8 7 6 5 4 3 1 2 - Winnebago · 188312-01-000 detail aa wire tie to radio wiring. see wiring...

BA

DETAIL AA

5 PIN HSGTO WIRE ASM-ROOF

3

4

USB CHARGER-DUAL,DC188312-01-000DETAIL AA

WIRE TIE TO RADIO WIRING.

SEE WIRING INSTL-CHASSIS FOR ADDITIONAL INFORMATION.

2. USE SEAL-TRIM 113452-01-000 TO PROTECT WIRES FROM SHARP EDGES.

12V BREAKER PANELDETAIL CA

EEF

SWITCHESDETAIL DB

4

6 PIN HOUSINGTO LEFT MIRROR

BRACKET-RELAY PANEL145448-01-CHTSCREWG67-10-08U (4)

DA

FA

SPEAKER171547-01-CHT (2)SCREWG11-08-20U (8)SPEAKER193631-01-000 (2)SCREWG11-08-20U (8)

2 PIN HSG TOCLEARANCE LIGHTS

DOOR ASM145066-03-CHTSCREWG67-06-10U (6)SCREWG67-10-08U (4)

CB

USE TAPE 136748-01-000 TO SECURE WIRES IN A-POST.

1.

TAPE (2)(400 MM)

WIRING TO OUTSIDE

NOTES:

EEE

PANEL ASM145063-08-CHTSCREWG67-06-10U (6)

WIRE ASM-IP,MAIN301286-01-000

2651B1

1B1 CODES/STANDARDS USA

265 CODES/STANDARDS-CSA/CMVSS

GROMMET23942-01-000 (2)

CUT VISOR WIRING TO 300MM BEFORE CONNECTING.5

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000

FOR ELECTRICALTORQUE

SPECIFICATIONSSEE DWG NO.

128783-01-000

TO SUNVISOR SHADE(3) BUTT SPLICESJJX-BRNHHK-BLKHHL-BLK/GRY

5

RECEPTACLE-12V111414-01-000DETAIL AA

TO SIDEWALL

45D LOFT BED - WITHOUT

70D RADIO - SATELLITE SIRIUSXM

70D3

3 PIN HSG TOWIRE ASM-ROOF 6

45DCONNECT 3-PIN HOUSINGS IN WIRE ASM-ROOFTOGETHER WITH

6

ALARM-JACKS DOWN160876-01-000

LABEL-WARNING,PINCH HAZARD137260-02-CHT

2 PIN HSGTO WIRE ASM-ROOF 3 PIN HSG

TO WIRE ASM-SIDEWALL

6 PIN HSGTO WIRE ASM-SIDEWALL

3

UNSPECIFIED TOLERANCES: MATERIAL:

C

D

1

TWO-PLACE (X.XX)

DSNR:

DESCRIPTION:

8

2

B

ALL DIMENSIONS ARE IN MILLIMETERSDFTR:

6

A

6

FIRST USED:

A

REV

WHOLE DIM (X)

D

REF:

8

ITEM/PART NO:

4

WEIGHT: (LBS)

SHEET:

7

B

2

4

REFER TO ES0018 FOR FASTENERTIGHTENING GUIDELINES

ANGLE

5

5

13

COPYRIGHT 2016 WINNEBAGO INDUSTRIES, INC.

ONE-PLACE (X.X)

C

7

WIRING INSTL-FRONT END

1 OF 10 000177419 / 30128201000

3

1.5

0.50

1

RADIO SPEAKERS-PREMIUM SOUND57P

RADIO SPEAKERS571

AMPLIFIER-PREMIUM AUDIO000013490 / 312664-01-000WIRE ASM-AMP194532-01-000194532-02-000FASTENER-DUAL LOCK85774-01-000 (80 MM)(2)85774-02-000 (80 MM)(2)

BOX ASM-SPEAKER000175453 / 302121-01-XXXSGREWG11-10-16U (4)SPEAKER-8"193633-01-000SCREWG11-08-08U (4)GRILL193633-02-000PLATE-SPEAKER194221-01-000 (2)SCREWG11-08-08U (8)PIGTAIL-SUBWOOFER193633-04-000SEAL123655-01-000(360MM) (2)SCREWG11-10-12U (4)

57P

57P

571

57P

17 L-SER

RADIO-KIT,SXM000111632 / 321635-01-000

28-Jun-2017

265

1B1

YELWHT

1B1

2 & 6 PIN HOUSINGSTO HEATER/AC CONTROLS

NOTES:

WIRE ASM-IP,MAIN

BUTT SPLICESPADE TERMINALTO 12V RCP

2

1

RING TERMINALSTO GROUND STUD

CODES/STANDARDS-CSA/CMVSS

265

2 & 6 PIN HOUSINGSTO LEFT MIRROR

(2) BUTT SPLICESTO CB PREPDETAIL BB

ROUTE WIRES UP LEFT A-PILLAR.

DETAIL BB

TO SWITCHESDETAIL DB

RADIO - CB WIRE PREP

1

2

CODES/STANDARDS USA

DETAIL BA

TO CUSTOMERSCB RADIO

TO WIRE ASM-RADIODETAIL JA

LABEL-CB PREP OPTION104678-01-000

2 PIN HOUSING(2) BUTT SPLICES

579

CB POWER PROVISION

YELLOW +12VWHITE GROUNDCOAX ANTENNA(SEE REVERSE SIDE ALSO)

EDGE OF LABEL TO HANG JUST BELOW BOTTOM OF DASH.

579

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

TO SWITCHES

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 2 OF 1028-Jun-2017

GROMMET23942-01-000SEAL

6BLK

265

VIEW CB(WITH COVER REMOVED)

1

3

1

RELAY63912-02-000 (7)SCREWG11-08-08B (7)

BUSS BAR141744-02-000

1B1

BRACKET-MOUNTING118571-07-000SCREWG19-10-08B (2)NUTG11-10-00B (2)

STUD-FEED THRU118499-01-000 (2)

DETAIL CA(FRONT VIEW)

10YEL

3


DETAIL CA(BACK VIEW)

CODES/STANDARDS USA

8BLK

CHASSIS P0WER

265

1B1

2

NOTES:

BUSS BAR141744-02-000

BRACKET136120-02-CHTSCREWG11-08-08B (2)

6BLK

CIRCUITS LABELED ON BREAKER ARE FROM WIRE ASM-IP,MAIN, UNLESS OTHERWISE SPECIFIED.

SEAL ALL SCREWS ON EXTERIOR SIDE OF COMPARTMENT.REFER TO SEALANT MANUAL.

COACH P0WER

LABEL136161-05-CHT

BUSS BAR141744-01-000

PLATE-CIRCUIT BREAKER139067-07-CHTSCREWG11-08-08U (4)

BUSS BAR141744-02-000

HEADLAMP MODULE(CHASSIS SUPPLIED)SCREWG1108-08B (2)

CIRCUIT BREAKER-6 AMP93654-01-000SCREWG52-06-04U

CIRCUIT BREAKER-15 AMP93654-02-000 (6)SCREWG52-06-04U (6)


CIRCUIT BREAKER-30 AMP93655-02-000SCREWG52-06-04U

PLUG81211-06-000 (7)

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

LABEL-CIRCUITBREAKER-MAIN93236-48-000

BUSS BAR141744-01-000

SJ

CIRCUIT FFD IS PART OF WIRE ASM-CHASSIS.


158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 3 OF 10

PARK BRAKEINTERLOCK

DOORUNLOCK

POWERSEATS

DOCKINGLAMPS

RUN/ACCPOWER #2

DOORLOCK

WIPER/WASHER

DOCKINGLAMPS

SWITCHTRIGGER

AUXSTART

SOLENOID

COOLINGFANS

FOGLAMPS

RUN/ACCPOWER #1

POWERMIRRORS

DOMELAMP

HEATERBLOWER

RUNONLY

POWER

25

25

1520

15

20

12 VOLTRECPS

MIRRORS

HEATERA/C

DOORLOCKS

HI-SPDBLOWER

BRAKECONTROLLER

(WORKHORSE)

RUN/ACCPOWER #1

RUN/ACCPOWER #2

POWERSEATS

CHASSISBATTERY

FEED

STEPBATTERY

POWER

AWNING

FOG/SPOT

LAMPSCOOLING

FANSDOCKING

LAMPS

RADIO

STEPCONTROL

POWER

WIPER/WASHER

(FREIGHTLINER)

RUN ONLYPOWER

6 30

15

15

15 1520

MK

RH

EEE

KKA JJY

ER

JJW

WJ

LW

FX KA

DDF

LS

28-Jun-2017



128783-01-000

1

SEE SHEET 5 FOR GAUGE PLACEMENT.

SWITCH-BATTERY BOOST174757-31-CHT

SWITCH-MIRROR HEAT174757-25-CHT

SWITCH-EXHAUST BRAKE174757-29-CHTDETAIL EA

MOUNT SWITCH SO WHEN ACTUATOR IS PUSHED LEFT,THE LETTER L IS SHOWING.

LABEL-JACKS DOWN133533-01-CHT

SWITCH-GEN SET174757-05-CHT

4

PANEL-SWITCHMOUNTING,3-WAY174834-02-CHT

265

2

SWITCH-HEADLAMP(CHASSIS SUPPLIED)PLATE-MOUNTING189004-02-CHTCLAMP-MOUNTING189009-01-CHTNUTD65-08-08U (4)

SWITCH-MIRRORCONTROLS88246-01-000SPACER-SWITCH,MIRROR184039-01-CHT

SWITCH-SOLAR SHADE145638-04-CHT

CLUSTER(CHASSIS SUPPLIED)

CONNECT TO MATING LABELED CONNECTOR ON CHASSISSUPPLIED WIRING.


4

CONNECT POSITIVE WIRE TO TERMINAL MARKEDWITH A "+", YEL-WINNEBAGO WIRING RED-HWH WIRING

DETAIL DB

SWITCH-AIR HORN174757-13-CHT

1B1

LIGHT ASM-INDICATOR,RED190682-01-000

NOTES:

3

265

SWITCH-FRONT AUX174757-35-CHT

DETAIL DA

CODES/STANDARDS USA

2

1

1B1


SWITCH-RADIO POWER174757-12-CHT


3

SWITCH-WIPER174663-01-000

INFORMATIONBAR SWITCH(CHASSIS SUPPLIED)

PLATE ASM-SWITCH118662-29-CHTNUTD27-08-00B (2)

5

5RADIO000014453 / 311897-01-000DETAIL JA

7. APPLY TAPE 8363-01-000 AS NECESSARYTO SECURE NON-LOCKING CONNECTIONS.

ATTACH TO RADIO WITH SCREW SUPPLIED WITH RADIO.6

PLUG USB CABLE INTO LEAD ON BACK OF RADIO MARKED 'USB'ROUTE CABLE TO DASH POCKET BELOW RADIO.

6

DETAIL DC

REPLACE CHASSIS SUPPLIED IGNITION SWITCH.9

9SWITCH-IGNITION185422-01-000

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000

CHASSIS SUPPLIED ROCKER SWITCHES. DOME LAMP SWITCH NOT USED.SEE DETAIL DC FOR SWITCH POSITION.

8

8

SWITCH-DOME LIGHT174757-10-CHT

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 4 OF 1028-Jun-2017

4

6

7

11

5

2

8

12

9

3

1

10

WIRE ASM-EXHAUST BRAKE SWITCH000026468 / 315655-01-000

CONNECTS TOCHASSIS WIRING

NOTES:

CHASSIS WIRING HAS MATING CONNECTORAND IS LABELED "ENGINE BRAKE SWITCH"

1

1

DETAIL EA

2651B1


265 CODES/STANDARDS-CSA/CMVSS

FREIGHTLINER CLUSTERLOCATION

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 5 OF 10

TACHOMETER SPEEDOMETER

OILPRESSURE

ENGINETEMPERATURE

FRONT AIRPRESSURE

REAR AIRPRESSURE

FUEL

VOLTMETER

28-Jun-2017

265

CODES/STANDARDS USA


VIEW FA1B1 265

1B1

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

2 PIN HOUSINGTO WASHER BOTTLE

4 PIN HOUSINGTO WIRE ASM-HEADLAMP

WIRE ASM-IP,MAINFROM INTERIOR

RELAY177459-01-000 (3)SCREWG39-10-08U (3)

TO EVAPORATORTHERMOSTAT ANDA/C BINARY SWITCH

4 PIN HOUSINGTO WIRE ASM-HEADLAMP

6 PIN HOUSINGTO RIGHT MIRROR

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 6 OF 1028-Jun-2017

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

CODES/STANDARDS USA


2651B1

1B1

265

ANTENNA-RADIO90944-02-000CABLE ASM-ANTENNA90944-03-000EXTENDER-SHAFT109889-01-000

REAR EDGEOF ROOF CAP

70C

DETAIL GA

ROUTE CABLE TO EXTERIOR THRU HOLE IN PANEL ALONG WITHHEATER WIRING TO RIGHT CAMERA IN MIRROR.

52.0

500

150

2

3

TO REAR CAMERA

CABLE-MONITORTO LEFT MIRROR

REAR CAMERA CABLE

CABLE-MONITORTO RIGHT MIRROR

RADIO - SATELLITE SIRIUSXM70D4

3

4

ANTENNA-SATELLITE RADIO(SUPPLIED W/ SXM RECEIVER)PLATE-SATELLITE RADIO177256-03-CHTSCREWG11-08-08U (4)SEAL

1

70D

2

MOUNT ANTENNA SUCH THAT BASE IS SQUARE WITH REAR OF ROOFCAP AND COVERS HOLE IN ROOF.

RUN CABLE UP A-PILLAR THRU LEFT HAND COVE TO REAR OF UNIT.

1

NOTES:

SEAL AROUND ANTENNA BASE.

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 7 OF 1028-Jun-2017

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

CODES/STANDARDS USA


2651B1

1B1

265

1

1

2

2

NOTES:

PARTS SUPPLIED WITH REAR CAMERA, VISOR NOT USED.

ALIGN CAMERA IN CENTER OF SHROUD OPENING ANDADJUST SO BACKWALL IS JUST VISIBLE.

CAMERA-REAR183822-01-CHT

REAR CAP(REF)

BARCKET-CAMERA

BARCKET-MOUNT,CAMERA152022-05-CHTWASHERE13-14-00U (2)NUTD29-04-00U (2)

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 8 OF 1028-Jun-2017



128783-01-000

CODES/STANDARDS USA


2651B1

1B1

265

3

2

1

65

12

4

11

3

10

2

9

1

87

7

6 5

12

4

11

23

10

9

1

8

2

1

3

NOTES:

MARK RIGHT CABLE WITH WHITE TAPE 900000-08-000 NEXT TOCONNECTOR.

MARK LEFT CABLE WITH YELLOW TAPE 900000-07-000 NEXT TOCONNECTOR.

2

1

TO LEFTCAMERA

INMIRROR

2

DETAIL JA

WIRE ASM-IP,MAIN

1TO RIGHT

CAMERAIN

MIRROR

CABLE-RCA,2-WAY148591-01-000

CABLE144677-21-000

TRIGGEROUTPUT

LEFTCAMERA

TO REARCAMERA

YEL

REARINPUT

LEFTINPUT

AUDIO

RIGHTINPUT

GND

SWITCH-VIDEO CAMERA180731-09-000FASTENER-DUAL LOCK85774-01-000 (100 MM)85774-02-000 (100 MM)(APPLY TO DASH SUPPORT)

REARCAMERA

+12V

RIGHTCAMERA

VIDEO

ROUTE TO DASHPOCKET BELOW

RADIO

CABLE144677-21-000

HARNESS183820-08-000

CABLE183822-02-000

VIN

ANTSWR

RR

SWL

ROUTE TO DASHPOCKET BELOWRADIO

HARNESS183820-19-000

RL

USB CABLE

FL

RADIO - SATELLITE SIRIUSXM70D

TO SATELLITERADIO 70D

70DMICROPHONE CABLE

FR

YEL

RIN

2

1

NOT USED

VOUT

LIN

ENSURE CAMERA POWER JUMPER IS IN 12V POSITION.MOVE TO 12V POSITION IF NECESSARY. SEE DETAIL JB.

3

3

DETAIL JB

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000

PIONEER RADIOAVH-X2800BS

5V-1A

RC IN MIC

AUX10A

W/R

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 9 OF 10

BLU/WHT

FN

YEL/BLK(NOT USED)

BLUNT CUT

28-Jun-2017

X-X

FORELECTRICAL

CALLOUTSSEE DWG NO.

121339-01-000



128783-01-000

PRLED-22

2651B1


CODES/STANDARDS-CSA/CMVSS265

DETAIL KC

COMNONC

WIRE ASM-LOFT BED

NC NC-1

SWITCH-MAGNET, SURFACE MOUNT187753-01-CHTSCREWG18-08-10U (2)NUTD65-08-00U (2)SCREW(SUPPIED WITH SWITCH)BRACKET000005519 / 312324-01-CHTTIE-WIRE008343-01-000 (2)

NOTES:

DETAIL KB(SWITCH COVER NOT SHOWN)

1 ATTACH THE MAGNET WITH WIRE CONNECTIONS TO BRACKET SHOWN ANDTHEN ATTACH THE MAGNET WITHOUT WIRE CONNECTIONS SO IT IS DIRECTLYACROSS FROM THE OTHER MAGNET WHEN BED IS IN THE DOWN POSTION.

SEE DETAIL KC FOR WIRING CONNECTIONS.

45B LOFT BED

WIRE ASM-LOFT BED000009104 / 310864-01-000

KA

DETAIL KA

45B

1

KB

SWITCH-ROCKER135740-07-CHT (2)SWITCH-BASE135741-01-CHT (2)SWITCH-BEZEL135742-01-CHT (2)SCREWG11-08-08U (4)

SWITCH-CONTROL,LOFTBED,TOUCH189056-01-000SCREW076790-05-000 (2)

TO WIRE ASM-BED LIFT

2 WIRE ROUTED THROUGH ROUTED PATH IN SIDEWALL BETWEEN ARROWS.

2

SCREW076790-08-000 (2)

WIRE ASM-LOFT BED SWITCH000122806 / 323456-01-000

158

4

7

SHEET:

2

4

C

A

DESCRIPTION:

B

3 2

REV

A

ITEM/PART NO:

3

D

6

78

D

5

B

C

16


000177419 / 30128201000 10 OF 10

WIRE ASM-LOFT BED EXTENSION000004364 / 312116-01-000

28-Jun-2017

Date post:	27-Jul-2020
Category:	Documents
Upload:	others
View:	1 times
Download:	0 times

8 7 6 5 4 3 1 2 - Winnebago · 188312-01-000 detail aa wire tie to radio wiring. see wiring...

Documents