PACKAGE AIR CONDITIONERS FEATURING NEW INDUSTRY STANDARDR410A REFRIGERANTRLNL-B/RLNL-C SERIES 6, 7.5, 8.5, 10 & 12.5 TON [21.1, 26.4, 29.9,35.2 & 44 kW]60 HZ MODELS
92-23577-82-01SUPERSEDES 92-23577-82-00
[ ] Designates Metric Conversions
THESE INSTRUCTIONS ARE INTENDED AS AN AID TO QUALI-FIED, LICENSED SERVICE PERSONNEL FOR PROPER INSTALLA-TION, ADJUSTMENT AND OPERATION OF THIS UNIT. READTHESE INSTRUCTIONS THOROUGHLY BEFORE ATTEMPTINGINSTALLATION OR OPERATION. FAILURE TO FOLLOW THESEINSTRUCTIONS MAY RESULT IN IMPROPER INSTALLATION,ADJUSTMENT, SERVICE OR MAINTENANCE POSSIBLY RESULT-ING IN FIRE, ELECTRICAL SHOCK, PROPERTY DAMAGE, PER-SONAL INJURY OR DEATH.
WARNING!
DO NOT DESTROYPLEASE READ CAREFULLY AND KEEP IN A SAFE PLACE
FOR FUTURE REFERENCE.
INSTALLATION INSTRUCTIONS
Recognize this symbol as an indication of Important Safety Information!!
ISO 9001:2008
I. TABLE OF CONTENTSI. Table of Contents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2II. Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2III. Checking Product Received . . . . . . . . . . . . . . . . . . . . . 2IV. Equipment Protection . . . . . . . . . . . . . . . . . . . . . . . . . . 2V. Specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
A. General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2B. Major Components . . . . . . . . . . . . . . . . . . . . . . . . 3C. R-410A Refrigerant. . . . . . . . . . . . . . . . . . . . . . . . 3
Unit Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-6General Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-17Electrical Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18-22
VI. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23A. General . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 231. Pre-Installation Check Points . . . . . . . . . . . . . . . 232. Location. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
B. Outside Slab Installation . . . . . . . . . . . . . . . . . . . . . 23C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23D. Rooftop Installation . . . . . . . . . . . . . . . . . . . . . . . . . 24
VII. Ductwork . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25VIII. Filters. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25VIX. Conversion Procedure. . . . . . . . . . . . . . . . . . . . . . . . . 25X. Condensate Drain . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26XI. Electrical Wiring. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
A. Power Wiring. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26B. Control Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26C. Internal Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27D. Grounding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27E. Thermostat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
XII. Indoor Air Flow Data . . . . . . . . . . . . . . . . . . . . . . . . . . 27XIII. Crankcase Heat. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27XIV. Pre-Start Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28XV. Startup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28XVI. Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29XVII. Miscellaneous . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29XVIII. Airflow Data Tables . . . . . . . . . . . . . . . . . . . . . . . . 30-34XIX. Heater Kit Characteristics. . . . . . . . . . . . . . . . . . . . 35-43XX. Troubleshooting. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44XXI. Wiring Diagrams. . . . . . . . . . . . . . . . . . . . . . . . . . . 45-52XXII. Charge Charts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 53-58
II. INTRODUCTION
THE MANUFACTURER’S WARRANTY DOES NOT COVERANY DAMAGE OR DEFECT TO THE AIR CONDITIONERCAUSED BY THE ATTACHMENT OR USE OF ANY COM-PONENTS, ACCESSORIES OR DEVICES (OTHER THANTHOSE AUTHORIZED BY THE MANUFACTURER) INTO,ONTO OR IN CONJUNCTION WITH THE AIR CONDITION-ER. YOU SHOULD BE AWARE THAT THE USE OF UNAU-THORIZED COMPONENTS, ACCESSORIES OR DEVICESMAY ADVERSELY AFFECT THE OPERATION OF THE AIRCONDITIONER AND MAY ALSO ENDANGER LIFE ANDPROPERTY. THE MANUFACTURER DISCLAIMS ANYRESPONSIBILITY FOR SUCH LOSS OR INJURY RESULT-ING FROM THE USE OF SUCH UNAUTHORIZED COMPO-NENTS, ACCESSORIES OR DEVICES.
This booklet contains the installation and operating instructionsfor your air conditioner. There are a few precautions thatshould be taken to derive maximum satisfaction from it.Improper installation can result in unsatisfactory operation ordangerous conditions.
Read this booklet and any instructions packaged with separateequipment required to make up the system prior to installation.Give this booklet to the owner and explain its provisions. Theowner should retain this booklet for future reference.
III.CHECKING PRODUCT RECEIVEDUpon receiving the unit, inspect it for any damage from ship-ment. Claims for damage, either shipping or concealed, shouldbe filed immediately with the shipping company. Check the unitmodel number, heating size, electrical characteristics, andaccessories to determine if they are correct.
IV. EQUIPMENT PROTECTION FROM THEENVIRONMENT
The metal parts of this unit may be subject to rust or deteriora-tion in adverse environmental conditions. This oxidation couldshorten the equipment’s useful life. Salt spray, fog or mist inseacoast areas, sulphur or chlorine from lawn watering sys-tems, and various chemical contaminants from industries suchas paper mills and petroleum refineries are especially corro-sive.
If the unit is to be installed in an area where contaminantsare likely to be a problem, special attention should begiven to the equipment location and exposure.
1. Avoid having lawn sprinkler heads spray direction on theunit cabinet.
2. In coastal areas, locate the unit on the side of the buildingaway from the waterfront.
3. Shielding provided by a fence or shrubs may give someprotection.
Regular maintenance will reduce the buildup of contami-nants and help to protect the unit’s finish.
DISCONNECT ALL POWER TO THE UNIT BEFORE START-ING MAINTENANCE. FAILURE TO DO SO CAN RESULT INSEVERE ELECTRICAL SHOCK OR DEATH.
1. Frequent washing of the cabinet, fan blade and coil withfresh water will remove most of the salt or other contami-nants that build up on the unit.
2. Regular cleaning and waxing of the cabinet with a goodautomobile polish will provide some protection.
3. A good liquid cleaner may be used several times a year toremove matter that will not wash off with water.
Several different types of protective coatings are offered insome areas. These coatings may provide some benefit, but theeffectiveness of such coating materials cannot be verified bythe equipment manufacturer.
The best protection is frequent cleaning, maintenance andminimal exposure to contaminants.
V. SPECIFICATIONS
A. GENERAL
The Packaged Air Conditioner is available without heat or with10, 15, 20, 30, 40 or 50 kW electric heat. Cooling capacities of6, 71⁄2 , 81⁄2 , 10 and 121⁄2 nominal tons of cooling are available.Units are convertible from horizontal supply and return to bot-tom supply and return by relocation of supply and return airaccess panels. See cover installation detail.
2
WARNING!
WARNING!
• R-410A refrigerant cylinders are pink.
• R-410A, as with other HFC’s is only compatible with POEoils.
• Vacuum pumps will not remove moisture from POE oil.
• R-410A systems are to be charged with liquid refrigerants.Prior to March 1999, R-410A refrigerant cylinders had a diptube. These cylinders should be kept upright for equipmentcharging. Post March 1999 cylinders do not have a dip tubeand should be inverted to ensure liquid charging of theequipment.
• Do not install a suction line filter drier in the liquid line.
• A liquid line filter drier is standard on every unit.
• Desiccant (drying agent) must be compatible for POE oilsand R-410A.
3. Evaporator Coil / TXV
The thermostatic expansion valve is specifically designed tooperate with R-410A. DO NOT use an R-22 TXV. The exist-ing evaporator must be replaced with the factory specifiedTXV evaporator specifically designed for R-410A.
4. Tools Required For Installing & Servicing R-410A Models
Manifold Sets:-Up to 800 PSIG High side-Up to 250 PSIG Low Side-550 PSIG Low Side Retard
Manifold Hoses:-Service Pressure Rating of 800 PSIG
Recovery Cylinders:-400 PSIG Pressure Rating-Dept. of Transportation 4BA400 or BW400
R-410A systems operate at higher pressures than R-22 sys-tems. Do not use R-22 service equipment or components on R-410A equipment.
3
CAUTION!
The units are weatherized for mounting outside of the building.
The information on the rating plate is in compliance with theFTC and DOE rating for single phase units. The following infor-mation is for three phase units which are not covered underthe DOE certification program.
1. The efficiency rating of this unit is a product thermal effi-ciency rating determined under continuous operating condi-tions independent of any installed system.
B. MAJOR COMPONENTS
The unit includes a hermetically-sealed refrigerating system(consisting of a compressor, condenser coil, evaporator coilwith thermal expansion valve), a circulation air blower, a con-denser fan, and all necessary internal electrical wiring. Thecooling system of these units is factory-evacuated, chargedand performance tested. Refrigerant amount and type are indi-cated on rating plate.
C. R-410A REFRIGERANT
All units are factory charged with R-410A refrigerant.
1. Specification of R-410A:
Application: R-410A is not a drop-in replacement for R-22;equipment designs must accommodate its higher pressures. Itcannot be retrofitted into R-22 units.
Pressure: The pressure of R-410A is approximately 60%(1.6 times) greater than R-22. Recovery and recycle equip-ment, pumps, hoses and the like need to have design pressureratings appropriate for R-410A. Manifold sets need to range upto 800 psig high-side and 250 psig low-side with a 550 psiglow-side retard. Hoses need to have a service pressure ratingof 800 psig. Recovery cylinders need to have a 400 psig ser-vice pressure rating. DOT 4BA400 or DOT BW400.
Combustibility: At pressures above 1 atmosphere, mixture ofR-410A and air can become combustible. R-410A and airshould never be mixed in tanks or supply lines, or beallowed to accumulate in storage tanks. Leak checkingshould never be done with a mixture of R-410A and air.Leak checking can be performed safely with nitrogen or a mix-ture of R-410A and nitrogen.
2. Quick Reference Guide For R-410A
• R-410A refrigerant operates at approximately 60% higherpressure (1.6 times) than R-22. Ensure that servicing equip-ment is designed to operate with R-410A.
4
RETURN COVER
SUPPLY*
RETURN*
SUPPLY COVER(REAR SIDE)
COMPRESSORACCESS
FIGURE 1UNIT DIMENSIONS
FIGURE 2UNIT DIMENSIONS
ST-A1112-02-00
ST-A1112-01-00
403⁄16”[1020.7 mm]
313⁄16”[96.8 mm]
5”[127 mm]
1111⁄16”[296.9 mm]
41⁄8”[104.8 mm]
65⁄8”[168.3 mm]
613⁄16”[173 mm]
583⁄4”[1492.2 mm]
23”[584.2 mm]
2”[50.8 mm]
47⁄16”[112.7 mm]
2”[50.8 mm]
2”[50.8 mm]
2”[50.8 mm]
2”[50.8 mm]
POWERENTRY
13⁄4” [44.5 mm]DIA.
CONTROLENTRY
7⁄8” [22.2 mm]DIA.
9311⁄16”[2379.6 mm]
CONTROL/FILTERACCESS PANEL(FRONT SIDE)
25”[635 mm]
151⁄8”[384.2 mm]
14”[355.6 mm]
[ ] Designates Metric Conversions
34”[863.6 mm]
8911⁄16”[2278 mm]
*ACTUAL OPENINGDIMENSIONS
543⁄4”[1390.6 mm]
107⁄16”[265.1 mm]
S
S
CONDENSERCOIL
(RIGHT SIDE)
5
FIGURE 3UNIT DIMENSIONS
A0737-03
CONDENSATE DRAIN1” [25.4 mm] FNPT
CONTROL/FILTERACCESS
ELECTRIC HEATACCESS
BLOWER ACCESS
CONTROL ENTRY POWER ENTRY
COMPRESSORACCESS
(BOTH SIDE SOME MODELS)
GAUGE PORTCONNECTIONS
93.688”[2379.7 mm]
58.75”[1487.7 mm]
44”[1117.6 mm]
27.268”[692.6 mm]
33.715”[805.5 mm]
5.625”[142.9 mm]
7.020”[178.3 mm]
SUPPLY RETURN DIMENSIONS FOR DOWNFLOW APPLICATIONS
25"[635 mm]
14"[355.6 mm]
34"[863.6 mm]
8"[203.2 mm]
THRU THE BASE ELECTRIC
54"[1371.6 mm]
23"[585.5 mm]
FIGURE 4BOTTOM VIEW
A0712-02
9311/16”[2379.4 mm]
47/16”[112.7 mm]
151/8”[384.1 mm]
47/16”[112.7 mm]
107/16”[265.1 mm]
21/8”[54 mm]
61/2”[165.1 mm]
271/2”[698.5 mm]
21/8”[54 mm]
8815/16”[2259 mm]
23/8”[60.3 mm]
583/4”[1492.2 mm]
6
*26"[660.4 mm]
12"[304.8 mm]
44"[1117.6 mm]
34"[863.6 mm]
14"[355.6 mm]
28"[711.2 mm]
SUPPLY AND RETURN DIMENSIONS FOR HORIZONTAL APPLICATION
SUPPLY DUCT MAY EXTEND UP TO THIS LEVEL
FIGURE 5REAR VIEW
A0714-03*RECOMMENDED DUCT DIMENSIONS ARE 26”
9311/16”[2379.6 mm]
135/8”[346 mm]
47/16”[112.7 mm]
77/32”[183.3 mm]
7
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B072CL/C072CL B072CM/C072CM B072DL/C072DL B072DM/C072DM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 76,000 [22.27] 76,000 [22.27] 76,000 [22.27] 76,000 [22.27]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 2400/2400 [1133/1133] 2400/2400 [1133/1133] 2400/2400 [1133/1133] 2400/2400 [1133/1133]ARI Net Cooling Capacity Btu [kW] 73,000 [21.39] 73,000 [21.39] 73,000 [21.39] 73,000 [21.39]Net Sensible Capacity Btu [kW] 53,900 [15.79] 53,900 [15.79] 53,900 [15.79] 53,900 [15.79]Net Latent Capacity Btu [kW] 19,100 [5.6] 19,100 [5.6] 19,100 [5.6] 19,100 [5.6]IEER3 12.8 12.8 12.8 12.8Net System Power kW 6.31 6.31 6.31 6.31
CompressorNo./Type 1/Scroll 1/Scroll 1/Scroll 1/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control Orifices Orifices Orifices OrificesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/11x12 [279x305] 1/11x12 [279x305] 1/11x12 [279x305] 1/11x12 [279x305]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 1 1/2 1 1/2 1 1/2 1 1/2Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 120 [3402] 120 [3402] 120 [3402] 120 [3402]WeightsNet Weights lbs. [kg] 901 [409] 901 [409] 901 [409] 901 [409]Ship Weights lbs. [kg] 938 [425] 938 [425] 938 [425] 938 [425]
CONTINUED
8
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B072YL/C072YL B072YM/C072YM B085CL/C085CL B085CM/C085CM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 76,000 [22.27] 76,000 [22.27] 88,000 [25.78] 88,000 [25.78]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 2400/2400 [1133/1133] 2400/2400 [1133/1133] 2800/3000 [1321/1416] 2800/3000 [1321/1416]ARI Net Cooling Capacity Btu [kW] 73,000 [21.39] 73,000 [21.39] 85,000 [24.9] 85,000 [24.9]Net Sensible Capacity Btu [kW] 53,900 [15.79] 53,900 [15.79] 66,100 [19.37] 66,100 [19.37]Net Latent Capacity Btu [kW] 19,100 [5.6] 19,100 [5.6] 18,900 [5.54] 18,900 [5.54]IEER3 12.8 12.8 12.1 12.1Net System Power kW 6.31 6.31 7.53 7.53
CompressorNo./Type 1/Scroll 1/Scroll 1/Scroll 1/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control Orifices Orifices Orifices OrificesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/11x12 [279x305] 1/11x12 [279x305] 1/11x12 [279x305] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 1 1/2 1 1/2 2 2Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 120 [3402] 120 [3402] 190.9 [5412] 190.9 [5412]WeightsNet Weights lbs. [kg] 901 [409] 901 [409] 965 [438] 965 [438]Ship Weights lbs. [kg] 938 [425] 938 [425] 1002 [455] 1002 [455]
CONTINUED
9
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B085CN/C085CN B085DL/C085DL B085DM/C085DM B085DN/C085DN
Cooling Performance1
Gross Cooling Capacity Btu [kW] 88,000 [25.78] 88,000 [25.78] 88,000 [25.78] 88,000 [25.78]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 2800/3000 [1321/1416] 2800/3000 [1321/1416] 2800/3000 [1321/1416] 2800/3000 [1321/1416]ARI Net Cooling Capacity Btu [kW] 85,000 [24.9] 85,000 [24.9] 85,000 [24.9] 85,000 [24.9]Net Sensible Capacity Btu [kW] 66,100 [19.37] 66,100 [19.37] 66,100 [19.37] 66,100 [19.37]Net Latent Capacity Btu [kW] 18,900 [5.54] 18,900 [5.54] 18,900 [5.54] 18,900 [5.54]IEER3 12.8 12.8 12.1 12.1Net System Power kW 6.31 6.31 7.53 7.53
CompressorNo./Type 1/Scroll 1/Scroll 1/Scroll 1/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control Orifices Orifices Orifices Capillary TubesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 2 2 2 3Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 190.9 [5412] 190.9 [5412] 190.9 [5412] 190.9 [5412]WeightsNet Weights lbs. [kg] 965 [438] 965 [438] 965 [438] 973 [441]Ship Weights lbs. [kg] 1002 [455] 1002 [455] 1002 [455] 1002 [455]
CONTINUED
10
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B085YL/C085YL B085YM/C085YM B085YN/C085YN B090CL/C090CL
Cooling Performance1
Gross Cooling Capacity Btu [kW] 88,000 [25.78] 88,000 [25.78] 88,000 [25.78] 93,000 [27.25]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 2800/3000 [1321/1416] 2800/3000 [1321/1416] 2800/3000 [1321/1416] 3000/2775 [1416/1310]ARI Net Cooling Capacity Btu [kW] 85,000 [24.9] 85,000 [24.9] 85,000 [24.9] 90,000 [26.37]Net Sensible Capacity Btu [kW] 66,100 [19.37] 66,100 [19.37] 66,100 [19.37] 63,100 [18.49]Net Latent Capacity Btu [kW] 18,900 [5.54] 18,900 [5.54] 18,900 [5.54] 26,900 [7.88]IEER3 12.8 12.8 12.1 11.9Net System Power kW 6.31 6.31 7.53 7.99
CompressorNo./Type 1/Scroll 1/Scroll 1/Scroll 1/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control Orifices Orifices Orifices TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 2 2 3 2Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 190.9 [5412] 190.9 [5412] 190.9 [5412] 107.5/110.7 [3048/3138]WeightsNet Weights lbs. [kg] 965 [438] 965 [438] 965 [438] 1017 [461]Ship Weights lbs. [kg] 1002 [455] 1002 [455] 1002 [455] 1054 [478]
CONTINUED
11
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B090CM/C090CM B090CN/C090CN B090DL/C090DL B090DM/C090DM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 93,000 [27.25] 93,000 [27.25] 93,000 [27.25] 93,000 [27.25]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 3000/2775 [1416/1310] 3000/2775 [1416/1310] 3000/2775 [1416/1310] 3000/2775 [1416/1310]ARI Net Cooling Capacity Btu [kW] 90,000 [26.37] 90,000 [26.37] 90,000 [26.37] 90,000 [26.37]Net Sensible Capacity Btu [kW] 63,100 [18.49] 63,100 [18.49] 63,100 [18.49] 63,100 [18.49]Net Latent Capacity Btu [kW] 26,900 [7.88] 26,900 [7.88] 26,900 [7.88] 26,900 [7.88]IEER3 11.9 11.9 11.9 11.9Net System Power kW 7.99 7.99 7.99 7.99
CompressorNo./Type 1/Scroll 1/Scroll 1/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control TX Valves TX Valves TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 2 3 2 2Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 107.5/110.7 [3048/3138] 107.5/110.7 [3048/3138] 107.5/110.7 [3048/3138] 107.5/110.7 [3048/3138]WeightsNet Weights lbs. [kg] 1017 [461] 1017 [461] 1017 [461] 1017 [461]Ship Weights lbs. [kg] 1054 [478] 1054 [478] 1054 [478] 1054 [478]
CONTINUED
12
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B090DN/C090DN B090DN/C090DN B090YM/C090YM B090YN/C090YN
Cooling Performance1
Gross Cooling Capacity Btu [kW] 93,000 [27.25] 93,000 [27.25] 93,000 [27.25] 93,000 [27.25]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 3000/2775 [1416/1310] 3000/2775 [1416/1310] 3000/2775 [1416/1310] 3000/2775 [1416/1310]ARI Net Cooling Capacity Btu [kW] 90,000 [26.37] 90,000 [26.37] 90,000 [26.37] 90,000 [26.37]Net Sensible Capacity Btu [kW] 63,100 [18.49] 63,100 [18.49] 63,100 [18.49] 63,100 [18.49]Net Latent Capacity Btu [kW] 26,900 [7.88] 26,900 [7.88] 26,900 [7.88] 26,900 [7.88]IEER3 11.9 11.9 11.9 11.9Net System Power kW 7.99 7.99 7.99 7.99
CompressorNo./Type 2/Scroll 2/Scroll 2/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9] 1 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control TX Valves TX Valves TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 3 2 2 3Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 107.5/110.7 [3048/3138] 107.5/110.7 [3048/3138] 107.5/110.7 [3048/3138] 107.5/110.7 [3048/3138]WeightsNet Weights lbs. [kg] 1025 [465] 1017 [461] 1017 [461] 1025 [465]Ship Weights lbs. [kg] 1054 [478] 1054 [478] 1054 [478] 1054 [478]
CONTINUED
13
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B102CL/C102CL B102CM/C102CM B102DL/C102DL B102DM/C102DM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 101,000 [29.59] 101,000 [29.59] 101,000 [29.59] 101,000 [29.59]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 3200/3200 [1510/1510] 3200/3200 [1510/1510] 3200/3200 [1510/1510] 3200/3200 [1510/1510]ARI Net Cooling Capacity Btu [kW] 97,000 [28.42] 97,000 [28.42] 97,000 [28.42] 97,000 [28.42]Net Sensible Capacity Btu [kW] 74,000 [21.68] 74,000 [21.68] 74,000 [21.68] 74,000 [21.68]Net Latent Capacity Btu [kW] 23,000 [6.74] 23,000 [6.74] 23,000 [6.74] 23,000 [6.74]IEER3 12 12 12 12Net System Power kW 8.59 8.59 8.59 8.59
CompressorNo./Type 2/Scroll 2/Scroll 2/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7] 2 / 18 [7]Refrigerant Control TX Valves TX Valves TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 2 3 2 3Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 154.4/166.6 [4372/4723] 154.4/166.6 [4372/4723] 154.4/166.6 [4372/4723] 154.4/166.6 [4372/4723]WeightsNet Weights lbs. [kg] 1059 [480] 1067 [484] 1059 [480] 1067 [484]Ship Weights lbs. [kg] 1096 [497] 1096 [497] 1096 [497] 1096 [497]
CONTINUED
14
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B102YL/C102YL B102YM/C102YM B120CL/C120CL B120CM/C120CM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 101,000 [29.59] 101,000 [29.59] 123,000 [36.04] 123,000 [36.04]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 3200/3200 [1510/1510] 3200/3200 [1510/1510] 4000/3750 [1888/1770] 4000/3750 [1888/1770]ARI Net Cooling Capacity Btu [kW] 97,000 [28.42] 97,000 [28.42] 118,000 [34.57] 118,000 [34.57]Net Sensible Capacity Btu [kW] 74,000 [21.68] 74,000 [21.68] 88,800 [26.02] 88,800 [26.02]Net Latent Capacity Btu [kW] 23,000 [6.74] 23,000 [6.74] 29,200 [8.56] 29,200 [8.56]IEER3 12 12 11.9 11.9Net System Power kW 8.59 8.59 10.49 10.49
CompressorNo./Type 2/Scroll 2/Scroll 2/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 2 / 22 [9] 2 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 2 / 18 [7] 2 / 18 [7] 3 / 18 [7] 3 / 18 [7]Refrigerant Control TX Valves TX Valves TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 2 3 2 3Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 154.4/166.6 [4372/4723] 154.4/166.6 [4372/4723] 172.8/180.8 [4899/5126] 172.8/180.8 [4899/5126]WeightsNet Weights lbs. [kg] 1059 [480] 1059 [480] 1112 [504] 1120 [508]Ship Weights lbs. [kg] 1096 [497] 1096 [497] 1149 [521] 1149 [521]
CONTINUED
15
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B120DL/C120DL B120DM/C120DM B120YL/C120YL B120YM/C120YM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 123,000 [36.04] 123,000 [36.04] 123,000 [36.04] 123,000 [36.04]EER/SEER2 11.2/NA 11.2/NA 11.2/NA 11.2/NANominal CFM/ARI Rated CFM [L/s] 4000/3750 [1888/1770] 4000/3750 [1888/1770] 4000/3750 [1888/1770] 4000/3750 [1888/1770]ARI Net Cooling Capacity Btu [kW] 118,000 [34.57] 118,000 [34.57] 118,000 [34.57] 118,000 [34.57]Net Sensible Capacity Btu [kW] 88,800 [26.02] 88,800 [26.02] 88,800 [26.02] 88,800 [26.02]Net Latent Capacity Btu [kW] 29,200 [8.56] 29,200 [8.56] 29,200 [8.56] 29,200 [8.56]IEER3 11.9 11.9 11.9 11.9Net System Power kW 10.49 10.49 10.49 10.49
CompressorNo./Type 2/Scroll 2/Scroll 2/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9] 2 / 22 [9]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 3 / 18 [7] 3 / 18 [7] 3 / 18 [7] 3 / 18 [7]Refrigerant Control TX Valves TX Valves TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HP 2 at 1/3 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 2 3 2 3Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 172.8/180.8 [4899/5126] 172.8/180.8 [4899/5126] 172.8/180.8 [4899/5126] 172.8/180.8 [4899/5126]WeightsNet Weights lbs. [kg] 1112 [504] 1112 [504] 1112 [504] 1120 [508]Ship Weights lbs. [kg] 1149 [521] 1149 [521] 1149 [521] 1149 [521]
CONTINUED
16
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B150CL/C150CL B150CM/C150CM B150DL/C150DL B150DM/C150DM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 156,000 [45.71] 156,000 [45.71] 156,000 [45.71] 156,000 [45.71]EER/SEER2 11/NA 11/NA 11/NA 11/NANominal CFM/ARI Rated CFM [L/s] 5000/4400 [2360/2076] 5000/4400 [2360/2076] 5000/4400 [2360/2076] 5000/4400 [2360/2076]ARI Net Cooling Capacity Btu [kW] 148,000 [43.36] 148,000 [43.36] 148,000 [43.36] 148,000 [43.36]Net Sensible Capacity Btu [kW] 107,600 [31.53] 107,600 [31.53] 107,600 [31.53] 107,600 [31.53]Net Latent Capacity Btu [kW] 40,400 [11.84] 40,400 [11.84] 40,400 [11.84] 40,400 [11.84]IEER3 11.4 11.4 11.4 11.4Net System Power kW 13.39 13.39 13.39 13.39
CompressorNo./Type 2/Scroll 2/Scroll 2/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88 88 88Outdoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] OD 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 2 / 20 [8] 2 / 22 [9] 2 / 22 [9] 2 / 22 [8]
Indoor Coil—Fin Type Louvered Louvered Louvered LouveredTube Type Rifled Rifled Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 4 /15 [6] 4 /15 [6] 4 /15 [6] 4 /15 [6]Refrigerant Control TX Valves TX Valves TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller Propeller Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1 Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/2 HP 2 at 1/2 HP 2 at 1/2 HP 2 at 1/2 HPMotor RPM 1075 1075 1075 1075
Indoor Fan—Type FC Centrifugal FC Centrifugal FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/Variable Belt/Variable Belt/VariableNo. Motors 1 1 1 1Motor HP 3 5 3 5Motor RPM 1725 1725 1725 1725Motor Frame Size 56 56 56 56
Filter—Type Disposable Disposable Disposable DisposableFurnished Yes Yes Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 159.2/156 [4513/4423] 159.2/156 [4513/4423] 159.2/156 [4513/4423] 159.2/156 [4513/4423]WeightsNet Weights lbs. [kg] 1230[558] 1238 [562] 1230 [558] 1238 [562]Ship Weights lbs. [kg] 1267 [575] 1267 [575] 1267 [575] 1267 [575]
CONTINUED
17
GENERAL DATA - RLNL
NOM. SIZES 6-121⁄2 TONS [21.1-43.9 kW]
Model RLNL-Series B150YL/C150YL B150YM/C150YM
Cooling Performance1
Gross Cooling Capacity Btu [kW] 156,000 [45.71] 156,000 [45.71]EER/SEER2 11/NA 11/NANominal CFM/ARI Rated CFM [L/s] 5000/4400 [2360/2076] 5000/4400 [2360/2076]ARI Net Cooling Capacity Btu [kW] 148,000 [43.36] 148,000 [43.36]Net Sensible Capacity Btu [kW] 107,600 [31.53] 107,600 [31.53]Net Latent Capacity Btu [kW] 40,400 [11.84] 40,400 [11.84]IEER3 11.4 11.4Net System Power kW 13.39 13.39
CompressorNo./Type 2/Scroll 2/Scroll
Outdoor Sound Rating (dB)5 88 88Outdoor Coil—Fin Type Louvered LouveredTube Type MicroChannel MicroChannelMicroChannel Depth in. [mm] 1 [25.4] 1 [25.4]Face Area sq. ft. [sq. m] 27 [2.51] 27 [2.51]Rows / FPI [FPcm] 2 / 20 [8] 2 / 20 [8]
Indoor Coil—Fin Type Louvered LouveredTube Type Rifled RifledTube Size in. [mm] 0.375 [9.5] 0.375 [9.5]Face Area sq. ft. [sq. m] 13.5 [1.25] 13.5 [1.25]Rows / FPI [FPcm] 4 /15 [6] 4 /15 [6]Refrigerant Control TX Valves TX ValvesDrain Connection No./Size in. [mm] 1/1 [25.4] 1/1 [25.4]
Outdoor Fan—Type Propeller PropellerNo. Used/Diameter in. [mm] 2/24 [609.6] 2/24 [609.6]Drive Type/No. Speeds Direct/1 Direct/1CFM [L/s] 8000 [3775] 8000 [3775]No. Motors/HP 2 at 1/2 HP 2 at 1/2 HPMotor RPM 1075 1075
Indoor Fan—Type FC Centrifugal FC CentrifugalNo. Used/Diameter in. [mm] 1/15x15 [381x381] 1/15x15 [381x381]Drive Type/No. Speeds Belt/Variable Belt/VariableNo. Motors 1 1Motor HP 3 5Motor RPM 1725 1725Motor Frame Size 56 56
Filter—Type Disposable DisposableFurnished Yes Yes(No.) Size Recommended in. [mm x mm x mm] (6)2x18x18 [51x457x457] (6)2x18x18 [51x457x457]
Refrigerant Charge Oz. [g] 159.2/156 [4513/4423] 159.2/156 [4513/4423]WeightsNet Weights lbs. [kg] 1238 [562] 1238 [562]Ship Weights lbs. [kg] 1267 [575] 1267 [575]
18
ELECTRICAL DATA - RLNL-B
UnitInformation
ELECTRICAL DATA - RLNL SERIES
B072CL/C072CL
B072CM/C072CM
B072DL/C072DL
B072DM/C072DM
B072YL/C072YL
B072YM/C072YM
B085CL/C085CL
B085CM/C085CM
B085CN/C085CN
Com
pressorMotor
CondenserMotor
EvaporatorFan
Unit Operating VoltageRange
Volts
Minimum CircuitAmpacity
Minimum OvercurrentProtection Device Size
Maximum OvercurrentProtection Device Size
No.
Volts
Phase
RPM
HP, Compressor 1
Amps (RLA), Comp. 1
Amps (LRA), Comp. 1
HP, Compressor 2
Amps (RLA), Comp. 2
Amps (LRA), Comp. 2
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
187-253 187-253 414-506 414-506 518-632 518-632 187-253 187-253 187-253
208/230 208/230 460 460 575 575 208/230 208/230 208/230
37/37 37/37 18 18 14 14 42/42 42/42 47/47
40/40 40/40 20 20 15 15 45/45 45/45 50/50
50/50 50/50 25 25 20 20 60/60 60/60 70/70
1 1 1 1 1 1 1 1 1
200/240 200/240 480 480 600 600 200/240 200/240 200/240
3 3 3 3 3 3 3 3 3
3450 3450 3450 3450 3450 3450 3450 3450 3450
5 5 5 5 5 5 6 6 6
20.5/20.5 20.5/20.5 9.6 9.6 7.6 7.6 23.2/23.2 23.2/23.2 23.2/23.2
155/155 155/155 75 75 54 54 164/164 164/164 164/164
— — — — — — — — —
— — — — — — — — —
— — — — — — — — —
2 2 2 2 2 2 2 2 2
208/230 208/230 460 460 575 575 208/230 208/230 208/230
1 1 1 1 1 1 1 1 1
1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3
2.4/2.4 2.4/2.4 1.4 1.4 1 1 2.4/2.4 2.4/2.4 2.4/2.4
4.7/4.7 4.7/4.7 2.4 2.4 1.5 1.5 4.7/4.7 4.7/4.7 4.7/4.7
1 1 1 1 1 1 1 1 1
208/230 208/230 460 460 575 575 208/230 208/230 208/230
3 3 3 3 3 3 3 3 3
1 1/2 1 1/2 1 1/2 1 1/2 1 1/2 1 1/2 2 2 3
5.6/5.6 5.6/5.6 2.8 2.8 1.9 1.9 8/8 8/8 13/13
28.8/28.8 28.8/28.8 14.4 14.4 14 14 56/56 56/56 74.5/74.5
19
ELECTRICAL DATA - RLNL-B
UnitInformation
ELECTRICAL DATA - RLNL SERIES
B085DL/C085DL
B085DM/C085DM
B085DN/C085DN
B085YL/C085YL
B085YM/C085YM
B085YN/C085YN
B090CL/C090CL
B090CM/C090CM
B090CN/C090CN
Com
pressorMotor
CondenserMotor
EvaporatorFan
Unit Operating VoltageRange
Volts
Minimum CircuitAmpacity
Minimum OvercurrentProtection Device Size
Maximum OvercurrentProtection Device Size
No.
Volts
Phase
RPM
HP, Compressor 1
Amps (RLA), Comp. 1
Amps (LRA), Comp. 1
HP, Compressor 2
Amps (RLA), Comp. 2
Amps (LRA), Comp. 2
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
414-506 414-506 414-506 518-632 518-632 518-632 187-253 187-253 187-253
460 460 460 575 575 575 208/230 208/230 208/230
21 21 24 16 16 20 43/43 43/43 48/48
25 25 25 20 20 20 45/45 45/45 50/50
30 30 35 20 20 25 50/50 50/50 60/60
1 1 1 1 1 1 2 2 2
480 480 480 600 600 600 200/240 200/240 200/240
3 3 3 3 3 3 3 3 3
3450 3450 3450 3450 3450 3450 3450 3450 3450
6 6 6 6 6 6 3 1/4 3 1/4 3 1/4
11.2 11.2 11.2 7.9 7.9 7.9 13.1/13.1 13.1/13.1 13.1/13.1
75 75 75 54 54 54 83.1/83.1 83.1/83.1 83.1/83.1
— — — — — — 3 1/4 3 1/4 3 1/4
— — — — — — 13.1/13.1 13.1/13.1 13.1/13.1
— — — — — — 83.1/83.1 83.1/83.1 83.1/83.1
2 2 2 2 2 2 2 2 2
460 460 460 575 575 575 208/230 208/230 208/230
1 1 1 1 1 1 1 1 1
1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3
1.4 1.4 1.4 1 1 1 2.4/2.4 2.4/2.4 2.4/2.4
2.4 2.4 2.4 1.5 1.5 1.5 4.7/4.7 4.7/4.7 4.7/4.7
1 1 1 1 1 1 1 1 1
460 460 460 575 575 575 208/230 208/230 208/230
3 3 3 3 3 3 3 3 3
2 2 3 2 2 3 2 2 3
4 4 7 4 4 8 8/8 8/8 13/13
28 28 38.1 19 19 20 56/56 56/56 74.5/74.5
414-506 414-506 414-506 518-632 518-632 518-632 187-253 187-253 414/506
460 460 460 575 575 575 208/230 208/230 460
21 21 24 16 16 21 49/49 54/54 23
25 25 25 20 20 25 50/50 55/55 25
25 25 30 20 20 25 60/60 60/60 25
2 2 2 2 2 2 2 2 2
480 480 480 600 600 600 200/230 200/230 460
3 3 3 3 3 3 3 3 3
3450 3450 3450 3450 3450 3450 3450 3450 3450
3 1/4 3 1/4 3 1/4 3 1/4 3 1/4 3 1/4 3 3/4 3 3/4 3 3/4
6.1 6.1 6.1 4.4 4.4 4.4 16/16 16/16 7.1
41 41 41 33 33 33 91/91 91/91 46
3 1/4 3 1/4 3 1/4 3 1/4 3 1/4 3 1/4 3 3/4 3 3/4 3 3/4
6.1 6.1 6.1 4.4 4.4 4.4 16/16 16/16 7.1
41 41 41 33 33 33 91/91 91/91 46
2 2 2 2 2 2 2 2 2
460 460 460 575 575 575 208/230 208/230 460
1 1 1 1 1 1 1 1 1
1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3
1.4 1.4 1.4 1 1 1 2.4/2.4 2.4/2.4 1.4
2.4 2.4 2.4 1.5 1.5 1.5 4.7/4.7 4.7/4.7 2.4
1 1 1 1 1 1 1 1 1
460 460 460 575 575 575 208/230 208/230 460
3 3 3 3 3 3 3 3 3
2 2 3 2 2 3 2 3 2
4 4 7 4 4 8 8/8 13/13 4
28 28 38.1 19 19 20 56/56 74.5/74.5 28
20
UnitInformation
ELECTRICAL DATA - RLNL SERIES
B090DL/C090DL
B090DM/C090DM
B090DN/C090DN
B090YL/C090YL
B090YM/C090YM
B090YN/C090YN
B102CL/C102CL
B102CM/C102CM
B102DL/C102DL
Com
pressorMotor
CondenserMotor
EvaporatorFan
Unit Operating VoltageRange
Volts
Minimum CircuitAmpacity
Minimum OvercurrentProtection Device Size
Maximum OvercurrentProtection Device Size
No.
Volts
Phase
RPM
HP, Compressor 1
Amps (RLA), Comp. 1
Amps (LRA), Comp. 1
HP, Compressor 2
Amps (RLA), Comp. 2
Amps (LRA), Comp. 2
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
ELECTRICAL DATA - RLNL-B
21
414-506 518-632 518-632 187-253 187-253 414-506 414-506 518-632 518-632
460 575 575 208/230 208/230 460 460 575 575
26 19 24 49/49 54/54 25 28 19 24
30 20 25 50/50 55/55 25 30 20 25
30 20 30 60/60 60/60 30 35 20 30
2 2 2 2 2 2 2 2 2
460 575 575 200/240 200/240 480 480 575 575
3 3 3 3 3 3 3 3 3
3450 3450 3450 3450 3450 3450 3450 3450 3450
3 3/4 3 3/4 3 3/4 4 1/4 4 1/4 4 1/4 4 1/4 4 1/4 4 1/4
7.1 5.6 5.6 16/16 16/16 7.8 7.8 5.7 5.7
46 37 37 110/110 110/110 52 52 38.9 38.9
3 3/4 3 3/4 3 3/4 4 1/4 4 1/4 4 1/4 4 1/4 4 1/4 4 1/4
7.1 5.6 5.6 16/16 16/16 7.8 7.8 5.7 5.7
46 37 37 110/110 110/110 52 52 38.9 38.9
2 2 2 2 2 2 2 2 2
460 575 575 208/230 208/230 460 460 575 575
1 1 1 1 1 1 1 1 1
1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3 1/3
1.4 1 1 2.4/2.4 2.4/2.4 1.4 1.4 1 1
2.4 1.5 1.5 4.7/4.7 4.7/4.7 2.4 2.4 1.5 1.5
1 1 1 1 1 1 1 1 1
460 575 575 208/230 208/230 460 460 575 575
3 3 3 3 3 3 3 3 3
3 2 3 2 3 2 3 2 3
7 4 8 8/8 13/13 4 7 4 8
38.1 19 20 56/56 74.5/74.5 28 38.1 19 20
UnitInformation
ELECTRICAL DATA - RLNL SERIES
B102DM/C102DM
B102YL/C102YL
B102YM/C102YM
B120CL/C120CL
B120CM/C120CM
B120DL/C120DL
B120DM/C120DM
B120YL/C120YL
B120YM/C120YM
Com
pressorMotor
CondenserMotor
EvaporatorFan
Unit Operating VoltageRange
Volts
Minimum CircuitAmpacity
Minimum OvercurrentProtection Device Size
Maximum OvercurrentProtection Device Size
No.
Volts
Phase
RPM
HP, Compressor 1
Amps (RLA), Comp. 1
Amps (LRA), Comp. 1
HP, Compressor 2
Amps (RLA), Comp. 2
Amps (LRA), Comp. 2
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
ELECTRICAL DATA - RLNL-B
22
187-253 187-253 414-506 414-506 518-632 518-632
208/230 208/230 460 460 575 575
67/67 71/71 33 36 28 28
70/70 75/75 35 40 30 30
80/80 90/90 40 45 35 35
2 2 2 2 2 2
208/230 208/230 460 460 575 575
3 3 3 3 3 3
3450 3450 3450 3450 3450 3450
5 3/4 5 3/4 5 3/4 5 3/4 5 3/4 5 3/4
22.4/22.4 22.4/22.4 10.6 10.6 7.7 7.7
149/149 149/149 75 75 54 54
5 1/4 5 1/4 5 1/4 5 1/4 5 1/4 5 1/4
19/19 19/19 9.7 9.7 7.4 7.4
123/123 123/123 62 62 50 50
2 2 2 2 2 2
208/230 208/230 460 460 575 575
1 1 1 1 1 1
1/2 1/2 1/2 1/2 1/2 1/2
2.3/2.3 2.3/2.3 1.5 1.5 1 1
5.6/5.6 5.6/5.6 3.1 3.1 2.2 2.2
1 1 1 1 1 1
208/230 208/230 460 460 575 575
3 3 3 3 3 3
3 5 3 5 3 5
15/15 18.8/18.8 7 10 8 8
74.5/74.5 82.6/82.6 38.1 41.3 20 33
UnitInformation
ELECTRICAL DATA - RLNL SERIES
B150CL/C150CL
B150CM/C150CM
B150DL/C150DL
B150DM/C150DM
B150YL/C150YL
B150YM/C150YM
Com
pressorMotor
CondenserMotor
EvaporatorFan
Unit Operating VoltageRange
Volts
Minimum CircuitAmpacity
Minimum OvercurrentProtection Device Size
Maximum OvercurrentProtection Device Size
No.
Volts
Phase
RPM
HP, Compressor 1
Amps (RLA), Comp. 1
Amps (LRA), Comp. 1
HP, Compressor 2
Amps (RLA), Comp. 2
Amps (LRA), Comp. 2
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
No.
Volts
Phase
HP
Amps (FLA, each)
Amps (LRA, each)
ELECTRICAL DATA - RLNL-B
23
VI. INSTALLATIONA. GENERAL
1. PRE-INSTALLATION CHECK-POINTS
Before attempting any installation, the following pointsshould be carefully considered:
a. Structural strength of supporting members.(rooftop installation)
b. Clearances and provision for servicing.
c. Power supply and wiring.
d. Air duct connections.
e. Drain facilities and connections.
f. Location for minimum noise.
2. LOCATION
These units are designed for outdoor installations. Theycan be mounted on a slab or rooftop. They are not to beinstalled within any part of a structure such as an attic,crawl space, closet, or any other place where condenserair flow is restricted or other than outdoor ambient condi-tions prevail. Since the application of the units is of theoutdoor type, it is important to consult your local codeauthorities at the time the first installation is made.
B. OUTSIDE SLAB INSTALLATION (Typical outdoor slabinstallations are shown in Figures 6 and 7.)
1. Select a location where external water drainage cannotcollect around the unit.
2. Provide a level concrete slab extending 3" [76.2 mm]beyond all four sides of the unit. The slab should be suf-ficient above grade to prevent ground water from enter-ing the unit. IMPORTANT: To prevent transmission ofnoise or vibration, slab should not be connected tobuilding structure.
3. The location of the unit should be such as to provideproper access for inspection and servicing.
4. Locate unit where operating sounds will not disturbowner or neighbors.
5. Locate unit so roof runoff water does not pour directly onthe unit. Provide gutter or other shielding at roof level.Do not locate unit in an area where excessive snow drift-ing may occur or accumulate.
C. CLEARANCESThe following minimum clearances must be observed forproper unit performance and serviceability.
1. Provide 48" [1219.2 mm] minimum clearance at the frontof the unit. Provide 18" [457.2 mm] minimum clearanceat all other sides of the unit.
2. Provide 60" [1524 mm] minimum clearance between topof unit and maximum 3 foot [.91 m] overhang.
3. Unit is design certified for application on combustibleflooring with 0" [0 mm] minimum clearance.
4. See Figure 6 for illustration of minimum installation-ser-vice clearances.
FIGURE 6OUTSIDE SLAB INSTALLATION, BASEMENT ORCRAWL SPACE DISTRIBUTION SYSTEM
FIGURE 7OUTSIDE SLAB INSTALLATION, CLOSET DISTRIBUTIONSYSTEM. SLAB FLOOR CONSTRUCTION
A0739-03
A0741-03
RecommendedClearance Location
48” [1219.2 mm] A - Front
18” [457.2 mm] B - Condenser Coil
18” [457.2 mm] C - Duct Side
18”* [457.2 mm] D - Evaporator End
60” [1524 mm] E - Above
*Without Economizer. 48” [1219.2 mm] With*Economizer
SUPPLY
DUCT
RETURN
DUCT
24
D. ROOFTOP INSTALLATION
1. Before locating the unit on the roof, make sure that thestrength of the roof and beams is adequate at that pointto support the weight involved. This is very importantand user’s responsibility.
2. For rigging and roofcurb details, see Figures 8 and 9.Use field-furnished spreaders.
3. For roofcurb assembly, see Roofcurb Installation Instruc-tions.
4. If the roofcurb is not used, provisions for disposing ofcondensate water runoff must be provided.
5. The unit should be placed on a solid and level roofcurbor platform of adequate strength. See Figure 10.
6. The location of the unit on the roof should be such as toprovide proper access for inspection and servicing.
IMPORTANT: If unit will not be put into service immediately,cover supply and return openings to prevent excessive con-densation.
FIGURE 8RIGGING FOR LIFTING
INSTALL GASKET
NAILING STRIP
DUCT FLANGE NOTTO EXCEED 1" [25.4 mm]
SUPPLY DUCT
RETURN DUCT
CAULK ALL JOINTSWATERTIGHT
ROOFCURB
UNIT
A0719-02
A0719-03
CORNER WEIGHTS BY PERCENTAGE
A B C D
33% 27% 17% 23%
FIGURE 9ROOFCURB INSTALLATION
A074403Illustration
A074403
A0744-03
25
VII. DUCTWORKDuctwork should be fabricated by the installing contractor inaccordance with local codes and NFPA90A. Industry manualsmay be used as a guide when sizing and designing the ductsystem - contact Air Conditioning Contractors of America, 151316th St. N.W., Washington, D.C. 20036.
DO NOT, UNDER ANY CIRCUMSTANCES, CONNECTRETURN DUCTWORK TO ANY OTHER HEAT PRODUCINGDEVICE SUCH AS A FIREPLACE INSERT, STOVE, ETC.UNAUTHORIZED USE OF SUCH DEVICES MAY RESULT INFIRE, CARBON MONOXIDE POISONING, EXPLOSION,PROPERTY DAMAGE, SEVERE PERSONAL INJURY ORDEATH.
The unit should be placed as close to the space to be air condi-tioned as possible allowing clearance dimensions as indicated.Ducts should be run as directly as possible to supply andreturn outlets. Use of non-flammable waterproof flexible con-nectors on both supply and return connections at the unit toreduce noise transmission is recommended.
It is preferable to install the unit on the roof of the structure ifthe registers or diffusers are located on the wall or in the ceil-ing. A slab installation could be considered when the registersare low on a wall or in the floor.
On ductwork exposed to outside air conditions of temperatureand humidity, use a minimum of 2" [50.8 mm] of insulation anda vapor barrier. Distribution system in attic, furred space orcrawl space should be insulated with at least 2" [50.8 mm] ofinsulation with vapor barrier. One-half to 1" [25.4 mm] thick-ness of insulation is usually sufficient for ductwork inside the airconditioned space.
Balancing dampers should be provided for each branch duct inthe supply system. Ductwork should be properly supportedfrom the structure.
When installing ductwork, consider the following items:
1. Noncombustible flexible connectors should be usedbetween ductwork and unit to reduce noise and vibrationtransmission into the ductwork.
2. When auxiliary heaters are installed, use noncombustibleflexible connectors and clearance to combustible materialof 0" [0 mm] for the first 3 feet [.91 m] of discharge duct.Clearance to unit top and side is 0" [0 mm].
VIII. FILTERSThis unit is provided with 6 - 2" x 18" x 18" [51mm x 457 mm x457 mm] disposable filters. When replacing filters, ensure theyare inserted fully to the back to prevent bypass.
VIX.CONVERSION PROCEDUREDOWNFLOW TO HORIZONTAL
1. Remove the screws and covers from the outside of thesupply and return sections.
2. Install the covers over the bottom supply and return open-ings, painted side up inserting the leading flange under thebracket provided. Place the back flange to the top of thefront bracket provided. See Figure 11.
3. Secure the return and supply cover to the front bracket withone (1) screw.
FIGURE 10FLAT ROOFTOP INSTALLATION, ATTIC OR DROP CEILINGDISTRIBUTION SYSTEM. MOUNTED ON ROOFCURB.CURB MUST BE LEVEL
WARNING!
A1112-03
FIGURE 11COVER GASKET DETAIL
A0725-01
REAR PANEL
FRONT BRACKET
SUPPLY OR RETURN COVERINSULATION
BACKBRACKET
INSULATION
BASE PAN
BASE RAIL
NOTE: COVER SLIDESUNDER BACKBRACKET FLANGE.
NOTE: COVER FITS ONTOP OF FRONTBRACKET FLANGE.
26
X. CONDENSATE DRAINIMPORTANT: Install a condensate trap to ensure propercondensate drainage. See Figure 12.The condensate drain pan has a threaded female 1 inch NPT(11.5 TPI) connection. Consult local codes or ordinances forspecific requirements of condensate drain piping and disposal.• To use the removable drain pan feature of this unit, some ofthe condensate line joints should assembled for easyremoval and cleaning.
• Use a thin layer of Teflon tape or paste on drain pan con-nections and install only hand tight.
• Do not over tighten drain pan connections as damage to thedrain pan may occur.
• Drain line MUST NOT block service access panels.• Drain line must be no smaller than drain pan outlet and ade-quately sized to accommodate the condensate dischargefrom the unit.
• Drain line should slope away from unit a minimum of 1/8”per foot to ensure proper drainage.
• Drain line must be routed to an acceptable drain or outdoorsin accordance with local codes.
• Do not connect condensate drain line to a closed sewerpipe.
• Drain line may need insulation or freeze protection in certainapplications.
XI. ELECTRICAL WIRINGField wiring must comply with the National Electrical Code (CECin Canada) and local ordinances that may apply.A. POWER WIRING
1. This unit incorporates single-point electrical connectionsfor the unit and electric heat accessory.
2. It is important that proper electrical power is available tothe unit. Voltage should not vary more than 10% from thevalues marked on the unit rating plate. Phase voltagesmust be balanced within 3%.
3. Install a branch circuit disconnect within sight of the unit.Use the unit rating plate or RLNL-B Electrical Data todetermine the required size.
4. The branch circuit wire must be sized in accordance withthe National Electrical Code (C.E.C. in Canada) and localordinances that may apply using the minimum circuitampacity found on the unit rating plate.
5. Field-installed power wiring must be run through ground-ed rain-tight conduit attached to the unit power entrypanel and connected as follows:UNITS WITHOUT ELECTRIC HEAT - Connect powerwiring to the power terminal block located on the left sideof the electric heat compartment. Connect the groundwire to the adjacent ground lug.
UNITS WITH FACTORY INSTALLED ELECTRIC HEAT -Connect power wiring to the power terminal block locatedon the electric heater kit. Connect the ground wire to theadjacent ground lug. DO NOT connect aluminum wiringdirectly to the electric heater terminal block. Wiring to theunit contactors is factory-connected.
6. For field installation of an electric heater kit, follow theinstructions below. Refer to the information supplied withthe kit.a. Removing screws as required, open heater accessdoor and detach adjacent power entry panel.
b. Remove wires to unit contactor (1L1, 1L2, 1L3) fromunit terminal block on the left side of the electric heatcompartment. Remove and discard the terminal blockand the adjacent ground lug.
c. Remove the heater kit block-off panel and install theheater kit in its place using 9 of the 12 screws previ-ously removed.
d. Connect the unit contactor wires (1L1, 1L2, 1L3) to thecompressor fuse block on the heater kit.
e. Re-install the power entry panel & run conduit and theproper size field wiring through the opening in thepanel.
f. Connect field wiring to the power terminal block locatedon the electric heater kit. Connect ground wire to theadjacent ground lug.
g. Connect heater kit control plug to the receptacle on thecontrol wiring harness.
h. Close heater access door and secure with screws pre-viously removed.
B. CONTROL WIRING (Class II)
1. Low voltage wiring should not be run in conduit withpower wiring.
2. Control wiring is routed through the 7/8" [22 mm] hole inthe unit side panel. See Figure 14. Use a minimum #18AWG thermostat wire. For wire lengths exceeding 50'[15.24 m] use #16 AWG thermostat wire. Connect thecontrol wiring to the low voltage terminal block located onthe unit integrated control. Route wires under the controlvoltage shield. See Figure 14.
3. It is necessary that only approved thermostats be used.Please contact your distributor for part number informa-tion. See thermostat specification catalog for recommend-ed thermostat.
FIGURE 12CONDENSATE DRAIN
FIGURE 13BRANCH CIRCUIT DISCONNECT LOCATION
3”[76 mm]
3”[76 mm]
27
4. Figure 15 shows representative low voltage connectiondiagrams. Read your thermostat installation instructionsfor any special requirements for your specific thermostat.
C. INTERNAL WIRING1. A diagram of the internal wiring of this unit is located onthe inside of the control access panel and in this manual.If any of the original wiring must be replaced, the wiregauge and insulation must be the same as original wiring.Transformer is factory-wired for 230 volts on 208/230 voltmodels and must be changed for 208-volt applications.See unit wiring diagram for 208-volt wiring.
D. GROUNDING
THE UNIT MUST BE PERMANENTLY GROUNDED. AGROUNDING LUG IS PROVIDED IN THE ELECTRICHEAT ACCESS AREA FOR A GROUND WIRE. FAILURETO GROUND THIS UNIT CAN RESULT IN FIRE OR
ELECTRICAL SHOCK CAUSING PROPERTY DAMAGE,SEVERE PERSONAL INJURY OR DEATH.
E. THERMOSTATThe thermostat should be mounted on an inside wall aboutfive feet above the floor in a location where it will not beaffected by unconditioned air, sun, or drafts from open doorsor other sources. READ installation instructions in air condi-tioner thermostat package CAREFULLY because each hassome different wiring requirements.
XII. INDOOR AIR FLOW DATABelt-drive blower models have motor sheaves set for properCFM at a typical external static. See Tables C through G forblower performance.
XIII. CRANKCASE HEAT (OPTIONAL)Crankcase heaters are standard on 6 ton and single stage 71⁄2.Crankcase heat is not required on other models, but may bedesirable under certain conditions.
FIGURE 14
WARNING!
28
XIV. PRE-START CHECK1. Is unit properly located and slightly slanted toward indoorcondensate drain?
2. Is ductwork insulated, weatherproofed, with proper spacingto combustible materials?
3. Is air free to travel to and from outdoor coil? (See Figure 4.)4. Is the wiring correct, tight, and according to unit wiring dia-gram?
5. Is unit grounded?6. Are field supplied air filters in place and clean?7. Do the outdoor fan and indoor blower turn freely withoutrubbing, and are they tight on the motor shafts?
XV. STARTUP1. Turn thermostat to “OFF,” turn “on” power supply at discon-nect switch.
2. Turn temperature setting as high as it will go.3. Turn fan switch to “ON.”4. Indoor blower should run. Be sure it is running in the rightdirection.
5. Turn fan switch to “AUTO.” Turn system switch to “COOL”and turn temperature setting below room temperature. Unitshould run in cooling mode.
6. Is outdoor fan operating correctly in the right direction?7. Is compressor running correctly.Record the following after the unit has run some time.
A. Operating Mode _______________________________
B. Discharge Pressures (High) _____________PSIG [kPa]
C. Vapor Pressure at Compressors (Low) _____PSIG [kPa]
D. Vapor Line Temperature at Compressors ______°F [C°].
E. Indoor Dry Bulb __________________________°F [C°].
F. Indoor Wet Bulb__________________________°F [C°].
G.Outdoor Dry Bulb_________________________°F [C°].
H. Outdoor Wet Bulb ________________________°F [C°].
I. Voltage at Contactor ________________________Volts
J. Current at Contactors ______________________ Amps
K. Model Number_________________________________
L. Serial Number _________________________________
M.Location______________________________________
N. Owner _______________________________________
O.Date_________________________________________8. Turn thermostat system switch to “HEAT.” Unit compres-sors should stop. Raise temperature setting to above roomtemperature. Unit should run in heating mode and auxiliaryheaters, if installed, should come on.
9. Check the refrigerant charge using the instructions locatedon unit charging chart. Replace service port caps. Serviceport cores are for system access only and will leak if nottightly capped.
10. Adjust discharge air grilles and balance system.11. Check ducts for condensation and air leaks.12. Check unit for tubing and sheet metal rattles.13. Instruct the owner on operation and maintenance.14. Leave “INSTALLATION” and ”USE AND CARE“ instruc-
tions with owner
R Y1 Y2 G C W1 W2 W3 B
TERMINAL BLOCK
st-A1125-12-00
COOL
POWER
FAN
HEAT
ONLY USEDON DUAL
FUEL OR HEATPUMP
MODELSLOW VOLTAGETHERMOSTAT CONNECTIONS
FIGURE 15THERMOSTATCONNECTIONSDIAGRAM
ST-A1125-12-00
29
XVI. OPERATIONCOOLING MODEWith thermostat in the cool mode, fan auto and the room tem-perature higher than the thermostat setting:
A. Indoor blower contactor is energized through thermostatcontact (G).
B. Compressor contactors are energized through thermostatcontacts (Y1) & (Y2) and high pressure controls.
C. Economizer enthalpy control (if installed) controls operationof first-stage cooling and positions fresh air damper to main-tain mixed air temperature. Second-stage cooling operatesnormally as required by second stage of thermostats.
D. The system will continue in cooling operation as long as allsafety controls are closed, until the thermostat is satisfied.
HEATING MODEWith the thermostat in heat mode, fan on auto, and the roomtemperature lower than the thermostat setting, the Indoorblower contactor is energized through thermostat contact (G).
ONLY ELECTRIC HEATER KITS SUPPLIED BY THIS MAN-UFACTURER AS DESCRIBED IN THIS PUBLICATION HAVEBEEN DESIGNED, TESTED, AND EVALUATED FOR USEWITH THIS UNIT. USE OF ANY OTHER MANUFACTUREDELECTRIC HEATERS INSTALLED WITHIN THIS UNIT MAYCAUSE HAZARDOUS CONDITIONS RESULTING IN PROP-ERTY DAMAGE, FIRE, BODILY INJURY OR DEATH.
In the heating mode, the thermostat will energize one or moresupplementary heaters.
XVII. MISCELLANEOUSREPLACEMENT PARTSContact your local distributor for a complete parts list.
.
WARNING!
30
XVIII.A
IRFL
OW
DATA
TABLE
S
AIR-FLOWPERFORMANCE–6TONRLNL-B072/C072MODELS
1800
[849]
1900
[897]
2000
[944]
2100
[991]
2200
[1038]
2300
[1085]
2400
[1133]
2500
[1180]
2600
[1227]
2700
[1274]
2800
[1321]
AirFlow
CFM[L/s]
ModelRKNL-B072/C072
Voltage208/230,460,575—3phase
ExternalStaticPressure—InchesofWater[kPa]
0.1[.02]
RPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
W0.2[.05]
0.3[.07]
0.4[.10]
0.5[.12]
0.6[.15]
0.7[.17]
0.8[.20]
0.9[.22]
1.0[.25]
1.1[.27]
1.2[.30]
1.3[.32]
1.4[.35]
1.5[.37]
——
——
——
——
835
631
880
686
924
740
965
794
1005
847
1043
898
1079
949
1113
999
1146
1048
1177
1096
1206
1144
——
——
——
808
622
854
681
899
739
941
795
982
851
1021
906
1058
960
1093
1013
1127
1065
1159
1117
1189
1167
1217
1217
——
——
——
828
673
874
734
918
794
959
853
999
911
1037
968
1074
1025
1108
1080
1141
1135
1172
1189
1201
1242
1228
1293
——
——
803
663
850
727
894
790
937
853
978
914
1017
974
1055
1034
1090
1093
1124
1151
1156
1208
1186
1264
1214
1319
1241
1373
——
——
826
718
871
784
915
850
957
914
997
978
1036
1041
1072
1103
1107
1164
1140
1224
1171
1283
1201
1342
1228
1399
1254
1456
——
802
706
849
775
894
844
937
912
978
979
1017
1045
1055
1110
1091
1174
1125
1238
1157
1300
1187
1362
1216
1423
1242
1482
1267
1541
——
826
764
872
836
916
907
959
977
999
1047
1038
1115
1075
1183
1110
1249
1143
1315
1174
1380
1204
1444
1231
1507
1257
1569
1282
1630
805
751
852
826
897
900
940
973
981
1046
1021
1118
1059
1188
1095
1258
1129
1327
1162
1395
1192
1462
1221
1529
1248
1594
1273
1658
——
831
813
877
890
922
967
964
1043
1005
1118
1044
1191
1081
1265
1116
1337
1149
1408
1181
1478
1211
1548
1239
1616
1265
1684
——
——
858
878
904
958
947
1037
989
1115
1029
1192
1067
1268
1103
1344
1137
1418
1170
1492
1201
1565
1230
1637
1257
1708
1282
1778
——
——
886
947
931
1029
973
1110
1014
1190
1053
1270
1091
1349
1126
1426
1160
1503
1191
1579
1221
1654
1250
1728
1276
1802
——
——
——
NOTE:L-Driveleftofboldline,M-Driverightofboldline.
NOTES:1.Factorysheavesettingsareshowninboldtype.
2.Donotsetmotorsheavebelowminimum
turnsopen
shown.
3.Re-adjustmentofsheaverequiredtoachieveratedairflowatARIm
inimum
E.S.P.
4.Drivedatashownisforhorizontalairflowwithdrycoil.addcomponentresistance
toduct
resistancetodeterminetotalE.S.P.
DrivePackage
MotorH.P.[W]
BlowerSheave
Motorsheave
TurnsOpen
RPM
LM
1.5[1118.6]
AK66
1VP-50
1.5[1118.6]
AK66
1VP-44
01
23
45
1119
1072
1019
967
915
859
01
23
45
1267
1215
1163
1113
1064
1015
AIRFLOWCORRECTIONFACTORS
6TONS[21.10kW
]ActualCFM[L/s]
1800
2000
2200
2400
2600
2800
TotalMBH
SensibleMBH
PowerKW
[849]
[944]
[1038]
[1133]
[1227]
[1321]
0.97
0.98
0.99
1.00
1.01
1.02
0.91
0.94
0.97
1.00
1.02
1.05
0.99
0.99
0.99
1.00
1.00
1.01
[]DesignatesMetricConversions
CCoommppoonneenntt
Wet Coil
Concentric Diffuser RXRN-FA65 or
FA75 & Transition RXMC-CE05
Concentric Diffuser RXRN-AA61 or
AA71 & Transition RXMC-CE05
Economizer
100%
R.A. Dam
per Open
Horizontal Economiser
100%
R.A. O
pen
Horizontal Economiser
100%
O.A. Dam
per Open
Standard Indoor Airflow-CFM [L/s]
Resistance-Inches Water [Kpa]
1800
[849]
0.031
0.036
0.041
0.047
0.051
0.055
[0.008]
[0.009]
[0.01]
[0.012]
[0.013]
[0.014]
DNA
DNA
DNA
DNA
0.017
0.02
[0.042]
[0.050]
DNA
DNA
DNA
DNA
DNA
DNA
0.02
0.03
0.04
0.05
0.06
0.07
[0.005]
[0.007]
[0.01]
[0.012]
[0.015]
[0.017]
0.02
0.02
0.03
0.03
0.04
0.04
[0.005]
[0.005]
[0.007]
[0.007]
[0.01]
[0.01]
0.07
0.07
0.07
0.08
0.08
0.08
[0.017]
[0.017]
[0.017]
[0.02]
[0.02]
[0.02]
2000
[944]
2200
[1038]
2400
[1133]
2600
[1227]
2800
[1321]
COMPONENT AIR RESISTANCE, IWC
6 TONS [21.10 kW
]
31
AIR-FLOW PERFORMANCE – 7.5 TON RLNL-B085/C085 & B090/C090 MODELS
55
AIRFLOW PERFORMANCE—RKNB- SERIES
AIR
FLO
W P
ER
FOR
MA
NC
E—
7.5
TON
[26.
4 kW
]
1097
2328
1126
3100
[146
3]56
080
459
894
063
210
1066
471
377
213
1180
113
7383
014
3586
014
9788
915
5992
118
1695
019
0197
919
8710
0920
7210
3821
5710
6822
4332
00 [1
510]
576
876
612
1011
646
1089
678
722
781
1371
810
1433
839
1495
868
1557
898
1619
928
1880
957
1965
987
2051
1016
2136
1045
2222
2414
1075
2307
3300
[155
7]59
295
462
810
9666
011
6869
273
178
914
3181
814
9384
815
5587
716
1790
618
5993
519
4496
520
2999
421
1510
2322
0010
53
Capa
city
7.5
Ton
[26.
4 kW
]
2286
1082
2371
3400
[160
5]60
710
3064
311
8067
312
4771
073
979
814
9182
715
53
RPM
WR
PMW
RPM
WR
PMR
PMR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
2400
[113
3]—
——
—54
058
058
261
271
189
074
095
277
010
1479
910
7682
811
3885
712
0088
712
6192
915
3895
816
2398
717
0910
1717
9425
00 [1
180]
——
——
552
633
593
624
720
950
749
1012
778
1074
808
1136
837
1198
866
1260
895
1322
936
1602
965
1687
995
1773
1024
1858
2600
[122
7]—
——
—56
468
760
363
572
910
1075
810
7278
711
3481
611
9684
612
5887
513
2091
415
8194
316
6697
217
5110
0218
3710
3119
2227
00 [1
274]
——
539
670
577
744
614
648
737
1070
766
1132
796
1194
825
1256
854
1318
883
1380
921
1645
950
1730
980
1816
1009
1901
1038
1986
2800
[132
1]—
—55
473
359
080
162
566
074
611
3177
511
9280
412
5483
413
1686
313
7889
214
4092
817
0995
817
9498
718
8010
1619
6510
4620
5029
00 [1
369]
——
569
801
604
866
638
673
755
1191
784
1253
813
1315
842
1376
872
1438
906
1688
936
1773
965
1858
994
1944
1024
2029
1053
2115
3000
[141
6]54
674
185
486
961
793
165
068
576
312
5179
213
1382
213
7585
114
3788
014
9891
317
5294
318
3797
219
2310
0220
0810
3120
9310
6021
79
3500
[165
2]62
211
1265
812
7168
913
4471
974
880
715
5283
616
1386
516
7589
417
3792
019
8795
020
7297
921
5810
0922
4310
3823
2810
6724
1410
9724
9985
616
1588
616
7791
319
2394
320
0897
220
9410
0121
7910
3122
6410
6023
5010
8924
35
3600
[169
9]63
812
0267
213
6170
414
4072
875
781
516
1284
416
7487
417
3590
317
9792
820
5195
721
3698
622
2210
1623
0710
4523
9310
7524
7811
0425
63
Air
Flow
CFM
[L/s
]
1156
2499
1104
2392
1134
2478
1163
2563
1111
2456
1141
2542
1170
2627
RPM
WR
PMW
RPM
W10
4618
7910
7519
6511
0520
5010
5319
4410
8320
2911
1221
1410
6120
0810
9020
9311
1921
7810
6820
7210
9721
5711
2722
4310
7521
3611
0422
2111
3423
0710
8222
0011
1222
8511
4123
7110
9022
6411
1923
5011
4824
35
1126
2585
1155
2670
1185
2756
1119
2521
1148
2606
1178
2691
1133
2649
1163
2734
1192
2820
0.1
[.02
]0.
2 [.
05]
0.3
[.07
]0.
4 [.
10]
0.7
[.17
]0.
8 [.
20]
0.9
[.22
]1.
0 [.
25]
1.1
[.27
]1.
2 [.
30]
1.3
[.32
]1.
4 [.
35]
1.5
[.37
]1.
6 [.
40]
1.7
[.42
]1.
8 [.
45]
1.9
[.47
]2.
0 [.
50]
Exte
rnal
Sta
tic P
ress
ure—
Inch
es o
f Wat
er [k
Pa]
743
751
760
769
RPM 64
565
666
768
070
872
573
4
777
786
1107
1189
1274
1306W 66
471
776
982
888
795
610
24
1366
1426
0.6
[.15
]0.
5 [.
12]
1249
1309
1369
1430W 81
287
894
510
1710
6911
2911
89
1490
1550
1187
1247
1307
1368W 72
979
185
392
399
310
6911
44
1428
1488
Driv
e Pa
ckag
eL
MM
otor
H.P
. [W
]2.
0 [1
491.
4]2.
0 [1
491.
4]Bl
ower
She
ave
BK11
0BK
90M
otor
She
ave
1VP-
441V
P-44
Turn
s O
pen
12
34
56
12
34
56
RPM
682
650
620
587
555
523
869
838
806
774
742
710
N3.
0 [2
237.
1]BK
651V
P-44
12
34
56
1157
1106
1056
1005
954
904
NO
TES:
1. F
acto
ry s
heav
e se
tting
s ar
e sh
own
in b
old
prin
t.2.
Re-
adju
stm
ent o
f she
ave
requ
ired
to a
chie
ve ra
ted
airf
low
at A
RI m
inim
um E
.S.P
.3.
Do
not o
pera
te a
bove
blo
wer
RPM
sho
wn
as m
otor
ove
rload
ing
will
occ
ur.
4.D
o no
t set
mot
or s
heav
e be
low
one
turn
ope
n.
NO
TE: L
-Driv
e le
ft of
1st
bol
d lin
e, M
-Driv
e in
mid
dle
of b
old
lines
, N-D
rive
right
of 2
nd b
old
line.
AIR
FLO
W C
OR
RE
CT
ION
FA
CTO
RS
7.5
TON
[26.
4 kW
] 0.98
0.99
TOTA
L M
BH
0.99
0.97
0.97
3000
[141
6]1.
001.
01
1.00
0.99
1.02
3400
[160
5]
POW
ER k
W1.
000.
991.
00
3200
[151
0]
0.94
SEN
SIBL
E M
BH0.
91
2800
[132
1]AC
TUAL
—CF
M[L
/s]
2600
[122
7]1.
02
1.01
1.05
3600
[169
9]1.
03
1.02
1.08
3800
[179
3]
CO
MP
ON
EN
T A
IR R
ES
ISTA
NC
E, I
WC
7.
5 TO
N [2
6.4
kW]
Com
pone
nt
Stan
dard
Indo
or A
irflo
w—
CFM
[L/s
]24
00[1
133]
2600
[122
7]28
00[1
321]
3000
[141
6]32
00[1
510]
3400
[160
4]36
00[1
699]
Res
ista
nce—
Inch
es W
ater
[kPa
]
Wet
Coi
l0.
047
[0.0
12]
0.05
1[0
.013
]0.
055
[0.0
14]
0.06
0[0
.015
]0.
065
[0.0
16]
0.07
1[0
.018
]0.
076
[0.0
19]
Econ
omiz
er10
0% R
.A. D
ampe
r Ope
n0.
05[0
.012
]0.
06[0
.015
]0.
07[0
.017
]0.
08[0
.020
]0.
09[0
.022
]0.
10[0
.025
]0.
11[0
.027
]H
oriz
onta
l Eco
nom
izer
100%
R.A
. Dam
per O
pen
0.03
[0.0
07]
0.04
[0.0
09]
0.04
[0.0
10]
0.05
[0.0
11]
0.05
[0.0
12]
0.06
[0.0
14]
0.06
[0.0
15]
Conc
entr
ic D
iffus
er R
XRN
-FA6
5 or
FA
75 &
Tra
nsiti
on R
XMC-
CD04
DN
A.0
17[0
.042
].0
20[0
.050
].0
25[0
.062
].0
31[0
.077
].0
37[0
.092
]D
NA
Conc
entr
ic D
iffus
er R
XRN
-AA6
1 or
AA
71 &
Tra
nsiti
on R
XMC-
CE05
DN
AD
NA
DN
AD
NA
DN
AD
NA
.017
[0.0
42]
Hor
izon
tal E
cono
miz
er
100%
O.A
. Dam
per O
pen
0.08
[0.0
20]
0.08
[0.0
20]
0.08
[0.0
20]
0.10
[0.0
24]
0.11
[0.0
27]
0.12
[0.0
30]
0.13
[0.0
32]
NO
TES:
1. M
ultip
ly c
orre
ctio
n fa
ctor
tim
es g
ross
per
form
ance
dat
a.2.
Res
ultin
g se
nsib
le c
apac
ity c
anno
t exc
eed
tota
l cap
acity
.
[]
Des
ign
ates
Met
ric
Co
nve
rsio
ns
NO
TE: A
dd c
ompo
nent
resi
stan
ce to
duc
t res
ista
nce
to d
eter
min
e to
tal e
xter
nal s
tatic
pre
ssur
e.D
NA
= D
ata
not A
vaila
ble.
32
AIR-FLOW PERFORMANCE – 8.5 TON RLNL B102/C102 MODELS
56
AIRFLOW PERFORMANCE—RKKB/RKMB-A
IRF
LO
W P
ER
FO
RM
AN
CE
—8.
5 T
ON
[29
.9 k
W]
1060
2350
1089
3400
[160
5]—
——
—68
112
4471
013
0673
913
6876
914
3079
814
9182
715
5385
616
1588
616
7791
319
2394
320
0897
220
9410
0121
7910
3122
6435
00 [1
652]
——
673
1270
690
1304
719
1366
748
1428
777
1490
807
1552
836
1613
865
1675
894
1737
920
1987
950
2072
979
2158
1009
2243
2435
1038
2328
3600
[169
9]—
—68
613
5269
813
6472
814
2675
714
8878
615
5081
516
1284
416
7487
417
3590
317
9792
820
5195
721
3698
622
2210
1623
0710
4523
9337
00 [1
746]
672
1361
700
1435
727
1510
755
1584
782
1659
810
1733
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
W27
00 [1
274]
——
——
——
——
——
708
1009
737
1070
766
1132
796
1194
825
1256
854
1318
883
1380
921
1645
950
1730
980
1816
2800
[132
1]—
——
——
——
——
—71
710
6974
811
3177
511
9280
412
5483
413
1686
313
7889
214
4092
817
0995
817
9498
718
8029
00 [1
369]
——
——
——
——
——
725
1129
755
1191
784
1253
813
1315
842
1376
872
1438
906
1688
936
1773
965
1858
994
1944
3000
[141
6]—
——
——
——
—70
511
2773
411
8976
312
5179
213
1382
213
7585
114
3788
014
9891
317
5294
318
3797
219
2310
0220
0831
00 [1
463]
——
——
——
——
713
1187
743
1249
772
1311
801
1373
830
1435
860
1497
889
1559
921
1816
950
1961
979
987
1009
2072
3200
[151
0]—
——
——
—69
311
8572
212
4776
113
0978
113
7181
014
3383
914
9586
815
5789
816
1992
818
8093
719
6598
720
5110
1821
3633
00 [1
557]
——
——
——
701
1246
731
1307
760
1369
789
1431
818
1493
848
1555
877
1617
906
1856
935
1944
968
2029
994
2115
1023
2200
3800
[179
3]68
614
4371
315
1874
115
9276
816
6779
617
4182
318
1685
118
9087
819
6594
020
0396
020
7598
121
8910
0123
0210
1624
1610
4325
2910
6226
4383
718
0886
518
8293
318
9695
319
5697
320
7099
321
8310
0222
9710
3024
1010
5425
24
4000
[188
8]71
316
0974
016
8376
817
5879
518
3282
319
0785
019
8187
820
5693
520
8595
521
9997
523
1299
624
2610
1625
3910
4326
5310
7027
6710
7728
80
1119
2521
1067
2414
1097
2499
1126
2585
1071
2478
1104
2563
1133
2649
RPM
WR
PMW
RPM
W10
0919
0110
3819
6610
6820
7210
1619
6510
4620
5010
7521
3610
2420
2910
5321
1510
8222
0010
3120
9310
6021
7910
9022
6410
3821
5710
6822
4310
9723
2810
4522
2210
7523
0711
0423
9210
5322
8610
8223
7111
1124
56
1082
2756
1119
2870
1147
2983
1075
2637
1111
2751
1140
2864
1097
2994
1135
3107
——
Capa
city
8.5
Ton
[29.
9 kW
]
3900
[184
1]69
915
2672
716
0175
416
7578
217
5080
918
2483
718
9986
419
7392
720
1594
820
8096
821
9498
823
0710
0824
2110
2925
3410
5726
4810
6927
6110
9028
7511
2729
88—
—
4100
[193
5]72
616
9275
417
6678
118
4180
919
1583
619
9086
420
6492
220
9194
222
0496
323
1898
324
3110
0325
4510
2426
5810
5627
7210
8428
8510
8429
9911
0531
1211
4432
26—
—
Air
Flow
CFM
[L/s
]
1148
2606
——
——
——
——
——
RPM
WR
PMW
1097
2157
1127
2243
1104
2221
1134
2307
1112
2285
1141
2371
1119
2350
1148
2435
1126
2414
——
1134
2478
——
1141
2542
——
——
——
——
——
——
——
——
——
——
——
0.1
[.02
]0.
2 [.
05]
0.3
[.07
]0.
4 [.
10]
0.5
[.12
]0.
6 [.
15]
0.7
[.17
]0.
8 [.
20]
0.9
[.22
]1.
0 [.
25]
1.1
[.27
]1.
2 [.
30]
1.3
[.32
]1.
4 [.
35]
1.5
[.37
]1.
6 [.
40]
1.7
[.42
]1.
8 [.
45]
1.9
[.47
]2.
0 [.
50]
Exte
rnal
Sta
tic P
ress
ure—
Inch
es o
f Wat
er [k
Pa]
Driv
e Pa
ckag
eL
MM
otor
H.P
. [W
]2.
0 [1
491.
4]3.
0 [2
237.
1]Bl
ower
She
ave
BK90
BK65
Mot
or S
heav
e1V
P-44
1VP-
44Tu
rns
Ope
n1
23
45
61
23
45
6R
PM86
082
479
175
772
369
011
4810
9810
4999
994
989
9
NO
TES:
1. F
acto
ry s
heav
e se
tting
s ar
e sh
own
in b
old
prin
t.2.
Re-
adju
stm
ent o
f she
ave
requ
ired
to a
chie
ve ra
ted
airf
low
at A
RI m
inim
um E
.S.P
.3.
Do
not o
pera
te a
bove
blo
wer
RPM
sho
wn
as m
otor
ove
rload
ing
will
occ
ur.
4.D
o no
t set
mot
or s
heav
e be
low
one
turn
ope
n.
NO
TE: L
-Driv
e le
ft of
bol
d lin
e, M
-Driv
e rig
ht o
f bol
d lin
e.
AIR
FL
OW
CO
RR
EC
TIO
N F
AC
TO
RS
8.5
TO
N [
29.9
kW
] 0.98
0.99
TOTA
L M
BH0.
96
1.00
0.97
0.97
3200
[151
0]1.
001.
01
1.01
0.99
1.03
3600
[169
9]
POW
ER k
W0.
991.
000.
991.
00
3400
[160
5]1.
03
1.02
1.07
4000
[188
8]1.
04
1.03
0.94
1.09
4200
[198
2]
SEN
SIBL
E M
BH1.
02
1.01
1.05
0.88
3800
[179
3]
0.91
3000
[141
6]AC
TUAL
—CF
M[L
/s]
2600
[122
7]28
00[1
321]
CO
MP
ON
EN
T A
IR R
ES
ISTA
NC
E, I
WC
8.
5 T
ON
[29
.9 k
W]
Com
pone
nt
Stan
dard
Indo
or A
irflo
w—
CFM
[L/s
]
Conc
entr
ic D
iffus
er R
XRN
-FA6
5 or
FA75
& T
rans
ition
RXM
C-CD
040.
17[0
.042
]0.
20[0
.050
]0.
25[0
.062
]0.
31[0
.077
]0.
37[0
.092
]D
NA
DN
A
Conc
entr
ic D
iffus
er R
XRN
-AA6
1 or
AA71
& T
rans
ition
RXM
C-CE
05D
NA
2600
[122
7]28
00[1
321]
3000
[141
6]32
00[1
510]
3400
[160
4]36
00[1
699]
3800
[179
3]
DN
AD
NA
DN
AD
NA
Res
ista
nce—
Inch
es W
ater
[kPa
]
0.17
[0.0
42]
0.18
[0.0
45]
Hor
izon
tal E
cono
miz
er
100%
O.A
. Dam
per O
pen
0.08
[0.0
20]
0.08
[0.0
20]
0.10
[0.0
24]
0.11
[0.0
27]
0.12
[0.0
30]
0.13
[0.0
32]
Wet
Coi
l0.
051
[0.0
13]
0.05
5[0
.014
]0.
060
[0.0
15]
0.06
5[0
.016
]0.
071
[0.0
18]
0.07
6[0
.019
]0.
082
[0.0
20]
0.15
[0.0
36]
Econ
omiz
er10
0% R
.A. D
ampe
r Ope
n0.
06[0
.015
]0.
07[0
.017
]0.
08[0
.020
]0.
09[0
.022
]0.
10[0
.025
]0.
11[0
.027
]0.
12[0
.030
]H
oriz
onta
l Eco
nom
izer
100%
R.A
. Dam
per O
pen
0.04
[0.0
09]
0.04
[0.0
10]
0.05
[0.0
11]
0.05
[0.0
12]
0.06
[0.0
14]
0.06
[0.0
15]
0.07
[0.0
17]
DN
A
4000
[188
8]
0.21
[0.0
52]
0.08
7[0
.022
]
0.16
[0.0
40]
0.13
[0.0
32]
0.08
[0.0
20]
DN
A
4200
[198
2]
0.24
[0.0
60]
0.09
3[0
.023
]
0.18
[0.0
44]
0.14
[0.0
35]
0.09
[0.0
21]
NO
TE: A
dd c
ompo
nent
resi
stan
ce to
duc
t res
ista
nce
to d
eter
min
e to
tal e
xter
nal s
tatic
pre
ssur
e.D
NA
= D
ata
not A
vaila
ble.
NO
TES:
1. M
ultip
ly c
orre
ctio
n fa
ctor
tim
es g
ross
per
form
ance
dat
a.2.
Res
ultin
g se
nsib
le c
apac
ity c
anno
t exc
eed
tota
l cap
acity
.
[]
Des
ign
ates
Met
ric
Co
nve
rsio
ns
33
AIR-FLOW PERFORMANCE – 10 TON RLNL B120/C120 MODELS
57
AIRFLOW PERFORMANCE—RKKB/RKMB/RKNB-
1090
2875
1110
3900
[184
1]69
915
2672
716
0175
416
7578
217
5080
918
2483
718
9986
419
7392
720
1594
820
8096
821
9498
823
0710
0824
2110
2925
3410
5726
4810
6927
6140
00 [1
888]
713
1609
740
1683
768
1758
795
1832
823
1907
850
1961
878
2056
935
2085
955
2199
975
2312
996
2426
1016
2539
1043
2653
1070
2767
2988
1077
2880
4100
[193
5]72
616
9275
417
6678
118
4180
919
1583
619
9086
420
6492
220
9194
222
0496
323
1898
324
3110
0325
4510
2426
5810
5627
7210
8428
8510
8429
9942
00 [1
982]
740
1774
767
1849
795
1923
822
1998
850
2072
877
2147
Exte
rnal
Sta
tic P
ress
ure—
Inch
es o
f Wat
er [k
Pa]
3200
[151
0]—
——
——
—65
711
7071
512
4574
213
1977
013
9479
714
6882
515
4385
216
1788
016
9295
616
9897
617
0399
618
1710
1719
3033
00 [1
557]
——
——
673
1179
701
1253
728
1328
756
1402
783
1477
811
1551
838
1626
866
1700
943
1705
963
1708
948
1822
976
1935
1024
2049
3400
[160
5]—
——
—68
712
6171
413
3674
214
1076
914
8579
715
5982
416
3485
217
0887
917
6395
018
1197
118
2796
219
4198
920
5410
3221
6835
00 [1
652]
——
673
1270
700
1344
728
1419
755
1493
783
1588
810
1642
838
1717
865
1791
938
1813
958
1832
978
1946
975
2059
1003
2173
1039
2286
3600
[169
9]—
—68
613
5271
414
2774
115
0176
915
7679
616
5082
417
2585
117
9987
918
7494
518
9296
619
5198
620
6598
921
7810
1622
9210
4724
0537
00 [1
746]
672
1361
700
1435
727
1510
755
1584
782
1659
810
1733
837
1808
865
1882
933
1896
953
1956
973
2070
993
2183
1002
2297
1030
2410
1054
2524
3800
[179
3]68
614
4371
315
1874
115
9276
816
6779
617
4182
318
1886
118
9087
819
6594
020
0396
020
7598
121
8910
0123
0210
1624
1610
4325
2910
6226
43
4300
[202
9]75
318
5778
119
3280
820
0683
620
8185
321
5591
722
1593
723
2895
724
4297
825
5599
826
6910
1827
8210
3928
9610
8330
0911
1131
2310
9932
3693
022
0995
023
2397
024
3899
025
5010
1126
6310
3127
7710
7028
9010
9730
0410
9231
17
4700
[221
8]80
721
8883
522
6386
223
3790
624
6292
725
7694
726
8996
728
0398
829
1610
0830
3010
2831
4310
4832
5710
6933
7111
3734
8411
6535
9811
3037
11
1130
3102
1097
2994
1117
3107
1138
3221
1105
3112
1125
3226
1145
3339
1037
2044
1057
2157
1077
2271
1044
2162
1065
2276
1085
2390
1052
2281
1072
2395
1092
2508
1059
2400
1080
2513
1100
2627
1067
2519
1087
2632
1108
2746
1075
2637
1095
2751
1115
2864
1082
2756
1102
2870
1123
2983
1120
3350
1140
3453
1160
3577
1112
3231
1133
3345
1153
3458
1150
3825
1170
3938
1190
4052
1191
3442
—11
5032
1511
7133
2911
5833
34—
1178
3448
1166
3453
1186
3566
1098
2384
1118
2498
1105
2503
1125
2617
1113
2622
1133
2735
1120
2740
1141
2854
1128
2859
1148
2973
1135
2978
1156
3091
1143
3097
1163
3210
1181
3690
——
1173
3572
1193
3685
——
——
——
1199
3561
——
——
——
——
——
1138
2611
1159
2725
1179
2838
1146
2730
1166
2844
1186
2957
1153
2849
1174
2962
1194
3076
1161
2968
1181
3081
——
1168
3086
1189
3200
——
1176
3205
1196
3318
——
1183
3324
——
——
——
——
——
——
——
——
——
——
——
4400
[207
7]76
719
4079
420
1482
220
8984
921
6387
722
3892
423
3394
524
4796
525
6098
526
7410
0627
8710
2629
0110
4630
1410
9731
2811
2432
4111
0733
5545
00 [2
124]
780
2023
808
2097
835
2172
863
2248
912
2338
1188
932
2452
4600
[217
1]79
421
0582
121
8084
022
5487
623
2991
924
5794
025
7196
026
8498
027
9810
0029
1110
2130
2510
4131
3810
6132
5211
2433
6511
5134
7911
2235
9295
225
8597
326
7999
327
9310
1329
0610
3330
2010
5431
3311
1032
4711
3833
6011
1534
7438
09—
1127
3468
1148
3582
1168
3695
—
1142
3706
1163
3819
1183
3933
1135
3587
1155
3701
1175
3814
——
——
1196
3928
——
——
——
——
——
——
——
——
——
——
4800
[226
5]82
122
7184
823
4587
624
2091
425
8193
426
9595
528
0897
529
2299
530
3510
1531
4910
3632
6210
5633
7610
7634
8911
5136
0311
7837
1611
3738
3011
5739
4311
7840
5711
9841
70—
——
——
——
——
—
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
W0.
1 [.
02]
0.2
[.05
]0.
3 [.
07]
0.4
[.10
]0.
5 [.
12]
0.6
[.15
]0.
7 [.
17]
0.8
[.20
]0.
9 [.
22]
1.0
[.25
]1.
1 [.
27]
1.2
[.30
]1.
3 [.
32]
1.4
[.35
]1.
5 [.
37]
RPM
1.6
[.40
]1.
7 [.
42]
1.8
[.45
]W
RPM
WR
PMW
RPM
W1.
9 [.
47]
2.0
[.50
]2.
1 [.
52]
2.2
[.55
]2.
3 [.
57]
Air
Flow
CFM
[L/s
]
Capa
city
10 T
on [3
5.2
kW]
AIR
FL
OW
PE
RF
OR
MA
NC
E—
10 T
ON
[35
.2 k
W]
Driv
e Pa
ckag
eL
MM
otor
H.P
. [W
]2.
0 [1
491.
4]3.
0 [2
237.
1]Bl
ower
She
ave
BK90
BK65
Mot
or S
heav
e1V
P-44
1VP-
44Tu
rns
Ope
n1
23
45
61
23
45
6R
PM84
581
077
573
970
466
911
3810
8910
4199
294
389
4
NO
TES:
1. F
acto
ry s
heav
e se
tting
s ar
e sh
own
in b
old
prin
t.2.
Re-
adju
stm
ent o
f she
ave
requ
ired
to a
chie
ve ra
ted
airf
low
at A
RI m
inim
um E
.S.P
.3.
Do
not o
pera
te a
bove
blo
wer
RPM
sho
wn
as m
otor
ove
rload
ing
will
occ
ur.
4.D
o no
t set
mot
or s
heav
e be
low
one
turn
ope
n.
NO
TE: L
-Driv
e le
ft of
bol
d lin
e, M
-Driv
e rig
ht o
f bol
d lin
e.
AIR
FL
OW
CO
RR
EC
TIO
N F
AC
TO
RS
10 T
ON
[35
.2 k
W]
0.98
0.99
TOTA
L M
BH0.
96
0.99
0.97
0.97
3800
[179
3]1.
001.
01
1.00
0.99
1.02
4200
[198
2]
POW
ER k
W0.
981.
000.
981.
00
4000
[188
8]1.
03
1.01
1.07
4600
[217
1]
0.95
SEN
SIBL
E M
BH0.
910.
93
3600
[169
9]AC
TUAL
—CF
M[L
/s]
3200
[151
0]34
00[1
605]
1.04
1.01
1.09
4800
[226
5]1.
02
1.01
1.05
4400
[207
7]
CO
MP
ON
EN
T A
IR R
ES
ISTA
NC
E, I
WC
10
TO
N [
35.2
kW
]
Com
pone
nt
Stan
dard
Indo
or A
irflo
w—
CFM
[L/s
]
Conc
entr
ic D
iffus
er R
XRN
-FA6
5 or
FA75
& T
rans
ition
RXM
C-CD
040.
31[0
.077
]0.
37[0
.092
]D
NA
DN
AD
NA
DN
AD
NA
Conc
entr
ic D
iffus
er R
XRN
-AA6
1 or
AA71
& T
rans
ition
RXM
C-CE
05D
NA
3200
[151
0]34
00[1
604]
3600
[169
9]38
00[1
793]
4000
[188
8]42
00[1
982]
4400
[207
6]
DN
A0.
17[0
.042
]0.
18[0
.045
]0.
21[0
.052
]
Res
ista
nce—
Inch
es W
ater
[kPa
]
0.24
[0.0
60]
0.27
[0.0
67]
Hor
izon
tal E
cono
miz
er
100%
O.A
. Dam
per O
pen
0.11
[0.0
27]
0.12
[0.0
30]
0.13
[0.0
32]
0.15
[0.0
.36]
0.16
[0.0
40]
0.18
[0.0
44]
Wet
Coi
l0.
065
[0.0
16]
0.07
1[0
.018
]0.
076
[0.0
19]
0.08
2[0
.020
]0.
087
[0.0
22]
0.09
3[0
.023
]0.
099
[0.0
25]
0.19
[0.0
47]
Econ
omiz
er10
0% R
.A. D
ampe
r Ope
n0.
09[0
.022
]0.
10[0
.025
]0.
11[0
.027
]0.
12[0
.030
]0.
13[0
.032
]0.
14[0
.035
]0.
15[0
.037
]
DN
A
4600
[217
1]
DN
A
0.10
5[0
.026
]
0.20
[0.5
0]
0.16
[0.0
40]
0.10
[0.0
24]
DN
A
4800
[226
5]
Hor
izon
tal E
cono
miz
er10
0% R
.A. D
ampe
r Ope
n0.
05[0
.012
]0.
06[0
.014
]0.
06[0
.015
]0.
07[0
.017
]0.
08[0
.020
]0.
09[0
.021
]0.
09[0
.022
]
DN
A
0.11
0[0
.027
]
0.21
[0.0
52]
0.17
[0.0
42]
0.10
[0.0
25]
Conc
entr
ic D
iffus
er R
XRN
-AA6
6 or
AA76
& T
rans
ition
RXM
C-CF
06D
NA
DN
AD
NA
DN
AD
NA
DN
AD
NA
0.31
[0.0
77]
0.32
[0.0
80]
NO
TE: A
dd c
ompo
nent
resi
stan
ce to
duc
t res
ista
nce
to d
eter
min
e to
tal e
xter
nal s
tatic
pre
ssur
e.D
NA
= D
ata
not A
vaila
ble.
NO
TES:
1. M
ultip
ly c
orre
ctio
n fa
ctor
tim
es g
ross
per
form
ance
dat
a.2.
Res
ultin
g se
nsib
le c
apac
ity c
anno
t exc
eed
tota
l cap
acity
.
[]
Des
ign
ates
Met
ric
Co
nve
rsio
ns
34
AIR-FLOW PERFORMANCE – 12.5 TON RLNL B150/C150 MODELS
58
AIRFLOW PERFORMANCE—RKKB/RKMB- SERIES
AIR
FLO
W P
ER
FOR
MA
NC
E—
12.5
TO
N [4
4 kW
]
1181
3717
1200
4600
[217
1]—
—90
821
3192
722
4494
723
5796
624
7098
625
8410
0526
9710
2528
1010
4429
2410
6430
3710
8331
5011
0332
6311
2233
7711
4234
9011
6136
0347
00 [2
218]
903
2178
922
2291
941
2404
961
2517
980
2631
1000
2744
1019
2857
1039
2970
1058
3084
1078
3197
1097
3310
1117
3424
1136
3537
1156
3650
3830
1175
3763
4800
[226
5]91
723
4593
724
5895
625
7197
626
8499
527
9810
1429
1110
3430
2410
5331
3810
7332
5110
9233
6411
1234
7711
3135
9111
5137
0411
70
1239
3817
5100
[240
7]
1190
963
3930
2889
4900
[231
3]
982
932
3002
2519
1002
951
3116
2632
1021
971
3229
2745
1041
990
3342
2859
1060
1010
3456
2972
1079
1029
3085
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
W38
00 [1
793]
——
——
——
——
——
——
902
1649
922
1762
941
1875
961
1989
980
2102
1000
2215
1019
2328
1039
2442
1058
2555
4000
[188
8]—
——
——
——
——
—90
717
6192
618
7494
619
8796
521
0198
522
1410
0423
2710
2424
4010
4325
5410
6326
6710
8227
8041
00 [1
935]
——
——
——
——
900
1769
919
1882
939
1996
958
2109
978
2222
997
2335
1016
2449
1036
2562
1055
2675
1075
2788
1094
2902
4200
[198
2]—
——
——
——
—91
218
9793
220
1095
121
2397
122
3699
023
5010
1024
6310
2925
7610
4926
8910
6828
0310
8829
1611
0730
2943
00 [2
029]
——
——
——
906
1917
925
2030
945
2144
964
2257
984
2370
1003
2483
1023
2597
1042
2710
1062
2823
1081
2937
1101
3050
1120
3163
4400
[207
7]—
——
—90
019
4491
920
5793
921
7095
822
8497
823
9799
725
1010
1726
2410
3627
3710
5628
5010
7529
6310
9530
7711
1431
9011
3333
0345
00 [2
124]
——
——
913
2091
933
2204
952
2317
972
2430
991
2544
1011
2657
1030
2770
1050
2884
1069
2997
1089
3110
1108
3223
1128
3337
1147
3450
5000
[236
0]94
727
0096
728
1498
629
2710
0630
4010
2531
5310
4532
6710
6433
8010
8334
9311
0336
0711
2237
2011
4238
3311
6139
4611
8140
6012
0041
7312
2042
8610
4931
9910
6833
1210
8834
2511
0735
3811
2736
5211
4637
6511
6638
7811
8539
9112
0541
05
5200
[245
4]97
830
8699
831
9910
1733
1210
3734
2510
5635
3910
7636
5210
9537
6511
1538
7911
3439
9211
5441
0511
7342
1811
9343
3212
1244
4512
3245
5812
5146
7235
69
4056
1220
3943
1195
3877
1214
3990
1234
4103
1209
4044
1229
4157
1248
4270
1099
3682
1118
RPM
WR
PMW
RPM
W10
7826
6810
9727
8111
1728
9511
0228
9411
2130
0711
4031
2011
1430
1511
3331
2811
5332
4211
2731
4311
4632
5611
6633
6911
4032
7611
5933
9011
7935
0311
5334
1711
7235
3011
9236
4311
6735
6311
8836
7812
0637
90
1239
4399
1259
4513
1278
4626
1224
4218
1244
4331
1263
4445
1271
4785
1290
4898
1310
5011
Capa
city
12.5
Ton
[44
kW]
3795
1258
1138
3909
1157
4022
1177
4135
1196
4249
1216
4362
1235
4475
1255
4588
1274
4702
1294
4815
5300
[250
1]99
432
9010
1434
0310
3335
1610
5336
3010
7237
4310
9238
5611
1139
6911
3140
8311
5041
9611
7043
0911
8944
2312
0945
3612
2846
4912
4847
6212
6748
7612
8749
89—
——
—
Air
Flow
CFM
[L/s
]
4170
1253
4216
1273
4330
1266
4384
1287
4497
RPM
WR
PMW
1136
3008
1156
3121
1160
3233
1179
3347
1172
3355
1192
3468
1185
3482
1205
3596
1198
3616
1218
3729
1211
3756
1231
3870
1225
3903
1245
4016
1298
4739
1317
4853
1283
4558
1302
4671
——
——
1313
4928
——
——
——
0.1
[.02
]0.
2 [.
05]
0.3
[.07
]0.
4 [.
10]
0.5
[.12
]0.
6 [.
15]
0.7
[.17
]0.
8 [.
20]
0.9
[.22
]1.
0 [.
25]
1.1
[.27
]1.
2 [.
30]
1.3
[.32
]1.
4 [.
35]
1.5
[.37
]1.
6 [.
40]
1.7
[.42
]1.
8 [.
45]
1.9
[.47
]2.
0 [.
50]
Exte
rnal
Sta
tic P
ress
ure—
Inch
es o
f Wat
er [k
Pa]
5600
[264
3]10
4539
50
5400
[254
9]
1064
1011
4063
3502
1083
1030
4176
3615
1103
1050
4290
3728
1122
1069
4403
3842
1142
1089
4516
3955
1161
1108
4068
5500
[259
6]10
2837
2210
4738
3510
6639
4810
8640
6211
0541
7511
2542
8811
4444
0111
6445
1511
8346
2812
0347
4112
2248
5512
4249
68—
——
——
—11
2841
8111
4742
9511
6744
0811
8645
2112
0646
3512
2547
4812
4548
6112
6449
74—
—
5700
[269
0]10
6241
8610
8143
0011
0144
1311
2045
2611
4046
3911
5947
5311
7948
6611
9849
79—
——
——
——
——
——
——
—46
3011
8147
4312
00—
——
——
——
——
——
—
——
——
——
4856
1220
4969
——
——
——
——
——
——
——
——
5800
[273
7]10
7944
3110
9945
4411
1846
5811
3847
7111
5748
8411
7749
98—
——
——
——
——
——
——
——
——
——
——
——
—
——
——
——
——
——
——
——
——
——
——
Driv
e Pa
ckag
eL
MM
otor
H.P
. [W
]3.
0 [2
237.
1]5.
0 [3
728.
5]Bl
ower
She
ave
BK65
BK65
Mot
or S
heav
e1V
P-44
1VM
-50
Turn
s O
pen
12
34
56
12
34
56
RPM
1135
1087
1038
990
942
894
1283
1231
1178
1126
1074
1022
NO
TES:
1. F
acto
ry s
heav
e se
tting
s ar
e sh
own
in b
old
prin
t.2.
Re-
adju
stm
ent o
f she
ave
requ
ired
to a
chie
ve ra
ted
airf
low
at A
RI m
inim
um E
.S.P
.3.
Do
not o
pera
te a
bove
blo
wer
RPM
sho
wn
as m
otor
ove
rload
ing
will
occ
ur.
4.D
o no
t set
mot
or s
heav
e be
low
one
turn
ope
n.
NO
TE: L
-Driv
e le
ft of
bol
d lin
e, M
-Driv
e rig
ht o
f bol
d lin
e.
AIR
FLO
W C
OR
RE
CT
ION
FA
CT
OR
S12
.5 T
ON
[44
kW]
0.97
0.98
TOTA
L M
BH0.
95
0.99
0.96
0.94
4400
[207
7]0.
991.
00
1.00
0.99
1.00
4800
[226
5]
POW
ER k
W0.
980.
990.
980.
97
4600
[217
1]1.
01
1.00
1.03
5000
[236
0]
0.91
SEN
SIBL
E M
BH0.
850.
88
4200
[198
2]AC
TUAL
—CF
M[L
/s]
3800
[179
3]40
00[1
888]
1.01
1.05
1.02
5200
[245
4]
1.02
1.07
1.03
5400
[254
9]
1.02
1.09
1.04
5600
[264
3]
1.03
1.11
1.05
5800
[273
7]
CO
MP
ON
EN
T A
IR R
ES
ISTA
NC
E, I
WC
12.
5 T
ON
[44
kW]
Com
pone
nt
Stan
dard
Indo
or A
irflo
w—
CFM
[L/s
]
Conc
entr
ic D
iffus
er R
XRN
-AA6
1 or
AA71
& T
rans
ition
RXM
C-CE
050.
18[0
.045
]
3800
[179
3]40
00[1
888]
4200
[198
2]44
00[2
076]
4600
[217
1]48
00[2
265]
5000
[235
9]
0.21
[0.0
52]
0.24
[0.0
60]
0.27
[0.0
67]
DN
A
Res
ista
nce—
Inch
es W
ater
[kPa
]
DN
AD
NA
Hor
izon
tal E
cono
miz
er
100%
O.A
. Dam
per O
pen
0.15
[0.0
36]
0.16
[0.0
40]
0.18
[0.4
4]0.
19[0
.047
]0.
20[0
.050
]0.
21[0
.052
]
Wet
Coi
l0.
082
[0.0
20]
0.08
7[0
.022
]0.
093
[0.0
23]
0.09
9[0
.025
]0.
105
[0.0
26]
0.11
0[0
.027
]0.
115
[0.0
29]
0.21
[0.0
52]
Econ
omiz
er10
0% R
.A. D
ampe
r Ope
n0.
12[0
.030
]0.
13[0
.032
]0.
14[0
.035
]0.
15[0
.037
]0.
16[0
.040
]0.
17[0
.042
]0.
18[0
.045
]H
oriz
onta
l Eco
nom
izer
100%
R.A
. Dam
per O
pen
0.07
[0.0
17]
0.08
[0.0
20]
0.09
[0.0
21]
0.09
[0.0
22]
0.10
[0.0
24]
0.10
[0.0
25]
0.10
[0.0
24]
0.21
[0.0
52]
0.09
[0.0
22]
0.19
[0.0
47]
DN
A
0.12
0[0
.030
]
5200
[245
4]
0.22
[0.0
55]
0.10
[0.0
25]
0.20
[0.0
50]
DN
A
0.12
5[0
.031
]
5400
[254
8]
0.23
[0.0
57]
0.12
[0.0
30]
0.21
[0.0
52]
DN
A
0.13
1[0
.033
]
5600
[264
3]
0.24
[0.0
60]
0.14
[0.0
35]
0.22
[0.0
55]
DN
A
0.13
6[0
.034
]
5800
[273
7]
Conc
entr
ic D
iffus
er R
XRN
-AA6
6 or
AA76
& T
rans
ition
RXM
C-CF
06D
NA
DN
AD
NA
DN
A0.
31[0
.077
]0.
32[0
.080
]0.
34[0
.085
]0.
36[0
.090
]0.
39[0
.097
]D
NA
DN
A
NO
TE: A
dd c
ompo
nent
resi
stan
ce to
duc
t res
ista
nce
to d
eter
min
e to
tal e
xter
nal s
tatic
pre
ssur
e.D
NA
= D
ata
not A
vaila
ble.
NO
TES:
1. M
ultip
ly c
orre
ctio
n fa
ctor
tim
es g
ross
per
form
ance
dat
a.2.
Res
ultin
g se
nsib
le c
apac
ity c
anno
t exc
eed
tota
l cap
acity
.
[]
Des
ign
ates
Met
ric
Co
nve
rsio
ns
58
AIRFLOW PERFORMANCE—RKKB/RKMB- SERIESA
IRF
LOW
PE
RFO
RM
AN
CE
—12
.5 T
ON
[44
kW]
1181
3717
1200
4600
[217
1]—
—90
821
3192
722
4494
723
5796
624
7098
625
8410
0526
9710
2528
1010
4429
2410
6430
3710
8331
5011
0332
6311
2233
7711
4234
9011
6136
0347
00 [2
218]
903
2178
922
2291
941
2404
961
2517
980
2631
1000
2744
1019
2857
1039
2970
1058
3084
1078
3197
1097
3310
1117
3424
1136
3537
1156
3650
3830
1175
3763
4800
[226
5]91
723
4593
724
5895
625
7197
626
8499
527
9810
1429
1110
3430
2410
5331
3810
7332
5110
9233
6411
1234
7711
3135
9111
5137
0411
70
1239
3817
5100
[240
7]
1190
963
3930
2889
4900
[231
3]
982
932
3002
2519
1002
951
3116
2632
1021
971
3229
2745
1041
990
3342
2859
1060
1010
3456
2972
1079
1029
3085
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
WR
PMW
RPM
W38
00 [1
793]
——
——
——
——
——
——
902
1649
922
1762
941
1875
961
1989
980
2102
1000
2215
1019
2328
1039
2442
1058
2555
4000
[188
8]—
——
——
——
——
—90
717
6192
618
7494
619
8796
521
0198
522
1410
0423
2710
2424
4010
4325
5410
6326
6710
8227
8041
00 [1
935]
——
——
——
——
900
1769
919
1882
939
1996
958
2109
978
2222
997
2335
1016
2449
1036
2562
1055
2675
1075
2788
1094
2902
4200
[198
2]—
——
——
——
—91
218
9793
220
1095
121
2397
122
3699
023
5010
1024
6310
2925
7610
4926
8910
6828
0310
8829
1611
0730
2943
00 [2
029]
——
——
——
906
1917
925
2030
945
2144
964
2257
984
2370
1003
2483
1023
2597
1042
2710
1062
2823
1081
2937
1101
3050
1120
3163
4400
[207
7]—
——
—90
019
4491
920
5793
921
7095
822
8497
823
9799
725
1010
1726
2410
3627
3710
5628
5010
7529
6310
9530
7711
1431
9011
3333
0345
00 [2
124]
——
——
913
2091
933
2204
952
2317
972
2430
991
2544
1011
2657
1030
2770
1050
2884
1069
2997
1089
3110
1108
3223
1128
3337
1147
3450
5000
[236
0]94
727
0096
728
1498
629
2710
0630
4010
2531
5310
4532
6710
6433
8010
8334
9311
0336
0711
2237
2011
4238
3311
6139
4611
8140
6012
0041
7312
2042
8610
4931
9910
6833
1210
8834
2511
0735
3811
2736
5211
4637
6511
6638
7811
8539
9112
0541
05
5200
[245
4]97
830
8699
831
9910
1733
1210
3734
2510
5635
3910
7636
5210
9537
6511
1538
7911
3439
9211
5441
0511
7342
1811
9343
3212
1244
4512
3245
5812
5146
7235
69
4056
1220
3943
1195
3877
1214
3990
1234
4103
1209
4044
1229
4157
1248
4270
1099
3682
1118
RPM
WR
PMW
RPM
W10
7826
6810
9727
8111
1728
9511
0228
9411
2130
0711
4031
2011
1430
1511
3331
2811
5332
4211
2731
4311
4632
5611
6633
6911
4032
7611
5933
9011
7935
0311
5334
1711
7235
3011
9236
4311
6735
6311
8836
7812
0637
90
1239
4399
1259
4513
1278
4626
1224
4218
1244
4331
1263
4445
1271
4785
1290
4898
1310
5011
Capa
city
12.5
Ton
[44
kW]
3795
1258
1138
3909
1157
4022
1177
4135
1196
4249
1216
4362
1235
4475
1255
4588
1274
4702
1294
4815
5300
[250
1]99
432
9010
1434
0310
3335
1610
5336
3010
7237
4310
9238
5611
1139
6911
3140
8311
5041
9611
7043
0911
8944
2312
0945
3612
2846
4912
4847
6212
6748
7612
8749
89—
——
—
Air
Flow
CFM
[L/s
]
4170
1253
4216
1273
4330
1266
4384
1287
4497
RPM
WR
PMW
1136
3008
1156
3121
1160
3233
1179
3347
1172
3355
1192
3468
1185
3482
1205
3596
1198
3616
1218
3729
1211
3756
1231
3870
1225
3903
1245
4016
1298
4739
1317
4853
1283
4558
1302
4671
——
——
1313
4928
——
——
——
0.1
[.02
]0.
2 [.
05]
0.3
[.07
]0.
4 [.
10]
0.5
[.12
]0.
6 [.
15]
0.7
[.17
]0.
8 [.
20]
0.9
[.22
]1.
0 [.
25]
1.1
[.27
]1.
2 [.
30]
1.3
[.32
]1.
4 [.
35]
1.5
[.37
]1.
6 [.
40]
1.7
[.42
]1.
8 [.
45]
1.9
[.47
]2.
0 [.
50]
Exte
rnal
Sta
tic P
ress
ure—
Inch
es o
f Wat
er [k
Pa]
5600
[264
3]10
4539
50
5400
[254
9]
1064
1011
4063
3502
1083
1030
4176
3615
1103
1050
4290
3728
1122
1069
4403
3842
1142
1089
4516
3955
1161
1108
4068
5500
[259
6]10
2837
2210
4738
3510
6639
4810
8640
6211
0541
7511
2542
8811
4444
0111
6445
1511
8346
2812
0347
4112
2248
5512
4249
68—
——
——
—11
2841
8111
4742
9511
6744
0811
8645
2112
0646
3512
2547
4812
4548
6112
6449
74—
—
5700
[269
0]10
6241
8610
8143
0011
0144
1311
2045
2611
4046
3911
5947
5311
7948
6611
9849
79—
——
——
——
——
——
——
—46
3011
8147
4312
00—
——
——
——
——
——
—
——
——
——
4856
1220
4969
——
——
——
——
——
——
——
——
5800
[273
7]10
7944
3110
9945
4411
1846
5811
3847
7111
5748
8411
7749
98—
——
——
——
——
——
——
——
——
——
——
——
—
——
——
——
——
——
——
——
——
——
——
Driv
e Pa
ckag
eL
MM
otor
H.P
. [W
]3.
0 [2
237.
1]5.
0 [3
728.
5]Bl
ower
She
ave
BK65
BK65
Mot
or S
heav
e1V
P-44
1VM
-50
Turn
s O
pen
12
34
56
12
34
56
RPM
1135
1087
1038
990
942
894
1283
1231
1178
1126
1074
1022
NO
TES:
1. F
acto
ry s
heav
e se
tting
s ar
e sh
own
in b
old
prin
t.2.
Re-
adju
stm
ent o
f she
ave
requ
ired
to a
chie
ve ra
ted
airf
low
at A
RI m
inim
um E
.S.P
.3.
Do
not o
pera
te a
bove
blo
wer
RPM
sho
wn
as m
otor
ove
rload
ing
will
occ
ur.
4.D
o no
t set
mot
or s
heav
e be
low
one
turn
ope
n.
NO
TE: L
-Driv
e le
ft of
bol
d lin
e, M
-Driv
e rig
ht o
f bol
d lin
e.
AIR
FLO
W C
OR
RE
CT
ION
FA
CT
OR
S12
.5 T
ON
[44
kW]
CO
MP
ON
EN
T A
IR R
ES
ISTA
NC
E, I
WC
12.
5 T
ON
[44
kW]
Com
pone
nt
Stan
dard
Indo
or A
irflo
w—
CFM
[L/s
]
Conc
entr
ic D
iffus
er R
XRN
-AA6
1 or
AA71
& T
rans
ition
RXM
C-CE
050.
18[0
.045
]
3800
[179
3]40
00[1
888]
4200
[198
2]44
00[2
076]
4600
[217
1]48
00[2
265]
5000
[235
9]
0.21
[0.0
52]
0.24
[0.0
60]
0.27
[0.0
67]
DN
A
Res
ista
nce—
Inch
es W
ater
[kPa
]
DN
AD
NA
Hor
izon
tal E
cono
miz
er
100%
O.A
. Dam
per O
pen
0.15
[0.0
36]
0.16
[0.0
40]
0.18
[0.4
4]0.
19[0
.047
]0.
20[0
.050
]0.
21[0
.052
]
Wet
Coi
l0.
082
[0.0
20]
0.08
7[0
.022
]0.
093
[0.0
23]
0.09
9[0
.025
]0.
105
[0.0
26]
0.11
0[0
.027
]0.
115
[0.0
29]
0.21
[0.0
52]
Econ
omiz
er10
0% R
.A. D
ampe
r Ope
n0.
12[0
.030
]0.
13[0
.032
]0.
14[0
.035
]0.
15[0
.037
]0.
16[0
.040
]0.
17[0
.042
]0.
18[0
.045
]H
oriz
onta
l Eco
nom
izer
100%
R.A
. Dam
per O
pen
0.07
[0.0
17]
0.08
[0.0
20]
0.09
[0.0
21]
0.09
[0.0
22]
0.10
[0.0
24]
0.10
[0.0
25]
0.10
[0.0
24]
0.21
[0.0
52]
0.09
[0.0
22]
0.19
[0.0
47]
DN
A
0.12
0[0
.030
]
5200
[245
4]
0.22
[0.0
55]
0.10
[0.0
25]
0.20
[0.0
50]
DN
A
0.12
5[0
.031
]
5400
[254
8]
0.23
[0.0
57]
0.12
[0.0
30]
0.21
[0.0
52]
DN
A
0.13
1[0
.033
]
5600
[264
3]
0.24
[0.0
60]
0.14
[0.0
35]
0.22
[0.0
55]
DN
A
0.13
6[0
.034
]
5800
[273
7]
Conc
entr
ic D
iffus
er R
XRN
-AA6
6 or
AA76
& T
rans
ition
RXM
C-CF
06D
NA
DN
AD
NA
DN
A0.
31[0
.077
]0.
32[0
.080
]0.
34[0
.085
]0.
36[0
.090
]0.
39[0
.097
]D
NA
DN
A
NO
TE: A
dd c
ompo
nent
resi
stan
ce to
duc
t res
ista
nce
to d
eter
min
e to
tal e
xter
nal s
tatic
pre
ssur
e.D
NA
= D
ata
not A
vaila
ble.
NO
TES:
1. M
ultip
ly c
orre
ctio
n fa
ctor
tim
es g
ross
per
form
ance
dat
a.2.
Res
ultin
g se
nsib
le c
apac
ity c
anno
t exc
eed
tota
l cap
acity
.
[]
Des
ign
ates
Met
ric
Co
nve
rsio
ns
3800 [1793]
3900 [1840]
4000 [1888]
4100 [1935]
4200 [1982]
4300 [2029]
4400 [2076]
4500 [2123]
4600 [2171]
4700 [2218]
4800 [2265]
4900 [2312]
5000 [2359]
5100 [2407]
5200 [2454]
5300 [2501]
5400 [2548]
5500 [2595]
5600 [2643]
5700 [2690]
5800 [2737]
Air Flow
CFM [L/s]
Model RKNL-B150 & RKNL-C150
Voltage 208/230, 460, 575 — 3 phase
External Static Pressure — Inches of Water [kPa]
0.1 [.02]
RPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
WRPM
W0.2 [.05]
0.3 [.07]
0.4 [.10]
0.5 [.12]
0.6 [.15]
0.7 [.17]
0.8 [.20]
0.9 [.22]
1.0 [.25]
1.1 [.27]
1.2 [.30]
1.3 [.32]
1.4 [.35]
1.5 [.37]
1.6 [.40]
1.7 [.42]
1.8 [.45]
1.9 [.47]
2.0 [.50]
——
——
——
——
——
8341660861174388818269141909
9391992
——
——
——
——
8201647
8471734874182190019089261995
9512082
——
——
——
——
8331726
8601817887190891319999382090
9632181
——
——
——
82017178471812
8731907900200292520979512192
9762287
——
——
——
83418088601907
8872006913210693822059632304
9882403
——
——
8211805
84819088742011
900211492622179512320976242310012527
——
——
8351909
86220168882123
914223093923379642445989255210132659
——
82319108502021
87621339022244
9282355953246697825771002268810262800
812191283820278652142
89122589172373
9422488967260399127181015283410392949
827203485421538802272
90623919312510
95626309812749100528681029298710523106
842216386922878952410
92025339462656
97027809952903101930261043314910663273
858230288424299102556
93526849602811
985293810093065103331931056332010703153
874244990025809262711
951284397529741000310510243236104733681070349910823316
890260491627399412875
966301099031451015328110383416106235511074335710953486
906276893229079573046
9823186100633251030346510533604107637431087353211073664
923294094830839733227
9973370102135141045365710683800107935791100371311203848
93931219643268989341610133563103737101060385810723629109237661113390211334039
956331098134611005361310293764105339161076406710853820110639591126409811464237
973350899836631022381910453974106841301079387710994018112041591140430111604442
9903714101438731038403310624192107239361093408011134223113443671153451011734654
10073928103140921055425510784419108741441107429011284435114845811167472711874873
965207599021581014224110382324106224071082241611042516112526161146271711672817
9762169100122561025234310492430107325171091251611122619113427221155282411762927
9882272101323631037245410602545107925191100262411222729114328341164293911843044
10002382102424771048257210722668108926311110273911312846115229531173306011933167
10122502103626011060270010772641109827511120286011402969116130791182318812023298
10252630104827331072283610872765110828771129298911503100117132121191332412113435
10372766106128731077278210982896111930101139312411603238118033521201346612213580
10502911107330221087291711083034112931501150326611703382119034991210361512303731
10633064107729411098306011193178114032971160341511803534120036531220377112403890
10763226108930881109320911303330115134511171357211913692121138131230393412504055
10793119110032431121336611413489116236121182373512023858122139811241410412604227
10913278111234031132352911533654117337791193390512124030123241551251428112704406
11033444112435711144369911643827118439541204408212234209124343371262446512814592
111536161136374611563876117640061196413612154266123543961254452512734655
——
112837961148392811684060118841921207432412274457124645891265472112844853
——
1140398211604117118042511200438512194520123946541258478912764923
——
——
11534176117343121193444912124586123247221251485912694996
——
——
——
1166437611864515120546541225479312444932
——
——
——
——
——
11794583119947241218486612375007
——
——
——
——
——
——
1193479712124941
——
——
——
——
——
——
——
——
12065018
——
——
——
——
——
——
——
——
——
NOTE: L-Drive left of bold line, M-Drive right of bold line.
NOTES:1.Factory sheave settings are shown in bold type.
2.Do not set motor sheave below minimum
turns open shown.
3.Re-adjustment of sheave required to achieve rated airflow at ARI m
inimum
E.S.P.
4.Drive data shown is for horizontal airflow with dry coil. add component resistance to
duct resistance to determine total E.S.P.
Drive Package
Motor H.P. [W]
Blower Sheave
Motor sheave
Turns Open
RPM
L (B-51)
M (B-58
5.0 [3728.5]
BK85H
1VP-65
3.0 [2237.1]
BK72H
1VP-44
12
34
56
1058
1022
978
932
861
813
12
34
56
1278
1245
1206
1167
1138
1097
UNIT MODELNUMBERRLNL-
35
XIX. HEATER KIT CHARACTERISTICSTABLE AAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
208/240V – 3 PHASE
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 208/240 V/3 PHASE
HEATER KIT FLA UNIT MIN. CKT.AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B072CL/ NONE — — 37/37 50/50C072CL CC10C 7.2/9.6 20.0/23.1 37/37 50/50
CC15C 10.8/14.4 30.0/34.6 45/51 50/60CC20C 14.4/19.2 40.0/46.2 57/65 60/70CC30C 21.6/28.8 60.0/69.3 82/94 90/100
B072CM/ NONE — — 37/37 50/50C072CM CC10C 7.2/9.6 20.0/23.1 37/37 50/50
CC15C 10.8/14.4 30.0/34.6 45/51 50/60CC20C 14.4/19.2 40.0/46.2 57/65 60/70CC30C 21.6/28.8 60.0/69.3 82/94 90/100
B085CL/ NONE — — 42/42 60/60C085CL CC10C 7.2/9.6 20.0/23.1 42/42 60/60
CC15C 10.8/14.4 30.0/34.6 48/54 60/60CC20C 14.4/19.2 40.0/46.2 60/68 60/70CC30C 21.6/28.8 60.0/69.3 85/97 90/100CC40C 28.8/38.4 80.1/92.4 111/126 125/150
B085CM/ NONE — — 42/42 60/60C085CM CC10C 7.2/9.6 20.0/23.1 42/42 60/60
CC15C 10.8/14.4 30.0/34.6 48/54 60/60CC20C 14.4/19.2 40.0/46.2 60/68 60/70CC30C 21.6/28.8 60.0/69.3 85/97 90/100CC40C 28.8/38.4 80.1/92.4 111/126 125/150
B085CN/ NONE — — 47/47 70/70C085CN CC10C 7.2/9.6 20.0/23.1 47/47 70/70
CC15C 10.8/14.4 30.0/34.6 54/60 70/70CC20C 14.4/19.2 40.0/46.2 67/74 70/80CC30C 21.6/28.8 60.0/69.3 92/103 100/110CC40C 28.8/38.4 80.1/92.4 117/132 125/150
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 208/240 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
36
HEATER KIT CHARACTERISTICSTABLE BAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
208/240V – 3 PHASE
B090CL/ NONE — — 43/43 50/50C090CL CC10C 7.2/9.6 20.0/23.1 43/43 50/50
CC15C 10.8/14.4 30.0/34.6 48/54 50/60CC20C 14.4/19.2 40.0/46.2 60/68 60/70CC30C 21.6/28.8 60.0/69.3 85/97 90/100CC40C 28.8/38.4 80.1/92.4 111/126 125/150
B090CM/ NONE — — 43/43 50/50C090CM CC10C 7.2/9.6 20.0/23.1 43/43 50/50
CC15C 10.8/14.4 30.0/34.6 48/54 50/60CC20C 14.4/19.2 40.0/46.2 60/68 60/70CC30C 21.6/28.8 60.0/69.3 85/97 90/100CC40C 28.8/38.4 80.1/92.4 111/126 125/150
B090CN/ NONE — — 48/48 60/60C090CN CC10C 7.2/9.6 20.0/23.1 48/48 60/60
CC15C 10.8/14.4 30.0/34.6 54/60 60/60CC20C 14.4/19.2 40.0/46.2 67/74 70/80CC30C 21.6/28.8 60.0/69.3 92/103 100/110CC40C 28.8/38.4 80.1/92.4 117/132 125/150
B102CL/ NONE — — 49/49 60/60C102CL CC10C 7.2/9.6 20.0/23.1 49/49 60/60
CC15C 10.8/14.4 30.0/34.6 49/54 60/60CC20C 14.4/19.2 40.0/46.2 60/68 60/70CC30C 21.6/28.8 60.0/69.3 85/97 90/100CC40C 28.8/38.4 80.1/92.4 111/126 125/150
B102CM/ NONE — — 54/54 60/60C102CM CC10C 7.2/9.6 20.0/23.1 54/54 60/60
CC15C 10.8/14.4 30.0/34.6 54/60 60/60CC20C 14.4/19.2 40.0/46.2 67/74 70/80CC30C 21.6/28.8 60.0/69.3 92/103 100/110CC40C 28.8/38.4 80.1/92.4 117/132 125/150
37
HEATER KIT CHARACTERISTICS (continued)TABLE CAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
208/240V – 3 PHASE
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 208/240 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B120CL/ NONE — — 49/49 60/60C120CL CC10C 7.2/9.6 20.0/23.1 49/49 60/60
CC15C 10.8/14.4 30.0/34.6 49/54 60/60CC20C 14.4/19.2 40.0/46.2 60/68 60/70CC30C 21.6/28.8 60.0/69.3 85/97 90/100CC40C 28.8/38.4 80.1/92.4 111/126 125/150CC50C 36.1/48.0 100.1/115.5 136/155 150/175
B120CM/ NONE — — 54/54 60/60C120CM CC10C 7.2/9.6 20.0/23.1 54/54 60/60
CC15C 10.8/14.4 30.0/34.6 54/60 60/60CC20C 14.4/19.2 40.0/46.2 67/74 70/80CC30C 21.6/28.8 60.0/69.3 92/103 100/110CC40C 28.8/38.4 80.1/92.4 117/132 125/150CC50C 36.1/48.0 100.1/115.5 142/161 150/175
B150CL/ NONE — — 67/67 80/80C150CL CC10C 7.2/9.6 20.0/23.1 67/67 80/80
CC15C 10.8/14.4 30.0/34.6 67/67 80/80CC20C 14.4/19.2 40.0/46.2 69/77 80/80CC30C 21.6/28.8 60.0/69.3 94/106 100/110CC40C 28.8/38.4 80.1/92.4 119/135 125/150CC50C 36.1/48.0 100.1/115.5 144/164 150/175
B150CM/ NONE — — 71/71 90/90C150CM CC10C 7.2/9.6 20.0/23.1 71/71 90/90
CC15C 10.8/14.4 30.0/34.6 71/71 90/90CC20C 14.4/19.2 40.0/46.2 74/82 90/90CC30C 21.6/28.8 60.0/69.3 99/111 100/125CC40C 28.8/38.4 80.1/92.4 124/139 125/150CC50C 36.1/48.0 100.1/115.5 149/168 150/175
38
HEATER KIT CHARACTERISTICS (continued)TABLE DAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
480V – 3 PHASE
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 480 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B072DL/ NONE — — 18 25C072DL CC10D 9.6 11.5 18 25
CC15D 14.4 17.3 26 30CC20D 19.2 23.1 33 35CC30D 28.8 34.6 47 50
B072DM/ NONE — — 18 25C072DM CC10D 9.6 11.5 18 25
CC15D 14.4 17.3 26 30CC20D 19.2 23.1 33 35CC30D 28.8 34.6 47 50
B085DL/ NONE — — 21 30C085DL CC10D 9.6 11.5 21 30
CC15D 14.4 17.3 27 30CC20D 19.2 23.1 34 35CC30D 28.8 34.6 49 50CC40D 38.4 46.2 63 70
B085DM/ NONE — — 21 30C085DM CC10D 9.6 11.5 21 30
CC15D 14.4 17.3 27 30CC20D 19.2 23.1 34 35CC30D 28.8 34.6 49 50CC40D 38.4 46.2 63 70
B085DN/ NONE — — 24 35C085DN CC10D 9.6 11.5 24 35
CC15D 14.4 17.3 34 35CC20D 19.2 23.1 45 45CC30D 28.8 34.6 57 60CC40D 38.4 46.2 68 70
39
HEATER KIT CHARACTERISTICS (continued)TABLE EAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
480V – 3 PHASE
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 480 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B090DL/ NONE — — 21 25C090DL CC10D 9.6 11.5 21 25
CC15D 14.4 17.3 27 30CC20D 19.2 23.1 34 35CC30D 28.8 34.6 49 50CC40D 38.4 46.2 63 70
B090DM/ NONE — — 21 25C090DM CC10D 9.6 11.5 21 25
CC15D 14.4 17.3 27 30CC20D 19.2 23.1 34 35CC30D 28.8 34.6 49 50CC40D 38.4 46.2 63 70
B090DN/ NONE — — 24 30C090DN CC10D 9.6 11.5 24 30
CC15D 14.4 17.3 31 35CC20D 19.2 23.1 38 40CC30D 28.8 34.6 52 60CC40D 38.4 46.2 67 70
B102DL/ NONE — — 23 25C102DL CC10D 9.6 11.5 23 25
CC15D 14.4 17.3 27 30CC20D 19.2 23.1 34 35CC30D 28.8 34.6 49 50CC40D 38.4 46.2 63 70
B102DM/ NONE — — 26 30C102DM CC10C 9.6 11.5 26 30
CC15D 14.4 17.3 31 35CC20D 19.2 23.1 38 40CC30D 28.8 34.6 52 60CC40D 38.4 46.2 67 70
40
HEATER KIT CHARACTERISTICS (continued)TABLE FAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
480V – 3 PHASE
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 480 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B120DL/ NONE — — 25 30C120DL CC10D 9.6 11.5 25 30
CC15D 14.4 17.3 27 30CC20D 19.2 23.1 34 35CC30D 28.8 34.6 49 50CC40D 38.4 46.2 63 70CC50D 48.0 57.7 78 80
B120DM/ NONE — — 28 35C120DM CC10D 9.6 11.5 28 35
CC15D 14.4 17.3 31 35CC20D 19.2 23.1 38 40CC30D 28.8 34.6 52 60CC40D 38.4 46.2 67 70CC50D 48.0 57.7 81 90
B150DL/ NONE — — 33 40C150DL CC10D 9.6 11.5 33 40
CC15D 14.4 17.3 33 40CC20D 19.2 23.1 38 40CC30D 28.8 34.6 52 60CC40D 38.4 46.2 67 70CC50D 48.0 57.7 81 90
B150DM/ NONE — — 36 45C150DM CC10D 9.6 11.5 36 45
CC15D 14.4 17.3 36 45CC20D 19.2 23.1 42 45CC30D 28.8 34.6 56 60CC40D 38.4 46.2 71 80CC50D 48.0 57.7 85 90
41
HEATER KIT CHARACTERISTICS (continued)TABLE GAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
600V – 3 PHASE
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 600 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B072YL/ NONE — — 14 20C072YL CC10Y 9.6 9.2 14 20
CC15Y 14.4 13.9 20 20CC20Y 19.2 18.5 26 30CC30Y 28.8 27.7 37 40
B072YM/ NONE — — 14 20C072YM CC10Y 9.6 9.2 14 20
CC15Y 14.4 13.9 20 20CC20Y 19.2 18.5 26 30CC30Y 28.8 27.7 37 40
B085YL/ NONE — — 16 20C085YL CC10Y 9.6 9.2 17 20
CC15Y 14.4 13.9 23 25CC20Y 19.2 18.5 29 30CC30Y 28.8 27.7 40 40CC40Y 38.4 37.0 52 60
B085YM/ NONE — — 16 20C085YM CC10Y 9.6 9.2 17 20
CC15Y 14.4 13.9 23 25CC20Y 19.2 18.5 29 30CC30Y 28.8 27.7 40 40CC40Y 38.4 37.0 52 60
B085YN/ NONE — — 20 25C085YN CC10Y 9.6 9.2 22 25
CC15Y 14.4 13.9 28 30CC20Y 19.2 18.5 34 35CC30Y 28.8 27.7 45 45CC40Y 38.4 37.0 57 60
UNIT MODELNUMBERRLNL-
42
HEATER KIT CHARACTERISTICS (continued)TABLE HAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
600V – 3 PHASE
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 600 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B090YL/ NONE — — 16 20C090YL CC10Y 9.6 9.2 17 20
CC15Y 14.4 13.9 23 25CC20Y 19.2 18.5 29 30CC30Y 28.8 27.7 40 40CC40Y 38.4 37.0 52 60
B090YM/ NONE — — 16 20C090YM CC10Y 9.6 9.2 17 20
CC15Y 14.4 13.9 23 25CC20Y 19.2 18.5 29 30CC30Y 28.8 27.7 40 40CC40Y 38.4 37.0 52 60
B090YN/ NONE — — 21 25C090YN CC10Y 9.6 9.2 22 25
CC15Y 14.4 13.9 28 30CC20Y 19.2 18.5 34 35CC30Y 28.8 27.7 45 45CC40Y 38.4 37.0 57 60
B102YL/ NONE — — 19 20C102YL CC10Y 9.6 9.2 19 20
CC15Y 14.4 13.9 23 25CC20Y 19.2 18.5 29 30CC30Y 28.8 27.7 40 40CC40Y 38.4 37.0 52 60
B102YM/ NONE — — 24 30C102YM CC10Y 9.6 9.2 24 25
CC15Y 14.4 13.9 28 30CC20Y 19.2 18.5 34 35CC30Y 28.8 27.7 45 45CC40Y 38.4 37.0 57 60
43
HEATER KIT CHARACTERISTICS (continued)TABLE IAUXILIARY HEATER KITS CHARACTERISTICS AND APPLICATION (RLNL MODELS)
600V – 3 PHASE
UNIT MODELNUMBERRLNL-
HEATER KITMODEL NO.
RXJJ-
HEATER kW@ 600 V HEATER KIT FLA UNIT MIN. CKT.
AMPACITY
MAX. FUSE ORCKT. BKR. SIZE(CKT. BKR. MUSTBE HACR TYPEFOR USA)
B120YL/ NONE — — 19 20C120YL CC10Y 9.6 9.2 19 20
CC15Y 14.4 13.9 23 25CC20Y 19.2 18.5 29 30CC30Y 28.8 27.7 40 40CC40Y 38.4 37.0 52 60CC50Y 48.0 46.2 63 70
B120YM/ NONE — — 24 30C120YM CC10Y 9.6 9.2 24 30
CC15Y 14.4 13.9 28 30CC20Y 19.2 18.5 34 35CC30Y 28.8 27.7 45 45CC40Y 38.4 37.0 57 60CC50Y 48.0 46.2 68 70
B150YL/ NONE — — 28 35C150YL CC10Y 9.6 9.2 28 35
CC15Y 14.4 13.9 28 35CC20Y 19.2 18.5 34 35CC30Y 28.8 27.7 45 45CC40Y 38.4 37.0 57 60CC50Y 48.0 46.2 68 70
B150YM/ NONE — — 28 35C150YM CC10Y 9.6 9.2 28 35
CC15Y 14.4 13.9 28 35CC20Y 19.2 18.5 34 35CC30Y 28.8 27.7 45 45CC40Y 38.4 37.0 57 60CC50Y 48.0 46.2 68 70
44
WARNING!
XX. TROUBLE SHOOTING CHART
DISCONNECT ALL POWER TO UNIT BEFORE SERVICING. CONTACTOR MAY BREAK ONLY ONE SIDE. FAILURETO SHUT OFF POWER CAN CAUSE ELECTRICAL SHOCK RESULTING IN PERSONAL INJURY OR DEATH.
SYMPTOM POSSIBLE CAUSE REMEDYUnit will not run • Power off or loose electrical connection • Check for correct voltage at compressor contactor in control
box• Thermostat out of calibration-set too high • Reset• Defective contactor • Check for 24 volts at contactor coil - replace if contacts are
open• Blown fuses • Replace fuses• Transformer defective • Check wiring-replace transformer• High pressure control open (if provided) • Reset-also see high head pressure remedy-• Interconnecting low voltage wiring damaged • Replace thermostat wiring
Condenser fan runs, compressor • Run capacitor defective (single phase only) • Replacedoesn’t • Loose connection • Check for correct voltage at compressor -
check & tighten all connections• Compressor stuck, grounded or open motor winding • Wait at least 2 hours for overload to reset.open internal overload. If still open, replace the compressor.
• Low voltage condition At compressor terminals, voltage must be within 10% of ratingplate volts when unit is operating.
Insufficient cooling • Improperly sized unit • Recalculate load• Improper airflow • Check - should be approximately 400 CFM [188.78 L/s] per ton.• Incorrect refrigerant charge • Charge per procedure attached to unit service panel.• Air, non-condensibles or moisture in system • Recover refrigerant, evacuate & recharge, add filter drier• Incorrect voltage • At compressor terminals, voltage must be within 10% of rating
plate volts when unit is operating.
Compressor short cycles • Incorrect voltage • At compressor terminals, voltage must be ± 10% ofnameplate marking when unit is operating.
• Defective overload protector • Replace - check for correct voltage• Refrigerant undercharge • Add refrigerant
Registers sweat • Low evaporator airflow • Increase speed of blower or reduce restriction - replace airfilter
High head-low vapor pressures • Restriction in liquid line, expansion device or filter drier • Remove or replace defective component• Flow check piston size too small • Change to correct size piston• Incorrect capillary tubes • Change coil assembly• TXV does not open • Replace TXV
High head-high or normal vapor • Dirty condenser coil • Clean coilpressure - Cooling mode • Refrigerant overcharge • Correct system charge
• Condenser fan not running • Repair or replace• Air or non-condensibles in system • Recover refrigerant, evacuate & recharge
High head-high or normal vapor • Low air flow - condenser coil • Check filters - correct to speedpressure - Heating mode • Refrigerant overcharge • Correct system charge
• Air or non-condensibles in system • Recover refrigerant, evacuate & recharge• Dirty condenser coil • Check filter - clean coil
Low head-high vapor pressures • Defective Compressor valves • Replace compressor
Low vapor - cool compressor - • Low evaporator airflow • Increase speed of blower or reduce restriction - replace airiced evaporator coil filter
• Operating below 65°F outdoors • Add Low Ambient Kit• Moisture in system • Recover refrigerant - evacuate & recharge - add filter drier• TXV limiting refrigerant flow • Replace TXV
High vapor pressure • Excessive load • Recheck load calculation• Defective compressor • Replace
Fluctuating head & vapor • TXV hunting • Check TXV bulb clamp - check air distribution on coil - replacepressures TXV
• Air or non-condensibles in system • Recover refrigerant, evacuate & recharge
Gurgle or pulsing noise at • Air or non-condensibles in system • Recover refrigerant, evacuate & rechargeexpansion device or liquid line
45
XXI. WIRING DIAGRAMS
46
47
48
49
50
51
52
53
RLNL SYSTEM CHARGE CHARTSFIGURE 16
55
65
75
85
95
105
115
175
200
225
250
275
300
325
350
375
400
425
450
475
500
525
100 105 110 115 120 125 130 135 140 145 150 155 160 165
92-102259-06-01
SYSTEM CHARGE CHART - REFRIGERANT 410A6 TON, CIRCUIT 1
XXII. CHARGING CHARTS
54
RLNL SYSTEM CHARGE CHARTSFIGURE 17
55
65
75
85
95
105
115
175
200
225
250
275
300
325
350
375
400
425
450
475
500
525
100 105 110 115 120 125 130 135 140 145 150 155 160 165
92-102259-07-01
SYSTEM CHARGE CHART - REFRIGERANT 410A7 TON, CIRCUIT 1
55
RLNL SYSTEM CHARGE CHARTSFIGURE 18
56
RLNL SYSTEM CHARGE CHARTSFIGURE 19
57
RLNL SYSTEM CHARGE CHARTSFIGURE 20
FIGURE 21
RLNL SYSTEM CHARGE CHARTS
58
59
60 CM 1209