTS AND MOUNTING - IF USED
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-20 - LAMP ASSY- REAR LIGHTS AND MOUNTING - IF USED
Page 2 of 2
1 1 411778A1 LIGHT, TAIL Combination; RH; Incl. 5, 6; Mounted In Grille
2 1 411777A1 LIGHT, TAIL Combination; LH; Incl. 5, 6; Mounted In Grille
3 8 892-11005 LOCK WASHER M5,
4 8 825-1405 NUT M5, Cl 8,
5 1 A186295 LENS
6 2 A15084 LAMP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-20A - LAMP ASSY - LAMPS, REAR COMBINATION - IF USED
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-20A - LAMP ASSY - LAMPS, REAR COMBINATION - IF USED
Page 2 of 2
1 1 87404946 LIGHT ASSY. Combination; RH; Incl. 6 - 9
2 1 87404944 LIGHT ASSY. Combination; LH; Incl. 5, 7 - 9
3 4 864-6020 SCREW Hex Soc Hd, M6 x 20, 8.8,
4 2 L18331 CABLE STRAP 15"
5 1 8603178 LENS LH
6 1 8603177 LENS RH
7 1 408146A1 GASKET Not Illustrated
8 1 411085A1 LAMP 24V, 10W; Tail
9 3 410939A1 BULB 24V; Stop, Reverse, Turn Signal
721D : CASE WHEEL LOADER (NORTH AMERICA)04-20B - LAMP ASSY - LAMPS, REAR COMBINATION (OPTIONAL GUARD)
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-20B - LAMP ASSY - LAMPS, REAR COMBINATION (OPTIONAL GUARD)
Page 2 of 2
1 1 8605683 BRACKET Left Guard; Case Power Tan
2 1 8605684 BRACKET Right Guard; Case Power Tan
3 2 8605680 GUARD Tail Light; Case Power Tan
4 2 896-11008 WASHER M8 x 17.5 x 2, HT,
5 2 832-10408 LOCK NUT M8 x 1.25, Cl 8,
6 4 864-6025 SCREW Hex Soc Hd, M6 x 25, 8.8,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-21 - LICENSE PLATE LIGHT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-21 - LICENSE PLATE LIGHT
Page 2 of 2
1 1 193446A1 PLATE License
2 4 895-15006 WASHER M6 x 25 x 1.6,
3 6 614-6020 BOLT Hex, M6 x 20, 8.8,
4 4 895-11006 WASHER M6,
5 4 832-10406 NUT M6 x 1, Cl 8,
6 1 120229A1 LIGHT
7 2 892-11006 LOCK WASHER M6,
8 2 829-1406 NUT M6, Cl 10,
9 4 L18331 CABLE STRAP 15"
721D : CASE WHEEL LOADER (NORTH AMERICA)04-22 - LAMP - LICENSE PLATE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-22 - LAMP - LICENSE PLATE
Page 2 of 2
1 1 120229A1 LIGHT License Plate; Incl. 2
2 1 E133303 BULB 24V
3 2 829-1406 NUT M6, Cl 10,
4 2 892-11006 LOCK WASHER M6,
5 2 614-6020 BOLT Hex, M6 x 20, 8.8,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-23 - LAMP ASSY, FRONT AND REAR - CAB/CANOPY
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-23 - LAMP ASSY, FRONT AND REAR - CAB/CANOPY
Page 2 of 2
REF INSTRUCTION CAB OR CANOPY FLOOD LAMPS
4 A187520 LIGHT ASSY. Incl. 1 - 6
1 1 A187913 SUPPORT
2 1 121-232 BOLT Hex Flg, 5/16"-18 x 2", Serr,
3 1 231-5145 NUT Flg, USR, 5/16"-18,
4 2 273-10510 SELF-TAP SCREW Slotted Flat Hd, #10 x 5/8",
5 1 103653A1 HEADLIGHT
6 1 NSS NOT SERVICED SEPARATELY Housing
721D : CASE WHEEL LOADER (NORTH AMERICA)04-24 - BEACON ASSY, ROTATING - MOUNTING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-24 - BEACON ASSY, ROTATING - MOUNTING
Page 2 of 2
1 367751A1 BEACON Rotating; Incl. 1 - 8
1 1 192809A1 LENS Amber
1 1 87400956 LENS Blue
2 3 168-71 SCREW Drive, #8 x 1/2", Lens mounting
3 3 238-5005 O-RING -005, 70 Duro, .101" ID x .070" Thk,
4 1 NSS NOT SERVICED SEPARATELY Clip
5 1 P40533 LAMP 24V; Halogen
6 1 A187575 BELT Drive Motor
7 1 NSS NOT SERVICED SEPARATELY Base; Incl. Drive Motor
8 3 614-6020 BOLT Hex, M6 x 20, 8.8,
11 1 238764A2 WIRE HARNESS Cab Roof
12 1 374430A2 BEACON SWITCH Rotating Beacon
13 1 A149799 FUSE 7.5 amp
14 1 REF INSTRUCTION HARNESS MAIN CAB; SEE FIG 04-09
15 1 313215A2 BRACKET Beacon Mounting
16 1 313213A3 BRACKET Beacon Mounting; At Cab
17 1 313216A2 ARM Beacon Mounting
18 2 38-31620 PIN 1/4" x 1 1/4", Coiled,
19 2 373596A1 SPRING Return
20 2 495-11081 WASHER 3/4", SAE,
21 2 100-3375 LOCKING RING #75, .574" Dia, E-Type,
22 3 864-8020 SCREW Hex Soc Hd, M8 x 20, 8.8,
23 X L18331 CABLE STRAP
24 3 892-11008 LOCK WASHER M8,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-25 - HARNESS - CIGAR LIGHTER
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-25 - HARNESS - CIGAR LIGHTER
Page 2 of 2
1 1 REF INSTRUCTION HARNESS MAIN CAB; SEE FIG 04-09
2 1 A149801 FUSE 15 amp
3 1 313368A1 WIRE HARNESS Cigar Lighter
4 1 319055A1 JUNCTION BLOCK
5 1 E134655 LIGHTER, CIGARETTE
6 X L18331 CABLE STRAP 15"
721D : CASE WHEEL LOADER (NORTH AMERICA)04-26 - CANOPY, ROPS - WIPER, FRONT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-26 - CANOPY, ROPS - WIPER, FRONT
Page 2 of 2
1 1 322848A1 MOTOR, WIPER 24 volt; Windshield Front
1 AR 322848A1R REMAN-WIPER MOTOR Wiper Motor - For N.A. Only
AR 322848A1C CORE-WIPER MOTOR Return Number, ELECTRONIC CONTROL UNIT - for N.A. Only
2 1 399232A1 COVER Front Wiper
3 2 1270742C1 SCREW Cross Pan Hd, M6 x 12,
4 2 833-40306 NUT M6, U,
5 1 627-6012 BOLT Hex, M6 x 12, 10.9, Full Thd,
6 1 892-11006 LOCK WASHER M6,
7 1 321736A1 ARM, WIPER Dual; Replaced By 87319294
7 1 87319294 ARM, WIPER Dual; 800mm
8 1 A187574 WIPER BLADE 700 mm (27-9/16 in); Replaced By 87319295
8 1 87319295 WIPER BLADE Assembly 700mm (27-9/16 in); Includes 'U' Shaped Retaining Clip
9 1 1968053C1 ELBOW 90 deg Bulkhead
10 1 N8361 WASHER Belleville
11 1 326203A1 NUT
12 1 248-1169 GROMMET 3/8" ID x 5/8" Groove Dia,
13 1 236781A1 CONTAINER Container/A; Windshield Washer; Front; If Used
13 1 371185A1 WINDSHIELD WASH RESERVOIR Container/A; Windshield Washer; Front; If Used
13A 1 87439461 CAP Vented with Tether
14 1 324467A1 HOSE 559mm (22 in); Pump to Check Valve; Cut from 4-1056T1; If Used
14 1 8500662 HOSE WASHER 2540mm (100 in); Pump to Check Valve; Cut from 4-1056T1; If Used
15 1 324203A1 CHECK VALVE
16 1 324468A1 HOSE 1651 mm (65 in); Windshield Washer; Front
17 3 832-10408 LOCK NUT M8 x 1.25, Cl 8,
18 3 895-15008 WASHER M8 x 20 x 1.6,
19 2 L18331 CABLE STRAP M8 x 20; 8,8; Znd
721D : CASE WHEEL LOADER (NORTH AMERICA)04-27 - CAB - WIPER, FRONT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-27 - CAB - WIPER, FRONT
Page 2 of 2
1 1 322848A1 MOTOR, WIPER 24 volt; Windshield Front; Incl. 87408552 Motor; 87408553 Hardware Kit
1 AR 322848A1R REMAN-WIPER MOTOR Wiper Motor - For N.A. Only
AR 322848A1C CORE-WIPER MOTOR Return Number, ELECTRONIC CONTROL UNIT - for N.A. Only
87408552 WIPER MOTOR
87408553 KIT Hardware
2 1 399232A1 COVER Front Wiper
3 2 1270742C1 SCREW Cross Pan Hd, M6 x 12,
4 2 833-40306 NUT M6, U,
5 1 627-6012 BOLT Hex, M6 x 12, 10.9, Full Thd,
6 1 892-11006 LOCK WASHER M6,
7 1 321736A1 ARM, WIPER Dual; Replaced By 87319294
7 1 87319294 ARM, WIPER Dual; 800mm
8 1 A187574 WIPER BLADE 700 mm (27-9/16 in); Replaced By 87319295
8 1 87319295 WIPER BLADE Assembly 700mm (27-9/16 in); Includes 'U' Shaped Retaining Clip
9 1 1968053C1 ELBOW 90 deg Bulkhead
10 1 N8361 WASHER Belleville
11 1 326203A1 NUT
12 1 248-1169 GROMMET 3/8" ID x 5/8" Groove Dia,
13 1 371185A1 WINDSHIELD WASH RESERVOIR Windshield Washer; Front and Rear; Incl. 13A
13A 1 87439461 CAP Vented with Tether
14 3 895-15008 WASHER M8 x 20 x 1.6,
15 3 832-10408 LOCK NUT M8 x 1.25, Cl 8,
16 2 8500662 HOSE WASHER 2540 mm (100 in); Reservoir to Check Valve; Cut from 4-1056T1
17 1 324203A1 CHECK VALVE
18 1 324468A1 HOSE 1651 mm (65 in); Windshield Washer; Front
19 X L18331 CABLE STRAP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-28 - CAB - WIPER, REAR
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)04-28 - CAB - WIPER, REAR
Page 2 of 3
1 413378A1 MOTOR, WIPER 24 volt; Incl. 1 - 14
1 1 87408552 WIPER MOTOR 24 volt; Windshield Rear; Replaces 431823A1
87408553 KIT Hardware; Incl. 10, 11, 13, 14
2 1 NSS NOT SERVICED SEPARATELY Bracket
3 3 NSS NOT SERVICED SEPARATELY Screw, Special
4 1 NSS NOT SERVICED SEPARATELY Washer, Special, Retaining
5 1 NSS NOT SERVICED SEPARATELY Nut, Special
6 1 NSS NOT SERVICED SEPARATELY Arm, Wiper
7 1 413824A1 LINK
8 1 NSS NOT SERVICED SEPARATELY Shaft
9 4 NSS NOT SERVICED SEPARATELY Screw, Special
10 1 L112088 WASHER Shaft
11 1 L112087 NUT Shaft
12 1 L112089 WASHER
13 1 829-1408 NUT M8, Cl 10,
14 1 L112081 CAP
15 5 892-11006 LOCK WASHER M6,
16 1 627-6012 BOLT Hex, M6 x 12, 10.9, Full Thd,
17 4 614-6020 BOLT Hex, M6 x 20, 8.8,
18 1 324869A2 COVER Rear Wiper
19 1 A187712 ARM, WIPER Windshield Rear; Replaced By 87319296
19 1 87319296 ARM, WIPER Windshield Rear
20 1 132024A1 WIPER BLADE Replaced By 87319297
20 1 87319297 WIPER BLADE Blade; 500mm (19-1/2 in)
21 1 1345074C1 SEAL
22 1 353-411 PLUG Dome, 1.000" hole, Nylon,
23 1 248-1169 GROMMET 3/8" ID x 5/8" Groove Dia,
24 1 371185A1 WINDSHIELD WASH RESERVOIR Windshield Washer; Front And Rear; See Figure 04-27 For Mounting Hardware; Incl. 24a
721D : CASE WHEEL LOADER (NORTH AMERICA)04-28 - CAB - WIPER, REAR
Page 3 of 3
24A 1 87439461 CAP Vented with Tether
25 1 8500662 HOSE WASHER 2540 mm (100 in); Reservoir to Check Valve; Cut from 4-1056T1
26 1 324203A1 CHECK VALVE
27 1 324469A1 HOSE 3073 mm (121 in); Windshield Washer; Rear; Cut from 4-1056T1
28 4 L100659 CLIP
29 1 324550A1 JET Windshield Washer; Rear
30 1 248-1237 GROMMET 1/4" ID x 1" Groove Dia, Diag Cut,
31 X L18337 CABLE STRAP 9.95"-12.1" lg, Not Illustrated
721D : CASE WHEEL LOADER (NORTH AMERICA)04-29 - RADIO - MOUNTING -12 VOLT
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-29 - RADIO - MOUNTING -12 VOLT
Page 2 of 2
REF INSTRUCTION RADIO READY SYSTEM
REF INSTRUCTION 12 VOLT
1 1 197745A1 ANTENNA
2 1 316654A1 CABLE ASSY. Antenna
3 1 316655A1 GROUND CABLE
4 1 893-11006 LOCK WASHER Ext Tooth, M6,
5 1 829-1406 NUT M6, Cl 10,
6 1 277919A2 HARNESS Radio
7 1 A149799 FUSE 7.5 amp
8 1 277982A1 TRANSFORMER 24 - 12 V
9 1 319160A1 WIRE HARNESS Radio
10 1 316666A2 SUPPORT Radio; Use Existing Hardware
13 2 182721A2 SPEAKER 5-1/2
14 2 187281A1 COVER
15 8 761-17325 SELF-TAP SCREW Pan Hd, M4.2 x 25,
16 8 302862A1 NUT
17 2 L18331 CABLE STRAP 15"
18 2 169850C2 CABLE CLIP
19 2 760-14113 SELF-TAP SCREW Pan Hd, M3.5 x 13,
721D : CASE WHEEL LOADER (NORTH AMERICA)04-30 - RADIO - MOUNTING - 24 VOLT REMOTE
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-30 - RADIO - MOUNTING - 24 VOLT REMOTE
Page 2 of 2
REF INSTRUCTION REMOTE RADIO SYSTEM
REF INSTRUCTION 24 VOLT
1 1 197745A1 ANTENNA
2 1 316654A1 CABLE ASSY. Antenna
3 1 316655A1 GROUND CABLE
4 1 893-11006 LOCK WASHER Ext Tooth, M6,
5 1 829-1406 NUT M6, Cl 10,
6 1 277919A2 HARNESS Radio
7 1 A149799 FUSE 7.5 amp
8 1 319160A1 WIRE HARNESS Radio Installation
9 1 316781A2 RADIO 24 Volt; Main Chassis; Use Existing Hardware
12 1 186082A1 REMOTE CONTROL Radio
13 2 842-1425 SCREW Cross Oval Hd, M4 x 25, 4.8,
14 2 302862A1 NUT
15 2 182721A2 SPEAKER 5-1/2
16 2 187281A1 COVER
17 8 761-17325 SELF-TAP SCREW Pan Hd, M4.2 x 25,
18 8 302862A1 NUT
19 1 186084A1 RADIO 24 Volt; Tape Player; Order from Ship Direct; If Used; Europe Only
20 2 L18331 CABLE STRAP 15"
21 1 334569A1 PLATE Mounting for Tape Player; If Used; Europe Only
22 2 169850C2 CABLE CLIP
721D : CASE WHEEL LOADER (NORTH AMERICA)04-31 - CONVERTER, POWER OUTLET - MOUNTING
Page 1 of 2
721D : CASE WHEEL LOADER (NORTH AMERICA)04-31 - CONVERTER, POWER OUTLET - MOUNTING
Page 2 of 2
REF INSTRUCTION POWER OUTLET
1 1 318150A2 WIRE HARNESS Converter
2 1 A149799 FUSE 7.5 amp
3 1 318356A1 TRANSFORMER 24 - 12 V
4 1 363649A2 SUPPORT Converter
5 2 895-18010 WASHER M10 x 18 x 1.6,
6 2 832-10410 LOCK NUT M10 x 1.5, Cl 8,
7 4 760-14395 SELF-TAP SCREW Pan Hd, M4.2 x 9.5,
8 2 L18331 CABLE STRAP 15"
9 1 283779A1 POWER SOCKET
10 1 283781A1 CAP Plug
721D : CASE WHEEL LOADER (NORTH AMERICA)05-01 - STEERING WHEEL - COLUMN
Page 1 of 3
721D : CASE WHEEL LOADER (NORTH AMERICA)05-01 - STEERING WHEEL - COLUMN
Page 2 of 3
1 1 384985A1 CAP Incl. 1A
1A 1 1342054C1 PLASTIC PLUG Not Illustrated
1B 1 87578198 EMBLEM CASE; Not Illustrated, If Used
2 1 NSS NOT SERVICED SEPARATELY M14, Nut
3 1 895-11014 WASHER M14 x 28 x 2.5,
1 283484A1 STEERING WHEEL Incl. 4 - 8A
4 1 D147465 STEERING WHEEL Not Serviced Separately; Order 283484A1; See Below
1 283484A1 STEERING WHEEL Incl. Spacer Ring, Wheel Hub, Bolt, Washers and Wheel; Not Illustrated; Replaces D148204
5 3 NSS NOT SERVICED SEPARATELY Bolt
6 1 NSS NOT SERVICED SEPARATELY Cap
7 1 329105A1 HUB
8 1 S301400 BOOT
8A 1 NSS NOT SERVICED SEPARATELY Plug; Remote to Use Spinner Knob
9 1 L127996 KNOB Spinner; Includes Washer and Nut
1 226107A3 STEERING COLUMN Tilt; Incl. 2, 10
10 1 318942A1 KIT Locking, Tilt
10 1 339490A1 KIT Spring
10 1 339499A1 KIT Lever
10 1 339500A1 NUT Shaft
10 1 NSS NOT SERVICED SEPARATELY Column, Steering; Housing; Shaft
10A 1 283095A2 BALL KNOB
11 4 627-10025 BOLT Hex, M10 x 25, 10.9, Full Thd,
12 4 895-18010 WASHER M10 x 18 x 1.6,
13 4 829-1410 NUT M10, Cl 10,
14 1 251715A4 SUPPORT
15 1 19-1049 U-BOLT 5/16"-18 x 2 5/16" x 3",
16 2 495-21044 WASHER 3/8",
17 2 425-105 NUT 5/16"-18, G5,
18 1 L100096 ISOLATOR
19 2 7807271 SCREW 3/8 x 1-1/4
20 2 A145915 SEAL
21 1 237344A2 PLATE
22 4 A141515 ISOLATOR
721D : CASE WHEEL LOADER (NORTH AMERICA)05-01 - STEERING WHEEL - COLUMN
Page 3 of 3
23 4 895-15010 WASHER M11 x 24 x 2,
24 4 827-10050 BOLT Hex, M10 x 50, 10.9,
25 2 827-10045 BOLT Hex, M10 x 45, 10.9,
26 2 892-11010 LOCK WASHER M10,
27 1 8602659 HYDRAULIC VALVE Steering; See Figure 05-02
27 1 87307059 HYDRAULIC STEERING Steering; Replaced 8602659
28 1 251730A4 PLATE Instrument Cluster
29 4 627-12025 BOLT Hex, M12 x 1.75 x 25, 10.9, Full Thd,
30 4 896-11012 WASHER M13.5 x 24.5 x 3, HT,
31 4 829-1412 NUT M12, Cl 10,
32 2 251725A3 BRACKET
33 2 627-8025 BOLT Hex, M8 x 25, 10.9,
34 2 895-15008 WASHER M8 x 20 x 1.6,
35 4 833-40306 NUT M6, U,
36 2 895-11008 WASHER M8 x 16 x 1.6,
37 2 829-1408 NUT M8, Cl 10,
