Page 1
Chemical Resistance - Composite HoseThe following chart indicates he chemical resistance only of hose and fittings with various conveyants.
Because a hose is chemically resistant does not mean it is suitable, e.g. All hoses listed are resistant to various degrees to aviation fuel but Group 2 hoses should not be used because the polypropylene coated wire will not dissipate static electricity. Group 2 hoses must not be used where static electricity can cause a hazard, the same applies to polypropylene camlocks. Group 2 and 3 hoses are chemically resistant to milk but should not be used if the food quality is to be maintained because of a problem with cleaning the inside of the hose.
The information given is to be used as a guide onyl. Where more than one hose is suitable for an aggressive conveyant and the hose is used close to maximum working pressure or maximum temperature, even though the is an adequate safety margin, it would be prudent to go to a higher rating hose.
Group 1 Hose, polypropylene fabric and steel wireGroup 2 Hose, polypropylene fabric and coated wireGroup 3 Hose, polypropylene fabric and stainless steel wireGroup 4 Hose, polymide and polyester fabrics and stainless steel wireGroup 5 Hose, polyester fabric and stainless steel wireGroup 6 Hose, polyester fabric and steel wire (manufactured on special order only).Group 7 Hose, polymide fabric and stainless steel wire
There are various working pressures for hoses in each group.
There are various working pressures for hoses in each group. Check with the technical charts for this information.
A - suitable up to 60˚CB - suitable ambient temperatureC - suitable ambient temperature Intermittent use i.e. tanker loading and unloading, in some instances. A limited life can be expected.D - not suitable or not knownR - check remarksX - suitable fittings
Select group or groups of hose suitable for conveyant and temperature requirement for Conveyants Chart, then select from Technical Chart which hose in group meets your working pressure requirements.
Acetal B B B X X X
Acetaldehyde 100 D B B X X X X
Acetic Acid (Con.) D B B X X X
Acetic Acid (Dilute) 75 D C C X X X
Acetic Acid Glacial 97 D B B X X X
Acetic Acid Aldehyde D B B X X X X X
Acetic Acid Anhydride 100 D B B X X X X
Acetic Ester B A A X X X X
Acetoecetic Ester 100 D C C X X X X
Acetic Ether C B B X X X X
Acetic Oxide D B B X X X
Acetone 100 A A A B A A B X X X X X X
Acetone Cyanhydrin D B B X X X
Acetophenone 100 B B B X X X X
Acetyl Acetone 100 B B B X X X X X X
Acetonitrile B B B X X X X X
Acetylacetone 100 B B B X X X X X X
Acetyl Chloride 100 D D D
Acetyl Oxide D B B X X X X
Acetylene 100 D D D A X X X X X
Acetylene Dichloride 100 B B B X X X X X X
Acrylic Acid D B B X X X X
Adipic Acid Aqueous SAT A A A X X X X
Agricultural Spray Oil A A A X X X X
Air 80˚C A A A R R X X X X X X
Allyl Alcohol 100 A
Allyl Bromide 100 C C C X X
Allyl Chloride 100 C C C X X
Alum D A A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Alums Aqueous SAT D A A X X X X X
Adiponitrile 100 B B B X X X
Aluminium Acetate Sol SAT D A A X X
Aluminium Hydroxide D A D X X X
Aluminium Salts SAT D A B X X X
Aluminium Flouride D A D X X
Aluminium Sulphate Sol A A A A X X X X X X
Aminoethanolamine D B B X X X X X X
Ammonia Solution ALL D A A X X X
Ammonia Anhydrous A X X
Ammonia in Water D A A X X
Ammonium Salts SAT D A B X X X
Ammonium Chloride SAT D A C X
Ammonium Hydroxide B B B A X X X
Ammonium Nitrae Sol. D B B X X X
Ammonium Phosphate B A A X X X X X
Ammonium Sulphate Sol. B A A R X X X X X
Ammonium Sulphide A A A X X X X X X
Ammonium Sulphite A A A X X X X X
Ammonium Thiosulphate A A A X X X X X X
Ammonium Metaphosphate B A A X X X
Ammonium Persulphate D A A X X
Ammonium Thiocyanate D A A X X X
Amylacetate 100 C C C X X X X X
Amylacetone B B B X X X X X
Amylalcohol 100 B B B B A A B X X X X X X
Amylamine B B B X X X
Amylchloride 100 C C C X X
Amyloleate D D D
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
38
Page 2
Amylphenol C B B X X X X X
Amethole C C C X X X X X
Amyphthalate B B B X X X X X
Anethole D D D B
Aniline 100 A A A X X X X X X
Animal Oils / Grease 100 A A A X X X X X X
Anisole 100 C C C X X
Antimony Chloride ALL D B D X X X X
Antimony Pentachloride D B B X
Antifreeze A A A X X X X
Aqua Regis D C D X
Aromatic Spirits B B B A A X X X X X
Aromatic Tar D D D D R R D X X X X X
Arsenic Acid 80 D B C X
Arsenic Chloride D B D X
Arsenic Trichloride D B D X
Asphalt D D D D R R D X X X X
ASTM Oil No.1 B B B X X X X X
ASTM Oil No. 2 B B B X X X X X
ASTM Oil No. 3 B B B X X X X X
Alphanol A A A X X X X X
Acintene B B B X X X X X
Aviation Fuel B B B A A A A X X X X
Aviation Turbine Fuel B B B A A A A X X X X
Barium Carbonate A A A X X X X X
Barium Chloride Sol B A B X X
Barium Hydroxide B A A X X X X X X
Barium Sulphate B A A X X X X X X
Barium Sulphide B A A X X X X X
Barium Salts SAT D A B X X X
Beer D A A X X X
Beet Sugar Liquors D A A X X X
Belt Oil B B B X X
Benzaldehyde D B C X X X
Benzene (Benzol) B B B B A A B X X X X X
Benzoic Acid Sol. A A A X X X
Benzoic Acid D A A X X X
Benzoic Aldehyde D B B X
Benzotrichloride D D D
Benzoylchloride C C C X X
Benzyl Acetate D B B X X X
Benzyl Alcohol A A A D D D D X X X X X X
Benzyl Butyl Phthalate B B B X X X X
Benzyl Chloride D B C X X
Bichromate of Soda B A A X X X
Bismuth Carbonate A A A X X X
Bleach 12.5% 12.5 D B C X X
Borax A A A X X X X X
Borax Aqueous 10 A A A X X X X X
Boric Acid 10 D A A X X X X X
Brine SAT D A D X
Bromine D D D D D X
Bromine Water SAT D D D
Bromo Benzene D D D
Bromo-chloro Methane D D D
Bromo Tolulene D D D
Bunker C B B B A A X X X X X
Bunker Oil B B B A A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Butadiene 50 B B B A X X X X X
Butane Liquid A X X X X
Butanediol 10 B B B X X X
Butanol C C C X X X
Butyl Alcohol 100 A A A X X X X X
Butyl Acetate 100 C C C A X X X X
Butyl Aceto-Acetate D D D
Butyl Acrylate B B B X X X
Butyl Alcohol Normal B B B X X X
Butyl Aldehyde D D D
Butyl Amine D B B X X
N-Butylamine D B B X X X
Butyl Benzene B B B X X X
Butyl Benzene Phthalate B B B X X X
Buyl Bromide D D D
Butyl Butyrate B B B X X X
Butyl Carbitol A A A X X X X
Butyl Carbitol Acetate C C C X X X
Butyl Cellosolve A A A X X X X
Butyl Chloride D D D
Butyl Ether B B B X X X
Butyl Ethyl Ether B B B X X X
Butylene Glycol 100 A A A X X X X
Butyl Diethoxol D B B X X X
Butyl Ethoxol D B B X X X
Butyl Hydroperoxide B X
Butyl Methacrylate C C C X X X
Butyl Phhalate A A A X X X X X
Butyl Stearate B B B X X X
Butyraldehyde D D D
Butyric Acid 20 B B B X X X X
Butyric Anhydride B B B X X X X X
Butyrolacetone C C C X X X X
Cadmium Acetate C A A X X X
Cadmium Salts D B C X X
Calcium Acetate B A B X X X X X
Calcium Salts SAT D A B X X X
Calcium Aluminate A A A X X X X X
Calcium Alkyl Phenate B A B X X X X X
Calcium Bichromate C A B X X X
Calcium Bisulphate D A A X X X X X
Calcium Bisulphite D A A X X X X X
Calcium Carbonate C A A X X X X X
Calcium Chlorate B A A X X X
Calcium Chloride SAT D A C A X X X X X
Calcium Hydroxide B A A X X X X
Calcium Nitrate D A A X X
Calcium Silicate A A A X X X X X
Calcium Sulphate C A A X X
Calcium Sulphydrate B A A X X X X X
Calcium Sulphide B A A X X X X X
Calcium Sulphite D A A X X X X X
Camphor Oil C C C X X X X
Cane Sugar Liqours D A A X X
Caprylic Acid A A A X X X X X
Carbinols B B B X X X X
Carbitol Acetate C B C X X X X
Carbitol B A B B B X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
39
Page 3
Carbitol Cellosolve D B C X X
Carbolic Acid 100 B A A X X R X
Carbolic Oil C C C X X X X
Carbon Bisulphide D B B X X X X
Carbon Dioxide Gas A A A X X X X X
Carbon Dioxide Liquid A S
Carbon Disulphide 100 D B B A X X X X X
Carbon Tetrachloride C C C X X X X
Carbonic Acid D A A X X X X X
Cashew Nut Shell Oil B B B X X X X
Castor Oil A A A X X X X
Caustic Potash 50 C A B X X X
Caustic Potash 10% 10 A A A X X X
Caustic Soda 50 C A B X X X
Cellosolve 100 B B B X X X X X
Cellosolve Acetate A A A X X X X X X
Chine Wood Oil B B B X X
Cerechlor A A A X X X X X
Chlorinated Solvents D B B X X X X
Chlorine Dry D D D
Chlorine Wet D D D
Chloro Acetic Acid 100 D B D X
Chlorine D D D
Chlorobenzene 100 C C C X X X X
Chlorobutane 100 C C C X X X X
Chloroform 100 C C C A X X X X
Chlorohydrins C C C X
Chloroprene C C C X X X
Chloropropionic Acid D C D X
Chloropentane C C C X X
Chlorobenzol C C C X X X X
Chloro Phenol D C D X X
Chloro Propanone D D D
Chlorosulphonic Acid D D D
Chlorothene C B B X X X X X
Chlorotoluene D D D
Chrome Alum SAT D A A X X X X
Chromic Acid Aqueous 50 D C C X X X X
Citric Acid 100 D A A X X X X
Coal Tar (Refined) 100 B B B A A X X X X
Coal Tar Naphtha B B B A A X X X X
Coal Oil B B B X X X X X
Chromic Acid 80 D B D X X X X
Chromic Acid 50 D A D X X X X
Coconut Oil A A A X X X
Cod Liver Oil A A A X X X X
Coke Oven Gas A A A R X X X X
Compressor Oil A A A X X X
Copper Arsenate D A A X X X
Copper Cyanide D A A X X X
Copper Chloride SAT D A D X
Copper Hydrate D A A X X X
Copper Hydroxide D A A X X X
Copper Nitrate D A A X X X
Copper Nitrite D A A X X X
Copper Salts SAT D A A X X X
Copper Sulphate D A A A X X X
Copper Sulphide D A A X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Corn Oil A A A A A X X X
Cottonseed Oil A A A A A X X X
Creosote 100 B B B X X X X X
Cresols 90 B B B X X X X
Meta Cresol B B B X X X X
Ortho Cresol B B B X X X X
Para Cresol B B B X X X X
Cresol 95% Xylene 5% B B B X X X X
Cresol 90% Xylene 5% B B B X X X X
Cresylic Acid 90 B B B X X X X X
Croton Aldehyde 100 D D D X
Crude Napthenic Oil B B B X X X X
Crude Oil A A A R R X X X X X
Cumene 100 B B B A X X X X X
Cupric Carbonate A A A X X X X
Cupric Chloride D B B X X X X
Cupric Nitrate D A A X X X X
Cupric Nitrite D A A X X X X
Cyclohexane 100 B B B R X X X X X
Cyclohexanol 100 B B B X X X X
Cyclohexanone 100 C C C R X X X X
Cyclohexylamine B B B X X X X
Cyclopentane B B B X X X X
Cyclopentanol B B B X X X X
Cyclopentanone B B B X X X X
Cymene B B B X X X X X
p-Cymene 100 B B B X X X X
D.D.T. 5% D A A X X X X
D.D.T. (in Kerosene) A A A X X X X
Decalin 100 D D D A X X X
Decanol B B B A X X X X
Decyl Alcohol 100 B B B X X X X
Decyl Acrylate 100 B B B X X X X
Decyl Aldehyde D A A X X X
Decyl Butyl Phthalate 100 B B B X X X X
Denaturated Alcohol B B B X X X X
Detergents A A A X X X X X
Dextrin 100 A A A X X X X X
Diacetone D A A X X X X X
Diacetone Alcohol 100 B B B B B B B X X X X X
Diamoinoethylamine 100 C B B X X X X
Diamylamine 100 C B B X X X X
Diamyl Naphthalene B B B X X X X
Diamyl Phenol D B B X X
Dibenzyl Ether B B B X X X X
Dibromoethane 100 D B B X X X X
Dibutylamine 100 C B B X X X X
Dibutyl Ether 100 C C C X X X X
Dibutyl Phthalate 100 B B B X X X X
Dibutyl Sebacate 100 B B B X X X X
Dicalcium Phosphate A A A X X X X X
Dichloroacetate Acid D B C X
Dichloro Benzene 100 C C C X X X X
Dichloro Butane 100 C C C X X X
Dichloro Ethane 100 C C C X X X X
Dichloro Ethylne 100 C C C X X X X
Dichlororethyl-ether 100 C C C X X X X
Dichloro Hexane B X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
40
Page 4
Dichloro Methane 100 C C C B X X X
Dichloropentane B X X X
Dichloro Propane 100 C C C B X X X
Dichloropropylene 100 C C C X X X
Dicyclopentadiene D D D B X X X
Diesel Oil 100 B B B B A A B X X X
Diethanol Amine 100 C A A X X X X X
Diethylamine 100 C B B X X X X
Dibutyl Maleate B B B X X X
Diethylaminoethanol 100 C B B X X X
Diethyl Benzene 100 B B B X X X X
Diethyl Carbinol A A A X X X X X
Diethyl Carbonate D A A X X X X X
Diethylene Dioxide C A B X X X X X
Diethylene Glycol 100 A A A B X X X X X
Diethylene Triamine 100 C B B X X X X
Diethyl Ethanolamine C B B X X X X
Diethyl Ether 100 B B B X X X X
Diethyl Ketone 100 B B B X X X X X
Diethyl Oxalate 100 B B B X X X X
Diethyl Phthalate 100 A A A X X X X X
Diethyl Sebacate 100 A A A X X X X X
Diethyl Sulphate 100 D B B X X X X X
Diethyl Triamine D B B X X X X
Dihydroxy Ethyl Amine B B B X X X X
Diisobutylene C C C B X X X X
Diisobutyl Ketone 100 B B B X X X X
Diisobutyl Phthalate 100 B B B X X X X
Diisooctyl Adipate 100 B B B X X X X
Diisodecyl Phthalate B B B X X X X
Diisooctyl Phthalate A A A X X X X X
Diisoolecyl Adipate B B B X X X X
Diisopropanolamine 100 B B B X X X X
Diisopropyl Ether 100 B B B X X X X
Diisopropyl Ketone 100 B B B X X X X
Dilauryl Ether C C C X X X X
Dimethyl Amine 100 B B B X X X X X
Dimethyl Benzene C B B X X X X
Dimethyl Carbinol B B B X X X X
Dimethyl Ether C C C X X X X
Dimethyl Ethanolamine C B B X X X X
Dimethyl Formamide 100 A A A X X X X X X
Dimethyl Ketone 100 A A A X X X X X
Dimethyl Phenol D A A X X X X
Dimethyl Phthalate 100 B B B X X X X X
Dimethylamino Ethanol B B B X X X X
Dimethyl Sulphate D B B X X X X X
Dimethyl Sulphide100 100 B B B X X X X
Dinitro Benzene 100 D C C X
Dioctyl Adipate B B B X X X X
Dioctyl Amine 100 B B B X X X X
Dioctyl Phthalate 100 B B B A X X X X X
Dioctyl Sebacte 100 B B B X X X X
Dioxane 100 B B B X X X X
Dioxol D C C X X X X
Dipentene 100 B B B X X X X
Diphenyl 100 B B B X X X X X
Diphenyl Ether 100 B B B X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Diphenyl Phthalate 100 B B B X X X X
Dipropyl Amine 100 B B B X X X X
Dipropylene Glycol 100 A A A X X X X X
Dipropyl Ketone A A A X X X X X
Disodium Phosphate A A A X X X X X
Disulphuric Acid D D D
Divinyl Benzene D B B X X X X
Dodecyl Alcohol 100 B B B X X X X
Dodecyl Benzene 100 B B B X X X X
Dodecyl Phenol 100 B B B X X X X
Dodecyl Toluene B B B X X X X
Ethane (Liquid) A X
Epichlorohydrin 100 B B B X X X X X
Ethanoic Acid 60 D A A X X X
Ethanol 96 C C C C X X X X
Ethanol Amine 100 B A A X X X X X X
Ethers C C C B X X X X X
Ethyl Acetate 100 C C C B X X X X X
Ethyl Aceto Acetate 100 D C C X X X X X
Ethyl Acrylate 100 B B B X X X X
Ethyl Alcohol 96 A A A A X X X X X
Ethyl Aldehyde B B B X X X X
Ethyl Amine 100 C B B X X X X
Ethyl Benzene 100 B B B X X X X X
Ethyl Butanol 100 B B B X X X X
Ethyl Butyl Acetate A A A X X X X X
Ethyl Butyl Alcohol A A A X X X X X
Ethyl Butyl Amine B B B X X X X
Ethyl Butyl Ketone A A A X X X X X
Ethyl Butyraldehyde D B B X X X X
Ethyl Cellulose C C C X X X X
Ethyl Chloride 100 C C C X X X X
Ethyl Cyclohexane C C C X X X X
Ethyl Dichloride D B B X X X X
Ethylene (Liquid) A X
Ethylene Carbonate 100 C B B X X X X
Ethylene Chlorohydrin 100 B B B X X X X
Ethylene Cyanohydrin 100 D C C X X X X
Ethylene Bromide D B B X X X X X
Ethylene Diamine 100 B B B X X X X
Ethylene Dibromide 100 C B B X X X
Ethylene Dichloride 100 C C C X X X
Ethylene Glycol 100 A A A X X X X X
Ethyl Ether 100 B B B X X X X
Ethyl Formate 100 D B B X X X X
Ethyl Hexoic Acid D B B X X
Ethylene Oxide @ 10˚C 100 D B B R X X X
Ethyl Hexyl Acetate B B B X X X X
Ethyl Hexyl Acrylate 100 D B B X X X X
Ethyl Hexyl Alcohol 100 A A A X X X X X
2-Ethyl Hexyl Amine C B B X X X X
Ethyl Iodide 100 C C C X X X X
Ethyl Isobutyl Ether 100 D B B X X X X
Ethyl Methyl Ketone B B B X X X X
Ethyl Methacrylate C C C X X X X
Ethyl Propyl Ether 100 B B B X X X X
Ethyl Propyl Ketone 100 C C C X X X X
Ethyl Silicate 100 A A A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
41
Page 5
Ethyl Sulphate 100 B B B X X X X
Ethyl Vinyl Ether 100 B B B X X X X
Ethyl Oxalate 100 B B B X X X X
Ethyl Phthalate A A A X X X X X
Ethylidene Chloride D B B X X X X
Ethoxol B B B X X X X
Ethoxol Acetate B B B X X X X
Ethoxy Ethanol C C C X X X X
Ethoxy Ethyl Acetate 100 B B B X X X X
Fatty Acids 100 D A A X X X X X
Fatty Alcohols 100 A A A X X X X X
Ferric Chloride D A D X
Ferric Bromide D A D X
Ferric Sulphate D A A X X
Ferroc Nitrate D B B X X
Ferrous, Ferric Salts SAT D A B X X X X
Ferrous Acetate D A A X X X
Ferrous Chloride D A D X
Ferrous Hydroxide D A A X X X
Ferrous Sulphate D A A X X X X
Fluoboric Acid D B B X X X X
Flourine D D D
Fluosilicic Acid D A A X X
Formaldehyde Solution 45 D A A X X X
Formalin D A A X X X X
Formamide 100 D A B X X X X
Formic Acid 100 D A B X X X X
Formic Aid 90% 90 D B B X X X
Freon 12 Anhydrous B B B B B X X X
Freon 13 Anhydrous B B B X X X
Freon 21 Anhydrous B B B X X X
Freon 22 Anhydrous B B B X X X
Freon 112 Anhydrous B B B X X X
Freon 114 Anhydrous B B B X X X
Fructose 100 A A A X X X X X X
Fruit Juices D A A X X X
Fuel Oil 100 B B B A A A A X X X X X
Furan C C C X X
Furosilicic Acid D A A X
Furfuryl 100 C C C X X X X
Furfuryl Alcohol 100 C C C X X X
Furyl Methyl Alcohol D A A X X X X X
Fusel Oil A A A X X X X X
Gallic Acid D A A X X X X
Gallic Acid Solution ALL C A A X X X X X X
Gasoline 100 B B B A A X X X X X
Gasoline (100 octane) B B B A A X X X X X
Gelatine Aqueous ALL A A A X X X X X
Glacial Acetic Acid D B B X X
Gluconic Acid ALL C A A X X X X X
Glucose A A A A X X X X
Glucose Aqueous ALL A A A X X X X X
Glue A A A X X X X
Glycerine ALL A A A B B B B X X X X X X
Glycerol ALL A A A B B B B X X X X X X
Glycols Aqueous ALL A A A X X X X X
Glycolic Acid Aqueous 37 D A A X X X X X X
Grease B B B A A A A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Green Sulphate Liquor D B B X
Harness Oil B B B X X X X
Heptanal A A A X X X X X
Heptane 100 B B B A A X X X X
Heptanol 100 A A A X X X X X X
Heptanone 100 B B B X X X X
Heptene 100 B B B X X X X
Hexaldehyde D B B X X
Hexamethyleneimine D C C X X X X
Hexane 100 B B B A A X X X X
Hexanol 100 A A A X X X X X
Hexyl Alcohol A A A X X X X X
Hexyl Amine 100 D B B X X X X
Hexylene D B B X X X
Hexylene Glycol A A A X X X X X
Hexyl Methyl Ketone B B B X X X X
Hydrazine Hydrate D B B X
Hydraulic Oil B B B A A X X X X X
Hydrobromic Acid 50% 50 D A D X
Hydrochloric Acid 30 D B C X
Hydrocynic Acid D A B X X
Hydroflouric Acid 60 D C D X
Hydroflusilic Acid 20 D A A X X X X
Hydrogen Peroxide 90 D B B X X
Hydrogen Peroxide 10% 10 D A A X X X
Hydrogen Peroxide 30% 30 D B B X X
Hydrogen Sulphide Dry D A A X X X X
Hydroxethyl Acetate D B B X X X X
Hydroquinone 100 A A A X X X X
Insulating Oil B B B X X
Iodine D C D X
Iodine Solution D B D X
Iron Acetate Sol. D A A X X X X X
Iron Hydroxide D A A X X X X X
Iron Salts SAT D A B X X X X X
Iron Halides D A D X
Iron Sulphate D A A X X X X X
Iron Sulphide D A A X X X X X
Iron Sulphite D A A X X X X X
Isoamyl Acetate C C C X X X X X
Isoamyl Alcohol 100 B B B X X X X X
Isoamyl Bromide 100 D B D X
Isoamyl Butyrate 100 B B B X X X X X
Isoamyl Chloride 100 D C C X
Isoamyl Ether 100 B B B X X X X X
Isoamyl Phthalate B B B X X X X X
Isobutane D B B B X X X X X
Isobutanol 100 A A A A A X X X X X
Isobutyl Acetate 100 C C C B B X X X X X
Isobutyl Alcohol 100 A A A X X X X X X
Isobutyl Acrylate 100 B B B X X X X
Isobutyl Aldehyde D B B X X X X
Isobutylamine 100 D B B X X X X
Isobutyl Bromide 100 D B D X X
Isobutyl Carbinol D B D X X X X
Isobutyl Chloride 100 D B D X X
Isobutylene B B B B X X
Isobutyl Ether 100 C C C X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
42
Page 6
Isobutyraldehyde D D D
Isobutylene (-6˚C) B B B B X X
Isooctane 100 C C C X X X
Isodecyl Alcohol 100 A A A X X X X
Isopentane 100 C C C X X X
Isopentene 100 C C C X X X
Isophorone 100 B B B X X X X
Isophorone Diamine C C C X X X
Isoprene 100 B B B X X
Isopropanol A A A A A X X X
Isopropanol Amine 100 D B B X X X
Isopropyl Acetate 100 C C C X X X X
Isopropyl Alcohol 100 A A A A A X X X X X
Isopropyl Amine 100 D B B X X X X
Isopropyl Benzene 100 B B B X X X X
Isopropyl Chloride 100 D B D X X
Isopropyl Ether 100 C C C X X X
Isopropyl Toluene 100 B B B X X X X X
Isovaleraldehyde C C C X X X
Jams 100 B A A X X X X
Jet Fuel 100 B B B B A A B X X X X
Jet Fuel (JP1 to JP5) B B B B A A B X X X X
Kerosene 100 B B B B A A B X X X X
Ketones 100 B B B B B A X X X X
Laetic Acid 20 D A B A X X X X
Lanolin A A A X X X X
Lard A A A A A X X X X X
Latex A R A X X X X X
Lauryl Alcohol 100 B B B X X X X
Lead Acetate D A B X X
Lead Alkyls
Lead Salts D A B X X X
Lead Sulphate (Noah) D A B X X X
Ligroin C C C X X X X
Limonene B B B X X X X X X
Light Oil Residual A A A X X X X X
Lime Water A A A X X X X X
Linseed Oil 100 A A A X X X X X X
Lithium Hydroxide A A A X X X X X
Lubricating Oils B B B A A A A X X X X X
Latex (natural) A R A X X X X
Latex (synthetic) A R A X X X X
Magnesium Acetate B A B X X X
Magnesium Carbonate A A A X X X X
Magnesium Chloride D B D X
Magnesium Hydroxide D A A X X X
Magnesium Salts SAT D A B X
Magnesium Sulphate B A A X X X X X
Magnesium Nitrate B A A X X X
Maize Germ Oil B B B X X X X X
Maleic Acid 100 D A B X X X X X
Maleic Acid Aqueous D B C X X X
Maleic Anhydride D C D X X X
Malic Acid 100 D B B X X X
Manganese Salts SAT D A B X X
Magnesium Hydrate D A A X X X
Magnesium Chloride Sol. D A D X
Manganese Sulphate C B B X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Manganese Sulphide C B B X X
Manganese Sulphite C B B X X
Mercuric Chloride D A D X
Mercuric Chloride Sol. D A D X
Mesityl Oxide D A A X X
Methacrylic Acid D B B X X
Methane Liquid D D D A X X X X
Methanol A A A A A X X X X X X
Methyl Acetate 100 C C C B B B A X X X X X
Methyl Alcohol 100 A A A X X X X X X
Methyl Acrylate 100 B B B X X X X X
Methyl Aceto Acetate 100 D C C X X X
Methyl Acetone 100 B B B X X X X X
Methylamine C B B X X X X X X
Methylallyl Acetate D B D X X
Methylallyl Chloride D B D X
Methylallyl Alcohol A A A X X X X X
Methylamyl Acetate 100 C C C X X X X
Metylamyl Alcohol 100 B A A X X X X X
Methylamyl Carbinol 100 B A A X X X X X
Methyamyl Ketone 100 B B B X X X X X
Methyl Benzene B B B X X X X X X
Methyl Butanol A A A X X X X X
Methyl Butyl Ketone 100 B B B X X X X X
Methyl Butyraldehyde D D D
Methyl Carbitol A A A X X X X X
Methyl Cellosolve 100 B B B B B X X X X X
Methyl Chloride 100 C C C R X X X X
Methyl Cyanide 100 B B B X X X X X
Methyl Cyclohexane 100 B B B X X X X X
2 Methyl Pentene C C C X X X X
Methylene Bromide 100 D C C X X
Methylene Chloride D B D X X X
Methyl Ethyl Ketone 100 C C C B B B B X X X X X
Methyl Ethylpyridine C C C X X
Methyl Ethoxol B B B X X X X X
Methyl Hexanol B B B X X X
Methyl Hexanone B B B X X X X X
Methyl Hexyl Ketone B B B X X X X X
Methyl Methacrylate 100 C C C B X X X X
Methyl Propyl Ether D B B X X
Methyl Propyl Ketone B B B X X X X
Methyl Styrene 100 B B B X X X X
Mineral Jelly 100 A A A X X X X X
Mineral Oil 100 B B B A X X X X X
Mineral Spirits 100 B B B X X X X
Mineral Wax D D D
Milk R R
Molasses A A A X X X X X X
Mono Ethanolamine B A A X X X X X
Monoethylamine A A A X X X X
Monobutyl Ether B B B X X X X
Monochloracetic Acid 100 D B D X
Monochloro Benzene D R R X
Mononitrobenzene B B B X X X X
Morpholine 100 B B B X X X X
Motor Oil B B B A X X X X X
Mould Oil B B B A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
43
Page 7
Naphtha 100 B B B A A X X X X X
Naphthalene A A A X X X
Naphthalene (in sol.) 100 A A A X X
Naphthalene Molten D D D A A X X X
Naphtha Solvent C C C A A X X X X X
Natural Gas (liquid) A X X X
Neohexane 100 B B B X X X X
Neutral Oil B B B X X X X
Nickel Chloride SAT D A D X
Nickel Nitrate D A A X
Nickel Salts D A B X X
Nickel Sulphate D A A X X
Nitric Aid 10% / 25% D A B X X
Nitric Acid 25% / 70% D C D X
Nitrobenzene 100 B B B X X
Nitrogen (liquid) A X
O-nitrophenol D A A X X X X X X
Nitropropane 100 C C C X X X X
Nitrotoluene 100 B B B X X X X X
Nitrous Oxide
Nonane 100 B B B X X X X
Nonenes 100 B B B X X X X
Nonyl Alcohol B B B X X X X X
Nonylphenol C C C X X X X
Octadecanoic Acid B B B X X X X
Octane 100 B B B X X X X
Octanol 100 B B B X X X X
Octyl Acetate 100 C C C X X X X
Octyl Acrylate 100 B B B X X X X
Octyl Alcohol B B B X X X X
Octyl Aldehyde D B B X X
Octyl Amine A A A X X X X X
Octyl Carbinol B B B X X X X
Octyl Cresol D A A X X X
Octylene Glycol A A A X X X X X
Oils most commercial B B B A A A A X X X X X
Oil - Mineral B B B A A A A X X X X X
Oleic Acid D B B X
Oleum D D D
Ortho Nitro Toluene D C C X X
Orthoxylene B B B X X X X
Oxalic Acid 50 D B B X
Ozone B B B X X
Paint Oil B B B X X X X X
Palmitic Acid D A A X X X X X X
Palm Oil 100 B B B A A X X X X X
Paraffin A A A X X X X X X
Parffin Wax 100 A A A X X X X X X
Paraldehyde C C C X X X X
Paraxylene B B B X X X X
Paris Green & Lime B A A X X X
Peggasol D A B X X
Pelargonic Acid D A B X X
Pentachloro Ethane D D D
1,3-pentadiene C C C X X X X
Pentane 100 B B B A A X X X X X X
Pentanol 100 A A A X X X X X
Pentanone 100 B B B X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Pentasol 100 B B B X X X X X
Pentene 100 B B B X X X X X
Perchloric Acid 50 D B D X
Perchloroethylene C C C X X X
Petrolatum 100 A A A X X X X X X
Petroleum 100 A A A A A X X X X X X
Petroleum (crude) A A A A A X X X X X X
Petroleum(spirits) A A A A A X X X X X X
Petroleum Ether 100 C C C B B X X X X X
Petroleum Naphtha 100 C C C B B X X X X X
Phenol 100 B A A X X X X
Phenoxyethanol C C C X X X X
Phenyl Hydrazine 100 D C C X
Phosphoric Acid 10-95 D B C X X
Phosphorus D D D
Phosphorus Pentoxide D A B X X
Phthalic Acid 50 D B B X X
Phthalic Anhydride D D D
Picric Acid 1 D B B X X
Pinene B B B X X X X X X
Pine Coating Oil B B B X X X X X
Pine Oil 100 B B B X X X X X X
Pine Tar B B B X X X X X
Plasticizers 100 B B B X X X X X
Polyethylene Glycol 100 B B B X X X X X
Polypropylene Glycol 100 B B B X X X X X X
Potassium Acetate A A A X X X X X
Potassium Bicarbonate A A A X X X X X
Potassium Bisulphate D C C X X X
Potassium Borate A A A X X X
Potassium Bromide D B B X X
Potassium Carbonate D A A X X
Potassium Chlorate D A A X X X
Potassium Chloride D A D X
Potassium Chromate D A A X X
Potassium Dichromate D A A X X X
Potassium Halides D A D X
Potassium Hydrate D A A X X X X X
Potassium Hydroxide D A A X X X X X
Potassium Nitrate D A A X X
Potassium Permangate D A A X X X X
Potassium Salts SAT D A B X
Potassium Silicate D A A X X
Potassium Sulphate D A A X
Potassium Sulphide D A A X
Potassium Sulphite D A A X
Propane Liquid A A X X X
Propellor Oil B A A X X X X X X
Propanediol D A A X X X
Propanol A A A A A X X X X X X
Propyl Acetate 100 C C C A A X X X X
Propyl Alcohol 100 A A A X X X X X X
Propyl Aldehyde D A A X X
Propyl Chloride B B B X X X X X
Propyl Diamine D B B X X X
Propylene Glycol D A A A A X X
Propylene Oxide D C C X X X X
Propenoic Acid D B B X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
44
Page 8
Propinonic Acid D B B X X X X
Propinonic Anhydride D C C X X X X
Propion Aldehyde 100 D C C X X X X
Propyl Amine D B B X X X X X
Propylene Liquid A X X X
Prussic Acid D A A X X
Pyridene 100 D B B X X X X X X
Pyrosulpheric Acid D D D
Pyroligneous Acid D C D X
Petrolatum B B B A A X X X X X X
Quenching Oil B B B X X X X X
Rance Oil B B B X X X X X
Refined Oil B B B X X X X X
Richfield A 100% B B B X X X X
Richfield D 33% B B B X X X X
Salt Solutions D A B X X X
Sea Water D A D X X X
Sewage D B B X X X X
Silicate of Soda D A A X X
Silicone Oil 100 A A A X X X X X
Silver Salts SAT D A B X X X X X
Silver Halides SAT D A D X
Silver Nitrate D A B X X
Soap Solutions B A A X X X X X X
Soda Ash D A A X X X X X
Sodium Acetate A A A X X X X X
Sodium Aluminate D A D X
Sodium Bicarbonate A A A X X X X
Sodium Chlorate D A A X X X
Sodium Chloride SAT D B D X X X
Sodium Cyanide D A B X X
Sodium Bisulphate D A A X X
Sodium Bisulphite D A A X X X
Sodium Carbonate Sol. D A A X X
Sodium Chromate D B D X X
Sodium Dichromate D B D X X
Sodium Flouride D A B X X X
Sodium Hydrate C A B X X X X X
Sodium Hydrosulphide D A B X X X X X
Sodium Hydroxide D B B X X
Sodium Hydrochlorite D B D X
Sodium Hypochlorite 20 D C D X
Sodium Metaphosphate B A B X X X X
Sodium Nitrate D A A X X X X X X
Sodium Salts SAT D A B X X X X
Sodium Sulphate D A A X X
Sodium Sulphide D A A X X
Sodium Sulphite D A A X X
Sodium Silicate A A A X X X
Sodium Thiosulphate 20 D A B X X X
Stannic Chloride D A D X
Stannic Sulphide D A A X X X X
Stannous Chloride D A D X
Stannous Sulphide D A A X X X
Starch Aqueous B A A X X X X X X
Stearic Acid D A A R X X X X
Styrene Monomer 100 B B B X X X X X X
Silicone oil Emulsion A A A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Spermaceti B B B X X X X X
Sperm Oil Alcohol B B B X X X X X
Spindle Oil B B B X X X X X
Sugar Syrup A A A X X X X X X
Sulphamic Acid D B D X X
Sulpholane D D D
Sulphonic Acid D B D X
Sulphonyl Chloride D D D
Sulphur Chloride D D D
Sulphur Dioxide Sol. D A D X X
Sulphur Liquid D D D
Sulphurous Acid D B D X X
Sulphyryl Chloride D D D
Tall Oil 100 A A A X X X X X X
Tallow 100 A A A X X X X X X
Tanners Oil B B B X X X X
Tannic Acid 10 D A A X X X X
Tartaric Acid D A B X X X X
Tetra Bromoethane D A D X X
Tetrachloro Ethane C C C X X X X
Tetrachloro Ethylene C C C X X X X
Tetrachloro Methane D D D X X X
Tetradecanol B B B X X X X
Tetraethylene Glycol 100 B B B X X X X
Tetrahydro Furan D D D A X
Tetralin C C C X X X X X
Thionyl Chloride D D D
Tin Halides D A D X
Tin Salts SAT D A B X
Toluene 100 C C C B B B X X X X X
Toluene Diisocyanate 100 B B B X X X X X
Toluol C C C B B B X X X X X
Transformer Oil 100 B B B X X X X X
Transmission Oil 100 B B B X X X X X
Tributylamine 100 B B B X X X X
Tributyl Phosphate 100 B B B X X X X
Trichloro Benzene 100 C C C X X X X X
Trichloro Ethane 100 C C C X X X X
Trichloro Ethylene 100 C C C X X X X X
Trichloropropane 100 C C C X X X X
Tricresyl Phosphate 100 B B B X X X X X
Tridecanol 100 B B B X X X X
Triethanolamine 100 D B B X X X X X
Triethylamine 100 D B B X X X X X
Triethylbenzene 100 B B B X X X X
Triethylene Glycol 100 A A A X X X X X
Triethylene Tetramine 100 D B B X X X X
Trimethylbenzene 100 B B B X X X X X
Trioctyl Phosphate 100 B B B X X X X
Tripropylene Glycol 100 A A A X X X X X
Trisodium Phosphate A A A A X X X X X
Tritolyl Phosphate 100 B B B X X X X
Trixylenyl Phosphate 100 B B B X X X X
Tung Oil B B B X X X X X
Turbine Oil B B B X X X X
Turpentine 100 C C C A A B X X X X X
Urine D A D X X X X
Urea Aqeous B A B X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
45
Page 9
Urea / Ammonia Sol. B A B X X
Vaseline B B B A A X X X X
Valeraldehyde C C C X X X X
Vegetable Oils A A A X X X X
Vinegar D A A A X X X
Vinyl Acetate D B B B X X X X
Vinyl Chloride D B B B X X
Vinyl Ethyl Ether C C C X X X X
Vinylidene Chloride C C C X X X X
Vinyl Neodecanoate C C C X X X X
Vinyl Toluene B B B X X X X
Waste Oil B B B A X X X X X
Water Potable D A A X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
Water (non drinking) A A A X X X X X X
White Oil B B B A A X X X X
White Spirit 100 D B B A A X X X X
White Paraffin B B B A A X
Whisky D B B X X X X
Wine D B B X
Xylene 100 C C C C C X X X X X
Xylenois 100 B B B X X X X X
Yeast Aqueous D A A X X X
Zinc Chloride Aqueous D A D X X
Zinc Halides D A D X
Zinc Salts Aqueous D A B X X X X X
Zinc Sulphate Aqueous D A B X X X X X
% C
once
ntra
tion
Gro
up 1
Gro
up 2
Gro
up 3
Gro
up 4
Gro
up 5
Gro
up 6
Gro
up 7
M.S
.
S.S
.
Bro
nze
Bra
ss
Alu
m.
Po.
Pro
p.
46
![Chemical Resistance[1]](https://static.documents.pub/doc/80x56/55cf991c550346d0339ba159/chemical-resistance1.jpg)
