2. ECN Category (mark om)
Supplemental 11 Dired Revision 1x1 Change ECN [I Temporary II Standby II Supersedure II CanceliVoid II
6623 1 7 .--- .................................... h l . ECN
12a. Modification Work 12b. Work Package NO.
[] Yes (fill out Blk. 1Zb)
12c. Modification Work Comp
[XI No (NABlks. lZb, 12c. 12d)
Design AUfhoritylCog. Engineer Design AuthoritylCag. Engineer Signature &Date Signature & Date
I N/A I N/A
N/A
Addition of Web Strap to CGI and modifications to references.
USQ Approval: C V D - 0 0 - r 5 9 7 9 p:41 14a. Justification (mark m e )
3ritwia Change[] Design Improvement[X] Environmental[] Facility Deadiuation[]
I\s-l’ound[] Facilitate const[] Const. ErrorlOmission[] Design Error/Omission[]
14b. Justification Details
Provides additional support for SCHe Bottles. Updated references to reflect current documentation.
The design verification method for SS/SC components is by independent review in accordance with EN-6-027-01 Docurncntation of this review is accomplished by the independent reviewcr
See distribution sheet.
re on page 2 of this ECN. siunatu a p m 15. Dislribution (include name, MSIN, and no. of copies)
wle STk
A-780C-01 kl
Pago 2 of 2 6623 17
CONSTRUCTION I 16. Design
compu*rsoRware
[I [I lnvmtory Adjvstnrnf Kcquest [I Ennronmmnlal PSmUf
20. m e r Affected Documents: (NOTE: Documents listed below will not be revised by lhis ECN.) Signatures below
indicate that the signing organization has been notified of other affected documents listed below. Document NumberlRevision Document NumbcrlRevision
NA
Date
Signature or a Control Number that tracks the Approval Signdlure
ADDITIONAL ~
Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
Prepared for the US. Department of Energy Assistant Secretary for Environmental Management
Project Hanford Management Contractor for the U.S. Department of Energy under Contract DE-AC06-96RL13200
P.O. Box 1000 Richland, Washington
Fluor H anford
- ~
Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
Project No: W-441
FH
Date Published September 2000
Prepared for the US. Department of Energy Assistant Secretary for Environmental Management Project Hanford Management Contractor for the U.S. Department of Energy under Contract DE-AC06-96RLI3200
P.O. Box 1000 Richland, Washington
Fluor Hanf ord
-
SNF-4880 Revision 1
TRADEMARK DISCLAIMER Reference nere n to anr sPecif8c commerc.al Dioa.cI Process or sewice by trade name, trademark, manufacturer, or otherwise, does not necessarily constitute or imply its endorsement, recommendation, or favoring by the United States Government or any agency thereof or its contractors or subcontractors.
This report has been reproduced from the best available copy.
Prinled m the United Stater Of Amsnca
Total Pages: I3
(3) Revision
Authorized for Release
(5) Cog. Engr. (6) Cog. Mgr. Date (4) Description of Change - Replace, Add, and Delete Pages
(7) EDT 626321, INITIALLY RELEASED C. Miska T. Choho
I i I
.... . . . .
Page 1 of 9
Item No.: NIA I Manufacturer: NIA I Supplier: NIA Mfg. Pa#Model No.: NIA
Part Description: NIA I Supplier's P/N: NIA
Equipment No.: Specification No.: Manufacturer: Past P.O. No.: Seismic Restraint Cables and Web SNF-5304 McMaster Carr NIA Straps for SCHe supply bottles to the Helium process system. Procurement and/or Model No.: Cable Restraint: 30785T5 (Dwg. H- l - 82367, Item 72) Web: 8842T18 Component Description: This seismic restraint cable fits the neck of the SCH helium supply bottle to limit bottle motion
(W-441-P5)
Equipment Supplier (if different from manufacturer): Equip. Supplier's Part No.: Apollo NIA
in the event,of a Sejsmic,Event., The web strap is for the seismic . . . . . . . . . . . . . . . . . . . . . . . . . . stand and has a ratchettensioning buckle. . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . S W O " Commercial. A"!l!?k.'ty2?-??? !tern.. -- .. . . . . . . . . . . . . . . . . . . . . .....................
1. Is the Item available from a catalogue from a qualified NQAl supplier or IS0 9000 supplier (coordinate with project CGI interface Engineer or BTR)? [ ] YES (go to#2 below) [ X I NO (go to procedure step 6.3.2, proceed to dedicate Item) If not available from a qualified NQAI supplier, is it available from an IS0 9000 supplier? (coordinate w/ project CGI Interface ~ Engineer ~ or ~ BTR): ~ 1 1 YES (go to ~~ #2 ~~~~~~~~~~~~~~~~~ below, dedicate Item) [ X NO (dedicate ~~~ Item) . ~~
~ ~~ ~~~~~~~~~~ ~ ~~~~~~~~~~~~~~~~~ ~~~~~~~ ~~~~~~~~ ~ ~~~~
: Recornmendeo Proc-rcrnent Stratcgy(cooro nale w in pro.ec1 CGI interface Eng neer or BTR) NIA Section 2c CG Determtnaton
CGI Determination Questions:
#I : Is the Item subject to design or specification requirements that are unique to nuclear facilities or activities? [ ] YES (the Item is not commercial grade) [ X I NO (continue)
#2: Is the Item used in applications other than nuclearfacilities or activities?
[ ] NO (the item is not commercial grade) [ X I YES (continue) #3: Is the Item ordered from manufactwedsupplier on the basis of specifications set forth in the manufacturer's catalog?
[ ] NO (the item is not commercial grade) [ X I YES (continue) [ X ] All three criteria have been satisfied. The Item meets the definition of commercial grade. ..... . . . . . . .
Secbon 20 Reason for Dedcatian The above Comnerca Grade (CG) descnbeo llm IS beng Dedicated lor Jse in !he appleahon cited lor the folmng reason@)
X Item is being purchased from a non-ESL manufacturer supplier as CG to be used in a Safety Class application.
Item is being purchased from a non-ESL manufacturer supplier as CG to be used in a Safety Significant application.
item was purchased from a non-ESL manufacturer supplier as CG to be used in a Safety Class application.
Item was ~~~ purchased ~~ ~ ~ ~ ~ ~ from~a no!:ESL manufacturer supplier as CG to be used in a Safety Significant application.
Other ('like-for-like', similar, substitution, replacement evaluation)
9/2/00
Commercial Grade Item Upgrade Dedication Form ECNNo NIA CGI No CGI-SNF-D-l3-2-P5-053 Title Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
1 2 B PaNComponent Functional Mode
Active X Passive Safety Function #1
Safety Function #2 Active X ' Passive
Safety Funchon #3 Active 1 Passive C Host Component Safety FuncOon (if applicable) NIA
The cable provides a restraint to limit motion of the SCHe helium supply bottle in the event of a Seismic Event. Maintain critical function before, during, and after Seismic Event
Active Mechanical or Electrical change of state IS requlred l o occur for the component to perform its safety function
Passive ~ Change of state E not required for the component to perform its safety function
-1 ~- i
Page 2 of 9
D Failure Mode($ and the effects on component or system safety function (see Worksheet 1) 1 Failure of the restraint cable during a Seismic Event could allow bottle displacement which may be in excess of
movement experienced during the seismic testing. The effects of this condition on the SCHe supply integrity is not defined and would constitute an unreviewed safety question.
2 Damagelcorrosion of the cable or web may reduce its strength to withstand the forces associated with the Seismic Event
Environmental Qualification Required:
Yes ~ X 1 HNF-PRO-97, SNF-5304
No
If yes: NPH Design Requirements Performance Categoty: PC-3 NPH Design Req'ts.: Seismic Condition C Required Safety Functions: Maintain critical function before, during, and after Seismic Event.
~ - ~ ~ p Qualification ~. Perlod: .
Sect on 5 Cmpooent Funcbonai C assificahon ~p~
X 1 SafetyClass(SC) 1 1 General Sewice I I Safety Significant (SS) If paNcomponent classificabon is different from host componenVsystem, document basis NIA
National CodeslStandards: ISA-S5.1, S5.4, S18.1, and S20.20 Safety Analysis Report (SAR) HNF- 3553, Annex B Drawings Dwg. H-1-82367, Item 72, HNF-SD-SNF-SEL-002 Vendor Manual/Manufacturer/Supplier Information Catalog Cut Sheets - McMaster-Carr Pages 1013, 1020 and 1164
~~ ~~~ ~~ ~~ ~~
Commercial Grade Item Upgrade Dedication Form ECNNo N/A CGI No. CGI-SNF-D-13-2-P5-053 T,II~ Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
SNF-4880, Rev 1
Page 3 of 9
~
3. Performance Critical Characteristics (for reasonable assurance that the Item will perform its intended safety function(s)) Environmental I Note 1
& Acceotance Methods
3. Notes and Legend: Rev. 1: Added Web Strap
McMaster-Carr X 1, IN 30785T5 (Per Procurement Package SNF-5304, X 1, IN (W-441-P5), Dwg H-1-82367 with DCN W-441-HE- 446~ Item 721
1. The seismic restraint cable and web strap (Nylon) is not subject to degradation from the 40°F and 60% RH or 115°F and 22% RH conditions and is suitable for Environmental Condition B application.
2. Maintain critical function before, during, and after seismic event. SNF-5304 provides a seismic testing plan for these components at a seismic spectra defined in SNF-4895. Equipment that has been shaker-table tested should not be installed in a plant (Ref. IEEE Standard 344-1984, Section 7). Consequently, the seismic test constitutes a destructive test.
3. Material verification acceptance method may be by either inspection or test.
Cable - End Connections
Web Strap - Length Web Strap - Configuration Web Strap - Material
1 Special Test and inspeclion 1 IN for inspection 1 T for Test 1 A far Analysis
2 Commercial Grade Suruev 3 Source Verification 4 Vendorillem Hislory
318" 24 Threaded Stud One End, Loop with 1, IN Stainless Steel Swage Fitting on Other End. Nominal 114" X 1, IN Stainless Steel Note 3 X 1, IN
Cable Free of Kinks or Broken Strands Which 1, IN Could Affect Load Capacity. Nominal 2 X 1, IN
Nominal 5' X 1, IN With Ratcheting Buckle X 1. IN Nylon (Color = Black) X 1, IN
X
X
Commercial Grade Item Upgrade Dedication Form
I i l t le Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
SNF-4880, Rev. 1
.- ~ ..... ........ DETERMINATION OF FAILURE MECHANISMS
.. ......... .... ...... 1 - _ _ . Definition I X = Applicable to Component under Evaluation
Separation of a solid accompanied by little or no macroscopic plastic deformation
The gradual deterioration of a material due to chemical or electrochemical reactions. such as oxidation, between the material and its environment
Destruction of materials by the abrasive action of moving fluids, usually accelerated by the presence of solid particles carried with the fluid
An electrical circuit that is unintentionally broken so that there is no complete path for current flow
An abnormal connection by which an electrical current IS
connected to ground. 01 to some conducting body,
Clogging of a filtering medium resulting in the inability to perform its purification function or blockage of flow
Binding of a normally moving item through excessive pressure. temperature, friction. lamming
Mechanical oscillations produced are beyond the defined permissible limits due to unbalancing, poor support, or iotation at critical speeds
A loss of mechanical and physical properties of a material due to exposure to high temperatures. radiation exposure
Under the action of excesswe external farce the material of the part has been deformed or distorted
From prolonged exposure to high temperature and stress. the abject will show a slow change in its physical [shape and dimension) and mechanical characteristics
Fracture characterized by tearing of metal accompanied >y appreciable gross plastic deformation
resulting I" eYCeSSlYeCUllerlt flow
rioration of the cable andlor web with use that c(
- ..... "new I _I . IAx.- .
- .............................
9/2/00
Commercial Grade Item Upgrade Dedication Form ECNNo NIA CGI No CGI-SNF-D-13-2-P5-053 Title Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
~
. -_ I I . I - . - -. . . . . . . .-
SECTlOh 3 BY INSPECTION * See Aitacnrenln -at eH.1 clLerr nsl'rtonhr S s m p q bze R e k e - i ~ {See j e c m 7, . . .
1 Characteristic: Manufacturer /I Sample I Acceptance Cr tena McMaster Carr Recc.pt Inspect on Pan / Repon # 100~0
Characteristic: Model Number. Cable
Acceptance Criteria: 8842T18
Characteristic: Cable - End Connections
Acceptance Criteria: 318" 24 Threaded Stud One End, Loop with Stainless Steel Swage Fitting on Other End. Receipt Inspection Plan I Report #:
Characteristic: Cable Diameter
Sample S1Z.Z' U iOO%
Commercial Grade Item Upgrade Dedication Form ECNNo N/A CGI No CGI-SNF-D-13-2-P5-053 Title Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
~
N m e .
Commercial Grade Item Upgrade Dedication Form ECNNo. MA CGI No CGI-SNF-D-13-2-P5-053 m e Seismic Restraint Cable and Web Strap for SCHe Helium Bottles
Initial Procurement Documents
SNF-4880, Rev 1
Manufactureis Recommended Spare Parts List
Other: Catalog Cut Sheets -Catalog Cut Sheets - McMaster-Carr Pages 1013,1020 and 1164
Procurement Documents
1 Valve Seat Leakaae ReDort
Weld Records
All
912100
EDT No.
Name Attach'' EDTECN Text With All Text Only Appendix Attach. Only Only
MSlN
I D . Whitehurst I x3-78 I x I I I I G. Singh
CVD Library
R. Ramsgate
J. Brehm
x3-78 X
x3-78 X
x3-78 X
x3-79 X
I P. Beaudet I 58-07 I x I I I I
C. Miska
L. Price
SNF Startup
IP. Morrell (AVS) I G1-SO I x I I I I x3-78 X
R3-26 X
B2-64 X
D. Whitworth
ISNF Proiect Files I R3-11 I x I I I I X3-25 X
R3-47 X
R3-11 X