Date post: | 31-Mar-2015 |
Category: |
Documents |
Upload: | estrella-speck |
View: | 212 times |
Download: | 0 times |
Chevy 166G-4500 Cutaway Van
Type III Ambulance Conversion
This document is the exclusive property of MEDIX Specialty Vehicles, Inc. and considered “on loan” to those to whom MEDIX has distributed
it. © 2009
Chevy Metro Express 166Type III Ambulance Conversion
We hope this “walk-around” of the Chevy Metro Express 166 Type III by MEDIX Specialty Vehicles, Inc. will assist you in making an informed choice about purchasing a Chevy 166.
MEDIX Specialty Vehicles, Inc. is an experienced manufacturer of Chevrolet Ambulances. In 2001 MEDIX received Approval from General Motors and General Motors International Product Center to perform modifications to the Chevy Cutaway Van and continues to perform to the expectations of both General Motors and MEDIX customers..
Chevy Metro Express 166Type III Ambulance Conversion
Chevy Metro Express 166Type III Ambulance Conversion
Chevy Metro Express 166Type III Ambulance Conversion
Chevy Metro Express 166Type III Ambulance Conversion
Wheel Base159” Completed Vehicle
Weight- 10,115 lbs. Usable Payload- 4,085
lbs.
GVWR – 14,200 lbs. Front GAWR- 4,600 lbs. Rear- GAWR- 9,600 lbs.
Overall Width94”
Overall Length166”
Overall Height
107”
Chevy Metro Express 166Type III Ambulance Conversion
Aisle Width
48.0”
Floor Length
157+”
Interior Headroom
72”
The Chassis
Transmission- Automatic 6-Speed
Rear Axle Ratio- 3.73:1
Engine-Duramax 6.6L V-8 Diesel
Fuel Economy - 8-15 mpg
Batteries- Dual 770 CCATotal CCA- 1,540
In Roll-out tray in Curbside forward compartment
The Chassis
The Chassis
Fuel Fill w/cast aluminum bezel
Tilt Steering Wheel; Power Windows, Door Locks& Mirrors; Dual Captain’s Chairs w/tilt back; AM/FM/CD Radio w/4-spkrs; molded rubber
floor mats
225/75R16 E BSW Tires & Spare Shipped Loose
Stainless Steel Wheel Liners w/ valve extensions-
optional
Environmental Systems
HVAC Unit Output Vents& Filtered Return Air
Located above Walk-Thru
PoweredExhaust
Vent
Free-Blow HVAC System-36K BTU Heat- 32K BTU Cool
720 CFM multi-speed fan, Thermostatic Control
FreshAir
Intake
Electrical Cabinet
Vented, latching, hinged doorLocated above Walk-Thru
Power Distribution & Control
20 Amp Shoreline Inlet
Common component circuitbreakers and relays
Power Distribution & Control
Front Console-Switch Control Panel,Panel for Radios, Cup
Holders, Siren Control Head. Map Book/Report Book Storage Slots - optional
Carson SA 500 Siren Control Head,multi-tone
Switch Control PanelDigital Volt/Amp MeterBack lighted Legends
Indicator Lamps
Power Distribution & Control
CPI Thru-the-BumperMounted Siren
Speakers
Rear Switch Control Panelw/HVAC thermostat control
Power Distribution & Control
12 VDC Outlet w/cover
125 VACDuplex Outlets
Rear Action Area
Emergency Lighting
Whelen 9x7 Red Halogen Warning Lights on all side and rear corners
Whelen 9x7 Amber Halogen Warning Light rear center
Emergency Lighting
Whelen 9x7 Red Halogen Mid-Body Lights
Whelen 7x3 Red Halogen Warning Lights on fenders as Intersection
LightsWhelen 5x2 LED Warning Lights as
Grille Lights
Whelen 4500 Halogen, 4-Red, 1-Clear center, 2- Clear
rotators
Note: Optional 9 x 7 LED Lights replacing Light Bar shown
Patient Compartment Interior
Space for the Patient,Space for the Medic
Easy, safe access to interior
Optional CPR Seat Configuration
Optional CS Cabinet and Window over
Squad Bench
Ten critically spaced dome lights; two fold-down IV Hangers;
Overhead grab rail
Patient Compartment Interior
Aisle Width- 37” w/ Std ALS Cabinet
ALS Cabinet- Lower locking; Upper is open w/shelf or as
Optional Configurations shown
Automotive style Technician’s Seat w/ Type II Lap and Shoulder
beltNOTE: Type I Lap Belt Shown
Steel Cabinet Base Storage w/drop-down latching door
Patient Compartment Interior
Shown with optional 125 VAC heater
Patient Compartment Interior
Inside/Outside Access
LifePak
Area
Action Area
Overhead
CPR Overhead
Storage behind Tech Seat- Inverter Pre-Wire; Vacuum pump
Vacuum-Formed Cushions and Pads
Patient Compartment Interior
Lift-UpSharps/Waste
Shown with optional Cargo Net
2nd Action Area, Storage Cabinet
Patient Compartment Interior Action Area OverheadCPR Seat &
Overhead Cabinet
Primary Action Area
Patient Care Systems
Vacuum Gauge hard plumbed to vacuum Pump; Aspirator Canister; dual quick-connect oxygen outlets (2-in Action Area, 1- over Squad
Bench
Exterior Compartment
Access to Oxygen Cylinder Retention
Bracket
Shown with optional Zico
Cylinder Retention Bracket
•Aluminum Diamond Plate step body& upper threshold• LED Step Light•Stainless steel threshold w/safety grip tape
•Stainless steel threshold w/safety grip tape•Aluminum grip strut, flip-up bumper step•Reflective tape on bumper edge
Protective & Safety Surfaces
Exterior Compartmentation - Streetside
COMPT 1- OxygenStorage; open
storage
COMPT 2- Open Storage w/adjustable shelf
Shown w/optional Spare Tire storage
Shown w/optional Zico Cylinder Retention
Bracket
COMPT 3- Inside/Outside access w/Adjustable shelf & open storage below
Exterior Compartmentation - Curbside
COMPT 4- ALS Cabinet- Inside /Outside access
COMPT 6- Back Board Storage w/Adjustable
beltsShown w/ optional divider
COMPT 5- Battery Storage w/Roll-Out Tray
Paint, Decals, Lettering
Warranties
Paint Stripe- OptionalStar-of-Life Decals- OptionalLettering- Optional
Contact MEDIX3008 Mobile Drive Elkhart, IN 46514 U.S.A.
Ph- 574.266.0911 Fx- 574.266.6669
[email protected]@medixambulance.com
www.medixambulance.com
Structural Warranty- 180 Months (15 yrs)Electrical Warranty- 72 Months/72,000 MilesLimited Warranty- 12 Months/12,000 MilesPaint - 48 Months
MEDIX Specialty Vehicles, Inc.3008 Mobile Drive Elkhart, Indiana 46514 U.S.A.
PH- 574.266.0911 FX- 574.266.6669www.medixambulance.com
Due to on-going product improvements and changing requirements of the ambulance industry, Medix Specialty Vehicles Inc. reserves the right to change this specification and related product without prior notice and without obligation to change prior product or parts.