of 198
Document No : BPS-0SGA-121 103
Rev : 0
Date : 6th June 2015
Rev. # Clause #
Cikarang Listrindo CFPP Coal Fired Power Station, Babelan - Fire Protection System
Title : Technical Submmission of the Pump & Accessories
Description of Change
_________________
Date : Approved By
(F-Consult Ltd)
Patrick Lee________________________ _________________________
Date: 6th June 2015 Date :Prepared By Reviewed By
(Deluge Fire Protection) (PT Cikarang Listrindo)
NO Page
1 3 -- 97a
b
c
2 98 -- 198a
b
c
Nominal Pump Capacity 12 m.cu/ hr (200 lpm) @ 10 bar
Nominal Pump Capacity 1500 usgpm (5650 lpm) @ 10 bar
Electric Jockey Pump Nominal Pump Capacity 12 m.cu/ hr (200 lpm) @ 11 bar
Aurora Diesel Fire Water Pump
Description
Aurora Electric Fire Water Pump set Per UL/FM ApprovedNominal Pump Capacity 2000 usgpm (7570 lpm) @ 9 bar
Aurora Diesel Fire Water Pump set Per UL/FM ApprovedNominal Pump Capacity 2000 usgpm (7570 lpm) @ 9 bar
Aurora Electric Fire Water PumpNominal Pump Capacity 1500 usgpm (5650 lpm) @ 10 bar
Pumps and Accessories for Fuel Handling System
Pumps and Accessories for Power Island System
Electric Jockey Pump
Nominal Pump Capacity 12 m.cu/ hr (200 lpm) @ 11 bar
T
TEC
ECHCOASTA
ELECTDIESJOCK
HNALFATITRICFIREELFIREPKEYPUMP
NICFIRIONPUMP.CapPUMPCap.PCap.12M
CAREDN,BA
p.2000Gp2000Gpm
M3/H@10
ALPOABEm@9Bam@9Bar00MeterT
P
070707
DAOWEELAarTotalHeTotalHeaTotalHead
AUPT. ROD
7/17/207/17/207/17/20
ATERAN
eadadd
URORADA NU
13-0
014014014
TA
A PUMPRMALA05-2015
PA5
Project : Coal Fired Power Station, Babelan INDUSTRIAL DIVISION
No
1 2 Set
1 "Aurora" Horizontal Split CaseModel : 8-481-21/Single StagePump Material Design, Casing : Cast Iron, Impeller : Bronze, Shaft : Carbon Steel with Bronze Sleeve, Shaft Seal : Gland PackingPump Accessories : Suction and Discharge Gauges, Automatic AirRelease Valve, Casing Relief Valve
1 "Factory Choice" ODP Electric Motor 250 HP @ 1480 RpmWith 380V/ 3Ph/ 50Hz
1 "Tornatech" Electric Fire Pump ControllerModel : GPY
2 1 Set
1 "Aurora" Horizontal Split CaseModel : 6-491-14A/single stagePump Material Design, Casing : Cast Iron, Impeller : Bronze, Shaft : Carbon Steel with Bronze Sleeve, Shaft Seal : Gland PackingPump Accessories : Suction and Discharge Gauges, Automatic AirRelease Valve, Main Relief Valve, Enclosed Waste Cone
1 "CLARKE" Diesel Engine JU6H-UFAAS0, 260 HP @ 2100 RpmHeat Exchanger Cooling System with cooling loop and double startertwin solenoidEngine accessories : Batteries Cables, Battery rack, Silencer,Flexible Exhaust Connector, Fuel Tank (Supplied by Import)
1 "Tornatech" Diesel Fire Pump ControllerModel : GPD- Flow Meter
3 1 Set
1 "Aurora" Vertical Multistage In-LineModel : PVM 10-14Pump Material Design, Casing : Stainless Steel, Impeller : StainlessSteel, Shaft : Stainless Steel, Shaft Seal : Mechanical Seal
1 "Factory Choice" Motor 10 HP @ 2915 Rpm
Cap. : 12 M/H @ 100 Meter Total Head
Cap. 2000 GPM @ 9 Bar Total Head
DIESEL FIRE PUMP UL/FM, NFPA-20 STANDARDCap. 2000 GPM @ 9 Bar Total Head
JOCKEY PUMP
Qty Description
Pump and Accessories For Fuel Handling SystemsELECTRIC FIRE PUMP UL/FM, NFPA-20 STANDARD
SUBJECT : TECHNICAL REVIEW
Page 1 of 2
1
REFERENCE LIST AURORA PUMP IN INDONESIA
NO PROJECT NAME LOCATION LINE DUTY YEAR
1 HINDOLI PALEMBANG BUILDING FIRE PUMP 1988
2 SEMEN CIBINONG CIBINONG INDUSTRY FIRE PUMP, TRANSFER PUMP 1999
3 MACRO DENPASAR BUILDING FIRE PUMP 1999
4 BATU HIJAU WTP SECTION I - MINING FIRE PUMP 1999
5 PLAZA DAGO BANDUNG BUILDING FIRE PUMP 1999
6 MAKRO JAKARTA BUILDING FIRE PUMP 1999
7 MAKRO MEDAN BUILDING FIRE PUMP 2000
8 SCHLUMBERGER BALIKPAPAN BUILDING FIRE PUMP 2000
9 BATU HIJAU WTP SECTION II - MINING FIRE PUMP 2000
10 MULAWARMAN UNIV. PACKAGED I - BUILDING FIRE PUMP 2000
11 MULAWARMAN UNIV. PACKAGED II - BUILDING FIRE PUMP 2000
12 MULAWARMAN UNIV.PACKAGED III - BUILDING FIRE PUMP 2000
13 GS BATTERY JAKARTA FACTORY FIRE PUMP 2000
14 AUTO 2000 TEBET JAKARTA SHOWROOM FIRE PUMP 2001
15 GLOBAL AGROTEK JAKARTA BUILDING FIRE PUMP 2002
16 MALL FANTASI BALIKPAPAN BUILDING FIRE PUMP 2002
17 TEMPO MEDAN WAREHOUSE FIRE PUMP 2002
18 SUSU CAIR INDOMILK - FACTORY FIRE PUMP 2002
19 PRESIDEN HOTEL JAKARTA BUILDING FIRE PUMP 2002
20 BINTARO TRADE CENTER JAKARTA BUILDING FIRE PUMP 2003
21 MALL KAREBOSI MAKASSAR BUILDING FIRE PUMP 2003
22 MULIA TOWER JAKARTA BUILDING FIRE PUMP 2003
23 BNI46 LADA JAKARTA BUILDING FIRE PUMP 2003
24 EXSPAN KAJI JAKARTA BUILDING FIRE PUMP 2003
25 WTC MANGGA DUA JAKARTA BUILDING PLUMBING 2003
26 TAMAN IMPIAN JAYA ANCOL JAKARTA BUILDING FIRE PUMP 2003
27 SEMEN CIBINONG CIBINONG CEMENT INDUSTRY SEWAGE PUMP 2003
28 PANGRANGO PLAZA BOGOR BUILDING FIRE PUMP 2003
29 ACA BANDUNG BUILDING FIRE PUMP 2003
30 ITC KEBON KELAPA BANDUNG MARKET FIRE PUMP 2003
31 PUPUK KUJANG CIKAMPEK WAREHOUSE WATER IN TAKE VERTICAL TURBINE 2004
32 MATA PELANGI OFFICE JAKARTA BUILDING FIRE PUMP 2004
33 BSD MARKET TANGERANG BUILDING FIRE PUMP 2004
34 TOTAL INDONESIA - MINING PROCESS PUMP 2004
35 GRAND SOLO MALL SOLO BUILDING FIRE PUMP 2004
36 CIPUTRA SERAYA MALL PEKANBARU BUILDING FIRE PUMP 2004
2
37 PUSAT DAGANG INVESTASI BATAM BUILDING FIRE PUMP 2004
38 BELLAGIO RESIDENCE JAKARTA BUILDING FIRE PUMP 2004
39 PONDOK INDAH MALL 2 JAKARTA BUILDING FIRE PUMP, CHILLER PUMP 2004
40 SAN MIGUEL JAKARTA FACTORY FIRE PUMP 2004
41 BAYER MEDAN FACTORY FIRE PUMP 2005
42 BAYER SURABAYA FACTORY FIRE PUMP 2005
43 MEGA GLODOK KEMAYORAN JAKARTA BUILDING FIRE PUMP 2005
44 SEMEN PADANG PADANG CEMENT INDUSTRY COOLING TOWER 2005
45 SEMEN CIBINONG CIBINONG CEMENT INDUSTRY WATER INJECTION 2005
46 SEMEN CIBINONG CIBINONG CEMENT INDUSTRY WATER SPRAY 2005
47 PERTAMINA PRABUMULIH PRABUMULIH OIL & GAS FIRE PUMP 2005
48 - - - FIRE PUMP 2005
49 BG JUNCTION / BUBUTAN SURABAYA BUILDING CHILLER & BOOSTER 2005
50 BAYER JAKARTA FACTORY VERTICAL TURBINE FIRE PUMP 2005
51 BPKP PRAMUKA JAKARTA BUILDING FIRE PUMP 2005
52 BATAM CITY SQUARE BATAM BUILDING FIRE PUMP 2005
53 MECOINDO CIKARANG FACTORY FIRE PUMP 2006
54 - - OIL & GAS FIRE PUMP 2006
55 GRIYA JENGGALA JAKARTA RESIDENTIAL FIRE PUMP 2006
56 SUDIRMAN PARK JAKARTA BUILDING FIRE PUMP 2006
57 PEARL GARDEN JAKARTA BUILDING FIRE PUMP 2006
58 MODERN GOLF APARTEMENT TANGERANG BUILDING FIRE PUMP 2006
59 CITY HOME KLP. GADING JAKARTA BUILDING FIRE PUMP 2006
60 ISLAMIC CENTER JAKARTA BUILDING FIRE PUMP 2006
61 INDONESIA NS FACTORY JAKARTA FACTORY FIRE PUMP 2006
62 PLAZA CIBUBUR JAKARTA BUILDING FIRE PUMP 2006
63 SUDIRMAN PLAZA JAKARTA BUILDING FIRE PUMP 2006
64 WISMA 76 JAKARTA BUILDING FIRE PUMP 2006
65 GRAND INDONESIA JAKARTA BUILDING
FIRE PUMP, CHILLER PUMP, PLUMBING PUMP
2006
66 NUSA 2 GOLF RESIDENT BALI BUILDING FIRE PUMP 2006
68 PT. PJB UP MUARAKARANG JAKARTA POWER PLANT FIRE PUMP 2006
69 LAMONGAN INTEGRATED SHORE BASE LAMONGAN SHORE BASE - WAREHOUSE FIRE PUMP 2006
70 UPH KARAWACI TANGERANG BUILDING FIRE PUMP 2006
71 XL PEKAN BARU PEKAN BARU BUILDING FIRE PUMP 2006
72 DSS PROJECT JAKARTA FACTORY FIRE PUMP 2006
73 SKF INDONESIA JAKARTA FACTORY FIRE PUMP 2006
74 JOHNSON & SON PROJECT JAKARTA FACTORY FIRE PUMP 2006
75 SENTRA GROSIR CIKARANG BUILDING FIRE PUMP 2006
76 SEMEN BASOWA SULAWESI CEMENT INDUSTRY REGENERATIVE TURBIN PUMP 2006
3
77 GRAND INDONESIA JAKARTA BUILDING FIRE PUMP 2006
78 KEDUTAAN BELANDA JAKARTA BUILDING FIRE PUMP 2006
79 HARDA BANK JAKARTA BUILDING VERTICAL TURBINE FIRE PUMP 2006
80 MENARA PRIMA JAKARTA BUILDING FIRE PUMP 2006
81 WISMA PONDOK INDAH JAKARTA BUILDING FIRE PUMP, CHILLER PUMP 2006
82 SEMEN PADANG PADANG CEMENT INDUSTRY HVAC PUMP 2006
83 ITC KOPO BANDUNG BUILDING FIRE PUMP 2006
84 THE EAST JAKARTA BUILDING FIRE & CHILLER PUMP 2006
85 PERTAMINA SAGATA KALIMANTAN OIL & GAS FIRE PUMP 2006
86 HOLCIM INDONESIA JAKARTA CEMENT INDUSTRY REGENERATIVE TURBINE PUMP 2006
87 SPRING HILL GOLF RESIDENCE JAKARTA RESIDENTIAL FIRE PUMP 2006
88 HOLCIM INDONESIA JAKARTA CEMENT INDUSTRY REGENERATIVE TURBINE PUMP 2006
89 JACC JAKARTA BUILDING FIRE PUMP 2006
90 ETERNIT GRESIK GRESIK FACTORY FIRE PUMP 2006
91 PLAZA ASIA TASIKMALAYA TASIKMALAYA BUILDING CHILLER PUMP 2006
92 IPEKA SCHOOL JAKARTA BUILDING FIRE PUMP 2006
93 PLAZA ASIA TASIKMALAYA TASIKMALAYA BUILDING PLUMBING PUMP SUBMERSIBLE PUMP DEEP WELL PUMP
2007
94 TOYOTA ASTRA MOTOR JAKARTA FACTORY FIRE PUMP 2007
95 CARREFOUR CIBINONG BANDUNG BUILDING FIRE PUMP 2007
96 CARREFOUR KIARA CONDONG MALL BANDUNG BUILDING FIRE PUMP 2007
97 PERFETI VAN MELLE JAKARTA FACTORY FIRE PUMP 2007
98 DATA CENTER SURABAYA BUILDING FIRE PUMP 2007
99 TOYOTA ASTRA MOTOR JAKARTA FACTORY CHILLER PUMP 2007
100 GRAND INDONESIA JAKARTA BUILDING CHILLER PUMP APARTMENT, CONVENTION HALL 2007
101 CNOOC OFFCHORE OFFSHORE OIL RIG VERTICALTURBINE SEA WATER FIRE PUMP 2007
102 PASAR BARU SQUARE BALIKPAPAN HOTEL AND MALL FIRE PUMP 2007
103 SEMEN PADANG PADANG CEMENT INDUSTRY HVAC PUMP 2007
104 NESTLE - PASURUAN PASURUAN FACTORY FIRE PUMP 2007
105 ST. REGIS BALI BALI BUILDING FIRE PUMP, CHILLER PUMP PLUMBING PUMP, DEEP WELL PUMP
2007
106 CARREFOUR RUNGKUT SURABAYA BUILDING FIRE PUMP 2007
107 PABRIK SUGIZINDO CIBINONG FACTORY FIRE PUMP 2007
108 SEK-NEG DIKLAT CIPETE JAKARTA BUILDING FIRE PUMP 2007
109 THE CITY TOWER JAKARTA OFFICE FIRE PUMP 2007
110 KEM TOWER KEMAYORAN JAKARTA BUILDING FIRE PUMP 2007
4
111 WATERPLACE RESIDENCE SURABAYA BUILDING FIRE PUMP 2007
112 SEASON CITY JAKARTA BUILDING FIRE PUMP 2007
113 HOTEL MALEOSAN MANADO BUILDING FIRE PUMP 2007
114 APARTMENT BSB BALIKPAPAN BUILDING FIRE PUMP 2007
115 HOLCIM INDONESIA JAKARTA BUILDING WATER SPRAY 2008
116 GRAHA 165 JAKARTA BUILDING CHILLER PUMP 2008
117 ARKADIA OFFICE JAKARTA BUILDING FIRE PUMP 2008
118 SAINATH OFFICE JAKARTA BUILDING FIRE PUMP 2008
119 GRAND CITY SURABAYA SURABAYA BUILDING CHILLER PUMP 2008
120 KEM TOWER KEMAYORAN JAKARTA BUILDING PLUMBING PUMP, CHILLER PUMP, SUBMERSIBLE PUMP
2008
121 THE ADHIWANGSA RESIDENCE SURABAYA RESIDENTIAL FIRE PUMP 2008
122 DAPENRA JAKARTA BUILDING FIRE PUMP 2008
123 LUCKY SQUARE MALL BANDUNG BUILDING FIRE PUMP 2008
124 BEST WESTERN BALI HOTEL BALI BUILDING FIRE PUMP 2008
125 ASTON VERANDA HOTEL JAKARTA BUILDING FIRE PUMP 2008
126 SEMEN PADANG PADANG CEMENT INDUSTRY HVAC PUMP 2008
127 HOLCIM INDONESIA CILACAP CEMENT INDUSTRY WATER SPRAY 2008
128 CYBER-2 JAKARTA OFFICE FIRE PUMP 2008
129 HOTEL HILTON BANDUNG HOTEL FIRE PUMP 2008
130 SUDIRMAN TOWER JAKARTA BUILDING FIRE PUMP 2008
131 FREEPORT IRIAN JAYA MINING CIRCULATION PUMP 2008
132 GRAHA PENA SURABAYA BUILDING FIRE PUMP 2008
133 BPK PENABUR - KELAPA GADING JAKARTA BUILDING FIRE PUMP 2008
134 FLOUR MILLS - CILEGON CILEGON FACTORY FIRE PUMP 2008
135 MEDCO ENERGI SUMATERA OIL & GAS FIRE PUMP 2008
136 PARAGON CITY SEMARANG BUILDING FIRE PUMP 2008
137 MENARA MTH JAKARTA BUILDING FIRE PUMP 2008
138 QATAR EMBASSY JAKARTA BUILDING FIRE PUMP 2008 139 CYBER-2 JAKARTA OFFICE HVAC PUMP, PLUMBING PUMP 2008
140 MEDCO II SUMATERA OIL & GAS FIRE PUMP 2008
141 CYBER ANNEX JAKARTA BUILDING FIRE PUMP, HVAC PUMP, PLUMBING PUMP 2008
142 RENOVASI GEDUNG MAHKAMAH AGUNG, RI JAKARTA BUILDING FIRE PUMP 2008
143 W HOTEL SEMINYAK BALI HOTEL FIRE PUMP 2008
144 EQUITY TOWER JAKARTA BUILDING FIRE PUMP 2008
145 DEPO PERTAMINA BOJONEGORO OIL & GAS FIRE PUMP 2008
146 SEASON CITY JAKARTA BUILDING HVAC PUMP 2008
147 DUFAN ANCOL JAKARTA BUILDING FIRE PUMP 2008
5
148 TRANS KALLA MAKASSAR BUILDING FIRE PUMP 2009
149 PUPUK KUJANG CIKAMPEK FACTORY HYDROMATIC PUMP 2009
150 INDOSAT SUKABUMI BUILDING FIRE PUMP 2009
151 IT BATAM BATAM BUILDING FIRE PUMP 2009
152 SAMPOERNA STRATEGIC SQUARE JAKARTA BUILDING HOT WATER PUMP 2009 153 KANTOR PERWAKILAN PEMDA SULUT JAKARTA BUILDING FIRE PUMP 2009
154 LOMBOK AIRPORT LOMBOK BUILDING FIRE PUMP 2009
155 LAN SAMARINDA SAMARINDA BUILDING FIRE PUMP 2009
156 CENTRAL PARK JAKARTA BUILDING HVAC PUMP 2009
157 OFFICE KRAMAT RAYA JAKARTA BUILDING FIRE PUMP 2009
158 BINUS BOARDING HOUSE JAKARTA BUILDING FIRE PUMP 2009
159 BANDARA KUALANAMU MEDAN BUILDING FIRE PUMP, CHILLER PUMP, PLUMBING PUMP 2009
160 PPPK PETRA SURABAYA BUILDING FIRE PUMP 2009
161 PUSDIKLAT MAHKAMAH AGUNG JAKARTA BUILDING FIRE PUMP 2009
162 WILMAR NABATI INDONESIA GRESIK INDUSTRY FIRE PUMP 2009
163 PUSDIKLAT MAHKAMAH AGUNG BOGOR BUILDING FIRE PUMP 2009
164 PERTAMINA ACEH EP RANTAU ACEH OIL & GAS FIRE PUMP 2009
165 DINAS PEMADAM KEBAKARAN-LEBAK BULUS JAKARTA BUILDING FIRE PUMP 2009
166 TEMPO SCAN TOWER JAKARTA BUILDING FIRE PUMP, CHILLER PUMP, PLUMBING PUMP 2010
167 CIK DITIRO APARTMENT JAKARTA BUILDING FIRE PUMP 2010
168 CENTRAL PARK CGPP II JAKARTA BUILDING CHILLER PUMP 2010
169 CENTRAL PARK BALL ROOM JAKARTA BUILDING CHILLER PUMP 2010
170 SEASON CITY SCHOOL JAKARTA BUILDING FIRE PUMP 2010
171 PERTAMINA UPMS IV DEPOT REWULU SEMARANG OIL & GAS FIRE PUMP 2010
172 PERTAMINA UPMS VII MAKASAR OIL & GAS FIRE PUMP 2010
173 KEMANG VILLAGE SCHOOL JAKARTA BUILDING FIRE PUMP 2010
174 KEMANG VILLAGE JAKARTA BUILDING FIRE PUMP 2010
175 RUSUNAMI GADING ICON JAKARTA RESIDENTIAL FIRE PUMP 2010
176 MENARA ALLIANZ JAKARTA BUILDING FIRE PUMP 2010
177 PERTAMINA UPMS VII DEPOT MAKASAR MAKASAR OIL & GAS VERTICAL TURBINE - FIRE PUMP 2010
178 PERTAMINA UPMS III UJUNG BERUNG BANDUNG OIL & GAS FIRE PUMP 2010
179 DPPU AVIASI KUALANAMU MEDAN MEDAN OIL & GAS FIRE PUMP 2010
180 MEDCO ENERGY M-12 TARAKAN KALIMANTAN OIL & GAS FIRE PUMP 2010
6
181 KEMANG VILLAGE KVR & RITZ TOWER JAKARTA BUILDING FIRE PUMP 2010
182 CIPUTRA WORLD SURABAYA BUILDING FIRE PUMP 2010
183 PERTAMINA UPMS III - LPG BALONGAN BALONGAN OIL & GAS FIRE PUMP 2010
184 PERTAMINA UBEP TARAKAN TARAKAN OIL & GAS FIRE PUMP 2010
185 DPPU SOEKARNO HATTA CENGKARENG OIL & GAS VEHRTICAL SUMP PUMP 2010
186 HOTEL SENTRA KELAPA GADING JAKARTA BUILDING PLUMBING 2010
187 ANCOL MENTION JAKARTA BUILDING FIRE PUMP 2010
188 GEDUNG LEMIGAS CIPULIR JAKARTA BUILDING FIRE PUMP 2010
189 MEDCO EOR RIMAU PALEMBANG OIL AND GAS FIRE PUMP 2010
190 PERTAMINA EP PENDOPO PRABUMULIH OIL AND GAS FIRE PUMP 2010
191 SUNTER OFFICE JAKARTA BUILDING FIRE PUMP 2010
192 KAWASAN PERGUDANGAN NARAGONG NARAGONG BUILDING FIRE PUMP 2010
193 KRAFT FOOD INDONESIA CIKARANG BUILDING FIRE PUMP 2010
194 HANG LEKIR RESIDANCE JAKARTA BUILDING FIRE PUMP 2010
195 CIPUTRA WORLD SURABAYA BUILDING FIRE PUMP 2010
196 CENTRAL PARK JAKARTA HOTEL FIRE PUMP 2011
197 RS. ADVENT BANDUNG BANDUNG BUILDING FIRE PUMP 2011
198 MENARA CITICON JAKARTA BUILDING FIRE PUMP 2011
199 BINUS SERPONG 3 JAKARTA BUILDING FIRE PUMP 2011
200 NUSANTARA TURBINE PROPULSI BANDUNG INDUSTRY VERTICAL TURBINE FIRE PUMP 2011
201 GEDUNG BERSAMA GRAMEDIA JAKARTA BUILDING FIRE PUMP 2011
202 TANGERANG CITY MALL TANGERANG BUILDING CHILLER PUMP 2011
203 BOILER YOGYAKARTA INDUSTRY BOILER PUMP 2011
204 GALERI MODECOR JAKARTA BUILDING FIRE PUMP 2011
205 MALL OF KEDIRI KEDIRI BUILDING FIRE PUMP 2011
206 PERTAMINA UPMS V DEPOT BADAS SURABAYA OIL & GAS VERTICAL TURBINE FIRE PUMP 2011
207 PERTAMINA EP RANTAU ACEH OIL & GAS FIRE PUMP 2011
208 MALL SERANG BANTEN BANTEN BUILDING FIRE PUMP 2011
209 WHITZ HOTEL SEMARANG HOTEL FIRE PUMP 2011
210 ST.MORITZ JAKARTA BUILDING-PRESIDENTIAL FIRE PUMP 2011
211 ST.MORITZ JAKARTA BUILDING-AMBASSADOR FIRE PUMP 2011
212 SWISS BELL HOTEL BALI HOTEL FIRE PUMP 2011
7
213 REGENT HOTEL BALI HOTEL HVAC 2011
214 KAMPUNG ITSB CIKARANG BUILDING FIRE PUMP 2011
215 BANK RIAU RIAU BUILDING FIRE PUMP 2011
216 THE STONE BALI BALI BUILDING FIRE PUMP 2011
217 WISMA PONDOK INDAH III JAKARTA BUILDING FIRE PUMP, PLUMBING PUMP, CHILLER PUMP, SUBMERSIBLE PUMP
2011
218 HOTEL NOVOTEL GAJAH MADA JAKARTA HOTEL FIRE PUMP, CHILLER PUMP 2011
219 APARTMENT NOVOTEL GAJAH MADA JAKARTA RESIDENTIAL FIRE PUMP 2011
220 APARTMENT RUSUNAMI SUNTER PARK VIEW JAKARTA RESIDENTIAL FIRE PUMP 2011
221 APARTMENT RUSUNAMI PURI PARK VIEW TOWER A,B & C JAKARTA RESIDENTIAL FIRE PUMP 2011
222 APARTMENT RUSUNAMI PURI PARK VIEW TOWER E JAKARTA RESIDENTIAL FIRE PUMP 2011
223 GAJAH MADA PLAZA JAKARTA BUILDING CHILLER PUMP 2011
224 GUDANG DHL JAKARTA BUILDING FIRE PUMP 2011
225 IRMC SHOWROOM & OFFICE JAKARTA BUILDING FIRE PUMP 2011
226 GREEN BAY PLUIT TAHAP I JAKARTA BUILDING PLUMBINGPUMP, SUBMERSIBLE PUMP 2011
227 HOTEL TRANS & IBIS BANDUNG BUILDING FIRE PUMP, CHILLER PUMP 2011
228 PERTAMINA EP KTI PAPUA SORONG OIL & GAS FIRE PUMP 2011
229 PERTAMINA JAYAPURA DEPOT SORONG PAPUA OIL & GAS FIRE PUMP 2011
230 ASAM ASAM COAL MINING KALIMANTAN MINING FIRE PUMP 2011
231 LOGO OFFICE JAKARTA BUILDING FIRE PUMP 2011
232 HOLIDAY INN SUNTER JAKARTA HOTEL FIRE PUMP, PLUMBING PUMP, CHILLER PUP 2011
233 HOLIDAY INN SUNTER JAKARTA RUKAN FIRE PUMP, PLUMBING PUMP 2011
234 GUDANG GARAM TOWER JAKARTA BUILDING FIRE PUMP 2011
235 MEDAN CENTER POINT MEDAN BUILDING FIRE PUMP 2011
236 PERTAMINA UPMS V - LPG TANJUNG PERAK SURABAYA OIL & GAS FIRE PUMP 2011
237 SUJ INDOCHEM CILEGON CILEGON FACTORY FIRE PUMP 2011
238 ARMADA JOHNSON CONTROL CIKAMPEK FACTORY FIRE PUMP 2011
239 PERTAMINA MAKASAR MULTI DEPOT MAKASAR OIL & GAS JOCKEY PUMP 2011
240 PLTA BRANTAS SURABAYA POWER PLANT FIRE PUMP 2011
241 PERTAMINA EP PENDOPO PRABUMULIH OIL & GAS FIRE PUMP 2011
242 PERTAMINA UPMS V - DEPOT SEMAMPIR SURABAYA OIL & GAS VERTICAL TURBINE FIRE PUMP 2011
8
243 PERTAMINA LPG TANJUNG PRIOK JAKARTA OIL & GAS FIRE PUMP 2011
244 PERTAMINA UPMS V - DPPU KUPANG SURABAYA OIL & GAS FIRE PUMP 2011
245 PERTAMINA UBEB TANJUNG KAL-SEL OIL & GAS FIRE PUMP 2011
246 PABRIK ROKOK GUDANG GARAM SEMARANG FACTORY FIRE PUMP 2011
247 GEDUNG AUDITORIUM PT. AHM CIKARANG FACTORY FIRE PUMP 2011
248 U RESIDENCE JAKARTA BUILDING FIRE PUMP 2011
249 CIKINI GOLD CENTER JAKARTA BUILDING FIRE PUMP 2011
250 WEST MARK APARTMENT JAKARTA RESIDENTIAL FIRE PUMP 2011
251 GREEN BAY PLUIT TAHAP-1A JAKARTA BUILDING FIRE PUMP 2011
252 GEDUNG EXIM MELATI JAKARTA BUILDING CHILLER PUMP 2011
253 APM ARMADA AUTO PARTS CIKARANG FACTORY FIRE PUMP 2011
254 PERTAMINA EP REGION JAWA FIELD CEPU CEPU OIL & GAS FIRE PUMP 2012
255 SRC FACTORY KARAWANG KARAWANG FACTORY FIRE PUMP 2012
256 PT. TEMPO JL. KEMUNING JAKARTA FACTORY FLOOD PUMP 2012
257 PERTAMINA SURABAYA-DEPOT MAUMERE SURABAYA OIL & GAS VERTICAL TURBINE- FIRE PUMP 2012
258 OTTO PHARMACEUTIAL BANDUNG FACTORY FIRE PUMP 2012
259 PERTAMINA JAYAPURA DEPOT DOBO, TUAL & MERAUKE JAYAPURA OIL & GAS FIRE PUMP 2012
260 MEDCO M12 TARAKAN SUMATERA OIL & GAS FIRE PUMP 2012
261 PERTAMINA PERTAGAS SUMATERA SUMATERA OIL & GAS FIRE PUMP 2012
262 PERTAMINA PRABUMULIH SUMATERA OIL & GAS FIRE PUMP 2012
263 PERTAMINA UPMS III JBB DEPOT TASIKMALAYA TASIKMALAYA OIL & GAS FIRE PUMP 2012
264 PERTAMINA MAKASSAR DEPOT GORONTALO MAKASSAR OIL & GAS FIRE PUMP 2012
265 PERTAMINA BITUNG MAKASSAR OIL & GAS JOCKEY PUMP 2012
266 PERTAMINA UPMS III - DEPOT PADALARANG JAWA BARAT OIL & GAS FIRE PUMP 2012
267 CNG SEI GELAM JAMBI OIL & GAS FIRE PUMP 2012
268 PERTAMINA BIAK, JAYAPURA JAYAPURA OIL & GAS FIRE PUMP 2012
269 PERTAMINA SEMARANG CILACAP JAWA TENGAH OIL & GAS FIRE PUMP 2012
270 PERTAMINA REWULU JOGJA OIL & GAS JOCKEY PUMP 2012
271 SUGAR REFINERY MARUNDA JAKARTA JAKARTA FACTORY FIRE PUMP 2012
272 SUJ CILEGON CILEGON FACTORY FIRE PUMP 2012
273 INDOFOOD CIKUPA - TANGERANG TANGERANG FACTORY FIRE PUMP 2012
9
274 PERTAMINA BALIKPAPAN KALIMANTAN OIL & GAS JOCKEY PUMP 2012
275 REGENT HOTEL BALI BUILDING CHILLER PUMP 2012
276 BANK MEGA CARD CENTER JAKARTA BUILDING FIRE PUMP 2012
277 PUSAT TIKI-JNE JAKARTA BUILDING FIRE PUMP 2012
278 KEMANG VILLAGE INFINITY-TOWER JAKARTA BUILDING FIRE PUMP 2012
279 KEMANG VILLAGE INTERCON TOWER JAKARTA BUILDING FIRE PUMP 2012
280 DHARMAWANGSA 101 HOTEL JAKARTA BUILDING FIRE PUMP 2012
281 MENARA PRIMA II JAKARTA BUILDING CHILLER PUMP, SUBMERSIBLE PUMP 2012
282 RS. AKADEMIKA UGM JOGYAKARTA BUILDING FIRE PUMP 2012
283 HOTEL AMARIS NUSA 2 BALI BUILDING FIRE PUMP 2012
284 TRANS STUDIO BANDUNG BUILDING CIRCULATION PUMP 2012
285 THE WINDSOR APARTMENT JAKARTA BUILDING FIRE PUMP 2012
286 STREET GALERY PONDOK INDAH JAKARTA BUILDING FIRE PUMP, SUBMERSIBLE PUMP 2012
287 GREEN BAY TAHAP II - MALL JAKARTA BUILDING FIRE PUMP 2012
288 PULOMAS PARK CENTER JAKARTA BUILDING FIRE PUMP 2012
289 AKADEMI PERKERETAAPIAN MADIUN BUILDING FIRE PUMP 2012
290 BANDARA SULTAN THAHA JAMBI BUILDING FIRE PUMP 2012
291 BANDARA DEPATI AMIR BANGKA BELITUNG BUILDING FIRE PUMP, PLUMBING PUMP 2012
292 PASAR SINPASA BEKASI BUILDING FIRE PUMP 2012
293 HOLIDAY INN EXPRESS BALI BUILDING FIRE PUMP 2012
294 GREEN LAKE SUNTER-TAHAP I JAKARTA BUILDING FIRE PUMP 2012
295 DSO DJARUM TANDES SURABAYA SURABAYA FACTORY FIRE PUMP 2013
296 BALI DESA NUSA DUA BALI BUILDING FIRE PUMP 2013
297 BANDARA DJUANDA SURABAYA BUILDING FIRE PUMP 2013
298 SIMPRUG BOTANICA JAKARTA BUILDING FIRE PUMP 2013
299 MENARA PRIMA 2 JAKARTA BUILDING PLUMBING PUMP 2013
300 CONDOTEL AWANA BALI BUILDING FIRE PUMP 2013
301 SHANGRILA HOTEL BALI BUILDING FIRE PUMP 2013
302 PERTAMINA BALIKPAPAN DEPOT SAMARINDA BALIKPAPAN OIL & GAS JOCKEY PUMP 2013
303 PERTAMINA BALIKPAPAN DEPOT PANGKALAN BUN, DEPOT PULAU PISAU, DPPU JUWATA
BALIKPAPAN OIL & GAS FIRE PUMP 2013
304 PERTAMINA BALIKPAPAN DEPOT SINTANG BALIKPAPAN OIL & GAS FIRE PUMP 2013
10
305 PERTAMINA BALIKPAPAN DEPOT TARAKAN BALIKPAPAN OIL & GAS VERTICAL TURBINE FIRE PUMP 2013
306 PERTAMINA BALIKPAPAN DEPOT BANJARMASIN BALIKPAPAN OIL & GAS VERTICAL TURBINE FIRE PUMP 2013
307 HOTEL SANTIKA CIKARANG CIKARANG BUILDING FIRE PUMP 2013
308 BALI NUSA DUA CONVENTION CENTER BALI BUILDING FIRE PUMP 2013
309 GEDUNG BINA MULYA 1 JAKARTA BUILDING CHILLER PUMP 2013
310 TOWER PLN BEKASI BEKASI PLN CIRCULATION PUMP 2013
311 PERTAMINA TBBM SERUI PAPUA OIL & GAS FIRE PUMP 2013
312 FLOUR MILL CILEGON CILEGON INDUSTRI FIRE PUMP 2013
313 PERTAGAS JAMBI TEMPINO JAMBI OIL & GAS FIRE PUMP 2013
314 PERTAMINA SANGATTA KALIMANTAN TIMUR OIL & GAS FIRE PUMP 2013
315 THE MANSION @ DUKUH GOLF KEMAYORAN JAKARTA BUILDING FIRE PUMP 2013
316 PERTAMINA TJILIK RIWUT KALIMANTAN TENGAH OIL & GAS FIRE PUMP 2013
317 PERTAMINA LPG DUMAI RIAU OIL & GAS FIRE PUMP 2013
318 PERTAMINA REGION IV SEMARANG TBBM LOMANIS CILACAP JAWA TENGAH OIL & GAS FIRE PUMP 2013
319 PERTAMINA EP FIELD TAMBUN JAWA BARAT OIL & GAS FIRE PUMP 2013
320 PERTAMINA REGION IV SEMARANG-TBBM LOMANIS CILACAP
JAWA TENGAH OIL & GAS JOCKEY PUMP 2013
321 PERTAMINA TBBM KAIMANA PAPUA OIL & GAS FIRE PUMP 2013
322 PERTAMINA LABUHA PAPUA OIL & GAS FIRE PUMP 2013
323
PERTAMINA UPMS VII SULAWESI TBBM MOUTONG& TBBM BANGGAI, TBBM LUWUK & TBBM POSO, TBBM RAHA, TBBM POSO, TBBM MOUTONG & TBBM BANGGAI
SULAWESI OIL & GAS FIRE PUMP 2013
324 PGN LAMPUNG LAMPUNG OIL & GAS FIRE PUMP 2013
325 DSO DJARUM TANDES JAWA TIMUR INDUSTRI FIRE PUMP 2013
326 PANTAI INDAH KAPUK MAL & HOTEL JAKARTA BUILDING FIRE PUMP 2013
327 SAHID SUDIRMAN CENTER JAKARTA BUILDING FIRE PUMP 2013
328 HARRIS HOTEL & YELLO HOTEL HAYAM WURUK JAKARTA BUILDING FIRE PUMP 2013
329 HOTEL HOLIDAY INN EXPRESS - CIKINI JAKARTA BUILDING FIRE PUMP 2013
330 MENTENG PARK JAKARTA BUILDING FIRE PUMP 2013
331 HOTEL AMARIS PASAR MINGGU JAKARTA BUILDING FIRE PUMP 2013
11
332 HOTEL 101 LEGIAN BALI BUILDING FIRE PUMP 2013
333 HOTEL 101 JOGYAKARTA JOGYAKARTA BUILDING FIRE PUMP 2013
334 UPH KARAWACI TANGERANG BUILDING FIRE PUMP 2013
335 BINTARO PARK VIEW JAKARTA BUILDING FIRE PUMP 2013
336 HOTEL ALILA SCBD JAKARTA BUILDING VERTICAL TURBINE FIRE PUMP, PLUMBING PUMP, SUBMERSIBLE PUMP
2013
337 SOHO PODOMORO CITY JAKARTA BUILDING FIRE PUMP 2014
338 WOLRD VISION INDONESIA JAKARTA BUILDING FIRE PUMP 2014
339 LOBP BATAKAN BALIKPAPAN KALIMANTAN TIMUR OIL & GAS FIRE PUMP 2014
340 PERTAMINA TBBM NABIRE PAPUA OIL & GAS FIRE PUMP 2014
341 PERTAMINA TBBM MASOHI MALUKU TENGAH OIL & GAS VERTICAL TURBINE 2014
342 PABRIK PENGOLAHAN DAGING DI PURWAKARTA JAWA BARAT INDUSTRI FIRE PUMP 2014
343 HOTEL BEST WESTERN SOLO SOLO BUILDING FIRE PUMP 2014
344 ELPIS RESIDENCE JAKARTA BUILDING FIRE PUMP 2014
345 BANDARA SUPADIO PONTIANAK BUILDING FIRE PUMP 2014
346 HOTEL 101 BOGOR BOGOR BUILDING FIRE PUMP 2014
347 PURI INDAH FINANCIAL TOWER JAKARTA BUILDING FIRE PUMP 2014
348 ONE BELPARK MALL JAKARTA BUILDING FIRE PUMP 2014
349 BATULICIN KALIMANTAN SELATAN OIL & GAS VERTICAL TURBINE 2014
350 SENORO SULAWESI TENGAH OIL & GAS FIRE PUMP 2014
351 CENTRAL KITCHEN THE DUCK KING TANGERANG INDUSTRI FIRE PUMP 2014
352 GEDUNG GIS JAKARTA BUILDING FIRE PUMP 2014
353 THE MANSION @ TOWER BOUGENVILLE JAKARTA BUILDING FIRE PUMP 2014
354 MENARA SENTRAYA JAKARTA BUILDING FIRE PUMP 2014
355 HOTEL BEDROCK BALI BUILDING FIRE PUMP 2014
12
356 GOR PKP CIRACAS JAWA BARAT BUILDING FIRE PUMP 2014
357 GARDEN WING APARTMENT KARAWANG JAWA BARAT BUILDING FIRE PUMP 2014
358 HOTEL ASTON & TRAINING CENTER, SENTUL JAWA BARAT BUILDING FIRE PUMP 2014
359 PABRIK PRINTING FLEXO DI SIDOARJO JAWA TIMUR INDUSTRI FIRE PUMP 2014
360 PERTAMINA TBBM KOTA BARU & DEPOT LPG BALIKPAPAN KALIMANTAN OIL & GAS VERTICAL TURBINE FIRE PUMP 2014
361 PABRIK DUA BERLIAN JAKARTA INDUSTRI FIRE PUMP 2014
362 PERTAMINA ELNUSA DEPO PLUMPANG JAKARTA OIL & GAS FIRE PUMP 2014
363 PERTAMINA EP ASSET 1 LIRIK FIELD RIAU OIL & GAS FIRE PUMP 2014
364 PERTAMINA TBBM SANANA MALUKU OIL & GAS VERTICAL TURBINE 2014
365 MAXX BOX KARAWACI BUILDING FIRE PUMP 2014
366 HOTEL HARRIS BENOA BALI BUILDING FIRE PUMP 2014
367 HOTEL TIJILI SEMINYAK BALI BUILDING FIRE PUMP 2014
368 MALL & HOTEL PIK JAKARTA BUILDING PLUMBING PUMP 2014
369 CONVENTION HALL SAMARINDA BUILDING FIRE PUMP 2014
370
KAMPUS ITB TAHAP II
BANDUNG BUILDING FIRE PUMP 2014
371 PERTAMINA AREA SULAWESI BITUNG SULAWESI OIL & GAS VERTICAL TURBINE 2014
372 PERTAMINA DPPU SAM RATULANGI MANADO SULAWESI OIL & GAS FIRE PUMP 2014
373 PERTAMINA FIELD TARAKAN SULAWESI OIL & GAS FIRE PUMP 2014
374 PERTAMINA SULAWESI KOLONEDALE SULAWESI OIL & GAS JOCKEY PUMP 2014
375 PERTAMINA BALONGAN BALONGAN OIL & GAS VERTICAL TURBINE 2014
376 PABRIK ETERNA GELORAPUTRA CIKUPA INDUSTRI FIRE PUMP 2014
377 ANCOL DOUBLE DECKER JAKARTA BUILDING FIRE PUMP 2014
378 CENTENIAL TOWER JAKARTA BUILDING FIRE PUMP 2014
379 HOTEL ALILA SCBD JAKARTA BUILDING VERTICAL TURBINE-JOCKEY PUMP 2014
13
380 OAK TOWER JAKARTA BUILDING FIRE PUMP 2014
381 ST. REGIS - HOTEL JAKARTA BUILDING FIRE PUMP 2014
382 ST. REGIS - OFFICE JAKARTA BUILDING FIRE PUMP 2014
383 HOTEL GUNUNG GEULIS BOGOR BUILDING FIRE PUMP 2014
384 NPK GRANULAR II PT. PUPUK KUJANG CIKAMPEK INDUSTRI FIRE PUMP 2015
385 PGN JAWA BARAT OIL & GAS FIRE PUMP 2015
386 PERTAMINA DEPOT SINTANG KALIMANTAN BARAT OIL & GAS FIRE PUMP 2015
387 PABRIK KERTAS CIKARANG BARAT INDUSTRI FIRE PUMP 2015
388 PERTAMINA SANGA SANGA KALIMANTAN OIL & GAS FIRE PUMP 2015
389 PABRIK ETERNIT GRESIK JAWA TIMUR INDUSTRI FIRE PUMP 2015
390 PABRIK VALEO PURWAKARTA INDUSTRI VERTICAL TURBINE & JOCKEY PUMP 2015
391 HOTEL ARCS JAMBULUWUK BALI BUILDING FIRE PUMP 2015
392 MEDAN CENTER POINT APARTMENT CENTRUM & CENTRIA MEDAN BUILDING FIRE PUMP 2015
393 MENARA PALMA II JAKARTA BUILDING FIRE PUMP 2015
394 ST. MORITZ II - OFFICE TOWER JAKARTA BUILDING FIRE PUMP 2015
395 PLAZA SADIRA PEKANBARU BUILDING FIRE PUMP 2015
396 PERTAMINA FIELD TANJUNG KALIMANTAN SELATAN OIL AND GAS FIRE PUMP 2015
1Complete Solutionsfor Fire Protection Fluid Handling
2Aurora Pump is a global manufacturer of pumps and systems for the commercial, municipal, industrial and fire protection markets. We provide the solutions to meet your pumping needs.
NOTE: Front case wearing rings are standard on all size pumps. Rear case rings are standard on all sizes except
the 2x2x9C. The 2x2x9C does not require a wear ring.
911 Series 911.5 Series
Single Stage Inline Fire Pump
Model 383
Flows: 50 to 1,500 GPM (11.3 to 340 m3/hr) Pressures: 40 to 205 PSI (2.7 to 14.1 bar)
ULListed/FMApproved/NFPA-20Design
ForCommercial,IndustrialandMarineUse
SpaceSavingVerticalDesign
EasyMaintenancewithoutDisturbingSurroundingPiping
Bronze-FittedPumpConstruction
End Suction Fire Pump
Model 384
Flows: 400 to 750 GPM (90.8 to 170.3 m3/hr) Pressures: 47 to 105 PSI (3.2 to 7.2 bar)
ULListed,FMApprovedPerformance
ElectricandDieselSpeeds
BackPulloutDesignforEasyPumpServicewithoutDisconnectingPipe
Frame-MountedDesign
SmallFootprintIdealforRetrofit
DesignedforInstallationssuchasSchools,OfficeBuildings,andHospitals
FIRE PUMPS
912 Series
Horizontal Split Case Electric Drive Fire Pumps
Models 481, 485, 491, 492, 495
Flows: 250 to 5000 GPM (56.8 to 1135 m3/hr) Pressures: 40 to 490 PSI (2.8 to 33.8 bar)
ULListed/FMApproved/NFPA-20Design
ForCommercial,IndustrialandMarineUse
DieselandElectricDrivenAvailable
LowerInitialCost
QuickerDeliverywithRedHotQuickShipProgram
EaseofMaintenance
Vertical Split Case Electric Drive Fire Pump
Model 483
Flows: 250 to 5000 GPM (56.8 to 1135 m3/hr) Pressures: 40 to 490 PSI (2.8 to 33.8 bar)
ULListed/FMApproved/NFPA-20Design
ForCommercial,IndustrialandMarineUse
ElectricDrivenAvailable
LowerInitialCost
EaseofMaintenance
Controllersmountedandwiredondieselpumpbase.Typicalhouseddieseldrivenfirepumpwithtestmeter.
3Horizontal Split Case Diesel Drive Fire Pumps
Models 481, 485, 491, 492, 495
Flows: 250 to 5000 GPM (56.8 to 1135 m3/hr) Pressures: 40 to 490 PSI (2.8 to 33.8 bar)
ULListed/FMApproved/NFPA-20Design
ForCommercial,IndustrialandMarineUse
DieselandElectricDrivenAvailable
LowerInitialCost
QuickerDeliverywithRedHotQuickShipProgram
EaseofMaintenance
Packaged Fire Pump Systems
ULListed/FMApprovedAuroraFirePump
ULListed/FMApprovedFirePumpController
ETLListedPackagedFirePumpSystem
AuroraJockeyPump
ULListedJockeyPumpController
PressureSensingLinesComplete perNFPA20
ListedOS&YGate&ButterflyValveswithTamperSwitches
SuctionandDischargePressureGauges
AutomaticCasingAirReleaseValve
CasingPressureReliefValve (ElectricPackages)
HoseHeaderwithValves,Caps&Chains
SuctionandDischargePipingperNFPA20
RemovableLiftingLugs
913 Series
Fire Pump Vertical Turbine
Model 483
Flows: 250 to 4500 GPM (56.8 to 1022 m3/hr) Pressures: 75 to 387 PSI (5.2 to 26.7 bar)
ULListed/FMApproved/NFPA-20Design
ForCommercial,IndustrialandMarineUse
SpecialMaterialsforSeawaterApplications
DieselandElectricDriven
914 Series
Jockey Pumps
Models PVM, PVMI, PVMX
Horsepower: 12 to 40 Flows: 50 GPM (11.3 M3/HR) Capacities: 215 GPM (48.8 M3/HR) Pressures: 330 PSI (22.7 bar) Heads: 800 Feet (244 Meters) Temperatures: 250F (121C)
Space-SavingDesignRecommendedwhereFloorSpaceisExtremelyLimited
AvailableinCastIronor304and316StainlessSteelMaterials
PVM Series
FIRE PUMPS
918 Series
Compact Fire Pump Systems
Flows: 750 GPM (170.3 m3/hr) Pressures: 160 PSI (11.0 bar)
ULListed/FMApprovedAuroraFirePump
ULListed/FMApprovedFirePumpController
ETLListedPackagedFirePumpSystem
AuroraJockeyPump
ULListedJockeyPumpController
PressureSensingLinesComplete perNFPA20
ListedOS&YGate&ButterflyValves
SuctionandDischargePiping perNFPA20
IdealforSmallerAreas Fitsthrougha36"Doorway
MultipleStartingMethods AvailablefortheFirePumpwith OptionalAutomaticTransferSwitch
OptionalCityBypass
919 Series
FIRE PUMP SYSTEMS
HYDRA
ULI
C
19
INSTIT
UTE
17
ISO 9
001 R
EGISTERED QUALITY SYSTEM
NOTE: AuroraPumpreservestherighttomakerevisionstoitsproductsandtheirspecifications,andtothisbulletinandrelatedinformation,withoutnotice.
800AirportRoadNorthAurora,Illinois60542Phone:888-987-8680
3601FairbanksAvenueKansasCity,Kansas66106Phone:888-416-9510
www.aurorapump.com
AF-02-100109/122012PentairPumpGroup,Inc.
With over ninety years of experience, Auroras commitment to excellence goes beyond the product line by being dedicated to keeping our customers, distributors and employees constantly educated and updated on the leading developments in technology. Our computer software programs assist with selecting the best pumps and systems along with providing pump drawings and specifications. These programs save valuable time in the selection and evaluation of pumps and systems.
As an ISO 9001 registered company, Aurora Pump is committed to quality. In addition, to meet your quick ship requirements, the Aurora Distribution Center is stocked with parts and pumps to handle same day shipments. These components, along with our outstanding customer service program, will keep your Aurora Pump system at peak performance for years to come. You can rely on Aurora Pump and our qualified distribution network to provide total fluid flow solutions.
Aurora Pump provides fire protection pumping for a variety of solutions throughout the world.
ACCESSORIES
CasingReliefValve/AirReliefValve
EccentricSuctionReducers,Concentric DischargeIncreasers
TestManifold,HoseValves,BallDripValve
MainReliefValve,WasteCone
FlowMeteringSystems
DieselBatteries,RacksandCables
DoubleWallFuelTanks/NFPA-20&UL-142Fittings
DieselEngineMufflers
ExhaustFlexConnectors
CityBypass
BackflowPreverter
InsulatedExhaustPiping
RoofCurbforVerticalTurbineInstallationandRemoval
AlarmsandTamperSwitchesPre-WiredtoaCommonJuctionBox
DesignedtoMeetSpecificEnvironmentalRequirements
All-SteelBuildingwith SeismicCertification
EasyAccessEntries
ElectricHeaterswith Built-InThermostat
ContinuousDutyExhaustFan
ACMotor/SolenoidOperatedLouver
InteriorFluorescentandFloodLight,Exterior70WHPSLight
SprinklerSystemperNFPA13
FinishedthroughWallor FloorPenetration
SinglePointElectricalConnection
StateCertificationLabel
FIRE PUMP HOUSES
qwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmrtyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxc
SparePartListBookControllerModel:GPD
PERTAMINABALIKPAPANDEPOTPANGKALANBUN,
DEPOTPULANGPISAU,DPPUJUWATA
Preparedby:PT.RodaNurmala
RianText Box
RianText BoxELECTRIC FIRE PUMPAurora Horizontal Split Case Model : 8-481-21/Single Stage COAL FIRED POWER STATION,BABELAN
Customer :Project name : Default
Pump Performance CurveEncompass 2.0 - 15.1.1.0
0
90
180
270
360Po
wer
- hp
Power
0.0
1.5
3.0
4.5
6.0
7.5
9.0
10.5
12.0
13.5
15.0
0 500 1,000 1,500 2,000 2,500 3,000 3,500 4,000
Hea
d - b
ar
Flow - USgpm
21.00 in
38 53
53
63
63
69
697272
7373
16.94 in
Preferred operating region
Item number : 012 Size : 8-481-21 Service : Stages : 1Quantity : 1 Driver type : MotorQuote number : 259241 Frequency : 50 HzDate last saved : 13 May 2015 1:59 AM Speed, rated : 1,480 rpmFlow, rated : 2,000.0 USgpm Based on curve number : 184-8X10X21-1480Differential head /pressure, rated
: 9.03 bar Efficiency : 65.96 %
:
Shutoff head : 10.07 bar:
Suction pressure, max : 0.00 psi.gPower, maximum : 250 hp
adminText Box
adminText BoxEFP.Cap.2000 Gpm @ 9 Bar Total Head
DIVISI OGText Box
AURORA MODEL 481 PUMPSON STANDARD STEEL BASE
DISCH MODEL CASE BORE2-1/2 481 10B 3 8 4 13-1/2 9-3/4 4 20 5 10
(203) (102) (343) (247) (102) (609) (127) (254)3 481 10 4 9* 4-1/2 13-1/2 10 4-1/2 24 5 11
(228) (114) (343) (254) (114) (609) (127) (279)4 481 10+ 5 14-1/2 11-1/4 5 26 6 12-3/4
(254) (127) (368) (286) (127) (660) (152) (324)4 481 11D 5 10+ 5 14-1/2 12 5 26 6 12-3/4
(254) (127) (368) (305) (124) (660) (152) (324)4 481 15 5 11 5-1/2 14-1/2 13 5-1/2 26 6 14
(279) (140) (368) (330) (140) (660) (152) (355)5 481 11** 5-1/2 16 11-1/4 5-1/2 28-1/2 6 13-1/4
(279) (140) (406) (286) (140) (723) (152) (336)5 481 15 6 12-1/2 6-1/4 16 13-1/4 6-1/4 26-1/2 6 15
(217) (159) (406) (336) (159) (673) (152) (381)5 481 17 6 12-1/2 6-1/4 16 14 6-1/4 28-1/2 6 15
(217) (159) (406) (355) (159) (723) (152) (381)6 481 11 8 12-1/2 6-1/4 16 11-3/4 6-1/4 28-1/2 6 14-1/2
(217) (159) (406) (298) (159) (723) (152) (368)6 481 11HH 8 16-1/2 8-5/8 18-1/2 10 8-5/8 32-7/8 8 15
(419) (219) (460) (254) (219) (835) (203) (381)6 481 14HH 8 16-1/2 7-1/2 20-1/2 15 7-1/2 36-3/4 8 17
(419) (191) (519) (381) (191) (933) (203) (431)6 481 13-1/2 6-3/4 18 14-1/4 6-3/4 32 7 16-3/4
(343) (171) (457) (368) (171) (812) (178) (425)6 481 14-3/4 8 18 16 8 32 7 18
(374) (203 (457) (406) (203) (812) (178) (457)6 481 20 8 14-3/4 8 18 15-3/4 8 32 7 18
(374) (203) (457) (400) (203) (812) (178) (457)8 481 12 10 14-3/4 8 18 17 9 32 7 17-3/4
(374) (203) (457) (431) (228) (812) (178) (450)8 481 17B 10 14-3/4 8 18 17 8 32 7 17-3/4
(374) (203) (457) (431) (203) (812) (178) (450)8 481 18-1/2 9-1/2 21-7/8 18 9-1/2 38 11 21
(470) (241) (555) (457) (241) (964) (279) (533)
10 481 15C 12 25 13-1/2 21-7/8 17 13-1/2 38 11 20(635) (343) (555) (431) (343) (964) (279) (508)
10 481 18 12 25 13-1/2 21-7/8 18 13-1/2 38 11 22(635) (343) (555) (457) (343) (964) (279) (558)
10 481 18D 12 25 12-1/4 24-1/4 20 12-1/4 43 11-1/2 24(635) (311) (616) (508) (311) (1092) (292) (610)
12 481 18A 14 24 15 25-1/4 18 15 44 11 23(609) (381 (615) (457) (381) (1117) (279) (584)
PUMP SIZE
BASE
D S W X Z CP HY YY ZZ APPROX
BASE
21
BASE
BASE
23 22 2828 29 30 3018
7A
7
2
1-1/4
2
BASE
38 36 40 40 44 45 49
(1
14
3)
(1
24
5)
33 32 35 34
21 21A
10
8 481 26 15 25-1/4 20 15 43-7/8 11 25(660) (381) (641) (508) (381) (1114) (279) (635)
24 12
5
6B
15B 15C18B 18C
8
8
3
4A
5A
BASE
2
41-1/4
BASE
BASE
BASE
11A 11C
11B 11C
6
5
BASE
BASE
BASE
BASE
BASE
BASE
7
BASE
BASE
BASE
BASE
BASE
BASE
-
7
7
7
5
5
7
7
7
7
7
7
7
9
9
9
9
-
10
10
10
10
7
7
9
9
9
10
10
10
10
11
11
11
11
11
9
9
11
11
11
11
11
11
11
12
12
12
12
12
11
11
11
11
2926
11
11
2625
11
2524 24
11
11
11
11
11
12
OPTIONAL 250# SUCTION AND DISCHARGE FLANGES
STANDARD 125# SUCTION AND DISCHARGE FLANGES
OPTIONAL 125# SUCTION FLANGE, 250# DISCHARGE
FLANGE
MOTOR FRAME
11
12
12
12
12
12
12
12
12
12
11
11
11
11
11
12
12
12
12
12
10
10
11
11
11
12
12
12
12
12
12
12
12
12
11
11
11
11
11
12
12
12
12
12
12
12
12
12
10
10
11
11
11
12
12
12
12
12
12
12
12
12
11
11
11
11
11
12
12
12
12
12
12
12
12
12
11
11
11
11
11
12
12
12
12
12
12
12
12
12
14
11
11
12
12
12
12
12
12
12
12
12
12
12
12
14
11
11
12
12
12
12
12
12
12
13
13
13
13
13
13
14
14
14
12
12
12
12
12
12
12
12
12
13
13
13
13
13
14
14
14
-
-
15
15
15
15
15
15
15
15
15
15
15
15
15
15
16
16
16
-
-
15
15
15
15
15
15
15
-
-
15
15
15
15
15
16
16
16
16
-
-
15
15
15
15
15
15
15
15
16
15
15
15
15
15
16
16
16
16
-
-
15
15
15
15
15
15
15
-
-
16
16
16
16
16
16
16
16
16
-
-
15
-
-
15
15
15
15
16
16
16
16
16
16
16
16
16
16
16
16
-
-
15
-
-
16
16
16
16
-
-
16
16
16
16
16
16
16
16
17
-
-
15
-
-
15
15
15
15
16
16
16
16
16
16
16
16
16
16
16
17
-
-
-
-
-
16
16
16
16
-
-
16
16
16
16
16
17
17
17
17
16
16
17
17
9 9 9
9 9 9
11 11 11
C
177
6B
BASE 17 17 17 17
44
9TS
44
9T
Section 912 Page 231Date March 22, 2013Supersedes Section 912 Page 231
Dated July 2012
BASE HA HB HE HG HH HF HP5 12 38 9 3 1/2 17 20
(305) (964) (228) (76) (13) (431) (508)7 13 42 10 4 5/8 17 24
(330) (1066) (254) (101) (15) (431) (609)9 15 44 12 3-3/8 5/8 19 24
(381) (1117) (305) (86) (15) (482) (609)10 18 44 15 4 5/8 42 1
(457) (1117) (381) (101) (15) (1066) (25)11 18 48 15 4 5/8 46 1
(457) (1219) (381) (101) (15) (1168) (25)12 18 54 15 4 5/8 52 1
(457) (1371) (381) (101) (15) (1320) (25)13 18 60 15 4 5/8 35 24
(457) (1524) (381) (101) (15) (888) (609)14 18 65 15 4 5/8 40 24
(457) (1651) (381) (101) (15) (1015) (609)15 22 60 19 4 5/8 58 1
(558) (1524) (482) (101) (15) (1473) (25)16 22 72 19 4 5/8 70 1
(558) (1828) (482) (101) (15) (1778) (25)17 22 84 19 4 5/8 82 1
(558) (2133) (482) (101) (15) (2082) (25)
NOTES1. All dimensions are in inches.2. Dimensions may vary 3/8".3. Not for construction purposes unless certified.4. Coupling gap may vary 1/8" thru 2-1/16".5. Conduit box is shown in approximate location. Dimensions are
not specifed as they vary with each motor manufacturer.6. Suction and discharge flanges are ANSI standard flat face.
* D is 10-1/2 when using frames 324TS - 365TS.** D is 12 when using frames 404TS - 445TS.*** Pump sizes 6-481-11HH & 6-481-14HH are furnished as standard
with 125# suction flange & 250# discharge flange.+D is 10-1/2 when using frames 404TS - 405T and D is 11 when
using frames 444TS - 445TS.
2013 Pentair Ltd.
RianHighlight
RianHighlight
RianRectangle
RianLine
RianLine
RianLine
roda nurmlaRectangle
adminHighlight
adminHighlight
adminHighlight
adminHighlight
adminHighlight
adminHighlight
adminHighlight
AURORA FIRE PUMPSSTANDARD FIRE PUMP ACCESSORIES
Section 916 Page 201Date February 2005Supersedes Section 916 Page 201Dated May 2004
Pentair Water
PIPE SIZE ATAP SIZE2-1/2-481-103-481-104-481-114-481-155-481-115-481-155-481-17 1-1/4"6-481-116-481-11HH6-481-14HH6-481-156-481-186-481-208-481-128-481-2110-481-1510-481-18D8-481-1710-481-18 2"
12-481-18ALL VERTICAL 3/4"(483) MODELS
ALL 2-STAGE 1-1/4"(485) MODELS
490 MODELS 3/4
NOTES:1. Dimensions are in inches (mm) and may
vary 1/4 (6).2. Accessories shown are shipped loose for
field installtion. 3. Casing relief valve is to be adjusted to
appropriate pressure upon field installtion4. Casing relief valve is furnished on electric
motor driven units only.5. Two stage pumps require both vent taps
piped to air release valve.6. Suction guage range is 30-0-150 PSI for
suction pressures up to 75 PSI, or 30-0-300 PSI for suction pressures over 75 PSI.
7. Discharge gauge range is 0-300-PSI forpumps with rated discharge pressures upto 150 PSI, or 0-600 PSI for pumps withrated discharge pressures over 150 PSI.
E
D
C
"A" PIPE TAP INCASING DISCHARGE
VALVE INLET SIZE "B"(PIPING BY OTHERS)
CASING RELIEF VALVE3/4" NPT OUTLET
1/2" PIPING BYOTHERS (SEE NOTE 5)
FLOAT-OPERATEDAIR RELEASE VALVE
1/2" NPT OUTLET
3-1/2" (89) DIA. SUCTION ANDDISCHARGE GAUGES WITH1/4" SHUT-OFF COCKS
CASING RELIEF VALVE
SYSTEM VALVE
G.P.M. INLET CSIZE - B
250500750
1000 3/4 4-1/21250 (114)15002000250030003500
1 5-1/2
4000(140)
SYSTEMOPERATING D EPRESSURE
UP TO 175 P.S.I. 5-7/8 (149) 3-3/4 (95)OVER 175 P.S.I. 6-11/16 (170) 5-5/8 (143)
FLOAT OPERATED AIR RELEASE VALVE
RianHighlight
RianHighlight
RianHighlight
RianRectangle
RianHighlight
RianHighlight
RianHighlight
RianRectangle
RianHighlight
RianRectangle
roda nurmlaText Box
RianRectangle
RianHighlight
adminOval
Section 916 Page 206Date June 2002Supersedes Section 916 Page 206Dated July 2001
Pentair Water
AURORA FIRE PUMPSAUTOMATIC AIR RELEASE VALVE
1/2 NPT" OUTLET4-3/4 (121)
5-1/4 (133)
1/2" NPT INLET
HYDR8AC(VAL-MATIC VM15A)
OR APPROVED EQUAL USEDWITH HORIZONTAL FIRE PUMPS
WORKING PRESSURE UP TO 300 PSI(FM APPROVED)
9-1/2 (241)
2" NPT OUTLET
12 (305)
2" NPT INTLET
HYDR8AD(VAL-MATIC #102)
USED WITH VERTICAL TURBINE FIRE PUMPSWORKING PRESSURE UP TO 300 PSI
NOTES:1. All dimensions are in inches (mm) and may vary 1/4 (6).
RianHighlight
RianHighlight
RianText Box
The drawings included in this package are for controllers covered under our standard offering. Actual AS BUILT drawings may differ from what is shown in this package
NOTE:
2012
Contents:
Model GPY
!"
Project:Customer:Engineer:Pump Manufacturer:
#"$
Submittal Data Sheet Model GPY Electric Fire Pump Controller
FM Global New York City
CE Mark
NEMA 12 NEMA 4X-304 sst painted IP54NEMA 3 NEMA 4X-304 sst brushed finish IP55 NEMA 3R NEMA 4X-316 sst painted IP65NEMA 4 NEMA 4X-316 sst brushed finish IP66
Accessories Bottom entry gland plate Lifting Lugs Keylock handle
Glossy textured finish
Accepted for use in the City of New York by the Department of Buildings
Built to NFPA 20 (latest edition)
Optional
Standard, Listings,
Approvals and Certifications
Paint Specifications
Underwriters Laboratory (UL) UL218 - Fire pump controllers CSA C22.2 No. 14 Industrial Control EquipmentClass 1321/1323
Various EN, IEC & CEE directives and standardsProtection Rating
Standard: NEMA 2 (IP31)Optional
Enclosure
Red RAL3002 Powder coating
*Please see Disconnecting Means details on page 2.
Optional 150,000 A 100,000 A
Shortcircuit Withstand Rating 208V to 480V - 3ph - 50/60Hz 600V - 3ph - 60Hz
Standard 100,000 A 50,000 A
1July 2012
Across-the line startingLocked rotor current
Full load current
Percent of motor speed (%)
Line
cur
rent
% o
f ful
l load
20 40 60 80 100
600
Transition current
Wye delta starting
Open transition
210
Starting Method: Reduced Voltage Wye-delta openTypical Voltage Applied at Start: 100% Inrush Current: 33% of normal load currentStarting Torque: 33%Motor Type: Wye-deltaNo. of Contactors: 2 at 58%, 1 at 33% of motor FLC Min. ampacity of motor conductors: 6 at 125% x 58% of FLC
T2
T1
T31M
T4
T6
T52M
1S
3L2
1M
CR4
2M
CR5
1S
CR5 2M
1S
3L1
3L2
3L3
3L1
M
From normal incoming power through Disconnecting Means (IS/CB)*
RianHighlight
RianHighlight
RianHighlight
RianHighlight
RianHighlight
Submittal Data Sheet Model GPY Electric Fire Pump Controller
Surge Suppression
Service Entrance
Rating
Door interlocked in the ON position
Emergency Start Handle
Integrated limit switch Across the line start (direct on line)
Flange mounted
Operate shunt trip to open circuit breaker Factory set at 600% of motor full load current
Voltage phase to phase (normal power) Amperage of each phase when motor is running
Pressure Sensing Drain connection 3/8"
Pressure transducer and run test solenoid valve assembly for fresh water application Pressure sensing line connection 1/2 Female NPT
Rated for 0-500PSI working pressure (calibrated at 0-300psi) Externally mounted with protective cover
Under regular maintained operation, events can be stored in memory for up to 5 years. Data viewable on operator interface display screen
Surge arrestor rated to suppress surges above line voltage
Isolating switch and circuit breaker assembly:
Isolating switch rated not less than 115% of motor full load currentCircuit breaker continuous rating not less than 115% of motor full load currentOvercurrent sensing non-thermal type, magnetic only Instantaneous trip setting of not more than 20 times the motor full load current
Common flange mounted operating handle
Trip between 8 and 20 seconds
Downloadable by USB port to external memory device
Continuous system pressure display Cut-in and Cut-out pressure settings Pressure readings with date stamp Event recording with date stamp
Pressure Readings
Pressure and Event
Recorder
Disconnecting Means
Suitable as service entrance equipment
Pull and latch activation
Locked Rotor Protector
Electrical Readings
2July 2012
Submittal Data Sheet Model GPY Electric Fire Pump Controller
Audible Alarm Power available Locked rotor Manual start Phase reversal Periodic test Deluge valve start Motor run Fail to start Remote automatic start Pump room alarm Low discharge pressure Remote manual start Motor trouble Low pump room temperature Overcurrent Phase loss Pump room temperature (F or C) Undercurrent Phase unbalance Pump on demand/Automatic start Undervoltage Low w ater level Emergency start Overvoltage
Overvoltage Undervoltage Phase unbalance Low pump room temperature
temperature
Overcurrent Fail to start Undercurrent Ground fault
Expandable storage Multi-language
Sequential start timer (on delay) Periodic test timer Pressure Non-pressure Automatic Non-automatic
** Can only be used if approved by the AHJ
Actuation
Start on pressure drop
Manual Start
Start pushbutton Run test pushbutton Deluge valve start
Timers
Remote start from manual device
Field Adjustable & Visual Countdown
Visual IndicationMode
Manual with Stop pushbutton
Remote start signal from automatic deviceAutomatic Start
Embedded microcomputer with software PLC logic 4.2 color touch screen (HMI technology) Upgradable software
Stopping Automatic after expiration of minimum run timer **
ViZiTouch Operator Interface
Visual Indications and
Alarms
Operation
Common motor trouble
Remote Alarm Contacts
SPDT-8A-250V.AC Power available
4 alarm bell - 85 dB at 10ft. (3m)
Phase reversal
Common pump room alarm Motor run
3July 2012
208V - 240V 380V - 416V 440V - 480V 600V
275 (125)
5 - 30 (3.7- 22)
5 - 50 (3.7 - 37)
5 - 60 (3.7 - 45)
5 - 75 (3.7 - 55)
375 (170)
40 - 60 (30 - 45)
60 - 100 (45 - 75)
75 - 150 (55 - 110)
100 - 150 (75 - 110)
600(270)
75 - 150(55 - 110)
125 - 350 (90 - 257)
200 - 400 (147- 295)
200 - 500 (147 - 368)
Approx. Shipping Weight in Lbs (Kg) HP Range (kW)
Submittal Data Sheet Model GPY Electric Fire Pump Controller
D1Low suction pressure transducer for fresh water rated at 0-300PSI with visual indication and alarm contact
D1ALow suction pressure transducer for sea water rated at 0-300PSI with visual indication and alarm contact
D5Pressure transducer and run test solenoid valve for fresh water rated for 0-500PSI (for calibration purposes only)
D5DPressure transducer and run test solenoid valve for sea water rated for 0-500PSI
D10 Omit mounting feet (when applicable) D13
High withstand rating (fire pump section only) up to 480V = 150KA / 600V = 100KA
D14Anti-condensation heater & thermostat (fire pump section only)
D14AAnti-condensation heater & humidistat (fire pump section only)
D14BAnti-condensation heater & thermostat & humidistat (fire pump section only)
D15 TropicalizationD18 CE Mark with factory certificate D19 French labelingD20 Spanish labelingD21 Other languagesD26 Modbus RTU provisionD26A Modbus TCP/IP provision
D27Motor heater connection (external single phase power source and heater on/off contact)
D27AMotor heater connection (internal single phase power source and heater on/off contact)
D28 Customized drawing set D34 Field programmable I/O board - 8 Input / 5 outputD35 Field programmable I/O board - 8 Input / 10 output
D36Redundant pressure transducer for fresh water rated for 0-500PSI (calibrated at 0-300PSI)
D36ARedundant pressure transducer for sea water rated for 0-500PSI (calibrated at 0-300PSI)
D37 Window kit for operator interface
4July 2012
Note: Options chosen from this page are not electrically represented on the wiring schematics in this submittal package.
A4 Flow switch provision
A8Foam pump application w/o pressure transducer and run test solenoid valve
A9 Low zone pump control functionA10 Medium zone pump control function A11 High zone pump control function
A13Non-pressure actuated controller w/o pressure transducer and run test solenoid valve
A16Lockout/interlock circuit from equipment installed inside the pump room Built in alarm panel (120V.AC supervisory power) providing indication for:
Audible alarm & silence pushbutton for motor run, phase reversal, loss of phase.
Pilot lights for loss of phase & supervisory power available
B11BBuilt in alarm panel same as B11 but 220-240VAC supervisory power
B19High motor temperature thermistor relay c/w visual indication and alarm contact (Form C-SPDT)
B21Ground fault alarm detection c/w visual indication and alarm contact (Form C-SPDT)
C1 Extra motor run alarm contact (Form C-SPDT)C4 Periodic test alarm contact (Form C-SPDT)C6 Low discharge pressure alarm contact (Form C-SPDT)C7 Low pump room temperature alarm contact (Form C-SPDT)C10 High water reservoir level alarm contact (Form C-SPDT)C11 High electric motor temperature alarm contact (Form C-SPDT)C12 High electric motor vibration c/w visual indication and alarm contact (Form C-SPDT)C14 Pump on demand/automatic start alarm contact (Form C-SPDT)C15 Pump fail to start alarm contact (Form C-SPDT)C16 Control voltage healthy alarm contact (Form C-SPDT)C17 Flow meter valve loop open c/w visual indication and alarm contact (Form C-SPDT)C18 High water reservoir level c/w visual indication and alarm contact (Form C-SPDT)C19 Emergency start alarm contact (Form C-SPDT)C20 Manual start alarm contact (Form C-SPDT)C21 Deluge valve start alarm contact (Form C-SPDT)C22 Remote automatic start alarm contact (Form C-SPDT)C23 Remote manual start alarm contact (Form C-SPDT)C24 High pump room temperature alarm contact (Form C-SPDT)Cx Additional visual and alarm contact (Specify function) (Form C-SPDT)
B11
Submittal Data Sheet Model GPY Electric Fire Pump Controller
5July 2012
ViZiTouch Operator Interface
??
4
9
11 12
10
13
5 6 7
3
2
1
88
1 - Power LED2 - Color touch screen3 - Alarm LED4 - HOME page button 5 - ALARM page button6 - CONFIGURATION page button7 - HISTORY page button
8 - USB port9 - START button10 - Contextual navigation pad11 - STOP button12 - RUN TEST button13 - HELP button
qwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmrtyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxcvbnmqwertyuiopasdfghjklzxc
SparePartListBookControllerModel:GPD
PERTAMINABALIKPAPANDEPOTPANGKALANBUN,
DEPOTPULANGPISAU,DPPUJUWATA
Preparedby:PT.RodaNurmala
RianText Box
RianText BoxDIESEL FIRE PUMP Aurora Horizontal Split Case Model : 6-491-14 A/Single Stage COAL FIRED POWER STATION,BABELAN
Customer :Project name : Default
Pump Performance CurveEncompass 2.0 - 15.1.1.0
0
80
160
240
320Po
wer
- hp
Power
0.0
1.5
3.0
4.5
6.0
7.5
9.0
10.5
12.0
13.5
15.0
0 500 1,000 1,500 2,000 2,500 3,000 3,500 4,000
Hea
d - b
ar
Flow - USgpm
14.25 in 51 63 72
72
80
80
84
84
86
86
11.06 in
Preferred operating region
Item number : 012 Size : 6-491-14A Service : Stages : 1Quantity : 1 Driver type : EngineQuote number : 259241 Frequency : 0 HzDate last saved : 13 May 2015 2:04 AM Speed, rated : 2,100 rpmFlow, rated : 2,000.0 USgpm Based on curve number : 194-6X10X14A-2100Differential head /pressure, rated
: 9.03 bar Efficiency : 75.93 %
:
Shutoff head : 10.20 bar:
Suction pressure, max : 0.00 psi.gPower, maximum : 245 hp
adminText Box
adminText BoxDFP.Cap.2000 Gpm @ 9 Bar Total Head
2013 Pentair Ltd.
AURORA MODELS 481, 491 AND 492 PUMPS
SINGLE-STAGE FIRE PUMPCUMMINS CFP9E DIESEL ENGINE DRIVE
Section 913 Page 291Date JULY 2013
PUMP SIZE
SUCTIONPOWER SERIES S W X Z CP YY ZZ HD HYDISCH MODEL
CASE BORE
5 491 14A 8 - 8.25 17.63 13.5 9.75 31.69 17.25 1 27.81 12.385 491 18A 8 - 8.13 18.88 15 10.63 31.38 18.75 1 27.81 11.136 491 14A 10 - 9.38 20.13 13.25 10 31.38 18.75 1 31.81 24.386 491 18C 10 - 9.38 20.13 16 11.75 35.88 20 1 31.81 24.386 491 19A 10 - 9.38 22.63 18 12.13 35.88 18 1 31.81 21.886 481 20 8 5 8 18 15.75 8 32 18 1.25 27.81 128 491 14A 12 - 10.75 20.5 16 10.75 36.63 22 1 31.81 248 481 17B 10 5 8 18 17 8 32 17.75 1.25 27.81 128 491 18A 12 - 10.75 23.75 16 12.5 41.5 22 1 31.81 20.758 481 21/A 10 6B 9.5 21.88 18 9.5 38 21 1.25 27.81 22.638 481 24 12 7 15 25.25 20 15 43.88 25 1.25 36.81 19.25
10 481 15C 12 6B 13.5 21.88 18 13.5 38 20 1.25 36.81 22.6310 481 18 12 6B 13.5 21.88 18 13.5 38 22 1.25 36.81 22.6310 492 18 12 - 11.5 25.56 21 11.5 45.81 21 1 31.81 18.9410 481 18D 12 7A 12.25 24.31 20 12.25 43 24 1.25 36.81 20.2510 491 20* 16 - 15 25.25 20 15 43.88 25 1.25 36.81 18.9412 481 18A 14 7 15 25.25 18 15 43.88 23 1.25 36.81 19.25
NOTES:1. All dimensions are in inches and may vary 3/8".2. Not for construction purposes, unless certified.3. Suction and discharge flanges are ANSI Standard flat face.4. Refer to individual engine dimension print for reference point
used to determine overall engine length.5. Left hand (counterclockwise) rotation is not available.
6. The driveshaft is not designed to operate at a 0 angle. The engine crankshaft is to be parallel offset of 0.50 0.25 inch. The engine crankshaft may be parallel offset from the pump shaft 0.50 inch right or left.
* Pump size 1049120 is furnished as standard with 125# suction flange and 250# discharge flange.
-
adminHighlight
adminRectangle
DIVISI OGHighlight
DIVISI OGHighlight
DIVISI OGHighlight
PT. RODA NURMALA
Project
CheckedApproved
Drawn
Scale
Dwg. No :
UNSCALE
AY
STANDAR INSTALASI NFPA DIESEL, ELECTRIC & JOCKEY FIRE PUMP
Single Line Pippe Drawing
RN-DK0031300810
PRELIMINARY ONLY
RZ
This Draw Property of PT. Roda Nurmala, Shall be use for Corporate purpose. if this draw not used again, so expected to deleted this drawn.
NOTE :This Draw just preliminary only for describe the real condition.
NFPA 20 Piping & Accessories Standard Inform ation
2000 GPM Fire Pum p Jockey Pum p 12 M3/H
Suction Pipe
Discharge Pipe
Relief Valve
Waste Cone
Metering Device
Suction Gate Valve
Suction Pipe
Discharge Pipe
Suction Gate Valve
10''
10''
6'' X 6''
6'' X 10''
8''
OS & Y Valve
2.5''
2.5''
OS & Y Valve
FW
COAL FIRED POWER STATION,B AB ELAN
FM-UL-cUL APPROVED RATINGS BHP/KW
FIRE PUMP ENGINES
MODELSJU6H-UF32 JU6H-UFM2 JU6H-UF54 JU6H-UFAAPG
JU6H-UFD0 JU6H-UF34 JU6H-UF58 JU6H-UF60 JU6H-UFAARGJU6H-UFD2 JU6H-UFM8 JU6H-UF50 JU6H-UF62 JU6H-UF84JU6H-UF30 JU6H-UFM0 JU6H-UF52 JU6H-UFAAQ8 JU6H-UFAAS0
JU6HMODEL
RATED SPEED US-EPA (NSPS)
Available Until
1470 1760 2100 2350 2600 2800 3000
UFD0 110 82 144 107 148 110 12/31/09UFD2 148 110 148 110 12/31/09UF30 94 70 140 104 160 119 160 119 12/31/09UF32 160 119 160 119 12/31/09
UF34 160 119 175 131 12/31/11 12/31/12 +
UFM8 136 101 175 131 12/31/09UFM0 175 131 207 154 200 149 12/31/08UFM2 200 149 200 149 12/31/08UF58 138 103 183 137 12/31/08UF50 183 137 210 157 210 157 12/31/08UF52 210 157 210 157 12/31/08UF54 216 161 216 161 12/31/11UFAAPG 220 164 N/A
Picture shown represents JU6H-TRWA engine model
USA EPA (NSPS) Emissions Compliant. Applies to John UFAAQ8 227 169 N/A UF60 200 149 240 179 240 179 12/31/08UF62 240 179 240 179 12/31/08UFAARG 252 188 N/A UF84 259 193 275 205 12/31/11UFAAS0 260 194 N/A
SPECIFICATIONSJU6H MODELS
( ) p ppDeere model year per Table 4 of 40 CFR Part 60 Sub Part IIII.
All Models are available for Export N/A = Not Applicable / Non-Emissionized+ Not Available in California
Less than 175 HPGreater than 174 HP
ITEM
JU6H MODELS
D0 D2 30 32 34 M8 M0 M2 58 50 52 54 60 62 84 AAPG AAQ8 AARG AAS0
Number of Cylinders 6Aspiration T TRWARotation* CWOverall Dimensions in. (mm) 45.8 (1163) H x 57.4 (1457) L x 36.6 (930) W 45.8 (1163) H x 58 (1473) L x 36.6 (930) WCrankshaft Centerline Height - in. (mm) 14 (356)Weight lb (kg) 1657 (750) 1693 (766)Compression Ratio 17.0:1Displacement cu. in. (L) 414 (6.8)Engine Type 4 Stroke Cycle Inline ConstructionBore & Stroke in. (mm) 4.19 x 5.00 (106 x 127)Installation Drawing D536Wiring Diagram AC C07651Wiring Diagram DC C072145 C072128
Abbreviations: CW Clockwise T Turbocharged TRWA Turbocharged with Raw Water Aftercooling L - Length W Width H - Height *Rotation viewed from Heat Exchanger / Front of engine
Engine Series John Deere 6068 SeriesSpeed Interpolation Optional
CERTIFIED POWER RATING Each engine is factory tested to verify power and performance.
Although FM-UL ratings are shown at specific speeds, Clarke engines can be applied at any intermediate speed. To determine the intermediate speed
ENGINE RATINGS BASELINES Engines are to be used for stationary emergency standby fire pump service only. Engines
are to be tested in accordance with NFPA 25.
Engines are rated at standard SAE conditions of 29.61 in. (752.1 mm) Hg barometer and
FM
app ed at a y te ed ate speed o dete e t e te ed ate speedpower; make a linear interpolation from the Clarke FM-UL power curve. Contact Clarke or your Pump OEM Representative to obtain details.
77F (25C) inlet air temperature [approximates 300 ft. (91.4 m) above sea level] by the testing laboratory (see SAE Standard J 1349).
A deduction of 3 percent from engine horsepower rating at standard SAE conditions shall be made for diesel engines for each 1000 ft. (305 m) altitude above 300 ft. (91.4 m)
A deduction of 1 percent from engine horsepower rating as corrected to standard SAE conditions shall be made for diesel engines for every 10F (5.6C) above 77F (25C) ambient temperature.
adminHighlight
adminRectangle
adminHighlight
adminHighlight
adminHighlight
adminHighlight
adminHighlight
adminHighlight
ENGINE EQUIPMENT
FIRE PUMP ENGINES
MODELSJU6H-UF32 JU6H-UFM2 JU6H-UF54 JU6H-UFAAPG
JU6H-UFD0 JU6H-UF34 JU6H-UF58 JU6H-UF60 JU6H-UFAARGJU6H-UFD2 JU6H-UFM8 JU6H-UF50 JU6H-UF62 JU6H-UF84JU6H-UF30 JU6H-UFM0 JU6H-UF52 JU6H-UFAAQ8 JU6H-UFAAS0
ENGINE EQUIPMENTEQUIPMENT STANDARD OPTIONALAir Cleaner Direct Mounted, Washable, Indoor Service with Drip Shield Disposable, Drip Proof, Indoor Service Outdoor Type, Single or
Two Stage (Cyclonic)Alarms Overspeed Alarm & Shutdown, Low Oil Pressure, Low & High
Coolant Temperature, Low Raw Water Flow, High Raw Water Temperature
Low Coolant Level, Low Oil Level, Oil Filter Differential Pressure, Fuel Filter Differential Pressure, Air Filter Restriction
Alternator 12V-DC, 42 Amps with Poly-Vee Belt and Guard 24V-DC, 40 Amps with Poly-Vee Belt and GuardCoupling Bare Flywheel Listed Driveshaft and Guard UFD0/D2/30/32/34 CDS20-S1; Coupling Bare Flywheel Listed Driveshaft and Guard, UFD0/D2/30/32/34 CDS20 S1;
UFM8/M0/M2/58/50/52/54/60/62/84 CDS30-S1; AAPG/AAQ8/AARG/AAS0 CDS50-SC
Engine Heater 115V-AC, 1360 Watt 230V-AC, 1360 WattExhaust Flex Connection SS Flex, 150# ANSI Flanged Connection, 5 SS Flex, 150# ANSI Flanged Connection, 6Exhaust Protection Metal Guards on Manifolds and TurbochargerFlywheel Housing SAE #3Flywheel Power Take Off 11.5 SAE Industrial Flywheel ConnectionFuel Connections Fire Resistant, Flexible, USA Coast Guard Approved, Supply and SS, Braided, cUL Listed, Supply and Return Lines
Return LinesFuel Filter Primary Filter with Priming PumpFuel Injection System Stanadyne, Direct Injection
Fuel Solenoid 12V-DC Energized to Stop (ETS) 12V-DC Energized to Run (ETR) JU6H-UFAA models only
12V-DC Energized to Run (ETR); 24V-DC Energized to Run (ETR); 24V-DC Energized to Stop (ETS)
Governor, Speed Constant Speed, MechanicalHeat Exchanger Tube and Shell Type, 60 PSI (4 BAR), NPT(F) Connections
Sea Water CompatibleInstrument Panel English and Metric, Tachometer, Hourmeter, Water Temperature,
Oil Pressure and Two (2) VoltmetersJunction Box Integral with Instrument Panel; For DC Wiring Interconnection to
Engine ControllerLube Oil Cooler Engine Water Cooled, Plate TypeLube Oil Filter Full Flow with By-Pass ValveLube Oil Pump Gear Driven, Gear TypeManual Start Control On Instrument Panel with Control Position Warning LightOverspeed Control Electronic with Reset and Test on Instrument PanelOverspeed Control Electronic with Reset and Test on Instrument PanelRaw Water Cooling Loop w\Alarms
Galvanized Seawater, All 316SS, High Pressure
Raw Water Cooling Loop Solenoid Operation
Automatic from Fire Pump Controller and from Engine Instrument Panel (for Horizontal Fire Pump Applications)
Not Supplied (for Vertical Turbine Fire Pump Applications)
Run Stop Control On Instrument Panel with Control Position Warning Light
Starters Two (2) 12V-DC Two (2) 24V-DC
Throttle Control Adjustable Speed Control, Tamper Proof Water Pump Centrifugal Type Poly-Vee Belt Drive with GuardWater Pump Centrifugal Type, Poly-Vee Belt Drive with Guard
Abbreviations :DC Direct Current, AC Alternating Current, SAE Society of Automotive Engineers, NPT(F) National Pipe Tapered Thread (Female) SS Stainless Steel
C13556 revP13APR15
Specifications and information contained in this brochure subject to change without notice. .
Fire Protection Products, Inc.100 Progress Place, Cincinnati, Ohio 45246United States of AmericaTel +1-513-475-(FIRE)3473 Fax +1-513-771-8930www.clarkefire.com
UK, Ltd.Grange Works, Lomond Rd., Coatbridge, ML5-2NNUnited KingdomTel +44-1236-429946 Fax +44-1236-427274www.clarkefire.com
adminHighlight
NAMEPLATE BHP (MAXIMUM PUMP LOAD)
722(538.5)
2098.5 2099 2099.5 2100 2100.5 2101 2101.5720.5
721
721.5
722
722.5
723
723.5
Non Emissionized
Ref: Engine Emission Label
RESTRICTED:
DATE CREATED
DRAWING NO. REVA
ENGINE MODEL DS0H-UFAA9208/28/13
C135397
THIS DRAWING AND THE IN-FORMATION HEREIN ARE OUR PROPERTY AND MAY BE USED BY OTHER ONLY AS AUTHORIZED BY US. UNPUBLISHED -- ALL RIGHTS RESERVED UNDER THECOPYRIGHT LAWS.KEVIN KUNKLER 28AUG13
CREATED
USE ONLY FOR STAND-BY FIRE PUMP APPLICATIONS
FIRE PUMP MODEL: DS0H-UFAA92Heat Exchanger Cooled/Turbocharged
Raw Water Charge Cooling18.3 Liter
ENGINE SPEED - RPM
STANDARD CONDITIONS: (SAE J1349, ISO 3046)77F (25C) AIR INLET TEMPERATURE29.61 IN. (751.1MM) HG BAROMETRIC PRESSURE#2 DIESEL FUEL (SEE C13940)
ENGINE PERFORMANCE:
adminRectangle
DS0H-UFAA92
USA ProducedINSTALLATION & OPERATION DATA (I&O Data)
Basic Engine Description Engine Manufacturer 180 Series
Ignition Type Compression (Diesel)
Number of Cylinders 10
Bore and Stroke - in (mm) 5.04 (128) X 5.59 (142)
Displacement - in (L) 1115 (18.3)
Compression Ratio 14.6:1
Valves per cylinderIntake 1
Exhaust 1
Combustion System Direct Injection
Engine Type Vee, 4 stroke cycle
Fuel Management Control Mechanical, Inline Pump
Firing Order (CW Rotation) 1-6-5-10-2-7-8-3-4-9
Aspiration Twin Turbocharged
Charge Air Cooling Type Raw Water Cooled
Rotation, viewed from front of engine, Clockwise (CW) Standard
Engine Crankcase Vent System Closed
Installation Drawing D665
Weight - lb (kg) 3200 (1450)
Power Rating 2100 Nameplate Power - HP (kW) 722 (538.5)
Cooling System - [C051529] 2100 Engine Coolant Heat - Btu/sec (kW) 336 (355)
Engine Radiated Heat - Btu/sec (kW) 77 (81.2)
Heat Exchanger Minimum Flow60F (15C) Raw H20 - gal/min (L/min) 45 (170)
100F (37C) Raw H20 - gal/min (L/min) 55 (208) Heat Exchanger Maximum Cooling Raw Water
Inlet Pressure - psi (bar) 60 (4.1)
Flow - gal/min (L/min) 80 (303)
Typical Engine H20 Operating Temp - F (C)[1] 170 (76.7) - 200 (93.3) Thermostat
Start to Open - F (C) 160 (71.1)
Fully Opened - F (C) 185 (85)
Engine Coolant Capacity - qt (L) 33 (31.2)
Coolant Pressure Cap - lb/in (kPa) 7 (48.3)
Maximum Engine Coolant Temperature - F (C) 205 (96.1)
Minimum Engine Coolant Temperature - F (C) 160 (71.1)
High Coolant Temp Alarm Switch - F (C) 205 (96.1)
Electric System - DC Standard System Voltage (Nominal) 24
Battery Capacity for Ambients Above 32F (0C)Voltage (Nominal) 12 [C07633]
Qty. Per Battery Bank 2
SAE size per J537 8D
CCA @ 0F (-18C) 1400
Reserve Capacity - Minutes 430
Battery Cable Circuit, Max Resistance - ohm 0.0012
Battery Cable Minimum Size0-120 in. Circuit Length [2] 00
121-160 in. Circuit Length [2] 000
161-200 in. Circuit Length [2] 0000
Charging Alternator Maximum Output - Amp, 45 [65.26101-7153C]
Starter Cranking Amps, Rolling - @60F (15C) 315 [65.26201-7074D]
NOTE: This engine is intended for indoor installation or in a weatherproof enclosure. 1Engine H2O temperature is dependent on raw water temperature and flow. 2Positive and Negative Cables Combined Length.
Page 1 of 2
adminHighlight
DS0H-UFAA92
USA ProducedINSTALLATION & OPERATION DATA (I&O Data)
Exhaust System (dual exhaust outlets) 2100 Exhaust Flow - ft./min (m/min)[3] 3813 (108)
Exhaust Temperature - F (C) 970 (521)
Maximum Allowable Back Pressure - in H20 (kPa) 40 (10) Minimum Exhaust Pipe Dia. - in (mm)[4] (quantity 2) 5 (127)
Fuel System 2100 Fuel Consumption - gal/hr (L/hr) 36.3 (137)
Fuel Pressure - lb/in (kPa) 17 (117) - 26 (179)
Minimum Line Size - Supply - in. .75 Schedule 40 Steel Pipe
Pipe Outer Diameter - in (mm) 1.05 (26.7)
Minimum Line Size - Return - in. .50 Schedule 40 Steel Pipe
Pipe Outer Diameter - in (mm) 0.848 (21.5)
Maximum Allowable Fuel Pump Suction Liftwith clean Filter - in H20 (mH20) 54 (1.4)
Maximum Allowable Fuel Head above Fuel pump, Supply or Return - ft (m) 16 (4.9)
Fuel Filter Micron Size 5
Heater System Standard Optional Engine Coolant Heater
Wattage (Nominal) 2500 2500
Voltage - AC, 1 Phase 230 (+5%, -10%) 115 (+5%, -10%)
Part Number [C122194] [C122190]
Air System 2100 Combustion Air Flow - ft./min (m/min) 2271 (64.3)
Air Cleaner Standard Optional Part Number [C03244 Qty (2)] [C03330 Qty 2]
Type Indoor Service Only, Canister,
with Shield Single-Stage
Cleaning method Washable Disposable
Air Intake Restriction Maximum LimitDirty Air Cleaner - in H20 (kPa) 14 (3.5) 14 (3.5)
Clean Air Cleaner - in H20 (kPa) 7 (1.7) 7 (1.7) Maximum Allowable Temperature (Air To Engine Inlet) - F (C)[5] 130 (54.4)
Lubrication System Oil Pressure - normal - lb/in (kPa) 53 (365) - 89 (614)
Low Oil Pressure Alarm Switch - lb/in (kPa) 11.4 (78.6)
In Pan Oil Temperature - F (C) 156 (68.9) - 230 (110)
Total Oil Capacity with Filter - qt (L) 37 (35)
Lube Oil Heater Optional Optional Wattage (Nominal) 300 300
Voltage 120V (+5%, -10%) 240V (+5%, -10%)
Part Number C04559 C04560
Performance 2100 BMEP - lb/in (kPa) 244 (1680)
Piston Speed - ft/min (m/min) 1957 (597)
Mechanical Noise - dB(A) @ 1m Consult Factory
Power Curve C135397
3Engine has dual exhaust outlets. Combined total exhaust flow from both outlets is given. 4Based on Nominal System. Back pressure flow analysis must be done to assure maximum allowable back pressure is not exceeded. (Note: minimum exhaust Pipe diameter is based on: 15 feet of
pipe, one 90 elbow, and a silencer pressure drop no greater than one half of the maximum allowable back pressure.) 5Review for horsepower derate if ambient air entering engine exceeds 77F (25C). [ ] indicates component reference part number.
Page 2 of 2C135404 Rev F
DP 18MAR15
adminHighlight
CLARKE Fire Protection Products
Air Cleaner Crank Pin BearingsIndoor Usage Only TypeOne PieceOiled Fabric Pleats Material Steel backed, Lead Bronze
Material...... Surgical Cotton Aluminum Mesh Crankshaft
Material Forged SteelAir Cleaner - Optional Type of BalanceDynamical, Screwed on BalancedType. Canister WeightsMaterial Pleated PaperHousing.. Enclosed Cylinder Block
TypeOne Piece w/ Non-Siamese Cyl.Camshaft Material Cast IronMaterial...... Chromium Molybdenum Steel
Nitride Hardening Cylinder HeadLocation...... In Block Type.. Individual, 2 ValveDrive... Gear Material Cast IronType of Cam........Ground
Cylinder LinersCharge Air Cooler Type..Centrifugal Cast, Wet LinerType.. Raw Water Cooled - All Material.Alloy Iron Plateau, HonedMaterials (in contact with raw water) Tubes.. 90/10 CU/NI (Effective Dec 2013) Tube Header Plate Brass (ASTM C4621) Heat Exchanger - Standard (Sea Water Compatible) Inlet/Outlet CoversBronze (BC6) Type Tube & Shell PlumbingGalvanized Steel Pipe Materials (in contact with raw water)
ISO 15540 Hose (Standard) Tubes.... CopperOther Materials (Optional) Shell.. Copper
Headers. CopperCoolant Pump Electrode ZincType . CentrifugalDrive. Belt Injection Pump
Type In LineCoolant Thermostat Drive GearTypeFull BlockingQty3 Lubrication Cooler
Type PlateCooling Loop (Galvanized)Tees, Elbows, PipeGalvanized Steel Lubrication PumpBall ValvesBrass ASTM B 124 Type GearSolenoid Valve Brass Drive GearPressure RegulatorBronzeStrainerCast Iron (1/2"- 1" Loops) Main Bearings
or Bronze (1.25" - 2" Loops) Type... Precision Half ShellsMaterial.. Steel Backed, Lead Bronze
Cooling Loop (Sea Water)Tees, Elbows, Pipe316 Stainless Steel PistonBall Valves316 Stainless Steel Type and Material. Aluminum Alloy with Reinforced/Top GrooveSolenoid Valve 316 Stainless Steel Cooling Oil Jet SprayPressure Regulator/StrainerCast Brass ASTM B176 C87800
Piston PinCooling Loop (Sea Water) Type . Full FloatingTees, Elbows, Pipe316 Stainless SteelBall Valves316 Stainless Steel Piston RingsSolenoid Valve 316 Stainless Steel Number/Piston.. 3Pressure Regulator/Strainer316 Stainless Steel Top.. Keystone Barrel Faced-
Hard Chrome CoatedConnecting Rod Second Tapered Cast IronTypeOne Piece, Diagonally Split Hard Chrome CoatedMaterialDie Forged Steel Third Double Rail Type
with Expander Spring
DR8 & DS0
Type.
ENGINE MATERIALS AND CONSTRUCTION
C134774 revC
adminHighlight
adminHighlight
CLARKEwww.clarkefire.com
RPM BHP OVERALL 31.5 Hz 63 Hz 125 Hz 250 Hz 500 Hz 1k Hz 2k Hz 4k Hz 8k Hz 16k HzdB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
2100 260 107.5 65.6 67.5 81.5 89.1 97.0 100.2 103.7 100.8 96.1 97.6
RPM BHP OVERALL 31.5 Hz 63 Hz 125 Hz 250 Hz 500 Hz 1k Hz 2k Hz 4k Hz 8k Hz 16k HzdB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A) dB(A)
2100 260 110.2 99.9 104.3 99 101.2 100.8 103.5 100.7 90.4 84
The above data reflects values for a typical engine of this model, speed and power in a free-field environment.
Installation specifics such as background noise level and amplification of noise levels from reflecting off of surrounding objects, will affect the overall noise levels observed. As a result of this, Clarke makes no guarantees to the above levels in an actual installation.
Raw Exhaust Engine Noise ** Octave Band
Octave Band
* Values above are provided at 3.3ft (1m) from engine block and do not include the raw exhaust noise.
** Values above are provided at 23ft (7m), 90 o horizontal, from a vertical exhaust outlet and does not include noise created mechanically by the engine.
Fire Protection Products
JU6H-UFAAS0FIRE PUMP DRIVER
NOISE DATA
Mechanical Engine Noise *
C135162_revA 18Apr13 dsp
adminHighlight
DIVISI OGHighlight
DIVISI OGHighlight
DIVISI OGHighlight
DIVISI OGRectangle
DIVISI OGRectangle
ED
C
"A" PIPE TAP INCASING DISCHARGE
VALVE INLET SIZE "B"(PIPING BY OTHERS)
CASING RELIEF VALVE3/4" NPT OUTLET
1/2" PIPING BYOTHERS (SEE NOTE 5)
FLOAT-OPERATEDAIR RELEASE VALVE
1/2" NPT OUTLET
3-1/2" (89) DIA. SUCTION ANDDISCHARGE GAUGES WITH1/4" SHUT-OFF COCKS
AURORA FIRE PUMPSSTANDARD FIRE PUMP ACCESSORIES
Section 916 Page 201Date September 2013Supersedes Section 916 Page 201Dated February 2005
PIPE SIZE A TAP SIZE 2-1/2-481-10 3-481-10 4-481-11 4-481-15 5-481-11 5-481-15 5-481-17 1-1/4 6-481-11 6-481-11HH 6-481-14HH 6-481-15 6-481-18 6-481-20 8-481-12 8-481-21 10-481-15 10-481-18D 8-481-17 10-481-18 2
12-481-18 ALL VERTICAL 3/4 (483) MODELS
ALL 2-STAGE 1-1/4 (485) MODELS
490 MODELS 3/4
NOTES: 1. Dimensions are in inches (mm) and may
vary 1/4 (6). 2. Accessories shown are shipped loose for
field installtion. 3. Casing relief valve is to be adjusted to
appropriate pressure upon field installtion 4. Casing relief valve is furnished on electric
motor driven units only. 5. Two stage pumps require both vent taps
piped to air release valve. 6. Suction guage range is 30-0-150 PSI for
suction pressures up to 75 PSI, or 30-0-300 PSI for suction pressures over 75 PSI.
7. Discharge gauge range is 0-300-PSI for pumps with rated discharge pressures up to 150 PSI, or 0-600 PSI for pumps with rated discharge pressures over 150 PSI.
CASING RELIEF VALVE SYSTEM VALVE G.P.M. INLET C SIZE - B 250 500 750 1000 3/4 4-1/2 1250 (114) 1500 2000 2500 3000 3500
1
5-1/2
4000 (140)
SYSTEM OPERATING D E PRESSURE UP TO 175 P.S.I. 5-7/8 (149) 3-3/4 (95) OVER 175 P.S.I. 6-11/16 (170) 5-5/8 (143)
FLOAT OPERATED AIR RELEASE VALVE
UP TO 175 P.S.I. 5-7/8 (149) 3-3/4 (95)
STANDARD FIRE PUMP ACCESSORIES
Section 916 Page 206Date September 2013Supersedes Section 916 Page 206Dated June 2002
AURORA FIRE PUMPSAUTOMATIC AIR RELEASE VALVE
1/2 NPT" OUTLET 5-1/8 (130)
6-5/16 (160)
1/2" NPT INLET
HYDR8AC(VAL-MATIC VM-22.7)
OR APPROVED EQUAL USEDWITH HORIZONTAL FIRE PUMPS
WORKING PRESSURE UP TO 300 PSI(FM APPROVED)
9-1/2 (241)
2" NPT OUTLET
12 (305)
2" NPT INTLET
HYDR8AD (VAL-MATIC #102)
USED WITH VERTICAL TURBINE FIRE PUMPS WORKING PRESSURE UP TO 300 PSI
NOTES: 1. All dimensions are in inches (mm) and may vary 1/4 (6).
AUTOMATIC AIR RELEASE VALVE
PART NO.1234567
1011121314172134
MATERIALCAST IRON ASTM A126, CLASS BCAST IRON ASTM A126, CLASS BSTAINLESS STEEL T316, ASTM A240STAINLESS STEEL T316, ASTM A276STAINLESS STEEL T316, ASTM A240COMPRESSED NON-ASBESTOS FIBERALLOY STEEL SAE, GRADE 5STAINLESS STEEL T316, ASTM A240VITONSTAINLESS STEEL T316, ASTM A479STAINLESS STEEL PH 15-7 MOSTEELSTAINLESS STEEL T316, ASTM F879STAINLESS STEEL T316, ASTM F593STAINLESS STEEL T316, ASTM A240
PART NAMEBODYCOVERLEVER FRAMESEATFLOATGASKETCOVER BOLTFLOAT ARMORIFICE BUTTONPIVOT PINPIN RETAINERPIPE PLUGFLOAT RETAINERLOCATORLOCK WASHER
NOTE: ALL SPECIFICATIONS ASLAST REVISED.
VM-15A-M
MATERIALS OF CONSTRUCTION 2/23/87
AIR RELEASE VALVESERIES NO. 15A
STANDARD MATERIALS OF CONSTRUCTION
Revised 1-29-03DATE
DRWG. NO.
VALVE AND MANUFACTURING CORP.
SERIES NO. 15AAIR RELEASE VALVE
VPROVIDINGSYSTEM
EFFICIENCYAND
PROTECTION
AIR VALVESBulletin 1500
NSF/ANSI 61Certified
2TABLE OF CONTENTSUNDERSTANDING AIR VALVES
Air and Its Impact on a Water and Wastewater System pp. 3-7Features and Benefits pp. 8-9
AIR VALVE APPLICATIONSLook to Val-Matic for Solutions p. 10Applications, Functions, Purpose and Features p. 11
TECHNICAL DATA
Air Release Valves pp. 12-13
Air/Vacuum Valves pp. 14-15
Combination Air Valves pp. 16-19
Surge-Suppression Air Valves pp. 20-21
Well Service Air Valves pp. 22-23
Vacuum Breaker Valves pp. 24-25
Vacuum Priming Valves p. 26
Air Valve Sizing Software p. 27V
O ne of the most misunderstood aspects of theWater & Wastewater industry is the presenceof air in a pipeline and its impact on opera-tions. Many operational problems, especially at the timeof initial start-up, including broken pumps, valves andpipe, as well as faulty instrumentation readings, areblamed on inadequate thrust blocking, improper pipelinebedding, etc. In reality, many of these problems are notcaused by improper installation of the line, but by failureto de-aerate the line. Properly de-aerating your pipelinewill safeguard it from air-related problems, however if nosteps are taken to accomplish this, you should be ready fortrouble.
SO
![BPS spectra from BPS graphs arXiv:1710.08449v2 [hep-th] 30 ... · Prepared for submission to JHEP BPS spectra from BPS graphs Maxime Gabella Institute for Advanced Study, Einstein](https://static.documents.pub/doc/80x56/5d648c8288c993f2418b587b/bps-spectra-from-bps-graphs-arxiv171008449v2-hep-th-30-prepared-for.jpg)
