D A T A S H E E T

Designed in compliance with applicable BCI, DIN, BS and IEC standards.Tested in compliance to BCI and IEC standards.

TROJAN BATTERYCOMPANY WITH

QUALITY SYSTEMCERTIFIED BY DNV= ISO 9001:2015 =

OPERATIONAL DATA

Operating Temperature Self Discharge

-4°F to 122°F (-20°C to 50°C)At temperatures below 32°F (0°C) maintain a state of charge greater than 60%

Less than 3% per month depending on storage temperature conditions

CHARGING TEMPERATURE COMPENSATION

Add Subtract

0.005 volt per cell for every 1°C below 25°C0.0028 volt per cell for every 1°F below 77°F

0.005 volt per cell for every 1°C above 25°C 0.0028 volt per cell for every 1°F above 77°F

CHARGING INSTRUCTIONS

Charger Voltage Settings (at 77°F/25°C)

System Voltage 12V 24V 36V 48V

Maximum Charge Current (A) 20% of C20

Absorption Voltage (2.40 V/cell) 14.40 28.80 43.20 57.60

Float Voltage (2.25 V/cell) 13.50 27.00 40.50 54.00

Do not install or charge batteries in a sealed or non-ventilated compartment. Constant under or overcharging will damage the battery and shorten its life as with any battery.

ELECTRICAL SPECIFICATIONS

Cranking Performance Capacity A Minutes Capacity B Amp-Hours (Ah) Energy kWh Internal Resistance (mΩ) Short Circuit Current (A)

C.C.A. D @ 0°F (-18°C) C.A. E @ 32°F (0°C) @ 25 Amps @ 75 Amps 5-Hr 10-Hr 20-Hr 100-Hr 100-Hr4.3 2920

— — 254 70 114 126 132 135 1.62

STATE OF CHARGE MEASURE OF OPEN-CIRCUIT VOLTAGE

Percentage Charge Cell 12 Volt

100 2.14 12.84

75 2.09 12.54

50 2.04 12.24

25 1.99 11.94

0 1.94 11.64

MODEL T1275-AGMVOLTAGE 12

MATERIAL Polypropylene

DIMENSIONS Inches (mm)

BATTERY VRLA AGM / Non-Spillable / Maintenance-Free

COLOR Maroon

WATERING No Watering Required

PRODUCT + PHYSICAL SPECIFICATIONS

BCI Group Size Type Terminal Type G Dimensions C Inches (mm) Weight Lbs.I (kg)

GC12 T1275-AGM M8, AP, LTLength Width Height F

83 (38)12.96 (329) 7.06 (179) 10.96 (278)

BATTERY DIMENSIONS Dimensions Inches (mm)

12380 CLARK ST. SANTA FE SPRINGS, CA 906705194 MINOLA DR. LITHONIA, GA 30038

SCALEDWN BY

DATE

TITLE

DWG NO

APPVD

REV

THIS DRAWING AND DATA EMBODY PROPRIETARY INFORMATION WHICH IS THE CONFIDENTIAL PROPERTY OF TROJAN BATTERY COMPANY WHICH SHALL NOT BE COPIED, REPRODUCED DISCLOSED TO OTHERS OR USED IN WHOLE OR PART FOR ANY PURPOSE WITHOUT THE EXPRESS WRITTEN PERMISSION OF TROJAN BATTERY CO. THIS DRAWING IS LOANED IN CONFIDENCE WITH THE UNDERSTANDING THAT IT SHALL BE RETURNED ON DEMAND

CHK

UNLESS OTHERWISESPECIFICED

TOLERANCES ARE:

X.X 0.02"X.XX 0.01"X.XXX 0.005"ANGLES = 0 30'

CSIZE=DWG SCALE

NOTES: UNLESS OTHERWISE SPECIFIED

A

B

C

D

E

F

G

H

B

C

D

E

F

G

H

1234567

7 6 5 4 3

7.02 (178)CASE WIDTH

10.57(268)

12.82 (326)

12.96 (329)

7.06 (179)COVER WIDTH

6.95 (177)

10.18 (259)

10.96 (278)

DATEREVDESCRIPTION ZONE8/5/14 AINITIAL RELEASE; ECO4552

12/11/14BREMOVE CROSS SECTION SIDE VIEW; TITLE CHANGE FROM 12V150 GOLF; COR477112/17/14CREMOVING LETTERS FROM VENTS; COR4788

C12-5-2014A. SAN

T1275-AGM GOLFAGM MKTG

1. ALL DIMENSIONS ARE NOMINAL. 2. HEAT SEAL MELT = 0.100".

721038

SCALE 0.50

UNCONTROLLED COPY WHEN DOWNLOADED or PRINTED- Check MASTER DOCUMENT LOG to verify that this document/drawing is current prior to use

12380 CLARK ST. SANTA FE SPRINGS, CA 906705194 MINOLA DR. LITHONIA, GA 30038

SCALEDWN BY

DATE

TITLE

DWG NO

APPVD

REV

THIS DRAWING AND DATA EMBODY PROPRIETARY INFORMATION WHICH IS THE CONFIDENTIAL PROPERTY OF TROJAN BATTERY COMPANY WHICH SHALL NOT BE COPIED, REPRODUCED DISCLOSED TO OTHERS OR USED IN WHOLE OR PART FOR ANY PURPOSE WITHOUT THE EXPRESS WRITTEN PERMISSION OF TROJAN BATTERY CO. THIS DRAWING IS LOANED IN CONFIDENCE WITH THE UNDERSTANDING THAT IT SHALL BE RETURNED ON DEMAND

CHK

UNLESS OTHERWISESPECIFICED

TOLERANCES ARE:

X.X 0.02"X.XX 0.01"X.XXX 0.005"ANGLES = 0 30'

CSIZE=DWG SCALE

NOTES: UNLESS OTHERWISE SPECIFIED

A

B

C

D

E

F

G

H

B

C

D

E

F

G

H

1234567

7 6 5 4 3

7.02 (178)CASE WIDTH

10.57(268)

12.82 (326)

12.96 (329)

7.06 (179)COVER WIDTH

6.95 (177)

10.18 (259)

10.96 (278)

DATEREVDESCRIPTION ZONE8/5/14 AINITIAL RELEASE; ECO4552

12/11/14BREMOVE CROSS SECTION SIDE VIEW; TITLE CHANGE FROM 12V150 GOLF; COR477112/17/14CREMOVING LETTERS FROM VENTS; COR4788

C12-5-2014A. SAN

T1275-AGM GOLFAGM MKTG

1. ALL DIMENSIONS ARE NOMINAL. 2. HEAT SEAL MELT = 0.100".

721038

SCALE 0.50

UNCONTROLLED COPY WHEN DOWNLOADED or PRINTED- Check MASTER DOCUMENT LOG to verify that this document/drawing is current prior to use

12380 CLARK ST. SANTA FE SPRINGS, CA 906705194 MINOLA DR. LITHONIA, GA 30038

SCALEDWN BY

DATE

TITLE

DWG NO

APPVD

REV

THIS DRAWING AND DATA EMBODY PROPRIETARY INFORMATION WHICH IS THE CONFIDENTIAL PROPERTY OF TROJAN BATTERY COMPANY WHICH SHALL NOT BE COPIED, REPRODUCED DISCLOSED TO OTHERS OR USED IN WHOLE OR PART FOR ANY PURPOSE WITHOUT THE EXPRESS WRITTEN PERMISSION OF TROJAN BATTERY CO. THIS DRAWING IS LOANED IN CONFIDENCE WITH THE UNDERSTANDING THAT IT SHALL BE RETURNED ON DEMAND

CHK

UNLESS OTHERWISESPECIFICED

TOLERANCES ARE:

X.X 0.02"X.XX 0.01"X.XXX 0.005"ANGLES = 0 30'

CSIZE=DWG SCALE

NOTES: UNLESS OTHERWISE SPECIFIED

A

B

C

D

E

F

G

H

B

C

D

E

F

G

H

1234567

7 6 5 4 3

7.02 (178)CASE WIDTH

10.57(268)

12.82 (326)

12.96 (329)

7.06 (179)COVER WIDTH

6.95 (177)

10.18 (259)

10.96 (278)

DATEREVDESCRIPTION ZONE8/5/14 AINITIAL RELEASE; ECO4552

12/11/14BREMOVE CROSS SECTION SIDE VIEW; TITLE CHANGE FROM 12V150 GOLF; COR477112/17/14CREMOVING LETTERS FROM VENTS; COR4788

C12-5-2014A. SAN

T1275-AGM GOLFAGM MKTG

1. ALL DIMENSIONS ARE NOMINAL. 2. HEAT SEAL MELT = 0.100".

721038

SCALE 0.50

UNCONTROLLED COPY WHEN DOWNLOADED or PRINTED- Check MASTER DOCUMENT LOG to verify that this document/drawing is current prior to use

M8 with AP Adapter (adapter provided but not installed)

Battery Height with Terminal in Inches (mm) 11.41 (290)

Torque Values: in-lb (Nm) Connection to M8: 85 – 90 (10 – 11) Connection to AP: 50 – 70 (6 – 8)

TERMINAL CONFIGURATIONSG

M8

Battery Height with Terminal in Inches (mm) 10.57 (268)

Torque Values: in-lb (Nm) Bolt: 85 – 90 (10 – 11)

M8 with LT Adapter (adapter provided but not installed)

Battery Height with Terminal in Inches (mm) 12.07 (307)

Torque Values: in-lb (Nm) Connection to M8: 85 – 90 (10-11) Connection to LT: 65 – 75 (7.5 – 8.5)

Bolt Size M8 x 1.25

800.423.6569 / +1.562.236.3000 / trojanbattery.com© 2018 Trojan Battery Company, LLC. All rights reserved. Trojan Battery Company is not liable for damages that may result from any information provided in or omitted from this publication, under any circumstances. Trojan Battery Company reserves the right to make adjustments to this publication at any time, without notice or obligation.

A. The number of minutes a battery can deliver when discharged at a constant rate at 80°F (27°C) and maintain a voltage above 1.75 V/cell. Capacities are based on peak performance.

B. The amount of amp-hours (Ah) a battery can deliver when discharged at a constant rate at 80°F (27°C) for the 20-Hour rate and 86°F (30°C) for the 5-Hour rate and maintain a voltage above 1.75 V/cell. Capacities are based on peak performance.

C. Dimensions may vary depending on type of handle or terminal. Batteries should be mounted with 0.5 inches (12.7 mm) spacing minimum.

D. C.C.A. (Cold Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 0°F (-18°C) at a voltage above 1.2 V/cell.

E. C.A. (Cranking Amps) - the discharge load in amperes which a new, fully charged battery can maintain for 30 seconds at 32°F (0°C) at a voltage above 1.2 V/cell. This is sometimes referred to as marine cranking amps @ 32°F or M.C.A. @ 32°F.

F. Height taken from bottom of the battery to the highest point on the battery. Heights may vary depending on type of terminal. G. Terminal images are representative only.H. A boost charge should be performed every 6 months when batteries are in storage.I. Weight may vary.

Reliant_T1275AGM_092118

SELF DISCHARGE VS. TIMEH

TROJAN T1275-AGM PERFORMANCEDi

schar

ge Cu

rrent

(am

ps)

1.0

10.0

100.0

1 10 100

Time (min)

Storage Time in Months

2.14

2.10

2.09

2.06

2.02

1.98

1.94

0 2 4 6 8 10 12 14 16

100

80

75

60

40

20

0

Recharge Threshold @ 75% SOC

40°C (104°F) 30°C (86°F)

25°C (77°F)

10°C (50°F)

Stat

e of C

harg

e %

Open

Circu

it Volt

age P

er Ce

ll

2.14

2.10

2.09

2.06

2.02

1.98

1.94

0 2 4 6 8 10 12 14 16

100

80

75

60

40

20

0

Recharge Threshold @ 75% SOC

40°C (104°F) 30°C (86°F)

25°C (77°F)

10°C (50°F)

PERCENT CAPACITY VS. TEMPERATURE

Tem

pera

ture

(C)

Percent of Available Capacity

Tem

pera

ture

(F)

20%0% 40% 60% 80% 100% 120%

0

20

-20

-40

40

60

80

100

120

140

0

-20

-10

-30

-40

10

20

30

40

50

60

PERCENT CAPACITY VS. TEMPERATURE