Air Cooled Water Chillers
CLS 182 to 60241 to 150 kW
Technical BrochureTM CLS-W.3GBDate : October 2004Supersedes : TM CLS-W.2GB/07.04
R
Page 2
Specifications
General characteristicsThe CLS air cooled water chillers have been designed to operatewith the HFC 407C refrigerant.
They are complete with two independent refrigerant circuitsfitted with a high efficiency and low vibration level Scroll compressoron each circuit.
These units are suitable for outdoor installation on the roof of abuilding or on the ground.
All the CLS units are completely factory tested in compliance withthe internal quality system specifications and procedures, and areready for field installation.
The "Plug and Play" concept has been introduced in each CLS unit,thanks to the use of BMS compatible microprocessor-based controlsystem and to the integrated hydraulic module supplied asoptional on all versions of the CLS range.
Also, thanks to the versions and options available, the CLSair cooled water chillers can fit all the demands of the market.
The CLS range is available in 5 versions; each version is composedof 9 sizes.
CLS STD : Standard version fitted with standard equipmentintended for reliable operation. The CLS STD units cover a nominalcooling capacity range from 41 to 150 kW.
CLS LN : Low noise version having same equipment as STDversion, except that it is fitted with low speed type larger size fans.The CLS LN units cover a nominal cooling capacity range from 41to 150 kW.
CLS ELN : Extra low noise version fitted with greater heatexchange surface area condenser coils, very low speed type fansand a stepless fan speed controller. Furthermore, the ELN versionis equipped with a reinforced soundproofing :
- mufflers mounted on compressor discharge lines (all sizes),
- soundproofing jacket on compressor (sizes 182 to 302),
- sound insulation on compressor compartment (sizes 352 to 602).
The CLS ELN units cover a nominal cooling capacity range from41 to 150 kW.
CLS HPF : High pressure fan version having same equipment asSTD version, except that larger size fans with 80 Pa external staticpressure are fitted on this HPF version. The CLS HPF units cover anominal cooling capacity range from 41 to 145 kW.
CLS HT : High temperature version having same equipment asSTD version, except that it is fitted with fans allowing unit to operateat high ambient temperatures (up to +48 °C). The CLS HT unitscover a nominal cooling capacity range from 44 to 155 kW.
Reference standardsThe following applies to all the sizes and versions belonging to theCLS units :
✓ Performance test EN 12055
✓ Machine Directive CEE 89 / 392
✓ Low Voltage Directive CEE 73/23 (EN 60204-1)
✓ Electromagnetic Compatibility Directive CEE 89/336 asmodified by Directive CEE 92/31 (EN 50081-1, EN 50082-2)
Cabinet and structureThe unit structure shall be of heavy gauge galvanized steel fastenedwith non-corrosive screws and bolts. Galvanized steel parts shallbe painted with baked on enamel colored white (RAL 9001).
CompressorsEach unit shall be equipped with 2 Scroll hermetic compressors.
Compressors on all models shall be mounted on rubber anti-vibration pads and have direct on line starting.
The compressor motors shall be refrigerant gas cooled, with integralthermistor protection against overloads. The overload protection isautomatically reset.
The motor terminal boxes shall have IP-54 weather protection.
EvaporatorEvaporators are of a brazed stainless steel plate type heat exchanger.They are insulated with a closed cell foam material and are fittedwith an electric cable resistance to prevent the unit from freezingat a low temperature when the unit is off.
Design working pressure shall be 10 bar on the water side and30 bar on the refrigerant side.
Water connections are of a 2 " Victaulic type on each evaporator.Optional inlet and outlet 2" male threaded gas type manifolds canbe supplied to ensure single flow and return water connections.
Condenser coilsThe condenser coils shall be seamless copper tubes, arranged instaggered rows, mechanically expanded into corrugated aluminumfins.
Condenser coil fansThe condenser fans shall be direct drive with aluminum wing contourblades. Each fan will have a painted galvanized steel protectionguard.
The totally enclosed fan motors shall have IP 54 degree of protectionand thermo-contact protection embedded in their windings.
Fan controlsEach unit can be equipped, as optional , with a stepless fan speedcontroller, operating on the basis of condensing pressure, to keepfan rpm under control in order to operate at a low ambienttemperature (-18 °C).
This fan speed controller is supplied as standard on the ELN units.However, it is not available on HPF and HT units.
Refrigerant circuitsAll the units are composed of two independent and separaterefrigerant circuits. All the components that constitute each circuitare shwon on the functional diagram (see chapter "Refrigerant flowdiagram").
Integrated hydraulic module (optional)Units can be supplied with optional integrated hydraulic modulecomposed of water tank and 1 or 2 pumps complete with accessories.
Antifreeze heater is supplied as standard in the tank.
Units can also be supplied with pump kit only (with 1 or 2 pumps).
Page 3
Specifications (continued)
Control
76
1
8 5 4
2 3
9 10
11
Power and control panelThe control compartment shall contain an electronic circuit boardand a key control panel with display of operating parameters,alarms and stops.
Thermal relays and fuses are supplied to protect compressors, fansand pumps from overloading.
Control and safety devicesEach CLS unit is fitted with the following devices :
Safety :
✓ Fan thermal protection.
✓ Compressor thermal protection.
✓ Water differential pressure switch.
✓ High pressure switch.
✓ Evaporator antifreeze protection.
✓ Low pressure switch.
✓ Crankcase heater.
Control :
✓ Evaporator water inlet temperature sensor.
✓ Evaporator water outlet temperature sensor.
Factory-installed accessories and options✓ Coils with hydrophilic coated fins.✓ Coils with vinyl coated fins.✓ Coils with polyurethane coated fins.✓ Copper / Copper coils.✓ LP & HP manometers.✓ Condenser coil guards.✓ Integrated hydraulic module with water tank, antifreeze
resistance and 1 or 2 pumps.
✓ Pump kit with 1 or 2 pumps.✓ Compressor overload protection kit.✓ Inlet and outlet water connection manifolds.✓ Phase monitor.✓ Stepless fan speed controller (STD and LN versions).
Field-installed accessories✓ Water filter.✓ Flow switch.✓ Spring anti-vibration mounts.✓ Remote control kit (On/Off, Cooling).✓ Modbus interface kit.✓ Remote keyboard panel.✓ Chiller sequencer (4 units maximum).
The controller provides information on status of operation,configuration and alarms through a display and LEDs on the frontpanel.
Display
It allows mainly to show :
- the entering water temperature of the unit in tenths of degreesCelsius with a decimal point,
- the alarm code if at least one alarm is active.
LEDs1 - Heating mode display : not used
2 - Cooling mode display
3 - Operating mode selection
4 - Unit On/Off; Alarm restoration
5 - Display
6 - Compressor 2 ON LED (Blink : time delay in progress)
7 - Electric resistance ON LED
8 - Compressor 1 ON LED (Blink : time delay in progress)
9 - Voltage ON LED
10 - Unit activated alarm LED
11 - Start key and LED - Cooling
If COOLING LED is OFF, the controller is in STANDBY mode.
Controller display panel Remote control kit (optional)
Page 4
Refrigerant Flow Diagram
Components (refrigerant circuits) :
1 - Compressors C1, C2
2 - Discharge valve
3 - Muffler (for ELN version only)
4 - Air cooled condenser
5 - PED pressure relief valve
6 - Liquid valve
7 - Filter drier
8 - Sight glass
9 - Expansion valve
10 - Plate heat exchanger
Safety / Control devices :
- High pressure switch
- Low pressure switch
- Transducer (optional)
- Water differential pressure switch
- Pressure tapping and refrigerantcharging/discharging points
Components (optional hydraulic module) :
A - Shutoff valve
B - Pump(s)
C - Check valve
D - Expansion tank
E - Relief valve
F - Air vent
G - Filling up valve
H - Drain valve
I - Manometer
L - Water tank
Refrigerant circuits Hydraulic module (optional)
BP1
CT2
AP1
PED
4
3
5
6
7 89
101
C2
G
D
L
A
A
A
A
C
C
B
B
E F
HI
2
BP1
CT1
D
AP1
PED
4
3
5
6
7 89
101
C1
2
A
B
C
D
Page 5
Operating Limits
CLS 182 to 302
CLS 352 to 602
Min. Max. Min. Max. Min. Max. Min. Max.
Water °C
Brine (for low liquid temp. application)
°C
Temperature difference K
Flow rate l/h 3902 9106 6731 15705 7949 18547 9104 21242
bar
Cooling - STD / LN / HPF °C 15 46 15 46 15 46 15 46
Cooling - ELN °C -18 46 -18 46 -18 46 -18 46
Cooling - HT °C 15 48 15 48 15 48 15 48
Standard fans Pa
High pressure fans -HPF version
Pa
litres
Nominal supply voltage
330 370
Temperature difference
Recommended system chilled water volume
+6 to +15
-8 to +5
3 to 7
400 V / 3 Ph / 50 Hz
10
0
80
200 280
302
Chiller
Liquid outlet temperature
Ambient air
Air entering temperature
External static pressure
CLS182 202 242
Min. Max. Min. Max. Min. Max. Min. Max. Min. Max.
Water °C
Brine (for low liquid temp. application)
°C
Temperature difference K
Flow rate l/h 11168 26058 12925 30157 14817 34572 16641 38829 18367 42857
bar
Cooling - STD / LN / HPF °C 15 46 15 46 15 44 15 44 15 44
Cooling - ELN °C -18 46 -18 46 -18 44 -18 44 -18 44
Cooling - HT °C 15 48 15 48 15 46 15 46 15 46
Standard fans Pa
High pressure fans - HPF version
Pa
litres
400 V / 3 Ph / 50 Hz
552 602
+6 to +15
450 530 600
-8 to +5
3 to 7
CLS352 402 502
10
0
677 747
80
Nominal supply voltage
Max. operating pressure - Water side
Recommended system chilled water volume
Ambient air
Air entering temperature
Chiller
Liquid outlet temperature
External static pressure
Page 6
Correction Factors
Fouling factors
Altitude factorsAltitude (m) Cooling capacity factor Power input factor
0 1.000 1.000600 0.987 1.0101200 0.973 1.0201800 0.958 1.0292400 0.943 1.038
Fouling factor(m2.°C/kW)
Cooling capacityfactor
Power inputfactor
Fouling factor(m2.°C/kW)
Cooling capacityfactor
Power inputfactor
0.044 1.000 1.000 0.044 1.000 1.0000.088 0.987 0.995 0.088 0.987 1.0230.176 0.964 0.985 0.176 0.955 1.0680.352 0.915 0.962 0.352 0.910 1.135
EVAPORATOR CONDENSER
Ethylene glycol solution correction factorsEthylene glycol percent by weight % 10 20 30 35 40Freezing point °C -4 -10 -17 -21 -25Cooling capacity correction factors (1) 0.995 0.985 0.970 0.963 0.955Power input correction factors (1) 0.998 0.995 0.985 0.983 0.980Flow rate correction factors 1.015 1.050 1.085 1.123 1.160Pressure drop correction factors (2) 1.070 1.160 1.235 1.283 1.330
(1) Factors applicable only for glycol solution leaving temperature >= 7 °C. For temperatures < 7 °C, refer to table "Low temperatureoperation correction factors".
(2) Factors applicable only for glycol solution leaving temperature > 5 °C. For temperatures < 5 °C, refer to table "Pressure drop correctionfactors for low temperature operation".
Low temperature operation correction factorsLeaving water temperature °C 7 4 2 0 -2 -4 -6 -8Minimum ethylene glycol percent % 0 10 10 20 20 30 30 35Cooling capacity correction factors 1.000 0.887 0.816 0.748 0.685 0.624 0.568 0.513Power input correction factors 1.000 0.940 0.900 0.865 0.826 0.788 0.753 0.718
Pressure drop correction factors for low temperature operation
Ethylene glycol percent by weight Glycol solution leaving temperature (°C) Pressure drop correction factors5 1.0714 1.0763 1.0812 1.0851 1.1930 1.200-1 1.208-2 1.215-3 1.299-4 1.306-5 1.320-6 1.333
10%
20%
30%
Page 7
Physical Data - CLS STD
(1) Data based on 7 °C leaving chilled water temperature and 35 °C ambient air temperature.(2) Maximum power input includes : maximum compressor power input and maximum fan power input.(3) Sound pressure level values refer to ISO standard 3744.(*) With optional manifolds.
CLS STD sizes 182 202 242 302 352 402 502 552 602
Nominal cooling capacity (1) kW 40.9 54.1 64.9 74.3 90.0 105.3 121.4 135.5 149.5
Compressor power input - Cooling kW 12.3 18.2 24.2 27.7 33.2 37.5 46.2 51.7 57.1
Maximum power input (2) kW 18.8 25.4 30.0 35.6 42.5 49.0 59.4 64.7 71.8
EER 3.3 3.0 2.7 2.7 2.7 2.8 2.6 2.6 2.6
Number of refrigerant circuits 2 2 2 2 2 2 2 2 2
Total unit capacity steps % 50/100 50/100 50/100 50/100 43-57/100 50/100 50/100 43-57/100 50/100
Refrigerant
Type
Charge kg 7 7 9 10 12 12 17 18.5 20
Compressors
Number 2 2 2 2 2 2 2 2 2
Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
Evaporators
Number 2 2 2 2 2 2 2 2 2
Type Plate Plate Plate Plate Plate Plate Plate Plate Plate
Antifreeze heater power input W 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35
Air cooled condensers
Number 2 2 2 2 2 2 2 2 2
Total coil face area per coil m2 2.1 2.1 2.1 2.1 2.85 2.85 3.6 3.6 3.6
Number of rows 2 2 3 4 3 4 4 5 5
Fans
Number 2 2 2 2 3 3 3 3 3
Total air flow m3/h 21000 21000 20300 19700 30000 28700 30000 30000 30000
Power input kW 0.96 0.96 0.96 0.96 1.44 1.44 1.44 1.44 1.44
Water connection *
Type
Inlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Outlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Dimensions
Length mm 2110 2110 2110 2110 2760 2760 3110 3110 3110
Width mm 1110 1110 1110 1110 1110 1110 1110 1110 1110
Height mm 1750 1750 1750 1750 1750 1750 1750 1750 1750
Weight
Basic - Shipping / Operating kg 600 / 610 630 / 640 754 / 764 808 / 818 888 / 898 962 / 972 1050 / 1060 1185 / 1195 1220 / 1230
1 pump - Shipping / Operating kg 632 / 642 662 / 672 786 / 796 840 / 850 920 / 930 994 / 1004 1082 / 1092 1217 / 1227 1252 / 1262
2 pumps - Shipping / Operating kg 652 / 662 682 / 692 806 / 816 860 / 870 940 / 950 1014 / 1024 1102 / 1112 1237 / 1247 1272 / 1282
Water tank + 1 pump - Shipping/Operating kg 697 / 907 727 / 937 851 / 1061 905 / 1115 1020 / 1350 1094 / 1424 1202 / 1602 1337 / 1737 1372 / 1772
Water tank + 2 pumps - Shipping/Operating kg 717 / 927 747 / 957 871 / 1081 925 / 1135 1040 / 1370 1114 / 1444 1222 / 1622 1357 / 1757 1392 / 1792
Sound levels
Sound power levels dB(A) 84 84 86 86 89 89 90 90 90
Sound pressure levels at 10 meters (3) dB(A) 52 52 54 54 57 57 58 58 58
HFC 407 C
Male gas threaded
Page 8
Physical Data - CLS LN
(1) Data based on 7 °C leaving chilled water temperature and 35 °C ambient air temperature.(2) Maximum power input includes : maximum compressor power input and maximum fan power input.(3) Sound pressure level values refer to ISO standard 3744.(*) With optional manifolds.
CLS LN sizes 182 202 242 302 352 402 502 552 602
Nominal cooling capacity (1) kW 40.9 54.1 64.9 74.3 90.0 105.3 121.4 135.5 149.5
Compressor power input - Cooling kW 12.3 18.2 24.2 27.7 33.2 37.5 46.2 51.7 57.1
Maximum power input (2) kW 19.3 25.9 30.4 36.0 43.2 49.7 60.1 65.4 72.5
EER 3.3 3.0 2.7 2.7 2.7 2.8 2.6 2.6 2.6
Number of refrigerant circuits 2 2 2 2 2 2 2 2 2
Total unit capacity steps % 50/100 50/100 50/100 50/100 43-57/100 50/100 50/100 43-57/100 50/100
Refrigerant
Type
Charge kg 7 7 9 11 12 13 17 18.5 20
Compressors
Number 2 2 2 2 2 2 2 2 2
Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
Evaporators
Number 2 2 2 2 2 2 2 2 2
Type Plate Plate Plate Plate Plate Plate Plate Plate Plate
Antifreeze heater power input W 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35
Air cooled condensers
Number 2 2 2 2 2 2 2 2 2
Total coil face area per coil m2 2.1 2.1 2.1 2.1 2.85 2.85 3.6 3.6 3.6
Number of rows 2 2 3 4 3 4 4 5 5
Fans
Number 2 2 2 2 3 3 3 3 3
Total air flow m3/h 21000 21000 21000 20100 30500 29000 31500 31500 31500
Power input kW 1.4 1.4 1.4 1.4 2.1 2.1 2.1 2.1 2.1
Water connection *
Type
Inlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Outlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Dimensions
Length mm 2110 2110 2110 2110 2760 2760 3110 3110 3110
Width mm 1110 1110 1110 1110 1110 1110 1110 1110 1110
Height mm 1850 1850 1850 1850 1850 1850 1850 1850 1850
Weight
Basic - Shipping / Operating kg 600 / 610 630 / 640 754 / 764 808 / 818 888 / 898 962 / 972 1050 / 1060 1185 / 1195 1220 / 1230
1 pump - Shipping / Operating kg 632 / 642 662 / 672 786 / 796 840 / 850 920 / 930 994 / 1004 1082 / 1092 1217 / 1227 1252 / 1262
2 pumps - Shipping / Operating kg 652 / 662 682 / 692 806 / 816 860 / 870 940 / 950 1014 / 1024 1102 / 1112 1237 / 1247 1272 / 1282
Water tank + 1 pump - Shipping/Operating kg 697 / 907 727 / 937 851 / 1061 905 / 1115 1020 / 1350 1094 / 1424 1202 / 1602 1337 / 1737 1372 / 1772
Water tank + 2 pumps - Shipping/Operating kg 717 / 927 747 / 957 871 / 1081 925 / 1135 1040 / 1370 1114 / 1444 1222 / 1622 1357 / 1757 1392 / 1792
Sound levels
Sound power levels dB(A) 80 80 82 82 85 85 86 86 86
Sound pressure levels at 10 meters (3) dB(A) 48 48 50 50 53 53 54 54 54
HFC 407C
Male gas threaded
Page 9
Physical Data - CLS ELN
(1) Data based on 7 °C leaving chilled water temperature and 35 °C ambient air temperature.(2) Maximum power input includes : maximum compressor power input and maximum fan power input.(3) Sound pressure level values refer to ISO standard 3744.(*) With optional manifolds.
CLS ELN sizes 182 202 242 302 352 402 502 552 602
Nominal cooling capacity (1) kW 40.8 54.1 63.8 69.4 88.9 99.1 121.4 135.5 149.5
Compressor power input - Cooling kW 12.3 18.2 24.7 30.2 33.8 40.8 46.2 51.7 57.1
Maximum power input (2) kW 19.3 25.9 30.4 36.0 43.2 49.7 60.1 65.4 72.5
EER 3.3 3.0 2.6 2.3 2.6 2.4 2.6 2.6 2.6
Number of refrigerant circuits 2 2 2 2 2 2 2 2 2
Total unit capacity steps % 50/100 50/100 50/100 50/100 43-57/100 50/100 50/100 43-57/100 50/100
Refrigerant
Type
Charge kg 7.5 7.5 9 11 12 12 17 18.5 20
Compressors
Number 2 2 2 2 2 2 2 2 2
Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
Evaporators
Number 2 2 2 2 2 2 2 2 2
Type Plate Plate Plate Plate Plate Plate Plate Plate Plate
Antifreeze heater power input W 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35
Air cooled condensers
Number 2 2 2 2 2 2 2 2 2
Total coil face area per coil m2 2.1 2.1 2.1 2.1 2.85 2.85 3.6 3.6 3.6
Number of rows 3 3 4 4 4 4 4 5 5
Fans
Number 2 2 2 2 3 3 3 3 3
Total air flow m3/h 14400 14400 14400 13800 20100 19900 21650 31500 31500
Power input kW 1.4 1.4 1.4 1.4 2.1 2.1 2.1 2.1 2.1
Water connection *
Type
Inlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Outlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Dimensions
Length mm 2110 2110 2110 2110 2760 2760 3110 3110 3110
Width mm 1110 1110 1110 1110 1110 1110 1110 1110 1110
Height mm 1850 1850 1850 1850 1850 1850 1850 1850 1850
Weight
Basic - Shipping / Operating kg 642 / 652 668 / 678 796 / 806 818 / 828 950 / 960 974 / 984 1070 / 1080 1205 / 1215 1240 / 1250
1 pump - Shipping / Operating kg 674 / 684 700 / 710 828 / 838 850 / 860 982 / 992 1006 / 1016 1102 / 1112 1237 / 1247 1272 / 1282
2 pumps - Shipping / Operating kg 694 / 704 720 / 730 848 / 858 870 / 880 1002 / 1012 1026 / 1036 1122 / 1132 1257 / 1267 1292 / 1302
Water tank + 1 pump - Shipping/Operating kg 739 / 949 765 / 975 893 / 1103 915 / 1125 1082 / 1412 1106 / 1436 1222 / 1622 1357 / 1757 1392 / 1792
Water tank + 2 pumps - Shipping/Operating kg 759 / 969 785 / 995 913 / 1123 935 / 1145 1102 / 1432 1126 / 1456 1242 / 1642 1377 / 1777 1412 / 1812
Sound levels
Sound power levels dB(A) 77 77 78 78 79 81 82 82 82
Sound pressure levels at 10 meters (3) dB(A) 45 45 46 46 47 49 50 50 50
HFC 407C
Male gas threaded
Page 10
Physical Data - CLS HPF
(1) Data based on 7 °C leaving chilled water temperature and 35 °C ambient air temperature.(2) Maximum power input includes : maximum compressor power input and maximum fan power input.(3) Sound pressure level values refer to ISO standard 3744.(*) With optional manifolds.
CLS HPF sizes 182 202 242 302 352 402 502 552 602
Nominal cooling capacity (1) kW 40.9 54.1 64.9 74.3 90.0 105.3 121.4 133.4 145.4
Compressor power input - Cooling kW 12.3 18.2 24.2 27.7 33.2 37.5 46.2 51.7 57.1
Maximum power input (2) kW 19.8 26.4 31.0 36.6 44.0 50.5 60.9 65.4 72.5
EER 3.3 3.0 2.7 2.7 2.7 2.8 2.6 2.6 2.5
Number of refrigerant circuits 2 2 2 2 2 2 2 2 2
Total unit capacity steps % 50/100 50/100 50/100 50/100 43-57/100 50/100 50/100 43-57/100 50/100
Refrigerant
Type
Charge kg 7.5 7.5 9 11 12 12 17 18.5 20
Compressors
Number 2 2 2 2 2 2 2 2 2
Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
Evaporators
Number 2 2 2 2 2 2 2 2 2
Type Plate Plate Plate Plate Plate Plate Plate Plate Plate
Antifreeze heater power input W 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35
Air cooled condensers
Number 2 2 2 2 2 2 2 2 2
Total coil face area per coil m2 2.1 2.1 2.1 2.1 2.85 2.85 3.6 3.6 3.6
Number of rows 2 2 3 4 3 4 4 5 5
Fans
Number 2 2 2 2 3 3 3 3 3
Total air flow m3/h 21000 21000 20300 19700 30000 28700 30000 30000 30000
Power input kW 1.96 1.96 1.96 1.96 2.94 2.94 2.94 2.94 2.94
Water connection *
Type
Inlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Outlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Dimensions
Length mm 2100 2100 2100 2100 2760 2760 3110 3110 3110
Width mm 1110 1110 1110 1110 1110 1110 1110 1110 1110
Height mm 1850 1850 1850 1850 1850 1850 1850 1850 1850
Weight
Basic - Shipping / Operating kg 600 / 610 630 / 640 754 / 764 808 / 818 888 / 898 962 / 972 1050 / 1060 1185 / 1195 1220 / 1230
1 pump - Shipping / Operating kg 632 / 642 662 / 672 786 / 796 840 / 850 920 / 930 994 / 1004 1082 / 1092 1217 / 1227 1252 / 1262
2 pumps - Shipping / Operating kg 652 / 662 682 / 692 806 / 816 860 / 870 940 / 950 1014 / 1024 1102 / 1112 1237 / 1247 1272 / 1282
Water tank + 1 pump - Shipping/Operating kg 697 / 907 727 / 937 851 / 1061 905 / 1115 1020 / 1350 1094 / 1424 1202 / 1602 1337 / 1737 1372 / 1772
Water tank + 2 pumps - Shipping/Operating kg 717 / 927 747 / 957 871 / 1081 925 / 1135 1040 / 1370 1114 / 1444 1222 / 1622 1357 / 1757 1392 / 1792
Sound levels
Sound power levels dB(A) 87 87 89 89 92 92 93 93 93
Sound pressure levels at 10 meters (3) dB(A) 55 55 57 57 60 60 61 61 61
HFC 407C
Male gas threaded
Page 11
Physical Data - CLS HT
(1) Data based on 7 °C leaving chilled water temperature and 35 °C ambient air temperature.(2) Maximum power input includes : maximum compressor power input and maximum fan power input.(3) Sound pressure level values refer to ISO standard 3744.(*) With optional manifolds.
CLS HT sizes 182 202 242 302 352 402 502 552 602
Nominal cooling capacity (1) kW 43.9 58.3 70.0 79.4 93.4 109.2 125.9 140.4 155.0
Compressor power input - Cooling kW 12.2 17.7 23.3 25.9 31.8 35.8 44.3 49.5 54.7
Maximum power input (2) kW 19.8 26.4 31.0 36.6 44.0 50.5 60.9 65.4 72.5
EER 3.6 3.3 3.0 3.1 2.9 3.1 2.8 2.8 2.8
Number of refrigerant circuits 2 2 2 2 2 2 2 2 2
Total unit capacity steps % 50/100 50/100 50/100 50/100 43-57/100 50/100 50/100 43-57/100 50/100
Refrigerant
Type
Charge kg 7.5 7.5 9 11 12 12 17 18.5 20
Compressors
Number 2 2 2 2 2 2 2 2 2
Type Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll Scroll
Evaporators
Number 2 2 2 2 2 2 2 2 2
Type Plate Plate Plate Plate Plate Plate Plate Plate Plate
Antifreeze heater power input W 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35 2 x 35
Air cooled condensers
Number 2 2 2 2 2 2 2 2 2
Total coil face area per coil m2 2.1 2.1 2.1 2.1 2.85 2.85 3.6 3.6 3.6
Number of rows 2 2 3 4 3 4 4 5 5
Fans
Number 2 2 2 2 3 3 3 3 3
Total air flow m3/h 36700 36700 35500 25500 38800 37200 39600 30000 30000
Power input kW 1.96 1.96 1.96 1.96 2.94 2.94 2.94 2.94 2.94
Water connection *
Type
Inlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Outlet diameter inch 2" 2" 2" 2" 2" 2" 2" 2" 2"
Dimensions
Length mm 2100 2100 2100 2100 2760 2760 3110 3110 3110
Width mm 1110 1110 1110 1110 1110 1110 1110 1110 1110
Height mm 1850 1850 1850 1850 1850 1850 1850 1850 1850
Weight
Basic - Shipping / Operating kg 600 / 610 630 / 640 754 / 764 808 / 818 888 / 898 962 / 972 1050 / 1060 1185 / 1195 1220 / 1230
1 pump - Shipping / Operating kg 632 / 642 662 / 672 786 / 796 840 / 850 920 / 930 994 / 1004 1082 / 1092 1217 / 1227 1252 / 1262
2 pumps - Shipping / Operating kg 652 / 662 682 / 692 806 / 816 860 / 870 940 / 950 1014 / 1024 1102 / 1112 1237 / 1247 1272 / 1282
Water tank + 1 pump - Shipping/Operating kg 697 / 907 727 / 937 851 / 1061 905 / 1115 1020 / 1350 1094 / 1424 1202 / 1602 1337 / 1737 1372 / 1772
Water tank + 2 pumps - Shipping/Operating kg 717 / 927 747 / 957 871 / 1081 925 / 1135 1040 / 1370 1114 / 1444 1222 / 1622 1357 / 1757 1392 / 1792
Sound levels
Sound power levels dB(A) 87 87 89 89 92 92 93 93 93
Sound pressure levels at 10 meters (3) dB(A) 55 55 57 57 60 60 61 61 61
HFC 407C
Male gas threaded
Page 12
Electrical Data
Compressors @ 400 V / 3 Ph / 50 Hz
Power input at nominal conditions
per compressor
(kW)
Current at nominal
conditions per
compressor (A)
Power input at max.
conditions per
compressor(kW)
Current at max.
conditions per
compressorFLA (A)
Start up currentLRA (A)
Power factor at nominal
conditions
Crankcase heater @ 230 V/1Ø
(W)
Unit fuse(A)
Cable section (mm2)
Circuit 1 6 10.1 9 15 99 0.84 70
Circuit 2 6 10.1 9 15 99 0.84 70
Circuit 1 8.5 14.4 12 21 127 0.84 70
Circuit 2 8.5 14.4 12 21 127 0.84 70
Circuit 1 12 20 15 24 150 0.87 65
Circuit 2 12 20 15 24 150 0.87 65
Circuit 1 13.7 24.3 17 29 175 0.81 75
Circuit 2 13.7 24.3 17 29 175 0.81 75
Circuit 1 13.7 24.3 17 29 175 0.81 75
Circuit 2 18.6 31.4 24 38.5 215 0.86 130
Circuit 1 18.6 31.4 24 38.5 215 0.86 130
Circuit 2 18.6 31.4 24 38.5 215 0.86 130
Circuit 1 23 38.5 29 47 270 0.86 130
Circuit 2 23 38.5 29 47 270 0.86 130
Circuit 1 20.3 34.3 28 48 272 0.84 150
Circuit 2 25.3 44.2 35 58.5 320 0.83 150
Circuit 1 25.3 44.2 35 58.5 320 0.83 150
Circuit 2 25.3 44.2 35 58.5 320 0.83 150
552 125 70
602 160 70
CLS models
182 50
242 63 25
16
202 63 25
352 100 35
302 80 35
502 125 50
402 100 35
Page 13
Electrical Data (continued)
Units @ 400 V / 3 Ph / 50 Hz
Pump(s)
CLS STD models 182 202 242 302 352 402 502 552 602Nominal current input A 22.2 30.6 41.9 50.5 58.5 65.6 79.8 81.3 91.2Maximum current input A 32.1 43.3 49.9 59.9 70.3 79.8 97.2 108.8 119.8Nominal power input kW 13.0 18.0 25.0 28.4 33.7 38.6 47.5 47.0 52.0Maximum power input kW 18.8 25.4 30.0 35.6 42.5 49.0 59.4 64.7 71.8Starting current (LRA) A 116 150 176 206 247 256 320 370 381
CLS LN / ELN models 182 202 242 302 352 402 502 552 602Nominal current input A 22.6 31.0 42.3 50.9 59.2 66.3 80.5 82.0 91.9Maximum current input A 32.5 43.7 50.3 60.3 71.0 80.5 97.9 109.5 120.5Nominal power input kW 13.4 18.4 25.4 28.8 34.4 39.3 48.1 47.7 52.7Maximum power input kW 19.3 25.9 30.4 36.0 43.2 49.7 60.1 65.4 72.5Starting current (LRA) A 116 150 176 206 247 257 321 371 382
CLS HPF / HT models 182 202 242 302 352 402 502 552 602Nominal current input A 23.7 32.1 43.4 52.0 60.8 67.9 82.1 83.6 93.5Maximum current input A 33.6 44.8 51.4 61.4 72.6 82.1 99.5 111.1 122.1Nominal power input kW 14.0 19.0 26.0 29.4 35.2 40.1 49.0 48.5 53.5Maximum power input kW 19.8 26.4 31.0 36.6 44.0 50.5 60.9 64.7 73.3Starting current (LRA) A 118 151 177 207 249 259 322 373 384
CLS STD models with pump 182 202 242 302 352 402 502 552 602Nominal current input A 24.3 32.7 45.7 54.3 63.4 70.5 84.7 86.2 96.1Maximum current input A 34.2 45.4 53.7 63.7 75.2 84.7 102.1 113.7 124.7Nominal power input kW 13.8 18.8 26.5 29.9 35.5 40.4 49.3 48.8 53.8Maximum power input kW 19.6 26.2 31.5 37.1 44.3 50.8 61.2 66.5 73.6Starting current (LRA) A 118 152 180 210 252 261 325 375 386
CLS LN / ELN with pump 182 202 242 302 352 402 502 552 602Nominal current input A 24.7 33.1 46.1 54.7 64.1 71.2 85.4 86.9 96.8Maximum current input A 34.6 45.8 54.1 64.1 75.9 85.4 102.8 114.4 125.4Nominal power input kW 14.2 19.2 26.9 30.3 36.2 41.1 49.9 49.5 54.5Maximum power input kW 20.1 26.7 31.9 37.5 45.0 51.5 61.9 67.2 74.3Starting current (LRA) A 119 152 180 210 252 262 326 376 387
CLS HPF / HT with pump 182 202 242 302 352 402 502 552 602Nominal current input A 25.8 34.2 47.2 55.8 65.7 72.8 87.0 88.5 98.4Maximum current input A 35.7 46.9 55.2 65.2 77.5 87.0 104.4 116.0 127.0Nominal power input kW 14.8 19.8 27.5 30.9 37.0 41.9 50.8 50.3 55.3Maximum power input kW 20.6 27.2 32.5 38.1 45.8 52.3 62.7 66.5 75.1Starting current (LRA) A 120 153 181 211 254 264 327 378 389
kW A kW A182 0.8 1.7 2 x 0.8 2 x 2.1202 0.8 1.7 2 x 0.8 2 x 2.1242 1.1 3.1 2 x 1.5 2 x 3.8302 1.1 3.1 2 x 1.5 2 x 3.8352 1.5 3.8 2 x 1.8 2 x 4.9402 1.8 4.9 2 x 1.8 2 x 4.9502 1.8 4.9 2 x 1.8 2 x 4.9552 1.8 4.9 2 x 1.8 2 x 4.9602 1.8 4.9 2 x 1.8 2 x 4.9
CLS modelsUnits with 1 pump Units with 2 pumps
Page 14
Sound Levels
Sound power levels Lw-dB(A) Sound pressure levels Lp-dB(A)
Note : Sound pressure levels are given at 10 meters according toISO 3744.
Note : Sound pressure levels are given at 10 meters according toISO 3744.
Note : Sound pressure levels are given at 10 meters according toISO 3744.
Note : Sound pressure levels are given at 10 meters according toISO 3744.
125 250 500 1000 2000 4000 8000
182 STD 84 82 81 80 78 68 57 84202 STD 84 82 81 80 78 68 57 84242 STD 86 84 83 82 80 70 59 86302 STD 86 84 83 82 80 70 59 86352 STD 89 87 86 85 83 73 62 89402 STD 89 87 86 85 83 73 62 89502 STD 90 88 87 86 84 74 63 90552 STD 90 88 87 86 84 74 63 90602 STD 90 88 87 86 84 74 63 90
Frequency (Hz) Lw global dB(A)
CLS STD sizes
125 250 500 1000 2000 4000 8000
182 LN 80 78 77 76 74 64 53 80202 LN 80 78 77 76 74 64 53 80242 LN 82 80 79 78 76 66 55 82302 LN 82 80 79 78 76 66 55 82352 LN 85 83 82 81 79 69 58 85402 LN 85 83 82 81 79 69 58 85502 LN 86 84 83 82 80 70 59 86552 LN 86 84 83 82 80 70 59 86602 LN 86 84 83 82 80 70 59 86
Frequency (Hz) Lw global dB(A)
CLS LN sizes
125 250 500 1000 2000 4000 8000
182 ELN 77 75 74 73 71 61 50 77202 ELN 77 75 74 73 71 61 50 77242 ELN 78 76 75 74 72 62 51 78302 ELN 78 76 75 74 72 62 51 78352 ELN 79 77 76 75 73 63 52 79402 ELN 81 79 78 77 75 65 54 81502 ELN 82 80 79 78 76 66 55 82552 ELN 82 80 79 78 76 66 55 82602 ELN 82 80 79 78 76 66 55 82
Frequency (Hz) Lw global dB(A)
CLS ELN sizes
125 250 500 1000 2000 4000 8000
182 87 85 84 83 81 71 60 87202 87 85 84 83 81 71 60 87242 89 87 86 85 83 73 62 89302 89 87 86 85 83 73 62 89352 92 90 89 88 86 76 65 92402 92 90 89 88 86 76 65 92502 93 91 90 89 87 77 66 93552 93 91 90 89 87 77 66 93602 93 91 90 89 87 77 66 93
Frequency (Hz) Lw global dB(A)
CLS HPF/HT
sizes
125 250 500 1000 2000 4000 8000
182 STD 52 50 49 48 46 36 25 52202 STD 52 50 49 48 46 36 25 52242 STD 54 52 51 50 48 38 27 54302 STD 54 52 51 50 48 38 27 54352 STD 57 55 54 53 51 41 30 57402 STD 57 55 54 53 51 41 30 57502 STD 58 56 55 54 52 42 31 58552 STD 58 56 55 54 52 42 31 58602 STD 58 56 55 54 52 42 31 58
Frequency (Hz) Lw global dB(A)
CLS STD sizes
125 250 500 1000 2000 4000 8000
182 LN 48 46 45 44 42 32 21 48202 LN 48 46 45 44 42 32 21 48242 LN 50 48 47 46 44 34 23 50302 LN 50 48 47 46 44 34 23 50352 LN 53 51 50 49 47 37 26 53402 LN 53 51 50 49 47 37 26 53502 LN 54 52 51 50 48 38 27 54552 LN 54 52 51 50 48 38 27 54602 LN 54 52 51 50 48 38 27 54
Frequency (Hz) Lw global dB(A)
CLS LN sizes
125 250 500 1000 2000 4000 8000
182 ELN 45 43 42 41 39 29 18 45202 ELN 45 43 42 41 39 29 18 45242 ELN 46 44 43 42 40 30 19 46302 ELN 46 44 43 42 40 30 19 46352 ELN 47 45 44 43 41 31 20 47402 ELN 49 47 46 45 43 33 22 49502 ELN 50 48 47 46 44 34 23 50552 ELN 50 48 47 46 44 34 23 50602 ELN 50 48 47 46 44 34 23 50
Frequency (Hz) Lw global dB(A)
CLS ELN sizes
125 250 500 1000 2000 4000 8000
182 55 53 52 51 49 39 28 55202 55 53 52 51 49 39 28 55242 57 55 54 53 51 41 30 57302 57 55 54 53 51 41 30 57352 60 58 57 56 54 44 33 60402 60 58 57 56 54 44 33 60502 61 59 58 57 55 45 34 61552 61 59 58 57 55 45 34 61602 61 59 58 57 55 45 34 61
Frequency (Hz) Lw global dB(A)
CLS HPF/HT
sizes
Page 15
Cooling Capacities - CLS 182÷602 STD / LN / HPF
Notes : - LWT : Leaving water temperature.- Power input values are given for compressors only.
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
6 42.3 10.4 40.9 11.4 40.4 11.7 39.3 12.2 36.2 13.6 34.0 14.3 33.3 14.87 44.0 10.5 42.5 11.5 42.0 11.8 40.9 12.3 37.6 13.7 35.4 14.5 34.7 15.08 44.8 10.6 43.4 11.6 42.8 11.9 41.7 12.5 38.3 13.9 37.7 14.6 36.4 15.210 46.5 10.9 44.9 31.4 44.4 12.2 43.2 12.8 39.8 14.2 39.1 15.012 48.0 11.2 46.5 12.2 45.9 12.6 44.7 13.1 41.2 14.6 40.5 15.315 50.3 11.7 48.6 12.8 48.1 13.0 46.8 13.6 43.2 15.1 42.5 15.86 55.9 15.4 54.1 16.8 53.4 17.2 52.0 18.0 47.8 20.1 44.9 21.2 44.1 22.07 58.2 15.6 56.2 17.0 55.5 17.5 54.1 18.2 49.8 20.3 46.8 21.4 45.9 22.28 59.3 15.8 57.3 17.2 56.6 17.7 55.1 18.4 50.7 20.6 49.8 21.7 48.1 22.510 61.5 16.2 59.4 46.5 58.7 18.1 57.2 18.9 52.6 21.1 51.7 22.112 63.5 16.6 61.4 18.1 60.7 18.6 59.2 19.4 54.5 21.6 53.6 22.615 66.5 17.3 64.3 18.9 63.6 19.3 62.0 20.1 57.1 22.4 56.2 23.36 67.0 20.4 64.8 22.3 64.0 22.9 62.4 23.9 57.3 26.7 53.9 28.2 52.9 29.27 69.8 20.7 67.4 22.6 66.5 23.2 64.9 24.2 59.7 27.0 56.1 28.5 55.0 29.58 71.1 20.9 68.7 22.9 67.9 23.5 66.1 24.5 60.7 27.3 59.7 28.8 57.7 29.910 73.7 21.5 71.3 61.7 70.4 24.1 68.6 25.1 63.1 28.0 62.0 29.412 76.2 22.1 73.7 24.1 72.7 24.7 70.9 25.8 65.3 28.7 64.2 30.115 79.8 23.0 77.1 25.1 76.2 25.7 74.3 26.8 68.4 29.8 67.3 31.06 76.8 23.4 74.2 25.6 73.3 26.2 71.4 27.4 65.6 30.6 61.7 32.2 60.5 33.47 79.9 23.7 77.2 25.9 76.2 26.6 74.3 27.7 68.3 30.9 64.2 32.6 63.0 33.88 81.4 24.0 78.7 26.2 77.7 26.9 75.7 28.1 69.5 31.3 68.4 33.0 66.1 34.210 84.4 24.6 81.6 70.7 80.6 27.6 78.5 28.7 72.2 32.1 71.0 33.712 87.2 25.3 84.3 27.6 83.2 28.3 81.2 29.5 74.7 32.8 73.5 34.415 91.3 26.3 88.2 28.7 87.3 29.4 85.0 30.6 78.3 34.1 77.1 35.56 93.0 28.0 89.9 30.7 88.8 31.4 86.5 32.8 79.5 36.6 74.7 38.6 73.3 40.07 96.8 28.4 93.5 31.0 92.3 31.9 90.0 33.2 82.7 37.1 77.8 39.1 76.3 40.58 98.6 28.7 95.3 31.4 94.1 32.2 91.7 33.6 84.2 37.5 82.8 39.5 80.0 41.010 102.2 29.5 98.8 84.7 97.6 33.0 95.1 34.4 87.5 38.5 86.0 40.412 105.6 30.3 102.1 33.0 100.8 33.9 98.4 35.4 90.5 39.3 89.1 41.315 110.6 31.5 106.9 34.4 105.7 35.2 103.0 36.7 94.9 40.8 93.4 42.66 108.8 31.7 105.2 34.6 103.9 35.5 101.2 37.1 93.0 41.4 87.4 43.6 85.8 45.27 113.3 32.1 109.4 35.0 108.0 36.0 105.3 37.5 96.8 41.9 91.0 44.1 89.3 45.78 115.3 32.5 111.5 35.4 110.1 36.4 107.2 38.0 98.6 42.3 96.9 44.6 93.6 46.310 119.6 33.3 115.6 95.7 114.2 37.3 111.2 38.9 102.3 43.4 100.6 45.612 123.6 34.2 119.5 37.3 118.0 38.3 115.1 40.0 105.9 44.4 104.2 46.615 129.4 35.6 125.0 38.9 123.7 39.8 120.5 41.5 111.0 46.1 109.2 48.16 125.4 39.0 121.3 42.7 119.7 43.8 116.7 45.7 107.3 51.0 100.8 53.87 130.6 39.5 126.1 43.2 124.5 44.4 121.4 46.2 111.6 51.6 104.9 54.48 133.0 40.0 128.6 43.6 126.9 44.9 123.6 46.8 113.6 52.2 111.8 55.010 137.9 41.1 133.3 117.9 131.7 46.0 128.2 47.9 118.0 53.512 142.5 42.2 137.8 46.0 136.0 47.2 132.7 49.2 122.1 54.715 149.2 43.9 144.1 47.9 142.6 49.0 139.0 51.1 128.0 56.86 139.9 43.6 135.3 47.7 133.6 48.9 130.2 51.1 119.7 57.0 112.4 60.17 145.7 44.2 140.7 48.2 138.9 49.6 135.5 51.7 124.5 57.6 117.0 60.88 148.3 44.7 143.5 48.8 141.6 50.2 137.9 52.3 126.8 58.3 124.7 61.510 153.9 45.9 148.7 131.8 146.9 51.4 143.1 53.6 131.6 59.812 159.0 47.2 153.7 51.4 151.8 52.7 148.1 55.1 136.2 61.215 166.5 49.1 160.8 53.6 159.1 54.8 155.0 57.1 142.8 63.56 154.4 48.2 149.4 52.7 147.5 54.1 143.7 56.5 132.1 63.0 124.1 66.47 160.8 48.8 155.3 53.3 153.3 54.8 149.5 57.1 137.5 63.7 129.2 67.28 163.7 49.4 158.4 53.9 156.3 55.4 152.3 57.9 139.9 64.5 137.6 67.910 169.8 50.8 164.2 145.7 162.1 56.8 157.9 59.2 145.3 66.112 175.5 52.1 169.7 56.8 167.5 58.3 163.4 60.9 150.4 67.615 183.8 54.2 177.5 59.2 175.6 60.6 171.1 63.1 157.6 70.2
43 46Ambient air temperature (°C)
25 30 32 35
182
LWT (°C)
CLS models
40
202
242
302
352
552
602
402
502
Page 16
Cooling Capacities - CLS 182÷602 ELN
Notes : - LWT : Leaving water temperature.- Power input values are given for compressors only.
Cool. Cap.(kW)
Power Input (kW)
Cool. Cap.(kW)
Power Input (kW)
Cool. Cap.(kW)
Power Input (kW)
Cool. Cap.(kW)
Power Input (kW)
Cool. Cap.(kW)
Power Input (kW)
Cool. Cap.(kW)
Power Input (kW)
Cool. Cap.(kW)
Power Input (kW)
6 42.2 10.4 40.8 11.4 40.3 11.7 39.2 12.2 36.1 13.6 33.9 14.4 33.3 14.97 43.9 10.6 42.4 11.5 41.9 11.9 40.8 12.3 37.5 13.8 35.3 14.5 34.6 15.18 44.7 10.7 43.2 11.7 42.7 12.0 41.6 12.5 38.2 13.9 37.6 14.7 36.3 15.210 46.4 11.0 44.8 31.5 44.3 12.3 43.1 12.8 39.7 14.3 39.0 15.012 47.9 11.3 46.3 12.3 45.7 12.6 44.6 13.2 41.1 14.6 40.4 15.315 50.2 11.7 48.5 12.8 48.0 13.1 46.7 13.6 43.0 15.2 42.4 15.86 55.9 15.4 54.1 16.8 53.4 17.3 52.0 18.0 47.8 20.1 44.9 14.4 44.1 14.97 58.2 15.6 56.2 17.0 55.5 17.5 54.1 18.2 49.8 20.3 46.8 14.5 45.9 15.18 59.3 15.8 57.3 17.2 56.6 17.7 55.1 18.5 50.7 20.6 49.8 14.7 48.1 15.210 61.5 16.2 59.4 46.5 58.7 18.1 57.2 18.9 52.6 21.1 51.7 15.012 63.5 16.6 61.4 18.1 60.6 18.6 59.2 19.4 54.4 21.6 53.6 15.315 66.5 17.3 64.3 18.9 63.6 19.3 61.9 20.1 57.1 22.4 56.1 15.86 65.9 20.9 63.7 22.8 62.9 23.4 61.3 24.4 56.4 27.2 53.0 28.7 52.0 29.87 68.6 21.1 66.3 23.1 65.4 23.7 63.8 24.7 58.7 27.6 55.1 29.1 54.1 30.18 69.9 21.4 67.6 23.3 66.7 24.0 65.0 25.0 59.7 27.9 58.7 29.4 56.7 30.510 72.5 22.0 70.1 63.0 69.2 24.6 67.4 25.6 62.0 28.6 61.0 30.012 74.9 22.5 72.4 24.6 71.5 25.2 69.7 26.3 64.2 29.3 63.1 30.715 78.4 23.5 75.8 25.6 74.9 26.2 73.0 27.3 67.3 30.4 66.2 31.76 71.7 25.5 69.3 27.9 68.5 28.6 66.7 29.9 61.3 33.3 57.6 35.1 56.5 36.47 74.7 25.8 72.1 28.2 71.2 29.0 69.4 30.2 63.8 33.7 60.0 35.5 58.8 36.88 76.0 26.1 73.5 28.5 72.6 29.3 70.7 30.6 65.0 34.1 63.9 35.9 61.7 37.310 78.8 26.9 76.2 77.1 75.3 30.0 73.3 31.3 67.4 35.0 66.3 36.712 81.5 27.6 78.8 30.0 77.8 30.8 75.9 32.2 69.8 35.8 68.7 37.515 85.3 28.7 82.4 31.3 81.5 32.0 79.4 33.4 73.2 37.1 72.0 38.76 91.8 28.5 88.8 31.2 87.7 32.0 85.4 33.4 78.5 37.3 73.8 39.3 72.4 40.87 95.6 28.9 92.4 31.6 91.1 32.5 88.9 33.8 81.7 37.7 76.8 39.8 75.4 41.28 97.4 29.3 94.2 31.9 93.0 32.8 90.5 34.2 83.2 38.2 81.8 40.2 79.1 41.710 101.0 30.1 97.6 86.2 96.4 33.6 93.9 35.0 86.4 39.2 85.0 41.112 104.3 30.9 100.9 33.6 99.6 34.5 97.2 36.0 89.4 40.0 88.0 42.015 109.3 32.1 105.6 35.0 104.4 35.9 101.8 37.4 93.7 41.6 92.2 43.36 102.4 34.4 99.0 37.7 97.8 38.6 95.3 40.4 87.6 45.0 82.3 47.5 80.7 49.27 106.6 34.9 102.9 38.1 101.6 39.2 99.1 40.8 91.1 45.5 85.6 48.0 84.0 49.88 108.5 35.3 105.0 38.5 103.6 39.6 100.9 41.3 92.7 46.1 91.2 48.6 88.1 50.310 112.6 36.3 108.8 104.1 107.5 40.6 104.7 42.3 96.3 47.3 94.7 49.612 116.3 37.2 112.5 40.6 111.0 41.7 108.3 43.5 99.7 48.3 98.1 50.715 121.8 38.8 117.7 42.3 116.4 43.3 113.4 45.1 104.5 50.2 102.8 52.36 125.4 39.0 121.3 42.7 119.7 43.8 116.7 45.7 107.3 51.0 95.1 57.97 130.6 39.5 126.1 43.2 124.5 44.4 121.4 46.2 111.6 51.6 99.0 58.68 133.0 40.0 128.6 43.6 126.9 44.9 123.6 46.8 113.6 52.2 105.5 59.310 137.9 41.1 133.3 117.9 131.7 46.0 128.2 47.9 118.0 53.512 142.5 42.2 137.8 46.0 136.0 47.2 132.7 49.2 122.1 54.715 149.2 43.9 144.1 47.9 142.6 49.0 139.0 51.1 128.0 56.86 139.9 43.6 135.3 47.7 133.6 48.9 130.2 51.1 119.7 57.0 117.7 58.97 145.7 44.2 140.7 48.2 138.9 49.6 135.5 51.7 124.5 57.6 122.4 59.68 148.3 44.7 143.5 48.8 141.6 50.2 137.9 52.3 126.8 58.3 124.7 60.310 153.9 45.9 148.7 131.8 146.9 51.4 143.1 53.6 131.6 59.812 159.0 47.2 153.7 51.4 151.8 52.7 148.1 55.1 136.2 61.215 166.5 49.1 160.8 53.6 159.1 54.8 155.0 57.1 142.8 63.56 154.4 48.2 149.4 52.7 147.5 54.1 143.7 56.5 132.1 63.0 129.9 65.17 160.8 48.8 155.3 53.3 153.3 54.8 149.5 57.1 137.5 63.7 135.1 65.98 163.7 49.4 158.4 53.9 156.3 55.4 152.3 57.9 139.9 64.5 137.6 66.710 169.8 50.8 164.2 145.7 162.1 56.8 157.9 59.2 145.3 66.112 175.5 52.1 169.7 56.8 167.5 58.3 163.4 60.9 150.4 67.615 183.8 54.2 177.5 59.2 175.6 60.6 171.1 63.1 157.6 70.2
182ELN
LWT (°C)
CLS models
46Ambient air temperature (°C)
25 30 32 35
552ELN
602ELN
40 43
402ELN
502ELN
202ELN
242ELN
302ELN
352ELN
Page 17
Cooling Capacities - CLS 182÷602 HT
Notes : - LWT : Leaving water temperature.- Power input values are given for compressors only.
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
Cool. Cap.(kW)
Power Input(kW)
6 45.4 10.3 43.9 11.2 43.3 11.5 42.2 12.0 38.8 13.4 36.5 14.2 35.8 14.7 34.8 15.17 47.3 10.4 45.6 11.4 45.0 11.7 43.9 12.2 40.4 13.6 38.0 14.3 37.2 14.8 36.2 15.38 48.1 10.5 46.5 11.5 45.9 11.8 44.7 12.3 41.1 13.7 40.4 14.5 39.1 15.010 49.9 10.8 48.2 31.1 47.7 12.1 46.4 12.6 42.7 14.1 42.0 14.8 40.6 14.212 51.6 11.1 49.9 12.1 49.2 12.4 48.0 13.0 44.2 14.4 43.5 15.115 54.0 11.6 52.2 12.6 51.6 12.9 50.3 13.5 46.3 15.0 45.6 15.66 60.3 14.9 58.3 16.3 57.5 16.7 56.1 17.5 51.5 19.5 48.4 20.5 47.5 21.3 46.2 21.97 62.7 15.1 60.6 16.5 59.8 17.0 58.3 17.7 53.6 19.7 50.4 20.8 49.4 21.5 48.0 22.28 63.9 15.3 61.8 16.7 61.0 17.1 59.4 17.9 54.6 19.9 53.7 21.0 51.9 21.810 66.3 15.7 64.0 45.0 63.3 17.6 61.6 18.3 56.7 20.4 55.7 21.5 53.9 20.612 68.5 16.1 66.2 17.6 65.3 18.0 63.8 18.8 58.7 20.9 57.7 21.915 71.7 16.8 69.3 18.3 68.5 18.7 66.8 19.5 61.5 21.7 60.5 22.66 72.2 19.6 69.8 21.4 69.0 22.0 67.3 23.0 61.8 25.7 58.1 27.1 57.0 28.1 55.4 28.97 75.2 19.9 72.7 21.7 71.7 22.3 70.0 23.3 64.4 25.9 60.5 27.4 59.3 28.3 57.7 29.28 76.6 20.1 74.1 22.0 73.2 22.6 71.2 23.5 65.4 26.2 64.4 27.7 62.2 28.710 79.4 20.7 76.9 59.3 75.9 23.2 73.9 24.1 68.0 26.9 66.8 28.3 64.6 27.212 82.1 21.2 79.4 23.2 78.4 23.7 76.4 24.8 70.4 27.6 69.2 28.915 86.0 22.1 83.1 24.1 82.1 24.7 80.1 25.8 73.7 28.6 72.5 29.86 82.1 21.9 79.3 24.0 78.3 24.5 76.3 25.7 70.1 28.7 65.9 30.2 64.7 31.3 62.9 32.37 85.4 22.2 82.5 24.3 81.4 24.9 79.4 25.9 73.0 28.9 68.6 30.5 67.3 31.7 65.4 32.58 87.0 22.5 84.1 24.5 83.1 25.2 80.9 26.3 74.3 29.3 73.1 30.9 70.7 32.010 90.2 23.0 87.2 66.2 86.2 25.9 83.9 26.9 77.2 30.1 75.9 31.6 73.3 30.312 93.2 23.7 90.1 25.9 88.9 26.5 86.8 27.6 79.8 30.7 78.6 32.215 97.6 24.6 94.3 26.9 93.3 27.5 90.9 28.7 83.7 31.9 82.4 33.36 96.5 26.8 93.2 29.4 92.1 30.1 89.7 31.4 82.5 35.1 77.5 37.0 76.0 38.3 73.9 39.57 100.4 27.2 97.0 29.7 95.7 30.6 93.4 31.8 85.8 35.5 80.7 37.4 79.1 38.8 76.9 39.98 102.3 27.5 98.8 30.1 97.6 30.8 95.1 32.2 87.3 35.9 85.9 37.8 83.0 39.310 106.0 28.3 102.5 81.1 101.2 31.6 98.6 32.9 90.8 36.9 89.2 38.7 86.2 37.212 109.5 29.0 105.9 31.6 104.6 32.5 102.1 33.9 93.9 37.6 92.4 39.615 114.7 30.2 110.9 32.9 109.6 33.7 106.8 35.1 98.4 39.1 96.9 40.86 112.8 30.3 109.1 33.0 107.7 33.9 104.9 35.4 96.4 39.5 90.6 41.6 89.0 43.2 86.5 44.47 117.5 30.7 113.4 33.4 112.0 34.4 109.2 35.8 100.4 40.0 94.4 42.1 92.6 43.7 90.0 44.98 119.6 31.0 115.6 33.8 114.2 34.8 111.2 36.3 102.2 40.4 100.5 42.6 97.1 44.210 124.0 31.8 119.9 91.4 118.4 35.6 115.3 37.2 106.1 41.5 104.3 43.6 100.8 41.812 128.2 32.7 123.9 35.6 122.4 36.6 119.3 38.2 109.8 42.4 108.0 44.515 134.2 34.0 129.6 37.2 128.3 38.0 124.9 39.6 115.1 44.0 113.2 45.96 130.0 37.4 125.8 40.9 124.1 42.0 121.0 43.8 111.2 48.9 104.5 51.5 102.5 53.47 135.4 37.8 130.7 41.4 129.1 42.5 125.9 44.3 115.7 49.4 108.8 52.1 106.7 53.98 137.9 38.3 133.3 41.8 131.6 43.0 128.1 44.8 117.8 50.0 115.9 52.7 112.0 54.610 143.0 39.4 138.2 112.9 136.5 44.1 132.9 45.9 122.3 51.2 120.3 53.812 147.7 40.4 142.9 44.1 141.0 45.2 137.6 47.1 126.6 52.4 124.5 55.015 154.7 42.1 149.4 45.9 147.8 46.9 144.1 48.9 132.7 54.4 130.5 56.76 145.1 41.8 140.3 45.7 138.5 46.9 135.0 49.0 124.1 54.6 116.6 57.6 114.4 59.77 151.1 42.3 145.9 46.2 144.0 47.5 140.4 49.5 129.1 55.2 121.3 58.2 119.0 60.38 153.8 42.8 148.7 46.7 146.8 48.0 143.0 50.1 131.4 55.9 129.3 58.9 124.9 61.010 159.5 44.0 154.2 126.2 152.3 49.2 148.3 51.3 136.5 57.3 134.2 60.212 164.8 45.2 159.4 49.2 157.3 50.5 153.5 52.7 141.2 58.6 139.0 61.515 172.6 47.0 166.7 51.3 165.0 52.5 160.7 54.7 148.1 60.8 145.7 63.46 160.1 46.2 154.8 50.5 152.9 51.8 149.0 54.1 136.9 60.3 128.7 63.6 126.3 66.07 166.7 46.8 161.0 51.1 158.9 52.5 155.0 54.7 142.5 61.0 133.9 64.4 131.4 66.78 169.7 47.3 164.2 51.7 162.1 53.1 157.9 55.4 145.1 61.8 142.7 65.1 137.8 67.510 176.1 48.6 170.2 139.6 168.1 54.4 163.7 56.7 150.6 63.4 148.1 66.512 181.9 49.9 175.9 54.4 173.7 55.9 169.4 58.3 155.9 64.8 153.4 68.015 190.5 52.0 184.0 56.7 182.1 58.0 177.4 60.5 163.4 67.3 160.8 70.1
43 48Ambient air temperature (°C)
25 30 32 35 46
182HT
LWT (°C)
CLS models
40
202HT
242HT
302HT
352HT
552HT
602HT
402HT
502HT
Page 18
Water Pressure Drop Curves
1 Size 182
2 Size 202
3 Size 242
4 Size 302
5 Size 352
x 1000 (l/h)
kPa
3 4 5 6 7 8 9 105
6
8
9
10
7
20
30
40
50
60
80
90
100
200
70
20 30 40 50
1
2 34
5 6
7
8
9
6 Size 402
7 Size 502
8 Size 552
9 Size 602
Page 19
Integrated Hydraulic Module Data (optional)
0
50
100
150
200
250
0 5000 10000 15000 20000 25000 30000
CLS 552-602
CLS 402-502
CLS 302CLS 352
CLS 242
CLS 202
CLS 182
l/h
kPa
CLS sizes 182 202 242 302 352 402 502 552 602
Water tank volume (all versions) litres 210 210 210 210 330 330 400 400 400
Expansion tank volume (all versions) litres 12 12 12 12 18 18 18 18 18
Antifreeze electric heater kW 0.2 0.2 0.2 0.2 0.4 0.4 0.4 0.4 0.4
Page 20
Dimensions
Models CLS 182 to 302 STD/LN/ELN/HPF/HT
35 mmonly for
transport
(+35 mm only for transport)
Cableentry
177
1100
470
404
177 36.5
368
36.51037
1110
2" male
VIEW CVIEW B
VIEW A
Lift
ing
poin
t
Lift
ing
poin
t
Note : For units without hydraulic module, the water connections are done on the optional 2" male threaded gas type manifolds located insidethe unit.
Models Versions Dimensions A (mm) Dimensions B (mm) Dimensions C (mm) Number of fansStandard 1756 2110 1750 2LN/HPF/HT 1756 2110 1850 2ELN 1756 2110 1850 2Standard 1756 2110 1750 2LN/HPF/HT 1756 2110 1850 2ELN 1756 2110 1850 2Standard 1756 2110 1750 2LN/HPF/HT 1756 2110 1850 2ELN 1756 2110 1850 2Standard 1756 2110 1750 2LN/HPF/HT 1756 2110 1850 2ELN 1756 2110 1850 2
CLS 182
CLS 202
CLS 302
CLS 242
Page 21
Dimensions (continued)
Models CLS 352 to 602 STD/LN/ELN/HPF/HT
35 mmonly for
transport
(+35 mm only for transport)
2" male
VIEW CVIEW B
VIEW A
Lift
ing
poin
t
Cab
le e
ntr
y
Lift
ing
poin
t
177 177 36.5
368
36.51037
1110
1100
470
404
Note : For units without hydraulic module, the water connections are done on the optional 2" male threaded gas type manifolds located insidethe unit.
Models Versions Dimensions A (mm) Dimensions B (mm) Dimensions C (mm) Number of fansStandard 2406 2760 1750 3LN/HPF/HT 2406 2760 1850 3ELN 2406 2760 1850 3Standard 2756 3110 1750 3LN/HPF/HT 2756 3110 1850 3ELN 2756 3110 1850 3
CLS502 to 602
CLS352 & 402
Page 22
Space Requirements
Single unit applications
Multi units applications
A1 A2 A3 A1 A2 A3 A1 A2 A3 A1 A2 A3 A1 A2 A3ARRANGEMENT 1 1.0 1.0 1.0 1.0 0.8 0.8 1.0 0.8 0.8 1.0ARRANGEMENT 2 1.0 1.5 1.0 1.0 2.0 1.0 0.8 2.0 0.8 1.0 1.5 0.8 0.8 1.5 1.0
LOUVRED A & DSOLID B & C
LOUVRED A & CSOLID B & D
SOLID A & BSOLID C & D
SOLID A & CLOUVRED B & D
LOUVRED A & BSOLID C & D
1000 mm
3000 mm
1000 mm
1000 mm1500 mm
VIEW A
WALL A
WALL A
1.5 m
1.5 m
A1
A1 A3A2
A2
2.0 m
1.0 m1.0 m
WALL C
ARRANGEMENT 1 ARRANGEMENT 2
WALL C
WALL D
WALL D
WALL B
WALL B
Note : No more than one wall can be higher than the unit.The area enclosed by the wall must be kept clear of all obstructions that would impede air flow to the unit.
Page 23
Notes
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
..................................................................................................................................................................
As part of our ongoing product improvement programme, our products are subject to change without prior notice. Non contractual photos.
Wesper42 cours Jean-Jaurès17800 PonsFRANCE
✆ : +33-5 46 92 33 33: +33-5 46 91 38 33 / 5 46 91 26 44 (Export Department)
www.wesper.com