AFSL Consumer and Display Fireworks Seminar
Kingsport, TNSeptember 8, 2015
1
AGENDA FOR MEETING
I. Introduction – John Rogers, Executive Director
II. Update on CPSC – Quin Dodd, AFSL General Counsel
III. Consumer Fireworks Mid-Year Program Summary
– John Rogers, Exec. Director
IV. Introduction of New Test Lab – Chuck Rogers, BV
V. Domestic Audit Program– Jerry Wingard, Auditor
VI. Election of Directors
BREAK
VII. New Standards/Program Changes – John Rogers
VIII. Charging for Failed Lots – John Rogers
IX. Update of Display Fireworks Program – John Rogers
X. Questions/Answers2
I. Introduction
- John Rogers, Executive Director
3
II. Update on CPSC
- Quin D. Dodd
4
III. Consumer Fireworks Mid-year Program Summary
- John Rogers, Executive Director
5
6
CASES TESTED BY YEAR 1994-2014
Quality Improvement Program
0.90
1.682.00
1.702.01
2.23
2.772.97
3.51
4.835.12
6.22
7.11
5.895.72
5.49
6.27
7.45
6.175.92
7.87
0
1,000,000
2,000,000
3,000,000
4,000,000
5,000,000
6,000,000
7,000,000
8,000,000
9,000,000
1994
1995
1996
1997
1998
1999
2000
2001
2002
2003
2004
2005
2006
2007
2008
2009
2010
2011
2012
2013
2014
CASES TESTED BY YEAR
JANUARY – JUNE 2010-2015
3.16
4.21
3.753.43
4.334.60
0
500,000
1,000,000
1,500,000
2,000,000
2,500,000
3,000,000
3,500,000
4,000,000
4,500,000
5,000,000
Jan.-Jun.
2010
Jan.-Jun.
2011
Jan.-Jun.
2012
Jan.-Jun.
2013
Jan.-Jun.
2014
Jan.-Jun.
2015
QIP COMPLIANCE PERCENTAGE BY YEAR
2010 - 2015
94% 94% 92% 91% 93% 95%
6% 6% 8% 9% 7% 5%
2010 2011 2012 2013 2014 2015 (half)
Compliance Non-Compliance
2
REGULAR, ASSORTMENT, AND COMPONENT
JANUARY TO JUNE 2015
83.3%
14.6%
2.0%
Cases tested for Regular Program: 3.82 million cases (including
54,000 cases in Thailand).Cases tested for Assortment Program: 673,000 cases.
Cases tested for Component Program: 94,000Total Cases: 4,595,359.
Regular Assortment Component
7
PERCENTAGE TESTING BY PRODUCT CATEGORY
JANUARY TO JUNE 2015
0.0%0.1% 0.1% 0.2% 0.3% 0.4% 1.0% 1.1% 1.2% 1.5% 1.8%2.7%
3.4% 3.5% 3.5%5.3%
16.7% 17.2%
40.0%
Bo
by
Tr
ap
Cr
ac
k S
trip
Wh
eel
Sn
ak
e
Co
mb
ina
tion
Missile
Gr
ou
nd
Sp
inn
er
He
licop
ter
Pa
rty P
op
pe
r
Sp
ecia
lty
Sm
ok
e
Sn
ap
pe
r
Fire
cra
cke
r
Ro
cke
t
Ro
ma
n C
an
dle
Sp
ar
kler
Fo
un
tain
Re
loa
da
ble S
hell
Min
e an
d S
hell
TOP 10 VIOLATIONS JAN. TO JUN. 2015
Percentage of Total Violations
13.9%
11.8%
8.9%
7.8%
6.4% 6.3%
4.1% 3.9% 3.6%2.8%
Tu
be
Ab
us
e T
es
t
No
Effe
cts
Aeria
l Effe
cts
be
low
5/6
me
ters
Fla
min
g d
eb
erit
be
low
3 m
ete
r
Cau
tion
ary
La
be
ling
Tilt B
loc
k T
es
t
To
tal P
yro
tec
hn
icW
eig
ht
Blo
wo
ut
Lo
ng
fus
e b
urn
time
No
fun
ctio
n
IV. Introduction of New Testing Laboratory,
Bureau Veritas
- Mr. Chuck Rogers, Americas Director
13
September 8, 2015
AFSL Seminar
NFA
15Bureau Veritas Presentation _ Jul 30, 2015
Bureau Veritas at a Glance
Marine 8%
In-Service
Inspection
& Verification
13%
Certification
8%
Industry
23%
Government Services
& International Trade 6%
Consumer Products
Services 14%
Construction
11%
Eight Global Businesses with Global Leadership Positions Revenue breakdown (2014)
Commodities 17%
Americas
27%
Asia Pacific
28%
Europe, Middle
East, Africa
45%
66,500 skilled employees servicing 400,000 customers across wide range of end markets
1,440 Laboratories and Offices in 140 Countries
2014 Revenue: €4.17bn revenue
Founded in 1828
Global leader in conformity assessment and certification services in QHSE
Broad Geographical Presence
营业额地域性分布
Revenue breakdown (2014)
16Bureau Veritas Presentation _ Jul 30, 2015
Bureau Veritas Vision, Mission and Values
Our Group has built a successful global business based upon its long-standing
reputation. This reputation is one of the most valuable assets for the Group worldwide
and is reflected in our core and business values.
17Bureau Veritas Presentation _ Jul 30, 2015
BVCPS IAA Station Office
Guangzhou 广州
Shenzhen 深圳Hong Kong 香港
Hangzhou 杭州
Qingdao青岛
Shanghai 上海
Xiamen
Ningbo 宁波
Wenzhou 温州
Taipei, Taiwan
台湾台北
Dongguan 东莞
Nanjing南京
BVCPS IAA Main Office
Tianjin 天津
Shantou 汕头Zhongshan 中山
Wuxi 无锡
Fuzhou 福州
Nantong 南通
BVCPS IAAS Services – Greater China Network
Liuyang 浏阳
18Bureau Veritas Presentation _ Jul 30, 2015
Liuyang Operation Manager
Mike Sui, +86-136 5231 0985
Liuyang Supervisors
Cass Ruan, +86-731-83836812
Timmy Hu, +86-731-83836804
South China General Manager
Catherine Wang, +86-20-83851373
Program Manager
Alex Shen, +86-20-83805961
Integrity Assurance Manager
Henry Yang, +86 -13602118465
Liuyang office Address
Management Contact for Liuyang office
浏阳市浏阳大道87号柏建大厦12楼12F Baijian Building, Liuyang Avenue, Liuyang City, Hunan Province, China
Operation / Program Management/ Integrity
Outlook of Liuyang office
Outlook of Liuyang office
Local Contact Point
BV Liuyang Office
19Bureau Veritas Presentation _ Jul 30, 2015
Consumer Fireworks
Booking submission: Visit AFSL website at www.afsl.org, click AFSL
eBooking button for booking submission.
20Bureau Veritas Presentation _ Jul 30, 2015
Guideline for open-day to shippers/factories
► As a trustworthy partner, BV is honored to host Open-day meeting with shippers, in order to build up a direct, open and effective communication channel with AFSL shippers and factories.
► AFSL would be updated for each activity and very welcome to participant as well.
► Shippers and factories are encouraged to direct their inquiries and concerns to BV contacts as listed below:
BV Contact
NamePosition Tel# Email address
Alex Shen PSD Program Manager +86-20-83805961 [email protected]
Mike SuiLiuyang Operation
Manager+86-136 5231 0985 [email protected]
► Open-day initial meeting date and time would be
15:00-17:00 on every Tuesday and Thursday at BV LiuYang office
21Bureau Veritas Presentation _ Jul 30, 2015© - Copyright Bureau Veritas
Chuck RogersAmericas Director, Technical Consulting & Supply
Chain Solutions
AFSL Program Manager
Inspections, Audits and Assessments
Bureau Veritas Consumer Product Services
908 South Walton Blvd, Suite 40
Bentonville, AR
72712
Office: 479-845-7453
Email:[email protected]
22Bureau Veritas Presentation _ Jul 30, 2015© - Copyright Bureau Veritas
V. Domestic Audit Program for U.S. Importers
- Jerry Wingard, Project Manager
23
PURPOSE:
A. Monitor Integrity of Certification Process in
China.
Application of AFSL Stickers
Authenticity of AFSL Stickers
AFSL Lot Identification Stamps
Integrity of Shipping Cartons
INTERNAL AUDIT PROGRAM
24
B. Assist Importers in Correcting Deficiencies in
Program
Familiarity with Requirements of Program
How to Address untested Lots
Assuring Compliance with CPSC Certification
Requirements.
25
C. Enhance the Integrity of the AFSL Program
Demonstrate that Program is Adequately Monitored
Improve the Credibility of the Program for Regulatory
Authorities (DOT and CPSC)
26
Phase I - The Domestic Audit Program was initiated
in October 2012 with audits of Board of Directors’
companies.
Phase II – The general members’ audits were initiated
in February 2013.
Phase III – Re-audits were initiated in March 2015.
27
SUMMARY OF AUDITS FROM PHASE II131 companies have been audited. The chart below shows the audit results:
28
Problems/Issues Found in Phase II Audits
0.00
5,000.00
10,000.00
15,000.00
20,000.00
25,000.00
Uncertified
Products
Products Tested by
other Labs
Uncertified
Domestic Products
Products that
failed AFSL
testing
During Phase II of the Audits 1,306,276 cartons were
inspected
19,353
4,0033,035
708
AFSL CERTIFICATION PROCESS FINDINGS PHASE I AND II
30
Finishing Phase II
On February 16, 2015 the Board officially suspended
8 companies for not responding or agreeing to permit
the required audits.
There are 8 more companies that have not responded
to numerous request for visits.
If you have received phone calls and messages from
AFSL please contact Jerry Wingard at 803-331-3551
as soon as possible.
Domestic Audit Phase III
Phase III moved forward March 12, 2015 with follow-up audits of companies that scored 75% or less on their initial audits in Phase I and II. Locations that score 100% will not be audited during Phase III.
Audits started with companies that had inventories greater than 10,000 cartons and will follow with companies that had less than 10,000 cartons.
We also started with companies that scored the lowest and continue with companies with the highest scores, then adjusted to better minimize travel expenses.
32
Domestic Audits Phase III
As of today 15 companies have been re-audited.
The results of these audits:
1. 9 Companies had improved their scores.
2. 4 Companies’ scores had remained the same and
still have violations.
3. 2 Companies’ scores dropped below their last
audit.
33
VI. Election of Directors
34
BREAK
35
VII. Changes to AFSL Consumer Fireworks Standards
- John D. Rogers, Executive Director
36
REQUIREMENTS FOR MULTIPLE TUBE MINE AND SHELL DEVICES TO ADDRESS RESIDUAL BURN
2-1.7 The finished item, including tubes and internal
construction materials, must not continue to burn or re-
ignite after functioning. See Appendix L for Test
Procedure.
37
SPECIAL WARNING LABEL FOR MULTIPLE TUBE MINE/SHELL DEVICES FOR RESIDUAL BURN
4-2.10 Multiple-tube Mine and Shell Devices subject to this
Standard must bear a warning label which reads: “May re-
ignite. Soak with water after use.”
NOTE: The label must be placed on the top surface of the device,
where feasible. Where not feasible, the label must be place on the
flat surface closest to the fuse. The label must be consistent with
AFSL labeling requirements in Appendix B.
38
WARNING
MAY RE-IGNITE. SOAK WITH WATER
AFTER USE.
RESIDUAL BURN REQUIREMENTS FOR MULTIPLE TUBE MINE AND SHELL DEVICES
Test Procedure Effective Date: August 15, 2015
39
REQUIREMENT FOR COVERED FUSES
AFSL Board approved to incorporate the following language
into each AFSL Standards for Consumer Fireworks:
“Fireworks devices subject to this Standard must have covered
fuses that successfully resist ignition from open flames, hot
surfaces and incendiary sparks when tested in accordance with
test procedures found in PYR 1129 – 2013 edition and any
additional requirements specified by AFSL” with the effective
date on August 1, 2015.
NFPA has withdrawn the covered fuse requirement. As a result,
AFSL will make a decision on this requirement during the
October 2015 Board Meeting.
40
FCA Status
AFSL Board decide not to pursue the FCA at this moment.
6 FCA’S have been approved.
Approx. 200 approvals through FCA’s as of
January 2015.
41
OTHER ACTIVITIES:
VIII. Charging Factories for Failed Lots
- John D. Rogers
42
Which Factories will be Charged?
Factories that have a compliance rate lower than 93%
from June 2014 to May 2015.
Factory compliance data will be evaluated quarterly. Any
factory that has a compliance rate of lower than 93%,
based on testing done in the previous 12 months will be
subject to the fee.
43
How Much will be Charged?
US$0.30 per case for Regular and Assortment cases.
US$0.20 per case for Component cases.
44
Who will Collect the Fees?
AFSL will rely on the contract testing laboratory to collect
the failed Lot fees from the factories. AFSL will perform
the evaluations and send invoices to factories with a copy
to the appropriate shipper.
The contract testing laboratory will collect the fees from
each factory and credit to the AFSL account.
45
How will Fees be Calculated and Collected?
AFSL will analyze monthly the data to determine how many
Lots have been failed for each factory during the previous
month.
Based on the data, AFSL will prepare an invoice for each
subject factory with a cover letter explaining the charged fee.
The contract testing laboratory will mail or hand-deliver the
invoice to the factory, and provide a copy to the shipper that
requested testing for the Lots in question.
46
What are the Penalties for Failure to Pay the Failed Lot Fees? Failed Lot fees are due within 15 days from the date of
notice.
Fees for failed Lots will be considered delinquent if not
paid within 30 days from the date of the notice.
Factories that fail to pay the failed Lot fees will have all
future requests for testing delayed until payments are
received.
Written notice of the testing hold will be provided to the
factory with a copy to the shipper.47
IX. Display Fireworks Testing Program Overview
- Mr. John D. Rogers
48
PARTICIPATING DISPLAY FIREWORKS IMPORTERSMore than 50% of U.S. Market
49 49
1 Alonzo Fireworks Display, Inc. Mechanicville, NY
2 Ammo Hut Productions, Inc., Claremore, OK
3 Arthur Rozzi Pyrotechnics, Inc., Maineville, OH
4 Atlas PyroVision Entertainment Group, Inc., Jaffrey, NH
5 Central States Fireworks, Inc., Athens, IL
6 Fireworks by Grucci, Brookhaven, NY
7 Hamburg Fireworks Display Inc., Lancaster, OH
8 J&M Displays, Inc., Yarmouth, IA
9 Kellner's Fireworks Inc., Harrisville, PA
10 Lew's Fireworks, Inc., Watertown, SD
11 Magic in the Sky, LLC, San Antonio, TX
12 Melrose Pyrotechnics, Inc., Kingsbury, IN
13 Pyro Shows, Inc., La Follette, TN
14 Pyro Spectaculars, Inc., Rialto, CA
15 Pyrotecnico, New Castle, PA
16 RES Specialty Pyrotechnics, Belie Plaine, MN
17 Starfire Corporation, Carrolltown, PA
18 Western Enterprises, Inc., Carrier, OK
19 Wolverine Fireworks Display, Inc., Kawkawlin, MI
20 Zambelli Fireworks, New Castle, PA
PARTICIPATING DISPLAY FIREWORKS SHIPPERS
50
1 An Ping County Fireworks General Factory
2 Babytiger Fireworks Import & Export Ltd., Co.
3 Cenxi Wahyee Advanced Fireworks Factory
4 Dancing Fireworks Group
5 Far East San Luen Fat Trading Company
6 Glorious Professional Products Trading Limited
7 Hua Hui Fireworks Manufacturing Co., Ltd.
8 Hunan Cereals, Oils and Foodstuffs Import & Export Group Co., Ltd.
9 ICON Pyrotechnics International Co., Ltd.
10 Inter-Oriental Fireworks (HK) Ltd.
11 Jiangxi Changshan Exporting Fireworks Manufacture Co., Ltd.
12 Jiangxi Panda Fireworks Co., Ltd.
13 Jiangxi Province Lidu Fireworks Corporation Ltd.
14 Jiangxi Province Light Industrial Products I/E Co., Ltd.
15 Jiangxi Wanzai Golden Peak Fireworks Corp.
16 Liuyang Goldenkey Trade Co., Ltd.
17 Liuyang Jingli Fireworks Trade Co., Ltd.
18 Liuyang Jinsheng Fireworks Co., Ltd.
19 Liuyang Leping Import & Export Co., Ltd.
20 Liuyang Qingtai Export Trade Co., Ltd.
21 Liuyang Sunny Fireworks Trade Co., Ltd.
22 Liuyang Xiangguang Fireworks Trading Co., Ltd.
23 NanChang Xiangtian Imp. & Exp. Co., Ltd.
24 United Pyrotechnics (USA) Inc.
25 Yung-Feng Firecrackers & Fireworks Co., Ltd.
DISPLAY FIREWORKS TEST SUMMARYJANUARY – JUNE 2012, 2013, 2014 AND 2015
51
2012 2013 2014 2015
Total Cases 9,370 60,847 71,177 66,913
CO Cases 5,484 56,855 70,719 64,376
Container Loading 3,275 36,511 58,732 40,955
0
10,000
20,000
30,000
40,000
50,000
60,000
70,000
80,000
DISPLAY FIREWORKS COMPLIANCE RATEJANUARY – JUNE 2012, 2013, 2014 AND 2015
-1.0%
9.0%
19.0%
29.0%
39.0%
49.0%
59.0%
69.0%
79.0%
89.0%
99.0%
2012 2013 2014 2015
Compliance Rate
58.5%
93.4%96.2%
52
99.4%
X. Questions & Answers
53