CASE IH - manuals.crary.commanuals.crary.com/manuals/airreel/12086_r062008.pdf · Manual P/N 12086...

Manual P/N 12086Rev. 062008Companion to P/N 12069SN Range: 709608-Current

PARTS MANUAL

CASE IH 10101020

HOW TO REACH US

Send us Your Warranty CardPlease take time to fill in the information requested on the card. When you send in the completed card, we register your Air Reel and start coverage under our limited warranty.Two serial number stickers are included with each Air Reel. The decals are located on the Air Reel manifold. Place one sticker on the warranty registration card and mail it back to Crary Industries. Place the second sticker in the owner’s manual for future reference.

ADDRESS HOURS TELEPHONE FAX NUMBER

E-MAIL INTERNET

Crary Industries 237 12th St. NW

P.O. Box 849 West Fargo, ND 58078-0849

Mon. - Fri. 8 a.m. to 5 p.m.

Central Standard Time

1-800-247-7335 Fax: 1-701-282-9522

For service: [email protected] Visit us on the web @

www.crary.com

PArtS ordErIng InformAtIon For service assistance or parts, contact your nearest authorized Crary dealer. Your nearest authorized Crary dealer will need to know the serial number of your Air Reel to provide the most efficient service. See information below for how to identify and record the serial number for your Air Reel.

ILLUStrAtIon And tEXt This parts catalog is arranged to assist in identifying Air Reel parts. All parts are illustrated in either assembled or ex-ploded views. Except for some common hardware, all parts are identified with an item number that corresponds to the Item column on the corresponding parts information table. The text pages list the reference number, part number, part description and the quantity required.

rEPLACEmEnt PArtS

Only genuine Crary replacement parts should be used to repair the Air Reel. Crary replacement parts are available from your Crary Dealer. To obtain prompt, efficient service, remember to give the dealer the correct part description and serial number of the Air Reel.

When ordering parts for your unit provide the following:

1. The SERIAL NUMBER of your Air Reel.

2. The PART NUMBER of the part.

3. The PART DESCRIPTION.

4. The QUANTITY needed.

SErIAL nUmbEr LoCAtIon

Give your authorized Crary dealer the serial number of your Air Reel when ordering parts, requesting service, or any other information. Record the serial number in the space provided below and on the warranty and registration card. The serial number is located on the manifold.

Serial number ________________________

WArnIngWe urge using only genuine replacement parts, which meet all the latest requirements. Replacement parts manufactured by others could present safety hazards, even though they may fit on this unit.

MANUFACTURED BY CRARY INDUSTRIES

MANUFACTURED IN U.S.A.XXXXXX

WEST FARGO, NORTH DAKOTA 58078 U.S.A.SERIAL NUMBER

Figure 2, Serial number decal

Figure 1, Serial number location

Page iiiCase IH Air Reel Parts Catalog

ContentsAIR MANIFOLD ............................................................................................................................................................2-9AUGER DRIVE SHAFT TORQUE LIMITER ..................................................................................................................58BAT TUBE/REEL TINE .............................................................................................................................................22-23DECALS ........................................................................................................................................................................59DRIVELINE/C FLANGE ASSEMBLY ........................................................................................................................54-57ECCENTRIC ARM ASSEMBLY ................................................................................................................................26-27ECCENTRIC ARM/HYDRAULIC MOTOR ................................................................................................................24-25ECCENTRIC MOUNT ASSEMBLY................................................................................................................................13ECCENTRIC MOUNT PLATE/ROLLER ...................................................................................................................14-15FAN HOSE ASSEMBLY ................................................................................................................................................32GEARBOX/FAN ........................................................................................................................................................34-37GEARBOX MOUNT/RH DRIVE ...............................................................................................................................40-53GEARBOX REPLACEMENT PARTS .......................................................................................................................38-39IDLER GEAR AND AIR TUBE .................................................................................................................................. 10-11REEL ARM MOUNT .................................................................................................................................................28-31REEL BAT ARM .............................................................................................................................................................12REEL BAT ASSEMBLY ............................................................................................................................................. 16-21SWITCH/MOUNT PLATE ASSEMBLY ..........................................................................................................................33

oPtIonS ......................................................................................................................................................................61AUXILIARY REEL TINE KIT ..........................................................................................................................................64GEARBOX/FAN EXTENSION KIT ...........................................................................................................................62-63NEUTRAL DRIVE SHAFT KIT .......................................................................................................................................65STATIC PRESSURE GAGE ..........................................................................................................................................66

PArtS IndEX ...............................................................................................................................................................67

SECtIon PAgE

Case IH Headers1010, 1020

Parts Catalog Air Reel

Page 1Case IH Air Reel Parts Catalog

AIr mAnIfoLd 15’ HEADERS 06/08

Page 2 Case IH Air Reel Parts Catalog

ASSEmbLY, AIr mAnIfoLd, 15 ft. (22392)ItEm PArt nUmbEr dESCrIPtIon QtY

1 11001 DECAL, SAFETY (CAUTION) 12 11002 DECAL, WARNING 13 11012 DECAL, CRARY AIR REEL 14 15031 WASHER, 3/8" FLAT ZP 15 15057 BOLT, 3/8" X 1" CARRIAGE NC GR5 ZP 126 15176 SCREW, 11/32" X 7/8" HWH AB THREAD ZP 37 15388 NUT, 3/8" NE NYLOCK ZP 138 15486 BOLT, 3/8" X 3-1/2" CARRIAGE NC GR5 ZP 19 17224 DECAL, CENTER MANIFOLD DIRECTION 110 17406 PILLOWBLOCK, STAMPED STEEL 311 17407 BEARING INSERT, 1" HEX 312 17444 COLLAR, 1" HEX, SET 213 22181 SHIELD, DRIVE SHAFT (79.38") 114 22192 SHIELD, DRIVE SHAFT (70.00") 115 22364 WELDMENT, IDLER MOUNT, CLAMP, RIGHT HAND 116 24268-12 MANIFOLD, F.A.R. (15 FT) 117 24910-12 WELDMENT, END CLAMP, RIGHT HAND (W/MOTOR MT.) 118 24917-12 WELDMENT, END CLAMP, LEFT HAND 119 25569-00 SHAFT, REEL DRIVE (168.13") 120 25760-00 ASSEMBLY, HUB/PINION GEAR (INCLUDES ITEMS A-F) 3

A 13768-00 HUB, PINION GEAR 1B 25658-12 RING, PINION RETAINER 2C 17703 GEAR, IDLER, 1.575" BORE 1D 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 1E 15356 NUT, 5/16" NE NYLOCK ZP 4F 15154 BOLT, 5/16" X 2-1/2" HHCS GR5 ZP 3

06/08 15’ HEADERS AIr mAnIfoLd


AIr mAnIfoLd 16.5’, 17.5’ & 20’ HEADERS 06/08


ASSEmbLY, AIr mAnIfoLd

ItEm PArt nUmbEr dESCrIPtIon22394

16.5 footQtY

2239517.5 foot

QtY

2239720 foot

QtY

1 11001 DECAL, SAFETY (CAUTION) 1 1 12 11002 DECAL, WARNING 1 1 13 11012 DECAL, CRARY AIR REEL 1 1 14 15031 WASHER, 3/8" FLAT ZP 2 2 25 15057 BOLT, 3/8" X 1" CARRIAGE NC GR5 ZP 14 14 146 15176 SCREW, 11/32" X 7/8" HWH AB THREAD ZP 4 4 47 15388 NUT, 3/8" NE NYLOCK ZP 16 16 168 15486 BOLT, 3/8" X 3-1/2" CARRIAGE NC GR5 ZP 2 2 29 17224 DECAL, CENTER MANIFOLD DIRECTION 1 1 110 17406 PILLOWBLOCK, STAMPED STEEL 4 4 411 17407 INSERT, BEARING, 1" HEX 4 4 412 17444 COLLAR, 1" HEX, SET 2 2 213 22185 SHIELD, DRIVE SHAFT (59.50") 1 1 1

1422184 SHIELD, DRIVE SHAFT (52.75") 122179 SHIELD, DRIVE SHAFT (62.25") 1 1

1522184 SHIELD, DRIVE SHAFT (52.75”) 1 122188 SHIELD, DRIVE SHAFT (82.50") 1

16 22364 WELDMENT, IDLER MOUNT CLAMP, RIGHT HAND 1 1 117 22365 WELDMENT, IDLER MOUNT CLAMP, LEFT HAND 1 1 1

1824269-12 MANIFOLD, F.A.R. (16 FOOT) 124272-12 MANIFOLD, F.A.R. (18 FOOT) 124273-12 MANIFOLD, F.A.R. (20 FOOT) 1

19 24910-12 WELDMENT, END CLAMP, RIGHT HAND (W/MOTOR MNT) 1 1 1

2024917-12 WELDMENT, LH END CLAMP 1 124975-12 WELDMENT, END CLAMP, LEFT HAND (W/MOTOR MNT) 1

2125567-00 SHAFT, REEL DRIVE (187.81”) 125566-00 SHAFT, REEL DRIVE (197.66”) 125564-00 SHAFT, REEL DRIVE (227.13") 1

22 25760-00 ASSEMBLY, HUB/PINION GEAR (INCLUDES ITEMS A-F) 4 4 4A 13768-00 HUB, PINION GEAR 1 1 1B 25658-12 RING, PINION RETAINER 2 2 2C 17703 GEAR, IDLER, 1.575" BORE 1 1 1D 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 1 1 1E 15356 NUT, 5/16" NE NYLOCK ZP 4 4 4F 15154 BOLT, 5/16" X 2-1/2" HHCS GR5 ZP 3 3 3

06/08 16.5’, 17.5’ & 20’ HEADERS AIr mAnIfoLd


AIr mAnIfoLd 22.5’ & 25’ HEADERS 06/08



ItEm PArt nUmbEr dESCrIPtIon22399

22.5 footQtY

2240225 foot

QtY

1 11001 DECAL, SAFETY (CAUTION) 1 12 11002 DECAL, WARNING 1 13 11012 DECAL, CRARY AIR REEL 1 14 14022-00 COUPLER, 1" HEX SHAFT 1 15 15031 WASHER, 3/8" FLAT ZP 2 26 15057 BOLT, 3/8" X 1" CARRIAGE NC GR5 ZP 14 147 15176 SCREW, 11/32" X 7/8" HWH AB THREAD 4 48 15356 NUT, 5/16" NE NYLOCK ZP 2 29 15388 NUT, 3/8" NE NYLOCK ZP 16 1610 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 2 211 15486 BOLT, 3/8" X 3-1/2" CARRIAGE NC GR5 ZP 2 212 17224 DECAL, CTR MANIFOLD DIRECTION 1 113 17406 PILLOWBLOCK, STAMPED STEEL 4 414 17407 INSERT, BEARING, 1" HEX 4 415 17444 COLLAR, 1" HEX, SET 2 2

1622185 SHIELD, DRIVE SHAFT (59.50") 122374 SHIELD, DRIVE SHAFT (86.25") 1

17 22189 SHIELD, DRIVE SHAFT (92.00") 1 1

1822192 SHIELD, DRIVE SHAFT (70.00") 125580-00 SHIELD, DRIVE SHAFT (43.75") 1

1925576-00 SHIELD, DRIVE SHAFT (8.75”) 125580-00 SHIELD, DRIVE SHAFT (43.75") 1

20 22364 WELDMENT, IDLER MOUNT CLAMP, RIGHT HAND 1 121 22365 WELDMENT, IDLER MOUNT CLAMP, LEFT HAND 1 1

2224274-12 MANIFOLD, F.A.R. (22 FOOT) 124278-12 MANIFOLD, F.A.R. (25 FOOT) 1

23 24910-12 WELDMENT, END CLAMP, RIGHT HAND (W/MOTOR MOUNT) 1 124 24917-12 WELDMENT, END CLAMP, LEFT HAND 1 125 25563-00 SHAFT, REEL DRIVE (239.75") 1 1

2625574-00 SHAFT, REEL DRIVE (16.69") 125571-00 SHAFT, REEL DRIVE (52.50") 1

27 25760-00 ASSEMBLY, HUB/PINION GEAR (INCLUDES ITEMS A-F) 4 4A 13768-00 HUB, PINION GEAR 1 1B 25658-12 RING, PINION RETAINER 2 2C 17703 GEAR, IDLER, 1.575" BORE 1 1D 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 1 1E 15356 NUT, 5/16" NE NYLOCK ZP 4 4F 15154 BOLT, 5/16" X 2-1/2" HHCS GR5 ZP 3 3

06/08 22.5’ & 25’ HEADERS AIr mAnIfoLd


AIr mAnIfoLd 30’ HEADERS 06/08



ItEm PArt nUmbEr dESCrIPtIon27134-0030 foot

QtY1 11001 DECAL, SAFETY (CAUTION) 12 11002 DECAL, WARNING 13 11012 DECAL, CRARY AIR REEL 14 15031 WASHER, 3/8" FLAT ZP 35 15057 BOLT, 3/8" X 1" CARRIAGE NC GR5 ZP 166 15176 SCREW, 11/32" X 7/8" HWH AB THREAD ZP 57 15356 NUT, 5/16" NE NYLOCK ZP 28 15388 NUT, 3/8" NE NYLOCK ZP 199 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 2

10 15486 BOLT, 3/8" X 3-1/2" CARRIAGE FULL THREAD GR5 311 17224 DECAL, CTR MANIFOLD DIRECTION 112 17406 PILLOWBLOCK, STAMPED STEEL 513 17407 INSERT, BEARING, 1" HEX 514 17444 COLLAR, 1" HEX, SET 215 27139-00 SHIELD, DRIVE SHAFT (18.25") 116 22181 SHIELD, DRIVE SHAFT (79.38") 317 22364 WELDMENT, IDLER MOUNT CLAMP, RIGHT HAND 218 22365 WELDMENT, IDLER MOUNT CLAMP, LEFT HAND 119 14022-00 COUPLER, 1" HEX SHAFT 120 27130-12 MANIFOLD, F.A.R. (30 FOOT-L) 121 24910-12 WELDMENT, END CLAMP, RIGHT HAND (W/MOTOR MNT) 122 24975-12 WELDMENT, END CLAMP, LEFT HAND (W/MOTOR MNT) 123 25563-00 SHAFT, REEL DRIVE (239.75") 124 27138-00 SHAFT, REEL DRIVE (112.06") 125 22185 SHIELD, DRIVE SHAFT (59.50") 126 25760-00 ASSEMBLY, HUB/PINION GEAR (INCLUDES ITEMS A-F) 5

A 13768-00 HUB, PINION GEAR 1B 25658-12 RING, PINION RETAINER 2C 17703 GEAR, IDLER, 1.575" BORE 1D 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 1E 15356 NUT, 5/16" NE NYLOCK ZP 4F 15154 BOLT, 5/16" X 2-1/2" HHCS GR5 ZP 3

06/08 30’ HEADERS AIr mAnIfoLd


IdLEr gEAr And AIr tUbE ALL MODELS 06/08


06/08 ALL MODELS IdLEr gEAr And AIr tUbE

ASS

Emb

LY, I

dLE

r g

EAr

An

d A

Ir t

Ub

E

ItEm

PAr

t n

Um

bEr

dES

Cr

IPtI

on

2260

015

ft.

QtY

2260

216

.5 f

t.Q

tY

2260

317

.5 f

t.Q

tY

2260

520

ft.

QtY

2260

722

.5 f

t.Q

tY

2260

925

ft.

QtY

2241

930

ft.

QtY

2261

230

ft.

QtY

115

031

WA

SH

ER

, 3/8

" FLA

T ZP

1824

2424

2424

3030

215

008

BO

LT, 3

/8" X

2" H

HC

S G

R5

ZP6

88

88

810

103

1504

7N

UT,

3/8

" CE

NTE

RLO

CK

ZP

68

88

88

1016

422

164

AS

SE

MB

LY, I

DLE

R G

EA

R (I

NC

LUD

ES

ITE

MS

5-1

0)6

88

88

810

105

1770

3G

EA

R, I

DLE

R, 1

.575

" BO

RE

11

11

11

11

617

669

BE

AR

ING

, RA

DIA

L 17

MM

11

11

11

11

721

978

RIN

G, P

INIO

N R

ETA

INE

R2

22

22

22

28

1767

0A

DA

PTO

R, S

HO

ULD

ER

BO

RE

11

11

11

11

915

436

BO

LT, 5

/16"

X 1

-142

" HH

CS

NC

GR

5 ZP

33

33

33

33

1015

356

NU

T, 5

/16"

NE

NY

LOC

K Z

P3

33

33

33

3

1122

346

AS

SE

MB

LY, R

EE

L B

AT A

RM

, 6 B

AT

(SE

E P

AG

E 1

2)3

44

44

45

5

1217

313

SE

AL,

FO

AM

, AIR

TU

BE

1719

2023

2629

3536

1322

153

WE

LDM

EN

T, A

IR T

UB

E15

1718

2124

2733

3414

2240

5A

SS

EM

BLY

, DO

UB

LE A

IR T

UB

E W

ELD

ME

NT

22

22

22

22

1515

176

SC

RE

W, 1

1/32

" X 7

/8" H

WH

AB

TH

RE

AD

ZP

5157

6069

7887

105

108


rEEL bAt Arm ALL MODELS 06/08

rEEL bAt Arm ASSEmbLY (22346)ItEm PArt nUmbEr dESCrIPtIon QtY

1 21509 BEARING W/CAP (INCLUDES ITEMS 2-4) 6

2 12528 BEARING CAP, PLASTIC 6

3 17404 BEARING BASE, PLASTIC 6

4 15030 WASHER, 1/4” FLAT ZP 12

5 15140 BOLT, 5/16” X 2” GR5 HCS ZP 6

6 15178 NUT, 5/16” CENTERLOCK NC ZP 12

7 15282 BOLT, 5/16 X 1-1/2 GR5 HEX CPS ZP 6

8 15356 NUT, 5/16” NE NYLOCK ZP 44

9 15396 BOLT, 5/16 X 7/8 NC HHCS GR5 ZP 44

10 17634 SECTION, INTERNAL GEAR 8

11 21550 REEL ECCENTRIC ARM 6


06/08 ALL MODELS ECCEntrIC moUnt ASSEmbLY

ASSEmbLY, bAt & ECCEntrIC moUnt

ItEm PArt nUmbEr dESCrIPtIon QtY

124919 ASSEMBLY, ECCENTRIC MOUNT PLATE/ROLLER, RIGHT HAND (SEE PAGE 15) 124920 ASSEMBLY, ECCENTRIC MOUNT PLATE/ROLLER, LEFT HAND (NOT SHOWN) (SEE PAGE 14) 1

2 15057 BOLT, 3/8" X 1" CARRIAGE NC GR5 ZP 63 15260 WASHER, 3/8" SAE FLAT ZP 124 15047 NUT, 3/8" CENTERLOCK ZP 6


ECCEntrIC moUnt PLAtE/roLLEr ALL MODELS 06/08

ASSEmbLY, ECCEntrIC moUnt PLAtE/roLLEr (LEft HAnd) (24920)ItEm PArt nUmbEr dESCrIPtIon QtY

1 24905-12 PLATE, ECCENTRIC ROLLER MOUNT 12 15031 WASHER, 3/8" FLAT ZP 33 15047 NUT, 3/8" CENTERLOCK ZP 34 15250 WASHER, 5/16" FLAT ZP 95 21588 BUSHING, ROLLER 36 17629 BEARING, RADIAL 67 21797 ROLLER, PLASTIC, 3" SM, VIRGIN UHMW 38 15008 BOLT, 3/8" X 2" HHCS GR5 ZP 3


06/08 ALL MODELS ECCEntrIC moUnt PLAtE/roLLEr

ASSEmbLY, ECCEntrIC moUnt PLAtE/roLLEr (rIgHt HAnd) (24919)ItEm PArt nUmbEr dESCrIPtIon QtY

1 24905-12 PLATE, ECCENTRIC ROLLER MOUNT 12 15031 WASHER, 3/8" FLAT ZP 33 15047 NUT, 3/8" CENTERLOCK ZP 34 15250 WASHER, 5/16" FLAT ZP 95 21588 BUSHING, ROLLER 36 17629 BEARING, RADIAL 67 21797 ROLLER, PLASTIC, 3/8" SM, VIRGIN UHMW 38 15008 BOLT, 3/8" X 2" HHCS GR5 ZP 3


rEEL bAt ASSEmbLY 15’ HEADERS 06/08


ASSEmbLY, rEEL bAt (15') (24936)ItEm PArt nUmbEr dESCrIPtIon QtY

1 15178 NUT, 5/16" CENTERLOCK NC ZP 82 15282 BOLT, 5/16" X 1-1/2" HHCS GR5 ZP 83 24888 SHAFT, BAT SPLICE 14 24927 ASSEMBLY, BAT TUBE/REEL TINE (74") 15 24931 ASSEMBLY, BAT TUBE/REEL TINE (86") 16 27983-00 ASSEMBLY, LH END SHAFT PIVOT (INCLUDES ITEMS BELOW) 1

12529 TINE, PLASTIC REEL 115597 SCREW, 12-14 X 2” FLAT HD, THD.FORM 127951-12 WELDMENT, LH END SHAFT PIVOT 1

7 27984-00 ASSEMBLY, RH END SHAFT PIVOT (INCLUDES ITEMS BELOW) 112529 TINE, PLASTIC REEL 115597 SCREW, 12-14 X 2” FLAT HD, THD.FORM 127952-12 WELDMENT, RH END SHAFT PIVOT 1

06/08 15’ HEADERS rEEL bAt ASSEmbLY


rEEL bAt ASSEmbLY 16.5’, 17.5’, 20’, 22.5’ & 25’ HEADERS 06/08


ASSEmbLY, rEEL bAt (16 ft. tHrU 25 ft)

ItEm PArt nUmbEr dESCrIPtIon

2493816.5 ft.

QtY

2493917.5 ft.

QtY

2494120 ft.QtY

2494322.5 ft.

QtY

2494625 ft.QtY

124922 ASSEMBLY, BAT TUBE/REEL TINE (56") 124925 ASSEMBLY, BAT TUBE/REEL TINE (66") 1 124934 ASSEMBLY, BAT TUBE/REEL TINE (96") 1 1

224924 ASSEMBLY, BAT TUBE/REEL TINE (65") 1 1 1 124932 ASSEMBLY, BAT TUBE/REEL TINE (92") 1

324922 ASSEMBLY, BAT TUBE/REEL TINE (56") 1 124931 ASSEMBLY, BAT TUBE/REEL TINE (86") 1 124933 ASSEMBLY, BAT TUBE/REEL TINE (95") 1

4 24888 SHAFT, BAT SPLICE 2 2 2 2 2

5 27983-00 ASSEMBLY, LH END SHAFT PIVOT (INCLUDES ITEMS BELOW) 2 2 2 2 2

12529 TINE, PLASTIC REEL 1 1 1 1 115597 SCREW, 12-14 X 2” FLAT HD, THD.FORM 1 1 1 1 127951-12 WELDMENT, LH END SHAFT PIVOT 1 1 1 1 1

6 27984-00 ASSEMBLY, RH END SHAFT PIVOT (INCLUDES ITEMS BELOW) 1 1 1 1 1

12529 TINE, PLASTIC REEL 1 1 1 1 115597 SCREW, 12-14 X 2” FLAT HD, THD.FORM 1 1 1 1 127952-12 WELDMENT, RH END SHAFT PIVOT 1 1 1 1 1

7 15282 BOLT, 5/16" X 1-1/2" HHCS GR5 ZP 1 1 1 1 18 15178 NUT, 5/16" CENTERLOCK NC ZP 12 12 12 12 12

06/08 16.5’, 17.5’, 20’, 22.5’ & 25’ HEADERS rEEL bAt ASSEmbLY


rEEL bAt ASSEmbLY 30’ & 35’ HEADERS 06/08


ASSEmbLY, rEEL bAt (30’) (27144-00)


1 24930 ASSEMBLY, BAT TUBE/REEL TINE (85") 12 24931 ASSEMBLY, BAT TUBE/REEL TINE (86") 13 24931 ASSEMBLY, BAT TUBE/REEL TINE (86") 14 24930 ASSEMBLY, BAT TUBE/REEL TINE (85") 15 24888 SHAFT, BAT SPLICE 36 27983-00 ASSEMBLY, LH END SHAFT PIVOT (INCLUDES ITEMS BELOW) 1

12529 TINE, PLASTIC REEL 115597 SCREW, 12-14 X 2” FLAT HD, THD.FORM 127951-12 WELDMENT, LH END SHAFT PIVOT 1

7 27984-00 ASSEMBLY, RH END SHAFT PIVOT (INCLUDES ITEMS BELOW) 112529 TINE, PLASTIC REEL 115597 SCREW, 12-14 X 2” FLAT HD, THD.FORM 127952-12 WELDMENT, RH END SHAFT PIVOT 1

8 15282 BOLT, 5/16" X 1-1/2" HHCS GR5 ZP 169 15178 NUT, 5/16" CENTERLOCK NC ZP 16

06/08 30’ & 35’ HEADERS rEEL bAt ASSEmbLY


bAt tUbE/rEEL tInE ALL MODELS 06/08


06/08 ALL MODELS bAt tUbE/rEEL tInE

ASS

Emb

LY, b

At t

Ub

E/r

EEL

tIn

E

ItEm

PAr

t n

Um

bEr

dES

Cr

IPtI

on

2492

256

"Q

tY

2492

360

"Q

tY

2492

465

"Q

tY

2492

566

"Q

tY

2492

667

"Q

tY

2492

774

"Q

tY

2492

875

"Q

tY

2492

977

"Q

tY

2493

085

"Q

tY

2493

186

"Q

tY

2493

292

"Q

tY

2493

395

"Q

tY

2493

496

"Q

tY

2717

2-00

101"

QtY

112

529

TIN

E, P

LAS

TIC

RE

EL

1010

1112

1213

1314

1515

1617

1718

215

597

SC

RE

W, 1

2-14

X 2

" FLA

T H

EA

D T

HR

EA

D F

OR

M10

1011

1212

1313

1415

1516

1717

18

3

2487

5-12

TUB

E, R

EE

L B

AT (5

6")

124

876-

12TU

BE

, RE

EL

BAT

(60"

)1

2487

7-12

TUB

E, R

EE

L B

AT (6

5")

124

878-

12TU

BE

, RE

EL

BAT

(66"

)1

2487

9-12

TUB

E, R

EE

L B

AT (6

7")

124

880-

12TU

BE

, RE

EL

BAT

(74"

)1

2488

1-12

TUB

E, R

EE

L B

AT (7

5")

124

882-

12TU

BE

, RE

EL

BAT

(77"

)1

2488

3-12

TUB

E, R

EE

L B

AT (8

5")

124

884-

12TU

BE

, RE

EL

BAT

(86"

)1

2488

5-12

TUB

E, R

EE

L B

AT (9

2")

124

886-

12TU

BE

, RE

EL

BAT

(95"

)1

2488

7-12

TUB

E, R

EE

L B

AT (9

6")

127

129-

12TU

BE

, RE

EL

BAT

(101

")1


ECCEntrIC Arm/HYd. motor ALL MODELS 06/08


06/08 ALL MODELS ECCEntrIC Arm/HYd. motor

ASSEmbLY, ECCEntrIC Arm & HYdrAULIC motorItEm PArt nUmbEr dESCrIPtIon QtY

1 12491 MOTOR, HYDRAULIC GEAR SAE 2 BOLT 8.0/8.9 CID 112050 KIT, MOTOR SEAL (ROSS/PARKER) (NOT SHOWN) 116516 KIT, SEAL (CHAR-LYNN) (NOT SHOWN) 1

2 14022-00 COUPLER, 1" HEX SHAFT 13 15014 BOLT, 1/2" X 1-1/2" HHCS GR5 ZP 24 15034 WASHER, 1/2" FLAT ZP 265 15049 NUT, 1/2" CENTERLOCK GRB ZP 146 15356 NUT, 5/16" NE NYLOCK ZP 27 15436 BOLT, 5/16" X 1-1/4" HHCS NC GR5 ZP 28 15562 BOLT, 1/2" X 2-1/2" HEX SOCKET B-HD CPS 129 16067 ADAPTER, -10MORING/-8MJIC 45 DEGREE 210 21520 BUSHING, PIVOT STRAP 1211 22347 ASSEMBLY, ECCENTRIC ARM -6 BAT REEL (SEE PG 26-27) 212 22489 ASSEMBLY, BRACE CLAMP 2

SEAL KIT FOR CHARLYNN MOTORS

SEAL KIt for CHArLYnn motorS (16516)ItEm PArt nUmbEr dESCrIPtIon QtY

1 16516 SEAL KIT FOR CHARLYNN MOTORS 1DUST SEAL 1BACK UP RING 1PRESSURE SEAL (002, 003, 008, 009 MOTORS) 1SEAL, FLANGE 1SEAL, HOUSING PLUG (008 MOTORS) 1SEAL, HOUSING PLUG (009 MOTORS) 1SEAL 3WASHER 7LOCTITE CAPSULE 1SEAL (O-RING PORT HOUSING) 2O-RING (DRAIN PORT) 1O-RING (HOUSING PLUG- END PORTED MODEL) 2

SEAL KIT FOR ROSS/PARKER MOTORS

SEAL KIt for HYdrAULIC motor (12050)ItEm PArt nUmbEr dESCrIPtIon QtY

1 12050 SEAL KIT, MOTOR 8.0 CID AIR REEL MOTOR (ROSS) 1SEAL RINGS (PART NO. 0832821) 5COMMUTATOR SEAL (PART NO. 032821) 1INNER SEAL (PART NO. 032377) 1BACK UP WASHER (PART NO. 028516) 1DIRT AND WATER SEAL (PART NO. 478036) 1GREASE PACK (PART NO. 406018) 1SERVICE MANUAL (PART NO. 050015) 1


ECCEntrIC Arm ASSEmbLY ALL MODELS 06/08


ASSEmbLY, ECCEntrIC Arm (22347)ItEm PArt nUmbEr dESCrIPtIon QtY

1 21976 RING, ECCENTRIC FAR 12 21550-12 ARM, REEL/ECCENTRIC 63 15300 BOLT, 5/16" X 5/8" HHCS GR5 ZP 244 15356 NUT, 5/16" NE NYLOCK ZP 485 15403 BOLT, 5/16" X 1-3/4" HHCS GR5 ZP 66 15754-00 BOLT, 5/16" X 2-1/4" HCPS GR5 67 24318-12 SHIELD, END-6 BAT 18 15250 WASHER, 5/16" FLAT ZP 129 15219 BOLT, 5/16" X 1" HHCS NC GR5 ZP 1210 21509 KIT, BEARING W/CAP (INCLUDES ITEMS A-C) 6

A 17404 BASE, BEARING, PLASTIC 1B 12528 CAP, BEARING, PLASTIC 1C 15030 WASHER, 1/4" FLAT ZP 2

06/08 ALL MODELS ECCEntrIC Arm ASSEmbLY


rEEL Arm moUnt PRE 1995 HEADERS 06/08

(Left Hand)

(rigHt Hand)


06/08 PRE 1995 HEADERS rEEL Arm moUnt

rEEL Arm moUnt KIt, CIH 1010/20 PrE 1995 (22254)ItEm PArt nUmbEr dESCrIPtIon QtY

1 15043 NUT, 1/2" HEX NC ZP 22 15047 NUT, 3/8" CENTERLOCK ZP 83 15049 NUT, 1/2" CENTERLOCK GRB ZP 24 15057 BOLT, 3/8" X 1" CARRIAGE NC GR5 ZP 85 15086 BOLT, 1/2" X 3" HHCS GR5 ZP 26 15092 BOLT, 1/2" X 2-1/2" HHCS GR5 ZP 27 17843 ACTUATOR, ELECTRIC 18 22260 PAD, REEL SUPPORT, LEFT HAND (CIH, DAC, NH) 19 22290 PAD, REEL SUPPORT, RIGHT HAND (CIH) 110 22479 ASSEMBLY, PIVOT CLAMP 111 22214 WELDMENT, REEL SUPPORT, RIGHT HAND (CIH 1010) 112 22220 WELDMENT, REEL SUPPORT, LEFT HAND (CIH 1010) 113 23501 CLAMP, HALF 214 22809 GUIDE, SADDLE 2


rEEL Arm moUnt 1995 & LATER HEADERS 06/08

(Left Hand)

(rigHt Hand)


06/08 1995 & LATER HEADERS rEEL Arm moUnt

rEEL Arm moUnt KIt, CIH 1010/20 1995 & LAtEr (24100)ItEm PArt nUmbEr dESCrIPtIon QtY

1 15043 NUT, 1/2” HEX NC ZP 42 15047 NUT, 3/8” CENTERLOCK ZP 83 15049 NUT, 1/2” CENTERLOCK GRB ZP 64 15053 NUT, 1/4”-20 SERRATED FLANGE NC ZP 45 15057 BOLT, 3/8” X 1” CARRIAGE NC GR5 ZP 86 15086 BOLT, 1/2” X 3” HHCS GR5 ZP 67 15092 BOLT, 1/2” X 2-1/2” HHCS GR5 ZP 28 15174 BOLT, 1/2” X 4” HHCS GR5 ZP 19 15375 PIN, 1/8” X 1.00” COTTER ZP 210 0103-0714-00 BOLT, 1/4” X 2-3/4” HEX GR5 ZP 411 16544 PIN, 3/8” X 2” LONG, CLEVIS 212 17843 ACTUATOR, ELECTRIC 113 22260 PAD, REEL SUPPORT, LEFT HAND (CIH, DAC, NH) 114 22290 PAD, REEL SUPPORT, RIGHT HAND (CIH) 115 22479 ASSEMBLY, PIVOT CLAMP 116 22214 WELDMENT, REEL SUPPORT, RIGHT HAND (CIH 1010) 117 22220 WELDMENT, REEL SUPPORT, LEFT HAND (CIH 1010) 118 23501 CLAMP, HALF 219 24095-11 WELDMENT, ADJUSTMENT TUBE 220 24098-11 WELDMENT, CYLINDER TUBE 121 24099-11 YOKE, REEL SUPPORT 222 70036 SPACER, .75” X .62” 223 22809 GUIDE, SADDLE 2

12506 HARNESS, ACTUATOR SWITCH ADAPTER (NOT SHOWN) 1


fAn HoSE ASSEmbLY ALL MODELS 06/08

ASSEmbLY, fAn HoSEItEm PArt nUmbEr dESCrIPtIon QtY

1 16092 CLAMP, 8-11/16", T-BOLT 42 17437 ELBOW, 8", MANIFOLD 13 21512 BAND, ELBOW SUPPORT 24 16091 CLAMP, 8-3/8", T-BOLT 55 17410 HOSE, 8" ID X 6' LONG, FLEX 16 12146 ELBOW, 5" X 45 DEGREE, RUBBER 17 21924 CAP, TUBE, 8" NOTCHED 18 24651-12 WELDMENT, HOSE CONNECTOR 19 17777 HOSE, 8" ID X 8' LONG, FLEX 110 15382 BOLT, 3/8” X 1” SERR FLNG GR5 NC ZP 211 15051 NUT, 3/8” SERRATED FLANGE NC ZP 2


06/08 ALL MODELS SWItCH/moUnt PLAtE

SWItCH/moUnt PLAtE ASSEmbLY (24333)ItEm PArt nUmbEr dESCrIPtIon QtY

1 12167 DECAL, ACTUATOR SWITCH 1

2 17849 ELECTRIC SWTICH ASSEMBLY - SPLIT 6 AMP 1

3 17850 ELECTRIC SWITCH ASSEMBLY - SPLIT 15 AMP 1

4 24332-12 PLATE, SWITCH MOUNT 1


gEArboX/fAn ALL MODELSS/N 0-709885 06/08


06/08 ALL MODELSS/N 0-709885 gEArboX/fAn

gEArboX/fAn (22760)ItEm PArt nUmbEr dESCrIPtIon QtY

1 22327 GEARBOX, 9.37:1 (SEE PAGES 38-39) 12 21445 HUB/MOTOR MOUNT PLATE (8 IN. -B PILOT) 13 15014 BOLT, 1/2 X 1-1/2 HEX HD 44 15049 NUT, 1/2 CENTERLOCK GRB ZP 45 21193 8” FAN RH SIDE W/ BUTTERFLY 16 15076 BOLT, 3/8 X 1 THREAD CUT 87 15099 WASHER, 7/8 SAE FLAT 28 14056-00 FAN ROTOR, 16.5” X 3” CW 7/8 STL. 19 15098 WASHER, 3/4 SAE FLAT 110 15055 NUT, SPINDLE CASTLE 111 15068 PIN, 5/32 X 1-1/4 COTTER 212 21194 8” FAN LH SIDE W/ BUTTERFLY 113 15364 BOLT, 3/8 NC X 1-1/4 HEX HD 1214 15051 NUT, 3/8 SERR FLANGE 1215 22655 BASE 116 23152 WELDMENT, BASE STRAP 117 16449 BEARING, 5/8” 2-BOLT FLNG. 218 15238 BOLT, 1/4 X 3/4” CRG 419 23161 WELDMENT, SCREEN/BLADE 120 15129 WASHER, 5/8 SAE FLAT 221 23155 WELDMENT, PIVOT 122 23158 WELDMENT, SCREEN CLEANER 123 23163 WELDMENT, SCREEN CAP 124 15053 NUT, 1/4 SERR FLANGE 825 15001 BOLT, 1/4 X 3/4 HEX HD 426 15095 SCREW, NO. 14 X 1/2” TAPPING HWH ZP 627 7022 KEYSTOCK, 3/16” 128 25644-12 WELDMENT, ACTUATOR MOUNT 129 25641-12 WELDMENT, VALVE ACTUATOR 130 25638-35 WELDMENT, INDICATOR 131 21444 PLATE, LARGE BUTTERFLY 132 15552 BOLT, #10-24 X 1 IN. GR8 HCPS PLAIN 433 15397 NUT, #10 X 24 NYLOCK 434 13460-00 ACTUATOR, 2” STROKE WARNER 135 15342 BOLT, 1/4 X 1-1/2” HCS G5 ZP 236 15087 NUT, 1/4” CENTERLOCK 237 25592-12 WRAP, ROTARY SCREEN 1


gEArboX/fAn ALL MODELSS/N 709886-CURRENT 06/08


06/08 ALL MODELSS/N 709886-CURRENT gEArboX/fAn

gEArboX/fAn (22760)ItEm PArt nUmbEr dESCrIPtIon QtY

1 22327 GEARBOX, 9.37:1 (SEE PAGES 38-39) 12 21445 HUB/MOTOR MOUNT PLATE (8 IN. -B PILOT) 13 15014 BOLT, 1/2” X 1-1/2” HEX HD 44 15049 NUT, 1/2” CENTERLOCK GRB ZP 45 21193 8” FAN RH SIDE W/ BUTTERFLY 16 15076 BOLT, 3/8” X 1 THREAD CUT 87 15099 WASHER, 7/8 SAE FLAT 28 14056-00 FAN ROTOR, 16.5” X 3” CW, 7/8 STL 19 15098 WASHER, 3/4 SAE FLAT 310 21194 8” FAN LH SIDE W/ BUTTERFLY 111 15364 BOLT, 3/8 NC X 1-1/4 HEX HD 1212 15051 NUT, 3/8 SERR FLANGE 1213 22655 BASE 114 7022 KEYSTOCK, 3/16” 115 25644-12 WELDMENT, ACTUATOR MOUNT 116 25641-12 WELDMENT, VALVE ACTUATOR 117 25638-35 WELDMENT, INDICATOR 118 21444 PLATE, LARGE BUTTERFLY 119 15552 BOLT, #10-24 X 1 IN. GR8 HCPS PLAIN 320 15397 NUT, #10X24 NYLOCK 321 13460-00 ACTUATOR, 2” STROKE WARNER 122 15342 BOLT, 1/4 X 1-1/2 HCS G5 ZP 223 15087 NUT, 1/4” CENTERLOCK 224 29917-12 WELDMENT, 8” ROTARY SCREEN BASE STRAP 125 15055 NUT, HST SPINDLE CASTLE 126 15068 PIN, 5/32 X 1-1/4 COTTER 127 18998-00 BEARING, 3/4” ROUND INSERT 228 36008-00 FLANGETTE, 47MM 2 HOLE 429 29919-12 WELDMENT, PIVOT 130 53035-12 WELDMENT, ROTARY SCREEN (8”-RH) 131 15367 BOLT, 5/16 X 3/4 CRG 432 15351 NUT, 5/16 SERR FLANGE 433 15053 NUT, 1/4 SERR FLANGE 434 15001 BOLT, 1/4 X 3/4 HEX HD 435 29921-12 WELDMENT, 8” FAN SCREEN CLEANER 136 53048-12 WELDMENT, 8” FAN ROTARY SCREEN CAP 1


gEArboX rEPLACEmEnt PArtS ALL MODELS 06/08


06/08 ALL MODELS gEArboX rEPLACEmEnt PArtS

gEArboX (rEPLACEmEnt PArtS)

ItEm PArt nUmbEr dESCrIPtIon 9.375:1(22327)

1 16807 66 GEAR, SP BEV LH 19T 12 NPN 66 GEAR, SP BEV RH 29T 13 36222-00 11 NUT, LOCK 3/4" NF 14 NPN 66 SHIM, .002 RED 25 NPN 66 SHIM, .005 BLUE 26 NPN SPEC. HOUSING, SUB-ASSEMBLY 17 NPN SPEC. HOUSING, PINION 18 NPN SPEC. CAP, OPEN 29 NPN SPEC. CAP, CLOSED 210 16821 SPEC. SLEEVE, INPUT 111 16820 SPEC. SHAFT, OUTPUT PINION 112 NPN SPEC. GEAR INTG HEL LH 14T 113 NPN SPEC. GEAR, HEL RH 81T 114 NPN SPEC. SPACER 115 NPN SPEC. SHIM, .002 RED 416 NPN SPEC. SHIM, .005 BLUE 417 NPN SPEC. SHIM, .002 RED 418 NPN SPEC. SHIM, .005 BLUE 419 16815 BEARING, BALL 206NPP OR EQUIVALENT 220 0201-0077-00 BEARING, 2.328 X .465 CUP 221 16817 BEARING, CUP 27620 OR EQUIVALENT 222 0201-0078-00 BEARING, 1.250 X .660 CONE 223 16819 BEARING, CONE 27687 OR EQUIVALENT 224 NPN SCREW, 3/8" X 1" NC HHCS GR5 425 NPN SCREW, 5/16" X 1" NC HHCS GR5 2026 NPN SCREW, 3/8" X 1-1/4" NC HHCS GR5 827 NPN WASHER, 3/4" X 1-1/2" X 1/8" 128 NPN WASHER, 1-17/64" X 1-3/4" X 1/8" 229 NPN NUT, 3/8" NC HEX 830 NPN KEY, 1/4" SQUARE X 15/16" P&W 131 NPN KEY, 3/4" SQUARE X 1-1/2" SQUARE END 132 NPN KEY, 1/4" X 1" WOODRUFF 133 16814 RING, RETAINING 5160-118 134 NPN RING, BEVELED RETAINING N5002-244 135 NPN OIL, MOBILUBE SHC 75W-90 4036 NPN PLATE, NAME, CRARY 137 NPN PAINT, FLAT BLACK 5.12038 NPN PLUG, PIPE SOCKET 1/4 NPT 239 NPN PLUG, PIPE 1/2" O-RING BOSS 340 NPN PLUG, VENTED 1/8 NPT, 1-5 PSI BALL 141 16625 SEAL, 472681 OR EQUIVALENT 142 16624 SEAL, 32395 OR EQUIVALENT 243 NPN O-RING, -044 144 NPN O-RING, -158 245 NPN O-RING, -138 246 NPN SCREW, 5/16" X 3/4" NC HHCS GR5 147 NPN TAG, LUBRICATION 1

16125 GEAROX SEAL AND SHIM KIT (NOT SHOWN) 125320 GEARBOX, REBUILT (22327/9.37:1) (NOT SHOWN) 116621 GEARBOX GEAR KIT (9.375:1) (NOT SHOWN) 1


gEArboX moUnt/rH drIvE 15’ - 22.5’ (PRE 1993) 06/08


gEArboX moUnt & rIgHt HAnd drIvE (PrE 93)


1 12457 BUSHING, SD 1-3/8” 22 15003 BOLT, 5/16” X 3/4” HHCS GR5 ZP 33 15012 BOLT, 1/2” X 1” HHCS GR5 ZP 44 15612 BOLT, 1/2” X 1-1/4” SERR FLG 125 15049 NUT, 1/2” CENTERLOCK GRB ZP 46 15034 WASHER, 1/2” FLAT ZP 167 15250 WASHER, 5/16” FLAT ZP 38 15282 BOLT, 5/16” X 1-1/2” HHCS GR5 ZP 69 15409 NUT, 2/16” TINNERMAN, U-TYPE 310 15498 KEY, 5/16” SQUARE X 1-1/2” 411 22623 PLATE, MOUNT SUPPORT CIH 1010-1020 112 22624 PLATE, GEARBOX MOUNT CIH 1010-1020 213 22696 WELDMENT, SHIELD 114 (SEE DRIVELINE OPTIONS, PAGES 54-55)15 24036 SHAFT, GEARBOX DRIVE 116 24037-12 SHIELD, SLIP CLUTCH 117 24039 ASSEMBLY, SHIELD MOUNT PLATE 1

16067 ADAPTER, -10MORING/-8MJIC 45 DEGREE (NOT SHOWN) 2

06/08 15’ - 22.5’ (PRE 1993) gEArboX moUnt/rH drIvE


gEArboX moUnt/rH drIvE 25’ & 30’ (PRE 1993) 06/08


gEArboX moUnt & rIgHt HAnd drIvE PrE 93 (25ft - 30ft)ItEm PArt nUmbEr dESCrIPtIon QtY

1 12457 BUSHING, SD 1-3/8" 22 15003 BOLT, 5/16" X 3/4" HHCS GR5 ZP 33 15012 BOLT, 1/2" X 1" HHCS GR5 ZP 44 15612 BOLT, 1/2” X 1-1/4” SERR FLG 125 15049 NUT, 1/2" CENTERLOCK GRB ZP 46 15034 WASHER, 1/2" FLAT ZP 167 15250 WASHER, 5/16" FLAT ZP 38 15282 BOLT, 5/16" X 1/2" HHCS GR5 ZP 69 15402 NUT, 5/16" TINNERMAN, U-TYPE 310 15498 KEY, 5/16" SQUARE X 1-1/2" 411 22624 PLATE, GEARBOX MOUNT, CIH 1010-1020 212 22696 WELDMENT, SHIELD 113 (SEE DRIVELINE OPTIONS, PAGES 54-55)14 24036 SHAFT, GEARBOX DRIVE 115 24037-12 SHIELD, SLIP CLUTCH 116 24039 ASSEMBLY, SHIELD MOUNT PLATE 117 24042-12 MOUNT PLATE SUPPORT, CIH 1010-1020 1


06/08 25’ & 30’ (PRE 1993) gEArboX moUnt/rH drIvE


gEArboX moUnt/rH drIvE 15’ - 22.5’ (1993/1994) 06/08


gEArboX moUnt & rIgHt HAnd drIvE (1993-1994)ItEm PArt nUmbEr dESCrIPtIon QtY

1 12457 BUSHING, 1-3/8" SD 22 15002 BOLT, 1/4" X 1" HHCS GR5 ZP 33 15003 BOLT, 5/16" X 3/4" HHCS GR5 ZP 34 15006 BOLT, 3/8" X 1" HHCS GR5 ZP 25 15612 BOLT, 1/2” X 1-1/4” SERR FLG 126 15049 NUT, 1/2" CENTERLOCK GRB ZP 47 15051 NUT, 3/8" SERRATED FLANGE NC ZP 28 15034 WASHER, 1/2" FLAT ZP 149 15250 WASHER, 5/16" FLAT ZP 3

10 15282 BOLT, 5/16" X 1-1/2" HHCS GR5 ZP 611 15402 NUT, 5/16" TINNERMAN, U-TYPE 312 15498 KEY, 5/16" SQUARE X 1-3/4" 413 16490 CHAIN, #60 X 43" 114 22623 SUPPORT, MOUNT PLATE (CIH 1010/1020) 115 22624 PLATE, GEARBOX MOUNT (CIH 1010/1020) 216 23229 ASSEMBLY, TORQUE LIMITER CLUTCH (SEE PG. 58) 117 23240 SHIELD, CHAIN DRIVE 118 23903 BUSHING, SH 1-1/8" HEX 119 23904 WELDMENT, SPROCKET/HUB 120 (SEE DRIVELINE OPTIONS, PAGES 54-55)21 24035 SHAFT, GEARBOX DRIVE 122 24037-12 SHIELD, SLIP CLUTCH 123 24039 ASSEMBLY, SHIELD MOUNT PLATE 124 15012 BOLT, 1/2” X 1” HHCS GR5 ZP 2


06/08 15’ - 22.5’ (1993/1994) gEArboX moUnt/rH drIvE


gEArboX moUnt/rH drIvE 15’ - 22.5’ (1995 & LATER) 06/08


gEArboX moUnt & rIgHt HAnd drIvE (1995 And LAtEr)ItEm PArt nUmbEr dESCrIPtIon QtY

1 12457 BUSHING, 1-3/8” SD 22 15002 BOLT, 1/4” X 1” HHCS GR5 ZP 33 15003 BOLT, 5/16” X 3/4” HHCS GR5 ZP 34 15006 BOLT, 3/8” X 1” HHCS GR5 ZP 25 15612 BOLT, 1/2” X 1-1/4” SERR FLG 126 15031 WASHER, 3/8” FLAT ZP 27 15049 NUT, 1/2” CENTERLOCK GRB ZP 48 15051 NUT, 3/8” SERRATED FLANGE NC ZP 29 15034 WASHER, 1/2” FLAT ZP 1410 15250 WASHER, 5/16” FLAT ZP 311 15282 BOLT, 5/16” X 1-1/2” HHCS GR5 ZP 612 15402 NUT, 5/16” TINNERMAN, U-TYPE 313 15498 KEY, 5/16” SQUARE X 1-1/2” 414 16947 CHAIN, #60 X 67 115 22624 PLATE, GEARBOX MOUNT (CIH 1010/1020) 216 23229 ASSEMBLY, TORQUE LIMITER CLUTCH) (SEE PG. 58) 117 23903 BUSHING, SH 1-1/8” HEX 118 23904 WELDMENT, SPROCKET/HUB 119 (SEE DRIVELINE OPTIONS, PAGES 54-55)20 24035 SHAFT, GEARBOX DRIVE 121 24037-12 SHIELD, SLIP CLUTCH 122 24039 ASSEMBLY, SHIELD MOUNT PLATE 123 24042-12 SUPPORT, MOUNT PLATE (CIH 1010/1020) 124 24111-12 WELDMENT, CHAIN DRIVE SHIELD 125 15013 BOLT, 1/2” X 1-1/4” HHCS NC GR5 ZP 2


06/08 15’ - 22.5’ (1995 & LATER) gEArboX moUnt/rH drIvE


gEArboX moUnt/rH drIvE 25’ & 30’ (1993 & LATER)S/N 0-706454 06/08


gEArboX moUnt And rIgHt HAnd drIvE 93-LAtEr, (25’ & 30’)ItEm PArt nUmbEr dESCrIPtIon QtY

1 12457 BUSHING, 1-3/8” SD 22 15003 BOLT, 5/16” X 3/4” HHCS GR5 ZP 33 15612 BOLT, 1/2” X 1-1/4” SERR FLG 124 15049 NUT, 1/2” CENTERLOCK GRB ZP 215 15051 NUT, 3/8” SERRATED FLANGE NC ZP 76 15057 BOLT, 3/8” X 1” CARRIAGE NC GR5 ZP 77 15034 WASHER, 1/2” FLAT ZP 168 15250 WASHER, 5/16” FLAT ZP 39 15282 BOLT, 5/16” X 1-1/2” HHCS GR5 ZP 610 15402 NUT, 5/16” TINNERMAN, U-TYPE 311 15498 KEY, 5/16” SQUARE X 1-3/4” 312 17060 FLANGETTE, 72MS RND 3 BIT, 1-3/8” ZP 213 17062 BEARING, 1-1/8” HEX 207 KRRB9 114 22624 PLATE, GEARBOX MOUNT (CIH 1010/1020) 215 (SEE DRIVELINE OPTIONS, PAGES 54-55)16 24037-12 SHIELD, SLIP CLUTCH 117 24039 ASSEMBLY, SHIELD MOUNT PLATE 118 24042-12 SUPPORT, MOUNT PLATE (CIH 1010/1020) 119 25756-00 SHAFT, GEARBOX DRIVE 120 25757-12 BRACKET, BEARING MOUNT 121 25758-00 SHAFT, RIGHT HAND DRIVE 122 25762-12 WELDMENT, SHIELD 123 15013 BOLT, 1/2” X 1-1/4” HHCS NC GR5 ZP 4


06/08 25’ & 30’ (1993 & LATER)S/N 0-706454 gEArboX moUnt/rH drIvE


gEArboX moUnt KIt 25’ & 30’ (1993 & LATER)S/N 706455-CURRENT 06/08


06/08 25’ & 30’ (1993 & LATER)S/N 706455-CURRENT gEArboX moUnt KIt

gEArboX moUnt KIt (29873)ItEm PArt nUmbEr dESCrIPtIon QtY

1 29833-12 GBOX DRIVE LH SHIELD 12 29832-12 GBOX DRIVE RH SHIELD 13 29831-12 HINGE, SHIELD 24 15612 BOLT, 1/2 X 1-1/4” SERRATED FLANGE 45 15390 BOLT, 5/16 NC X 6-1/2” GR5 HCS ZP 26 15356 NUT, 5/16” NE NYLOCK ZP 27 15097 WASHER, 1/2” SAE FLAT ZP 48 15012 BOLT, 1/2 X 1” GR5 HEX CAPSCREW ZP 49 0125-0060-00 LATCH, FLEXIBLE DRAW 210 15423 SCW, MCH 10-24 X 1/2” PAN HD, PH ZP 411 15557 BOLT, 10-24 X 3/4” HHCS G8 PLAIN 412 15397 NUT, 10/24 NYLOCK TYPE NM, ZP 8

29817-00 ASSEMBLY, GEARBOX MOUNT (CIH 1010/20) (INCLUDES ITEMS 13-16) 113 29815-12 BRACKET, GEARBOX MOUNT (CIH 1010/20) 114 29816-12 PLATE, GEARBOX MOUNT (CIH 1010/20) 115 15013 BOLT, 1/2” X 1-1/4” GR5 HHCS NC ZP 316 0101-0100-00 NUT, 1/2”-13 UC NYLOCK 3



rIgHt HAnd drIvE KIt 25’ & 30’ (1993 & LATER)S/N 706455-CURRENT 06/08


06/08 25’ & 30’ (1993 & LATER)S/N 706455-CURRENT rIgHt HAnd drIvE KIt

drIvE KIt ASSEmbLY (29871)ItEmS PArt nUmbErS dESCrIPtIon QtY

1 29866-12 BRACKET, BEARING MOUNT 12 29865-00 SHAFT, CIH 10250 RH DRIVE 13 (SEE DRIVELINE OPTIONS, PAGES 56-57)4 29196-00 SHIELD, DRIVE SHAFT (3.65”) 15 17062 BEARING, 1-1/8 HEX 207 KRRB9 16 17060 FLANGETTE, 72MS RND 3 BIT, ZP 27 15057 BOLT, CARR 3/8 X 1” GR5 NC ZP 78 15051 NUT, 3/8” SERRATED FLANGE NC ZP 79 12457 BUSHING, SD 1-3/8” 210 15498 KEY, 5/16” X 1-1/2” SQUARE 211 53102-00 SHAFT, 1-3/8” 6 SPLINE TO HEX 1


drIvELInE/C fLAngE ASSEmbLY ALL MODELS 06/08


06/08 ALL MODELS drIvELInE/C fLAngE ASSEmbLY

drIvELInE/C-fLAngE ASSEmbLY (24027 & 24028)

ItEm PArt nUmbEr dESCrIPtIon 24027QtY

24028QtY

116934 HEADER DRIVELINE W/CLUTCH (S) (SEE TABLE BELOW) 116935 HEADER DRIVELINE W/CLUTCH (L) (SEE TABLE BELOW) 1

2 13911-00 COUNTER FLANGE, 1-1/8", HEX, W/QD 1 13 15219 BOLT, 5/16" X 1" HHCS NC GR5 ZP 6 64 15356 NUT, 5/16" NE NYLOCK ZP 6 65 15256 SCREW, 3/8" X 3/4" SQUARE HEAD SET ZP 1 16 15070 SCREW, 3/8" X 1" SQUARE HEAD SET 1 1

drIvELInE SErvICE PArtS

ItEm PArt nUmbEr dESCrIPtIon 16934QtY

16935QtY

7 0883-0120-00 KIT, CROSS AND BEARING W-2400 2 28 12209 CHAIN, SHAFETY 1 19 12210 DECAL, OUT 1 110 12211 DECAL, IN 1 111 12215 YOKE, INBOARD 1B 1 112 12218 YOKE, INBOARD 2A 1 113 12220 CONE, 6 RIB SAFETY 2 214 12223 RING, SC25, BEARING 2 215 14714-00 YOKE, FLANGE 1 116 14722-00 CLUTCH, FRICTION (INCLUDES ITEMS A-J) 1 1

A 14061-00 SPRING, BELVILLE (WALTERSCHEID) 1 1B 14062-00 SET, FRICTION DISC (WALTERSCHEID) 1 1C 14720-00 YOKE, FLANGE 1 1D 14721-00 HUB, CLUTCH 1 1E 14736-00 PLATE, THRUST 1 1F 15647 NUT, M10 X 1.5 HEX NYLOCK TYP NE YZP 6 6G 15747-00 BOLT, M10 X 1.5 X 50 CLASS 8.8 HCPS 6 6H 15748-00 BOLT, M12 X 1.75 X 65 CLASS 8.8 HCPS 1 1J 15749-00 NUT, M12 X 1.75 HEX NYLOCK TYPE NE YZP 1 1

1714728-00 PROFILE, INNER 1B, (SHORT) 114732-00 PROFILE, INNER 1B, (LONG) 1

1814729-00 PROFILE, OUTER 2A, (SHORT) 114733-00 PROFILE, OUTER 2A, (LONG) 1

1914730-00 TUBE, INNER SHIELD, (SHORT) 114734-00 TUBE, INNER SHIELD, (LONG) 1

2014731-00 TUBE, OUTER SHIELD, (SHORT) 114735-00 TUBE, OUTER SHIELD, (LONG) 1

21 15575 PIN, M10 X 80, SPRING 2 2

HEAdEr WIdtH

YEAr of HEAdEr

AIr rEEL SErIAL #

drIvELInE PArt nUmbEr24027 24028 29859-00*

15’-20’ ALL ALL X22.5’ ALL ALL X

25’1992 & earlier ALL X1993 & later 0-706454 X1993 & later 706455-CURRENT X

30’ ALL ALL X*See PageS 56-57 fOr Part # 29859-00


drIvELInE/C fLAngEASSEmbLY

25’ & 30’ HEADERS 1993 & LATERS/N 706455-CURRENT 06/08


06/08 25’ & 30’ HEADERS 1993 & LATERS/N 706455-CURRENT

drIvELInE/C fLAngEASSEmbLY

drIvELInE SErvICE PArtS (14389-00)ItEm PArt nUmbEr dESCrIPtIon QtY

5 0883-0120-00 KIT, CROSS AND BEARING W-2400 26 12209 SAFETY CHAIN 17 12215 YOKE, INBOARD 1B 18 12218 YOKE, INBOARD 2A 19 12220 CONE, 6 RIB SAFTEY 210 12223 RING, SC25 BEARING 211 14714-00 YOKE, FLANGE 112 14744-00 CLUTCH, FRICTION (INCLUDES ITEMS BELOW) 1

A 14061-00 SPRING, BELVILLE (WSCHEID) 1B 14062-00 SET, FRICTION DISC 1C 14720-00 YOKE, FLANGE 1D 14736-00 PLATE, THRUST 1E 14737-00 HUB, CLUTCH 1F 15647 NUT, M10 X 1.5 HEX NYLOCK TYPE NE 6G 15747-00 BOLT, M10 X 1.5 X 50 CLASS 8.8 HC 6

14738-00 BACK-UP RING (NOT SHOWN) 114739-00 BALL, CLUTCH (NOT SHOWN) 314740-00 SPRING, COMPRESSION (NOT SHOWN) 114741-00 COLLAR, LOCK (NOT SHOWN) 114742-00 RING, BACKUP (NOW SHOWN) 114743-00 RING, SNAP (NOT SHOWN) 1

13 14732-00 PROFILE, INNER 1B (LONG) 114 14733-00 PROFILE, OUTER 2A (LONG) 115 14734-00 TUBE, INNER SHIELD (LONG) 116 14735-00 TUBE, OUTER SHIELD (LONG) 117 15575 PIN, M10 X 80 SPRING 218 12210 DECAL, OUT 119 12211 DECAL, IN 1

drIvELInE/C-fLAngE ASSEmbLY (29859-00)ItEm PArt nUmbEr dESCrIPtIon QtY

1 13911-00 COUNTER FLANGE, 1-1/8 HEX 6 BOLT 12 14389-00 ASSEMBLY, DRIVELINE/CLUTCH 1-3/8 6 SPLINE (SEE TABLE BELOW) 13 15219 BOLT, 5/16 X 1” GR5 HHCS NC ZP 64 15356 NUT, 5/16” NE NYLOCK ZP 6

HEAdEr WIdtH

YEAr of HEAdEr

AIr rEEL SErIAL #

drIvELInE PArt nUmbEr24027* 24028* 29859-00

15’-20’ ALL ALL X22.5’ ALL ALL X

25’1992 & earlier ALL X1993 & later 0-706454 X1993 & later 706455-CURRENT X

30’ ALL ALL X*See PageS 54-55 fOr Part #’S 24027 & 24028


torQUE LImItEr, AUgEr drIvE SHAft (23229)ItEm PArt nUmbEr dESCrIPtIon QtY

1 16494 CLUTCH, TORQUE LIMITER (INCLUDES ITEMS A-F) 1

A NPN HUB 1

B NPN PRESSURE PLATE 2

C NPN RETAINER, SPRING 1

D NPN NUT, ADJUSTING 1

E NPN SCREWS, 5/16” SET 2

F NPN SCREWS, ADJUSTING NUT 3

2 12115 SET, CLUTCH DISC 1

3 16495 SPROCKET, 60A25 1

4 12936-00 SPRING, CLUTCH 1

5 16496 BUSHING, SPROCKET 1

torQUE LImItEr, AUgEr drIvESHAft ALL MODELS 06/08


3

1 2

THIS SIDE OF MANIFOLD IS TO BE

TOWARD THE COMBINE.

237 NW 12 TH ST BOX 849 WEST FARGO, ND 58078(701)-282-5520

P/N 17224

4

5

TM

ItEm PArt nUmbEr dESCrIPtIon QtY1 11001 DECAL, CAUTION 12 17224 DECAL CTR MANIFOLD DIRECTION 13 11002 DECAL, WARNING 14 16722 AIR REEL STRIPING NA5 11012 DECAL, CRARY AIR REEL 1

06/08 ALL MODELS dECALS



OPTIONS



KIt, gEArboX/fAn EXtEnSIon ALL MODELS 06/08


06/08 ALL MODELS KIt, gEArboX/fAn EXtEnSIon

gEArboX/fAn EXtEnSIon KIt (24493)ItEm PArt nUmbEr dESCrIPtIon QtY

1 10218 30 MM BEARING 1

2 13014 U-BOLT, FAN MOUNT 3/8 X 3 X 4” ZP 1

3 15006 BOLT, 3/8” X 1” GR5 HEX CAPSCREW ZP 2

4 15012 BOLT, 1/2” X 1” GR5 HEX CAPSCREW ZP 2

5 15014 BOLT, 1/2” X 1-1/2” GR5 HEX CAPSCREW ZP 4

6 15031 WASHER, 3/8” FLAT ZP 2

7 15042 NUT, 3/8” HEX NUT NC ZP 4

8 15049 NUT, 1/2” CENTER LOCKNUT ZP 4

9 15097 WASHER, 1/2” SAE FLAT ZP 4

10 22341 KEY, 3/16” SQ X 2” PLAIN 1

11 24642 SHAFT/COUPLER WELDMENT 1

12 24495-12 HUB, MACHINED EXTENSION 1

13 24510-12 PLATE, BEARING RETAINER 1

1424638-12 BRACKET, EXTENSION SUPPORT - CASE IH (SHORT) 1

24639-12 BRACKET, EXTENSION SUPPORT - CASE IH (LONG) 1

15 24640-12 BRACKET, EXTENSION SUPPORT - JD/NH 1

16 24641-12 BRACKET, EXTENSION SUPPORT - GLEANER 1


AUXILIArY rEEL tInE KIt (25605)ItEm PArt nUmbEr dESCrIPtIon QtY

1 15031 WASHER, 3/8” FLAT ZP 2

2 15047 NUT, 3/8 CENTER LOCKNUT ZP 2

3 15115 BOLT, CRG 3/8 X 2-1/2” GR5 NC SP 2

4 15302 STL MCH BSH, 7/8 ID NAR-RIM 10GA 4

25602-00 RH AUX. REEL TINE ASSEMBLY (INCLUDES ITEMS 5-7) 1

5 25601-12 PIVOT STRAP/TUBE WELDMENT 1

6 12529 TINE, PLASTIC REEL 1

7 15597 SCREW, 12-14 X 2” FLAT HD, THD. FORM 1

25603-00 LH AUX. REEL TINE ASSEMBLY (INCLUDES ITEMS 5-7) 1

5 25601-12 PIVOT STRAP/TUBE WELDMENT 1

6 12529 TINE, PLASTIC REEL 1

7 15597 SCREW, 12-14 X 2” FLAT HD, THD. FORM 1

(rigHt Side)

(Left Side)

KIt, AUXILIArY rEEL tInE ALL MODELS 06/08


06/08 25’ & 30’ (1993 & LATER) KIt, nEUtrAL drIvE SHAft

KIt, nEUtrAL drIvE SHAft (53107)ItEm PArt nUmbEr dESCrIPtIon QtY

1 15057 BOLT, 3/8 X 1 CRG 6

2 15260 WASHER, 3/8 SAE FLAT 6

3 15388 NUT, 3/8” NYLOCK 6

4 17059 BEARING, 1-3/8 IN. ROUND BORE 2

5 17060 FLANGETTE, 72MSI - 3/8 IN. 4

6 53102-00 SHAFT, 1-3/8” 6 SPLINE TO HEX 1


StAtIC PrESSUrE gAgE ALL MODELS 06/08

ASSEmbLY, StAtIC PrESSUrE gAgE (53094-00)ItEm PArt nUmbEr dESCrIPtIon QtY

1 36195-00 GAGE, LOW PRESSURE AIR 1

2 13041-00 ADAPTOR, -4FMNPT/-4MJIC BULKHEAD 1

3 0937-0013-00 WASHER, .438 X 1.500 X .125 1

4 53093-00 GRIP, ROUND VINYL (W/HOLE) 1

5 15032 WASHER, 7/16 FLAT 1


PARTS INDEX



0101-0100-00 ............................................... 510103-0714-00 ............................................... 310125-0060-00 ............................................... 510201-0077-00 ............................................... 390201-0078-00 ............................................... 390883-0120-00 ......................................... 55, 570937-0013-00 ............................................... 677022........................................................ 35, 3710218............................................................ 6311001 ............................................ 3, 5, 7, 9, 5911002 ............................................ 3, 5, 7, 9, 5911012 ............................................ 3, 5, 7, 9, 5912050............................................................ 2512115 ............................................................ 5812146............................................................ 3212167............................................................ 3312209...................................................... 55, 5712210...................................................... 55, 5712211 ...................................................... 55, 5712215...................................................... 55, 5712218...................................................... 55, 5712220...................................................... 55, 5712223...................................................... 55, 5712457.............................. 41, 43, 45, 47, 49, 5312491............................................................ 2512506............................................................ 3112528...................................................... 12, 2712529.................................... 17, 19, 21, 23, 6512936-00 ...................................................... 5813014............................................................ 6313041-00 ...................................................... 6713460-00 ................................................ 35, 3713768-00 ............................................ 3, 5, 7, 913911-00 ................................................. 55, 5714022-00 .............................................. 7, 9, 2514056-00 ................................................ 35, 3714061-00 ................................................ 55, 5714062-00 ................................................ 55, 5714389-00 ...................................................... 5714714-00 ................................................ 55, 5714720-00 ................................................ 55, 5714721-00 ...................................................... 5514722-00 ...................................................... 5514728-00 ...................................................... 5514729-00 ...................................................... 5514730-00 ...................................................... 5514731-00 ...................................................... 5514732-00 ................................................ 55, 5714733-00 ................................................ 55, 5714734-00 ................................................ 55, 5714735-00 ................................................ 55, 5714736-00 ................................................ 55, 5714737-00 ...................................................... 5714738-00 ...................................................... 5714739-00 ...................................................... 5714740-00 ...................................................... 5714741-00 ...................................................... 5714742-00 ...................................................... 5714743-00 ...................................................... 5714744-00 ...................................................... 5715001...................................................... 35, 3715002...................................................... 45, 4715003.................................... 41, 43, 45, 47, 4915006................................................ 45, 47, 6315008................................................ 11, 14, 1515012.................................... 41, 43, 45, 51, 6315013................................................ 47, 49, 5115014.......................................... 25, 35, 37, 6315030...................................................... 12, 27

15031.............. 3, 5, 7, 9, 11, 14, 15, 47, 63, 6515032............................................................ 6715034.............................. 25, 41, 43, 45, 47, 4915042............................................................ 6315043...................................................... 29, 3115047........................ 11, 13, 14, 15, 29, 31, 6515049 25, 29, 31, 35, 37, 41, 43, 45, 47, 49, 6315051........................ 32, 35, 37, 45, 47, 49, 5315053................................................ 31, 35, 3715055...................................................... 35, 3715057.............. 3, 5, 7, 9, 13, 29, 31, 49, 53, 6615068...................................................... 35, 3715070............................................................ 5515076...................................................... 35, 3715086...................................................... 29, 3115087...................................................... 35, 3715092...................................................... 29, 3115095............................................................ 3515097...................................................... 51, 6315098...................................................... 35, 3715099...................................................... 35, 3715115 ............................................................ 6515129............................................................ 3515140............................................................ 1215154.................................................. 3, 5, 7, 915174............................................................ 3115176............................................ 3, 5, 7, 9, 1115178.......................................... 12, 17, 19, 2115219................................................ 27, 55, 5715238............................................................ 3515250.................. 14, 15, 27, 41, 43, 45, 47, 4915256............................................................ 5515260...................................................... 13, 6615282............ 12, 17, 19, 21, 41, 43, 45, 47, 4915300............................................................ 2715302............................................................ 6515342...................................................... 35, 3715351............................................................ 3715356........ 3, 5, 7, 9, 11, 12, 25, 27, 51, 55, 5715364...................................................... 35, 3715367............................................................ 3715375............................................................ 3115382............................................................ 3215388............................................ 3, 5, 7, 9, 6615390............................................................ 5115396............................................................ 1215397................................................ 35, 37, 5115402.......................................... 43, 45, 47, 4915403............................................................ 2715409............................................................ 4115423............................................................ 5115436...................................... 3, 5, 7, 9, 11, 2515486.................................................. 3, 5, 7, 915498.............................. 41, 43, 45, 47, 49, 5315552...................................................... 35, 3715557............................................................ 5115562............................................................ 2515575...................................................... 55, 5715597.................................... 17, 19, 21, 23, 6515612.............................. 41, 43, 45, 47, 49, 5115647...................................................... 55, 5715747-00 ................................................ 55, 5715748-00 ...................................................... 5515749-00 ...................................................... 5515754-00 ...................................................... 2716067........................ 25, 41, 43, 45, 47, 49, 5116091............................................................ 3216092............................................................ 3216125............................................................ 39

16449............................................................ 3516490............................................................ 4516494............................................................ 5816495............................................................ 5816496............................................................ 5816516............................................................ 2516544............................................................ 3116621............................................................ 3916624............................................................ 3916625............................................................ 3916722............................................................ 5916807............................................................ 3916814............................................................ 3916815............................................................ 3916817............................................................ 3916819............................................................ 3916820............................................................ 3916821............................................................ 3916934............................................................ 5516935............................................................ 5516947............................................................ 4717059............................................................ 6617060................................................ 49, 53, 6617062...................................................... 49, 5317224............................................ 3, 5, 7, 9, 5917313............................................................ 1117404...................................................... 12, 2717406.................................................. 3, 5, 7, 917407.................................................. 3, 5, 7, 917410............................................................ 3217437............................................................ 3217444.................................................. 3, 5, 7, 917629...................................................... 14, 1517634............................................................ 1217669............................................................ 1117670............................................................ 1117703............................................ 3, 5, 7, 9, 1117777............................................................ 3217843...................................................... 29, 3117849............................................................ 3317850............................................................ 3318998-00 ...................................................... 3721193 ...................................................... 35, 3721194 ...................................................... 35, 3721444...................................................... 35, 3721445...................................................... 35, 3721509...................................................... 12, 2721512............................................................ 3221520............................................................ 2521550...................................................... 12, 2721588...................................................... 14, 1521797...................................................... 14, 1521924............................................................ 3221976............................................................ 2721978............................................................ 1122153............................................................ 1122164............................................................ 1122179.............................................................. 522181.......................................................... 3, 922184.......................................................... 5, 722185.......................................................... 5, 922187.............................................................. 522188.............................................................. 522189.............................................................. 722192.............................................................. 322193.............................................................. 722214...................................................... 29, 3122220...................................................... 29, 3122254............................................................ 29


Part # Page(s) Part # Page(s) Part # Page(s)

22260...................................................... 29, 3122290...................................................... 29, 3122327................................................ 35, 37, 3922341............................................................ 6322346...................................................... 11, 1222347...................................................... 25, 2722364.................................................. 3, 5, 7, 922365...................................................... 5, 7, 922374.............................................................. 722392.............................................................. 322393.............................................................. 522395.............................................................. 522397.............................................................. 522398.............................................................. 722402.............................................................. 722405............................................................ 1122419............................................................ 1122479...................................................... 29, 3122489............................................................ 2522600............................................................ 1122602............................................................ 1122603............................................................ 1122605............................................................ 1122607............................................................ 1122609............................................................ 1122612............................................................ 1122623...................................................... 41, 4522624.................................... 41, 43, 45, 47, 4922655...................................................... 35, 3722696...................................................... 41, 4322809...................................................... 29, 3123152............................................................ 3523155............................................................ 3523158............................................................ 3523161............................................................ 3523163............................................................ 3523229................................................ 45, 47, 5823240............................................................ 4523501...................................................... 29, 3123903...................................................... 45, 4723904...................................................... 45, 4724027............................................................ 5524028............................................................ 5524035...................................................... 45, 4724036...................................................... 41, 4324037-12 .............................. 41, 43, 45, 47, 4924039.................................... 41, 43, 45, 47, 4924042-12 .......................................... 43, 47, 4924095-11 ....................................................... 3124098-11 ....................................................... 3124099-11 ....................................................... 3124100............................................................ 3124111-12 ....................................................... 4724268-12 ........................................................ 324269-12 ........................................................ 524272-12 ........................................................ 524273-12 ........................................................ 524274-12 ........................................................ 724278-12 ........................................................ 724318-12 ...................................................... 2724332-12 ...................................................... 3324333............................................................ 3324493............................................................ 6324495-12 ...................................................... 6324510-12 ...................................................... 6324638-12 ...................................................... 6324639-12 ...................................................... 6324640-12 ...................................................... 6324641-12 ...................................................... 63

24642............................................................ 6324651-12 ...................................................... 3224875-12 ...................................................... 2324876-12 ...................................................... 2324877-12 ...................................................... 2324878-12 ...................................................... 2324879-12 ...................................................... 2324880-12 ...................................................... 2324881-12 ...................................................... 2324882-12 ...................................................... 2324883-12 ...................................................... 2324884-12 ...................................................... 2324885-12 ...................................................... 2324886-12 ...................................................... 2324887-12 ...................................................... 2324888................................................ 17, 19, 2124905-12 ................................................ 14, 1524910-12 ............................................ 3, 5, 7, 924917-12 ................................................ 3, 5, 724919...................................................... 13, 1524920...................................................... 13, 1424922...................................................... 19, 2324923............................................................ 2324924...................................................... 19, 2324925...................................................... 19, 2324926............................................................ 2324927...................................................... 17, 2324928............................................................ 2324929............................................................ 2324930...................................................... 21, 2324931.......................................... 17, 19, 21, 2324932...................................................... 19, 2324933...................................................... 19, 2324934...................................................... 19, 2324936............................................................ 1724938............................................................ 1924939............................................................ 1924941............................................................ 1924943............................................................ 1924946............................................................ 1924975-12 .................................................... 5, 925320............................................................ 3925563-00 .................................................... 7, 925564-00 ........................................................ 525566-00 ........................................................ 525567-00 ........................................................ 525569-00 ........................................................ 325571-00 ........................................................ 725575-00 ........................................................ 725576-00 ........................................................ 725580-00 ........................................................ 725592-12 ...................................................... 3525601-12 ...................................................... 6525602-00 ...................................................... 6525603-00 ...................................................... 6525605............................................................ 6525638-35 ................................................ 35, 3725641-12 ................................................ 35, 3725644-12 ................................................ 35, 3725658-12 ............................................ 3, 5, 7, 925756-00 ...................................................... 4925757-12 ...................................................... 4925758-00 ...................................................... 4925760-00 ............................................ 3, 5, 7, 925762-12 ...................................................... 4927129-12 ...................................................... 2327130-12 ........................................................ 927134-00 ........................................................ 927138-00 ........................................................ 9

27139-00 ........................................................ 927144-00 ...................................................... 2127172-00 ...................................................... 2327951-12 .......................................... 17, 19, 2127952-12 .......................................... 17, 19, 2127983-00 .......................................... 17, 19, 2127984-00 .......................................... 17, 19, 2129196-00 ...................................................... 5329815-12 ...................................................... 5129816-12 ...................................................... 5129817-00 ...................................................... 5129831-12 ...................................................... 5129832-12 ...................................................... 5129833-12 ...................................................... 5129865-00 ...................................................... 5329866-12 ...................................................... 5329871............................................................ 5329873............................................................ 5129917-12 ...................................................... 3729919-12 ...................................................... 3729921-12 ...................................................... 3736008-00 ...................................................... 3736195-00 ...................................................... 6736222-00 ...................................................... 3953035-12 ...................................................... 3753048-12 ...................................................... 3753093-00 ...................................................... 6753094-00 ...................................................... 6753102-00 ................................................ 53, 6653107............................................................ 6670036............................................................ 31


Part # Page(s) Part # Page(s) Part # Page(s)

manufactured in the United States of America

by Crary Industries

237 12TH ST. NW • P.O. BOX 849 WESt fArgo, nd 58078-0849

PH: 1-800-247-7335 • FAX: (701) 282-9522www.crary.com

Date post:	05-Mar-2021
Category:	Documents
Upload:	others
View:	1 times
Download:	0 times

CASE IH - manuals.crary.commanuals.crary.com/manuals/airreel/12086_r062008.pdf · Manual P/N 12086...

Documents