tEU Application - kurther Information Request - October 2015
AlTACHMENT NO. 3
INFORMATION ON CONTINUOUS DUST MONITORS
BAILIEBORO FOODS LIMITED
FURTHER INFORM ATlON RESPONSE
ON APPLICATION FOR
INDUSTRIAL EMISSIONS ACTIVITIES LICENCE REVIEW
ATACHMENT NO. 3 Ballieboro Foods Limited Lear, Bailieborough, Co. Cavan
Fo
r ins
pecti
on pu
rpos
es on
ly.
Cons
ent o
f cop
yrigh
t own
er req
uired
for a
ny ot
her u
se.
EPA Export 10-08-2018:03:51:10
. :- %
1
L DT770 & DT270 - - PRODUCT DATA SHEET c PARTICULATE MONITORING SYSTEMS v) 3 5 n z
ACCREDITED DUST MONITOR
Continuous particulate emissions monitoring and recording system comprising probe and combined con fro1 unit/microprocessor-based da tdogger
Full report and analysis facility by linking to any PC and printer +
Up to 4 channels of dust monitoring via expansion modu!e
Capable of monitoring in dry, humid and wet gas streams using patented insulated probe option
Enhanced measurement through unique Electrodynamic@ technology
Continuous quantitative monitoring in m g h 3 to satisfy U.K. and European Environmental Legislation
WpUonal on DT270
Fo
r ins
pecti
on pu
rpos
es on
ly.
Cons
ent o
f cop
yrigh
t own
er req
uired
for a
ny ot
her u
se.
EPA Export 10-08-2018:03:51:10
The OT2701770 utilises PCME's unlque Electrcdynamie measurement principle. When the senslng probe Is installed In the duct or stack, padicles in the air stream interact with the senslng rod and 8 charge induction athct is anafysed from the probe. Distributions in the partlde stream result in a frequency charge induction response, whlch is dlrectly proportIona1 to the concentratlon of particulate. Unlike Triboelectrfc systems the measurement Is not affected by build up on the probe, which can cause zero and calibration drift. Very Low Dust concentrations can also be measured due to this unlque ElectmdynamlP bchnlque.
Various independent laboratories have vatidated this nlationshlp.
PCME's ElectrodynamP technlque also enabtes the use of fully Insulated probes essential for use In high humidity and wet gas streams as well as applicatbns with hlgh conductlve dust foadlngs.
.. .
.
The DT770 8r DT270 calculates and records both the TEPA avemges (EPA mode) and Instantaneous levels of emissions ( P m s s Control Mode). The Instrument is calibrated to quantitatively monitor In mglm%, by comparison with the results of an lsokinetic Sample. BROKEN BAG MODE
Graphlcally displays filter cleaning cycle (Broken Bag Mode) Permlts anticlpatlon of arrestment plant failure Assists diagnosis of location of broken bags
tEPA MODE Calculates and records average emissions In mglrn' for up to 24 hours using 30 second averages and up to 600 days (if using I hour averages)
Instantaneous and €PA REPORT BROKEN BAQ MODE average emission timits, Instrument faults and .
Downloads data to standard PC (including laptop and notebook computers) EPA Reporter software produces B
EFA report
PROCESS CONTROL MODE Stores lnstantaneous emlsslon lor past 24 hours Emissions can be mvtewed using on-board graphical display for effective trend analysis PC connectable (laptop and notebook computers) for emission display and analysis In real time
Activates alarms on
110 1w memory full condltlon 90
3 ; 1 l 1 1 1 1 1 % E
30
to 0
+--I--+- m
14- ism iom IIDOB iaDec iemc 20m 2 1 m IIM 11AO I t 1 2 I t 1 4 I1:18 11:18 3 Wpnlng C+aadflb comprehenslve graphics DayfYear I9W (OD Mth)
) *
# Environmental and Process Control modes Unlque graphlcs and digltal display (for trend anatysis) Automatic zero, span, probe contamlncrtion and system checks Records born +EPA data and Instantaneous data (for process control) Broken bag dlagnostlcs (remote broken bag dragnostics optlonal) Full on-bard review feature Rewrds data from other monltors
Autoranglng capsbllity # Simple calibration mode after isokinetic sampling
Expandable to 4 sensors Secure data and password protectlon lnterllnks wlth EPA Reporter reporting and enalysls software for on-line control and historical reprtlng uslng PC 24 hour memory t i 8 month memory capability
Dynatrack Instrument automatically adjusts it's dynamic range to track fast moving dust pulses (typically found affer reverse jet cleaning baghouses) to ensure good measurement
AOC The instrument automatically adjusts its gain control to suit varying dust loading appllcatlons (no need b r user to adjust gain controts or potentiometers)
AZC Automatic Zero Compensatlon eliminates drift due to frequency driven signal processing. Alpha check Inbuilt system check, processor driven for system integrity 3eta cheek Digital communication check for sensor integrlty ECD Inbuilt Error Code Diagnostics visually dlsplayed for user information Gamma check Instrument zero, span and probe short clrcuit cheek
Fo
r ins
pecti
on pu
rpos
es on
ly.
Cons
ent o
f cop
yrigh
t own
er req
uired
for a
ny ot
her u
se.
EPA Export 10-08-2018:03:51:10
I . .. .- , . ' 7
Y
' Control Module Expanslon Module Enclosure rating lP65 iP65 Enclosure sire (mm) 16oW x 9Od x 260 I 16GwxOWx3601 Encfosure welght 3kg 4.5kg Enclosure material Dle-casl aluminium (epoxy-coated) Die-cast alumlnlum (epoxy-mated) Power supply (switchable) Fuse rating 250mA 250mA Oisplay type Backllt LCD provldlng numerical NIA
&.
11 OVac or 230Vac 50Hz MOH2 1 OVA 11 OVac or 230Vae SOHzl6OHz
InputslOutputs (per channel)
. .
Temperature range (electronics) No. of dust channels
I Unit
and graphical dlsplay -25'C to *55'C 1 Up to an additlonal3
-2572 to +55'C
Enclosure temperature rat1i-y Endosure ratlng Sensor rod material
Air purge option
Alr consumption Alr pressure
Special
Airline connection
Sensor melosure material Cable from Sensor Cable length
-25'C to * W C IP65 31 6 stainless steel Fully insulated Sensw'
Yr" BSP Up to 0.5 litreslmln 4 b a g mln, 10 b a g max Dimst atumlnlum {ewwaated) 8-core screened 10 m standard : 300m max
Resolution co.oi r n ~ r n 3 Response tlme Self checks
4 0 seconds for 05% change (user selectable) Automatlc zem, span and probe short-clrcult checks
Sensors & Cables I- I Standard bmperature upto 250°C Optional upto 400°C
upto mo*c Over 8WC eclnsult factory
Sensor lengths 100,200,300,400, 500,600,
Cms-stack probes* 800, to00 8 1500mm.* F m 2ooo to 6000mm avai lm on appllcation
Endosure weight 1.8 !q .- I opllonal exira
N.B. t Refera lo optha avallable on Dl770 onty
Fo
r ins
pecti
on pu
rpos
es on
ly.
Cons
ent o
f cop
yrigh
t own
er req
uired
for a
ny ot
her u
se.
EPA Export 10-08-2018:03:51:10
- - . .-
.-
PRODUCT DATA SHEET DT770 & DT270
Control Module
IJJ Personal Computer
I
Expansion Module
4-20mA For connection details, refer to lnstallatlon and User Manual
P# Upto 2wc Upto 890-C
CONTROL UNIT EXPANSION UNIT SENSOR UNIT AND CABLE (Sped$ for each channel)
x1 x: 5 - X I x
MT: 115Vac = 1 2 3 W = 2 Special = 2
Cable length In metre3 (lOm standard) 3OOm max -raturn: upto +250'G
upao t4WC uplo em%
Duet Uiametet In mm Air p u s : MO alr purge = N
Air purge = AP Matedal: Standard S
Insulated. t S m a l = Z
270or 770
-Total Number of Channels:
no 01 770
expadon unit (1 to 3) (see wnnecllon schfmwk]
270 or 770
About PCME PCME Is a world leader h particulate measurement. The company prduces equipment for both emlsslons monitorlng, process control and sollds ffow monitoring. A dedicated team of qualified appllcatlon and sales englneers is always on hand and should be mnsulted in the selectlon and usage of the most sultable equlpment for any partlwlate appllcatlon.
Contect your naiional or area sales a d serviw o f h PCME Ltd PCME Inc Cleawlew Building, Edlson Road 9324 Qulfstream Road, West Unit St. Ives, Cambs PEV 4GH Frankort, IL 60423-0423. USA Tel: Int +44 (0)1480 46.8200 Tel: *I 81 5 464 8705 Fax: Int + 44 (0)1480 463400 Fax: +I a i 5 464 871 7 E-mall: [email protected] E-rnall: sales@?pmaInc.com www.pcrne.co.uk ww.pcmaine.eom
PC#E products are the subject of worldwide patents. Due ia the contlnulng pmducl development programme, PCME remm the &ht to c h a w Issue m€J m y specikations wilhout prior notiw.
Fo
r ins
pecti
on pu
rpos
es on
ly.
Cons
ent o
f cop
yrigh
t own
er req
uired
for a
ny ot
her u
se.
EPA Export 10-08-2018:03:51:10
mailto:[email protected]:sales@?pmaInc.comhttp://www.pcrne.co.uk
