AUTOMOTIVE SA PRICE LIST - APRIL 2017 - WABCO list-april-2017.pdf · automotive sa price list -...

AUTOMOTIVE SA PRICE LIST - APRIL 2017

INDEX

ABS Components-Truck/Bus 17 Levelling Valves 7

ABS Components-Trailer 17 Lift Axle Control Valves 5

ABS/EBS - Speed Sensors 17 Line Filter 10

Actuator / Hydraulic Actuators 9 Load Regulating Valve 10

Adaptor Valves 10 Load Sensing / Levelling Valve Parts 7

Accessories 20 Load Sensing Valves -Air Susp 7

Air Dryers 3 Load Sensing Valves -Mech Susp 6

Air Processing Units 3 Low Pressure Switches 10

Air Reservoirs 12 Manoevering Valve 8

Air Throttle Valves 9 Multi Circuit Protection Valves 4

Brake Chambers 11 Non-Return Valves 10

Brake Chambers -Disc Brakes 11 Nylon Pipes 14

Cartridges - Desiccant 3 Operating Cylinders 9

Charging Valves 9 Pressure Limiting Valves 9

Clutch Servos 8 Proportional Solenoid valves (Gearbox) 4

Compressors 14 Quick Release Valves 8

Compressor spares 14-16 Raise / Lower Valve 10

Condensor Drain Valves 4 Ratio Valves 7

Couplings (Duomatic) 13 Relay Emergency Valves 6

Couplings (F & J) 13 Relay Valves 6

Couplings (Palm) 13 Rubber Hose 13

Diagnostic Software 19 Safety Valves 10

Diaphragms 12 Shut-Off Cock 10

Door Control Valve 10 Silencers 10

Double Check Valves 10 Slack Adjusters 18

Double Diaphragm Spring Brakes 11 Solenoid Valves 12

Double Diaphragm Spares 12 Spiral Binding 20

Drain Valves 8 Spring Boxes 7

EBS Components - Trailers 18 Spring Brakes 11

EBS Components - Truck 18 Spring Brakes -Disc Brakes 11

EBS Software 19 Spring Brake Spares 11

ECAS Truck Components 5 Stop Light Switches 10

Electrical Suzy 13 Suzy Pipes 13

Exhaust Brake Valves 8 TATA Spares 19

Foot Brake Valves 4 Test Equipment ABS 20

Fittings Compression 21 Test Equipment Pneumatic 20

Fittings Push In 25 Trailer Control Valves 7

Fittings Push In PlasticType 29 Trailer Release Valve (PREV) 10

Gearbox / Control / 3/2-way 9 Unloader Valves 3

Governor Valves 3

Hand Control Valves 5

AUTOMOTIVE SA PRICE LIST - April 2017

PART NUMBER DESCRIPTION

SUGGESTED

RETAIL REPAIR KIT NO

SUGGESTED

RETAIL

UNLOADER VALVES

975 303 473 0 NEW GENERATION WITHOUT AIR DRYER PORT 8.1 BAR 980.73 975 303 001 2 648.88

975 303 474 0 NEW GENERATION FOR USE WITH AIR DRYER 8.1 BAR 980.73 975 303 001 2 648.88

SERVICE KIT For Unloader /473 0 and /474 0 ASA5698 380.31

GOVERNOR VALVES

475 315 007 0 9.2 BAR D2 GOVERNOR Replaces 975 499 017 0 1311.66

AIR DRYERS & APUs

432 410 022 0 AIRDRYER With Unloader 9.5 bar PORT 4/23 NISSAN UD460 5188.04 432 410 001 2 190.64

432 410 002 2 395.64

SERVICE KIT ASA7070 719.20

432 410 083 0 AIRDRYER With Unloader 9.3 bar PORT 4/23 SCANIA WITH HEATER 11145.23 432 410 001 2 190.64

432 410 002 2 395.64

CARTRIDGE (SCANIA) 1 1/4" 13 BAR 432 410 927 2 1154.60


432 410 113 0 AIR DRYER With Unloader 12.5 BAR 3371.78


432 410 117 0 AIR DRYER With Unloader 10 BAR MAN F 2000 2559.57 432 410 002 2 395.64


432 410 202 0 AIR DRYER With Unloader 8.1 BAR 3296.80 432 410 001 2 190.64


432 410 720 0 AIR DRYER With Unloader 12.5 BAR Without Heater On Request

For MAN TGA/TGS/TGL/TGM S/S 432 410 120 0

432 413 003 0 AIR DRYER (ROCKWELL) BACKFLOW 0.7 NLA 432 413 925 2 239.52

Bypass Valve 432 420 926 2 On Request

Turbo Cut Out valve old number 432 413 928 2 432 413 934 2 586.92

Purge Valve 432 413 929 2 806.60


932 400 001 0 DRYER With Unloader 12 BAR (ACTROS) W/O Heater (W/O Port 4/25) NLA See replacement ….024 0

932 400 002 0 DRYER With Unloader 12 BAR (ACTROS) With Heater NLA See replacement ….024 0

932 400 005 0 DRYER With Unloader 12 BAR (ACTROS) W/O Heater (With Port 4/25) NLA See replacement ….024 0

932 400 024 0 DRYER With Unloader 12 Bar With heater Replaces 010/020/050 3968.10 432 410 001 2 190.64

932 400 000 2 1527.15

932 510 009 0 SCANIA AIRDRYER 32670.00

432 420 220 2 CARTRIDGE (ACTROS) M39 20 BAR 1168.40

432 420 002 0 AIR DRYER WITHOUT UNLOADER M12 CONTROL PORT 4486.38 432 410 002 2 395.64


432 421 008 0 AIR DRYER WITHOUT UNLOADER M16 CONTROL PORT 4376.90 432 410 002 2 395.64


432 425 105 0 AIRDRYER FOR VOLVO NLA Use 432 425 101 0 9020.00 432 425 920 2 1336.56

932 510 956 2 AIRDRYER SCANIA for 932 510 004/5 0 /6 0 15524.07

AIR DRYER CARTRIDGES

432 410 222 7 CARTRIDGE (STD) M39 x 1.5 13 BAR 420.47

432 410 927 2 CARTRIDGE G 1,1/4 13 BAR SCANIA 1154.60

432 420 220 2 CARTRIDGE M39 x 1.5 20 BAR ACTROS 1168.40

432 901 223 2 CARTRIDGE With Coalescing Filter M39x1.5 13 BAR (SILVER) 1006.25

432 410 244 2 CARTRIDGE Coalescing & Oil Filter M39x1.5 13 BAR (GOLD) 1840.00

3 of 30

Prices and Product Availability are Subject to Change Without Notice



SUGGESTED


SUGGESTED

RETAIL

CONDENSOR DRAIN VALVE

432 511 000 0 CONDENSOR DRAIN VALVE 3034.65 432 511 000 2 1553.84

NYLON FILTER 432 511 220 4 432 511 220 4 184.78

MULTI CIRCUIT PROTECTION VALVES

934 702 100 0 5 PORT 4 X M16 1 X M22 1542.13

934 702 210 0 7 PORT 6 X M16 1 X M22 2123.69

934 702 221 0 7 PORT 6 X M16 1 X M22 1475.32

934 702 250 0 5 PORT 4 X M16 1 X M22 1046.36 ASA5394 499.15

934 702 260 0 5 PORT 5 X M22 (VOSS) 1475.32 ASA5394 499.15

934 702 300 0 5 PORT 4 X M16 1 X M22 1223.53 ASA5391 493.67

934 702 320 0 5 PORT 4 X M16 1 X M22 2518.62

934 705 005 0 PROTECTION VALVE (ACTROS) 7505.24

932 500 501 1 PRESSOR SENSOR FOR 9347050050 replaces 441 043 504 1 2809.45

934 714 003 0 5 PORT 4 X 3/8" 1 X 1/2" 2535.58

934 714 010 0 5 PORT 4 X M16 1 X M22 1709.08

934 714 110 0 5 PORT 4 X M16 1 X M22 On Request

934 714 145 0 PROTECTION VALVE FOR VOLVO 5355.81

934 714 211 0 4 WAY PROTECTION VALVE 5009.95

934 714 400 0 PROTECTION VALVE MAN TGA 3100.90

934 714 740 0 7 PORT SUPPLY: 1XM22 DEL M14 4550.11

932 510 958 2 SCANIA PROTECTION VALVE Excluding the PC Board On Request

PROPORTIONAL SOLENOID VALVE (GEARBOX, VOITH)

472 260 005 0 PROP Solenoid 10173.00

472 260 011 0 PROP Solenoid 1x M22 Voss 13040.22

472 250 000 0 Proportional Solenoid Valve 6640.85

FOOT BRAKE VALVES W/K 20/01 W/K 21/01

461 315 004 0 MERCEDES 1624 M16 SUP/DEL PORTS M12 GAUGE PORTS 2805.32 461 315 005 2 679.11

SERVICE KIT 461 315 915 2 742.33

461 315 008 0 MERCEDES 1928/2633 M16 SUP/DEL PORTS 0.3 PREDOMINANCE 2207.44 461 315 005 2 679.11

SERVICE KIT 461 315 915 2 742.33

461 315 042 0 VOLVO / SCANIA M16 PORTS 4389.94

461 315 180 0 SCANIA PUSH-IN FITTINGS NLA 461 315 907 2 1320.54

SERVICE KIT 461 315 924 2 1490.66

461 315 263 0 MERCEDES AXOR long Silencer 5088.46

461 315 264 0 MERCEDES AXOR 3282.23

461 315 497 0 VOLVO/DAF M16 SUP/DEL PORTS M12 GAUGE PORTS 3441.35 461 315 005 2 679.11

SERVICE KIT 461 315 915 2 742.33

461 319 008 0 MERCEDES 2638 M16 SUP/DEL PORTS M12 SIGNAL PORT 6644.93 461 319 007 2 909.21

461 319 250 0 MERCEDES S.K. RANGE/POWERLINER 3343.00 461 319 004 2 1152.26

SERVICE KIT 461 319 905 2 679.11

461 319 270 0 MERCEDES LN2 Econoliner M22 SUP/DEL Ports M16 Signal Port 3343.00

461 319 271 0 MERCEDES 2933.28

461 319 273 0 MERCEDES AXOR 3538.20

461 319 274 0 FOOT VALVE 3418.40

461 324 001 0 MERCEDES 14/18 Repair for Pneumatic Side Only 461 315 005 2 679.11

461 494 502 0 RENAULT Kerax 7275.68

461 499 005 0 DUAL FOOT VALVE MERCEDES 14424.55

470 012 000 0 MERCEDES 2632 C/W SLAVE CYLINDER M16 PORTS 10450.91 461 307 002 2 596.82

461 307 399 0 FOOT VALVE On request

See Page 16 for EBS Truck Brake Signal Transmitters (Foot valves)

4 of 30




SUGGESTED


SUGGESTED

RETAIL

ECAS SOLENOID VALVES

472 880 001 0 ECAS 2 POINT SOLENOID 6346.35

472 880 030 0 ECAS SOLENOID - TRAILER ECAS and TRUCKS 7126.84

472 900 060 0 Superseded by 472 880 001 0

472 905 111 0 ECAS SOLENOID - MAN TGA & DAF TRUCKS LIFT AXLES 7200.40

472 905 114 0 ECAS SOLENOID - TRAILER LIFT AXLES 9491.92

ECAS HEIGHT SENSORS

441 050 012 0 BAYONET WITHOUT LEVER AND TEMPERATURE COMPENSATION 1516.24

441 050 100 0 ECAS LEVELLING VALVE-TRUCK 1605.42

441 050 011 0 ECAS LEVELLING VALVE-TRUCK On request

441 050 121 0 ECAS LEVELLING VALVE-TRUCK 1720.77

441 050 123 0 BAYONET WITHOUT TEMP COMPENSATION; CROSS LEVER 1615.75

ECAS/ELM REMOTE CONTROL UNIT

446 056 116 0 REMOTE CONTROL UNIT 1963.27

LIFT AXLE CONTROL VALVE

463 084 010 0 ELECTRONICALLY CONTROLLED (TRAILER ABS) On request

463 084 020 0 FULLY AUTOMATIC SINGLE CIRCUIT LIFT VALVE 7883.68

463 084 041 0 FULLY AUTOMATIC SINGLE CIRCUIT WITH 8mm FITTINGS PI 4178.35

HAND CONTROL VALVES

961 701 110 0 3 PORT VALVE M14 POARTS (ANTI-CLOCKWISE) 7164.07


961 701 115 0 3 PORT VALVE M14 POARTS (ANTI-CLOCKWISE) 8432.72

961 702 014 0 4 PORT VALVE M14 PORTS 7837.02


961 703 001 0 4 PORT VALVE WITH BUS STOP POSITION M14 PORTS 8741.29 961 703 000 2 1504.10

961 721 000 0 TRAILER BRAKE -IN PRESS -8.5 BAR / OUT = 7.5 BAR SS 9617210410 961 721 004 2 1118.28

961 721 004 0 VALVE WITH HANDLE LOCK (TRAILER BRAKE) 4010.62 961 721 004 2 1118.28

961 721 008 0 2 PORT HAND CONTROL (TRAILER BRAKE) 4166.01 961 721 004 2 1118.28

961 721 040 0 SELF RETURN T.C.2 (TRAILER BRAKE) 4738.39 961 721 004 2 1118.28

961 721 045 0 2 PORT with DUST BOOT 2460.88

961 722 230 0 2 PORT SLIDE (LHD BRACKET) (MB) 4715.29

961 722 232 0 3 PORT HAND CONTROL & SLIDE TYPE CONNECT (VOSS) M14 4370.64


961 722 252 0 H/CTRL (LHD BRACKET) 3 PORT M14 3330.73


961 722 258 0 H/CTRL (CENTRE BRACKET) 3 PORT M14 2956.25


961 722 272 0 HAND CONTROL INT. (RHD) convert 961 722 252 0 NLA


961 722 284 0 4 PORT (RHD BRACKET) (MB) 3466.37


961 722 288 0 3 PORT (RHD BRACKET) M14 PORTS (MB) 5743.13


961 723 017 0 PARKING HAND CONTROL 1529.71

961 723 019 0 2 PORT (CENTRE BRACKET) M16 PORTS (MAN) 2790.96

961 723 100 0 3 PORT (CENTRE BRACKET) M16 PORSTS (MAN) 3150.00

961 723 104 0 H/CTRL POWER LINER 3 PORT M16 VOSS (SIDE) 2711.96

5 of 30




SUGGESTED


SUGGESTED

RETAIL

HAND CONTROL VALVES Continued……………

961 723 118 0 3 PORT (CENTRE BRACKET) M14 VOSS PORTS (MAN) 1892.07

961 723 124 0 3 PORT (CENTRE BRACKET) M16 PORTS (MB) 3232.12

961 723 125 0 H/CTRL (ACTROS) 3 PORT M16 (SIDE) VOSS 4436.53

961 723 201 0 3 PORTS (BOTTOM) M16 CENTRE BRACKET NLA

961 723 203 0 3 PORT (CENTRE BRACKET) M16 PORTS 3366.24

961 723 213 0 3 PORTS (BOTTOM) M16 CENTRE BRACKET 4374.06

961 723 405 0 H/CTRL 2 PORT M16 (BOTTOM) 2993.14

961 723 426 0 H/CTRL MAN TGA WITH ELECTRICAL PLUG 5765.21

M302890 HAND CONTROL VALVE 2 PORT WITH LOCK POSITION 911.69

RELAY VALVES

280375 R6 VALVE 753.22

472 195 031 0 ABS SOLENOID RELAY VALVE (TRAILER) 2579.52

480 202 004 0 EBS RELAY VALVE (ACTROS) 8199.00

973 001 010 0 M22 PORTS SQUARE RELAY VALVE 880.11 973 001 000 2 494.05

ASA5198 89.17

973 001 020 0 M16 PORTS SQUARE RELAY VALVE 880.11 973 001 000 2 494.05

ASA5198 89.17

973 003 007 0 M22 SQUARE RELAY (MAN) 3509.69

973 006 001 0 PLASTIC WITHOUT SILENCER M22/M22/M16 VOSS 1411.52

973 006 003 0 PLASTIC WITH SILENCER M22/M22/M16 VOSS 905.89

973 011 000 0 PORT 1 & 2 M22, PORT 4 M16, NO SILENCER 991.36 ASA7168 99.71

973 011 001 0 M22 PORTS (MAN / SCANIA) PORT 1&2 M22 VOSS/PORT 4 M16 1225.69 ASA7168 99.71

973 011 022 0 3/8" PORTS WITH FLANGE FREIGHTLINER 1517.81 ASA7168 99.71

973 011 050 0 M22 SUPPLY PORTS / DEL PORTS M16 989.16

973 011 200 0 MAN / SCANIA 1095.94 ASA7168 99.71

973 011 206 0 RENAULT PORT 1 & 2 M22, PORT 4 M16, 2350.92

480 202 005 0 RELAY VALVE(ACTROS) - 8X4 7710.50

480 205 104 0 SOLENOID RELAY VALVE 2099.48

RELAY EMERGENCY VALVES

281672 RE6 VALVE 930.81 266784 355.12

471 005 020 0 RELAY EMERGENCY VALVE NLA

971 002 150 0 RELAY EMERGENCY VALVE 3330.04

971 002 300 0 RELAY EMERGENCY VALVE 3500.96

971 002 900 0 PARK RELEASE EMERGENCY VALVE (PREV VALVE) 1970.90

LOADSENSING VALVES (MECHANICAL SUSPENSION)

475 702 022 0 LOAD SENSING VALVE / MECHANICALLY CONTROLLED On request

475 710 008 0 M22 PORTS PORT 4 M16 On request 475 710 001 2


475 710 012 0 M22 PORTS VOSS PORT 4 M16 VOSS (MAN L2000 / M2000 / M2000L) 5506.70

475 710 016 0 M22 VOSS PORTS PORT 4 M16 VOSS (MAN) 2958.51 475 710 001 2


475 710 020 0 DYNAMIC M16 PORTS 4059.23 475 710 001 2


475 710 036 0 RELAY LOAD SENSING DYNAMIC 22 DIA DEL. PORTS 2333.56 475 710 001 2


475 710 128 0 PORT 1 M22. PORT 2 M16 (VOLVO FH12 / FH16) 6194.10

475 710 136 0 M16 VOSS PORTS PORT 1 M22 VOSS (MERCEDES) 3626.48 475 710 001 2


475 713 501 0 PORT 1/4 M22. PORT 2 M16 Static Valve 2522.80

475 720 003 0 NEW GENERATION MINI LSV DAF 5441.09


475 720 005 0 NEW GENERATION MINI LSV 2551.45

6 of 30




SUGGESTED


SUGGESTED

RETAIL

LOAD SENSING VALVE (AIR SUSPENSION)

475 711 024 0 CONTROL PRESSURE 0.6 TO 4.3 BAR 4191.82 475 711 000 2 1847.72

475 711 096 0 CONTROL PRESSURE 0.45 TO 6.1 BAR 5941.27 475 711 000 2 1847.72

475 711 118 0 CONTROL PRESSURE 0.5 TO 3 BAR 6609.53 475 711 000 2 1847.72

475 714 510 0 CONTROL PRESSURE 0.4 TO 3.6 BAR 3018.45

475 721 000 0 M16 PORTS PORT 22 M22 (DAF SCANIA) 0.5 TO 4.7BAR 4831.64


475 721 008 0 NEW GENERATION MINI LSV AXOR 11328.71

475 721 009 0 NEW GENERATION MINI LSV AXOR 5407.25

884 503 224 0 LOADSENSING VALVE On request

LOAD SENSING / LEVELLING VALVE SPARES

433 300 383 4 LINK CONNECTION (RUBBER L SHAPE) 80.32

433 300 385 4 LINK CONNECTION (RUBBER L SHAPE) LEVELLING 201.84

433 401 380 4 RUBBER LINK (464 002 … 0) LEVELLING VALVE 206.31

464 002 730 2 METAL ARM (464 002 … 0) LEVELLING VALVE 362.64

475 701 712 2 LOAD SENSING ARM WITH RUBBER LINK 222.04

433 300 381 4 LINK RUBBER STR. 8 DIA LSV 64.96

ASA5080 LINKAGE KIT LSV TANDEM AXLE 354.99

ASA5081 LINKAGE KIT LSV SINGLE AXLE 198.00

433 401 003 0 LINKAGE KIT Levelling Valve 160.00

441 050 718 2 Flat Arm for ECAS Distance Sensor / Levelling Valve 525.60

475 713 710 2 Arm and Cable for 475 713 … 0 Mechanical LSV 1247.35

A6356 DATA PLATE -MECHANICAL/AIR SUSPENSION VALVE 66.53

SPRING BOXES

433 302 002 0 (260MM LONG) 20-35N With Rubber Connector 514.27

433 302 008 0 (160MM LONG) 40-100N With Knuckle Joint 1128.30

433 302 014 0 (220MM LONG) 26-47N WithOUT Rubber Connector 514.27

433 302 026 0 (220MM LONG) 449-145N With Rubber Connector 697.62

RATIO LOAD VALVES

473 300 001 0 3.3:1 RATIO VALVE 5378.60

473 301 001 0 1.5 :1 RATIO 3590.14

TRAILER CONTROL VALVES

480 204 002 0 ACTROS/ NISSAN/ DAF E.B.S. (REPLACES 001 0 VARIANT) 6736.95

973 002 430 0 (M16) PORT NO DUMP NO PREDOMINANCE 3845.00 ASA5741 416.87

973 002 521 0 WITH DUMP VALVE (M16) PREDOMINANCE .2 BAR (Adjustable) 2608.76 ASA5741 416.87

973 009 001 0 WITH DUMP VALVE (M22 VOSS) POWERLINER 3476.16 973 009 000 2 1320.05

973 009 006 0 WITH DUMP VALVE (M22 VOSS) MAN 3476.16 973 009 000 2 1320.05

973 009 014 0 WITH DUMP VALVE (M16) PREDOMINANCE 0,4 BAR (Adjustable) 4863.20 973 009 000 2 1320.05

973 009 015 0 WITH DUMP VALVE (M16) VOLVO 0.1 PREDOMINANCE 4863.20 973 009 000 2 1320.05

973 009 010 0 WITH DUMP VALVE (M16) 0.2 PREDOMINANCE 6055.86

ASA7273 3/8" PORTS FREIGHTLINER (KNORR KX2106/5) 4079.13

LEVELLING VALVES

464 002 330 0 2 STAGE (INT) WITH ARM (VOLVO/IVECO) 1932.22 464 002 008 2 533.68

464 002 440 0 2 STAGE -WITH ARM (M.A.N.) 2665.79 464 002 008 2 533.68

464 006 002 0 2 STAGE -WITH ARM (M.A.N./B.P.W.) 1576.75

464 006 100 0 2 STAGE -WITH ARM (DAF/TRAILER) 2306.98

464 007 001 0 CAB SUSPENSION (PUSH-IN) 2272.72

464 007 010 0 CAB SUSPENSION (M10 X 1) 2514.90

7 of 30




SUGGESTED


SUGGESTED

RETAIL

CLUTCH SERVOS

970 051 111 0 M.A.N. (STROKE 85MM / DIA 80.5MM) 5413.55

970 051 114 0 HINO/FIAT (STROKE 67MM / DIA 80.5MM) 5809.94 970 051 904 2 2891.21

BOOT 897 754 882 4 176.69

970 051 126 0 NISSAN/HINO (STROKE 67MM / DIA 80.5MM) 4273.46 970 051 904 2 2891.21

BOOT 897 754 882 4 176.69

970 051 127 0 CLUTCH SERVO SCANIA (STROKE 58.5MM / DIA 108MM) 8341.29

BOOT 897 754 882 4 176.69

970 051 128 0 CLUTCH SERVO MERC. (STROKE 58.5MM / DIA 108MM) 12788.20

BOOT 897 754 882 4 176.69

970 051 131 0 MERCEDES (STROKE 72MM / DIA 90MM) 8077.30 970 051 903 2 1038.40

970 051 159 0 MERCEDES (NEW GENERATION) (STROKE 85MM / DIA 108MM) 10664.66

970 051 164 0 MERCEDES LN2 (STROKE 85MM / DIA 108MM) 5336.28 970 051 945 2 2550.00

BOOT 897 754 882 4 176.69

970 051 406 0 MAN F2000 (STROKE 85MM / DIA 75MM) 4383.32

970 051 412 0 CLUTCH SERVO FOR MAN TGA –MINERAL OIL 8543.02 970 051 971 2 4772.00

970 051 414 0 MAN F2000 (STROKE 85MM / DIA 108MM) 3612.15 970 051 961 2 2785.02

BOOT 897 754 882 4 176.69

970 051 424 0 HINO 700 (STROKE 85MM / DIA108MM) 6426.97 970 051 961 2 2785.02

BOOT 897 754 882 4 176.69

970 051 431 0 ACTROS (STROKE 85MM / DIA 102MM) Kit Includes Main Seal 5550.12 970 051 974 2 3951.18

BOOT 897 754 882 4 176.69

970 051 432 0 CLUTCH SERVO MAN TGM (STROKE 85MM/DIA 80MM) MINERAL OIL 12765.51

970 051 435 0 MAN (STROKE 85MM / DIA 75MM) 7166.98 970 051 970 2 3125.93

BOOT 897 754 882 4 176.69

970 051 438 0 CLUTCH SERVO FOR RENAULT (INCL. 3/2 DIR. CONTR. VALVE) 12484.00 970 051 984 2 4084.00

970 051 439 0 CLUTCH SERVO FOR MAN (STROKE 25 / DIA 108MM) 11583.71

970 051 441 0 ACTROS/AXOR - MINERAL OIL Kit Excludes main Seal 5851.42 970 051 987 2 1029.32

970 150 001 0 ACTROS MP11 (Alternative for 9701500020) 16914.04

NOTE: SPECIAL INSTALLATION INSTRUCTIONS

970 051 187 0 CLUTCH SERVO 7290.44

DRAIN VALVES

SF1280 MANUAL DRAIN VALVE 1/4"NPTM 64.00

934 300 003 0 MANUAL TILT TYPE M22 82.89

934 300 006 0 MANUAL DRAIN VALVE 1/2" NPT 153.50

934 301 000 0 AUTO DRAIN VALVE M22 1273.43

934 301 003 0 AUTO DRAIN VALVE M22 Use 934 301 000 0

QUICK RELEASE VALVES

973 500 000 0 M22 PORTS 286.69

973 500 014 0 1/2" X 3/8" X 3/8" PORTS 328.50

973 500 031 0 POWER LINER M22 (VOSS) (4 PORT) 594.22

973 500 051 0 WITH ANTI-COMPOUND, DOUBLE CHECK VALVE FOR EBS TRAIL. 883.00

973 500 059 0 M22 - 4 PORT 2501.73

MANOEUVERING VALVES

ASA1689 PUSH AND HOLD TYPE WITH FITTINGS 1135.04

EXHAUST BRAKE VALVES

463 013 112 0 SHORT STEM -2 X M12 PORTS WITHOUT LOCK NUT 537.82 ASA5705 85.12

463 013 114 0 LONG STEM -2 X M12 PORTS WITHOUT LOCKNUT 591.55 ASA5705 85.12

463 013 116 0 SHORT STEM -2 X M12 PORTS WITH LOCKNUT 706.68 ASA5705 85.12

463 013 130 0 SHORT STEM -3 X M16 PORTS (VOSS) WITHOUT LOCKNUT 852.79

463 013 200 0 SHORT STEM -3 X M16 PORTS (VOSS) WITHOUT LOCKNUT 873.50

463 013 210 0 SHORT STEM -2 X M16 -1 X M12 PORTS (VOSS) WITHOUT LOCKNUT 982.00

891 500 464 4 LOCK NUT M26 14.00 19.25

8 of 30




SUGGESTED


SUGGESTED

RETAIL

OPERATING CYLINDERS

421 411 070 0 CYLINDER - DIA 35MM, STROKE 85MM 2341.66

421 429 003 0 A.D.E. CYLINDER 407/400 / DIA : 28MM -STROKE 48MM 1755.48

AIR THROTTLE

361 064 050 0 AIR THROTTLE VALVE 10471.61 361 050 000 2 330.93

DIAPHRAGM FOR (423 020 016 0) 897 121 030 4 1264.68

ACTUATOR / SERVO UNITS

425 307 012 0 ACTUATOR 100MM X 80MM STROKE 10477.96 425 307 000 2 1279.88

AGA199 MADE UP 425 307 012 0 + CLEVIS 10477.96

921 399 025 0 AIR/HYDRAULIC ACTUATOR 7873.69

974 010 006 0 SERVO MASTER SUPERCEDED TO 974 010 008 0 NLA

974 010 008 0 SERVO MASTER MAN TGL (WITH MASTER CYLINDER) on request

GEARBOX VALVES / DIRECTIONAL CONTROL VALVES

463 022 020 0 VALVE M10 PORTS 1744.35

463 036 001 0 DIFLOCK M10 PORTS WITH KNOB WITHOUT LOCKNUT 630.69

463 036 010 0 M16 VOSS PORTS WITHOUT KNOB WITHOUT LOCKNUT 811.81

463 036 016 0 DIFF LOCK SWITCH (M28 MOUNTING) 1268.90

463 037 001 0 M10 4/2 CONTROL VALVE WITHOUT HANDLE & LOCKNUT 1411.66

463 039 006 0 DAIMLER ZF BOX 3653.60

563 020 000 0 3/2 CONTROL VALVE (MAN) -M10 2257.01

571 040 000 0 3/2 CONTROL VALVE 3 X M14 -1 X M10 1331.47

891 500 520 4 M28 LOCKNUT FOR 463 037 001 0 160.00

899 851 810 4 HANDLE FOR 463 037 001 0 301.82

A5821 WASHER FOR M28 LOCKNUT 48.35

ASA5910 MADE UP 463 036 001 0 & WASHER & NUT 963.20

CHARGING VALVES

434 100 023 0 5.5 BAR WITH BACKFLOW (M22) 612.40 ASA5699 101.66

434 100 024 0 6.0 BAR WITH BACKFLOW 612.40 ASA5699 101.66

434 100 122 0 4.5 BAR WITHOUT BACKFLOW (M22) 441.51 ASA5699 101.66



434 100 220 0 4.5 BAR WITH LIMITED BACKFLOW (M22) 608.83

434 100 222 0 6.2 BAR WITH LTD BACK FLOW 1071.44

434 100 224 0 1.7 BAR WITH LTD BACK FLOW 885.49

PRESSURE LIMITING VALVES

475 009 008 0 SET AT 0.7 BAR (MAN) 1795.62

475 009 026 0 SET AT 3.0 BAR 2533.87

475 010 010 0 PRESSURE LIMITING VALVE (3.5 TO 6 BAR) on request

475 010 300 0 SET AT 8.5 BAR (MAN) 705.24

475 010 301 0 SET AT 10.0 BAR (MAN) 804.12

475 010 333 0 PRESSURE LIMITING VALVE MAN TGA. 1387.52

475 010 400 0 SET AT 8 BAR (DAF) 1643.57 475 010 002 2 on request

475 015 001 0 SET AT 7.4 BAR (MAN- MERCEDES) 1284.36 475 015 001 2 477.02

475 015 004 0 PRESSURE LIMITING VALVE (SET AT 3.5 BAR) (MAN- Merc) 881.22 475 015 001 2 477.02

475 015 009 0 PRESSURE LIMITING VALVE (SET AT 5.3 BAR) (Renault) 1006.50 475 015 001 2 477.02

475 015 061 0 PRESSURE LIMITING VALVE (SEE 421 355 931 2 kit) ZF Gearbox see kit 421 355 931 2 4099.52

9 of 30




SUGGESTED


SUGGESTED

RETAIL

DOUBLE CHECK VALVES

434 208 029 0 VALVE WITH INTEGRAL BRACKET (M22) PORTS 322.80

NON-RETURN VALVES

434 014 000 0 M22 PORTS 208.12

SAFETY VALVES

434 612 004 0 ACTROS M22 13 BAR 450.60

SHUT OFF COCKS

452 002 132 0 M22 WITH EXHAUST 180º 460.40

LOAD REGULATING VALVE

475 800 301 0 OPERATING PRESSURE 7.35 BAR (M22) 7973.12

LOW PRESSURE SWITCH

441 014 004 0 L.P. SWITCH 5.5+0.6 Bar (M12) Normally Closed 451.60




AGA987 L.P. SWITCH 4.5Bar 1/4" NPT Normally Closed 563.69

ADAPTOR VALVES

975 001 000 0 0.6 TO 0.8 BAR 964.96

975 002 001 0 1 TO 1 RATIO AT 5.8 BAR 2856.70

975 002 017 0 1 TO 1 RATIO AT 4 BAR 2571.98

DOOR CONTROL VALVE

472 017 480 0 24V M12 PORTS 7374.00

SILENCERS

432 407 060 0 M22 -13 BAR SCREW ON 181.97

432 407 070 0 SNAP-ON -11 BAR 208.87

RAISE / LOWER VALVE

463 032 020 0 SUPPLY -M16. DEL -M12 3147.39

TRAILER RELEASE VALVE

971 002 900 0 PREV (Park Relay Emergency Valve) EBS Trailer systems 1970.90

STOP LIGHT SWITCH

262625 STOPLIGHT SWITCH 1/4"NPT 1107.44

441 014 001 0 STOPLIGHT SWITCH 2 BAR (M12) 506.72

441 014 021 0 STOPLIGHT SWITCH 0.5 BAR (M12) 376.99

LINE FILTER

432 500 020 0 LINE FILTER M22 X M22 200.69

10 of 30




SUGGESTED


SUGGESTED

RETAIL

BRAKE CHAMBERS

AGA109 TYPE 20 NLA

AGA339 TYPE 12 714.29

AGA449 TYPE 30 with nuts 840.00

423 105 111 0 T20 WITH STUDS 1843.55

423 106 292 0 T24 WITH STUDS 2156.85

423 107 900 0 T30 (M16 PORTS) (see AGA354) 1471.01

423 109 001 0 T27 WITH STUDS 2466.46

423 206 700 0 T24 WITHOUT STUDS NLA

423 206 701 0 T24 WITHOUT STUDS NLA

BRAKE CHAMBER (DISC BRAKE)

423 104 710 0 T16 On request

SPRING BRAKES / TRI-STOP

925 320 502 0 TRISTOP TYPE 20-30 WELDED PUSH ROD 8450.06 925 320 002 2 497.35

925 321 463 0 Springbrake On request

925 321 473 0 Springbrake On request




925 421 751 0 T24/24 PUSHROD 200MM 4675.96

925 421 752 0 T24/24 PUSHROD 200MM 4675.96

925 424 100 0 TRI-STOP TYPE 16-24 WELDED PUSH ROD 4156.63

925 424 101 0 TRISTOP TYPE 16-24 WELDED PUSH ROD 4532.19

425 451 052 0 TRISTOP TYPE 24-24 WEDGE TYPE RIGHT - NISSAN 10697.98

425 451 053 0 TRISTOP TYPE 24-24 WEDGE TYPE LEFT - NISSAN 10697.98

925 490 902 0 TRISTOP TYPE 20-24 WELD PUSH ROD REPLACES 925 420 902 0 7415.84 925 320 001 2 488.31

925 494 041 0 UNIVERSAL TYPE 16-24 NO Clevis, nuts and washers, see AGA432 4835.29



925 492 102 0 UNIVERSAL TRISTOP TYPE 30-30 5331.66

AGA431 UNVERSAL (9254909250) 20-24 with Clevis, nuts and washers 5102.43

AGA430 UNVERSAL (9254911410) 24-24 with Clevis, nuts and washers 5137.25

AGA432 UNIVERSAL (9254940410) 16-24 with Clevis, nuts and washers 5052.98

SPRING BRAKES (DISC BRAKES)

925 424 800 0 TRISTOP TYPE 16-16 (M22 VOSS) LHS 4750.36

925 424 801 0 TRISTOP TYPE 16-16 (M22 VOSS) RHS 4750.36

925 426 200 0 TRISTOP TYPE 14-16 (M22 VOSS ) LHS 4502.18

925 426 201 0 TRISTOP TYPE 14-16 (M22 VOSS ) RHS 4502.18

925 480 004 0 TRISTOP TYPE 20-24 (M22 VOSS) 5953.79

925 481 012 0 TRISTOP TYPE 24-24 (M22 VOSS) LHS 5364.36

925 481 013 0 TRISTOP TYPE 24-24 (M22 VOSS) RHS 5364.36

SPRING BRAKES/DOUBLE DIAPHRAGM

AGA1125 DOUBLE DIAPHRAGM TYPE 24/30 LS REPLACES AGA349 1019.60

SPRINGBRAKE SPARES

895 801 513 2 M16 X 14MM PIN CLEVIS 150.02

897 750 980 4 DUST BOOT (1 HOLE) 53.20

897 751 010 4 DUST BOOT (1 X LARGE HOLE) 53.20

897 753 261 4 DUST BOOT (2 HOLE) 77.87

A5803 DUST BOOT MAXI BOOSTER T24 252.30

ASA6194 KIT MAXI BOOSTER T24 442.10

11 of 30




SUGGESTED


SUGGESTED

RETAIL

DOUBLE DIAPHRAGM SPARES

ASA1779 T24 PUSH ROD 109.69

ASA1780 T30 PUSH ROD 132.22

895 801 513 2 CLEVIS M16 X 1.5 X 1/2" PIN 150.02

ASA6868 LONG CLEVIS 5/8" Thread X 1/2" PIN

DIAPHRAGMS

897 121 030 4 TYPE 3 1264.68

234433M TYPE 9 NLA

234226M TYPE 12 NLA

897 121 610 4 WABCO TYPE 14 322.46

A6447 TYPE 16 121.21

897 120 510 4 WABCO TYPE 16 222.03

A6448 TYPE 20 121.21

897 120 520 4 WABCO TYPE 20 on request

897 120 525 4 TYPE 20 DEEP DISH on request

A2400 TYPE 24 65.65

897 120 530 4 WABCO TYPE 24 259.39

897 120 536 4 TYPE 24 DEEP DISH 473.94

897 121 925 4 TYPE 27 683.70

A3000 TYPE 30 72.22

897 120 540 4 WABCO TYPE 30 309.50

897 120 546 4 WABCO TYPE 30 LONG STROKE 326.68

234362M TYPE 36 NLA

SOLENOID VALVES

472 070 639 0 (24V M16 PORTS) NORMALLY CLOSED 1059.56

472 102 040 0 24V NORMALLY OPEN 3272.58

472 132 198 0 (24V M12 PORTS) NORMALLY CLOSED 2181.08

472 170 600 0 24V NORMALLY CLOSED M12 (Kostal) 1393.24

472 172 626 0 24V NORMALLY CLOSED 983.32

472 172 686 0 24V NORMALLY CLOSED DAF 1139.08

472 174 504 0 24V NORMALLY CLOSED M12 5350.22

472 176 316 0 24V NORMALLY OPEN M16 ACTROS/DAF 1505.90

472 195 078 0 FREIGHTLINER 12V WITH FLANGE 3018.06

472 195 079 0 FREIGHTLINER 12V WITH FLANGE 3018.06

AIR RESERVOIRS

8" DIA (203MM) Length

AGA179 5 LITRE RESERVOIR 816.53 195MM

051010004M 10 LITRE RESERVOIR 957.30 355MM



A6104 TANK STRAP 8" DIA (SINGLE) 129.55

11" DIA (276MM)





1675062M TANK STRAPS 11" DIA. (PAIR) 253.98

390mm DIA

A6741 FATBOY 90 LITRE RESERVOIR 3698.75

A6742 FATBOY TANK STRAPS (PAIR) 761.24

12 of 30




SUGGESTED


SUGGESTED

RETAIL

F & J COUPLINGS AND SPARE PARTS

Standard

0520010022 1/2" Female std 77.28

A6722 M22 x 1.5 Female with striker plug assembled Trailer 146.97

APSA1519 1/2" Female with striker plug assembled Trailer 94.88

A6723 M22 Female F&J with short stem shut off valve Truck 246.10

0520010062 1/2" Female F&J with short stem shut off valve Truck 158.70

0520003005 M16 x 1.5 Female F&J with short stem shut off valve Truck 176.36

ASA531/2 1/2" Female F&J with short stem shut off valve Truck 227.70

0520010032LB 1/2" Short stem Shut off valve only With Long Body 122.35

0520020032LB M22 Short stem Shut off valve only With Long Body 163.14

4000 M22 Female Coupling with short Stem Shut Off Valve NEW EURO SPEC 863.17

4625 M22 x 1.5 Female F&J + Striker NEW EURO SPEC 445.88

0520000014 1/2" Male Coupling std Trailer 36.74

0520000024 M22 x 1.5 Male Coupling std Trailer 66.14

0520030052 1/2" Male F&J with long stem shut off valve Truck 94.69

0520030062 1/2" Male F&J with long stem shut off valve Truck 410.23

A6704 M22 x 1.5 Male F&J with long stem shut off valve Truck 164.12

0520001005 M16 x 1.5 Male F&J with long stem shut off valve Truck 128.60

0520030012 1/2" long stem Shut off valve only 61.57

0520030012LB 1/2" long stem Shut off valve only With Long Body 122.35

0520030112LB M22 long stem Shut off valve only With Long Body 163.14

AP11168 1/2" STRIKER PLUG / Operating Plug 41.46

4072 M22 Male Coupling with Shut Off Valve NEW EURO SPEC 583.07

4001 M22 x 1.5 Male Coupling NEW EURO SPEC 102.89

A5776 M22 x 1.5 STRIKER PLUG 50.21

0520030022 Dust cover (Female dummy) for male couplings with Chain and bracket 178.75

0520030142 Dust Flap Nylon for Female Couplings 32.33

1178075 Dust Plug male for female couplings with chain and bracket 150.00

A1121 Service Tag 13.97

A1122 Emergency Tag 13.97

0520030152 Plastic Mounting Bracket 20.21

PALM COUPLINGS

897 550 020 4 REPLACEMENT SEAL (PALM COUPLING) 24.50

952 200 021 0 EMERGENCY PALM (TRAILER) COUPLING 272.42

952 200 022 0 SERVICE PALM (TRAILER) COUPLING 272.42

952 200 221 0 EMERGENCY PALM (TRUCK) COUPLING 437.06

952 200 222 0 SERVICE PALM (TRUCK) COUPLING 437.06

DUOMATIC COUPLINGS

452 802 009 0 M16 X 1.5 TRUCK 3089.80

452 804 012 0 M16 X 1.5 TRAILER 660.92

ELECTRICAL SUZY

AGA347 7 PIN COIL & PLUGS ISO 7638 1742.95

A7184 7 PIN COIL & PLUGS ISO 7638 ABS/EBS SMALL COIL 3.5m (ADR) 1463.48

AGA348 15 PIN ISO 12098 COIL WITH PLUGS 2673.82

A7185 15 PIN ISO 12098 COIL WITH PLUGS SMALL COIL 3.5m (ADR) 2143.56

A7186 GREEN MAMBA - THE ORIGINAL ONE ! 7pin Venter type plug 3.5m On Request

AGA780 15 pin ISO to 12v 7pin Venter type plug 3.5m 3404.00

A7187 15 pin ISO to 12v 7pin Venter type plug 3.5m IMPORTED 1650.00

A6698 7 PIN FEMALE SOCKET EASY CONNECTION 498.36

A6699 7 PIN MALE PLUG EASY CONNECTION 498.36

A6701 15 PIN MALE PLUG EASY CONNECTION 938.28

A6700 15 PIN FEMALE SOCKET EASY CONNECTION 873.57

RUBBER HOSE

A3626 1/2" S.A.E. SPEC. HOSE PER METRE (SAE J1402) 79.46

SUZY PIPES

ASA5477 RED SUZI WITH SPRINGS & 1/2" FITTINGS 368.00

ASA5478 YELLOW SUZI WITH SPRINGS & 1/2" FITTINGS 368.00

A7188 NEW GENERATION SUZI black Red tail 4.0m M18 fitting* 457.70

A7189 NEW GENERATION SUZI black Yellow tail 4.0m M18 fitting* 457.70

* Kink proof from Twisting, Memory coil

13 of 30




SUGGESTED


SUGGESTED

RETAIL

NYLON PIPES Prices are indicated Per/ Metre

828 251 908 6 06 BLACK 15.84

A6038 06 RED 15.84

A6041 06 YELLOW 15.84

A6119 06 BLUE 15.84

A6245 06 GREEN 15.84

828 251 907 6 08 BLACK 20.88

A5914 08 RED 20.88

A6244 08 YELLOW 20.88

A6241 08 BLUE 20.88

A5912 08 GREEN 20.88

828 251 906 6 010 BLACK 27.67

A3005/N/10R 010 RED 29.34

A3005/N/10SY 010 YELLOW 29.34

A5606 011 BLACK (PUSH ON) 54.29

A5632 012 RED 45.48

A5633 012 GREEN 45.48

A5634 012 YELLOW 45.48

A5635 012 BLUE 45.48

A5782 012 BLACK 45.48

A5607 013 BLACK (PUSH ON) 59.47

828 251 904 6 015 BLACK 63.92

COMPRESSORS

411 003 011 0 SINGLE 150CC COMPRESSOR (SELF LUBE) 18151.92

411 034 501 0 NLA REPLACED BY 411 142 711 0 NLA

411 141 000 0 SINGLE 75MM BORE COMPRESSOR (MONO BLOCK) 15481.69

411 142 711 0 SINGLE 90MM BORE COMPRESSOR (M/BENZ) 8936.92

411 145 507 0 SINGLE 75MM BORE (MAN) 9747.09

411 151 009 0 COMPRESSOR, REPLACEMENT OF 411 151 008 0 8964.68411 154 004 0 SINGLE 85MM BORE (ACTROS/ATEGO) REPLACES 411 154 003 0 11352.48

411 553 003 0 COMPRESSOR FOR ATEGO BUS S/S 912 510 003 0 38012.91

412 100 806 2 MAN HEAD ONLY (F2000) NO GASKET S/S 412 100 805 2 3346.13

412 352 003 0 SINGLE 85MM BORE (MAN) 11267.70

412 352 027 0 AXOR COMPRESSOR ESS 10343.36

912 110 140 4 Mounting Flange gasket for 412 352 027 0 220.46

412 704 008 0 TWIN 85mm Bore (VOLVO) with ESS 5 Hole Mount (20701801) On request

412 704 014 0 COMPRESSOR FOR VOLVO FM 9 with ESS 5 Hole Mount (20842990) On request

911 155 521 0 COMPRESSOR CUMMIN'S ISC ENGINE 16577.79

911 504 506 0 COMPRESSOR FOR DAF 95X S/S 911 504 504 0 ESS 18347.42

911 505 150 0 TWIN COMPRESSOR VOLVO FL7 3 Hole Mount centre 20593.27

911 506 505 0 TWIN 75MM BORE (IVECO) On request

912 117 000 0 MAN COMPRESSOR 14268.34

912 510 103 0 TWIN 85mm Bore (AXOR) Replaces 912 510 104 0 (move plug) 27120.00

912 510 104 0 TWIN 85mm Bore (AXOR) Replaced by 912 510 103 0 (move plug) 27120.00

912 512 008 0 NLA Replaced by 912 512 029 0

912 512 029 0 VOLVO B13 Replaces 912 512 008 0 29141.00

412 704 018 0 TWIN 85mm Bore (VOLVO) ESS 3 Hole Mount off centre (21172036) 31593.65

M101170 COMPRESSOR FOR MAN CLA Replaced by M101610

M101610 COMPRESSOR FOR MAN CLA 13100.80

M100960 SINGLE CYLINDER COMPRESSOR FOR TATA 5465.63

M101221 TCL COMPRESSOR 2522.12

911 153 921 2 ISX CUMMINS HEAD-9111535100/60 12541.44

411 553 923 2 REPAIR KIT FOR 4115530030 6319.66

14 of 30




SUGGESTED


SUGGESTED

RETAIL

COMPRESSOR SPARES

411 003 000 0 COMPRESSOR SUPERCEDED TO 411 003 011 0 NLA

ASA5272 GASKET KIT INCLUDING OIL SEAL 293.55

ASA5273 RING SET (75MM BORE) 428.45

411 003 011 0 SELF LUBE 150CC COMPRESSOR 75MM BORE 18151.92

ASA5272 GASKET KIT (INCL. OIL SEAL) 293.55

ASA5273 RINGS (75MM BORE) 428.45

ASA6282 HEAD KIT 1407.00

411 011 000 0



411 042 340 4 MAIN BEARING BUSH 215.52

411 042 341 4 CON ROD BEARING PER HALF 77.83

411 041 845 0

ASA5277 HEAD KIT NLA

ASA5279 RING SET (75MM BORE) NLA



411 141 000 0 DEUTZ / IVECO / BELL COMPRESSOR


411 141 205 4 MAIN BUSH NLA

ASA5279 RING SET (75MM BORE) NLA

ASA6312 HEAD KIT NLA

411 142 711 0 SINGLE 229CC 90MM BORE COMPRESSOR (M/BENZ 1924)

411 142 651 4 HEAD KIT On Request

411 142 002 2 GASKET KIT 938.64

ASA5410 RING SET 293.66

411 143 805 0 DEUTZ / IVECO COMPRESSOR On request

411 141 205 4 BUSH On request

811 408 040 4 OIL SEAL 76.87

897 670 190 4 O' RING FRONT 7.24



411 145 507 0 MAN COMPRESSOR

411 041 050 4 VALVE PLATE 222.95

411 041 051 4 LEAF VALVE 290.00

411 042 341 4 CON ROD BEAING PER HALF 77.83

411 145 000 2 GASKET KIT 987.33

411 145 653 2 CYLINDER HEAD 1581.44

411 151 008 0 MERCEDES S/S 4111510090

411 154 002 2 HEAD 3468.80

911 501 624 2 PISTON & RINGS 1360.73

411 154 000 2 GASKET KIT 636.87

ASA6690 RINGSET Per Piston 85MM 315.38

411 154 003 0 MERCEDES ATEGO & BELL S/S 411 154 004 0

411 151 052 4 GASKET FOR BARREL AND VALVE PLATE On request

411 154 000 2 GASKET KIT 636.87

411 154 002 2 CYLINDER HEAD 3468.80

911 145 738 2 CON ROD 272.17

911 501 624 2 PISTON AND RINGS (85MM) 1360.73


15 of 30




SUGGESTED


SUGGESTED

RETAIL

COMPRESSOR SPARES Continued …….

412 352 003 0 MAN COMPRESSOR

412 352 001 2 GASKET KIT 921.59


911 145 738 2 CON ROD 272.17

911 501 624 2 PISTON WITH RINGS (85MM) 1360.73

412 352 924 2 HEAD L SHAPED HEAD 4776.53


412 704 008 0 TWIN CYLINDER COMPRESSOR (VOLVO)

412 704 920 2 GASKET KIT 1853.03

412 704 932 2 COMPLETE HEAD 8209.76

911 501 624 2 PISTON WITH RING 1360.73

911 505 732 2 CONROD NLA


412 704 014 0 COMPRESSOR FOR VOLVO FM 9

412 704 933 2 HEAD 11154.98

911 501 624 2 PISTON WITH RING 1360.73

412 704 018 0 VOLVO COMPRESSOR (S/S 412 704 015 0)

412 704 933 2 HEAD 11154.98

911 506 505 0 IVECO COMPRESSOR

911 506 928 2 GASKET KIT 1790.11

A6608 RING SET X 2 371.18

ASA7073 COMPLETE REPAIR KIT 1462.48

911 504 506 0 TWIN CYL - DAF COMPRESSOR Replaces 9115045040

911 504 920 2 CYLINDER HEAD NLA

411 141 623 2 PISTON WITH RING NLA

A6608 RINGS x 2 371.18

411 033 801 2 ADE 400 HEAD (THIN PLATE) - M/BENZ - kit only available


412 090 804 2 MAN COMPRESSOR HEAD ONLY NO GASKET, replaced 4120908032 4450.00

912 510 103 0 AXOR TWIN COMPRESSOR

912 510 920 2 CYLINDER HEAD 15133.98

912 551 001 0 NISSAN UD 460 NLA Replaced by 912 551 002 0 (Exclusive to UD)

912 551 921 2 CYLINDER HEAD 13147.17


412 352 027 0 MERC AXOR SINGLE CYLINDER

911 501 624 2 PISTON WITH RING 1360.73


412 352 923 2 GASKET KIT 946.29

412 352 922 2 CYLINDER HEAD 10165.43

912 110 140 4 GASKET FOR MOUNTING FLANGE 220.46

M100960 TATA Single Cylinder 5465.63

M111410 Valve Plate 1174.45

MSP1/226 RING SET 276.30

MSP1/216 GASKET KIT 649.52

M101610 MAN CLA Single Cylinder Replaces M101170

M112000 VALVE PLATE 3036.00

MSP1/311 RING SET 1104.00

MSP1/310 REPAIR KIT 1161.00


300001469 MAJOR KIT 236.55

300001487 RING SET 58.65

16 of 30




SUGGESTED


SUGGESTED

RETAIL

ABS COMPONENTS -TRUCK AND BUSES

ECU'S

446 004 335 0 ECU 4 CHANNEL 24V E-VERSION 10012.33

ABS-SOLENOID VALVES

472 195 082 0 SOLENOID VALVE 12V FREIGHTLINER 1/2" LHS (472 195 078 0) 2875.00

472 195 083 0 SOLENOID VALVE 12V FREIGHTLINER 1/2"RHS (472 195 079 0) 2875.00

472 195 016 0 SOLENOID VALVE 24V (MAN) M22 Bayonet 2382.62

472 195 018 0 ABS SOLENOID VALVE 24V 2382.62

ABS COMPONENTS -TRAILERS

ABS UNITS (ECU)

400 500 081 0 VCS II 24V (MIXED POWER SUPPLY) 2S/2M 4S/2M 4S/3M 9516.31

400 500 083 0 VCS II 12V 2S/2M 10606.34

400 500 070 0 VCS II 24V 2S/2M ONLY 9516.31

400 500 088 0 ABSCOM 4S/2M 5177.93

ABS MODULATOR RELAY VALVES

472 195 031 0 24V M22 BAYONET 2579.52

472 195 034 0 12V 1/2" 2838.41

472 195 041 0 24V M22 BAYONET (BOXER) VCS1 7906.92

ABS/EBS SENSOR CABLES (TRUCK & TRAILER)

441 032 808 0 SENSOR -400MM 368.11

441 032 823 0 SENSOR -2000MM 918.56

441 032 851 0 SENSOR -1500MM 440.91

441 032 905 0 SENSOR BPW (DISC/CALIPER) 350MM Straight 957.75

441 032 920 0 SENSOR TRUCK STRAIGHT 2.5M 597.68

441 032 921 0 SENSOR TRUCK STRAIGHT 3.0M Replaced by 441 035 926 2

441 035 926 2 SENSOR TRUCK STRAIGHT 3.0M 542.40

449 712 023 0 VCS EXTENSION CABLE 2300MM 134.32



449 723 030 0 SENSOR EXT CABLE 3.0M EBS - E 309.96

SENSOR BUSH

899 760 510 4 SENSOR COPPER BUSH 60.99

ABS/EBS CABLES AND POWER SUPPLY

449 423 060 0 SOLENOID VALVE EXTENTION CABLE -VARIO "C" -6M 733.27

449 423 120 0 SOLENOID VALVE EXTENTION CABLE -VARIO "C" -12M 868.42

449 615 030 0 DIAGNOSTIC CABLE VCSII -3M 630.71

449 616 158 0 3RD MODULATOR/DIAGNOSTIC CABLE 15/3M 2192.54

449 384 333 0 6M Y CABLE 12M STOPLIGHT POWER CABLE 3531.88

449 133 120 0 12M 7PIN ISO FEMALE SOCKET - SEMI TRAILER 2372.07

449 233 100 0 12M 7PIN ISO MALE SOCKET - DRAWBAR TRAILER 3256.33

449 173 150 0 POWER CABLE EBS E TRAILER 3153.50

ABS WARNING LIGHT

A6609 ABS WARNING LIGHT (ROUND -TANKERS) 131.28

17 of 30




SUGGESTED


SUGGESTED

RETAIL

EBS-D COMPONENTS -TRAILERS

CONTROL UNITS AND VALVES

480 102 010 0 EBS D MODULATOR (ECU) 4S/2M NLA

480 102 014 0 EBS D MODULATOR (ECU) 4S/3M WITH RSS on request

480 102 015 0 EBS D MODULATOR (ECU) 4S/2M WITH RSS FOR TCE ONLY NLA

449 372 130 0 EBS 3RD SOLENOID CABLE - TRAILERS 3410.56

EBS-E COMPONENTS -TRAILERS

CONTROL UNITS AND VALVES

480 102 030 0 MODULATOR (ECU) 2S/2M 4 GIO 24V RSS 23863.60

480 102 080 0 MODULATOR (ECU) 4S/2M Multi Voltage ABS 12/24V RSS 22704.96

480 102 066 0 MODULATOR (ECU) 4S/3M 7 GIO + PEM 2 24V RSS 14907.27

480 207 001 0 EBS 3RD MODULATOR 24V (DRAWBAR) 5561.56

446 192 110 0 SMARTBOARD With Battery 9866.84

446 192 111 0 SMARTBOARD Without Battery ADR Compliant 8721.60

449 911 120 0 SMARTBOARD to EBS E CABLE 1933.05

EBS COMPONENTS -TRUCKS

AXLE MODULATORS

480 103 012 0 EBS AXLE (6X2) 1999 MERCEDES 17252.04

480 103 016 0 EBS AXLE (6X2) 2001 MERCEDES 14505.96

480 103 033 0 EBS AXLE (6X4) NISSAN UD 440 19052.74

480 103 042 0 EBS AXLE (6X4) DAF 18915.77

480 104 002 0 EBS AXLE 16731.50

480 104 106 0 EBS AXLE MAN 2005 (Replacement for 480 104 104 0) 14619.95

BRAKE SIGNAL TRANSMITTER

480 001 000 0 ACTROS WITHOUT SILENCER M22 VOSS PORT 4 M16 8612.15

480 001 011 0 ACTROS WITH SILENCER WITHOUT SIGNAL PORT (4) M22 VOSS 7736.89

480 001 010 0 M22 VOSS PORT 4 M16 WITH SILENCER 7460.55

480 001 400 0 M22 VOSS NO PORT 4 WITH SILENCER (NISSAN UD440) 8367.99

480 001 500 0 M22 VOSS NO PORT 4 WITH SILENCER DAF 8595.40

480 020 003 0 CENTRAL BRAKE UNIT CBU MAN TGM On request

480 003 000 0 BRAKE SIGNAL TRANSMITTER 7451.55

EBS. ECU (ELECTRONIC CONTROL UNITS)

446 130 014 0 MB-ECU ACTROS 4X2 RIGID 6X2, 6X4 On request

446 130 015 0 MB-ECU ACTROS 4X2 On request

446 130 053 0 MB-ECU ACTROS MPII On request

TRAILER CONTROL VALVE

480 204 002 0 T.C.U (MERCEDES IVECO DAF 75 85 95 SERIES) NISSAN 6736.95

SUPERCEDES "001 0" VERSION

SLACK ADJUSTERS

433 576 502 0 Slack adjuster 5398.72

433 576 503 0 Slack adjuster 5398.76

433 506 103 0 Slack adjuster 2830.54

18 of 30




SUGGESTED


SUGGESTED

RETAIL

TATA SPARES AND COMPONENTS

M100960 TATA SINGLE CYLINDER COMPRESSOR 5465.63

M111410 Valve Plate 1174.45

MSP1/226 RING Set 276.30

MSP1/216 GASKET KIT 649.52

M600781 FOOT VALVE (Not Stocked - only Repair kit)


M600900 FOOT VALVE (Not Stocked - only Repair kit)


M304941 AIRDRYER 6109.89

MSP3/96 REPAIR KIT INCLUDES CARTRIDGE 2440.16

M305201 AIRDRYER WITH PROTECTION VALVE Diam: 110mm Leng:160mm 5645.02


M311700 CARTRIDGE ONLY 1729.28

M303510 AIRDRYER Diam: 130mm Length:120mm


M311370 CARTRIDGE ONLY 1619.34


300001469 MAJOR KIT 236.55

300001487 RING SET 58.65

M305201 Airdryer with protection valve Dia 110mm Length 160mm 5645.00


M302890 Hand Control Brake Valve 2 port with lock position 911.69

475 710 022 0 Mechanical Suspension Loadsensing Valve for TATA 2863.53

DIAGNOSTIC EQUIPMENT Please Speak to WABCO Sales personnel for Diagnostic pricing

ESSENTIAL EQUIPMENT

446 301 030 0 Diagnostic Interface & PC cable S/S 4463010220 On Request

446 300 329 2 Diagnostic Cable for Trailer VCSI VCSII TCE EBS On Request

446 300 360 0 Diagnostic Inter Adapter CAN Cable EBS-E On Request

446 300 361 0 Diagnostic Cable CAN for 4463003600 above EBS-E On Request

446 300 430 0 Compact Tester: Truck and Trailer ABS replaces 4463004100 On Request

446 300 400 0 Compact Tester V1,75 Vario C, VCS I and VCSII On Request

GENERAL SOFTWARE

446 301 510 0 Diagnostic Software for Trailer VCSII On Request

446 301 542 0 Diagnostic Software for Trailer EBS D On Request

446 301 588 0 Diagnostic Software for Trailer EBS E On Request

446 301 589 0 Diagnostic Software for Trailer EBS E On Request

446 301 682 0 Diagnostic Software for Trailer TCE On Request

446 301 545 0 Diagnostic Software for Truck EBS (Europe) On Request

446 301 556 0 Diagnostic Software for Truck EBS (Asia) On Request

446 301 628 0 Diagnostic Software D+ ABS E Gen Hino Toyota On Request

446 301 547 0 Diagnostic Software for Daimler Chrysler (Actros) On Request

446 301 874 0 Diagnostic Software ENR Actros/Merc ECAS On Request

446 301 692 0 Diagnostic Software ODR Tracker On Request

GENERAL DIAGNOSTICS CABLES

446 300 408 0 ABS/ASR E vers. Inter-Adapter Cable Hino Toyota On Request

446 300 317 0 ECAS / ATC Inter adapter 25pin On Request

446 300 344 0 EBS Diagnostic. Asia Vehicles OLD Nissan UD On Request

446 300 401 0ND EBS Diagnostic. Nissan UD On Request

446 300 454 0 EBS (EPB) Cable MPII (Actros, Axor, defender) On Request

446 300 340 0 EBS / ECAS (EPB) Cable (Actros Axor) old cable On Request

446 300 345 0 ZBR MAN cable (TGA MAN ECAS etc) On Request

19 of 30




SUGGESTED


SUGGESTED

RETAIL

ACCESSORIES AND GENERAL COMPONENTS

MOISTURE REPELLING AND PROTECTIVE SPRAY

A7178 NANO PROTECH 100ml can 360.00

CONSPICUITY TAPE

A7190 Yellow Tape Continuous 50mm wide 50m roll ECE 104 75.90

A7191 Yellow Tape Segmented Curtainsiders 50mm W 50m roll 89.70

A7192 Yellow Tape Segmented Tankers 50mm wide 50m roll ECE 104 92.00

SPIRAL BINDING

A900 SPIRAL BINDING (CLEAR) PER METRE 12.05

TEST EQUIPMENT -PNEUMATIC

AGA1390 TRAILER TEST KIT C/W GAUGES X 2 HOSES (6M) X 2 1931.47

453 004 007 0 WABCO TEST GAUGE 1452.00

AGA211 AIR GAUGE 0-10 BAR (DASH BOARD) 845.25

ASA5896* HOSE TEST GAUGE 519.12

TEST EQUIPMENT -ABS

SPEAK TO SALES COUNTER FOR SPECIAL PRICING

TEST GAUGE

453 004 007 0 PRESSURE GAUGE 0-16 Bar 1452.00

20 of 30




SUGGESTED


SUGGESTED

RETAIL

STANDARD COMPRESSION FITTINGS

UNIONS

893 800 294 0 M10-06 41.15

893 800 304 0 M10-08 91.33

893 800 014 0 M12-06 32.60

893 800 234 2 M12-08 31.01

893 800 044 0 M12-010 39.73

893 800 984 0 M12-012 66.93

893 800 064 0 M14-06 45.63

893 800 244 0 M14-08 37.67

893 800 073 0 M14-010 46.19

1677039 M14-012 115.67

893 809 010 0 M16-06 44.65

893 809 020 0 M16-08 48.23

893 801 994 0 M16-010 62.80

893 800 974 0 M16-012 66.87

893 800 022 0 M22-06 53.25

893 800 224 0 M22-08 50.18

893 800 109 0 M22-010 55.62

893 800 964 0 M22-012 75.90

893 800 033 0 M22-015 (STOSS) 110.24

ASA5223 M22-015 (SHORT) 82.55

893 800 264 0 M26-015 (STOSS) 133.96

ASA7077 M26-015 (SHORT) 163.10

893 800 254 0 M26-018 (STOSS) 209.32

893 801 000 0 1/8" BSP-06 55.76

893 800 371 0 1/4" BSP-06 61.23

893 800 904 0 1/4" NPT-08 46.05

ASA5128 1/2"BSP-012 (STEEL) 103.23

ASA931 1/2"NPT-012 116.47

ASA5182 1/2"NPT-012 (STEEL) 142.34

ASA5315 1/2"NPT-015 (STEEL) 133.96

893 801 314 0 1/4"NPT-012 (STEEL) 63.12

ASA5208 3/8"NPT-012 58.97

ELBOWS

893 830 104 0 M12-08 (BULKHEAD) 155.96

ASA6503 M16-08 160.76

893 830 214 0 M16-012 (BULKHEAD) 144.62

893 830 770 0 M22-08 (BULKHEAD) 186.31

893 830 204 0 M22-012 (BULKHEAD) 86.00 143.74

893 830 042 0 M22-015 (STOSS) 202.34

ASA5225 M22-015 SHORT NUT 173.04

893 890 063 0 M22 (M) -M22 (FEM) 214.91

ASA1342 010SW-010 144.52

ASA1258 012SW-012 149.71

ASA1261 06SW-06 129.14

ASA1263 08-08 B/H 205.70

ASA1476 08SW-08 106.05

ASA965 1/2"NPT-012 (BRASS) 193.25

ASA6579 1/4" NPT-08 161.29

ASA5313 1/4"NPT-012 243.03

ASA963 1/4"NPT-012 (BRASS) on request

ASA1237 1/8"NPT-06 on request

ASA1435 3/8"NPT-012 164.12

893 830 091 0 M26-015 (BULKHEAD) 337.81

21 of 30




SUGGESTED


SUGGESTED

RETAIL

TEES

893 860 053 0 010-010-010 186.49

ASA1504 010SW-010-010 173.04

893 860 374 0 012-012-012 (STEEL) 9 179.40

ASA1259 012-012SW-012 212.27

893 860 394 0 012-06-012 397.71

893 850 314 0 012-M22-012 345.37

ASA1260 012SW-012-012 196.57

ASA5258 012SW-06-012 176.02

ASA5207 012SW-TEST-012 415.38

893 860 014 0 06-06-060 130.25

ASA1345 06-06SW-06 172.38

ASA1336 06SW-06-06 198.08

893 860 194 0 08-06-080 199.11

893 860 144 0 08-08-080 186.99

ASA5242 08-08SW-08 223.27

ASA5443 08SW-08-08 145.13

A1012 1/2" HOSE TEE 78.92

A844T 1/4"(F)-1/4"(F)-1/4"(F) (T-BLOCK) 80.39

A636 1/4"(M)-1/4"(F)-1/4"(F) (T-BLOCK) 79.51

A637 3/8"(M)-3/8"(F)-3/8"(F) (T-BLOCK) 93.30

A6605 3/8"(M)-1/4"(F)-3/8"(F) 100.01

A6606 M16(M)-1/4"(F)-3/8"(F) 100.01

893 850 660 0 M16-012-012 on request

893 850 324 0 M22-012-012 300.06

893 850 394 0 M22-M22-012 use ASA7262P

893 500 044 4 M22-M22-M22 on request

BULKHEAD STRAIGHTS

ASA5366 012-1/2"BSP 158.92

ASA1009 1/2"-012 B/H (BRASS) 158.38

893 821 234 0 M16-012 148.66

893 103 900 4 M16-M22 (BODY ONLY) 92.22

893 821 224 0 M22-012 (BULKHEAD STRAIGHT) 93.50

893 890 040 0 M22-1/2"BSP 159.49

893 890 014 0 M22-M22 66.98

LINE CONNECTORS

893 820 024 0 010-010 55.11

893 820 160 0 010-010 (BULKHEAD LINE CONNECTOR) on request

893 820 564 0 012-012 64.50

893 820 574 0 012-012 (BULKHEAD LINE CONNECTOR) 101.07

ASA5231 015-015 (SHORT NUT) 106.05

893 820 061 0 015-015 (STOSS) 142.34

ASA5261 016-016 (SHORT NUT) 329.34

893 820 012 0 06-060 46.72

893 821 390 0 06-06 (BULKHEAD LINE CONNECTOR) 96.18

893 820 134 0 08-080 42.87

ASA5255 08-08 (BULKHEAD LINE CONNECTOR) 79.61

TEST CONNECTORS

463 703 106 0 M14 (FEM) 174.38

ASA5254 M16 (FEM) 168.44

463 703 114 0 M16 (M) 122.46

463 703 107 0 M18 (FEM) 221.15

ASA5207 012SW-TEST-012 TEE 415.38

463 705 102 0 1/4"NPT (MALE) 127.26

22 of 30




SUGGESTED


SUGGESTED

RETAIL

'O' RINGS

897 071 110 4 M12 1.74

897 770 070 4 M14 1.89

897 770 250 4 M16-M18 1.38

897 080 400 4 M22 1.98

THRUST RINGS

893 030 070 4 M12 7.75

893 030 080 4 M14 17.91

893 030 014 4 M15 14.93

893 030 170 4 M16 6.59

893 030 020 4 M18 27.47

893 030 040 4 M22 7.25

LOCKNUTS

5000112 M8 2.37

5000113 M10 3.83

810 304 031 4 M16 (BOOSTERS) 13.25

810 315 004 4 M16 10.34

810 315 005 4 M18 14.20

891 500 454 4 M22 11.61

891 500 464 4 M26 19.25

891 500 520 4 M28 (EXHAUST BRAKE VALVE 3./2 WAY DIR. CONT. V) On request

A6001 M8 (NYLOC) On request

INSERTS

893 040 210 4 06L 2.34

893 040 220 4 08L 3.16

893 040 230 4 10L 3.89

893 040 240 4 12L 4.58

893 040 250 4 15L 6.04

CUTTING RINGS

893 050 014 4 06L 6.53

893 050 054 4 08L 7.16

893 050 024 4 10L 7.81

893 050 144 4 12L 10.02

893 050 034 4 15L 10.48

A5554 16L On request

893 050 040 4 18L 16.24

PIPE NUTS

893 070 054 4 06 (M12) 6.00

893 070 104 4 08 (M14) On request

893 070 834 4 012 (M18) On request

893 070 065 4 015 (LONG) On request

893 070 174 4 015 (SHORT) NLA

KOR'S

ASA5252 08-060 60.86

ASA1267 012-060 121.72

ASA1351 012-080 58.22

ASA1350 012-010 61.40

ASA5490 016-012 On request

ADAPTORS/HOSE TAILS

A23 1/2"NPT-1/2" HOSE 62.55

A24 3/8"NPT-1/2" HOSE 20.70

A25 1/4"-1/2" HOSE 33.62

A588 Ø12 PIPE STEM-1/2" HOSE 64.83

A646 M22-1/2" HOSE 98.62

4087055F M16 M HOSE ADAPTOR WITH O RING replaces 893 120 414 4 83.32

23 of 30




SUGGESTED


SUGGESTED

RETAIL

PLUGS

893 010 030 4 M12 28.39

893 010 011 4 M14 35.85

893 011 710 4 M16 37.00

893 011 711 4 M16 (FOOTBRAKE)

893 010 020 4 M22 40.00

893 010 230 4 M26 On request

A174 1/8"NPT 14.06

A31 1/4"NPT 17.15

A30 3/8"NPT 17.15

A29 1/2"NPT 40.44

NIPPLES

893 100 035 4 M22-M22 42.20

893 100 164 4 M22-1/2"BSP 113.78

893 103 900 4 M16-M22 BULKHEAD ADAPTOR 92.22

893 890 014 0 M22-M22 BULKHEAD 66.98

893 890 040 0 M22-1/2" BULKHEAD 159.49

A60 1/4"NPT-1/4"NPT 37.23

A6217 1/2"-1/2"NPT 69.48

SOCKETS

893 240 224 4 M12 39.87

893 300 011 4 M22 (LONG) 77.74

893 300 012 4 M22 (SHORT) 47.54

W103/8 1/2"NPT 61.47

CABLE TIES

A1134 200MM PRICE PER BUT SOLD IN PACK OF 100 0.78

A6153 395MM PRICE PER BUT SOLD IN PACK OF 100 3.38

REDUCERS

893 180 034 4 M16 (M-M22F) 89.35

893 180 880 4 M26(M)-M22(F) 197.18

893 181 184 4 M22(M)-M16(F) , replaced by 8931040522

A34 3/4"NPT(M)-1/2"NPT(F)

A36 3/8"NPT(M)-1/4"NPT(F) 24.90

A39 1/2"NPT(M)-1/4"NPT(F) 50.21

A498 M22(M)-1/4"NPT(F) 42.87

A499 M22(M)-3/8"NPT(F) 42.87

A5379 M16(M)-3/8"NPT(F) 61.60

A6181 1/4"NPT(M)-1/8"NPT(F) 16.73

A672 1/2"NPT(M)-M22(F) 93.14

A673 M22(M)-1/2"NPT(F) 76.79

PIPE CLIPS / CLAMP

893 511 110 4 06 P-CLIP 21.92

893 511 000 4 012 P-CLIP 12.68

893 511 010 4 015 P-CLIP 17.59

A5370 1/2" HOSE P-CLAMP 5.71

A6669 1/2" HOSE P-CLAMP (12 - 22MM) 11.66

A6183 1/2" HOSE P-CLAMP (16 - 25MM) 13.68

A6720 1/2" HOSE P-CLAMP (20 - 22MM) 32.60

24 of 30




SUGGESTED


SUGGESTED

RETAIL

PUSH IN FITTINGS

STRAIGHT UNIONS

893 803 035 0 M10 - 6mm (M10x1 thread) on request

893 803 022 0 M12 - 6mm (alternative 4100916M) on request

893 803 023 0 M16 - 6mm on request

893 803 024 0 M22 - 6mm on request

893 803 025 0 M10 - 8x1 mm (M10x1 thread) 93.20

893 800 007 2 M12 - 8x1 mm (8938034900, 4100888M) ** 66.98

893 800 001 2 M16 - 8x1 mm (8938035400, 4100911M) ** 63.71

893 800 005 2 M22 - 8x1 mm (8938034000, 4100913M) ** 80.94

893 800 002 2 M16 - 12x1.5 mm (8938034300, 4100915M) ** 67.06

893 800 008 2 M22 - 12x1.5 mm (8938034400, 4100914M) ** 89.88

893 800 004 2 M22 - 15x1.5 mm (8938037800, 4101056M) ** 106.61

893 803 420 0 M22 - 10x1 mm on request

893 803 410 0 M16 - 10x1 mm replaced by 8938000092

893 803 990 0 M26 - 15x1.5 mm 311.06

893 800 005 2 M16 - 16 x 1 ** 80.94 Plastic Release Tool

** This type of fitting has pipe removable using a tool below

899 700 001 4 8mm Nylon Pipe Extraction tool plastic 37.13

899 700 002 4 12mm Nylon Pipe Release tool plastic 38.70

899 700 003 4 15mm Nylon Pipe Release tool plastic 42.57

899 700 012 4 8mm Nylon Pipe Release tool stainless steel 1388.50

899 700 014 4 12mm Nylon Pipe Release tool stainless steel 1388.50

899 700 015 4 15mm Nylon Pipe Release tool stainless steel 1388.50 Stainless Release Steel

MALE BULKHEAD BARREL TEE BLOCK

893 851 400 0 M22-M16F-M16F * (alternative 4101087M) 219.21

893 851 390 0 M16-M16F-M16F * (alternative 4101086M) 205.13

4101083M M12-M12F-M12F 134.72

* WITH Lock nut, Thrust ring and O ring

MALE BULKHEAD STUD BLOCK

4101005M M22 / M22 - M16F B/H stud * (alternative 8931042962) 136.76

4101017M M16 / M22 - M16F B/H stud * (alternative 8931042972) on request


MALE BULKHEAD ELBOW BLOCK

893 401 008 4 M12 - M12F B/H Elbow stud * on request



893 890 450 0 M22 - M22F B/H Elbow stud * 152.33

4101105M M22-M16F B/H Elbow stud NLA

4101098M M12-M12F B/H Elbow stud 116.57

4101102M M16-M16F B/H Elbow stud on request

* WITHOUT Lock nut, Thrust ring and O ring

FEMALE TEE BLOCK

4100994M M12F - M12F - M12F TEE Block (alternative 8935010054) 173.88

893 501 191 4 M16F-M16F-M16F TEE BLOCK (alternative 4100993M) 72.57

893 501 197 4 M22-M22F-M22F TEE BLOCK (alternative 4101198M) 180.70

25 of 30




SUGGESTED


SUGGESTED

RETAIL

MALE BULKHEAD TEE BRANCH BLOCK

890 159 586 4 M16F -M22 - M16F TEE Branch * 261.89

4101096M M16F-M22-M16F TEE BRANCH (alternative 8901595864 *) 176.62

4101095M M16F -M16 - M16F TEE Branch (alternative 8935010014 * ) on request

4101091M M12F -M12 - M12F TEE Branch (alternative 893 501 006 4 * ) on request

A6605 3/8M - 1/4F - 3/8F TEE Branch (replaces A36 & A637) 100.01

A6606 M16M -1/4F - 3/8F TEE Branch 100.01

* WITHOUT Lock nut, Thrust ring and O ring

SCREW THREAD WITH SWIVEL PLUG

893 920 827 2 M 10x1 Swivel Plug P5 on request

893 129 191 2 M 12x1.5 Swivel Plug P5 on request

893 129 192 2 M 16x1.5 Swivel Plug P5 50.99

893 129 193 2 M 22x1.5 Swivel Plug P5 64.37

SWIVEL PLUG ELBOW

893 401 827 2 M12x1.5 Elbow for P5 plug 76.40

893 401 015 2 M 16x1.5 Elbow for P5 plug 71.76

SWIVEL PLUG BARREL TEE

893 501 193 4 M12x1.5 Barrel Tee for P5 plug on request

893 501 194 4 M 16x1.5 Barrel Tee for P5 plug on request

SWIVEL PLUG BRANCH TEE

893 501 195 4 M12x1.5 Branch Tee for P5 plug on request

893 501 196 4 M 16x1.5 Branch Tee for P5 plug on request

BULKHEAD UNIONS

ASA7098 M16 - 12mm * on request

ASA7169 M22 - 12mm * (Alternative: ASA7100) 209.01

ASA7099 M22 - 08mm * 195.60

ASA7123 M22 - 12mm * M18 body 244.96

ASA7124 M22 - 08mm * M18 body 293.07


BULKHEAD ELBOWS

ASA7101 M22 - 12mm Swivel Type Short P5 plug (alternative: ASA7170) 257.50

ASA7102 M12 - 08mm * (Alternative: 893 831 291 0 * ) 185.99

ASA7103 M16 - 08mm Swivel Type Short P5 plug (Alternative: 893 831 293 0 *) 226.85

ASA7187 M22 - 15mm * 303.73


TEES

ASA7105 08-08-08 374.82

ASA7182 12-12-12 (Alternative: ASA7104) 364.45

ASA7106 15-15-15 (Alternative: ASA7183) 522.83

ASA7177 012-08-012 327.42

ASA7203 012-08-08 386.27

26 of 30




SUGGESTED


SUGGESTED

RETAIL

BRANCH TEES (ASSEMBLED)

ASA7107 012-M22-08 * (replaces: 8938510200) 342.22

ASA7109 012-M22-012 * (replaces 8938509700 and ASA7202) 300.11

ASA7164 08-M22-08 * 540.20


BARREL TEES (ASSEMBLED)

ASA7108 M22-012-08 * (replaces 8938510500) 297.69

ASA7110 M22-012-012 * 298.84

ASA7115 M12-08-08 * (replaces 8938510600)


TEST POINT TEES (ASSEMBLED)

ASA7111 M22 - TP - 08 * 331.05

ASA7112 M22 - TP - 012 * 336.81

ASA7113 M16 - TP - 012 * 318.32

ASA7114 M16 - TP - 08 * 333.12

ASA7097 M12 - TP - 08 * 297.61


LINE CONNECTORS

893 803 034 0 6mm-6mm 175.59

893 803 037 0 08mm - 08mm (replaces 4101064M) 170.34

893 803 039 0 12mm - 12mm (replaces 4101066M) 194.80

893 803 041 0 15mm - 15mm on request

VEE NUTS

893 771 236 4 VEE Nut 6x1 Pipe M12 66.41

893 771 234 4 VEE Nut 8x1 Pipe M14 66.41

893 771 235 4 VEE Nut 12x1.5 Pipe M18 101.19

O-RINGS

897 071 110 4 M12 1.74

897 770 250 4 M16 1.38

897 080 400 4 M22 1.98

THRUST RINGS

893 030 070 4 M12 7.75

893 030 170 4 M16 6.59

893 030 040 4 M22 7.25

27 of 30




SUGGESTED


SUGGESTED

RETAIL

VARIOUS

891 503 076 2 Locknut with O ring M22 On request

891 500 454 4 Locknut withOUT O ring M22 11.61

4101058M M16 M Test point (alternative 4637031140) 99.95

4101057M M12 M Test point (replaces 4637020030) 100.95

893 022 014 4 M16 M Plug with Oring (alternative 4101061F) 35.85

893 022 015 4 M22 M Plug with Oring (alternative 4087057F) 58.67

A6735 3/8" - 1/2" Hose Tail 56.94

4087055F M16 - 1/2" Hose Tail with Oring (alternative 8931294452 ) 83.32

4087063F M22 - 1/2" Hose Tail with Oring (alternative 8931294462) 87.97

ASA7127 M16M - 1/2"hose - 1/2" hose 293.94

M22 - 1/2" Hose Tail with Oring M22 X 1.5 X 13mm

893 104 058 4 M22 Bulkhead Stud ID M16 (alternative 4100992M) On request

(No Locknut)

899 360 210 4 Thread Filter M 12x1.5 On request

899 360 260 4 Thread Filter M 16x1.5 15.91

899 360 140 4 Thread Filter M 22x1.5

4101163M M18 - M16 Socket 72.55

A6717 M16 - 1/2" Socket On request

28 of 30




SUGGESTED


SUGGESTED

RETAIL

COMPOSITE FITTINGS (PLASTIC)

UNION PLUG (Threadless)

893 800 091 2 UNION 8x1 mm pipe REGULAR 65.99

893 800 096 2 UNION 8x 1 mm pipe SMALL 61.21

893 800 093 2 UNION 12x 1.5mm pipe REGULAR 76.85

893 800 098 2 UNION 15 x 1.5 mm pipe HEAVY

UNION TEE BLOCK

893 503 071 4 UNION T&L SMALL 80.93

893 503 072 4 UNION T&L REGULAR 73.46

893 503 073 4 UNION T&L HEAVY on request

TEST POINT (Threadless)

893 880 011 0 Test Point REGULAR 72.12

SWIVEL BODY (Threaded)

893 920 313 2 SWIVEL M12 x 1.5 SMALL 55.20

893 920 314 2 SWIVEL M12 x 1.5 REGULAR 59.80

893 920 316 2 SWIVEL M16 x 1.5 SMALL 53.83



893 920 320 2 SWIVEL M22 x 1.5 HEAVY

PUSH IN ELBOW

893 920 323 2 90 DEG 8 x 1 mm pipe SMALL 115.63

893 920 324 2 90 DEG 8 x 1 mm pipe REGULAR 118.54

893 920 326 2 90 DEG 12 x 1.5 mm pipe REGULAR 123.77

893 920 327 2 90 DEG 15 x 1.5 mm pipe HEAVY M18 body

BULKHEAD ELBOWS

ASA7101P M22 - 12mm pipe Swivel Type 197.58



ASA7187P M22 - 15mm pipe Swivel Type on request


29 of 30




SUGGESTED


SUGGESTED

RETAIL

TEE

ASA7105P 08-08-08 mm pipe 264.57

ASA7182P 12-12-12 mm pipe 304.03

ASA7106P 15-15-15 mm pipe on request

ASA7177P 12-08-12 mm pipe 300.96

ASA7203P 12-08-08 mm pipe 289.92

BULKHEAD SWIVEL TEE

ASA7107P 012-M22-08 mm pipe 284.74

ASA7109P 012-M22-012 mm pipe 295.61

ASA7164P 08-M22-08 mm pipe 282.32

BULKHEAD SWIVEL BARRELTEE

ASA7108P M22-012-08 284.74

ASA7110P M22-012-012 295.61

ASA7115P M12-08-08 258.13

ASA7218P M16-12-12 245.02

ASA7261P M16-08-12 235.10

BULKHEAD SWIVEL TEST POINT BARRELTEE

ASA7111P M22 - TP - 08 276.79

ASA7112P M22 - TP - 012 290.86

ASA7113P M16 - TP - 012 267.40

ASA7114P M16 - TP - 08 256.51

ASA7097P M12 - TP - 08 270.19

30 of 30


Date post:	06-Feb-2018
Category:	Documents
Upload:	trankiet
View:	230 times
Download:	3 times

AUTOMOTIVE SA PRICE LIST - APRIL 2017 - WABCO list-april-2017.pdf · automotive sa price list -...

Documents