CV301 Mod 2 Blending of Aggregates

BLENDING OF AGGREGATESWarning: If your mind hasnt yet blended with Gradation of Aggregates (posted on the instructors website) then youll probably struggle with this presentation. You should also have Assignment 1 Example at the ready.BLENDING OF AGGREGATESBLENDING OF AGGREGATESBLENDING OF AGGREGATES

What is asphalt concrete?Basically, its just aggregatecoated with asphalt cementand then compacted.There are 3 basic elements to the compacted mix1. Aggregate Particles2. Asphalt Cement3. Air VoidsNot all the asphalt cement ends up coating the aggregate particlessome is absorbed into the water-permeable voids within the aggregate particles.

VMAAre you a member?Of whatthe Virile Mens Association? Voluptuous Mamas of America?Voids in the Mineral Aggregate Volatile Mercenaries of Alberta? so whats it mean?Any help?Well, VMA is one of the most important properties of an asphalt paving mix.Firstly, heres a representation of a compacted paving mix.Theres stone, and sand particles all coated with asphalt cement and theres a few air voids (the white spaces).If we removed all the asphalt cement but the aggregate stayed put it would look like this:The space occupied by the asphalt cement and air voids (not including the asphalt cement absorbed) is voids in the mineral aggregate.This diagram shows the mix without the aggregatetheres just the asphalt cement and air voids.Vmb is the Bulk Volume of the MixIn mathematical termsVvma = Va + VbeVvma is the Volume of Voids in the Mineral AggregateVa is the Volume of Air Voids in the MixVbe is the Effective Volume of Asphalt Cement in the Mix

VMA and Dense Graded AggregateOnce the mix has been compacted to its densest state then theres nowhere for particles to go when subjected to traffic.Densely graded mixes are going to offer the greatest resistance to loads because they minimize the void space and therefore the movement paths within the mix.where pi = total % passing sieve size i di = width of opening of sieve size i D = largest size (sieve opening) in gradationMathematically, Fuller Grading Curves offer the maximum density and minimum voids:

VMA and Dense Graded AggregateWhen plotted they look like this:These can be used to set grading limits (specs) as with the red and green dashed curves.Notice that the High Spec is above the Fuller Curve below the #8 sieveThis allows for a reduction in the number of finer sizes which will in turn allow an increase in voids But why would we want to increase the voids?The goal is to blend the stock aggregates to produce a blend that falls between the two limits

Chart1

111000000000011000000000000001111111111

0.70.80.709499704410010010010010010010010010010010.81001001001001001001001001001001001001001000.70412947630.70710678120.70710678120.70710678120.86579807070.81542716780.87407093530.81649658090.86602540380.8908708064

0.50.750.502535941910.750.49957965520.49789472750.50.50.61221168690.70599526870.71274118720.71367593020.70710678120.7715167498

0.40.50.35415212670.70.50.35385036960.3532561620.35206473810.35355339060.43289903530.4992140420.61708994480.58195074250.61806148560.6299407883

0.290.350.50.350.24936895150.25020999580.24978982760.24894736370.30610584350.35299763430.43634848460.50385183010.50398412670.5506129341

0.230.270.40.270.17633047660.17692518480.1766280810.21553814720.2496070210.30854497240.35627704580.43634848460.4489847454

0.160.180.290.180.12468447570.12510499790.15292425170.1757556610.21817424230.2519259150.30854497240.3887301263

0.10.130.230.130.08816523830.10831566580.12469858950.1536229150.17813852290.21817424230.2748737084

0.080.160.080.07633329320.08832353660.10899541270.12543258480.15427248620.1943650632

0.040.10.040.06224424110.07720103630.08899438180.10862780490.1374368542

0.0544058820.06303438220.07707139550.0967733402

0.04442221670.05458937630.0686606562

0.03847076810.0486320816

0.0342724842

0.074

#100

#50

#30

#16

#8

#4

"

"

"

1"

1"

2"

2"

High Spec

Low Spec

No. 30 Fuller

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

1"

1"

2"

2"

#16 Fuller

#8 Fuller

#4 Fuller

'3/8" Fuller

'1/2" Fuller

'3/4" Fuller

'1" Fuller

'1-1/2" Fuller

'2" Fuller

'2-1/2" Fuller

Sieve Opening (mm)

% Passing

Fuller Grading Curves

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

25

37.5

50

63

Sheet1

CV605 Pavement ManagementTo make 30 kg of blended aggregate, first weigh out 16.140 kg of coarse aggregate and then 12.420 kg of fine aggregate.0.0740.0740Sieve SizeSpec.Sieve Analysis Results (% Passing)cfmcfmcfmcfmcfmcfmcfmcfmcfm

Marshall Method of Asphalt Mix Design: Aggregate Blends0.074#200100SizeOpeningMidpointCAFAMF2345678910

Sieve on the Gilson Shaker with the No. 4 and No. 8 screens and the pan in two half batches.0.1490.1490Designation(mm)% Passing10000000000000000000000000001

0.149#10010013/4"19.1100%100.0%100.0%100.0%20000000000000000000000002

Sieve SizeSpec LimitsSieve Analysis Results (% Passing)Proportioned % PassingBlendedOK?Into each specimen pan, place the following weights of mineral filler, "Pan stock", "#8 stock" and "#4 stock" from each sieved stockpile (in the order specified):0.2970.297021/2"12.790%100.0%100.0%100.0%3-21.5764285714-3.12595238125.7023809524-4.2110810811-0.75795045055.9690315315-1.1749763593-0.34393617022.51891252960.5469201229-0.10913210450.56221198160.8411175962-0.06901426720.2278966710.9228966346-0.05786258010.13496594550.9633163513-0.05235080060.08903444933

SizeOpeningLowHighCAFAMF53.841.44.8Aggregate0.297#5010033/8"9.5288%88.0%100.0%100.0%40.63704237472.5004541128-2.13749648750.55913678771.7752093179-1.33434610550.45132505510.7715598898-0.22288494490.42365133850.51393755960.06241110190.42394522680.51667344760.05938132550.42555445540.53165420410.04279134054

Designation(mm)% Passing% PassingCAFAMF% Passing0.590.5904#44.7660%9.7%97.9%100.0%50.57015159861.2184407052-0.78859230380.55496380250.5104001134-0.06536391590.55153824860.35070405630.09775769510.55200974620.3726848220.07530543190.55249042980.39509383720.0524157335

3/4"19.1100%100%100.0%100.0%100.0%53.8%41.4%4.8%100.0%J0.59#301005#82.3843%2.1%92.6%100.0%60.6203391170.34539664210.03426424090.61906473280.26171208190.11922318530.61958377850.29579608290.08462013860.61998435830.32210082650.05791481516

1/2"12.780%100%100.0%100.0%100.0%53.8%41.4%4.8%100.0%JMass for each Specimen Tin (g)1.191.1906#161.1934%1.5%85.9%100.0%70.59771484770.26493990640.13734524580.59839313390.31271063340.08889623270.59881037420.34209626980.05909335617

3/8"9.5275%100%88.0%100.0%100.0%47.3%41.4%4.8%93.5%JStock1.19#161007#300.5924%1.4%56.6%100.0%80.19981991740.74332906380.05685101880.20025214220.76450807850.03523977938

#44.7650%70%9.7%97.9%100.0%5.2%40.5%4.8%50.5%JSize2.382.3808#500.29718%1.3%22.2%99.3%9-0.04963344461.03286797920.01676546539

#82.3835%50%2.1%92.6%100.0%1.1%38.3%4.8%44.3%J2.38#81009#1000.14912%1.2%11.5%94.7%1010

#161.1927%40%1.5%85.9%100.0%0.8%35.6%4.8%41.2%L#4593.44.764.76010#2000.0747%1.1%6.3%75.0%

#300.5918%29%1.4%56.6%100.0%0.8%23.4%4.8%29.0%J#875.44.76#41000.42365133850.51393755960.062411101948

#500.29713%23%1.3%22.2%99.3%0.7%9.2%4.8%14.7%JPan473.69.529.5200.42394522680.51667344760.059381325549

#1000.1498%16%1.2%11.5%94.7%0.6%4.8%4.5%10.0%JMF57.69.523/8"1000.42555445540.53165420410.0427913405410

#2000.0744%10%1.1%6.3%75.0%0.6%2.6%3.6%6.8%JSpecimen Aggregate Mass:1200.012.712.700.55153824860.35070405630.097757695158

12.71/2"1000.55200974620.3726848220.075305431959

19.119.100.55249042980.39509383720.052415733510

19.13/4"1000.6203391170.34539664210.034264240967

252500.61906473280.26171208190.119223185368

251"1000.61958377850.29579608290.084620138669

37.537.500.61998435830.32210082650.0579148151610

37.51"1000.59771484770.26493990640.137345245878

505000.59839313390.31271063340.088896232779

502"1000.59881037420.34209626980.0590933561710

636300.19981991740.74332906380.056851018889

632"1000.20025214220.76450807850.0352397793810

0.50687678980.42222250080.0709007094

1

0.61055576320.30639320620.0830510306

1

Sieve SizePercent Passing

SizeOpeningNominal Maximum Particle Size (mm)

Designation(mm)0.591.192.384.769.5212.719.12537.55063

2"63100.0%

2"50100.0%89.1%

1"37.5100.0%86.6%77.2%

1"25100.0%81.6%70.7%63.0%

3/4"19.1100.0%87.4%71.4%61.8%55.1%

1/2"12.7100.0%81.5%71.3%58.2%50.4%44.9%

3/8"9.52100.0%86.6%70.6%61.7%50.4%43.6%38.9%

#44.76100.0%70.7%61.2%49.9%43.6%35.6%30.9%27.5%

#82.38100.0%70.7%50.0%43.3%35.3%30.9%25.2%21.8%19.4%

#161.19100.0%70.7%50.0%35.4%30.6%25.0%21.8%17.8%15.4%13.7%

#300.59100.0%70.4%49.8%35.2%24.9%21.6%17.6%15.4%12.5%10.9%9.7%

#500.29770.9%50.0%35.3%25.0%17.7%15.3%12.5%10.9%8.9%7.7%6.9%

#1000.14950.3%35.4%25.0%17.7%12.5%10.8%8.8%7.7%6.3%5.5%4.9%

#2000.07435.4%24.9%17.6%12.5%8.8%7.6%6.2%5.4%4.4%3.8%3.4%

Cu36

Cz2.25

Sheet1

0.074

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

Sieve Opening (mm)

% Passing

Blended Aggregates

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

Sheet2

0.074

#100

#50

#30

#16

#8

#4

"

"

"

1"

1"

2"

2"

High Spec

Low Spec

No. 30 Fuller

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

1"

1"

2"

2"

#16 Fuller

#8 Fuller

#4 Fuller

'3/8" Fuller

'1/2" Fuller

'3/4" Fuller

'1" Fuller

'1-1/2" Fuller

'2" Fuller

'2-1/2" Fuller

Sieve Opening (mm)

% Passing


#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

25

37.5

50

63

Sheet3

VMA and Dense Graded AggregateThis is a compromise between stability (lower with higher voids) and durability.Experience has shown that asphalt mixes need to have between 3% and 5% air voidsIf the voids are too low, then asphalt cement can bleed to the surface in hot weather.Its analogous to Portland Cement Concrete and air entraining to match exposure to the environment.So minimum VMA values are specified for different Nominal Maximum Particle Sizes

Blending Stock AggregatesNormally, aggregate stocks come from different sources:1. stone comes from crushed bedrock,2. sand comes from natural deposits,3. mineral filler comes from the bottom of the crusher (dust)There are two basic approaches:Simultaneous equations (used on Assignment 1)Trial and Error (spreadsheet, used for lab)

Assignment 1 ExampleTwo questions using simultaneous equations.1. Produce a blend of the given aggregates that results in 28.0% passing the 0.6 mm sieve.The proportion of dust is set at 2 %.The condition given is for the 0.6 mm sieve.Let C be the fraction of Cyclone A Crushed and N be the fraction of Newmarket Sand.When we apply the proportions to find the percent passing the 0.6 mm sieve for the blend, we get:0.005C + 0.51N + 1.00(.02) = 0.281The second condition is that all the proportions must sum to 1:or0.005C + 0.51N = 0.26C + N = 0.982Multiply equation 2 by 0.005 then subtract 2 from 10.005C + 0.005N = 0.0049(0.51 - 0.005)N = 0.26 - 0.0049(0.505)N = 0.2551N = 0.505149 50.51%

Therefore, C = 100% - 50.51% - 2% = 47.49%C + N + 0.02 = 1.0

MATERIAL% Used25.419.016.012.79.54.752.361.180.6000.3000.1500.075Cyclone A Crushed100.0%100.0%100.0%90.0%59.0%16.0%3.2%2.0%0.5%0.0%0.0%0.0%Newmarket Sand100.0%100.0%100.0%100.0%100.0%96.0%82.0%73.0%51.0%36.0%21.0%9.2%DFC DUST2.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%

50.51%

47.49%

Assignment 1 Example: Q 1 ContdNow for the blended gradationBefore we start to crank off the blend, lets check the proportions by finding P0.6This is the percent passing the 0.6 mm sieve given for condition 1.Now we do the same for all the other sizesP0.6 = 0.4749x0.5% + 0.5051x51.0% + 0.02x100.0% = 27.9976%P0.6 28.0%P25.4 = 0.4749x100.0%+0.5051x100.0%+0.02x100.0% = 100.0%P19.0 = 0.4749x100.0%+0.5051x100.0%+0.02x100.0% = 100.0%P16.0 = 0.4749x100.0%+0.5051x100.0%+0.02x100.0% = 100.0%P12.7 = 0.4749x90.0%+0.5051x100.0%+0.02x100.0% = 95.251%P12.7 95.3%P9.5 = 0.4749x59.0% + 0.5051x100.0% + 0.02x100.0% = 80.529%P9.5 80.5%P4.75 = 0.4749x16.0% + 0.5051x96.0% + 0.02x100.0% = 58.088%P4.75 58.1%P2.36 = 0.4749x3.2% + 0.5051x82.0% + 0.02x100.0% = 44.938%P2.36 44.9%P1.18 = 0.4749x2.0% + 0.5051x73.0% + 0.02x100.0% = 39.822%P1.18 39.8%P0.3 = 0.4749x0.0% + 0.5051x36.0% + 0.02x100.0% = 20.184%P0.3 20.2%P0.075 = 0.4749x0.0% + 0.5051x9.2% + 0.02x100.0% = 6.647%P0.075 6.6%Thats the one all right! So were good to go.P0.150 = 0.4749x0.0% + 0.5051x21.0% + 0.02x100.0% = 12.607%P0.150 12.6%

SIEVE SIZE (mm):25.419.016.012.79.54.752.361.180.6000.3000.1500.075BLEND:SPECIFICATIONLow:100.0%100.0%100.0%80.0%70.0%50.0%35.0%25.0%18.0%13.0%8.0%4.0%High:100.0%100.0%100.0%100.0%90.0%70.0%50.0%40.0%29.0%23.0%16.0%10.0%TARGET:100.0%100.0%100.0%90.0%80.0%60.0%42.5%32.5%23.5%18.0%12.0%7.0%

MATERIAL% Used25.419.016.012.79.54.752.361.180.6000.3000.1500.075Cyclone A Crushed47.49%100.0%100.0%100.0%90.0%59.0%16.0%3.2%2.0%0.5%0.0%0.0%0.0%Newmarket Sand50.51%100.0%100.0%100.0%100.0%100.0%96.0%82.0%73.0%51.0%36.0%21.0%9.2%DFC DUST2.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%

100.0%

100.0%

100.0%

95.3%

80.5%

58.1%

44.9%

39.8%

28.0%

20.2%

6.6%

12.6

Assignment 1 Example: Q1 FinaleThe table above is used to weigh out and blend the sieved stock for individual 1210 g specimens.Any sizes with 100% passing will retain none of the material. Hence 0 g are recorded for all these sizes.These values represent the cumulative mass (the scale reading) after adding the required mass of each stock sieve sizeFirst, how much Cyclone A will be used?For a specimen with 1210 g of aggregate we need 47.49% of 1210 g of all Cyclone A sizes = 574.63 gNow, how much Newmarket Sand will be used?For a specimen with 1210 g of aggregate we need 50.51% of 1210 g of all Newmarket Sand sizes = 611.17 gAnd, how much DFC Dust will be used?For a specimen with 1210 g of aggregate we need 2% of 1210 g for DFC Dust = 24.2 gNow for the other Cyclone A masses:The 12.7 mm sieve will retain 100 90 or 10% of the mass of Cyclone A used: 0.10 x 574.63 = 57.5 gThe 9.5 mm sieve will retain 100 59 or 41% of the mass of Cyclone A used: 0.41 x 574.63 = 235.6 gThe 4.75 mm sieve will retain 100 16 or 84% of the mass of Cyclone A used: 0.84 x 574.63 = 482.7 gThe 2.36 mm sieve will retain 100 3.2 or 96.8% of the mass of Cyclone A used: 0.968 x 574.63 = 556.2 gNow for the other Newmarket Sand masses:The 4.75 mm sieve will retain 100 96 or 4% of the mass of Newmarket Sand used: 0.04 x 611.17 = 24.4 gThe 2.36 mm sieve will retain 100 82 or 18% of the mass of Newmarket Sand used: 0.18 x 611.17 = 110.0 gWe can check these numbers by summing over each size and calculating the % passing which should agree with the blend gradationP12.7 = 100%x(1.00 57.5/1210) = 95.25% (95.3%)P9.5 = 100%x(1.00 235.6/1210) = 80.5% (80.5%)P4.75 = 100%x(1.00 507.1/1210) = 58.1% (58.1%)P2.36 = 100%x(1.00 666.2/1210) = 44.9% (44.9%)The last column should (and does) sum to the total specimen mass (1210 g)The final step(s) is to determine the mass of asphalt cement required for the 6 asphalt contents listed.Since were using % of total mix, we have to use a bit of algebra. (I wont tell anyone if you dont.)Let the Mass of AC required = Mb and Pb = %ACApplying this formula to each %AC:P16.0 = 100%x(1.00 0/1210) = 100.0% (100.0%)P19.0 = 100%x(1.00 0/1210) = 100.0% (100.0%)

MATERIAL% Used25.419.016.012.79.54.752.361.180.6000.3000.1500.075Cyclone A Crushed47.49%100.0%100.0%100.0%90.0%59.0%16.0%3.2%2.0%0.5%0.0%0.0%0.0%Newmarket Sand50.51%100.0%100.0%100.0%100.0%100.0%96.0%82.0%73.0%51.0%36.0%21.0%9.2%DFC DUST2.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%

CUMULATIVE WEIGHT19.016.012.79.54.752.36Passing 2.36Cyclone A Crushed47.49%(% USED)Newmarket Sand50.51%(% USED)DFC DUST2.0 (% USED)Total Specimen Mass (g):1210

% ACWeight (g)4.3%4.8%5.3%5.8%6.3%6.8%

574.63

611.17

24.2

0

0

0

0

0

0

0

0

0

0

0

0

57.5

235.6

482.7

556.2

24.4

110.0

507.1

666.2

1210

54.4

61.0

67.7

74.5

81.4

88.3

57.5

235.6

0

0

Assignment 1 Example : Q 22. Produce a blend of the given aggregates that results in 74.0% passing the 9.5 mm sieve and 61.0% passing the 2.36 mm sieve.The conditions given are for the 9.5 mm & 2.36 mm sieves.Let G be the fraction of Gumshoe Gold, S be the fraction of Saltwater Sludge and H be the fraction of Homers Donut Crumbs.Applying the first condition for P9.5:1The third condition is that all the proportions must sum to 1:0.34G + 0.89S + H = 0.742G + S + H = 1.00G = 0.392098555 39.21%

and H = 0.596856414% 59.69%

0.02G + 0.48S + H = 0.613S = 0.011045029 1.10%

The second condition for P2.36:Using the Sharp EL546W Calculator, Mode 21:for instructions, visit http://math.mohawkcollege.ca/calc.asp

MATERIAL% Used25.419.016.012.79.54.752.361.180.6000.3000.1500.075Gumshoe Gold100.0%100.0%98.0%79.0%34.0%9.0%2.0%0.0%0.0%0.0%0.0%0.0%Saltwater Sludge100.0%100.0%100.0%98.0%89.0%67.0%48.0%21.0%8.0%1.5%1.0%0.0%H's Donut Crumbs100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%53.0%26.0%5.0%2.0%

1.10%

39.21%

59.69%

Assignment 1 Example: Q 2 ContdNow for the blended gradationBefore we start to crank off the blend, lets check the proportions by finding P9.5 and P2.36Now we do the same for all the other sizesP0.6 = 0.3921x0.0% + 0.0110x8.0% + 0.5969x53.0% = 31.7237%P0.6 31.7%P25.4 = 0.3921x100% + 0.0110x100.0% + 0.5969x100% = 100%P19.0 = 0.3921x100% + 0.0110x100% + 0.5969x100% = 100%P16.0 = 0.3921x98.0% + 0.0110x100% + 0.57969x100% = 99.2158%P16.0 99.2%P12.7 = 0.3921x79.0% + 0.0110x98.0% + 0.5969x100 = 91.7439%P12.7 91.7%P9.5 = 0.3921x34.0% + 0.0110x89.0% + 0.5969x100.0% = 74.0004%P9.5 74.0%P4.75 = 0.3921x9.0% + 0.0110x67.0% + 0.5969x100.0% = 63.9559%P4.75 64.0%P2.36 = 0.3921x2.0% + 0.0110x48.0% + 0.5969x100.0% = 61.0022%P2.36 61.0%P1.18 = 0.3921x0.0% + 0.0110x21.0% + 0.5969x100% = 59.921%P1.18 59.9%P0.3 = 0.3921x0.0% + 0.0110x1.5% + 0.5969x26.0% = 15.5359%P0.3 15.5%P0.075 = 0.3921x0.0% + 0.0110x0.0% + 0.5969x2.0% = 1.1938%P0.075 1.2%Got em both! So were good to go.P0.150 = 0.3921x0.0% + 0.0110x1.0% + 0.5969x5.0% = 2.9955%P0.150 3.0%

SIEVE SIZE (mm):25.419.016.012.79.54.752.361.180.6000.3000.1500.075BLEND:SPECIFICATIONLow:100.0%100.0%90.0%75.0%65.0%55.0%40.0%28.0%15.0%5.0%2.0%0.0%High:100.0%100.0%100.0%95.0%85.0%75.0%70.0%60.0%35.0%23.0%12.0%5.0%TARGET:100.0%100.0%95.0%85.0%75.0%65.0%55.0%44.0%25.0%14.0%7.0%2.5%

MATERIAL% Used25.419.016.012.79.54.752.361.180.6000.3000.1500.075Gumshoe Gold39.21%100.0%100.0%98.0%79.0%34.0%9.0%2.0%0.0%0.0%0.0%0.0%0.0%Saltwater Sludge1.10%100.0%100.0%100.0%98.0%89.0%67.0%48.0%21.0%8.0%1.5%1.0%0.0%H's Donut Crumbs59.69%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%53.0%26.0%5.0%2.0%

100.0%

100.0%

99.2%

91.7%

74.0%

64.0%

61.0%

59.9%

31.7%

15.5%

1.2%

3.0

Assignment 1 Example: Q2 FinaleThe table above is used to weigh out and blend the sieved stock for individual 1200 g specimens.Any sizes with 100% passing will retain none of the material. Hence 0 g are recorded for all these sizes.These values represent the cumulative mass (the scale reading) after adding the required mass of each stock sieve sizeFirst, how much Gumshoe Gold will be used?For a specimen with 1200 g of aggregate we need 39.21% of 1200 g of all Gumshoe Gold sizes = 470.5 gNow, how much Saltwater Sludge will be used?For a specimen with 1200 g of aggregate we need 1.10% of 1200 g of all Saltwater Sludge sizes = 13.2 gNow for the other Gumshoe Gold masses:The 12.7 mm sieve will retain 100 79 or 21% of the mass of Gumshoe Gold used: 0.21 x 470.5 = 98.8 gThe 9.5 mm sieve will retain 100 34 or 66% of the mass of Gumshoe Gold used: 0.66 x 470.5 = 310.5 gThe 4.75 mm sieve will retain 100 9 or 91% of the mass of Gumshoe Gold used: 0.91 x 470.5 = 428.2 gThe 2.36 mm sieve will retain 100 2.0 or 98.0% of the mass of Gumshoe Gold used: 0.98 x 470.5 = 461.1 gNow for the other Saltwater Sludge masses:The 4.75 mm sieve will retain 100 67 or 33% of the mass of Saltwater Sludge used: 0.33 x 13.2 = 4.4 gThe 2.36 mm sieve will retain 100 48 or 52% of the mass of Saltwater Sludge used: 0.52 x 13.2 = 6.9 gWe can check these numbers by summing over each size and calculating the % passing which should agree with the blend gradationP12.7 = 100%x(1.00 98.8/1200) = 91.8% (91.8%)P9.5 = 100%x(1.00 312.0/1200) = 74.0% (74.0%)P4.75 = 100%x(1.00 432.6/1200) = 64.0% (64.0%)P2.36 = 100%x(1.00 468.0/1200) = 61.0% (61.0%)The last column should (and does) sum to the total specimen mass (1200 g)The final step(s) is to determine the mass of asphalt cement required for the 6 asphalt contents listed.Since were using % of total mix, we have to use a bit of algebra. (I wont tell anyone if you dont.)Let the Mass of AC required = Mb and Pb = %ACApplying this formula to each %AC:How much Homers Donut Crumbs will be used?P16.0 = 100%x(1.00 9.4/1200) = 99.2% (99.2%)P19.0 = 100%x(1.00 0.0/1200) = 100.0% (100.0%)For a specimen with 1200 g of aggregate we need 59.69% of 1200 g of all Homers Donut Crumb sizes = 716.3 gThe 9.5 mm sieve will retain 100 89 or 11% of the mass of Saltwater Sludge used: 0.11 x 13.2 = 1.5 gThe 16.0 mm sieve will retain 100 98 or 2% of the mass of Gumshoe Gold used: 0.02 x 470.5 = 9.4 gThe 12.7 mm sieve will retain 100 98 or 2% of the mass of Saltwater Sludge used: 0.02 x 13.2 = 0.3 g

MATERIAL% Used25.419.016.012.79.54.752.361.180.6000.3000.1500.075Gumshoe Gold39.21%100.0%100.0%98.0%79.0%34.0%9.0%2.0%0.0%0.0%0.0%0.0%0.0%Saltwater Sludge1.10%100.0%100.0%100.0%98.0%89.0%67.0%48.0%21.0%8.0%1.5%1.0%0.0%H's Donut Crumbs59.69%100.0%100.0%100.0%100.0%100.0%100.0%100.0%100.0%53.0%26.0%5.0%2.0%

CUMULATIVE WEIGHT19.016.012.79.54.752.36Passing 2.36Gumshoe Gold 39.21%(% USED)Saltwater Sludge1.10%(% USED)Homer's Donut Crumbs 59.69%(% USED)Total Specimen Mass (g):1200

% ACWeight (g)5.0%5.5%6.0%6.5%7.0%7.5%

470.5

13.2

716.3

0

9.4

0

0

0.3

1.5

0

0

0

0

0

0

98.8

310.5

428.2

461.1

4.4

6.9

63.2

69.8

76.6

83.4

90.3

97.3

0

9.4

98. 8

312.0

432.6

468.0

1200

Trial and Error Before the third lab, each group must perform its blending calculations. The first priority is making sure your sieve results are reasonable. If youve mixed up any sizes, even if you have a sieving error of 0%, youll still be using garbage for data.The instructor will provide you with a set that is free of calculation errors, based on the data you submitted after you submit the report for the first lab.

Trial and ErrorOnce you have a decent set of data, start an Excel spreadsheet using the following format:This section is for your sieve analysis results.The numbers shown are for illustration only (they werent that great)This section is for the sieve sizes and specs.These are the trial proportions for CA (PCA) & FA (PFA).The stock proportions are found by multiplying each sieve result by the trial proportion.Eg.: 4.1% = 7.8% x 0.520Eg.: 44.3% = 96.3% x 0.460Eg.: 2.0% = 100% x 0.020The gradation of the blended aggregate is found by adding the proportions of the materials:Eg.: 50.4% = 4.1% + 44.3% + 2.0%The last column shows the percent error if the blend percent passing is outside the spec rangeWhere does the 2.7% come from?The error in P3/8 is 92.7% - 90% = 2.7%The PMF is calculated (100 PCA PFA)

Sieve SizeSpec LimitsSize DesignationOpening (mm)Lower LimitUpper Limit3/4"19.1100%100%1/2"12.798%100%3/8"9.5275%90%#44.7650%60%#82.3836%60%#161.1925%58%#300.5916%45%#500.2977%26%#1000.1493%10%#2000.0740%5%

Sieve Analysis ResultsCAFAMF100.0%100.0%100.0%100.0%100.0%100.0%86.0%100.0%100.0%7.8%96.3%100.0%1.1%88.9%100.0%0.8%80.7%99.9%0.5%61.1%99.6%0.4%30.4%98.3%0.4%11.4%88.2%0.4%5.4%57.5%

Stock ProportionsBlended Aggregate52.0 46.0 2.0 CAFAMF52.0%46.0%2.0%100.0%0.00%52.0%46.0%2.0%100.0%0.00%44.7%46.0%2.0%92.7%2.70%4.1%44.3%2.0%50.4%0.00%0.6%40.9%2.0%43.5%0.00%0.4%37.1%2.0%39.5%0.00%0.3%28.1%2.0%30.4%0.00%0.2%14.0%2.0%16.2%0.00%0.2%5.2%1.8%7.2%0.00%0.2%2.5%1.2%3.8%0.00%

Percent Passing

% Out of SpecTotal2.7%

Trial and ErrorOf course a grading plot makes the numbers easier to understand:What would it look like before specifying PCA and PFA?



Stock ProportionsBlended Aggregate52.0 46.0 2.0 CAFAMF52.0%46.0%2.0%100.0%0.00%52.0%46.0%2.0%100.0%0.00%44.7%46.0%2.0%92.7%2.70%4.1%44.3%2.0%50.4%0.00%0.6%40.9%2.0%43.5%0.00%0.4%37.1%2.0%39.5%0.00%0.3%28.1%2.0%30.4%0.00%0.2%14.0%2.0%16.2%0.00%0.2%5.2%1.8%7.2%0.00%0.2%2.5%1.2%3.8%0.00%

Percent Passing

% Out of SpecTotal2.7%

Chart2

0.9110000000000

0.60.981100100100100100100100100100100

0.60.750.927

0.580.50.504

0.450.360.435

0.260.250.395

0.10.160.304

0.050.070.162

0.030.072

00.038

0.074

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

Sieve Opening (mm)

% Passing

Blended Aggregates

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

Example

CV301 MATERIALS 2To make 32 kg of blended aggregate, first weigh out 16.640 kg of coarse aggregate and then 14.720 kg of fine aggregate.COURSE0.0740.0740Sieve SizeSpec.Sieve Analysis Results (% Passing)cfmcfmcfmcfmcfmcfmcfmcfmcfm



Percent Passing2.70%0.149#10010013/4"19.1100%100.0%100.0%100.0%20000000000000000000000002

Sieve SizeSpec LimitsSieve Analysis ResultsStock ProportionsBlended Aggregate% Out of SpecInto each specimen pan, place the following weights of mineral filler, "Pan stock", "#8 stock" and "#4 stock" from each sieved stockpile (in the order specified):0.2970.297021/2"12.799%100.0%100.0%100.0%3-14.8633783784-2.873108108118.7364864865-4.0843243243-1.11837837846.2027027027-1.467734375-0.6924218753.160156250.2414545455-0.41418181821.17272727270.951089838-0.29865979380.34756995581.1508984375-0.26613281250.1152343751.1947024952-0.25900191940.06429942423

Size DesignationOpening (mm)Lower LimitUpper LimitCAFAMF52.046.02.00.297#5010033/8"9.5283%86.0%100.0%100.0%40.46589673860.52423238880.00987087260.47607677090.6445655911-0.1206423620.47169802360.5928065522-0.06450457580.466549630.53194989950.00150047050.46642825990.5305152430.00305649710.46751845280.5434018821-0.01092033494

CAFAMF0.590.5904#44.7655%7.8%96.3%100.0%50.46822525380.7493946342-0.21761988810.46667702020.6101943512-0.07687137140.46581857580.53301239880.00116902540.46579873880.53122887360.00297238760.46595343880.5451378051-0.01109124385

3/4"19.1100%100%100.0%100.0%100.0%52.0%46.0%2.0%100.0%0.00%0.59#301005#82.3848%1.1%88.9%100.0%60.49093992670.5453556453-0.03629557210.49049190450.49602342480.01348467070.49055297920.50274842230.00669859850.49069229450.5180885867-0.00878088126

1/2"12.798%100%100.0%100.0%100.0%52.0%46.0%2.0%100.0%0.00%Mass for each Specimen Tin (g)1.191.1906#161.1942%0.8%80.7%99.9%70.50472042750.46971651620.02556305620.50486612360.48575927520.00937460110.50501952590.5026505722-0.00767009817

3/8"9.5275%90%86.0%100.0%100.0%44.7%46.0%2.0%92.7%2.70%Stock1.19#161007#300.5931%0.5%61.1%99.6%80.46325376230.53295714260.00378909510.46363370110.5506695273-0.01430322848

#44.7650%60%7.8%96.3%100.0%4.1%44.3%2.0%50.4%0.00%Size2.382.3808#500.29717%0.4%30.4%98.3%90.4502287390.588903995-0.0391327349

#82.3836%60%1.1%88.9%100.0%0.6%40.9%2.0%43.5%0.00%2.38#81009#1000.1497%0.4%11.4%88.2%1010

#161.1925%58%0.8%80.7%99.9%0.4%37.1%2.0%39.5%0.00%#4595.2fraction retained on #4 x 1200 g4.764.76010#2000.0743%0.4%5.4%57.5%

#300.5916%45%0.5%61.1%99.6%0.3%28.1%2.0%30.4%0.00%#882.8fraction retained on #8 x 1200 g4.76#4100CourseTitle0.42365133850.51393755960.062411101948

#500.2977%26%0.4%30.4%98.3%0.2%14.0%2.0%16.2%0.00%Pan498.0fraction retained on #8 x 1200 g9.529.5201CV301 MATERIALS 20.42394522680.51667344760.059381325549

#1000.1493%10%0.4%11.4%88.2%0.2%5.2%1.8%7.2%0.00%MF24.0proportion of MF x 1200 g9.523/8"1002EA448 HIGHWAY MATERIALS0.42555445540.53165420410.0427913405410

#2000.0740%5%0.4%5.4%57.5%0.2%2.5%1.2%3.8%0.00%Specimen Aggregate Mass:1200.012.712.700.55153824860.35070405630.097757695158

12.71/2"1000.55200974620.3726848220.075305431959

19.119.100.55249042980.39509383720.052415733510

19.13/4"1000.6203391170.34539664210.034264240967

Size of Batch:32kg252500.61906473280.26171208190.119223185368

251"1000.61958377850.29579608290.084620138669

37.537.500.61998435830.32210082650.0579148151610

37.51"1000.59771484770.26493990640.137345245878

505000.59839313390.31271063340.088896232779

502"1000.59881037420.34209626980.0590933561710

636300.19981991740.74332906380.056851018889

632"1000.20025214220.76450807850.0352397793810

0.50687678980.42222250080.0709007094

1

0.61055576320.30639320620.0830510306

1



Designation(mm)0.591.192.384.769.5212.719.12537.55063

2"63100.0%

2"50100.0%89.1%

1"37.5100.0%86.6%77.2%

1"25100.0%81.6%70.7%63.0%

3/4"19.1100.0%87.4%71.4%61.8%55.1%

1/2"12.7100.0%81.5%71.3%58.2%50.4%44.9%

3/8"9.52100.0%86.6%70.6%61.7%50.4%43.6%38.9%

#44.76100.0%70.7%61.2%49.9%43.6%35.6%30.9%27.5%

#82.38100.0%70.7%50.0%43.3%35.3%30.9%25.2%21.8%19.4%

#161.19100.0%70.7%50.0%35.4%30.6%25.0%21.8%17.8%15.4%13.7%

#300.59100.0%70.4%49.8%35.2%24.9%21.6%17.6%15.4%12.5%10.9%9.7%

#500.29770.9%50.0%35.3%25.0%17.7%15.3%12.5%10.9%8.9%7.7%6.9%

#1000.14950.3%35.4%25.0%17.7%12.5%10.8%8.8%7.7%6.3%5.5%4.9%

#2000.07435.4%24.9%17.6%12.5%8.8%7.6%6.2%5.4%4.4%3.8%3.4%

Cu36

Cz2.25

Example

0.074

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

Sieve Opening (mm)

% Passing

Blended Aggregates

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

Data

0.074

#100

#50

#30

#16

#8

#4

"

"

"

1"

1"

2"

2"

High Spec

Low Spec

No. 30 Fuller

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

1"

1"

2"

2"

#16 Fuller

#8 Fuller

#4 Fuller

'3/8" Fuller

'1/2" Fuller

'3/4" Fuller

'1" Fuller

'1-1/2" Fuller

'2" Fuller

'2-1/2" Fuller

Sieve Opening (mm)

% Passing


19.1

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

25

37.5

50

63

Blend

ID # DEFINITIONID #CLASSGROUP #C O A R S E A G G R E G A T EF I N E A G G R E G A T EM I N E R A L F I L L E RID #CLASSGROUP #Students'Instructor'sC O A R S E A G G R E G A T EF I N E A G G R E G A T EM I N E R A L F I L L E R

TOTAL MASSESM A S S E S R E T A I N E DTOTAL MASSESM A S S E S R E T A I N E DTotalM A S S E S R E T A I N E DProportions Dev DFTProportions Dev DFTP E R C E N T P A S S I N GM A S S E S R E T A I N E DM A S S E S R E T A I N E DCLASS AVERAGES

YearClass #Class CodeGroup #CODEID #B4 WashAft Wash"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200PanB4 WashAft Wash"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200PanMass"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200CAFACAFA"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200CLASS AVERAGES

20050EXAMPLE920050911EXAMPLE9278327720038921771851172110496474.900018.236.840.997.2152.29429.82.452.68000000.050.210.916.2322.41EXAMPLE952.5424.2%45.4%52462.7%24.7%100.0%100.0%86.0%7.8%1.1%0.8%0.5%0.4%0.4%0.4%100.0%100.0%100.0%96.3%88.9%80.7%61.1%30.4%11.4%5.4%100.0%100.0%100.0%100.0%100.0%99.9%99.6%98.3%88.2%57.5%YearClassMaterialCODEID#"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200

200512CV131200511222005CV13131943115042272687142143261151551200025.3839.2750.34121.3163.0589.0518.521.8856.5200000005.9919.8636.1522005CV13155.440.74.2%52.3%53.4240.341.8%50.9%100.0%99.9%92.8%8.6%4.2%3.8%3.7%3.6%3.4%3.4%100.0%100.0%100.0%95.1%87.4%77.7%54.1%22.5%5.2%1.6%100.0%100.0%100.0%100.0%100.0%100.0%100.0%89.4%64.9%36.0%CA100.0%99.9%92.6%11.7%6.2%5.2%4.6%4.1%3.6%3.4%2005112005111100.0%99.9%92.6%11.7%6.2%5.2%4.6%4.1%3.6%3.4%

200512CV132200512332005CV132291428050624222451514932312392505.1484.600018.538.946.9105.8154.592.521.11.950.150000000.016.915.4431.0432005CV13258.539.21.5%46.3%56.6241.150.9%48.2%100.0%99.8%91.5%14.4%9.3%7.6%6.5%5.4%4.6%4.3%100.0%100.0%100.0%96.3%88.6%79.4%58.4%27.8%9.5%5.3%100.0%100.0%100.0%100.0%100.0%100.0%100.0%86.2%69.2%38.1%FA100.0%100.0%100.0%96.4%89.6%80.4%59.1%26.6%9.5%5.1%2005122005122100.0%100.0%100.0%96.4%89.6%80.4%59.1%26.6%9.5%5.1%

200512CV133200513442005CV1333102304800196262318514.57310.52.330505.8482.400017.430.9440.6594.86189.6982.7925.050.853.27000000.066.939.4813.123.2142005CV13358.636.84.5%52.9%54.2142.13.1%53.4%100.0%100.0%93.7%9.1%3.2%2.7%2.6%2.3%2.2%2.1%100.0%100.0%100.0%96.6%90.4%82.4%63.7%26.1%9.8%4.8%100.0%100.0%100.0%100.0%100.0%99.9%87.0%82.2%75.4%56.4%MF100.0%100.0%100.0%100.0%100.0%99.9%97.0%86.9%70.7%44.8%2005132005133100.0%100.0%100.0%100.0%100.0%99.9%97.0%86.9%70.7%44.8%

200512CV134200514552005CV13431763052013237249415441292624143564.3533.100022.838.156126.3172.396.615.80.949.22000000.290.335.0315.3225.2152005CV1345641.30.8%47.8%55.942.20.5%48.7%100.0%99.6%92.1%13.6%8.8%7.5%6.5%5.7%5.0%4.5%100.0%100.0%100.0%96.0%89.2%79.3%56.9%26.4%9.3%6.5%100.0%100.0%100.0%100.0%100.0%99.4%99.3%89.8%68.9%48.8%200611200611499.9%99.8%71.6%8.9%5.8%5.0%4.7%4.4%4.0%3.8%

200512CV135200515662005CV135314030870019326481361023543544.9526.900015.934.149.2121.4176.295.326.33.549.960000000.024.915.8531.6162005CV13557.540.23.2%50.8%53.8544.432.4%53.6%100.0%100.0%93.9%9.5%5.2%4.9%4.8%4.7%4.6%4.4%100.0%100.0%100.0%97.1%90.8%81.8%59.5%27.2%9.7%4.9%100.0%100.0%100.0%100.0%100.0%100.0%100.0%90.2%68.3%36.7%2006122006125100.0%100.0%100.0%96.6%89.8%81.1%61.5%29.9%11.3%6.0%

200512CV136200516772005CV136296828950021724151763619151376505.4485.700012.732.443.695.919269.826.22.349.320000000.065.7615.1525.472005CV1365541.42.8%51.9%55.2422.4%52.6%100.0%100.0%92.7%11.3%5.4%4.2%3.5%3.0%2.6%2.4%100.0%100.0%100.0%97.5%91.1%82.4%63.5%25.5%11.7%6.5%100.0%100.0%100.0%100.0%100.0%100.0%99.9%88.3%69.3%48.5%2006132006136100.0%100.0%100.0%100.0%99.9%97.9%79.8%46.8%19.5%5.7%

200512CV137200517882005CV137341133180724126892155233232483516.4498.70002436.655135.9141.576.416.82.145.520000.020.050.094.769.98.8922.3382005CV13754.341.70.0%46.0%54.939.60.0%43.9%100.0%99.8%92.7%13.9%7.6%6.1%5.1%4.4%3.7%3.5%100.0%100.0%100.0%95.4%88.3%77.6%51.3%23.9%9.1%5.8%100.0%100.0%100.0%100.0%99.9%99.8%89.5%78.3%80.5%50.9%2006212006217100.0%99.8%69.8%8.3%5.4%4.6%4.4%4.1%3.7%3.5%

200512CV138200518992005CV138280527710322822161784022222093471.1451.100013.429.239.880.7150.6102.827.42.850.0100000004.7415.4928.5292005CV13855.741.63.2%50.2%56.6440.863.1%49.1%100.0%99.9%91.8%12.8%6.4%5.0%4.2%3.4%2.7%2.4%100.0%100.0%100.0%97.2%91.0%82.5%65.4%33.4%11.6%5.8%100.0%100.0%100.0%100.0%100.0%100.0%100.0%90.5%69.0%43.0%2006222006228100.0%100.0%100.0%97.1%90.6%81.1%60.7%28.1%10.3%5.8%

200612CV13120061110102006CV1312700261101980516477116571053528509.700013.833.349.7106.816498.926.58.642.1000000.080.2220.9825.8737.1102006CV13146.347.318.5%57.8%54463.2%48.5%100.0%99.3%69.5%8.5%5.9%5.3%5.1%4.8%4.4%4.3%100.0%100.0%100.0%97.4%91.1%81.7%61.4%30.4%11.6%6.6%100.0%100.0%100.0%100.0%100.0%99.8%99.5%50.2%38.6%11.9%CA99.9%99.8%71.6%8.9%5.8%5.0%4.7%4.4%4.0%3.8%2006232006239100.0%100.0%100.0%100.0%100.0%99.8%89.6%78.3%51.9%10.0%

200612CV13220061211112006CV1322997288700726194712633661165495.1472.100015.435.346.994.7158.681.132.50.847.640000000.7118.5543.5645.65112006CV13254.545.51.7%43.1%100.0%100.0%75.8%10.8%6.6%5.5%5.3%5.1%4.7%4.5%100.0%100.0%100.0%96.9%89.8%80.3%61.2%29.1%12.7%6.2%100.0%100.0%100.0%100.0%100.0%100.0%98.5%61.1%8.6%4.2%FA100.0%100.0%100.0%96.6%89.8%81.1%61.5%29.9%11.3%6.0%20071120071110100.0%99.9%77.8%10.8%7.0%5.6%5.1%4.7%4.3%4.0%

200612CV13320061312122006CV1332656257613572816777622771062526.7502.200021.131.842101.8165.4108.626.52.649.79000000.27.4142.7446.7347.99122006CV13352.9437.3%52.7%52.846.95.7%49.9%99.5%99.3%71.9%8.8%5.9%5.1%4.8%4.6%4.2%4.0%100.0%100.0%100.0%96.0%90.0%82.0%62.7%31.3%10.6%5.6%100.0%100.0%100.0%100.0%100.0%99.6%85.1%14.2%6.1%3.6%MF100.0%100.0%100.0%100.0%99.9%97.9%79.8%46.8%19.5%5.7%20071220071211100.0%100.0%100.0%97.4%91.1%81.9%61.1%30.0%11.6%6.2%

200612CV13420061413132006CV1342959287102928180041457841475.6447.300011.333.842.782.1159.982.228.31.361.8600000.060.126.3725.1248.360.52132006CV13459377.8%47.8%53477.0%49.8%100.0%99.9%68.6%7.7%7.6%7.1%7.0%6.7%6.5%6.3%100.0%100.0%100.0%97.6%90.5%81.5%64.3%30.7%13.4%7.4%100.0%100.0%100.0%100.0%99.9%99.8%89.7%59.4%21.9%2.2%20071320071312100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.5%83.4%39.3%

200612CV13520061514142006CV1352676259104895161670188101462537.9511.200019.439.441.2127.5159.297.626.11.146.980000.020.154.5226.7540.0142.6144.37142006CV13551.448.34.4%54.0%100.0%99.9%66.4%6.0%3.4%2.7%2.4%2.1%1.5%1.3%100.0%100.0%100.0%96.4%89.1%81.4%57.7%28.1%10.0%5.1%100.0%100.0%100.0%100.0%99.7%90.4%43.1%14.8%9.3%5.6%20072120072113100.0%99.9%82.6%9.5%5.3%4.2%3.8%3.5%3.2%3.0%

200612CV13620061615152006CV13625852481007201624922210121373454.8433.300019.63541.584.6151.676.922.61.359.24000000.220.9119.8834.3955.95152006CV13651.8445.4%49.7%52.8473.2%49.3%100.0%100.0%72.1%9.3%5.8%4.9%4.5%4.1%3.6%3.3%100.0%100.0%100.0%95.7%88.0%78.9%60.3%26.9%10.0%5.1%100.0%100.0%100.0%100.0%100.0%99.6%98.5%66.4%41.9%5.6%20072220072214100.0%100.0%100.0%97.7%91.8%83.3%64.7%34.4%15.2%7.6%

200612CV13720061716162006CV137300029030781219131182236843534.9509.800010.933.748.6108.9174.198.6261.552.18000003.1839.3146.9750.4451.21162006CV13753.942.22.4%48.5%5441.42.1%48.3%100.0%99.8%72.7%8.9%5.0%4.3%4.2%4.0%3.7%3.6%100.0%100.0%100.0%98.0%91.7%82.6%62.2%29.7%11.2%6.4%100.0%100.0%100.0%100.0%100.0%93.9%24.7%10.0%3.3%1.9%20072320072315100.0%100.0%100.0%100.0%100.0%99.6%98.3%91.8%68.1%23.6%

200612CV13820061817172006CV13830002901007241951146302461153518494.900024.835.939.696.7148.2116.828.63.650.15000000.070.190.8536.8144.6172006CV13884.514.163.3%122.7%53.8463.1%44.1%100.0%100.0%75.9%10.8%6.0%5.0%4.2%4.0%3.6%3.4%100.0%100.0%100.0%95.2%88.3%80.6%62.0%33.4%10.8%5.3%100.0%100.0%100.0%100.0%100.0%99.9%99.6%98.3%26.6%11.1%20073120073116100.0%99.9%77.6%8.9%5.0%4.2%3.8%3.5%3.1%2.9%

200622CV23120062118182006CV2313000293103938186283115622373500.1474.500012.33245.695.8157.496.527.528.339.390000002.27.8829.1933.85182006CV23154444.7%50.1%53.646.44.2%50.6%100.0%99.9%68.6%6.6%3.8%3.4%3.3%3.1%2.3%2.2%100.0%100.0%100.0%97.5%91.1%82.0%62.9%31.4%12.1%6.6%100.0%100.0%100.0%100.0%100.0%100.0%94.4%80.0%25.9%14.1%CA100.0%99.8%69.8%8.3%5.4%4.6%4.4%4.1%3.7%3.5%20073220073217100.0%100.0%100.0%96.7%90.5%81.3%60.7%29.3%11.7%6.1%

200622CV23220062219192006CV23227662686009011690651125843495.1472.100015.435.346.994.7158.681.132.50.850.04000000.371.015.889.3733.21192006CV23260387.4%52.6%55445.6%51.3%100.0%100.0%67.4%6.3%4.0%3.6%3.5%3.3%3.0%2.9%100.0%100.0%100.0%96.9%89.8%80.3%61.2%29.1%12.7%6.2%100.0%100.0%100.0%100.0%100.0%99.3%98.0%88.2%81.3%33.6%FA100.0%100.0%100.0%97.1%90.6%81.1%60.7%28.1%10.3%5.8%20073320073318100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.4%76.7%35.4%

200622CV23320062320202006CV23325022414027061607691843531483.4465.500014.23350.6106.6166.965.224.10.660.8440000000.030.370.5158.48202006CV23355432.1%47.3%53.844.31.6%48.3%100.0%99.9%71.7%7.5%4.7%4.0%3.8%3.7%3.5%3.4%100.0%100.0%100.0%97.1%90.2%79.8%57.7%23.2%9.7%4.7%100.0%100.0%100.0%100.0%100.0%100.0%100.0%99.4%99.2%3.9%MF100.0%100.0%100.0%100.0%100.0%99.8%89.6%78.3%51.9%10.0%20081120081119

200622CV23420062421212006CV234268825920986515707520881475472.7459.90007.926.352.6111.7146.480.519.31.752.930000000.066.1427.6451.01212006CV2345543.61.8%50.2%100.0%99.7%67.5%9.1%6.3%5.5%5.2%4.9%4.4%4.2%100.0%100.0%100.0%98.3%92.8%81.6%58.0%27.0%10.0%5.9%100.0%100.0%100.0%100.0%100.0%100.0%99.9%88.4%47.8%3.6%20081220081220

200622CV23520062522222006CV23524722387047801500691655851515.5510.500018.131.752.7108.9161.3111.723.51.343.01000000.0827.2534.8539.8542.67222006CV23552.842.84.9%53.9%52.844.56.0%55.2%100.0%99.8%68.3%7.6%4.8%4.2%4.0%3.8%3.4%3.2%100.0%100.0%100.0%96.5%90.3%80.1%59.0%27.7%6.0%1.5%100.0%100.0%100.0%100.0%100.0%99.8%36.6%19.0%7.3%0.8%20081320081321

200622CV23620062623232006CV23625362471047271567893613101773464.445200014.829.24593.6161.17721.51.850.2000000.195.3615.231.546.95232006CV23644.845.920.8%60.6%54.840.13.9%50.2%100.0%99.8%71.2%9.4%5.9%4.5%3.9%3.5%2.9%2.6%100.0%100.0%100.0%96.8%90.5%80.8%60.7%26.0%9.4%4.8%100.0%100.0%100.0%100.0%100.0%99.6%89.3%69.7%37.3%6.5%20082120082122

200622CV23720062724242006CV237300629170480119079220451040481.3452.8400015.235.933.377.2157.21003.328.550.090000000.058.7841.6344.55242006CV23755.9941.36.4%47.5%56445.4%44.8%100.0%99.9%73.2%9.8%6.7%6.1%5.9%5.8%5.4%5.3%100.0%100.0%100.0%96.8%89.4%82.5%66.4%33.8%13.0%12.3%100.0%100.0%100.0%100.0%100.0%100.0%99.9%82.5%16.9%11.1%20082220082223

200622CV23820062825252006CV23830302900098751836105331212172545043900012.528.640.499.9150.177.122.63.5500000000.540.370.346.76252006CV238504211.8%57.0%54.744.72.7%50.2%100.0%99.7%70.8%10.2%6.8%5.7%5.3%4.9%4.3%4.3%100.0%100.0%100.0%97.2%90.9%81.9%59.7%26.3%9.2%4.2%100.0%100.0%100.0%100.0%100.0%100.0%98.9%99.3%99.4%6.5%20082320082324

200712CV13120071126262007CV1312888284806.13534.782168.13107.816.165.945.26.963.924.37501.9478.800018.1529.3737.7286.27149.87115.6935.497.0745.3000000.040.121.28.8126.73262007CV13154.441.75.8%46.8%54.343.65.2%46.7%100.0%99.8%81.3%6.2%2.5%1.9%1.7%1.5%1.3%1.1%100.0%100.0%100.0%96.4%90.5%83.0%65.8%36.0%12.9%5.8%100.0%100.0%100.0%100.0%100.0%99.9%99.7%97.4%80.6%41.0%CA100.0%99.9%77.8%10.8%7.0%5.6%5.1%4.7%4.3%4.0%20091120091125

200712CV13220071227272007CV1323004.12895.800927.71175296.2828.0319.211821.211.046.76544.8518.0400012.9336.0456.52127.8316587.7529.221.7151.450000000.051.259.0430.18272007CV13258.7537.053.3%42.3%55.2402.9%44.4%100.0%100.0%69.1%10.8%7.6%6.7%6.0%5.4%4.7%4.3%100.0%100.0%100.0%97.6%91.0%80.6%57.2%26.9%10.8%5.4%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.6%82.4%41.3%FA100.0%100.0%100.0%97.4%91.1%81.9%61.1%30.0%11.6%6.2%20091220091226

200712CV13320071328282007CV133291327910057019231474724241992530.4504.600021.328.346.799.6177.987.533.72.142.4200000001.647.1329.18282007CV13354.441.75.8%46.8%57.5413.2%41.7%100.0%100.0%80.4%14.4%9.4%7.8%6.9%6.1%5.5%5.1%100.0%100.0%100.0%96.0%90.6%81.8%63.1%29.5%13.0%6.7%100.0%100.0%100.0%100.0%100.0%100.0%100.0%96.1%83.2%31.2%MF100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.5%83.4%39.3%20091320091327

200712CV13420071429292007CV13432202954.802556205017958282527113501.4476.400012.429.643.6108.3163.398.416.6249.65000000.010.50.998.2725.71292007CV13460.539.41.8%41.3%60.539.31.8%41.1%100.0%99.9%82.7%19.0%13.4%11.6%10.8%10.0%9.2%8.8%100.0%100.0%100.0%97.5%91.6%82.9%61.3%28.8%9.1%5.8%100.0%100.0%100.0%100.0%100.0%100.0%99.0%98.0%83.3%48.2%20092120092128

200712CV13520071530302007CV13529572840035702089115231081053494.7471.400018.929.742.591.8150.9106.327.31.352.730000000.061.2310.2430.2302007CV13555.440.64.8%44.3%55.443.63.7%44.1%100.0%99.9%80.6%10.0%6.1%5.3%5.0%4.7%4.4%4.2%100.0%100.0%100.0%96.2%90.2%81.6%63.0%32.5%11.0%5.5%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.7%80.6%42.7%20092220092229

200712CV13620071631312007CV13626172606012573191660835544505.2477.10009.526.543.593.417393.830.52.850.230000000.081.769.5828.63312007CV13654397.8%45.0%54.542.55.8%45.0%100.0%99.5%77.6%4.4%2.1%1.8%1.7%1.5%1.3%1.2%100.0%100.0%100.0%98.1%92.9%84.3%65.8%31.5%13.0%6.9%100.0%100.0%100.0%100.0%100.0%100.0%99.8%96.5%80.9%43.0%20092320092330

200712CV13720071732322007CV137296428263089816898213942132529.8501.900015.435.446.3107.3160.4102.127.82.349.79000000.010.071.111.0234.74322007CV13754.441.74.1%46.6%55.843.51.3%45.5%99.9%99.9%69.6%12.6%9.9%5.2%5.0%5.0%4.9%4.8%100.0%100.0%100.0%97.1%90.4%81.7%61.4%31.1%11.9%6.6%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.8%77.9%30.2%20101120101131

200712CV13820071833332007CV1382643.32580.10349519071022413111153485.9460.7000039.959136.9134.462.721.2351.1600000000.470.7232.25332007CV1385541.20.0%39.3%54.538.50.0%37.5%100.0%99.9%81.2%9.0%5.2%4.2%3.8%3.3%2.9%2.7%100.0%100.0%100.0%100.0%91.8%79.6%51.5%23.8%10.9%6.5%100.0%100.0%100.0%100.0%100.0%100.0%100.0%99.1%98.6%37.0%20101220101232

200722TR13120072134342007TR13128602784037931818100197796953851000017.532.249.8100.4157.5112.933.64.152.5000000.141.610.9332.2752.4342007TR13151458.2%52.6%5543.53.8%45.6%100.0%99.9%72.2%8.6%5.1%4.4%4.2%4.0%3.6%3.4%100.0%100.0%100.0%96.7%90.8%81.5%62.8%33.6%12.6%6.3%100.0%100.0%100.0%100.0%100.0%99.7%97.0%79.2%38.5%0.2%CA100.0%99.9%82.6%9.5%5.3%4.2%3.8%3.5%3.2%3.0%20101320101333

200722TR13220072235352007TR1322549251200104230751523453492.2468.500013.434.338.8101.4139102.331.93.650.1000001.24.3711.4612.2537.88352007TR13256.342.64.6%53.4%54444.0%53.0%100.0%100.0%95.9%5.4%3.4%3.2%3.1%3.0%2.9%2.7%100.0%100.0%100.0%97.3%90.3%82.4%61.8%33.6%12.8%6.3%100.0%100.0%100.0%100.0%100.0%97.6%91.3%77.1%75.5%24.4%FA100.0%100.0%100.0%97.7%91.8%83.3%64.7%34.4%15.2%7.6%20102120102134

200722TR13320072336362007TR1333538335502565123362324317131575566.9483.3500010.333.4548.23103.43160.0992.7727.393.540.980000000.41.169.1430.28362007TR13359.738.73.4%40.1%57.5422.9%42.2%100.0%99.3%80.9%14.9%8.3%7.1%6.6%6.2%5.8%5.6%100.0%100.0%100.0%98.2%92.3%83.8%65.5%37.3%20.9%16.1%100.0%100.0%100.0%100.0%100.0%100.0%99.0%97.2%77.7%26.1%MF100.0%100.0%100.0%100.0%100.0%99.6%98.3%91.8%68.1%23.6%20102220102235

200722TR13420072437372007TR1342566.82486.7005651589169582621261110516.03503.100010.833.350.1124149.799.728.54.656.800000001.712.337.4372007TR134000.0%0.0%56411.6%40.6%100.0%100.0%78.0%16.1%9.5%7.2%6.2%5.4%4.4%4.0%100.0%100.0%100.0%97.9%91.5%81.7%57.7%28.7%9.4%3.9%100.0%100.0%100.0%100.0%100.0%100.0%100.0%97.0%78.3%34.2%20102320102336

200722TR13520072538382007TR13531133070001202823911743532455.7436.100012.83046.297.6129.292.8251.853.680000000.162.2426.0341.88382007TR13553.1541.213.4%55.5%52.543.53.4%55.2%100.0%100.0%96.1%5.5%2.5%2.0%1.9%1.8%1.6%1.5%100.0%100.0%100.0%97.2%90.6%80.5%59.1%30.7%10.3%4.8%100.0%100.0%100.0%100.0%100.0%100.0%99.7%95.8%51.5%22.0%20111120111137

200722TR13620072639392007TR136254825430031020641201767573466.4439.70001225.835.888.5205.846.523.31.359.540000000.143.3122.0951.42392007TR13654.441.75.6%56.2%5539.55.7%54.4%100.0%100.0%87.8%6.8%2.1%1.5%1.2%0.9%0.7%0.5%100.0%100.0%100.0%97.4%91.9%84.2%65.2%21.1%11.1%6.2%100.0%100.0%100.0%100.0%100.0%100.0%99.8%94.4%62.9%13.6%20111220111238

200722TR13720072740402007TR13730382957.50380919301267682111500.1476.600001732.941.495.2153104.525.250.6000000.070.281.7910.130402007TR137000.0%0.0%623513.9%57.0%100.0%99.9%73.3%9.7%5.6%3.1%2.8%2.8%2.7%2.7%100.0%100.0%100.0%100.0%96.6%90.0%81.7%62.7%32.1%11.2%100.0%100.0%100.0%100.0%100.0%99.9%99.4%96.5%80.0%40.7%20111320111339

200722TR13820072841412007TR1382917.82841.90069019581022712131072526496.700016.831.843.4101.2186.68034.40.856.630000000.091.810.9741.18412007TR1385544.33.6%46.6%5544.53.5%46.7%100.0%100.0%76.4%9.2%5.8%4.8%4.4%4.0%3.6%3.4%100.0%100.0%100.0%96.8%90.8%82.5%63.3%27.8%12.6%6.0%100.0%100.0%100.0%100.0%100.0%100.0%99.8%96.8%80.6%27.3%20112120112140

200732TR14120073142422007TR1412925284800681.551949.37113.3424.7115.2714.4818.612.184.52451423.9900018.5425.0643.23109.29135.9863.7623.322.4438.2000000.040.311.4311.2330.97422007TR14152.9424.1%42.3%5540.52.2%40.4%100.0%100.0%76.7%10.1%6.2%5.3%4.8%4.3%3.7%3.3%100.0%100.0%100.0%95.9%90.3%80.7%56.5%26.4%12.2%7.1%100.0%100.0%100.0%100.0%100.0%99.9%99.2%96.3%70.6%18.9%CA100.0%99.9%77.6%8.9%5.0%4.2%3.8%3.5%3.1%2.9%20112220112241

200732TR14220073243432007TR14226872639.13013.11699.111797.0193.5814.255.585.15.863.032.55551.91522.7100017.9938.7751.02113.1167.99932.9950.0400000.030.070.091.199.5529.43432007TR14251.245.54.1%44.7%53442.7%43.9%100.0%99.5%73.5%6.6%3.1%2.6%2.4%2.2%2.0%1.9%100.0%100.0%100.0%96.7%89.7%80.5%60.0%29.6%11.6%5.6%100.0%100.0%100.0%100.0%99.9%99.9%99.8%97.6%80.9%41.2%FA100.0%100.0%100.0%96.7%90.5%81.3%60.7%29.3%11.7%6.1%20112320112342

200732TR14320073344442007TR1433031293400695200612633172215122492.4468.700015.129.743.793.7164.286321.650.01000000.030.11.619.6431.13442007TR14352.8446.8%45.7%55433.5%43.7%100.0%100.0%77.1%10.9%6.7%5.6%5.1%4.4%3.9%3.5%100.0%100.0%100.0%96.9%90.9%82.0%63.0%29.7%12.2%5.7%100.0%100.0%100.0%100.0%100.0%99.9%99.8%96.8%80.7%37.8%MF100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.4%76.7%35.4%20121120121143

200732TR14420073445452007TR1443489.33380.900707.32338.8166.150.33125.328.311.613.9515.5487.900021.328.543.293155.2110.429.25.950.010000000.091.519.2328.29452007TR14456.7404.1%42.6%57423.5%41.6%100.0%100.0%79.7%12.7%7.9%6.5%5.6%4.9%4.1%3.7%100.0%100.0%100.0%95.9%90.3%82.0%63.9%33.8%12.4%6.7%100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.0%81.5%43.4%20121220121244

200732TR14520073546462007TR1453081.23002.6005652218.8136.224.57.96.111.32.82.8515.4488.10001426.544.9135.7132.3104.224.51.853.30000000.061.5212.5539.17462007TR14556.441.12.0%41.2%55421.5%42.7%100.0%100.0%81.7%9.7%5.2%4.4%4.2%4.0%3.6%3.5%100.0%100.0%100.0%97.3%92.1%83.4%57.1%31.4%11.2%6.5%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.1%76.5%26.5%20121320121345

200732TR14620073647472007TR14631723092.808.2657.22235.2116.219.810.89.911.24.83.8551524.100022.235.542.993.2208.285.929.12.355.8100000000.0420.1335.64472007TR14654.542.95.0%46.3%54.443.24.9%46.5%100.0%99.7%79.0%8.6%4.9%4.3%3.9%3.6%3.3%3.1%100.0%100.0%100.0%96.0%89.5%81.7%64.8%27.0%11.5%6.2%100.0%100.0%100.0%100.0%100.0%100.0%100.0%99.9%63.9%36.1%20122120122146

200732TR14720073748482007TR147325931990773922891161766810538.2518.100014.339.651.699.1185.286.233.73.751.30000000.051.399.930.7482007TR14751.944.84.2%45.4%54423.8%42.1%100.0%99.8%77.1%6.9%3.3%2.8%2.6%2.4%2.2%2.1%100.0%100.0%100.0%97.3%90.0%80.4%62.0%27.6%11.6%5.3%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.3%80.7%40.2%20122220122247

200732TR14820073849492007TR14826192580006201852789.83.53.45.22.51.1452.4431.300012.129.450.297132.483.323.11.850.900000001.610.831492007TR148000.0%53.741.52.9%40.6%100.0%100.0%76.3%5.6%2.6%2.3%2.1%2.0%1.8%1.7%100.0%100.0%100.0%97.3%90.8%79.7%58.3%29.0%10.6%5.5%100.0%100.0%100.0%100.0%100.0%100.0%100.0%96.9%78.8%39.1%20122320122348

200812CV13120081150502008CV131502008CV1310.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%CA0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13220081251512008CV132512008CV1320.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%FA0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13320081352522008CV133522008CV1330.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%MF0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13420081453532008CV134532008CV1340.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13520081554542008CV135542008CV1350.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13620081655552008CV136552008CV1360.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13720081756562008CV137562008CV1370.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200812CV13820081857572008CV138572008CV1380.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14120082158582008TR141582008TR1410.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%CA0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14220082259592008TR142592008TR1420.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%FA0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14320082360602008TR143602008TR1430.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%MF0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14420082461612008TR144612008TR1440.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14520082562622008TR145622008TR1450.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14620082663632008TR146632008TR1460.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14720082764642008TR147642008TR1470.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200822TR14820082865652008TR148652008TR1480.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13120091166662009CV131662009CV1310.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13220091267672009CV132672009CV1320.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13320091368682009CV133682009CV1330.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13420091469692009CV134692009CV1340.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13520091570702009CV135702009CV1350.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13620091671712009CV136712009CV1360.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13720091772722009CV137722009CV1370.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200912CV13820091873732009CV138732009CV1380.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14120092174742009TR141742009TR1410.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14220092275752009TR142752009TR1420.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14320092376762009TR143762009TR1430.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14420092477772009TR144772009TR1440.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14520092578782009TR145782009TR1450.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14620092679792009TR146792009TR1460.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14720092780802009TR147802009TR1470.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

200922TR14820092881812009TR148812009TR1480.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%0.0%

201012CV13120101102010CV131

201012CV13220101202010CV132

201012CV13320101302010CV133

201012CV13420101402010CV134

201012CV13520101502010CV135

201012CV13620101602010CV136

201012CV13720101702010CV137

201012CV13820101802010CV138

201022TR14120102102010TR141

201022TR14220102202010TR142

201022TR14320102302010TR143

201022TR14420102402010TR144

201022TR14520102502010TR145

201022TR14620102602010TR146

201022TR14720102702010TR147

201022TR14820102802010TR148

201112CV13120111102011CV131

201112CV13220111202011CV132

201112CV13320111302011CV133

201112CV13420111402011CV134

201112CV13520111502011CV135

201112CV13620111602011CV136

201112CV13720111702011CV137

201112CV13820111802011CV138

201122TR14120112102011TR141

201122TR14220112202011TR142

201122TR14320112302011TR143

201122TR14420112402011TR144

201122TR14520112502011TR145

201122TR14620112602011TR146

201122TR14720112702011TR147

201122TR14820112802011TR148

201212CV13120121102012CV131

201212CV13220121202012CV132

201212CV13320121302012CV133

201212CV13420121402012CV134

201212CV13520121502012CV135

201212CV13620121602012CV136

201212CV13720121702012CV137

201212CV13820121802012CV138

201222TR14120122102012TR141

201222TR14220122202012TR142

201222TR14320122302012TR143

201222TR14420122402012TR144

201222TR14520122502012TR145

201222TR14620122602012TR146

201222TR14720122702012TR147

201222TR14820122802012TR148

201312CV13120131102013CV131

201312CV13220131202013CV132

201312CV13320131302013CV133

201312CV13420131402013CV134

201312CV13520131502013CV135

201312CV13620131602013CV136

201312CV13720131702013CV137

201312CV13820131802013CV138

201322TR14120132102013TR141

201322TR14220132202013TR142

201322TR14320132302013TR143

201322TR14420132402013TR144

201322TR14520132502013TR145

201322TR14620132602013TR146

201322TR14720132702013TR147

201322TR14820132802013TR148

32 x 0.520 = 16.640 kg

32 x 0.460 = 14.720 kg

1200 x (0.504-0.435)

1200 x 0.435 - 24.0

0.020 x 1200

1200 x (1-0.504)

AVGBLEND

CV301 MATERIALS 2Marshall Method of Asphalt Mix Design: Aggregate BlendsBlend:16.64kg CAMass for each Specimen Tin (g)

14.72kg FAStock

Year:2005Class:0EXAMPLEGroup:9INDEX:1Blend Batch Size:32kgSize

Combined Mass of CA & FA:31.36kgSieve

SPEC:2(1: Old; 2: OPS HL3)Override Proportions:5246#4595.2SieveOpn'gParticle%603010

DP:3Percent PassingPrimary CriteriaSecondary#882.8Des'n(mm)SizePassing

Sieve SizeSpec LimitsSieve Analysis ResultsStock ProportionsBlended AggregateOK?% Above Lower Limit% Below Upper LimitDeviations from TargetsPan498.0250.81.7058637123100000000000000

Size DesignationOpening (mm)Lower LimitUpper LimitCAFAMF52462MF24.0Asphalt Institute N.M.P.S.OPSS N.M.P.S.1.538.11.5809249757100000000000000

CAFAMFSpecimen:1200.0IS P

Trial and ErrorWhat would it look like before specifying PCA and PFA?Now youre looking at the grading curve for the mineral filler (PMF = 100%)If you specified 100% CA youd see the CA grading curve, or 100% FA would get you the FA grading curveTypically youd set the PMF to a reasonable number (say 4%) and set PCA = PFA (= say 48%)



Percent Passing

Stock ProportionsBlended Aggregate100.0 CAFAMF0.0%0.0%100.0%100.0%0.0%0.0%0.0%100.0%100.0%0.0%0.0%0.0%100.0%100.0%10.0%0.0%0.0%100.0%100.0%40.0%0.0%0.0%100.0%100.0%40.0%0.0%0.0%99.9%99.9%41.9%0.0%0.0%99.6%99.6%54.6%0.0%0.0%98.3%98.3%72.3%0.0%0.0%88.2%88.2%78.2%0.0%0.0%57.5%57.5%52.5%

% Out of SpecTotal390%

Chart1

0.9110000000000

0.60.981100100100100100100100100100100

0.60.751

0.580.51

0.450.361

0.260.250.999

0.10.160.996

0.050.070.983

0.030.882

00.575

0.074

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

Sieve Opening (mm)

% Passing

Blended Aggregates

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

Example

CV301 MATERIALS 2To make 32 kg of blended aggregate, first weigh out 16.640 kg of coarse aggregate and then 14.720 kg of fine aggregate.COURSE0.0740.0740Sieve SizeSpec.Sieve Analysis Results (% Passing)cfmcfmcfmcfmcfmcfmcfmcfmcfm



Percent Passing2.70%0.149#10010013/4"19.1100%100.0%100.0%100.0%20000000000000000000000002

Sieve SizeSpec LimitsSieve Analysis ResultsStock ProportionsBlended Aggregate% Out of SpecInto each specimen pan, place the following weights of mineral filler, "Pan stock", "#8 stock" and "#4 stock" from each sieved stockpile (in the order specified):0.2970.297021/2"12.799%100.0%100.0%100.0%3-14.8633783784-2.873108108118.7364864865-4.0843243243-1.11837837846.2027027027-1.467734375-0.6924218753.160156250.2414545455-0.41418181821.17272727270.951089838-0.29865979380.34756995581.1508984375-0.26613281250.1152343751.1947024952-0.25900191940.06429942423

Size DesignationOpening (mm)Lower LimitUpper LimitCAFAMF52.046.02.00.297#5010033/8"9.5283%86.0%100.0%100.0%40.46589673860.52423238880.00987087260.47607677090.6445655911-0.1206423620.47169802360.5928065522-0.06450457580.466549630.53194989950.00150047050.46642825990.5305152430.00305649710.46751845280.5434018821-0.01092033494

CAFAMF0.590.5904#44.7655%7.8%96.3%100.0%50.46822525380.7493946342-0.21761988810.46667702020.6101943512-0.07687137140.46581857580.53301239880.00116902540.46579873880.53122887360.00297238760.46595343880.5451378051-0.01109124385

3/4"19.1100%100%100.0%100.0%100.0%52.0%46.0%2.0%100.0%0.00%0.59#301005#82.3848%1.1%88.9%100.0%60.49093992670.5453556453-0.03629557210.49049190450.49602342480.01348467070.49055297920.50274842230.00669859850.49069229450.5180885867-0.00878088126

1/2"12.798%100%100.0%100.0%100.0%52.0%46.0%2.0%100.0%0.00%Mass for each Specimen Tin (g)1.191.1906#161.1942%0.8%80.7%99.9%70.50472042750.46971651620.02556305620.50486612360.48575927520.00937460110.50501952590.5026505722-0.00767009817

3/8"9.5275%90%86.0%100.0%100.0%44.7%46.0%2.0%92.7%2.70%Stock1.19#161007#300.5931%0.5%61.1%99.6%80.46325376230.53295714260.00378909510.46363370110.5506695273-0.01430322848

#44.7650%60%7.8%96.3%100.0%4.1%44.3%2.0%50.4%0.00%Size2.382.3808#500.29717%0.4%30.4%98.3%90.4502287390.588903995-0.0391327349

#82.3836%60%1.1%88.9%100.0%0.6%40.9%2.0%43.5%0.00%2.38#81009#1000.1497%0.4%11.4%88.2%1010

#161.1925%58%0.8%80.7%99.9%0.4%37.1%2.0%39.5%0.00%#4595.2fraction retained on #4 x 1200 g4.764.76010#2000.0743%0.4%5.4%57.5%

#300.5916%45%0.5%61.1%99.6%0.3%28.1%2.0%30.4%0.00%#882.8fraction retained on #8 x 1200 g4.76#4100CourseTitle0.42365133850.51393755960.062411101948

#500.2977%26%0.4%30.4%98.3%0.2%14.0%2.0%16.2%0.00%Pan498.0fraction retained on #8 x 1200 g9.529.5201CV301 MATERIALS 20.42394522680.51667344760.059381325549

#1000.1493%10%0.4%11.4%88.2%0.2%5.2%1.8%7.2%0.00%MF24.0proportion of MF x 1200 g9.523/8"1002EA448 HIGHWAY MATERIALS0.42555445540.53165420410.0427913405410

#2000.0740%5%0.4%5.4%57.5%0.2%2.5%1.2%3.8%0.00%Specimen Aggregate Mass:1200.012.712.700.55153824860.35070405630.097757695158

12.71/2"1000.55200974620.3726848220.075305431959

19.119.100.55249042980.39509383720.052415733510

19.13/4"1000.6203391170.34539664210.034264240967

Size of Batch:32kg252500.61906473280.26171208190.119223185368

251"1000.61958377850.29579608290.084620138669

37.537.500.61998435830.32210082650.0579148151610

37.51"1000.59771484770.26493990640.137345245878

505000.59839313390.31271063340.088896232779

502"1000.59881037420.34209626980.0590933561710

636300.19981991740.74332906380.056851018889

632"1000.20025214220.76450807850.0352397793810

0.50687678980.42222250080.0709007094

1

0.61055576320.30639320620.0830510306

1



Designation(mm)0.591.192.384.769.5212.719.12537.55063

2"63100.0%

2"50100.0%89.1%

1"37.5100.0%86.6%77.2%

1"25100.0%81.6%70.7%63.0%

3/4"19.1100.0%87.4%71.4%61.8%55.1%

1/2"12.7100.0%81.5%71.3%58.2%50.4%44.9%

3/8"9.52100.0%86.6%70.6%61.7%50.4%43.6%38.9%

#44.76100.0%70.7%61.2%49.9%43.6%35.6%30.9%27.5%

#82.38100.0%70.7%50.0%43.3%35.3%30.9%25.2%21.8%19.4%

#161.19100.0%70.7%50.0%35.4%30.6%25.0%21.8%17.8%15.4%13.7%

#300.59100.0%70.4%49.8%35.2%24.9%21.6%17.6%15.4%12.5%10.9%9.7%

#500.29770.9%50.0%35.3%25.0%17.7%15.3%12.5%10.9%8.9%7.7%6.9%

#1000.14950.3%35.4%25.0%17.7%12.5%10.8%8.8%7.7%6.3%5.5%4.9%

#2000.07435.4%24.9%17.6%12.5%8.8%7.6%6.2%5.4%4.4%3.8%3.4%

Cu36

Cz2.25

Example

0.074

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

Blended Aggregate

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

Sieve Opening (mm)

% Passing

Blended Aggregates

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

19.1

Data

0.074

#100

#50

#30

#16

#8

#4

"

"

"

1"

1"

2"

2"

High Spec

Low Spec

No. 30 Fuller

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

High Spec

Low Spec

#200

#100

#50

#30

#16

#8

#4

3/8"

1/2"

3/4"

1"

1"

2"

2"

#16 Fuller

#8 Fuller

#4 Fuller

'3/8" Fuller

'1/2" Fuller

'3/4" Fuller

'1" Fuller

'1-1/2" Fuller

'2" Fuller

'2-1/2" Fuller

Sieve Opening (mm)

% Passing


19.1

#200

0.149

0.297

0.59

1.19

2.38

4.76

9.52

12.7

25

37.5

50

63

Blend

ID # DEFINITIONID #CLASSGROUP #C O A R S E A G G R E G A T EF I N E A G G R E G A T EM I N E R A L F I L L E RID #CLASSGROUP #Students'Instructor'sC O A R S E A G G R E G A T EF I N E A G G R E G A T EM I N E R A L F I L L E R

TOTAL MASSESM A S S E S R E T A I N E DTOTAL MASSESM A S S E S R E T A I N E DTotalM A S S E S R E T A I N E DProportions Dev DFTProportions Dev DFTP E R C E N T P A S S I N GM A S S E S R E T A I N E DM A S S E S R E T A I N E DCLASS AVERAGES

YearClass #Class CodeGroup #CODEID #B4 WashAft Wash"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200PanB4 WashAft Wash"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200PanMass"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200CAFACAFA"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200CLASS AVERAGES

20050EXAMPLE920050911EXAMPLE9278327720038921771851172110496474.900018.236.840.997.2152.29429.82.452.68000000.050.210.916.2322.41EXAMPLE952.5424.2%45.4%52462.7%24.7%100.0%100.0%86.0%7.8%1.1%0.8%0.5%0.4%0.4%0.4%100.0%100.0%100.0%96.3%88.9%80.7%61.1%30.4%11.4%5.4%100.0%100.0%100.0%100.0%100.0%99.9%99.6%98.3%88.2%57.5%YearClassMaterialCODEID#"""No. 4No. 8No. 16No. 30No. 50No. 100No. 200

200512CV131200511222005CV13131943115042272687142143261151551200025.3839.2750.34121.3163.0589.0518.521.8856.5200000005.9919.8636.1522005CV13155.440.74.2%52.3%53.4240.341.8%50.9%100.0%99.9%92.8%8.6%4.2%3.8%3.7%3.6%3.4%3.4%100.0%100.0%100.0%95.1%87.4%77.7%54.1%22.5%5.2%1.6%100.0%100.0%100.0%100.0%100.0%100.0%100.0%89.4%64.9%36.0%CA100.0%99.9%92.6%11.7%6.2%5.2%4.6%4.1%3.6%3.4%2005112005111100.0%99.9%92.6%11.7%6.2%5.2%4.6%4.1%3.6%3.4%

200512CV132200512332005CV132291428050624222451514932312392505.1484.600018.538.946.9105.8154.592.521.11.950.150000000.016.915.4431.0432005CV13258.539.21.5%46.3%56.6241.150.9%48.2%100.0%99.8%91.5%14.4%9.3%7.6%6.5%5.4%4.6%4.3%100.0%100.0%100.0%96.3%88.6%79.4%58.4%27.8%9.5%5.3%100.0%100.0%100.0%100.0%100.0%100.0%100.0%86.2%69.2%38.1%FA100.0%100.0%100.0%96.4%89.6%80.4%59.1%26.6%9.5%5.1%2005122005122100.0%100.0%100.0%96.4%89.6%80.4%59.1%26.6%9.5%5.1%

200512CV133200513442005CV1333102304800196262318514.57310.52.330505.8482.400017.430.9440.6594.86189.6982.7925.050.853.27000000.066.939.4813.123.2142005CV13358.636.84.5%52.9%54.2142.13.1%53.4%100.0%100.0%93.7%9.1%3.2%2.7%2.6%2.3%2.2%2.1%100.0%100.0%100.0%96.6%90.4%82.4%63.7%26.1%9.8%4.8%100.0%100.0%100.0%100.0%100.0%99.9%87.0%82.2%75.4%56.4%MF100.0%100.0%100.0%100.0%100.0%99.9%97.0%86.9%70.7%44.8%2005132005133100.0%100.0%100.0%100.0%100.0%99.9%97.0%86.9%70.7%44.8%

200512CV134200514552005CV13431763052013237249415441292624143564.3533.100022.838.156126.3172.396.615.80.949.22000000.290.335.0315.3225.2152005CV1345641.30.8%47.8%55.942.20.5%48.7%100.0%99.6%92.1%13.6%8.8%7.5%6.5%5.7%5.0%4.5%100.0%100.0%100.0%96.0%89.2%79.3%56.9%26.4%9.3%6.5%100.0%100.0%100.0%100.0%100.0%99.4%99.3%89.8%68.9%48.8%200611200611499.9%99.8%71.6%8.9%5.8%5.0%4.7%4.4%4.0%3.8%

200512CV135200515662005CV135314030870019326481361023543544.9526.900015.934.149.2121.4176.295.326.33.549.960000000.024.915.8531.6162005CV13557.540.23.2%50.8%53.8544.432.4%53.6%100.0%100.0%93.9%9.5%5.2%4.9%4.8%4.7%4.6%4.4%100.0%100.0%100.0%97.1%90.8%81.8%59.5%27.2%9.7%4.9%100.0%100.0%100.0%100.0%100.0%100.0%100.0%90.2%68.3%36.7%2006122006125100.0%100.0%100.0%96.6%89.8%81.1%61.5%29.9%11.3%6.0%

200512CV136200516772005CV136296828950021724151763619151376505.4485.700012.732.443.695.919269.826.22.349.320000000.065.7615.1525.472005CV1365541.42.8%51.9%55.2422.4%52.6%100.0%100.0%92.7%11.3%5.4%4.2%3.5%3.0%2.6%2.4%100.0%100.0%100.0%97.5%91.1%82.4%63.5%25.5%11.7%6.5%100.0%100.0%100.0%100.0%100.0%100.0%99.9%88.3%69.3%48.5%2006132006136100.0%100.0%100.0%100.0%99.9%97.9%79.8%46.8%19.5%5.7%

200512CV137200517882005CV137341133180724126892155233232483516.4498.70002436.655135.9141.576.416.82.145.520000.020.050.094.769.98.8922.3382005CV13754.341.70.0%46.0%54.939.60.0%43.9%100.0%99.8%92.7%13.9%7.6%6.1%5.1%4.4%3.7%3.5%100.0%100.0%100.0%95.4%88.3%77.6%51.3%23.9%9.1%5.8%100.0%100.0%100.0%100.0%99.9%99.8%89.5%78.3%80.5%50.9%2006212006217100.0%99.8%69.8%8.3%5.4%4.6%4.4%4.1%3.7%3.5%

200512CV138200518992005CV138280527710322822161784022222093471.1451.100013.429.239.880.7150.6102.827.42.850.0100000004.7415.4928.5292005CV13855.741.63.2%50.2%56.6440.863.1%49.1%100.0%99.9%91.8%12.8%6.4%5.0%4.2%3.4%2.7%2.4%100.0%100.0%100.0%97.2%91.0%82.5%65.4%33.4%11.6%5.8%100.0%100.0%100.0%100.0%100.0%100.0%100.0%90.5%69.0%43.0%2006222006228100.0%100.0%100.0%97.1%90.6%81.1%60.7%28.1%10.3%5.8%

200612CV13120061110102006CV1312700261101980516477116571053528509.700013.833.349.7106.816498.926.58.642.1000000.080.2220.9825.8737.1102006CV13146.347.318.5%57.8%54463.2%48.5%100.0%99.3%69.5%8.5%5.9%5.3%5.1%4.8%4.4%4.3%100.0%100.0%100.0%97.4%91.1%81.7%61.4%30.4%11.6%6.6%100.0%100.0%100.0%100.0%100.0%99.8%99.5%50.2%38.6%11.9%CA99.9%99.8%71.6%8.9%5.8%5.0%4.7%4.4%4.0%3.8%2006232006239100.0%100.0%100.0%100.0%100.0%99.8%89.6%78.3%51.9%10.0%

200612CV13220061211112006CV1322997288700726194712633661165495.1472.100015.435.346.994.7158.681.132.50.847.640000000.7118.5543.5645.65112006CV13254.545.51.7%43.1%100.0%100.0%75.8%10.8%6.6%5.5%5.3%5.1%4.7%4.5%100.0%100.0%100.0%96.9%89.8%80.3%61.2%29.1%12.7%6.2%100.0%100.0%100.0%100.0%100.0%100.0%98.5%61.1%8.6%4.2%FA100.0%100.0%100.0%96.6%89.8%81.1%61.5%29.9%11.3%6.0%20071120071110100.0%99.9%77.8%10.8%7.0%5.6%5.1%4.7%4.3%4.0%

200612CV13320061312122006CV1332656257613572816777622771062526.7502.200021.131.842101.8165.4108.626.52.649.79000000.27.4142.7446.7347.99122006CV13352.9437.3%52.7%52.846.95.7%49.9%99.5%99.3%71.9%8.8%5.9%5.1%4.8%4.6%4.2%4.0%100.0%100.0%100.0%96.0%90.0%82.0%62.7%31.3%10.6%5.6%100.0%100.0%100.0%100.0%100.0%99.6%85.1%14.2%6.1%3.6%MF100.0%100.0%100.0%100.0%99.9%97.9%79.8%46.8%19.5%5.7%20071220071211100.0%100.0%100.0%97.4%91.1%81.9%61.1%30.0%11.6%6.2%

200612CV13420061413132006CV1342959287102928180041457841475.6447.300011.333.842.782.1159.982.228.31.361.8600000.060.126.3725.1248.360.52132006CV13459377.8%47.8%53477.0%49.8%100.0%99.9%68.6%7.7%7.6%7.1%7.0%6.7%6.5%6.3%100.0%100.0%100.0%97.6%90.5%81.5%64.3%30.7%13.4%7.4%100.0%100.0%100.0%100.0%99.9%99.8%89.7%59.4%21.9%2.2%20071320071312100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.5%83.4%39.3%

200612CV13520061514142006CV1352676259104895161670188101462537.9511.200019.439.441.2127.5159.297.626.11.146.980000.020.154.5226.7540.0142.6144.37142006CV13551.448.34.4%54.0%100.0%99.9%66.4%6.0%3.4%2.7%2.4%2.1%1.5%1.3%100.0%100.0%100.0%96.4%89.1%81.4%57.7%28.1%10.0%5.1%100.0%100.0%100.0%100.0%99.7%90.4%43.1%14.8%9.3%5.6%20072120072113100.0%99.9%82.6%9.5%5.3%4.2%3.8%3.5%3.2%3.0%

200612CV13620061615152006CV13625852481007201624922210121373454.8433.300019.63541.584.6151.676.922.61.359.24000000.220.9119.8834.3955.95152006CV13651.8445.4%49.7%52.8473.2%49.3%100.0%100.0%72.1%9.3%5.8%4.9%4.5%4.1%3.6%3.3%100.0%100.0%100.0%95.7%88.0%78.9%60.3%26.9%10.0%5.1%100.0%100.0%100.0%100.0%100.0%99.6%98.5%66.4%41.9%5.6%20072220072214100.0%100.0%100.0%97.7%91.8%83.3%64.7%34.4%15.2%7.6%

200612CV13720061716162006CV137300029030781219131182236843534.9509.800010.933.748.6108.9174.198.6261.552.18000003.1839.3146.9750.4451.21162006CV13753.942.22.4%48.5%5441.42.1%48.3%100.0%99.8%72.7%8.9%5.0%4.3%4.2%4.0%3.7%3.6%100.0%100.0%100.0%98.0%91.7%82.6%62.2%29.7%11.2%6.4%100.0%100.0%100.0%100.0%100.0%93.9%24.7%10.0%3.3%1.9%20072320072315100.0%100.0%100.0%100.0%100.0%99.6%98.3%91.8%68.1%23.6%

200612CV13820061817172006CV13830002901007241951146302461153518494.900024.835.939.696.7148.2116.828.63.650.15000000.070.190.8536.8144.6172006CV13884.514.163.3%122.7%53.8463.1%44.1%100.0%100.0%75.9%10.8%6.0%5.0%4.2%4.0%3.6%3.4%100.0%100.0%100.0%95.2%88.3%80.6%62.0%33.4%10.8%5.3%100.0%100.0%100.0%100.0%100.0%99.9%99.6%98.3%26.6%11.1%20073120073116100.0%99.9%77.6%8.9%5.0%4.2%3.8%3.5%3.1%2.9%

200622CV23120062118182006CV2313000293103938186283115622373500.1474.500012.33245.695.8157.496.527.528.339.390000002.27.8829.1933.85182006CV23154444.7%50.1%53.646.44.2%50.6%100.0%99.9%68.6%6.6%3.8%3.4%3.3%3.1%2.3%2.2%100.0%100.0%100.0%97.5%91.1%82.0%62.9%31.4%12.1%6.6%100.0%100.0%100.0%100.0%100.0%100.0%94.4%80.0%25.9%14.1%CA100.0%99.8%69.8%8.3%5.4%4.6%4.4%4.1%3.7%3.5%20073220073217100.0%100.0%100.0%96.7%90.5%81.3%60.7%29.3%11.7%6.1%

200622CV23220062219192006CV23227662686009011690651125843495.1472.100015.435.346.994.7158.681.132.50.850.04000000.371.015.889.3733.21192006CV23260387.4%52.6%55445.6%51.3%100.0%100.0%67.4%6.3%4.0%3.6%3.5%3.3%3.0%2.9%100.0%100.0%100.0%96.9%89.8%80.3%61.2%29.1%12.7%6.2%100.0%100.0%100.0%100.0%100.0%99.3%98.0%88.2%81.3%33.6%FA100.0%100.0%100.0%97.1%90.6%81.1%60.7%28.1%10.3%5.8%20073320073318100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.4%76.7%35.4%

200622CV23320062320202006CV23325022414027061607691843531483.4465.500014.23350.6106.6166.965.224.10.660.8440000000.030.370.5158.48202006CV23355432.1%47.3%53.844.31.6%48.3%100.0%99.9%71.7%7.5%4.7%4.0%3.8%3.7%3.5%3.4%100.0%100.0%100.0%97.1%90.2%79.8%57.7%23.2%9.7%4.7%100.0%100.0%100.0%100.0%100.0%100.0%100.0%99.4%99.2%3.9%MF100.0%100.0%100.0%100.0%100.0%99.8%89.6%78.3%51.9%10.0%20081120081119

200622CV23420062421212006CV234268825920986515707520881475472.7459.90007.926.352.6111.7146.480.519.31.752.930000000.066.1427.6451.01212006CV2345543.61.8%50.2%100.0%99.7%67.5%9.1%6.3%5.5%5.2%4.9%4.4%4.2%100.0%100.0%100.0%98.3%92.8%81.6%58.0%27.0%10.0%5.9%100.0%100.0%100.0%100.0%100.0%100.0%99.9%88.4%47.8%3.6%20081220081220

200622CV23520062522222006CV23524722387047801500691655851515.5510.500018.131.752.7108.9161.3111.723.51.343.01000000.0827.2534.8539.8542.67222006CV23552.842.84.9%53.9%52.844.56.0%55.2%100.0%99.8%68.3%7.6%4.8%4.2%4.0%3.8%3.4%3.2%100.0%100.0%100.0%96.5%90.3%80.1%59.0%27.7%6.0%1.5%100.0%100.0%100.0%100.0%100.0%99.8%36.6%19.0%7.3%0.8%20081320081321

200622CV23620062623232006CV23625362471047271567893613101773464.445200014.829.24593.6161.17721.51.850.2000000.195.3615.231.546.95232006CV23644.845.920.8%60.6%54.840.13.9%50.2%100.0%99.8%71.2%9.4%5.9%4.5%3.9%3.5%2.9%2.6%100.0%100.0%100.0%96.8%90.5%80.8%60.7%26.0%9.4%4.8%100.0%100.0%100.0%100.0%100.0%99.6%89.3%69.7%37.3%6.5%20082120082122

200622CV23720062724242006CV237300629170480119079220451040481.3452.8400015.235.933.377.2157.21003.328.550.090000000.058.7841.6344.55242006CV23755.9941.36.4%47.5%56445.4%44.8%100.0%99.9%73.2%9.8%6.7%6.1%5.9%5.8%5.4%5.3%100.0%100.0%100.0%96.8%89.4%82.5%66.4%33.8%13.0%12.3%100.0%100.0%100.0%100.0%100.0%100.0%99.9%82.5%16.9%11.1%20082220082223

200622CV23820062825252006CV23830302900098751836105331212172545043900012.528.640.499.9150.177.122.63.5500000000.540.370.346.76252006CV238504211.8%57.0%54.744.72.7%50.2%100.0%99.7%70.8%10.2%6.8%5.7%5.3%4.9%4.3%4.3%100.0%100.0%100.0%97.2%90.9%81.9%59.7%26.3%9.2%4.2%100.0%100.0%100.0%100.0%100.0%100.0%98.9%99.3%99.4%6.5%20082320082324

200712CV13120071126262007CV1312888284806.13534.782168.13107.816.165.945.26.963.924.37501.9478.800018.1529.3737.7286.27149.87115.6935.497.0745.3000000.040.121.28.8126.73262007CV13154.441.75.8%46.8%54.343.65.2%46.7%100.0%99.8%81.3%6.2%2.5%1.9%1.7%1.5%1.3%1.1%100.0%100.0%100.0%96.4%90.5%83.0%65.8%36.0%12.9%5.8%100.0%100.0%100.0%100.0%100.0%99.9%99.7%97.4%80.6%41.0%CA100.0%99.9%77.8%10.8%7.0%5.6%5.1%4.7%4.3%4.0%20091120091125

200712CV13220071227272007CV1323004.12895.800927.71175296.2828.0319.211821.211.046.76544.8518.0400012.9336.0456.52127.8316587.7529.221.7151.450000000.051.259.0430.18272007CV13258.7537.053.3%42.3%55.2402.9%44.4%100.0%100.0%69.1%10.8%7.6%6.7%6.0%5.4%4.7%4.3%100.0%100.0%100.0%97.6%91.0%80.6%57.2%26.9%10.8%5.4%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.6%82.4%41.3%FA100.0%100.0%100.0%97.4%91.1%81.9%61.1%30.0%11.6%6.2%20091220091226

200712CV13320071328282007CV133291327910057019231474724241992530.4504.600021.328.346.799.6177.987.533.72.142.4200000001.647.1329.18282007CV13354.441.75.8%46.8%57.5413.2%41.7%100.0%100.0%80.4%14.4%9.4%7.8%6.9%6.1%5.5%5.1%100.0%100.0%100.0%96.0%90.6%81.8%63.1%29.5%13.0%6.7%100.0%100.0%100.0%100.0%100.0%100.0%100.0%96.1%83.2%31.2%MF100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.5%83.4%39.3%20091320091327

200712CV13420071429292007CV13432202954.802556205017958282527113501.4476.400012.429.643.6108.3163.398.416.6249.65000000.010.50.998.2725.71292007CV13460.539.41.8%41.3%60.539.31.8%41.1%100.0%99.9%82.7%19.0%13.4%11.6%10.8%10.0%9.2%8.8%100.0%100.0%100.0%97.5%91.6%82.9%61.3%28.8%9.1%5.8%100.0%100.0%100.0%100.0%100.0%100.0%99.0%98.0%83.3%48.2%20092120092128

200712CV13520071530302007CV13529572840035702089115231081053494.7471.400018.929.742.591.8150.9106.327.31.352.730000000.061.2310.2430.2302007CV13555.440.64.8%44.3%55.443.63.7%44.1%100.0%99.9%80.6%10.0%6.1%5.3%5.0%4.7%4.4%4.2%100.0%100.0%100.0%96.2%90.2%81.6%63.0%32.5%11.0%5.5%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.7%80.6%42.7%20092220092229

200712CV13620071631312007CV13626172606012573191660835544505.2477.10009.526.543.593.417393.830.52.850.230000000.081.769.5828.63312007CV13654397.8%45.0%54.542.55.8%45.0%100.0%99.5%77.6%4.4%2.1%1.8%1.7%1.5%1.3%1.2%100.0%100.0%100.0%98.1%92.9%84.3%65.8%31.5%13.0%6.9%100.0%100.0%100.0%100.0%100.0%100.0%99.8%96.5%80.9%43.0%20092320092330

200712CV13720071732322007CV137296428263089816898213942132529.8501.900015.435.446.3107.3160.4102.127.82.349.79000000.010.071.111.0234.74322007CV13754.441.74.1%46.6%55.843.51.3%45.5%99.9%99.9%69.6%12.6%9.9%5.2%5.0%5.0%4.9%4.8%100.0%100.0%100.0%97.1%90.4%81.7%61.4%31.1%11.9%6.6%100.0%100.0%100.0%100.0%100.0%100.0%99.9%97.8%77.9%30.2%20101120101131

200712CV13820071833332007CV1382643.32580.10349519071022413111153485.9460.7000039.959136.9134.462.721.2351.1600000000.470.7232.25332007CV1385541.20.0%39.3%54.538.50.0%37.5%100.0%99.9%81.2%9.0%5.2%4.2%3.8%3.3%2.9%2.7%100.0%100.0%100.0%100.0%91.8%79.6%51.5%23.8%10.9%6.5%100.0%100.0%100.0%100.0%100.0%100.0%100.0%99.1%98.6%37.0%20101220101232

200722TR13120072134342007TR13128602784037931818100197796953851000017.532.249.8100.4157.5112.933.64.152.5000000.141.610.9332.2752.4342007TR13151458.2%52.6%5543.53.8%45.6%100.0%99.9%72.2%8.6%5.1%4.4%4.2%4.0%3.6%3.4%100.0%100.0%100.0%96.7%90.8%81.5%62.8%33.6%12.6%6.3%100.0%100.0%100.0%100.0%100.0%99.7%97.0%79.2%38.5%0.2%CA100.0%99.9%82.6%9.5%5.3%4.2%3.8%3.5%3.2%3.0%20101320101333

200722TR13220072235352007TR1322549251200104230751523453492.2468.500013.434.338.8101.4139102.331.93.650.1000001.24.3711.4612.2537.88352007TR13256.342.64.6%53.4%54444.0%53.0%100.0%100.0%95.9%5.4%3.4%3.2%3.1%3.0%2.9%2.7%100.0%100.0%100.0%97.3%90.3%82.4%61.8%33.6%12.8%6.3%100.0%100.0%100.0%100.0%100.0%97.6%91.3%77.1%75.5%24.4%FA100.0%100.0%100.0%97.7%91.8%83.3%64.7%34.4%15.2%7.6%20102120102134

200722TR13320072336362007TR1333538335502565123362324317131575566.9483.3500010.333.4548.23103.43160.0992.7727.393.540.980000000.41.169.1430.28362007TR13359.738.73.4%40.1%57.5422.9%42.2%100.0%99.3%80.9%14.9%8.3%7.1%6.6%6.2%5.8%5.6%100.0%100.0%100.0%98.2%92.3%83.8%65.5%37.3%20.9%16.1%100.0%100.0%100.0%100.0%100.0%100.0%99.0%97.2%77.7%26.1%MF100.0%100.0%100.0%100.0%100.0%99.6%98.3%91.8%68.1%23.6%20102220102235

200722TR13420072437372007TR1342566.82486.7005651589169582621261110516.03503.100010.833.350.1124149.799.728.54.656.800000001.712.337.4372007TR134000.0%0.0%56411.6%40.6%100.0%100.0%78.0%16.1%9.5%7.2%6.2%5.4%4.4%4.0%100.0%100.0%100.0%97.9%91.5%81.7%57.7%28.7%9.4%3.9%100.0%100.0%100.0%100.0%100.0%100.0%100.0%97.0%78.3%34.2%20102320102336

200722TR13520072538382007TR13531133070001202823911743532455.7436.100012.83046.297.6129.292.8251.853.680000000.162.2426.0341.88382007TR13553.1541.213.4%55.5%52.543.53.4%55.2%100.0%100.0%96.1%5.5%2.5%2.0%1.9%1.8%1.6%1.5%100.0%100.0%100.0%97.2%90.6%80.5%59.1%30.7%10.3%4.8%100.0%100.0%100.0%100.0%100.0%100.0%99.7%95.8%51.5%22.0%20111120111137

200722TR13620072639392007TR136254825430031020641201767573466.4439.70001225.835.888.5205.846.523.31.359.540000000.143.3122.0951.42392007TR13654.441.75.6%56.2%5539.55.7%54.4%100.0%100.0%87.8%6.8%2.1%1.5%1.2%0.9%0.7%0.5%100.0%100.0%100.0%97.4%91.9%84.2%65.2%21.1%11.1%6.2%100.0%100.0%100.0%100.0%100.0%100.0%99.8%94.4%62.9%13.6%20111220111238

200722TR13720072740402007TR13730382957.50380919301267682111500.1476.600001732.941.495.2153104.525.250.6000000.070.281.7910.130402007TR137000.0%0.0%623513.9%57.0%100.0%99.9%73.3%9.7%5.6%3.1%2.8%2.8%2.7%2.7%100.0%100.0%100.0%100.0%96.6%90.0%81.7%62.7%32.1%11.2%100.0%100.0%100.0%100.0%100.0%99.9%99.4%96.5%80.0%40.7%20111320111339

200722TR13820072841412007TR1382917.82841.90069019581022712131072526496.700016.831.843.4101.2186.68034.40.856.630000000.091.810.9741.18412007TR1385544.33.6%46.6%5544.53.5%46.7%100.0%100.0%76.4%9.2%5.8%4.8%4.4%4.0%3.6%3.4%100.0%100.0%100.0%96.8%90.8%82.5%63.3%27.8%12.6%6.0%100.0%100.0%100.0%100.0%100.0%100.0%99.8%96.8%80.6%27.3%20112120112140

200732TR14120073142422007TR1412925284800681.551949.37113.3424.7115.2714.4818.612.184.52451423.9900018.5425.0643.23109.29135.9863.7623.322.4438.2000000.040.311.4311.2330.97422007TR14152.9424.1%42.3%5540.52.2%40.4%100.0%100.0%76.7%10.1%6.2%5.3%4.8%4.3%3.7%3.3%100.0%100.0%100.0%95.9%90.3%80.7%56.5%26.4%12.2%7.1%100.0%100.0%100.0%100.0%100.0%99.9%99.2%96.3%70.6%18.9%CA100.0%99.9%77.6%8.9%5.0%4.2%3.8%3.5%3.1%2.9%20112220112241

200732TR14220073243432007TR14226872639.13013.11699.111797.0193.5814.255.585.15.863.032.55551.91522.7100017.9938.7751.02113.1167.99932.9950.0400000.030.070.091.199.5529.43432007TR14251.245.54.1%44.7%53442.7%43.9%100.0%99.5%73.5%6.6%3.1%2.6%2.4%2.2%2.0%1.9%100.0%100.0%100.0%96.7%89.7%80.5%60.0%29.6%11.6%5.6%100.0%100.0%100.0%100.0%99.9%99.9%99.8%97.6%80.9%41.2%FA100.0%100.0%100.0%96.7%90.5%81.3%60.7%29.3%11.7%6.1%20112320112342

200732TR14320073344442007TR1433031293400695200612633172215122492.4468.700015.129.743.793.7164.286321.650.01000000.030.11.619.6431.13442007TR14352.8446.8%45.7%55433.5%43.7%100.0%100.0%77.1%10.9%6.7%5.6%5.1%4.4%3.9%3.5%100.0%100.0%100.0%96.9%90.9%82.0%63.0%29.7%12.2%5.7%100.0%100.0%100.0%100.0%100.0%99.9%99.8%96.8%80.7%37.8%MF100.0%100.0%100.0%100.0%100.0%100.0%99.8%97.4%76.7%35.4%20121120121143

200732TR14420073445452007TR1443489.33380.900707.32338.8166.150.33125.328.311.613.9515.5487.900021.328.543.293155.2110.429.25.950.010000000.091.519.2328.29452007TR14456.7404.1%42.6%57423.5%41.6%100.0%100.0%79.7%12.7%7.9%6.5%5.6%4.9%4.1%3.7%100.0%100.0%100.0%95.9%90.3%82.0%63.9%33.8%12

Date post:	08-Sep-2015
Category:	Documents
Upload:	truong-khai
View:	227 times
Download:	0 times

CV301 Mod 2 Blending of Aggregates

Documents