Ope

rato

r’s M

anua

l

Operator’s Manual

THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF J.I. CASE OR IT’S SUCCESSORS. J.I. CASE AND IT’S SUCCESSORS

ARE NOT RESPONSIBLE FOR THE QUALITY OR ACCURACY OF THIS MANUAL.

TRADE MARKS AND TRADE NAMES CONTAINED AND USED HEREIN ARE THOSE OF OTHERS, AND ARE USED HERE IN A DESCRIPTIVE SENSE TO REFER TO THE PRODUCTS OF OTHERS.

1370 S/n 8736001 & Up

CA-O-1370LATE

1370 Tractor Operator's Manual

Starting with SN 8736001

9-4721 I Reprinted I

2

,c:,: '

Engine Lubrication System Oil Pressure ................................ : 45 to 60 PSI (310 to 414 kPa) with

Engine Warm and Operating at Rated Engine Speed.

Type System .................................... Pressure and Spray Circulation with Piston Oil Cooling.

Oil Pump ............................................................ .............. Gear Type

Oil Filter (2) .................................. Full Flow Spin on Type, Pleated with Bypass Valve in Filter Base.

Oil Capacity ........................... With Filters, 22 U.S. Qts. (20.8 liters) Without Filters, 18 U.S. Qts. (17.1 liters)

Oil Cooler ......................................................................... Engine Oil

Fuel System

Fuel Injection Pump .................................. Robert Bosch, Type PES (Multiple Plunger.).

Pump Timing ............................. .......... 30 Degrees Before Top Dead Center (Port Closing).

Fuel Injectors ................................................................. Pencil Type (Opening Pressure 3200 PSI). (22 063 kPa)

Fuel Transfer Pump ......................... Plunger Type, Integral Part of Injection Pump.

Governor .............................. Variable Speed, Fly-Weight Centrifugal Type; Integral Parts of Injection Pump.

1st Stage fuel filter ...................................... Full Flow Spin on Type

2nd Stage fuel filter ..................................... Full Flow Spin on Type

Fuel Tank Water Trap and Drain ............................ Located in Base of Fuel Tank.

Fuel Tank Capacity .............................. 80 U.S. Gallons (302.8 liters)

Fuel Level Gauge ................ Electric, Located on Instrument Panel.

Hand Primer Pump ........................................ Located on Top of the Fuel Transfer Pump.

Preliminary Fuel Filter ................................. Located at the Bottom of the Fuel Transfer Pump.

5

HYDRAULIC OIL FILTERS (Continued)

7. Install a new gasket on filter manifold and install the assem­bled unit into the torque tube with bolts and washers. Torque bolts 35 to 42 ft. Ibs. (48 to 57 Nm). Install drain plugs.

8. Remove fill cap located on top right hand side of the PTO hous­ing (See Page 24) andadd3 Gal­lons (11.4 liters) of clean Case TFD fluid. Install filler cap. Start tractor and run at low RPM for approximately 5 minutes to fill the filter cavi­ty and filters. Check for leaks and that the transmission fil­ter pressure gauge pointer on the instrument panel is in the green operating zone.

WING NUT_~ WASHER ___ ®

WING NUT"-.....

~@

Bleeding Procedure

With the engine running at 1000 to 1500 RPM, turn the steering wheel to hard right and left several times to purge the steering system. Check the brake system by depressing the brake pedals. If a spongy reaction is noted, the brakes must be bled. Open the R.H. brake bleed screw, located above the R.H. axle housing, wide enough for fluid to form a spout and flow until free of air bubbles. IMPORTANT: Slowly depress the brake pedal fully. Close the bleed screw with the pedal depressed com­pletely and slowly release pedal completely. Repeat the proced­ure several times to assure that all of the air is purged from the system. Repeat this procedure for the L.H. brake.

25

... ~ ~\

)

Figure 5

DIFFERENTIAL LOCK

Your tractor is equipped with a differential lock that will turn both wheels at the same speed. This prevents the usual loss of power when one wheel is slipping and the other wheel has traction.

ENGAGING THE DIFFERENTIAL LOCK:

When one wheel starts to slip or whenever desired, engage the differ­entiallock by depressing the differential lock pedal located on the plat­form beneath and rearward of the brake pedals.

IMPORTANT: The front wheels should be in the straight ahead posi­tion when engaging or disengaging the differential lock. Always disengage the differential before turning the tractor.

CAUTION: DO NOT OPERATE THE TRACTOR AT HIGH SPEEDS OR ATTEMPT TO TURN THE TRACTOR WITH THE DIFFERENTIAL LOCK ENGAGED.

Figure 48

DISENGAGING THE DIFFERENTIAL LOCK: When one or both brake pedals are applied, the differential lock

will disengage.

64

DUAL REAR WHEEL MOUNTING

When dual wheels are desired for certain working conditions, the inner wheel may be dished in and the outer wheel dished out or both may be dished in or out on the 120" (3 048mm) long axle. On the 96" (2 438.4mm) short axle, the inner wheel must be dished in and the outer wheel dished in or out.

The rear duals may be used with two cast iron wheels or one cast iron and one fabricated (Stamped Steel) wheel. The fabricated wheel must al­ways be on the outside. NOTE: Do not apply wheel weights when using fabricated wheel.

Additional maximum tread spacing on long axle may be obtained by using spacers with the fabricated outside wheels. Each spacer is 10" (254mm) in width. For dual tread spacings, See Page 15.

DUAL CAST IRON WHEELS

TAPERED BUSHING HUB

DUAL CAST IRON AND STAMPED STEEL WHEELS

\

Figure 75

WHEEL MOUNTING BOLTS

Figure 76

89

TAPERED

BUSHING HUB

TABLE OF CONTENTS

SAFETY PRECAUTIONS ............................................................ I-VI SERIAL NUMBERS .................................................. ; ...................... 3 DIESEL ENGINE SPECIFICATIONS ........................................... 4,5

GENERAL SPECIFICATIONS ..................................................... 6-15 Cooling System ............................................................................. 6 Electrical System ......................................................................... 6 Parking Brake .............................................................................. 7 Hydraulic Power Assist Brakes .................................................... 7 Power Shift Transmission ............................................................. 7 Differential Lock .... '" .................................................................... 7 Hydrostatic Power Steering .......................................................... 7 Draft-O-Matic System ................................................................... 7 Remote Hydraulic System ............................................................ 8 Variable Flow Remote Hydraulic System ..................................... 8 Power Take-Off ............................................................................. 8 Drawba,r ....................................................................................... 8

TRAVEL SPEEDS ........................................................................... 9 OVERALL MEASUREMENTS ....................................................... 10 WEIGHT ........................................................................................ 10 OPERATOR'S CAB ........................................................................ 10 TIRE AND WHEEL EQUIPMENT ... , ............................................ 11 FRONT WHEEL TREAD SPACING .............................................. 12 REAR WHEEL TREAD SPACING ............................................ 13,14 DUAL REAR TIRE PRESSURES .................................................. 14 DUAL REAR WHEEL TREAD SPACING ..................................... 15

FUEL SPECIFICATIONS ........................................................... 16,17 Fuel Conditioner .......................................................................... 17

LUBRICATION ........................................................................... 18-26 Engine Hour Meter ........................................................... ........... 18 Engine Lubrication ...................................................................... 19 Recommendations and Capacities ............................................... 20 Lubrication Chart .................................................................... 20,21 Engine Crankcase Oil Change ..................................................... 22 Engine oil filters ..................................................................... 22,23 Transmission Case Oil Change and Level Check ........................ 23 Hydraulic Oil Filters ............................................................... 24,25 Bleeding Procedure ..................................................................... 25 Packing Front Wheel Bearings ................................................... 26

SAFETY PRECAUTION Alternator Charging system Do's and Don'ts .............................. 27

131

TABLE OF CONTENTS (Continued) OPERATING INSTRUCTIONS ................................................... 28-90

Run-In-Procedure ........................................................................ 28 Pre-Starting Check List ............................................................... 29 Towing ........................................................................................ 29 Operating Controls and Instruments ........................................ 30-49 Cab Air Combinations ............................................................. 45,46 Amber Warning Lamps and SMV Symbol ............................... 50,51 Implement Warning Lamp .......................................................... 52 Operator's Seat ....................................................................... 53,54

Forward and Rearward Adjustment ......................................... 53 Seat Tension Adjustment ............. " ............................................ 53 Seat Belts ................................................................................. 54

Tilt and Telescoping Steering Column ......................................... 55 Starting Procedure .................................................................. 56,57 Stopping the Engine .................................................................... 57 Cold Weather Operation .......................................................... 58,59 Cold Weather Starting Procedure ............................................ 60,61

Operation of Quick Start Aid ................................................... 60 Cold Weather Starting Fluid ....................................................... 61 Coolant Heater ............................................................................ 61 Power Shift Transmission ........................................... ................ 62 Differential Lock ......................................................................... 64 Power Take-Off and Operation ................................................ 65,66 PTO Operating Precautions ......................................................... 67 Case Draft-O-Matic Hydraulic System and Controls ................ 68-70 Draft Arm Mechanical Flotation ................................................. 71 Anti-Sway Chain .......................................................................... 71 Draft-O-Matic Adjustments ...................................................... 72,73 Hitch Coupler .......................................................................... 74,75 Remote Hydraulic Control ........................................................... 76 Variable Flow Remote Hydraulic Control ................................... 77 Remote Hydraulic Cylinder Coupling .......................................... 78 Remote Cylinders .................................................................... 79-81 Drawbar .................................................................................. 82,83 Front Axle Adjustments .............................................................. 84 Front End Weights ...................................................................... 85 Rear Wheel Adjustments and Mounting .................................. 86-90 Rear Wheel \Veights .................................................................... 90 Rear Tire Liquid Weight ............................................................. 90

PREVENTIVE MAINTENANCE ............................................... 91-130 Cooling System ........................................................................ 92-95

Facts About Pressurized Cooling System ................................. 92 Anti-Freeze Solutions ................................................................ 93 Checking Thermostats .............................................................. 93 Cleaning the Cooling System .................................................... 94 Thermostat Replacement .......................................................... 95

132

TABLE OF CONTENTS (Continued)

PREVENTIVE MAINTENANCE (Continued)

Fan Belt Adjustment ................................................................... 96 Replacing Fan Belt ..................................................................... 96 Diesel Fuel System ................................................................. 97,98 Servicing Fuel Filters ............................................................ 99,100 Bleeding the Fuel System ................ ; ......................................... 101 Servicing the Air Induction and Filter System ..................... 102-107

Final Air Filter Servict:> Interval ............................................ 102 Self Cleaning Air Inductiun System ........................................ 103 Servicing the Air Induction System .................................... 104.105 Servicing the Final Air Filter ............................................ 106.107

Safety Start Switch Adjustment ................................................. 108 Parking Brake Adjustment ........................................................ 109 Electrical System ................................................................. 110-112

Headlights and Fixed Flood Lights ......................................... 110 Combination Rear Tail and Flood Light ................................. 110 Flashing Amber Warning Lights .............................................. 111 Implement Warning Lamp ...................................................... 111 Adjustable Flood Lights .......................................................... 112 Parkin~ arake Warning Light ................................................ 112 Instrument Panel Gauge Lights .............................................. 112

Front Headlight Adjustment ...................................................... 113 Storage Battery .....................................•.............................. 114.115 Operator Roll Over Protective Structure (ROPS) ................ 116-119 Operator's Cab ..................................................................... 120-130

Preventive Maintenance ............... ..................................... 120,121 Air Filter Removal ................................................................. 121 Air Filter Service .............................................................. 122.123 Seat Belt Inspection and Care ................................................ 123 Operator's Seat and Trim ................................................. 124.125 Dome Light ............................................................................. 126 Fuse Panel ............................................................................. 126 Checking Refrigerant Level ............................................... 127.128 Compressor Belt Adjustment .................................................. 129 Compressor Belt Replacement ................................................ 130

133