Date post: | 19-Jun-2018 |
Category: |
Documents |
Upload: | vuongkhanh |
View: | 353 times |
Download: | 8 times |
The information in this manual is currentas of its publication date, and applies tocompressor serial number:
and all subsequent serial numbers.
02250174-685-R02
201104010000
PORTABLE AIR COMPRESSOR125, 130, 185 AND 49HP 185
Failure to follow the instructions and procedures in this manual or,
misuse of this equipement will VOID its warranty!
WARRANTY NOTICE
PART NUMBER:
KEEP FORFUTURE REFERENCE
PARTS LIST MANUAL
©SULLAIR CORPORATION
CATERPILLAR AND JOHN DEERE
AIR CARE SEMINAR TRAININGSullair Air Care Seminars are courses that provide hands-on instruction for the proper operation, maintenance,and servicing of Sullair products. Individual seminars on portable compressors and compressor electricalsystems are offered at regular intervals throughout the year at Sullair’s corporate headquarters training facilitylocated at Michigan City, Indiana.
Instruction includes training on the function and installation of Sullair service parts, troubleshooting commonfaults and malfunctions, and actual equipment operation. These seminars are recommended for maintenance,contractor maintenance, and service personnel.
For detailed course outlines, schedule, and cost information contact:
SULLAIR TRAINING DEPARTMENT
1-888-SULLAIR or219-879-5451 (ext. 5623)
- Or Write -Sullair Corporation
3700 E. Michigan Blvd.Michigan City, IN 46360
Attn: Service Training Department.
PAGE SECTION DESCRIPTION PAGE SECTION DESCRIPTION
TABLE OF CONTENTS
5 1.1 PROCEDURE FOR ORDERING PARTS
6 1.2 RECOMMENDED SERVICE PARTS LIST
8 1.3 ENGINE, COMPRESSOR & PARTS 125, 130 & 185 CAT
10 1.4 ENGINE, COMPRESSOR & PARTS 49HP 185 CAT
12 1.5 ENGINE, COMPRESSOR & PARTS 125, 130 & 185 JD
14 1.6 ENGINE, COMPRESSOR & PARTS 49HP 185 JD
16 1.7 AIR INLET & EXHAUST 125, 130, 185 & 49HP 185 CAT
18 1.8 EXHAUST 125, 130, 185 & 49HP 185 CAT & SAFE ZONE
20 1.9 AIR INLET & EXHAUST 125, 130 & 185 JD
22 1.10 EXHAUST SYSTEM 49HP 185 JD
24 1.11 AIR INLET 125, 130, 185 & 49HP 185 CAT SAFE ZONE
26 1.12 COOLING SYSTEM & PARTS
30 1.13 DISCHARGE SYSTEM 125, 130 & 185
34 1.14 DISCHARGE SYSTEM 49HP 185
36 1.15 MANIFOLD REGULATOR/BLOWDOWN
38 1.16 FUEL SYSTEM JD & CAT
40 1.17 ELECTRICAL SYSTEM PARTS
42 1.18 FRAME, RUNNING GEAR & PARTS 125, 130 & 185
44 1.19 FRAME & PARTS LESS RUNNING GEAR 125, 130, 185 & SAFE ZONE
46 1.20 FRAME RUNNING GEAR & PARTS 49HP 185
48 1.21 FRAME & PARTS LESS RUNNING GEAR 49HP 185
50 1.22 CANOPY & PARTS 125, 130 & 185
52 1.23 CANOPY & PARTS 125, 130 & 185 AUSTRALIA
54 1.24 CANOPY & PARTS 49HP 185
56 1.25 DECAL & PARTS
60 1.26 INSTRUMENT PANEL & PARTS
62 1.27 INSTRUMENT PANEL STANDARD GAUGE JD
64 1.28 INSTRUMENT PANEL FULL GAUGE JD
66 1.29 INSTRUMENT PANEL STANDARD GAUGE CAT
68 1.30 INSTRUMENT PANEL STANDARD GAUGE CAT WITH ESTOP
70 1.31 INSTRUMENT PANEL FULL GAUGE CAT
TABLE OF CONTENTS (CONTINUED)PAGE SECTION DESCRIPTION PAGE SECTION DESCRIPTION
72 1.32 INSTRUMENT PANEL FULL GAUGE CAT WITH ESTOP
74 1.33 INSTRUMENT PANEL STANDARD GAUGE CAT AUSTRALIA
76 1.34 OPTIONAL DUAL HOSE REELS & OILERS
78 1.35 OPTIONAL SINGLE HOSE REEL & OILERS
80 1.36 OPTIONAL SINGLE ONE PINT OILER
82 1.37 OPTIONAL OILER SEPARATOR
84 1.38 DRAWBAR INSTALLATION
86 1.39 OPTIONAL CANADIAN LIGHTS
88 1.40 OPTIONAL CRASH FRAME 125, 130 & 185
PARTS LIST
5
1.1 PROCEDURE FOR ORDERING PARTS Parts should be ordered from the nearest Sullair Representative or theRepresentative from whom the compressor was purchased. If for anyreason parts cannot be obtained in this manner, contact the factorydirectly at the address, phone numbers or email below.
When ordering parts always indicate the Serial Number of thecompressor. This can be obtained from the Bill of Lading for thecompressor or from the Serial Number Plate located on thecompressor. See Figure 1-1: Serial Plate / Serial Number Location.
The genuine Sullair service parts listed meet or exceed the demands ofthis compressor. Use of replacement parts other than those approvedby Sullair Corporation may lead to hazardous conditions over whichSullair Corporation has no control. Such conditions include, but are notlimited to, bodily injury and compressor failure.
SULLAIR CORPORATION3700 East Michigan Boulevard
Michigan City, Indiana 46360 U.S.Awww.sullair.com1-219-874-5451
Figure 1-1: Serial Plate / Serial Number Location
RECOMMENDED SERVICE PARTS LIST
6
1.2 RECOMMENDED SERVICE PARTS LIST
KEY NO. ORDER PART NO. QTY DESCRIPTION125, 130, 185 & 49HP 185 Models
1 02250102-158 2 Element, Primary for Air Filter
2 02250102-160 2 Element, Seconday for Air Filter (optional)
3 250028-032 1 Element for Compressor Fluid Filter
4 250034-112 1 Element for Air/Fluid Separator
5 02250153-904 1 Element for Engine Fuel/Water Separator
6 02250147-737 1 Repair kit for Regulator/Blowdown Valve Manifold
7 02250124-404 1 Element for Compressor Fluid Thermal Valve
8 241772 1 Repair Kit for Separator Return Line Strainer
9 02250115-271 1 Replacement , Air Filter Dust Ejector
10 02250139-986 1 Kit, Engine/Compressor Drive Coupling
11 02250138-090 1 Repair Kit for Compressor Inlet Valve 125,130 & 185
12 02250140-049 1 Element for Engine Oil Filter (Caterpillar)
13 02250144-815 1 Element for Engine Oil Filter (John Deere)
14 02250140-048 1 Element for Engine Fuel Filter (Caterpillar)
15 02250144-814 1 Element for Engine Fuel Filter (John Deere)
16 02250152-936 1 Kit, 50 Hour Maintenance
17 02250152-937 1 Kit, 250 Hour Maintenance (Caterpillar)
18 02250152-943 1 Kit, 250 Hour Maintenance (John Deere)
19 02250152-938 1 Kit, 1500 Hour Maintenance (Caterpillar)
20 02250152-944 1 Kit, 1500 Hour Maintenance (John Deere)
21 02250159-777 1 Switch, Compressor High Temperature Shutdown
22 02250139-887 1 Switch, High Coolant Temperature Shutdown (Caterpillar)
23 02250138-107 1 Switch, High Coolant Temperature Shutdown (John Deere)
24 02250130-668 1 Switch, Engine Low Oil Pressure Shutdown (Caterpillar)
PLEASE NOTE: WHEN ORDERING PARTS,INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
7
25 02250130-668 1 Switch, Engine Low Oil Pressure Shutdown (John Deere)
26 02250153-875 1 Relay, Engine Starter
27 02250144-353 1 Relay, Engine Glow Plug
28 02250155-383 1 Relay, Low Fuel Shutdown (Optional)
29 250030-757 1 Sullair AWF Fluid—5 Gallons (18.9 Liters)
30 250030-758 1 Sullair AWF Fluid—55 Gallon Drum (208 Liters)
31 250023-146 1 Manual, CIMA Safety
32 02250150-183 1 Kit, Regulator Manifold Diaphragm
33 02250145-097 1 Kit for Compressor Inlet Valve Rebuild 125, 130 & 185
34 02250155-970 1 Kit for Compressor Inlet Valve Rebuild 49hp 185
35 02250155-971 1 Kit for Compressor Inlet Valve Repair 49hp 185
KEY NO. ORDER PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS,INDICATE SERIAL NUMBER OF COMPRESSOR
CAUTIONMixing of other lubricants within the com-pressor unit will void all warranties.
ENGINE, COMPRESSOR & PARTS 125, 130 & 185 CAT
8
1.3 ENGINE, COMPRESSOR & PARTS 125, 130 & 185 CAT
02250176-218-R02
PARTS LIST
9
1.3 ENGINE, COMPRESSOR & PARTS 125, 130 & 185 CAT
KEY NO. PART NO. QTY DESCRIPTION
1 02250064-593 1 rod, threaded speed control 1/4-282 02250064-594 1 spacer, brake lever 250p3 02250071-119 1 adapter, sae #4 to 10 series4 02250099-622 1 elbow, 90 3/8”tube x 1/8”npt m5 02250112-337 1 spring, extension .31 x 7.5#/in6 02250125-471 6 washer, snubbing vibration mount7 02250125-472 4 mount, vibration isolator 1858 02250136-993 2 support, engine front ca 185dpq 60hp9 02250138-058 1 coupling, assy ktr 185dpq 60hp10 02250138-059 1 hub, coupling ktr 185dpq 60hp11 02250138-698 1 tee, male branch 3/8”tube x 1/8”npt12 02250139-762 1 hose,rad upper cat 185 60hp13 02250139-763 1 hose,rad lower cat 185 60hp14 02250139-888 8 capscrew, hex met fine m14-1.5x3015 02250139-916 1 support,fuel fltr perkins 185q16 02250142-248 1 valve,check 1/8 female - male17 02250148-573 1 spacer, fan 1.50 185 cat18 02250172-482 1 tabulation,speed control 185-260 ca/pe19 02250176-102 1 switch, engine sht dwn 235 n.c. 3/8npt20 02250176-103 1 support,spd ctl 185 cat t321 02250179-468 1 fan, 18” blower 185 ca322 040014 3 clamp, hose 1 5/16” to 2 1/4” adj.23 040083 1 clamp, hose 1 13/16” x 2 3/4” adj.24 250011-578 1 joint, ball female 1/4” l.h.25 250011-597 1 joint, ball female 1/4” r.h.26 250024-272 1 cylinder, speed 3/4 x 1 stroke27 408300-005 2 clamp, hose 5/8” i.d.28 408300-009 1 clamp, hose 1 13/16” i.d.
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
29 821206-150 1 key, square cl2 3/8” x 1 1/230 825206-337 2 nut,hex pltd 3/8-1631 825504-145 2 nut,hex locking 1/4-2032 825508-262 2 nut,hex locking 1/2-1333 828006-030 1 capscrew,hex 8.8 m6 x 30mm34 828006-065 4 capscrew,hex 8.8 m6 x 65mm35 828012-075 2 capscrew,hex 8.8 m12 x 75mm36 829106-125 19 capscrew,hex gr5 3/8-16 x 1 1/437 829106-450 2 capscrew,hex gr5 3/8-16 x 4 1/238 829108-325 2 capscrew,hex gr5 1/2-13 x 3 1/439 829310-020 8 screw, socket iso 4762 m10 x 20mm40 837806-094 14 washer, spr lock reg pltd 3/841 838206-071 4 washer, pl-b reg pltd 3/842 838208-112 2 washer, pl-b reg pltd 1/243 838806-160 4 washer, spr lock-metric pltd m644 866604-164 1 nut, hex jam lh pltd 1/4-2845 867304-150 1 capscrew, ferry head hd pltd 1/4-20 x 1 1/246 868204-164 2 nut, hex jam rh pltd 1/4-2847 878609-091 8 washer, nord-lock pl 9/16”48 CONSULT
FACTORY1 engine
49 CONSULT FACTORY
1 compressor & part,dxx102147e
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
ENGINE, COMPRESSOR & PARTS 49HP 185 CAT
10
1.4 ENGINE, COMPRESSOR & PARTS 49HP 185 CAT
02250193-123 R00
PARTS LIST
11
1.4 ENGINE, COMPRESSOR & PARTS 49HP 185 CAT
KEY NO. PART NO. QTY DESCRIPTION
1 02250064-593 1 rod, thrd speed control 1/4-282 02250064-594 1 spacer, brake lever 250p3 02250099-622 1 elbow, 90 3/8”tube x 1/8”npt m4 02250124-065 1 spg,ext 3.0lg 4.52lb/in .313od5 02250125-471 4 washer, snubbing vibration mount6 02250125-472 4 mount, vibration isolator 1857 02250136-993 2 supt, eng frt ca 185dpq 60hp8 02250138-058 1 coupling, assy ktr 185dpq 60hp9 02250138-698 1 tee,m br 3/8”tube x 1/8”npt10 02250139-762 1 hose, rad upper cat 185 60hp11 02250139-763 1 hose, rad lower cat 185 60hp12 02250139-888 8 capscr,hx met fine m14-1.5x3013 02250139-916 1 supt, fuel fltr perkins 185q14 02250142-248 1 vlv, check 1/8 female - male15 02250148-573 1 spacer, fan 1.50 185 cat16 02250160-636 1 angle, unit supt new 12s 260dpq17 02250172-482 1 tab, speed control 185-260 ca/pe18 02250176-102 1 sw, eng sht dwn 235 n.c. 3/8npt19 02250176-103 1 supt, spd ctl 185 cat t320 02250179-468 1 fan, 18” blower 185 ca321 027443 1 orf,.062 brass 1/4mnpt22 040014 3 clamp, hose 1 5/16” to 2 1/4” adj.23 040083 1 clamp, hose 1 13/16” x 2 3/4” adj.24 250011-578 1 joint, ball female 1/4” l.h.25 250011-597 1 joint, ball female 1/4” r.h.26 250018-430 1 elbow, 1/4” tube x 1/4” npt27 250024-272 1 cylinder, speed 3/4 x 1 stroke28 250034-403 1 housing, adapter (250034-402c)29 250041-287 1 elbow, 90d 1/4” tube x 1/4”fnpt30 408300-005 2 clamp, hose 5/8” i.d.31 408300-009 1 clamp, hose 1 13/16” i.d.32 825206-337 1 nut, hex pltd 3/8-1633 825504-145 2 nut, hex locking 1/4-2034 825508-262 4 nut, hex locking 1/2-13
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
35 828006-065 4 capscr, hex 8.8 m6 x 65mm36 828012-025 2 capscr, hex 8.8 m12 x 25mm37 828012-030 10 capscr, hex 8.8 m12 x 30mm38 829106-125 12 capscr, hex gr5 3/8-16 x 1 1/439 829106-450 1 capscr, hex gr5 3/8-16 x 4 1/240 829108-325 4 capscr, hex gr5 1/2-13 x 3 1/441 829310-020 8 scrw, soc iso 4762 m10 x 20mm42 837806-094 13 washer, spr lock reg pltd 3/843 838206-071 2 washer, pl-b reg pltd 3/844 838208-112 4 washer, pl-b reg pltd 1/245 838806-160 4 washer, spr lock-metric pltd m646 866604-164 1 nut, hx jam lh pltd 1/4-2847 867304-100 1 capscr, ferry hd pltd 1/4-20 x 148 867304-150 1 capscr, ferry hd pltd 1/4-20 x 1 1/249 868204-164 2 nut, hx jam rh pltd 1/4-2850 868900-005 1 bushing, red hex pltd 1/4 x 1/851 878608-077 2 washer, nord-lock pl 1/2”52 878609-091 8 washer, nord-lock pl 9/16”53 888833-016 1 elb,met st thd m33 x 1 5/1654 888916-075 1 conn,37 fl 1”m x 3/4”f55 CONSULT
FACTORY1 unit, compressor 12s
56 CONSULT FACTORY
1 eng, dsl cat
A1 - lower radiator hose connectionA2 - upper radiator hose connectionA3 - hub p/n 02250195-135 is supplied with compressor unit.A4 - use loc-tite 242 on items 35, 37 & 41
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
ENGINE, COMPRESSOR & PARTS 125, 130 & 185 JD
12
1.5 ENGINE, COMPRESSOR & PARTS 125, 130 & 185 JD
02250161-144-R03
PARTS LIST
13
1.5 ENGINE, COMPRESSOR & PARTS 125, 130 & 185 JD
KEY NO. PART NO. QTY DESCRIPTION
1 02250064-594 2 spacer, brake lever 250p 2 02250071-119 1 adapter, sae #4 to 10 series3 02250099-622 1 elbow, 90 3/8”tube x 1/8”npt m4 02250125-471 6 washer, snubbing vibration mount5 02250125-472 4 mount, vibration isolator 1856 02250138-107 1 switch,engine hi-temp, 225f nc7 02250138-698 1 tee, male branch 3/8”tube x 1/8”npt8 02250139-986 1 coupling, assembly ktr w/hub 185q 60hp9 02250142-248 1 valve,check 1/8 female - male
10 02250143-547 1 support, engine front rh 185jd 60hp11 02250143-548 1 support, engine front lh 185jd 60hp12 02250143-579 1 hose,radiator upper 185jd 60hp13 02250143-580 1 hose,radiator lower 185jd 60hp14 02250148-086 1 rod,speed ctl 185dpq jd15 02250148-089 1 cylinder, speed air 1-1/16 bore 1’ stk16 02250148-091 1 support, low rpm stop 185 jd17 02250148-166 1 spring, extension spd ctl 185 jd18 02250148-791 1 valve, eng oil drain m22x1.519 02250152-418 1 clip,spring spd ctl 185-26020 02250152-439 1 support,spd ctl 185-260 jd21 02250161-100 1 spacer, fan 125-185jd hd drv22 02250161-101 1 fan, 18” blr 125-185 jd hd drv23 02250166-052 1 shield, alternator 185-260jd24 040014 1 clamp, hose 1 5/16” to 2 1/4” adj.25 040083 3 clamp, hose 1 13/16” x 2 3/4” adj.26 040136 1 rod end, spherical rh 5/1627 040513 1 clamp, hose 13/16” to 1-1/2”28 250011-578 1 joint, ball female 1/4” l.h. 29 408300-005 2 clamp, hose 5/8” i.d. 30 408300-009 1 clamp, hose 1 13/16” i.d. -
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
31 821206-150 1 key, square cl2 3/8” x 1 1/232 824605-195 1 nut,jam rh unfin 5/16-2433 825204-226 1 nut,hex pltd 1/4-2034 825305-283 1 nut,hex f pltd 5/16-1835 825504-145 2 nut,hex locking 1/4-2036 825508-262 2 nut,hex locking 1/2-1337 828008-020 3 capscrew,hex 8.8 m8 x 20mm38 828008-120 4 capscrew,hex 8.8 m8 x 120mm39 828010-035 12 capscrew,hex 8.8 m10 x 35mm40 828012-075 2 capscrew,hex 8.8 m12 x 75mm41 828016-035 4 capscrew,hex 8.8 m16 x 35mm42 828306-075 8 capscrew, socket hd 3/8-16 x 3/443 829104-100 1 capscrew,hex gr5 1/4-20 x 144 829106-125 8 capscrew,hex gr5 3/8-16 x 1 1/445 829108-325 2 capscrew,hex gr5 1/2-13 x 3 1/446 829705-100 1 screw, hex ser washer 5/16-18 x 147 838205-071 3 washer, pl-b reg pltd 5/1648 838208-112 2 washer, pl-b reg pltd 1/249 838808-200 6 washer, spr lock-metric pltd m850 838810-220 12 washer, spr lock-metric pltd m1051 842115-062 1 hose,heater 5/8 (ft)52 866604-164 1 nut, hex jam lh pltd 1/4-2853 867304-150 2 capscrew, ferry head hd pltd 1/4-20 x 1 1/254 868204-164 1 nut, hex jam rh pltd 1/4-2855 878610-100 4 washer, nord-lock pl 5/8”56 Consult Factory 1 engine, jd 4024t 60hp 185dpq57 Consult Factory 1 compressor & part,dxx102147e
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
ENGINE, COMPRESSOR & PARTS 49HP 185 JD
14
1.6 ENGINE, COMPRESSOR & PARTS 49HP 185 JD
02250193-124-R00
PARTS LIST
15
1.6 ENGINE, COMPRESSOR & PARTS 49HP 185 JD
KEY NO. PART NO. QTY DESCRIPTION
1 02250064-594 2 spacer, brake lever 250p2 02250099-622 1 elbow, 90 3/8”tube x 1/8”npt m3 02250125-471 4 washer, snubbing vibration mount4 02250125-472 4 mount, vibration isolator 1855 02250138-058 1 coupling, assy ktr 185dpq 60hp6 02250138-107 1 sw,engine hi-temp, 225f nc7 02250138-698 1 tee,m br 3/8”tube x 1/8”npt8 02250142-248 1 vlv, check 1/8 female - male9 02250143-547 1 supt, eng frt rh 185jd 60hp10 02250143-548 1 supt, eng frt lh 185jd 60hp11 02250143-579 1 hose, radiator upper 185jd 60hp12 02250143-580 1 hose, radiator lower 185jd 60hp13 02250148-086 1 rod, speed ctl 185dpq jd14 02250148-089 1 cylinder, speed air 1-1/16 bore 1’ stk15 02250148-091 1 support, low rpm stop 185 jd16 02250148-166 1 spg, ext spd ctl 185 jd17 02250148-791 1 valve, eng oil drain m22x1.518 02250152-418 1 clip, spring spd ctl 185-26019 02250152-439 1 supt,spd ctl 185-260 jd20 02250160-636 1 angle, unit supt new 12s 260dpq21 02250161-100 1 spcr,fan 125-185jd hd drv22 02250161-101 1 fan, 18” blr 125-185 jd hd drv23 02250166-052 1 shield, alternator 185-260jd24 027443 1 orf,.062 brass 1/4mnpt25 040014 1 clamp, hose 1 5/16” to 2 1/4” adj.26 040083 3 clamp, hose 1 13/16” x 2 3/4” adj.27 040136 1 rod end, spherical rh 5/1628 040513 1 clamp, hose 13/16” to 1-1/2”29 250011-578 1 joint, ball female 1/4” l.h.30 250018-430 1 elbow, 1/4” tube x 1/4” npt31 250034-403 1 housing, adapter (250034-402c)32 250041-287 1 elbow, 90d 1/4” tube x 1/4”fnpt33 408300-005 3 clamp, hose 5/8” i.d.34 408300-009 1 clamp, hose 1 13/16” i.d.35 824605-195 1 nut, jam rh unfin 5/16-2436 825204-226 1 nut, hex pltd 1/4-20
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
37 825305-283 1 nut, hex f pltd 5/16-1838 825504-145 2 nut, hex locking 1/4-2039 825508-262 4 nut, hex locking 1/2-1340 828008-020 3 capscr, hex 8.8 m8 x 20mm41 828008-120 4 capscr, hex 8.8 m8 x 120mm42 828012-025 2 capscr, hex 8.8 m12 x 25mm43 828012-030 10 capscr, hex 8.8 m12 x 30mm44 828016-035 4 capscr, hex 8.8 m16 x 35mm45 828306-075 8 capscr, soc hd 3/8-16 x 3/446 829104-100 1 capscr, hex gr5 1/4-20 x 147 829106-125 12 capscr, hex gr5 3/8-16 x 1 1/448 829108-325 4 capscr, hex gr5 1/2-13 x 3 1/449 829705-100 1 screw, hex ser washer 5/16-18 x 150 837806-094 12 washer, spr lock reg pltd 3/851 838205-071 3 washer, pl-b reg pltd 5/1652 838208-112 4 washer, pl-b reg pltd 1/253 838808-200 6 washer, spr lock-metric pltd m854 842115-062 2 hose, heater 5/8 (ft)55 866604-164 1 nut, hx jam lh pltd 1/4-2856 867304-100 1 capscr, ferry hd pltd 1/4-20 x 157 867304-150 1 capscr, ferry hd pltd 1/4-20 x 1 1/258 868204-164 1 nut, hx jam rh pltd 1/4-2859 868900-005 1 bushing, red hex pltd 1/4 x 1/860 878608-077 2 washer, nord-lock pl 1/2”61 878610-100 4 washer, nord-lock pl 5/8”62 888833-016 1 elb,met st thd m33 x 1 5/1663 888916-075 1 conn,37 fl 1”m x 3/4”f
64 CONSULT FACTORY 1 unit, compressor 12s
65 CONSULT FACTORY 1 engine, jd 4024t 49hp 185dpq
A1 - lower radiator hose connectionA2 - upper radiator hose connectionA3 - hub p/n 02250195-135 is supplied with compressor unit.A4 - use loc-tite 242 on items 41, 43 & 45
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
AIR INLET & EXHAUST 125, 130, 185 & 49HP 185 CAT
16
1.7 AIR INLET & EXHAUST 125, 130, 185 & 49HP 185 CAT
02250141-018-R09
PARTS LIST
17
1.7 AIR INLET & EXHAUST 125, 130, 185 & 49HP 185 CAT
KEY NO. PART NO. QTY DESCRIPTION
1 02250084-842 1 clamp, t-bolt ss band 4.50”id
2 02250106-068 1 plug,4” round black plastic
3 02250109-423 1 elbow, 90m 5/16”tube x 1/8”npt
4 02250110-197 1 filter, air plastic strt inl
5 02250136-929 1 support, air fltrs 185dpq 60hp
6 02250136-931 1 hose, air inl unit 186dpq 60hp
7 02250136-942 1 muffler,jd cat 185dpq 60hp
8 02250136-995 1 support,muff cat 185dpq 60hp
9 02250136-996 1 tube, exhaust outlet cat 185 60hp
10 02250136-997 1 tube, exhaust inlet cat 185 60hp
11 02250139-771 1 shield, heat exhaust 185q cat
12 02250140-051 1 adapter, air inlet eng.breath 185ca
13 02250140-440 1 filter, air 7” plstc 90 non cint.
14 02250140-875 1 hose, air inl fltr 185q 60hp
15 02250140-876 1 hose, air inlet eng 185q 60hp
16 02250147-925 1 tube,engine vent 185dpq pe
17 02250148-054 1 clamp, hose spring 3/4 od ss
18 02250157-075 1 baffle, frm low frt 185 dlq
19 02250157-090 1 elbow,exh outlet cat 185dlq
20 02250158-022 1 baffle, air exhst frt 185dlq
21 02250185-476 1 hose,compr inl 185 w/12s unit
22 040083 3 clamp, hose 1 13/16” x 2 3/4” adj.
23 043203 2 clamp, exhaust 2-1/2”
24 043370 2 band, mounting 6 1/2”
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 250018-550 3 clamp, hose 2-13/16 to 3-3/4”
26 825305-283 13 nut,hex f pltd 5/16-18
27 825506-198 2 nut,hex locking 3/8-16
28 828008-020 8 capscrew,hex 8.8 m8 x 20mm
29 829106-100 2 capscrew,hex gr5 3/8-16 x 1
30 829705-075 11 screw, hex ser washer 5/16-18 x 3/4
31 830104-250 1 screw, mach-hex 1/4-20 x 2 1/2
32 838205-071 4 washer, pl-b reg pltd 5/16
33 838808-200 8 washer, spr lock-metric pltd m8
34 842115-050 1 hose,heater 1/2” (ft)
A1 - less running gear machines only
A2 - portable machines only
A3 - to 185 unit air inlet valve
A4 - to 49hp 185 unit air inlet valve
A5 - to engine air inlet connection
A6 - to engine exhaust outlet
A7 - mounted at lifting bail
A8 - to unused exhaust outlet hole
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
EXHAUST 125, 130, 185 & 49HP 185 CAT & SAFE ZONE
18
1.8 EXHAUST 125, 130, 185 & 49HP 185 CAT & SAFE ZONE
02250184-254 R00
PARTS LIST
19
1.8 EXHAUST 125, 130, 185 & 49HP 185 CAT & SAFE ZONE
KEY NO. PART NO. QTY DESCRIPTION
1 02250136-942 1 muffler,jd cat 185dpq 60hp
2 02250136-995 1 support,muff cat 185dpq 60hp
3 02250136-997 1 tube, exhaust inlet cat 185 60hp
4 02250139-771 1 shield, heat exhaust 185q cat
5 02250175-953 1 panel, hi temp mat 185 dtz muff
6 02250184-040 1 strap,spk arsr 185bdlq safezne
7 02250184-048 1 elbow, exhaust 90deg extended 185bdlq
8 041992 2 clamp, hose 7”
9 043203 3 clamp, exhaust 2-1/2”
10 043370 2 band, mounting 6 1/2”
11 241135 1 arrestor, spark 10p epa 185
12 825305-283 6 nut,hex f pltd 5/16-18
13 825506-198 2 nut,hex locking 3/8-16
14 828008-020 4 capscrew,hex 8.8 m8 x 20mm
15 829106-100 2 capscrew,hex gr5 3/8-16 x 1
16 829705-075 4 screw, hex ser washer 5/16-18 x 3/4
17 838808-200 4 washer, spr lock-metric pltd m8
18 879505-283 2 nut,hex flgd ss 5/16-18
19 880305-071 2 washer, plug b reg ss 5/16”
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
21
1.9 AIR INLET & EXHAUST 125, 130 & 185 JD
KEY NO. PART NO. QTY DESCRIPTION
1 02250109-423 1 elbow, 90m 5/16”tube x 1/8”npt
2 02250136-929 1 support, air fltrs 185dpq 60hp
3 02250136-931 1 hose, air inl unit 186dpq 60hp
4 02250136-942 1 muffler,jd cat 185dpq 60hp
5 02250136-943 1 tube, exhaust outlet 185dpq 60hp
6 02250137-896 1 clamp, v-band jd 4024t 185dpq
7 02250140-440 2 filter, air 7” plstc 90 non cint.
8 02250143-583 1 support,muffler jd 185dpq 60hp
9 02250143-584 1 hose, air inl jd 185dpq 60hp
10 02250143-585 1 tube, exhaust inlet 185dpq jd 60hp
11 02250146-699 1 support, air filter 185 dpq jd eng
12 02250147-977 1 shield, heat muffler top 185jd
13 02250156-122 1 shield, muffler frt mnt 185q jd
14 02250157-075 1 baffle, frm low frt 185 dlq
15 02250157-081 1 elbow ,exh outlet 185dlq jd
16 02250157-082 1 tube,exhaust flex 185dlq jd
17 02250157-085 1 angle, exhst supt 185dlq jd
18 02250158-022 1 baffle, air exhst frt 185dlq
19 02250160-099 1 shield, heat 185dpq jd wiring
20 02250175-954 1 plate, ole cover 185 jd frm
21 040083 1 clamp, hose 1 13/16” x 2 3/4” adj.
22 043203 4 clamp, exhaust 2-1/2”
23 043370 2 band, mounting 6 1/2”
24 250018-550 3 clamp, hose 2-13/16 to 3-3/4”
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 825304-236 2 nut,hex f pltd 1/4-20
26 825305-283 12 nut,hex f pltd 5/16-18
27 825908-125 2 nut,hex metric m8 x 1.25
28 828008-020 6 capscrew,hex 8.8 m8 x 20mm
29 828012-030 4 capscrew,hex 8.8 m12 x 30mm
30 829704-075 2 screw, hex ser washer 1/4-20 x 3/4
31 829705-075 14 screw, hex ser washer 5/16-18 x 3/4
32 830104-250 2 screw, mach-hex 1/4-20 x 2 1/2
33 838205-071 8 washer, pl-b reg pltd 5/16
34 838808-200 6 washer, spr lock-metric pltd m8
35 838812-250 4 washer, spr lock-metric pltd m12
36 865412-240 4 washer, metric-iso7089- 12
37 866900-005 1 plug, pipe 1/8” 3000# stl plt
A1 - less running gear machines only
A2 - portable machines only
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
23
1.10 EXHAUST SYSTEM 49HP 185 JD
KEY NO. PART NO. QTY DESCRIPTION
1 02250084-842 1 clamp, t-bolt ss band 4.50”id
2 02250106-068 1 plug, 4” round black plastic
3 02250109-423 1 elbow, 90m 5/16”tube x 1/8”npt
4 02250136-929 1 supt, air fltrs 185dpq 60hp
5 02250136-942 1 muf, jd cat 185dpq 60hp
6 02250136-943 1 tube,exh outlet 185dpq 60hp
7 02250137-896 1 clp,v-band jd 4024t 185dpq
8 02250140-440 2 filter, air 7” plstc 90 non cint.
9 02250143-584 1 hose, air inl jd 185dpq 60hp
10 02250146-699 1 support, air filter 185 dpq jd eng
11 02250156-122 1 shield, muffler frt mnt 185q jd
12 02250157-075 1 baffle, frm low frt 185 dlq
13 02250157-081 1 elbow ,exh outlet 185dlq jd
14 02250157-085 1 angle, exhst supt 185dlq jd
15 02250158-022 1 baffle, air exhst frt 185dlq
16 02250160-099 1 shield, heat 185dpq jd wiring
17 02250185-476 1 hose, compr inl 185 w/12s unit
18 02250191-957 1 supt, muffler 185jd/12s
19 02250191-958 1 tube,exhst 185jd/12s
20 02250191-959 1 tube, exhst 185dlqjd/12s
21 02250191-960 1 shield, muffler top 185jd/12s
22 040083 1 clamp, hose 1 13/16” x 2 3/4” adj.
23 043203 4 clamp, exhaust 2-1/2”
24 043370 2 band, mounting 6 1/2”
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 250018-550 2 clamp, hose 2-13/16 to 3-3/4”
26 825304-236 2 nut, hex f pltd 1/4-20
27 825305-283 15 nut, hex f pltd 5/16-18
28 825908-125 2 nut, hex metric m8 x 1.25
29 828008-020 6 capscr, hex 8.8 m8 x 20mm
30 828012-030 4 capscr, hex 8.8 m12 x 30mm
31 829704-075 2 screw, hex ser washer 1/4-20 x 3/4
32 829705-075 17 screw, hex ser washer 5/16-18 x 3/4
33 830104-250 2 screw, mach-hex 1/4-20 x 2 1/2
34 838205-071 6 washer, pl-b reg pltd 5/16
35 838808-200 6 washer, spr lock-metric pltd m8
36 838812-250 4 washer, spr lock-metric pltd m12
37 865412-240 4 washer, metric-iso7089- 12
38 866900-005 1 plug, pipe 1/8” 3000# stl plt
A1 - to unit air inlet valve.
A2 - mounted at engine flywheel housing
A3 - mounted at lifting bail
A4 - John Deer engine turbo charger
A5 - less running gear machines only
A6 - portable machines only
A7 - to unused exhaust outlet hole
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
AIR INLET 125, 130, 185 & 49HP 185 CAT SAFE ZONE
24
1.11 AIR INLET 125, 130, 185 & 49HP 185 CAT SAFE ZONE
02250184-256 R00
PARTS LIST
25
1.11 AIR INLET 125, 130, 185 & 49HP 185 CAT SAFE ZONE
KEY NO. PART NO. QTY DESCRIPTION
1 02250109-423 1 elbow, 90m 5/16”tube x 1/8”npt
2 02250110-197 1 filter, air plastic strt inl
3 02250136-929 1 support, air fltrs 185dpq 60hp
4 02250136-931 1 hose, air inl unit 186dpq 60hp
5 02250140-440 1 filter, air 7” plstc 90 non cint.
6 02250148-054 4 clamp, hose spring 3/4 od ss
7 02250183-830 1 hose, air inlet fltr 185dlq
8 02250183-831 1 tube, engine vent 185dlq safe zone
9 02250183-832 2 hose, reducing 1 3/4x2 1/4x2lg
10 02250183-877 1 elbow,air inl eng breath 185dlq
11 02250183-894 1 valve, air stop 2.25”
12 040083 5 clamp, hose 1 13/16” x 2 3/4” adj.
13 250018-550 3 clamp, hose 2-13/16 to 3-3/4”
14 825305-283 3 nut,hex f pltd 5/16-18
15 828008-020 4 capscrew,hex 8.8 m8 x 20mm
16 829705-075 3 screw, hex ser washer 5/16-18 x 3/4
17 838808-200 4 washer, spr lock-metric pltd m8
18 842115-050 2 hose,heater 1/2” (ft)
A1 - to compressor
A2 - to engine
A3 - to engine vent
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
27
1.12 COOLING SYSTEM & PARTS (CONTINUED)
KEY NO. PART NO. QTY DESCRIPTION
1 02250083-466 1 bucket,radiator fluid recovery2 02250086-448 2 channel, extruded rubber “u” .25”w (ft)3 02250107-493 1 hose,hydparkrimp 3/4” x 72”4 02250108-406 1 hose,fuel 3/4” x 50” 375dpq5 02250112-141 1 guard, fan 20” (110-130 & 185 cat)6 02250124-404 1 element, therm vlv 160deg setting7 02250132-254 1 manifold, thrm by-pass 185 bdr8 02250132-260 1 support,manf thrm vlv 185 60hp9 02250136-539 1 receiver, air oil 10” 185 60hp
10 02250136-929 1 support, air fltrs 185dpq 60hp11 02250137-297 12 seal,clip-on baffles 185 60hp12 02250139-755 1 baffle, cooler r.h. 185dpq ca 60hp13 02250139-756 1 baffle, cooler l.h. 185dpq ca 60hp14 02250139-757 1 baffle, cooler upper 185dpq ca 60hp15 02250139-758 1 baffle, cooler lower 185dpq ca 60hp16 02250139-760 1 radiator,185dpq ca 60hp17 02250139-761 1 cooler, oil blower 185dpq 60hp18 02250139-768 1 support, cooler rad 185dpq ca 60hp19 02250139-775 1 hose, hydraulic parkrimp 3/4 x 2420 02250139-776 1 hose, hydraulic parkrimp 3/4 x 3221 02250140-186 1 guard, fan 185q 60hp22 02250140-228 1 shroud, fan 18” dia 185q 60hp cat23 02250143-581 1 shroud, fan 18” 185jd 60hp24 02250179-908 2 wrap,sprial hose 1” id blk25 02250180-201 1 panel, acst 2” top clr baf 18526 02250191-908 1 support, air cooler l-brkt l.s,185 dpq27 02250191-909 1 support, air cooler l-brkt r.s,185 dpq28 02250191-910 2 support,cooler baffle l-brkt,185 dpq
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
29 040061 1 drainlock, 1/4”30 040162 1 grommet,rubber 1” hole31 047235 2 clamp, hose 3/8”32 250025-914 1 adapter, oil filter .970-20 x 3/4-1633 250026-982 1 element, fluid filter (ref 250025-523 tab)34 250041-174 6 weatherstrip, 1”thick x 1”wide (ft)35 250042-623 1 plug,str thd 3/4-16 sae vit36 408300-005 1 clamp, hose 5/8” i.d.37 408300-009 1 clamp, hose 1 13/16” i.d.38 408300-010 1 clamp, hose 2 3/8” i.d.39 825304-236 20 nut,hex f pltd 1/4-2040 825305-283 35 nut,hex f pltd 5/16-1841 825504-145 1 nut,hex locking 1/4-2042 826502-218 1 o-ring, viton 1 1/4 x 1/8”43 829106-075 2 capscrew,hex gr5 3/8-16 x 3/444 829704-075 20 screw, hex ser washer 1/4-20 x 3/445 829705-075 21 screw, hex ser washer 5/16-18 x 3/446 829705-100 15 screw, hex ser washer 5/16-18 x 147 837806-094 2 washer, spr lock reg pltd 3/848 838204-071 20 washer, pl-b reg pltd 1/449 838205-071 43 washer, pl-b reg pltd 5/16
Continued on page 29
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
29
1.12 COOLING SYSTEM & PARTS
KEY NO. PART NO. QTY DESCRIPTION
51 842315-025 4 hose,fuel line 1/4 (ft)
52 842315-031 1 hose,fuel line 5/16 (ft)
53 870016-012 1 reducer,str thrd viton 1 x 3/4
54 870112-012 5 connector, straight x jic 1 1/16 x 1 1/16
55 870612-012 3 connector,90d str x jic 1 1/16 x 1 1/16
56 871800-106 1 tee, straight thd m-rn viton 1 1/16”
A1 - John Deere only
A2 - Caterpillar only
A3 - 49hp 185 only
A4 - to unit oil supply
A5 - route out bottom of frame
A6 - 49hp 185 wrap hose near 12s unit
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
31
1.13 DISCHARGE SYSTEM 125, 130 & 185 (CONTINUED)
KEY NO. PART NO. QTY DESCRIPTION
1 02250052-841 4 insert, nylon tubing 1/4”od
2 02250054-860 2 tube,nyl .25 od x 040w wht(ft)
3 02250054-861 2 tube,nyl .25 od x .040w blk (ft)
4 02250081-220 1 tube,5/16 od x .040 wall
5 02250083-049 1 valve,1-1/4” npt min press chk
6 02250097-138 1 conn, female pipe 1/8-27 npt
7 02250097-611 1 plug,sight glass 1-7/8” sae
8 02250099-052 5 insert, nyl tubing 3/8”od
9 02250099-622 1 elbow, 90 3/8”tube x 1/8”npt m
10 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
11 02250108-700 1 connector, tube oil return 1/4 x 1/4
12 02250109-215 1 orifice, .040” x .25m x .25m nptf
13 02250114-091 1 tube, oil siphon 1/4”od 110-185
14 02250134-143 1 panel, frame frt 185dpq 60hp
15 02250139-756 1 baffle, cooler l.h. 185dpq ca 60hp
16 02250139-774 1 hose, hydraulic parkrimp 1-1/4 x 18
17 02250139-778 1 hose, hydraulic parkrimp 1” x 72lg
18 02250139-950 1 tbg, nylon 3/8”od red
19 02250139-951 1 tbg, nylon 3/8”od yellow
20 02250139-952 1 tbg ,nylon 3/8”od green
21 02250139-953 2 tbg, nylon 3/8”od blue
22 02250139-954 1 tbg, nylon 3/8”od orange
23 02250140-184 1 frame assembly, 185q 60hp
24 02250140-185 1 bumper,baffle 185q 60hp
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 02250142-248 1 valve,check 1/8 female - male
26 02250142-844 1 valve, drain 1-1/16-12unf o-ring
27 02250144-503 1 support, rec tank 185q
28 02250148-203 1 sub assembly,manf regulator-blowdown 185
29 02250159-777 1 switch, temp n.c. 250°f, single pole
30 02250174-721 1 tank,receiver air/oil 185p
31 040029 1 plug,o-ring boss sae 1 1/4
32 040127 1 orifice,ctl .062 1/8 fnpt x 1/8 mnpt
33 040383 2 coupling, 3/4” female npt
34 040513 1 clamp, hose 13/16” to 1-1/2”
35 241771 1 strainer, v-type 300psix1/4
36 250006-938 1 valve,pressure relief 200 psig
37 250018-428 1 connector,1/4”tube x 1/4”npt
38 250018-429 1 elbow, 90 1/4”tube x 1/8”npt -
39 250019-916 1 valve, double ball 3/4” x 1”
Continued on page 33
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
DISCHARGE SYSTEM 125, 130 & 185
32
1.13 DISCHARGE SYSTEM 125, 130 & 185 (CONTINUED)
02250140-633-R11
PARTS LIST
33
1.13 DISCHARGE SYSTEM 125, 130 & 185
KEY NO. PART NO. QTY DESCRIPTION
40 250034-143 1 element,sep-fin 10 25/30
41 250041-084 1 connector,fem 1/4t x 1/4 npt
42 810204-025 1 connector, tube-m 1/4 x 1/4
43 825304-236 4 nut,hex f pltd 1/4-20
44 825505-166 1 nut,hex locking 5/16-18
45 825506-198 1 nut,hex locking 3/8-16
46 829106-125 1 capscrew,hex gr5 3/8-16 x 1 1/4
47 829704-100 2 screw, hex ser washer 1/4-20 x 1
48 829705-100 1 screw, hex ser washer 5/16-18 x 1
49 838204-071 4 washer, pl-b reg pltd 1/4
50 838205-071 1 washer, pl-b reg pltd 5/16
51 838206-071 2 washer, pl-b reg pltd 3/8
52 842115-075 1 hose,heater 3/4 (ft)
53 860016-100 1 elbow, 37fl 45m 1 x 1
54 860116-100 1 connector,37 fl/mpt pltd 1 x 1
55 866416-020 2 nipple,pipe-xs plt 1 x 2
56 866416-040 1 nipple,pipe-xs plt 1 x 4
57 867030-040 1 elbow, pipe 90 deg 300# plt 1”
58 867105-040 2 bushing,red pltd 1 1/4 x 1
59 870024-020 1 reducer,str thrd viton 1 1/2 x 1 1/4
60 870112-012 1 connector, straight x jic 1 1/16 x 1 1/16
61 870620-020 2 connector,90d str x jic 1 5/8 x 1 5/8
62 871800-106 1 tee, straight thd m-rn viton 1 1/16”
63 877202-012 1 adapter, pipe male 7/16 orng x 1/8
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
64 Consult Factory 1 compressor consult factory
A - shown 3/8” od tubing blue
B - to start run valve (end-tee) 3/8” od tubing red
C - shown 1/4” od tubing white
D - to start run valve (side) 3/8” od tubing orange
E - to speed cylinder 3/8” od tubing yellow
F - to speed cylinder 3/8” od tubing green
G - to unit air filter 5/16” od tubing white
H - shown 1/4” od tube black
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
35
1.14 DISCHARGE SYSTEM 49HP 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250052-841 3 insert, nylon tubing 1/4”od2 02250054-860 2 tube,nyl .25 od x 040w wht(ft)3 02250054-861 3 tube, nyl .25 od x .040w blk (ft)4 02250081-220 5 tube, 5/16 od x .040 wall5 02250083-049 1 vlv, 1-1/4” npt min press chk6 02250097-611 1 plug, sight glass 1-7/8” sae7 02250099-052 5 insert, nyl tubing 3/8”od8 02250099-622 1 elbow, 90 3/8”tube x 1/8”npt m9 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m10 02250108-700 1 connector, tube oil return 1/4 x 1/411 02250139-778 1 hose, hydraulic parkrimp 1” x 72lg12 02250139-950 4 tbg, nylon 3/8”od red13 02250139-951 2 tbg, nylon 3/8”od yellow14 02250139-952 2 tbg ,nylon 3/8”od green15 02250139-953 5 tbg, nylon 3/8”od blue16 02250139-954 4 tbg, nylon 3/8”od orange17 02250142-248 1 valve,check 1/8 female - male18 02250142-844 1 valve, drain 1-1/16-12unf o-ring19 02250144-503 1 support, rec tank 185q20 02250148-203 1 sub assembly,manf regulator-blowdown 18521 02250152-810 1 flange, kit sae split 2” m12-1.75 bolt22 02250174-721 1 tank,receiver air/oil 185p 0-ring23 02250192-569 1 hose, medium pressure 1.38id x 15” oal24 02250193-120 1 switch, nc 250f pole25 027443 1 orifice,.062 brass 1/4mnpt26 040029 1 plug,o-ring boss sae 1 1/427 040127 1 orifice,ctl .062 1/8 fnpt x 1/8 mnpt28 040383 2 coupling, 3/4” female npt29 040513 1 clamp, hose 13/16” to 1-1/2”30 241771 1 strainer, v-type 300psix1/431 250004-043 1 tube,ss 1/4”od oil siphon 18532 250006-938 1 valve,pressure relief 200 psig33 250018-428 1 connector,1/4”tube x 1/4”npt34 250018-430 1 elbow, 1/4” tube x 1/4” npt35 250019-916 1 valve, double ball 3/4” x 1”36 250034-143 1 element,sep-fin 10 25/30
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
37 250041-287 1 elbow, 90d 1/4” tube x 1/4”fnpt38 810204-025 1 connector, tube-m 1/4 x 1/439 825304-236 4 nut,hex f pltd 1/4-2040 825505-166 2 nut,hex locking 5/16-1841 825506-198 3 nut,hex locking 3/8-1642 829106-125 3 capscrew,hex gr5 3/8-16 x 1 1/443 829704-100 2 screw, hex ser washer 1/4-20 x 144 829705-100 2 screw, hex ser washer 5/16-18 x 145 838204-071 4 washer, pl-b reg pltd 1/446 838205-071 2 washer, pl-b reg pltd 5/1647 838206-071 6 washer, pl-b reg pltd 3/848 842115-075 1 hose,heater 3/4 (ft)49 860016-100 1 elbow, 37fl 45m 1 x 150 860116-100 1 connector,37 fl/mpt pltd 1 x 151 866416-020 2 nipple,pipe-xs plt 1 x 252 866416-080 1 nipple,pipe-xs plt 1 x 853 867030-040 1 elbow, pipe 90 deg 300# plt 1”54 867105-040 2 bushing,red pltd 1 1/4 x 155 868900-005 1 bushing,red hex pltd 1/4 x 1/856 870112-012 1 connector, straight x jic 1 1/16 x 1 1/1657 870620-024 1 connector,90d str x jic 1 7/8 x 1 5/858 871800-106 1 tee, straight thd m-rn viton 1 1/16”59 878312-106 1 elbow, female str thd 1 1/16
A1 - HOSE FROM THERMO-VALVE. SEE COOLING SYSTEM AA - SHOWN 3/8” OD TUBING BLUEBB - TO START RUN VALVE (END-TEE) 3/8” OD TUBING REDCC - SHOWN 1/4” OD TUBING WHITEDD - TO START RUN VALVE (SIDE) 3/8” OD TUBING ORANGEEE - TO SPEED CYLINDER 3/8” OD TUBING YELLOWFF - FROM SPEED CYLINDER 3/8” OD TUBING GREENGG - TO UNIT AIR FILTER 5/16” OD TUBING WHITE
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
37
1.15 MANIFOLD REGULATOR/BLOWDOWN
KEY NO. PART NO. QTY DESCRIPTION
1 02250081-218 1 elbow, 90d 5/16” tube x 1/4”npt
2 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
3 02250129-957 1 connector,3/8tube x 1/2npt
4 02250148-188 2 connector,3/8 tube x 1/4npt
5 02250148-190 1 support, manifold reg. bd 185q
6 02250151-201 0 manifold, press reg/bd 150psi 185h
7 250018-430 1 elbow, 90 1/4t pls x 1/4 npt m
8 829706-050 2 screw, hex ser washer 3/8-16 x 1/2
9 838206-071 2 washer, pl-b reg pltd 3/8
10 860404-025 1 nipple,pipe-hex 1/4 x 1/4
11 866815-010 1 tee, pipe 150# plt 1/4
Reference:
sub-assembly p/n 02250148-203
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
39
1.16 FUEL SYSTEM JD & CAT
KEY NO. PART NO. QTY DESCRIPTION
1 02250075-714 2 adapter,1/2str oring x 1/4 fnpt
2 02250102-573 1 tube,fuel return 1/4” jd 185q
3 02250108-700 1 connector, tube oil return 1/4 x 1/4
4 02250118-494 1 filter, ass’y fuel/water sep
5 02250118-524 2 plug,fuel/water sep 1/2-20 unf
6 02250118-809 2 connector, tube oil return 5/16x1/4
7 02250132-591 1 tank, fuel 20 gal 185dpq 60hp
8 02250137-493 1 strap,hold down fuel frt 60hp
9 02250137-494 1 strap,holddown fuel rear 60hp
10 02250139-885 1 tube, fuel pick-up 185dpq 60hp
11 02250139-886 1 tube, fuel return 185dpq jd
12 02250139-916 1 support,fuel fltr perkins 185q
13 02250152-163 1 adapter, fuel pickup 185 60hp
14 02250162-229 1 ventilator,fuel tank
15 02250162-230 1 cap, fuel fill buttress thread
16 043258 1 connector, hose 5/16”hose x 1/4”npt
17 047115 1 valve, ball 1/4” npt
18 047235 14 clamp, hose 3/8”
19 250004-752 1 gasket, fuel gauge neoprene
20 406615 2 elbow, 5/16”hose x 1/4”npt
21 825305-283 4 nut,hex f pltd 5/16-18
22 825505-166 4 nut,hex locking 5/16-18
23 829705-100 4 screw, hex ser washer 5/16-18 x 1
24 837802-047 5 washer, spr lock reg pltd #10
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 838205-071 6 washer, pl-b reg pltd 5/16
26 842315-025 4 hose,fuel line 1/4 (ft)
27 842315-031 7 hose,fuel line 5/16 (ft)
28 860404-025 1 nipple,pipe-hex 1/4 x 1/4
29 876002-075 5 screw,rnd phillips 10-24 x 3/4”
A1 - items included with all engines
A2 - fuel supply to engine fuel pump
A3 - from engine fuel pump
A4 - to engine fuel rack
A5 - pre-installed on John Deere engines
A6 - fuel return from cat engine
A7 - fuel return from John Deere engine
A8 - fuel shutoff (optional)
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
41
1.17 ELECTRICAL SYSTEM PARTS
KEY NO. PART NO. QTY DESCRIPTION
1 02250071-380 1 grip,cd n4 .187-.250 x 1/2”2 02250086-448 2 channel, extruded rubber “u”3 02250092-169 2 washer, external serrated m104 02250097-138 1 conn, female pipe 1/8-27 npt5 02250101-258 1 cable, ground 4-gauge strap6 02250104-192 1 battery, grp 31 760 cca7 02250104-193 2 hold-down, battery 11” j-bolt8 02250110-529 1 spg, ext .50 dia 30 lbs9 02250119-658 1 lamp, license plate std
10 02250119-678 1 bracket, license plate lamp11 02250130-668 1 switch, engine oil pressure n.o.12 02250137-492 1 tray, battery 185dpq 60hp13 02250139-964 1 harn,wrg std lt 4-wire 185q 60hp14 02250142-600 2 cap, .25 dia rubber15 02250160-837 1 switch, battery disconnect 6-36v;16 02250163-818 1 switch, e-stop hd push-pull red17 02250163-819 1 gasket, e-stop large portable mach18 02250163-820 1 encl, large portable e-stop19 02250163-821 1 plate, cover large portable e-stop20 02250165-472 1 loc,batt disconnect switch21 02250192-901 1 supt,batt disc switch 185dpq22 02250193-120 1 switch, nc 250f 2 pole23 02250193-121 1 wire temp switch ground24 041561 2 boot, battery terminal25 250004-618 1 adapter, 1/8npt x 1/8jap pt26 250006-076 4 nut, plastic lic plate mtg27 250018-671 1 cable, batt #0 x 15”28 250019-104 1 angle, hold-down battery
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
29 250019-480 1 cable, batt 0 ga x 15” black30 250023-996 1 fuse, blade type atc 30amp31 250028-415 2 lamp, tail/turn/stop (shock mtg)32 250030-047 1 cable, batt 0 ga x 54 red33 825502-083 2 nut, hex locking #10-2434 825908-125 1 nut, hex metric m8 x 1.2535 829106-100 1 capscr, hex gr5 3/8-16 x 136 829705-050 2 screw, hex ser washer 5/16-18 x 1/237 829705-075 3 screw, hex ser washer 5/16-18 x 3/438 838205-071 3 washer, pl-b reg pltd 5/1639 843200-025 8 wrap, tie nylon tf4-840 866402-000 1 nipple, pipe-xs plt 1/8 x cl41 866815-005 1 tee, pipe 150# plt 1/842 866900-005 1 plug, pipe 1/8” 3000# stl plt43 876002-075 2 screw,rnd phillips 10-24 x 3/4”44 882304-016 4 capscr, soc btn hd m4 x 16mm
A1 - Caterpillar onlyA2 - John Deere onlyA3 - use to attach starter wireA5 - e-stop parts (optional)A6 - used to secure inst pnl harness to canopyA7 - battery disconnect parts (optional)
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
FRAME, RUNNING GEAR & PARTS 125, 130 & 185
42
1.18 FRAME, RUNNING GEAR & PARTS 125, 130 & 185
02250140-871-R08
PARTS LIST
43
1.18 FRAME, RUNNING GEAR & PARTS 125, 130 & 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250052-701 2 refl,red 3” truck-lite2 02250052-702 2 refl, yellow 3” truck-lite3 02250094-269 1 chain, 1/4 x 72 w/2 ez3 hooks4 02250100-538 1 conn, delta-shaped chain 1/4”5 02250106-068 2 plug, 4” round black plastic6 02250116-794 1 jack, hd w/pad 185-425 std7 02250121-515 2 stud, ball gas spring 5/16th x .54l8 02250125-604 2 washer, snubbing 375 vibration mount9 02250133-864 1 drawbar, std pivot 185dpq
10 02250133-984 1 supt, shipping 185 pivot drbar11 02250134-142 1 pnl, frm rear 185dpq 60hp12 02250134-143 1 pnl, frm frt 185dpq 60hp13 02250134-494 1 hng, canopy 185 clam14 02250134-853 1 axle,tornl 3500 lb 185 std15 02250134-854 2 fender, plastic 185dpq 60hp16 02250136-005 2 tire, assy st175/80d1317 02250136-794 1 supt, latch striker 185 60hp18 02250137-297 10 seal, clip-on baffles 185 60hp19 02250139-967 1 latch, assembly pinned 185q 60hp20 02250139-975 1 pin, safety snap 1/4x 2-1/4 ss21 02250139-977 1 cable, lanyard 1/16x6 loop&eye22 02250140-185 1 bumper, baffle 185q 60hp23 02250140-244 1 pnl,acst frame panel front24 02250140-880 1 plate, lift bail cover 18525 02250141-183 1 support, dr-bar swivel 185q26 02250141-345 1 anl, machine tie down 185q60hp27 02250142-977 1 pnl, toolbox expanded 185pe28 02250143-807 1 panel, toolbox 185jd 60hp29 02250143-986 1 pnl, toolbox rear 185pe30 02250144-615 1 frm assy,185q jd-cat 60hp
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
31 02250152-910 1 bail,lft assy 185dpq 60hp32 02250153-887 4 strap, machine hold-down-aust.33 02250153-927 1 bumper,baf 185q 60hp australia34 02250163-806 1 panel, frm lh 185 fender mtg35 02250163-810 1 panel, frm rh 185 fendef mtg36 250002-221 1 eye, 3” lunette demountable37 250025-692 4 screw, mach phill #10-24 x 1/238 825305-283 25 nut, hex f pltd 5/16-1839 825501-070 4 nut, hex locking #8-3240 825502-083 5 nut, hex locking #10-2441 825508-262 4 nut, hex locking 1/2-1342 825510-329 2 nut, hex locking 5/8-1143 829108-125 15 capscr, hex gr5 1/2-13 x 1 1/444 829110-150 4 capscr, hex gr5 5/8-11 x 1 1/245 829110-475 1 capscr, hex gr5 5/8-11 x 4 3/446 829705-075 42 screw, hex ser washer 5/16-18 x 3/447 837808-125 13 washer, spr lock reg pltd 1/248 837810-156 4 washer, spr lock reg pltd 5/849 838205-071 25 washer, pl-b reg pltd 5/1650 838208-112 12 washer, pl-b reg pltd 1/251 838210-112 8 washer, pl-b reg pltd 5/852 875608-125 8 capscr, hx gr5 1/2-13 x 1 1/4 plt53 875901-075 4 screw,flt phillips 8-32 x 3/4”54 876002-075 1 screw,rnd phillips 10-24 x 3/4”55 878608-077 8 washer, nord-lock pl 1/2”
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
FRAME & PARTS LESS RUNNING GEAR 125, 130, 185 & SAFE ZONE
44
1.19 FRAME & PARTS LESS RUNNING GEAR 125, 130, 185 & SAFE ZONE
02250184-252 R01
PARTS LIST
45
1.19 FRAME & PARTS LESS RUNNING GEAR 125, 130, 185 & SAFE ZONE
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-205 2 channel, utility mount 100-250
2 02250106-068 3 plug,4” round black plastic
3 02250121-515 2 stud,ball gas spring 5/16th x .54l
4 02250134-494 2 hinge,canopy 185 clam
5 02250136-794 1 support,latch striker 185 60hp
6 02250137-297 1 seal,clip-on baffles 185 60hp
7 02250139-669 1 panel, frame frt 185dpq 60hp ss
8 02250139-967 1 catch,assembly pinned 185q 60hp
9 02250139-975 1 pin,safety snap 1/4x 2-1/4 ss
10 02250139-977 1 cable,lanyard 1/16x6 loop&eye
11 02250140-244 1 foam, frame panel front
12 02250140-880 1 plate, lift bail cover 185
13 02250142-977 1 panel,toolbox expanded 185pe
14 02250143-986 1 panel,toolbox rear 185pe
15 02250152-319 1 panel, frame rear 185dlq tab
16 02250152-910 1 bail, lifting assy 185dpq 60hp
17 02250163-805 1 panel, frame lh 185 fender mtg tab
18 02250163-809 1 panel, frame rh 185 fender mtg tab
19 02250182-007 1 frame,assy hot-dip galvanized 185
20 02250184-000 1 angle, front frm spk arsr 185bdlq sz
21 02250184-042 1 tabulation,bumper 185b
22 250025-692 4 screw, mach phill #10-24 x 1/2
23 250040-100 4 washer, .625 hardened
24 825305-283 6 nut,hex f pltd 5/16-18
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 825502-083 5 nut,hex locking #10-24
26 825505-166 1 nut,hex locking 5/16-18
27 828505-100 5 capscrew,hex gr8 5/16-18 x 1
28 828510-150 4 capscrew,hex gr8 5/8-11 x 1 1/2
29 829108-125 6 capscrew,hex gr5 1/2-13 x 1 1/4
30 829705-075 9 screw, hex ser washer 5/16-18 x 3/4
31 829705-100 2 screw, hex ser washer 5/16-18 x 1
32 837805-078 5 washer, spr lock reg pltd 5/16
33 837808-125 6 washer, spr lock reg pltd 1/2
34 837810-156 4 washer, spr lock reg pltd 5/8
35 838205-071 14 washer, pl-b reg pltd 5/16
36 876002-075 1 screw,rnd phillips 10-24 x 3/4”
37 879505-283 17 nut,hex flgd ss 5/16-18
38 879808-125 2 capscrew, hex ss 1/2 x 1 1/4
39 879905-075 30 screw, hx ser wshr 5/16 x 3/4”
40 879905-100 4 screw, hx ser wshr 5/16 x 1”
41 880305-071 42 washer, plug b reg ss 5/16”
42 880308-112 2 washer, plug b reg ss 1/2”
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
47
1.20 FRAME RUNNING GEAR & PARTS 49HP 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250052-701 2 refl,red 3” truck-lite2 02250052-702 2 refl, yellow 3” truck-lite3 02250094-269 1 chain, 1/4 x 72 w/2 ez3 hooks4 02250100-538 1 conn, delta-shaped chain 1/4”5 02250106-068 1 plug, 4” round black plastic6 02250116-794 1 jack, hd w/pad 185-425 std7 02250121-515 2 stud, ball gas spring 5/16th x .54l8 02250125-604 2 washer, snubbing 375 vibration mount9 02250133-864 1 drawbar, std pivot 185dpq
10 02250133-984 1 supt, shipping 185 pivot drbar11 02250134-143 1 pnl, frm frt 185dpq 60hp12 02250134-494 2 hng, canopy 185 clam13 02250134-854 2 fender, plastic 185dpq 60hp14 02250136-005 2 tire, assy st175/80d1315 02250136-794 1 supt, latch striker 185 60hp16 02250139-967 1 latch, assembly pinned 185q 60hp17 02250139-975 1 pin, safety snap 1/4x 2-1/4 ss18 02250139-977 1 cable, lanyard 1/16x6 loop&eye19 02250140-244 1 pnl,acst frame panel front20 02250141-183 1 support, dr-bar swivel 185q21 02250141-345 1 anl, machine tie down 185q60hp22 02250142-977 1 pnl, toolbox expanded 185pe23 02250143-807 1 panel, toolbox 185jd 60hp24 02250143-986 1 pnl, toolbox rear 185pe25 02250144-586 1 axle, torsional 185dpq26 02250152-319 1 pnl, frm rear 185dlq tab27 02250165-862 32 trim, clip on28 02250185-416 1 bail,lft assy 185 w/12s unit29 02250185-488 1 plate, lift bail cvr 185 w/12s30 02250191-792 1 tab, bumper 185/12s
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
31 02250191-795 1 tab, pnl frm lh 185/12s32 02250191-798 1 tab, pnl frm rh 185/12s33 02250191-819 1 frame, assy 185/12s34 02250191-961 1 supt, toolbox 185ca/12s35 250002-221 1 eye, 3” lunette demountable36 825305-283 22 nut, hex f pltd 5/16-1837 825501-070 4 nut, hex locking #8-3238 825502-083 5 nut, hex locking #10-2439 825508-262 2 nut, hex locking 1/2-1340 825510-329 2 nut, hex locking 5/8-1141 829108-125 10 capscr, hex gr5 1/2-13 x 1 1/442 829110-125 4 capscr, hex gr5 5/8-11 x 1 1/443 829110-475 2 capscr, hex gr5 5/8-11 x 4 3/444 829705-075 54 screw, hex ser washer 5/16-18 x 3/445 837808-125 8 washer, spr lock reg pltd 1/246 837810-156 4 washer, spr lock reg pltd 5/847 838205-071 54 washer, pl-b reg pltd 5/1648 838208-112 12 washer, pl-b reg pltd 1/249 838210-112 8 washer, pl-b reg pltd 5/850 875608-125 8 capscr, hx gr5 1/2-13 x 1 1/4 plt51 875901-075 4 screw,flt phillips 8-32 x 3/4”52 876002-075 5 screw,rnd phillips 10-24 x 3/4”53 878608-077 8 washer, nord-lock pl 1/2”
A1 - John Deere onlyA2 - Caterpillar only
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
FRAME & PARTS LESS RUNNING GEAR 49HP 185
48
1.21 FRAME & PARTS LESS RUNNING GEAR 49HP 185
02250193-128 R00
PARTS LIST
49
1.21 FRAME & PARTS LESS RUNNING GEAR 49HP 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-205 2 channel, utility mount 100-250
2 02250106-068 2 plug, 4” round black plastic
3 02250121-515 2 stud, ball gas spring 5/16th x .54l
4 02250134-143 1 pnl, frm frt 185dpq 60hp
5 02250134-494 2 hng, canopy 185 clam
6 02250136-794 1 supt, latch striker 185 60hp
7 02250139-967 1 latch, assembly pinned 185q 60hp
8 02250139-975 1 pin, safety snap 1/4x 2-1/4 ss
9 02250139-977 1 cable, lanyard 1/16x6 loop&eye
10 02250140-244 1 pnl,acst frame panel front
11 02250142-977 1 pnl, toolbox expanded 185pe
12 02250143-807 1 panel, toolbox 185jd 60hp
13 02250143-986 1 pnl, toolbox rear 185pe
14 02250152-319 1 pnl, frm rear 185dlq tab
15 02250165-862 32 trim, clip on
16 02250185-416 1 bail,lft assy 185 w/12s unit
17 02250185-488 1 plate, lift bail cvr 185 w/12s
18 02250191-792 1 tab, bumper 185/12s
19 02250191-795 1 tab, pnl frm lh 185/12s
20 02250191-798 1 tab, pnl frm rh 185/12s
21 02250191-819 1 frame, assy 185/12s
22 02250191-961 1 supt, toolbox 185ca/12s
23 825305-283 22 nut, hex f pltd 5/16-18
24 825502-083 5 nut, hex locking #10-24
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 829108-125 8 capscr, hex gr5 1/2-13 x 1 1/4
26 829110-100 6 capscr, hex gr5 5/8-11 x 1
27 829705-075 54 screw, hex ser washer 5/16-18 x 3/4
28 837808-125 8 washer, spr lock reg pltd 1/2
29 837810-156 6 washer, spr lock reg pltd 5/8
30 838205-071 54 washer, pl-b reg pltd 5/16
31 838210-112 6 washer, pl-b reg pltd 5/8
32 876002-075 5 screw,rnd phillips 10-24 x 3/4”
A1 - John Deere only
A2 - Caterpillar only
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
51
1.22 CANOPY & PARTS 125, 130 & 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250121-515 2 stud,ball gas spring 5/16th x .54l
2 02250134-135 1 panel, canopy side rh 185 clam
3 02250134-137 4 gussett, can frm supt 185 clam
4 02250134-138 1 panel,canopy top 185 clam
5 02250134-140 2 channel, canopy supt frt-r 185 clam
6 02250134-141 2 channel, canopy supt sides 185 clam
7 02250134-494 1 hinge,canopy 185 clam
8 02250134-568 2 support,gas sprng can 185 60hp
9 02250134-713 2 louver,canopy ends 185q 60hp
10 02250137-298 2 spring,gas canopy 900n 185 60hp
11 02250139-985 1 striker,latch 185 canopy
12 02250142-100 16 screw, shldr 1/4-20 x 1/4 ss
13 02250142-101 16 washer, flat 5/16 x 11/16 ss black
14 02250154-659 1 trim,clip-on grip 185-260duq
15 02250155-717 20 panel, accust louvers 185
16 02250180-111 1 panel,canopy lh 185 champ tab
17 825305-283 36 nut,hex f pltd 5/16-18
18 829705-075 60 screw, hex ser washer 5/16-18 x 3/4
19 838205-071 44 washer, pl-b reg pltd 5/16
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
CANOPY & PARTS 125, 130 & 185 AUSTRALIA
52
1.23 CANOPY & PARTS 125, 130 & 185 AUSTRALIA
02250180-196-R00
PARTS LIST
53
1.23 CANOPY & PARTS 125, 130 & 185 AUSTRALIA
KEY NO. PART NO. QTY DESCRIPTION
1 02250121-515 2 stud,ball gas spring 5/16th x .54l
2 02250134-136 0 panel,canopy side lh 185 clam
3 02250134-137 4 gussett, can frm supt 185 clam
4 02250134-138 1 panel,canopy top 185 clam
5 02250134-140 2 channel, canopy supt frt-r 185 clam
6 02250134-141 2 channel, canopy supt sides 185 clam
7 02250134-494 1 hinge,canopy 185 clam
8 02250134-568 2 support,gas sprng can 185 60hp
9 02250134-713 2 louver,canopy ends 185q 60hp
10 02250137-298 2 spring,gas canopy 900n 185 60hp
11 02250139-985 1 striker,latch 185 canopy
12 02250142-100 16 screw, shldr 1/4-20 x 1/4 ss
13 02250142-101 16 washer, flat 5/16 x 11/16 ss black
14 02250154-659 1 trim,clip-on grip 185-260duq
15 02250155-717 20 panel, accust louvers 185
16 02250180-116 1 panel,canopy side lh 185 clam
17 825305-283 36 nut,hex f pltd 5/16-18
18 829705-075 60 screw, hex ser washer 5/16-18 x 3/4
19 834205-075 4 screw, tc-hex 5/16-18 x 3/4
20 838205-071 44 washer, pl-b reg pltd 5/16
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
55
1.24 CANOPY & PARTS 49HP 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250121-515 2 stud, ball gas spring 5/16th x .54l
2 02250134-137 4 gussett, can frm supt 185 clam
3 02250134-140 2 chan, can supt frt-r 185 clam
4 02250134-494 1 hng, canopy 185 clam
5 02250134-568 2 supt, gas sprng can 185 60hp
6 02250134-713 2 louver, canopy ends 185q 60hp
7 02250137-298 2 spg, gas canopy 900n 185 60hp
8 02250139-985 1 striker, latch 185 canopy
9 02250142-100 16 screw, shldr 1/4-20 x 1/4 ss
10 02250142-101 16 washer, flat 5/16 x 11/16 ss black
11 02250154-659 1 trim,clip-on grip 185-260duq
12 02250155-717 20 panel, accust louvers 185
13 02250185-423 2 chan, can supt sides 185 extd
14 02250191-801 1 tab, pnl can rh 185/12s
15 02250191-807 1 tab, pnl canopy lh 185/12s
16 02250191-813 1 tab, pnl can top 185/12s
17 825305-283 41 nut, hex f pltd 5/16-18
18 829705-075 60 screw, hex ser washer 5/16-18 x 3/4
19 838205-071 49 washer, pl-b reg pltd 5/16
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
57
1.25 DECAL & PARTS (CONTINUED)
KEY NO. PART NO. QTY DESCRIPTION
1 02250052-701 2 refl,red 3” truck-lite
2 02250052-702 2 refl, yellow 3” truck-lite
3 02250057-624 1 decal, iso 9001 blk 3.44x5.75
4 02250059-058 2 decal, “sullair” 3.50 x 28.0
5 02250097-455 1 decal, 5 year warranty
6 02250118-638 1 decal,lead warn. prop. 65
7 02250140-065 1 decal,oper instr - perkins
8 02250140-918 3 decal,”185” 3 inches high
9 02250140-925 1 decal, “need an air tool?” sml
10 02250141-346 1 decal, rated 2550 idle 2550 rpm
11 02250141-347 1 decal, rated 2650 idle 2650 rpm
12 02250141-348 1 decal, “125” 3 inches high
13 02250141-349 1 decal, “130” 3 inches high
14 02250142-050 1 decal, drwbr instl 185q pe std
15 02250142-212 1 decal,rated 2800 idle 2000
16 02250142-530 1 decal,caution- do not overfill
17 02250144-447 1 decal, wd 185 pe/cat/jd tier ii
18 02250147-899 2 decal, “49hp” 3” black
19 02250148-780 1 decal, rated 2650 idle 2000
20 02250148-781 1 decal, rated 2550 idle 2000
21 02250171-788 2 decal, do not oper w/o grd #2
22 02250171-789 2 decal, do not oper w/o grd #3
23 02250171-794 1 decal, tie down
24 02250171-795 1 decal, diesel fuel
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 02250171-800 1 decal, do not oper w/doors ope
26 02250171-808 1 decal, pressurized vessel
27 02250171-814 1 decal, corrosive
28 02250171-815 4 decal, read instruction manual
30 02250171-821 1 decal, tow bar/commencing
31 02250172-064 2 decal, axle lubrication instr
33 02250172-089 1 decal, engine coolant
34 02250172-271 3 decal, warning hot surfaces
35 02250172-276 1 decal, rad fill/hot/see manual
36 02250172-282 1 decal, compr oil sullair awf
37 02250172-292 1 decal, water drain
38 02250172-453 1 decal, warning electrical shock
39 02250172-457 1 decal, warning exhaust gases
40 02250172-460 2 decal, warning crush/pinch point
42 02250172-828 1 decal,do not group 185-375 t3
43 02250173-353 2 decal,caution do not mix
44 02250175-355 1 id, name plate s/n 375=425
45 02250175-422 1 decal,wrn low sulfur fuel only
47 02250176-405 1 decal, maint 185 jd
48 02250176-406 1 decal, maint 185 cat t3
50 040103 4 reflector, red 1.68 x 4.25
Continued on page 59
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
59
1.25 DECAL & PARTS
KEY NO. PART NO. QTY DESCRIPTION
51 049463 1 decal, noise emission control
52 250023-694 1 decal, rated 2800 idle 2200
53 250034-319 2 reflector, amber 1.68 x 4.25
54 825501-070 4 nut, hex locking #8-32
55 843102-038 4 rivet, pop 1/8 x 3/8
56 875901-075 4 screw,flt phillips 8-32 x 3/4”
57 02250172-459 1 decal, warning
58 02250179-647 2 decal,compr fil w/mobil delvac
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
A1: all cat
A2: all jd
A3: 49hp 185 views
A4: all cat & jd
A5: 185 cat & 49hp 185 cat
A6: 185 jd & 49hp 185 jd
A7: 125 cat
A8: 130 cat
A9: 125 jd
A10: 130 jd
A11: items 43 & 58 located on lifting bail cover plate.
A12: items 50 & 53 to cover hole pattern in panels on both sides of compressor.
A13: items 28, 30, 31, 40, & 57 are not used on a less running gear option. less running gear option does not include drawbar or fenders. any decals pertaining to these parts are not required.
A14: view does not show louvers.
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
61
1.26 INSTRUMENT PANEL & PARTS
KEY NO. PART NO. QTY DESCRIPTION
1 02250103-623 1 hinge, instrument panel door 185q-8f
2 02250112-009 4 screw,phil pan hd #6-32 x3/8
3 02250125-511 1 catch,locking instrument panel
4 02250138-181 1 door,instrument panel 185 60hp
5 250022-436 3 weatherstrip, 3/16 x 3/8 ft
6 250025-692 8 screw, mach phill #10-24 x 1/2
7 250035-095 3 bumper,rubber 1/2 dia
8 825500-102 4 nut,hex locking #6-32
9 825501-070 1 nut,hex locking #8-32
10 825615-002 2 nut,acorn pltd #8-32
11 838200-045 4 washer, pl-b reg pltd #6
12 875901-075 1 screw,flt phillips 8-32 x 3/4”
13 876001-038 2 screw,rnd phillips 8-32 x 3/8”
14 SEE BELOW 1 instrument panel & parts
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
Instrument Panels:02250153-403 panel, instrument std gauge jd 160h
02250154-137 panel, instrument full gauge jd 160h
02250155-952 inst pnl & pts, 185 jd std gauge
02250155-953 inst pnl & pts, 185 jd full gauge
02250155-955 inst pnl & pts, 185 pe/cat std gauge
02250155-956 inst pnl & pts, 185 pe/cat full gauge
02250155-958 inst pnl & pts, 185 aus pe/cat std gauge
02250183-995 inst pnl & pts, 185 pe/cat std gauge w/estop
02250183-996 inst pnl & pts, 185 pe/cat full gauge w/estop
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
63
1.27 INSTRUMENT PANEL STANDARD GAUGE JD
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
3 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
4 02250099-630 1 tube,nylon .375”od x .050w black (ft)
5 02250129-189 1 lense, cliplite led
6 02250129-190 1 panel, instrument plastic ssam
7 02250130-631 1 decal,starting aid 185-375 cat
8 02250131-485 1 decal,group std panel (ssam)
9 02250132-883 1 switch, engine ignition 12-volt
10 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
11 02250136-999 1 valve, ball 2-way 1/4”npt
12 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
13 02250137-265 1 cover, access ssam molded abs
14 02250139-296 1 controller,ssam 185-60hp
15 02250155-951 1 harness, wiring 185 jd tii
16 040038 1 switch, starter push-button
17 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
18 838200-045 2 washer, pl-b reg pltd #6
19 867100-005 1 bushing,red pltd 1/4 x 1/8
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
65
1.28 INSTRUMENT PANEL FULL GAUGE JD
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250044-366 1 gauge, volt-meter 12 volt 2”
3 02250050-513 1 gage, temperature mech 72” 130-250f 2”
4 02250050-516 1 gauge, pressure mech 0-100psi 2”
5 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
6 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
7 02250099-630 1 tube,nylon .375”od x .050w black (ft)
8 02250129-189 1 lense, cliplite led
9 02250129-190 1 panel, instrument plastic ssam
10 02250130-631 1 decal,starting aid 185-375 cat
11 02250130-635 1 harness, voltmeter 125-425 jd/cat
12 02250131-486 1 decal,group full gauge (ssam)
13 02250132-883 1 switch, engine ignition 12-volt
14 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
15 02250136-999 1 valve, ball 2-way 1/4”npt
16 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
17 02250137-265 1 cover, access ssam molded abs
18 02250139-296 1 controller,ssam 185-60hp
19 02250143-278 1 gauge, temp mech 8ft 140-300$sf
20 02250155-951 1 harness, wiring 185 jd tii
21 040038 1 switch, starter push-button
22 250041-286 1 elbow, 90d 1/4” tube x 1/8”fnpt
23 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
24 838200-045 2 washer, pl-b reg pltd #6
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 867100-005 1 bushing,red pltd 1/4 x 1/8
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
67
1.29 INSTRUMENT PANEL STANDARD GAUGE CAT
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250044-366 1 gauge, volt-meter 12 volt 2”
3 02250050-513 1 gage, temperature mech 72” 130-250f 2”
4 02250050-516 1 gauge, pressure mech 0-100psi 2”
5 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
6 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
7 02250099-630 1 tube,nylon .375”od x .050w black (ft)
8 02250129-189 1 lense, cliplite led
9 02250129-190 1 panel, instrument plastic ssam
10 02250130-631 1 decal,starting aid 185-375 cat
11 02250130-635 1 harness, voltmeter 125-425 jd/cat
12 02250131-486 1 decal,group full gauge (ssam)
13 02250132-883 1 switch, engine ignition 12-volt
14 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
15 02250136-999 1 valve, ball 2-way 1/4”npt
16 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
17 02250137-265 1 cover, access ssam molded abs
18 02250139-296 1 controller,ssam 185-60hp
19 02250143-278 1 gauge, temp mech 8ft 140-300$sf
20 02250155-954 1 harness, wiring 185 pe/cat tier ii
21 040038 1 switch, starter push-button
22 250041-286 1 elbow, 90d 1/4” tube x 1/8”fnpt
23 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
24 838200-045 2 washer, pl-b reg pltd #6
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 867100-005 1 bushing,red pltd 1/4 x 1/8
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
INSTRUMENT PANEL STANDARD GAUGE CAT WITH ESTOP
68
1.30 INSTRUMENT PANEL STANDARD GAUGE CAT WITH ESTOP
02250183-995 R00
PARTS LIST
69
1.30 INSTRUMENT PANEL STANDARD GAUGE CAT WITH ESTOP
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
3 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
4 02250099-630 1 tube,nylon .375”od x .050w black (ft)
5 02250129-189 1 lense, cliplite led
6 02250129-190 1 panel, instrument plastic ssam
7 02250130-631 1 decal,starting aid 185-375 cat
8 02250131-485 1 decal,group std panel (ssam)
9 02250132-883 1 switch, engine ignition 12-volt
10 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
11 02250136-999 1 valve, ball 2-way 1/4”npt
12 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
13 02250137-265 1 cover, access ssam molded abs
14 02250139-296 1 controller,ssam 185-60hp
15 02250183-994 1 harness, wiring 185 pe/cat tier ii
16 040038 1 switch, starter push-button
17 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
18 838200-045 2 washer, pl-b reg pltd #6
19 867100-005 1 bushing,red pltd 1/4 x 1/8
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
71
1.31 INSTRUMENT PANEL FULL GAUGE CAT
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250044-366 1 gauge, volt-meter 12 volt 2”
3 02250050-513 1 gage, temperature mech 72” 130-250f 2”
4 02250050-516 1 gauge, pressure mech 0-100psi 2”
5 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
6 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
7 02250099-630 1 tube,nylon .375”od x .050w black (ft)
8 02250129-189 1 lense, cliplite led
9 02250129-190 1 panel, instrument plastic ssam
10 02250130-631 1 decal,starting aid 185-375 cat
11 02250130-635 1 harness, voltmeter 125-425 jd/cat
12 02250131-486 1 decal,group full gauge (ssam)
13 02250132-883 1 switch, engine ignition 12-volt
14 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
15 02250136-999 1 valve, ball 2-way 1/4”npt
16 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
17 02250137-265 1 cover, access ssam molded abs
18 02250139-296 1 controller,ssam 185-60hp
19 02250143-278 1 gauge, temp mech 8ft 140-300$sf
20 02250155-954 1 harness, wiring 185 pe/cat tier ii
21 040038 1 switch, starter push-button
22 250041-286 1 elbow, 90d 1/4” tube x 1/8”fnpt
23 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
24 838200-045 2 washer, pl-b reg pltd #6
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 867100-005 1 bushing,red pltd 1/4 x 1/8
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
INSTRUMENT PANEL FULL GAUGE CAT WITH ESTOP
72
1.32 INSTRUMENT PANEL FULL GAUGE CAT WITH ESTOP
02250183-996 R00
PARTS LIST
73
1.32 INSTRUMENT PANEL FULL GAUGE CAT WITH ESTOP
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250044-366 1 gauge, volt-meter 12 volt 2”
3 02250050-513 1 gage, temperature mech 72” 130-250f 2”
4 02250050-516 1 gauge, pressure mech 0-100psi 2”
5 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
6 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
7 02250099-630 1 tube,nylon .375”od x .050w black (ft)
8 02250129-189 1 lense, cliplite led
9 02250129-190 1 panel, instrument plastic ssam
10 02250130-631 1 decal,starting aid 185-375 cat
11 02250130-635 1 harness, voltmeter 125-425 jd/cat
12 02250131-486 1 decal,group full gauge (ssam)
13 02250132-883 1 switch, engine ignition 12-volt
14 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
15 02250136-999 1 valve, ball 2-way 1/4”npt
16 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
17 02250137-265 1 cover, access ssam molded abs
18 02250139-296 1 controller,ssam 185-60hp
19 02250143-278 1 gauge, temp mech 8ft 140-300$sf
20 02250183-994 1 harness, wiring 185 pe/cat tier ii
21 040038 1 switch, starter push-button
22 250041-286 1 elbow, 90d 1/4” tube x 1/8”fnpt
23 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
24 838200-045 2 washer, pl-b reg pltd #6
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 867100-005 1 bushing,red pltd 1/4 x 1/8
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
INSTRUMENT PANEL STANDARD GAUGE CAT AUSTRALIA
74
1.33 INSTRUMENT PANEL STANDARD GAUGE CAT AUSTRALIA
02250155-958-R02
PARTS LIST
75
1.33 INSTRUMENT PANEL STANDARD GAUGE CAT AUSTRALIA
KEY NO. PART NO. QTY DESCRIPTION
1 02250044-361 1 gauge, pressure air 0-300 2”
2 02250050-517 1 hour-meter, 12-24vdc 10000hr 2”
3 02250099-626 1 elbow, 90 3/8”tube x 1/4”npt m
4 02250099-630 1 tube,nylon .375”od x .050w black (ft)
5 02250129-189 1 lense, cliplite led
6 02250129-190 1 panel, instrument plastic ssam
7 02250130-631 1 decal,starting aid 185-375 cat
8 02250132-883 1 switch, engine ignition 12-volt
9 02250136-998 1 tee, male branch 3/8”tube x 1/4”npt m
10 02250136-999 1 valve, ball 2-way 1/4”npt
11 02250137-033 1 elbow, 90 f 3/8”tube x 1/4”npt
12 02250137-265 1 cover, access ssam molded abs
13 02250139-296 1 controller,ssam 185-60hp
14 02250142-253 1 decal,group std panel (ssam)
15 02250155-957 1 harness, wiring 185 aus p/c tier ii
16 040038 1 switch, starter push-button
17 835700-050 2 screw, tc-f rd hd #6-32 x 1/2
18 838200-045 2 washer, pl-b reg pltd #6
19 867100-005 1 bushing,red pltd 1/4 x 1/8
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
77
1.34 OPTIONAL DUAL HOSE REELS & OILERS
KEY NO. PART NO. QTY DESCRIPTION
1 02250048-573 1 support, hose reel manifold 110-250
2 02250048-574 1 support, hose reel 110-250 portables
3 02250054-969 2 hose, medium pressure 1”jic x 32”long
4 02250136-247 1 draw-bar, long pivot 185dpq
5 02250141-183 1 support, dr-bar swivel 185q
6 040170 2 reel, hose 100ft 3/4”hose x 3/4”npt
7 040885 2 hose,assembly 5/8”id x 18”long
8 043480 2 valve, air velocity flow 3/4”npt
9 045241 2 adapter, swivel 90deg 3/4”h x 3/4”p
10 250002-145 1 support, service manifold
11 250005-016 1 oiler,1qt
12 250008-322 2 u-bolt,hose reel mount 110-250
13 250019-865 3 valve, ball 3/4” service
14 250031-648 3 coupling, 3/4” male npt am7
15 251315 1 lubricator, cf 1 pt 1” 30cf
16 405403 1 oiler,line 2-quart 1” npt
17 825304-236 4 nut,hex f pltd 1/4-20
18 825305-283 4 nut,hex f pltd 5/16-18
19 825506-198 12 nut,hex locking 3/8-16
20 829106-100 8 capscrew,hex gr5 3/8-16 x 1
21 829705-075 2 screw, hex ser washer 5/16-18 x 3/4
22 838204-071 4 washer, pl-b reg pltd 1/4
23 838205-071 4 washer, pl-b reg pltd 5/16
24 838206-071 12 washer, pl-b reg pltd 3/8
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 860116-100 1 connector,37 fl/mpt pltd 1 x 1
26 860216-100 1 elbow, 37fl 90m 1 x 1
27 866412-000 7 nipple,pipe-xs plt 3/4 x cl
28 866416-000 5 nipple,pipe-xs plt 1 x cl
29 866416-020 1 nipple,pipe-xs plt 1 x 2
30 866900-040 1 plug, pipe 1” 3000# stl plt
31 867030-030 2 elbow, pipe 90 deg 300# plt 3/4”
32 867104-030 3 bushing,red pltd 1 x 3/4
33 867430-040 1 coupling,pipe 1 300# plt
34 867830-040 1 cross, pipe 1” plt
35 868030-040 1 union,pipe-brs seat 1 300# plt
36 868304-100 2 u-bolt,1/4” x 1” pipe pltd
37 868305-125 1 u-bolt,5/16” x 1 1/4” pipe pltd
38 868430-040 1 tee, pipe pltd 1
39 869015-040 1 coupling, pipe 1 150# plt
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
79
1.35 OPTIONAL SINGLE HOSE REEL & OILERS
KEY NO. PART NO. QTY DESCRIPTION
1 02250054-447 1 support, manifold single hose reel
2 02250054-969 1 hose, medium pressure 1”jic x 32”long
3 02250136-247 1 draw-bar, long pivot 185dpq
4 040170 1 reel, hose 100ft 3/4”hose x 3/4”npt
5 040701 1 hose,assembly 5/8”id x 28”long
6 043480 1 valve, air velocity flow 3/4”npt
7 045241 1 adapter, swivel 90deg 3/4”h x 3/4”p
8 250002-145 1 support, service manifold
9 250005-016 1 oiler,1qt
10 250008-322 2 u-bolt,hose reel mount 110-250
11 250019-865 2 valve, ball 3/4” service
12 250031-648 2 coupling, 3/4” male npt am7
13 251315 1 lubricator, cf 1 pt 1” 30cf
14 405403 1 oiler,line 2-quart 1” npt
15 825304-236 4 nut,hex f pltd 1/4-20
16 825305-283 4 nut,hex f pltd 5/16-18
17 825506-198 8 nut,hex locking 3/8-16
18 829106-100 4 capscrew,hex gr5 3/8-16 x 1
19 829705-075 2 screw, hex ser washer 5/16-18 x 3/4
20 838204-071 4 washer, pl-b reg pltd 1/4
21 838205-071 4 washer, pl-b reg pltd 5/16
22 838206-071 8 washer, pl-b reg pltd 3/8
23 860116-100 1 connector,37 fl/mpt pltd 1 x 1
24 860216-100 1 elbow, 37fl 90m 1 x 1
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
25 866412-000 5 nipple,pipe-xs plt 3/4 x cl
26 866416-000 5 nipple,pipe-xs plt 1 x cl
27 866416-020 1 nipple,pipe-xs plt 1 x 2
28 866900-040 1 plug, pipe 1” 3000# stl plt
29 867030-030 1 elbow, pipe 90 deg 300# plt 3/4”
30 867104-030 2 bushing,red pltd 1 x 3/4
31 867430-040 1 coupling,pipe 1 300# plt
32 868030-040 1 union,pipe-brs seat 1 300# plt
33 868304-100 2 u-bolt,1/4” x 1” pipe pltd
34 868305-125 1 u-bolt,5/16” x 1 1/4” pipe pltd
35 868430-040 2 tee, pipe pltd 1
KEY NO. PART NO. QTY DESCRIPTION
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
81
1.36 OPTIONAL SINGLE ONE PINT OILER
KEY NO. PART NO. QTY DESCRIPTION
1 250002-145 1 support, service manifold
2 250019-865 2 valve, ball 3/4” service
3 250031-648 2 coupling, 3/4” male npt am7
4 251315 1 lubricator, cf 1 pt 1” 30cf
5 825304-236 2 nut,hex f pltd 1/4-20
6 825305-283 2 nut,hex f pltd 5/16-18
7 827905-075 2 capscrew,hex gr8 5/16-18 x 3/4
8 838204-071 2 washer, pl-b reg pltd 1/4
9 838205-071 2 washer, pl-b reg pltd 5/16
10 866412-000 2 nipple,pipe-xs plt 3/4 x cl
11 866416-000 2 nipple,pipe-xs plt 1 x cl
12 866416-020 1 nipple,pipe-xs plt 1 x 2
13 866416-035 1 nipple,pipe-xs plt 1 x 3 1/2
14 867104-030 1 bushing,red pltd 1 x 3/4
15 868030-040 1 union,pipe-brs seat 1 300# plt
16 868104-075 1 elbow, red 1 x 3/4 plt
17 868304-100 1 u-bolt,1/4” x 1” pipe pltd
18 868430-040 1 tee, pipe pltd 1
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
83
1.37 OPTIONAL OILER SEPARATOR
KEY NO. PART NO. QTY DESCRIPTION
1 02250127-121 1 separator, moisture
2 250002-145 1 support, service manifold
3 250005-016 1 oiler,1qt
4 250019-865 2 valve, ball 3/4” service
5 250031-648 2 coupling, 3/4” male npt am7
6 825304-236 1 nut,hex f pltd 1/4-20
7 825305-283 1 nut,hex f pltd 5/16-18
8 829705-075 1 screw, hex ser washer 5/16-18 x 3/4
9 838204-071 1 washer, pl-b reg pltd 1/4
10 838205-071 1 washer, pl-b reg pltd 5/16
11 866412-000 2 nipple,pipe-xs plt 3/4 x cl
12 866416-000 2 nipple,pipe-xs plt 1 x cl
13 866416-020 1 nipple,pipe-xs plt 1 x 2
14 866416-035 2 nipple,pipe-xs plt 1 x 3 1/2
15 867030-040 1 elbow, pipe 90 deg 300# plt 1”
16 867104-030 1 bushing,red pltd 1 x 3/4
17 868030-040 1 union,pipe-brs seat 1 300# plt
18 868104-075 1 elbow, red 1 x 3/4 plt
19 868304-100 1 u-bolt,1/4” x 1” pipe pltd
20 868430-040 1 tee, pipe pltd 1
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
85
1.38 DRAWBAR INSTALLATION
KEY NO. PART NO. QTY DESCRIPTION
1 838208-112 1 washer, pl-b reg pltd 1/2
2 875608-125 1 capscrew, hex gr5 1/2-13 x 1 1/4 plt
3 878608-077 1 washer, nord-lock pl 1/2”
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
87
1.39 OPTIONAL CANADIAN LIGHTS
KEY NO. PART NO. QTY DESCRIPTION
1 02250101-371 1 nameplate,vin canada dual language
2 02250101-403 1 cover,vin canada
3 02250129-278 4 reflector, 3” dia adhs mtg red
4 02250129-279 2 reflector, 3” adhs mtg yellow
5 02250139-566 2 lamp,led side clearance red
6 02250139-567 2 lamp,led side clearance yellow
7 02250139-571 4 holder,lamp side clearance blk
8 02250139-964 1 harness, wire std lt 4-wire 185q 60hp
9 825502-083 1 nut,hex locking #10-24
10 876002-075 1 screw,rnd phillips 10-24 x 3/4”
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR
PARTS LIST
89
1.40 OPTIONAL CRASH FRAME 125, 130 & 185
KEY NO. PART NO. QTY DESCRIPTION
1 02250101-442 28 decal,conspicuity tape 2” white
2 02250183-898 4 decal,stacking limit by number
3 02250183-899 4 decal,do not operate w/stacked
4 02250184-527 1 frame,assy crash 185b safe zone
5 02250185-136 1 decal,do not lift
6 250040-099 8 washer, .500 hardened
7 825108-448 4 nut,hex pltd 1/2-13
8 827908-200 4 capscrew,hex gr8 1/2-13 x 2
9 837808-125 4 washer, spr lock reg pltd 1/2
10 866900-040 4 plug, pipe 1” 3000# stl plt
PLEASE NOTE: WHEN ORDERING PARTS, INDICATE SERIAL NUMBER OF COMPRESSOR