6
COLLECTIVE VENTILATION NOE ® RANGE 400° C - 1/2 h CMV/Collective extraction units Flow rate 400 to 11400 m 3 /h
CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com P21
COLLECTIVE VENTILATION
NOE®
RANGE
400° C - 1/2 h
CMV/Collective extraction units
Flow rate 400 to 11400 m3/h
P22 CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com
C4 EXTRACTION UNIT DESCRIPTION NOE
®
Ventilation unit PULLEY/BELT TRANSMISSION
400 to 11400 m3/h
CTICM C4 - 400° C - 1/2 h approved
Report no. 09-E-544
CSTB technical notification for Hygro A, Hygro B and Hygro Gas usage
CMV POWER selection software
APPLICATION
• Intended mainly for air extraction in houses and public assembly buildings requiring high flow rates.
• C4, 400°C 1/2 h certified 50 Hz and 60 Hz.
RANGE
• Comprising 10 models, it covers flow rates from 400 to 11400 m3/h in a number of configurations.
INSTALLATION
• Can be installed internally or externally.
• Easy access to all internal parts.
• May be fully dismantled.
CONSTRUCTION
• Housing: galvanized steel sheet. Amply dimensioned, it offers powerful air handling and acoustic performance characteristics.
• Internal access via two removable panels.
• Bird protection grid on discharge.
• Circular nozzles with double lip seal for watertight networks (ATEC CSTB
No. 13-224-V2). s T
• Local padlockable switch on front panel.
• Pressure switch factory-fitted in the unit and set to 80 Pa (Gas CMV). Time delay possible (see MISTRAL 30 S unit option).
• External pressure tap to check air flow.
• Vibration pads incorporated under the chassis of the motorized fan unit. s SILENCE version 400°C 1/2 h certified. The insulation of the unit
using 25mm M0 mineral wool allows acoustic performance characteristics compliant with the requirements of the new regulations to be achieved.
MOTOR FAN
• Transmission by pulley and belt, motor pulley variable when stopped.
• Three-phase one-speed motor, IP55 F, 230/400V-3, 50 Hz.
• Door opening sensor available for office ventilation.
• Centrifugal impulse turbine with double opening.
• Flexible connection from turbine to unit.
• Spare belt supplied.
The units are available in two versions:
H: 1 horizontal intake Ø D1 + 1 horizontal discharge Ø D2 in-line
V: 1 horizontal intake Ø D1 + 1 horizontal intake Ø D2 + 1 vertical discharge LxL1
Reference to be given in the order:
NOE 3000 SILENCE H
1 2 3 4
1: Unit 400° C/1/2 h pulley belt transmission
2: Maximum flow rate in use
3: SILENCE version 400° C 1/2 h certified
4: Installation configuration H = in-line discharge / V = 1 or 2 horizontal intakes and vertical discharge
NOE 4800 - V
1 2 3 4
COLLECTIVE
CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com P23
DIMENSIONS
CHARACTERISTICS NOE®
*Overall depth of LOBBY® unit
Dim. unit Ground Discharge version V Discharge version H Intake versions H and V Intake version V on Weight Weight of
Reference overall fixing from the top on side of local switch opposite local switch side of local switch condensate
Lenght Width Height Lenght Width Position Width Lenght Ø Floor centreline distance Ø Floor centreline distance Ø Floor centreline distance NOE® NOE® SILENCE tray
NOE®
A (mm)
B (mm)
H (mm)
X (mm)
Y (mm)
A1 (mm)
L1 (mm)
L (mm)
D2 (mm)
H1 (mm)
D1 (mm)
H1 (mm)
D2 (mm)
H1 (mm)
(kg) (kg) (kg)
2600-3000 900 585 580 940 470 370 330 271 400 320 400 320 315 320 55/57 60/62 5
3400-3800 1000 650 680 1040 520 380 360 298 450 360 450 360 400 360 72/74 78/80 6
4800-5600 1110 740 780 1150 575 400 420 355 500 375 500 375 450 375 86/88 93/95 7
6800-8000 1300 860 880 1340 670 450 500 407 630 455 630 455 500 455 119/122 129/132 10
10000-11400 1400 940 980 1440 720 410 585 490 710 485 710 485 630 485 154/159 165/170 12
ELECTRICAL
CHARACTERISTICS NOE®
Reference Motor power
(kW) Current protection
at 400 V (A) Rotation speed
(rpm) Power supply (V/phases/Hz)
NOE® 2600 0,37 1,1 865 / 1100 230-400 / 3 / 50
NOE® 3000 0,55 1,4 975 / 1240 230-400 / 3 / 50
NOE® 3400 0,55 1,4 740 / 940 230-400 / 3 / 50
NOE® 3800 0,75 1,9 880 / 1120 230-400 / 3 / 50
NOE® 4800 0,75 1,9 650 / 830 230-400 / 3 / 50
NOE® 5600 1,10 2,6 720 / 940 230-400 / 3 / 50
NOE® 6800 1,10 2,6 540 / 700 230-400 / 3 / 50
NOE® 8000 1,50 3,5 600 / 780 230-400 / 3 / 50
NOE® 10000 1,50 3,5 470 / 580 230-400 / 3 / 50
NOE® 11400 2,20 4,8 530 / 655 230-400 / 3 / 50
P24 CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com
ACOUSTIC
CHARACTERISTICS NOE®
• The Lp4m dB(A) ) values shown on the curves relate to the average overall acoustic pressure level radiated in a free field on a reflecting plane, unit discharge not connected. These values also enable you to obtain the spectrum for NOE® SILENCE units.
• The Lw cond dB(A) ( ) values shown on the curves relate to the average overall acoustic pressure level radiated in the intake duct for a NOE®
device.
• To obtain the overall Lw cond dB(A) for a NOE® SILENCE, ôter 5 dB(A) subtract 5 dB(A) from the overall Lw cond dB(A) ( ) value shown on the curves.
• To obtain the acoustic power spectrum radiated in the intake duct in dB(A) for a non-insulated NOE®, device, add the correction coefficients from the table below to the Lw cond dB(A) ( ) value shown on the curves
Intake acoustic spectrum weighting for non-insulated NOE® as a function of the Lw cond dB(A) ( ) values shown on the curves
Frequency 63Hz 125Hz 250Hz 500Hz 1000Hz 2000Hz 4000Hz 8000Hz
NOE® 2600 and 3000 dB(A) weighting -35 -18 -16 -9 -5 -5 -9 -19
NOE® 3400 and 3800 dB(A) weighting -33 -18 -13 -9 -5 -5 -8 -17
NOE® 4800 and 5600 dB(A) weighting -30 -16 -14 -9 -5 -5 -9 -19
NOE® 6800 and 8000 dB(A) weighting -29 -19 -11 -8 -6 -5 -8 -17
NOE® 10000 and 11400 dB(A) weighting -27 -18 -12 -7 -6 -5 -9 -18
• To obtain the acoustic power spectrum radiated in the intake duct in dB(A) for a NOE® SILENCE device, add the correction coefficients from the table below to the acoustic spectrum of a non-insulated device dB(A) obtained using the table above.
Intake acoustic spectrum weighting for NOE® SILENCE as a function of the intake acoustic spectrum for non-insulated NOE®
Frequency 63Hz 125Hz 250Hz 500Hz 1000Hz 2000Hz 4000Hz 8000Hz
Weighting pour NOE® SILENCE dB(A) 0 -1 -2 -4 -4 -6 -6 -8
Tolerance: Overall values +/- 3 dB(A) Acoustic spectrum +/- 5 dB(A)
• Overall acoustic pressure level radiated rejection : Lw rejet dB(A) = Lp4m dB(A) ) + 20
• To define the average overall acoustic pressure level radiated at a certain distance in dB(A) in free field on a reflecting plane, discharge unit not
connected, add the value from the table below to the Lp4m dB(A) ) value shown on the curves.
Lp weighting at various distances
Distance 2 m 3 m 4 m 5 m 7 m 10 m
Distance weighting 6 2 0 -2 -5 -8
NOTA : The curves are made with a suction and discharge nozzle connected sub- woofer is not connected (C configuration according to NF N 13141-4).
COLLECTIVE
74
51
70
56
53 52 i à 1120 tr/min max
mini à 975 tr/mi
in 52
maxi à 1240 tr/
Sta
tic p
res
su
re (
Pa)
Sta
tic p
res
su
re (
Pa)
Sta
tic p
res
su
re (
Pa)
Sta
tic p
res
su
re (
Pa)
Po
wer
co
ns
um
pti
on
(W
) P
ow
er
co
ns
um
pti
on
(W
) P
ow
er
co
ns
um
pti
on
(W
) P
ow
er
co
ns
um
pti
on
(W
)
SELECTION
CURVES NOE®
320 800
700
NOE® 2600
NOE® 3000
240
160
80
00
320
240
160
80
00
maxi à 1100 tr/min 49
72 hygro à 960 tr/min
mini à 865 tr/min 44
m
n 46
49 51
72 74
44
51
74
1000 2000
Flow rate (m3/h)
5
75
77
46
1000 2000
Flow rate (m3/h)
600
500
400
300
200
100
0 3000
800
700
600
500
400
300
200
100
0 3000
320 800
700
NOE® 3400
240
160
80
00
maxi à 940 tr/min
hygro à 820 tr/min
mini à 740 tr/min
48
71
44
1000
50
73
46
69
2000
Flow rate (
m3/h)
54
77
50
73
3000
600
500
400
300
200
100
0 4000
400 1000
900
320 800
700
NOE® 3800
240 79 600
500
160 400
900
800
700
600
67
69 69
47 à 880 tr/min mini
0 tr/min 100
75
52
1040 tr/min
75
54
2
76 75
67
67
SELECTION
CURVES
NOE®
COLLECTIVE
