CONTENTS PAGE - mindaasl.commindaasl.com/uploads/5fec3cdb20ba46a3973b285e6daafbd1.pdf · CONTENTS...

-[ 1 ]-

CONTENTS PAGE NO.

STARTER MOTOR SPARES IDENTIFICATION 3ALTERNATOR SPARES IDENTIFICATION 4

STARTER MOTORS

INTERNATIONAL TRACTORSSONALIKA ALL MODELS 5GARDEN TRAC 22 HP 7GARDEN TRAC - 26HP 9

ESCORTS TRACTORSPOWERTRAC PT434/439/4455/425 10FARMTRAC FT45/60/50/65 12FARMTRAC FT30/35 CHAMPION,PT EURO 45/50 13

TMTL - EICHER TRACTOR5150PS,333/380/480/ 5150ME,241/242,312 /364 /368 /485

15-16

5660 17MAHINDRA & MAHINDRA TRACTORS 265DI/275DI/ 475DI 18PTL - SWARAJ TRACTORS 735 19

TAFE TRACTORS1035DI/ 241DI/ 245DI/ 5245DI/ 462/ 558, 572 21MASSEY FERGUSON MODELS MF9000 23

NEW HOLLAND TRACTORS

3630 DI / 3600-2 254010 / 4510/ 4710 26MECH STEERING MODELS (SIMPSON-3 SERIES / 3 CYL.)

27

ACE TRACTORSALL MODELS 29DI-550 Star (3R 1040 KIRLOSKAR ENGINE) 31DI- 854NG / 550NG/ 450NG/ 350NG 32

HMT LIMITED 6522/ 7511, 2522 / 3522/ 4022/4522/5022 34-35JOHN DEERE TRACTORS ALL MODELS 37INDOFARM TRACTORS 2030DI /2035DI / 2040DI (2 series 2 cyl.)3050DI /

3055DI / 3065DI (3 Series 4 Cyl.)39-40

PREET TRACTORS ALL MODELS 42-43SAME - DEUTZ FAHR TRACTORS ALL MODELS 45APE 3 WHEELER G430, GL430, G435 & GL435 46STANDARD TRACTORS 2 Cyl. Tractors, All 3 & 4 Cyl.Tractors 47

-[ 2 ]-

ALTERNATORSINTERNATIONAL TRACTORS SONALIKA ALL MODELS 6

GARDEN TRAC 22 HP 8ESCORTS TRACTORS POWERTRAC ALL MODELS 11

FARMTRAC ALL MODELS, PT 434/425/EURO 45/50 14PTL - SWARAJ TRACTORS 735 20

TAFE TRACTORS1035DI/ 241DI/ 245DI/ 5245DI/ 462/ 558, 572 22MASSEY FERGUSON MODELS MF9000 24

NEW HOLLAND TRACTORS 3630 DI / 3600-2 28

ACE TRACTORSALL MODELS 30DI- 854NG / 550NG/ 450NG/ 350NG 33

HMT LIMITED ALL MODELS 36JOHN DEERE TRACTORS ALL MODELS 38INDOFARM TRACTORS ALL MODELS 41PREET TRACTORS ALL MODELS 44STANDARD TRACTORS ALL MODELS 48TROUBLE SHOOTING CHART - STARTER MOTOR 49TROUBLE SHOOTING CHART - ALTERNATOR 50TERMS & CONDITIONS 51

-[ 3 ]-

STARTER MOTOR & SPARES1) STARTER MOTOR ASSEMBLY

2) SOLENOID SWITCH ASSEMBLY

3) ARMATURE WITH BEARING

4) PINION DRIVE ASSEMBLY

5) FRONT BRACKET

6) REAR BRACKET

7) GEAR BRACKET ASSEMBLY

8) END CAP ASSEMBLY - SOLENOID SWITCH

9) PINION SHAFT

10) STOP RING KIT

11) OVER RUNNING CLUTCH ASSEMBLY

12) BODY ASSEMBLY (WITHOUT CARBON BRUSH)

13) BRUSH HOLDER ASSEMBLY KIT

14) CARBON BRUSH ASSEMBLY

15) SHIFT LEVER ASSEMBLY KIT

16) COUNTER SUNK BOLD FOR SOLENOID SWITCH TIGHTENING

17) STEEL KIT - FRONT BRACKET ASSEMBLY

18) RUBBER PARTS KIT

19) STEEL KIT FOR STARTER ASSEMBLY

20) ARMATURE BEARING (6001-2Z)

21) NEEDLE ROLER BEARING

-[ 4 ]-

ALTERNATOR & SPARES1) ALTERNATOR ASSEMBLY

2) FRONT BRACKET ASSEMBLY

3) REGULATOR HOLDER ASSEMBLY

4) ROTOR ASSEMBLY

5) STATOR ASSEMBLY

6) REAR BRACKET AND RECTIFIER ASSEMBLY

7) REAR BRACKET, RECTIFIER ASSEMBLY & STATOR ASSEMBLY

8) STEEL KIT FOR REAR BRACKET TIGHTENING

9) STEEL KIT FOR REGULATOR TIGHTENING

10) STEEL KIT FOR ALTERNATOR ASSEMBLY

11) CARBON BRUSH KIT FOR REGULATOR ASSEMBLY

12) PULLEY ASSEMBLY KIT

13) STEEL KIT FOR PULLEY TIGHTENING

14) ALTERNATOR FAN

15) COVER OF REAR BRACKET

16) WOODRUFF KEY

17) BEARING 6203 2RS

18) BEARING 6001 2RS

19) BUSHING

-[ 5 ]-

S. No. PAL Ref. No SPARK MINDA Part No

Description MRP (INR)

MOQ

1 02 230 01029 SMA-1029IT Sonalika International Tractors - All models

5500 2

2 02 230 02044 SOL-2044 Solenoid Assy 880 2

3 02 225 02025 ARM-2025 Armature with Bearing 1926 9

4 02 230 02009A DRA-2009A Pinion Drive Assy. 1200 2

5 02 230 04046 SMFB-4046 Front Bracket 850 2

6 02 230 04090 RB-4090 Rear Bracket 150 5

7 KT-02001A GB-2001A Gear Bracket Assy (Gear bkt., Needle Roller Bearing, Dewatering)

475 2

8 KT-02002A SCA-2002A Solenoid Cover Assy. Tightening Kit (Solenoid cover Assy., Cylinder head bolt(M5), Washer spring lock, O ring)

170 5

9 KT-02003A PS-2003A Pinion Shaft with lock spring kit (Pinion Shaft, Lock spring, Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit (Lock spring, Stop ring, Restoring spring)

57 5

11 7157 980 SMMP-0980 Over Running Clutch Assy. 860 5

12 02 230 02152 BDA-2152 Body Assy./ Stator Assy.( with Carbon Brush)

1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy., Carbon Brushes (-Ve), Carbon Brushes (+Ve), Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes (+Ve), Brush Spring

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy kit (Shift Lever, Ball Pin, Shooting Spring)

67 5

16 KT-02011 SMMP-2011 Counter Sunk Bolt with Tuflok for solenoid Tightening

50 5

17 KT-02008A SMMP-2008A Steel Parts Kit for Front Bracket Assy. 70 5

18 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring, Sealing Ring)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw, Flange Nut(M6), Plain Washer, Seal Rear Bkt

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing ( 6001-2Z)- Armature 60 5

21 FG-324 592 003 SMMP-2003 Needle Roller Bearing 110 5

22 KT-02019 SMMP-2019 Field Coil 727 5

STARTER MOTOR & SPARES ITL

-[ 6 ]-


Description MRP ( INR )

MOQ

1 03 242 01020T ATR-1020 Sonalika International Tractors- All models

3225 2

2 0143 170 ALFB-3170 Front Bracket Assy. 500 2

3 03 242 02024 REG-2024 Regulator Holder Assy 550 5

4 03 242 02001 ROT-2001 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2

6 03 242 02022 COL-2022 Cooler Assy.( Rear Bracket with Rectifier Assy. without stator Assy)

860 5

7 KT-03010 ALMP-3010 Rear Bracket Assy(Rear Bracket with Rec-tifier Assy.with Stator Assy.

1600 2

8 KT-03002 ALMP-3002 Steel Part Kit for Rear Bracket Tightening 62 5

9 KT-03003 ALMP-3003 Steel Part Kit for Regulator Tightening 60 5

10 KT-03004 ALMP-3004 Steel Part Kit for Alternator Assy. 35 5

11 KT-03005 ALMP-3005 Carbon Brush Kit for Regulator Assy 72 5

12 KT-03006A ALMP-3006A Pulley Assy Kit 168 2

13 KT-03007 ALMP-3007 Steel Part Kit for Pulley Tightening 65 2

14 03 242 040008 ALMP-40008 Fan 57 5

15 FG-6108 237 ALMP-8237 Cover of Back Bracket 45 5

16 FG-324165637P 6203-2RS Bearing 6203 2RS 131 5

17 FG-324162027P ALMP-2027P Bearing 6003 2RS 75 5

18 FG-4336 087 AMLP-6087 Bushing 18 5

ALTERNATOR & SPARES ITL

-[ 7 ]-



MOQ

1 02 220 01002 SMA-1002IT GARDENTRAC - 22HP 5500 22 02 220 02002 SOL-2002 Solenoid Switch 880 23 02 225 02025 ARM-2025 Armature with Bearing 1926 94 02 220 02004

(IM)DRA-2004 Pinion Drive Assy. 1200 2

5 02 220 04002 SMFB-4002 Front Bracket 850 26 02 230 04090 RB-4090 Rear Bracket 150 57 KT-02001C GB-2001C Gear Bracket Assy

(Gear bkt. , Needle Roller Bearing)475 2

8 KT-02002A SCA-2002A Solenoid Cover Assy. Tightening Kit (Solenoid cover Assy.,Cylinder head bolt (M5),Washer spring lock, O ring)

170 5

9 KT-02003I (IM) PS-2003I Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004A SMMP-2004A Stop Ring Kit( Lock spring,Stop ring, Restoring spring)

57 5

11 7157 980 SMMP-0980 Over Running Clutch Assy. 860 512 02 230 02152 BDA-2152 Body Assy./ Stator Assy.( with Carbon

Brush)1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy., Carbon Brushes(-Ve), Carbon Brushes(+Ve), Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes (+Ve),Brush Spring

265 10


67 5


50 5

17 KT-02008E SMMP-2008E Steel Parts Kit for Front Bracket Assy. 70 518 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring, Sealing

Ring, Gasket, Gasket)55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut(M6),Plain Washer,seal rear bkt

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing( 6001-2Z)- Armature 60 521 FG-324 592 003 SMMP-2003 Needle Roller Bearing 110 522 KT-02019 SMMP-2019 Field Coil 727 5

STARTER MOTOR & SPARES ITL (IM)

-[ 8 ]-



MOQ

1 03 242 01025T ATR-1025 GARDENTRAC - 22HP 3225 2

2 03 242 02014 ALFB-2014 Front Bracket Assy. 530 2

3 03 242 02024 REG-2024 Regulator Holder Sub Assy. 550 5

4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5

7 KT-03010B ALMP-3010B Rear Bracket Assy(Rear Bracket with Recti-fier Assy.with Stator Assy.

1600 2





12 KT-03006I ALMP-3006I Pulley Assy Kit 168 2

13 KT-03007E ALMP-3007E Steel Part Kit for Pulley Tightening 65 2

14 FG-0324240008 ALMP-40008 Fan 57 5


16 FG-324 165 637P

6203-2RS Bearing 6203 2RS 131 5

17 FG-324 162 027P

ALMP-2027P Bearing 6003 2RS 75 5

18 FG-4336 087 AMLP-6087 Bushing 18 5

ALTERNATOR & SPARES ITL (IM)

-[ 9 ]-

STARTER MOTOR & SPARES ITLS. No. PAL Ref. No SPARK MINDA

Part NoDescription MRP

( INR )MOQ

1 02 220 01011 SMA-1011IT GARDENTRAC 26HP 5500 2

2 02 230 02138 SOL-2138 Solenoid assy. 880 2

3 02 225 02025 ARM-2025 Armature with bearing 1926 9

4 02 230 02132 DRA-2132 Pinion Drive Assy. 1200 2

5 02 230 04245G SMFB-4245 Front Bracket-Mach. 850 2

6 02 230 04247 RB-4247 Rear Bracket-Mach. 222 5

7 KT-02001G GB-2001G Gear Bracket Assy. (Gear Bkt, Needle Roller Bearing)

475 2

8 KT-02002A SCA-2002A Solenoid Cover Assy. Tightening Kit (Sole-noid Cover Assy., Cylinder Head Bolt (M5), Washer Spring Lock, O-Ring)

170 5

9 KT-02003P PS-2003P Pinion Shaft with Lock Spring Kit (Pinion Shaft, Lock spring, Stop ring & Restoring spring)

800 2

10 KT-02004A SMMP-2004A Stop Ring Kit ( Lock spring, Stop ring & Restoring spring)

57 5



1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes( +Ve),Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy.(Carbon Brushes( -Ve),Carbon Brushes(+Ve),Brush Spring

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy Kit (Shift Lever, Ball Pin & Shooting Spring)

67 5

16 KT-02011 SMMP-2011 Counter Sunk Bolt with Tuflok for Solenoid Tightening

50 5


18 KT-02009 SMMP-2009 Rubber & Gasket Seal kit ( O-Ring, Sealing Ring, Gasket)

55 5

19 KT-02010D SMMP-2010D Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut -M6, Seal- Rear Bracket, Plain Washer -M6)

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing ( 6001-2Z )- Armature 60 5



-[ 10 ]-

ESCORTS (POWERTRAC)STARTER MOTOR & SPARES



MOQ

1 02 225 01012 SMA-1012EP PT434 / 439 / 4455 5500 2

1.1 02 225 01006 SMA-1006EP PT 425 5500 2




5 02 230 04032 SMFB-4032 Front Bracket (SMA-1012EP) 850 2

5.1 FG- 1655 200 SMFB-200A Front Bracket (SMA-1006EP) 850 2

6 02 230 04090 RB-4090 Rear Bracket 150 5

7 KT-02001C GB-2001C Gear Bracket Assy (Gear bkt. , Needle Roller Bearing)

475 2

8 KT-02002C SCA-2002C Solenoid Cover Assy.Tightening Kit (Solelonid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003F PS-2003F Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock spring,Stop ring, Re-storing spring)

57 5



1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit(Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes( +Ve),Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes (+Ve), Brush Spring)

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy kit (Shift Lever,Ball Pin,Shooting Spring)

67 5


50 5


18 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing Ring,Gasket)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut(M6), Plain Washer, seal rear bkt)

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing ( 6001-2Z)- Armature 60 5


-[ 11 ]-



MOQ

1 03 242 01010T ATR-1010 All Powertrac models 3225 2



4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5

7 KT-03010 ALMP-3010 Rear Bracket Assy(Rear Bracket with Recti-fier Assy.with Stator Assy.

1600 2





12 KT-03006E ALMP-3006E Pulley Assy Kit 168 2

13 KT-03007D ALMP-3007D Steel Part Kit for Pulley Tightening 65 2

14 FG-0324240008 ALMP-40008 Fan 57 5


16 FG-324165637P 6203-2RS Bearing 6203 2RS 131 5


18 FG-4336 087 AMLP-6087 Bushing 18 5

ALTERNATOR & SPARESESCORTS

POWERTRAC

-[ 12 ]-



MOQ

1 02 230 01013 SMA-1013EF FT45/FT60/FT50/ FT65 5600 2


3 7151 542 ARM-542 Armature with Bearing 2000 9



6 02 230 02041 RB-2041 Rear Bracket Assy. 222 5


475 2

8 KT-02002E SCA-2002E Solenoid Cover Assy.Tightening Kit (Solelonid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003G (EF) PS-2003G Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2


57 5



1850 2


435 10

14 KT-02006 CB-2006 Carbon Brush Assy.(Carbon Brushes( -Ve),Carbon Brushes( +Ve),Brush Spring)

265 10


67 5


50 5

17 KT-02008E SMMP-2008E Steel Parts Kit for Front Bracket Assy. 70 5


55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut(M6),Plain Washer,seal rear bkt)

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing( 6001-2Z)-Armature 60 5



ESCORTS (FARMTRAC)STARTER MOTOR & SPARES

-[ 13 ]-



MOQ

1 02 230 01060 SMA-1060EF FT30/35 CHAMPION, PT EURO 45/50 5600 2




5 02 230 04217 SMFB-4217 Front Bracket-Mach. 850 2


7 KT-02001C GB-2001C Gear Bracket Assy. (Gear Bkt, Needle Roller Bearing)

475 2

8 KT-02002C SCA-2002C Solenoid Cover Assy. Tightening Kit (Sole-noid Cover Assy., Cylinder Head Bolt (M5), Washer Spring Lock, O-Ring)

170 5

9 KT-02003Q PS-2003Q Pinion Shaft with Lock Spring Kit (Pinion Shaft, Lock spring, Stop ring & Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit ( Lock spring, Stop ring & Restoring spring)

57 5


12 02 230 02152 BDA-2152 Body Assy./ Stator Assy. (With Carbon Brush)

1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy., Carbon Brushes (-Ve),Carbon Brushes (+Ve). & Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. ( Carbon Brushes -4nos & Brush Spring -4nos.)

265 10


67 5


50 5

17 KT-02014 SMMP-2014 Steel Parts Kit for Front Bracket Assy. 70 5


55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut -M6, Seal- Rear Bracket, Plain Washer -M6)

45 5




STARTER MOTOR & SPARESESCORTS

(FARMTRAC)

-[ 14 ]-

ALTERNATOR & SPARESESCORTS

(FARMTRAC)S. No. PAL Ref. No SPARK MINDA


( INR )MOQ

1 03 235 01002T ATR-1002EF All Farmtrac models, PT434/PT-425 3225 2



4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5


1600 2





12 KT-03006F ALMP-3006F Pulley Assy Kit 168 2

13 KT-03007D ALMP-3007D Steel Part Kit for Pulley Tightening 65 2

14 FG-0324204008 ALMP-40008 Fan 57 5


16 FG-324165637P 6203-2RS Bearing 6203 2RS 131 5


18 FG-4336 087 AMLP-6087 Bushing 18 5

-[ 15 ]-

EICHER (TMTL)STARTER MOTOR & SPARES



MOQ

1 02 225 01001 SMA-1001ET 5150 PS 5500 2

1.1 02 225 01007 SMA-1007ET 333/380/480/ 5150ME 5500 2

1.2 02 225 01008 SMA-1008ET 241/242 (All Variants) 5500 2

1.3 02 225 01009 SMA-1009ET 312 /364 /368 /485 5500 2

2 02 230 02044 SOL-2044 Solenoid Assy (SMA-1001ET) 880 2

2.1 02 230 02088 SOL-2088 Solenoid Assy (SMA-1009ET) 880 2

2.2 02 230 02039 SOL-2039 Solenoid Switch (SMA-1007ET) 880 2

2.3 02 230 02072 SOL-2072 Solenoid Switch (SMA-1008ET) 880 2


4 02 230 02009B DRA-2009B Pinion Drive Assy. (SMA-1001ET) 1200 2

4.1 02 230 02042 DRA-2042 Pinion Drive Assy. (SMA-1007ET/1009ET) 1200 2

4.2 02 230 02066 DRA-2066 Pinion Drive Assy. (SMA-1008ET) 1200 2

5 02 230 04060 SMFB-4060 Front Bracket (SMA-1001ET) 850 2

5.1 02 230 04147 SMFB-4147 Front Bracket (SMA-1007ET) 850 2



6 02 230 04090 RB-4090 Rear Bracket (SMA-1001ET) 150 5

6.1 02 230 02041 RB-2041 Rear Bracket (SMA-1007-ET/1008ET/1009ET)

222 5

7 KT-02001B GB-2001B Gear Bracket Assy (Gear bkt. , Needle Roller Bearing)

475 2

7.1 KT-02001C GB-2001C Gear Bracket Assy (SMA-1008ET) (Gear bkt. , Needle Roller Bearing)

475 2

8 KT-02002A SCA-2002A Solenoid Cover Assy.Tightening Kit (Solenoid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

-[ 16 ]-

STARTER MOTOR & SPARESEICHER (TMTL)



MOQ

9 KT-02003B (K6) PS-2003B Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring) DRA-2009B

800 2

9.1 KT-02003E (ST) PS-2003E Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring) DRA-2042

800 2

9.2 KT-02003H (K7) PS-2003H Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring) DRA-2066

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit (Lock spring,Stop ring, Re-storing spring)

57 5


12 02 230 02152 BDA-2152 Body Assy./ Stator Assy. ( with Carbon Brush)

1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy.,Carbon Brushes (-Ve ),Carbon Brushes(+Ve ),Brush Spring

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve),Carbon Brushes (+Ve),Brush Spring)

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy kit (Shift Lever, Ball Pin,Shooting Spring)

67 5


50 5


18 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing Ring, Gasket)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut(M6),Plain Washer,seal rear bkt

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing( 6001-2Z)- Armature 60 5



-[ 17 ]-

EICHER (TMTL)STARTER MOTOR & SPARES



MOQ

1 02 230 01049 SMA-1049ET 5660 5500 2






7 KT-02001F GB-2001F Gear Bracket Assy. (Gear Bkt, Needle Roller Bearing)

475 2


170 5

9 KT-02003A PS-2003A Pinion Shaft with Lock Spring Kit (Pinion Shaft, Lock spring, Stop ring & Restoring spring)

800 2


57 5



1850 2


435 10


265 10


67 5


50 5



55 5

19 KT-02010B SMMP-2010B Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut -M6, Seal- Rear Bracket, Plain Washer -M6)

45 5




-[ 18 ]-

STARTER MOTOR & SPARES M&MS. No. PAL Ref. No SPARK MINDA


( INR )MOQ

1 02 220 01006S SMA-1006MM 265DI/275DI/ 475DI 5500 2





6 02 230 04090 RB-4090 Rear Bracket 150 5


475 2

8 KT-02002B SCA-2002B Solenoid Cover Assy.Tightening Kit (Solenoid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003D (MM) PS-2003D Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2


57 5



1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit(Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes (+Ve),Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy.(Carbon Brushes (-Ve),Carbon Brushes( +Ve),Brush Spring)

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy kit(Shift Lever,Ball Pin,Shooting Spring)

67 5


50 5


18 KT-02009 SMMP-2009 Rubber & gasket Seal kit(O- Ring,Sealing Ring,Gasket,Gasket)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut (M6), Plain Washer, Seal Rear Bkt

45 5


21 FG-324592003 SMMP-2003 Needle Roller Bearing 110 5


-[ 19 ]-

M&M SWARAJSTARTER MOTOR & SPARESS. No. PAL Ref. No SPARK MINDA


( INR )MOQ

1 02 225 01015 SMA-1015SW 735 5500 22 02 230 02044 SOL-2044 Solenoid Switch 880 2


4 02 230 02009B (K6)

DRA-2009B Pinion Drive Assy 1200 2


6 02 230 04090 RB-4090 Rear Bracket Assy 150 5

7 KT-02001B GB-2001B Gear Bracket Assy (Gear Bracket, Needle Roller Bearing)

475 2

8 KT- 02002A SCA-2002A Solenoid Cover Assy. Tightening Kit (Solenoid Cover ssy., Cylinder head bolt(M5) , Washer spring lock, O-ring)

170 5

9 KT-02003B(K6) PS-2003B Pinion Shaft with lock spring kit (Pinion Shaft, Lock spring, stop ring, Restor-ing Spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock Spring, Stop Ring, Re-storing spring)

57 5


12 02 230 02152 BDA-2152 Body Assy. / Stator Assy. (With Carbon Brush)

1850 2

13 KT- 02005 BH-2005 Brush Holder Assy kit( Brush holder Assy., Carbon Brushes( -ve) Carbon Brushes(-Ve), brush spring

435 10

14 KT- 02006 CB-2006 Carbon Brush Assy.(Carbon Brushes( -ve) Carbon Brushes(-Ve), brush spring

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy Kit (Shift Lever, ball pin, shooting spring)

67 5

16 KT-02011 SMMP-2011 Counter Sunk Bolt with tuflok for solenoid tightening

50 5

17 KT- 02008E SMMP-2008E Steel part kit for front bracket assy 70 5

18 KT-02009 SMMP-2009 Rubber & gasket seal kit (O Ring, sealing Ring ,Gaskets)

55 5

19 KT-02010A SMMP-2010A Steel parts kit for starter Motor Assy. ( Set Screw, Flange Nut( M6), Plain Washer, Seal rear bracket

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing (6001-2Z)- Armature 60 5



-[ 20 ]-

M&M SWARAJALTERNATOR & SPARESS. No. PAL Ref. No SPARK MINDA


( INR )MOQ

1 03 235 01008T ATR-1008SW 735 3225 2

2 03 242 02003 ALFB-2003 Front Bracket Assy 500 2

3 03 235 02012 REG-2012 Regulator Holder Assy with Connector 550 5

4 03 242 02001 ROT-2001 Rotor Assy. 990 2

5 03 235 02011 STA-2011 Stator Assy 775 2


860 5

7 03 242 02028 ALMP-2028 Rear Bracket,Rectifier Assy. & Stator Assy 1600 2

8 KT-03002 ALMP-3002 Steel Part Kit for Rear Bracket tighening 62 5

9 KT-03003 ALMP-3003 Steel Part Kit for Regulator Tighening 60 5



12 KT-03007B ALMP-3007B Steel Part Kit for pulley Tighening 65 2

13 KT-03008A ALMP-3008A Connector Assy Kit 38 2

14 FG-03235 04026 ALMP-4026 Pulley Assy Kit( C.I) 168 2

15 FG-03242 40008 ALMP-40008 Fan 57 5


17 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5

18 FG-324162 027P AMLP-6087 Bearing 6003 2RS 75 5

19 FG-433 6087 ALMP-6087 Bushing 18 5

-[ 21 ]-

TAFESTARTER MOTOR & SPARESS. No. PAL Ref. No SPARK MINDA


( INR )MOQ

1 02 225 01014 SMA-1014TF 1035DI/ 241DI/ 245DI/ 5245DI/ 462/ 558, 572

5500 2



4 02 230 02042 (ST)

DRA-2042 Pinion Drive Assy. 1200 2



7 KT-02001B GB-2001B Gear Bracket Assy (Gear bkt., Needle Roller Bearing, Dewatering)

475 2

8 KT-02016 SCA-2016 Solenoid Cover Assy. Tightning Kit (Solelonid cover Assy., Cylinder head bolt(M5), Washer spring lock, O ring)

170 5

9 KT-02003E (ST) PS-2003E Pinion Shaft with lock spring kit (Pinion Shaft, Lock spring, Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit (Lock spring, Stop ring, Restoring spring)

57 5



1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit(Brush Holder Assy., Carbon Brushes (-Ve),Carbon Brushes (+Ve), Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes( +Ve),Brush Spring)

265 10


67 5


50 5


18 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing Ring, Gasket, Gasket)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut (M6), Plain Washer Seal Rear Bkt

45 5




-[ 22 ]-

TAFEALTERNATOR & SPARESS. No. PAL Ref. No SPARK MINDA


( INR )MOQ

1 03 235 01007T ATR-1007 1035DI/ 241DI/ 245DI/ 5245DI/ 462/ 558, 572

3225 2


3 03 242 02029 REG-2029 Regulator Holder Assy with connector 550 5

4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5

7 KT-03010A ALMP-3010A Rear Bracket Assy(Rear Bracket with Rectifier Assy. with Stator Assy.

1600 2





12 FG-03242 04039 ALMP-4039 Pulley (CI) 168 2

13 KT-03007B ALMP-3007B Steel Part Kit for Pulley Tightening 65 2

14 FG-03242 40008 ALMP-40008 Fan 57 5


16 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5

17 FG-324162 027P ALMP-2027P Bearing 6003 2RS 75 5

18 FG-4336 087 AMLP-6087 Bushing 18 5

-[ 23 ]-

TAFESTARTER MOTOR & SPARESS. No. PAL Rtef. No SPARK MINDA


( INR )MOQ

1 02 230 01041 SMA-1041TF Massey Ferguson models MF9000 5600 22 02 230 02080 SOL-2080 Solenoid Assy 880 2


4 02 230 02042 (ST)

DRA-2042 Pinion Drive Assy. 1200 2



7 KT-02001B GB-2001B Gear Bracket Assy (Gear bkt. , Needle Roller Bearing, Dewatering)

475 2

8 KT-02016 SCA-2016 Solenoid Cover Assy.Tightning Kit (Solelonid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003E (ST) PS-2003E Pinion Shaft with lock spring kit (Pinion Shaft, Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock spring,Stop ring, Restoring spring)

57 5



1850 2


435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes (+Ve), Brush Spring)

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy kit(Shift Lever,Ball Pin, Shooting Spring)

67 5


50 5


18 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing Ring, Gasket, Gasket)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut (M6), Plain Washer Seal Rear Bkt

45 5




-[ 24 ]-



MOQ

1 03 242 01001T ATR-1001TF Massey Ferguson models MF9000 3225 2



4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5

7 KT-03010A ALMP-3010A Rear Bracket Assy(Rear Bracket with Rectifier Assy.with Stator Assy.

1600 2





12 FG-03242 04039 ALMP-4039 Pulley (CI) 168 2


14 FG-03242 40008 ALMP-40008 Fan 57 5


16 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


18 FG-4336 087 AMLP-6087 Bushing 18 5

TAFEALTERNATOR & SPARES

-[ 25 ]-

NEW HOLLAND (IVECO)STARTER MOTOR & SPARES



MOQ

1 02 230 01038 SMA-1038NH 3630 DI / 3600-2 5600 22 02 230 02049 SOL-2049 Solenoid Assy 880 23 7151 542 ARM-542 Armature with Bearing 2000 94 02 230 02053

(NI)DRA-2053 Pinion Drive Assy. 1200 2

5 02 230 04114 (NI14)

SMFB-4114 Front Bracket 850 2

6 FG-02 230 04090 RB-4090 Rear Bracket 150 57 KT-02001B GB-2001B Gear Bracket Assy


8 KT-02012 SCA-2012 Solenoid Cover Assy.Tightening Kit (Solenoid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02013 PS-2013 Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock spring,Stop ring, Restoring spring)

57 5

11 7157 980 SMMP-0980 Over Running Clutch Assy. 860 512 02 230 02152 BDA-2152 Body Assy./ Stator Assy. (with Carbon

Brush)1850 2


435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes ( +Ve), Brush Spring)

265 10


67 5


50 5

17 KT-02008D SMMP-2008D Steel Parts Kit for Front Bracket Assy. 70 518 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring, Sealing


19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut (M6), Plain Washer, Seal Rear Bkt)

45 5


-[ 26 ]-



MOQ

1 02 230 01021 SMA-1021NH 4010 / 4510/ 4710 5600 22 02 230 02087 SOL-2087 Solenoid Assy 880 23 7151 542 ARM-542 Armature with Bearing 2000 94 02 230 02009B

(K6)DRA-2009B Pinion Drive Assy. 1200 2

5 02 230 04060 (NH 60)


6 02 230 04090 RB-4090 Rear Bracket 150 57 KT-02001B GB-2001B Gear Bracket Assy


8 KT-02015 SCA-2015 Solenoid Cover Assy.Tightening Kit (Solenoid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003B (K6) PS-2003B Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock spring,Stop ring, Restor-ing spring)

57 5

11 7157 980 SMMP-0980 Over Running Clutch Assy. 860 512 02 230 02152 BDA-2152 Body Assy./ Stator Assy.( with Carbon

Brush)1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes( +Ve),Brush Spring)

435 10


265 10


67 5


50 5

17 KT-02008E SMMP-2008E Steel Parts Kit for Front Bracket Assy. 70 518 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing

Ring,Gasket,Gasket)55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut (M6),Plain Washer, Seal Rear Bkt

45 5


NEW HOLLAND (SIMPSON)STARTER MOTOR & SPARES

-[ 27 ]-



MOQ

1 02 230 01045 SMA-1045NH Mech Steering models (Simpson-3 Series / 3 Cyl)

5600 2

2 02 230 02097 SOL-2097 Solenoid Switch 880 23 7151 542 ARM-542 Armature With Bearing 2000 94 02 230 02042

(ST)DRA-2042 Pinion Drive Assy 1200 2

5 02 230 04147 SMFB-4147 Front Bracket 850 26 02 230 02041 RB-2041 Rear Bracket Assy 222 57 KT- 02001B GB-2001B Gear Bracket Assy

(Gear Bracket, Needle Roller Bearing)475 2

8 KT- 02002F SCA-2002F Solenoid Cover Assy. Tightening Kit (Solenoid Cover ssy., Cylinder head bolt(M5) , Washer spring lock, O-ring)

170 5

9 KT-02003E(ST) PS-2003E Pinion Shaft with lock spring kit (Pinion Shaft, Lock spring, stop ring, Restoring Spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock Spring, Stop Ring, Restoring spring)

57 5

11 7157 980 SMMP-0980 Over Running Clutch Assy. 860 512 02 230 02152 BDA-2152 Body Assy. / Stator Assy.

(With Carbon Brush)1850 2

13 KT-02005 BH-2005 Brush Holder Assy kit ( Brush holder Assy., Carbon Brushes (-ve) Carbon Brushes (-Ve), brush spring

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-ve) Carbon Brushes (-Ve), brush spring

265 10

15 KT-02007 SMMP-2007 Shift Lever Assy Kit (Shift Lever, ball pin, shooting spring)

67 5

16 KT-02011 SMMP-2011 Counter Sunk Bolt with tuflok for solenoid tightening

50 5

17 KT- 02008E SMMP-2008E Steel part kit for front bracket assy 70 518 KT-02009 SMMP-2009 Rubber & gasket seal kit

(O Ring, sealing Ring ,Gaskets)55 5

19 KT-02010A SMMP-2010A Steel parts kit for starter Motor Assy. (Set Screw, Flange Nut (m6), Plain Washer, Seal rear bracket

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing (6001-2Z)- Armature 60 521 FG-324 592 003 SMMP-2003 Needle Roller Bearing 110 522 KT-02019 SMMP-2019 Field Coil 727 5

NEW HOLLAND (SIMPSON)STARTER MOTOR & SPARES

-[ 28 ]-



MOQ

1 03 235 01001T ATR-1001NH 3630 / 3600-2 3225 2



4 03 235 02007 ROT-2007 Rotor Assy. 990 2

5 03 235 02011 STA-2011 Stator Assy. 775 2


860 5

7 KT-03010C ALMP-3010C Rear Bracket Assy(Rear Bracket with Recti-fier Assy.with Stator Assy.

1600 2





12 KT-03006G ALMP-3006G Pulley Assy Kit 168 2

13 KT-03007E ALMP-3007E Steel Part Kit for Pulley Tightening 65 2

14 FG-03242040008

ALMP-40008 Fan 57 5


16 FG-03235 04003 ALMP-4003 Connector Assy 38 2

17 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5

18 FG-324162 027P AMLP-6087 Bearing 6003 2RS 75 5

19 FG-4336 087 ALMP-6087 Bushing 18 5

NEW HOLLAND (IVECO)ALTERNATOR & SPARES

-[ 29 ]-



MOQ

1 02 230 01014 SMA-1014A ACE Tractor – All Models 5500 22 02 230 02019 SOL-2019 Solenoid Switch 880 23 02 225 02025 ARM-2025 Armature with Bearing 1926 94 02 230 02009F

(M2)DRA-2009F Pinion Drive Assy. 1200 2

5 02 230 04038 SMFB-4038 Front Bracket 850 26 02 230 04090 RB-4090 Rear Bracket 150 57 KT-02001D GB-2001D Gear Bracket Assy


8 KT-02002D SCA-2002D Solenoid Cover Assy.Tightening Kit (Solenoid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003C PS-2003C Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit (Lock spring,Stop ring, Restoring spring)

57 5

11 7157 980 SMMP-0980 Over Running Clutch Assy. 860 512 02 230 02152 BDA-2152 Body Assy./ Stator Assy. (with Carbon

Brush)1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes ( +Ve),Brush Spring)

435 10


265 10


67 5


50 5

17 KT-02008B SMMP-2008B Steel Parts Kit for Front Bracket Assy. 70 518 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing

Ring,Gasket,Gasket)55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut(M6),Plain Washer,seal rear bkt)

45 5


ACESTARTER MOTOR & SPARES

-[ 30 ]-



MOQ

1 03 242 01011T ATR-1011 ACE Tractor – All Models 3225 2



4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5


1600 2





12 KT-03006C ALMP-3006C Pulley Assy Kit 168 2


14 FG-03242 40008 ALMP-40008 Fan 57 5


16 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


18 FG-4336 087 AMLP-6087 Bushing 18 5

ACEALTERNATOR & SPARES

-[ 31 ]-



MOQ

1 02 225 01021 SMA-1021A DI-550 Star (3R 1040 Kirloskar engine) 5500 2



4 02 230 02009B DRA-2009B Pinion Drive Assy. 1200 2



7 KT-02001E GB-2001E Gear Bracket Assy. (Gear Bkt, Needle Roller Bearing)

475 2

8 KT-02002A SCA-2002A Solenoid Cover Assy. Tightening Kit (Solenoid Cover Assy., Cylinder Head Bolt (M5), Washer Spring Lock, O-Ring)

170 5

9 KT-02003B PS-2003B Pinion Shaft with Lock Spring Kit (Pinion Shaft, Lock spring, Stop ring & Restoring spring)

800 2


57 5

11 FG-7157 980 SMMP-0980 Over Running Clutch Assy. 860 5


1850 2


435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes (+Ve). & Brush Spring)

265 10


67 5


50 5

17 KT-02014 SMMP-2014 Steel Parts Kit for Front Bracket Assy. 70 5


55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy. (Set Screw, Hex Nut -M5, Washer Spring Lock Washer -M5)

45 5





-[ 32 ]-



MOQ

1 02 225 01004 SMA-1004A DI- 854NG / 550NG/ 450NG/ 350NG 5500 2







475 2


170 5


800 2


57 5



1850 2


435 10


265 10


67 5


50 5



55 5


45 5





-[ 33 ]-



MOQ

1 03 242 01027T ATR-1027 DI- 854NG / 550NG/ 450NG/ 350NG 3225 2


3 03 242 02024 REG-2024 Regulator Holder Assy. 550 5

4 01431 40 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2

6 03 242 02022 COL-2022 Cooler assy. ( Rear Bracket with Rectifier Assy. without stator Assy.)

860 5

7 KT-03010 ALMP-3010 Rear Bracket Assy. (Rear Bracket with Rectifier Assy. with Stator Assy.)

1600 2




11 KT-03005 ALMP-3005 Carbon Brush Kit for Regulator Assy. 72 5

12 KT-03007B ALMP-3007B Pulley Assy Kit 65 2

13 03 242 040008 ALMP-40008 Fan 57 5


15 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


17 FG-4336 087 ALMP-6087 Bushing 18 5

ACEALTERNATOR & SPARES

-[ 34 ]-



MOQ

1 02 230 01011 SMA-1011H 6522/ 7511 5600 2

1.1 02 230 01012 SMA-1012H 2522 / 3522/ 4022/4522/5022 5500 2


3 02 225 02025 ARM-2025 Armature with Bearing (SMA-1012H) 1926 9

3.1 7151 542 ARM-542 Armature with Bearing (SMA-1011H) 2000 9


5 02 230 04046 SMFB-4046 Front Bracket (SMA-1011H) 850 2

5.1 02 230 04037 SMFB-4037 Front Bracket (SMA-1012H) 850 2

6 FG-02230 04090 RB-4090 Rear Bracket 150 5

7 KT-02001A GB-2001A Gear Bracket Assy (SMA-1011H) (Gear bkt. , Needle Roller Bearing, Dewater-ing)

475 2

7.1 KT-02001D GB-2001D Gear Bracket Assy (SMA-1012H) (Gear bkt. , Needle Roller Bearing, Dewater-ing)

475 2

8 KT-02002A SCA-2002A Solenoid Cover Assy.Tightning Kit (Solelonid cover Assy.,Cylinder head bolt(M5),Washer spring lock, O ring)

170 5

9 KT-02003A (IL) PS-2003A Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restroing spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit (Lock spring,Stop ring, Re-stroing spring)

57 5



1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit(Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes (+Ve),Brush Spring)

435 10

HMTSTARTER MOTOR & SPARES

-[ 35 ]-

HMTSTARTER MOTOR & SPARESS. No. PAL Ref. No SPARK MINDA


( INR )MOQ


265 10


67 5

16 KT-02011 SMMP-2011 Counter Sunk Bolt with Tuflok for solenoid Tigtening

50 5


17.1 KT-02008E SMMP-2008E Steel Parts Kit for Front Bracket Assy. 70 5

18 KT-02009 SMMP-2009 Rubber & gasket Seal kit(O- Ring,Sealing Ring,Gasket,Gasket)

55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut(M6),Plain Washer, Seal Rear Bkt)

45 5




-[ 36 ]-


Description MRP ( INR ) MOQ

1 03 242 01009T ATR-1009 HMT- All Models 3225 2



4 03 242 02002 ROT-2002 Rotor Assy. 990 2

5 03 235 02011 STA-2011 Stator Assy. 775 2


860 5


1600 2






13 FG-03242 04013 ALMP-4013 Fan 57 5


15 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


17 FG-4336 087 AMLP-6087 Bushing 18 5

HMTALTERNATOR & SPARES

-[ 37 ]-



1 02 230 01007S SMA-1007JD John Deere - All Models 5500 2


3 7151 542 ARM-542 Armature with bearing 2000 9





475 2

8 KT-02002I SCA-2002I Solenoid Cover Assy. Tightening Kit (Sole-noid Cover Assy., Cylinder Head Bolt (M5), Washer Spring Lock, O-Ring)

170 5


800 2


57 5



1850 2


435 10


265 10


67 5


50 5



55 5


45 5




JOHN DEERESTARTER MOTOR & SPARES

-[ 38 ]-



1 13 242 11002S SMA-1002S John Deere - All Models (Internal Fan) 3225 2

2 FG-13240 12006 ALFB-2006 Front Bracket Assy. 500 2

3 KT-03011A REG-3011A Regulator Holder Assy. 550 5

4 FG-13240 02001 ROT-2001S Rotor Assy. 990 2

5 FG-13240 12005 STA-2005 Stator Assy. 775 2

6 FG-13240 12007 COL-2007 Cooler Assy.( Rear Bracket with Rectifier Assy. without stator Assy)

860 5

7 FG-13240 12002 ALMP-12002 Rear Bracket Assy. (Rear Bracket with Recti-fier Assy. with Stator Assy.)

1600 2



10 KT-13002 ALMP-3004A Steel Part Kit for Alternator Assy. 35 5

11 KT-03005 ALMP-3005 Carbon Brush Kit for Regulator Assy. 72 5

12 FG-13242 14001 ALMP-14001 Pulley (JI) 168 2



15 FG-13240 14017 6203-2RS Bearing 6203 2RS 131 5

16 FG-13240 14016 ALMP-14016 Bearing 6003 2RS 75 5

17 FG-13240 14003 ALMP-14003 BUSH 18 5

JOHN DEEREALTERNATOR & SPARES

-[ 39 ]-



1 02 230 01008 SMA-1008ID "2030DI /2035DI / 2040DI (2 series 2 cyl.)"

5500 2

1.1 02 230 01010 SMA-1010ID "3050DI / 3055DI / 3065DI (3 Series 4 Cyl.)"

5600 2



4 02 230 02009B DRA-2009B Pinion Drive Assy. (SMA-1008ID) 1200 2

4.1 02 230 02009A DRA-2009A Pinion Drive Assy. (SMA-1010ID) 1200 2

5 02 230 04030 SMFB-4030 Front Bracket (SMA-1008ID) 850 2

5.1 02 230 04046 SMFB-4046 Front Bracket (SMA-1010ID) 850 2

6 02 230 04090 RB-4090 Rear Bracket 150 5

7 KT-02001D GB-2001D Gear Bracket Assy (Gear bkt. , Needle Roller Bearing)

475 2


170 5

9 KT-02003B PS-2003B Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring) DRA-2009B

800 2

9.1 KT-02003A PS-2003A Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring) DRA-2009A

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock spring,Stop ring, Re-stroing spring)

57 5

11 7157980 SMMP-0980 Over Running Clutch Assy. 860 5


1850 2

INDOFARMSTARTER MOTOR & SPARES

-[ 40 ]-




435 10


265 10


67 5


50 5

17 KT-02008 E SMMP-2008E Steel Parts Kit for Front Bracket Assy. 70 5


55 5

19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut (M6), Plain Washer, Seal Rear Bkt

45 5




INDOFARMSTARTER MOTOR & SPARES

-[ 41 ]-



1 03 242 01008T ATR-1008 INDOFARM- All Models 3225 2



4 03 242 02002 ROT-2002 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5

7 KT-03010 ALMP-3010 Rear Bracket , Rectifier Assy.& Stator Assy. 1600 2






13 FG-03242 04013 ALMP-4013 Fan 57 5


15 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


17 FG-4336 087 AMLP-6087 Bushing 18 5

INDOFARMALTERNATOR & SPARES

-[ 42 ]-



1 02 230 01018 SMA-1018PT Preet Tractors (All Models) 5600 2



4 02 230 02009A (IL)

DRA-2009A Pinion Drive Assy. 1200 2


6 02 230 04090 RB-4090 Rear Bracket 150 5

7 KT-02001D GB-2001D Gear Bracket Assy (Gear bkt. , Needle Roller Bearing)

475 2


170 5

9 KT-02003A (IL) PS-2003A Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring, Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit (Lock spring,Stop ring, Re-storing spring)

57 5


12 02 230 02152 BDA-2152 Body Assy./ Stator Assy. (without Carbon Brush)

1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy.,Carbon Brushes( -Ve),Carbon Brushes (+Ve),Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy.(Carbon Brushes (-Ve),Carbon Brushes( +Ve),Brush Spring

265 10


67 5

PREETSTARTER MOTOR & SPARES

-[ 43 ]-

PREETSTARTER MOTOR & SPARESS. No. PAL Ref. No SPARK MINDA

Part NoDescription MRP ( INR ) MOQ


50 5


18 KT-02009 SMMP-2009 Rubber & gasket Seal kit(O- Ring,Sealing Ring,Gasket)

55 5

19 KT-02010B SMMP-2010B Steel Parts Kit for Starter Assy.(Set Screw,Flange Nut (M6), Plain Washer, Seal Rear Bkt)

45 5




-[ 44 ]-

PREETALTERNATOR & SPARESS. No. PAL Ref. No SPARK MINDA


1 03 242 01013T ATR-1013 Preet Tractors (All Models) 3225 2



4 0143 140 ROT-3140 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2


860 5

7 KT-03010 ALMP-3010 Rear Bracket Assy(Rear Bracket with Rectifier Assy.with Stator Assy.

1600 2





12 FG-6022 047 ALMP-2047 Pulley (CI) 320 2


14 FG-03242 40008 ALMP-40008 Fan 57 5


16 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


18 FG-4336 087 AMLP-6087 Bushing 18 5

-[ 45 ]-

SAME - DEUTZ FAHRSTARTER MOTOR & SPARES



1 02 230 01033 SMA-1033SM SAME - All Models 5500 2

2 7155 63P SOL-5563 Solenoid assy. 880 2

3 7151 542 ARM-542 Armature with bearing 2000 9




7 KT-02001C GB-2001C Gear Bracket Assy. (Gear Bkt, Needle Roller Bearing)

475 2

8 KT-02002I SCA-2002I Solenoid Cover Assy. Tightening Kit (Sole-noid Cover Assy., Cylinder Head Bolt (M5), Washer Spring Lock, O-Ring)

170 5


800 2


57 5



1850 2


435 10


265 10


67 5


50 5



55 5

19 KT-02010B SMMP-2010B Steel Parts Kit for Starter Assy. (Set Screw, Flange Nut -M6, Seal- Rear Bracket, Plain Washer -M6)

45 5

20 FG-324165031 SMMP-5031 Ball Bearing ( 6001-2Z )- Armature 60 5

21 FG-324592003 SMMP-2003 Needle Roller Bearing 110 5


-[ 46 ]-

GREAVES APESTARTER MOTOR & SPARESS. No. PAL Ref. No SPARK MINDA


1 02 210 01001S SMA-1001G Greaves engines - G430, GL430, G435 & GL435

4025 2

2 02 210 02022 ARM-2022 Armature Assy with 2-Ball Bearings 1375 5


4 02 210 02004 SMMP-C2004 Over Running Clutch Assy. 660 5

5 02 210 02006 BDA-2006G Stator With Brush Holder Assy. 1260 2

6 02 210 02002 BDA-2002G Stator Assy. ( without Brush Holder Assy.) 880 2

7 7150 870 SOL-0870 Solenoid Switch 725 2

8 7150 810 SCA-810 Solenoid Cover Assy. 160 5

9 KT-C1101 PS-C1101 Pinion Shaft with Lock Spring Kit (Pinion Shaft, Lock spring, Stop ring & Restoring spring)

260 2

10 KT-C1102 SMMP-C1102 Stop Ring Kit ( Lock spring, Stop ring & Restoring spring)

35 5

11 KT-C1103 CB-1103 Carbon Brush Assy. ( Carbon Brushes - 4nos & Brush Spring -4nos.)

250 10

12 KT-C1104 BH-1104 Brush Holder Assy Kit (Brush Holder Assy., Carbon Brushes -4nos. & Brush Spring -4nos.)

325 10

13 KT-C1105 SMMP-C1105 Shift Lever Assy Kit (Shift Lever, Ball Pin & Shooting Spring)

40 5

14 KT-C1106 SMMP-C1106 Hex Socket Head Screw with Tuflok for Solenoid Fixing -2nos. with Spring Lock Washer

33 5

15 KT-C1107A SMMP-C1107A Steel Parts Kit for Front Bracket Assy. 45 5

16 KT-C1108 SMMP-C1108 Steel Parts Kit for Starter Assy. (Set Screw, Hex Nut -M5, Washer Spring Lock Washer -M5)

30 5

17 FG-02210 04036 SMFB-4036 Front Bracket 520 2

18 FG-02210 04024 RB-4024 Rear Bracket 215 5

19 FG-02210 04020 GB-4020 Gear Bracket 350 2

20 FG-02210 03001 SMMP-3001 Ball Bearing ( 6002-2Z ) for Armature Assy. 70 5

21 FG-02210 03002 SMMP-3002 Ball Bearing ( 608-2Z ) for Armature Assy. 45 5

-[ 47 ]-

STANDARD TRACTORSSTARTER MOTOR & SPARES



1 02 230 01020 SMA-1020SD 2 Cyl. Tractors 5500 21.1 02 230 01019 SMA-1019SD All 3 & 4 Cyl.Tractors 5600 22 02 230 02033 SOL-2033 Solenoid Assy 880 23 02 225 02025 ARM-2025 Armature with Bearing (SMA-1020SD) 1926 9

3.1 7151 542 ARM-542 Armature with Bearing (SMA-1019SD) 2000 94 02 230 02009A

(IL)DRA-2009A Pinion Drive Assy. 1200 2

5 "FG-02230 04046 "


6 FG-02230 04090 RB-4090 Rear Bracket 150 57 KT-02001A GB-2001A Gear Bracket Assy

(Gear bkt., Needle Roller Bearing, Dewatering)

475 2


170 5

9 KT-02003A(IL) PS-2003A Pinion Shaft with lock spring kit (Pinion Shaft,Lock spring,Stop ring, Restoring spring)

800 2

10 KT-02004 SMMP-2004 Stop Ring Kit( Lock spring,Stop ring, Restroing spring)

57 5

11 7157 980 SMMP-0980 Over running Clutch Assembly 860 512 02 230 02152 BDA-2152 Body Assy./ Stator Assy.( with Carbon

Brush)1850 2

13 KT-02005 BH-2005 Brush Holder Assy Kit (Brush Holder Assy., Carbon Brushes (-Ve),Carbon Brushes (+Ve),Brush Spring)

435 10

14 KT-02006 CB-2006 Carbon Brush Assy. (Carbon Brushes (-Ve), Carbon Brushes (+Ve),Brush Spring)

265 10


67 5


50 5

17 KT-02008 A SMMP-2008A Steel Parts Kit for Front Bracket Assy. 70 518 KT-02009 SMMP-2009 Rubber & gasket Seal kit (O- Ring,Sealing


19 KT-02010A SMMP-2010A Steel Parts Kit for Starter Assy.Flange Nut M6),Plain Washer,Seal Rear Bkt

45 5

20 FG-324 165 031 SMMP-5031 Ball Bearing( 6001-2Z)- Armature 60 521 FG-324592003 SMMP-2003 Needle Roller Bearing 110 522 KT-02019 SMMP-2019 Field Coil 727 5

-[ 48 ]-



1 03 242 01014T ATR-1014 Standard Tractors- All models 3225 2



4 03 242 02001 ROT-2001 Rotor Assy. 990 2

5 03 242 02026 STA-2026 Stator Assy. 775 2

6 03 242 02022 COL-2022 Rear Bracket & Rectifier Assy. 860 5

7 KT-03010 ALMP-3010 Rear Bracket , Rectifier Assy.& Stator Assy. 1600 2





12 KT-03006A ALMP-3006A Pulley Assy Kit 168 2

13 KT-03007A ALMP-3007A Steel Part Kit for Pulley Tightening 65 2

14 03 242 40008 ALMP-40008 Fan 57 5


16 FG-324165 637P 6203-2RS Bearing 6203 2RS 131 5


18 FG-4336 087 AMLP-6087 Bushing 18 5

STANDARD TRACTORSALTERNATOR & SPARES

-[ 49 ]-(48)

TROUBLE SHOOTING CHART - STARTER MOTOR

TS STM POSSIBLE CAUSE ACTION NEEDED

STARTER MOTOR DOES NOTWORK

1) DEAD BATTERY

2) OXIDISED / DIRTY TERMINALS / LOSSE CONNECTION

3) FAULTING INGINITION SWITCH

1) CHARGE REPLACE BATTERY

2) CLEAN TERMINAL, TIGHTEN CONNECTION, APPLY GREASE

3) CHECK SWITCH - REPAIR/ REPLACE IF REQUIRED

STARTER CRANKS BUT THE ENGINE DOES NOT FIRE

1) WEAK BATTERY

2) BLOCKED FUSED LINES / AIR TRAPPED IN FUEL LINES

3) FAULTY STARTER MOTOR

1) CHECK BATTERY IF REPLACED NEW BATTERY REQUIRED

2) CHECK FLOW OF FUELS REMOVE BLOCKS AIR/LOCKS

3) CHECK THE BRUSHES, SPRING TENSION, ARMATURE

STARTER MOTORS WORKS BUT PINION DOES NOT ENGAGE

1) PINION STICKY ON SHAFT

2) DAMAGED SHIFT LAYER

1) CHECK THE DRIVE MOVEMENT ON THE SHAFT CHANGE PINION ASSEMBLY IF NOT FOUND OK

2) CHANGE THE SHIFT LEVER

STARTER MOTORS CONTINUES TO RUN AFTER SWITCH IS RELEASED

1) DAMAGED PINION OR RING GEAR TEETH

2) FAULTY IGNITION SWITCH

3) FAULTY SOLENDOID SWITCH

4) STICKY DRIVE ASSEMBLY

1) DAMAGED OF PINION / RING GEAR TEETH OR REPLACE

2) REPAIR / REPLACE IGINITION SWITCH

3) REPAIR / REPLACE SOLENOID SWITCH

4) STICKY DRIVE ASSEMBLY MOVEMENT ON SHAFT

STARTER MOTORS ENGAGES WITH RING GEAR BUT ENGINES DOES NOT CRANK

1) SLIPPAGE OF CLUTCH (PINION DRIVE ASSEMBLY)

2)DEFFECTIVE SLOENOID SWITCH 3) WEAK AND DEAD BATTERY

4) JAMMED ENGINE

1) CHANGE THE DRIVE ASSEMBLY

2) REPAIR / REPLACE SOLENOID SWITCH

3) REPLACE WITH FULLY CHARGED BATTERY

4) REPAIR THE ENGINE

PROBLEM

-[ 50 ]-(49)

TROUBLE SHOOTING CHART - ALTERNATOR

PROBLEM POSSIBLE CAUSE ACTION NEEDED

WARNING LAMP DOES NOT GLOW . NO OUTPUT FROM ALTERNATOR EVEN AND AFTER THE ENGINE HAS STARTED

1) FAULTY LAMP

2) LOOSE/WRONG CONNECTION OF ALTERNATOR CABLES

1) REPLACE THE LAMP

2) CORRECT THE CONNECTION

WARNING LAMP GLOW EVEN AFTER THE ENGINE HAS STARTED. ALTERNATOR DOES NOT CHARGE THE BATTERY

1) OXIDISED / DIRTY TERMINALS LOOSE CONNECTION

2) OPEN RECTIFIER

3) DEFECTIVE REGULATOR

1) CLEAN THE TERMINALS. TIGHTEEN CONNECTION

& APPLY GREASE 2) REPLACE DEFECTIVE

DIODES

3) REPLACE REGULATOR

BATTERY GETS DRAINED CHARGING CURRENT IS LESS THEN 10A EVEN WHEN THE BATTERY VOLTAGE IS LESS 11.5V

1) WEAK BATTERY

2) DEFECTIVE LEAKS DIODE

3) WORKNOUT BRUSHES SLIP RINGS

4) LOOSE BELT CAUSING SLIP

5) STICKY BEARING CAUSING SLIP

1) CHECK BATTERY ELECTORLYTE IF NECESSARY

2) CHECK THE RECTIFIER & DIODES

3) CHECK THE BRUSHES SPRING

4) ADJUST BELT TENSION

5) REPLACE BEARINGS

OUTPUT VOLTAGE IS LESS THAN 13.5V. BATTERY NEVER FULLY CHARGED

1) ONE OR MORE DIODES ARE LEAKY

2) DEFECTIVE REGULATOR

3) WINDING INSULATION HAS BECOME WEAK

1) CHECK THE RECTIFIER ASSEMBLY LEAKY DIODES

2) CHANGE THE REGULATOR

3) CHECK ROTOR AND STATOR INSULATION BY MEGGAR TEST RECTIFY WINDING DAMAGES

BATTERY ELECTROLAYTEBOILS DUE TO OVER CHARGING. OUTPUT VOLTAGE IS MORE THAN 14.5V

DEFECTIVE REGULATOR REPLACED REGULATOR AS IT IS AN INTEGRATED CIRCUIT MODULE

-[ 51 ]-

NOTES

-[ 52 ]-(51)

TERMS & Conditions: 1)This Price List cancels all our previous Price lists. The

2)Company reserve the right to increase or decrease the prices without any prior notice

3)Maximum Retail Prices are inclusive of all applicable duties, center and Local Taxes.

4)Disputes, if any shall be subject to Delhi Jurisdiction only.

Date post:	06-Feb-2018
Category:	Documents
Upload:	hathuy
View:	252 times
Download:	8 times

CONTENTS PAGE - mindaasl.commindaasl.com/uploads/5fec3cdb20ba46a3973b285e6daafbd1.pdf · CONTENTS...

Documents