8FG(D)35.40.45.50U 8FG35.40.45.50U 8FD35 ... - Forklift Dealer · Fully-stamped steel side panels...

8FG(D)35.40.45.50U

8FG35.40.45.50U

8FD35.40.45.50USTANDARD EQUIPMENT

DURABILITY PERFORMANCE Automatic transmission with oil cooler

Controller Area Network (CAN-bus) communication EPA/CARB certified engines Full floating powertrain

Fully-stamped steel side panels Toyota 4-cylinder, 3.7L OHV Hydraulic valve lifters

Full floating front axle gasoline engine (1FS) Integrated head light and turn signal lever

Moisture resistant electric connectors Toyota 4-cylinder, 3.0L DOHC Tier 4 Final Electric shift control

High cooling capacity radiator (Diesel Oxidation Catalyst) diesel engine (1KD) Speed control (Technician programmable)

Tilt cylinder boots Electronic fuel injection (gasoline only) Engine protection system

Low maintenance battery Distributorless ignition system (1FS)

Large capacity engine cooling fan UL “G” gasoline engine ERGONOMICS

8-inch cyclone air cleaner UL “D” diesel engine Dash mounted instrument display

Plate iron front fenders Automatic Fork Leveling feature 11.8" diameter two-spoke steering wheel

Anti-restart ignition key switch Integrated monitoring system - includes Load sensing power steering

Stamped steel engine hood – Digital hour meter display Cowl-mount hydraulic control levers with rubber

Radiator screen – Engine coolant temperature gauge boot covers

External hydraulic oil cooler – Fuel gauge (except LPG only models) 12" long dual operator assist grips

– Check engine light Low wide entry steps

SAFETY – Sedimentor warning light (diesel only) Dash integrated amenity tray and oversized

System of Active StabilityTM (SAS) – Glow indicator light (diesel only) cup holder

Operator Presence Sensing System (OPSS) – Engine oil pressure warning light 4-Way adjustable vinyl full-suspension seat

Bolt-on overhead guard – Battery charge warning light Non cinching seatbelt

Key lowering interlock – OPSS activation light

Electric horn 2-stage limited free lift mast (V) SERVICEABILITY

Neutral start safety switch Adjustable headlights with guards Easy access no-tools floorboard

Asbestos free components Double action parking brake (Hand) Engine hood assist damper with lock device

Orange forks Alternator with built-in regulator Air cleaner discharge valve

– Gas model = 60A Easy lift engine hood with wide 75 degree opening

– Diesel model = 80A

V-C-1 FL July 19, 2013

8FG(D)35U

8FG35U

8FD35UMAIN VEHICLE SPECIFICATIONS1 Manufacturer TOYOTA TOYOTA2 Model 8FG35U 8FD35U3 Load Capacity lb (kg) 8000 (3500) 8000 (3500)4 Load Center in (mm) 24 (600) 24 (600)5 Power Type Gasoline Diesel6 Operator Position Seated Rider Seated Rider7 Tire Type Front/Rear Pneumatic Pneumatic8 Wheels (x = driven) Front/Rear 2x/2 2x/29 Maximum Fork Height (MFH) (Top of Forks) (V Mast) in (mm) 120 (3050) 120 (3050)

10 Free Lift (Top of Forks) in (mm) 4.3 (110) 4.3 (110)13 Fork Size T x W x L in (mm) 2x6x42 (50x150x1070) 2x6x42 (50x150x1070)

Fork Spread (Outer Edge to Edge) Max / Min in (mm) 46.1/11.8 (1170/300) 46.1/11.8 (1170/300)14 Tilt Range Fwd/Bwd deg 6/12 6/1215 Length to Fork Face in (mm) 115.2 (2925) 115.2 (2925)16 Overall Width in (mm) 53.1 (1350) 53.1 (1350)17 Mast Lowered Height in (mm) 83 (2110) 83 (2110)18 Mast Extended Height (Top of Load Backrest) in (mm) 168.1 (4270) 168.1 (4270)19 Overhead Guard Height in (mm) 87 (2210) 87 (2210)21 Turning Radius (Outside) in (mm) 103 (2610) 103 (2610)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 19.9 (505) 19.9 (505)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 122.5 (3120) 122.5 (3120)

Full Load mph (km/h) 13.7/13.7 (22.0/22.0) 13.1/13.1 (21.0/21.0)No Load mph (km/h) 15.0/15.0 (24.0/24.0) 14.4/14.4 (23.0/23.0)Full Load fpm (mm/sec) 103 (525) 103 (525)No Load fpm (mm/sec) 108 (550) 108 (550)Full Load fpm (mm/sec) 104 (530) 104 (530)No Load fpm (mm/sec) 94 (480) 94 (480)Full Load lb (kg) <N> 7900 (3600) <35000> 8100 (3700) <36000>No Load lb (kg) <N> 3200 (1450) <14200> 3230 (1460) <14300>

29 Full Load % 32 34Full Load % 42 43No Load % 24 24

32 Total Weight lb (kg) 12570 (5700) 12750 (5780)Front lb (kg) 18310 (8090) 18360 (8110)Rear lb (kg) 2260 (1110) 2390 (1170)Front lb (kg) 5620 (2550) 5670 (2570)Rear lb (kg) 6950 (3150) 7080 (3210)

35 Number Front / Rear 2/2 2/236 Tires Front 250-15-18PR 250-15-18PR37 Rear 7.00-12-12PR 7.00-12-12PR38 Wheelbase in (mm) 74.8 (1900) 74.8 (1900)

Front in (mm) 43.9 (1115) 43.9 (1115)Rear in (mm) 43.3 (1100) 43.3 (1100)

40 Min. with Load in (mm) 4.7 (120) 4.7 (120)41 Center of Wheelbase in (mm) 7.9 (200) 7.9 (200)42 Service (Foot) Hydraulic Hydraulic43 Parking Hand Hand45 Battery Voltage/Capacity (5 HR) V/AH 12/48 12/7049 Make / Model TOYOTA 1FS TOYOTA 1KD

SAE HP 87 @ 2350 74 @ 2200<kW> <65 @ 2350> <55 @ 2200>

Internal Combustion SAE ft-lb 200 @ 1600 220 @ 1200-1500 Engine <N-m> <276 @ 1600> <300 @ 1200-1500>

Number of Cylinders 4 4Piston Displacement cu-in (cc) 224 (3685) 182 (2982)Fuel Tank Capacity US gal (liter) 24 (90) 24 (90)Type Powershift PowershiftSpeeds Forward / Reverse 1/1 1/1

Aux. Hydraulic psi (kg/cm2) 2630 (185) 2630 (185) Function (For <MPa> <18.1> <18.1>

58 Attachments) ² Max Flow Rate gpm (lpm) 33.8 (128) 33.8 (128)1. Computed Values. 2. Values taken at Hydraulic Control Valve. Does not take into consideration losses through mast plumbing (hosing, fittings, QD's, etc).

V-C-2 FL June 20, 2013

28

Transmission

Gradeability at 1 mph (1.5 km/h)1

Gradeability, Max.1

Speeds

30

24

25

26

50

51

52

33

55

39

34

Travel, Max.(Forward / Reverse)

Lifting

Lowering

Drawbar Pull, Max.

57

Weight Distribution

Size

Tread Width

Full Load

Rated Torque @ r.p.m.

Underclearance (Full Load)

Brake

Rated Horsepower @ r.p.m.

Max. Operating Pressure

No Load

8FG(D)35U

8FG35U

8FD35UDIMENSIONAL DRAWING RATED CAPACITY8FG(D)35U Unit: in (mm) 8FG(D)35U

PC = Published Maximum Fork Height (MFH)

Capacity @ 24" Load Center (lbs.)

LC = Desired Load Center (in.)

LD = Load Distance (in.) [Reference Chart Below]

W = Capacity at LC (lbs.)

Load Distance

(LD)

V 19.9 (505) in. (mm)

FV 19.9 (505) in. (mm)

FSV 21.1 (535) in. (mm)

*Should W calculate to a value greater than 9,000

lbs., then maximum capacity at the desired load

center is no greater than 9,000 lbs. This calculation

has been provided for estimation purposes ONLY.

For official rated capacity values, please submit

capacity requests through the Toyota DCS. (All capacities based on standard forks)

*Contact Factory for Tilt Limit Specifications

I.T.A. CARRIAGE CLASS III

UNDERCLEARANCE in (mm)Mast Full Load 4.7 (120)Drive Axle Full Load 6.7 (170)Steer Axle No Load 8.3 (210)Center of Wheelbase Full Load 7.9 (200)Counterweight No Load 7.9 (200)

VARIABLE DIMENSIONS 8FG35U 8FD35U

V & FV FSV V & FV FSVA: Load Distance 19.9 (505) 21.1 (535) 19.9 (505) 21.1 (535)

B: Length to Fork Face 115.2 (2925) 116.3 (2955) 115.2 (2925) 116.3 (2955)

C: Basic Right Angle Stacking 122.5 (3120) 124 (3150) 122.5 (3120) 124 (3150)

89 (2260) 89.5 (2270) 89 (2260) 89.5 (2270)

WHEEL & TIRE CONFIGURATIONSDrive Wheel & Tire Steer Wheel & Tire

STANDARD Dual Drive TiresFront Solid Tires Special Single Dual Solid Rear Solid Tires Side Ring Rear Solid Side RingCONFIGURATION (F00D) (F01B)* F00A F00D & F01B (F41A) Wheel (F60A) F41A F60A

Tire Size 250-15-18PR 29X8-15-12PR 250-15 28X12-15-20PR 7.00-15 7.00-12-12PR 7.00-12 7.00-12-12PR 7.00-127.00-15 6.00-15 7.00-15 9.75-15 6.00-15 5.00S-12 DT 5.00S-12 DT 5.00S-12 5.00S-12

(Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring) (Divided) (Divided) (Side Ring) (Side Ring)Overall Width 53.1 (1350) 66.5 (1690) 53.1 (1350) 57.1 (1450) 66.5 (1690) --- --- --- ---Tread 43.9 (1115) 49.6 (1260) 43.9 (1115) 45.3 (1150) 49.6 (1260) 43.3 (1100) 43.3 (1100) 43.3 (1100) 43.3 (1100)

V-C-3 FL June 20, 2013

D: Intersecting Aisle Width

Wheel Size

Standard Rear Tires

20.5 (520)

51.2

(130

0) 87.0

(221

0)

41.5

(105

5)

16.5

(420

)

74.8 (1900)

- B -

83 (2

110)

168.

1 (4

270)

120

(305

0)

4.3 (110) Free Lift

42 (1070)

2 (50)- A -

Fron

t Tre

ad

11.8

(300

)

43.9

(111

5)

Rea

r Tr

ead

43.3

(110

0)

- D -

46.1

(117

0)

6 (150)- C -

103 (2610) T.R.

53.1

(135

0)

20.5 (520)

61%

8FG(D)35U

8FG35U

8FD35UOPTIONAL MASTS SPECIFICATIONS AND VARIABLE DIMENSIONSWide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three Stage Mast (FSV),

Model 8FG35U 8FD35U

Type of Mast V FV FSV V FV FSVPERFORMANCE

Full Load fpm (mm/sec) 103 (525) 102 (520) 100 (510) 103 (525) 102 (520) 100 (510)No Load fpm (mm/sec) 108 (550) 104 (530) 102 (520) 108 (550) 104 (530) 102 (520)Full Load fpm (mm/sec) 104 (530) 102 (520) 102 (520) 104 (530) 102 (520) 102 (520)No Load fpm (mm/sec) 94 (480) 93 (470) 93 (470) 94 (480) 93 (470) 93 (470)

MAST SPECIFICATIONS & RATED CAPACITIESWide Visible Mast (V), Wide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three Stage Mast (FSV)

(Top of Forks) FWD BWD FWD BWD

in (mm) in (mm) in (mm) in (mm) in (mm) in (mm) deg deg lb (kg) deg deg lb (kg)

120 (3050) 83.1 (2110) 151.6 (3850) 168.1 (4270) 4.3 (110) 4.3 (110) 6 12 8000 (3500) 6 12 8000 (3500)

132 (3350) 90.2 (2290) 163.4 (4150) 179.9 (4570) 4.3 (110) 4.3 (110) 6 12 8000 (3500) 6 12 8000 (3500)

147.5 (3750) 98 (2490) 179.1 (4550) 195.7 (4970) 4.3 (110) 4.3 (110) 6 12 8000 (3500) 6 12 8000 (3500)

159.5 (4050) 107.9 (2740) 190.9 (4850) 207.5 (5270) 4.3 (110) 4.3 (110) 6 12 8000 (3500) 6 12 8000 (3500)

179 (4550) 117.7 (2990) 210.6 (5350) 227.2 (5770) 4.3 (110) 4.3 (110) 6 12 8000 (3500) 6 12 8000 (3500)

199 (5050) 127.6 (3240) 230.3 (5850) 246.9 (6270) 4.3 (110) 4.3 (110) 6 6 7800 (3500) 6 12 7800 (3500)

120 (3050) 83.1 (2110) 152.8 (3880) 168.1 (4270) 50.4 (1280) 35 (890) 6 12 8000 (3500) 6 12 8000 (3500)

132 (3350) 90.2 (2290) 164.6 (4180) 179.9 (4570) 57.5 (1460) 42.1 (1070) 6 12 8000 (3500) 6 12 8000 (3500)

159.5 (4050) 83.1 (2110) 192.1 (4880) 207.5 (5270) 50.4 (1280) 35 (890) 6 6 8000 (3500) 6 6 8000 (3500)

171.5 (4350) 85 (2160) 203.9 (5180) 219.3 (5570) 52.4 (1330) 37 (940) 6 6 8000 (3500) 6 6 8000 (3500)

187 (4750) 90.2 (2290) 219.7 (5580) 235 (5970) 57.5 (1460) 42.1 (1070) 6 6 7700 (3500) 6 6 7700 (3500)

199 (5050) 94.1 (2390) 231.5 (5880) 246.9 (6270) 61.4 (1560) 46.1 (1170) 6 6 7500 (3400) 6 6 7500 (3400)

218.5 (5550) 100 (2540) 251.2 (6380) 266.5 (6770) 67.3 (1710) 52 (1320) 6 6 6200 (2800) 6 6 7250 (3300)

238 (6050) 107.9 (2740) 270.9 (6880) 286.2 (7270) 75.2 (1910) 59.8 (1520) 6 6 4600 (2100) 6 6 7050 (3200)

Note: Height of standard load backrest is 48 in. (1220 mm)

FL September 5, 2013V-C-4

With Standard Load Backrest

Tilt RangeWith Standard Load Backrest

Load Capacity @ 24 in

(600mm) L.C.

Tilt Range

FSV

Single Tire

Without Load Backrest

FV


Free Lift

ExtendedMast

TypeLowered


(600mm) L.C.

V

Overall Height Dual Tire

Lowering

Lifting

Maximum Fork

Height

Speeds

8FG(D)40U

8FG40U



Fork Spread (Outer Edge to Edge) Max / Min in (mm) 46.1/11.8 (1170/300) 46.1/11.8 (1170/300)14 Tilt Range Fwd/Bwd deg 6/12 6 / 1215 Length to Fork Face in (mm) 117.3 (2980) 117.3 (2980)16 Overall Width in (mm) 53.1 (1350) 53.1 (1350)17 Mast Lowered Height in (mm) 83 (2110) 83 (2110)18 Mast Extended Height (Top of Load Backrest) in (mm) 168.1 (4270) 168.1 (4270)19 Overhead Guard Height in (mm) 87 (2210) 87 (2210)21 Turning Radius (Outside) in (mm) 104.5 (2660) 104.5 (2660)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 19.9 (505) 19.9 (505)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 124.5 (3170) 124.5 (3170)






40 Min. with Load in (mm) 4.7 (120) 4.7 (120)41 Center of Wheelbase in (mm) 7.9 (200) 7.9 (200)42 Service (Foot) Hydraulic Hydraulic43 Parking (Foot) Hand Hand45 Battery Voltage/Capacity (5 HR) V/AH 12/48 12/7049 Make / Model TOYOTA 1FS TOYOTA 1KD

SAE HP 87 @ 2350 74 @ 2200<kW> <65 @ 2350> <55 @ 2200>




58 Attachments) ² Max Flow Rate gpm (lpm) 33.8 (128) 33.8 (128)1. Computed Values.2. Values taken at Hydraulic Control Valve. Does not take into consideration losses through mast plumbing (hosing, fittings, QD's, etc).

V-C-5 FL June 20, 2013

57 Max. Operating Pressure

50 Rated Horsepower @ r.p.m.

51 Rated Torque @ r.p.m.

52

55 Transmission


Brake

28 Drawbar Pull, Max.


30 Gradeability, Max.1

33 Weight Distribution

Full Load

34 No Load

Size

39 Tread Width

24

Speeds


25 Lifting

26 Lowering

8FG(D)40U

8FG40U







Load Distance

(LD)

V 19.9 (505) in. (mm)

FV 19.9 (505) in. (mm)

FSV 21.1 (535) in. (mm)






capacity requests through the Toyota DCS.

(All capacities based on standard forks)







C: Basic Right Angle Stacking 124.5 (3170) 126 (3200) 124.5 (3170) 126 (3200)90 (2280) 90 (2290) 90 (2280) 90 (2290)


STANDARD Dual Drive TiresFront Solid Tires Special Single Dual Solid Rear Solid TiresCONFIGURATION (F00D) (F01B)* F00A F00D & F01B (F41A)

Tire Size 250-15-18PR 29X8-15-12PR 250-15 28X12-15-20PR 7.00-15 7.00-12-12PR 7.00-127.00-15 6.00-15 7.00-15 9.75-15 6.00-15 5.00S-12 5.00S-12

(Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring)Overall Width 53.1 (1350) 66.5 (1690) 53.1 (1350) 57.1 (1450) 66.5 (1690) --- ---Tread 43.9 (1115) 49.6 (1260) 43.9 (1115) 45.3 (1150) 49.6 (1260) 43.3 (1100) 43.3 (1100)

V-C-6 FL June 20, 2013


Wheel Size

Standard Rear Tires

11.8

(300

)

43.9

(111

5)

43.3

(110

0)

- D -

46.1

(117

0)

6 (150)- C -

104.5 (2660) T.R.

22.6(575)

51.2

(130

0) 87.0

(221

0)

41.5

(105

5)

16.5

(420

)

74.8 (1900)

- B -

83 (2

110)

168.

1 (4

270)

120

(305

0)

4.3 (110) Free Lift

42 (1070)

2 (50)- A -

53.1

(135

0)

55%

Fron

t Tre

ad

Rea

r Tr

ead

8FG(D)40U

8FG40U


Model 8FG40U 8FD40U






120 (3050) 83.1 (2110) 151.6 (3850) 168.1 (4270) 4.3 (110) 4.3 (110) 6 12 9000 (4000) 6 12 9000 (4000)

132 (3350) 90.2 (2290) 163.4 (4150) 179.9 (4570) 4.3 (110) 4.3 (110) 6 12 9000 (4000) 6 12 9000 (4000)

147.5 (3750) 98 (2490) 179.1 (4550) 195.7 (4970) 4.3 (110) 4.3 (110) 6 12 9000 (4000) 6 12 9000 (4000)

159.5 (4050) 107.9 (2740) 190.9 (4850) 207.5 (5270) 4.3 (110) 4.3 (110) 6 12 9000 (4000) 6 12 9000 (4000)

179 (4550) 117.7 (2990) 210.6 (5350) 227.2 (5770) 4.3 (110) 4.3 (110) 6 6 9000 (4000) 6 12 9000 (4000)

199 (5050) 127.6 (3240) 230.3 (5850) 246.9 (6270) 4.3 (110) 4.3 (110) 6 6 9000 (4000) 6 12 9000 (4000)

120 (3050) 83.1 (2110) 152.8 (3880) 168.1 (4270) 50.4 (1280) 35 (890) 6 12 9000 (4000) 6 12 9000 (4000)

132 (3350) 90.2 (2290) 164.6 (4180) 179.9 (4570) 57.5 (1460) 42.1 (1070) 6 12 9000 (4000) 6 12 9000 (4000)

159.5 (4050) 83.1 (2110) 192.1 (4880) 207.5 (5270) 50.4 (1280) 35 (890) 6 6 9000 (4000) 6 6 9000 (4000)

171.5 (4350) 85 (2160) 203.9 (5180) 219.3 (5570) 52.4 (1330) 37 (940) 6 6 9000 (4000) 6 6 9000 (4000)

187 (4750) 90.2 (2290) 219.7 (5580) 235 (5970) 57.5 (1460) 42.1 (1070) 6 6 9000 (4000) 6 6 9000 (4000)

199 (5050) 94.1 (2390) 231.5 (5880) 246.9 (6270) 61.4 (1560) 46.1 (1170) 6 6 9000 (4000) 6 6 9000 (4000)

218.5 (5550) 100 (2540) 251.2 (6380) 266.5 (6770) 67.3 (1710) 52 (1320) 6 6 7700 (3500) 6 6 9000 (4000)

238 (6050) 107.9 (2740) 270.9 (6880) 286.2 (7270) 75.2 (1910) 59.8 (1520) 6 6 5950 (2700) 6 6 7280 (3300)

Note: Height of standard load backrest is 48 in. (1220 mm)BWD Tilt angle with A4 piping is reduced to 10 degree for FV mast

FL September 5, 2013

Lifting

Lowering

Mast

Type

Maximum Fork

Height

Overall Height

Speeds

Free Lift Single Tire Dual Tire

Lowered

ExtendedWithout Load

BackrestWith Standard Load Backrest

Tilt Range Load Capacity @ 24 in

(600mm) L.C.

Tilt Range

V-C-7


(600mm) L.C.Without Load


V

FV

FSV

8FG(D)45U

8FG45U



Fork Spread (Outer Edge to Edge) Max / Min in (mm) 45.7/11.8 (1160/300) 45.7/11.8 (1160/300)14 Tilt Range Fwd/Bwd deg 6/12 6/1215 Length to Fork Face in (mm) 122.4 (3110) 122.4 (3110)16 Overall Width in (mm) 57.1 (1450) 57.1 (1450)17 Mast Lowered Height in (mm) 86.5 (2200) 86.5 (2200)18 Mast Extended Height (Top of Load Backrest) in (mm) 168.1 (4270) 168.1 (4270)19 Overhead Guard Height in (mm) 90.6 (2300) 90.6 (2300)21 Turning Radius (Outside) in (mm) 108.5 (2750) 108.5 (2750)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 21.5 (545) 21.5 (545)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 129.5 (3300) 129.5 (3300)






40 Min. with Load in (mm) 4.7 (120) 4.7 (120)41 Center of Wheelbase in (mm) 9.1 (230) 9.1 (230)42 Service (Foot) Hydraulic Hydraulic43 Parking Hand Hand45 Battery Voltage/Capacity (5 HR) V/AH 12/48 12/7049 Make / Model TOYOTA 1FS TOYOTA 1KD

SAE HP 87 @ 2350 74 @ 2200<kW> <65 @ 2350> <55 @ 2200>





V-C-8 FL June 20, 2013

24

Speeds


25 Lifting

26 Lowering


Brake





Full Load

34 No Load

Size

39 Tread Width




52

55 Transmission

8FG(D)45U

8FG45U







Load Distance

(LD)

V 21.5 (545) in. (mm)

FV 21.5 (545) in. (mm)

FSV 22.6 (575) in. (mm)














C: Basic Right Angle Stacking 129.5 (3300) 131 (3330) 129.5 (3300) 131 (3330)

93.5 (2380) 93.5 (2380) 93.5 (2380) 93.5 (2380)


STANDARD Dual Drive TiresFront Solid Tires Special Single Dual Solid Side Ring Rear Solid Side RingCONFIGURATION (F00C) (F01B)* F00A F00C & F01B Wheel (F60A) (F41A & F60A)

Tire Size 300-15-20PR 8.25-15-12PR 300-15 32X12-15-20PR 8.25-15 7.00-12-12PR 7.00-12-12PR 7.00-128.00-15 6.50-15 8.00-15 9.75-15 6.50-15 5.00S-12 DT 5.00S-12 5.00S-12

(Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring) (Divided) (Side Ring) (Side Ring)Overall Width 57.1 (1450) 74.4 (1890) 57.1 (1450) 57.1 (1450) 74.4 (1890) --- --- ---Tread 45.3 (1150) 54.5 (1385) 45.3 (1150) 45.3 (1150) 54.5 (1385) 43.3 (1100) 43.3 (1100) 43.3 (1100)

V-C-9 FL June 20, 2013


Wheel Size

Standard Rear Tires

11.8

(300

)

45.3

(115

0)

43.3

(110

0)

- D -

45.7

(116

0)

6 (150)- C -

108.5 (2750) T.R.

57.1

(145

0)

22.2(565)

52.4

(133

0) 90.5

(230

0)

41.5

(105

5)

16.5

(420

)

78.7 (2000)

- B -

86.5

(220

0)168.

1 (4

270)

- A -

120

(305

0)

42 (1070)

4.3 (110) Free Lift

2 (50)

66%

Fron

t Tre

ad

Rea

r Tr

ead

8FG(D)45U

8FG45U


Model 8FG45U 8FD45U





in (mm) in (mm) in (mm) in (mm) in (mm) in (mm) deg deg lb (kg) deg deg lb (kg)120 (3050) 86.6 (2200) 146.7 (3725) 168.1 (4270) 4.3 (110) 4.3 (110) 6 12 10000 (4500) 6 12 10000 (4500)132 (3350) 92.5 (2350) 158.5 (4025) 179.9 (4570) 4.3 (110) 4.3 (110) 6 12 10000 (4500) 6 12 10000 (4500)

147.5 (3750) 102.4 (2600) 174.2 (4425) 195.7 (4970) 4.3 (110) 4.3 (110) 6 12 10000 (4500) 6 12 10000 (4500)159.5 (4050) 110.2 (2800) 186 (4725) 207.5 (5270) 4.3 (110) 4.3 (110) 6 12 10000 (4500) 6 12 10000 (4500)

179 (4550) 120.1 (3050) 205.7 (5225) 227.2 (5770) 4.3 (110) 4.3 (110) 6 6 10000 (4500) 6 12 10000 (4500)199 (5050) 129.9 (3300) 225.4 (5725) 246.9 (6270) 4.3 (110) 4.3 (110) 6 6 8850 (4000) 6 12 9750 (4400)120 (3050) 86.6 (2200) 147.2 (3740) 168.1 (4270) 59.5 (1510) 38.6 (980) 6 12 10000 (4500) 6 12 10000 (4500)132 (3350) 92.5 (2350) 159.1 (4040) 179.9 (4570) 65.4 (1660) 44.5 (1130) 6 12 10000 (4500) 6 12 10000 (4500)

159.5 (4050) 83.5 (2120) 186.8 (4745) 207.5 (5270) 56.3 (1430) 35.4 (900) 6 6 10000 (4500) 6 6 10000 (4500)171.5 (4350) 86.6 (2200) 198.6 (5045) 219.3 (5570) 59.5 (1510) 38.6 (980) 6 6 9750 (4500) 6 6 9750 (4500)

187 (4750) 92.5 (2350) 214.4 (5445) 235 (5970) 65.4 (1660) 44.5 (1130) 6 6 9300 (4200) 6 6 9700 (4400)199 (5050) 96.5 (2450) 226.2 (5745) 246.9 (6270) 69.3 (1760) 48.4 (1230) 6 6 8800 (4000) 6 6 9450 (4300)

218.5 (5550) 102.4 (2600) 245.9 (6245) 266.5 (6770) 75.2 (1910) 54.3 (1380) 6 6 6650 (3000) 6 6 9000 (4100)238 (6050) 110.2 (2800) 265.6 (6745) 286.2 (7270) 83.1 (2110) 62.2 (1580) 6 6 5150 (2300) 6 6 8600 (3900)

NOTE: Height of standard load backrest is 48 in. (1220 mm).

FL June 20, 2013

Lifting

Lowering

V-C-10

Mast

Type

FSV


V

Extended

Overall Height

Lowered

FV


Maximum Fork

Height

Speeds

Tilt Range

Dual Tire


(600mm) L.C.


Free Lift


(600mm) L.C.

Tilt Range

Single Tire


8FG(D)50U

8FG50U

8FD50UMAIN VEHICLE SPECIFICATIONS1 Manufacturer TOYOTA TOYOTA2 Model 8FG50U 8FD50U3 Load Capacity lb (kg) 11000 (5000) 11000 (5000)4 Load Center in (mm) 24 (600) 24 (600)5 Power Type Gasoline Diesel6 Operator Position Seated Rider Seated Rider7 Tire Type Front/Rear Pneumatic Pneumatic8 Wheels (x = driven) Front/Rear 2x/2 2x/29 Maximum Fork Height (MFH) (Top of Forks) (V Mast) in (mm) 120.5 (3060) 120.5 (3060)

10 Free Lift (Top of Forks) in (mm) 4.7 (120) 4.7 (120)13 Fork Size T x W x L in (mm) 2.4x6x48 (60x150x1220) 2.4x6x48 (60x150x1220)

Fork Spread (Outer Edge to Edge) Max / Min in (mm) 45.7/11.8 (1160/300) 45.7/11.8 (1160/300)14 Tilt Range Fwd/Bwd deg 6/12 6/1215 Length to Fork Face in (mm) 124.8 (3170) 124.8 (3170)16 Overall Width in (mm) 57.1 (1450) 57.1 (1450)17 Mast Lowered Height in (mm) 96.5 (2450) 96.5 (2450)18 Mast Extended Height (Top of Load Backrest) in (mm) 174.6 (4435) 174.6 (4435)19 Overhead Guard Height in (mm) 90.6 (2300) 90.6 (2300)21 Turning Radius (Outside) in (mm) 110.5 (2810) 110.5 (2810)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 21.9 (555) 21.9 (555)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 132.5 (3370) 132.5 (3370)







SAE HP 87 @ 2350 74 @ 2200<kW> <65 @ 2350> <55 @ 2200>





V-C-11 FL June 20, 2013

24

Speeds


25 Lifting

26 Lowering


Brake





Full Load

34 No Load

Size

39 Tread Width




52

55 Transmission

8FG(D)50U

8FG50U







Load Distance

(LD)

V 21.9 (555) in. (mm)

FSV 23.0 (585) in. (mm)









I.T.A. CARRIAGE CLASS IV



V FSV V FSVA: Load Distance 21.9 (555) 23 (585) 21.9 (555) 23 (585)

B: Length to Fork Face 124.8 (3170) 126 (3200) 124.8 (3170) 126 (3200)

C: Basic Right Angle Stacking 132.5 (3370) 133.5 (3400) 132.5 (3370) 133.5 (3400)

95.5 (2430) 96 (2440) 95.5 (2430) 96 (2440)


STANDARD Dual Drive TiresFront Solid Tires Special Single Dual Solid Rear Solid TiresCONFIGURATION (F00C) (F01B)* F00A F00C & F01B (F41A)

Tire Size 300-15-20PR 8.25-15-12PR 300-15 32X12-15-20PR 8.25-15 7.00-12-14PR 7.00-128.00-15 6.50-15 8.00-15 9.75-15 6.50-15 5.00S-12 5.00S-12

(Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring) (Side Ring)Overall Width 57.1 (1450) 74.4 (1890) 57.1 (1450) 57.1 (1450) 74.4 (1890) --- ---Tread 45.3 (1150) 54.5 (1385) 45.3 (1150) 45.3 (1150) 54.5 (1385) 43.3 (1100) 43.3 (1100)

V-C-12 FL June 20, 2013


Wheel Size

Standard Rear Tires

11.8

(300

)

45.3

(115

0)

43.3

(110

0)

- D -

45.7

(116

0)

6 (150)- C -

110.5 (2810) T.R.

57.1

(145

0)

24.2(615)

52.2

(133

5) 90.5

(230

0)

41.5

(105

5)

16.5

(420

)

78.7 (2000)

- B -

96.5

(245

0)174.

6 (4

435)

- A -

120.

5 (3

060)

48 (1220)

4.7 (120)Free Lift

2.4 (60)

56%

Fron

t Tre

ad

Rea

r Tr

ead

8FG(D)50U

8FG50U


Model 8FG50U 8FD50U

Type of Mast V FSV V FSVPERFORMANCE

Full Load fpm (mm/sec) 94 (480) 94 (475) 94 (480) 94 (475)No Load fpm (mm/sec) 102 (520) 94 (480) 102 (520) 94 (480)Full Load fpm (mm/sec) 106 (540) 102 (520) 106 (540) 102 (520)No Load fpm (mm/sec) 96 (490) 93 (470) 96 (490) 93 (470)




120.5 (3065) 96.5 (2450) 153.7 (3905) 174.6 (4435) 4.9 (125) 4.9 (125) 6 12 11000 (5000) 6 12 11000 (5000)

132.5 (3365) 102.4 (2600) 165.6 (4205) 186.4 (4735) 4.9 (125) 4.9 (125) 6 12 11000 (5000) 6 12 11000 (5000)

148 (3765) 110.2 (2800) 181.3 (4605) 202.2 (5135) 4.9 (125) 4.9 (125) 6 12 11000 (5000) 6 12 11000 (5000)

160 (4065) 120.1 (3050) 193.1 (4905) 214 (5435) 4.9 (125) 4.9 (125) 6 12 11000 (5000) 6 12 11000 (5000)

179.5 (4565) 129.9 (3300) 212.8 (5405) 233.7 (5935) 4.9 (125) 4.9 (125) 6 6 11000 (5000) 6 12 11000 (5000)

199.5 (5065) 139.8 (3550) 232.5 (5905) 253.4 (6435) 4.9 (125) 4.9 (125) 6 6 9000 (4000) 6 12 10600 (4800)

160 (4065) 89.4 (2270) 194.3 (4935) 214 (5435) 55.1 (1400) 35.4 (900) 6 6 10800 (4900) 6 6 10800 (4900)

172 (4365) 92.5 (2350) 206.1 (5235) 225.8 (5735) 58.3 (1480) 38.6 (980) 6 6 10600 (4800) 6 6 10600 (4800)

187.5 (4765) 96.5 (2450) 221.9 (5635) 241.5 (6135) 62.2 (1580) 42.5 (1080) 6 6 9500 (4300) 6 6 10200 (4600)

199.5 (5065) 102.4 (2600) 233.7 (5935) 253.4 (6435) 68.1 (1730) 48.4 (1230) 6 6 9000 (4100) 6 6 10000 (4500)

219 (5565) 110.2 (2800) 253.4 (6435) 273 (6935) 76 (1930) 56.3 (1430) 6 6 6800 (3100) 6 6 9500 (4300)

239 (6065) 120.1 (3050) 273 (6935) 292.7 (7435) 85.8 (2180) 66.1 (1680) 6 6 5300 (2400) 6 6 9000 (4100)


FL June 20, 2013V-C-13


(600mm) L.C.Without Load


V

FSV

Free Lift Single Tire Dual Tire

Lowered



Tilt Range Load Capacity @ 24 in

(600mm) L.C.

Tilt Range

Lifting

Lowering

Mast

Type

Maximum Fork

Height

Overall Height

Speeds

8FG(D)35.40.45.50U

8FG35.40.45.50U

8FD35.40.45.50Um Option Availablel Option Not Available

Option Item Option Code 8FG35U 8FD35U 8FG40U 8FD40U 8FG45U 8FD45U 8FG50U 8FD50U

MASTS

Wide Visible Mast (V) 1 M00B m m m m m m m m

Full-Free Lift Two-Stage Mast (FV) 2 M00F m m m m m m l l

Full-Free Lift Three-Stage Mast (FSV) 3 M00D m m m m m m m m

LOAD HANDLING

Fork Bar (Carriage) 4 M30AXX m m m m m m m m

Fully Oil Charged Lift Cylinders 5 M09A m m m m m m m m

Fully Tapered & Polished Forks 6 M20GXX m m m m m m l l

Fully Tapered & Polished 46" Lumber Forks 7 TS89 m m m m m m l l

High Load Backrest 8 M40AXX m m m m m m m m

Hydraulic Accumulator (2 quart piston type) 9 M82B m m m m m m m m

Hydraulic Quick Disconnects (Dual) 10 TS27 m m m m m m m m

Less Forks 11 M20N m m m m m m m m

Less Mast and Forks and Load Backrest 12 M02B m m m m m m m m

Side Hosing Termination 13 Q49D m m m m m m m m

Tapered Forks 14 M20BXX m m m m m m m m

Without Load Backrest 15 M40N m m m m m m m m

LOAD HANDLING (HOSE & VALVE ASSEMBLY)

3 Way Valve (No 3rd Function Hosing) - - - Standard Standard Standard Standard Standard Standard Standard Standard

3 Way Valve (With 3rd Function Hosing) 16 A410 m m m m m m m m

4 Way Valve (No 3rd or 4th Function Hosing) 17 A405 m m m m m m m m

4 Way Valve (With 3rd & 4th Function Hosing) 18 A450 m m m m m m m m

LOAD HANDLING (ATTACHMENT, HOSE & VALVE ASSEMBLY)

Cascade Component Guard (Hang-On Sideshifter) 19 TR11 m m m m m m m m

Clamp Release Interlock 3rd Lever 20 Q15A m m m m m m m m

Clamp Release Interlock 4th Lever 21 Q15B m m m m m m m m

Hang-on Sideshifter (Cascade) 22 E911 m m m m m m m m

BODY

Engine Hood Ventilation 23 G20B m m m m m m m m

Polycarbonate OHG Cover 24 TS22 m m m m m m m m

Polycarbonate OHG Cover - TINTED (Gray) 25 TR37 m m m m m m m m

Rear View Mirrors (Left & Right Sides) J10B m m m m m m m m

Special Color Cab with Single Color Truck 26 R00C m m m m m m m m

Special Color Cab with Dual Color Truck 26 R00D m m m m m m m m

Special Paint - Single Color 27 R00A m m m m m m m m

Special Paint - Dual Color 27 R00B m m m m m m m m

Steel Cabin 28 H00H m m m m m m m m

1. Not available with FSV Mast, FV Mast, M02B, M82B, Q49D 15. Includes M02B. Not available with M02B, M20H, M40A, E811, E711B

2. Not available with V Mast, FSV Mast, M02B, M09A, M20H, M82B, 16. Not available with A405, A450, E911, E811, E711B, M02B, M20H, Q15B

118 FV mast includes M09A 17. Not available with A410, A450, E911, E811, E711B, M20H, Q15A, Q15B, Q49D.

3. Not available with V Mast, FV Mast, M02B Includes A26A.

4. Not available with M02B 18. Not available with A410, A405, E911, E811, E711B, M02B, M20H, Q15A. Includes A26A.

5. Requires V Mast or FSV Mast. Not available with FV Mast, M02B. Included in FV mast. 19. Requires E911. Not available with M30A. (Standard Carriage Size Only)

Includes M02B. 20. Requires A410. Not available with A405, A450, E911, E811, E711B, M02B,

6. Not available with E411B, E811, M02B, M20B, M20H, M20N, Q15A, Q15B M20B, M20G, M20H, M40A, Q15B

7. Requires M20G48. Not available with M20B, M20N 21. Requires A450. Not available with E45A, V Mast, FV Mast, M02B, M20B, M20G, M40A,

8. Not available with E711B, E811, M02B, M20H, M40N, Q15A, Q15B Q15A, Q15B, Q49D, A410, A405, A450, E911

9. Requires FSV Mast. Not available with H00H, V Mast, FV Mast, M02B. 22. Not available with A410, A405, A450, E811, E711B, M02B, B20H, Q15A,

10. Requires A450, FSV Mast, Q49D. Q15B, Q49D

11. Includes M02B. Not available with M02B, M20B, M20G, M20H 23. Not available with H00H

12. Requires T41N. Not available with A410, A450, E911, E811, E711B, V Mast, FSV Mast, 24. Not available with TR37, H00H

FV Mast, M20B, M20G, M20H, M20N, M20A, M40A, M40N, M82B, Q15A, Q15B, Q49D 25. Not available with TS22, H00H

Includes M20N & M40N. 26. Requires paint code and paint map. Requires H00H.

13. Requires A410 or A450. Not available with A405, E911, E811, E711B, V Mast, 27. Requires paint code and paint map. Not available with H00HM02B, M20H 28. Not available with A30B, A30F, D22A, G20B, H19A, J26A, M82B. Back tilt is restricted

14. Not available with E811, E711B, M02B, M20G, M20H, M20N, Q15A, Q15B to 6 deg.

V-C-14 Rev. November 3, 2014

OPTIONS AVAILABILITY CHART

8FG(D)35.40.45.50U

8FG35.40.45.50U


Option Item Option Code 8FG35U 8FD35U 8FG40U 8FD40U 8FG45U 8FD45U 8FG50U 8FD50U

POWERTRAIN

Box Fin Radiator 1 C27A m m m m m m m m

Cold Climate Spec 2 B01A l m l m l m l m

Cyclone Air Cleaner (Dual Element) C15B m m m m m m m m

High Capacity Alternator 3 D05A m Standard m Standard m Standard m Standard

High Capacity Battery TS05 m m m m m m m m

High Capacity Cooling Package 4 A26A m m m m m m m m

Keyless Ignition Switch D29A m m m m m m m m

Low LPG Fuel Warning Indicator 5 C28A m l m l m l m l

LPG Bracket (Swing Down Type) 6 C03F m l m l m l m l

LPG Regulator Drain Valve 7 C14A m l m l m l m l

Pre-Cleaner 8 C16A m m m m m m m m

Sealed Alternator 9 D22A m l m l m l m l

Sealed Starter 10 D28A Standard m Standard m Standard m Standard m

Upswept Exhaust 11 C10A m m m m m m m m

STEERING AND OPERATION

Directional Lever on Column 12 E11A m m m m m m m m

EZ Pedal Foot Direction Control 13 E43A m m m m m m m m

Intelli-Shift 14 E17A m m m m m m m m

Mini Lever controls with Ergo-Shift 15 E45A m m m m m m m m

Single Pedal (Combination Brake/Inching) 16 E32B m m m m m m m m

Steering Wheel with Knob E41A m m m m m m m m

Synchronized Steering E72A m m m m m m m m

LIGHTS

Front Combination Lights J20B m m m m m m m m

Rear Combination Lights 17 J21A m m m m m m m m

Strobe Light - Blue 18 J19M m m m m m m m m

Strobe Light - Yellow 19 J19G m m m m m m m m

LED LIGHTS

LED Front Combination Lights 20 TR22 m m m m m m m m

LED Headlights J24L m m m m m m m m

LED Rear Combination Lights 21 J21D m m m m m m m m

LED Rear Working Light 22 J26A m m m m m m m m

LED Reverse Activated Rear Work Light 23 J26F m m m m m m m m

LED Strobe Light - Blue 24 TR43 m m m m m m m m

LED Strobe Light - Yellow 25 TR41 m m m m m m m m

1. Not available with A26A 16. Requires E43A when ordered with A10A

2. Not available A30B, A30E, A30F, A30I, C03F, C11D, C14A, C28A, D05A, D28A 17. Not available with J21D, (D61B, J19G or J19M, J26A or J26F, K21I, L37A combined)

3. Not available with A30F, B01A, D22A 18. Not available with J19G, C10A+ C16A Combined, C10A + J26A or J26F combined,

4. Not available with C27A, A450, A405 (D61B, J21A, J26A or J26F, K21I, L37A combined)

5. Requires A30E. Not available with A30F, A30I, B01A, C10A, D22A 19. Not available with J19M, C10A+ C16A Combined, C10A + J26A or J26F combined,

6. Requires A30E or A30F or A30I. Not available with B01A,C10A (D61B, J21A, J26A or J26F, K21I, L37A combined)

7. Not available with B01A. C14A is included in C28A 20. Requires J24L, J21D.

8. Not available with C10A and J19G or J19M combined, J26A, J26F 21. Not available with D61B, J21A

9. Not available with A30F, C28A, D05A, D59C, E43A, E45A, H00H, H19A, J26A, J26F 22. Not available with A30B, A30F, C16A, D22A, H00H, J26F, C10A and J19G or J19M combined,

10. Not available with A30B, A30F, B01A (D61B, J19G or J19M, J21A, K21I, L37A combined.)

11. Not available with A30E, A30F, A30I, CO3F, C28A, C16A and J19G or J19M, 23. Not available with A30B, A30F, C16A, D22A, J26A, C10A and J19G or J19M combined,

J26A or J26F all combined (D61B, (J19G or J19M), J21A, K21I, L37A all combined.)

12. Requires E45A. Not available with A30B, A30F, E43A 24. Not available with A10A, J19G, S31D, C10A+C16A, C10A+J26A,

13. Requires E32B, K21D or K21I. Not available with A30B, A30F, D22A, D59C, E11A, C10A+J26F, TR41, D61B+J21A+J26A+K21I+L37A, D61B+J21A+J26F+K21I+L37A

G20B, G41F, G41G 25. Not available with A10A, J19M, S31D, C10A+C16A, C10A+J26A,

14. Requires L26B. C10A+J26F, TR41, D61B+J21A+J26A+K21I+L37A, D61B+J21A+J26F+K21I+L37A

15. Requires L26B. Not available with A30B, A30F, D22A, D59C, S33A

V-C-15 Rev. April 24, 2015


8FG(D)35.40.45.50U

8FG35.40.45.50U


Option Item Option Code 8FG35U 8FD35U 8FG40U 8FD40U 8FG45U 8FD45U 8FG50U 8FD50ULIGHTING - OTHER

Auto Lights-Off (Wired to Oil Pressure Switch) 1 TS47 m m m m m m m m

Key Off Head Light Off System 2 J39A m m m m m m m m

Operator Compartment Light 3 H19A m m m m m m m m

Wiring Harness for rear overhead guard options 4 D61B m m m m m m m m

SEAT AND SEAT BELTS

4-Way Adjustable Vinyl Full-Suspension Seat 5 G40I Standard Standard Standard Standard Standard Standard Standard Standard4-Way Adjustable Cloth Full-Suspension Seat 6 G40C m m m m m m m m

Swivel Seat - Cloth (with G40C seat) 7 G41G m m m m m m m m

Swivel Seat - Vinyl (with G40I seat) 8 G41F m m m m m m m m

Orange Seat Belt G43C m m m m m m m m

INDICATORS AND MISCELLANEOUS

12 Volt Power Supply 9 D59B m m m m m m m m

12 Volt Power Supply for TSDR 10 D59C m m m m m m m m

Adj Volume Back-up Alarm (Smart Alarm) 11 K21I m m m m m m m m

Back-Up Alarm 12 K21D m m m m m m m m

Block Heater 13 TS26 m m m m m m m m

Fire Extinguisher 14 S10A m m m m m m m m

5 Pound Fire Extinguisher Upgrade 15 TR46 m m m m m m m m

Multifunction Digital Display with Self-Diagnostics 16 L26B m m m m m m m m

OK Monitor L09A m m m m m m m m

Operator Cooling Fan 17 TS28 m m m m m m m m

Pencil/Tape Holder (Mounted on OHG Leg) S03A m m m m m m m m

Pre Delivery Inspection PDIA m m m m m m m m

Rear Pillar Assist Grip with Horn Button 18 L37A m m m m m m m m

TELEMATICS (Only one T-Matics option may be ordered per truck)CDMA network (U.S. only) 19 TR60 m m m m m m m m

GSM network (Canada/U.S.) 20 TR61 m m m m m m m m

iRF, Proximity Card, CAN 20 TR62 m m m m m m m m

iRF, iButton, CAN 20 TR63 m m m m m m m m

Wi-Fi, Proximity Card, CAN 20 TR66 m m m m m m m m

Wi-Fi, iButton, CAN 20 TR67 m m m m m m m m

CHASSIS

Single Drive Tires 21 F00A m m m m m m m m

Dual Drive Tires 22 F00C l l l l m m m m

Dual Drive Tires 23 F00D m m m m l l l l

Front Solid Tires 24 F01B m m m m m m m m

Rear Solid Tires 25 F41A m m m m m m m m

Side Ring Rear Wheel F60A m m Standard Standard m m Standard Standard

SPECIAL U.L. MODELS

Type DS 26 A30B l m l m l m l m

Type LP 27 A30E m l m l m l m l

Type LPS 28 A30F m l m l m l m l

Type G/LP 29 A30I m l m l m l m l

1. Requires J39A, T41N. 15. Requires S10A. Available for inland transport only cannot be shipped by aircraft 2. Not available with L26B 16. Not available with J39A3. Not available with A30B, A30F, D22A, H00H 17. Requires D59C. Not available with H00H, D59B4. Not available with J21D, (J19G OR J19M, J21A, J26A OR J26F, K21I, L37A all combined) 18. Not available with (D61B, (J19G or J19M), J21A, (J26A or J26F), K21I, L37A combined)5. Not available with G40C, G41F, G41G 19. Not available with A10A, A01A, (H00H & TS26 combined)6. Not available with G40I, G41F, G41G 20. Not available with (H00H & TS26 combined)7. Not available with E43A, G40C, G40I, G41F. Includes G40C 21. Not available with F00C, F00D, F01B8. Not available with E43A, G40C, G40I, G41G. Includes G40I 22. Not available with F00A, F00D9. Not available with D59C 23. Not available with F00A, F00C10. Requires T41N and a TSDR. Not available with A30B, A10A, A30F, D22A, D59B, 24. Not available with F00A

E43A, E45A 25. Requires F60A on 8FG(D)45U truck.11. Not available with K21D, (D61B &(J19G or J19M) & J21A & (J26A or J26F) 26. Not available with D05A, D28A, D59C, E11A, E43A, E45A, H00H, H19A, J26A, J26F

& L37A all combined). (Range of 82 to 102 db) 27. Not available with A30F, A30I, B01A, C10A12. Not available with K21I 28. Requires C14A. Not available with A30E, A30I, B01A, C10A, C28A, D05A, D22A, D28A, 13. Requires T41N. Not available with G20B D59C, E11A, E43A, E45A, H00H, H19A, J26A, J26F. Includes D22A and D28A.14. Available for inland transport only cannot be shipped by aircraft or vessel. 29. Requires C14A. Not available with A30E, A30F,B01A, C10A, C28A

V-C-16 Rev. February 16, 2015


U.L. Approved Model

T-Matics Mobile

T-Matics Command

8FG(D)35.40.45.50U

8FG35.40.45.50U

8FD35.40.45.50UMAST HOSING CONFIGURATIONS

Mast Type 8FG(D)35.40.45U 8FG(D)50U

A410, A430 A450 A410, A430 A450

3rd Function 3rd Function 4th Function 3rd Function 3rd Function 4th Function

V Mast #8 Internal #8 Internal #8 Internal #8 Internal #8 Internal #8 Internal

FV Mast #6 Internal #6 Internal #6 Internal N/A N/A N/A

FSV Mast #8 Internal #8 Internal #8 Internal #8 Internal #8 Internal #8 Internal

Note: Option Q49D #6 hosing at termination point

CASCADE SIDESHIFTERS

8FG(D)50U 120F-SSS-C033 ---- ---- 120F-SSS-C035

CASCADE HANG-ON SIDESHIFTER DIMENSIONS (E911)

Model Carrige width Cascade Model Assembly weight Effective thickness Max Sideshift

46.1 (1170) 100F-SSS-B140 275 (125) 3 (77) 8 (200)8FG(D)35.40.45U 57.9 (1470) 100F-SSS-B143 367 (167) 3 (77) 8 (200)

64.2 (1630) 100F-SSS-B142 429 (195) 3 (77) 8 (200)46.1 (1170) 120F-SSS-C033 354 (161) 3.1 (80) 8 (200)66.9 (1700) 120F-SSS-C035 515 (234) 3.1 (80) 8 (200)

8FG(D)60.70.80U 66.9 (1700) 150Ｆ-SSS-C089 587 (267) 3.1 (80) 12 (300)

A26A High Capacity Cooling Package Details

OPTION A26A

High Capacity Cooling Contents1

1. Additional Plates on Hydraulic Oil Cooler2. Higher Speed Fan Pulley

Notes:

1. A26A is standard with 4-way valve.

V-C-17 FL April 4, 2014

----

67"

Cascade Sideshifter Cascade Sideshifter Cascade Sideshifter Cascade Sideshifter

8FG(D)50U

Model46" 58" 64"

8FG(D)35.40.45U 100F-SSS-B140 100F-SSS-B143 100F-SSS-B142

Forkbar width

(Front view of the sideshifter)

8FG(D)35.40.45.50U

8FG35.40.45.50U

8FD35.40.45.50UMAST INTERCHANGEABILITY

Mast TypeModel Group Wide Visible Mast Wide Visible Full-Free Lift Wide Visible Full-Free Lift m Interchangeable Only Within Model Group

(V) Two-Stage Mast Three-Stage Mast

Model Group (FV) (FSV)

8FG(D)35.40U m m m

8FG(D)45U m m m

8FG(D)50U m N/A m

NOTE: Mast may only be interchanged with models within the same group.

MAST WEIGHTMaximum Model Maximum Model

Mast Type Fork Height 8FG(D)35U 8FG(D)40U 8FG(D)45U Fork Height 8FG(D)50U

in (mm) lb (kg) lb (kg) lb (kg) in (mm) lb (kg)120 (3050) 1870 (850) 1870 (850) 2210 (1000) 120.5 (3065) 2450 (1110)132 (3350) 1940 (880) 1960 (890) 2290 (1040) 132.5 (3365) 2540 (1150)

147.5 (3750) 2050 (930) 2050 (930) 2450 (1110) 148 (3765) 2760 (1250)V 159.5 (4050) 2230 (1010) 2230 (1010) 2670 (1210) 160 (4065) 2910 (1320)

179 (4550) 2340 (1060) 2360 (1070) 2820 (1280) 179.5 (4565) 3060 (1390)199 (5050) 2470 (1120) 2470 (1120) 2980 (1350) 199.5 (5065) 3220 (1460)

FV 120 (3050) 1940 (880) 1940 (880) 2400 (1090) --- - -132 (3350) 2030 (920) 2030 (920) 2490 (1130) --- - -

159.5 (4050) 2450 (1110) 2450 (1110) 3020 (1370) 160 (4065) 3220 (1460)171.5 (4350) 2510 (1140) 2510 (1140) 3110 (1410) 172 (4365) 3290 (1490)

FSV 187 (4750) 2620 (1190) 2620 (1190) 3240 (1470) 187.5 (4765) 3370 (1530)199 (5050) 2690 (1220) 2690 (1220) 3350 (1520) 199.5 (5065) 3530 (1600)

218.5 (5550) 2800 (1270) 2800 (1270) 3570 (1620) 219 (5565) 3770 (1710)238 (6050) 3040 (1380) 3040 (1380) 3750 (1700) 239 (6065) 3880 (1760)

Notes: The figures are without load backrest and forks.

The figures presented in this chart have been rounded off to the nearest number.

Use caution when applying them to specific products.

WIDE CARRIAGE AND HIGH LOAD BACKRESTW/L in (mm)

Model Group H 46/48 52/54 58/60 64/66 76/78 in (mm) (1170/1230) (1320/1380) (1470/1530) (1630/1690) (1930/1990)

42 (1070) m -- -- -- -- 8FG(D)35.40.45U 48 (1220) Standard m m m m

60 (1520) m -- m -- -- m Option Available

W/L in (mm) l Not Available Model Group H 46/48 67/69 76/78

in (mm) (1170/1230) (1700/1760) (1930/1990)

54 (1370) Standard m m

60 (1520) -- m --Note:

H: Height of Load Backrest (From Top of Forks)

W: Max Fork SpreadL: Overall Width

MAST CARRIAGE ROLLERS (QTY) SIDE THRUST ROLLERS (QTY)

Mast Mast

Model V FV FSV Model V FV FSV

8FG(D)35U 6 6 6 8FG(D)35U 4 4 48FG(D)40U 6 6 6 8FG(D)40U 4 4 48FG(D)45U 4 4 4 8FG(D)45U 4 4 48FG(D)50U 4 -- 4 8FG(D)50U 4 -- 4

V-C-18 FL September 5, 2013

8FG(D)50U

8FG(D)35.40.45.50U

8FG35.40.45.50U

8FD35.40.45.50USTANDARD TAPER (STD) AND FULLY TAPERED & POLISHED FORKS (FTP)

MODEL ITA Length Width Thickness Standard Taper Fully Tapered & m Option AvailableCLASS in (mm) in (mm) in (mm) Forks (STD) Polished Forks l Not Available

III 36 (920) 6 (150) 2 (50) m l

III 42 (1070) 6 (150) 2 (50) m l

III 48 (1220) 6 (150) 2 (50) m m

8FG(D)35U III 54 (1370) 6 (150) 2 (50) m l

III 60 (1520) 6 (150) 2 (50) m l

III 72 (1820) 6 (150) 2 (50) l l

III 36 (920) 6 (150) 2 (50) m l

III 42 (1070) 6 (150) 2 (50) m l

8FG(D)40U III 48 (1220) 6 (150) 2 (50) m m

8FG(D)45U III 54 (1370) 6 (150) 2 (50) m l

III 60 (1520) 6 (150) 2 (50) m l

III 72 (1820) 6 (150) 2 (50) l l

IV 36 (920) 6 (150) 2.4 (60) l l

IV 42 (1070) 6 (150) 2.4 (60) l l

IV 48 (1220) 6 (150) 2.4 (60) m l

8FG(D)50U IV 54 (1370) 6 (150) 2.4 (60) l l

IV 60 (1520) 6 (150) 2.4 (60) m l

IV 72 (1820) 6 (150) 2.4 (60) m l

COUNTERWEIGHT WEIGHTS

Model lb (kg)

8FG(D)35U 3695 (1675)8FG(D)40U 4465 (2025)8FG(D)45U 4885 (2215)8FG(D)50U 5525 (2505)

ALTERNATOR

8FG35.40.45.50U

Standard (Volt-Amp) 12-60High Capacity (Volt-Amp) 12-80Sealed (Volt-Amp) 12-30

8FD35.40.45.50U

High Capacity (std) (Volt-Amp) 12-80

V-C-19 FL June 20, 2013

8FG(D)35.40.45.50U

8FG35.40.45.50U

8FD35.40.45.50UCapacity with CASCADE Hang-On Sideshifter at 24" Load Center (lb) - Unshifted (E911)

Model 8FG(D)40U 8FG(D)45U

Attachment Mfr. Cascade Cascade Cascade46" 100F-SSS-B140 100F-SSS-B140 100F-SSS-B14058" 100F-SSS-B143 100F-SSS-B143 100F-SSS-B14364" 100F-SSS-B142 100F-SSS-B142 100F-SSS-B142

Load Capacity at 24 in. (600mm) Load Capacity at 24 in. (600mm) Load Capacity at 24 in. (600mm)

Load Center Load Center Load Center

Drive Tires Drive Tires Drive TiresSingle (STD) Dual Single (STD) Dual Single (STD) Dual

inch (mm) lb (kg) lb (kg) lb (kg) lb (kg) lb (kg) lb (kg)120 (3050) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)132 (3350) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)

147.5 (3750) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)159.5 (4050) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)179 (4550) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)199 (5050) 7100 (3150) 7100 (3150) 7200 (3250) 8200 (3650) 8100 (3650) 8950 (4000)120 (3050) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)132 (3350) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)

159.5 (4050) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 9150 (4100) 9150 (4100)171.5 (4350) 7300 (3150) 7300 (3150) 8200 (3650) 8200 (3650) 8950 (4100) 8950 (4100)187 (4750) 7000 (3150) 7000 (3150) 8000 (3650) 8200 (3650) 8500 (3850) 8900 (4000)199 (5050) 6800 (3050) 6800 (3050) 6800 (3050) 8200 (3650) 8050 (3600) 8650 (3900)

218.5 (5550) 5600 (2520) 6600 (3000) 5100 (2320) 8200 (3650) 6000 (2700) 8250 (3750)238 (6050) 4100 (1850) 6400 (2900) 3950 (1800) 6600 (2950) 4600 (2000) 7850 (3550)

1. Max. Fork Height may be different from model to model. See Mast Specifications section for exact maximum fork height for each model.

Capacity with CASCADE Hang-On Sideshifter at 24" Load Center (lb) - Unshifted (E911)

Model 8FG(D)50U

Attachment Mfr. Cascade46" 120F-SSS-C03367" 120F-SSS-C035

Load Capacity at 24 in. (600mm) Load Center

Drive TiresSingle (STD) Dual

inch (mm) lb (kg) lb (kg)120.5 (3065) 10100 (4570) 10100 (4570)132.5 (3365) 10100 (4570) 10100 (4570)148 (3765) 10100 (4570) 10100 (4570)160 (4065) 10100 (4570) 10100 (4570)

179.5 (4565) 10100 (4570) 10100 (4570)199.5 (5065) 8000 (3520) 9650 (4370)160 (4065) 9850 (4470) 9850 (4470)172 (4365) 9650 (4370) 9650 (4370)

187.5 (4765) 8650 (3920) 9250 (4200)199.5 (5065) 8200 (3720) 9050 (4100)219 (5565) 6150 (2770) 8650 (3920)239 (6065) 4650 (2100) 8200 (3720)

1. Max. Fork Height may be different from model to model. See Mast Specifications section for exact maximum fork height for each model.

V-C-20 FL June 20, 2013

8FG(D)35U

FSV

V

FV

FSV

Maximum Fork Height

Maximum Fork HeightMast

Type

Mast Type

V

Attachment No.

Attachment No.

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80USTANDARD EQUIPMENT

DURABILITY PERFORMANCE Full floating powertrain

Controller Area Network (CAN-bus) communication EPA/CARB certified engines Hydraulic valve lifters

Fully-stamped steel side panels Toyota 4-cylinder, 3.7L OHV Integrated head light and turn signal lever

Full floating front axle gasoline engine (1FS) Electric shift control

Moisture resistant electric connectors Toyota 4-cylinder, 3.0L DOHC Tier 4 Final Speed control (Technician programmable)

High cooling capacity radiator (Diesel Oxidation Catalyst) diesel engine (1KD) Engine protection system

Tilt cylinder boots Electronic fuel injection (gasoline only) Dual Drive Tires

Low maintenance battery Distributorless ignition system (1FS)

Large capacity engine cooling fan UL “G” gasoline engine ERGONOMICS

8-inch cyclone air cleaner UL “D” diesel engine Dash mounted instrument display

Plate iron front fenders Automatic Fork Leveling feature 11.8" diameter two-spoke steering wheel

Anti-restart ignition key switch Integrated monitoring system - includes Load sensing power steering

Stamped steel engine hood – Digital hour meter display Cowl-mount hydraulic control levers with rubber

Radiator screen – Engine coolant temperature gauge boot covers

External hydraulic oil cooler – Fuel gauge (except LPG only models) 12" long dual operator assist grips

– Check engine light Low wide entry steps

SAFETY – Sedimentor warning light (diesel only) Dash integrated amenity tray and oversized

System of Active StabilityTM (SAS) – Glow indicator light (diesel only) cup holder

Operator Presence Sensing System (OPSS) – Engine oil pressure warning light 4-Way adjustable vinyl full-suspension seat

Bolt-on overhead guard – Battery charge warning light Non cinching seatbelt

Key lowering interlock – OPSS activation light

Electric horn 2-stage limited free lift mast (V) SERVICEABILITY

Neutral start safety switch Adjustable headlights with guards Easy access no-tools floorboard

Asbestos free components Double action parking brake (Hand) Engine hood assist damper with lock device

Orange forks Alternator with built-in regulator Air cleaner discharge valve

– Gas model = 60A Easy lift engine hood with wide 75 degree opening

– Diesel model = 80A Easy access to common service items

Automatic transmission with oil cooler such as filters & dipsticks

V-C-21 FL July 19, 2013

8FG(D)60U

8FG60U

8FD60UMAIN VEHICLE SPECIFICATIONS1 Manufacturer TOYOTA TOYOTA2 Model 8FGU60 8FDU603 Load Capacity lb (kg) 13500 (6000) 13500 (6000)4 Load Center in (mm) 24 (600) 24 (600)5 Power Type Gasoline Diesel6 Operator Position Seated Rider Seated Rider7 Tire Type Front/Rear Pneumatic Pneumatic8 Wheels (x = driven) Front/Rear 4x/2 4x/29 Maximum Fork Height (MFH) (Top of Forks) (V Mast) in (mm) 120.5 (3060) 120.5 (3060)


Fork Spread (Outer Edge to Edge) Max / Min in (mm) 66.9/11.8 (1700/300) 66.9/11.8 (1700/300)14 Tilt Range Fwd/Bwd deg 6/12 6/1215 Length to Fork Face in (mm) 137.4 (3490) 137.4 (3490)16 Overall Width in (mm) 77.4 (1965) 77.4 (1965)17 Mast Lowered Height in (mm) 96.8 (2460) 96.8 (2460)18 Mast Extended Height (Top of Load Backrest) in (mm) 174.6 (4435) 174.6 (4435)19 Overhead Guard Height in (mm) 90.9 (2310) 90.9 (2310)21 Turning Radius (Outside) in (mm) 127 (3230) 127 (3230)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 22.8 (580) 22.8 (580)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 150 (3810) 150 (3810)




35 Number Front / Rear 4/2 4/236 Tires Front 8.25-15-12PR 8.25-15-12PR37 Rear 8.25-15-12PR 8.25-15-12PR38 Wheelbase in (mm) 88.6 (2250) 88.6 (2250)



SAE HP 93 @ 2550 74 @ 2200<kW> <69 @ 2550> <55 @ 2200>





V-C-22 FL June 20, 2013




52

55 Transmission


Brake





Full Load

34 No Load

Size

39 Tread Width

24

Speeds


25 Lifting

26 Lowering

8FG(D)60U

8FG60U







Load Distance

(LD)

V 22.8 (580) in. (mm)

FSV 24.2 (615) in. (mm)












V & FV FSV V FSVA: Load Distance 22.8 (580) 24.2 (615) 22.8 (580) 24.2 (615)


C: Basic Right Angle Stacking 150 (3810) 151.5 (3850) 150 (3810) 151.5 (3850)

113.5 (2880) 113.5 (2890) 113.5 (2880) 113.5 (2890)


Dual Drive Tires Front Solid Tires Rear Solid Tires (Standard) (F01B)* F01B

Tire Size 8.25-15-12PR 8.25-15 8.25-15-12PR 8.25-156.50-15 6.50-15 6.50-15 6.50-15

(Side Ring) (Side Ring) (Side Ring) (Side Ring)Overall Width 77.4 (1965) 77.4 (1965) --- ---Tread 56.7 (1440) 56.7 (1440) 57.5 (1460) 57.5 (1460)

V-C-23 FL June 20, 2013

Wheel Size


Standard Rear Tires

41.5

(105

5)

26.0(660)

53.1

(135

0) 90.9

(231

0)

96.8

(246

0)

19.1

(485

)

88.6 (2250)

- B -

174.

6 (4

435)

- A -

120.

5 (3

060)

48 (1220)

4.9 (125) Free Lift

2.4 (60)

56.7

(144

0)

11.8

(300

)

77.4

(196

5)

57.5

(146

0)

- D -

66.9

(170

0)

6 (150)

- C -

127 (3230) T.R.

69%

Fron

t Tre

ad

Rea

r Tr

ead

8FG(D)60U

8FG60U

8FD60UOPTIONAL MASTS SPECIFICATIONS AND VARIABLE DIMENSIONSWide Visible Full-Free Lift Two-Stage Mast (FV), Wide Visible Full-Free Lift Three Stage Mast (FSV)

Model 8FG60U 8FD60U




Standard ITA Class IV Carriage

(Top of Forks) FWD BWD

in (mm) in (mm) in (mm) in (mm) in (mm) in (mm) deg deg lb (kg)

120.5 (3065) 96.9 (2460) 156.7 (3980) 174.6 (4435) 4.9 (125) 4.9 (125) 6 12 13500 (6000)

132.5 (3365) 102.8 (2610) 168.5 (4280) 186.4 (4735) 4.9 (125) 4.9 (125) 6 12 13500 (6000)

140.5 (3565) 106.7 (2710) 176.4 (4480) 194.3 (4935) 4.9 (125) 4.9 (125) 6 12 13500 (6000)

148 (3765) 110.6 (2810) 184.3 (4680) 202.2 (5135) 4.9 (125) 4.9 (125) 6 12 13500 (6000)

179.5 (4565) 130.3 (3310) 215.8 (5480) 233.7 (5935) 4.9 (125) 4.9 (125) 6 12 13500 (6000)

219 (5565) 150 (3810) 255.1 (6480) 273 (6935) 4.9 (125) 4.9 (125) 6 12 13500 (6000)

160 (4065) 92.9 (2360) 196.9 (5000) 214 (5435) 56.1 (1425) 39 (990) 6 6 13300 (6000)

172 (4365) 96.9 (2460) 208.7 (5300) 225.8 (5735) 60 (1525) 42.9 (1090) 6 6 12900 (5850)

187.5 (4765) 100.4 (2550) 224.4 (5700) 241.5 (6135) 63.6 (1615) 46.5 (1180) 6 6 12400 (5620)

199.5 (5065) 110.6 (2810) 236.2 (6000) 253.4 (6435) 73.8 (1875) 56.7 (1440) 6 6 12110 (5500)

219 (5565) 120.5 (3060) 255.9 (6500) 273 (6935) 83.7 (2125) 66.5 (1690) 6 6 11450 (5200)

239 (6065) 122.4 (3110) 275.6 (7000) 292.7 (7435) 85.6 (2175) 68.5 (1740) 6 6 11450 (5200)


FL June 20, 2013

Tilt RangeLoad Capacity @

24 in (600mm)

L.C.



LiftingSpeeds

Lowering

Mast

Type

Maximum Fork

Height

Overall Height



V

FSV

Free Lift

Lowered

V-C-24

8FG(D)70U

8FG70U



Fork Spread (Outer Edge to Edge) Max / Min in (mm) 66.9/11.8 (1700/300) 66.9/11.8 (1700/300)14 Tilt Range Fwd/Bwd deg 6/12 6/1215 Length to Fork Face in (mm) 139.6 (3545) 139.6 (3545)16 Overall Width in (mm) 77.4 (1965) 77.4 (1965)17 Mast Lowered Height in (mm) 96.8 (2460) 96.8 (2460)18 Mast Extended Height (Top of Load Backrest) in (mm) 174.6 (4435) 174.6 (4435)19 Overhead Guard Height in (mm) 90.9 (2310) 90.9 (2310)21 Turning Radius (Outside) in (mm) 129 (3280) 129 (3280)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 23 (585) 23 (585)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 152 (3870) 152 (3870)







SAE HP 93 @ 2550 74 @ 2200<kW> <69 @ 2550> <55 @ 2200>

Internal Combustion SAE ft-lb 200 @ 1600 220 @ 1500 Engine <N-m> <276 @ 1600> <300 @ 1200-1500>




V-C-25 FL June 20, 2013

24

Speeds


25 Lifting

26 Lowering


Brake





Full Load

34 No Load

Size

39 Tread Width




52

55 Transmission

8FG(D)70U

8FG70U







Load Distance

(LD)

V 23.0 (585) in. (mm)

FSV 24.4 (620) in. (mm)












V & FV FSV V FSVA: Load Distance 23 (585) 24.4 (620) 23 (585) 24.4 (620)


C: Basic Right Angle Stacking 152 (3870) 153.5 (3900) 152 (3870) 153.5 (3900)

114.5 (2910) 114.5 (2910) 114.5 (2910) 114.5 (2910)


Dual Drive Tires Front Solid Tires Rear Solid Tires (Standard) (F01B)* (F01B)

Tire Size 8.25-15-14PR 8.25-15 8.25-15-14PR 8.25-156.50-15 6.50-15 6.50-15 6.50-15


V-C-26 FL June 20, 2013

Wheel Size


Standard Rear Tires

41.5

(105

5)

28.0(710)

53.1

(135

0) 90.9

(231

0)

96.8

(246

0)

19.1

(485

)

88.6 (2250)

- B -

174.

6 (4

435)

- A -

120.

6 (3

065)

48 (1220)

4.9 (125) Free Lift

2.6 (65)

56.7

(144

0)

11.8

(3

00)

77.4

(196

5)

57.5

(146

0)

- D -

66.9

(170

0)

6 (150)

- C -

129 (3280) T.R.

60%

Fron

t Tre

ad

Rea

r Tr

ead

8FG(D)70U

8FG70U


Model 8FG70U 8FD70U







120.5 (3065) 96.9 (2460) 156.7 (3980) 174.6 (4435) 4.9 (125) 4.9 (125) 6 12 15500 (7000)

132.5 (3365) 102.8 (2610) 168.5 (4280) 186.4 (4735) 4.9 (125) 4.9 (125) 6 12 15500 (7000)

140.5 (3565) 106.7 (2710) 176.4 (4480) 194.3 (4935) 4.9 (125) 4.9 (125) 6 12 15500 (7000)

148 (3765) 110.6 (2810) 184.3 (4680) 202.2 (5135) 4.9 (125) 4.9 (125) 6 12 15500 (7000)

179.5 (4565) 130.3 (3310) 215.8 (5480) 233.7 (5935) 4.9 (125) 4.9 (125) 6 12 15500 (7000)

219 (5565) 150 (3810) 255.1 (6480) 273 (6935) 4.9 (125) 4.9 (125) 6 12 14750 (6700)

160 (4065) 92.9 (2360) 196.9 (5000) 214 (5435) 56.1 (1425) 39 (990) 6 6 15500 (7000)

172 (4365) 96.9 (2460) 208.7 (5300) 225.8 (5735) 60 (1525) 42.9 (1090) 6 6 14800 (6730)

187.5 (4765) 100.4 (2550) 224.4 (5700) 241.5 (6135) 63.6 (1615) 46.5 (1180) 6 6 14750 (6700)

199.5 (5065) 110.6 (2810) 236.2 (6000) 253.4 (6435) 73.8 (1875) 56.7 (1440) 6 6 14750 (6700)

219 (5565) 120.5 (3060) 255.9 (6500) 273 (6935) 83.7 (2125) 66.5 (1690) 6 6 12700 (5750)

239 (6065) 122.4 (3110) 275.6 (7000) 292.7 (7435) 85.6 (2175) 68.5 (1740) 6 6 12550 (5700)

NOTE: Height of standard load backrest is 54 in. (1370 mm).NOTE: Mast will be removed for delivery if Overall Lowered Height is >106 in (2692 mm).

Rev. July 22, 2014

LiftingSpeeds

Lowering

Mast

Type

Maximum Fork

Height

Overall HeightLoad Capacity

@ 24 in

(600mm) L.C.Lowered


BackrestWith Standard Load BackrestWithout Load


V-C-27

V

FSV

Free Lift

Tilt Range

8FG(D)80U

8FG80U



Fork Spread (Outer Edge to Edge) Max / Min in (mm) 66.9/11.8 (1700/300) 66.9/11.8 (1700/300)14 Tilt Range Fwd/Bwd deg 6/12 6/1215 Length to Fork Face in (mm) 141.3 (3590) 141.3 (3590)16 Overall Width in (mm) 77.4 (1965) 77.4 (1965)17 Mast Lowered Height in (mm) 102.8 (2610) 102.8 (2610)18 Mast Extended Height (Top of Load Backrest) in (mm) 174.8 (4440) 174.8 (4440)19 Overhead Guard Height in (mm) 90.9 (2310) 90.9 (2310)21 Turning Radius (Outside) in (mm) 130.5 (3320) 130.5 (3320)22 Load Distance (Centerline of front axle to front face of forks) in (mm) 23.2 (590) 23.2 (590)23 Basic Right Angle Stacking Aisle Width (Add load length and clearance) in (mm) 154 (3910) 154 (3910)







SAE HP 93 @ 2550 74 @ 2200<kW> <69 @ 2550> <55 @ 2200>





V-C-28 FL June 20, 2013

24

Speeds


25 Lifting

26 Lowering


Brake





Full Load

34 No Load

Size

39 Tread Width




52

55 Transmission

8FG(D)80U

8FG80U







Load Distance

(LD)

V 23.2 (590) in. (mm)












V VA: Load Distance 23.2 (590) 23.2 (590)

B: Length to Fork Face 141.3 (3590) 141.3 (3590)

C: Basic Right Angle Stacking 154 (3910) 154 (3910)

115.5 (2930) 115.5 (2930)


Dual Drive Tires Front Solid Tires Rear Solid Tires (Standard) (F01B)* (F01B)

Tire Size 8.25-15-14PR 8.25-15 8.25-15-14PR 8.25-156.50-15 6.50-15 6.50-15 6.50-15


V-C-29 FL June 20, 2013


Standard Rear Tires

Wheel Size

41.5

(105

5)

29.5(750)

53.1

(135

0)

90.9

(231

0)

102.

8 (2

610)

19.1

(485

)

88.6 (2250)

- B -

174.

8 (4

440)

- A -

120.

8 (3

070)

48 (1220)

5.1 (130) Free Lift

2.8 (70)

56.7

(144

0)

11.8

(300

)

77.4

(196

5)

57.5

(146

0)

- D -

66.9

(170

0)

6 (150)

- C -

130.5 (3320) T.R.

54%

Fron

t Tre

ad

Rea

r Tr

ead

8FG(D)80U

8FG80U


Model 8FG80U 8FD80U

Type of Mast V VPERFORMANCE

Full Load fpm (mm/sec) 81 (410) 73 (370)No Load fpm (mm/sec) 87 (440) 87 (440)Full Load fpm (mm/sec) 104 (530) 104 (530)No Load fpm (mm/sec) 94 (480) 94 (480)





121 (3070) 102.8 (2610) 160.8 (4085) 174.8 (4440) 5.1 (130) 5.1 (130) 6 12 17500 (8000)

132.5 (3370) 106.7 (2710) 172.6 (4385) 186.6 (4740) 5.1 (130) 5.1 (130) 6 12 17500 (8000)

140.5 (3570) 110.6 (2810) 180.5 (4585) 194.5 (4940) 5.1 (130) 5.1 (130) 6 12 17500 (8000)

148.5 (3770) 120.5 (3060) 188.4 (4785) 202.4 (5140) 5.1 (130) 5.1 (130) 6 12 17500 (8000)

180 (4570) 140.2 (3560) 219.9 (5585) 233.9 (5940) 5.1 (130) 5.1 (130) 6 12 17500 (8000)

NOTE: Height of standard load backrest is 54 in. (1370 mm).NOTE: Mast will be removed for delivery if Overall Lowered Height is >106 in (2692 mm).

Rev. July 22, 2014


(600mm) L.C.Lowered


BackrestWith Standard Load BackrestWithout Load


Overall Height Free Lift

Tilt Range

LiftingSpeeds

Lowering

V-C-30

V

Mast

Type

Maximum Fork

Height

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80Um Option Availablel Option Not Available

Option Item Option Code 8FG60U 8FD60U 8FG70U 8FD70U 8FG80U 8FD80U

MASTS

Wide Visible Mast (V) 1 M00B m m m m m m

Full-Free Lift Three-Stage Mast (FSV) 2 M00D m m m m l l

LOAD HANDLING

Fork Bar (Carriage) 3 M30AXX m m m m m m

Fully Oil Charged Lift Cylinders 4 M09A m m m m m m

High Load Backrest 5 M40AXX m m m m m m

Hydraulic Accumulator (2 quart piston type) 6 M82B m m m m l l

Hydraulic Quick Disconnects (Dual) 7 TS27 m m m m m m

Less Forks 8 M20N m m m m m m

Less Mast and Forks and Load Backrest 9 M02B m m m m m m

Pin Type Forks 10 M20HXX m m m m m m

Side Hosing Termination 11 Q49D m m m m l l

Tapered Forks 12 M20BXX m m m m m m

Without Load Backrest 13 M40N m m m m m m

LOAD HANDLING (HOSE & VALVE ASSEMBLY)

3 Way Valve (No 3rd Function Hosing) - - - Standard Standard Standard Standard Standard Standard

3 Way Valve (With 3rd Function Hosing) 14 A410 m m m m m m

4 Way Valve (No 3rd or 4th Function Hosing) 15 A405 m m m m m m

4 Way Valve (With 3rd & 4th Function Hosing) 16 A450 m m m m m m

LOAD HANDLING (ATTACHMENT, HOSE & VALVE ASSEMBLY)

Cascade Component Guard (Hang-On Sideshifter) 17 TR11 m m m m m m

Clamp Release Interlock 3rd Lever 18 Q15A m m m m m m

Clamp Release Interlock 4th Lever 19 Q15B m m m m m m

Hang-on Sideshifter (Cascade) 20 E911 m m m m m m

Integral Sideshifter (Rightline) 21 E811 m m m m m m

Integral Sideshifting Fork Positioner (Rightline) 22 E711B m m m m m m

BODY

Engine Hood Ventilation 23 G20B m m m m m m

Polycarbonate OHG Cover 24 TS22 m m m m m m

Polycarbonate OHG Cover - TINTED (Gray) 25 TR37 m m m m m m

Rear View Mirrors (Left & Right Sides) J10B m m m m m m

Special Color Cab with Single Color Truck 26 R00C m m m m m m

Special Color Cab with Dual Color Truck 26 R00D m m m m m m

Special Paint - Single Color 27 R00A m m m m m m

Special Paint - Dual Color 27 R00B m m m m m m

Steel Cabin 28 H00H m m m m m m

1. Not available with FSV Mast, FV Mast, M02B, M82B, Q49D 15. Not available with A410, A450, E911, E811, E711B, M20H, Q15A, Q15B, Q49D

2. Not available with V Mast, FV Mast, M02B Includes A26A.

3. Not available with M02B. M30A72 requires E811 or E711B 16. Not available with A410, A405, E911, E811, E711B, M02B, M20H, Q15A. Includes A26A.

4. Requires V Mast or FSV Mast. Not available with FV Mast, M02B. Included in FV mast. 17. Requires E911. Not available with M30A. (Standard Carriage Size Only)

Includes M02B. 18. Requires A410. Not available with A405, A450, E911, E811, E711B

5. Not available with E711B, E811, M02B, M20H, M40N, Q15A, Q15B M02B, M20B, M20G, M20H, M40A, Q15B

6. Requires FSV Mast. Not available with H00H, V Mast, FV Mast, M02B. 19. Requires A450. Not available with E45A, V Mast, FV Mast, M02B, M20B, M20G,

7. Requires A450, FSV Mast, Q49D. Not available with TS23. M40A, Q15A, Q15B, Q49D, A410, A405, A450, E911

8. Includes M02B. Not available with M02B, M20B, M20G, M20H 20. Requires M20H or M20N. (M40N is standard). Not available with A410, A405

9. Requires T41N. Not available with A410, A450, E911, E811, E711B, A450, E811, E711B, M02B, B20H, Q15A, Q15B, Q49D

V Mast, FSV Mast, FV Mast, M20B, M20G, M20H, M20N, M20A, M40A, M40N, M82B, 21. Requires M20H or M20N. (M40N is standard). Not available with A410, A405, A450,

Q15A, Q15B, Q49D E911, E711B, M02B, M20B, M20G, M40A, M40N, Q15A, Q15B, Q49D

10. Requires E811 or E711B. Not available with A410, A405, A450, E911, FV Mast, M02B, 22. Requires M20H or M20N. (M40N is standard). Not available with A410, A405, A450,

M20B, M20G, M20N, M40A, M40N, Q15A, Q15B, Q49D E911, E811, M02B, M20B, M20G, M40A, M40N, Q15A, Q15B, Q49D

11. Requires A410 or A450. Not available with A405, E911, E811, E711B, V Mast, 23. Not available with H00H

M02B, M20H 24. Not available with TR37, H00H

12. Not available with E811, E711B, M02B, M20G, M20H, M20N, Q15A, Q15B 25. Not available with TS22, H00H

13. Includes M02B. Not available with M02B, M20H, M40A, E811, E711B 26. Requires paint code and paint map. Requires H00H.

14. Not available with A405, A450, E911, E811, E711B, M02B, M20H, Q15B 27. Requires paint code and paint map. Not available with H00H.

28. Not available with A30B, A30F, D22A, G20B, H19A, J26A, M82B. Back tilt is restrictedto 6 deg.

V-C-31 Rev. November 3, 2014


8FG(D)60.70.80U

8FG60.70.80U



POWERTRAIN

43.5 lb. LP Aluminum Tank XA50 m l m l m l

43.5 lb. LP Steel Tank XA43 m l m l m l

Box Fin Radiator 1 C27A m m m m m m

Cold Climate Spec 2 B01A l m l m l m

Cyclone Air Cleaner (Dual Element) C15B m m m m m m

High Capacity Alternator 3 D05A m Standard m Standard m Standard

High Capacity Battery TS05 m m m m m m

High Capacity Cooling Package 4 A26A m m m m m m

Keyless Ignition Switch D29A m m m m m m

Low LPG Fuel Warning Indicator 5 C28A m l m l m l

LPG Bracket (Swing Down Type) 6 C03F m l m l m l

LPG Regulator Drain Valve 7 C14A m l m l m l

Pre-Cleaner 8 C16A m m m m m m

Sealed Alternator 9 D22A m l m l m l

Sealed Starter 10 D28A Standard m Standard m Standard m

Upswept Exhaust 11 C10A m m m m m m

STEERING AND OPERATION

Directional Lever on Column 12 E11A m m m m m m

EZ Pedal Foot Direction Control 13 E43A m m m m m m

Intelli-Shift 14 E17A m m m m m m

Mini Lever controls with Ergo-Shift 15 E45A m m m m m m

Single Pedal (Combination Brake/Inching) 16 E32B m m m m m m

Steering Wheel with Knob E41A m m m m m m

Synchronized Steering E72A m m m m m m

LIGHTS

Front Combination Lights J20B m m m m m m

Rear Combination Lights 17 J21A m m m m m m

Strobe Light - Blue 18 J19M m m m m m m

Strobe Light - Yellow 19 J19G m m m m m m

LED LIGHTS

LED Front Combination Lights 20 TR22 m m m m m m

LED Headlights J24L m m m m m m

LED Rear Combination Lights 21 J21D m m m m m m

LED Rear Working Light 22 J26A m m m m m m

LED Reverse Activated Rear Work Light 23 J26F m m m m m m

LED Strobe Light - Blue 24 TR43 m m m m m m

LED Strobe Light - Yellow 25 TR41 m m m m m m

1. Not available with A26A 16. Requires E43A when ordered with A10A.

2. Not available A30E, A30F, A30I, C03F, C11D, C14A, C28A, D05A, D28A 17. Not available with J21D, (D61B, J19G or J19M, J26A or J26F, K21I, L37A combined)

3. Not available with A30B, A30F, B01A, D22A 18. Not available with J19G, C10A+ C16A Combined, C10A +

4. Not available with C27A, S31D, A450, A405, E711B J26A or J26F combined, (D61B, J21A, J26A or J26F, K21I, L37A combined)

5. Requires A30E. Not available with A30F, A30I, B01A, C10A, D22A 19. Not available with J19M, C10A+ C16A Combined, C10A + J26A or J26F combined,

6. Requires A30E or A30F or A30I. Not available with B01A,C10A (D61B, J21A, J26A or J26F, K21I, L37A combined)

7. Not available with B01A. C14A is included in C28A. 20. Requires J24L, J21D.

8. Not available with C10A and J19G or J19M combined, J26A, J26F 21. Not available with D61B, J21A

9. Not available with A30F, C28A, D05A, D59C, E43A, E45A, H00H, H19A, J26A, J26F 22. Not available with A30B, A30F, C16A, D22A, H00H, J26F, C10A and J19G or J19M combined,

10. Not available with A30B, A30F, B01A (D61B, J19G or J19M, J21A, K21I, L37A combined.)

11. Not available with A30E, A30F, A30I, CO3F, C28A, C16A and J19G or J19M, 23. Not available with A30B, A30F, C16A, D22A, J26A, C10A and J19G or J19M combined,

J26A or J26F all combined (D61B, (J19G or J19M), J21A, K21I, L37A all combined.)

12. Requires E45A. Not available with A30B, A30F, E43A 24. Not available with A10A, J19G, S31D, C10A+C16A, C10A+J26A,

13. Requires E32B, K21D or K21I. Not available with A30B, A30F, D22A, D59C, E11A, C10A+J26F, TR41, D61B+J21A+J26A+K21I+L37A, D61B+J21A+J26F+K21I+L37A

G20B, G41F, G41G 25. Not available with A10A, J19M, S31D, C10A+C16A, C10A+J26A,

14. Requires L26B. C10A+J26F, TR41, D61B+J21A+J26A+K21I+L37A, D61B+J21A+J26F+K21I+L37A

15. Requires L26B. Not available with A30B, A30F, D22A, D59C, S33A,

V-C-32 Rev. April 24, 2015


8FG(D)60.70.80U

8FG60.70.80U



LIGHTING - OTHER

Auto Lights-Off (Wired to Oil Pressure Switch) 1 TS47 m m m m m m

Key Off Head Light Off System 2 J39A m m m m m m

Operator Compartment Light 3 H19A m m m m m m

Wiring Harness for rear overhead guard options 4 D61B m m m m m m

SEAT AND SEAT BELTS

4-Way Adjustable Vinyl Full-Suspension Seat 5 G40I Standard Standard Standard Standard Standard Standard

4-Way Adjustable Cloth Full-Suspension Seat 6 G40C m m m m m m

Swivel Seat - Cloth (with G40C seat) 7 G41G m m m m m m

Swivel Seat - Vinyl (with G40I seat) 8 G41F m m m m m m

Orange Seat Belt G43C m m m m m m

INDICATORS AND MISCELLANEOUS

12 Volt Power Supply 9 D59B m m m m m m

12 Volt Power Supply for TSDR 10 D59C m m m m m m

Adj Volume Back-up Alarm (Smart Alarm) 11 K21I m m m m m m

Back-Up Alarm 12 K21D m m m m m m

Block Heater 13 TS26 m m m m m m

Fire Extinguisher 14 S10A m m m m m m

5 Pound Fire Extinguisher Upgrade 15 TR46 m m m m m m

Multifunction Digital Display with Self-Diagnostics 16 L26B m m m m m m

OK Monitor L09A m m m m m m

Operator Cooling Fan 17 TS28 m m m m m m

Pencil/Tape Holder (Mounted on OHG Leg) S03A m m m m m m

Pre Delivery Inspection PDIA m m m m m m

Rear Pillar Assist Grip with Horn Button 18 L37A m m m m m m

TELEMATICS (Only one T-Matics option may be ordered per truck)

CDMA network (U.S. only) 19 TR60 m m m m m m

GSM network (Canada/U.S.) 20 TR61 m m m m m m

iRF, Proximity Card, CAN 20 TR62 m m m m m m

iRF, iButton, CAN 20 TR63 m m m m m m

Wi-Fi, Proximity Card, CAN 20 TR66 m m m m m m

Wi-Fi, iButton, CAN 20 TR67 m m m m m m

CHASSIS

Dual Drive Tires 21 F00C Standard Standard Standard Standard Standard Standard

Front Solid Tires 22 F01B m m m m m m

Rear Solid Tires 23 F41A m m m m m m

Side Ring Rear Wheel F60A Standard Standard Standard Standard Standard Standard

SPECIAL U.L. MODELS

Type DS 24 A30B l m l m l m

Type LP 25 A30E m l m l m l

Type LPS 26 A30F m l m l m l

Type G/LP 27 A30I m l m l m l

1. Requires J39A, T41N. 14. Available for inland transport only cannot be shipped by aircraft or vessel.2. Not available with L26B 15. Requires S10A. Available for inland transport only cannot be shipped by aircraft 3. Not available with A30B, A30F, D22A, H00H 16. Not available with J39A4. Not available with J21D; [(J19G OR J19M), J21A, (J26A OR J26F), K21I, L37A combined] 17. Requires D59C. Not available with H00H, D59B5. Not available with G40C, G41F, G41G 18. Not available with (D61B, (J19G or J19M), J21A, (J26A or J26F), K21I, L37A combined)6. Not available with G40I, G41F, G41G 19. Not available with A10A, A01A, (H00H & TS26 combined)7. Not available with E43A, G40C, G40I, G41F. Includes G40C 20. Not available with (H00H & TS26 combined)8. Not available with E43A, G40C, G40I, G41G. Includes G40I 21. Not available with F00A, F00D9. Not available with D59C 22. Not available with F00A10. Requires T41N and a TSDR. Not available with A10A, A30B, A30F, D22A, D59B, 23. Requires F60A on 8FG(D)45U truck.

E43A, E45A 24. Not available with D05A, D28A, D59C, E11A, E43A, E45A, H00H, H19A, J26A, J26F11. Not available with K21D, (D61B & J19G or J19M & J21A & J26A or J26F & L37A combined) 25. Not available with A30F, A30I, B01A, C10A

(Range of 82 to 102 db) 26. Requires C14A. Not available with A30E, A30I, B01A, C10A, C28A, D05A, D22A,12. Not available with K21I D28A, D59C, E11A, E43A, E45A, H00H, H19A, J26A, J26F. Includes D22A and D28A.13. Requires T41N. Not available with G20B 27. Requires C14A. Not available with A30E, A30F,B01A, C10A, C28A

V-C-33 Rev. February 16, 2015


U.L. Approved Model

T-Matics Mobile

T-Matics Command

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80UMAST HOSING CONFIGURATIONS

Mast Type 8FD60.70U 8FD80U

A410, A430 A450 A410, A430 A4503rd Function 3rd Function 4th Function 3rd Function 3rd Function 4th Function

V Mast #8 Internal #8 Internal #8 Internal #8 Internal #8 Internal #8 InternalFV Mast N/A N/A N/A N/A N/A N/AFSV Mast #8 Internal #8 Internal #8 Internal N/A N/A N/ANote: Option Q49D #6 hosing at termination point

ITA CLASS IV STANDARD TAPER (STD) AND FULLY TAPERED

MODEL ITA Length Width Thickness Standard TaperCLASS in (mm) in (mm) in (mm) Forks (STD) m Option Available

IV 48 (1220) 6 (150) 2.6 (65) m l Not Available8FD60.70U IV 60 (1520) 6 (150) 2.6 (65) m

IV 72 (1820) 6 (150) 2.6 (65) m

IV 48 (1220) 6 (150) 2.8 (70) m

8FD80U IV 60 (1520) 6 (150) 2.8 (70) m

IV 72 (1820) 6 (150) 2.8 (70) m

PIN TYPE STANDARD TAPER AND FULLY TAPERED

MODEL Fork Length Width Thickness Standard TaperType in (mm) in (mm) in (mm) Forks (M20HXX)Pin 48 (1220) 5.6 (150) 2.6 (65) m

8FD60.70U Pin 60 (1520) 5.6 (150) 2.6 (65) m

Pin 66 (1670) 5.6 (150) 2.6 (65) m

Pin 72 (1820) 5.6 (150) 2.6 (65) m

Pin 48 (1220) 5.6 (150) 2.8 (70) m

8FD80U Pin 60 (1520) 5.6 (150) 2.8 (70) m

Pin 72 (1820) 5.6 (150) 2.8 (70) m

COUNTERWEIGHT WEIGHTSModel lb (kg)

8FD60U 5755 (2610) 8FD70U 7200 (3265) 8FD80U 8950 (4060)

Option A26A High Capacity Cooling Package Details

OPTION A26A

High Capacity Cooling Contents1

1. Additional Plates on Hydraulic Oil Cooler2. Higher Speed Fan Pulley

Notes:

1. A26A is standard with 4-way valve.

ALTERNATOR

8FD60.70.80U

High Capacity (std) (Volt-Amp) 12-808FG60.70.80U

Standard (Volt-Amp) 12-60

V-C-34 FL April 4, 2014

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80UMAST INTERCHANGEABILITY

Mast TypeModel Group Wide Visible Mast Wide Visible Full-Free Lift Wide Visible Full-Free Lift m Interchangeable Only Within Model Group

(V) Two-Stage Mast Three-Stage Mast

Model Group (FV) (FSV)

8FG(D)60.70U m - - - m

8FG(D)80U m - - - - - -NOTE: Mast may only be interchanged with models within the same group.

MAST WEIGHTMaximum Fork Height Model Maximum Fork Height Model

Mast Type 8FG(D)60.70U 8FG(D)80U

in (mm) lb (kg) in (mm) lb (kg)120.5 (3065) 3000 (1360) 121 (3070) 3180 (1440)132.5 (3365) 3110 (1410) 132.5 (3370) 3240 (1470)

V 140.5 (3565) 3180 (1440) 140.5 (3570) 3310 (1500)148 (3765) 3240 (1470) 148.5 (3770) 3550 (1610)

179.5 (4565) 3660 (1660) 180 (4570) 3900 (1770)219 (5565) 4010 (1820) - - - - - -160 (4065) 3810 (1730) - - - - - -172 (4365) 3900 (1770) - - - - - -

FSV 187.5 (4765) 3990 (1810) - - - - - -199.5 (5065) 4370 (1980) - - - - - -219 (5565) 4610 (2090) - - - - - -239 (6065) 4650 (2110) - - - - - -

Notes: The figures are without load backrest and forks.The figures presented in this chart have been rounded off to the nearest number.Use caution when applying them to specific products.

WIDE CARRIAGE AND HIGH LOAD BACKRESTW/L in (mm)

Model Group H 67/69 76/78in (mm) (1700/1760) (1930/1990)

8FG(D)60.70U 54 (1370) Standard m

8FG(D)80U 60 (1520) m m

Note: m Option Availablel Not Available

H: Height of Load Backrest (From Top of Forks)

MAST CARRIAGE ROLLERS (QTY) W: Max Fork SpreadMast L: Overall Width

Model V FSV

8FG(D)60U 4 48FG(D)70U 4 48FG(D)80U 4 --

SIDE THURST ROLLERS (QTY)Mast

Model V FSV

8FG(D)60U 4 48FG(D)70U 4 48FG(D)80U 4 --

V-C-35 FL July 1, 2013

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80UCASCADE SIDESHIFTERS

8FG(D)60.70.80U ---- ---- ---- 150F-SSS-C089

CASCADE HANG-ON SIDESHIFTER DIMENSIONS (E911)

Model Carrige width Cascade Model Assembly weight Effective thickness Max Sideshift

8FG(D)60.70.80U 66.9 (1700) 150F-SSS-C089 587 (267) 3.1 (80) 12 (300)

RIGHTLINE INTEGRAL SIDESHIFTER DIMENSIONS (E811)

Fork Spread

Min Max

66.9 (1700) 15 (381) 66.9 (1700) 72.5 (1842) 53.9 (1370) 12 (300)

71.3 (1810) 15 (381) 71.3 (1810) 76.9 (1953) 53.9 (1370) 12 (300)

66.9 (1700) 15 (381) 66.9 (1700) 72.5 (1842) 53.7 (1365) 12 (300)

71.3 (1810) 15 (381) 71.3 (1810) 76.9 (1953) 53.7 (1365) 12 (300)

V-C-36 FL June 20, 2013

Max Sideshift

8FG(D)80U

Model Carrige width Overall Width Side Plate Height

8FG(D)60.70U

Model

46" 58" 64" 67"

Fork Spread

Overall width

Side

pla

te h

eigh

t

Forkbar width

(Front view of the sideshifter)

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80UCapacity CASCADE Hang-On Sideshifter at 24" Load Center (lb) - Unshifted (E911)

Model 8FG(D)60U 8FG(D)70U

Attachment Mfr. Cascade CascadeAttachment No. 150F-SSS-C089 150F-SSS-C089

Load Capacity at 24 in. (600mm)

Load Center

Drive Tires Drive TiresDual Dual

inch (mm) lb (kg) lb (kg)120.5 (3065) 12250 (5450) 14100 (6370)132.5 (3365) 12250 (5450) 14100 (6370)140.5 (3565) 12250 (5450) 14100 (6370)148 (3765) 12250 (5450) 14100 (6370)

179.5 (4565) 12000 (5450) 14100 (6370)219 (5565) 11300 (5120) 13350 (6020)160 (4065) 12000 (5450) 14100 (6400)172 (4365) 11700 (5320) 13500 (6120)

187.5 (4765) 11250 (5100) 13300 (6020)199.5 (5065) 10500 (4770) 12450 (5650)219 (5565) 9750 (4420) 11550 (5220)239 (6065) 8800 (4000) 10500 (4750)

Note: Dual Tread is standard on 8FG(D)60.70.80U models1. Max. Fork Height may be different from model to model. See Mast Specifications section for exact maximum fork height for each model.

Capacity CASCADE Hang-On Sideshifter at 24" Load Center (lb) - Unshifted (E911)

Model 8FG(D)80U

Attachment Mfr. CascadeAttachment No. 150F-SSS-C089

Load Capacity at 24 in. (600mm)

Load Center

Drive TiresDual

inch (mm) lb (kg)121 (3070) 15000 (6800)

132.5 (3370) 15000 (6800)140.5 (3570) 15000 (6800)148.5 (3770) 15000 (6800)180 (4570) 15000 (6800)

Note: Dual Tread is standard on 8FG(D)60.70.80U models1. Max. Fork Height may be different from model to model. See Mast Specifications section for exact maximum fork height for each model.

V-C-37 FL June 20, 2013

Mast TypeMax Fork Height


V

V

FSV

8FG(D)60.70.80U

8FG60.70.80U

8FD60.70.80U

Capacity RIGHTLINE Integral Pin Type Sideshifter at 24" Load Center (lb) - Unshifted (E811)

Model 8FG(D)60U 8FG(D)70U 8FG(D)80U

Attachment Mfr. Rightline Rightline RightlineV Mast 67" KSM024 KSM024 KSM026FSV Mast 67" KSM025 KSM025 --V Mast 72" KSM021 KSM021 KSM023FSV Mast 72" KSM022 KSM022 --

Load Capacity at 24 in. Load Capacity at 24 in. Load Capacity at 24 in.

(600mm) Load Center (600mm) Load Center (600mm) Load Center

Drive Tires Drive Tires Drive TiresDual (STD) Dual (STD) Dual (STD)

inch (mm) lb (kg) lb (kg) inch (mm) lb (kg)120.5 (3065) 12000 (5450) 14100 (6400) 121 (3070) 16200 (7350)132.5 (3365) 12000 (5450) 14100 (6400) 132.5 (3370) 16200 (7350)140.5 (3565) 12000 (5450) 14100 (6400) 140.5 (3570) 16200 (7350)148 (3765) 12000 (5450) 14100 (6400) 148.5 (3770) 16200 (7350)

179.5 (4565) 12000 (5450) 14100 (6400) 180 (4570) 16200 (7350)219 (5565) 11350 (5150) 13300 (6050) - - - - - -160 (4065) 12000 (5450) 14100 (6400) - - - - - -172 (4365) 11750 (5350) 13550 (6150) - - - - - -

187.5 (4765) 11200 (5100) 13300 (6050) - - - - - -199.5 (5065) 10550 (4800) 12450 (5650) - - - - - -219 (5565) 9800 (4450) 11550 (5250) - - - - - -239 (6065) 8800 (4000) 10450 (4750) - - - - - -

1) Max. Fork Height may be different from model to model. See Mast Specifications section for exact maximim fork height for each model.2) All listed capacities are based on attachment in unshifted position.3) Pin Carriage does not include Load Backrest Extension.4) Option increases Load Distance by the following: V - Mast: 8FD60U = 3.2 in (81 mm); 8FD70.80U = 3.0 in (76 mm); FSV - Mast: 8FD60U = 3.2 in (81 mm); 8FD70U = 3.0 in (76 mm)

Capacity RIGHTLINE Integral Pin Type Sideshifting Fork Positioner at 24" Load Center (E711B)

Model 8FG(D)60U 8FG(D)70U 8FG(D)80U

Attachment Mfr. Rightline Rightline RightlineV Mast 67" KETA70PW676 KETA70PW676 KETA80PW676FSV Mast 67" KETA70PT676 KETA70PT676 ---V Mast 72" KETA70PW726 KETA70PW726 KETA80PW726FSV Mast 72" KETA70PT726 KETA70PT726 ---

Load Capacity at 24 in. Load Capacity at 24 in. Load Capacity at 24 in.

(600mm) Load Center (600mm) Load Center (600mm) Load Center

Drive Tires Drive Tires Drive TiresDual (STD) Dual (STD) Dual (STD)

inch (mm) lb (kg) lb (kg) inch (mm) lb (kg)120.5 (3065) 11900 (5400) 14000 (6360) 121 (3070) 16100 16100132 (3365) 11900 (5400) 14000 (6360) 132.5 (3370) 16100 16100140 (3565) 11900 (5400) 14000 (6360) 140.5 (3570) 16100 16100148 (3765) 11900 (5400) 14000 (6360) 148.5 (3770) 16100 16100

179.5 (4565) 11900 (5400) 14000 (6360) 180 (4570) 16100 16100218.5 (5565) 11250 (5110) 13200 (6000) - - - - - -159.5 (4065) 11900 (5400) 14000 (6360) - - - - - -171.5 (4365) 11650 (5290) 13450 (6110) - - - - - -187.5 (4765) 11100 (5000) 13200 (6000) - - - - - -199 (5065) 10450 (4750) 12350 (5610) - - - - - -219 (5565) 9700 (4400) 11450 (5200) - - - - - -

238.5 (6065) 8700 (3950) 10350 (4700) - - - - - -1) Max. Fork Height may be different from model to model. See Mast Specifications section for exact maximim fork height for each model.2) All listed capacities are based on attachment in unshifted position.3) Pin Carriage does not include Load Backrest Extension.4) Option increases Load Distance by the following: V - Mast: 8FD60U = 3.2 in (81 mm); 8FD70.80U = 3.0 in (76 mm); FSV - Mast: 8FD60U = 3.2 in (81 mm); 8FD70U = 3.0 in (76 mm)

V-C-38 FL June 20, 2013

Attachment No.

Attachment No.

V

FSV

V

FSV


Mast TypeMax Fork Height Max Fork Height

Max Fork Height

Date post:	19-Mar-2020
Category:	Documents
Upload:	others
View:	8 times
Download:	0 times

8FG(D)35.40.45.50U 8FG35.40.45.50U 8FD35 ... - Forklift Dealer · Fully-stamped steel side panels...

Documents