PRODUCT GUIDE
COMMERCIAL GARAGE DOORS
1 TABLE OF CONTENTS 2TABLE OF CONTENTS
CO
NT
EN
TS
TECHNOLOGY OF DESIGN
5 3-Inch Commercial Flush
7 2-Inch Commercial Flush
9 Commercial FullView
11 Commercial Ribbed
13 Swing-Up Center Post
15 Design & Construction
17 Accessories
The Strength of Design3
19 Upgrade Your Door
22 Product Chart
This is a thermal image side-by-side comparison of a competitor’s polyurethane door in the same location as a Midland ThermoGuard™ door. The dark areas show where energy loss occurs. The test was performed when
the outside temperature was 0°F and the inside temperature was 55°F.
1 Better Energy Efficiency 2 Better Fit & Finish 3 Better Quality
WE BUILD DOORS THAT OUR DEALERS LOVE TO INSTALL AND CUSTOMERS ARE PROUD TO OWN
THERMAL IMAGE TEST SHOWS YOU WHY GARAGE DOORS ARE NOT ALL THE SAME
Midland proudly builds the strongest commercial and residential doors in the industry. With nearly 40 years of experience building doors for homes, farms and commercial buildings, we take great pride in our workmanship and attention to detail.
34 RAISED STEEL PANELTHE STRENGTH OF DESIGN3 4THE STRENGTH OF DESIGN
HEAVY-DUTY WEATHER SEALMidland doors utilize commercial grade weather seal with an aluminum retainer
Door Pictured: 2-Inch EnergySaver™
LOWER ENERGY COSTSClosed cell polystyrene insulation helps maintain building temperatureand resists moisture
THERMAL BREAKSMidland doors incorporate a true
thermal break that minimizes energy loss between sections
POLYURETHANE INSULATION
The custom-blendpolyurethane efficiently
cuts energy expenses while also acting as a
sound barrier
DURABLE STEELMidland doors use hot dipped
galvanized steel, that is conditioned, and embossed with a pebble texture
for maximum durability
Door Pictured: 3-Inch ThermoGuard™
We don’t just say our doors are tough, we can prove it. We dare you to drive a truck over another door like we did on this 3-Inch EnergySaver™ door.
STRENGTH OF DESIGN
A SUPERIOR GARAGE DOORINSIDE & OUT
VS.
COMPETITOR
WHY DOES THIS MIDLAND DOOR PERFORM THAT MUCH BETTER?
1
2
3
4
5
SUPERIOR FITDoor sections have tighter and more consistent section gaps
MINIMAL AIR INFILTRATIONThe flexible commercial-grade seal between the door sections minimizes air infiltration
STRUCTURAL RIGIDITYConcealed full-height vertical center stiles and tailor-made custom end stiles provide structural rigidity
GALVANIZED HARDWARE & TRACKCarries the load of the door while operating smoothly
MOISTURE RESISTANTClosed-cell end dams help to keep moisture away from insulation
1
2
3
4
5
34 RAISED STEEL PANEL3-INCH COMMERCIAL FLUSH5 63-INCH COMMERCIAL FLUSH
3-INCH COMMERCIAL FLUSHUNCOMPROMISING QUALITY & STRENGTH At Midland, we’re proud to make the strongest, longest-lasting commercial overhead doors in the industry, and our 3-Inch doors are the best of the best. Our ThermoGuard™ and EnergySaver™ doors are manufactured using a state-of-the-art production line to deliver exceptional R-values. Our quality doesn’t end there. The hot-dipped galvanized panels move seamlessly on the heavy-duty, angle-mount galvanized steel track.
White Almond Sandtone
Gray**Coffee
COLORS
The ColorSelect™ process uses a Sherwin Williams Polane® Solar Reflective Polyurethane Enamel that utilizes the latest technologies to provide a durable, heat-repelling coating.
*Available in ThermoSteel™ only. **Available in ThermoGuard™ only. Due to the printing process, colors may vary.
Black**
Tera-Bronze
Green
Beige*
Foam/Insulate Polyurethane Polystyrene
R-Value 26.0 17.05
Thickness 3 inches 3 inches
Maximum Width 40 feet 2 inches 40 feet 2 inches
Exterior Steel 27 gauge 25 gauge
Interior Steel 27 gauge 25 gauge
Warranty* 10 years 10 yearsExcludes Springs
*For full warranty details contact your Midland dealer
ThermoGuard™ EnergySaver™
INSULATION WINDOWS
24” x 7”
24” x 12”
32” x 14”20 gauge upgrade,
white only20 gauge upgrade,
white only
Reverse Angle Mounted TrackContinuous leg-in angle to attach to steel jambs
Angle Mounted TrackContinuous leg-out angle used on larger doors to attach to wood jambs
GLASS
Choose from Plain, Obscure, Frosted, Gray Tinted, Bronze Tinted, LoE, and Double Dark
See page 28 for complete glass selections available
TRACK MOUNTING TRACK CONFIGURATIONS
Standard LiftFor normal installations
Inclined TrackTo follow pitchof roof
Hi-LiftTo put horizontal track as close to ceiling as possible
Vertical LiftFull vertical rise where headroom is available
Low HeadroomFor low-clearance installations
See page 15 for full commercial track configurations
34 RAISED STEEL PANEL2-INCH COMMERCIAL FLUSH7 82-INCH COMMERCIAL FLUSH
2-INCH COMMERCIAL FLUSHSIMPLICITY & HEAVY-DUTY RELIABILITY Match your overhead door to your business with our custom-colored, 2-Inch doors. Keep the cold out and the heat in with the polyurethane insulation in our ThermoGuard™ doors or the polystyrene core of our EnergySaver™ doors. Both doors have commercial-grade astragal weather seals with aluminum retainers along the bottom.
White Almond Sandtone
Gray**Coffee
COLORS
The ColorSelect™ process uses a Sherwin Williams Polane® Solar Reflective Polyurethane Enamel that utilizes the latest technologies to provide a durable, heat-repelling coating.
*Available in ThermoSteel™ only. **Available in ThermoGuard™ only. Due to the printing process, colors may vary.
Black**
Tera-Bronze
Green
Beige*
Foam/Insulate Polyurethane Polystyrene
R-Value 18.0 9.25
Thickness 2 inches 2 inches
Maximum Width 32 feet 2 inches 24 feet 2 inches
Exterior Steel 27 gauge 25 gauge
Interior Steel 27 gauge 25 gauge
Warranty* 10 years 10 yearsExcludes Springs
*For full warranty details contact your Midland dealer
ThermoGuard™ EnergySaver™
INSULATION WINDOWS
24” x 7”
24” x 12”
20 gauge upgrade, white only
20 gauge upgrade, white only
Bracket Mounted Track To attach to wood jambs
Reverse Angle Mounted TrackContinuous leg-in angle to attach to steel jambsAngle Mounted
TrackContinuous leg-out angle used on larger doors to attach to wood jambs
GLASS
Choose from Plain, Obscure, Frosted, Gray Tinted, Bronze Tinted, LoE, and Double Dark
See page 28 for complete glass selections available
TRACK MOUNTING TRACK CONFIGURATIONS
Standard LiftFor normal installations
Inclined TrackTo follow pitchof roof
Hi-LiftTo put horizontal track as close to ceiling as possible
Vertical LiftFull vertical rise where headroom is available
Low HeadroomFor low-clearance installations
See page 15 for full commercial track configurations
34 RAISED STEEL PANELCOMMERCIAL FULLVIEW9
COMMERCIAL FULLVIEWNATURAL LIGHT WITH STRENGTH & STABILITY Our FullView doors provide strength and durability while allowing natural light in. Commercial FullView doors are available in 2-inch and 3-inch thicknesses and, like all Midland commercial doors, feature heavy-duty galvanized steel tracks and hardware. FullView doors are available with insulated or un-insulated glass.
TRACK CONFIGURATIONS
Standard LiftFor normal installations
Inclined TrackTo follow pitchof roof
Hi-LiftTo put horizontal track as close to ceiling as possible
Vertical LiftFull vertical rise where headroom is available
Low HeadroomFor low-clearance installations
Frame 6063-T-6 Aluminum 6063-T-6 Aluminum
Thickness 2 inches 3 inches
Warranty* 5 years 5 yearsExcludes Springs
White Anodized2”, 3”
Clear Anodized2”
Deep Bronze Anodized2”
Black Anodized2”
FRAME COLORS
The ColorSelect™ process uses a Sherwin Williams Polane® Solar Reflective Polyurethane Enamel that utilizes the latest technologies to provide a durable, heat-repelling coating.
Due to the printing process, colors may vary.
SPECIFICATIONS
GLASS
Plain Obscure Frosted* Gray Tinted
Bronze Low E Double Dark*
*Tempered only. All other glass is available in both tempered and untempered.
1/2 inch insulated1/4 inch non-insulated1/8 inch non-insulated
GLASS
Choose from Plain, Obscure, Frosted, Gray Tinted, Bronze Tinted, LoE, and Double Dark
See page 28 for complete glass selections available *For full warranty details contact your Midland dealer
INSULATION
Strengthens the door
FULL BOX FRAME
Provides and energy efficient seal to help maintain building temperature
AIR INFILTRATION SEAL
See page 15 for full commercial track configurations
10COMMERCIAL FULLVIEW
COMMERCIAL RIBBED CS20 | CS24 | CS26DURABLE ROLL-FORMED STEEL Get strength and value with our CS Series of commercial overhead doors. Each starts with a strong, 2-inch ribbed base for added strength, and uses pebble-grain textured steel in 20-, 24- or 26-gauge thickness for durability. We spot-weld the CS20 and CS24 doors by hand for greater structural integrity than the many bolt-together doors on the market.
WhiteCS20, CS24, CS26
CoffeeCS24, CS26
COLORS
The ColorSelect™ process uses a Sherwin Williams Polane® Solar Reflective Polyurethane Enamel that utilizes the latest technologies to provide a durable, heat-repelling coating.
Due to the printing process, colors may vary.
Bracket Mounted Track To attach to wood jambs
Reverse Angle Mounted TrackContinuous leg-in angle to attach to steel jambsAngle Mounted
TrackContinuous leg-out angle used on larger doors to attach to wood jambs
GLASS
Choose from Plain, Obscure, Frosted, Gray Tinted, Bronze Tinted, LoE, and Double Dark
See page 28 for complete glass selections available
TRACK MOUNTING TRACK CONFIGURATIONS
Standard LiftFor normal installations
Inclined TrackTo follow pitchof roof
Hi-LiftTo put horizontal track as close to ceiling as possible
Vertical LiftFull vertical rise where headroom is available
Low HeadroomFor low-clearance installations
SandtoneCS24
WINDOWS
24” x 5”
24” x 12”
Foam/Insulate
R-Value T-Bond: 7.0 T-Bond: 7.0 T-Bond: 7.0
Thickness 2 inches 2 inches 2 inches
Maximum Width 40 ft 2 in 26 ft 2 in 16 ft 2 in
Exterior Steel 20 gauge 24 gauge 26 gauge
Warranty* 10 years 10 years 25 yearsExcludes Springs
*For full warranty details contact your Midland dealer
CS20 CS24 CS26
INSULATION
Plain Steel/T-Bond
Plain Steel/T-Bond
Plain Steel/T-Bond
12COMMERCIAL RIBBEDCOMMERCIAL RIBBED11
See page 15 for full commercial track configurations
SWING-UP CENTER POSTTRANSFORM TWO OR THREE DOORS INTO ONE Create a custom commercial door as wide as 60 feet. Incorporating the strength and durability of our 3-Inch Commercial series, the Swing-Up Center Post System turns two or three overhead doors into one large opening ideal for farm and commercial storage. While maintaining a heavy-duty 3-inch steel track and hand-welded machined hinge ensure lasting durability and solid steel floor plate and head plate for lasting stability.
SWING-UP CENTER POST13 14SWING-UP CENTER POST
White Almond Sandtone
Gray**Coffee
COLORS
The ColorSelect™ process uses a Sherwin Williams Polane® Solar Reflective Polyurethane Enamel that utilizes the latest technologies to provide a durable, heat-repelling coating.
*Available in ThermoSteel™ only. **Available in ThermoGuard™ only. Due to the printing process, colors may vary.
Black**
Tera-Bronze
Green
Beige*
Foam/Insulate Polyurethane Polystyrene
R-Value 26.0 17.05
Thickness 3 inches 3 inches
Maximum Width 40 feet 2 inches 40 feet 2 inches
Exterior Steel 27 gauge 25 gauge
Interior Steel 27 gauge 25 gauge
Warranty* 10 years 10 yearsExcludes Springs
*For full warranty details contact your Midland dealer
ThermoGuard™ EnergySaver™
INSULATION WINDOWS
24” x 7”
24” x 12”
20 gauge upgrade, white only
20 gauge upgrade, white only
GLASS
Choose from Plain, Obscure, Frosted, Gray Tinted, Bronze Tinted, LoE, and Double Dark
See page 28 for complete glass selections available
32” x 14”
DESIGN & CONSTRUCTION
16DESIGN & CONSTRUCTION
White Almond Sandtone Gray*** Tera-Bronze
Green Coffee Black***
COLORS Midland Garage Doors are available in an assortment of colors that coordinate perfectly with the exterior finish of your home. Match the color and pattern to find the door that’s just right for you. Custom colors are available through the Color Select Custom Paint Process. See your Midland Dealer to view these color samples in person.
WINDOWS Brighten up your garage door with beautiful and durable Midland windows. Our broad selection of window options make it easy to customize your garage door to fit your home.
24” x 7” 24” x 12”24” x 5” 32” x 14”
Get the color you need with our ColorSelect™ option. Offering over 3,800 color options. You can coordinate a garage door with any window, door, trim or paint color. The ColorSelect™ process uses a Sherwin Williams Polane® Solar Reflective Polyurethane Enamel that utilizes the latest technologies to provide a durable, heat-repelling coating.
Plain Obscure Frosted* Gray Tinted
Bronze Low E Double Dark*
*Tempered only. All other glass is available in both tempered and untempered.
GLASS Choose from glass options that determine the amount of natural light and privacy you desire.
DESIGN & CONSTRUCTION15
DESIGN & CONSTRUCTION17
BRACKET MOUNTED TRACK To attach to wood jambs
TRACK MOUNTING DETAILS
ANGLE MOUNTED TRACK Continuous leg-out angle used on larger doors to attach to wood jambs
REVERSE ANGLE MOUNTED TRACK Continuous leg-in angle to attach to steel jambs
18DESIGN & CONSTRUCTION
A Standard radius track works well for most garage door installations.
2-INCH
Headroom: 10-Inch: 11 inches 12-Inch: 13 - 14 inches 15-Inch: 15 - 17 inches
Sideroom: On Wood: 41/2 inches On Steel: 51/2 inches
Backroom: Door Height + 20 inches
3-INCH
Headroom: 15-Inch: 16 - 21 Inches
Sideroom: On Wood: 41/2 inches On Steel: 5 inches
Backroom: Door Height + 20 inches
STANDARD
HEADROOM
DOOR HEIGHT
1
Headroom is limited and standard track will not work. Springs are mounted at the front of the horizontal track.
2-INCH ON 2-INCH
Headroom: 10 - 11 inches
Sideroom: On Wood: 6 inches On Steel: 7 inches
Backroom: Door Height + 30 inches
2-INCH ON 3-INCH
Headroom: 10 - 11 inches
Sideroom: On Wood: 61/2 inches On Steel: 71/2 inches
Backroom: Door Height + 30 inches
HEADROOM
DOOR HEIGHT
LOW HEADROOM
2
A variation of Standard Track. Used where the ceiling is significantly taller or where extra clearance is needed to avoid obstacles.
2-INCH OR 3-INCH
Headroom: Maximum hi-lift minus 18 inchesSideroom: On Wood: 41/2 inches On Steel: 51/2 inches
Backroom: Backroom minus Hi-Lift
HEADROOM
DOOR HEIGHT
HIGH LIFT ARM
HI-LIFT3
A variation of Hi-Lift. Only vertical track is needed, there is no horizontal track.
2-INCH OR 3-INCH
Headroom: Twice door height plus 14 inchesSideroom: On Wood: 41/2 inches On Steel: 51/2 inches
Backroom: 18 inches required
HEADROOM
DOOR HEIGHT
VERTICAL4
Follows the pitch of the roof. A standard radius curve track is cut to allow the horizontal track to follow the roof pitch.
2-INCH OR 3-INCH
Headroom: Contact dealer
Sideroom: On Wood: 41/2 inches On Steel: 51/2 inches
Backroom: Door Height + 20 inches
INCLINED5
HEADROOM
DOOR HEIGHT
TRACK CONFIGURATIONS Overhead door track configurations require vertical, curved and horizontal track. The space above the top of the door to the nearest obstruction is the headroom. For full commercial track space requirements contact your Midland dealer.
UPGRADE YOUR DOOR19
UPGRADE YOUR COMMERCIAL DOORWITH OUR HARSH ENVIRONMENT DOOR PACKAGE Give your doors additional protection and durability. We offer a Harsh Environment Package and a Heavy-Duty Hardware Package to keep your door strong inside and out.
HARSH ENVIRONMENT PACKAGEThe package includes our toughest components to effectively stand up to Mother Nature.
• Corrosion-resistant rollers • Galvanized spring wire
• Zinc-plated shafts • Stainless steel cables
• 11-gauge heavy-duty hinges
• 43/8-inch shielded bearings on ends and center
HEAVY-DUTY HARDWARE PACKAGEThe package includes our durable heavy-duty hardware. Best of all, these components come standard on doors 30-feet-3-inches wide and larger.
• One-piece Triple End Stile hinges
• Grease zerks
• 5/8-inch rollers
GALVANIZED STEEL HARDWAREWe design our galvanized heavy-duty hardware with the same quality and long-lasting value we want for our buildings. That means years of trouble-free operation.
20UPGRADE YOUR DOOR
White
Almond
Sandtone
Gray
Tera-Bronze
Coffee
Green
Beige
Black
Clear Anodized
Deep Bronze Anodized
Black Anodized
Color Select
24” x 5”
24” x 7”
24” x 12”
32” x 14”
Plain
Obscure
Frosted
Gray
Bronze
Low E
Double Dark
ThermoGuard™
EnergySaver™
T-Bond
Plain Steel
Bracket Mount
Angle Mount
Reverse Angle Mount
Standard
Low HeadroomSprings Front
Hi-Lift
Vertical
Incline
3-InchThermoGuard
3-Inch EnergySaver
2-InchThermoGuard
2-Inch EnergySaver
CommercialFullView
CommercialRibbed CS20
CommercialRibbed CS24
CommercialRibbed CS26
Swing-UpCenter Post
• • • • • • • •• • • • •• • • • • •• • •• • • • •• • • • • • •• • • • •
• • •• • •
•••
• • • • • • • • •
CO
LOR
S
• • •• • • • •• • • • • • • •• • •
• • • • • • • • •• • • • • • • • •• • • • • • • • •• • • • • • • • •• • • • • • • • •• • • • • • • • •• • • • • • • • •
WIN
DO
WS
GLA
SSIN
SULA
TIO
N • • •• • •
• • •• • •
• • • • • •• • • • • • • • •• • • • • • • • •
• • • • • • • • •• • • • • • • •• • • • • • • • •• • • • • • • • •• • • • • • • • •
TRA
CK
MO
UN
TTR
AC
KC
ON
FIG
UR
ATI
ON
STUNNING SELECTIONSPRODUCT CHART21 22PRODUCT CHART
PRODUCT CHART
0220
MIDLAND GARAGE DOORS SOLD BY:
© 2019 MIDLAND GARAGE DOOR MFG. CO. INC. ALL RIGHTS RESERVED.
MIDLANDGARAGEDOOR.COM | 800. 437. 4056
PLACE YOUR ORDER TODAY
WEST FARGO 800.437.4056
675 12th Ave. NEWest Fargo, ND 58078
EDEN PRAIRIE800.521.0047
6775 Shady Oak Rd.Eden Prairie, MN 55344
OMAHA800.533.8358
13661 Giles RdOmaha, NE 68138