Air Emission Permit No. 09900002-011 is Issue to Hormel ...

Permit Applications Table

Permit Type Application Date Permit Action

Total Facility Operating Permit ‐Reissuance 2/6/04 & 8/22/05 008

Major Amendment 1/17/06 009

Major Amendment 3/3/11 & 6/17/11 010

Major Amendment 2/22/13 011

TABLE OF CONTENTS

Notice to the Permittee Permit Shield Facility Description Amendment Description Table A: Limits and Other Requirements Table B: Submittals Appendices 1. EU 051 Nitrogen Oxides Emission Factors and Fuel Heat Contents 2. Insignificant Activities Required to be Listed 3. GP 011 Modeling Parameters

4. Greenhouse Gas Emission Calculation Equations and Combustion Unit Inventory

NOTICE TO THE PERMITTEE: Your stationary source may be subject to the requirements of the Minnesota Pollution Control Agency’s (MPCA) solid waste, hazardous waste, and water quality programs. If you wish to obtain information on these programs, including information on obtaining any required permits, please contact the MPCA general information number at: Metro Area 651‐296‐6300 Outside Metro Area 1‐800‐657‐3864 TTY 651‐282‐5332 The rules governing these programs are contained in Minn. R. chs. 7000‐7105. Written questions may be sent to: Minnesota Pollution Control Agency, 520 Lafayette Road North, St. Paul, Minnesota 55155‐4194. Questions about this air emission permit or about air quality requirements can also be directed to the telephone numbers and address listed above. PERMIT SHIELD: Subject to the limitations in Minn. R. 7007.1800, compliance with the conditions of this permit shall be deemed compliance with the specific provision of the applicable requirement identified in the permit as the basis of each condition. Subject to the limitations of Minn. R. 7007.1800 and 7017.0100, subp. 2, notwithstanding the conditions of this permit specifying compliance practices for applicable requirements, any person (including the Permittee) may also use other credible evidence to establish compliance or noncompliance with applicable requirements. FACILITY DESCRIPTION:

The Hormel Foods Corporation operates a meat processing plant in Austin, Minnesota. At the facility, Quality Pork Processors (QPP) processes hogs, and the Permittee manufacturers the hogs into ham, bacon, dry sausage, fresh sausage, SPAM ®, and other meat products. Byproducts consist of blood, cracklings, bone meal, and choice white grease (a component of a broader category of substances known as refined animal fats). QPP is a co‐permittee however Hormel Foods owns all equipment and operates the majority of it; QPP only operates some of the emissions equipment (insignificant combustion sources) in the processing area.

There are many emission sources at the facility, however most of them qualify as insignificant activities under Minn. R. 7007.1300, subparts 3 and 4. Most of these insignificant activities are natural gas‐fired combustion sources such as makeup air heaters, space heaters, and process ovens. Some of these insignificant activities are included in the following facility discussion.

Seven boilers combusting mainly natural gas provide process steam. In addition, twelve natural gas‐fired process ovens produce meat products using natural or liquid smoke. Pre‐cooked process lines produce pre‐cooked bacon and bacon bits.

Rendering emissions are treated in a venturi scrubber and packed tower scrubbers before discharge to the atmosphere. Emissions from a bone meal dryer and a blood dryer are also treated by a venturi scrubber and packed tower scrubbers before discharge to the atmosphere.

ACTION 009

This amendment authorized construction and operation of seven identical 2000 kW diesel electric generators. The engines are Caterpillar model 3516 units and operate as peaking and emergency power units.

ACTION 010

This amendment authorized installation of a regenerative thermal oxidizer (RTO; CE 026), retirement of three packed tower scrubbers (CE 022, CE 023, and CE 024), and re‐routing of emissions from rendering machinery, and bone and blood meal dryers. The RTO replaced existing packed tower scrubbers CE 022, CE 023, and CE 024 that control condensable particulate matter and VOC emissions from rendering machinery (EU 028), a blood dryer (EU 050) and a bone meal dryer (EU 036).

This action also added a 94,700 ton per year carbon dioxide equivalent (CO2e) limit to maintain minor source status under New Source Review.

Finally, this action added GP 003 PM and opacity testing (due October 16, 2011 and thereafter at 60‐month intervals unless/until revised by future test results) as specified in the August 9, 2007, the MPCA test frequency approval letter, clarified that the GP 012 used oil analysis frequency is 60 months, and updated the total facility requirement pertaining to operating limits established through performance testing. This action also updated the nitrogen oxides (NOX) emission factor and opacity testing requirements for GP 011 peaking generators based on a January 14, 2010 Notice of Compliance.

ACTION 011 AMENDMENT DESCRIPTION:

This permit action will authorize construction of new, re‐designed rendering operations at the facility to replace existing rendering operations. The new operations will be referred to as Refined Products operations. The re‐designed Refined Products operations will be housed in a new manufacturing building to be constructed on the same site as the existing facility. The addition will include rendering machinery, some new and some relocated from existing operations, as well as new meat and bone meal (MBM) and dried blood truck load‐out system. Compliance Assurance Monitoring (CAM) Plans existing in the permit appendices were removed. Requirements referencing use of No. 6 Fuel Oil and used oil are being removed.

TABLE A: LIMITS AND OTHER REQUIREMENTSHormel Foods Corp/QPP - Austin

09900002 - 011

Facility Name:

Permit Number:

07/08/13A-1

Table A contains limits and other requirements with which your facility must comply. The limits are located in the first column ofthe table (What To do). The limits can be emission limits or operational limits. This column also contains the actions that you musttake and the records you must keep to show that you are complying with the limits. The second column of Table A (Why to do it)lists the regulatory basis for these limits. Appendices included as conditions of your permit are listed in Table A under total facilityrequirements.

Subject Item: Total Facility

What to do Why to do it

TOTAL FACILITY CARBON DIOXIDE EQUIVALENT (CO2e) LIMIT hdr

Carbon Dioxide Equivalent: less than or equal to 94700 tons/year using 12-monthRolling Sum for all CO2e emitting sources at the facility.

Title I Condition: To avoid classification as majorsource and modification under 40 CFR Section 52.21& Minn. R. 7007.3000

Carbon Dioxide Equivalent Emissions Monitoring: By the 15th day of each monththe Permittee shall calculate and record the following:

1. the type and amount of each fuel combusted at the facility in the previouscalendar month;

2. the total facility CO2e emissions from the previous calendar month usingEquations 1 and 2 in Appendix 4 of this permit;

3. the total facility CO2e emissions during the previous 12 calendar months bysumming the monthly total CO2e emissions from the past 12 months.


The Permittee is prohibited from emitting any greenhouse gases as defined at title40 CFR Section 98.6 other than carbon dioxide (CO2), nitrous oxide (N2O), andmethane (CH4).


OPERATIONAL REQUIREMENTS hdr

Ambient Air Quality Standards: The Permittee shall comply with and upon writtenrequest demonstrate compliance with National Primary and Secondary Ambient AirQuality Standards in Title 40 CFR part 50, and the Minnesota Ambient Air QualityStandards at Minn. R. 7009.0010 to 7009.0080.

40 CFR part 50; Minn. Stat. Sec. 116.07, subds. 4aand 9; Minn. R. 7007.0100, subps. 7A, 7L and 7M;Minn. R. 7007.0800, subps. 1, 2, and 4; Minn. R.7009.0010-7009.0080

Circumvention: Do not install or use a device or means that conceals or dilutesemissions, which would otherwise violate a federal or state air pollution control rule,without reducing the total amount of pollutant emitted.

Minn. R. 7011.0020

Air Pollution Control Equipment: Operate all pollution control equipment wheneverthe corresponding process equipment and emission units are operated, unlessotherwise noted in Table A.

Minn. R. 7007.0800, subp. 2; Minn. R. 7007.0800,subp. 16(J)

Operation and Maintenance Plan: Retain at the stationary source an operation andmaintenance plan for all air pollution control equipment. At a minimum, the O & Mplan shall identify all air pollution control equipment and shall include a preventativemaintenance program for that equipment, a description of (the minimum but notnecessarily the only) corrective actions to be taken to restore the equipment toproper operation to meet applicable permit conditions, a description of theemployee training program for proper operation and maintenance of the controlequipment, and the records kept to demonstrate plan implementation.

Minn. R. 7007.0800, subps. 14 and 16(J)

Operation Changes: In any shutdown, breakdown, or deviation the Permittee shallimmediately take all practical steps to modify operations to reduce the emission ofany regulated air pollutant. The Commissioner may require feasible and practicalmodifications in the operation to reduce emissions of air pollutants. No emissionsunits that have an unreasonable shutdown or breakdown frequency of process orcontrol equipment shall be permitted to operate.

Minn. R. 7019.1000, subp. 4

Fugitive Emissions: Do not cause or permit the handling, use, transporting, orstorage of any material in a manner which may allow avoidable amounts ofparticulate matter to become airborne. Comply with all other requirements listed inMinn. R. 7011.0150.

Minn. R. 7011.0150

Noise: The Permittee shall comply with the noise standards set forth in Minn. R.7030.0010 to 7030.0080 at all times during the operation of any emission units.This is a state only requirement and is not federally enforceable.

Minn. R. 7030.0010 - 7030.0080

Inspections: Upon presentation of credentials and other documents as may berequired by law, allow the Agency, or its representative, to enter the Permittee'spremises to have access to and copy any records required by this permit, to inspectat reasonable times (which include any time the source is operating) any facilities,equipment, practices or operations, and to sample or monitor any substances orparameters at any location.

Minn. R. 7007.0800, subp. 9(A)


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-2

The Permittee shall comply with the General Conditions listed in Minn. R.7007.0800, subp. 16.

Minn. R. 7007.0800, subp. 16

PERFORMANCE TESTING hdr

Performance Testing: Conduct all performance tests in accordance with Minn. R.ch. 7017 unless otherwise noted in Tables A and/or B.

Minn. R. ch. 7017

Performance Test Notifications and Submittals:

Performance Tests are due as outlined in Tables A and B of the permit. See TableB for additional testing requirements.

Performance Test Notification (written): due 30 days before each Performance TestPerformance Test Plan: due 30 days before each Performance TestPerformance Test Pre-test Meeting: due 7 days before each Performance TestPerformance Test Report: due 45 days after each Performance TestPerformance Test Report - Microfiche Copy: due 105 days after each PerformanceTest

The Notification, Test Plan, and Test Report may be submitted in alternative formatas allowed by Minn. R. 7017.2018.

Minn. R. 7017.2030, subps. 1-4, Minn. R. 7017.2035,subps. 1-2, and Minn. R. 7017.2018

Limits set as a result of a performance test (conducted before or after permitissuance) apply until superseded as stated in the MPCA's Notice of Complianceletter granting preliminary approval. Preliminary approval is based on formal reviewof a subsequent performance test on the same unit as specified by Minn. R.7017.2025, subp. 3. The limit is final upon issuance of a permit amendmentincorporating the change.

Minn. R. 7017.2025, subp. 3

MONITORING REQUIREMENTS hdr

Monitoring Equipment Calibration: Annually calibrate all required monitoringequipment (any requirements applying to continuous emission monitors are listedseparately in this permit).

Minn. R. 7007.0800, subp. 4(D)

Operation of Monitoring Equipment: Unless otherwise noted in Tables A and/or B,monitoring a process or control equipment connected to that process is notnecessary during periods when the process is shutdown, or during checks of themonitoring systems, such as calibration checks and zero and span adjustments. Ifmonitoring records are required, they should reflect any such periods of processshutdown or checks of the monitoring system.

Minn. R. 7007.0800, subp. 4(D)

RECORDKEEPING hdr

Recordkeeping: Retain all records at the stationary source for a period of five (5)years from the date of monitoring, sample, measurement, or report. Records whichmust be retained at this location include all calibration and maintenance records, alloriginal recordings for continuous monitoring instrumentation, and copies of allreports required by the permit. Records must conform to the requirements listed inMinn. R. 7007.0800, subp. 5(A).

Minn. R. 7007.0800, subp. 5(C)

Recordkeeping: Maintain records describing any insignificant modifications (asrequired by Minn. R. 7007.1250, subp. 3) or changes contravening permit terms (asrequired by Minn. R. 7007.1350, subp. 2), including records of the emissionsresulting from those changes.

Minn. R. 7007.0800, subp. 5(B)

If the Permittee determines that no permit amendment or notification is requiredprior to making a change, the Permittee must retain records of all calculationsrequired under Minn. R. 7007.1200. These records shall be kept for a period of fiveyears from the date the change was made or until permit reissuance, whichever islonger. The records shall be kept at the stationary source for the current calendaryear of operation and may be kept at the stationary source or office of thestationary source for all other years. The records may be maintained in eitherelectronic or paper format.

Minn. R. 7007.1200, subp. 4

REPORTING/SUBMITTALS hdr

Shutdown Notifications: Notify the Commissioner at least 24 hours in advance of aplanned shutdown of any control equipment or process equipment if the shutdownwould cause any increase in the emissions of any regulated air pollutant. If theowner or operator does not have advance knowledge of the shutdown, notificationshall be made to the Commissioner as soon as possible after the shutdown.However, notification is not required in the circumstances outlined in Items A, Band C of Minn. R. 7019.1000, subp. 3.

At the time of notification, the owner or operator shall inform the Commissioner ofthe cause of the shutdown and the estimated duration. The owner or operator shallnotify the Commissioner when the shutdown is over.

Minn. R. 7019.1000, subp. 3


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-3

Breakdown Notifications: Notify the Commissioner within 24 hours of a breakdownof more than one hour duration of any control equipment or process equipment ifthe breakdown causes any increase in the emissions of any regulated air pollutant.The 24-hour time period starts when the breakdown was discovered or reasonablyshould have been discovered by the owner or operator. However, notification is notrequired in the circumstances outlined in Items A, B and C of Minn. R. 7019.1000,subp. 2.

At the time of notification or as soon as possible thereafter, the owner or operatorshall inform the Commissioner of the cause of the breakdown and the estimatedduration. The owner or operator shall notify the Commissioner when thebreakdown is over.

Minn. R. 7019.1000, subp. 2

Notification of Deviations Endangering Human Health or the Environment: As soonas possible after discovery, notify the Commissioner or the state duty officer, eitherorally or by facsimile, of any deviation from permit conditions which could endangerhuman health or the environment.

Minn. R. 7019.1000, subp. 1

Notification of Deviations Endangering Human Health or the Environment Report:Within 2 working days of discovery, notify the Commissioner in writing of anydeviation from permit conditions which could endanger human health or theenvironment. Include the following information in this written description:1. the cause of the deviation;2. the exact dates of the period of the deviation, if the deviation has been corrected;3. whether or not the deviation has been corrected;4. the anticipated time by which the deviation is expected to be corrected, if not yetcorrected; and5. steps taken or planned to reduce, eliminate, and prevent reoccurrence of thedeviation.

Minn. R. 7019.1000, subp. 1

Application for Permit Amendment: If a permit amendment is needed, submit anapplication in accordance with the requirements of Minn. R. 7007.1150 throughMinn. R. 7007.1500. Submittal dates vary, depending on the type of amendmentneeded.

Minn. R. 7007.1150 - 7007.1500

Extension Requests: The Permittee may apply for an Administrative Amendment toextend a deadline in a permit by no more than 120 days, provided the proposeddeadline extension meets the requirements of Minn. R. 7007.1400, subp. 1(H).Performance testing deadlines from the General Provisions of 40 CFR pt. 60 andpt. 63 are examples of deadlines for which the MPCA does not have authority togrant extensions and therefore do not meet the requirements of Minn. R.7007.1400, subp. 1(H).

Minn. R. 7007.1400, subp. 1(H)

Emission Inventory Report: due on or before April 1 of each calendar year followingpermit issuance. Submit the report on a form or alternative media approved by theCommissioner.

Minn. R. 7019.3000 - 7019.3010

Emission Fees: due 60 days after receipt of an MPCA bill. Minn. R. 7002.0005 - 7002.0095


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-4

Subject Item: GP 001 SO2 and NOx Limits

Associated Items: EU 001 Boiler #1

EU 002 Boiler #2

EU 003 Boiler #3

EU 004 Boiler #4

EU 005 Boiler #5

EU 044 Boiler #6

EU 045 Boiler #7

EU 051 Emergency RICE(s)

EU 080 Generator #1

EU 081 Generator #2

EU 082 Generator #3

EU 083 Generator #4

EU 084 Generator #5

EU 085 Generator #6

EU 086 Generator #7


GP 001 ASSOCIATED ITEMS

GP 001 is composed of GP 011 and GP 012 emission units, and EU 051. GP 011is composed of EU 080 through EU 086. GP 012 is composed of EU 001 - EU 005,EU 044, and EU 045.

hdr

EMISSION LIMITS hdr

Nitrogen Oxides: less than or equal to 180 tons/year using 12-month Rolling Sumtotal for GP 001.

Title I Condition: To limit potential NOx emissions toless than major source levels defined by 40 CFRSection 52.21; Minn. R. 7007.3000

Sulfur Dioxide: less than or equal to 235 tons/year using 12-month Rolling Sumtotal for GP 001 combustion of diesel fuel, and refined animal fats. This does notinclude any SO2 emissions from distillate oil or diesel fuel combustion in EU 051.

Title I Condition: To limit potential SO2 emissions toless than major source levels defined by 40 CFRSection 52.21; Minn. R. 7007.3000

RECORDKEEPING hdr

Sulfur Dioxide Emissions Monitoring and Recordkeeping: By the 15th day of eachmonth the Permittee shall:

1) Calculate and record GP 001 SO2 emissions during the previous calendarmonth using the following equation:

SO2 = GP 011 + GP 012

where:

SO2 = GP 001 calendar month SO2 emissions, in tonsGP 011 = GP 011 calendar month SO2 emissions, in tons, determined under GP011GP 012 = GP 012 calendar month SO2 emissions, in tons, determined under GP012

(continued)

Minn. R. 7007.0800, subp. 4 and 5

(continued from above)

2) Calculate and record the 12-month rolling sum GP 001 SO2 emissions bysumming the monthly GP 001 SO2 emissions determined with the above equation,for the previous 12 months.

Minn. R. 7007.0800, subp. 4 and 5


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-5

Nitrogen Oxides Emissions Monitoring and Recordkeeping: By the 15th day ofeach month the Permittee shall:

1) Calculate and record GP 001 NOx emissions during the previous calendarmonth using the following equation:

NOx = GP 011 + GP 012 + (EU 051/2000)

where:

NOx = GP 001 calendar month NOx emissions, in tonsGP 011 = GP 011 calendar month NOx emissions, in tons, determined under GP011GP 012 = GP 012 calendar month NOx emissions, in tons, determined under GP012EU 051 = EU 051 calendar month NOx emissions, in pounds, determined under EU051

(continued)

Minn. R. 7007.0800, subp. 4 and 5

(continued from above)

2) Calculate and record the 12-month rolling sum GP 001 NOx emissions bysumming the monthly GP 001 NOx emissions determined with the above equation,for the previous 12 months.

Minn. R. 7007.0800, subp. 4 and 5


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-6

Subject Item: GP 003 Natural Smoke Process

Associated Items: EU 006 Smoked Meat Oven #6 with recirculated natural wood smoke

EU 007 Smoked Meat Oven #7 with recirculated natural wood smoke





EU 031 Natural Smoke Generator


SV 003 Natural Smoke Meat Oven (EU 006)







EMISSION LIMITS hdr

Total Particulate Matter: less than 0.30 grains/dry standard cubic foot unlessrequired to reduce emissions to meet the less stringent limit of either 7011.0730 or7011.0735 (table 1 and 2, respectively). This limit applies individually to eachstack/vent.

Minn. R. 7011.0715, subp. 1(A)

Opacity: less than or equal to 20 percent . This limit applies individually to eachstack/vent.

Minn. R. 7011.0715, subp. 1(B)

PERFORMANCE TEST REQUIREMENTS hdr

Performance Test: due before end of each calendar 60 months starting 10/07/2011to measure PM and opacity from one of the GP 003 emission units while usingnatural smoke from EU 031 or EU 032. The next PM and opacity tests are due10/7/2016.

Minn. R. 7017.2020, subp. 1


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-7

Subject Item: GP 005 Precook Processes

Associated Items: CE 006 Mist Eliminator - High Velocity, i.e., V>250 Ft/Min

CE 007 Mist Eliminator - High Velocity, i.e., V>250 Ft/Min


EU 018 Precooked Bacon, South

EU 019 Precooked Bacon, North

EU 020 Precooked Bacon, East

EU 021 Precooked Bacon, West

EU 029 Bacon Bits Precooked Line

SV 019 Precooked Bacon Stack N/S (EU 018 & EU 019/CE 006)

SV 020 Precooked Bakon Stack E/W (EU 020 & EU 021/CE 007)

SV 050 Bacon Bits Line (EU 029/CE 025)


EMISSION LIMITS hdr

Total Particulate Matter: less than 0.30 grains/dry standard cubic foot unlessrequired to reduce emissions to meet the less stringent limit of either 7011.0730 or7011.0735 (table 1 and 2, respectively). This limit applies individually to eachstack/vent.

Minn. R. 7011.0715, subp. 1(A)

Opacity: less than or equal to 20 percent opacity . This limit applies individually toeach stack/vent.

Minn. R. 7011.0715, subp. 1(B)

OPERATING REQUIREMENTS hdr

Vent all emissions from GP 005 precooked process equipment through thecorresponding mist eliminator (CE 006, CE 007, or CE 025).

Minn. R. 7007.0800, subp. 2

CONTROL EQUIPMENT REQUIREMENTS hdr

The Permittee shall operate and maintain each mist eliminator in accordance withthe Operation and Maintenance (O & M) Plan. The Permittee shall keep copies ofthe O & M Plan available onsite for use by staff and MPCA staff.

Minn. R. 7007.0800, subp. 14

Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for each mist eliminator, as required by this permit. The monitoring equipmentmust be installed, in use, and properly maintained when the mist eliminator iscontrolling emissions.

Minn. R. 7007.0800, subp. 4

CE 006 and CE 007 Pressure Differential: Not less than 0 inches wc and not morethan 2 inches wc for each mist eliminator when controlling precooked processemissions.

Minn. R. 7007.0800, subp. 14

CE 006 and CE 007 Minimum Water Flow Rate: Not less than 1 gallon per minute,for each mist eliminator when controlling precooked process emissions.

Minn. R. 7007.0800, subp. 14

CE 025 Pressure Differential: Less than 2 inches wc when controlling processemissions.

Minn. R. 7007.0800, subp. 14

CE 025 Minimum Water Flow Rate when controlling process emissions:

Filter: not less than 2 gallon per minute;Upper Intake: not less than 1 gallon per minuteLower Intake: not less than 1 gallon per minute

Minn. R. 7007.0800, subp. 14

Daily Monitoring: Once each day of operation, the Permittee shall monitor andrecord the pressure differential and water flow rate for each mist eliminator that iscontrolling any GP 005 precooked process emissions.

Minn. R. 7007.0800, subp. 4 and 5

Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of each misteliminator. The Permittee shall maintain a written record of the results of eachinspection.

Minn. R. 7007.0800, subp. 4, 5, and 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-8

Corrective Actions: The Permittee shall take corrective action as soon as possibleif any of the following occur:

- the pressure drop across any mist eliminator is outside the required operatingrange;- the water flow rate for any mist eliminator is less than the required minimum; or- any mist eliminator or any of its components are found during any inspection toneed repair.

Corrective actions shall return the pressure drop to within the permitted range,restore the water flow rate to at least the required minimum, and/or includecompletion of necessary repairs identified during the inspection, as applicable.Corrective actions include, but are not limited to, those outlined in the O & M Planfor the mist eliminator. The Permittee shall keep a record of the type and date ofany corrective action taken for any of the mist eliminators.

Minn. R. 7007.0800, subp. 4, 5, and 14

The Permittee shall calibrate or replace the CE 006, CE 007, and CE 025 pressuredifferential and flow rate monitors at least annually and shall maintain a writtenrecord of any action resulting from the calibration or replacement.

Minn. R. 7007.0800, subps. 4, 5, and 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-9

Subject Item: GP 010 Blood and Bone Meal Dryers

Associated Items: CE 018 Venturi Scrubber

CE 019 Packed-Gas Adsorption Column


CE 026 Thermal Oxidizer

EU 036 Existing Scott Bone Dryer

EU 050 New Duske Blood Dryer

EU 071 Room Air - Blood & Bone Drying

SV 033 Blood & Bone Dryers CE 018/CE 024 (venturi & packed tower E; bypasses packed tower F) (EU 036/EU 050)

SV 045 Blood & Bone Dryers CE 019 (packed tower F) (EU 036/EU 050)

SV 058 Regenerative Thermal Oxidizer (CE 026)


Subject Item GP 010 contains requirements applicable either:

1. prior to the startup of CE 026;2. after the startup of CE 026; or,3. both prior and after the startup of CE 026.

Requirements under any header that states 'APPLY ONLY BEFORE CE 026STARTUP' are no longer effective upon CE 026 startup.

Prior to CE 026 startup, EU 036 and EU 050 emissions will vent to CE 018 (venturiscrubber) and then through CE 024 (Tower E) and then either to CE 019 (Tower F),and vent to the atmosphere through SV 045, or bypass CE 019 and vent emissionsto the atmosphere from CE 024 through SV 033.

After CE 026 startup, EU 036 and EU 050 emissions will be vented to CE 018 andthen to CE 026 and then to the atmosphere through SV 058, and CE 024 will beshutdown.

hdr

EMISSION LIMITS - APPLY BEFORE AND AFTER CE 026 STARTUP

Refer to SV 058 for additional applicable limits and requirements that apply afterCE 026 startup

hdr

Total Particulate Matter: less than or equal to 0.30 grains/dry standard cubic foot ofexhaust gas unless required to further reduce emissions to comply with the lessstringent limit of either Minn. R. 7011.0730 or Minn. R. 7011.0735.

After CE 026 startup, this limit applies at the outlet of CE 018 and does not apply toSV 058.

Minn. R. 7011.0610, subp. 1(A)(1)

Opacity: less than or equal to 20 percent except for one six-minute period per hourof not more than 60 percent opacity.


Minn. R. 7011.0610, subp. 1(A)(2)

OPERATING REQUIREMENTS - APPLY AFTER CE 026 STARTUP hdr

Vent emissions from both the blood and bone dryers through CE 018 (venturiscrubber) and CE 026 (RTO) and then through SV 058. After CE 026 startup, thePermittee shall not route GP 010 emissions through CE 019 and CE 024.

Title I Condition: To avoid major source status under40 CFR Section 52.21 and Minn. R. 7007.3000

CE 018 CONTROL EQUIPMENT REQUIREMENTS - APPLY AFTER CE 026STARTUP

hdr

The Permittee shall operate and maintain CE 018 to achieve a control efficiency forTotal Particulate Matter: greater than or equal to 94 percent control efficiency


The Permittee shall operate and maintain CE 018 to achieve a control efficiency forPM < 10 micron: greater than or equal to 84 percent control efficiency


The Permittee shall operate and maintain CE 018 venturi scrubber at all times thatany emission unit controlled by CE 018 is in operation. The Permittee shalldocument periods of non-operation of CE 018.


The Permittee shall operate and maintain CE 018 in accordance with the Operationand Maintenance (O & M) Plan. The Permittee shall keep copies of the O & M Planavailable onsite for use by staff and MPCA staff.

Minn. R. 7007.0800, subp. 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-10

Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for CE 018, as required by this permit. The monitoring equipment must beinstalled, in use, and properly maintained when CE 018 is in operation.

Minn. R. 7007.0800, subp. 4

CE 018 Pressure Differential: greater than or equal to 5.0 inches w.c. Title I Condition: To avoid major source status under40 CFR Section 52.21 and Minn. R. 7007.3000; Minn.R. 7007.0800, subps. 2 & 14

CE 018 Water Flow Rate: greater than or equal to 10 gallons per minute. Title I Condition: To avoid major source status under40 CFR Section 52.21 and Minn. R. 7007.3000; Minn.R. 7007.0800, subps. 2 & 14

CE 018 Daily Monitoring and Recordkeeping: Once each day of EU 036 and/or EU050 operation, the Permittee shall monitor and record the pressure differential andthe water flow rate for CE 018.

Title I Condition: To avoid major source status under40 CFR Section 52.21 and Minn. R. 7007.3000; Minn.R. 7007.0800, subps. 4 & 5

Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of CE 018. ThePermittee shall maintain a written record of the results of each inspection.

Minn. R. 7007.0800, subps. 4, 5, and 14

Corrective Actions: The Permittee shall take corrective action as soon as possible ifany of the following occur:

- the CE 018 pressure drop is below the permitted minimum;- the CE 018 water flow rate is below the permitted minimum; or- CE 018 or any of its components are found during any inspection to need repair.

Corrective actions shall return the CE 018 pressure drop to at or above theminimum, the CE 018 water flow rate to at or above the permitted minimum, and/orinclude completion of necessary repairs identified during the inspection, asapplicable. Corrective actions include, but are not limited to, those outlined in theCE 018 O & M Plan. The Permittee shall keep a record of the type and date of anycorrective action taken.

Minn. R. 7007.0800, subps. 4, 5, and 14

The Permittee shall calibrate or replace the CE 018 pressure differential and flowrate monitors at least annually and shall maintain a written record of any actionresulting from the calibration or replacement.

Minn. R. 7007.0800, subps. 4, 5, and 14

OPERATING REQUIREMENTS - APPLY ONLY BEFORE CE 026 STARTUP hdr

Vent emissions from both the blood and bone dryers through CE 018 (venturiscrubber) and then through CE 024 (Tower E). After CE 024 the Permittee has theoption of routing emissions to CE 019 (Tower F), and then through SV 045, orbypass CE 019 and vent emissions from CE 024 through SV 033.

Minn. R. 7007.0800, subp. 2

CE 018 (VENTURI SCRUBBER), CE 019 (TOWER F) AND CE 024 (TOWER E)CONTROL EQUIPMENT REQUIREMENTS - APPLY ONLY BEFORE CE 026STARTUP

hdr

The Permittee shall operate and maintain CE 019 and CE 024 so that eachachieves a control efficiency for Total Particulate Matter: greater than or equal to 85percent control efficiency

Title I Condition: To avoid classification as a majorsource and modification under 40 CFR Section 52.21and Minn. R. 7007.3000; Minn. R. 7007.0800, subps. 2and 14

The Permittee shall operate and maintain CE 019 and CE 024 so that eachachieves a control efficiency for PM < 10 micron: greater than or equal to 85percent control efficiency


The Permittee shall operate and maintain CE 018 so that the scrubber achieves atotal control efficiency for Total Particulate Matter: greater than or equal to 94percent control efficiency


The Permittee shall operate and maintain CE 018 so that the scrubber achieves atotal control efficiency for PM < 10 micron: greater than or equal to 84 percentcontrol efficiency


The Permittee shall operate and maintain CE 018, CE 019, and CE 024 inaccordance with the Operation and Maintenance (O & M) Plan. The Permittee shallkeep copies of the O & M Plan available onsite for use by staff and MPCA staff.

Minn. R. 7007.0800, subp. 14

Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for CE 018, CE 019, and CE 024, as required by this permit. The monitoringequipment must be installed, in use, and properly maintained when CE 018, CE019, and CE 024 are in operation.

Minn. R. 7007.0800, subp. 4


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-11

CE 018 Pressure Differential: greater than or equal to 5 inches wc.CE 019 Pressure Differential: less than 7 inches wc.CE 024 Pressure Differential: less than 5 inches wc.

Minn. R. 7007.0800, subp. 14

CE 018 Water Flow Rate: not less than 10 gallons per minuteCE 019 Water Flow Rate: not less than 150 gallons per minuteCE 024 Water Flow Rate: not less than 50 gallons per minute

Minn. R. 7007.0800, subp. 14

CE 018, CE 019, and CE 024 Daily Monitoring: Once each day of operation, thePermittee shall monitor and record the pressure differential and the water flow ratefor CE 018, CE 019, and CE 024.

Minn. R. 7007.0800, subp. 4 and 5


Minn. R. 7007.0800, subps. 4, 5, and 14

Periodic Inspections: At least once per calendar quarter, or more frequently asrequired by the manufacturer, the Permittee shall inspect the components of CE018, CE 019, and CE 024. The Permittee shall maintain a written record of theresults of each inspection.

Minn. R. 7007.0800, subp. 4, 5, and 14


- the pressure drop of CE 018, CE 019, or CE 024 is below the required minimum;- the water flow rate of CE 018, CE 019, or CE 024 is below the permittedminimum; or- CE 018, CE 019, or CE 024 or any of their components are found during anyinspection to need repair.

Corrective actions shall return the pressure drop to within the permitted range,return the water flow rate to at least the permitted minimum, and/or includecompletion of necessary repairs identified during the inspection, as applicable.Corrective actions include, but are not limited to, those outlined in the O & M Planfor CE 018, CE 019, or CE 024. The Permittee shall keep a record of the type anddate of any corrective action taken.

Minn. R. 7007.0800, subp. 4, 5, and 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-12

Subject Item: GP 011 Electric Power Generators

Associated Items: EU 080 Generator #1

EU 081 Generator #2

EU 082 Generator #3

EU 083 Generator #4

EU 084 Generator #5

EU 085 Generator #6

EU 086 Generator #7


LIMITS AND OPERATIONAL REQUIREMENTS hdr

Opacity: less than or equal to 20 percent opacity once operating temperatures havebeen attained.

Minn. R. 7011.2300, subp. 1

Sulfur Dioxide: less than or equal to 0.5 lbs/million Btu heat input Minn. R. 7011.2300, subp. 2

Permitted fuel: diesel fuel only. Minn. R. 7007.0800, subp. 2

Diesel fuel sulfur content: less than or equal to 0.05 percent by weight. Minn. R. 7007.0800, subp. 2

Total GP 011 Operating Hours: less than or equal to 65 hours/day Minn. R. 7007.0800, subp. 2

MONITORING AND RECORDKEEPING hdr

Diesel Fuel Supplier Certification: For each diesel fuel delivery, obtain a suppliercertification either stating the actual sulfur content in percent by weight or certifyingthat the sulfur content does not exceed 0.05 percent by weight.

Minn. R. 7007.0800, subp. 4 and 5

Recordkeeping - GP 011 Operating Hours: Once each day the Permittee shallcalculate and record the total GP 011 operating hours for the previous calendarday. By the 15th day of each month, calculate and record the total GP 011operating hours for the previous calendar month.

Title I Condition: To limit potential NOx emissions toless than the major source levels defined in 40 CFRSection 52.21; Minn. R. 7007.3000; Minn. R.7007.0800, subp. 4 and 5

Recordkeeping - Fuel Usage: Once each day the Permittee shall calculate andrecord the GP 011 diesel fuel usage (gallons) for the previous calendar day. By the15th day of each month, calculate and record the total GP 011 diesel fuel usage(gallons) for the previous calendar month.

Title I Condition: To limit potential SO2 emissions toless than the major source levels defined in 40 CFRSection 52.21; Minn. R. 7007.3000; Minn. R.7007.0800, subp. 4 and 5

Sulfur Dioxide Emissions Monitoring: by the 15th day of each month, calculate andrecord GP 011 SO2 emissions for the previous calendar month using the followingequation:

GP 011 SO2 = (Dg * 6.92E-03)/2000

where:

GP 011 SO2 = GP 011 SO2 emissions, in tonsDg = diesel fuel combusted by GP 011 units during the previous month, in gallons6.92E-03 = conversion factor derived from fuel heat content (0.137 mmBtu/gallon)and sulfur content limit (0.05% by weight equivalent to 0.0505 lb/mmBtu)

Minn. R. 7007.0800, subp. 4 and 5

Nitrogen Oxides Emissions Monitoring: by the 15th day of each month, calculateand record GP 011 NOx emissions for the previous calendar month using thefollowing equation:

GP 011 NOx = (OH * EF)/2000

where:

GP 011 NOx = GP 011 NOx emissions, in tonsOH = GP 011 units total operating hours during the previous monthEF = NOx lb/hr emission factor; upon issuance of this permit the Permittee shalluse the manufacturer's 48.92 lb/hr NOx emission factor

This NOx lb/hr emission factor will be revised upon written MPCA approval of thelatest NOx emission factor performance test results. An EF determined for one unitapplies to all seven units for determining the GP 011 12-month rolling sum NOxemissions.

Minn. R. 7007.0800, subp. 4 and 5



09900002 - 011

Facility Name:

Permit Number:

07/08/13A-13

Performance Test: due before end of each 36 months starting 10/26/2012 todetermine the lb/hr NOx emission factor from one generator in GP 011 that has notbeen previously tested for NOx. If all GP 011 generators have been tested for NOx,test the generator with the least current NOx emission factor test.

Title I Condition: To limit potential NOx emissions toless than the major source levels defined in 40 CFRSection 52.21; Minn. R. 7007.3000; Minn. R.7017.2020, subp. 1

Performance Test: due before end of each 60 months starting 10/26/2012 tomeasure opacity from one GP 011 generator that has not been previously testedfor opacity. If all GP 011 generators have been tested for opacity, test the generatorwith the least current opacity test.

Minn. R. 7017.2020, subp. 1


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-14

Subject Item: GP 012 Boilers


EU 002 Boiler #2

EU 003 Boiler #3

EU 004 Boiler #4

EU 005 Boiler #5

EU 044 Boiler #6

EU 045 Boiler #7


EMISSION LIMITS hdr

Total Particulate Matter: less than or equal to 0.4 lbs/million Btu heat input (appliesindividually to EU 001 through EU 005).

Minn. R. 7011.0515, subp. 1

Opacity: less than or equal to 20 percent opacity except for one six-minute periodper hour of not more than 60 percent opacity (applies individually to EU 001through EU 005).

Minn. R. 7011.0515, subp. 2

OPERATING LIMITS hdr

Permitted Fuels:

EU 001, EU 002, EU 003, and EU 004: Limited to natural gas, and refined animalfats (RAF)EU 005: natural gas onlyEU 044, and EU 045: natural gas and RAF

Minn. R. 7007.0800, subp. 2

RECORDKEEPING hdr

Seperately record and maintain records of the quantity of natural gas combusted byEU 044 and the quantity of natural gas combusted by EU 045, on a monthly basis.

40 CFR Section 60.48c(g)

Recordkeeping - Fuel Usage: Once each day calculate and record the GP 012usage of natural gas (cubic feet), and RAF usage in EU 001, EU 002, EU 003, andEU 004 (gallons), and the RAF usage in EU 044 and EU 045 (gallons), during theprevious calendar day.

By the 15th day of each month, calculate and record the GP 012 usage of naturalgas (cubic feet), and RAF usage in EU 001, EU 002, EU 003, and EU 004(gallons), and the RAF usage in EU 044 and EU 045 (gallons), during the previouscalendar month.

Title I Condition: To limit potential SO2 and NOxemissions to less than major source levels defined by40 CFR Section 52.21; Minn. R. 7007.3000; Minn. R.7007.0800, subp. 4 and 5

Sulfur Dioxide Emissions Monitoring: By the 15th day of each month the Permitteeshall calculate and record the tons of SO2 emitted during the previous calendarmonth from the GP 012 combustion of RAF, using the following equation:

SO2 = (0.157CZ)/2000

where:

SO2 = GP 012 sulfur dioxide emissions during the previous month (tons)C = GP 012 gallons of refined animal fat burned during the previous monthZ = weight percent of sulfur in RAF burned the previous month

Minn. R. 7007.0800, subp. 4 and 5

Nitrogen Oxides Emissions Monitoring: By the 15th day of each month thePermittee shall calculate and record the tons of NOx emitted from GP 012 duringthe previous calendar month using the following equation:

NOx = (X1B1 + X2B2 + 0.0001C)/2000

where:

NOx = GP 012 nitrogen oxides emissions during the previous month (tons)B1 = GP 012 gallons of RAF burned during the previous month in EU 001 - 004B2 = GP 012 gallons of RAF burned during the previous month in EU 044 & 045X1 = NOx emission factor in lb of NOx/gallon of RAF from most recent test whilecombusting RAF in EU 001 - 004X2 = NOx emission factor in lb of NOx/gallon of RAF from most recent test whilecombusting RAF in EU 044 & 045 (if RAF NOx emission testing data is notavailable, X1 and/or X2 shall be 0.0366 lb/gal)C = GP 012 cubic feet of natural gas combusted during the previous month

Minn. R. 7007.0800, subp. 4 and 5


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-15

PERFORMANCE TESTING AND ANALYSIS hdr

RAF Sulfur Content: Perform an analysis during each 12-month period followingpermit issuance to determine weight percent sulfur content in RAF using EPAMethod 6A. The first analysis shall be performed within 180 days of permitissuance.

Title I Condition: To limit potential SO2 emissions toless than major source levels defined by 40 CFRSection 52.21; Minn. R. 7007.3000

Performance Test: due before end of each calendar 60 months starting 09/15/2002to measure NOx emissions while combusting only RAF in either EU 001, EU 002,EU 003, or EU 004. Testing is required only if a total of more than 500,000 gallonsof RAF has been combusted in EU 001 through EU 004 during the 60-month periodstarting 09/15/2002.


Performance Test: due 180 days after Initial Startup of RAF combustion in EU 044and/or EU 045, to measure NOx emissions. Testing shall be conducted whencombusting only RAF, and on either EU 044 or EU 045.



09900002 - 011

Facility Name:

Permit Number:

07/08/13A-16

Subject Item: GP 014 Refined Products Makeup Air Units

Associated Items: EU 092 Refined Products MAU 1

EU 093 Refined Products MAU 2


SV 062 Refined Products MAU 1 Stack




EMISSION LIMITS hdr

Total Particulate Matter: less than or equal to 0.4 lbs/million Btu heat input . Thenatural gas fuel restriction for these units constitutes compliance with this limit.

Minn. R. 7011.0515, subp. 1

Opacity: less than or equal to 20 percent opacity except for one six-minute periodper hour of not more than 60 percent opacity.

Minn. R. 7011.0515, subp. 2

Fuel Restriction: Units in this group are permitted to fire natural gas only. Minn. R. 7007.0800, subp. 2


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-17

Subject Item: SV 058 Regenerative Thermal Oxidizer (CE 026)

Associated Items: EU 028 Rendering Machinery



EU 087 Regenerative Thermal Oxidizer (CE 026)

EU 088 Refined Products Machinery

GP 010 Blood and Bone Meal Dryers

MR 001 CE 026/EU 087 Combustion Chamber Temperature


EMISSION LIMITS (The following limits apply prior to startup of EU 088) hdr

Total Particulate Matter: less than or equal to 6.37 lbs/hour for SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000;meets requirements of Minn. R. 7011.0610, subp.1(A)(1) and Minn. R. 7011.0715, subp. 1.A

PM < 10 micron: less than or equal to 6.37 lbs/hour for SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

PM < 2.5 micron: less than or equal to 6.37 lbs/hour from SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

Volatile Organic Compounds: less than or equal to 6.37 lbs/hour for SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

Opacity: less than or equal to 20 percent opacity for SV 058. Minn. R. 7011.0715, subp. 1.B; meets requirements ofMinn. R. 7011.0610, subp. 1(A)(2)

EMISSION LIMITS (The following limits apply after startup of EU 088) hdr

Total Particulate Matter: less than or equal to 1.22 lbs/hour for SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000; meets requirements of Minn. R.7011.0610, subp. 1(A)(1) and Minn. R. 7011.0715,subp. 1.A

PM < 10 micron: less than or equal to 1.15 lbs/hour for SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

PM < 2.5 micron: less than or equal to 1.41 lbs/hour from SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

Volatile Organic Compounds: less than or equal to 0.99 lbs/hour for SV 058. Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

Opacity: less than or equal to 20 percent opacity for SV058. Minn. R. 7011.0715, subp. 1.B; meets requirements ofMinn. R. 7011.0610, subp. 1(A)(2)


Vent all CE 009 (EU 028) and CE 018 (EU 036 and EU 050) emissions through CE026.

Venting of CE 009 (EU 028) emissions through CE 026 applies until startup of EU088.


CE 026 CONTROL EQUIPMENT REQUIREMENTS hdr

The Permittee shall operate and maintain CE 026 to achieve a total controlefficiency for Total Particulate Matter: greater than or equal to 62 percent controlefficiency

Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

The Permittee shall operate and maintain CE 026 to achieve a total controlefficiency for PM < 10 micron: greater than or equal to 62 percent control efficiency


The Permittee shall operate and maintain CE 026 to achieve a total controlefficiency for PM < 2.5 micron: greater than or equal to 62 percent control efficiency



09900002 - 011

Facility Name:

Permit Number:

07/08/13A-18

The Permittee shall operate and maintain CE 026 to achieve a total controlefficiency for Volatile Organic Compounds: greater than or equal to 97 percentcontrol efficiency



Minn. R. 7007.0800, subp. 14

CE 026 Combustion Chamber Temperature: greater than or equal to 1350 F on a3-hour rolling average, unless a new minimum is set pursuant to Minn. R.7017.2025, subp. 3, based on the values recorded during the most recentMPCA-approved performance test where compliance was demonstrated. The newminimum shall be implemented upon receipt of the Notice of Compliance lettergranting preliminary approval. The minimum is final upon issuance of a permitamendment incorporating the change.



Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring CE 026 combustion chamber temperature, asrequired by this permit. The monitoring equipment must be installed, in use, andproperly maintained when CE 026 is in operation.

40 CFR Section 64.7(b); Minn. R. 7017.0200

CE 026 Temperature Monitoring and Recordkeeping: The Permittee shall operateand maintain a continuous CE 026 combustion chamber temperature monitor andcontinuously record the combustion chamber temperature. The temperaturemonitoring device shall have a margin of error less than the greater of +/- 0.75percent of the temperature being measured or +/- 2.5 degrees Celsius (4.5 degreesFahrenheit).

The Permittee shall maintain a hard copy readout or computer disk file of thetemperature readings for the RTO combustion chamber including the calculated3-hour rolling average temperature values. The Permittee shall verify once eachshift, not to exceed 12 hours, if all observed 3-hour rolling average temperaturereadings were at or above the minimum specified in this permit. Recorded valuesbelow the minimum specified in this permit are considered deviations as defined byMinn. R. 7007.0100, subp. 8a.

Title I Condition: To avoid classification as a majorsource and modification under 40 CFR Section 52.21and Minn. R. 7007.3000; Minn. R. 7007.0800, subps. 4& 5; 40 CFR Section 64.3; Minn. R. 7017.0200

Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of CE 026. The CE026 burner may be inspected annually. The Permittee shall maintain a writtenrecord of the results of each inspection.

40 CFR Section 64.3; Minn. R. 7017.0200


- the 3-hour rolling average combustion chamber temperature is below the requiredminimum;- the RTO or any of its components are found during any inspection to need repair.

Corrective actions shall return the combustion chamber temperature to at or abovethe required minimum, and/or include completion of necessary repairs identifiedduring the inspection, as applicable. Corrective actions include, but are not limitedto, those outlined in the O & M Plan for CE 026. The Permittee shall keep a recordof the type and date of any corrective action taken.

40 CFR Section 64.7(d); Minn. R. 7017.0200

The Permittee shall calibrate or replace the CE 026 temperature gauge at leastonce every 12 months and shall maintain a written record of any action resultingfrom the calibration or replacement.


Documentation of Need for Improved Monitoring: If the Permittee fails to achievecompliance with an emission limitation or standard for which the monitoring did notprovide an indication of an excursion or exceedance while providing valid data, orthe results of compliance or performance testing document a need to modify theexisting required minimum CE 026 combustion chamber temperature, thePermittee shall promptly notify the MPCA and, if necessary, submit a permitamendment application to address the necessary monitoring change.

40 CFR Section 64.7(e); Minn. R. 7017.0200


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-19

As required by 40 CFR Section 64.9(a)(2), for the Semi-Annual Deviations Reportlisted in Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permittee shall include the following related to the monitoringidentified as required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable, and the corrective action taken; and

2) Summary information on the number, duration, and cause for monitor downtimeincidents.

40 CFR Section 64.9(a)(2); Minn. R. 7017.0200

The Permittee shall maintain records of monitoring data, monitor performance data,corrective actions taken, and other supporting information required to bemaintained for five (5) years. The Permittee may maintain records on alternativemedia, such as microfilm, computer files, magnetic tape disks, or microfiche,provided that the use of such alternative media allows for expeditious inspectionand review, and does not conflict with other applicable recordkeeping requirements.



Initial Performance Test: due 180 days after Initial Startup of CE 026/EU 087(regenerative thermal oxidizer) to measure PM2.5 emissions.

Minn. R. 7017.2020, subp. 1

Initial Performance Test: due 180 days after Initial Startup of CE 026/EU 087(regenerative thermal oxidizer) to measure PM emissions (including condensables).

Minn. R. 7017.2020, subp. 1

Initial Performance Test: due 180 days after Initial Startup of EU 088 to measurePM emissions.

Minn. R. 7017.2020, subp. 1

Initial Performance Test: due 180 days after Initial Startup of EU 088 to measurePM10 emissions.

Minn. R. 7017.2020, subp. 1

Initial Performance Test: due 180 days after Initial Startup of EU 088 to measurePM2.5 emissions.

Minn. R. 7017.2020, subp. 1

Initial Performance Test: due 180 days after Initial Startup of EU 088 to measureVOC emissions.

Minn. R. 7017.2020, subp. 1


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-20

Subject Item: SV 059 Crax Room Air Stack (CE 029 & CE 030)

Associated Items: EU 089 Crax Room Air

EU 090 Truck Loadout Room Air


EMISSION LIMITS hdr

Total Particulate Matter: less than or equal to 2.68 lbs/hour Title I Condition: To avoid major source classificationunder 40 CFR Section 52.21 and Minn. R. 7007.3000;meets requirements of Minn. R. 7011.0715, subp. 1(A)

PM < 10 micron: less than or equal to 2.68 lbs/hour Title I Condition: To avoid major source classificationunder 40 CFR Section 52.21 and Minn. R. 7007.3000

PM < 2.5 micron: less than or equal to 2.68 lbs/hour Title I Condition: To avoid major source classificationunder 40 CFR Section 52.21 and Minn. R. 7007.3000

Opacity: less than or equal to 20 percent opacity Minn. R. 7011.0715, subp. 1(B)

OPERATING REQUIREMENTS FOR CE 029 AND CE 030 hdr

The Permittee shall operate and maintain the venturi scrubber (CE 029) andpacked gas adsorption column (CE 030) at all times that EU 089 is in operation.The Permittee shall document periods of non-operation of the control equipment.

Vent all emissions from EU 089 through CE 029 and CE 030.

Title I Condition: To avoid major source classificationunder 40 CFR Section 52.21 and Minn. R. 7007.3000;Minn. R. 7007.0800, subps. 2 and 14

The Permittee shall operate and maintain the packed gas adsorption column (CE030) at all times that EU 090 is in operation. The Permittee shall document periodsof non-operation of the control equipment.

Vent all emissions from EU 090 through CE 030.


CONTROL EQUIPMENT REQUIREMENTS FOR CE 029 AND CE 030 hdr

The Permittee shall operate and maintain CE 029 so it achieves a control efficiencyfor Total Particulate Matter: greater than or equal to 94 percent control efficiency


The Permittee shall operate and maintain CE 029 so it achieves a control efficiencyfor PM < 10 micron: greater than or equal to 84 percent control efficiency

Title I Condition: To avoid major source classificationunder 40 CFR Section 52.21 and MInn. R. 7007.3000;Minn. R. 7007.0800, subps. 2 and 14





The Permittee shall operate and maintain CE 029 and CE 030 in accordance withthe Operation and Maintenance (O&M) Plan. The Permittee shall keep copies ofthe O&M Plan available onsite for use by staff and MPCA staff.

Minn. R. 7007.0800, subp. 14

Pressure Drop: greater than or equal to 4.0 inches of water column for CE 029unless a new minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based onvalues recorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.


Water flow rate: greater than or equal to 100 gallons/minute for CE 029 unless anew minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.





09900002 - 011

Facility Name:

Permit Number:

07/08/13A-21



MONITORING AND RECORDKEEPING FOR CE 029 AND CE 030 hdr

Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for CE 029 and CE 030, as required by this permit. The monitoring equipmentmust be installed, in use, and properly maintained when CE 029 and CE 030 are inoperation.


Daily Inspections: Once each calendar day when EU 089 is operating, thePermittee shall read and record the following:

1) the CE 029 pressure drop in inches of water column;2) the CE 029 water flow rate in gallons per minute.

Title I Condition: To avoid major source classificationunder 40 CFR Section 52.21 and Minn. R. 7007.3000;40 CFR Section 64.3; Minn. R. 7017.0200; Minn. R.7007.0800, subps. 2 and 14

Daily Inspections: Once each calendar day when either EU 089 or EU 090 isoperating, the Permittee shall read and record the following:



Recordkeeping of Pressure Drop and Water Flow Rate for CE 029 and CE 030:The Permittee shall record the time and date of each pressure drop reading andwater flow rate reading, and whether or not the observed value was within therange specified in this permit. Recorded values outside the range specified in thispermit are considered deviations as defined by Minn. R. 7007.0100, subp. 8a.


Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of CE 029 and CE030. The Permittee shall maintain a written record of the results of each inspection.



1) The pressure drop is below the required minimum;2) The water flow rate is below the permitted minimum; or3) The scrubber or any of its components are found during any inspection to needrepair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O&M Plan for CE 029 and CE030. The Permittee shall keep a record of the type and date of any corrective actiontaken.


The Permittee shall calibrate or replace the CE 029 and CE 030 pressure drop andflow rate monitors at least annually and shall maintain a written record of any actionresulting from the calibration or replacement.


Documentation of Need for Improved Monitoring: If the Permittee fails to achievecompliance with an emission limitation or standard for which the monitoring did notprovide an indication of an excursion or exceedance while providing valid data, orthe results of compliance or performance testing document a need to modify theexisting pressure drop range, the Permittee shall promptly notify the MPCA and, ifnecessary, submit a permit amendment application to address the necessarymonitoring change.


As required by 40 CFR Section 64.9(a)(2), for the Semiannual Deviations Reportlisted in Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permittee shall include the following related to the monitoringidentifiedas required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable, and the corrective action taken; and2) Summary information on the number, duration, and cause for monitor downtimeincidents.



09900002 - 011

Facility Name:

Permit Number:

07/08/13A-22



NOTIFICATION REQUIREMENTS(See Table B)

hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-23

Subject Item: EU 027 Rendering Room Air

Associated Items: CE 008 Packed-Gas Adsorption Column

SV 026 Rendering Room Air Packed Tower Scrubber Stack


EMISSION LIMITS hdr

Total Particulate Matter: less than or equal to 8.38 lbs/hour Title I Condition: To limit potential PM emissions toless than major source levels as defined by 40 CFR52.21; Minn. R. 7007.3000; meets requirements ofMinn. R. 7011.0715, subp. 1(A)

Particulate Matter < 10 micron: less than or equal to 8.38 lbs/hour Title I Condition: To limit potential PM10 emissions toless than major source levels as defined by 40 CFR52.21; Minn. R. 7007.3000



The Permittee shall operate and maintain the packed tower A (CE 008) at all timesthat the process equipment (EU 028 rendering machinery that emits EU 027rendering room air emissions) controlled by CE 008 is in operation. The Permitteeshall document periods of non-operation of the control equipment.



CE 008 (TOWER A) CONTROL EQUIPMENT REQUIREMENTS hdr






Minn. R. 7007.0800, subp. 14

CE 008 Pressure Differential: Greater than or equal to 5 inches w.c., unless a newminimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.


CE 008 Water Flow Rate: Greater than or equal to 100 gallons per minute, unless anew minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.






1. the CE 008 pressure differential; 2. the CE 008 water flow rate.

Title I Condition: To avoid classification as a majorsource and modification under 40 CFR Section 52.21and Minn. R. 7007.3000; Minn. R. 7007.0800, subps. 2and 14; 40 CFR Section 64.3; Minn. R. 7017.0200

Recordkeeping of Pressure Drop and Water Flow Rate: The Permittee shall recordthe time and date of each pressure drop reading and water flow rate reading, andwhether or not the observed value was within the range specified in this permit.Recorded values outside the range specified in this permit are considereddeviations as defined by Minn. R. 7007.0100, subp. 8a.





09900002 - 011

Facility Name:

Permit Number:

07/08/13A-24


- the pressure drop is below the required minimum;- the water flow rate is below the permitted minimum; or- the scrubber or any of its components are found during any inspection to needrepair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O & M Plan for CE 008. ThePermittee shall keep a record of the type and date of any corrective action taken.












SHUTDOWN REQUIREMENTS hdr

Shutdown: due 180 days after Initial Startup of EU 088. The conditions in the permitapplicable to EU 027 and associated items remains effective until permanentshutdown of EU 027 occurs.

Minn. R. 7007.0800, subp. 2


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-25

Subject Item: EU 028 Rendering Machinery


CE 009 Venturi Scrubber





SV 027 Rendering Cooker Stack



Subject Item EU 028 contains requirements applicable either:



Prior to CE 026 startup, EU 028 emissions will vent to CE 009, CE 022, and CE023 and then either vented to the atmosphere through SV 027, or routed to CE 008and then vented to the atmosphere through SV 026.

After CE 026 startup, EU 028 emissions will be vented to CE 009 and then to CE026 and then to the atmosphere through SV 058, and CE 022 and CE 023 will beshutdown.

hdr

EMISSION LIMITS - APPLY BEFORE AND AFTER CE 026 STARTUP


hdr



Minn. R. 7011.0715, subp. 1(A)

Opacity: less than or equal to 20 percent opacity .


Minn. R. 7011.0715, subp. 1(B)

OPERATING REQUIREMENTS - APPLY AFTER CE 026 STARTUP hdr

The Permittee shall operate and maintain the venturi scrubber (CE 009) at all timesthat the process equipment (EU 028 rendering machinery) controlled by CE 009 isin operation. The Permittee shall document periods of non-operation of the controlequipment.

Vent all emissions from Rendering Machinery through CE 009, CE 026 (RTO), andthen through SV 058. After CE 026 startup, the Permittee shall not route EU 028emissions through CE 022 and CE 023.


CONTROL EQUIPMENT REQUIREMENTS - APPLY AFTER CE 026 STARTUP

Refer to SV 058 for CE 026 applicable requirements

hdr






Minn. R. 7007.0800, subps. 2 and 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-26

CE 009 Pressure Differential: Greater than or equal to 5 inches w.c. Title I Condition: To avoid classification as a majorsource and modification under 40 CFR Section 52.21and Minn. R. 7007.3000; Minn. R. 7007.0800, subps. 2and 14

CE 009 Water Flow Rate: Greater than or equal to 50 gallons per minute. Title I Condition: To avoid classification as a majorsource and modification under 40 CFR Section 52.21and Minn. R. 7007.3000; Minn. R. 7007.0800, subps. 2and 14

MONITORING AND RECORDKEEPING - APPLY AFTER CE 026 STARTUP hdr





Title I Condition: To avoid classification as a majorsource and modification under 40 CFR Section 52.21and Minn. R. 7007.3000; Minn. R. 7007.0800, subps. 2and 14; 40 CFR Section 64.3; Minn. R. 7017.0200

Recordkeeping of CE 009 Pressure Drop and Water Flow Rate: The Permitteeshall record the time and date of each pressure drop reading and water flow ratereading, and whether or not the observed value was within the range specified inthis permit. Recorded values outside the range specified in this permit areconsidered deviations as defined by Minn. R. 7007.0100, subp. 8a.





- the CE 009 pressure drop is below the required minimum;- the CE 009 water flow rate is below the permitted minimum; or- CE 009 or any of its components are found during any inspection to need repair.













EMISSION LIMITS - APPLY ONLY BEFORE CE 026 STARTUP hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-27

Total Particulate Matter: less than or equal to 7.34 lbs/hour for SV 027. This limitapplies when EU 028 emissions are controlled by CE 009 (venturi scrubber), CE022 (Tower B), and CE 023 (Tower C) and vented through SV 027 (renderingprocess equipment bypass stack). See EU 027 for applicable limit when EU 028emissions are controlled by CE 009 & CE 008 (Tower A) and vented through SV026 (main stack).

Title I Condition: To limit potential PM emissions toless than major source levels as defined by 40 CFR52.21; Minn. R. 7007.3000; meets requirements ofMinn. R. 7011.0715, subp. 1(A)

PM < 10 micron: less than or equal to 7.34 lbs/hour for SV 027. This limit applieswhen EU 028 emissions are controlled by CE 009 (venturi scrubber), CE 022(Tower B), and CE 023 (Tower C) and vented through SV 027 (rendering processequipment bypass stack). See EU 027 for applicable limit when EU 028 emissionsare controlled by CE 009 & CE 008 (Tower A) and vented through SV 026 (mainstack).

Title I Condition: To limit potential PM emissions toless than major source levels as defined by 40 CFR52.21; Minn. R. 7007.3000

OPERATING REQUIREMENTS - APPLY ONLY BEFORE CE 026 STARTUP hdr

Vent all emissions from Rendering Machinery through CE 009 (venturi scrubber),and then CE 022 (Tower B) and CE 023 (Tower C). After CE 023 the Permittee hasthe option of routing emissions to CE 008 (Tower A) and then through SV 026, orbypass CE 008 and vent from CE 023 through SV 027.

Minn. R. 7007.0800, subp. 2

CE 009 (VENTURI SCRUBBER), CE 022 (TOWER B), AND CE 023 (TOWER C)CONTROL EQUIPMENT REQUIREMENTS - APPLY BEFORE CE 026 STARTUP

hdr









The Permittee shall operate and maintain CE 009, CE 022, and CE 023 inaccordance with the Operation and Maintenance (O & M) Plan. The Permittee shallkeep copies of the O & M Plan available onsite for use by staff and MPCA staff.

Minn. R. 7007.0800, subp. 14

Monitoring Equipment: The Permittee shall maintain the necessary monitoringequipment for measuring and recording pressure drop and water flow rate asrequired by this permit. The monitoring equipment must be installed, in use, andproperly maintained when CE 009, CE 022, and CE 023 are in operation.

Minn. R. 7007.0800, subp. 4

CE 009, CE 022, and CE 023 Pressure Differential: Less than 5 inches wc for CE022, less than 5 inches wc for CE 023, and not less than 5 inches wc for CE 009.

Minn. R. 7007.0800, subp. 14

CE 009, CE 022, and CE 023 Water Flow Rate: Not less than 20 gallons perminute for CE 022, not less than 30 gallons per minute for CE 023, and not lessthan 50 gallons per minute for CE 009.

Minn. R. 7007.0800, subp. 14

CE 009, CE 022, and CE 023 Daily Monitoring: Once each day of operation, thePermittee shall monitor and record the pressure differential and water flow rate forCE 009, CE 022, and CE 023.

Minn. R. 7007.0800, subp. 4 and 5


Minn. R. 7007.0800, subp. 4, 5, and 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-28




Minn. R. 7007.0800, subp. 4, 5, and 14

SHUTDOWN REQUIREMENTS hdr

Shutdown: due 180 days after Initial Startup of EU 088. The conditions in the permitapplicable to EU 028 and associated items remains effective until permanentshutdown of EU 028 occurs.

Minn. R. 7007.0800, subp. 2


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-29

Subject Item: EU 051 Emergency RICE(s)

Associated Items: GP 001 SO2 and NOx Limits

SV 044 Emergency RICE(s) (EU 051)


LIMITS AND OPERATING REQUIREMENTS hdr

Operating Hours: less than or equal to 500 hours/year using 12-month Rolling Sumas a total for all emergency RICE.

Minn. R. 7007.0800, subp. 2 and September 6, 1995,U.S. EPA memorandum entitled "Calculating Potentialto Emit for Emergency Generators"

Sulfur Dioxide: less than or equal to 0.5 lbs/million Btu heat input Minn. R. 7011.2300, subp. 2

Opacity: less than or equal to 20 percent opacity once operating temperatures havebeen attained.

Minn. R. 7011.2300, subp. 1

Emergency Reciprocating Internal Combustion Engine (RICE) Operation: ThePermittee is authorized to operate temporary or permanent emergency RICE at thefacility, providing the total horsepower of all emergency RICE does not exceed 599hp on a calendar-day basis, and any single engine does not exceed 500 hp.

Minn. R. 7007.0800, subp. 2

Permitted Fuels: gasoline, diesel fuel, natural gas, kerosene/naphtha, butane,liquified petroleum gases (LPG), or propane.

Minn. R. 7007.0800, subp. 2

Operation of Emergency RICE(s): The EU 051 Emergency RICE(s) shall onlyoperate under emergency situations. An emergency RICE is a reciprocatinginternal combustion engine which only operates when no other mechanical powersource is available to meet life safety and temporary production requirements, andoperates for necessary routine periodic equipment testing. Life safety andtemporary production requirements do not occur during routine operation orproduction and are circumstances demanding power to avoid death, illness, injury,or damage to process equipment or product.

An emergency RICE is a power source used to generate electricity, pump water orother liquids, or other application. Emergency RICE does not include RICE electricgenerators operated by an electric customer during periods of intentional electricservice disruption by the electric service provider or a RICE used as a substitute foranother power source that is undergoing scheduled maintenance.

Minn. R. 7007.0800, subp. 2

RECORDKEEPING hdr

Recordkeeping: For each emergency RICE that is operated at the facility, thePermittee shall record the arrival and departure date of the engine.

Once each day, the Permittee shall record in a log the serial number, model,manufacturer, horsepower rating and hours of operation of each emergency RICEthat operated at the facility during the previous calendar day. If no emergencyRICE were operated, the log shall indicate this.

By the 15th day of each month, the Permittee shall calculate and record the totalemergency RICE operating hours for the previous month, and the previous12-month period.

Minn. R. 7007.0800, subp. 4 and 5

Diesel Fuel Supplier Certification: For each delivery of diesel fuel, the Permitteeshall obtain a supplier certification that either states the actual sulfur content inpercent by weight in the diesel fuel, or guarantees that the sulfur content does notexceed 0.0015 percent by weight.

Minn. R. 7007.0800, subp. 4 and 5

Recordkeeping - Fuel Usage: Once each day calculate and record the EU 051usage of gasoline (gallons), diesel fuel (gallons), natural gas (cubic feet),kerosene/naphtha (gallons), butane (gallons), liquified petroleum gases (LPG)(gallons), or propane (gallons) during the previous calendar day.

By the 15th day of each month, calculate and record the EU 051 usage of gasoline(gallons), diesel fuel (gallons), natural gas (cubic feet), kerosene/naphtha (gallons),butane (gallons), liquified petroleum gases (LPG) (gallons), or propane (gallons)during the previous calendar month. The Permittee shall convert and record themonthly fuel usage from a volume basis, to a heat input basis according to theprocedure in the appendix.

Title I Condition: To limit potential NOx emissions toless than major source levels defined by 40 CFRSection 52.21; Minn. R. 7007.3000; Minn. R.7007.0800, subp. 4 and 5


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-30

Nitrogen Oxides Emissions Monitoring: By the 15th day of each month thePermittee shall:

1) Calculate and record EU 051 NOx emissions during the previous calendarmonth using the following equation:

NOx = (Fa * Ha) + (Fb * Hb) + (Fc * Hc) + (Fd * Hd) + (Fe * He) + (Ff * Hf)

(continued)

Minn. R. 7007.0800, subp. 4 and 5

where:NOx = EU 051 pounds NOx/monthFa = diesel fuel emission factorHa = diesel fuel heat inputFb = natural gas emission factorHb = natural gas heat inputFc = gasoline emission factorHc = gasoline heat inputFd = propane/liquified petroleum gases (LPG) emission factorHd = propane/liquified petroleum gases (LPG) heat inputFe = kerosene/naphtha emission factorHe = kerosene/naphtha heat inputFf = butane emission factorHf = butane heat input

All heat inputs are in units of mmBtu per month and determined according to theprocedure in the appendix. Emission factors (lb/mmBtu) are listed in the appendix,or obtained from the current version of AP-42 or the current MPCA emissioncalculation form for internal combustion engines, if more current than the appendix.

Minn. R. 7007.0800, subp. 4 and 5


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-31

Subject Item: EU 087 Regenerative Thermal Oxidizer (CE 026)

Associated Items: SV 058 Regenerative Thermal Oxidizer (CE 026)



Minn. R. 7011.0610, subp. 1(A)(1)

Opacity: less than or equal to 20 percent opacity except for one six-minute periodper hour of not more than 60 percent opacity.

Minn. R. 7011.0610, subp. 1(A)(2)

Permitted fuel: natural gas only. Combustion of only natural gas ensurescompliance with Minn. R. 7011.0715, subp. 1.A.

Minn. R. 7007.0800, subp. 2


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-32

Subject Item: EU 088 Refined Products Machinery

Associated Items: CE 026 Thermal Oxidizer





EMISSION LIMITS hdr

Total Particulate Matter: less than or equal to 0.97 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000; meets requirements of Minn. R.7011.0715, subp. 1(A)

PM < 10 micron: less than or equal to 0.97 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

PM < 2.5 micron: less than or equal to 0.97 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

Volatile Organic Compounds: less than or equal to 0.97 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000



The Permittee shall operate and maintain the venturi scrubber (CE 027), thepacked-gas adsorption column (CE 028), and the RTO (CE 026) at all times thatEU 088 is in operation. The Permittee shall document periods of non-operation ofthe control equipment.

Vent all emissions from Rendering Machinery through CE 027, CE 028, CE 026(RTO), and then through SV 058.

Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800, subps. 2 and 14

CONTROL EQUIPMENT REQUIREMENTS(See SV 058 for CE 026 Requirements)

hdr

The Permittee shall operate and maintain CE 027 so it achieves a total controlefficeincy for Total Particulate Matter: greater than or equal to 94 percent controlefficiency

Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21and Minn. R.7007.3000; Minn. R. 7007.0800, subps. 2 and 14

The Permittee shall operate and maintain CE 027 so it achieves a total controlefficency for PM < 10 micron: greater than or equal to 84 percent control efficiency


The Permittee shall operate and maintain CE 027 in accordance with the Operationand Maintenance (O&M) Plan. The Permittee shall keep copies of the O&M Planavailable onsite for use by staff and MPCA staff.

Minn. R. 7007.0800, subps. 2 and 14

Pressure Drop: greater than or equal to 4.0 inches of water column for CE 027,unless a new minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based onthe values recorded during the most recent MPCA-approved performance testwhere compliance was demonstrated. The new minimum shall be implementedupon receipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.


Water flow rate: greater than or equal to 50.0 gallons/minute for CE 027, unless anew minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.


The Permittee shall operate and maintain CE 028 so it achieves a total controlefficiency for Total Particulate Matter: greater than or equal to 85 percent controlefficiency


The Permittee shall operate and maintain CE 028 so it achieves a total controlefficiency for PM < 10 micron: greater than or equal to 84 percent control efficiency



Minn. R. 7007.0800, subps. 2 and 14


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-33









1) Pressure drop for CE 027 and CE 028 in inches of water column;2) Water flow rate for CE 027 and CE 028 in gallons per minute.

Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000; 40 CFR Section 64.3; Minn. R. 7017.0200;Minn. R. 7007.0800, subps. 2 and 14

Pressure Drop and Water Flow Rate Recordkeeping for CE 027 and CE 028: ThePermittee shall record the time and date of each pressure drop reading and waterflow rate reading, and whether or not the observed value was within the rangespecified in this permit. Recorded values outside the range specified in this permitare considered deviations as defined by Minn. R. 7007.0100, subp. 8a.


Periodic Inspections: Once per calendar quarter, or at a frequency predescribed bythe manufacturer, the Permittee shall inspect the components of CE 027 and CE028. The Permittee shall maintain a written record of the results of each inspection.


Corrective Actions: The Permittee shall take corrective actions as soon as possibleif any of the following occur:

1) The CE 027 or CE 028 pressure drop is below the required minimum;2) The CE 027 or CE 028 water flow rate is below the permitted minimum; or3) CE 027 or CE 028 or any of their components are found during any inspection inneed of repair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O&M Plan for CE 027 and CE028. The Permittee shall keep a record of the type and date of any correctiveactions taken.


The Permittee shall calibrate or replace the CE 027 and CE 028 pressure drop andwater flow rate monitors at least annually and shall maintain a written record of anyaction resulting from the calibration or replacement.


Documentation of Need for Improved Monitoring: If the Permittee fails to achievecompliance with an emission limitation or standard for which the monitoring did notprovide an indication of an excursion or exceedance while providing valid data, orthe results of compliance or performance testing document a need to modify theexisting pressure drop range, the Permitte shall promptly notify the MPCA and, ifnecessary, submit a permit amendment application to address the necessarymonitoring change.


As required by 40 CFR Section 64.9(a)(2), for the Semiannual Deviations Reportlisted in Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permittee shall include the following related to the monitoringidentified as required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable and the corrective actions taken; and2) Summary information on the number, duration, and cause for monitor downtimeincidents.



09900002 - 011

Facility Name:

Permit Number:

07/08/13A-34




hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-35

Subject Item: EU 091 Refined Products Room Air


SV 060 Refined Products Room Air Stack #1



EMISSION LIMITS hdr

Total Particulate Matter: less than or equal to 8.38 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000; meets requirements of Minn. R.7011.0715, subp. 1(A)

PM < 10 micron: less than or equal to 8.38 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000

PM < 2.5 micron: less than or equal to 8.38 lbs/hour Title I Condition: To avoid classification as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000



The Permittee shall operate and maintain the packed-gas adsorption column (CE031) at all times that EU 091 is in operation. The Permittee shall document periodsof non-operation of the control equipment.



CONTROL EQUIPMENT REQUIREMENTS hdr






Minn. R. 7007.0800, subps. 2 and 14



Water flow rate: greater than or equal to 1000 gallons/minute for CE 031, unless anew minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.






1) Pressure drop for CE 031 in inches of water column;2) Water flow rate for CE 031 in gallons per minute.


Recordkeeping of Pressure Drop and Water Flow Rate for CE 031: The Permitteeshall record the time and date of each pressure drop reading and water flow ratereading, and whether or not the observed value was within the range specified inthis permit. Recorded values outside the range specified in this permit areconsidered deviations as defined by Minn. R. 7007.0100, subp. 8a.

Title I Condition: To avoid classifcation as a majorsource under 40 CFR Section 52.21 and Minn. R.7007.3000; 40 CFR Section 64.3; Minn. R. 7017.0200;Minn. R. 7007.0800, subps. 4 and 5


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-36



Corrective Actions: The Permittee shall take corrective action as soon as possiblein any of the following occur:

1) The CE 031 pressure drop is below the required minimum;2) The CE 031 water flow rate is below the permitted minimum; or3) The scrubber or any of its components are found during any inspection to be inneed of repair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O&M Plan for CE 031. ThePermittee shall keep a record of the type and date of any corrective actions taken.


The Permittee shall calibrate or replace the CE 031 pressure drop and flow ratemonitors at least annually and shall maintain a written record of any action resultingfrom the calibration or replacement.




As required by 40 CFR Section 64.9(a)(2), for the Semiannual Deviations Reportlisted iin Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permitte shall include the following related to the monitoringidentified as required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable, and the corrective actions taken; and2) Summary information on the number, duration, and cause for monitor downtimeincidents.





hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-37

Subject Item: EU 092 Refined Products MAU 1

Associated Items: GP 014 Refined Products Makeup Air Units




hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-38






hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-39






hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-40

Subject Item: CE 029 Venturi Scrubber



See SV 059 for applicable CE 029 requirements. hdr


09900002 - 011

Facility Name:

Permit Number:

07/08/13A-41

Subject Item: CE 030 Packed-Gas Adsorption Column




See SV 059 for applicable CE 030 requirements. hdr

TABLE B: SUBMITTALSFacility Name: Hormel Foods Corp/QPP - Austin

Permit Number: 09900002 - 011

07/08/13B-1

Also, where required by an applicable rule or permit condition, send to the Permit Document Coordinator notices of:- accumulated insignificant activities,- installation of control equipment,- replacement of an emissions unit, and- changes that contravene a permit term.

Send submittals that are required to be submitted to the U.S. EPA regional office to:

Chief Air Enforcement Air and Radiation Branch EPA Region V 77 West Jackson Boulevard Chicago, Illinois 60604

Each submittal must be postmarked or received by the date specified in the applicable Table. Those submittals required by parts7007.0100 to 7007.1850 must be certified by a responsible official, defined in Minn. R. 7007.0100, subp. 21. Other submittals shallbe certified as appropriate if certification is required by an applicable rule or permit condition.

Send submittals that are required by the Acid Rain Program to:

U.S. Environmental Protection Agency Clean Air Markets Division 1200 Pennsylvania Avenue NW (6204N) Washington, D.C. 20460

Send any application for a permit or permit amendment to:

Fiscal Services Minnesota Pollution Control Agency 520 Lafayette Road North St. Paul, Minnesota 55155-4194

Table B lists most of the submittals required by this permit. Please note that some submittal requirements may appear in Table Aor, if applicable, within a compliance schedule located in Table C. Table B is divided into two sections in order to separately listone-time only and recurrent submittal requirements.

Unless another person is identified in the applicable Table, send all other submittals to:

AQ Compliance Tracking Coordinator Industrial Division Minnesota Pollution Control Agency 520 Lafayette Road North St. Paul, Minnesota 55155-4194

TABLE B: ONE TIME SUBMITTALS OR NOTIFICATIONSFacility Name: Hormel Foods Corp/QPP - Austin


07/08/13B-2

What to send When to send Portion of Facility Affected

Application for Permit Reissuance due 180 days before expiration of ExistingPermit

Total Facility

Notification of the Actual Date of Initial Startup due 15 days after Initial Startup of CE 026/EU087 or 15 days after permit issuance,whichever is later. The notification shallspecify the date that fuel was first combustedby CE 026/EU 087.

SV058

Notification of the Actual Date of Initial Startup due 15 days after Initial Startup of EU 088. EU088

Notification of the Actual Date of Initial Startup due 15 days after Initial Startup of EU 089and EU 090.

SV059





Notification of the Date Construction Began due 30 days after Start Of Construction of EU088.

EU088

Notification of the Date Construction Began due 30 days after Start Of Construction of EU089 and EU 090.

SV059


EU091


EU092


EU093


EU094

Notification due 30 days after Shutdown of EU 027.Notification shall be postmarked within 30days of actual shutdown.

EU027

Notification due 30 days after Shutdown of EU 028.Notification shall be postmarked within 30days of actual shutdown.

EU028

Testing Frequency Plan due 60 days after Initial Performance Test forPM and PM2.5 emissions. The plan shallspecify a testing frequency based on the initialperformance test results for PM and PM2.5and MPCA guidance. Future performancetests at 12-month, 36-month, or 60-monthintervals, or as applicable, shall be requiredupon written approval of the test frequencyplan.

SV058

Testing Frequency Plan due 60 days after Initial Performance Test forPM, PM10, PM2.5 and VOC emissions. Theplan shall specify a testing frequency basedon the initial performance test results for PM,PM10, PM2.5 and VOC and MPCA guidance.Future performance tests at 12-, 36-, or60-month intervals, or as applicable, shall berequired upon written approval of the testfrequency plan.

SV058

TABLE B: ONE TIME SUBMITTALS OR NOTIFICATIONSFacility Name: Hormel Foods Corp/QPP - Austin


07/08/13B-3

Testing Frequency Plan due 60 days after Performance Test fordetermining opacity. The plan shall specify atesting frequency for opacity based on theopacity performance test (due 10/26/2017)data and MPCA guidance. Futureperformance tests based on 12-month,36-month, or 60-month intervals, or asapplicable, shall be required upon writtenapproval of the plan by the MPCA.

Future testing shall be conducted on a unit notpreviously tested. After testing all units,testing shall be conducted on the unit whoseprevious test is least current.

GP011

Testing Frequency Plan due 60 days after Performance Test fordetermining the NOx lb/hr emission factor.The plan shall specify a testing frequency forNOx based on the NOx emission factorperformance test (due 10/26/2015) data andMPCA guidance. Future performance testsbased on 12-month, 36-month, or 60-monthintervals, or as applicable, shall be requiredupon written approval of the plan by theMPCA.

Future testing shall be conducted on a unit notpreviously tested. After testing all units,testing shall be conducted on the unit whoseprevious test is least current.

GP011

TABLE B: RECURRENT SUBMITTALSFacility Name: Hormel Foods Corp/QPP - Austin


07/08/13B-4

What to send When to send Portion of Facility Affected

Semiannual Deviations Report due 30 days after end of each calendarhalf-year starting 08/05/1999 . The firstsemiannual report submitted by the Permitteeshall cover the calendar half-year in which thepermit is issued. The first report of eachcalendar year covers January 1 - June 30.The second report of each calendar yearcovers July 1 - December 31.

Total Facility

Compliance Certification due 31 days after end of each calendar yearstarting 08/05/1999 (for the previous calendaryear). The certification shall be submitted on aform approved by the Commissioner, both tothe Commissioner and to the US EPAregional office in Chicago. This report coversall deviations experienced during the calendaryear.

Total Facility

APPENDIX MATERIAL Facility Name: Hormel Foods Corp/QPP ‐ Austin Permit Number: 09900002‐011 1. EU 051 Nitrogen Oxides Emission Factors and Fuel Heat Contents

Fuel Type NOx Emission Factor (lb/mmBtu)

Fuel Heat Content

Gasoline 1.63 0.13 mmBtu/gallon

Diesel Fuel 4.41 0.137 mmBtu/gallon

Natural Gas 4.08 0.0105 mmBtu/cubic foot

Kerosene/naphtha 3.474 0.135 mmBtu/gallon

Propane/ Liquid Petroleum Gas 1.519 0.0915 mmBtu/gallon

Butane 1.355 0.1026 mmBtu/gallon

Conversion of Fuel Volume to Heat Input: Fv * Fh = Fuel Heat Input (mmBtu/month) Where: Fv = volume of fuel used (gallons or cubic feet per month) Fh = fuel heat content as listed above (mmBtu/gallon or mmBtu/cubic foot)

2. Insignificant Activities Required to be Listed

Minn. R. 7007.1300, subp.

Activity Applicable Minn. R. Standard

3.A Space Heaters ‐ N Holding Pen 2 @0.32 mmBtu/hr 7011.0515 PM and opacity

3.A. Shop Space Heater 0.75 mmBtu/hr 7011.0515 PM and opacity

3.A. Break Room Space Heater 0.125 mmBtu/hr 7011.0515 PM and opacity

3.E(1) 500 gallon gasoline tank at QPP

3.F Laundry units 2 @0.25 mmBtu/hr & 2 @0.20 mmBtu/hr

7011.0515 PM and opacity

3.H(3) 4 welding stations and several portable welders 7011.0715 PM and opacity

3.I Nine vacuum pump vents 7011.0715 PM and opacity

3.I GP Salt System 7011.0715 PM and opacity

3.I GP Sugar System 7011.0715 PM and opacity

3.I 12 smoked meat/prepared sausage ovens w/smoke flavor spray


3.I Precooked Bacon Oven Room Vent 7011.0715 PM and opacity

3.I Three vacuum pump vents 7011.0715 PM and opacity

3.I MP Salt System 7011.0715 PM and opacity

3.I 17 dry sausage ovens 7011.0715 PM and opacity

3.I Two vacuum pump vents 7011.0715 PM and opacity

3.I One 500 gallon diesel fuel tank @QPP

3.I One 200,000 gallon lard tank ‐ steam heated

Minn. R. 7007.1300, subp.

Activity Applicable Minn. R. Standard

3.I One 200,000 gallon tallow tank ‐ steam heated

3.I Five dehairing room vents

3.I KC‐7 MAH @2.16 mmBtu/hr 7011.0515 PM and opacity

3.I Kill Floor MAU @1.0 mmBtu/hr 7011.0515 PM and opacity

3.I Dessicant Air Handler @0.273 mmBtu/hr 7011.0515 PM and opacity

3.I RWO MAU @0.243 mmBtu/hr 7011.0515 PM and opacity

3.I Drench Cabinet MAU @0.21 mmBtu/hr 7011.0515 PM and opacity

3.I Pig Skin Salt System 7011.0715 PM and opacity

3.I Office boiler @0.396 mmBtu/hr 7011.0515 PM and opacity

3.I Rendering MAU @2.17 mmBtu/hr 7011.0515 PM and opacity

3.I Hog Hair Hydrolyzer 7011.0715 PM and opacity

3.I New Boiler Room MAU @1.361 mmBtu/hr 7011.0515 PM and opacity

3.I Natural Gas Standby Generator 7011.2300 SO2 and opacity

3.I Refined Products MAU 4 7011.0515 PM and opacity

3.I Refined Products Roof Top Unit 1 7011.0515 PM and opacity

3.I Refined Products Roof Top Unit 2 7011.0515 PM and opacity

3.I Refined Products Energy Recovery Ventilator 1 7011.0515 PM and opacity

3.I Refined Products Energy Recovery Ventilator 2 7011.0515 PM and opacity

4 Three vapor smoke generators 7011.0715 PM and opacity

4 Old Boiler Room MAU @5.616 mmBtu/hr 7011.0515 PM and opacity

4 Two Radiant Wall Ovens @3.0 mmBtu/hr each 7011.0610 PM and opacity

4 Hog Hair Singer #1 @8 mmBtu/hr 7011.0715 PM and opacity

4 Hog Hair Singer #2 @6.5 mmBtu/hr 7011.0715 PM and opacity

4 KC‐9 MAH @5.612 mmBtu/hr 7011.0515 PM and opacity

4 Two Rendering MAH @2.48 mmBtu/hr each 7011.0515 PM and opacity

4 Room Air ‐ Blood/Bone Drying 7011.0715 PM and opacity

4 Dock Area Room Air 7011.0715 PM and opacity

4 Dock Area Surface Vents 7011.0715 PM and opacity

4 Two Hog Cut Space Heaters @ 4mmBtu/hr each 7011.0515 PM and opacity

4 Two Pretreatment Space Heaters @ 2.313 mmBtu/hr each


4 Two Front End Kill Space Heaters @3.255 mmBtu/hr each


Minn. R. 7008.4110

Maintenance grinding & sawdust cyclone vented indoors 100% of the time


3. GP 011 Modeling Parameters

stack/vent number

emission unit

stack height (feet)

flow rate (acfm)

stack diameter (feet)

stack temperature

F UTM

Easting (m)

UTM Northing

(m)

NOx lb/hr

SV 051 EU 080 35 15185 1.33 835 502805.2 4835695.6 48.92

SV 052 EU 081 35 15185 1.33 835 502805.2 4835791.0 48.92

SV 053 EU 082 35 15185 1.33 835 502805.2 4835814.5 48.92

SV 054 EU 083 35 15185 1.33 835 502805.2 4835838.0 48.92

SV 055 EU 084 35 15185 1.33 835 502797.0 4836094.5 48.92

SV 056 EU 085 35 15185 1.33 835 502797.0 4836102.3 48.92

SV 057 EU 086 35 15185 1.33 835 502797.0 4836110.1 48.92

4. Greenhouse Gas Emission Calculation Equations and Combustion Unit Inventory

Heat Contents and CO2e emission factors obtained from part 98 subp. C Table C‐1 and C‐2 Equation 1. CO2e = [(NG*1028*117.0036) + (RAF*125*156.7864) + (EU 051 CO2e) + (DO*138*163.6026)]/2000

Where:

CO2e = monthly total facility CO2e (tons/month)

NG = total facility monthly natural gas usage (mmcf/month)

1028 = natural gas heat content (mmBtu/mmcf)

117.0036 = total natural gas CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

RAF = total facility monthly refined animal fat usage (1000 gallons/month)

125 = refined animal fat heat content (mmBtu/1000 gallons)

156.7864 = total refined animal fat CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

EU 051 CO2e = total EU 051 CO2e emissions from LPG, propane, butane, gasoline, and naphtha/kerosene calculated with Equation 2 (lb/month)

DO = total facility monthly No. 2 distillate oil (diesel fuel in peaking generators) usage (1000 gallons/month)

138 = distillate oil heat content (mmBtu/1000 gallons)

163.6026 = total No. 2 distillate oil CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

Equation 2. EU 051 CO2e = [(LPG*92*139.3959) + (P*91*136.0449) + (B*101*144.1799) + (G*125*155.3574) + (NK*135*159.7666)]

Where:

EU 051 CO2e = monthly EU 051 CO2e from LPG, butane, gasoline, and naphtha/kerosene (lb/month)

LPG = EU 051 monthly LPG usage (1000 gallons/month)

92 = LPG heat content (mmBtu/1000 gallons)

139.3959 = total LPG CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

P = EU 051 monthly propane usage (1000 gallons/month)

91 = propane heat content (mmBtu/1000 gallons)

136.0449 = total propane CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

B = EU 051 monthly butane usage (1000 gallons/month)

101 = butane heat content (mmBtu/1000 gallons)

144.1799 = total butane CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

G = EU 051 monthly gasoline usage (1000 gallons/month)

125 = gasoline heat content (mmBtu/1000 gallons)

155.3574 = total gasoline CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

NK = EU 051 monthly naphtha usage (1000 gallons/month)

135 = naphtha/kerosene heat content (mmBtu/1000 gallons)

159.7666 = total naphtha/kerosene CO2e factor for CO2, N2O, and CH4 emissions (lb/mmBtu)

HORMEL COMBUSTION EQUIPMENT LIST

Emission Unit ID #

Equipment Max Firing Rate (mmBtu/hr)

Permitted or Design Fuel

Group 012

EU001 Boiler 1 49.00 NG, RAF (refined animal fat)

EU002 Boiler 2 49.00 NG, RAF



EU005 Boiler 5 7.14 Natural Gas



Group 011

EU080 Generator 1 18.03 FO #2 (No. 2 distillate oil)

EU081 Generator 2 18.03 FO #2






EU051 Emergency Generator 4.19 Gasoline, FO #2, NG, kerosene, butane, propane (LPG)

IA EU078 Emergency Generator 1.30 Natural Gas

Other NG Sources

Ovens (1.5 mmBtu/hr each * 12 ovens) 18.00 Natural Gas

Scott Bone Dryer 9.00 Natural Gas

Duske Blood Dryer 3.50 Natural Gas

Singer #1 8.00 Natural Gas

Singer #2 6.50 Natural Gas

Radiant Wall Oven (1st) 3.00 Natural Gas

Laundry (2) 0.50 Natural Gas

Laundry (2) 0.40 Natural Gas

Livestock Office Boiler 0.40 Natural Gas

Hog Cut (2) 8.00 Natural Gas

Emission Unit ID #

Equipment Max Firing Rate (mmBtu/hr)

Permitted or Design Fuel

Pretreatment (2) 4.63 Natural Gas

Front End Kill (2) 6.51 Natural Gas

N. Holding Pen (2) 0.64 Natural Gas

Shop 0.75 Natural Gas

KC‐9 5.62 Natural Gas

KC‐7 2.16 Natural Gas

MP‐11 Belt Grill 0.28 Natural Gas

RWO 0.24 Natural Gas

Rendering (2) 4.95 Natural Gas

Corvette Building 0.21 Natural Gas

Old Boiler Room 5.62 Natural Gas

New Boiler Room 1.36 Natural Gas

Break Room QPP 0.21 Natural Gas

Break Room QPP 0.13 Natural Gas

Kill Floor (Sticking) 1.00 Natural Gas

Rendering 2.17 Natural Gas

MP‐130 Desiccant Unit 0.86 Natural Gas

Trim/Blend Desiccant 0.36 Natural Gas

QPP Office MAU 1 0.26 Natural Gas

QPP Office RTU 1 0.39 Natural Gas




QPP Office water htrs 1.50 Natural Gas

DS 11 Hall Desiccant 0.40 Natural Gas

Livestock Boilers (2) 6.00 Natural Gas

Refined Products MAU 4 0.606 Natural Gas

Refined Products RTU 1 0.105 Natural Gas

Refined Products RTU 2 0.24 Natural Gas

Refined Products ERV 1 0.10 Natural Gas

Refined Products ERV 2 0.10 Natural Gas

Technical Support Document, Permit Action Number: 09900002 ‐ 011 Page 1 of 13 Date: 7/8/2013

TECHNICAL SUPPORT DOCUMENT

For

AIR EMISSION PERMIT NO. 09900002‐011

This technical support document (TSD) is intended for all parties interested in the permit and to meet

the requirements that have been set forth by the federal and state regulations (40 CFR § 70.7(a)(5) and

Minn. R. 7007.0850, subp. 1). The purpose of this document is to provide the legal and factual

justification for each applicable requirement or policy decision considered in the determination to issue

the permit.

1. General Information

1.1 Applicant and Stationary Source Location:

Table 1. Applicant and Source Address

Applicant/Address Stationary Source/Address

(SIC Code: 2013/2011)

Hormel Foods Corp/Quality Pork Processors

1 Hormel Place

Austin, MN 55912‐3680

Hormel Foods Corporation

500 14th Avenue Northeast

Austin, Mower County, MN 55912

Contact: Tyler Hulsebus

Phone: 507‐437‐5221

1.2 Facility Description

Hormel Foods Corporation (Permittee) operates a meat processing plant (Facility) in Austin, Minnesota.

At the Facility, Quality Pork Processors (QPP) processes hogs, and the Permittee manufactures the hogs

into ham, bacon, dry sausage, fresh sausage, SPAM®, and other meat products. Byproducts consist of

blood, cracklings, bone meal, and choice white grease (a component of a broader category of

substances known as Refined Animal Fats). QPP is a co‐Permittee however Hormel Foods owns all

equipment and operates the majority of it; QPP only operates some of the emissions equipment

(insignificant combustion sources) in the processing area.

1.3 Description of the Activities Allowed by this Permit Action

Hormel Foods is proposing to remove the existing rendering operations (EU027/028) and re‐design the operations to be installed in a new portion of the facility. Operations in the new portion of the facility will be referred to as refined products operations (EU088‐091). The re‐designed refined products operations will be housed in a new manufacturing building to be constructed on the same site as the existing facility. The addition to the facility will include rendering machinery, some new and some relocated from existing operations, as well as new meat and bone meal (MBM) and dried blood truck load out system.

With the installation of the RTO (CE026), CE022 and CE023 will be shut down and SV027 removed. Also, EU027, EU028 and CE009 will be removed. New venturi scrubbers (CE027 and CE029) and packed‐gas


adsorption columns (CE028, CE030 and CE031) will be added to control emissions from the refined products operations (EU088‐091) along with control from the RTO (CE026).

This project will include installation of eight (8) natural gas‐fired air handling units. Five of these units qualify as insignificant activities and three qualify as emission units (EU092‐094). No. 6 fuel oil storage tanks (TK001‐003) have been removed.

At the time of this permit action there is a minor amendment submitted June 13, 2011 that will not be included with this permit action as the construction schedule for the Refined Products Upgrade project is important to Hormel Foods.

1.4. Facility Emissions:

Table 2. Title I Emissions Increase Summary

Pollutant

Unlimited Potential

Emissions from the

Modification (tpy)

Limited

Potential

Emissions from

the

Modification

(tpy)

NSR/112(g)

Threshold for New

Major Source (tpy)

NSR/ 112(g)

Review Required?

(Yes/No)

PM 2,486 53.11 250 No

PM10 1,029 53.11 250 No

PM2.5 60.04 53.11 250 No

NOx 5.25 5.25 250 No

SO2 0.03 0.03 250 No

CO 4.42 4.42 250 No

Ozone (VOC) 190.35 53.01 250 No

Lead 2.63E‐05 2.63E‐05 250 No

CO2e* 6,273 6,273** 100,000 No

total HAPs 4.53E‐03 4.53E‐03 10/25 No

*Carbon dioxide equivalents as defined in Minn. R. 7007.0100.

** Does not affect existing facility‐wide CO2e limit of 94,700 tpy

Table 3. Total Facility Potential to Emit Summary

PM

tpy

PM10

tpy

PM2.5

tpy

SO2

tpy

NOx

tpy

CO

tpy

CO2e

Tpy

VOC

tpy

Single

HAP

tpy

All

HAPs

tpy

Total Facility

Limited Potential

Emissions

180.29 179.48 78.89 238.64 228.53 156.83 94,700 75.66 1.55

2.37


Table 4. Facility Classification

Classification Major/Affected

Source

Synthetic Minor/Area Minor/Area

PSD PM, PM10, PM2.5, SO2,

NOX, CO, CO2e, VOC

Part 70 Permit Program PM10, PM2.5, SO2, NOX,

CO

VOC

Part 63 NESHAP Single/Total HAPs

2. Regulatory and/or Statutory Basis

New Source Review

The Facility is an existing synthetic minor source under New Source Review regulations. Changes

authorized by this permit action will not change this status.

Part 70 Permit Program

The Facility is a major source under the Part 70 permit program.

New Source Performance Standards (NSPS)

The changes authorized by this permit action are not subject to any NSPS.

National Emission Standards for Hazardous Air Pollutants (NESHAP)

HAP emissions from the entire Facility after construction will remain less than the major source level as

defined in 40 CFR pt. 63. Therefore, no major source NESHAPs apply. Existing boilers are subject to the

area source MACT and EU051 is subject to subp. ZZZZ.

Compliance Assurance Monitoring (CAM)

CAM plans from permit no. 09900002‐010 that were placed in Appendix 5 of that permit were removed

and included as attachments to this TSD. For this permit action, CAM applies to Refined Products

Machinery (EU088), Crax Room Air (EU089) and Refined Products Room Air (EU091). Applicable

pollutants include PM and PM10 for all three emission units and VOC for EU088. All three emission units

qualify as “Other” PSEU.

Environmental Review & AERA

Environmental review and risk analysis are not triggered by this major amendment.

Minnesota State Rules

Portions of the facility are subject to the following Minnesota Standards of Performance:

Minn. R. 7011.0515 Standards of Performance for New Indirect Heating Equipment

Minn. R. 7011.0715 Standards of Performance for Post‐1969 Industrial Process Equipment


Table 5. Regulatory Overview of Units Affected by the Modification/Permit Amendment

Level* Applicable Regulations Comments:

GP001

GP012

App. 4

Title I Condition: To limit

potential SO2 emissions to less

than major source levels

defined by 40 CFR § 52.21;

Minn. R. 7007.3000; Minn. R.

7007.0800, subps. 2, 4 & 5,

Minn. R. 7011.0515, subp. 1

All references to #6 fuel oil and waste oil use at the facility are being

removed from the permit. This includes references in Appendix 4.

EU088 Title I Condition: To avoid

classification as a major source

under 40 CFR § 52.21; Minn. R.

7007.3000

Limits on PM, PM10, PM2.5 and VOC. Control by venturi scrubber

(CE027), packed‐gas adsorption column (CE028) and RTO (CE026).

EU089

EU090

(@ SV059)

Title I Condition: To avoid



7007.3000

Limits on PM, PM10 and PM2.5. Control by venturi scrubber (CE029)

and packed‐gas adsorption column (CE030).

EU091 Title I Condition: To avoid



7007.3000

Limits on PM, PM10 and PM2.5. Control by packed‐gas adsorption column (CE031).

EU092

EU093

EU094

(@ GP014)

Minn. R. 7011.0515 PM limit and opacity limit with exceptions. Fuel restricted to natural

gas.

SV058 Title I Condition: To avoid



7007.3000; Minn. R. 7011.0715

Limits on PM, PM10, PM2.5, VOC and opacity applicable upon startup

of EU088.

*Where the requirement appears in the permit (e.g., EU, SV, GP, etc.).

3. Technical Information

Hormel Foods Corporation proposes to construct the following emission units as part of the new refined

products operations at the facility:

Refined Products Machinery (EU088) ‐ High intensity vapors generated from the refined

products process will be treated in a new venturi scrubber (CE027) and packed‐gas

adsorption column (CE028) and then directed into the existing RTO (CE026) before being

released to the atmosphere through SV058.

Crax Room Air (EU089) ‐ Room air from the refined products grinding area will pass

through a new venturi scrubber (CE029) and directed into a packed‐gas adsorption

column (CE030) before venting to the atmosphere through SV059.


Truck Loadout Room Air (EU090) ‐ Room air from the refined products storage and truck

loadout area will be routed to a new packed‐gas adsorption column (CE030) prior to

venting to the atmosphere through SV059.

Refined Products Room Air (EU091) ‐ Room air from the refined products processing

area will be treated with a new packed‐gas adsorption column (CE031) and then vented

to the atmosphere through SV060 and 061.

Hormel Foods requests the two‐stage issuance option outlined in Minn. R. 7007.0750, subp. 7 for this

permit action. The first stage issuance permit conditions are related to construction and include

emissions limits, recordkeeping associated with these limits and are Title I Conditions to avoid major

source status under 40 CFR Section 52.21. Associated initial performance testing also qualifies as first

stage issuance permit conditions. See section 3.5 of this TSD for further information regarding two‐stage

issuance.

The permit will reflect three (3) stages of operation for the rendering and refined products equipment in

order to account for all possible operating scenarios within the construction schedule. Operating

scenarios 1 and 2 are already listed in the existing permit. Only scenario 3 will need to be added with

this permit action.

Operating Scenario 1 (Existing Rendering Machinery Prior to Startup of RTO (CE026)) ‐ Existing rendering

machinery (EU028) emissions will vent through CE009, CE022 and CE023 and then either be vented to

the atmosphere through SV027 or routed to CE008 and then vented to the atmosphere through SV026.

Operating Scenario 2 (Existing Rendering Machinery After Startup of RTO (CE026)) ‐ Existing rendering

machinery (EU028) emissions will vent through CE009 and then CE026 and then to the atmosphere

through SV058. CE022 and CE023 will be shut down, and SV027 will be removed.

Operating Scenario 3 (New Refined Products Machinery) ‐ New refined products machinery (EU088) will

vent through a new venturi scrubber (CE027), a new packed‐gas adsorption column (CE028), and

through the previously permitted RTO (CE026) and then to the atmosphere through SV058. The existing

rendering machinery (EU028) and CE009 will be shut down.

CE008 will continue to operate to control possible odor. EU036 and EU050 will vent through CE018 and

then CE026 and then to the atmosphere through SV058 following installation of CE026 and EU088. The

Refined Products Machinery project will not affect items CE018, EU036 or EU050.

Existing Rendering Room Air (EU027)

All particulate emitting equipment will be removed from the existing rendering room once the new

refined products machinery (EU088) is operating. The only items remaining in this area will be an

enclosed hog grinder and enclosed grease storage tanks. Hormel Foods believes there will not be any

particulate matter emitted from these processes. Thus, Hormel Foods proposes to remove EU027 from

the permit following startup of EU088. The existing packed‐gas adsorption column (CE008) will continue


to operate as a precaution for odor control only. Shutdown requirements have been added to the

permit for EU027 and EU028 in connection with construction of EU088.

Removal of #6 Fuel Oil and Used Oil

As part of this amendment, Hormel Foods requests to remove #6 fuel oil and used oil from the

permitted fuel options in GP012 Boilers. Storage tanks for #6 fuel oil have been removed and used oil

has not been burned in several years at the facility. The boilers will continue to burn natural gas as

primary fuel and refined animal fats (RAF) as an alternate fuel as economic conditions present

themselves. As a result of this, PTE for Boilers #1‐4 were revised in the facility description and TK001‐

003 were removed. TK001‐003 were also removed from Appendix 2.

Compliance Assurance Monitoring

EU088, EU089 and EU091 are subject to Compliance Assurance Monitoring (CAM) for PM and PM10 as

each of these units has control equipment and their uncontrolled emissions are greater than 100 tpy.

EU088 is also subject to CAM for VOC as the uncontrolled emissions are greater than 100 tpy. Each of

these emission units qualify as “Other” PSEU. Uncontrolled emissions from EU090 are below 100 tpy and

thus, EU090 is not subject to CAM. CAM plans for EU088, EU089 and EU091 are attached to this TSD.

Initial Performance Testing and Periodic Performance Testing

Initial performance tests for the new emission units will be due 180 days after initial startup. Performance tests for EU088 will measure PM, PM10, PM2.5 and VOC. Daily monitoring and recordkeeping of pressure drop and water flow rate will be conducted in lieu of performance testing for EU089‐091.

Smoked Meat Oven #7 (EU007) conducted a GP003 performance test for PM and opacity on October 7, 2011 showing compliance with permit limits. The next scheduled performance test for GP003 is due on or before October 7, 2016. Generator No. 5 (EU084) conducted a GP011 performance test for NOX and opacity on October 26, 2012 determining a lb/hr NOX emission factor. The next scheduled performance test for GP011 is due on or before October 26, 2015 for NOX and on or before October 26, 2017 for opacity.

Environmental Justice

An email response from EPA Region V dated April 23, 2013 stated the facility located at 500 14th Ave NE in Austin may have environmental justice concerns. Both Mower County and the City of Austin were contacted and asked if there were citizen complaints related to this facility. Mower County said they did not have any complaints on file for Hormel Foods Corp/QPP. The City of Austin also did not have any recent complaints on record for this facility.

3.1 Emissions Increase Analysis

The emission calculation methodologies for the proposed emission units related to the Refined Products Upgrade project are described below. Emission calculations are provided for the following emission units: EU088 (Refined Products Machinery), EU089 (Crax Room Air), EU090 (Truck Loadout Room Air), and EU091 (Refined Products Room Air). Revised emission calculations for Boilers 1‐4 were provided given these units will now burn only natural gas and RAF. (See attachment 2.)


Refined Products Machinery (EU088)

Controlled emissions for EU088 are based on a grain loading factor of 0.01 gr/dscf and the air flow for the system. EU088 will be controlled by CE027 (venturi scrubber), CE028 (packed‐gas adsorption column) and CE026 (previously permitted RTO) in series. The uncontrolled emissions are back calculated based on the control efficiencies listed in Minn. R. 7011.0070 for venturi scrubbers, packed‐gas adsorption columns and thermal oxidizers. The packed‐gas adsorption column control efficiencies are assumed equivalent to the spray tower efficiencies listed in Minn. R. 7011.0070.

The listed PM control efficiency for the venturi scrubber is 94%, the spray tower is 85%, and the thermal oxidizer is 62%. Thus, the overall control efficiency for PM is 99.96%.

0.94 + (1‐0.94)*0.85 + (1‐0.94)*(1‐0.85)*0.62 = 99.66%

The listed PM10 control efficiency for the venturi scrubber is 84%, the spray tower is 84%, and the thermal oxidizer is 62%. Thus, the overall control efficiency for PM10 is 99.03%.

0.84 + (1‐0.84)*0.84 + (1‐0.84)*(1‐0.84)*0.62 = 99.03%

Hormel Foods conservatively assumes that the venturi scrubber and packed‐gas adsorption column will not control PM2.5 emissions, but the previously permitted RTO will control PM2.5 emissions. The assumed control efficiency for PM2.5 is 62%. There is not a listed control efficiency for VOC for the venturi scrubber or packed‐gas adsorption column. The listed control efficiency for thermal oxidizers is 97%.

Published emission factors are not available for rendering operations such as those included in the Refined Products Upgrade project. As noted in AP‐42 Section 9.5.3.3, “Meat Rendering Plants”, emissions from edible rendering processes are not considered significant because no cooking vapors are emitted and direct heat with the edible fat is minimal. AP‐42 indicates that particulate matter is emitted from grinding and screening of the solids or crax but that no data is available. In addition, the technical support document for permit no. 09900002‐008 also indicates that rendering is not known as a substantial PM source. Therefore, Hormel Foods believes that calculating the controlled emissions based on the above grain loading factor and air flow for the system is a conservative estimate of PM emissions from Refined Products Machinery. In addition, EU088 will be controlled with a venturi scrubber, packed‐gas adsorption column and an RTO.

Pressure drop and water flow rate are indicators of control equipment performance. Hormel Foods is proposing to demonstrate compliance with the emission limits by monitoring pressure drop and water flow rate of the venturi scrubber and packed‐gas adsorption column. (See attached CAM plan.) The RTO monitoring and recordkeeping are already listed under SV058 in the permit. Hormel Foods is not proposing to modify the existing RTO monitoring conditions.

Crax Room Air (EU089)

Controlled emissions for EU089 are based on a grain loading factor of 0.01 gr/dscf and the air flow for the system. EU089 will be controlled by CE029 (venturi scrubber) and CE030 (packed‐gas adsorption column) in series. The uncontrolled emissions are back calculated based on the control efficiencies listed in Minn. R. 7011.0070 for venturi scrubbers and packed‐gas adsorption columns. The packed‐gas adsorption column control efficiencies are assumed equivalent to the spray tower efficiencies listed in Minn. R. 7011.0070.


The listed PM control efficiency for a venturi scrubber is 94% and spray tower is 85%. Thus, the overall control efficiency for PM is 99.1%.

0.94 + (1‐0.94)*0.85 = 99.1%

The listed PM10 control efficiency for a venturi scrubber is 84% and spray tower is 84%. Thus, the overall control efficiency for PM10 is 97.44%.

0.84 + (1‐0.84)*0.84 = 97.44%

Hormel Foods conservatively assumes that the venturi scrubber and packed‐gas adsorption column will not control PM2.5 emissions.

As mentioned above, Hormel Foods believes that calculating the controlled emissions based on the above grain loading and air flow for the system is a conservative estimate of PM emissions from Crax Room Air. In addition, EU089 will be controlled with a scrubber and packed‐gas adsorption column. Hormel Foods is proposing to demonstrate compliance with the emission limits by monitoring pressure drop and water flow rate of the venturi scrubber and packed‐gas adsorption column. (See attached CAM plan.)

Truck Loadout Room Air (EU090)

Controlled emissions for EU090 are based on a grain loading factor of 0.01 gr/dscf and the air flow for the system. EU090 will be controlled by CE030 (packed‐gas adsorption column). The uncontrolled emissions are back calculated based on the packed‐gas adsorption column control efficiencies. As noted above, the packed‐gas adsorption column control efficiencies are assumed equivalent to the spray tower efficiencies listed in Minn. R. 7011.0070.

The listed PM control efficiency for spray tower is 85%. The listed PM10 control efficiency for spray tower is 84%. Hormel Foods conservatively assumes that the packed‐gas adsorption column will not control PM2.5 emissions. Hormel Foods is proposing to demonstrate compliance with the emission limits by monitoring pressure drop and water flow rate of the packed‐gas adsorption column.

Refined Products Room Air (EU091)

Controlled emissions for EU091 are based on a grain loading factor of 0.01 gr/dscf and the air flow for the system. EU091 will be controlled by CE031 (packed‐gas adsorption column). The uncontrolled emissions are back calculated based on the packed‐gas adsorption column control efficiencies. As noted above, the packed‐gas adsorption column control efficiencies are assumed equivalent to the spray tower efficiencies listed in Minn. R. 7011.0070.

The listed PM control efficiency for spray tower is 85%. The listed PM10 control efficiency for spray tower is 84%. Hormel Foods conservatively assumes that the packed‐gas adsorption column will not control PM2.5 emissions.

CE031 will control emissions from the air in the rendering machinery building. All rendering machinery equipment is fully enclosed and vents via enclosed piping to the new venturi scrubber (CE027) and then to the new packed‐gas adsorption column (CE028) and then to the previously permitted RTO (CE026). Due to the enclosed nature of the equipment, Hormel Foods expects very little PM in the room air. Thus, Hormel Foods believes that calculating the controlled emissions based on the above grain loading and air flow for the system is a conservative estimate of PM emissions from Refined Products Room Air.


Hormel Foods is proposing to demonstrate compliance with the proposed emission limits for EU091 by monitoring pressure drop and water flow rate of the packed‐gas adsorption column. (See attached CAM plan.)

3.2 Periodic Monitoring and CAM

In accordance with the Clean Air Act, it is the responsibility of the owner or operator of a facility to have

sufficient knowledge of the facility to certify that the facility is in compliance with all applicable

requirements.

For CAM, the Permittee submitted a CAM proposal as required by 40 CFR § 64.3. It can be found in

Attachment 3 to this TSD. Further discussion of decisions about CAM can be found in Table 6.

In evaluating the monitoring included in the permit, the MPCA considered the following:

The likelihood of the facility violating the applicable requirements;

Whether add‐on controls are necessary to meet the emission limits;

The variability of emissions over time;

The type of monitoring, process, maintenance, or control equipment data already available for the emission unit;

The technical and economic feasibility of possible periodic monitoring methods; and

The kind of monitoring found on similar units elsewhere.

The table below summarizes the periodic monitoring requirements for those emission units for which

the monitoring required by the applicable requirement is nonexistent or inadequate or where CAM

applies.

Table 6. Periodic Monitoring

Level* Requirement (rule

basis)

Additional

Monitoring

Discussion

EU027

EU028

All limits and

requirements expire

upon startup of EU088

Permit requirements at EU027 and EU028 levels only

apply prior to startup of EU088. EU027 and EU028

will be shut down following startup of EU088.

EU088 PM/PM10/PM2.5: < 0.97

lb/hr

VOC: < 0.97 lb/hr

PM cont. eff.: > 94%

(CE027)

PM10 cont. eff.: > 84%

(CE027 & CE028)

Pressure Drop: > 4.0

inches w.c. (CE027)

Water Flow: > 50.0

Monitoring: monitor

the pressure drop and

water flow rate of

CE027 and CE028;

follow existing

monitoring reqs for

CE026 (see SV058)

Compliance with emission limits will be accomplished

by monitoring pressure drop and water flow rate of

the venturi scrubber (CE027) and packed‐gas

adsorption column (CE028) along with existing

monitoring requirements for the RTO (CE026).

Monitoring requirements for CE026 are listed at

SV058. Monitoring parameters, deviations and

corrective actions are described in the attached CAM

plan. CE 027 and CE 028 are assumed to have 0%

control for PM2.5.



basis)

Additional

Monitoring

Discussion

gal/min (CE027)


(CE028)


inches w.c. (CE028)

Water Flow: > 120

gal/min (CE028)

(Title I Condition: to

avoid major source

status under 40 CFR

52.21 & Minn. R.

7007.3000)

Opacity < 20%

(Minn. R. 7011.0715,

subp. 1(B))

EU089

EU090

(SV059)

PM/PM10/PM2.5: < 2.68

lb/hr


(CE029)


(CE029 & CE030)


inches w.c. (CE029)

Water Flow: > 100

gal/min (CE029)


(CE030)


inches w.c. (CE030)

Water Flow: > 320

gal/min (CE030)


avoid major source

status under 40 CFR

52.21 & Minn. R.

Monitoring: monitor


water flow rate of

CE029 and CE030



the venturi scrubber (CE029) and packed‐gas

adsorption column (CE030). Monitoring parameters,

deviations and corrective actions are described in the

attached CAM plan for EU089. EU090 is not subject

to CAM. CE 029 and CE 030 are assumed to have 0%

control for PM2.5.



basis)

Additional

Monitoring

Discussion

7007.3000)

Opacity < 20%

(Minn. R. 7011.0715,

subp. 1(B))

EU091 PM/PM10/PM2.5 < 8.38

lb/hr


(CE031)


(CE031)


inches w.c. (CE031)

Water Flow: > 1000

gal/min (CE031)


avoid major source

status under 40 CFR

52.21 & Minn. R.

7007.3000)

Opacity < 20%

(Minn. R. 7011.0715,

subp. 1(B))

Monitoring: monitor


water flow rate of

CE031



the packed‐gas adsorption column (CE031).

Monitoring parameters, deviations and corrective

actions are described in the attached CAM plan. CE

031 is assumed to have 0% control for PM2.5.

SV058 PM < 1.22 lb/hr

PM10 < 1.15 lb/hr

PM2.5 < 1.41 lb/hr

VOC < 0.99 lb/hr


avoid major source

status under 40 CFR

52.21 & Minn. R.

7007.3000)

Opacity < 20%

(Minn. R. 7011.0715,

subp. 1(B); meets reqs

of Minn. R. 7011.0610,

subp. 1(A)(2))

Monitor RTO (EU087/

CE026) temp,

recordkeeping, O&M

and periodic

inspections

Limits apply after startup of EU088. Existing permit

limits expire after startup of EU088.



basis)

Additional

Monitoring

Discussion

GP014 PM: < 0.4 lb/mmBtu

Opacity: < 20% with

exceptions

(Minn. R. 7011.0515)

None Fuel restriction of natural gas only should result in

minimal amount of PM and opacity. Limit exception

is one six‐minute period per hour of not more than

60% opacity.

*Where the requirement appears in the permit (e.g., EU, SV, GP, etc.).

3.3 Insignificant Activities

Hormel Foods Corporation/QPP ‐ Austin has several operations which are classified as insignificant

activities under the MPCA’s permitting rules. These are listed in Appendix 2 to the permit.

The permit is required to include periodic monitoring for all emissions units, including insignificant activities, per EPA guidance. The insignificant activities at this Facility are only subject to general applicable requirements. Using the criteria outlined earlier in this TSD, the following table documents the justification why no additional periodic monitoring is necessary for the current insignificant activities. See Attachment 2 of this TSD for PTE information for the insignificant activities.

Table 7. Insignificant Activities

Insignificant Activity

General Applicable

Emission limit

Discussion

Refined Products MAU 4,

Refined Products Roof Top

Units 1 and 2, Refined

Products Energy Recovery

Ventilators 1 and 2

PM < 0.4 lb/MMBtu,

Opacity < 20% with

exceptions

(Minn. R. 7011.0515)

For these units, based on the fuel used (natural gas)

and EPA published emissions factors, it is highly

unlikely that it could violate the applicable

requirement.

3.4 Permit Organization

Hormel Foods requested permit requirements related to EU089/090 to be listed at the SV059 level. The control equipment for these EUs are not listed as associated items under SV059, however requirements for CE029 and CE030 are listed at SV059. Placeholders were inserted at CE029 and CE030 referencing applicable requirements at the SV059 level for these control equipment units.

Notification requirements for newly constructed EUs at EU088, EU091, GP014 and SV059 reference Table B for locating the actual requirements. The headers for these requirements are located in Table A.

In general, the permit meets the MPCA Delta Guidance for ordering and grouping of requirements. One area where this permit deviates slightly from Delta guidance is in the use of appendices. While appendices are fully enforceable parts of the permit, in general, any requirement that the MPCA thinks should be electronically tracked (e.g., limits, submittals, etc.), should be in Table A or B of the permit. The main reason is that the appendices are word processing sections and are not part of the electronic tracking system. Violation of the appendices can be enforced, but the computer system will not automatically generate the necessary enforcement notices or documents. Staff must generate these.

3.5 Comments Received


The MPCA plans to issue this draft/proposed permit under the provisions of Minn. R. 7007.0750, subp.

7. This rule allows the MPCA to issue permits in two stages. The requirements issued in the first stage –

the Stage 1 conditions – are the portions of the draft/proposed permit that relate to the construction

activities authorized by the draft/proposed permit.

Examples of Stage 1 conditions include emissions limits, restrictions on hours of operation and the recordkeeping associated with that restriction, and requirements to demonstrate initial compliance (e.g., initial performance tests). In this draft/proposed permit, many Stage 1 conditions are identified as Title I Conditions to avoid classification as a major source and can be found at EU088, EU091, SV058 and SV059. During the public comment period and prior to final permit issuance, the Stage 1 conditions are denoted in the permit by “[Stage 1].” These designations will be removed in Stage 2 (final) permit issuance.

Public Notice Period: May 24, 2013 ‐ June 24, 2013

EPA 45‐day Review Period: May 24, 2013 ‐ July 8, 2013

Comments were not received from the public during the public notice period. There was a phone call to

request a copy of the permit application on June 3, 2013. Comments were not received from EPA during

their review period.

4. Permit Fee Assessment

Attachment 4 to this TSD contains the MPCA’s assessment of Application and Additional Points used to

determine the permit application fee for this permit action as required by Minn. R. 7002.0019. The

permit action includes one permit application received after the effective date of the rule (July 1, 2009).

The permit includes the incorporation of limits to avoid classification as a major source under 40 CFR

Section 52.21 (10 pts.).

5. Conclusion

Based on the information provided by Hormel Foods Corporation/Quality Pork Processors ‐ Austin, the

MPCA has reasonable assurance that the proposed operation of the emission facility, as described in the

Air Emission Permit No. 09900002‐011 and this TSD, will not cause or contribute to a violation of

applicable federal regulations and Minnesota Rules.

Staff Members on Permit Team: Tarik Hanafy (permit writer/engineer)

Jennifer Carlson (enforcement)

Jim Kolar (stack testing)

Marshall Cole (peer reviewer)

AQ File No. 418; DQ 4303

Attachments: 1. Facility Description and CD‐01 Forms

2. Calculation Spreadsheets 3. CAM Plans 4. Points Calculator

Attachment 1:Facility Description and CD 01 Forms

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ion:

AQ

D F

acili

ty ID

:

Fac

ility

Nam

e:

Act

ive

and

Pen

ding

Rec

ords

PE

R 0

11

0990

0002

Hor

mel

Foo

ds C

orp/

QP

P -

Aus

tin

FAC

ILIT

Y D

ESC

RIP

TIO

N: G

RO

UPS

(GP)

14 M

ay,

2013

16

:06

ID N

o.A

dded

By

(Act

ion)

Ret

ired

By

(Act

ion)

Incl

ude

in E

IO

pera

tor

IDfo

r It

em

Gro

up D

escr

iptio

nG

roup

Ite

ms

Gro

upS

tatu

s

1G

P 0

01

PE

R 0

09S

O2

and

NO

x Li

mits

EU

001

, EU

002

, EU

003

, EU

004

, EU

005

, EU

044

, EU

045

, EU

051

, EU

080

,E

U 0

81, E

U 0

82, E

U 0

83, E

U 0

84, E

U 0

85, E

U 0

86A

ctiv

e

2G

P 0

02

PE

R 0

08T

anks

TK

002

, TK

003

Ret

ired

3G

P 0

03

PE

R 0

08N

atur

al S

mok

e P

roce

ssE

U 0

06, E

U 0

07, E

U 0

08, E

U 0

09, E

U 0

10, E

U 0

11, E

U 0

31, E

U 0

32, S

V 0

03,

SV

005

, SV

007

, SV

009

, SV

011

, SV

012

Act

ive

4G

P 0

04

PE

R 0

08C

ontr

olle

d V

apor

and

Liq

uid

Sm

oke

Pro

cess

EU

012

, EU

013

, EU

014

, EU

015

, EU

016

, EU

017

, SV

012

, SV

013

, SV

014

,S

V 0

15, S

V 0

16, S

V 0

17, S

V 0

18R

etire

d

5G

P 0

05

PE

R 0

08P

reco

ok P

roce

sses

CE

006

, CE

007

, CE

025

, EU

018

, EU

019

, EU

020

, EU

021

, EU

029

, SV

019

,S

V 0

20, S

V 0

50A

ctiv

e

6G

P 0

06

PE

R 0

08M

W B

acon

Pad

Cut

ters

EU

024

, SV

022

, SV

023

Rem

oved

7G

P 0

07

PE

R 0

08S

alt a

nd S

ugar

Sto

rage

EU

033

, EU

034

, EU

035

Ret

ired

8G

P 0

08

PE

R 0

06B

oile

rs (

29.4

, 29.

4 M

MB

tu/h

r- N

atur

al G

as)

Ret

ired

9G

P 0

09

PE

R 0

06A

ll B

oile

rsE

U 0

02, E

U 0

03, E

U 0

04, E

U 0

05, E

U 0

44, E

U 0

45R

etire

d

10G

P 0

10

PE

R 0

10B

lood

and

Bon

e M

eal D

ryer

sC

E 0

18, C

E 0

19, C

E 0

24, C

E 0

26, E

U 0

36, E

U 0

50, E

U 0

71, S

V 0

33, S

V 0

45,

SV

058

Act

ive

11G

P 0

11P

ER

009

Ele

ctric

Pow

er G

ener

ator

sE

U 0

80, E

U 0

81, E

U 0

82, E

U 0

83, E

U 0

84, E

U 0

85, E

U 0

86A

ctiv

e

12G

P 0

12

PE

R 0

09B

oile

rsE

U 0

01, E

U 0

02, E

U 0

03, E

U 0

04, E

U 0

05, E

U 0

44, E

U 0

45A

ctiv

e

13G

P 0

13

PE

R 0

10A

ncill

ary

NG

-com

bust

ion

CO

2 em

issi

ons

(for

em

issi

ons

data

onl

y)A

ctiv

e

14G

P 0

14

PE

R 0

11R

efin

ed P

rodu

cts

Mak

eup

Air

Uni

tsE

U 0

92, E

U 0

93, E

U 0

94, S

V 0

62, S

V 0

63, S

V 0

64A

ctiv

e

Pag

e 1

of

1

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay,

2013

16

:06

FAC

ILIT

Y D

ESC

RIP

TIO

N: S

TAC

K/V

EN

TS

(SV

)

ID N

o.D

isch

arge

Dire

ctio

nF

low

Rat

e/Te

mpe

ratu

reIn

form

atio

n S

ourc

e

Exi

t G

as

Tem

pera

ture

at T

op(º

F)

Des

ign

Flo

w R

ate

at T

op(A

CF

M)

Wid

th(f

eet)

Dia

met

eror

Len

gth

(fee

t)

Insi

de D

imen

sion

sH

eigh

t of

Ope

ning

Fro

mG

roun

d(f

eet)

Add

edB

y(A

ctio

n)

Ret

ired

By

(Act

ion)

Ope

rato

rID

for

Item

Ope

rato

rs D

escr

iptio

nS

tack

/V

ent

Sta

tus

1S

V 0

01U

p, W

ith C

ap45

031

743

8.75

85P

ER

008

Boi

ler

Sta

ck (

Boi

lers

1-5

) --

Nat

. Gas

Fue

lA

ctiv

e

2S

V 0

02U

p, u

nkno

wn

Cap

115

4000

.83

60P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

06)

Rem

oved

3S

V 0

03U

p, W

ith C

ap13

040

001.

5041

PE

R 0

10N

atur

al S

mok

e M

eat O

ven

(EU

006

)A

ctiv

e

4S

V 0

04U

p, u

nkno

wn

Cap

115

4000

.83

60P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

07)

Rem

oved

5S

V 0

05U

p, W

ith C

ap13

040

001.

5041

PE

R 0

10N

atur

al S

mok

e M

eat O

ven

(EU

007

)A

ctiv

e

6S

V 0

06U

p, u

nkno

wn

Cap

115

4000

.83

60P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

08)

Rem

oved

7S

V 0

07U

p, W

ith C

ap13

040

001.

5041

PE

R 0

10N

atur

al S

mok

e M

eat O

ven

(EU

008

)A

ctiv

e

8S

V 0

08U

p, u

nkno

wn

Cap

115

4000

.83

60P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

09)

Rem

oved

9S

V 0

09U

p, u

nkno

wn

Cap

130

4000

1.5

41P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

09)

Act

ive

10S

V 0

10U

p, u

nkno

wn

Cap

115

4000

.83

60P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

10)

Rem

oved

11S

V 0

11U

p, u

nkno

wn

Cap

130

4000

1.5

41P

ER

006

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

10)

Act

ive

12S

V 0

12U

p, u

nkno

wn

Cap

130

4000

1.5

41P

ER

008

Nat

ural

Sm

oke

Mea

t Ove

n (E

U 0

11)

Act

ive

13S

V 0

13U

p, u

nkno

wn

Cap

130

4000

1.5

41P

ER

006

Liqu

id S

mok

e M

eat O

ven

(For

EU

012

)A

ctiv

e

14S

V 0

14U

p, W

ith C

ap13

040

001.

5041

PE

R 0

08Li

quid

Sm

oke

Pre

p. S

aus.

Ove

n #1

--

Ger

mos

#1A

ctiv

e

15S

V 0

15U

p, W

ith C

ap13

040

001.

5041

PE

R 0

08Li

quid

Sm

oke

Pre

p. S

aus.

Ove

n #2

--

Ger

mos

#2A

ctiv

e

16S

V 0

16U

p, W

ith C

ap13

040

001.

5041

PE

R 0

08Li

quid

Sm

oke

Pre

p. S

aus.

Ove

n #3

--

Ger

mos

#3A

ctiv

e

17S

V 0

17U

p, u

nkno

wn

Cap

130

4000

1.5

41P

ER

008

Liqu

id S

mok

e P

rep.

Sau

s. O

ven

(For

EU

016

/EU

039

/CE

014

)A

ctiv

e

18S

V 0

18U

p, u

nkno

wn

Cap

130

4000

1.5

41P

ER

008

Liqu

id S

mok

e P

rep.

Sau

s. O

ven

(For

EU

017

)A

ctiv

e

19S

V 0

19U

p, W

ith C

ap12

030

001.

5052

PE

R 0

10P

reco

oked

Bac

on S

tack

N/S

(E

U 0

18 &

EU

019

/CE

006

)A

ctiv

e

20S

V 0

20U

p, W

ith C

ap12

030

001.

5052

PE

R 0

10P

reco

oked

Bak

on S

tack

E/W

(E

U 0

20 &

EU

021

/CE

007

)A

ctiv

e

21S

V 0

21U

p, u

nkno

wn

Cap

400

255

.375

50P

ER

008

Sta

ndby

Gen

erat

or S

tack

(E

U 0

78)

Act

ive

22S

V 0

22U

p, u

nkno

wn

Cap

8040

0.6

760

PE

R 0

08B

acon

Pad

Cut

ter

Sta

ck (

For

EU

023

)R

emov

ed

23S

V 0

23U

p, u

nkno

wn

Cap

8040

0.6

760

PE

R 0

08B

acon

Pad

Cut

ter

Sta

ck (

For

EU

024

)R

emov

ed

24S

V 0

24U

p, u

nkno

wn

Cap

550

558

1.2

60P

ER

008

Ful

ton

Hea

ter

Sta

ckR

emov

ed

25S

V 0

25U

p, u

nkno

wn

Cap

120

1500

1.0

60P

ER

008

Kop

pens

Gril

l Sta

ck (

EU

026

/CE

010

)R

emov

ed

26S

V 0

26U

p, W

ith C

ap80

5000

02.

8371

PE

R 0

10R

ende

ring

Roo

m A

ir P

acke

d T

ower

Scr

ubbe

r S

tack

Act

ive

27S

V 0

27U

p, W

ith C

ap10

010

000

1.17

63P

ER

006

Ren

derin

g C

ooke

r S

tack

Act

ive

Pag

e 1

of

3

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay,

2013

16

:06

FAC

ILIT

Y D

ESC

RIP

TIO

N: S

TAC

K/V

EN

TS

(SV

)

ID N

o.D

isch

arge

Dire

ctio

nF

low

Rat

e/Te

mpe

ratu

reIn

form

atio

n S

ourc

e

Exi

t G

as

Tem

pera

ture

at T

op(º

F)

Des

ign

Flo

w R

ate

at T

op(A

CF

M)

Wid

th(f

eet)

Dia

met

eror

Len

gth

(fee

t)

Insi

de D

imen

sion

sH

eigh

t of

Ope

ning

Fro

mG

roun

d(f

eet)

Add

edB

y(A

ctio

n)

Ret

ired

By

(Act

ion)

Ope

rato

rID

for

Item

Ope

rato

rs D

escr

iptio

nS

tack

/V

ent

Sta

tus

28S

V 0

28U

p, u

nkno

wn

Cap

8530

001.

560

PE

R 0

08B

acon

Bits

Lin

e (E

U 0

29/C

E 0

25)

Rem

oved

29S

V 0

29U

p, u

nkno

wn

Cap

460

1350

03

72.7

PE

R 0

08H

og S

inge

r S

tack

(F

or E

U 0

30)

Act

ive

30S

V 0

30D

own

8012

000.

7556

PE

R 0

08G

P S

alt S

yste

m/S

ugar

Sys

tem

Act

ive

31S

V 0

31U

p, W

ith C

ap80

270

0.75

40P

ER

008

MP

Sal

t Sys

tem

Act

ive

32S

V 0

32D

own

8012

000.

7556

PE

R 0

08G

P S

ugar

Sys

tem

GP

Sug

ar S

yste

m (

EU

035

)A

ctiv

e

33S

V 0

33U

p, N

o C

apM

anuf

actu

rer

110

2000

02.

6755

.8P

ER

008

Blo

od &

Bon

e D

ryer

s C

E 0

18/C

E 0

24 (

vent

uri &

pac

ked

tow

er E

;by

pass

es p

acke

d to

wer

F)

(EU

036

/EU

050

)A

ctiv

e

34S

V 0

34P

ER

008

KC

-9 m

akeu

p ai

r ht

r (E

U 0

40)

Act

ive

35S

V 0

35P

ER

008

KC

-7 m

akeu

p ai

r ht

r (E

U 0

41)

Act

ive

36S

V 0

36P

ER

008

Ren

derin

g m

akeu

p ai

r ht

r (E

U 0

43)

Act

ive

37S

V 0

37P

ER

008

Ren

derin

g m

akeu

p ai

r ht

r (E

U 0

44)

Act

ive

38S

V 0

38U

p, W

ith C

apE

stim

ate

450

3500

02.

3330

PE

R 0

08B

oile

r #6

Act

ive

39S

V 0

39U

p, W

ith C

apE

stim

ate

450

3500

02.

3330

PE

R 0

08B

oile

r #7

Act

ive

40S

V 0

40U

p, u

nkno

wn

Cap

Est

ima

te80

400

0.67

60P

ER

008

Pad

Cut

ter

Rem

oved

41S

V 0

41P

ER

008

Rad

iant

Wal

l Ove

ns (

3.0

MM

btu/

hr)

(EU

047

)A

ctiv

e

42S

V 0

42U

p, u

nkno

wn

Cap

Est

ima

te17

020

001.

2560

PE

R 0

08R

WO

MA

U (

0.24

3 M

MB

tu/h

r) (

EU

048

)A

ctiv

e

43S

V 0

43U

p, u

nkno

wn

Cap

Est

ima

te17

020

001.

2560

PE

R 0

08M

icro

wav

e C

abin

et M

AU

(0.

21 M

MB

tu/h

r) (

EU

049

)A

ctiv

e

44S

V 0

44P

ER

008

Em

erge

ncy

RIC

E(s

) (E

U 0

51)

Act

ive

45S

V 0

4570

5800

060

62.4

PE

R 0

10B

lood

& B

one

Dry

ers

CE

019

(pa

cked

tow

er F

) (E

U 0

36/E

U 0

50)

Act

ive

46S

V 0

46U

p, N

o C

apM

anuf

actu

rer

250

1500

141

.25

PE

R 0

08R

adia

nt W

all O

vens

Act

ive

47S

V 0

47U

p, N

o C

ap2.

578

.67

PE

R 0

08H

og S

inge

r #2

Sta

ck (

EU

068

)A

ctiv

e

48S

V 0

48U

p, N

o C

ap19

8660

PE

R 0

08La

rd D

eodo

rizer

Coo

ling

Tow

erA

ctiv

e

49S

V 0

4940

000

2.5

30P

ER

008

Doc

k A

rea

Roo

m A

irA

ctiv

e

50S

V 0

50U

p, W

ith C

apE

stim

ate

8580

001.

560

PE

R 0

08B

acon

Bits

Lin

e (E

U 0

29/C

E 0

25)

Act

ive

51S

V 0

51U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#1

Act

ive

52S

V 0

52U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#2

Act

ive

53S

V 0

53U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#3

Act

ive

Pag

e 2

of

3

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay,

2013

16

:06

FAC

ILIT

Y D

ESC

RIP

TIO

N: S

TAC

K/V

EN

TS

(SV

)

ID N

o.D

isch

arge

Dire

ctio

nF

low

Rat

e/Te

mpe

ratu

reIn

form

atio

n S

ourc

e

Exi

t G

as

Tem

pera

ture

at T

op(º

F)

Des

ign

Flo

w R

ate

at T

op(A

CF

M)

Wid

th(f

eet)

Dia

met

eror

Len

gth

(fee

t)

Insi

de D

imen

sion

sH

eigh

t of

Ope

ning

Fro

mG

roun

d(f

eet)

Add

edB

y(A

ctio

n)

Ret

ired

By

(Act

ion)

Ope

rato

rID

for

Item

Ope

rato

rs D

escr

iptio

nS

tack

/V

ent

Sta

tus

54S

V 0

54U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#4

Act

ive

55S

V 0

55U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#5

Act

ive

56S

V 0

56U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#6

Act

ive

57S

V 0

57U

p, N

o C

apM

anuf

actu

rer

835

1518

51.

3335

PE

R 0

09G

ener

ator

#7

Act

ive

58S

V 0

58U

p, N

o C

apM

anuf

actu

rer

120

5000

04.

575

PE

R 0

10R

egen

erat

ive

The

rmal

Oxi

dize

r (C

E 0

26)

Act

ive

59S

V 0

59U

p, N

o C

apM

anuf

actu

rer

8078

806

656

.8P

ER

011

Cra

x R

oom

Air

Sta

ck (

CE

029

& C

E 0

30)

Act

ive

60S

V 0

60U

p, N

o C

apM

anuf

actu

rer

8010

6819

656

PE

R 0

11R

efin

ed P

rodu

cts

Roo

m A

ir S

tack

#1

Act

ive

61S

V 0

61U

p, N

o C

apM

anuf

actu

rer

8010

6819

656

PE

R 0

11R

efin

ed P

rodu

cts

Roo

m A

ir S

tack

#2

Act

ive

62S

V 0

62U

p, W

ith C

apM

anuf

actu

rer

175

4800

01.

2536

PE

R 0

11R

efin

ed P

rodu

cts

MA

U 1

Sta

ckA

ctiv

e

63S

V 0

63U

p, W

ith C

apM

anuf

actu

rer

175

4800

01.

2536

PE

R 0

11R

efin

ed P

rodu

cts

MA

U 2

Sta

ckA

ctiv

e

64S

V 0

64U

p, W

ith C

apM

anuf

actu

rer

175

2400

01.

2536

PE

R 0

11R

efin

ed P

rodu

cts

MA

U 3

Sta

ckA

ctiv

e

Pag

e 3

of

3

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay, 2

013

16:

07

FAC

ILIT

Y D

ESC

RIP

TIO

N: C

ON

TR

OL

EQ

UIP

ME

NT

(CE

)

ID N

o.A

dded

By

(Act

ion)

Ret

ired

By

(Act

ion)

Ope

rato

rID

for

Item

Con

trol

Equ

ip.

Type

Con

trol

Equ

ipm

ent

Des

crip

tion

Mod

elC

ontr

olE

quip

.S

tatu

s

Man

ufac

ture

rP

ollu

tant

sC

ontr

olle

dA

fterb

urne

rC

ombu

stio

nP

aram

eter

s

Cap

ture

Effi

cien

cy(%

)

Des

truc

tion/

Col

lect

ion

Effi

cien

cy(%

)

1C

E 0

01P

ER

008

053

Ven

turi

Scr

ubbe

rM

eat O

ven

Rem

oved

EU

006

VO

C10

050

2C

E 0

02P

ER

008

053

Ven

turi

Scr

ubbe

rM

eat O

ven

Rem

oved

EU

007

VO

C10

050

3C

E 0

03P

ER

008

053

Ven

turi

Scr

ubbe

rM

eat O

ven

Rem

oved

EU

008

VO

C10

050

4C

E 0

04P

ER

008

053

Ven

turi

Scr

ubbe

rM

eat O

ven

Rem

oved

EU

009

VO

C10

050

5C

E 0

05P

ER

008

053

Ven

turi

Scr

ubbe

rM

eat O

ven

Rem

oved

EU

010

VO

C10

050

6C

E 0

06P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inP

re-c

ooke

d B

acon

Act

ive

EU

018

& 0

19P

MV

OC

100

100

85 85

7C

E 0

07P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inP

re-c

ooke

d B

acon

Act

ive

EU

020

& 0

21P

MV

OC

100

100

85 85

8C

E 0

08P

ER

010

Tow

er A

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

Ren

derin

gA

ctiv

eE

U 0

27P

M10

PM

VO

C

100

100

100

85 85 0

9C

E 0

09P

ER

010

053

Ven

turi

Scr

ubbe

rR

ende

ring

Act

ive

EU

028

PM

10P

MV

OC

100

100

100

84 94 0

10C

E 0

10P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inK

oppe

ns G

rill

Rem

oved

EU

025

VO

C10

085

11C

E 0

11P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inB

acon

Bits

Fry

erR

emov

edE

U 0

29V

OC

100

85

12C

E 0

12P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inV

apor

Sm

oke

Gen

Act

ive

EU

037

PM

VO

C10

010

090 50

13C

E 0

13P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inV

apor

Sm

oke

Gen

Act

ive

EU

038

PM

VO

C10

010

090 50

14C

E 0

14P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inV

apor

Sm

oke

Gen

Act

ive

EU

039

PM

VO

C10

010

090 50

15C

E 0

15P

ER

008

018

Fab

ric F

ilter

- L

ow T

empe

ratu

re, i

.e.,

T<

180

Deg

rees

FG

P S

alt U

nloa

dA

ctiv

eE

U 0

33P

M10

099

16C

E 0

16P

ER

008

018

Fab

ric F

ilter

- L

ow T

empe

ratu

re, i

.e.,

T<

180

Deg

rees

FM

P S

alt U

nloa

dA

ctiv

eE

U 0

34P

M10

099

17C

E 0

17P

ER

008

018

Fab

ric F

ilter

- L

ow T

empe

ratu

re, i

.e.,

T<

180

Deg

rees

FG

P S

ugar

Uno

lad

Act

ive

EU

035

PM

100

99

18C

E 0

18P

ER

010

053

Ven

turi

Scr

ubbe

rB

lood

/Bon

e M

eal D

ryer

sA

ctiv

eE

U 0

36 &

050

PM

10P

MV

OC

100

100

100

84 94 70

19C

E 0

19P

ER

010

Tow

er F

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

Act

ive

EU

036

& 0

50P

M10

PM

100

100

85 85

20C

E 0

20P

ER

008

Doc

k05

3V

entu

ri S

crub

ber

Act

ive

EU

072

& 0

73P

MV

OC

100

100

90 70

21C

E 0

21P

ER

008

Doc

k Tw

r D

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

Act

ive

EU

072

& 0

73P

MV

OC

100

100

90 70

Pag

e 1

of

2

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay, 2

013

16:

07

FAC

ILIT

Y D

ESC

RIP

TIO

N: C

ON

TR

OL

EQ

UIP

ME

NT

(CE

)

ID N

o.A

dded

By

(Act

ion)

Ret

ired

By

(Act

ion)

Ope

rato

rID

for

Item

Con

trol

Equ

ip.

Type

Con

trol

Equ

ipm

ent

Des

crip

tion

Mod

elC

ontr

olE

quip

.S

tatu

s

Man

ufac

ture

rP

ollu

tant

sC

ontr

olle

dA

fterb

urne

rC

ombu

stio

nP

aram

eter

s

Cap

ture

Effi

cien

cy(%

)

Des

truc

tion/

Col

lect

ion

Effi

cien

cy(%

)

22C

E 0

22P

ER

008

Tow

er B

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

Act

ive

EU

028

PM

VO

C10

010

090 70

23C

E 0

23P

ER

008

Tow

er C

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

Act

ive

EU

028

PM

VO

C10

010

090 70

24C

E 0

24P

ER

010

Tow

er E

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

Act

ive

EU

036

& 0

50P

M10

PM

100

100

85 85

25C

E 0

25P

ER

008

014

Mis

t Elim

inat

or -

Hig

h V

eloc

ity, i

.e.,

V>

250

Ft/M

inC

A40

-S-L

EA

ctiv

eQ

uick

Dra

ftP

M10

PM

VO

C

100

100

100

85 85 85

26C

E 0

26P

ER

010

131

The

rmal

Oxi

dize

rT

R 5

096C

Act

ive

Tan

n C

orp/

Lang

bein

Eng

elbr

acht

PM

2.5

PM

10P

MV

OC

1350

F; 0

.8se

cre

tent

ion

100

100

100

100

62 62 62 97

27C

E 0

27P

ER

011

053

Ven

turi

Scr

ubbe

r2-

SV

-PB

S-1

2A

ctiv

eS

CP

Inc.

PM

10P

M10

010

084 94

28C

E 0

28P

ER

011

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

2-S

V-P

BS

-12

Act

ive

SC

P In

c.P

M10

PM

100

100

84 85

29C

E 0

29P

ER

011

053

Ven

turi

Scr

ubbe

r2-

SV

24-P

BS

-32

Act

ive

SC

P In

c.P

M10

PM

100

100

84 94

30C

E 0

30P

ER

011

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

2-S

V24

-PB

S-3

2A

ctiv

eS

CP

Inc.

PM

10P

M10

010

084 85

31C

E 0

31P

ER

011

050

Pac

ked-

Gas

Ads

orpt

ion

Col

umn

RA

S-1

00A

ctiv

eS

CP

Inc.

PM

10P

M10

010

084 85

Pag

e 2

of

2

ST.

PA

UL

, MN

551

55-4

194

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

D

14 M

ay, 2

013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

Max

Fue

lIn

put

(mil

Btu

)

Hor

mel

Foo

ds C

orp/

QP

P -

Aus

tin

Ret

ired

By

(Act

ion)

Ope

rato

r D

escr

iptio

nID

No.

Em

issi

onU

nit

Sta

tus

Add

edB

y(A

ctio

n)

Con

trol

Equ

ip.

ID N

o(s)

.

Sta

ck/

Ven

tID

No(

s).

Ope

rato

rID

for

Item

Insi

gnif-

ican

tA

ctiv

ity

SIC

Man

ufac

ture

rM

odel

Num

ber

Max

.D

esig

nC

apac

ity

Max

imum

Des

ign

Cap

acity

Mat

eria

lsU

nits

nU

nits

d

491

Boi

ler

#1E

U 0

01A

ctiv

eP

ER

006

SV

001

Hr

Hea

t20

13N

ebra

ska

NS

049

49M

mbt

u

492

Boi

ler

#2E

U 0

02A

ctiv

eP

ER

006

SV

001

Hr

Hea

t20

13N

ebra

ska

NS

049

49M

mbt

u

493

Boi

ler

#3E

U 0

03A

ctiv

eP

ER

006

SV

001

Hr

Hea

t20

13N

ebra

ska

NS

049

49M

mbt

u

254

Boi

ler

#4E

U 0

04A

ctiv

eP

ER

006

SV

001

Hr

Hea

t20

13C

leav

er B

rook

sP

B 4

00-6

0025

Mm

btu

7.14

5B

oile

r #5

EU

005

Act

ive

PE

R 0

06S

V 0

01H

r

H

eat

2013

Ecl

ipse

PR

CG

O7.

14M

mbt

u

1.5

6S

mok

ed M

eat O

ven

#6 w

ithre

circ

ulat

ed n

atur

al w

ood

smok

e

EU

006

Act

ive

PE

R 0

08S

V 0

03 (

M)

Hr

Hea

t20

13G

ladd

Ind

ustr

ies

oven

-gas

1.5

Mm

btu

1.5

7S

mok

ed M

eat O

ven

#7 w

ithre

circ

ulat

ed n

atur

al w

ood

smok

e

EU

007

Act

ive

PE

R 0

08S

V 0

05 (

M)

Hr

Hea

t20

13G

ladd

Ind

ustr

ies

oven

-gas

1.5

Mm

btu

1.5

8S

mok

ed M

eat O

ven

#8 w

ithre

circ

ulat

ed n

atur

al w

ood

smok

e

EU

008

Act

ive

PE

R 0

08S

V 0

07 (

M)

Hr

Hea

t20

13G

ladd

Ind

ustr

ies

oven

-gas

1.5

Mm

btu

1.5

9S

mok

ed M

eat O

ven

#9 w

ithre

circ

ulat

ed n

atur

al w

ood

smok

e

EU

009

Act

ive

PE

R 0

08S

V 0

09 (

M)

Hr

Hea

t20

13G

ladd

Ind

ustr

ies

oven

-gas

1.5

Mm

btu

1.5

10S

mok

ed M

eat O

ven

#10

with

reci

rcul

ated

nat

ural

woo

dsm

oke

EU

010

Act

ive

PE

R 0

08S

V 0

11 (

M)

Hr

Hea

t20

13G

ladd

Ind

ustr

ies

oven

-gas

1.5

Mm

btu

1.5

11S

mok

ed M

eat O

ven

#11

with

reci

rcul

ated

nat

ural

woo

dsm

oke

EU

011

Act

ive

PE

R 0

08S

V 0

12H

r

H

eat

2013

Gla

dd I

ndus

trie

sov

en-g

as1.

5M

mbt

u

1.5

12Li

quid

Sm

oke

Sm

oked

Mea

tO

ven

#12

EU

012

Act

ive

EIS

002

SV

013

Hr

Hea

t20

13A

lkar

oven

-gas

1.5

Mm

btu

1.5

13Li

quid

Sm

oke

Pre

p. S

ausa

geO

ven

#1E

U 0

13A

ctiv

eE

IS 0

02S

V 0

14H

r

H

eat

2013

Gla

dd I

ndus

trie

sov

en-g

as1.

5M

mbt

u

1.5

14Li

quid

Sm

oke

Pre

p. S

ausa

geO

ven

#2E

U 0

14A

ctiv

eE

IS 0

02S

V 0

15H

r

H

eat

2013

Gla

dd I

ndus

trie

sov

en-g

as1.

5M

mbt

u

1.5

15Li

quid

Sm

oke

Pre

p. S

ausa

geO

ven

#3E

U 0

15A

ctiv

eE

IS 0

02S

V 0

16H

r

H

eat

2013

Gla

dd I

ndus

trie

sov

en-g

as1.

5M

mbt

u

1.5

16Li

quid

Sm

oke

Pre

p. S

ausa

geO

ven

#4E

U 0

16A

ctiv

eE

IS 0

02S

V 0

17H

r

H

eat

2013

Gla

dd I

ndus

trie

sov

en-g

as1.

5M

mbt

u

1.5

17Li

quid

Sm

oke

Pre

p. S

ausa

geO

ven

#5E

U 0

17A

ctiv

eE

IS 0

02S

V 0

18H

r

H

eat

2013

Gla

dd I

ndus

trie

sov

en-g

as1.

5M

mbt

u

18P

reco

oked

Bac

on, S

outh

EU

018

Act

ive

PE

R 0

01C

E 0

06S

V 0

19H

r

20

13R

ayth

eon

Cus

tom

mad

e19

80L

b

19P

reco

oked

Bac

on, N

orth

EU

019

Act

ive

PE

R 0

01C

E 0

06S

V 0

19H

r

20

13R

ayth

eon

Cus

tom

mad

e19

80L

b

Pag

e 1

of

5 (

a)

14 M

ay,

2013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

ID N

o.E

leva

tor

Type

Bot

tlene

ckP

ct.

Fue

l/S

pace

Hea

t

Firi

ng M

etho

dA

dded

By

(Act

ion)

Rem

oval

Dat

eIn

itial

Sta

rtup

Dat

e

Com

m-

ence

Con

st.

Dat

e

Em

issi

onU

nit

Sta

tus

1E

U 0

01P

ER

006

01/0

1/19

82

01/0

1/19

80

Act

ive

2E

U 0

02P

ER

006

01/0

1/19

82

01/0

1/19

80

Act

ive

3E

U 0

03P

ER

006

01/0

1/19

82

01/0

1/19

80

Act

ive

4E

U 0

04P

ER

006

01/0

1/19

82

01/0

1/19

80

Act

ive

5E

U 0

05P

ER

006

01/0

1/19

82

01/0

1/19

80

Act

ive

6E

U 0

06P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

7E

U 0

07P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

8E

U 0

08P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

9E

U 0

09P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

10E

U 0

10P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

11E

U 0

11P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

12E

U 0

12E

IS 0

0201

/01/

199

401

/01/

199

4A

ctiv

e

13E

U 0

13E

IS 0

0201

/01/

198

201

/01/

198

2A

ctiv

e

14E

U 0

14E

IS 0

0201

/01/

198

201

/01/

198

2A

ctiv

e

15E

U 0

15E

IS 0

0201

/01/

198

201

/01/

198

2A

ctiv

e

16E

U 0

16E

IS 0

0201

/01/

198

201

/01/

198

2A

ctiv

e

17E

U 0

17E

IS 0

0201

/01/

198

201

/01/

198

2A

ctiv

e

18E

U 0

18P

ER

001

01/0

1/19

90

01/0

1/19

90

Act

ive

19E

U 0

19P

ER

001

01/0

1/19

90

01/0

1/19

90

Act

ive

Pag

e 1

of

5 (

b)

ST.

PA

UL

, MN

551

55-4

194

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

D

14 M

ay, 2

013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

Max

Fue

lIn

put

(mil

Btu

)

Hor

mel

Foo

ds C

orp/

QP

P -

Aus

tin

Ret

ired

By

(Act

ion)

Ope

rato

r D

escr

iptio

nID

No.

Em

issi

onU

nit

Sta

tus

Add

edB

y(A

ctio

n)

Con

trol

Equ

ip.

ID N

o(s)

.

Sta

ck/

Ven

tID

No(

s).

Ope

rato

rID

for

Item

Insi

gnif-

ican

tA

ctiv

ity

SIC

Man

ufac

ture

rM

odel

Num

ber

Max

.D

esig

nC

apac

ity

Max

imum

Des

ign

Cap

acity

Mat

eria

lsU

nits

nU

nits

d

20P

reco

oked

Bac

on, E

ast

EU

020

Act

ive

PE

R 0

01C

E 0

07S

V 0

20H

r

20

13R

ayth

eon

Cus

tom

mad

e19

80L

b

21P

reco

oked

Bac

on, W

est

EU

021

Act

ive

PE

R 0

01C

E 0

07S

V 0

20H

r

20

13R

ayth

eon

Cus

tom

mad

e19

80L

b

22S

tand

by G

ener

ator

EU

022

Rem

oved

PE

R 0

08E

nerg

y20

13O

nan

550E

N 1

5R/1

699D

55K

w

23M

W B

acon

Pad

Cut

ter

EU

023

Rem

oved

PE

R 0

0820

13S

trau

b D

esig

n C

ompa

n

24M

W B

acon

Pad

Cut

ter

EU

024

Rem

oved

PE

R 0

0820

13S

trau

b D

esig

n C

ompa

n

2.27

25F

ulto

n H

eate

rE

U 0

25A

ctiv

eP

ER

008

2013

Ful

ton

FT

O-2

40C

26B

elt G

rill P

reco

oked

Lin

eE

U 0

26R

emov

edP

ER

008

Hr

2013

Kop

pens

BG

7200

-950

1620

Lb

27R

ende

ring

Roo

m A

irE

U 0

27A

ctiv

eP

ER

006

CE

008

SV

026

Min

2013

5000

0F

t3

28R

ende

ring

Mac

hine

ryE

U 0

28A

ctiv

eP

ER

010

CE

008

CE

009

CE

022

CE

023

CE

026

SV

026

(M

)S

V 0

27 (

B)

SV

058

(M

)

Hr

2013

Dup

ps26

0J18

00G

al

29B

acon

Bits

Pre

cook

ed L

ine

EU

029

Act

ive

PE

R 0

08C

E 0

25S

V 0

50H

r

20

13A

man

aN

one

8050

Lb

830

Hog

Sin

ger

#1

EU

030

Act

ive

PE

R 0

0820

13H

orm

el

31N

atur

al S

mok

e G

ener

ator

EU

031

Act

ive

PE

R 0

08S

V 0

03S

V 0

05S

V 0

07S

V 0

09S

V 0

11

Hr

Woo

d20

13S

chro

ter

R91

100

Lb

32N

atur

al S

mok

e G

ener

ator

EU

032

Act

ive

PE

R 0

08S

V 0

03S

V 0

05S

V 0

07S

V 0

09S

V 0

11

Hr

Woo

d20

13S

chro

ter

R91

100

Lb

33G

P S

alt S

yste

mE

U 0

33A

ctiv

eE

IS 0

02C

E 0

15S

V 0

30H

r

20

1320

000

Lb

34M

P S

alt S

yste

mE

U 0

34A

ctiv

eE

IS 0

02C

E 0

16S

V 0

31H

r

20

1320

000

Lb

35G

P S

ugar

Sys

tem

EU

035

Act

ive

PE

R 0

08C

E 0

17S

V 0

32H

r

20

1320

000

Lb

936

Exi

stin

g S

cott

Bon

e D

ryer

EU

036

Act

ive

PE

R 0

10C

E 0

18C

E 0

26S

V 0

58H

r

20

13S

cott

4815

/144

LVS

144

1200

0L

b

37V

apor

Sm

oke

Gen

erat

or #

1E

U 0

37A

ctiv

eP

ER

008

CE

012

SV

014

2013

Ger

mos

38V

apor

Sm

oke

Gen

erat

or #

2E

U 0

38A

ctiv

eP

ER

008

CE

013

SV

015

2013

Ger

mos

39V

apor

Sm

oke

Gen

erat

or #

3E

U 0

39A

ctiv

eP

ER

008

CE

014

SV

016

SV

017

2013

Ger

mos

Pag

e 2

of

5 (

a)

14 M

ay,

2013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

ID N

o.E

leva

tor

Type

Bot

tlene

ckP

ct.

Fue

l/S

pace

Hea

t

Firi

ng M

etho

dA

dded

By

(Act

ion)

Rem

oval

Dat

eIn

itial

Sta

rtup

Dat

e

Com

m-

ence

Con

st.

Dat

e

Em

issi

onU

nit

Sta

tus

20E

U 0

20P

ER

001

01/0

1/19

90

01/0

1/19

90

Act

ive

21E

U 0

21P

ER

001

01/0

1/19

90

01/0

1/19

90

Act

ive

22E

U 0

22P

ER

008

01/0

1/20

04

01/0

1/19

82

01/0

1/19

82

Rem

oved

23E

U 0

23P

ER

008

01/0

1/20

04

01/0

1/19

9101

/01/

1991

Rem

oved

24E

U 0

24P

ER

008

01/0

1/20

04

01/0

1/19

9101

/01/

1991

Rem

oved

25E

U 0

25P

ER

008

01/0

1/19

9101

/01/

199

2A

ctiv

e

26E

U 0

26P

ER

008

01/0

1/20

05

01/0

1/19

92

01/0

1/19

92

Rem

oved

27E

U 0

27P

ER

006

01/0

1/19

82

01/0

1/19

82

Act

ive

28E

U 0

28P

ER

010

01/0

1/19

82

01/0

1/19

82

Act

ive

29E

U 0

29P

ER

008

04/2

9/19

98

Act

ive

30E

U 0

30P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

31E

U 0

31P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

32E

U 0

32P

ER

008

01/0

1/19

82

01/0

1/19

82

Act

ive

33E

U 0

33E

IS 0

02A

ctiv

e

34E

U 0

34E

IS 0

02A

ctiv

e

35E

U 0

35P

ER

008

Act

ive

36E

U 0

36P

ER

010

11/1

5/19

9610

/01/

199

6A

ctiv

e

37E

U 0

37P

ER

008

Act

ive

38E

U 0

38P

ER

008

Act

ive

39E

U 0

39P

ER

008

Act

ive

Pag

e 2

of

5 (

b)

ST.

PA

UL

, MN

551

55-4

194

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

D

14 M

ay, 2

013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

Max

Fue

lIn

put

(mil

Btu

)

Hor

mel

Foo

ds C

orp/

QP

P -

Aus

tin

Ret

ired

By

(Act

ion)

Ope

rato

r D

escr

iptio

nID

No.

Em

issi

onU

nit

Sta

tus

Add

edB

y(A

ctio

n)

Con

trol

Equ

ip.

ID N

o(s)

.

Sta

ck/

Ven

tID

No(

s).

Ope

rato

rID

for

Item

Insi

gnif-

ican

tA

ctiv

ity

SIC

Man

ufac

ture

rM

odel

Num

ber

Max

.D

esig

nC

apac

ity

Max

imum

Des

ign

Cap

acity

Mat

eria

lsU

nits

nU

nits

d

5.61

640

KC

-9 m

akeu

p ai

r ht

rE

U 0

40A

ctiv

eE

IS 0

02S

V 0

34M

in

20

13C

DI

DF

-230

-52-

100

59,0

00F

t3

2.16

41K

C-7

mak

eup

air

htr

EU

041

Act

ive

PE

R 0

08S

V 0

35M

in

20

13C

DI

DR

-218

-20-

100

20,0

00F

t3

2.47

542

Ren

derin

g m

akeu

p ai

r ht

rE

U 0

42A

ctiv

eE

IS 0

02S

V 0

36M

in

20

13T

itan

TA 3

0NG

HR

D23

,000

Ft3

2.47

543

Ren

derin

g m

akeu

p ai

r ht

rE

U 0

43A

ctiv

eE

IS 0

02S

V 0

37M

in

20

13T

itan

TA 3

0NG

HR

D23

,000

Ft3

29.4

44B

oile

r #6

EU

044

Act

ive

PE

R 0

06S

V 0

38H

r

20

13H

urst

Ser

ies

400

24,1

50L

b

29.4

45B

oile

r #7

EU

045

Act

ive

PE

R 0

06S

V 0

39H

r

20

13H

urst

Ser

ies

400

24,1

50L

b

46P

ad C

utte

rE

U 0

46R

emov

edP

ER

008

Hr

2013

Str

aub

Des

ign

840

Yd

3.0

47R

adia

nt W

all O

vens

#1

EU

047

Act

ive

PE

R 0

08H

r

20

13P

yram

id F

oods

40-1

528

000

Lb

0.24

348

RW

O M

AU

(0.

243

MM

Btu

/hr)

EU

048

Act

ive

EIS

002

SV

042

Min

2013

Kin

g20

05-9

5-D

F40

00F

t3

0.21

049

Dre

nch

Cab

inet

MA

U (

0.21

0M

MB

TU

/hr)

EU

049

Act

ive

PE

R 0

08S

V 0

43M

in

20

13K

ing

3000

Ft3

3.5

50N

ew D

uske

Blo

od D

ryer

EU

050

Act

ive

PE

R 0

10C

E 0

18C

E 0

26S

V 0

58H

r

M

eal,

Blo

od

2013

Dus

keT

PD

-125

033

00L

b

51E

mer

genc

y R

ICE

(s)

EU

051

Act

ive

PE

R 0

06S

V 0

44E

nerg

y20

13tb

dtb

d59

9H

p

4.0

52N

G S

pace

Hea

ter

- H

og C

utE

U 0

52A

ctiv

eP

ER

006

2013

4.0

53N

G S

pace

Hea

ter

- H

og C

utE

U 0

53A

ctiv

eP

ER

006

2013

2.31

354

NG

Spa

ce H

eate

r -

Pre

trea

tmen

tE

U 0

54A

ctiv

eP

ER

006

2013

2.31

355

NG

Spa

ce H

eate

r -

Pre

trea

tmen

tE

U 0

55A

ctiv

eP

ER

006

2013

3.25

556

NG

Spa

ce H

eate

r -

Fro

nt E

ndK

illE

U 0

56A

ctiv

eP

ER

006

2013

3.25

557

NG

Spa

ce H

eate

r -

Fro

nt E

ndK

illE

U 0

57A

ctiv

eP

ER

006

2013

0.32

58N

G S

pace

Hea

ter

- N

Hol

dP

enE

U 0

58A

ctiv

eP

ER

006

2013

0.32

59N

G S

pace

Hea

ter

- N

Hol

dP

enE

U 0

59A

ctiv

eP

ER

006

2013

0.75

60N

G S

pace

Hea

ter

- S

hop

EU

060

Act

ive

PE

R 0

0620

13

0.12

561

NG

Spa

ce H

eate

r -

Bre

akR

oom

EU

061

Act

ive

PE

R 0

0620

13

0.9

62La

undr

y (2

@ 0

.25

mm

Btu

/hr;

2@ 0

.2 m

mB

tu/h

r)E

U 0

62A

ctiv

eP

ER

006

2013

Pag

e 3

of

5 (

a)

14 M

ay,

2013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

ID N

o.E

leva

tor

Type

Bot

tlene

ckP

ct.

Fue

l/S

pace

Hea

t

Firi

ng M

etho

dA

dded

By

(Act

ion)

Rem

oval

Dat

eIn

itial

Sta

rtup

Dat

e

Com

m-

ence

Con

st.

Dat

e

Em

issi

onU

nit

Sta

tus

40E

U 0

40E

IS 0

0206

/15/

199

806

/01/

199

8A

ctiv

e

41E

U 0

41P

ER

008

06/1

5/19

98

06/0

1/19

98

Act

ive

42E

U 0

42E

IS 0

0206

/15/

199

806

/01/

199

8A

ctiv

e

43E

U 0

43E

IS 0

0206

/15/

199

806

/01/

199

8A

ctiv

e

44E

U 0

44N

o80

PE

R 0

0611

/01/

1999

Act

ive

45E

U 0

45N

o80

PE

R 0

0611

/01/

1999

Act

ive

46E

U 0

46P

ER

008

01/0

1/20

04

05/1

0/19

99

05/0

7/19

99

Rem

oved

47E

U 0

47P

ER

008

02/1

5/19

99

01/1

5/19

99

Act

ive

48E

U 0

48E

IS 0

0202

/15/

199

901

/30/

199

9A

ctiv

e

49E

U 0

49P

ER

008

06/1

5/19

99

05/0

1/19

99

Act

ive

50E

U 0

50P

ER

010

10/1

4/20

02

10/1

4/20

02

Act

ive

51E

U 0

51P

ER

006

Act

ive

52E

U 0

52P

ER

006

Act

ive

53E

U 0

53P

ER

006

Act

ive

54E

U 0

54P

ER

006

Act

ive

55E

U 0

55P

ER

006

Act

ive

56E

U 0

56P

ER

006

Act

ive

57E

U 0

57P

ER

006

Act

ive

58E

U 0

58P

ER

006

Act

ive

59E

U 0

59P

ER

006

Act

ive

60E

U 0

60P

ER

006

Act

ive

61E

U 0

61P

ER

006

Act

ive

62E

U 0

62P

ER

006

Act

ive

Pag

e 3

of

5 (

b)

ST.

PA

UL

, MN

551

55-4

194

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

D

14 M

ay, 2

013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

Max

Fue

lIn

put

(mil

Btu

)

Hor

mel

Foo

ds C

orp/

QP

P -

Aus

tin

Ret

ired

By

(Act

ion)

Ope

rato

r D

escr

iptio

nID

No.

Em

issi

onU

nit

Sta

tus

Add

edB

y(A

ctio

n)

Con

trol

Equ

ip.

ID N

o(s)

.

Sta

ck/

Ven

tID

No(

s).

Ope

rato

rID

for

Item

Insi

gnif-

ican

tA

ctiv

ity

SIC

Man

ufac

ture

rM

odel

Num

ber

Max

.D

esig

nC

apac

ity

Max

imum

Des

ign

Cap

acity

Mat

eria

lsU

nits

nU

nits

d

0.39

663

Offi

ce b

oile

rE

U 0

63A

ctiv

eP

ER

006

2013

0.97

64P

retr

eatm

ent B

oile

r 1

EU

064

Rem

oved

PE

R 0

0820

13

0.97

65P

retr

eatm

ent B

oile

r 2

EU

065

Rem

oved

PE

R 0

0820

13

0.97

66P

retr

eatm

ent B

oile

r 3

EU

066

Rem

oved

PE

R 0

0820

13

3.0

67R

adia

nt W

all O

vens

#2

EU

067

Act

ive

PE

R 0

08H

r

20

13P

yram

id F

oods

40-1

528

000

Lb

6.5

68H

og H

air

Sin

ger

#2E

U 0

68A

ctiv

eP

ER

008

SV

047

2013

SE

LO76

0

5.61

669

Old

Boi

ler

Roo

m M

AU

EU

069

Act

ive

PE

R 0

0820

13C

DI

DF

-230

-52-

100

70La

rd D

eodo

rizer

Coo

ling

Tow

erE

U 0

70A

ctiv

eP

ER

008

SV

048

2013

71R

oom

Air

- B

lood

& B

one

Dry

ing

EU

071

Act

ive

PE

R 0

08C

E 0

19S

V 0

4520

13

72R

oom

Air

Doc

k A

rea

EU

072

Act

ive

PE

R 0

08C

E 0

20C

E 0

21S

V 0

4920

13

73D

ock

Are

a S

urfa

ce V

ats

EU

073

Act

ive

PE

R 0

08C

E 0

20C

E 0

21S

V 0

4920

13

1.0

74K

ill F

loor

MA

UE

U 0

74A

ctiv

eP

ER

008

2013

0.27

375

Des

sica

nt A

ir H

andl

erE

U 0

75A

ctiv

eP

ER

008

2013

2.17

76R

ende

ring

MA

UE

U 0

76A

ctiv

eP

ER

008

2013

1.36

177

New

Boi

ler

Roo

m M

AU

EU

077

Act

ive

PE

R 0

0820

13

78N

G-f

ired

Em

erge

ncy

Gen

erat

or (

100

kW)

EU

078

Act

ive

PE

R 0

08E

nerg

y20

1310

0K

w

79P

ig S

kin

Sal

t bin

filte

r ve

ntE

U 0

79A

ctiv

eP

ER

008

2013

18.0

380

Gen

erat

or #

1E

U 0

80A

ctiv

eP

ER

009

SV

051

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

18.0

381

Gen

erat

or #

2E

U 0

81A

ctiv

eP

ER

009

SV

052

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

18.0

382

Gen

erat

or #

3E

U 0

82A

ctiv

eP

ER

009

SV

053

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

18.0

383

Gen

erat

or #

4E

U 0

83A

ctiv

eP

ER

009

SV

054

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

18.0

384

Gen

erat

or #

5E

U 0

84A

ctiv

eP

ER

009

SV

055

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

18.0

385

Gen

erat

or #

6E

U 0

85A

ctiv

eP

ER

009

SV

056

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

18.0

386

Gen

erat

or #

7E

U 0

86A

ctiv

eP

ER

009

SV

057

Ele

ct E

nerg

y20

13C

ater

pilla

r35

1620

00K

w

Pag

e 4

of

5 (

a)

14 M

ay,

2013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

ID N

o.E

leva

tor

Type

Bot

tlene

ckP

ct.

Fue

l/S

pace

Hea

t

Firi

ng M

etho

dA

dded

By

(Act

ion)

Rem

oval

Dat

eIn

itial

Sta

rtup

Dat

e

Com

m-

ence

Con

st.

Dat

e

Em

issi

onU

nit

Sta

tus

63E

U 0

63P

ER

006

Act

ive

64E

U 0

64P

ER

008

01/0

1/20

04

Rem

oved

65E

U 0

65P

ER

008

01/0

1/20

04

Rem

oved

66E

U 0

66P

ER

008

01/0

1/20

04

Rem

oved

67E

U 0

67P

ER

008

03/1

5/19

99

01/1

5/19

99

Act

ive

68E

U 0

68P

ER

008

09/0

9/20

03

09/0

1/20

03

Act

ive

69E

U 0

69P

ER

008

11/0

1/19

9910

/20/

199

9A

ctiv

e

70E

U 0

70P

ER

008

01/1

0/20

08

01/0

1/19

82

Act

ive

71E

U 0

71P

ER

008

Act

ive

72E

U 0

72P

ER

008

Act

ive

73E

U 0

73P

ER

008

Act

ive

74E

U 0

74P

ER

008

Act

ive

75E

U 0

75P

ER

008

Act

ive

76E

U 0

76P

ER

008

Act

ive

77E

U 0

77P

ER

008

Act

ive

78E

U 0

78P

ER

008

01/0

1/20

04

01/0

1/20

04

Act

ive

79E

U 0

79P

ER

008

Act

ive

80E

U 0

80P

ER

009

Act

ive

81E

U 0

81P

ER

009

Act

ive

82E

U 0

82P

ER

009

Act

ive

83E

U 0

83P

ER

009

Act

ive

84E

U 0

84P

ER

009

Act

ive

85E

U 0

85P

ER

009

Act

ive

86E

U 0

86P

ER

009

Act

ive

Pag

e 4

of

5 (

b)

ST.

PA

UL

, MN

551

55-4

194

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

D

14 M

ay, 2

013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

Max

Fue

lIn

put

(mil

Btu

)

Hor

mel

Foo

ds C

orp/

QP

P -

Aus

tin

Ret

ired

By

(Act

ion)

Ope

rato

r D

escr

iptio

nID

No.

Em

issi

onU

nit

Sta

tus

Add

edB

y(A

ctio

n)

Con

trol

Equ

ip.

ID N

o(s)

.

Sta

ck/

Ven

tID

No(

s).

Ope

rato

rID

for

Item

Insi

gnif-

ican

tA

ctiv

ity

SIC

Man

ufac

ture

rM

odel

Num

ber

Max

.D

esig

nC

apac

ity

Max

imum

Des

ign

Cap

acity

Mat

eria

lsU

nits

nU

nits

d

8.0

87R

egen

erat

ive

The

rmal

Oxi

dize

r (C

E 0

26)

EU

087

Act

ive

PE

R 0

10S

V 0

58 (

M)

Hea

t20

13Ta

nn C

orp/

Lan

gbei

n E

TR

509

6C8.

0M

mbt

u

88R

efin

ed P

rodu

cts

Mac

hine

ryE

U 0

88A

ctiv

eP

ER

011

CE

026

CE

027

CE

028

SV

058

(M

)H

r

20

13D

upps

440U

4600

Ga

l

89C

rax

Roo

m A

irE

U 0

89A

ctiv

eP

ER

011

CE

029

CE

030

SV

059

(M

)M

in

A

irflo

w20

13C

usto

m24

000

Ft3

90T

ruck

Loa

dout

Roo

m A

irE

U 0

90A

ctiv

eP

ER

011

CE

030

SV

059

(M

)M

in

A

irflo

w20

13C

usto

m80

00F

t3

91R

efin

ed P

rodu

cts

Roo

m A

irE

U 0

91A

ctiv

eP

ER

011

CE

031

SV

060

(M

)S

V 0

61 (

M)

Min

Airf

low

2013

Cus

tom

1000

00F

t3

92R

efin

ed P

rodu

cts

MA

U 1

EU

092

Act

ive

PE

R 0

11S

V 0

62 (

M)

Hr

Nat

ural

Gas

2013

Gre

enH

eck

DG

X-1

36-H

42-I

I48

96M

mbt

u

93R

efin

ed P

rodu

cts

MA

U 2

EU

093

Act

ive

PE

R 0

11S

V 0

63 (

M)

Hr

Nat

ural

Gas

2013

Gre

enH

eck

DG

X-1

36-H

42-I

I48

96M

mbt

u

94R

efin

ed P

rodu

cts

MA

U 3

EU

094

Act

ive

PE

R 0

11S

V 0

64 (

M)

Hr

Nat

ural

Gas

2013

Gre

enH

eck

DG

X-1

36-H

42-I

I24

48M

mbt

u

Pag

e 5

of

5 (

a)

14 M

ay,

2013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: E

MIS

SIO

N U

NIT

(EU

)

ID N

o.E

leva

tor

Type

Bot

tlene

ckP

ct.

Fue

l/S

pace

Hea

t

Firi

ng M

etho

dA

dded

By

(Act

ion)

Rem

oval

Dat

eIn

itial

Sta

rtup

Dat

e

Com

m-

ence

Con

st.

Dat

e

Em

issi

onU

nit

Sta

tus

87E

U 0

87P

ER

010

10/0

1/20

1108

/01/

2011

Act

ive

88E

U 0

88P

ER

011

Act

ive

89E

U 0

89P

ER

011

Act

ive

90E

U 0

90P

ER

011

Act

ive

91E

U 0

91P

ER

011

Act

ive

92E

U 0

92P

ER

011

Act

ive

93E

U 0

93P

ER

011

Act

ive

94E

U 0

94P

ER

011

Act

ive

Pag

e 5

of

5 (

b)

Insi

gnif-

ican

tA

ctiv

ity

Ope

rato

rID

for

Item

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay, 2

013

16:

08

FAC

ILIT

Y D

ESC

RIP

TIO

N: S

TOR

AG

E T

AN

KS

(TK

)

ID N

o.C

apac

ity(1

000

gal)

Inte

rior

Hei

ght

(ft.

)

Inte

rior

Dia

met

er(f

t.)

Add

edB

y(A

ctio

n)

Con

stru

ctio

n Ty

peTa

nkS

tatu

sP

rodu

ct S

tore

dC

ontr

olE

quip

.ID

No(

s).

Ret

ired

By

(Act

ion)

1T

K 0

0120

030

34A

ctiv

eE

IS 0

02N

o. 6

Fue

l oil

2T

K 0

0120

030

34R

emov

edP

ER

011

No.

6 F

uel o

il

3T

K 0

0220

030

34A

ctiv

eE

IS 0

02N

o. 6

Fue

l oil

4T

K 0

0220

030

34R

emov

edP

ER

011

No.

6 F

uel o

il

5T

K 0

0310

024

27A

ctiv

eE

IS 0

02N

o. 6

Fue

l oil

6T

K 0

0310

024

27R

emov

edP

ER

011

No.

6 F

uel o

il

Pag

e 1

of

1 (a

)

ID N

o.

FAC

ILIT

Y D

ESC

RIP

TIO

N: S

TOR

AG

E T

AN

KS

(TK

)

14 M

ay, 2

013

16:

08

Yea

rR

emov

edY

ear

Inst

alle

dS

eal T

ype

(flo

atin

g ro

of o

nly)

Add

edB

y(A

ctio

n)

Sup

port

Typ

e(f

loat

ing

roof

onl

y)C

olum

nC

ount

Col

umn

Dia

met

er(f

t.)

Dec

k Ty

pe

(flo

atin

g ro

of o

nly)

Tank

Sta

tus

1T

K 0

01E

IS 0

02A

ctiv

e

2T

K 0

01P

ER

011

Rem

oved

3T

K 0

02E

IS 0

02A

ctiv

e

4T

K 0

02P

ER

011

Rem

oved

5T

K 0

03E

IS 0

02A

ctiv

e

6T

K 0

03P

ER

011

Rem

oved

Pag

e 1

of

1 (

b)

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay, 2

013

16:

09

FAC

ILIT

Y D

ESC

RIP

TIO

N: C

ON

TIN

UO

US

MO

NIT

OR

S (M

R)

Par

amet

ers

Mon

itore

dS

eria

l Num

ber

ID N

o.M

odel

Num

ber

Man

ufac

ture

rO

pera

tor

IDfo

r It

em

Mon

itore

dIt

em

(ID

No(

s).)

Ret

ired

By

(Act

ion)

Add

edB

y(A

ctio

n)

Mon

itor

Des

crip

tion

Mon

itor

Sta

tus

1T

emp

tbd

MR

001

tbd

tbd

SV

058

PE

R 0

10C

E 0

26/E

U 0

87 C

ombu

stio

n C

ham

ber

Tem

pera

ture

Act

ive

Pag

e 1

of

1 (a

)

14 M

ay,

2013

16:

09

FAC

ILIT

Y D

ESC

RIP

TIO

N: C

ON

TIN

UO

US

MO

NIT

OR

S (M

R)

ID N

o.A

dded

By

(Act

ion)

Spa

nV

alue

Sys

tem

Ful

l-S

cale

Val

ue

Byp

ass

Cap

a-bi

lity?

Rem

oval

Dat

eIn

stal

latio

nD

ate

Opt

ical

Pa

thLe

ngth

Rat

io

Mon

itor

Sta

tus

1M

R 0

01P

ER

010

No

08/0

1/20

11A

ctiv

e

Pag

e 1

of

1 (

b)

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y14

May

, 201

3 1

6:09

520

LA

FAY

ET

TE

RO

AD

ST.

PA

UL

, MN

551

55-4

194

FAC

ILIT

Y D

ESC

RIP

TIO

N: D

ATA

AC

QU

ISIT

ION

SY

STE

MS

(DA

)

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

ID N

o.R

emov

alD

ate

Inst

alla

tion

Dat

eD

ata

Sto

rage

Med

ium

Ser

ial N

umbe

rM

anuf

actu

rer

Mod

el N

umbe

rD

AS

Sta

tus

Ope

rato

rID

for

Item

Dat

a A

cqui

sitio

n S

yste

m D

escr

iptio

nR

etire

dB

y(A

ctio

n)

Add

edB

y(A

ctio

n)

1D

A 0

0108

/01/

2011

Ele

ctro

nic

tbd

tbd

tbd

Act

ive

Reg

ener

ativ

e T

herm

al O

xidi

zer

PE

R 0

10

Pag

e 1

of

1

MIN

NE

SOTA

PO

LL

UT

ION

CO

NT

RO

L A

GE

NC

YA

IR Q

UA

LIT

Y52

0 L

AFA

YE

TT

E R

OA

DS

T. P

AU

L, M

N 5

5155

-419

4

Sho

w:

Act

ive

and

Pen

ding

Rec

ords

Act

ion:

PE

R 0

11

AQ

D F

acili

ty ID

:09

9000

02

Fac

ility

Nam

e:H

orm

el F

oods

Cor

p/Q

PP

- A

ustin

14 M

ay, 2

013

16:

0914

May

, 20

13

16:0

9

FAC

ILIT

Y D

ESC

RIP

TIO

N: C

ON

TIN

UO

US

MO

NIT

OR

ING

SY

STE

MS

(CM

)

ID N

o.A

dded

By

(Act

ion)

Ret

ired

By

(Act

ion)

Mon

itor

ID N

o(s)

.D

AS

ID N

o(s)

.O

pera

tor

IDfo

r It

em

CM

S D

escr

iptio

nP

aram

eter

Mon

th/

Yea

r In

stal

led

Mon

th/

Yea

rR

emov

ed

Cer

t.D

ate

Cer

t.B

asis

CM

SS

tatu

s

1C

M 0

01P

ER

010

MR

001

DA

001

RT

O C

ombu

stio

n C

ham

ber

Tem

pera

ture

Tem

pera

ture

08

/20

11A

ctiv

e

Pag

e 1

of

1

MINNESOTA POLLUTION CONTROL AGENCYAIR QUALITY520 LAFAYETTE ROADST. PAUL, MN 55155-4194

14 May, 2013 16:10

FACILITY DESCRIPTION: Potential-to-emit (by item)

Show: Active and Pending Records

AQD Facility ID:

Facility Name:

09900002

Hormel Foods Corp/QPP - Austin

Item UnrestrictedPotential

(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 001

Benzene PER 008 1.03E-04 4.51E-04

Benzene PER 011 4.42E-041.01E-04 4.42E-04

Arsenic compounds PER 008 4.37E-04 1.91E-03

Arsenic compounds PER 011 1.95E-034.46E-04 1.95E-03

Bis(2-ethylhexyl) phthalate PER 008

Beryllium Compounds PER 008 9.20E-06 4.03E-05

Beryllium Compounds PER 011 4.11E-059.39E-06 4.11E-05

Carbon Dioxide Equivalent PER 010 7.15E+03 3.13E+04

Carbon Dioxide Equivalent PER 011 3.36E+047.68E+03 3.36E+04

Cadmium compounds PER 008 1.32E-04 5.77E-04

Cadmium compounds PER 011 5.89E-041.34E-04 5.89E-04

Methane PER 011 5.20E-011.20E-01 5.20E-01

Carbon Monoxide PER 008 1.80E+014.12E+00 1.80E+01


Carbon Dioxide PER 011 3.36E+047.68E+03 3.36E+04

Cobalt compounds PER 008 1.99E-03 8.73E-03

Cobalt compounds PER 011 8.91E-032.03E-03 8.91E-03

Chromium compounds PER 008 2.80E-04 1.22E-03

Chromium compounds PER 011 1.25E-032.86E-04 1.25E-03

Dibutyl phthalate PER 008

1,4-Dichlorobenzene PER 011 2.52E-045.76E-05 2.52E-04

Ethylbenzene PER 008 2.10E-05 9.22E-05

Ethylbenzene PER 011 9.41E-052.15E-05 9.41E-05

Formaldehyde PER 008 1.41E-02 6.16E-02

Formaldehyde PER 011 4.88E-021.12E-02 4.88E-02

Hexane PER 008 3.86E-018.82E-02 3.86E-01

Hexane PER 011 3.79E-018.60E-02 3.79E-01

Naphthalene PER 008 3.74E-04 1.64E-03

Naphthalene PER 011 1.67E-033.82E-04 1.67E-03

HAPs - Total PER 008 4.10E-019.00E-02 4.10E-01

Mercury Compounds PER 008 3.74E-05 1.64E-04

Mercury Compounds PER 011 1.67E-043.82E-05 1.67E-04

Phenol PER 008

Toluene PER 008 2.05E-03 8.98E-03

Toluene PER 011 9.18E-032.10E-03 9.18E-03

1,1,1-Trichloroethane PER 011 3.49E-047.98E-05 3.49E-04

Manganese compounds PER 008 9.93E-04 4.35E-03

Manganese compounds PER 011 4.44E-031.01E-03 4.44E-03

Nitrous Oxide PER 011 5.00E-021.00E-02 5.00E-02

Lead Compounds PER 008 5.00E-04 2.19E-03

Lead Compounds PER 011 2.00E-024.08E-03 2.00E-02

o-Xylenes PER 008 3.51E-05 1.58E-04

o-Xylenes PER 011 1.61E-043.68E-05 1.61E-04

Phosphorus PER 008

Total Polycyclic aromatic hydr PER 008 3.94E-04 1.73E-03

Total Polycyclic aromatic hydr PER 011

Page 1 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 001

Nickel compounds PER 008 2.80E-02 1.22E-01

Nickel compounds PER 011 1.25E-012.86E-02 1.25E-01

Nitrogen Oxides PER 010 7.97E+011.82E+01 7.97E+01


Octachloridibenzo-p-dioxin (OC PER 011 4.60E-091.10E-09 4.60E-09

PM < 2.5 micron PER 011 7.26E+001.66E+00 7.26E+00

Lead PER 008 4.96E-04 2.17E-03

Lead PER 011 2.00E-024.08E-03 2.00E-02

PM < 10 micron PER 006 2.79E+01 2.78E+016.36E+00 2.78E+01

PM < 10 micron PER 011 7.26E+001.66E+00 7.26E+00

Polycyclic organic matter PER 008

Polycyclic organic matter PER 011 1.82E-054.15E-06 1.82E-05

Total Particulate Matter PER 006 7.31E+00 3.20E+01

Total Particulate Matter PER 011 7.26E+001.66E+00 7.26E+00

Antimony compounds PER 008 1.74E-03 7.61E-03

Antimony compounds PER 011 7.77E-031.77E-03 7.77E-03

Selenium compounds PER 008 2.26E-04 9.90E-04

Selenium compounds PER 011 1.01E-032.31E-04 1.01E-03

Sulfur Dioxide PER 010 4.36E+029.80E+01 4.30E+02


Volatile Organic Compounds PER 006 1.18E+002.70E-01 1.18E+00


Zinc PER 011 4.31E-029.83E-03 4.31E-02

EU 002

Benzene PER 008 1.03E-04 4.51E-04

Benzene PER 011 4.42E-041.01E-04 4.42E-04








Cadmium compounds PER 001 4.20E-03 2.80E-035.60E-03 2.44E-02


Methane PER 011 5.20E-011.20E-01 5.20E-01











Page 2 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 002




Hexane PER 008 3.86E-018.82E-02 3.86E-01

Hexane PER 011 3.79E-018.60E-02 3.79E-01






Phenol PER 008

Toluene PER 008 2.05E-03 8.98E-03

Toluene PER 011 9.18E-032.10E-03 9.18E-03







o-Xylenes PER 008 3.51E-05 1.58E-04

o-Xylenes PER 011 1.61E-043.68E-05 1.61E-04

Phosphorus PER 008








PM < 2.5 micron PER 011 7.26E+001.66E+00 7.26E+00

Lead PER 008 4.96E-04 2.17E-03

Lead PER 011 2.00E-024.08E-03 2.00E-02


PM < 10 micron PER 011 7.26E+001.66E+00 7.26E+00













Page 3 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 002

Zinc PER 011 4.31E-029.83E-03 4.31E-02

EU 003

Benzene PER 008 1.03E-04 4.51E-04

Benzene PER 011 4.42E-041.01E-04 4.42E-04










Methane PER 011 5.20E-011.20E-01 5.20E-01














Hexane PER 008 3.86E-018.82E-02 3.86E-01

Hexane PER 011 3.79E-018.60E-02 3.79E-01






Phenol PER 008

Toluene PER 008 2.05E-03 8.98E-03

Toluene PER 011 9.18E-032.10E-03 9.18E-03







o-Xylenes PER 008 3.51E-05 1.58E-04

o-Xylenes PER 011 1.61E-043.68E-05 1.61E-04

Phosphorus PER 008

Page 4 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 003








PM < 2.5 micron PER 011 7.26E+001.66E+00 7.26E+00

Lead PER 008 4.96E-04 2.17E-03

Lead PER 011 2.00E-024.08E-03 2.00E-02


PM < 10 micron PER 011 7.26E+001.66E+00 7.26E+00













Zinc PER 011 4.31E-029.83E-03 4.31E-02

EU 004

Benzene PER 008 5.25E-05 2.30E-04

Benzene PER 011 2.26E-045.17E-05 2.26E-04

Arsenic compounds PER 001 1.30E-03 6.00E-042.01E-02 8.80E-02









Methane PER 011 2.70E-016.00E-02 2.70E-01









Page 5 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 004






Hexane PER 008 1.97E-014.50E-02 1.97E-01

Hexane PER 011 1.94E-014.40E-02 1.94E-01







Phenol PER 008

Toluene PER 008 1.05E-03 4.58E-03

Toluene PER 011 4.70E-031.07E-03 4.70E-03







o-Xylenes PER 008 1.84E-05 8.06E-05

o-Xylenes PER 011 8.26E-051.89E-05 8.26E-05

Phosphorus PER 008







Octachloridibenzo-p-dioxin (OC PER 011 2.40E-092.40E-09

PM < 2.5 micron PER 011 3.72E+008.50E-01 3.72E+00

Lead PER 006 2.00E-03 9.00E-03

Lead PER 011 1.00E-022.09E-03 1.00E-02


PM < 10 micron PER 011 3.72E+008.50E-01 3.72E+00




Total Particulate Matter PER 011 3.72E+008.50E-01 3.72E+00

Antimony compounds PER 001 7.00E-04 3.00E-049.00E-04 3.80E-03





Page 6 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 004

Sulfur Dioxide PER 011 2.38E+005.40E-01 2.38E+00

Volatile Organic Compounds PER 006 6.00E-011.40E-01 6.00E-01

Zinc PER 011 2.21E-025.04E-03 2.21E-02

EU 005

Benzene PER 008 1.50E-05 6.57E-05






Carbon Monoxide PER 006 2.63E+006.00E-01 2.63E+00






Hexane PER 008 5.63E-021.29E-02 5.63E-02




Phenol PER 008

Toluene PER 008 2.43E-05 1.06E-04


Lead Compounds PER 008

Phosphorus PER 008



Nitrogen Oxides PER 008 3.13E+007.10E-01 3.13E+00

Lead PER 008 6.00E-04 3.00E-03

PM < 10 micron PER 008 1.06E+002.40E-01 1.06E+00


Total Particulate Matter PER 008 2.40E-01 1.06E+00

Antimony compounds PER 008


Sulfur Dioxide PER 008 6.90E-011.60E-01 6.90E-01


EU 006

Carbon Monoxide PER 008 5.50E-011.26E-01 5.50E-01

Nitrogen Oxides PER 006 5.30E-01 5.30E-011.20E-01 5.30E-01

PM < 10 micron PER 006 5.00E-02 5.00E-021.00E-02 5.00E-02

Total Particulate Matter PER 006 5.00E-021.00E-02 5.00E-02

Sulfur Dioxide PER 006 2.00E-03 2.00E-035.00E-04 2.00E-03


EU 007



Page 7 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 007





EU 008







EU 009







EU 010







EU 011







EU 012







EU 013






Page 8 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 013


EU 014







EU 015







EU 016







EU 017







EU 018




EU 019




EU 020




EU 021




Page 9 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 022

Carbon Monoxide PER 008

Nitrogen Oxides PER 008

PM < 10 micron PER 008

Total Particulate Matter PER 008

Sulfur Dioxide PER 008

Volatile Organic Compounds PER 008

EU 025







EU 026

PM < 10 micron PER 008 7.05E+00 7.05E+001.61E+00



EU 027



Volatile Organic Compounds PER 001 3.67E+018.37E+00 3.67E+01

EU 028




EU 029

PM < 10 micron PER 008 3.05E+016.97E+00 3.05E+01



EU 030


Nitrogen Oxides PER 008 3.50E+00 3.50E+008.00E-01 3.50E+00





EU 031

Benzene PER 008 1.30E-012.90E-02 1.30E-01

Cadmium compounds PER 001 8.00E-07


Chromium compounds PER 008


Methyl ethyl ketone (MEK) PER 008


Toluene PER 008 5.00E-021.10E-02 5.00E-02

Page 10 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 031

Manganese compounds PER 008

Nickel compounds PER 001


PM < 10 micron PER 008 3.48E+00 3.48E+007.95E-01 3.48E+00




EU 032

Benzene PER 008 1.30E-012.90E-02 1.30E-01

Cadmium compounds PER 001 8.00E-07


Chromium compounds PER 008


Methyl ethyl ketone (MEK) PER 008


Toluene PER 008 5.00E-02 2.79E-021.10E-02 5.00E-02

Manganese compounds PER 008

Nickel compounds PER 001






EU 033



EU 034



EU 035



EU 036







EU 037





Page 11 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 038





EU 039





EU 040







EU 041







EU 042







EU 043







EU 044



Hexane PER 008 2.32E-015.29E-02 2.32E-01


Toluene PER 008 4.38E-041.00E-04 4.38E-04

Total Polycyclic aromatic hydr PER 008 8.97E-052.05E-05 8.97E-05


Page 12 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 044

Lead PER 006 2.00E-03 1.10E-02





EU 045



Hexane PER 008 2.32E-015.29E-02 2.32E-01


Toluene PER 008 1.00E-04 4.38E-04



Lead PER 006 2.00E-03 1.10E-02





EU 047







EU 048







EU 049







EU 050






Page 13 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 050


EU 051






PM < 10 micron PER 006 3.30E-01 3.30E-011.32E+00 3.30E-01

Total Particulate Matter PER 006 3.30E-011.32E+00 3.30E-01

Sulfur Dioxide PER 006 3.10E-01 3.10E-011.23E+00 3.10E-01


EU 052







EU 053







EU 054







EU 055







EU 056






Page 14 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 056


EU 057







EU 058







EU 059







EU 060







EU 061







EU 062







EU 063


Page 15 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 063






EU 064







EU 065







EU 066







EU 067







EU 068







EU 069





Page 16 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 069



EU 070



EU 074







EU 075







EU 076







EU 077







EU 078



Nitrogen Oxides PER 008 7.20E-01 7.20E-012.86E+00 7.20E-01





EU 079



Page 17 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 080

Benzene PER 009 7.30E-031.40E-02 6.13E-02


Carbon Monoxide PER 009 3.50E-016.60E-01 2.89E+00



PM < 10 micron PER 009 1.57E-01 1.31E+003.00E-01 1.31E+00

Total Particulate Matter PER 009 1.57E-013.00E-01 1.31E+00


Volatile Organic Compounds PER 009 8.50E-011.62E+00 7.11E+00

EU 081

Benzene PER 009 7.30E-031.40E-02 6.13E-02









EU 082

Benzene PER 009 7.30E-031.40E-02 6.13E-02









EU 083

Benzene PER 009 7.30E-031.40E-02 6.13E-02









EU 084

Benzene PER 009 7.30E-031.40E-02 6.13E-02






Page 18 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 084




EU 085

Benzene PER 009 7.30E-031.40E-02 6.13E-02









EU 086

Benzene PER 009 7.30E-031.40E-02 6.13E-02









EU 088

PM < 2.5 micron PER 011 4.25E+009.70E-01 1.12E+01

PM < 10 micron PER 011 4.25E+009.70E-01 4.37E+02



EU 089

PM < 2.5 micron PER 011 8.81E+002.01E+00 8.81E+00

PM < 10 micron PER 011 8.81E+002.01E+00 3.44E+02



EU 090

PM < 2.5 micron PER 011 2.94E+006.70E-01 2.94E+00

PM < 10 micron PER 011 2.94E+006.70E-01 1.84E+01



EU 091

PM < 2.5 micron PER 011 3.67E+018.38E+00 3.67E+01

PM < 10 micron PER 011 3.67E+018.38E+00 2.29E+02



EU 092

Benzene PER 011 4.42E-051.01E-05 4.42E-05

Page 19 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 092


Beryllium PER 011 2.52E-075.76E-08 2.52E-07



Methane PER 011 4.73E-021.08E-02 4.73E-02






Hexane PER 011 3.78E-028.64E-03 3.78E-02



Mercury PER 011 5.47E-061.25E-06 5.47E-06

Toluene PER 011 7.15E-051.63E-05 7.15E-05





PM < 2.5 micron PER 011 1.60E-013.60E-02 1.60E-01

Lead PER 011 1.05E-052.40E-06 1.05E-05

PM < 10 micron PER 011 1.60E-013.60E-02 1.60E-01






EU 093

Benzene PER 011 4.42E-051.01E-05 4.42E-05





Methane PER 011 4.73E-021.08E-02 4.73E-02






Hexane PER 011 3.78E-028.64E-03 3.78E-02



Mercury PER 011 5.47E-061.25E-06 5.47E-06

Toluene PER 011 7.15E-051.63E-05 7.15E-05



Page 20 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

EU 093



PM < 2.5 micron PER 011 1.60E-013.60E-02 1.60E-01

Lead PER 011 1.05E-052.40E-06 1.05E-05

PM < 10 micron PER 011 1.60E-013.60E-02 1.60E-01






EU 094

Benzene PER 011 2.21E-055.04E-06 2.21E-05





Methane PER 011 2.36E-025.40E-03 2.36E-02






Hexane PER 011 1.89E-024.32E-03 1.89E-02



Mercury PER 011 2.73E-066.24E-07 2.73E-06

Toluene PER 011 3.57E-058.16E-06 3.57E-05





PM < 2.5 micron PER 011 8.00E-021.80E-02 8.00E-02

Lead PER 011 5.26E-061.20E-06 5.26E-06

PM < 10 micron PER 011 8.00E-021.80E-02 8.00E-02






FC 000

Carbon Dioxide Equivalent PER 010 9.80E+04

GP 001

Nitrogen Oxides PER 006 1.80E+02

Lead PER 006 5.60E-02

PM < 10 micron PER 008 2.23E+01

Total Particulate Matter PER 008 2.46E+01

Page 21 of 22


14 May, 2013 16:10



AQD Facility ID:

Facility Name:

09900002



(tons per yr)

LimitedPotential

(tons per yr)

ActualEmissions

(tons per yr)

Pollutant AddedBy

(Action)

RetiredBy

(Action)

HourlyPotential

(lbs per hr)

GP 001

Sulfur Dioxide PER 010 2.35E+02

GP 013


SV 049

PM < 10 micron PER 008 1.00E+002.28E-01 1.00E+00



SV 058


Carbon Monoxide PER 010 1.44E+00 1.44E+003.30E-01 1.44E+00

HAPs - Total PER 010 3.24E-02 3.24E-027.40E-03 3.24E-02


PM < 2.5 micron PER 010 2.79E+01 2.79E+016.37E+00 2.79E+01


Total Particulate Matter PER 010 2.79E+01 2.79E+016.37E+00 2.79E+01


Volatile Organic Compounds PER 010 2.79E+01 2.79E+016.37E+00 2.79E+01

Page 22 of 22

14 May, 2013 16:10


FACILITY DESCRIPTION: Potential-to-emit (by pollutant)

RetiredBy

(Action)

AddedBy

(Action)

ItemPollutant ActualEmissions

(tons per yr)

LimitedPotential

(tons per yr)

UnrestrictedPotential

(tons per yr)

HourlyPotential

(lbs per hr)

AQD Facility ID: 09900002

Facility Name: Hormel Foods Corp/QPP - Austin


Benzene

PER 008EU 001 1.030E-04 4.510E-04

PER 011EU 001 1.010E-04 4.420E-04 4.420E-04

PER 008EU 002 1.030E-04 4.510E-04

PER 011EU 002 1.010E-04 4.420E-04 4.420E-04

PER 008EU 003 1.030E-04 4.510E-04

PER 011EU 003 1.010E-04 4.420E-04 4.420E-04

PER 008EU 004 5.250E-05 2.300E-04

PER 011EU 004 5.170E-05 2.260E-04 2.260E-04

PER 008EU 005 1.500E-05 6.570E-05

PER 008EU 031 2.900E-02 1.300E-01 1.300E-01 0.000E+00

PER 008EU 032 2.900E-02 1.300E-01 1.300E-01 0.000E+00

PER 009EU 080 1.400E-02 6.130E-02 7.300E-03

PER 009EU 081 1.400E-02 6.130E-02 7.300E-03

PER 009EU 082 1.400E-02 6.130E-02 7.300E-03

PER 009EU 083 1.400E-02 6.130E-02 7.300E-03

PER 009EU 084 1.400E-02 6.130E-02 7.300E-03

PER 009EU 085 1.400E-02 6.130E-02 7.300E-03

PER 009EU 086 1.400E-02 6.130E-02 7.300E-03

PER 011EU 092 1.010E-05 4.420E-05 4.420E-05

PER 011EU 093 1.010E-05 4.420E-05 4.420E-05

PER 011EU 094 5.040E-06 2.210E-05 2.210E-05

Totals 6.908E-01 3.128E-01 0.000E+00

Arsenic compounds

PER 008EU 001 4.370E-04 1.910E-03 0.000E+00 0.000E+00

PER 011EU 001 4.460E-04 1.950E-03 1.950E-03 0.000E+00

PER 008EU 002 4.370E-04 1.910E-03 0.000E+00 0.000E+00

PER 011EU 002 4.460E-04 1.950E-03 1.950E-03 0.000E+00

PER 008EU 003 4.370E-04 1.910E-03 0.000E+00 0.000E+00

PER 011EU 003 4.460E-04 1.950E-03 1.950E-03 0.000E+00

PER 001EU 004 2.010E-02 8.800E-02 1.300E-03 6.000E-04

PER 011EU 004 2.280E-04 1.000E-03 1.000E-03 0.000E+00

PER 008EU 005 1.430E-06 6.250E-06 0.000E+00 0.000E+00

PER 011EU 092 9.600E-07 4.200E-06 4.200E-06

PER 011EU 093 9.600E-07 4.200E-06 4.200E-06

Page 1 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Arsenic compounds

PER 011EU 094 4.800E-07 2.100E-06 2.100E-06

Totals 6.867E-03 6.861E-03 0.000E+00

Bis(2-ethylhexyl) phthalate

PER 008EU 001 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 002 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 003 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 004 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 0.000E+00 0.000E+00 0.000E+00

Beryllium

PER 011EU 092 5.760E-08 2.520E-07 2.520E-07

PER 011EU 093 5.760E-08 2.520E-07 2.520E-07

PER 011EU 094 2.880E-08 1.260E-07 1.260E-07

Totals 6.300E-07 6.300E-07 0.000E+00

Beryllium Compounds

PER 008EU 001 9.200E-06 4.030E-05 0.000E+00 0.000E+00

PER 011EU 001 9.390E-06 4.110E-05 4.110E-05 0.000E+00

PER 008EU 002 9.200E-06 4.030E-05 0.000E+00 0.000E+00

PER 011EU 002 9.390E-06 4.110E-05 4.110E-05 0.000E+00

PER 008EU 003 9.200E-06 4.030E-05 0.000E+00 0.000E+00

PER 011EU 003 9.390E-06 4.110E-05 4.110E-05 0.000E+00

PER 008EU 004 4.690E-06 2.060E-05 0.000E+00 0.000E+00

PER 011EU 004 4.810E-06 2.110E-05 2.110E-05 0.000E+00

PER 008EU 005 8.570E-08 3.750E-07 0.000E+00 0.000E+00

Totals 1.448E-04 1.444E-04 0.000E+00

Carbon Dioxide Equivalent

PER 010EU 001 7.147E+03 3.130E+04

PER 011EU 001 7.682E+03 3.365E+04 3.365E+04

PER 010EU 002 7.147E+03 3.130E+04

PER 011EU 002 7.682E+03 3.365E+04 3.365E+04

PER 010EU 003 7.147E+03 3.130E+04

PER 011EU 003 7.682E+03 3.365E+04 3.365E+04

PER 010EU 004 7.147E+03 3.130E+04

PER 011EU 004 3.935E+03 1.724E+04 1.724E+04

PER 010EU 005 8.350E+02 3.659E+03

PER 010EU 044 4.815E+03 2.019E+04

Page 2 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Carbon Dioxide Equivalent

PER 010EU 045 4.815E+03 2.019E+04

PER 010EU 051 6.840E+02 1.710E+02

PER 010EU 078 1.520E+02 3.800E+01

PER 010EU 080 2.949E+03 1.292E+04

PER 010EU 081 2.949E+03 1.292E+04

PER 010EU 082 2.949E+03 1.292E+04

PER 010EU 083 2.949E+03 1.292E+04

PER 010EU 084 2.949E+03 1.292E+04

PER 010EU 085 2.949E+03 1.292E+04

PER 010EU 086 2.949E+03 1.292E+04

PER 011EU 092 5.728E+02 2.509E+03 2.509E+03

PER 011EU 093 5.728E+02 2.509E+03 2.509E+03

PER 011EU 094 2.864E+02 1.255E+03 1.255E+03

PER 010FC 000 9.802E+04

PER 010GP 013 1.063E+04 4.655E+04

PER 010SV 058 1.899E+03 7.441E+03

Totals 3.131E+05 2.225E+05 0.000E+00

Cadmium compounds

PER 008EU 001 1.320E-04 5.770E-04 0.000E+00 0.000E+00

PER 011EU 001 1.340E-04 5.890E-04 5.890E-04 0.000E+00

PER 001EU 002 5.600E-03 2.440E-02 4.200E-03 2.800E-03

PER 011EU 002 1.340E-04 5.890E-04 5.890E-04 0.000E+00

PER 008EU 003 1.320E-04 5.770E-04 0.000E+00 0.000E+00

PER 011EU 003 1.340E-04 5.890E-04 5.890E-04 0.000E+00

PER 008EU 004 6.720E-05 2.940E-04 0.000E+00 0.000E+00

PER 011EU 004 6.890E-05 3.020E-04 3.020E-04 0.000E+00

PER 008EU 005 7.850E-06 3.440E-05 0.000E+00 0.000E+00

PER 001EU 031 0.000E+00 0.000E+00 0.000E+00 8.000E-07

PER 001EU 032 0.000E+00 0.000E+00 0.000E+00 8.000E-07

PER 011EU 092 5.280E-06 2.310E-05 2.310E-05

PER 011EU 093 5.280E-06 2.310E-05 2.310E-05

PER 011EU 094 2.640E-06 1.160E-05 1.160E-05

Totals 2.161E-03 2.127E-03 1.600E-06

Methane

PER 011EU 001 1.200E-01 5.200E-01 5.200E-01

Page 3 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Methane

PER 011EU 002 1.200E-01 5.200E-01 5.200E-01

PER 011EU 003 1.200E-01 5.200E-01 5.200E-01

PER 011EU 004 6.000E-02 2.700E-01 2.700E-01

PER 011EU 092 1.080E-02 4.730E-02 4.730E-02

PER 011EU 093 1.080E-02 4.730E-02 4.730E-02

PER 011EU 094 5.400E-03 2.360E-02 2.360E-02

Totals 1.948E+00 1.948E+00 0.000E+00

Carbon Monoxide

PER 008EU 001 4.120E+00 1.803E+01 1.803E+01

PER 011EU 001 4.040E+00 1.767E+01 1.767E+01

PER 008EU 002 4.120E+00 1.803E+01 1.803E+01

PER 011EU 002 4.040E+00 1.767E+01 1.767E+01

PER 008EU 003 4.120E+00 1.803E+01 1.803E+01

PER 011EU 003 4.040E+00 1.767E+01 1.767E+01

PER 006EU 004 2.100E+00 9.200E+00 9.200E+00

PER 011EU 004 2.070E+00 9.050E+00 9.050E+00

PER 006EU 005 6.000E-01 2.630E+00 2.630E+00

PER 008EU 006 1.260E-01 5.500E-01 5.500E-01

PER 008EU 007 1.260E-01 5.500E-01 5.500E-01

PER 008EU 008 1.260E-01 5.500E-01 5.500E-01

PER 008EU 009 1.260E-01 5.500E-01 5.500E-01

PER 008EU 010 1.260E-01 5.500E-01 5.500E-01

PER 008EU 011 1.260E-01 5.500E-01 5.500E-01

PER 008EU 012 1.260E-01 5.500E-01 5.500E-01

PER 008EU 013 1.260E-01 5.500E-01 5.500E-01

PER 008EU 014 1.260E-01 5.500E-01 5.500E-01

PER 008EU 015 1.260E-01 5.500E-01 5.500E-01

PER 008EU 016 1.260E-01 5.500E-01 5.500E-01

PER 008EU 017 1.260E-01 5.500E-01 5.500E-01

PER 008EU 022 0.000E+00 0.000E+00 0.000E+00

PER 008EU 025 1.910E-01 8.400E-01 8.400E-01

PER 008EU 030 6.720E-01 2.940E+00 2.940E+00

PER 008EU 031 2.396E+00 1.049E+01 1.049E+01

PER 008EU 032 2.396E+00 1.049E+01 1.049E+01

PER 008EU 036 7.560E-01 3.310E+00 3.310E+00

Page 4 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Carbon Monoxide

PER 008EU 037 1.010E+00 4.420E+00 4.420E+00

PER 008EU 038 1.010E+00 4.420E+00 4.420E+00

PER 008EU 039 1.010E+00 4.420E+00 4.420E+00

PER 006EU 040 4.700E-01 2.070E+00 2.070E+00

PER 008EU 041 1.810E-01 7.900E-01 7.900E-01

PER 006EU 042 2.100E-01 9.100E-01 9.100E-01

PER 006EU 043 2.100E-01 9.100E-01 9.100E-01

PER 006EU 044 2.470E+00 1.080E+01 1.080E+01

PER 006EU 045 2.470E+00 1.080E+01 1.080E+01

PER 008EU 047 2.520E-01 1.100E+00 1.100E+00

PER 006EU 048 2.000E-02 9.000E-02 9.000E-02

PER 006EU 049 2.000E-02 8.000E-02 8.000E-02

PER 006EU 050 2.900E-01 1.300E+00 1.300E+00

PER 006EU 051 2.630E+02 6.570E+01 6.570E+01

PER 008EU 052 3.360E-01 1.470E+00 1.470E+00

PER 008EU 053 3.360E-01 1.470E+00 1.470E+00

PER 006EU 054 1.900E-01 8.500E-01 8.500E-01

PER 006EU 055 1.900E-01 8.500E-01 8.500E-01

PER 006EU 056 2.700E-01 1.200E+00 1.200E+00

PER 006EU 057 2.700E-01 1.200E+00 1.200E+00

PER 006EU 058 3.000E-02 1.200E-01 1.200E-01

PER 006EU 059 3.000E-02 1.200E-01 1.200E-01

PER 006EU 060 6.000E-02 2.800E-01 2.800E-01

PER 006EU 061 1.000E-02 5.000E-02 5.000E-02

PER 006EU 062 8.000E-02 3.300E-01 3.300E-01

PER 006EU 063 3.300E-02 1.500E-01 1.500E-01

PER 008EU 064 0.000E+00 0.000E+00 0.000E+00

PER 008EU 065 0.000E+00 0.000E+00 0.000E+00

PER 008EU 066 0.000E+00 0.000E+00 0.000E+00

PER 008EU 067 2.500E-01 1.100E+00 1.100E+00

PER 008EU 068 5.500E-01 2.390E+00 2.390E+00

PER 008EU 069 4.700E-01 2.070E+00 2.070E+00

PER 008EU 074 8.400E-02 3.700E-01 3.700E-01

PER 008EU 075 2.300E-02 1.000E-01 1.000E-01

PER 008EU 076 1.820E-01 8.000E-01 8.000E-01

Page 5 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Carbon Monoxide

PER 008EU 077 1.140E-01 5.000E-01 5.000E-01

PER 008EU 078 4.690E+00 1.170E+00 1.170E+00

PER 009EU 080 6.600E-01 2.890E+00 3.500E-01

PER 009EU 081 6.600E-01 2.890E+00 3.500E-01

PER 009EU 082 6.600E-01 2.890E+00 3.500E-01

PER 009EU 083 6.600E-01 2.890E+00 3.500E-01

PER 009EU 084 6.600E-01 2.890E+00 3.500E-01

PER 009EU 085 6.600E-01 2.890E+00 3.500E-01

PER 009EU 086 6.600E-01 2.890E+00 3.500E-01

PER 011EU 092 4.030E-01 1.770E+00 1.770E+00

PER 011EU 093 4.030E-01 1.770E+00 1.770E+00

PER 011EU 094 2.020E-01 8.800E-01 8.800E-01

PER 010SV 058 3.300E-01 1.440E+00 1.440E+00 1.440E+00

Totals 2.499E+02 2.321E+02 1.440E+00

Carbon Dioxide

PER 011EU 001 7.676E+03 3.362E+04 3.362E+04

PER 011EU 002 7.676E+03 3.362E+04 3.362E+04

PER 011EU 003 7.676E+03 3.362E+04 3.362E+04

PER 011EU 004 3.932E+03 1.722E+04 1.722E+04

PER 011EU 092 5.720E+02 2.507E+03 2.507E+03

PER 011EU 093 5.720E+02 2.507E+03 2.507E+03

PER 011EU 094 2.860E+02 1.253E+03 1.253E+03

Totals 1.244E+05 1.244E+05 0.000E+00

Cobalt compounds

PER 008EU 001 1.990E-03 8.730E-03 0.000E+00 0.000E+00

PER 011EU 001 2.030E-03 8.910E-03 8.910E-03 0.000E+00

PER 008EU 002 1.990E-03 8.730E-03 0.000E+00 0.000E+00

PER 011EU 002 2.030E-03 8.910E-03 8.910E-03 0.000E+00

PER 008EU 003 1.990E-03 8.730E-03 0.000E+00 0.000E+00

PER 011EU 003 2.030E-03 8.910E-03 8.910E-03 0.000E+00

PER 008EU 004 1.020E-03 4.450E-03 0.000E+00 0.000E+00

PER 011EU 004 1.040E-03 4.560E-03 4.560E-03 0.000E+00

PER 008EU 005 6.000E-07 2.630E-06 0.000E+00 0.000E+00

Totals 3.129E-02 3.129E-02 0.000E+00

Page 6 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Chromium compounds

PER 008EU 001 2.800E-04 1.220E-03 0.000E+00 0.000E+00

PER 011EU 001 2.860E-04 1.250E-03 1.250E-03 0.000E+00

PER 008EU 002 2.800E-04 1.220E-03 0.000E+00 0.000E+00

PER 011EU 002 2.860E-04 1.250E-03 1.250E-03 0.000E+00

PER 008EU 003 2.800E-04 1.220E-03 0.000E+00 0.000E+00

PER 011EU 003 2.860E-04 1.250E-03 1.250E-03 0.000E+00

PER 008EU 004 1.430E-04 6.250E-04 0.000E+00 0.000E+00

PER 011EU 004 1.460E-04 6.410E-04 6.410E-04 0.000E+00

PER 008EU 005 1.000E-05 4.380E-05 0.000E+00 0.000E+00

PER 008EU 031 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 032 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 011EU 092 6.720E-06 2.940E-05 2.940E-05

PER 011EU 093 6.720E-06 2.940E-05 2.940E-05

PER 011EU 094 3.360E-06 1.470E-05 1.470E-05

Totals 4.508E-03 4.465E-03 0.000E+00

Dibutyl phthalate

PER 008EU 001 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 002 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 003 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 001EU 004 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 001EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 0.000E+00 0.000E+00 0.000E+00

1,4-Dichlorobenzene

PER 011EU 001 5.760E-05 2.520E-04 2.520E-04

PER 011EU 002 5.760E-05 2.520E-04 2.520E-04

PER 011EU 003 5.760E-05 2.520E-04 2.520E-04

PER 011EU 004 2.950E-05 1.290E-04 1.290E-04

PER 011EU 092 5.760E-06 2.520E-05 2.520E-05

PER 011EU 093 5.760E-06 2.520E-05 2.520E-05

PER 011EU 094 2.880E-06 1.260E-05 1.260E-05

Totals 9.480E-04 9.480E-04 0.000E+00

Ethylbenzene

PER 008EU 001 2.100E-05 9.220E-05

PER 011EU 001 2.150E-05 9.410E-05 9.410E-05

PER 008EU 002 2.100E-05 9.220E-05

Page 7 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Ethylbenzene

PER 011EU 002 2.150E-05 9.410E-05 9.410E-05

PER 008EU 003 2.100E-05 9.220E-05

PER 011EU 003 2.150E-05 9.410E-05 9.410E-05

PER 008EU 004 1.070E-05 4.700E-05

PER 011EU 004 1.100E-05 4.820E-05 4.820E-05

PER 008EU 005 3.070E-06 1.340E-05

Totals 3.439E-04 3.305E-04 0.000E+00

Formaldehyde

PER 008EU 001 1.410E-02 6.160E-02 0.000E+00 0.000E+00

PER 011EU 001 1.120E-02 4.880E-02 4.880E-02 0.000E+00

PER 008EU 002 1.410E-02 6.160E-02 0.000E+00 0.000E+00

PER 011EU 002 1.120E-02 4.880E-02 4.880E-02 0.000E+00

PER 008EU 003 1.410E-02 6.160E-02 0.000E+00 0.000E+00

PER 011EU 003 1.120E-02 4.880E-02 4.880E-02 0.000E+00

PER 008EU 004 7.170E-03 3.140E-02 0.000E+00 0.000E+00

PER 011EU 004 5.710E-03 2.500E-02 2.500E-02 0.000E+00

PER 008EU 005 5.360E-04 2.350E-03 0.000E+00 0.000E+00

PER 008EU 031 1.530E-02 6.700E-02 6.700E-02 0.000E+00

PER 008EU 032 1.530E-02 6.700E-02 6.700E-02 0.000E+00

PER 008EU 051 1.800E-03 4.000E-04 4.000E-04

PER 011EU 092 3.600E-04 1.580E-03 1.580E-03

PER 011EU 093 3.600E-04 1.580E-03 1.580E-03

PER 011EU 094 1.800E-04 7.880E-04 7.880E-04

Totals 3.121E-01 3.097E-01 0.000E+00

Hexane

PER 008EU 001 8.820E-02 3.860E-01 3.860E-01

PER 011EU 001 8.600E-02 3.790E-01 3.790E-01

PER 008EU 002 8.820E-02 3.860E-01 3.860E-01

PER 011EU 002 8.600E-02 3.790E-01 3.790E-01

PER 008EU 003 8.820E-02 3.860E-01 3.860E-01

PER 011EU 003 8.600E-02 3.790E-01 3.790E-01

PER 008EU 004 4.500E-02 1.970E-01 1.970E-01

PER 011EU 004 4.400E-02 1.940E-01 1.940E-01

PER 008EU 005 1.290E-02 5.630E-02 5.630E-02

PER 008EU 044 5.290E-02 2.320E-01 2.320E-01

Page 8 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Hexane

PER 008EU 045 5.290E-02 2.320E-01 2.320E-01

PER 011EU 092 8.640E-03 3.780E-02 3.780E-02

PER 011EU 093 8.640E-03 3.780E-02 3.780E-02

PER 011EU 094 4.320E-03 1.890E-02 1.890E-02

Totals 1.946E+00 1.946E+00 0.000E+00

Methyl ethyl ketone (MEK)

PER 008EU 031 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 032 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 0.000E+00 0.000E+00 0.000E+00

Naphthalene

PER 008EU 001 3.740E-04 1.640E-03 0.000E+00 0.000E+00

PER 011EU 001 3.820E-04 1.670E-03 1.670E-03 0.000E+00

PER 008EU 002 3.740E-04 1.640E-03 0.000E+00 0.000E+00

PER 011EU 002 3.820E-04 1.670E-03 1.670E-03 0.000E+00

PER 008EU 003 3.740E-04 1.640E-03 0.000E+00 0.000E+00

PER 011EU 003 3.820E-04 1.670E-03 1.670E-03 0.000E+00

PER 008EU 004 1.910E-04 8.350E-04 0.000E+00 0.000E+00

PER 011EU 004 1.960E-04 8.570E-04 8.570E-04 0.000E+00

PER 008EU 005 4.360E-06 1.910E-05 0.000E+00 0.000E+00

PER 011EU 092 2.930E-06 1.280E-05 1.280E-05

PER 011EU 093 2.930E-06 1.280E-05 1.280E-05

PER 011EU 094 1.460E-06 6.410E-06 6.410E-06

Totals 5.918E-03 5.899E-03 0.000E+00

HAPs - Total

PER 008EU 001 9.000E-02 4.100E-01 4.100E-01 0.000E+00

PER 008EU 002 9.000E-02 4.100E-01 4.100E-01

PER 008EU 003 9.000E-02 4.100E-01 4.100E-01

PER 008EU 004 3.000E-02 1.100E-01 1.100E-01

PER 011EU 004 5.000E-02 2.000E-01 2.000E-01

PER 008EU 005 1.300E-02 6.000E-02 6.000E-02

PER 008EU 031 8.200E-02 3.600E-01 3.600E-01 0.000E+00

PER 008EU 032 8.200E-02 3.600E-01 3.600E-01 0.000E+00

PER 008EU 044 9.000E-02 4.100E-01 4.100E-01

PER 008EU 045 9.000E-02 4.100E-01 4.100E-01

PER 008EU 051 9.800E-03 2.500E-03 2.500E-03

Page 9 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




HAPs - Total

PER 009EU 080 3.070E-02 1.350E-01 1.600E-02

PER 009EU 081 3.070E-02 1.350E-01 1.600E-02

PER 009EU 082 3.070E-02 1.350E-01 1.600E-02

PER 009EU 083 3.070E-02 1.350E-01 1.600E-02

PER 009EU 084 3.070E-02 1.350E-01 1.600E-02

PER 009EU 085 3.070E-02 1.350E-01 1.600E-02

PER 009EU 086 3.070E-02 1.350E-01 1.600E-02

PER 011EU 092 9.060E-03 3.970E-02 3.970E-02

PER 011EU 093 9.060E-03 3.970E-02 3.970E-02

PER 011EU 094 4.530E-03 1.980E-02 1.980E-02

PER 010SV 058 7.400E-03 3.242E-02 3.242E-02 3.242E-02

Totals 4.109E+00 3.276E+00 3.242E-02

Mercury

PER 011EU 092 1.250E-06 5.470E-06 5.470E-06

PER 011EU 093 1.250E-06 5.470E-06 5.470E-06

PER 011EU 094 6.240E-07 2.730E-06 2.730E-06

Totals 1.367E-05 1.367E-05 0.000E+00

Mercury Compounds

PER 008EU 001 3.740E-05 1.640E-04 0.000E+00 0.000E+00

PER 011EU 001 3.820E-05 1.670E-04 1.670E-04 0.000E+00

PER 008EU 002 3.740E-05 1.640E-04 0.000E+00 0.000E+00

PER 011EU 002 3.820E-05 1.670E-04 1.670E-04 0.000E+00

PER 008EU 003 3.740E-05 1.640E-04 0.000E+00 0.000E+00

PER 011EU 003 3.820E-05 1.670E-04 1.670E-04 0.000E+00

PER 008EU 004 1.910E-05 8.350E-05 0.000E+00 0.000E+00

PER 011EU 004 1.960E-05 8.570E-05 8.570E-05 0.000E+00

PER 008EU 005 1.860E-06 8.130E-06 0.000E+00 0.000E+00

Totals 5.948E-04 5.867E-04 0.000E+00

Phenol

PER 008EU 001 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 002 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 003 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 004 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 0.000E+00 0.000E+00 0.000E+00

Page 10 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Toluene

PER 008EU 001 2.050E-03 8.980E-03

PER 011EU 001 2.100E-03 9.180E-03 9.180E-03

PER 008EU 002 2.050E-03 8.980E-03

PER 011EU 002 2.100E-03 9.180E-03 9.180E-03

PER 008EU 003 2.050E-03 8.980E-03

PER 011EU 003 2.100E-03 9.180E-03 9.180E-03

PER 008EU 004 1.050E-03 4.580E-03

PER 011EU 004 1.070E-03 4.700E-03 4.700E-03

PER 008EU 005 2.430E-05 1.060E-04

PER 008EU 031 1.100E-02 5.000E-02 5.000E-02 0.000E+00

PER 008EU 032 1.100E-02 5.000E-02 5.000E-02 2.790E-02

PER 008EU 044 1.000E-04 4.380E-04 4.380E-04

PER 008EU 045 1.000E-04 4.380E-04

PER 011EU 092 1.630E-05 7.150E-05 7.150E-05

PER 011EU 093 1.630E-05 7.150E-05 7.150E-05

PER 011EU 094 8.160E-06 3.570E-05 3.570E-05

Totals 1.334E-01 1.329E-01 2.790E-02

1,1,1-Trichloroethane

PER 011EU 001 7.980E-05 3.490E-04 3.490E-04

PER 011EU 002 7.980E-05 3.490E-04 3.490E-04

PER 011EU 003 7.980E-05 3.490E-04 3.490E-04

PER 011EU 004 4.090E-05 1.790E-04 1.790E-04

Totals 1.226E-03 1.226E-03 0.000E+00

Manganese compounds

PER 008EU 001 9.930E-04 4.350E-03 0.000E+00 0.000E+00

PER 011EU 001 1.010E-03 4.440E-03 4.440E-03 0.000E+00

PER 008EU 002 9.930E-04 4.350E-03 0.000E+00 0.000E+00

PER 011EU 002 1.010E-03 4.440E-03 4.440E-03 0.000E+00

PER 008EU 003 9.930E-04 4.350E-03 0.000E+00 0.000E+00

PER 011EU 003 1.010E-03 4.440E-03 4.440E-03 0.000E+00

PER 008EU 004 5.060E-04 2.220E-03 0.000E+00 0.000E+00

PER 011EU 004 5.190E-04 2.270E-03 2.270E-03 0.000E+00

PER 008EU 005 2.710E-06 1.190E-05 0.000E+00 0.000E+00

PER 008EU 031 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 032 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Page 11 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Manganese compounds

PER 011EU 092 1.820E-06 7.990E-06 7.990E-06

PER 011EU 093 1.820E-06 7.990E-06 7.990E-06

PER 011EU 094 9.120E-07 3.990E-06 3.990E-06

Totals 1.562E-02 1.561E-02 0.000E+00

Nitrous Oxide

PER 011EU 001 1.000E-02 5.000E-02 5.000E-02

PER 011EU 002 1.000E-02 5.000E-02 5.000E-02

PER 011EU 003 1.000E-02 5.000E-02 5.000E-02

PER 011EU 004 1.000E-02 3.000E-02 3.000E-02

PER 011EU 092 1.080E-03 4.730E-03 4.730E-03

PER 011EU 093 1.080E-03 4.730E-03 4.730E-03

PER 011EU 094 5.400E-04 2.360E-03 2.360E-03

Totals 1.918E-01 1.918E-01 0.000E+00

Lead Compounds

PER 008EU 001 5.000E-04 2.190E-03 0.000E+00 0.000E+00

PER 011EU 001 4.080E-03 2.000E-02 2.000E-02 0.000E+00

PER 008EU 002 5.000E-04 2.190E-03 0.000E+00 0.000E+00

PER 011EU 002 4.080E-03 2.000E-02 2.000E-02 0.000E+00

PER 008EU 003 5.000E-04 2.190E-03 0.000E+00 0.000E+00

PER 011EU 003 4.080E-03 2.000E-02 2.000E-02 0.000E+00

PER 008EU 004 2.550E-04 1.120E-03 0.000E+00 0.000E+00

PER 011EU 004 2.090E-03 1.000E-02 1.000E-02 0.000E+00

PER 008EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 7.000E-02 7.000E-02 0.000E+00

o-Xylenes

PER 008EU 001 3.510E-05 1.580E-04

PER 011EU 001 3.680E-05 1.610E-04 1.610E-04

PER 008EU 002 3.510E-05 1.580E-04

PER 011EU 002 3.680E-05 1.610E-04 1.610E-04

PER 008EU 003 3.510E-05 1.580E-04

PER 011EU 003 3.680E-05 1.610E-04 1.610E-04

PER 008EU 004 1.840E-05 8.060E-05

PER 011EU 004 1.890E-05 8.260E-05 8.260E-05

Totals 5.656E-04 5.656E-04 0.000E+00

Phosphorus

PER 008EU 001 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Page 12 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Phosphorus

PER 008EU 002 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 003 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 004 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 0.000E+00 0.000E+00 0.000E+00

Total Polycyclic aromatic hydr

PER 008EU 001 3.940E-04 1.730E-03

PER 011EU 001 0.000E+00 0.000E+00

PER 008EU 002 3.940E-04 1.730E-03

PER 011EU 002 0.000E+00 0.000E+00

PER 008EU 003 3.940E-04 1.730E-03

PER 011EU 003 0.000E+00 0.000E+00

PER 008EU 004 2.010E-04 8.810E-04

PER 011EU 004 0.000E+00 0.000E+00

PER 008EU 005 6.300E-07 2.760E-06

PER 008EU 044 2.050E-05 8.970E-05 8.970E-05

PER 008EU 045 2.050E-05 8.970E-05

Totals 1.822E-04 8.970E-05 0.000E+00

Nickel compounds

PER 008EU 001 2.800E-02 1.220E-01 0.000E+00 0.000E+00

PER 011EU 001 2.860E-02 1.250E-01 1.250E-01 0.000E+00

PER 008EU 002 2.800E-02 1.220E-01 0.000E+00 0.000E+00

PER 011EU 002 2.860E-02 1.250E-01 1.250E-01 0.000E+00

PER 008EU 003 2.800E-02 1.220E-01 0.000E+00 0.000E+00

PER 011EU 003 2.860E-02 1.250E-01 1.250E-01 0.000E+00

PER 008EU 004 1.430E-02 6.250E-02 0.000E+00 0.000E+00

PER 011EU 004 1.460E-02 6.410E-02 6.410E-02 0.000E+00

PER 008EU 005 1.500E-05 6.570E-05 0.000E+00 0.000E+00

PER 001EU 031 0.000E+00 0.000E+00 0.000E+00

PER 001EU 032 0.000E+00 0.000E+00 0.000E+00

PER 011EU 092 1.010E-05 4.420E-05 4.420E-05

PER 011EU 093 1.010E-05 4.420E-05 4.420E-05

PER 011EU 094 5.040E-06 2.210E-05 2.210E-05

Totals 4.393E-01 4.392E-01 0.000E+00

Page 13 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Nitrogen Oxides

PER 010EU 001 1.820E+01 7.970E+01 0.000E+00 7.970E+01

PER 011EU 001 1.245E+01 5.454E+01 5.454E+01 0.000E+00

PER 010EU 002 1.820E+01 7.970E+01 0.000E+00 7.970E+01

PER 011EU 002 1.245E+01 5.454E+01 5.454E+01 0.000E+00

PER 010EU 003 1.820E+01 7.970E+01 0.000E+00 7.970E+01

PER 011EU 003 1.245E+01 5.454E+01 5.454E+01 0.000E+00

PER 010EU 004 9.280E+00 4.070E+01 0.000E+00 4.070E+01

PER 011EU 004 6.380E+00 2.794E+01 2.794E+01 0.000E+00

PER 008EU 005 7.100E-01 3.130E+00 3.130E+00

PER 006EU 006 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 007 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 008 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 009 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 010 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 011 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 012 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 013 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 014 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 015 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 016 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 006EU 017 1.200E-01 5.300E-01 5.300E-01 5.300E-01

PER 008EU 022 0.000E+00 0.000E+00 0.000E+00

PER 008EU 025 2.270E-01 9.900E-01 9.900E-01 9.900E-01

PER 008EU 030 8.000E-01 3.500E+00 3.500E+00 3.500E+00

PER 008EU 031 2.100E-02 9.000E-02 9.000E-02 9.000E-02

PER 008EU 032 2.100E-02 9.000E-02 9.000E-02 9.000E-02

PER 008EU 036 9.000E-01 3.940E+00 3.940E+00 3.940E+00

PER 006EU 040 5.600E-01 2.460E+00 2.460E+00 2.460E+00

PER 008EU 041 2.160E-01 9.500E-01 9.500E-01 9.500E-01

PER 006EU 042 2.500E-01 1.080E+00 1.080E+00 1.080E+00

PER 006EU 043 2.500E-01 1.080E+00 1.080E+00 1.080E+00

PER 010EU 044 7.420E+00 3.250E+01 0.000E+00 3.250E+01

PER 010EU 045 7.420E+00 3.250E+01 0.000E+00 3.250E+01

PER 008EU 047 3.000E-01 1.310E+00 1.310E+00 1.310E+00

PER 006EU 048 2.000E-02 1.100E-01 1.100E-01 1.100E-01

Page 14 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Nitrogen Oxides

PER 006EU 049 2.000E-02 9.000E-02 9.000E-02 9.000E-02

PER 006EU 050 3.500E-01 1.530E+00 1.530E+00 1.530E+00

PER 006EU 051 1.857E+01 4.640E+00 4.640E+00

PER 008EU 052 4.000E-01 1.750E+00 1.750E+00 1.750E+00

PER 008EU 053 4.000E-01 1.750E+00 1.750E+00 1.750E+00

PER 006EU 054 2.300E-01 1.010E+00 1.010E+00 1.010E+00

PER 006EU 055 2.300E-01 1.010E+00 1.010E+00 1.010E+00

PER 006EU 056 3.300E-01 1.430E+00 1.430E+00 1.430E+00

PER 006EU 057 3.300E-01 1.430E+00 1.430E+00 1.430E+00

PER 006EU 058 3.000E-02 1.400E-01 1.400E-01 1.400E-01

PER 006EU 059 3.000E-02 1.400E-01 1.400E-01 1.400E-01

PER 006EU 060 8.000E-02 3.300E-01 3.300E-01 3.300E-01

PER 006EU 061 1.300E-02 5.500E-02 5.500E-02 5.500E-02

PER 006EU 062 9.000E-02 4.000E-01 4.000E-01 4.000E-01

PER 006EU 063 4.000E-02 1.700E-01 1.700E-01 1.700E-01

PER 008EU 064 0.000E+00 0.000E+00 0.000E+00

PER 008EU 065 0.000E+00 0.000E+00 0.000E+00

PER 008EU 066 0.000E+00 0.000E+00 0.000E+00

PER 008EU 067 3.000E-01 1.310E+00 1.310E+00 1.310E+00

PER 008EU 068 6.500E-01 2.850E+00 2.850E+00 2.850E+00

PER 008EU 069 5.600E-01 2.460E+00 2.460E+00 2.460E+00

PER 008EU 074 1.000E-01 4.400E-01 4.400E-01 4.400E-01

PER 008EU 075 2.700E-02 1.200E-01 1.200E-01 1.200E-01

PER 008EU 076 2.170E-01 9.500E-01 9.500E-01 9.500E-01

PER 008EU 077 1.360E-01 6.000E-01 6.000E-01 6.000E-01

PER 008EU 078 2.860E+00 7.200E-01 7.200E-01 7.200E-01

PER 009EU 080 4.892E+01 2.143E+02 2.140E+02

PER 009EU 081 4.892E+01 2.143E+02 2.140E+02

PER 009EU 082 4.892E+01 2.143E+02 2.140E+02

PER 009EU 083 4.892E+01 2.143E+02 2.140E+02

PER 009EU 084 4.892E+01 2.143E+02 2.140E+02

PER 009EU 085 4.892E+01 2.143E+02 2.140E+02

PER 009EU 086 4.892E+01 2.143E+02 2.140E+02

PER 011EU 092 4.800E-01 2.100E+00 2.100E+00

PER 011EU 093 4.800E-01 2.100E+00 2.100E+00

Page 15 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Nitrogen Oxides

PER 011EU 094 2.400E-01 1.050E+00 1.050E+00

PER 006GP 001 1.800E+02

PER 010SV 058 3.900E-01 1.720E+00 1.720E+00 1.720E+00

Totals 1.814E+03 4.212E+02 1.615E+03

Octachloridibenzo-p-dioxin (OC

PER 011EU 001 1.100E-09 4.600E-09 4.600E-09

PER 011EU 002 1.100E-09 4.600E-09 4.600E-09

PER 011EU 003 1.100E-09 4.600E-09 4.600E-09

PER 011EU 004 0.000E+00 2.400E-09 2.400E-09

Totals 1.620E-08 1.620E-08 0.000E+00

PM < 2.5 micron

PER 011EU 001 1.660E+00 7.260E+00 7.260E+00

PER 011EU 002 1.660E+00 7.260E+00 7.260E+00

PER 011EU 003 1.660E+00 7.260E+00 7.260E+00

PER 011EU 004 8.500E-01 3.720E+00 3.720E+00

PER 011EU 088 9.700E-01 1.118E+01 4.250E+00

PER 011EU 089 2.010E+00 8.810E+00 8.810E+00

PER 011EU 090 6.700E-01 2.940E+00 2.940E+00

PER 011EU 091 8.380E+00 3.671E+01 3.671E+01

PER 011EU 092 3.600E-02 1.600E-01 1.600E-01

PER 011EU 093 3.600E-02 1.600E-01 1.600E-01

PER 011EU 094 1.800E-02 8.000E-02 8.000E-02

PER 010SV 058 6.370E+00 2.790E+01 2.790E+01 2.790E+01

Totals 1.134E+02 1.065E+02 2.790E+01

Lead

PER 008EU 001 4.960E-04 2.170E-03

PER 011EU 001 4.080E-03 2.000E-02 2.000E-02

PER 008EU 002 4.960E-04 2.170E-03

PER 011EU 002 4.080E-03 2.000E-02 2.000E-02

PER 008EU 003 4.960E-04 2.170E-03

PER 011EU 003 4.080E-03 2.000E-02 2.000E-02

PER 006EU 004 2.000E-03 9.000E-03

PER 011EU 004 2.090E-03 1.000E-02 1.000E-02

PER 008EU 005 6.000E-04 3.000E-03

PER 006EU 044 2.000E-03 1.100E-02

Page 16 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Lead

PER 006EU 045 2.000E-03 1.100E-02

PER 011EU 092 2.400E-06 1.050E-05 1.050E-05

PER 011EU 093 2.400E-06 1.050E-05 1.050E-05

PER 011EU 094 1.200E-06 5.260E-06 5.260E-06

PER 006GP 001 5.600E-02

Totals 9.503E-02 1.260E-01 0.000E+00

PM < 10 micron

PER 006EU 001 6.360E+00 2.782E+01 2.786E+01 2.780E+01

PER 011EU 001 1.660E+00 7.260E+00 7.260E+00 0.000E+00

PER 006EU 002 6.360E+00 2.782E+01 2.786E+01 2.780E+01

PER 011EU 002 1.660E+00 7.260E+00 7.260E+00 0.000E+00

PER 006EU 003 6.360E+00 2.782E+01 2.786E+01 2.780E+01

PER 011EU 003 1.660E+00 7.260E+00 7.260E+00 0.000E+00

PER 006EU 004 3.330E+00 1.459E+01 1.459E+01 1.460E+01

PER 011EU 004 8.500E-01 3.720E+00 3.720E+00 0.000E+00

PER 008EU 005 2.400E-01 1.060E+00 1.060E+00

PER 006EU 006 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 007 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 008 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 009 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 010 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 011 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 012 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 013 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 014 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 015 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 016 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 006EU 017 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 008EU 018 1.970E+00 8.630E+00 8.630E+00 8.630E+00

PER 008EU 019 1.970E+00 8.630E+00 8.630E+00 8.630E+00

PER 008EU 020 1.970E+00 8.630E+00 8.630E+00 8.630E+00

PER 008EU 021 1.970E+00 8.630E+00 8.630E+00 8.630E+00

PER 008EU 022 0.000E+00 0.000E+00 0.000E+00

PER 008EU 025 1.730E-02 8.000E-02 8.000E-02 8.000E-02

PER 008EU 026 1.610E+00 0.000E+00 7.050E+00 7.050E+00

Page 17 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




PM < 10 micron

PER 006EU 027 8.380E+00 3.670E+01 3.670E+01 3.670E+01

PER 010EU 028 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 029 6.970E+00 3.051E+01 3.051E+01

PER 008EU 030 6.080E-02 2.700E-01 2.700E-01 2.700E-01

PER 008EU 031 7.950E-01 3.480E+00 3.480E+00 3.480E+00

PER 008EU 032 7.950E-01 3.480E+00 3.480E+00 3.480E+00

PER 008EU 033 2.200E-01 9.600E-01 9.600E-01 9.600E-01

PER 008EU 034 2.200E-01 9.600E-01 9.600E-01 9.600E-01

PER 008EU 035 2.200E-01 9.600E-01 9.600E-01 9.600E-01

PER 010EU 036 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 037 3.400E-01 1.490E+00 1.490E+00 1.490E+00

PER 008EU 038 3.400E-01 1.490E+00 1.490E+00 1.490E+00

PER 008EU 039 3.400E-01 1.490E+00 1.490E+00 1.490E+00

PER 006EU 040 4.000E-02 1.900E-01 1.900E-01 1.900E-01

PER 008EU 041 1.640E-02 7.000E-02 7.000E-02 7.000E-02

PER 006EU 042 2.000E-02 8.000E-02 8.000E-02 8.000E-02

PER 006EU 043 2.000E-02 8.000E-02 8.000E-02 8.000E-02

PER 006EU 044 9.900E-01 4.350E+00 4.350E+00 4.350E+00

PER 006EU 045 9.900E-01 4.350E+00 4.350E+00 4.350E+00

PER 008EU 047 2.280E-02 1.000E-01 1.000E-01 1.000E-01

PER 006EU 048 2.000E-03 8.000E-03 8.000E-03 8.000E-03

PER 006EU 049 2.000E-03 7.000E-03 7.000E-03 7.000E-03

PER 010EU 050 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 006EU 051 1.320E+00 3.300E-01 3.300E-01 3.300E-01

PER 008EU 052 3.000E-02 1.330E-01 1.330E-01 1.330E-01

PER 008EU 053 3.000E-02 1.330E-01 1.330E-01 1.330E-01

PER 006EU 054 1.800E-02 7.700E-02 7.700E-02 7.700E-02

PER 006EU 055 1.800E-02 7.700E-02 7.700E-02 7.700E-02

PER 006EU 056 2.500E-02 1.100E-01 1.100E-01 1.100E-01

PER 006EU 057 2.500E-02 1.100E-01 1.100E-01 1.100E-01

PER 006EU 058 2.000E-03 1.000E-02 1.000E-02 1.000E-02

PER 006EU 059 2.000E-03 1.000E-02 1.000E-02 1.000E-02

PER 006EU 060 6.000E-03 2.500E-02 2.500E-02 2.500E-02

PER 006EU 061 1.000E-03 4.000E-03 4.000E-03 4.000E-03

PER 006EU 062 7.000E-03 3.000E-02 3.000E-02 3.000E-02

Page 18 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




PM < 10 micron

PER 006EU 063 3.000E-03 1.300E-02 1.300E-02 1.300E-02

PER 008EU 064 0.000E+00 0.000E+00 0.000E+00

PER 008EU 065 0.000E+00 0.000E+00 0.000E+00

PER 008EU 066 0.000E+00 0.000E+00 0.000E+00

PER 008EU 067 2.280E-02 1.000E-01 1.000E-01 1.000E-01

PER 008EU 068 5.000E-02 2.200E-01 2.200E-01 2.200E-01

PER 008EU 069 4.000E-02 1.900E-01 1.900E-01 1.900E-01

PER 008EU 070 2.130E+00 9.340E+00 9.340E+00 9.340E+00

PER 008EU 074 8.000E-03 3.000E-02 3.000E-02 3.000E-02

PER 008EU 075 2.000E-03 1.000E-02 1.000E-02 1.000E-02

PER 008EU 076 1.600E-02 7.000E-02 7.000E-02 7.000E-02

PER 008EU 077 1.000E-02 5.000E-02 5.000E-02 5.000E-02

PER 008EU 078 2.000E-02 1.000E-02 1.000E-02 1.000E-02

PER 008EU 079 2.200E-01 9.600E-01 9.600E-01 9.600E-01

PER 009EU 080 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 009EU 081 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 009EU 082 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 009EU 083 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 009EU 084 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 009EU 085 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 009EU 086 3.000E-01 1.310E+00 1.570E-01 1.310E+00

PER 011EU 088 9.700E-01 4.367E+02 4.250E+00

PER 011EU 089 2.010E+00 3.441E+02 8.810E+00

PER 011EU 090 6.700E-01 1.835E+01 2.940E+00

PER 011EU 091 8.380E+00 2.294E+02 3.671E+01

PER 011EU 092 3.600E-02 1.600E-01 1.600E-01

PER 011EU 093 3.600E-02 1.600E-01 1.600E-01

PER 011EU 094 1.800E-02 8.000E-02 8.000E-02

PER 008GP 001 2.232E+01

PER 008SV 049 2.280E-01 1.000E+00 1.000E+00

PER 010SV 058 6.370E+00 2.790E+01 2.790E+01 2.790E+01

Totals 1.232E+03 2.762E+02 1.529E+02

Polycyclic organic matter

PER 008EU 001 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 011EU 001 4.150E-06 1.820E-05 1.820E-05 0.000E+00

Page 19 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Polycyclic organic matter

PER 008EU 002 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 011EU 002 4.150E-06 1.820E-05 1.820E-05 0.000E+00

PER 008EU 003 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 011EU 003 4.150E-06 1.820E-05 1.820E-05 0.000E+00

PER 008EU 004 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 011EU 004 2.130E-06 9.310E-06 9.310E-06 0.000E+00

PER 008EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 031 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 032 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 011EU 092 4.170E-07 1.820E-06 1.820E-06

PER 011EU 093 4.150E-07 1.820E-06 1.820E-06

PER 011EU 094 2.070E-07 9.080E-07 9.080E-07

Totals 6.846E-05 6.846E-05 0.000E+00

Total Particulate Matter

PER 006EU 001 7.310E+00 3.203E+01

PER 011EU 001 1.660E+00 7.260E+00 7.260E+00

PER 006EU 002 7.310E+00 3.203E+01

PER 011EU 002 1.660E+00 7.260E+00 7.260E+00

PER 006EU 003 7.310E+00 3.203E+01

PER 011EU 003 1.660E+00 7.260E+00 7.260E+00

PER 006EU 004 3.730E+00 1.634E+01

PER 011EU 004 8.500E-01 3.720E+00 3.720E+00

PER 008EU 005 2.400E-01 1.060E+00

PER 006EU 006 1.000E-02 5.000E-02 5.000E-02

PER 006EU 007 1.000E-02 5.000E-02 5.000E-02

PER 006EU 008 1.000E-02 5.000E-02 5.000E-02

PER 006EU 009 1.000E-02 5.000E-02 5.000E-02

PER 006EU 010 1.000E-02 5.000E-02 5.000E-02

PER 006EU 011 1.000E-02 5.000E-02 5.000E-02

PER 006EU 012 1.000E-02 5.000E-02 5.000E-02

PER 006EU 013 1.000E-02 5.000E-02 5.000E-02

PER 006EU 014 1.000E-02 5.000E-02 5.000E-02

PER 006EU 015 1.000E-02 5.000E-02 5.000E-02

PER 006EU 016 1.000E-02 5.000E-02 5.000E-02

PER 006EU 017 1.000E-02 5.000E-02 5.000E-02

Page 20 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)





PER 008EU 018 1.970E+00 8.630E+00 8.630E+00

PER 008EU 019 1.970E+00 8.630E+00 8.630E+00

PER 008EU 020 1.970E+00 8.630E+00 8.630E+00

PER 008EU 021 1.970E+00 8.630E+00 8.630E+00

PER 008EU 022 0.000E+00 0.000E+00 0.000E+00

PER 008EU 025 1.730E-02 8.000E-02 8.000E-02

PER 008EU 026 0.000E+00 0.000E+00 0.000E+00

PER 006EU 027 8.380E+00 3.670E+01 3.670E+01

PER 010EU 028 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 029 6.970E+00 3.051E+01 3.051E+01

PER 008EU 030 6.080E-02 2.700E-01 2.700E-01

PER 008EU 031 7.950E-01 3.480E+00 3.480E+00

PER 008EU 032 7.950E-01 3.480E+00 3.480E+00

PER 008EU 033 2.200E-01 9.600E-01 9.600E-01

PER 008EU 034 2.200E-01 9.600E-01 9.600E-01

PER 008EU 035 2.200E-01 9.600E-01 9.600E-01

PER 010EU 036 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 037 3.400E-01 1.490E+00 1.490E+00

PER 008EU 038 3.400E-01 1.490E+00 1.490E+00

PER 008EU 039 3.400E-01 1.490E+00 1.490E+00

PER 008EU 040 4.000E-02 1.900E-01 1.900E-01

PER 008EU 041 1.640E-02 7.000E-02 7.000E-02

PER 006EU 042 2.000E-02 8.000E-02 8.000E-02

PER 006EU 043 2.000E-02 8.000E-02 8.000E-02

PER 006EU 044 9.900E-01 4.350E+00

PER 006EU 045 9.900E-01 4.350E+00

PER 008EU 047 2.280E-02 1.000E-01 1.000E-01

PER 006EU 048 2.000E-03 8.000E-03 8.000E-03

PER 006EU 049 2.000E-03 7.000E-03 7.000E-03

PER 010EU 050 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 006EU 051 1.320E+00 3.300E-01 3.300E-01

PER 008EU 052 3.000E-02 1.330E-01 1.330E-01

PER 008EU 053 3.000E-02 1.330E-01 1.330E-01

PER 006EU 054 1.800E-02 7.700E-02 7.700E-02

PER 006EU 055 1.800E-02 7.700E-02 7.700E-02

Page 21 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)





PER 006EU 056 2.500E-02 1.100E-01 1.100E-01

PER 006EU 057 2.500E-02 1.100E-01 1.100E-01

PER 006EU 058 2.000E-03 1.000E-02 1.000E-02

PER 006EU 059 2.000E-03 1.000E-02 1.000E-02

PER 006EU 060 6.000E-03 2.500E-02 2.500E-02

PER 006EU 061 1.000E-03 4.000E-03 4.000E-03

PER 006EU 062 7.000E-03 3.000E-02 3.000E-02

PER 006EU 063 3.000E-03 1.300E-02 1.300E-02

PER 008EU 064 0.000E+00 0.000E+00 0.000E+00

PER 008EU 065 0.000E+00 0.000E+00 0.000E+00

PER 008EU 066 0.000E+00 0.000E+00 0.000E+00

PER 008EU 067 2.280E-02 1.000E-01 1.000E-01

PER 008EU 068 5.000E-02 2.200E-01 2.200E-01

PER 008EU 069 4.000E-02 1.900E-01 1.900E-01

PER 008EU 070 2.010E+00 8.820E+00 8.820E+00

PER 008EU 074 8.000E-03 3.000E-02 3.000E-02

PER 008EU 075 2.000E-03 1.000E-02 1.000E-02

PER 008EU 076 1.600E-02 7.000E-02 7.000E-02

PER 008EU 077 1.000E-02 5.000E-02 5.000E-02

PER 008EU 078 2.000E-02 1.000E-02 1.000E-02

PER 008EU 079 2.200E-01 9.600E-01 9.600E-01

PER 009EU 080 3.000E-01 1.310E+00 1.570E-01

PER 009EU 081 3.000E-01 1.310E+00 1.570E-01

PER 009EU 082 3.000E-01 1.310E+00 1.570E-01

PER 009EU 083 3.000E-01 1.310E+00 1.570E-01

PER 009EU 084 3.000E-01 1.310E+00 1.570E-01

PER 009EU 085 3.000E-01 1.310E+00 1.570E-01

PER 009EU 086 3.000E-01 1.310E+00 1.570E-01

PER 011EU 088 9.700E-01 1.242E+03 4.250E+00

PER 011EU 089 2.010E+00 9.789E+02 8.810E+00

PER 011EU 090 6.700E-01 1.958E+01 2.940E+00

PER 011EU 091 8.380E+00 2.447E+02 3.671E+01

PER 011EU 092 3.600E-02 1.600E-01 1.600E-01

PER 011EU 093 3.600E-02 1.600E-01 1.600E-01

PER 011EU 094 1.800E-02 8.000E-02 8.000E-02

Page 22 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)





PER 008GP 001 2.459E+01

PER 008SV 049 2.280E-01 1.000E+00 1.000E+00

PER 010SV 058 6.370E+00 2.790E+01 2.790E+01 2.790E+01

Totals 2.688E+03 2.622E+02 2.790E+01

Antimony compounds

PER 008EU 001 1.740E-03 7.610E-03 0.000E+00 0.000E+00

PER 011EU 001 1.770E-03 7.770E-03 7.770E-03 0.000E+00

PER 008EU 002 1.740E-03 7.610E-03 0.000E+00 0.000E+00

PER 011EU 002 1.770E-03 7.770E-03 7.770E-03 0.000E+00

PER 008EU 003 1.740E-03 7.610E-03 0.000E+00 0.000E+00

PER 011EU 003 1.770E-03 7.770E-03 7.770E-03 0.000E+00

PER 001EU 004 9.000E-04 3.800E-03 7.000E-04 3.000E-04

PER 011EU 004 9.090E-04 3.980E-03 3.980E-03 0.000E+00

PER 008EU 005 0.000E+00 0.000E+00 0.000E+00 0.000E+00

Totals 2.729E-02 2.729E-02 0.000E+00

Selenium compounds

PER 008EU 001 2.260E-04 9.900E-04 0.000E+00 0.000E+00

PER 011EU 001 2.310E-04 1.010E-03 1.010E-03 0.000E+00

PER 008EU 002 2.260E-04 9.900E-04 0.000E+00 0.000E+00

PER 011EU 002 2.310E-04 1.010E-03 1.010E-03 0.000E+00

PER 008EU 003 2.260E-04 9.900E-04 0.000E+00 0.000E+00

PER 011EU 003 2.310E-04 1.010E-03 1.010E-03 0.000E+00

PER 008EU 004 1.150E-04 5.050E-04 0.000E+00 0.000E+00

PER 011EU 004 1.180E-04 5.180E-04 5.180E-04 0.000E+00

PER 008EU 005 1.710E-07 7.510E-07 0.000E+00 0.000E+00

PER 011EU 092 1.150E-07 5.050E-07 5.050E-07

PER 011EU 093 1.150E-07 5.050E-07 5.050E-07

PER 011EU 094 5.760E-08 2.520E-07 2.520E-07

Totals 3.550E-03 3.549E-03 0.000E+00

Sulfur Dioxide

PER 010EU 001 9.800E+01 4.300E+02 4.355E+02

PER 011EU 001 1.060E+00 4.650E+00 4.650E+00 0.000E+00

PER 010EU 002 9.800E+01 4.300E+02 4.355E+02

PER 011EU 002 1.060E+00 4.650E+00 4.650E+00 0.000E+00

PER 010EU 003 9.800E+01 4.300E+02 4.355E+02

Page 23 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Sulfur Dioxide

PER 011EU 003 1.060E+00 4.650E+00 4.650E+00 0.000E+00

PER 010EU 004 5.000E+01 2.194E+02 2.222E+02

PER 011EU 004 5.400E-01 2.380E+00 2.380E+00 0.000E+00

PER 008EU 005 1.600E-01 6.900E-01 6.900E-01

PER 006EU 006 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 007 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 008 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 009 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 010 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 011 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 012 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 013 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 014 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 015 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 016 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 017 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 008EU 022 0.000E+00 0.000E+00 0.000E+00

PER 008EU 025 1.360E-03 6.000E-03 6.000E-03 6.000E-03

PER 008EU 030 4.800E-03 2.100E-02 2.100E-02 2.100E-02

PER 008EU 036 5.400E-03 2.400E-02 2.400E-02 2.400E-02

PER 006EU 040 3.000E-03 1.500E-02 1.500E-02 1.500E-02

PER 008EU 041 1.300E-03 6.000E-03 6.000E-03 6.000E-03

PER 006EU 042 1.000E-03 7.000E-03 7.000E-03 7.000E-03

PER 006EU 043 1.000E-03 7.000E-03 7.000E-03 7.000E-03

PER 010EU 044 6.400E-01 2.820E+00 2.820E+00

PER 010EU 045 6.400E-01 2.820E+00 2.820E+00

PER 008EU 047 1.800E-03 8.000E-03 8.000E-03 8.000E-03

PER 006EU 048 1.000E-04 6.000E-04 6.000E-04 6.000E-04

PER 006EU 049 1.000E-04 6.000E-04 6.000E-04 6.000E-04

PER 006EU 050 2.100E-03 9.200E-03 9.200E-03 9.200E-03

PER 006EU 051 1.230E+00 3.100E-01 3.100E-01 3.100E-01

PER 008EU 052 2.400E-03 1.100E-02 1.100E-02 1.100E-02

PER 008EU 053 2.400E-03 1.100E-02 1.100E-02 1.100E-02

PER 006EU 054 1.400E-03 6.000E-03 6.000E-03 6.000E-03

PER 006EU 055 1.400E-03 6.000E-03 6.000E-03 6.000E-03

Page 24 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)




Sulfur Dioxide

PER 006EU 056 2.000E-03 9.000E-03 9.000E-03 9.000E-03

PER 006EU 057 2.000E-03 9.000E-03 9.000E-03 9.000E-03

PER 006EU 058 2.000E-04 8.000E-04 8.000E-04 8.000E-04

PER 006EU 059 2.000E-04 8.000E-04 8.000E-04 8.000E-04

PER 006EU 060 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 061 1.000E-04 3.000E-04 3.000E-04 3.000E-04

PER 006EU 062 5.000E-04 2.000E-03 2.000E-03 2.000E-03

PER 006EU 063 2.000E-04 1.000E-03 1.000E-03 1.000E-03

PER 008EU 064 0.000E+00 0.000E+00 0.000E+00

PER 008EU 065 0.000E+00 0.000E+00 0.000E+00

PER 008EU 066 0.000E+00 0.000E+00 0.000E+00

PER 008EU 067 1.800E-03 8.000E-03 8.000E-03 8.000E-03

PER 008EU 068 4.000E-03 1.700E-02 1.700E-02 1.700E-02

PER 008EU 069 3.000E-03 1.500E-02 1.500E-02 1.500E-02

PER 008EU 074 1.000E-03 3.000E-03 3.000E-03 3.000E-03

PER 008EU 075 2.000E-04 1.000E-03 1.000E-03 1.000E-03

PER 008EU 076 1.000E-03 5.700E-03 5.700E-03 5.700E-03

PER 008EU 077 1.000E-03 3.600E-03 3.600E-03 3.600E-03

PER 008EU 078 1.000E-03 2.000E-04 2.000E-04 2.000E-04

PER 009EU 080 9.100E-01 3.990E+00 3.990E+00

PER 009EU 081 9.100E-01 3.990E+00 3.990E+00

PER 009EU 082 9.100E-01 3.990E+00 3.990E+00

PER 009EU 083 9.100E-01 3.990E+00 3.990E+00

PER 009EU 084 9.100E-01 3.990E+00 3.990E+00

PER 009EU 085 9.100E-01 3.990E+00 3.990E+00

PER 009EU 086 9.100E-01 3.990E+00 3.990E+00

PER 011EU 092 3.000E-03 1.260E-02 1.260E-02

PER 011EU 093 3.000E-03 1.260E-02 1.260E-02

PER 011EU 094 1.400E-03 6.300E-03 6.300E-03

PER 010GP 001 2.350E+02

PER 010SV 058 2.400E-03 1.030E-02 1.030E-02 1.030E-02

Totals 5.118E+01 2.519E+02 3.482E+01

Volatile Organic Compounds

PER 006EU 001 2.700E-01 1.180E+00 1.180E+00

PER 011EU 001 2.600E-01 1.160E+00 1.160E+00

Page 25 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)





PER 006EU 002 2.700E-01 1.180E+00 1.180E+00

PER 011EU 002 2.600E-01 1.160E+00 1.160E+00

PER 006EU 003 2.700E-01 1.180E+00 1.180E+00

PER 011EU 003 2.600E-01 1.160E+00 1.160E+00

PER 006EU 004 1.400E-01 6.000E-01 6.000E-01

PER 008EU 005 4.000E-02 1.700E-01 1.700E-01

PER 008EU 006 8.250E-03 4.000E-02 4.000E-02

PER 008EU 007 8.250E-03 4.000E-02 4.000E-02

PER 008EU 008 8.250E-03 4.000E-02 4.000E-02

PER 008EU 009 8.250E-03 4.000E-02 4.000E-02

PER 008EU 010 8.250E-03 4.000E-02 4.000E-02

PER 008EU 011 8.250E-03 4.000E-02 4.000E-02

PER 008EU 012 8.250E-03 4.000E-02 4.000E-02

PER 008EU 013 8.250E-03 4.000E-02 4.000E-02

PER 008EU 014 8.250E-03 4.000E-02 4.000E-02

PER 008EU 015 8.250E-03 4.000E-02 4.000E-02

PER 008EU 016 8.250E-03 4.000E-02 4.000E-02

PER 008EU 017 8.250E-03 4.000E-02 4.000E-02

PER 008EU 018 8.000E-02 3.700E-01 3.700E-01

PER 008EU 019 8.000E-02 3.700E-01 3.700E-01

PER 008EU 020 8.000E-02 3.700E-01 3.700E-01

PER 008EU 021 8.000E-02 3.700E-01 3.700E-01

PER 008EU 022 0.000E+00 0.000E+00 0.000E+00

PER 008EU 025 1.250E-02 5.000E-02 5.000E-02

PER 008EU 026 0.000E+00 0.000E+00 0.000E+00

PER 001EU 027 8.370E+00 3.670E+01 3.670E+01

PER 010EU 028 0.000E+00 0.000E+00 0.000E+00

PER 008EU 029 3.000E-01 1.300E+00 1.300E+00

PER 008EU 030 4.400E-02 1.900E-01 1.900E-01

PER 008EU 031 6.600E-01 2.890E+00 2.890E+00

PER 008EU 032 6.600E-01 2.890E+00 2.890E+00

PER 010EU 036 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 008EU 037 1.500E-02 6.600E-02 6.600E-02

PER 008EU 038 1.500E-02 6.600E-02 6.600E-02

PER 008EU 039 1.500E-02 6.600E-02 6.600E-02

Page 26 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)





PER 006EU 040 3.000E-02 1.400E-01 1.400E-01

PER 008EU 041 1.190E-02 5.000E-02 5.000E-02

PER 006EU 042 1.000E-02 6.000E-02 6.000E-02

PER 006EU 043 1.000E-02 6.000E-02 6.000E-02

PER 006EU 044 1.600E-01 7.100E-01 7.100E-01

PER 006EU 045 1.600E-01 7.100E-01 7.100E-01

PER 008EU 047 1.650E-02 7.000E-02 7.000E-02

PER 006EU 048 1.000E-03 6.000E-03 6.000E-03

PER 006EU 049 1.000E-03 5.000E-03 5.000E-03

PER 010EU 050 0.000E+00 0.000E+00 0.000E+00 0.000E+00

PER 006EU 051 1.293E+01 3.230E+00 3.230E+00

PER 008EU 052 2.200E-02 1.000E-01 1.000E-01

PER 008EU 053 2.200E-02 1.000E-01 1.000E-01

PER 006EU 054 1.300E-02 5.600E-02 5.600E-02

PER 006EU 055 1.300E-02 5.600E-02 5.600E-02

PER 006EU 056 1.800E-02 7.800E-02 7.800E-02

PER 006EU 057 1.800E-02 7.800E-02 7.800E-02

PER 006EU 058 2.000E-03 8.000E-03 8.000E-03

PER 006EU 059 2.000E-03 8.000E-03 8.000E-03

PER 006EU 060 4.000E-03 1.800E-02 1.800E-02

PER 006EU 061 7.000E-04 3.000E-03 3.000E-03

PER 006EU 062 5.000E-03 2.000E-02 2.000E-02

PER 006EU 063 2.000E-03 1.000E-02 1.000E-02

PER 008EU 064 0.000E+00 0.000E+00 0.000E+00

PER 008EU 065 0.000E+00 0.000E+00 0.000E+00

PER 008EU 066 0.000E+00 0.000E+00 0.000E+00

PER 008EU 067 1.650E-02 7.000E-02 7.000E-02

PER 008EU 068 4.000E-02 1.600E-01 1.600E-01

PER 008EU 069 3.000E-02 1.400E-01 1.400E-01

PER 008EU 074 6.000E-03 2.000E-02 2.000E-02

PER 008EU 075 2.000E-03 1.000E-02 1.000E-02

PER 008EU 076 5.000E-02 5.200E-02 5.200E-02

PER 008EU 077 7.000E-03 3.300E-02 3.300E-02

PER 008EU 078 2.000E-02 1.000E-02 1.000E-02

PER 009EU 080 1.620E+00 7.110E+00 8.500E-01

Page 27 of 28

14 May, 2013 16:10



RetiredBy

(Action)

AddedBy

(Action)


(tons per yr)

LimitedPotential

(tons per yr)


(tons per yr)

HourlyPotential

(lbs per hr)





PER 009EU 081 1.620E+00 7.110E+00 8.500E-01

PER 009EU 082 1.620E+00 7.110E+00 8.500E-01

PER 009EU 083 1.620E+00 7.110E+00 8.500E-01

PER 009EU 084 1.620E+00 7.110E+00 8.500E-01

PER 009EU 085 1.620E+00 7.110E+00 8.500E-01

PER 009EU 086 1.620E+00 7.110E+00 8.500E-01

PER 011EU 088 9.700E-01 1.416E+02 4.250E+00

PER 011EU 089 2.010E+00 8.810E+00 8.810E+00

PER 011EU 090 6.700E-01 2.940E+00 2.940E+00

PER 011EU 091 8.380E+00 3.671E+01 3.671E+01

PER 011EU 092 2.600E-02 1.200E-01 1.200E-01

PER 011EU 093 2.600E-02 1.200E-01 1.200E-01

PER 011EU 094 1.300E-02 6.000E-02 6.000E-02

PER 008SV 049 2.280E-01 1.000E+00 1.000E+00

PER 010SV 058 6.370E+00 2.790E+01 2.790E+01 2.790E+01

Totals 3.255E+02 1.444E+02 2.790E+01

Zinc

PER 011EU 001 9.830E-03 4.310E-02 4.310E-02

PER 011EU 002 9.830E-03 4.310E-02 4.310E-02

PER 011EU 003 9.830E-03 4.310E-02 4.310E-02

PER 011EU 004 5.040E-03 2.210E-02 2.210E-02

Totals 1.514E-01 1.514E-01 0.000E+00

Page 28 of 28

MINNESOTA POLLUTION CONTROL AGENCYAIR QUALITY520 LAFAYETTE ROADST. PAUL, MN 55155-4194 COMPLIANCE PLAN CD-01



8 Jul, 2013 08:31Page 1 of 42

Subject Item: Total Facility

NC/CA

Type Citation Requirement

CD hdr TOTAL FACILITY CARBON DIOXIDE EQUIVALENT (CO2e) LIMIT1.0

LIMIT Title I Condition: To avoidclassification as major source andmodification under 40 CFRSection 52.21 & Minn. R.7007.3000

Carbon Dioxide Equivalent: less than or equal to 94700 tons/year using 12-monthRolling Sum for all CO2e emitting sources at the facility.

2.0

CD Title I Condition: To avoidclassification as major source andmodification under 40 CFRSection 52.21 & Minn. R.7007.3000

Carbon Dioxide Equivalent Emissions Monitoring: By the 15th day of each monththe Permittee shall calculate and record the following:

1. the type and amount of each fuel combusted at the facility in the previouscalendar month;

2. the total facility CO2e emissions from the previous calendar month usingEquations 1 and 2 in Appendix 4 of this permit;

3. the total facility CO2e emissions during the previous 12 calendar months bysumming the monthly total CO2e emissions from the past 12 months.

3.0

CD Title I Condition: To avoidclassification as major source andmodification under 40 CFRSection 52.21 & Minn. R.7007.3000

The Permittee is prohibited from emitting any greenhouse gases as defined at title40 CFR Section 98.6 other than carbon dioxide (CO2), nitrous oxide (N2O), andmethane (CH4).

4.0

CD hdr OPERATIONAL REQUIREMENTS5.0

CD 40 CFR part 50; Minn. Stat. Sec.116.07, subds. 4a and 9; Minn. R.7007.0100, subps. 7A, 7L and 7M;Minn. R. 7007.0800, subps. 1, 2,and 4; Minn. R.7009.0010-7009.0080

Ambient Air Quality Standards: The Permittee shall comply with and upon writtenrequest demonstrate compliance with National Primary and Secondary Ambient AirQuality Standards in Title 40 CFR part 50, and the Minnesota Ambient Air QualityStandards at Minn. R. 7009.0010 to 7009.0080.

6.0

CD Minn. R. 7011.0020 Circumvention: Do not install or use a device or means that conceals or dilutesemissions, which would otherwise violate a federal or state air pollution control rule,without reducing the total amount of pollutant emitted.

7.0

CD Minn. R. 7007.0800, subp. 2;Minn. R. 7007.0800, subp. 16(J)

Air Pollution Control Equipment: Operate all pollution control equipment wheneverthe corresponding process equipment and emission units are operated, unlessotherwise noted in Table A.

8.0

CD Minn. R. 7007.0800, subps. 14and 16(J)

Operation and Maintenance Plan: Retain at the stationary source an operation andmaintenance plan for all air pollution control equipment. At a minimum, the O & Mplan shall identify all air pollution control equipment and shall include a preventativemaintenance program for that equipment, a description of (the minimum but notnecessarily the only) corrective actions to be taken to restore the equipment toproper operation to meet applicable permit conditions, a description of theemployee training program for proper operation and maintenance of the controlequipment, and the records kept to demonstrate plan implementation.

9.0

CD Minn. R. 7019.1000, subp. 4 Operation Changes: In any shutdown, breakdown, or deviation the Permittee shallimmediately take all practical steps to modify operations to reduce the emission ofany regulated air pollutant. The Commissioner may require feasible and practicalmodifications in the operation to reduce emissions of air pollutants. No emissionsunits that have an unreasonable shutdown or breakdown frequency of process orcontrol equipment shall be permitted to operate.

10.0

CD Minn. R. 7011.0150 Fugitive Emissions: Do not cause or permit the handling, use, transporting, orstorage of any material in a manner which may allow avoidable amounts ofparticulate matter to become airborne. Comply with all other requirements listed inMinn. R. 7011.0150.

11.0

CD Minn. R. 7030.0010 - 7030.0080 Noise: The Permittee shall comply with the noise standards set forth in Minn. R.7030.0010 to 7030.0080 at all times during the operation of any emission units.This is a state only requirement and is not federally enforceable.

12.0




8 Jul, 2013 08:31Page 2 of 42

CD Minn. R. 7007.0800, subp. 9(A) Inspections: Upon presentation of credentials and other documents as may berequired by law, allow the Agency, or its representative, to enter the Permittee'spremises to have access to and copy any records required by this permit, to inspectat reasonable times (which include any time the source is operating) any facilities,equipment, practices or operations, and to sample or monitor any substances orparameters at any location.

13.0

CD Minn. R. 7007.0800, subp. 16 The Permittee shall comply with the General Conditions listed in Minn. R.7007.0800, subp. 16.

14.0

CD hdr PERFORMANCE TESTING15.0

CD Minn. R. ch. 7017 Performance Testing: Conduct all performance tests in accordance with Minn. R.ch. 7017 unless otherwise noted in Tables A and/or B.

16.0

CD Minn. R. 7017.2030, subps. 1-4,Minn. R. 7017.2035, subps. 1-2,and Minn. R. 7017.2018

Performance Test Notifications and Submittals:

Performance Tests are due as outlined in Tables A and B of the permit. See TableB for additional testing requirements.

Performance Test Notification (written): due 30 days before each Performance TestPerformance Test Plan: due 30 days before each Performance TestPerformance Test Pre-test Meeting: due 7 days before each Performance TestPerformance Test Report: due 45 days after each Performance TestPerformance Test Report - Microfiche Copy: due 105 days after each PerformanceTest

The Notification, Test Plan, and Test Report may be submitted in alternative formatas allowed by Minn. R. 7017.2018.

17.0

CD Minn. R. 7017.2025, subp. 3 Limits set as a result of a performance test (conducted before or after permitissuance) apply until superseded as stated in the MPCA's Notice of Complianceletter granting preliminary approval. Preliminary approval is based on formal reviewof a subsequent performance test on the same unit as specified by Minn. R.7017.2025, subp. 3. The limit is final upon issuance of a permit amendmentincorporating the change.

18.0

CD hdr MONITORING REQUIREMENTS19.0

CD Minn. R. 7007.0800, subp. 4(D) Monitoring Equipment Calibration: Annually calibrate all required monitoringequipment (any requirements applying to continuous emission monitors are listedseparately in this permit).

20.0

CD Minn. R. 7007.0800, subp. 4(D) Operation of Monitoring Equipment: Unless otherwise noted in Tables A and/or B,monitoring a process or control equipment connected to that process is notnecessary during periods when the process is shutdown, or during checks of themonitoring systems, such as calibration checks and zero and span adjustments. Ifmonitoring records are required, they should reflect any such periods of processshutdown or checks of the monitoring system.

21.0

CD hdr RECORDKEEPING22.0

CD Minn. R. 7007.0800, subp. 5(C) Recordkeeping: Retain all records at the stationary source for a period of five (5)years from the date of monitoring, sample, measurement, or report. Records whichmust be retained at this location include all calibration and maintenance records, alloriginal recordings for continuous monitoring instrumentation, and copies of allreports required by the permit. Records must conform to the requirements listed inMinn. R. 7007.0800, subp. 5(A).

23.0

CD Minn. R. 7007.0800, subp. 5(B) Recordkeeping: Maintain records describing any insignificant modifications (asrequired by Minn. R. 7007.1250, subp. 3) or changes contravening permit terms (asrequired by Minn. R. 7007.1350, subp. 2), including records of the emissionsresulting from those changes.

24.0

CD Minn. R. 7007.1200, subp. 4 If the Permittee determines that no permit amendment or notification is requiredprior to making a change, the Permittee must retain records of all calculationsrequired under Minn. R. 7007.1200. These records shall be kept for a period of fiveyears from the date the change was made or until permit reissuance, whichever islonger. The records shall be kept at the stationary source for the current calendaryear of operation and may be kept at the stationary source or office of thestationary source for all other years. The records may be maintained in eitherelectronic or paper format.

25.0

CD hdr REPORTING/SUBMITTALS26.0




8 Jul, 2013 08:31Page 3 of 42

CD Minn. R. 7019.1000, subp. 3 Shutdown Notifications: Notify the Commissioner at least 24 hours in advance of aplanned shutdown of any control equipment or process equipment if the shutdownwould cause any increase in the emissions of any regulated air pollutant. If theowner or operator does not have advance knowledge of the shutdown, notificationshall be made to the Commissioner as soon as possible after the shutdown.However, notification is not required in the circumstances outlined in Items A, Band C of Minn. R. 7019.1000, subp. 3.

At the time of notification, the owner or operator shall inform the Commissioner ofthe cause of the shutdown and the estimated duration. The owner or operator shallnotify the Commissioner when the shutdown is over.

27.0

CD Minn. R. 7019.1000, subp. 2 Breakdown Notifications: Notify the Commissioner within 24 hours of a breakdownof more than one hour duration of any control equipment or process equipment ifthe breakdown causes any increase in the emissions of any regulated air pollutant.The 24-hour time period starts when the breakdown was discovered or reasonablyshould have been discovered by the owner or operator. However, notification is notrequired in the circumstances outlined in Items A, B and C of Minn. R. 7019.1000,subp. 2.

At the time of notification or as soon as possible thereafter, the owner or operatorshall inform the Commissioner of the cause of the breakdown and the estimatedduration. The owner or operator shall notify the Commissioner when thebreakdown is over.

28.0

CD Minn. R. 7019.1000, subp. 1 Notification of Deviations Endangering Human Health or the Environment: As soonas possible after discovery, notify the Commissioner or the state duty officer, eitherorally or by facsimile, of any deviation from permit conditions which could endangerhuman health or the environment.

29.0

CD Minn. R. 7019.1000, subp. 1 Notification of Deviations Endangering Human Health or the Environment Report:Within 2 working days of discovery, notify the Commissioner in writing of anydeviation from permit conditions which could endanger human health or theenvironment. Include the following information in this written description:1. the cause of the deviation;2. the exact dates of the period of the deviation, if the deviation has been corrected;3. whether or not the deviation has been corrected;4. the anticipated time by which the deviation is expected to be corrected, if not yetcorrected; and5. steps taken or planned to reduce, eliminate, and prevent reoccurrence of thedeviation.

30.0

S/A Minn. R. 7007.0800, subp. 6(A)(2) Semiannual Deviations Report: due 30 days after end of each calendar half-yearstarting 08/05/1999 . The first semiannual report submitted by the Permittee shallcover the calendar half-year in which the permit is issued. The first report of eachcalendar year covers January 1 - June 30. The second report of each calendaryear covers July 1 - December 31.

31.0

CD Minn. R. 7007.1150 - 7007.1500 Application for Permit Amendment: If a permit amendment is needed, submit anapplication in accordance with the requirements of Minn. R. 7007.1150 throughMinn. R. 7007.1500. Submittal dates vary, depending on the type of amendmentneeded.

32.0

S/A Minn. R. 7007.0400, subp. 2 Application for Permit Reissuance: due 180 days before expiration of ExistingPermit

33.0

CD Minn. R. 7007.1400, subp. 1(H) Extension Requests: The Permittee may apply for an Administrative Amendment toextend a deadline in a permit by no more than 120 days, provided the proposeddeadline extension meets the requirements of Minn. R. 7007.1400, subp. 1(H).Performance testing deadlines from the General Provisions of 40 CFR pt. 60 andpt. 63 are examples of deadlines for which the MPCA does not have authority togrant extensions and therefore do not meet the requirements of Minn. R.7007.1400, subp. 1(H).

34.0

S/A Minn. R. 7007.0800, subp. 6(C) Compliance Certification: due 31 days after end of each calendar year starting08/05/1999 (for the previous calendar year). The certification shall be submitted ona form approved by the Commissioner, both to the Commissioner and to the USEPA regional office in Chicago. This report covers all deviations experienced duringthe calendar year.

35.0

CD Minn. R. 7019.3000 - 7019.3010 Emission Inventory Report: due on or before April 1 of each calendar year followingpermit issuance. Submit the report on a form or alternative media approved by theCommissioner.

36.0

CD Minn. R. 7002.0005 - 7002.0095 Emission Fees: due 60 days after receipt of an MPCA bill.37.0




8 Jul, 2013 08:31Page 4 of 42

Subject Item: GP 001 SO2 and NOx Limits


EU 002 Boiler #2

EU 003 Boiler #3

EU 004 Boiler #4

EU 005 Boiler #5

EU 044 Boiler #6

EU 045 Boiler #7

EU 051 Emergency RICE(s)

EU 080 Generator #1

EU 081 Generator #2

EU 082 Generator #3

EU 083 Generator #4

EU 084 Generator #5

EU 085 Generator #6

EU 086 Generator #7

NC/CA


CD hdr GP 001 ASSOCIATED ITEMS

GP 001 is composed of GP 011 and GP 012 emission units, and EU 051. GP 011is composed of EU 080 through EU 086. GP 012 is composed of EU 001 - EU 005,EU 044, and EU 045.

1.0

CD hdr EMISSION LIMITS2.0

LIMIT Title I Condition: To limit potentialNOx emissions to less than majorsource levels defined by 40 CFRSection 52.21; Minn. R.7007.3000

Nitrogen Oxides: less than or equal to 180 tons/year using 12-month Rolling Sumtotal for GP 001.

3.0

LIMIT Title I Condition: To limit potentialSO2 emissions to less than majorsource levels defined by 40 CFRSection 52.21; Minn. R.7007.3000

Sulfur Dioxide: less than or equal to 235 tons/year using 12-month Rolling Sumtotal for GP 001 combustion of diesel fuel, and refined animal fats. This does notinclude any SO2 emissions from distillate oil or diesel fuel combustion in EU 051.

4.0


CD Minn. R. 7007.0800, subp. 4 and 5 Sulfur Dioxide Emissions Monitoring and Recordkeeping: By the 15th day of eachmonth the Permittee shall:

1) Calculate and record GP 001 SO2 emissions during the previous calendarmonth using the following equation:

SO2 = GP 011 + GP 012

where:

SO2 = GP 001 calendar month SO2 emissions, in tonsGP 011 = GP 011 calendar month SO2 emissions, in tons, determined under GP011GP 012 = GP 012 calendar month SO2 emissions, in tons, determined under GP012

(continued)

6.0




8 Jul, 2013 08:31Page 5 of 42

CD Minn. R. 7007.0800, subp. 4 and 5 (continued from above)

2) Calculate and record the 12-month rolling sum GP 001 SO2 emissions bysumming the monthly GP 001 SO2 emissions determined with the above equation,for the previous 12 months.

7.0

CD Minn. R. 7007.0800, subp. 4 and 5 Nitrogen Oxides Emissions Monitoring and Recordkeeping: By the 15th day ofeach month the Permittee shall:

1) Calculate and record GP 001 NOx emissions during the previous calendarmonth using the following equation:

NOx = GP 011 + GP 012 + (EU 051/2000)

where:

NOx = GP 001 calendar month NOx emissions, in tonsGP 011 = GP 011 calendar month NOx emissions, in tons, determined under GP011GP 012 = GP 012 calendar month NOx emissions, in tons, determined under GP012EU 051 = EU 051 calendar month NOx emissions, in pounds, determined under EU051

(continued)

8.0

CD Minn. R. 7007.0800, subp. 4 and 5 (continued from above)

2) Calculate and record the 12-month rolling sum GP 001 NOx emissions bysumming the monthly GP 001 NOx emissions determined with the above equation,for the previous 12 months.

9.0




8 Jul, 2013 08:31Page 6 of 42

Subject Item: GP 003 Natural Smoke Process

Associated Items: EU 006 Smoked Meat Oven #6 with recirculated natural wood smoke














NC/CA



LIMIT Minn. R. 7011.0715, subp. 1(A) Total Particulate Matter: less than 0.30 grains/dry standard cubic foot unlessrequired to reduce emissions to meet the less stringent limit of either 7011.0730 or7011.0735 (table 1 and 2, respectively). This limit applies individually to eachstack/vent.

2.0

LIMIT Minn. R. 7011.0715, subp. 1(B) Opacity: less than or equal to 20 percent . This limit applies individually to eachstack/vent.

3.0

CD hdr PERFORMANCE TEST REQUIREMENTS4.0

S/A Minn. R. 7017.2020, subp. 1 Performance Test: due before end of each calendar 60 months starting 10/07/2011to measure PM and opacity from one of the GP 003 emission units while usingnatural smoke from EU 031 or EU 032. The next PM and opacity tests are due10/7/2016.

5.0




8 Jul, 2013 08:31Page 7 of 42

Subject Item: GP 005 Precook Processes

Associated Items: CE 006 Mist Eliminator - High Velocity, i.e., V>250 Ft/Min



EU 018 Precooked Bacon, South

EU 019 Precooked Bacon, North

EU 020 Precooked Bacon, East

EU 021 Precooked Bacon, West

EU 029 Bacon Bits Precooked Line

SV 019 Precooked Bacon Stack N/S (EU 018 & EU 019/CE 006)

SV 020 Precooked Bakon Stack E/W (EU 020 & EU 021/CE 007)

SV 050 Bacon Bits Line (EU 029/CE 025)

NC/CA



LIMIT Minn. R. 7011.0715, subp. 1(A) Total Particulate Matter: less than 0.30 grains/dry standard cubic foot unlessrequired to reduce emissions to meet the less stringent limit of either 7011.0730 or7011.0735 (table 1 and 2, respectively). This limit applies individually to eachstack/vent.

2.0

LIMIT Minn. R. 7011.0715, subp. 1(B) Opacity: less than or equal to 20 percent opacity . This limit applies individually toeach stack/vent.

3.0

CD hdr OPERATING REQUIREMENTS4.0

CD Minn. R. 7007.0800, subp. 2 Vent all emissions from GP 005 precooked process equipment through thecorresponding mist eliminator (CE 006, CE 007, or CE 025).

5.0

CD hdr CONTROL EQUIPMENT REQUIREMENTS6.0

CD Minn. R. 7007.0800, subp. 14 The Permittee shall operate and maintain each mist eliminator in accordance withthe Operation and Maintenance (O & M) Plan. The Permittee shall keep copies ofthe O & M Plan available onsite for use by staff and MPCA staff.

7.0

CD Minn. R. 7007.0800, subp. 4 Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for each mist eliminator, as required by this permit. The monitoring equipmentmust be installed, in use, and properly maintained when the mist eliminator iscontrolling emissions.

8.0

CD Minn. R. 7007.0800, subp. 14 CE 006 and CE 007 Pressure Differential: Not less than 0 inches wc and not morethan 2 inches wc for each mist eliminator when controlling precooked processemissions.

9.0

CD Minn. R. 7007.0800, subp. 14 CE 006 and CE 007 Minimum Water Flow Rate: Not less than 1 gallon per minute,for each mist eliminator when controlling precooked process emissions.

10.0

CD Minn. R. 7007.0800, subp. 14 CE 025 Pressure Differential: Less than 2 inches wc when controlling processemissions.

11.0

CD Minn. R. 7007.0800, subp. 14 CE 025 Minimum Water Flow Rate when controlling process emissions:

Filter: not less than 2 gallon per minute;Upper Intake: not less than 1 gallon per minuteLower Intake: not less than 1 gallon per minute

12.0

CD Minn. R. 7007.0800, subp. 4 and 5 Daily Monitoring: Once each day of operation, the Permittee shall monitor andrecord the pressure differential and water flow rate for each mist eliminator that iscontrolling any GP 005 precooked process emissions.

13.0

CD Minn. R. 7007.0800, subp. 4, 5,and 14

Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of each misteliminator. The Permittee shall maintain a written record of the results of eachinspection.

14.0




8 Jul, 2013 08:31Page 8 of 42

CD Minn. R. 7007.0800, subp. 4, 5,and 14

Corrective Actions: The Permittee shall take corrective action as soon as possibleif any of the following occur:

- the pressure drop across any mist eliminator is outside the required operatingrange;- the water flow rate for any mist eliminator is less than the required minimum; or- any mist eliminator or any of its components are found during any inspection toneed repair.

Corrective actions shall return the pressure drop to within the permitted range,restore the water flow rate to at least the required minimum, and/or includecompletion of necessary repairs identified during the inspection, as applicable.Corrective actions include, but are not limited to, those outlined in the O & M Planfor the mist eliminator. The Permittee shall keep a record of the type and date ofany corrective action taken for any of the mist eliminators.

15.0

CD Minn. R. 7007.0800, subps. 4, 5,and 14


16.0




8 Jul, 2013 08:31Page 9 of 42

Subject Item: GP 010 Blood and Bone Meal Dryers

Associated Items: CE 018 Venturi Scrubber






EU 071 Room Air - Blood & Bone Drying

SV 033 Blood & Bone Dryers CE 018/CE 024 (venturi & packed tower E; bypasses packed tower F) (EU 036/EU 050)

SV 045 Blood & Bone Dryers CE 019 (packed tower F) (EU 036/EU 050)


NC/CA


CD hdr Subject Item GP 010 contains requirements applicable either:



Prior to CE 026 startup, EU 036 and EU 050 emissions will vent to CE 018 (venturiscrubber) and then through CE 024 (Tower E) and then either to CE 019 (Tower F),and vent to the atmosphere through SV 045, or bypass CE 019 and vent emissionsto the atmosphere from CE 024 through SV 033.

After CE 026 startup, EU 036 and EU 050 emissions will be vented to CE 018 andthen to CE 026 and then to the atmosphere through SV 058, and CE 024 will beshutdown.

1.0

CD hdr EMISSION LIMITS - APPLY BEFORE AND AFTER CE 026 STARTUP


2.0

LIMIT Minn. R. 7011.0610, subp. 1(A)(1) Total Particulate Matter: less than or equal to 0.30 grains/dry standard cubic foot ofexhaust gas unless required to further reduce emissions to comply with the lessstringent limit of either Minn. R. 7011.0730 or Minn. R. 7011.0735.


3.0

LIMIT Minn. R. 7011.0610, subp. 1(A)(2) Opacity: less than or equal to 20 percent except for one six-minute period per hourof not more than 60 percent opacity.


4.0

CD hdr OPERATING REQUIREMENTS - APPLY AFTER CE 026 STARTUP5.0

CD Title I Condition: To avoid majorsource status under 40 CFRSection 52.21 and Minn. R.7007.3000

Vent emissions from both the blood and bone dryers through CE 018 (venturiscrubber) and CE 026 (RTO) and then through SV 058. After CE 026 startup, thePermittee shall not route GP 010 emissions through CE 019 and CE 024.

6.0

CD hdr CE 018 CONTROL EQUIPMENT REQUIREMENTS - APPLY AFTER CE 026STARTUP

7.0

LIMIT Title I Condition: To avoid majorsource status under 40 CFRSection 52.21 and Minn. R.7007.3000

The Permittee shall operate and maintain CE 018 to achieve a control efficiency forTotal Particulate Matter: greater than or equal to 94 percent control efficiency

8.0




8 Jul, 2013 08:31Page 10 of 42

LIMIT Title I Condition: To avoid majorsource status under 40 CFRSection 52.21 and Minn. R.7007.3000

The Permittee shall operate and maintain CE 018 to achieve a control efficiency forPM < 10 micron: greater than or equal to 84 percent control efficiency

9.0


The Permittee shall operate and maintain CE 018 venturi scrubber at all times thatany emission unit controlled by CE 018 is in operation. The Permittee shalldocument periods of non-operation of CE 018.

10.0

CD Minn. R. 7007.0800, subp. 14 The Permittee shall operate and maintain CE 018 in accordance with the Operationand Maintenance (O & M) Plan. The Permittee shall keep copies of the O & M Planavailable onsite for use by staff and MPCA staff.

11.0

CD Minn. R. 7007.0800, subp. 4 Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for CE 018, as required by this permit. The monitoring equipment must beinstalled, in use, and properly maintained when CE 018 is in operation.

12.0

CD Title I Condition: To avoid majorsource status under 40 CFRSection 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 & 14

CE 018 Pressure Differential: greater than or equal to 5.0 inches w.c.13.0


CE 018 Water Flow Rate: greater than or equal to 10 gallons per minute.14.0


CE 018 Daily Monitoring and Recordkeeping: Once each day of EU 036 and/or EU050 operation, the Permittee shall monitor and record the pressure differential andthe water flow rate for CE 018.

15.0



16.0



- the CE 018 pressure drop is below the permitted minimum;- the CE 018 water flow rate is below the permitted minimum; or- CE 018 or any of its components are found during any inspection to need repair.

Corrective actions shall return the CE 018 pressure drop to at or above theminimum, the CE 018 water flow rate to at or above the permitted minimum, and/orinclude completion of necessary repairs identified during the inspection, asapplicable. Corrective actions include, but are not limited to, those outlined in theCE 018 O & M Plan. The Permittee shall keep a record of the type and date of anycorrective action taken.

17.0



18.0

CD hdr OPERATING REQUIREMENTS - APPLY ONLY BEFORE CE 026 STARTUP19.0

CD Minn. R. 7007.0800, subp. 2 Vent emissions from both the blood and bone dryers through CE 018 (venturiscrubber) and then through CE 024 (Tower E). After CE 024 the Permittee has theoption of routing emissions to CE 019 (Tower F), and then through SV 045, orbypass CE 019 and vent emissions from CE 024 through SV 033.

20.0

CD hdr CE 018 (VENTURI SCRUBBER), CE 019 (TOWER F) AND CE 024 (TOWER E)CONTROL EQUIPMENT REQUIREMENTS - APPLY ONLY BEFORE CE 026STARTUP

21.0

LIMIT Title I Condition: To avoidclassification as a major sourceand modification under 40 CFRSection 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14


22.0




8 Jul, 2013 08:31Page 11 of 42



23.0



24.0



25.0

CD Minn. R. 7007.0800, subp. 14 The Permittee shall operate and maintain CE 018, CE 019, and CE 024 inaccordance with the Operation and Maintenance (O & M) Plan. The Permittee shallkeep copies of the O & M Plan available onsite for use by staff and MPCA staff.

26.0

CD Minn. R. 7007.0800, subp. 4 Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring and recording pressure drop and water flowrate for CE 018, CE 019, and CE 024, as required by this permit. The monitoringequipment must be installed, in use, and properly maintained when CE 018, CE019, and CE 024 are in operation.

27.0

CD Minn. R. 7007.0800, subp. 14 CE 018 Pressure Differential: greater than or equal to 5 inches wc.CE 019 Pressure Differential: less than 7 inches wc.CE 024 Pressure Differential: less than 5 inches wc.

28.0

CD Minn. R. 7007.0800, subp. 14 CE 018 Water Flow Rate: not less than 10 gallons per minuteCE 019 Water Flow Rate: not less than 150 gallons per minuteCE 024 Water Flow Rate: not less than 50 gallons per minute

29.0

CD Minn. R. 7007.0800, subp. 4 and 5 CE 018, CE 019, and CE 024 Daily Monitoring: Once each day of operation, thePermittee shall monitor and record the pressure differential and the water flow ratefor CE 018, CE 019, and CE 024.

30.0



31.0

CD Minn. R. 7007.0800, subp. 4, 5,and 14


32.0

CD Minn. R. 7007.0800, subp. 4, 5,and 14




33.0




8 Jul, 2013 08:31Page 12 of 42

Subject Item: GP 011 Electric Power Generators

Associated Items: EU 080 Generator #1

EU 081 Generator #2

EU 082 Generator #3

EU 083 Generator #4

EU 084 Generator #5

EU 085 Generator #6

EU 086 Generator #7

NC/CA


CD hdr LIMITS AND OPERATIONAL REQUIREMENTS1.0

LIMIT Minn. R. 7011.2300, subp. 1 Opacity: less than or equal to 20 percent opacity once operating temperatures havebeen attained.

2.0

LIMIT Minn. R. 7011.2300, subp. 2 Sulfur Dioxide: less than or equal to 0.5 lbs/million Btu heat input3.0

CD Minn. R. 7007.0800, subp. 2 Permitted fuel: diesel fuel only.4.0

CD Minn. R. 7007.0800, subp. 2 Diesel fuel sulfur content: less than or equal to 0.05 percent by weight.5.0

LIMIT Minn. R. 7007.0800, subp. 2 Total GP 011 Operating Hours: less than or equal to 65 hours/day6.0

CD hdr MONITORING AND RECORDKEEPING7.0

CD Minn. R. 7007.0800, subp. 4 and 5 Diesel Fuel Supplier Certification: For each diesel fuel delivery, obtain a suppliercertification either stating the actual sulfur content in percent by weight or certifyingthat the sulfur content does not exceed 0.05 percent by weight.

8.0

CD Title I Condition: To limit potentialNOx emissions to less than themajor source levels defined in 40CFR Section 52.21; Minn. R.7007.3000; Minn. R. 7007.0800,subp. 4 and 5

Recordkeeping - GP 011 Operating Hours: Once each day the Permittee shallcalculate and record the total GP 011 operating hours for the previous calendarday. By the 15th day of each month, calculate and record the total GP 011operating hours for the previous calendar month.

9.0

CD Title I Condition: To limit potentialSO2 emissions to less than themajor source levels defined in 40CFR Section 52.21; Minn. R.7007.3000; Minn. R. 7007.0800,subp. 4 and 5

Recordkeeping - Fuel Usage: Once each day the Permittee shall calculate andrecord the GP 011 diesel fuel usage (gallons) for the previous calendar day. By the15th day of each month, calculate and record the total GP 011 diesel fuel usage(gallons) for the previous calendar month.

10.0

CD Minn. R. 7007.0800, subp. 4 and 5 Sulfur Dioxide Emissions Monitoring: by the 15th day of each month, calculate andrecord GP 011 SO2 emissions for the previous calendar month using the followingequation:

GP 011 SO2 = (Dg * 6.92E-03)/2000

where:

GP 011 SO2 = GP 011 SO2 emissions, in tonsDg = diesel fuel combusted by GP 011 units during the previous month, in gallons6.92E-03 = conversion factor derived from fuel heat content (0.137 mmBtu/gallon)and sulfur content limit (0.05% by weight equivalent to 0.0505 lb/mmBtu)

11.0




8 Jul, 2013 08:31Page 13 of 42

CD Minn. R. 7007.0800, subp. 4 and 5 Nitrogen Oxides Emissions Monitoring: by the 15th day of each month, calculateand record GP 011 NOx emissions for the previous calendar month using thefollowing equation:

GP 011 NOx = (OH * EF)/2000

where:

GP 011 NOx = GP 011 NOx emissions, in tonsOH = GP 011 units total operating hours during the previous monthEF = NOx lb/hr emission factor; upon issuance of this permit the Permittee shalluse the manufacturer's 48.92 lb/hr NOx emission factor

This NOx lb/hr emission factor will be revised upon written MPCA approval of thelatest NOx emission factor performance test results. An EF determined for one unitapplies to all seven units for determining the GP 011 12-month rolling sum NOxemissions.

12.0


S/A Title I Condition: To limit potentialNOx emissions to less than themajor source levels defined in 40CFR Section 52.21; Minn. R.7007.3000; Minn. R. 7017.2020,subp. 1

Performance Test: due before end of each 36 months starting 10/26/2012 todetermine the lb/hr NOx emission factor from one generator in GP 011 that has notbeen previously tested for NOx. If all GP 011 generators have been tested for NOx,test the generator with the least current NOx emission factor test.

14.0

S/A Minn. R. 7017.2020, subp. 1 Performance Test: due before end of each 60 months starting 10/26/2012 tomeasure opacity from one GP 011 generator that has not been previously testedfor opacity. If all GP 011 generators have been tested for opacity, test the generatorwith the least current opacity test.

15.0

S/A Minn. R. 7017.2020, subp. 1 Testing Frequency Plan: due 60 days after Performance Test for determining theNOx lb/hr emission factor. The plan shall specify a testing frequency for NOx basedon the NOx emission factor performance test (due 10/26/2015) data and MPCAguidance. Future performance tests based on 12-month, 36-month, or 60-monthintervals, or as applicable, shall be required upon written approval of the plan bythe MPCA.

Future testing shall be conducted on a unit not previously tested. After testing allunits, testing shall be conducted on the unit whose previous test is least current.

16.0

S/A Minn. R. 7017.2020, subp. 1 Testing Frequency Plan: due 60 days after Performance Test for determiningopacity. The plan shall specify a testing frequency for opacity based on the opacityperformance test (due 10/26/2017) data and MPCA guidance. Future performancetests based on 12-month, 36-month, or 60-month intervals, or as applicable, shallbe required upon written approval of the plan by the MPCA.

Future testing shall be conducted on a unit not previously tested. After testing allunits, testing shall be conducted on the unit whose previous test is least current.

17.0




8 Jul, 2013 08:31Page 14 of 42

Subject Item: GP 012 Boilers


EU 002 Boiler #2

EU 003 Boiler #3

EU 004 Boiler #4

EU 005 Boiler #5

EU 044 Boiler #6

EU 045 Boiler #7

NC/CA



LIMIT Minn. R. 7011.0515, subp. 1 Total Particulate Matter: less than or equal to 0.4 lbs/million Btu heat input (appliesindividually to EU 001 through EU 005).

2.0

LIMIT Minn. R. 7011.0515, subp. 2 Opacity: less than or equal to 20 percent opacity except for one six-minute periodper hour of not more than 60 percent opacity (applies individually to EU 001through EU 005).

3.0

CD hdr OPERATING LIMITS4.0

CD Minn. R. 7007.0800, subp. 2 Permitted Fuels:

EU 001, EU 002, EU 003, and EU 004: Limited to natural gas, and refined animalfats (RAF)EU 005: natural gas onlyEU 044, and EU 045: natural gas and RAF

5.0


CD 40 CFR Section 60.48c(g) Seperately record and maintain records of the quantity of natural gas combusted byEU 044 and the quantity of natural gas combusted by EU 045, on a monthly basis.

7.0

CD Title I Condition: To limit potentialSO2 and NOx emissions to lessthan major source levels definedby 40 CFR Section 52.21; Minn.R. 7007.3000; Minn. R.7007.0800, subp. 4 and 5

Recordkeeping - Fuel Usage: Once each day calculate and record the GP 012usage of natural gas (cubic feet), and RAF usage in EU 001, EU 002, EU 003, andEU 004 (gallons), and the RAF usage in EU 044 and EU 045 (gallons), during theprevious calendar day.

By the 15th day of each month, calculate and record the GP 012 usage of naturalgas (cubic feet), and RAF usage in EU 001, EU 002, EU 003, and EU 004(gallons), and the RAF usage in EU 044 and EU 045 (gallons), during the previouscalendar month.

8.0

CD Minn. R. 7007.0800, subp. 4 and 5 Sulfur Dioxide Emissions Monitoring: By the 15th day of each month the Permitteeshall calculate and record the tons of SO2 emitted during the previous calendarmonth from the GP 012 combustion of RAF, using the following equation:

SO2 = (0.157CZ)/2000

where:

SO2 = GP 012 sulfur dioxide emissions during the previous month (tons)C = GP 012 gallons of refined animal fat burned during the previous monthZ = weight percent of sulfur in RAF burned the previous month

9.0




8 Jul, 2013 08:31Page 15 of 42

CD Minn. R. 7007.0800, subp. 4 and 5 Nitrogen Oxides Emissions Monitoring: By the 15th day of each month thePermittee shall calculate and record the tons of NOx emitted from GP 012 duringthe previous calendar month using the following equation:

NOx = (X1B1 + X2B2 + 0.0001C)/2000

where:

NOx = GP 012 nitrogen oxides emissions during the previous month (tons)B1 = GP 012 gallons of RAF burned during the previous month in EU 001 - 004B2 = GP 012 gallons of RAF burned during the previous month in EU 044 & 045X1 = NOx emission factor in lb of NOx/gallon of RAF from most recent test whilecombusting RAF in EU 001 - 004X2 = NOx emission factor in lb of NOx/gallon of RAF from most recent test whilecombusting RAF in EU 044 & 045 (if RAF NOx emission testing data is notavailable, X1 and/or X2 shall be 0.0366 lb/gal)C = GP 012 cubic feet of natural gas combusted during the previous month

10.0

CD hdr PERFORMANCE TESTING AND ANALYSIS11.0

CD Title I Condition: To limit potentialSO2 emissions to less than majorsource levels defined by 40 CFRSection 52.21; Minn. R.7007.3000

RAF Sulfur Content: Perform an analysis during each 12-month period followingpermit issuance to determine weight percent sulfur content in RAF using EPAMethod 6A. The first analysis shall be performed within 180 days of permitissuance.

12.0

S/A Title I Condition: To limit potentialNOx emissions to less than majorsource levels defined by 40 CFRSection 52.21; Minn. R.7007.3000

Performance Test: due before end of each calendar 60 months starting 09/15/2002to measure NOx emissions while combusting only RAF in either EU 001, EU 002,EU 003, or EU 004. Testing is required only if a total of more than 500,000 gallonsof RAF has been combusted in EU 001 through EU 004 during the 60-month periodstarting 09/15/2002.

13.0

S/A Title I Condition: To limit potentialNOx emissions to less than majorsource levels defined by 40 CFRSection 52.21; Minn. R.7007.3000

Performance Test: due 180 days after Initial Startup of RAF combustion in EU 044and/or EU 045, to measure NOx emissions. Testing shall be conducted whencombusting only RAF, and on either EU 044 or EU 045.

14.0




8 Jul, 2013 08:31Page 16 of 42

Subject Item: GP 014 Refined Products Makeup Air Units

Associated Items: EU 092 Refined Products MAU 1






NC/CA



LIMIT Minn. R. 7011.0515, subp. 1 Total Particulate Matter: less than or equal to 0.4 lbs/million Btu heat input . Thenatural gas fuel restriction for these units constitutes compliance with this limit.

2.0

LIMIT Minn. R. 7011.0515, subp. 2 Opacity: less than or equal to 20 percent opacity except for one six-minute periodper hour of not more than 60 percent opacity.

3.0

CD Minn. R. 7007.0800, subp. 2 Fuel Restriction: Units in this group are permitted to fire natural gas only.4.0




8 Jul, 2013 08:31Page 17 of 42

Subject Item: SV 058 Regenerative Thermal Oxidizer (CE 026)

Associated Items: EU 028 Rendering Machinery



EU 087 Regenerative Thermal Oxidizer (CE 026)

EU 088 Refined Products Machinery

GP 010 Blood and Bone Meal Dryers

MR 001 CE 026/EU 087 Combustion Chamber Temperature

NC/CA


CD hdr EMISSION LIMITS (The following limits apply prior to startup of EU 088)1.0

LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000;meets requirements of Minn. R.7011.0610, subp. 1(A)(1) andMinn. R. 7011.0715, subp. 1.A

Total Particulate Matter: less than or equal to 6.37 lbs/hour for SV 058.2.0

LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000

PM < 10 micron: less than or equal to 6.37 lbs/hour for SV 058.3.0


PM < 2.5 micron: less than or equal to 6.37 lbs/hour from SV 058.4.0


Volatile Organic Compounds: less than or equal to 6.37 lbs/hour for SV 058.5.0

LIMIT Minn. R. 7011.0715, subp. 1.B;meets requirements of Minn. R.7011.0610, subp. 1(A)(2)

Opacity: less than or equal to 20 percent opacity for SV 058.6.0

CD hdr EMISSION LIMITS (The following limits apply after startup of EU 088)7.0

LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; meetsrequirements of Minn. R.7011.0610, subp. 1(A)(1) andMinn. R. 7011.0715, subp. 1.A

Total Particulate Matter: less than or equal to 1.22 lbs/hour for SV 058.8.0


PM < 10 micron: less than or equal to 1.15 lbs/hour for SV 058.9.0


PM < 2.5 micron: less than or equal to 1.41 lbs/hour from SV 058.10.0


Volatile Organic Compounds: less than or equal to 0.99 lbs/hour for SV 058.11.0

LIMIT Minn. R. 7011.0715, subp. 1.B;meets requirements of Minn. R.7011.0610, subp. 1(A)(2)

Opacity: less than or equal to 20 percent opacity for SV058.12.0





8 Jul, 2013 08:31Page 18 of 42


Vent all CE 009 (EU 028) and CE 018 (EU 036 and EU 050) emissions through CE026.

Venting of CE 009 (EU 028) emissions through CE 026 applies until startup of EU088.

14.0

CD hdr CE 026 CONTROL EQUIPMENT REQUIREMENTS15.0



16.0



17.0


The Permittee shall operate and maintain CE 026 to achieve a total controlefficiency for PM < 2.5 micron: greater than or equal to 62 percent control efficiency

18.0


The Permittee shall operate and maintain CE 026 to achieve a total controlefficiency for Volatile Organic Compounds: greater than or equal to 97 percentcontrol efficiency

19.0


20.0

CD Title I Condition: To avoidclassification as a major sourceand modification under 40 CFRSection 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14

CE 026 Combustion Chamber Temperature: greater than or equal to 1350 F on a3-hour rolling average, unless a new minimum is set pursuant to Minn. R.7017.2025, subp. 3, based on the values recorded during the most recentMPCA-approved performance test where compliance was demonstrated. The newminimum shall be implemented upon receipt of the Notice of Compliance lettergranting preliminary approval. The minimum is final upon issuance of a permitamendment incorporating the change.

21.0


CD 40 CFR Section 64.7(b); Minn. R.7017.0200

Monitoring Equipment: The Permittee shall install and maintain the necessarymonitoring equipment for measuring CE 026 combustion chamber temperature, asrequired by this permit. The monitoring equipment must be installed, in use, andproperly maintained when CE 026 is in operation.

23.0

CD Title I Condition: To avoidclassification as a major sourceand modification under 40 CFRSection 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 4 & 5; 40 CFR Section64.3; Minn. R. 7017.0200

CE 026 Temperature Monitoring and Recordkeeping: The Permittee shall operateand maintain a continuous CE 026 combustion chamber temperature monitor andcontinuously record the combustion chamber temperature. The temperaturemonitoring device shall have a margin of error less than the greater of +/- 0.75percent of the temperature being measured or +/- 2.5 degrees Celsius (4.5 degreesFahrenheit).

The Permittee shall maintain a hard copy readout or computer disk file of thetemperature readings for the RTO combustion chamber including the calculated3-hour rolling average temperature values. The Permittee shall verify once eachshift, not to exceed 12 hours, if all observed 3-hour rolling average temperaturereadings were at or above the minimum specified in this permit. Recorded valuesbelow the minimum specified in this permit are considered deviations as defined byMinn. R. 7007.0100, subp. 8a.

24.0

CD 40 CFR Section 64.3; Minn. R.7017.0200

Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of CE 026. The CE026 burner may be inspected annually. The Permittee shall maintain a writtenrecord of the results of each inspection.

25.0




8 Jul, 2013 08:31Page 19 of 42

CD 40 CFR Section 64.7(d); Minn. R.7017.0200


- the 3-hour rolling average combustion chamber temperature is below the requiredminimum;- the RTO or any of its components are found during any inspection to need repair.

Corrective actions shall return the combustion chamber temperature to at or abovethe required minimum, and/or include completion of necessary repairs identifiedduring the inspection, as applicable. Corrective actions include, but are not limitedto, those outlined in the O & M Plan for CE 026. The Permittee shall keep a recordof the type and date of any corrective action taken.

26.0


The Permittee shall calibrate or replace the CE 026 temperature gauge at leastonce every 12 months and shall maintain a written record of any action resultingfrom the calibration or replacement.

27.0

CD 40 CFR Section 64.7(e); Minn. R.7017.0200

Documentation of Need for Improved Monitoring: If the Permittee fails to achievecompliance with an emission limitation or standard for which the monitoring did notprovide an indication of an excursion or exceedance while providing valid data, orthe results of compliance or performance testing document a need to modify theexisting required minimum CE 026 combustion chamber temperature, thePermittee shall promptly notify the MPCA and, if necessary, submit a permitamendment application to address the necessary monitoring change.

28.0

CD 40 CFR Section 64.9(a)(2); Minn.R. 7017.0200




29.0



30.0


S/A Minn. R. 7017.2020, subp. 1 Initial Performance Test: due 180 days after Initial Startup of CE 026/EU 087(regenerative thermal oxidizer) to measure PM2.5 emissions.

32.0

S/A Minn. R. 7017.2020, subp. 1 Initial Performance Test: due 180 days after Initial Startup of CE 026/EU 087(regenerative thermal oxidizer) to measure PM emissions (including condensables).

33.0

S/A Minn. R. 7007.0800, subp. 2 Notification of the Actual Date of Initial Startup: due 15 days after Initial Startup ofCE 026/EU 087 or 15 days after permit issuance, whichever is later. Thenotification shall specify the date that fuel was first combusted by CE 026/EU 087.

34.0

S/A Minn. R. 7017.2020, subp. 1 Testing Frequency Plan: due 60 days after Initial Performance Test for PM andPM2.5 emissions. The plan shall specify a testing frequency based on the initialperformance test results for PM and PM2.5 and MPCA guidance. Futureperformance tests at 12-month, 36-month, or 60-month intervals, or as applicable,shall be required upon written approval of the test frequency plan.

35.0

S/A Minn. R. 7017.2020, subp. 1 Initial Performance Test: due 180 days after Initial Startup of EU 088 to measurePM emissions.

36.0

S/A Minn. R. 7017.2020, subp. 1 Initial Performance Test: due 180 days after Initial Startup of EU 088 to measurePM10 emissions.

37.0

S/A Minn. R. 7017.2020, subp. 1 Initial Performance Test: due 180 days after Initial Startup of EU 088 to measurePM2.5 emissions.

38.0

S/A Minn. R. 7017.2020, subp. 1 Initial Performance Test: due 180 days after Initial Startup of EU 088 to measureVOC emissions.

39.0




8 Jul, 2013 08:31Page 20 of 42

S/A Minn. R. 7017.2020, subp. 1 Testing Frequency Plan: due 60 days after Initial Performance Test for PM, PM10,PM2.5 and VOC emissions. The plan shall specify a testing frequency based on theinitial performance test results for PM, PM10, PM2.5 and VOC and MPCAguidance. Future performance tests at 12-, 36-, or 60-month intervals, or asapplicable, shall be required upon written approval of the test frequency plan.

40.0




8 Jul, 2013 08:31Page 21 of 42

Subject Item: SV 059 Crax Room Air Stack (CE 029 & CE 030)



NC/CA



LIMIT Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000; meets requirements ofMinn. R. 7011.0715, subp. 1(A)

Total Particulate Matter: less than or equal to 2.68 lbs/hour2.0

LIMIT Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000

PM < 10 micron: less than or equal to 2.68 lbs/hour3.0

LIMIT Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000

PM < 2.5 micron: less than or equal to 2.68 lbs/hour4.0

LIMIT Minn. R. 7011.0715, subp. 1(B) Opacity: less than or equal to 20 percent opacity5.0

CD hdr OPERATING REQUIREMENTS FOR CE 029 AND CE 0306.0

CD Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14

The Permittee shall operate and maintain the venturi scrubber (CE 029) andpacked gas adsorption column (CE 030) at all times that EU 089 is in operation.The Permittee shall document periods of non-operation of the control equipment.

Vent all emissions from EU 089 through CE 029 and CE 030.

7.0

CD Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14

The Permittee shall operate and maintain the packed gas adsorption column (CE030) at all times that EU 090 is in operation. The Permittee shall document periodsof non-operation of the control equipment.


8.0

CD hdr CONTROL EQUIPMENT REQUIREMENTS FOR CE 029 AND CE 0309.0

LIMIT Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14


10.0

LIMIT Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and MInn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14


11.0



12.0



13.0

CD Minn. R. 7007.0800, subp. 14 The Permittee shall operate and maintain CE 029 and CE 030 in accordance withthe Operation and Maintenance (O&M) Plan. The Permittee shall keep copies ofthe O&M Plan available onsite for use by staff and MPCA staff.

14.0




8 Jul, 2013 08:31Page 22 of 42



15.0



16.0



17.0



18.0

CD hdr MONITORING AND RECORDKEEPING FOR CE 029 AND CE 03019.0



20.0

CD Title I Condition: To avoid majorsource classification under 40CFR Section 52.21 and Minn. R.7007.3000; 40 CFR Section 64.3;Minn. R. 7017.0200; Minn. R.7007.0800, subps. 2 and 14



21.0


Daily Inspections: Once each calendar day when either EU 089 or EU 090 isoperating, the Permittee shall read and record the following:


22.0


Recordkeeping of Pressure Drop and Water Flow Rate for CE 029 and CE 030:The Permittee shall record the time and date of each pressure drop reading andwater flow rate reading, and whether or not the observed value was within therange specified in this permit. Recorded values outside the range specified in thispermit are considered deviations as defined by Minn. R. 7007.0100, subp. 8a.

23.0


Periodic Inspections: Once per calendar quarter, or at a frequency prescribed bythe manufacturer, the Permittee shall inspect the components of CE 029 and CE030. The Permittee shall maintain a written record of the results of each inspection.

24.0



1) The pressure drop is below the required minimum;2) The water flow rate is below the permitted minimum; or3) The scrubber or any of its components are found during any inspection to needrepair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O&M Plan for CE 029 and CE030. The Permittee shall keep a record of the type and date of any corrective actiontaken.

25.0




8 Jul, 2013 08:31Page 23 of 42


The Permittee shall calibrate or replace the CE 029 and CE 030 pressure drop andflow rate monitors at least annually and shall maintain a written record of any actionresulting from the calibration or replacement.

26.0



27.0


As required by 40 CFR Section 64.9(a)(2), for the Semiannual Deviations Reportlisted in Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permittee shall include the following related to the monitoringidentifiedas required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable, and the corrective action taken; and2) Summary information on the number, duration, and cause for monitor downtimeincidents.

28.0



29.0

CD hdr NOTIFICATION REQUIREMENTS(See Table B)

30.0

S/A Minn. R. 7007.0800, subp. 2 Notification of the Date Construction Began: due 30 days after Start OfConstruction of EU 089 and EU 090.

31.0

S/A Minn. R. 7007.0800, subp. 2 Notification of the Actual Date of Initial Startup: due 15 days after Initial Startup ofEU 089 and EU 090.

32.0




8 Jul, 2013 08:31Page 24 of 42

Subject Item: EU 027 Rendering Room Air



NC/CA



LIMIT Title I Condition: To limit potentialPM emissions to less than majorsource levels as defined by 40CFR 52.21; Minn. R. 7007.3000;meets requirements of Minn. R.7011.0715, subp. 1(A)


LIMIT Title I Condition: To limit potentialPM10 emissions to less thanmajor source levels as defined by40 CFR 52.21; Minn. R.7007.3000

Particulate Matter < 10 micron: less than or equal to 8.38 lbs/hour3.0




The Permittee shall operate and maintain the packed tower A (CE 008) at all timesthat the process equipment (EU 028 rendering machinery that emits EU 027rendering room air emissions) controlled by CE 008 is in operation. The Permitteeshall document periods of non-operation of the control equipment.


6.0

CD hdr CE 008 (TOWER A) CONTROL EQUIPMENT REQUIREMENTS7.0



8.0



9.0


10.0


CE 008 Pressure Differential: Greater than or equal to 5 inches w.c., unless a newminimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.

11.0


CE 008 Water Flow Rate: Greater than or equal to 100 gallons per minute, unless anew minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.

12.0




14.0




8 Jul, 2013 08:31Page 25 of 42

CD Title I Condition: To avoidclassification as a major sourceand modification under 40 CFRSection 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14; 40 CFR Section64.3; Minn. R. 7017.0200



15.0


Recordkeeping of Pressure Drop and Water Flow Rate: The Permittee shall recordthe time and date of each pressure drop reading and water flow rate reading, andwhether or not the observed value was within the range specified in this permit.Recorded values outside the range specified in this permit are considereddeviations as defined by Minn. R. 7007.0100, subp. 8a.

16.0



17.0



- the pressure drop is below the required minimum;- the water flow rate is below the permitted minimum; or- the scrubber or any of its components are found during any inspection to needrepair.


18.0



19.0



20.0





21.0



22.0

CD hdr SHUTDOWN REQUIREMENTS23.0

S/A Minn. R. 7007.0800, subp. 2 Shutdown: due 180 days after Initial Startup of EU 088. The conditions in the permitapplicable to EU 027 and associated items remains effective until permanentshutdown of EU 027 occurs.

24.0

S/A Minn. R. 7007.0800, subp. 2 Notification: due 30 days after Shutdown of EU 027. Notification shall bepostmarked within 30 days of actual shutdown.

25.0




8 Jul, 2013 08:31Page 26 of 42

Subject Item: EU 028 Rendering Machinery







SV 027 Rendering Cooker Stack


NC/CA


CD hdr Subject Item EU 028 contains requirements applicable either:



Prior to CE 026 startup, EU 028 emissions will vent to CE 009, CE 022, and CE023 and then either vented to the atmosphere through SV 027, or routed to CE 008and then vented to the atmosphere through SV 026.

After CE 026 startup, EU 028 emissions will be vented to CE 009 and then to CE026 and then to the atmosphere through SV 058, and CE 022 and CE 023 will beshutdown.

1.0

CD hdr EMISSION LIMITS - APPLY BEFORE AND AFTER CE 026 STARTUP


2.0

LIMIT Minn. R. 7011.0715, subp. 1(A) Total Particulate Matter: less than or equal to 0.30 grains/dry standard cubic foot ofexhaust gas unless required to further reduce emissions to comply with the lessstringent limit of either Minn. R. 7011.0730 or Minn. R. 7011.0735.


3.0

LIMIT Minn. R. 7011.0715, subp. 1(B) Opacity: less than or equal to 20 percent opacity .


4.0

CD hdr OPERATING REQUIREMENTS - APPLY AFTER CE 026 STARTUP5.0


The Permittee shall operate and maintain the venturi scrubber (CE 009) at all timesthat the process equipment (EU 028 rendering machinery) controlled by CE 009 isin operation. The Permittee shall document periods of non-operation of the controlequipment.

Vent all emissions from Rendering Machinery through CE 009, CE 026 (RTO), andthen through SV 058. After CE 026 startup, the Permittee shall not route EU 028emissions through CE 022 and CE 023.

6.0

CD hdr CONTROL EQUIPMENT REQUIREMENTS - APPLY AFTER CE 026 STARTUP

Refer to SV 058 for CE 026 applicable requirements

7.0



8.0




8 Jul, 2013 08:31Page 27 of 42



9.0

CD Minn. R. 7007.0800, subps. 2 and14


10.0


CE 009 Pressure Differential: Greater than or equal to 5 inches w.c.11.0


CE 009 Water Flow Rate: Greater than or equal to 50 gallons per minute.12.0

CD hdr MONITORING AND RECORDKEEPING - APPLY AFTER CE 026 STARTUP13.0



14.0

CD Title I Condition: To avoidclassification as a major sourceand modification under 40 CFRSection 52.21 and Minn. R.7007.3000; Minn. R. 7007.0800,subps. 2 and 14; 40 CFR Section64.3; Minn. R. 7017.0200



15.0


Recordkeeping of CE 009 Pressure Drop and Water Flow Rate: The Permitteeshall record the time and date of each pressure drop reading and water flow ratereading, and whether or not the observed value was within the range specified inthis permit. Recorded values outside the range specified in this permit areconsidered deviations as defined by Minn. R. 7007.0100, subp. 8a.

16.0



17.0



- the CE 009 pressure drop is below the required minimum;- the CE 009 water flow rate is below the permitted minimum; or- CE 009 or any of its components are found during any inspection to need repair.


18.0



19.0



20.0




8 Jul, 2013 08:31Page 28 of 42





21.0



22.0

CD hdr EMISSION LIMITS - APPLY ONLY BEFORE CE 026 STARTUP23.0

LIMIT Title I Condition: To limit potentialPM emissions to less than majorsource levels as defined by 40CFR 52.21; Minn. R. 7007.3000;meets requirements of Minn. R.7011.0715, subp. 1(A)

Total Particulate Matter: less than or equal to 7.34 lbs/hour for SV 027. This limitapplies when EU 028 emissions are controlled by CE 009 (venturi scrubber), CE022 (Tower B), and CE 023 (Tower C) and vented through SV 027 (renderingprocess equipment bypass stack). See EU 027 for applicable limit when EU 028emissions are controlled by CE 009 & CE 008 (Tower A) and vented through SV026 (main stack).

24.0

LIMIT Title I Condition: To limit potentialPM emissions to less than majorsource levels as defined by 40CFR 52.21; Minn. R. 7007.3000

PM < 10 micron: less than or equal to 7.34 lbs/hour for SV 027. This limit applieswhen EU 028 emissions are controlled by CE 009 (venturi scrubber), CE 022(Tower B), and CE 023 (Tower C) and vented through SV 027 (rendering processequipment bypass stack). See EU 027 for applicable limit when EU 028 emissionsare controlled by CE 009 & CE 008 (Tower A) and vented through SV 026 (mainstack).

25.0

CD hdr OPERATING REQUIREMENTS - APPLY ONLY BEFORE CE 026 STARTUP26.0

CD Minn. R. 7007.0800, subp. 2 Vent all emissions from Rendering Machinery through CE 009 (venturi scrubber),and then CE 022 (Tower B) and CE 023 (Tower C). After CE 023 the Permittee hasthe option of routing emissions to CE 008 (Tower A) and then through SV 026, orbypass CE 008 and vent from CE 023 through SV 027.

27.0

CD hdr CE 009 (VENTURI SCRUBBER), CE 022 (TOWER B), AND CE 023 (TOWER C)CONTROL EQUIPMENT REQUIREMENTS - APPLY BEFORE CE 026 STARTUP

28.0



29.0



30.0



31.0



32.0

CD Minn. R. 7007.0800, subp. 14 The Permittee shall operate and maintain CE 009, CE 022, and CE 023 inaccordance with the Operation and Maintenance (O & M) Plan. The Permittee shallkeep copies of the O & M Plan available onsite for use by staff and MPCA staff.

33.0




8 Jul, 2013 08:31Page 29 of 42

CD Minn. R. 7007.0800, subp. 4 Monitoring Equipment: The Permittee shall maintain the necessary monitoringequipment for measuring and recording pressure drop and water flow rate asrequired by this permit. The monitoring equipment must be installed, in use, andproperly maintained when CE 009, CE 022, and CE 023 are in operation.

34.0

CD Minn. R. 7007.0800, subp. 14 CE 009, CE 022, and CE 023 Pressure Differential: Less than 5 inches wc for CE022, less than 5 inches wc for CE 023, and not less than 5 inches wc for CE 009.

35.0

CD Minn. R. 7007.0800, subp. 14 CE 009, CE 022, and CE 023 Water Flow Rate: Not less than 20 gallons perminute for CE 022, not less than 30 gallons per minute for CE 023, and not lessthan 50 gallons per minute for CE 009.

36.0

CD Minn. R. 7007.0800, subp. 4 and 5 CE 009, CE 022, and CE 023 Daily Monitoring: Once each day of operation, thePermittee shall monitor and record the pressure differential and water flow rate forCE 009, CE 022, and CE 023.

37.0

CD Minn. R. 7007.0800, subp. 4, 5,and 14


38.0

CD Minn. R. 7007.0800, subp. 4, 5,and 14




39.0

CD hdr SHUTDOWN REQUIREMENTS40.0

S/A Minn. R. 7007.0800, subp. 2 Shutdown: due 180 days after Initial Startup of EU 088. The conditions in the permitapplicable to EU 028 and associated items remains effective until permanentshutdown of EU 028 occurs.

41.0

S/A Minn. R. 7007.0800, subp. 2 Notification: due 30 days after Shutdown of EU 028. Notification shall bepostmarked within 30 days of actual shutdown.

42.0




8 Jul, 2013 08:31Page 30 of 42

Subject Item: EU 051 Emergency RICE(s)

Associated Items: GP 001 SO2 and NOx Limits

SV 044 Emergency RICE(s) (EU 051)

NC/CA


CD hdr LIMITS AND OPERATING REQUIREMENTS1.0

LIMIT Minn. R. 7007.0800, subp. 2 andSeptember 6, 1995, U.S. EPAmemorandum entitled "CalculatingPotential to Emit for EmergencyGenerators"

Operating Hours: less than or equal to 500 hours/year using 12-month Rolling Sumas a total for all emergency RICE.

2.0

LIMIT Minn. R. 7011.2300, subp. 2 Sulfur Dioxide: less than or equal to 0.5 lbs/million Btu heat input3.0

LIMIT Minn. R. 7011.2300, subp. 1 Opacity: less than or equal to 20 percent opacity once operating temperatures havebeen attained.

4.0

CD Minn. R. 7007.0800, subp. 2 Emergency Reciprocating Internal Combustion Engine (RICE) Operation: ThePermittee is authorized to operate temporary or permanent emergency RICE at thefacility, providing the total horsepower of all emergency RICE does not exceed 599hp on a calendar-day basis, and any single engine does not exceed 500 hp.

5.0

CD Minn. R. 7007.0800, subp. 2 Permitted Fuels: gasoline, diesel fuel, natural gas, kerosene/naphtha, butane,liquified petroleum gases (LPG), or propane.

6.0

CD Minn. R. 7007.0800, subp. 2 Operation of Emergency RICE(s): The EU 051 Emergency RICE(s) shall onlyoperate under emergency situations. An emergency RICE is a reciprocatinginternal combustion engine which only operates when no other mechanical powersource is available to meet life safety and temporary production requirements, andoperates for necessary routine periodic equipment testing. Life safety andtemporary production requirements do not occur during routine operation orproduction and are circumstances demanding power to avoid death, illness, injury,or damage to process equipment or product.

An emergency RICE is a power source used to generate electricity, pump water orother liquids, or other application. Emergency RICE does not include RICE electricgenerators operated by an electric customer during periods of intentional electricservice disruption by the electric service provider or a RICE used as a substitute foranother power source that is undergoing scheduled maintenance.

7.0


CD Minn. R. 7007.0800, subp. 4 and 5 Recordkeeping: For each emergency RICE that is operated at the facility, thePermittee shall record the arrival and departure date of the engine.

Once each day, the Permittee shall record in a log the serial number, model,manufacturer, horsepower rating and hours of operation of each emergency RICEthat operated at the facility during the previous calendar day. If no emergencyRICE were operated, the log shall indicate this.

By the 15th day of each month, the Permittee shall calculate and record the totalemergency RICE operating hours for the previous month, and the previous12-month period.

9.0

CD Minn. R. 7007.0800, subp. 4 and 5 Diesel Fuel Supplier Certification: For each delivery of diesel fuel, the Permitteeshall obtain a supplier certification that either states the actual sulfur content inpercent by weight in the diesel fuel, or guarantees that the sulfur content does notexceed 0.0015 percent by weight.

10.0

CD Title I Condition: To limit potentialNOx emissions to less than majorsource levels defined by 40 CFRSection 52.21; Minn. R.7007.3000; Minn. R. 7007.0800,subp. 4 and 5

Recordkeeping - Fuel Usage: Once each day calculate and record the EU 051usage of gasoline (gallons), diesel fuel (gallons), natural gas (cubic feet),kerosene/naphtha (gallons), butane (gallons), liquified petroleum gases (LPG)(gallons), or propane (gallons) during the previous calendar day.

By the 15th day of each month, calculate and record the EU 051 usage of gasoline(gallons), diesel fuel (gallons), natural gas (cubic feet), kerosene/naphtha (gallons),butane (gallons), liquified petroleum gases (LPG) (gallons), or propane (gallons)during the previous calendar month. The Permittee shall convert and record themonthly fuel usage from a volume basis, to a heat input basis according to theprocedure in the appendix.

11.0




8 Jul, 2013 08:31Page 31 of 42

CD Minn. R. 7007.0800, subp. 4 and 5 Nitrogen Oxides Emissions Monitoring: By the 15th day of each month thePermittee shall:

1) Calculate and record EU 051 NOx emissions during the previous calendarmonth using the following equation:

NOx = (Fa * Ha) + (Fb * Hb) + (Fc * Hc) + (Fd * Hd) + (Fe * He) + (Ff * Hf)

(continued)

12.0

CD Minn. R. 7007.0800, subp. 4 and 5 where:NOx = EU 051 pounds NOx/monthFa = diesel fuel emission factorHa = diesel fuel heat inputFb = natural gas emission factorHb = natural gas heat inputFc = gasoline emission factorHc = gasoline heat inputFd = propane/liquified petroleum gases (LPG) emission factorHd = propane/liquified petroleum gases (LPG) heat inputFe = kerosene/naphtha emission factorHe = kerosene/naphtha heat inputFf = butane emission factorHf = butane heat input

All heat inputs are in units of mmBtu per month and determined according to theprocedure in the appendix. Emission factors (lb/mmBtu) are listed in the appendix,or obtained from the current version of AP-42 or the current MPCA emissioncalculation form for internal combustion engines, if more current than the appendix.

13.0




8 Jul, 2013 08:31Page 32 of 42

Subject Item: EU 087 Regenerative Thermal Oxidizer (CE 026)

Associated Items: SV 058 Regenerative Thermal Oxidizer (CE 026)

NC/CA


LIMIT Minn. R. 7011.0610, subp. 1(A)(1) Total Particulate Matter: less than or equal to 0.30 grains/dry standard cubic foot ofexhaust gas unless required to further reduce emissions to comply with the lessstringent limit of either Minn. R. 7011.0730 or Minn. R. 7011.0735.

1.0

LIMIT Minn. R. 7011.0610, subp. 1(A)(2) Opacity: less than or equal to 20 percent opacity except for one six-minute periodper hour of not more than 60 percent opacity.

2.0

CD Minn. R. 7007.0800, subp. 2 Permitted fuel: natural gas only. Combustion of only natural gas ensurescompliance with Minn. R. 7011.0715, subp. 1.A.

3.0




8 Jul, 2013 08:31Page 33 of 42

Subject Item: EU 088 Refined Products Machinery

Associated Items: CE 026 Thermal Oxidizer




NC/CA



LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; meetsrequirements of Minn. R.7011.0715, subp. 1(A)







Volatile Organic Compounds: less than or equal to 0.97 lbs/hour5.0



CD Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; Minn. R.7007.0800, subps. 2 and 14

The Permittee shall operate and maintain the venturi scrubber (CE 027), thepacked-gas adsorption column (CE 028), and the RTO (CE 026) at all times thatEU 088 is in operation. The Permittee shall document periods of non-operation ofthe control equipment.

Vent all emissions from Rendering Machinery through CE 027, CE 028, CE 026(RTO), and then through SV 058.

8.0

CD hdr CONTROL EQUIPMENT REQUIREMENTS(See SV 058 for CE 026 Requirements)

9.0

LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21andMinn. R. 7007.3000; Minn. R.7007.0800, subps. 2 and 14

The Permittee shall operate and maintain CE 027 so it achieves a total controlefficeincy for Total Particulate Matter: greater than or equal to 94 percent controlefficiency

10.0

LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; Minn. R.7007.0800, subps. 2 and 14

The Permittee shall operate and maintain CE 027 so it achieves a total controlefficency for PM < 10 micron: greater than or equal to 84 percent control efficiency

11.0



12.0



13.0




8 Jul, 2013 08:31Page 34 of 42



14.0



15.0



16.0



17.0



18.0



19.0




21.0

CD Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; 40 CFRSection 64.3; Minn. R. 7017.0200;Minn. R. 7007.0800, subps. 2 and14


1) Pressure drop for CE 027 and CE 028 in inches of water column;2) Water flow rate for CE 027 and CE 028 in gallons per minute.

22.0


Pressure Drop and Water Flow Rate Recordkeeping for CE 027 and CE 028: ThePermittee shall record the time and date of each pressure drop reading and waterflow rate reading, and whether or not the observed value was within the rangespecified in this permit. Recorded values outside the range specified in this permitare considered deviations as defined by Minn. R. 7007.0100, subp. 8a.

23.0


Periodic Inspections: Once per calendar quarter, or at a frequency predescribed bythe manufacturer, the Permittee shall inspect the components of CE 027 and CE028. The Permittee shall maintain a written record of the results of each inspection.

24.0




8 Jul, 2013 08:31Page 35 of 42


Corrective Actions: The Permittee shall take corrective actions as soon as possibleif any of the following occur:

1) The CE 027 or CE 028 pressure drop is below the required minimum;2) The CE 027 or CE 028 water flow rate is below the permitted minimum; or3) CE 027 or CE 028 or any of their components are found during any inspection inneed of repair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O&M Plan for CE 027 and CE028. The Permittee shall keep a record of the type and date of any correctiveactions taken.

25.0


The Permittee shall calibrate or replace the CE 027 and CE 028 pressure drop andwater flow rate monitors at least annually and shall maintain a written record of anyaction resulting from the calibration or replacement.

26.0


Documentation of Need for Improved Monitoring: If the Permittee fails to achievecompliance with an emission limitation or standard for which the monitoring did notprovide an indication of an excursion or exceedance while providing valid data, orthe results of compliance or performance testing document a need to modify theexisting pressure drop range, the Permitte shall promptly notify the MPCA and, ifnecessary, submit a permit amendment application to address the necessarymonitoring change.

27.0


As required by 40 CFR Section 64.9(a)(2), for the Semiannual Deviations Reportlisted in Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permittee shall include the following related to the monitoringidentified as required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable and the corrective actions taken; and2) Summary information on the number, duration, and cause for monitor downtimeincidents.

28.0



29.0


30.0

S/A Minn. R. 7007.0800, subp. 2 Notification of the Date Construction Began: due 30 days after Start OfConstruction of EU 088.

31.0

S/A Minn. R. 7007.0800, subp. 2 Notification of the Actual Date of Initial Startup: due 15 days after Initial Startup ofEU 088.

32.0




8 Jul, 2013 08:31Page 36 of 42

Subject Item: EU 091 Refined Products Room Air




NC/CA



LIMIT Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; meetsrequirements of Minn. R.7011.0715, subp. 1(A)








CD Title I Condition: To avoidclassification as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; Minn. R.7007.0800, subps. 2 and 14

The Permittee shall operate and maintain the packed-gas adsorption column (CE031) at all times that EU 091 is in operation. The Permittee shall document periodsof non-operation of the control equipment.


7.0

CD hdr CONTROL EQUIPMENT REQUIREMENTS8.0



9.0



10.0



11.0



12.0


Water flow rate: greater than or equal to 1000 gallons/minute for CE 031, unless anew minimum is set pursuant to Minn. R. 7017.2025, subp. 3, based on the valuesrecorded during the most recent MPCA-approved performance test wherecompliance was demonstrated. The new minimum shall be implemented uponreceipt of the Notice of Compliance letter granting preliminary approval. Theminimum is final upon issuance of a permit amendment incorporating the change.

13.0




15.0




8 Jul, 2013 08:31Page 37 of 42



1) Pressure drop for CE 031 in inches of water column;2) Water flow rate for CE 031 in gallons per minute.

16.0

CD Title I Condition: To avoidclassifcation as a major sourceunder 40 CFR Section 52.21 andMinn. R. 7007.3000; 40 CFRSection 64.3; Minn. R. 7017.0200;Minn. R. 7007.0800, subps. 4 and5

Recordkeeping of Pressure Drop and Water Flow Rate for CE 031: The Permitteeshall record the time and date of each pressure drop reading and water flow ratereading, and whether or not the observed value was within the range specified inthis permit. Recorded values outside the range specified in this permit areconsidered deviations as defined by Minn. R. 7007.0100, subp. 8a.

17.0



18.0


Corrective Actions: The Permittee shall take corrective action as soon as possiblein any of the following occur:

1) The CE 031 pressure drop is below the required minimum;2) The CE 031 water flow rate is below the permitted minimum; or3) The scrubber or any of its components are found during any inspection to be inneed of repair.

Corrective actions shall return the pressure drop to within the permitted range, thewater flow rate to at least the required minimum, and/or include completion ofnecessary repairs identified during the inspection, as applicable. Corrective actionsinclude, but are not limited to, those outlined in the O&M Plan for CE 031. ThePermittee shall keep a record of the type and date of any corrective actions taken.

19.0


The Permittee shall calibrate or replace the CE 031 pressure drop and flow ratemonitors at least annually and shall maintain a written record of any action resultingfrom the calibration or replacement.

20.0



21.0


As required by 40 CFR Section 64.9(a)(2), for the Semiannual Deviations Reportlisted iin Table B of this permit and/or the Notification of Deviations EndangeringHuman Health and the Environment listed earlier in Table A of this permit, asapplicable, the Permitte shall include the following related to the monitoringidentified as required by 40 CFR pt. 64:

1) Summary information on the number, duration, and cause of excursions orexceedances, as applicable, and the corrective actions taken; and2) Summary information on the number, duration, and cause for monitor downtimeincidents.

22.0



23.0


24.0


25.0


26.0




8 Jul, 2013 08:31Page 38 of 42




NC/CA



1.0


2.0


3.0




8 Jul, 2013 08:31Page 39 of 42




NC/CA



1.0


2.0


3.0




8 Jul, 2013 08:31Page 40 of 42




NC/CA



1.0


2.0


3.0




8 Jul, 2013 08:31Page 41 of 42

Subject Item: CE 029 Venturi Scrubber


NC/CA


CD hdr See SV 059 for applicable CE 029 requirements.1.0




8 Jul, 2013 08:31Page 42 of 42

Subject Item: CE 030 Packed-Gas Adsorption Column



NC/CA


CD hdr See SV 059 for applicable CE 030 requirements.1.0

Attachment 2:Calculation Spreadsheets

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3a

)3

b) 3

c) C

AS

#:

----

-- C

AS

#:

----

-- C

AS

#:

----

-- 3

d) P

ollu

tant

Nam

e: P

ollu

tant

Nam

e: P

ollu

tant

Nam

e:E

mis

sion

Em

issi

onP

MP

M10

PM

2.5

Sou

rce

Sou

rce

3e)

3f)

Typ

eID

No.

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Pot

entia

lA

ctua

lLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

tpy

tpy

tpy

tpy

tpy

tpy

Boi

ler

1E

U00

11.

667.

267.

26N

A1.

667.

267.

26N

A1.

667.

267.

26N

AB

oile

r 2

EU

002

1.66

7.26

7.26

NA

1.66

7.26

7.26

NA

1.66

7.26

7.26

NA

Boi

ler

3E

U00

31.

667.

267.

26N

A1.

667.

267.

26N

A1.

667.

267.

26N

AB

oile

r 4

EU

004

0.85

3.72

3.72

NA

0.85

3.72

3.72

NA

0.85

3.72

3.72

NA

Boi

ler

5E

U00

50.

053

0.23

0.23

NA

0.05

30.

230.

23N

AN

AN

AN

AN

AO

ven

#6E

U00

60.

011

0.05

0.05

NA

0.01

10.

050.

05N

AN

AN

AN

AN

AO

ven

#7E

U00

70.

011

0.05

0.05

NA

0.01

10.

050.

05N

AN

AN

AN

AN

AO

ven

#8E

U00

80.

011

0.05

0.05

NA

0.01

10.

050.

05N

AN

AN

AN

AN

AO

ven

#9E

U00

90.

011

0.05

0.05

NA

0.01

10.

050.

05N

AN

AN

AN

AN

AO

ven

#10

EU

010

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Ove

n #1

1E

U01

10.

011

0.05

0.05

NA

0.01

10.

050.

05N

AN

AN

AN

AN

AO

ven

#12

EU

012

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Ove

n #1

EU

013

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Ove

n #2

EU

014

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Ove

n #3

EU

015

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Ove

n #4

EU

016

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Ove

n #5

EU

017

0.01

10.

050.

05N

A0.

011

0.05

0.05

NA

NA

NA

NA

NA

Pre

cook

ed B

acon

Sou

thE

U01

81.

978.

638.

63N

A1.

978.

638.

63N

AN

AN

AN

AN

AP

reco

oked

Bac

on N

orth

EU

019

1.97

8.63

8.63

NA

1.97

8.63

8.63

NA

NA

NA

NA

NA

Pre

coo

ked

Ba

con

Ea

s tE

U02

01.

978.

638.

63N

A1.

978.

638.

63N

AN

AN

AN

AN

AP

reco

oke

d B

aco

n W

est

EU

021

1.97

8.63

8.63

NA

1.97

8.63

8.63

NA

NA

NA

NA

NA

Sta

nd-b

y G

ener

ato

rE

U07

80.

020.

110.

01N

A0.

020.

110.

01N

AN

AN

AN

AN

AF

ullo

n H

eate

rE

U02

50.

020.

080.

08N

A0.

020.

080.

08N

AN

AN

AN

AN

AR

end

erin

g R

oo

m A

irE

U0

27

Will

be

rem

oved

Ren

derin

g M

achi

neE

U0

28

Will

be

rem

oved

Cra

x G

rind

EU

028

0.29

12.5

51.

25N

A0.

2912

.55

1.25

NA

NA

NA

NA

NA

Cra

x S

cree

nE

U02

80.

3214

.04

1.40

NA

0.32

14.0

41.

40N

AN

AN

AN

AN

AB

acon

Bits

Pre

cook

ed L

ine

EU

029

6.97

30.5

130

.51

NA

6.97

30.5

130

.51

NA

NA

NA

NA

NA

Hog

Sin

ger

#1E

U03

00.

060.

270.

27N

A0.

060.

270.

27N

AN

AN

AN

AN

AN

atur

al S

mo

ke G

ener

ato

rE

U03

10.

803.

483.

48N

A0.

803.

483.

48N

AN

AN

AN

AN

AN

atur

al S

mo

ke G

ener

ato

rE

U03

20.

803.

483.

48N

A0.

803.

483.

48N

AN

AN

AN

AN

AG

P S

alt S

yste

mE

U03

30.

2296

.36

0.96

NA

0.22

96.3

60.

96N

AN

AN

AN

AN

AM

P S

alt S

yste

mE

U03

40.

2296

.36

0.96

NA

0.22

96.3

60.

96N

AN

AN

AN

AN

AG

P S

ugar

Sys

tem

EU

035

0.22

96.3

60.

96N

A0.

2296

.36

0.96

NA

NA

NA

NA

NA

Bo

ne D

rye r

EU

036

0.21

39.4

20.

90N

A0.

149.

860.

60N

AN

AN

AN

AN

AB

one

Dry

er-C

ombu

stio

nE

U03

60.

070.

300.

30N

A0.

070.

300.

30N

AN

AN

AN

AN

AV

apor

Sm

oke

Gen

#1

EU

037

0.03

1.49

0.15

NA

0.03

1.49

0.15

NA

NA

NA

NA

NA

Vap

or S

mok

e G

en #

2E

U03

80.

031.

490.

15N

A0.

031.

490.

15N

AN

AN

AN

AN

AV

apor

Sm

oke

Gen

#3

EU

039

0.03

1.49

0.15

NA

0.03

1.49

0.15

NA

NA

NA

NA

NA

KC

-9 M

akeu

p A

ir H

eate

rE

U04

00.

040.

190.

19N

A0.

040.

190.

19N

AN

AN

AN

AN

AK

C-7

Mak

eup

Air

Hea

ter

EU

041

0.02

0.07

0.07

NA

0.02

0.07

0.07

NA

NA

NA

NA

NA

Ren

derin

g M

akeu

p A

ir H

t rE

U04

20.

020.

080.

08N

A0.

020.

080.

08N

AN

AN

AN

AN

AR

ende

ring

Mak

eup

Air

Htr

EU

043

0.02

0.08

0.08

NA

0.02

0.08

0.08

NA

NA

NA

NA

NA

Boi

ler

6E

U04

40.

994.

354.

35N

A0.

994.

354.

35N

AN

AN

AN

AN

AB

oile

r 7

EU

045

0.99

4.35

4.35

NA

0.99

4.35

4.35

NA

NA

NA

NA

NA

Blo

od

Dry

er

EU

050

0.05

8.82

0.20

NA

0.05

3.32

0.20

NA

NA

NA

NA

NA

Blo

od D

ryer

-Com

bust

ion

EU

050

0.03

0.12

0.12

NA

0.03

0.12

0.12

NA

NA

NA

NA

NA

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

052

0.03

0.13

0.13

NA

0.03

0.13

0.13

NA

NA

NA

NA

NA

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

053

0.03

0.13

0.13

NA

0.03

0.13

0.13

NA

NA

NA

NA

NA

NG

Spa

ce H

ea

ter

- P

retr

ea

tmen

tE

U05

40.

020.

080.

08N

A0.

020.

080.

08N

AN

AN

AN

AN

AN

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

055

0.02

0.08

0.08

NA

0.02

0.08

0.08

NA

NA

NA

NA

NA

NG

Spa

ce H

eate

r F

ront

End

Kill

EU

056

0.0

20

.11

0.11

NA

0.02

0.11

0.11

NA

NA

NA

NA

NA

NG

Spa

ce H

eate

r F

ront

End

Kill

EU

057

0.0

20

.11

0.11

NA

0.02

0.11

0.11

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

1of

24

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3a

)3

b) 3

c) C

AS

#:

----

-- C

AS

#:

----

-- C

AS

#:

----

-- 3

d) P

ollu

tant

Nam

e: P

ollu

tant

Nam

e: P

ollu

tant

Nam

e:E

mis

sion

Em

issi

onP

MP

M10

PM

2.5

Sou

rce

Sou

rce

3e)

3f)

Typ

eID

No.

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Pot

entia

lA

ctua

lLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

tpy

tpy

tpy

tpy

tpy

tpy

Rad

iant

Wal

l Ove

ns #

2E

U06

70.

020.

100.

10N

A0.

020.

100.

10N

AN

AN

AN

AN

AH

og

Sin

ger

#2E

U06

80.

050.

220.

22N

A0.

050.

220.

22N

AN

AN

AN

AN

AO

ld B

oile

r R

oom

MA

UE

U06

90.

040.

190.

19N

A0.

040.

190.

19N

AN

AN

AN

AN

ALa

rd D

eodo

rizer

Coo

ling

Tow

erE

U07

02.

139.

349.

34N

A2.

028.

838.

83N

AN

AN

AN

AN

AG

ener

ator

#1

EU

080

0.30

1.31

0.16

NA

0.30

1.31

0.16

NA

NA

NA

NA

NA

Gen

erat

or #

2E

U08

10.

301.

310.

16N

A0.

301.

310.

16N

AN

AN

AN

AN

AG

ener

ator

#3

EU

082

0.30

1.31

0.16

NA

0.30

1.31

0.16

NA

NA

NA

NA

NA

Gen

erat

or #

4E

U08

30.

301.

310.

16N

A0.

301.

310.

16N

AN

AN

AN

AN

AG

ener

ator

#5

EU

084

0.30

1.31

0.16

NA

0.30

1.31

0.16

NA

NA

NA

NA

NA

Gen

erat

or #

6E

U08

50.

301.

310.

16N

A0.

301.

310.

16N

AN

AN

AN

AN

AG

ener

ator

#7

EU

086

0.30

1.31

0.16

NA

0.30

1.31

0.16

NA

NA

NA

NA

NA

RT

O C

ombu

stio

nE

U08

70.

060.

260.

26N

A0.

060.

260.

26N

A0.

060.

260.

26N

AR

efin

ed P

rodu

cts

Mac

hine

r yE

U08

80.

971,

242

4.25

NA

0.97

437

4.25

NA

0.97

11.1

84.

25N

AC

rax

Ro

om

Ai r

EU

089

2.01

979

8.81

NA

2.01

344

8.81

NA

2.01

8.81

8.81

NA

Tru

ck L

oa

do

ut R

oo

m A

i rE

U09

00.

6719

.58

2.94

NA

0.67

18.3

52.

94N

A0.

672.

942.

94N

AR

efin

ed

Pro

duc

ts R

oom

Air

EU

091

8.38

245

36.7

1N

A8.

3822

936

.71

NA

8.38

36.7

136

.71

NA

Ref

ined

Pro

duct

s M

AU

1E

U09

20.

040.

160.

16N

A0.

040.

160.

16N

A0.

040.

160.

16N

AR

efin

ed P

rodu

cts

MA

U 2

EU

093

0.04

0.16

0.16

NA

0.04

0.16

0.16

NA

0.04

0.16

0.16

NA

Ref

ined

Pro

duct

s M

AU

3E

U09

40.

020.

080.

08N

A0.

020.

080.

08N

A0.

020.

080.

08N

AA

ir H

andl

ing

Uni

t - In

sign

ifica

nt

Act

iviti

esIA

s0.

010.

040.

04N

A0.

010.

040.

04N

A0.

010.

040.

04N

A

4)A

ctua

lA

ctua

lA

ctua

lT

otal

Fac

ility

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

2982

.28

180.

29N

A14

90.0

717

9.48

NA

85.8

278

.89

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

2of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

C

AS

#:74

46-0

9-5

3c)

CA

S#

: --

----

CA

S#

:--

----

Pol

luta

nt N

ame:

3d)

Pol

luta

nt N

ame:

Pol

luta

nt N

ame:

SO

2N

Ox

VO

C

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

1.06

4.65

235.

00N

A12

.45

54.5

418

0.00

NA

0.26

1.16

1.16

NA

1.06

4.65

GP

01 li

mit

NA

12.4

554

.54

GP

01 li

mit

NA

0.26

1.16

1.18

NA

1.06

4.65

GP

01 li

mit

NA

12.4

554

.54

GP

01 li

mit

NA

0.26

1.16

1.18

NA

0.54

2.38

GP

01 li

mit

NA

6.38

27.9

4G

P01

lim

itN

A0.

140.

590.

60N

A0.

004

0.02

GP

01 li

mi t

NA

0.70

03.

07G

P01

lim

itN

A0.

039

0.17

0.17

NA

0.00

10.

000.

00N

A0.

150

0.66

0.66

NA

0.00

20.

010.

01N

A0.

001

0.00

0.00

NA

0.15

00.

660.

66N

A0.

002

0.01

0.01

NA

0.00

10.

000.

00N

A0.

150

0.66

0.66

NA

0.00

20.

010.

01N

A0.

001

0.00

0.00

NA

0.15

00.

660.

66N

A0.

002

0.01

0.01

NA

0.00

10.

000.

00N

A0.

150

0.66

0.66

NA

0.00

20.

010.

01N

A0.

001

0.00

0.00

NA

0.15

00.

660.

66N

A0.

002

0.01

0.01

NA

0.00

10.

000.

00N

A0.

150

0.66

0.66

NA

0.00

20.

010.

01N

A0.

001

0.00

0.00

NA

0.15

00.

660.

66N

A0.

002

0.01

0.01

NA

0.00

10.

000.

00N

A0.

150

0.66

0.66

NA

0.00

20.

010.

01N

A0.

001

0.00

0.00

NA

0.15

00.

660.

66N

A0.

002

0.01

0.01

NA

0.00

10.

000.

00N

A0.

150

0.66

0.66

NA

0.00

20.

010.

01N

A0.

001

0.00

0.00

NA

0.15

00.

660.

66N

A0.

002

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.08

0.37

0.37

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.08

0.37

0.37

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.08

0.37

0.37

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.08

0.37

0.37

NA

0.00

0.00

0.00

NA

2.92

12.7

80.

73N

A0.

040.

170.

01N

A0.

000.

010.

01N

A0.

230.

990.

99N

A0.

010.

050.

05N

A

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.30

1.30

1.30

NA

0.00

0.02

0.02

NA

0.80

3.50

3.50

NA

0.04

0.19

0.19

NA

NA

NA

NA

NA

0.02

0.09

0.09

NA

0.66

2.89

2.89

NA

NA

NA

NA

NA

0.02

0.09

0.09

NA

0.66

2.89

2.89

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

0.01

0.02

0.02

NA

0.90

3.94

3.94

NA

0.05

0.22

0.22

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.03

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.03

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.03

NA

0.00

0.01

0.01

NA

0.56

2.46

2.46

NA

0.03

0.13

0.13

NA

0.00

0.01

0.01

NA

0.22

0.95

0.95

NA

0.02

0.08

0.08

NA

0.00

0.01

0.01

NA

0.25

1.08

1.08

NA

0.01

0.04

0.04

NA

0.00

0.01

0.01

NA

0.25

1.08

1.08

NA

0.01

0.04

0.04

NA

0.99

4.35

GP

01 li

mi t

NA

0.64

2.82

GP

01 li

mit

NA

0.16

0.70

0.70

NA

0.99

4.35

GP

01 li

mi t

NA

0.64

2.82

GP

01 li

mit

NA

0.16

0.70

0.70

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

0.35

1.53

1.53

NA

0.02

0.02

0.08

NA

0.00

0.01

0.01

NA

0.40

1.75

1.75

NA

0.06

0.26

0.26

NA

0.00

0.01

0.01

NA

0.40

1.75

1.75

NA

0.06

0.26

0.26

NA

0.00

0.01

0.01

NA

0.23

1.01

1.01

NA

0.01

0.06

0.06

NA

0.00

0.01

0.01

NA

0.23

1.01

1.01

NA

0.01

0.06

0.06

NA

0.00

0.01

0.01

NA

0.33

1.43

1.43

NA

0.02

0.08

0.08

NA

0.00

0.01

0.01

NA

0.33

1.43

1.43

NA

0.02

0.08

0.08

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

3of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

C

AS

#:74

46-0

9-5

3c)

CA

S#

: --

----

CA

S#

:--

----

Pol

luta

nt N

ame:

3d)

Pol

luta

nt N

ame:

Pol

luta

nt N

ame:

SO

2N

Ox

VO

C

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

0.00

0.01

0.01

NA

0.30

1.31

1.31

NA

0.02

0.07

0.07

NA

0.00

0.02

0.02

NA

0.65

2.85

2.85

NA

0.04

0.16

0.16

NA

0.00

0.01

0.01

NA

0.56

2.46

2.46

NA

0.03

0.14

0.14

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mi t

NA

1.62

7.11

0.85

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mit

NA

1.62

7.11

0.85

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mit

NA

1.62

7.11

0.85

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mit

NA

1.62

7.11

0.85

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mit

NA

1.62

7.11

0.85

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mit

NA

1.62

7.11

0.85

NA

0.91

3.99

0.48

NA

48.9

221

4.27

GP

01 li

mit

NA

1.62

7.11

0.85

NA

0.00

0.02

0.02

NA

0.78

3.44

3.44

NA

0.04

0.19

0.19

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.97

141.

594.

25N

AN

AN

AN

AN

AN

AN

AN

AN

A2.

018.

818.

81N

AN

AN

AN

AN

AN

AN

AN

AN

A0.

672.

942.

94N

AN

AN

AN

AN

AN

AN

AN

AN

A8.

3836

.71

36.7

1N

A2.

88E

-03

1.26

E-0

21.

26E

-02

NA

0.48

2.10

2.10

NA

0.03

0.12

0.12

NA

2.88

E-0

31.

26E

-02

1.26

E-0

2N

A0.

482.

102.

10N

A0.

030.

120.

12N

A1.

44E

-03

6.31

E-0

36.

31E

-03

NA

0.24

1.05

1.05

NA

0.01

0.06

0.06

NA

6.77

E-0

42.

97E

-03

2.97

E-0

3N

A0.

110.

490.

49N

A0.

010.

030.

03N

A

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

1760

.75

228.

53N

A25

6.90

75.6

653

.25

238.

64N

AN

A

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

4of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

C

AS

#:63

0-08

-0 3

c) C

AS

#:

7439

-92-

1 3

c) C

AS

#:

----

-- P

ollu

tant

Nam

e:3d

) P

ollu

tant

Nam

e:3d

) P

ollu

tant

Nam

e:C

OLe

adC

O2e

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

4.04

17.6

717

.67

NA

4.08

E-0

31.

79E

-02

1.79

E-0

2N

A7.

68E

+03

3.3

6E+

049.

47E

+04

NA

4.04

17.6

717

.67

NA

4.08

E-0

31.

79E

-02

1.79

E-0

2N

A7.

68E

+03

3.36

E+

04T

otal

Fac

ility

Lim

itN

A4.

0417

.67

17.6

7N

A4.

08E

-03

1.79

E-0

21.

79E

-02

NA

7.68

E+

033.

36E

+04

Tot

al F

acili

ty L

imit

NA

2.07

9.05

9.05

NA

2.09

E-0

39.

16E

-03

9.16

E-0

3N

A3.

94E

+03

1.72

E+

04T

otal

Fac

ility

Lim

itN

A0.

588

2.58

2.58

NA

3.50

E-0

61.

53E

-05

1.53

E-0

5N

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

030

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

0.03

00.

130.

13N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

030

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

0.03

00.

130.

13N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

030

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

0.03

00.

130.

13N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

030

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

0.03

00.

130.

13N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

030

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

0.03

00.

130.

13N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

030

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

0.03

00.

130.

13N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A4.

7820

.94

1.20

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

0.19

0.84

0.84

NA

0.00

0.00

0.00

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

0.67

2.94

2.94

NA

4.00

E-0

61.

75E

-05

1.75

E-0

5N

AN

AN

AT

otal

Fac

ility

Lim

itN

A2.

4010

.49

10.4

9N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A2.

4010

.49

10.4

9N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

763.

313.

31N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A1.

014.

424.

42N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A1.

014.

424.

42N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A1.

014.

424.

42N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

472.

062.

06N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

180.

790.

79N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

210.

920.

92N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

210.

920.

92N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A2.

4710

.82

10.8

2N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A2.

4710

.82

10.8

2N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

291.

291.

29N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

080.

350.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

080.

350.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

190.

830.

83N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

190.

830.

83N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

271.

181.

18N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

271.

181.

18N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

5of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

C

AS

#:63

0-08

-0 3

c) C

AS

#:

7439

-92-

1 3

c) C

AS

#:

----

-- P

ollu

tant

Nam

e:3d

) P

ollu

tant

Nam

e:3d

) P

ollu

tant

Nam

e:C

OLe

adC

O2e

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

0.25

1.10

1.10

NA

1.50

E-0

66.

57E

-06

6.57

E-0

6N

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

552.

392.

39N

A3.

25E

-06

1.42

E-0

51.

42E

-05

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

0.47

2.07

2.07

NA

2.81

E-0

61.

23E

-05

1.23

E-0

5N

AN

AN

AT

otal

Fac

ility

Lim

itN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

i tN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

890.

35N

AN

AN

AN

AN

AN

AN

AT

otal

Fac

ility

Lim

itN

A0.

662.

892.

89N

A0.

000.

000.

00N

A93

64,

100

Tot

al F

acili

ty L

imi t

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imit

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Tot

al F

acili

ty L

imi t

NA

0.40

1.77

1.77

NA

2.40

E-0

61.

05E

-05

1.05

E-0

5N

A57

32,

509

Tot

al F

acili

ty L

imi t

NA

0.40

1.77

1.77

NA

2.40

E-0

61.

05E

-05

1.05

E-0

5N

A57

32,

509

Tot

al F

acili

ty L

imit

NA

0.20

0.88

0.88

NA

1.20

E-0

65.

26E

-06

5.26

E-0

6N

A28

61,

255

Tot

al F

acili

ty L

imi t

NA

0.09

0.42

0.42

NA

5.64

E-0

72.

47E

-06

2.47

E-0

6N

A13

559

0T

otal

Fac

ility

Lim

itN

AT

otal

Fac

ility

Lim

i t

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

0.06

0.06

NA

129,

147

94,7

0019

4.37

156.

83N

AN

A

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

6of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7440

-38-

2 3

c) C

AS

#:

71-4

3-2

3d

) P

ollu

tant

Nam

e:A

cetic

Aci

d3d

) P

ollu

tant

Nam

e:A

rsen

ic3d

) P

ollu

tant

Nam

e:B

enz

ene

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

4.4

6E

-04

1.9

5E

-03

1.9

5E

-03

NA

1.0

1E

-04

4.4

2E

-04

4.4

2E

-04

NA

NA

NA

NA

NA

4.4

6E

-04

1.9

5E

-03

1.9

5E

-03

NA

1.0

1E

-04

4.4

2E

-04

4.4

2E

-04

NA

NA

NA

NA

NA

4.4

6E

-04

1.9

5E

-03

1.9

5E

-03

NA

1.0

1E

-04

4.4

2E

-04

4.4

2E

-04

NA

NA

NA

NA

NA

2.2

8E

-04

1.0

0E

-03

1.0

0E

-03

NA

5.1

7E

-05

2.2

6E

-04

2.2

6E

-04

NA

NA

NA

NA

NA

1.4

0E

-06

6.1

3E

-06

6.1

3E

-06

NA

1.4

7E

-05

6.4

4E

-05

6.4

4E

-05

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.07

0.30

0.30

NA

NA

NA

NA

NA

0.03

0.13

0.13

NA

0.07

0.30

0.30

NA

NA

NA

NA

NA

0.03

0.13

0.13

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

7of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7440

-38-

2 3

c) C

AS

#:

71-4

3-2

3d

) P

ollu

tant

Nam

e:A

cetic

Aci

d3d

) P

ollu

tant

Nam

e:A

rsen

ic3d

) P

ollu

tant

Nam

e:B

enz

ene

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

9.6

0E

-07

4.2

0E

-06

4.2

0E

-06

NA

1.0

1E

-05

4.4

2E

-05

4.4

2E

-05

NA

NA

NA

NA

NA

9.6

0E

-07

4.2

0E

-06

4.2

0E

-06

NA

1.0

1E

-05

4.4

2E

-05

4.4

2E

-05

NA

NA

NA

NA

NA

4.8

0E

-07

2.1

0E

-06

2.1

0E

-06

NA

5.0

4E

-06

2.2

1E

-05

2.2

1E

-05

NA

NA

NA

NA

NA

2.2

6E

-07

9.8

9E

-07

9.8

9E

-07

NA

2.3

7E

-06

1.0

4E

-05

1.0

4E

-05

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

0.01

0.01

NA

0.69

0.69

0.59

0.59

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

8of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 74

40-4

1-7

3c)

CA

S#

: 74

40-4

2-9

3c)

CA

S#

: 74

40-4

7-3

3d

) P

ollu

tant

Nam

e:B

eryl

lium

3d)

Pol

luta

nt N

ame:

Cad

miu

m C

o.3d

) P

ollu

tant

Nam

e:C

hrom

ium

Co.

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

9.3

9E

-06

4.1

1E

-05

4.1

1E

-05

NA

1.3

4E

-04

5.8

9E

-04

5.8

9E

-04

NA

2.8

6E

-04

1.2

5E

-03

1.2

5E

-03

NA

9.3

9E

-06

4.1

1E

-05

4.1

1E

-05

NA

1.3

4E

-04

5.8

9E

-04

5.8

9E

-04

NA

2.8

6E

-04

1.2

5E

-03

1.2

5E

-03

NA

9.3

9E

-06

4.1

1E

-05

4.1

1E

-05

NA

1.3

4E

-04

5.8

9E

-04

5.8

9E

-04

NA

2.8

6E

-04

1.2

5E

-03

1.2

5E

-03

NA

4.8

1E

-06

2.1

1E

-05

2.1

1E

-05

NA

6.8

9E

-05

3.0

2E

-04

3.0

2E

-04

NA

1.4

6E

-04

6.4

1E

-04

6.4

1E

-04

NA

8.4

0E

-08

3.6

8E

-07

3.6

8E

-07

NA

7.7

0E

-06

3.3

7E

-05

3.3

7E

-05

NA

9.8

0E

-06

4.2

9E

-05

4.2

9E

-05

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

3.3

0E

-07

1.4

5E

-06

1.4

5E

-06

NA

1.5

0E

-08

6.5

7E

-08

6.5

7E

-08

NA

NA

NA

NA

NA

3.3

0E

-07

1.4

5E

-06

1.4

5E

-06

NA

1.5

0E

-08

6.5

7E

-08

6.5

7E

-08

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

9of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 74

40-4

1-7

3c)

CA

S#

: 74

40-4

2-9

3c)

CA

S#

: 74

40-4

7-3

3d

) P

ollu

tant

Nam

e:B

eryl

lium

3d)

Pol

luta

nt N

ame:

Cad

miu

m C

o.3d

) P

ollu

tant

Nam

e:C

hrom

ium

Co.

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

5.7

6E

-08

2.5

2E

-07

2.5

2E

-07

NA

5.2

8E

-06

2.3

1E

-05

2.3

1E

-05

NA

6.7

2E

-06

2.9

4E

-05

2.9

4E

-05

NA

5.7

6E

-08

2.5

2E

-07

2.5

2E

-07

NA

5.2

8E

-06

2.3

1E

-05

2.3

1E

-05

NA

6.7

2E

-06

2.9

4E

-05

2.9

4E

-05

NA

2.8

8E

-08

1.2

6E

-07

1.2

6E

-07

NA

2.6

4E

-06

1.1

6E

-05

1.1

6E

-05

NA

3.3

6E

-06

1.4

7E

-05

1.4

7E

-05

NA

1.3

5E

-08

5.9

3E

-08

5.9

3E

-08

NA

1.2

4E

-06

5.4

4E

-06

5.4

4E

-06

NA

1.5

8E

-06

6.9

2E

-06

6.9

2E

-06

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

2.2

1E

-03

2.2

1E

-03

NA

4.5

6E

-03

4.5

6E

-03

0.00

0.00

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

10of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 35

321-

22-6

3c)

CA

S#

: 50

-00-

0 3

c) C

AS

#:

110-

54-3

3d

) P

ollu

tant

Nam

e:D

ichl

orob

enze

ne3d

) P

ollu

tant

Nam

e:F

orm

alde

hyde

3d)

Pol

luta

nt N

ame:

Hex

ane

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

5.7

6E

-05

2.5

2E

-04

2.5

2E

-04

NA

1.1

2E

-02

4.8

8E

-02

4.8

8E

-02

NA

8.6

5E

-02

3.7

9E

-01

3.7

9E

-01

NA

5.7

6E

-05

2.5

2E

-04

2.5

2E

-04

NA

1.1

2E

-02

4.8

8E

-02

4.8

8E

-02

NA

8.6

5E

-02

3.7

9E

-01

3.7

9E

-01

NA

5.7

6E

-05

2.5

2E

-04

2.5

2E

-04

NA

1.1

2E

-02

4.8

8E

-02

4.8

8E

-02

NA

8.6

5E

-02

3.7

9E

-01

3.7

9E

-01

NA

2.9

5E

-05

1.2

9E

-04

1.2

9E

-04

NA

5.7

1E

-03

2.5

0E

-02

2.5

0E

-02

NA

4.4

3E

-02

1.9

4E

-01

1.9

4E

-01

NA

8.4

0E

-06

3.6

8E

-05

3.6

8E

-05

NA

5.2

5E

-04

2.3

0E

-03

2.3

0E

-03

NA

1.2

6E

-02

5.5

2E

-02

5.5

2E

-02

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.02

0.07

0.07

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.02

0.07

0.07

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

11of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 35

321-

22-6

3c)

CA

S#

: 50

-00-

0 3

c) C

AS

#:

110-

54-3

3d

) P

ollu

tant

Nam

e:D

ichl

orob

enze

ne3d

) P

ollu

tant

Nam

e:F

orm

alde

hyde

3d)

Pol

luta

nt N

ame:

Hex

ane

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

0.01

0.06

0.06

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

5.7

6E

-06

2.5

2E

-05

2.5

2E

-05

NA

3.6

0E

-04

1.5

8E

-03

1.5

8E

-03

NA

0.01

0.04

0.04

NA

5.7

6E

-06

2.5

2E

-05

2.5

2E

-05

NA

3.6

0E

-04

1.5

8E

-03

1.5

8E

-03

NA

0.01

0.04

0.04

NA

2.8

8E

-06

1.2

6E

-05

1.2

6E

-05

NA

1.8

0E

-04

7.8

8E

-04

7.8

8E

-04

NA

0.00

0.02

0.02

NA

1.3

5E

-06

5.9

3E

-06

5.9

3E

-06

NA

8.4

6E

-05

3.7

1E

-04

3.7

1E

-04

NA

2.0

3E

-03

8.9

0E

-03

8.9

0E

-03

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

3.5

8E

-01

3.5

8E

-01

NA

1.55

1.55

1.0

3E

-03

1.0

3E

-03

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

12of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 74

39-9

6-5

3c)

CA

S#

: 74

39-9

7-6

3c)

CA

S#

: 78

-93-

3 3

d) P

ollu

tant

Nam

e:M

anga

nese

Co.

3d)

Pol

luta

nt N

ame:

Mer

cur y

3d)

Pol

luta

nt N

ame:

Met

hyl E

thyl

Ke

tone

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

1.0

1E

-03

4.4

4E

-03

4.4

4E

-03

NA

3.8

2E

-05

1.6

7E

-04

1.6

7E

-04

NA

NA

NA

NA

NA

1.0

1E

-03

4.4

4E

-03

4.4

4E

-03

NA

3.8

2E

-05

1.6

7E

-04

1.6

7E

-04

NA

NA

NA

NA

NA

1.0

1E

-03

4.4

4E

-03

4.4

4E

-03

NA

3.8

2E

-05

1.6

7E

-04

1.6

7E

-04

NA

NA

NA

NA

NA

5.1

9E

-04

2.2

7E

-03

2.2

7E

-03

NA

1.9

6E

-05

8.5

7E

-05

8.5

7E

-05

NA

NA

NA

NA

NA

2.6

6E

-06

1.1

7E

-05

1.1

7E

-05

NA

1.8

2E

-06

7.9

7E

-06

7.9

7E

-06

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

2.5

5E

-06

1.1

2E

-05

1.1

2E

-05

NA

NA

NA

NA

NA

4.3

5E

-03

0.02

0.02

NA

2.5

5E

-06

1.1

2E

-05

1.1

2E

-05

NA

NA

NA

NA

NA

4.3

5E

-03

0.02

0.02

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

13of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 74

39-9

6-5

3c)

CA

S#

: 74

39-9

7-6

3c)

CA

S#

: 78

-93-

3 3

d) P

ollu

tant

Nam

e:M

anga

nese

Co.

3d)

Pol

luta

nt N

ame:

Mer

cur y

3d)

Pol

luta

nt N

ame:

Met

hyl E

thyl

Ke

tone

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

1.8

2E

-06

7.9

9E

-06

7.9

9E

-06

NA

1.2

5E

-06

5.4

7E

-06

5.4

7E

-06

NA

NA

NA

NA

NA

1.8

2E

-06

7.9

9E

-06

7.9

9E

-06

NA

1.2

5E

-06

5.4

7E

-06

5.4

7E

-06

NA

NA

NA

NA

NA

9.1

2E

-07

3.9

9E

-06

3.9

9E

-06

NA

6.2

4E

-07

2.7

3E

-06

2.7

3E

-06

NA

NA

NA

NA

NA

4.2

9E

-07

1.8

8E

-06

1.8

8E

-06

NA

2.9

3E

-07

1.2

9E

-06

1.2

9E

-06

NA

NA

NA

NA

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

6.1

9E

-04

6.1

9E

-04

NA

3.8

1E

-02

3.8

1E

-02

1.57

E-0

21.

57E

-02

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

14of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 91

-20-

3 3

c) C

AS

#:

7440

-02-

0 3

c) C

AS

#:

108-

95-2

3d)

Pol

luta

nt N

ame:

Nap

htha

lene

3d)

Pol

luta

nt N

ame:

Nic

kel C

o.3d

) P

ollu

tant

Nam

e:P

heno

l

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

3.8

2E

-04

1.6

7E

-03

1.6

7E

-03

NA

2.8

6E

-02

1.2

5E

-01

1.2

5E

-01

NA

NA

NA

NA

NA

3.8

2E

-04

1.6

7E

-03

1.6

7E

-03

NA

2.8

6E

-02

1.2

5E

-01

1.2

5E

-01

NA

NA

NA

NA

NA

3.8

2E

-04

1.6

7E

-03

1.6

7E

-03

NA

2.8

6E

-02

1.2

5E

-01

1.2

5E

-01

NA

NA

NA

NA

NA

1.9

6E

-04

8.5

7E

-04

8.5

7E

-04

NA

1.4

6E

-02

6.4

1E

-02

6.4

1E

-02

NA

NA

NA

NA

NA

4.2

7E

-06

1.8

7E

-05

1.8

7E

-05

NA

1.4

7E

-05

6.4

4E

-05

6.4

4E

-05

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

2.1

0E

-07

9.2

0E

-07

9.2

0E

-07

NA

0.02

0.07

0.07

NA

NA

NA

NA

NA

2.1

0E

-07

9.2

0E

-07

9.2

0E

-07

NA

0.02

0.07

0.07

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

15of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 91

-20-

3 3

c) C

AS

#:

7440

-02-

0 3

c) C

AS

#:

108-

95-2

3d)

Pol

luta

nt N

ame:

Nap

htha

lene

3d)

Pol

luta

nt N

ame:

Nic

kel C

o.3d

) P

ollu

tant

Nam

e:P

heno

l

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

2.9

3E

-06

1.2

8E

-05

1.2

8E

-05

NA

1.0

1E

-05

4.4

2E

-05

4.4

2E

-05

NA

NA

NA

NA

NA

2.9

3E

-06

1.2

8E

-05

1.2

8E

-05

NA

1.0

1E

-05

4.4

2E

-05

4.4

2E

-05

NA

NA

NA

NA

NA

1.4

6E

-06

6.4

1E

-06

6.4

1E

-06

NA

5.0

4E

-06

2.2

1E

-05

2.2

1E

-05

NA

NA

NA

NA

NA

6.8

8E

-07

3.0

1E

-06

3.0

1E

-06

NA

2.3

7E

-06

1.0

4E

-05

1.0

4E

-05

NA

NA

NA

NA

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

4.4

0E

-01

4.4

0E

-01

NA

1.3

4E

-01

1.3

4E

-01

7.78

E-0

27.

78E

-02

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

16of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7782

-49-

2 3

c) C

AS

#:

108-

88-3

3d

) P

ollu

tant

Nam

e:P

OM

3d)

Pol

luta

nt N

ame:

Se

leni

um3d

) P

ollu

tant

Nam

e:T

olue

ne

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

4.1

5E

-06

1.8

2E

-05

1.8

2E

-05

NA

2.3

1E

-04

1.0

1E

-03

1.0

1E

-03

NA

2.1

0E

-03

9.1

8E

-03

9.1

8E

-03

NA

4.1

5E

-06

1.8

2E

-05

1.8

2E

-05

NA

2.3

1E

-04

1.0

1E

-03

1.0

1E

-03

NA

2.1

0E

-03

9.1

8E

-03

9.1

8E

-03

NA

4.1

5E

-06

1.8

2E

-05

1.8

2E

-05

NA

2.3

1E

-04

1.0

1E

-03

1.0

1E

-03

NA

2.1

0E

-03

9.1

8E

-03

9.1

8E

-03

NA

2.1

3E

-06

9.3

1E

-06

9.3

1E

-06

NA

1.1

8E

-04

5.1

8E

-04

5.1

8E

-04

NA

1.0

7E

-03

4.7

0E

-03

4.7

0E

-03

NA

6.0

5E

-07

2.6

5E

-06

2.6

5E

-06

NA

1.6

8E

-07

7.3

6E

-07

7.3

6E

-07

NA

2.3

8E

-05

1.0

4E

-04

1.0

4E

-04

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

17of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7782

-49-

2 3

c) C

AS

#:

108-

88-3

3d

) P

ollu

tant

Nam

e:P

OM

3d)

Pol

luta

nt N

ame:

Se

leni

um3d

) P

ollu

tant

Nam

e:T

olue

ne

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.01

0.01

NA

NA

NA

NA

NA

0.01

0.02

0.02

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

0.00

0.00

0.00

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

4.1

5E

-07

1.8

2E

-06

1.8

2E

-06

NA

1.1

5E

-07

5.0

5E

-07

5.0

5E

-07

NA

1.6

3E

-05

7.1

5E

-05

7.1

5E

-05

NA

4.1

5E

-07

1.8

2E

-06

1.8

2E

-06

NA

1.1

5E

-07

5.0

5E

-07

5.0

5E

-07

NA

1.6

3E

-05

7.1

5E

-05

7.1

5E

-05

NA

2.0

7E

-07

9.0

8E

-07

9.0

8E

-07

NA

5.7

6E

-08

2.5

2E

-07

2.5

2E

-07

NA

8.1

6E

-06

3.5

7E

-05

3.5

7E

-05

NA

9.7

5E

-08

4.2

7E

-07

4.2

7E

-07

NA

2.7

1E

-08

1.1

9E

-07

1.1

9E

-07

NA

3.8

4E

-06

1.6

8E

-05

1.6

8E

-05

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

3.5

5E

-03

3.5

5E

-03

NA

2.8

4E

-01

2.8

4E

-01

1.4

1E

-01

1.4

1E

-01

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

18of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7782

-49-

2 3

c) C

AS

#:

108-

88-3

3d

) P

ollu

tant

Nam

e:E

thyl

benz

ene

3d)

Pol

luta

nt N

ame:

1,1,

1-T

richl

oroe

than

e 3d

) P

ollu

tant

Nam

e:o-

Xyl

ene

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

2.1

5E

-05

9.4

1E

-05

9.4

1E

-05

NA

7.9

8E

-05

3.4

9E

-04

3.4

9E

-04

NA

3.6

8E

-05

1.6

1E

-04

1.6

1E

-04

NA

2.1

5E

-05

9.4

1E

-05

9.4

1E

-05

NA

7.9

8E

-05

3.4

9E

-04

3.4

9E

-04

NA

3.6

8E

-05

1.6

1E

-04

1.6

1E

-04

NA

2.1

5E

-05

9.4

1E

-05

9.4

1E

-05

NA

7.9

8E

-05

3.4

9E

-04

3.4

9E

-04

NA

3.6

8E

-05

1.6

1E

-04

1.6

1E

-04

NA

1.1

0E

-05

4.8

2E

-05

4.8

2E

-05

NA

4.0

9E

-05

1.7

9E

-04

1.7

9E

-04

NA

1.8

9E

-05

8.2

6E

-05

8.2

6E

-05

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

19of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7782

-49-

2 3

c) C

AS

#:

108-

88-3

3d

) P

ollu

tant

Nam

e:E

thyl

benz

ene

3d)

Pol

luta

nt N

ame:

1,1,

1-T

richl

oroe

than

e 3d

) P

ollu

tant

Nam

e:o-

Xyl

ene

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

1.2

3E

-03

1.2

3E

-03

NA

5.6

7E

-04

5.6

7E

-04

3.3

1E

-04

3.3

1E

-04

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

20of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7782

-49-

2 3

c) C

AS

#:

108-

88-3

3d

) P

ollu

tant

Nam

e:O

CD

D

3d)

Pol

luta

nt N

ame:

Ant

imon

y

3d)

Pol

luta

nt N

ame:

Cob

alt

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

1.0

5E

-09

4.5

9E

-09

4.5

9E

-09

NA

1.7

7E

-03

7.7

7E

-03

7.7

7E

-03

NA

2.0

3E

-03

8.9

1E

-03

8.9

1E

-03

NA

1.0

5E

-09

4.5

9E

-09

4.5

9E

-09

NA

1.7

7E

-03

7.7

7E

-03

7.7

7E

-03

NA

2.0

3E

-03

8.9

1E

-03

8.9

1E

-03

NA

1.0

5E

-09

4.5

9E

-09

4.5

9E

-09

NA

1.7

7E

-03

7.7

7E

-03

7.7

7E

-03

NA

2.0

3E

-03

8.9

1E

-03

8.9

1E

-03

NA

5.3

7E

-10

2.3

5E

-09

2.3

5E

-09

NA

9.0

9E

-04

3.9

8E

-03

3.9

8E

-03

NA

1.0

4E

-03

4.5

6E

-03

4.5

6E

-03

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

21of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

7782

-49-

2 3

c) C

AS

#:

108-

88-3

3d

) P

ollu

tant

Nam

e:O

CD

D

3d)

Pol

luta

nt N

ame:

Ant

imon

y

3d)

Pol

luta

nt N

ame:

Cob

alt

3e)

3f)

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lP

oten

tial

Act

ual

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

Act

ual

Act

ual

Act

ual

5)

Po

tent

ial

Po

tent

ial

Po

tent

ial

2.7

3E

-02

2.7

3E

-02

NA

3.1

3E

-02

3.1

3E

-02

1.6

1E

-08

1.6

1E

-08

NA

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

22of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Boi

ler

1E

U00

1B

oile

r 2

EU

002

Boi

ler

3E

U00

3B

oile

r 4

EU

004

Boi

ler

5E

U00

5O

ven

#6

EU

00

6O

ven

#7

EU

00

7O

ven

#8

EU

00

8O

ven

#9

EU

00

9O

ven

#1

0E

U0

10

Ove

n #

11

EU

01

1O

ven

#1

2E

U0

12

Ove

n #

1E

U0

13

Ove

n #

2E

U0

14

Ove

n #

3E

U0

15

Ove

n #

4E

U0

16

Ove

n #

5E

U0

17

Pre

coo

ked

Ba

con

So

uth

EU

01

8P

reco

oked

Bac

on N

orth

EU

019

Pre

coo

ked

Ba

con

Ea

s tE

U0

20

Pre

coo

ked

Ba

con

Wes

tE

U0

21

Sta

nd-b

y G

ener

ato

rE

U0

78

Ful

lon

Hea

ter

EU

02

5R

end

erin

g R

oo

m A

irE

U0

27

Ren

derin

g M

achi

neE

U0

28

Cra

x G

rind

EU

028

Cra

x S

cre

en

EU

02

8B

aco

n B

its P

reco

oke

d L

ine

EU

02

9H

og

Sin

ger

#1

EU

03

0N

atur

al S

mo

ke G

ener

ato

rE

U0

31

Nat

ural

Sm

oke

Gen

erat

or

EU

03

2G

P S

alt

Sys

tem

EU

03

3M

P S

alt

Sys

tem

EU

03

4G

P S

ugar

Sys

tem

EU

03

5B

one

Dry

e rE

U0

36

Bo

ne D

ryer

-Co

mbu

stio

nE

U0

36

Va

por

Sm

oke

Gen

#1

EU

03

7V

apo

r S

mo

ke G

en #

2E

U0

38

Va

por

Sm

oke

Gen

#3

EU

03

9K

C-9

Mak

eup

Air

Hea

ter

EU

04

0K

C-7

Mak

eup

Air

Hea

ter

EU

04

1R

ende

ring

Mak

eup

Air

Ht r

EU

04

2R

ende

ring

Mak

eup

Air

Htr

EU

04

3B

oile

r 6

EU

044

Boi

ler

7E

U04

5B

loo

d D

rye

rE

U0

50

Blo

od

Dry

er-C

om

bust

ion

EU

05

0N

G S

pace

Hea

ter

- H

og C

u tE

U0

52

NG

Spa

ce H

eate

r -

Hog

Cu t

EU

05

3N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

4N

G S

pace

He

ate

r -

Pre

tre

atm

ent

EU

05

5N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

6N

G S

pace

He

ate

r F

ront

End

Kill

EU

05

7

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

3d)

Pol

luta

nt N

ame:

Zin

c

3d)

Pol

luta

nt N

ame:

Tot

al H

AP

s

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

y

9.83

E-0

34.

31E

-02

4.31

E-0

2N

A0.

060.

270.

27N

A9.

83E

-03

4.31

E-0

24.

31E

-02

NA

0.06

0.27

0.27

NA

9.83

E-0

34.

31E

-02

4.31

E-0

2N

A0.

060.

270.

27N

A5.

04E

-03

2.21

E-0

22.

21E

-02

NA

0.03

0.14

0.14

NA

NA

NA

NA

NA

6.0

4E

-04

2.6

5E

-03

2.6

5E

-03

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.12

0.54

0.54

NA

NA

NA

NA

NA

0.12

0.54

0.54

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

23of

24

3a)

3b)

Em

issi

onE

mis

sion

Sou

rce

Sou

rce

Typ

eID

No.

Rad

iant

Wal

l Ove

ns #

2E

U0

67

Ho

g S

inge

r #2

EU

06

8O

ld B

oile

r R

oom

MA

UE

U0

69

Lard

Deo

doriz

er C

oolin

g T

ower

EU

07

0G

ener

ator

#1

EU

08

0G

ener

ator

#2

EU

08

1G

ener

ator

#3

EU

08

2G

ener

ator

#4

EU

08

3G

ener

ator

#5

EU

08

4G

ener

ator

#6

EU

08

5G

ener

ator

#7

EU

08

6R

TO

Com

bust

ion

EU

08

7R

efin

ed P

rodu

cts

Mac

hine

r yE

U0

88

Cra

x R

oo

m A

i rE

U0

89

Tru

ck L

oa

do

ut R

oo

m A

i rE

U0

90

Ref

ine

d P

rod

ucts

Roo

m A

irE

U0

91

Ref

ined

Pro

duct

s M

AU

1E

U0

92

Ref

ined

Pro

duct

s M

AU

2E

U0

93

Ref

ined

Pro

duct

s M

AU

3E

U0

94

Air

Han

dlin

g U

nit -

Insi

gnifi

cant

A

ctiv

ities

IAs

4)T

otal

Fac

ility

Alt

erna

tive

For

m F

orm

atG

I-07

Faci

lity

Em

issi

ons

Sum

mar

yAi

r Q

ualit

y Pe

rmit

Pro

gram

Doc

Typ

e: P

erm

it A

pplic

atio

n

1a)

AQ

D F

acili

ty ID

No.

: '09

9000

021b

) A

Q F

ile N

o.:

418

2) F

acili

ty N

ame:

Hor

mel

Fo

od

s C

orpo

ratio

n/Q

ualit

y P

ork

Pro

cess

ors

(Q

PP

)

3c)

CA

S#

: 3

c) C

AS

#:

3d)

Pol

luta

nt N

ame:

Zin

c

3d)

Pol

luta

nt N

ame:

Tot

al H

AP

s

3e)

3f)

3e)

3f)

Po

tent

ial

Act

ual

Pot

entia

lA

ctua

lLb

s pe

r H

rU

nres

tric

ted

Lim

ited

Ton

s pe

r yr

Lbs

per

Hr

Unr

estr

icte

dLi

mite

dT

ons

per

yrtp

ytp

ytp

ytp

y

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

0.01

0.05

0.05

NA

NA

NA

NA

NA

6.8

9E

-04

2.9

6E

-03

2.9

6E

-03

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

NA

4.1

4E

-04

1.8

1E

-03

1.8

1E

-03

NA

NA

NA

NA

NA

4.1

4E

-04

1.8

1E

-03

1.8

1E

-03

NA

NA

NA

NA

NA

2.0

7E

-04

9.0

7E

-04

9.0

7E

-04

NA

NA

NA

NA

NA

9.7

4E

-05

4.2

6E

-04

4.2

6E

-04

NA

Act

ual

Act

ual

5)

Pot

entia

lP

oten

tial

2.37

2.37

NA

1.5

1E

-01

1.5

1E

-01

NA

Appl

icat

ion

is b

eing

sub

mitt

ed o

n pa

per

only

, so

edita

ble

calc

ulat

ion

spre

adsh

eet(

s)w

ill b

e e-

mai

led

to t

he M

PCA

upon

req

uest

or

are

incl

uded

on

an e

nclo

sed

CD.

Appl

icat

ion

is b

eing

sub

mitt

ed o

n a

com

pact

dis

c (C

D),

and

the

edi

tabl

e ca

lcul

atio

n sp

read

shee

t(s)

are

incl

uded

on

the

CD

ww

w.p

ca.s

tate

.mn.

us•

651

296

6300

•80

065

738

64•

aqf1

gi07

•12

/14/

12H:

\Wor

kshe

etin

ole_

mai

n

TTY

651

282

5332

or80

065

738

64•

Avai

labl

ein

alte

rnat

ive

form

ats

Page

24of

24

Hormel Foods Corporation/Quality Pork ProcessorsRefined Products Upgrade

AQD Facility ID: 09900002Facility Name: Hormel FoodsEmission Unit Boiler 1Stack/Vent Designation Number: SV001Maximum Rated Capacity: 49 MMBtu/hrControl Equipment: N/AFuel Type Natural Gas, Refined Animal FatEmission Limits:

Fuel Parameters: Max CapacityMMBtu/hr

Natural Gas 1,020 btu/scf 49.00 48,039 scf/hrRefined Animal 145,000 btu/gal 49.00 338 gal/hr

1 The use of Fuel Oil #6 and Used Oil for combustion will no longer be permitted in these boilersSulfur Content: 0.02 % Sulfur (Test Value)Ash Content 0.02 % ash (Test Value)

Calculations Summary: Natural GasPollutant Emission Emission Maximum Pollution Controlled Controlled Limited

Factor 1 Rate Uncontrolled Control Emission Emission Controlled(lb/MMscf) (lbs/hr) Emissions Efficiency Rate Rate Emissions

(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 0.37 1.60 0.00 0.37 1.60 naPM (filterable) 1.90 0.09 0.40 0.00 0.09 0.40 naPM10 7.60 0.37 1.60 0.00 0.37 1.60 naPM2.5 7.60 0.37 1.60 0.00 0.37 1.60 naNOx 32 1.54 6.73 0.00 1.54 6.73 naSO2 0.60 0.03 0.13 0.00 0.03 0.13 naCO 84 4.04 17.7 0.00 4.04 17.67 naVOC 5.50 0.26 1.2 0.00 0.26 1.16 naLead 5.00E 04 2.40E 05 1.05E 04 0.00 2.40E 05 1.05E 04 na2 AP 42 Chapter 1.4 0.3 100 MMBtu/hr

GP001 emission limit of less than or equal to 180 tons/year NOx using 12 month Rolling Sumtotal for GP001. SO2 emission limit of less than or equal to 235 tons/year using 12 month Rolling Sum total for GP 001combustion of refined animal fats.

Fuel Type 1 Heat Value Fuel Consumption Rate

Natural Gas Combustion HAPs:HAP Name Emission Emission Maximum Pollution Controlled Controlled Limited

(CAS) Factor Rate Uncontrolled Control Emission Emission ControlledEmissions Efficiency Rate Rate Emissions

(lbs/MMscf)3 (lbs/hr) (tons/yr) (%) (lbs/hr) (tons/yr) (tons/yr)Benzene (71 43 2) 2.1E 03 1.0E 04 4.42E 04 0.0 1.01E 04 4.4E 04 naDichlorobenzene (25321 22 6) 1.2E 03 5.8E 05 2.52E 04 0.0 5.76E 05 2.5E 04 naFormaldehyde (50 00 0) 7.5E 02 3.6E 03 1.58E 02 0.0 3.60E 03 1.6E 02 naHexane (110 54 3) 1.80 0.09 0.38 0.00 8.65E 02 3.8E 01 naNaphthalene (91 20 3)4 6.1E 04 2.9E 05 1.28E 04 0.0 2.93E 05 1.3E 04 naToluene (108 88 3) 3.4E 03 1.6E 04 7.15E 04 0.0 1.63E 04 7.2E 04 naPolycyclic Organic Matter (POM)5 8.6E 05 4.2E 06 1.82E 05 0.0 4.15E 06 1.8E 05 naArsenic (7440 38 2) 2.0E 04 9.6E 06 4.21E 05 0.0 9.61E 06 4.2E 05 naBeryllium (7440 41 7) 1.2E 05 5.8E 07 2.52E 06 0.0 5.76E 07 2.5E 06 naCadmium (7440 43 9) 1.1E 03 5.3E 05 2.31E 04 0.0 5.28E 05 2.3E 04 naChromium (7440 47 3) 1.4E 03 6.7E 05 2.95E 04 0.0 6.73E 05 2.9E 04 naManganese (7439 96 5) 3.8E 04 1.8E 05 8.00E 05 0.0 1.83E 05 8.0E 05 naMercury (7439 97 6) 2.6E 04 1.2E 05 5.47E 05 0.0 1.25E 05 5.5E 05 naNickel (7440 02 0) 2.1E 03 1.0E 04 4.42E 04 0.0 1.01E 04 4.4E 04 naSelenium (7782 49 2) 2.4E 05 1.2E 06 5.05E 06 0.0 1.15E 06 5.0E 06 naTotals 0.09 0.40 0.09 0.40

4Nahpthalene is included in the Polycyclic Organic Matter (POM) emissions and is not double counted in the total HAPs.5Total POM emission factor is equal to the sum of the individual POM compounds.

Natural Gas Combustion Greenhouse Gases:Pollutant GWP Emission Maximum Pollution Controlled Controlled Limited

Factor Uncontrolled Control Emission Emission Controlled(lbs/MMBtu)6 Emissions Efficiency Rate Rate Emissions

(lb/hr) (%) (lbs/hr) (tons/yr) (tons/yr)CO2 1 116.89 5,728 0.00 5,728 25,087 naCH4 21 2.20E 03 0.11 0.00 0.11 0.47 naN2O 310 2.20E 04 0.01 0.00 0.01 0.05 naTotal GHG (CO2e) 5,733 25,111 na6 Emission Factors obtained from 40 CFR 98. Converted from kg to lb.

Calculations Summary: Refined Animal FatPollutant Emission Emission Maximum Pollution Controlled Controlled Limited

Factor 7 Rate Uncontrolled Control Emission Emission Controlled(lb/1000 gal) (lbs/hr) Emissions Efficiency Rate Rate Emissions

(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 4.90 1.66 7.26 0.00 1.66 7.26 naPM10 4.90 1.66 7.26 0.00 1.66 7.26 naPM2.5 4.90 1.66 7.26 0.00 1.66 7.26 naNOx 36.85 12.45 54.54 0.00 12.45 54.54 naSOx 3.14 1.06 4.65 0.00 1.06 4.65 naCO 10.00 3.38 14.80 0.00 3.38 14.80 naVOC 0.31 0.10 0.46 0.00 0.10 0.46 naLead 0.01 4.08E 03 0.02 0.00 4.08E 03 0.02 na7 Emission factors derived from AP 42 Section 1.3 for Fuel Oil Combustion. Emission factors were updated based on a 2001 fuel analysis of RAF. The updatedemission factors reflect a 33% decrease in NOx emissions, a doubling of CO emissions, and an 8 fold increase in Lead emissions. All other factors are conservativelyassumed to be equal to those used for Fuel Oil #6 combustion.

3All emissions are calculated based on emission factors from AP 42, Section 1.4 "Natural Gas Combustion"(7/98).

Refined Animal Fat HAPs:HAP Name Emission Emission Maximum Pollution Controlled Controlled Limited

(CAS) Factor Rate Uncontrolled Control Emission Emission Controlled(lbs/1000 gal)8 (lbs/hr) Emissions Efficiency Rate Rate Emissions

(tons/yr) (%) (lbs/hr) (tons/yr) (tons/yr)Benzene 2.14E 04 7.23E 05 3.17E 04 0.00 7.23E 05 3.17E 04 naEthylbenzene 6.36E 05 2.15E 05 9.41E 05 0.00 2.15E 05 9.41E 05 naFormaldehyde 3.30E 02 1.12E 02 4.88E 02 0.00 1.12E 02 4.88E 02 naNaphthalene 1.13E 03 3.82E 04 1.67E 03 0.00 3.82E 04 1.67E 03 na1,1,1 Trichloroethane 2.36E 04 7.98E 05 3.49E 04 0.00 7.98E 05 3.49E 04 naToluene 6.20E 03 2.10E 03 9.18E 03 0.00 2.10E 03 9.18E 03 nao Xylene 1.09E 04 3.68E 05 1.61E 04 0.00 3.68E 05 1.61E 04 naOCDD 3.10E 09 1.05E 09 4.59E 09 0.00 1.05E 09 4.59E 09 naAntimony 5.25E 03 1.77E 03 7.77E 03 0.00 1.77E 03 7.77E 03 naArsenic 1.32E 03 4.46E 04 1.95E 03 0.00 4.46E 04 1.95E 03 naBeryllium 2.78E 05 9.39E 06 4.11E 05 0.00 9.39E 06 4.11E 05 naCadmium 3.98E 04 1.34E 04 5.89E 04 0.00 1.34E 04 5.89E 04 naChromium 8.45E 04 2.86E 04 1.25E 03 0.00 2.86E 04 1.25E 03 naCobalt 6.02E 03 2.03E 03 8.91E 03 0.00 2.03E 03 8.91E 03 naManganese 3.00E 03 1.01E 03 4.44E 03 0.00 1.01E 03 4.44E 03 naMercury 1.13E 04 3.82E 05 1.67E 04 0.00 3.82E 05 1.67E 04 naNickel 8.45E 02 2.86E 02 0.13 0.00 2.86E 02 0.13 naSelenium 6.83E 04 2.31E 04 1.01E 03 0.00 2.31E 04 1.01E 03 naZinc 2.91E 02 9.83E 03 4.31E 02 0.00 9.83E 03 4.31E 02 naTotals 0.01 0.05 0.01 0.058All emissions are calculated based on emission factors from AP 42, Section 1.3 "Fuel Oil Combustion"(5/10).

Calculations Summary Greenhouse Gases:Pollutant GWP Emission Maximum Pollution Controlled Controlled Limited


(lb/hr) (%) (lbs/hr) (tons/yr) (tons/yr)CO2 1 156.66 7,676 0.00 7,676 33,622 naCH4 21 2.43E 03 0.12 0.00 0.12 0.52 naN2O 310 2.43E 04 0.01 0.00 0.01 0.05 naTotal GHG (CO2e) 7,682 33,649 na8 Emission Factors obtained from 40 CFR 98 for Rendered Animal Fat. Converted from kg to lb.

Worse Case Potential to Emit Summary:Pollutant Before Before After

Operating Operating OperatingLimits Limits Limits(lb/hr) (ton/yr) (ton/yr)

PM 1.66 7.26 naPM (filterable) 0.09 0.40 naPM10 1.66 7.26 naPM2.5 1.66 7.26 naNOx 12.45 54.54 naSO2 1.06 4.65 naCO 4.04 17.67 naVOC 0.26 1.16 naLead 0.00 0.02 naDichlorobenzene 5.76E 05 2.52E 04 naHexane 0.086 0.379 naPolycyclic Organic Matter (POM) 4.15E 06 1.82E 05 naBenzene 1.01E 04 4.42E 04 naEthylbenzene 2.15E 05 9.41E 05 naFormaldehyde 1.12E 02 4.88E 02 naNaphthalene 3.82E 04 1.67E 03 na1,1,1 Trichloroethane 7.98E 05 3.49E 04 naToluene 2.10E 03 9.18E 03 nao Xylene 3.68E 05 1.61E 04 naOCDD 1.05E 09 4.59E 09 naAntimony 1.77E 03 7.77E 03 naArsenic 4.46E 04 1.95E 03 naBeryllium 9.39E 06 4.11E 05 naCadmium 1.34E 04 5.89E 04 naChromium 2.86E 04 1.25E 03 naCobalt 2.03E 03 8.91E 03 naManganese 1.01E 03 4.44E 03 naMercury 3.82E 05 1.67E 04 naNickel 2.86E 02 1.25E 01 naSelenium 2.31E 04 1.01E 03 naZinc 9.83E 03 4.31E 02 naCO2 7,676 33,622 naCH4 0.12 0.52 naN2O 0.01 0.05 naTotal GHG (CO2e) 7,682 33,649 na10 There are no operating limits for the boiler.
































AQD Facility ID: 09900002Facility Name: Hormel FoodsEmission Unit Boiler 3Stack/Vent Designation Number: SV001Maximum Rated Capacity: 49 MMBtu/hrControl Equipment: N/AFuel Type Natural Gas, Refined Animal Fat

Emission Limits:




























































AQD Facility Number: 09900002Company/Facility Name: Hormel Foods Corporation/Quality Pork ProcessorsEmission Unit Identification Number: EU036 Bone DryerStack/Vent Designation Number SV058Pollution Control Equipment Identification Number(s): CE026Process Type: Batch Process X Continuous ProcessMaximum Capacity: 3 dry ton/hr 12,000 lbs/hr @ 60% moistureSource of Emission Factors used in table below: AP 42 Chapter 9.9.1 Use Grain Drying Rack Dryer as surrogate

Since grain will be much dryer as a raw material, adjust weight to 10% moistureto compare to the emissions factor.

Calculations Summary:Pollutant Uncontrolled Emission Maximum Pollution Maximum Maximum Limited Actual

Emission Rate Uncontrolled Control Controlled Controlled Controlled EmissionsFactor Emissions Efficiency* Emissions Emissions Emissions (tons/yr)(lb/ton) (lb/hr) (ton/yr) (%) (lb/hr) (ton/yr) (tons/yr)

PM 3.00 9.00 39.42 97.72% 0.21 0.90 0.90 SeePM10 0.75 2.25 9.86 93.92% 0.14 0.60 0.60 EmissionsPM2.5 0.13 0.39 1.71 62% 0.15 0.65 0.65 InventorySOx na na na na na na na naNOx na na na na na na na naVOC unknown 0.00 0.00 97% 0.00 0.00 0.00 naCO na na na na na na na naLead na na na na na na na na

*Control efficiency for previously permitted RTO.


AQD Facility Number: 09900002Company/Facility Name: Hormel Foods Corporation/Quality Pork ProcessorsEmission Unit Identification Number: EU050 Blood DryerStack/Vent Designation Number SV058Pollution Control Equipment Identification Number(s): CE026Process Type: Batch Process X Continuous ProcessMaximum Capacity: 1.65 ton/hr dried blood meal productSource of Emission Factors used in table below: AP 42 Chapter 9.5.3 Table 9.5.3 2, Controlled Blood Dryers

**Assume Condensible PM equal to VOC, no VOC data provided.Calculations Summary:

Pollutant Uncontrolled Emission Maximum Pollution Maximum Maximum Limited ActualEmission Rate Uncontrolled Control Controlled Controlled Controlled EmissionsFactor Emissions Efficiency* Emissions Emissions Emissions (tons/yr)

(lb/ton) (lb/hr) (ton/yr) (%) (lb/hr) (ton/yr) (tons/yr)PM 1.22 2.01 8.82 97.72% 0.05 0.20 0.20 SeePM10 0.46 0.76 3.32 93.92% 0.05 0.20 0.20 EmissionsPM2.5 0.46 0.76 3.32 62% 0.29 1.26 1.26 InventorySOx na na na na na na na naNOx na na na na na na na naVOC** 0.46 0.76 3.32 97% 0.02 0.10 0.10 naCO na na na na na na na naLead na na na na na na na na

*Control efficiency for previously permitted RTO.


AQD Facility ID: 09900002Facility Name: Hormel FoodsEmission Unit Regenerative Thermal Oxidizer (EU087)Stack/Vent Designation Number: SV058Maximum Rated Capacity: 8 million BTU/hrControl Equipment: naFuel ParamatersFuel Type Natural Gas ONLY No secondary fuelHeat Value: 1020 Btu/cfFuel Consumption Rate: 7843 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr

Calculations Summary:Pollutant Emission Emission Maximum Pollution Controlled Controlled Limited

Factor Rate Uncontrolled Control Emission Emission Controlled(lb/MMcf) (lbs/hr) Emissions Efficiency Rate Rate Emissions

(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 0.06 0.26 0.00 0.06 0.26 naPM10 7.60 0.06 0.26 0.00 0.06 0.26 naPM2.5 7.60 0.06 0.26 0.00 0.06 0.26 naNOX 100.00 0.78 3.44 0.00 0.78 3.44 naSOX 0.60 0.00 0.02 0.00 0.00 0.02 naCO 84.00 0.66 2.89 0.00 0.66 2.89 naVOC 5.50 0.04 0.19 0.00 0.04 0.19 naLead 5.00E 04 3.92E 06 1.72E 05 0.00 3.92E 06 1.72E 05 na

Calculations Summary HAPs:HAP Name Emission Emission Maximum Pollution Controlled Controlled Limited


(lbs/MMcf)a (lbs/hr) (tons/yr) (%) (lbs/hr) (tons/yr) (tons/yr)Benzene (71 43 2) 2.1E 03 1.6E 05 7.21E 05 0.0 1.65E 05 7.2E 05 naDichlorobenzene (25321 22 6) 1.2E 03 9.4E 06 4.12E 05 0.0 9.41E 06 4.1E 05 naFormaldehyde (50 00 0) 7.5E 02 5.9E 04 2.58E 03 0.0 5.88E 04 2.6E 03 naHexane (110 54 3) 1.8E+00 1.4E 02 6.18E 02 0.0 1.41E 02 6.2E 02 naNaphthalene (91 20 3)b 6.1E 04 4.8E 06 2.10E 05 0.0 4.78E 06 2.1E 05 naToluene (108 88 3) 3.4E 03 2.7E 05 1.17E 04 0.0 2.67E 05 1.2E 04 naPolycyclic Organic Matter (POM)c 8.6E 05 6.8E 07 2.97E 06 0.0 6.78E 07 3.0E 06 naArsenic (7440 38 2) 2.0E 04 1.6E 06 6.87E 06 0.0 1.57E 06 6.9E 06 naBeryllium (7440 41 7) 1.2E 05 9.4E 08 4.12E 07 0.0 9.41E 08 4.1E 07 naCadmium (7440 43 9) 1.1E 03 8.6E 06 3.78E 05 0.0 8.63E 06 3.8E 05 naChromium (7440 47 3) 1.4E 03 1.1E 05 4.81E 05 0.0 1.10E 05 4.8E 05 naManganese (7439 96 5) 3.8E 04 3.0E 06 1.31E 05 0.0 2.98E 06 1.3E 05 naMercury (7439 97 6) 2.6E 04 2.0E 06 8.93E 06 0.0 2.04E 06 8.9E 06 naNickel (7440 02 0) 2.1E 03 1.6E 05 7.21E 05 0.0 1.65E 05 7.2E 05 naSelenium (7782 49 2) 2.4E 05 1.9E 07 8.24E 07 0.0 1.88E 07 8.2E 07 naTotals 0.01 0.06 0.01 0.06

bNahpthalene is included in the Polycyclic Organic Matter (POM) emissions and is not double counted in the total HAPs.cTotal POM emission factor is equal to the sum of the individual POM compounds.

aAll emissions are calculated based on emission factors from AP 42, Section 1.4 "Natural Gas Combustion"(7/98).


Factor Uncontrolled Control Emission Emission ControlledEmissions Efficiency Rate Rate Emissions

(lbs/MMBtu)d (lb/hr) (%) (lbs/hr) (tons/yr) (tons/yr)CO2 1 116.89 935 0.00 935 4,096 naCH4 21 2.20E 03 1.76E 02 0.00 1.76E 02 7.72E 02 naN2O 310 2.20E 04 1.76E 03 0.00 1.76E 03 7.72E 03 naTotal GHG (CO2e) 936.0 4,100 nad Emission Factors obtained from 40 CFR 98. Converted from kg to lb.


AQD Facility Number: 09900002Company/Facility Name: Hormel Foods Corporation/Quality Pork ProcessorsEmission Unit Identification Number: EU088 Refined Products MachineryStack/Vent Designation Number SV058Pollution Control Equipment Identification Number(s): CE026, CE027, CE028Process Type: Batch Process X Continuous ProcessMaximum Capacity: 12,000 acfmSource of Emission Factors used in table below: State Process Equipment Rule

Calculations Summary:Pollutant Emission Emission Maximum Pollution Maximum Maximum Limited Actual

Factor Rate Uncontrolled Control Controlled Controlled Controlled EmissionsEmissions Efficiency** Emissions Emissions Emissions (tons/yr)

(lb/msf) (lb/hr) (ton/yr) (%) (lb/hr)* (ton/yr) (tons/yr)PM na 283.57 1242.02 99.66% 0.97 4.25 4.25 naPM10 na 99.69 436.65 99.03% 0.97 4.25 4.25 naPM2.5 na 2.55 11.18 62% 0.97 4.25 4.25 naSOx na na na na na na na naNOx na na na na na na na naVOC na 32.33 141.59 97% 0.97 4.25 4.25 naCO na na na na na na na naLead na na na na na na na na

Notes:* Airflow: 12,000 acfm

100 F 0.010 gr/dscf0.0 % moisture 0.97 lbs/hr

11,314 scfm11,314 dscfm

PM control efficiency for venturi scrubber is 94%, packed gas adsorption column is 85%, and thermal oxidizer is 62%PM10 control efficiency for venturi scrubber is 84%, packed gas adsorption column is 84%, and thermal oxidizer is 62%Hormel conservatively assumed that the venturi scrubber would not control PM 2.5 emissions but the RTO would control at 62%.

Calculations for Minn. R. 7011.0715Airflow: 12,000 acfm Calculate Allowable Emissions:

100 F By Airflow 0.086 gr/dscf0.0 % moisture Table: 8.30 lbs/hr

11,314 scfm11,314 dscfm

** Control efficiencies based on Minn. R. 7011.0070. EU 088 is controlled by CE 027 (venturi scrubber), CE 028 (packed gas adsorption column) andCE 026 (already permitted RTO) in series.

There is no listed control efficicency for VOCs for venturi scrubbers or packed gas adsorption columns. Thermal oxidizers have a control efficiencylisted at 97%.


AQD Facility Number: 09900002Company/Facility Name: Hormel Foods Corporation/Quality Pork ProcessorsEmission Unit Identification Number: EU089 Crax Room AirStack/Vent Designation Number SV059Pollution Control Equipment Identification Number(s): CE029 and CE030Process Type: Batch Process X Continuous ProcessMaximum Capacity: 24,000 acfmSource of Emission Factors used in table below: State Process Equipment Rule



(lb/msf) (lb/hr) (ton/yr) (%) (lb/hr)* (ton/yr) (tons/yr)PM na 223.49 978.90 99.10% 2.01 8.81 8.81 naPM10 na 78.57 344.14 97.44% 2.01 8.81 8.81 naPM2.5 na 2.01 8.81 0% 2.01 8.81 8.81 naSOx na na na na na na na naNOx na na na na na na na naVOC na 2.01 8.81 0% 2.01 8.81 8.81 naCO na na na na na na na naLead na na na na na na na na



23,467 scfm23,467 dscfm

PM control efficiency for venturi scrubber is 94% and the packed gas adsorption column is 85%.PM10 control efficiency for venturi scrubber is 84% and the packed gas adsorption column is 84%.Hormel conservatively assumed that the venturi scrubber would not control PM2.5 emissions.There is no listed control efficicency for VOCs for venturi scrubbers.



22,629 scfm22,629 dscfm

** Control efficiencies based on Minn. R. 7011.0070. EU 089 is controlled by CE 029 (venturi scrubber) and CE 030 (packed gas adsorptioncolumn) in series.


AQD Facility Number: 09900002Company/Facility Name: Hormel Foods Corporation/Quality Pork ProcessorsEmission Unit Identification Number: EU090 Truck Loadout Room AirStack/Vent Designation Number SV059Pollution Control Equipment Identification Number(s): CE030Process Type: Batch Process X Continuous ProcessMaximum Capacity: 8,000 acfmSource of Emission Factors used in table below: State Process Equipment Rule



(lb/msf) (lb/hr) (ton/yr) (%) (lb/hr)* (ton/yr) (tons/yr)PM na 4.47 19.58 85% 0.67 2.94 2.94 naPM10 na 4.19 18.35 84% 0.67 2.94 2.94 naPM2.5 na 0.67 2.94 0% 0.67 2.94 2.94 naSOx na na na na na na na naNOx na na na na na na na naVOC na 0.67 2.94 0% 0.67 2.94 2.94 naCO na na na na na na na naLead na na na na na na na na



7,822 scfm7,822 dscfm

** Control efficiencies based on Minn. R. 7011.0070. EU 090 is controlled by CE 029 (packed gas adsorption column).PM control efficiency for packed gas adsorption column is 85%PM10 control efficiency for packed gas adsorption column is 84%Hormel conservatively assumed that the venturi scrubber would not control PM2.5 emissions.There is no listed control efficicency for VOCs for venturi scrubbers.



7,543 scfm7,543 dscfm


AQD Facility Number: 09900002Company/Facility Name: Hormel Foods Corporation/Quality Pork ProcessorsEmission Unit Identification Number: EU091 Refined Products Room AirStack/Vent Designation Number SV060, 061Pollution Control Equipment Identification Number(s): CE031Process Type: Batch Process X Continuous ProcessMaximum Capacity: 100,000 acfmSource of Emission Factors used in table below: State Process Equipment Rule



(lb/msf) (lb/hr) (ton/yr) (%) (lb/hr)* (ton/yr) (tons/yr)PM na 55.87 244.72 85% 8.38 36.71 36.71 naPM10 na 52.38 229.43 84% 8.38 36.71 36.71 naPM2.5 na 8.38 36.71 0% 8.38 36.71 36.71 naSOx na na na na na na na naNOx na na na na na na na naVOC na 8.38 36.71 0% 8.38 36.71 36.71 naCO na na na na na na na naLead na na na na na na na na



97,778 scfm97,778 dscfm

** Control efficiencies based on Minn. R. 7011.0070. EU 089 is controlled by CE 031 (packed gas adsorption column).PM control efficiency for packed gas adsorption column is 85%PM10 control efficiency for packed gas adsorption column is 84%Hormel conservatively assumed that the venturi scrubber would not control PM2.5 emissionsThere is no listed control efficicency for VOCs for venturi scrubbers.



94,286 scfm94,286 dscfm


AQD Facility ID: 09900002Facility Name: Hormel FoodsEmission Unit EU 092 Refined Products MAU 1Stack/Vent Designation Number: SV 062Maximum Rated Capacity: 4.9 million BTU/hrControl Equipment: naFuel ParamatersFuel Type Natural Gas ONLY No secondary fuelHeat Value: 1020 Btu/cfFuel Consumption Rate: 4800 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr



(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 0.036 0.16 0.00 0.036 0.16 naPM10 7.60 0.036 0.16 0.00 0.036 0.16 naPM2.5 7.60 0.036 0.16 0.00 0.036 0.16 naSOX 0.60 0.003 0.0126 0.00 0.0029 0.0126 naNOX 100.00 0.480 2.10 0.00 0.48 2.10 naVOC 5.50 0.026 0.12 0.00 0.026 0.12 naCO 84.00 0.403 1.77 0.00 0.40 1.77 naLead 5.00E 04 2.40E 06 1.05E 05 0.00 2.40E 06 1.05E 05 na




































This unit qualifies as an Insignificant Activity under Minn. R. 7007.1300 Subp. 3(I): <2 tons CO, < 1 ton NOx, SO2, PM/PM10, VOC, and <1000 ton CO 2 e

AQD Facility ID: 09900002Facility Name: Hormel FoodsEmission Unit Refined Products MAU 4Stack/Vent Designation Number: IAMaximum Rated Capacity: 0.606 million BTU/hrControl Equipment: naFuel Parameters:Fuel Type Natural Gas ONLY No secondary fuelHeat Value: 1020 Btu/cfFuel Consumption Rate: 594 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr



(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 4.52E 03 0.02 0.00 4.52E 03 0.02 naPM10 7.60 4.52E 03 0.02 0.00 4.52E 03 0.02 naPM2.5 7.60 4.52E 03 0.02 0.00 4.52E 03 0.02 naSOX 0.60 3.56E 04 1.56E 03 0.00 3.56E 04 1.56E 03 naNOX 100.00 5.94E 02 0.26 0.00 5.94E 02 0.26 naVOC 5.50 3.27E 03 0.01 0.00 3.27E 03 0.01 naCO 84.00 4.99E 02 0.22 0.00 4.99E 02 0.22 naLead 5.00E 04 2.97E 07 1.30E 06 0.00 2.97E 07 1.30E 06 na



(lbs/MMcf)a (lbs/hr) (tons/yr) (%) (lbs/hr) (tons/yr) (tons/yr)Benzene (71 43 2) 2.1E 03 1.2E 06 5.46E 06 0.0 1.2E 06 5.5E 06 naDichlorobenzene (25321 22 6) 1.2E 03 7.1E 07 3.12E 06 0.0 7.1E 07 3.1E 06 naFormaldehyde (50 00 0) 7.5E 02 4.5E 05 1.95E 04 0.0 4.5E 05 2.0E 04 naHexane (110 54 3) 1.8E+00 1.1E 03 4.68E 03 0.0 1.1E 03 4.7E 03 naNaphthalene (91 20 3)b 6.1E 04 3.6E 07 1.59E 06 0.0 3.6E 07 1.6E 06 naToluene (108 88 3) 3.4E 03 2.0E 06 8.85E 06 0.0 2.0E 06 8.8E 06 naPolycyclic Organic Matter (POM)c 8.6E 05 5.1E 08 2.25E 07 0.0 5.1E 08 2.2E 07 naArsenic (7440 38 2) 2.0E 04 1.2E 07 5.20E 07 0.0 1.2E 07 5.2E 07 naBeryllium (7440 41 7) 1.2E 05 7.1E 09 3.12E 08 0.0 7.1E 09 3.1E 08 naCadmium (7440 43 9) 1.1E 03 6.5E 07 2.86E 06 0.0 6.5E 07 2.9E 06 naChromium (7440 47 3) 1.4E 03 8.3E 07 3.64E 06 0.0 8.3E 07 3.6E 06 naManganese (7439 96 5) 3.8E 04 2.3E 07 9.89E 07 0.0 2.3E 07 9.9E 07 naMercury (7439 97 6) 2.6E 04 1.5E 07 6.77E 07 0.0 1.5E 07 6.8E 07 naNickel (7440 02 0) 2.1E 03 1.2E 06 5.46E 06 0.0 1.2E 06 5.5E 06 naSelenium (7782 49 2) 2.4E 05 1.4E 08 6.25E 08 0.0 1.4E 08 6.2E 08 naTotals 1.12E 03 4.91E 03 1.12E 03 4.91E 03




(lbs/MMBtu)d (lb/hr) (%) (lbs/hr) (tons/yr) (tons/yr)CO2 1 116.89 70.83 0.00 70.835 310.26 naCH4 21 2.20E 03 1.34E 03 0.00 1.34E 03 5.85E 03 naN2O 310 2.20E 04 1.34E 04 0.00 1.34E 04 5.85E 04 naTotal GHG (CO2e) 70.9 310.6 nad Emission Factors obtained from 40 CFR 98. Converted from kg to lb.



This unit qualifies as an Insignificant Activity under Minn. R. 7007.1300 Subp. 3(I): <2 tons CO, < 1 ton NOx, SO2, PM/PM10, VOC, and <1000 ton CO 2 e

Emission Unit Refined Products RTU 1Stack/Vent Designation Number: IAMaximum Rated Capacity: 0.105 million BTU/hrControl Equipment: naFuel Parameters:Fuel Type Natural Gas ONLY No secondary fuel% sulfur na% ash naHeat Value: 1020 Btu/cfFuel Consumption Rate: 103 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr



(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 7.82E 04 3.43E 03 0.00 7.82E 04 3.43E 03 naPM10 7.60 7.82E 04 3.43E 03 0.00 7.82E 04 3.43E 03 naPM2.5 7.60 7.82E 04 3.43E 03 0.00 7.82E 04 3.43E 03 naSOX 0.60 6.18E 05 2.71E 04 0.00 6.18E 05 2.71E 04 naNOX 100.00 1.03E 02 4.51E 02 0.00 0.01 4.51E 02 naVOC 5.50 5.66E 04 2.48E 03 0.00 5.66E 04 2.48E 03 naCO 84.00 8.65E 03 3.79E 02 0.00 0.01 3.79E 02 naLead 5.00E 04 5.15E 08 2.25E 07 0.00 5.15E 08 2.25E 07 na







(lbs/MMBtu)d (lb/hr) (%) (lbs/hr) (tons/yr) (tons/yr)CO2 1 116.89 12.3 0.00 12.3 54 naCH4 21 2.20E 03 2.31E 04 0.00 2.31E 04 1.01E 03 naN2O 310 2.20E 04 2.31E 05 0.00 2.31E 05 1.01E 04 naTotal GHG (CO2e) 12.3 53.8 nad Emission Factors obtained from 40 CFR 98. Converted from kg to lb.



This unit qualifies as an Insignificant Activity under Minn. R. 7007.1300 Subp. 3(I): <2 tons CO, < 1 ton NOx, SO2, PM/PM10, VOC, and <1000 ton CO 2 eEmission Unit Refined Products RTU 2Stack/Vent Designation Number: IAMaximum Rated Capacity: 0.24 million BTU/hrControl Equipment: naFuel Parameters:Fuel Type Natural Gas ONLY No secondary fuel% sulfur na% ash naHeat Value: 1020 Btu/cfFuel Consumption Rate: 235 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr



(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 1.79E 03 0.01 0.00 1.79E 03 0.01 naPM10 7.60 1.79E 03 0.01 0.00 1.79E 03 0.01 naPM2.5 7.60 1.79E 03 0.01 0.00 1.79E 03 0.01 naSOX 0.60 1.41E 04 6.18E 04 0.00 1.41E 04 6.18E 04 naNOX 100.00 2.35E 02 0.10 0.00 2.35E 02 0.10 naVOC 5.50 1.29E 03 0.01 0.00 1.29E 03 0.01 naCO 84.00 1.98E 02 0.09 0.00 1.98E 02 0.09 naLead 5.00E 04 1.18E 07 5.15E 07 0.00 1.18E 07 5.15E 07 na










This unit qualifies as an Insignificant Activity under Minn. R. 7007.1300 Subp. 3(I): <2 tons CO, < 1 ton NOx, SO2, PM/PM10, VOC, and <1000 ton CO 2 eEmission Unit Refined Products ERV 1Stack/Vent Designation Number: IAMaximum Rated Capacity: 0.1 million BTU/hrControl Equipment: naFuel Parameters:Fuel Type Natural Gas ONLY No secondary fuel% sulfur na% ash naHeat Value: 1020 Btu/cfFuel Consumption Rate: 98 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr



(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 7.45E 04 3.26E 03 0.00 7.45E 04 3.26E 03 naPM10 7.60 7.45E 04 3.26E 03 0.00 7.45E 04 3.26E 03 naPM2.5 7.60 7.45E 04 3.26E 03 0.00 7.45E 04 3.26E 03 naSOX 0.60 5.88E 05 2.58E 04 0.00 5.88E 05 2.58E 04 naNOX 100.00 9.80E 03 4.29E 02 0.00 9.80E 03 4.29E 02 naVOC 5.50 5.39E 04 2.36E 03 0.00 5.39E 04 2.36E 03 naCO 84.00 8.24E 03 3.61E 02 0.00 8.24E 03 3.61E 02 naLead 5.00E 04 4.90E 08 2.15E 07 0.00 4.90E 08 2.15E 07 na










This unit qualifies as an Insignificant Activity under Minn. R. 7007.1300 Subp. 3(I): <2 tons CO, < 1 ton NOx, SO2, PM/PM10, VOC, and <1000 ton CO 2 eEmission Unit Refined Products ERV 2Stack/Vent Designation Number: IAMaximum Rated Capacity: 0.1 million BTU/hrControl Equipment: naFuel Parameters:Fuel Type Natural Gas ONLY No secondary fuel% sulfur na% ash naHeat Value: 1020 Btu/cfFuel Consumption Rate: 98 cf/hrSource of Emission Factors: AP 42 Chapter 1.4 0.3 100 MMBtu/hr



(tpy) (%) (lbs/hr) (tons/yr) (tons/yr)PM 7.60 7.45E 04 3.26E 03 0.00 7.45E 04 3.26E 03 naPM10 7.60 7.45E 04 3.26E 03 0.00 7.45E 04 3.26E 03 naPM2.5 7.60 7.45E 04 3.26E 03 0.00 7.45E 04 3.26E 03 naSOX 0.60 5.88E 05 2.58E 04 0.00 5.88E 05 2.58E 04 naNOX 100.00 9.80E 03 4.29E 02 0.00 9.80E 03 4.29E 02 naVOC 5.50 5.39E 04 2.36E 03 0.00 5.39E 04 2.36E 03 naCO 84.00 8.24E 03 3.61E 02 0.00 8.24E 03 3.61E 02 naLead 5.00E 04 4.90E 08 2.15E 07 0.00 4.90E 08 2.15E 07 na









Attachment 3:CAM Plans

CAM SubmittalHormel Foods Corporation/QPP AustinApril 13, 2011

I. Background

A. Emission UnitDescription: Rendering Room AirIdentification: EU027APCD ID: CE008, Packed Gas Adsorption ColumnFacility: Austin, Minnesota

B. Applicable Regulation, Emissions Limit, and Monitoring RequirementsRegulation: Title I Condition: To limit potential PM emissions to less than major source levels

as defined by 40 CFR 52.21; Minn. R. 7007.3000, meets requirements of Minn.R. 7011.0715, subp. 1(A)

Emission Limits:Particulate Matter (PM): 8.38 lb/hr (based on state process equipment rule)PM10: 8.38 lb/hr (based on state process equipment rule)Monitoring Requirements: Pressure differential, water flow rates and quarterly inspections

C. Control TechnologyPacked Gas Adsorption Column

II. Monitoring ApproachThe key elements of the monitoring approach are presented in the table below:

Indicator No. 1 Indicator No. 2 Indicator No. 3I. Indicator MeasurementApproach

Pressure Differential Water Flow Rate Work Practice

II. Indicator Range A deviation is defined aspressure differential lessthan 5 inches w.c.Deviations trigger aninspection, corrective action,and a reportingrequirement.

A deviation is defined as awater flow rate less than100 gal/min. Deviationstrigger an inspection,corrective action, and areporting requirement.

A deviation is defined asfailure to perform inspectionquarterly or at thefrequency prescribed by themanufacturer.

Performance Criteriaa. Data Representativeness

Not applicable Not applicable Not applicable

b. Verification ofOperational Status

The monitoring equipmentmust be in use and properlymaintained when CE 008 isin operation.

The monitoring equipmentmust be in use and properlymaintained when CE 008 isin operation.

Not applicable

c. QA/QC Practices andCriteria


d. Monitoring Frequency Instantaneous. The pressuredifferential is recorded onceeach day when in operation.

Instantaneous. The waterflow rate is recorded onceeach day when in operation.

Inspection of the controlequipment componentsquarterly or at thefrequency prescribed by themanufacturer.

Data Collection Procedures The operator records the The operator records the Record results quarterly or

pressure drop and whetheror not the reading waswithin the range specifiedonce per day when inoperation.

water flow rate and whetheror not the reading waswithin the range specifiedonce per day when inoperation.

at the frequency prescribedby the manufacturer.

Averaging Period Not applicable Not applicable Not applicable

III. Basis and ImplementationThe proposed monitoring approach is based on the currently applicable requirements.The data listed in the monitoring approach is already addressed in the current permit and the facility airpollution control equipment maintenance plan.

IV. Rationale for Selection of Indicator RangesIndicator ranges for the pressure differential and water flow rate have been developed based on themanufacturer’s design operating guidelines.

CAM SubmittalHormel Foods Corporation/QPP AustinMay 10, 2011

I. Background

A. Emission UnitDescription: Regenerative Thermal OxidizerIdentification: EU028, 036, 050APCD ID: CE026Facility: Austin, Minnesota

B. Applicable Regulation, Emissions Limit, and Monitoring RequirementsRegulation: Title I Condition: To limit potential PM emissions to less than major source levels

as defined by 40 CFR 52.21; Minn. R. 7007.3000; meets requirements of Minn.R. 7011.0715, subp. 1(A)

Emission Limits:Particulate Matter (PM): 6.37 lb/hr (based on state process equipment rule)PM10: 6.37 lb/hr (based on state process equipment rule)Monitoring Requirements: Regenerative thermal oxidizer combustion chamber

temperature and annual inspections.

C. Control TechnologyRegenerative Thermal Oxidizer


Indicator No. 1 Indicator No. 2I. Indicator Measurement Approach Combustion chamber temperature Work practice

The combustion chamber temperatureis monitored with a thermocouple.

Inspection and maintenance of theburner.

II. Indicator Range An excursion is defined as temperaturereadings less than 1350 deg F.Excursions trigger an inspection,corrective action, and a reportingrequirement.

An excursion is defined as failure toperform an annual inspection.


The sensor is located in the incineratorchamber as an integral part of thedesign. The minimum tolerance of thethermocouple is ±10.0 deg F or ±0.75%.

Not applicable

b. Verification of Operational Status Not applicable Not applicablec. QA/QC Practices and Criteria Accuracy of the thermocouple will be

verified by a second or redundantthermocouple probe inserted into theincinerator chamber with a hand heldmeter. The validation check will beconducted at least annually.

Not applicable

d. Monitoring Frequency Measured continuously Annual inspection of the burnerData Collection Procedures Recorded continuously on a chart Record results of annual inspection.

recorder.Averaging Period No average is taken. Not applicable

III. Basis and ImplementationThe proposed monitoring approach is based on the currently applicable requirements.The data listed in the monitoring approach is already addressed in the enclosed permit application.

IV. Rationale for Selection of Indicator RangesThe incinerator chamber temperature was selected because it is indicative of a thermal incineratoroperation. If the chamber decreases significantly, complete combustion may not occur.The work practice comprised of an annual inspection and tuning of the incinerator burner was selectedbecause an inspection verifies equipment integrity and periodic tuning will maintain proper burneroperation and efficiency.Indicator ranges for the combustion chamber temperature has been developed based on themanufacturer’s design operating guidelines.

CAM SubmittalHormel Foods Corporation/QPP AustinFebruary 2013

I. Background

A. Emission UnitDescription: Refined Products MachineryIdentification: EU088APCD ID: CE026, Regenerative Thermal Oxidizer (previously permitted)

CE027, Venturi ScrubberCE028, Packed Gas Adsorption Column

Facility: Austin, Minnesota

B. Applicable Regulation, Emissions Limit, and Monitoring RequirementsRegulation: Title I Condition: To limit potential PM, PM10 and VOC emissions to less than

major source levels as defined by 40 CFR 52.21; Minn. R. 7007.3000; meetsrequirements of Minn. R. 7011.0715, subp. 1(A)

Emission Limits:Particulate Matter (PM): 0.97 lb/hrPM10: 0.97 lb/hrVOC: 0.97 lb/hrMonitoring Requirements: Regenerative thermal oxidizer (CE026) combustion chamber

temperature and annual inspections.Venturi scrubber (CE027) pressure differential, water flow ratesand quarterly inspections.Packed gas adsorption column (CE028) pressure differential,water flow rates and quarterly inspections.

C. Control TechnologyRegenerative Thermal Oxidizer, Venturi Scrubber, Packed Gas Adsorption Column


Regenerative Thermal Oxidizer (CE026)Indicator No. 1 Indicator No. 2

I. Indicator MeasurementApproach

Combustion chamber temperature Work pracitceThe combustion chamber temperature ismonitored with a temperature probe.

Inspection and maintenance of the burner asrecommended by the manufacturer

II. Indicator Range A deviation is defined as temperaturereadings less than 1350 deg F. Deviationstrigger an inspection, corrective action,and a reporting requirement.

A deviation is defined as failure to performannual inspection.


The sensor is located in the incineratorchamber as an integral part of the design.The minimum tolerance of thetemperature probe is ±2.5 deg C or ±4.5deg F.

Not applicable

b. Verification of OperationalStatus

Not applicable Not applicable


Calibration or replacement of thetemperature monitoring device shall bedone at least once per year.

Not applicable

d. Monitoring Frequency Measured continuously. “Continuous” or“Continuously” means to measure andrecord at least one data point every 15minute block time interval starting on thehour.

Annual inspection of the burner.

Data Collection Procedures Shall maintain on site a record of thetemperature in the combustion chamberwhen the thermal oxidizer is in operation.The record may be in the form ofelectronic computer files or in the form ofa chart recording.

Record results of annual inspection.

Averaging Period 3 Hour Rolling Average Not applicable

Venturi Scrubber (CE027)Indicator No. 1 Indicator No. 2 Indicator No. 3



II. Indicator Range A deviation is defined aspressure differential less than4.0 inches w.c. Deviationstrigger an inspection,corrective action, and areporting requirement.

A deviation is defined as awater flow rate less than 50gal/min. Deviations triggeran inspection, correctiveaction, and a reportingrequirement.





The monitoring equipmentmust be in use and properlymaintained when CE027 is inoperation.


Not applicable






Data Collection Procedures The operator records thepressure drop and whether ornot the reading was withinthe range specified once perday when in operation.

The operator records thewater flow rate and whetheror not the reading waswithin the range specifiedonce per day when inoperation.

Record results quarterly orat the frequency prescribedby the manufacturer.

Averaging Period No average is taken. No average is taken. Not applicable

Packed Gas Adsorption Column (CE028)Indicator No. 1 Indicator No. 2 Indicator No. 3



II. Indicator Range A deviation is defined as A deviation is defined as a A deviation is defined as

pressure differential less than2.0 inches w.c. Deviationstrigger an inspection,corrective action, and areporting requirement.

water flow rate less than120 gal/min. Deviationstrigger an inspection,corrective action, and areporting requirement.

failure to perform inspectionquarterly or at thefrequency prescribed by themanufacturer.






Not applicable











IV. Rationale for Selection of Indicator RangesThe incinerator chamber temperature was selected because it is indicative of a thermal incineratoroperation. If the chamber decreases significantly, complete combustion may not occur.The work practice comprised of an annual inspection and turning of the incinerator burner was selectedbecause an inspection verifies equipment integrity and periodic tuning will maintain proper burneroperation and efficiency.Indicator specified minimum values for the pressure differential and water flow rate for the venturiscrubber have been developed based on the manufacturer’s design operating guidelines.Indicator specified minimum values for the pressure differential and water flow rate for the packed gasadsorption column have been developed based on the manufacturer’s design operating guidelines.

CAM SubmittalHormel Food Corporation/QPP AustinFebruary 2013

I. Background

A. Emission UnitDescription: Crax Room AirIdentification: EU089APCD ID: CE029, Venturi Scrubber

CE030, Packed Gas Adsorption ColumnFacility: Austin, Minnesota

B. Applicable Regulation, Emissions Limits, and Monitoring RequirementsRegulation: Title I Condition: To limit potential PM and PM10 emissions to less than major

source levels as defined by 40 CFR 52.21; Minn. R. 7007.3000; meetsrequirements of Minn. R. 7011.0715, subp. 1(A)

Emission Limits:Particulate Matter (PM): 2.01 lb/hrPM10: 2.01 lb/hrMonitoring Requirements: Venturi scrubber (CE029) pressure differential, water flow rates

and quarterly inspections.Packed gas adsorption column (CE030) pressure differential,water flow rates and quarterly inspections.

C. Control TechnologyVenturi Scrubber, Packed Gas Adsorption Column


Venturi Scrubber (CE029)Indicator No. 1 Indicator No. 2 Indicator No. 3

I. Indicator MeasuringApproach










Not applicable



d. Monitoring Frequency Instantaneous. The pressure Instantaneous. The water Inspection of the control

differential is recorded onceeach day when in operation.

flow rate is recorded onceeach day when in operation.

equipment componentsquarterly or at thefrequency prescribed by themanufacturer.
















Not applicable











IV. Rationale for Selection of Indicator RangesIndicator specified minimum values for the pressure differential and water flow rate for the venturescrubber have been developed based on the manufacturer’s design operating guidelines.Indicator specified minimum values for the pressure differential and water flow rate for the packed gasadsorption column have been developed based on the manufacturer’s operating guidelines.

CAM SubmittalHormel Foods Corporation/QPP AustinFebruary 2013

I. Background

A. Emission UnitDescription: Refined Products Room AirIdentification: EU091APCD ID: CE031, Packed Gas Adsorption ColumnFacility: Austin, Minnesota

B. Applicable Regulation, Emissions Limit, and Monitoring RequirmentsRegulation: Title I Condition: To limit potential PM and PM10 emissions to less than

major source levels as defined by 40 CFR 52.21; Minn. R. 7007.3000;meets requirements of Minn. R. 7011.0715, subp. 1(A)

Emission Limits:Particulate Matter (PM): 8.38 lb/hrPM10: 8.38 lb/hrMonitoring Requirements: Pressure differential, water flow rate and quarterly

inspections

C. Control TechnologyPacked Gas Adsorption Column






A deviation is defined as awater flow rate less than1,000 gal/min. Deviationstrigger an inspection,corrective action, and areporting requirement.







Not applicable











IV. Rationale for Selection of Indicator RangesIndicator specified minimum values for the pressure differential and water flow rate have beendeveloped based on the manufacturer’s design operating guidelines.

Attachment 4:Points Calculator

Points Calculator

1) AQ Facility ID No.: 418 Total Points 352) Facility Name: Hormel Foods Corporation/QPP - Austin3) Small business? y/n? n4) DQ Numbers (including all rolled) : 43035) Date of each Application Received: 2/22/20136) Final Permit No. 09900002-0117) Permit Staff Tarik Hanafy

8) "Work completed" in which .xls file (i.e. unit 2b, unit 1a, biofuels)? na

TotalApplication Type DQ No. Qty. Points Points DetailsAdministrative Amendment 1 0Minor Amendment 4 0Applicability Request 10 0Moderate Amendment 15 0Major Amendment 4303 1 25 25Individual State Permit (not reissuance) 50 0Individual Part 70 Permit (not reissuance) 75 0

Additional PointsModeling Review 15 0

BACT Review 15 0LAER Review 15 0CAIR/Part 75 CEM analysis 10 0NSPS Review 10 0NESHAP Review 10 0Case-by-case MACT Review 20 0Netting 10 0Limits to remain below threshold 4303 1 10 10 to avoid PSDPlantwide Applicability Limit (PAL) 20 0AERA review 15 0Variance request under 7000.7000 35 0Confidentiality request under 7000.1300 2 0EAW reviewPart 4410.4300, subparts 18, item A; and 29 15 0Part 4410.4300, subparts 8, items A & B; 10, items A to C; 16, items A & D; 17, items A to C & E to G; and 18, items B & C

35 0

Part 4410.4300, subparts 4; 5 items A & B; 13; 15; 16, items B & C; and 17 item D

70 0

Add'l Points 10

NOTES:

(DQ DQ#)

Date post:	23-Feb-2022
Category:	Documents
Upload:	others
View:	1 times
Download:	0 times

Air Emission Permit No. 09900002-011 is Issue to Hormel ...

Documents