Diagrama Electrico D6N

8/17/2019 Diagrama Electrico D6N

1/20

INTERACTIVE SCHEMATIC

The Bookmarks panel will allow you to

quickly navigate to points of interest.

Click on any text that is BLUE and underlined.

These are hyperlinks that can be used to navi-

gate the schematic and machine views.

Cover Page

Information

Schematic

Machine Views

Component Table

Tap Table

Fluid Power Symbols

Electrical Symbols

Front Frame

Rear Frame

Tap Views

Features

Options

Bookmarks X

EC-C3

EC-C2 E-C60

EC-C1

E-C61

To set your screen resolution do the following:

RIGHT CLICK on the DESKTOP.

Select PROPERTIES.

CLICK the SETTINGS TAB.

MOVE THE SLIDER under SCREEN RESOLUTION until it shows 1024 X 768.

CLICK OK to apply the resolution.

This document is best viewed at a

screen resolution of 1024 X 768.


2/20

UENR5923

July 2014

D6N Track Type Tractor

Electrical System

LJR444-UP

GHS710-UPMLW366-UP


3/20

HARNESS and WIREElectrical Schematic Symbols

PressureSymbol

T

TemperatureSymbol

LevelSymbol

FlowSymbol

Circuit Breaker Symbol

Symbols

Symbols and Definitions

T

Fuse: A component in an electrical circuit that will open the circuit if too much current flows through it.

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has

screw terminals and a wire can be disconnected from it.

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.). No circle indicates that the wire cannot be

disconnected from the component.

Ground (Wired): This indicates that the component is connected to a grounded wire. The grounded wire is fastened to the machine.

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the

machine.

Reed Switch : A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it

opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its

resistance changes to give an indication to the gauge of the temperature or pressure.

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet

when current flows through it. The electromagnet can open or close the switch part of the relay.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current

flows through it The electromagnet can open or close a valve or move a piece of metal that can do work


4/20

COMPONENT TABLE:

Volume 1 of 2 - Chassis and Cab

Component Location Volume 1

ComponentSchematic

Location

Machine

LocationComponent

Schematic

Location

Machine

Location

575-CnoitisoPladePr otar eleceD-r osneS25-Cnoitc A-mr al A

473-HSensor - Coolant Temperature15-D Actuator - HVAC Water Valve

673-GdeepStuOenignE-r osneS331-BpukcaB-mr al A

777-ERNF-r osneS43-Dr otanr etl A

873-Ger usser PleuF-r osneS541-J1-yr ettaB

973-Fer utar epmeTleuF-r osneS651-J2-yr ettaB

083-Her utar epmeTr i Adlof inaMekatnI-r osneS741-J1ytuDyvaeH-yr ettaB

183-Her usser Pdlof inaMekatnI-r osneS851-J2ytuDyvaeH-yr ettaB

283-Ger usser PliO-r osneS951-InocaeB

385-CladePekar Becivr eS-r osneS0101-J1noitcnuJ-kcolB

4851-FdeepSr otoMr eetS-r osneS114-D2noitcnuJ-kcolB

583-GdeepStuptuOCT-r osneS2101-Jr otanr etl A-r ekaer B

6861-G1pStuptuOnoissimsnar T-r osneS3101-JniaM-r ekaer B

7861-G2pStuptuOnoissimsnar T-r osneS417-Btnemur tsnI-r etsulC

8861-Eer utar epmeTnoissimsnar T-r osneS515-Br eticxESSM-lioC

984-GleuFnIr etaW-r osneS615-Jniar tevir D-lor tnoC

093-EhctulCgninoitidnoCr i A-dioneloS711-HenignE-lor tnoC

1961-Ct)f eL(elgn AedalB-dioneloS8141-DtnemelpmI-lor tnoC

92C-16Solenoid - Blade Angle (Right)19D-5Control - Machine Security System (MSS)

3961-Dr ewoLedalB-dioneloS027-Er etf ihS-lor tnoC

4961-DesiaRedalB-dioneloS1231-ItloV21ottloV42-r etr evnoC

5961-Ctf eLtliTedalB-dioneloS225-FHLenignE-dnuor G

6961-DthgiRtliTedalB-dioneloS324-DenignE-dnuor G793-Er eetStf eLSD-dioneloS424-Iemar F-dnuor G

893-Er eetSthgiRSD-dioneloS5211-Br enildaeH-dnuor G

9961-GhctulCr aeGtsr iF-dioneloS6221-H1mr of talP-dnuor G

00161-GhctulCdr awr oF-dioneloS7221-H2mr of talP-dnuor G

1013-GpmuPleuF-dioneloS8221-G3mr of talP-dnuor G

20161-Df f otuhStnemelpmI-dioneloS9231-Hemar Fr aeR-dnuor G

3011-I1r otce jnI-dioneloS0341-Flor tnoCr eppiR-eldnaH

4011-I2r otce jnI-dioneloS1341-Flor tnoCtliT-eldnaH

5011-I3r otce jnI-dioneloS2311-Elor tnoChcniW-eldnaH

6011-I4r otce jnI-dioneloS332-Jnr oH

7011-H5r otce jnI-dioneloS435-Fr ewoP-eludoM

8011-H6r otce jnI-dioneloS534- A1r ewolBbaC-r otoM

90151-GpmuDekar Bkr aP-dioneloS634- A2r ewolBbaC-r otoM01151-Fekar Bpor P-dioneloS7341-H1r esnednoC-r otoM

11161-GhctulCesr eveR-dioneloS8341-H2r esnednoC-r otoM

21161-Cr ewoLr eppiR-dioneloS935-Cr epiWtnor F-r otoM

31161-CesiaRr eppiR-dioneloS043-GpmuPgnimir PleuF-r otoM

41161-GhctulCraeGdnoceS-dioneloS1431-HrepiWtfeL-rotoM


5/20

COMPONENT TABLE:

Volume 2 of 2 - Accugrade and Winch Attachments

ComponentSchematic

Location

Machine

Location

9413-BC AVH-ylbmess Ar ewolB

148C-5 Antenna Assembly - Product Link

0512-FyalpsiDedar Gucc A-r ezzuB

1517-DkniLtcudor P-lor tnoC

2516- AhcniW-lor tnoC

3511-DSPGedar gucc A-yalpsiD

4511-Fr esaL-yalpsiD

5513-F)r esaL(cir tcelEHL-tsaM

6513-E)r esaL(cir tcelEHR-tsaM

7514- Agnileuf eR-r otoM

8515-DSPG-oidaR

9513-Fr esaLHL-r evieceR

Component Location - Volume 2


6/20

CONNECTOR TABLE:

Volume 1 of 2 - Chassis and Cab

Connector Location Volume 1

Connector Number Schematic

Location

41-D1NNOC

41-E2NNOC

51-G3NNOC

41-H4NNOC

61-H5NNOC

41-G6NNOC

41-G7NNOC

31- A8NNOC21-E9NNOC

21-E01NNOC

21-J11NNOC

21-J21NNOC

11-C31NNOC

11-C41NNOC

11-B51NNOC

11- A71NNOC

9-H,I81NNOC


7/20

CONNECTOR TABLE:


Connector Location Volume 2

Connector Number Schematic

Location

CONN 9 B-6

CONN 10 A-3, B-6

CONN 12 D-6

CONN 15 D-3, F-2

CONN 17 D-4

CONN 26 E-7

CONN 29 F-4

CONN 30 E-4

CONN 31 F-4

CONN 32 F-4


8/20

CID/MID/FMI

Volume 1 of 2 - Cab and Chassis

Component Identifiers (CID¹)

Module Identif ier (MID²)

Caterpillar Monitor ing System

(MID No. 030)tnenopmoCDIC

0096 Fuel Level Sender

0100 Engine Oil Pressure Sensor

0110 Engine Coolant Temperature Sensor

0177 Transmission Oil Temperature Sensor

0248 Data Link0263 Sensor Power Supply

0271 Action Alarm

0280 Transmission Oil Temperature Sender

0324 Action Lamp

0600 Hydraulic Oil Temperature Sensor

0819 Display Data Link

0821 Display Power Supply

1045 Power Train O il Temperature Sensor

1425 Implement Tank Oil Temperature Sensor

Engine Control System


0001 Injector Cylinder #1






0041 8V DC Supply


Module Identi fier (MID²)

Implement Lockout Switch

Inching Pedal Position Sensor 0618 Park Brake Switch

0621 Downshift Switch

0622 Upshift Switch

0623 Direction Switch

0650 Harness Code

0668 Transmission Shift Lever

0671 Transmission Output Speed #1 Sensor

0672 Torque Converter Output Speed Sensor

0673 Transmission Output Speed #2 Sensor

0674 Transmission Intermediate Speed #1 Sensor 0675 Transmission Intermediate Speed #2 Sensor

0676 Left Track Steering Lever Posi tion Sensor

0677 Right Track Steering Lever Posit ion Sensor

0681 Parking Brake Solenoid

0070 Park Brake Switch

0075 Steering System Oi l Temperature Sensor

0168 Electrical System Voltage

0177 Transmission Oil Temperature Sensor

0190 Engine Speed Sensor

0248 CAT Data Link

0254 Electronic Control Module

0269 Sensor Power Supply

0298 Service Brake Switch

0299 Transmission Direction Lever Position Sensor

0368 Autoshift Switch

0468 Service Brake Pedal Position Sensor

0490

0573

Power Train Control System


Component Identi fiers (CID¹)

Module Identif ier (MID²)


9/20

CID/MID/FMI


Failure Mode Identif iers (FMI)¹FMI No. Failure Description

0 Data val id but above normal operat ional range.

1 Data val id but below normal operat ional range.

2 Data erratic, intermit tent, or incorrect.

3 Voltage above normal or shorted high.

4 Voltage below normal or shorted low.

5 Current below normal or open circuit.

6 Current above normal or grounded circuit .

7 Mechanical system not responding properly.8 Abnormal frequency, pulse width, or period.

9 Abnormal update.

10 Abnormal rate of change.

11 Fai lure mode not identif iable.

12 Bad device or component.

13 Out of calibration.

14 Parameter failures.


16 Parameter not available.

17 Module not responding.18 Sensor supply fault.

19 Condition not met.


¹The FMI is a diagnostic code that indicates what type of failure has occurred.


Module Identifier (MID²)

AccuGrade Laser System


0168 Electrical System Voltage

0248 CAT Data Link

0262 5 Volt Sensor Supply

Diagnostic Codes

AccuGrade Laser System

Display (CB), Electr ic Mast (EM), Laser Receiver (LR)noitpir cseDedoCcitsongaiD

CB 1 Set Limits Fault

CB 2 No Data

CB 3 Calibration Failure

CB 4 Data Error


CB 6 Wrong Blade Motion


CB 8 Timeout


CB 10 Set Limits Fault

CB 11 Low Voltage

CB 12 Hours Lost

CB 13 Calibration Lost. Recalibrate

CB 14 Memory Error. Retune

CB 15 Memory Error. Factory Default

CB 16 Linked Mode Sensor Missing

CB 17 Internal Failure. Cycle Power

CB 18 Network Warning. Check

CB 19 Network Error. Check

CB 23 Unknown Device. Cycle Power

CB 24 Duplicate Left / Right Device

CB 25 Elevation Limit Left

CB 26 Elevation Limit Right

CB 27 Internal Failure. Cycle Power CB 28 Invalid Serial Number

CB 29 Disconnect Suspected

CB 30 Duplicate Sensor Serial Number

CB 31 Recalibrate Linked Mode Elevation

Display Code Messages


10/20

SPECIFICATIONS and RELATED MANUALS

Resistor , Sender and Solenoid Specifications¹)smhO(ecnatsiseRnoitpir cseDtnenopmoC.oNtr aP

:r edneS8207-541Hydraulic Oil Temperature

Powertrain Oil Temperature

33,650.2 @ -40°C (-40°F)

3,268.3 @ 0°C (32°F)

1,142.1 @ 22°C (71.6°F)

18.6 @ 150°C (302°F)

172-2392 Solenoid:Park Brake Dump

Service Brake Dump41.9 ± 2.1

174-4909 Solenoid:Left Steer Clutch & Right Steer Clutch

Left Steer Brake & Right Steer Brake8.7 ± 0.4

6.0±6.71hctulCC/ A:dioneloS6015-381

220-4324 Solenoid:Reverse Clutch & Forward Clutch

First Gear Clutch Second Gear Clutch and Third Gear Clutch8.7 ± 0.4

Related Electrical Service Manuals

Title Form Number

Alternator: 226-7683 SENR4130

0935RNEK:lor tnoCenignE

4102RNER:metsySgnir otinoMr allipr etaC

7638RNES:lor tnoCniar Tr ewoP

7908RNER:metsySr esaLedar gucc A

r ebmuNedoMecivr eS0ecneuqeSedoMr otar epO

1edoCssenr aH

2tuodaeRcir emuN

3ecivr eS

4elatelttaTlatigiD

5stinU

6)lor tnoCnoissimsnar T(1noitar bilaC



9yalpsiDmetsySgnigr ahC

r ebmuNedoMr otar epO

0r eteMecivr eS

1r etemodO

2r etemodOr aeGdr 3

3)citsongaiD(gnillor cS

Monitoring System Service Modes

Monitoring System Operator Modes


11/20


12/20

B

C

D

F

E

B

C

D

F

E

1234567

ABBREV

RD

WH

OR

YL

PK

BK

GY

PU

BR

GN

BU

COLOR

RED

WHITE

ORANGE

YELLOW

PINK

BLACK

GRAY

PURPLE

BROWN

GREEN

BLUE

COLOR ABBREVIATIONS

S YM BO L DE SC RI PT IO N

BLADE, SPADE, RING ORSCREW

TERMINAL

CIRCUITCONNECTED

CIRCUITNOT CONNECTED

ELECTRICALCONNECTIONTO

MACHINE STRUCTURE

INTERNALELECTRICALCONNECTION

TO SURFACE OF COMPONENT

CONNECTOR

ATCHWIRE, CABLE, COMPONENT

SPLICE

CIRCUITGROUPING DESIGNATIONH#

CALLOUTS

(52) VALVE GP - CONTROL 138-1234

Callout Number (MachineLocation from

Component LocationsTable)

Component

Name

Part Number

WIRE GROUP COLOR DESCRIPTIONS

GROUNDCIRCUIT

WIRES THAT HAVE SYSTEMVOL TAGE WHENTHE KEY SWITCHIS OFF

WIRES THAT HAVE SYSTEMVOL TAGE WHENTHE KEY SWITCHIS ON

MONITORCIRCUIT

INTEGRATED BRAKING CONTROL/ ACCUGRAGE / CAES CIRCUIT

CONN 9

CONN 10

CONN 15

CONN 15

CONN 17

CONN 12

CONN 26

CONN 34

CONN 30

CONN 31 CONN 32

CONN 33

CONN 15

CONN 29

(157) GPS RADIO

(151) CONTROL GP

(148) ANTENNA AS

(161) TERM RES B2

(156) RH ELECTRIC MAST

(160) RH LASER RECEIVER

(155) LH ELECTRIC MAST

(159) LH LASER RECEIVER

(150) BUZZER 2

(154) ACCUGRADE LASER DISPLAY CD610

(153) ACCUGRADE GPS DISPLAY CD700

(163) CAN D TERM RES RADIATOR 2

(162) CAN D TERM RES RADIATOR 1

(149) BLOWER AS

AL29 RD-14

AL29 RD-14

AL18 BU-10

AL18 BU-10 AL11 BU-10 AL11 BU-10

AL23 PK 18

AL23 PK-18 AL24 PK-18

AL13 WH-16

AL19 BR 18

AL12 BR-18

AL14 OR-18

AL7 BK-14

AL17 BK-14

AL10 GN-18

AL10 GN-18

AL15 GN 18

AL9 BK-14

AL9 BK-14 AL8 BK-14

AL8 BK-14

AL4 RD-14

AL3 RD-14

AL3 RD-14

AL6 RD-14

AL6 RD-14 AL2 RD-14

AL2 RD-14

AL1 RD-14

AL1 RD-14

AL30 OR-18

AL30 OR-18

AL31 BR-18

AL31 BR-18

AL25 BU-18

AL25 BU-18

AL26 GY-18

AL26 GY-18

AL27 YL-18

AL27 YL-18

AL28 BR-18

AL28 BR-18

AL30 OR-18

AL31 BR-18 AL25 BU-18

AL26 GY-18 AL27 YL-18 AL28 BR-18 AL6 RD-14 AL10 GN-18

CONNECTS TO WC-C1

VOLUME 1 @ E-12

CONNECTS TO AJ-C57VOLUME 1 @ E-12

WINCH

RD-18 WH-BK-18

WH-18

BK-18

YL-18

RD-18

GY-BK-18

GY-18

WH-BK-18

RD-18

WH-18

BK-18

YL-18

GY-BK-18

GY-18

RADIO ADAPTER HARNESS 16-PIN

CONNECTS TO H-C10VOLUME 1 @ C-11

RADIO JUMPER

SEAT JUMPER

AL-C13E3370

ABC

123

AB

AL-C61224386

CDEFGH

12

AL-C31552273

3456

REEL IN

X AXIS

Y AXIS

ENABLE

DECODE

+5V PWR RTN

+5V PWR OUT.

WN PWR

FLOW

ACC ISOLATION

SYSTEM FLOW

REEL IN

RDRDBUBU

WH/BK WH/BK

BR

12

AL-C21552264

3

45678

1

2

3

4

5

6

7

8

9

10

AE-C21728037

11

12

13

14

15

16

1

2

AE-C13E3388

3

4

5

6

7

8

ABCD

12

12

12

12

HEATER SWITCH

BACK HEATER

SEAT HEATER

SEAT SUSP

TRACTOR CABBKRD

RDYLBK

BKBU

YLBU

RDBK

SEAT JUMPER241-5786

116-LE1 BR-14-GXL

116-LE1 BR-14-GXL

200-LE2 BK-14-GXL

200-LE2 BK-14-GXL

N960-LE3 OR-18-GXL

N960-LE3 OR-18-GXL

N957-LE6 PK-18-GXL

N957-LE6 PK-18-GXL

K960-LE4 PK-18-GXL

K960-LE4 PK-18-GXL

N961-LE8 OR-18-GXL

N961-LE8 OR-18-GXL

N958-LE7 PK-18-GXL

K961-LE5 GN-18-GXL

K961-LE5 GN-18-GXL

ACCUGRADE RADIO(FOR GPS OPTION ONLY)

N958-LE7 PK-18-GXL

106-PL1 RD-18

106-PL1 RD-18

106-PL8 RD-18

106-PL8 RD-18 106-PL7 RD-18

106-PL7 RD-18

200-PL2 BK-18

200-PL2 BK-18

200-PL9 BK-18

200-PL9 BK-18

200-PL10 BK-18

200-PL10 BK-18

308-PL11 YL-18

308-PL11 YL-18

308-PL3 YL-18

308-PL3 YL-18

308-PL12 YL-18

308-PL12 YL-18

403-PL4 GN-18

403-PL4 GN-18

403-PL14 GN-18

403-PL14 GN-18

403-PL13 GN-18

403-PL13 GN-18

893-PL5 GN-18

893-PL5 GN-18

893-PL5 GN-18892-PL6 BR-18

892-PL6 BR-18

892-PL6 BR-18

N957-PL15 PK-18

N957-PL15 PK-18

N957-PL15 PK-18

N960-PL16 OR-18

N960-PL16 OR-18

N960-PL16 OR-18

N970-PL18 YL-18

N970-PL18 YL-18

N970-PL18 YL-18

N973-PL19 BR-18

N973-PL19 BR-18N973-PL19 BR-18N 97 9- PL 17 G N- 18 N 97 9- PL 17 G N- 18

N979-PL17 GN-18

PRODUCT LINK

CONNECTS TO AJ-C106

VOLUME 1 @ J-12

F712-PL20 GY-18

F712-PL20 GY-18

F712-PL20 GY-18

F711-PL21 GN-18

F711-PL21 GN-18

F711-PL21 GN-18

CONNECTS TO AJ-C61VOLUME 1 @ A-11

1

2

LE-C13E5179

3

4

5

6

7

8

9

10

11

12

A

B

LE-C21678987

C

D

E

F

G

H

A

B

C

D

E

F

G

H

+ BATTERY

GROUND

COM 2 TXD

COM 2 RXD

CAN 1 +

COM 1 TXD

COM 1 RXD

CAN 1 -

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

PL-C31607690

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

4041

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

CAT DATALINK +

239-9954

CAT DATALINK -

RXD COMM #1

TXD COMM #1DTR COMM #1

DCD COMM #1SIGNAL GND COMM #1

+ BATT

ALTERNATOR R-TERM

KEYSWITCH RUN

GND

B+

+ BATT

GND

KEYSWITCH RUN

PS121SR263-9088

RXD COMM #1

SIGNAL GND COMM #1

TXD COMM #1

DTR COMM #1

DCD COMM #1

1

2

PL-C21552252

3

4

5

6

7

8

9

10

11

12

284-8532

1

2

PL-C12312300

3

4

5

6

7

8

T744-AM108 WH-14-GXL

T744-AM108 WH-14-GXLT744-AM153 WH-14-GXL




T744-AM78 WH-14-GXL

T744-AM78 WH-14-GXL



L872-AM109 BU-14-GXL

L872-AM109 BU-14-GXL L872-AM77 BU-14-GXL

L872-AM77 BU-14-GXL





T745-AM110 YL-14-GXL

T745-AM110 YL-14-GXL T745-AM122 YL-14-GXL




L873-AM111 GY-14-GXL




L873-AM37 GY-14-GXL

L873-AM37 GY-14-GXL

K961-AM114 GN-18-GXL



K961-AM62 GN-18-GXL







K961-AM64 GN-18-GXL

K961-AM64 GN-18-GXL

K960-AM115 PK-18-GXL



K960-AM61 PK-18-GXL







K960-AM63 PK-18-GXL

K960-AM63 PK-18-GXL

T744-AP1 WH-14-GXL

T744-AP1 WH-14-GXL

L872-AP2 BU-14-GXL

L872-AP2 BU-14-GXL

T745-AP3 YL-14-GXL

T745-AP3 YL-14-GXL

L873-AP4 GY-14-GXL

L873-AP4 GY-14-GXL

K961-AP7 GN-18-GXL

K961-AP7 GN-18-GXL

K960-AP8 PK-18-GXL

K960-AP8 PK-18-GXL

L872-AT1 BU-16-GXL

L872-AU1 BU-16-GXL

T744-AT2 WH-16-GXL

T744-AU2 WH-16-GXL

T744-AU5 WH-16-GXL

T745-AT9 YL-16-GXL

T745-AU9 YL-16-GXL

L873-AT10GY-16-GXL

L873-AU10GY-16-GXL

L855-AT4 GN-18-GXL

L855-AU4 GN-18-GXL

L854-AU3 YL-18-GXL

L854-AT3 YL-18-GXL

L873-AT10 GY-16-GXL

T745-AT9 YL-16-GXL

L855-AT4 GN-18-GXL

L854-AT3 YL-18-GXL

T744-AT2 WH-16-GXL

L872-AT1 BU-16-GXL

L873-AU10GY-16-GXLT745-AU9 YL-16-GXL

T744-AU5 WH-16-GXL

L855-AU4 GN-18-GXLL854-AU3 YL-18-GXL

T744-AU2 WH-16-GXL

L872-AU1 BU-16-GXL

T744-AF2 WH-16-GXLK960-AF3 PK-16-GXL

K961-AF4 GN-16-GXL

L872-AF1 BU-16-GXL

BLADE INCLINATIONSENSOR INTERFACE

K960-AH35 PK-18-GXL

K961-AH8 GN-18-GXLY787-AH10 WH-18-GXLY788-AH11 GY-18-GXL

ACCUGRADE LASER DISPLAY

200-AH30 BK-18-GXL

200-AH17 BK-18-GXL

L871-AH34 BU-18-GXL

E752-AH4 YL-18-GXLE753-AH5 WH-18-GXL

A487-AH50 PU-18-GXL250-AH51 BK-18-GXL

200-AH2 BK-14-GXL

L870-AH33 YL-18-GXL

Y788-AH11 GY-18-GXLY787-AH10 WH-18-GXL

K961-AH8 GN-18-GXLK960-AH35 PK-18-GXLE753-AH5 WH-18-GXLE752-AH4 YL-18-GXL

116-AH1 BR-14-GXL

200-AH30 BK-18-GXL200-AH17 BK-18-GXL

250-AH51 BK-18-GXL A487-AH50 PU-18-GXL

116-AH1 BR-14-GXL200-AH2 BK-14-GXL

K961-AH8 GN-18-GXLK960-AH35 PK-18-GXL

L870-AH33 YL-18-GXLL871-AH34 BU-18-GXL

E752-AH4 YL-18-GXLE753-AH5 WH-18-GXL

Y787-AH10 WH-18-GXLY788-AH11 GY-18-GXL

L870-AH33 YL-18-GXL

X868-AH57 PU-18-GXL

X868-AH57 PU-18-GXL

893-AH7 GN-18-GXL

893-AH7 GN-18-GXL

893-AH7 GN-18-GXL

892-AH6 BR-18-GXL

892-AH6 BR-18-GXL

892-AH6 BR-18-GXL

L871-AH56 BU-18-GXL

L871-AH56 BU-18-GXL

L871-AH58 BU-18-GXL

L871-AH58 BU-18-GXL

116-AH32 BR-18-GXL

116-AH32 BR-18-GXL

116-AH60 BR-18-GXL

116-AH60 BR-18-GXL

200-AH61 BK-18-GXL

200-AH61 BK-18-GXL

647-AH62 GN-18-GXL

647-AH62 GN-18-GXL

647-AH62 GN-18-GXL

USE IF ADVISORSHOULD CONTROLPM400 ON/OFF

USE IF PM400SHOULD ALWAYSBE ON

USE IF CD700SHOULD CONTROLPM400 ON/OFF

CONNECT TO CJ-C2 WHEN ADVISOR IS USED

VOLUME 2 @ D-4

L871-AH59 BU-18-GXL

H12

A487-AH63 PU-18-GXL

250-AH64 BK-18-GXL

L871-AH59 BU-18-GXL

L871-AH59 BU-18-GXL

K960-CT35 PK-18-GXL

K960-CT35 PK-18-GXL

K960-CT35 PK-18-GXL

K961-CT8 GN-18-GXL

K961-CT8 GN-18-GXL

K961-CT8 GN-18-GXL

Y787-CT10 WH-18-GXL

Y787-CT10 WH-18-GXL

Y787-CT10 WH-18-GXL

Y788-CT11 GY-18-GXL

Y788-CT11 GY-18-GXL

Y788-CT11 GY-18-GXL

N957-CT14 PK-18-GXL

N957-CT14 PK-18-GXL

N957-CT14 PK-18-GXL

N958-CT12 PK-18-GXL

N958-CT12 PK-18-GXL

N958-CT12 PK-18-GXL

N960-CT15 OR-18-GXL

N960-CT15 OR-18-GXL

N960-CT15 OR-18-GXL

N961-CT13 OR-18-GXL

N961-CT13 OR-18-GXL

N961-CT13 OR-18-GXL

ACCUGRADE GPS DISPLAY (ATCH)

116-CT1 BK-14-GXL 116-CT1 BK-14-GXL

200-CT2 BK-14-GXL

200-CT2 BK-14-GXL 200-CT30 BK-18-GXL

200-CT30 BK-18-GXL

200-CT32 BK-18-GXL

200-CT32 BK-18-GXL

200-CT17 BK-18-GXL

200-CT17 BK-18-GXL

L870-CT33 YL-18-GXL

L870-CT33 YL-18-GXL

L870-CT33 YL-18-GXL

L871-CT34 BU-18-GXL

E753-CT5 WH-18-GXL

E753-CT5 WH-18-GXL

E753-CT5 WH-18-GXL

E752-CT4 YL-18-GXL

E752-CT4 YL-18-GXL

E752-CT4 YL-18-GXL

N976-CT45 PU-18-GXL

N976-CT45 PU-18-GXLN976-CT45 PU-18-GXL

N967-CT46 GY-18-GXL

N967-CT46 GY-18-GXL

N967-CT46 GY-18-GXL

200-CT58 BK-18-GXL

200-CT58 BK-18-GXL

116-CT61 BR-18-GXL

116-CT61 BR-18-GXL

116-CT60 BR-18-GXL

116-CT60 BR-18-GXL

116-AP9 BR-14-GXL

116-AP9 BR-14-GXL216-AP10 BK-14-GXL

216-AP10BK-14-GXL

ACCUGRADE

SERVICE CONNECTOR

216-AM2 BK-14-GXL

216-AM2 BK-14-GXL

216-AM2 BK-14-GXL

116-AM1 BR-14-GXL

116-AM1 BR-14-GXL

116-AM1 BR-14-GXL

K961-AM3 GN-18-GXL

K960-AM4 PK-18-GXL K960-AM6 PK-18-GXL

K960-AM6 PK-18-GXL

K961-AM5 GN-18-GXL

K961-AM5 GN-18-GXL

200-RP1 BK-14-GXL

515-RP2 GY-14-GXL

516-RP5 GN-14-GXL

517-RP6 BU-14-GXL

C568-RP7 WH-14-GXL

515-RP3 GY-14-GXL

515-RP4 GY-14-GXL

200-RP1 BK-14-GXL

515-RP2 GY-14-GXL

516-RP5 GN-14-GXL

517-RP6 BU-14-GXL

C568-RP7 WH-14-GXL

200-RP1 BK-14-GXL

515-RP3 GY-14-GXL

515-RP4 GY-14-GXL

516-RP5 GN-14-GXL

517-RP6 BU-14-GXL

C568-RP7 WH-14-GXL

OROPS HVAC

L856-AT5 YL-18-GXL

L856-AT5 YL-18-GXL

L857-AT6 GN-18-GXL

L857-AT6 GN-18-GXL

L857-AU7 GN-18-GXL

L857-AU7 GN-18-GXL

L856-AU6 YL-18-GXLL856-AU6 YL-18-GXL

L856-AM7 YL-18-GXL

L856-AM8 YL-18-GXL

L856-AM7 YL-18-GXL

L856-AM11 YL-18-GXL

L856-AM10 YL-18-GXL

L856-AM9 YL-18-GXL

L856-AM11 YL-18-GXL

L856-AM10 YL-18-GXL

L856-AM9 YL-18-GXL

L857-AM12 GN-18-GXL

L857-AM13 GN-18-GXL

L857-AM14 GN-18-GXL L857-AM15 GN-18-GXL

L857-AM16 GN-18-GXL

L857-AM13 GN-18-GXL

L857-AM12 GN-18-GXL

L857-AM15 GN-18-GXL

L857-AM16 GN-18-GXL

X868-AH57 PU-18-GXL

TWISTED PAIR

A101-CJ1 GN-14

200-CJ2 BK-14

L872-CJ3 BU-14

T744-CJ4 WH-14

110-CJ5 RD-14

N957-CJ6 PK-18

N960-CJ7 OR-18

L870-CJ8 YL-18

L871-CJ9 BU-18

L854-CJ10 YL-18

L855-CJ11 WH-18

600-CJ12 BR-18

E752-CJ13 YL-18

E753-CJ14 GN-18

893-CJ15 GN-18

892-CJ16 BR-18

L856-CJ17 YL-18

L857-CJ18 GN-18

N958-CJ19 PK-18

N961-CJ20 OR-18

N976-CJ21 PU-18

N967-CJ22 GY-18

ACCUGRADE JUMPER

CONNECTS TO AJ-C64 WHEN ADVISOR IS USED

VOLUME 1 @ B-11

CONNECT TO AH-C1 WHEN ADVISOR IS USED

VOLUME 2 @ F-3

OR

CONNECT TO CT-C1 WHEN DISPLAY IS USED

VOLUME 2 @ D-3

CANOPY ONLY

L871-CT34 BU-18-GXL

L871-CT57 BU-18-GXL

L871-CT57 BU-18-GXL 200-CT56 BK-18-GXL

200-CT56 BK-18-GXL

TWISTED PAIR

CONNECTS TO AJ-C58VOLUME 1 @ F-5

CONNECT TO CJ-C2 WHEN DISPLAY IS USED

VOLUME 2 @ D-4

AM-C61740502

A

B

C

134-2540

A

B

AT-C22302566

C

D

E

F

G

H

I

J

A

B

AU-C22302566

C

D

E

F

G

H

I

J

RG-C1 AB

RG-C2

C

D

E

F

G

H

I

J

CAN 0 HIGH

CAN O LOW

SWITCHED POWER

CAN 0 LOW

SWITCHED POWER RTN

SWITCHED POWER RTN

226-2333

SWITCHED POWER RTN

SWITCHED POWER RTN

SWITCHED POWER

NC

NC

SWITCHED POWER

CAN 0 HIGH

SWITCHED POWER RTN

SWITCHED POWER RTN

SWITCHED POWER RTN

RD-14BU-20GN-20 WH-20BR-20BK-20GY-14OR-14


RD-20BU-20GN-20 WH-20BR-20BK-20

RD-20BU-20GN-20 WH-20BR-20BK-20

A

B

RL-C1

C

D

E

F

A

B

RL-C2

C

D

E

F

CAN 0 HIGH

SWITCHED POWER

CAN 0 LOW

226-2334

SWITCHED POWER RTN

SWITCHED POWER RTN

SWITCHED POWER RTN

RE-C1 AB

RE-C2

C

D

E

F

G

H

I

J

CAN 0 HIGH

CAN O LOW

SWITCHED POWER

CAN 0 LOW

SWITCHED POWER RTN

SWITCHED POWER RTN

226-2333

SWITCHED POWER RTN

SWITCHED POWER RTN

SWITCHED POWER

NC

NC

SWITCHED POWER

CAN 0 HIGH

SWITCHED POWER RTN

SWITCHED POWER RTN

SWITCHED POWER RTN



RD-20BU-20GN-20 WH-20BR-20BK-20

RD-20BU-20GN-20

WH-20BR-20BK-20

A

B

RH-C1

C

D

E

F

A

B

RH-C2

C

DE

F

CAN 0 HIGH

SWITCHED POWER

CAN 0 LOW

226-2334

SWITCHED POWER RTN

SWITCHED POWER RTN

SWITCHED POWER RTN

A

B

AF-C22302566

C

D

E

F

G

H

I

J

167-8712

AH-C31552267

A

B

C

BATTERY+BATTERY-KEYSWITCH

CDL+CDL-

CAN B-CAN D+CAN D-

COM 1 TXCOM 1 RXCOM 1 GND

CAN B+

ALARM ALARM RET AWAKE AWAKE RETURN

282-8241

CHASSIS GND

DIMMING

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

AH-C21471444

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

MPT 1253-7456

JUMPER251-7591

RECEPTACLE3E-3370

1

2

AH-C11673693

3

4

5

6

7

8

10

11

12

13

14

15

1617

18

19

20

21

22

9

23

24

25

26

27

28

29

30

31

1

2

AM-C22305008

3

4

AF-C12305009

1

2

AH-C42304011

1

2

AH-C52304012

A

B

C

D

E

F

G

H

J

K

L

M

N

P

R

S

T

U

V

W

X

Y

Z

AA

CT-C22485358

BB

CC

DD

EE

FF

GG

HH

II

JJ

KK

MM

NN

PP

QQ

RR

GND

B+

244-1716

RS-232 RXD 2

CAN D -

CAN B -

CAN B +

CAN D +

RS-232 TXD 2

RS-232 SGND 1

RS-232 SGND 2

RS-232 RXD 1

RS-232 TXD 1

B+

RS-232 CTS 0

RS-232 RTS 0

RS-232 TXD 0

RS-232 RXD 0

AWAKE

AWAKE RTN

CHASSIS GND

RS-232 SGND 0

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

CT-C11673693

25

26

27

28

29

30

31

A

B

AM-C78T8736

C

D

E

F

G

H

J

1

2

3

4

5

6

7

8

AP-C12312300

1

2

AP-C22312295

3

4

5

6

7

8

AM-C42312300

1

2

RP-C11552269

1

2

3

4

5

6

RP-C23E3382

134-2540

134-2540

AM-C91740502

A

B

C

AM-C81740502

A

B

C

1

2

3

4

5

6

7

8

AT-C12312300

1

2

3

4

5

6

7

8

9

10

11

12

AU-C12304010

AM-C12312295

AM-C32304009

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

CJ-C11673693

25

26

27

28

29

30

31

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

CJ-C21673692

25

26

27

28

29

30

31

1

2

RP-C36A5277

3

4

322-7212

MOTOR

LOWSPEED

MEDIUMSPEED

HIGHSPEED

MED-HISPEED

1

23

4

YL-14

OR-14

BU-14

RD-14

BLOWER MOTOR

BLOWER SPEED RESISTOR

WH/RD-14

BK-14

ACCUGRADE

ANTENNA GSM346-9376

GSM ANT

GSMGPS

GPS ANT

PL-SAT239-9954

PL-GSM351-8490


13/20

©2010 Caterpillar, All Rights Reserved

CHASSIS VIEW - LH

164

163

162

161

151

149

144

132

131123

71

68

61

50

49

48

47

35

34

2928

26

24

21

16

13

12 10

8

765

1

CONN 34

CONN 33

CONN 32

CONN 31

CONN 30CONN 29

CONN 27CONN 26

CONN 25

CONN 24

CONN 23

CONN 11

Item Not Shown

27

VIEW ALL CALLOUTS


15/20

2010 Caterpillar, All Rights Reserved©

CAB WIRING

Items Not Shown

Item Not Shown

158148

6458

56 55

45

44

43

42

41

39

38

37

259

3

2

CONN 18 CONN 17

CONN 15CONN 14

CONN 13

CONN 12CONN 8

CONN 5

VIEW ALL CALLOUTS


16/20


PILOT STATION

154

153

150

147

145

143

142

141

139

135

134

127126

125

124

122

121

120

118 83

77

7557

54

5351 31

20

15

14

CONN 22

CONN 21

CONN 20

CONN 19

VIEW ALL CALLOUTS


17/20


CONTROL VALVE LOCATIONS

140

117

115

114

113

112

111

110

109

102

10099

96

9594

93

92

91

87 8684

62

CONN 10

CONN 7

CONN 6

CONN 4

CONN 3

VIEW ALL CALLOUTS


18/20


ENGINE LH VIEWS

136

129

128

108107

106105104103

101

89

8281 80 79

78

7674

7372

63

46

40

22

17

CONN 28

VIEW ALL CALLOUTS


19/20


ENGINE RH VIEW

138137

119

116

98

97

90

8567

59

23

4

VIEW ALL CALLOUTS


20/20


ACCUGRADE

160

Items Not Shown

159

Items Not Shown

156Items Not Shown

155

Items Not ShownCONN 9

Item Not Shown(@ Winch Location)

VIEW ALL CALLOUTS

Date post:	06-Jul-2018
Category:	Documents
Upload:	keiber-bastos
View:	360 times
Download:	10 times

Diagrama Electrico D6N

Documents