+ All Categories
Home > Documents > Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters...

Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters...

Date post: 09-Aug-2020
Category:
Upload: others
View: 12 times
Download: 0 times
Share this document with a friend
43
Fuel Filtration Engine Liquid Filtration 23 www.donaldson.com FUEL FILTRATION Overview ......................................................................................................... 24-34 Typical Diesel Engine Fuel Circuit ........................................................................ 24 Harmful Contaminants Found in Fuel Systems .................................................. 25 Filter Media ............................................................................................................ 26 Frequently Asked Questions ................................................................................ 30 Biodiesel Fuel Awareness ..................................................................................... 31 Clean Fuel Carts .................................................................................................... 33 Clean Diesel Kits .................................................................................................... 34 Filtration Systems Standard or Modular Filter & Head Designs.............. 35-56 76mm / 3.0" dia. x M16-1.5 Flow Range up to 30 gph / 114 lph ....................................................... 36 80mm / 3.15" dia. x M94-3 Flow Range up to 60 gph / 227 lph....................................................... 39 93mm / 3.54" dia. x M92-2.5 Flow Range up to 90 gph / 341 lph....................................................... 41 93mm / 3.54" dia. x 1 3/16"-12 Flow Range up to 90 gph / 341 lph....................................................... 44 93mm / 3.54" dia. x 1"-14 Flow Range up to 160 gph / 606 lph..................................................... 47 108mm / 4.25" dia. x 1¼"-12 Flow Range up to 180 gph / 681 lph..................................................... 51 118mm / 4.65" dia. x 1¼"-12 Flow Range up to 250 gph / 946 lph..................................................... 53 118mm / 4.65" dia. x 1 1/16"-16 Flow Range up to 250 gph / 946 lph..................................................... 55 Water Drain Valves, Sensors & Bowl.................................................................. 57 Fuel Filters ....................................................................................................... 59-71 Spin-on Filters ....................................................................................................... 59 Stanadyne ® FM100 System Fuel Water Separators ............................................ 64 Cartridge Filters ..................................................................................................... 65 DAVCO ® Fuel System Filters ................................................................................. 67 Metal-Free Fuel Filters........................................................................................... 67 Racor ® Turbine System Filters............................................................................... 67 Box-Style Cartridge Filters .................................................................................... 68 In-Line Fuel Filters ................................................................................................. 69 Filter Kits............................................................................................................... 72 Twist&Drain Filter Kits........................................................................................... 72 Australia Filter Kits ................................................................................................. 74 Donaldson Blue™DBF5782 ................................................................................. 76 AdBlue Filter Kits ................................................................................................. 78
Transcript
Page 1: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Fuel Filtration

Engine Liquid Filtration • 23 www.donaldson.com

FUEL FILTRATION

Overview .........................................................................................................24-34Typical Diesel Engine Fuel Circuit ........................................................................ 24Harmful Contaminants Found in Fuel Systems .................................................. 25Filter Media ............................................................................................................ 26Frequently Asked Questions ................................................................................ 30Biodiesel Fuel Awareness ..................................................................................... 31Clean Fuel Carts .................................................................................................... 33Clean Diesel Kits .................................................................................................... 34

Filtration Systems – Standard or Modular Filter & Head Designs ..............35-5676mm / 3.0" dia. x M16-1.5 Flow Range up to 30 gph / 114 lph ....................................................... 3680mm / 3.15" dia. x M94-3 Flow Range up to 60 gph / 227 lph ....................................................... 3993mm / 3.54" dia. x M92-2.5 Flow Range up to 90 gph / 341 lph ....................................................... 4193mm / 3.54" dia. x 1 3/16"-12 Flow Range up to 90 gph / 341 lph ....................................................... 4493mm / 3.54" dia. x 1"-14 Flow Range up to 160 gph / 606 lph ..................................................... 47108mm / 4.25" dia. x 1¼"-12 Flow Range up to 180 gph / 681 lph ..................................................... 51118mm / 4.65" dia. x 1¼"-12 Flow Range up to 250 gph / 946 lph ..................................................... 53118mm / 4.65" dia. x 1 1/16"-16 Flow Range up to 250 gph / 946 lph ..................................................... 55

Water Drain Valves, Sensors & Bowl .................................................................. 57

Fuel Filters .......................................................................................................59-71Spin-on Filters ....................................................................................................... 59Stanadyne® FM100 System Fuel Water Separators ............................................ 64Cartridge Filters ..................................................................................................... 65DAVCO® Fuel System Filters ................................................................................. 67Metal-Free Fuel Filters ........................................................................................... 67Racor® Turbine System Filters ............................................................................... 67Box-Style Cartridge Filters .................................................................................... 68In-Line Fuel Filters ................................................................................................. 69

Filter Kits ............................................................................................................... 72Twist&Drain Filter Kits ........................................................................................... 72Australia Filter Kits .................................................................................................74

Donaldson Blue™DBF5782 ................................................................................. 76

AdBlue Filter Kits ................................................................................................. 78

Page 2: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 33 www.donaldson.com

FUEL FILTRATION

Clean Fuel Carts Filter Anywhere

Compact, mobile carts are great for fuel transfers and kidney looping. Use it in your workshop, with in-plant machinery, or with mobile equipment to achieve and maintain the ISO cleanliness standards of your fuel.

X011431 24-volt Clean Fuel CartThe X011431 features a high-quality 24/12V DC PIUSI® Panther pump for up to 21 gpm/80 lpm single-pass or kidney-looped filtration.

X011407 AC Clean Fuel CartThe X011407 features a high-quality 120V-AC PIUSI Panther® 56 pump for up to 15 gpm/56 lpm single-pass or kidney-looped filtration.

X011408 12-volt DC Clean Fuel CartThe X011408 features a high-quality 12V DC PIUSI Panther® pump for up to 16 gpm/60 lpm single-pass or kidney-looped filtration.MyCleanDIESEL com

MyCleanDIESEL com

MyCleanDIESEL com

You depend on diesel for the success of your operations. You want to understand solutions before you see problems.

Visit MyCleanDiesel.com to learn how clean diesel can help you Achieve More™.

• Learn the essentials of “clean diesel”: - What is clean diesel? - Why is clean diesel needed? - How do I get clean diesel?

• Learn how to Achieve More™ - Reduce unplanned downtime - Meet or exceed service intervals - Optimize fuel efficiency, power, and

emissions - Prevent rapid filter plugging

• Understand global emissions regulations and why they matter

• Engine technologies such as high pressure common rail (HPCR)

• Understand additives are typically added to diesel and why?

• Learn how fuel is delivered from the refinery to your tank and why it matters

• Find relevant, diverse, new case studies• Find up to date reference information/websites• Discover FAQs from people like you who depend

diesel for the success of their operation• Find a solution for your problem• Understand the solutions before you see the

problems• Contact the global Clean Fuels team in your area-

get almost immediate responses• Recognize and solve your diesel-related

problems• Find relevant how-to information

- Taking good samples - Patch testing to measure cleanliness - Changing filters

Fuel FiltrationClean Fuel Carts

Page 3: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

34 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ON

Donaldson Clean Diesel Kits are the answer to all your fuel cleanliness worries. You can’t always control the cleanliness of diesel fuel delivered to you, but you can control how clean it is when you pump into your vehicles and equipment.

Donaldson Clean Diesel Kits are easy to install on any fuel dispenser and come with everything needed to filter out even the finest contaminants before they enter your equipment’s fuel system. With the included easy-to-follow, step-by-step instructions, you’ll have effective, efficient filtration in minutes.

Every Clean Diesel Kit helps protect your engines, reduce your maintenance costs and prevent unplanned and costly downtime.

Additionally, each kit:

• Provides filtration to ISO 14/13/11 diesel cleanliness in a single pass

• Is recommended for all diesel and biodiesel blends

Clean Diesel Kits Clean Fuel In Minutes

ISO 14/13/11

X011450 High Capacity Kit includes dual head, high efficiency diesel filters (2), pressure gauge and flange adaptors.For flow rates up to 125 GPM / 473 LPM

X011448 Basic Kit includes single head, high efficiency diesel filter and pressure gauge.For flow rates up to 65 GPM / 246 LPM

X011449 Clean & Dry Kit includes single head (2), high efficiency diesel filter, water absorbing filter, pressure gauge (2) and T.R.A.P.™ breather. For flow rates up to 50 GPM / 189 LPM

Fuel FiltrationClean Diesel Kits

Page 4: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 35 www.donaldson.com

FUEL FILTRATION

Filtration Systems – Standard or Modular DesignsThe following pages are Donaldson’s catalog product offering for Fuel Assemblies with and without water separation. Within each range there are multiple head assembly and filter choices - including performance and water removal/drain options. Consult Donaldson for a custom solutions.

Use the matrix below to determine the filtration system that best matches your fuel flow requirements, key design requirements and mounting configuration on your engine.

There are multiple filter choices (with and without water separation) within each product families. The flow range values are for fuel filter water separator filtration systems. The flow range will be higher if applying a non-water separating filter. Families identified as "modular" should be considered if you're interested in priming pumps and other add-on components.

Donaldson recommends multiple assemblies in parallel for engine applications with higher flow ranges and horsepower (kilowatt).

Mix and Match Fuel Filter Systems

Families by Filter Diameter φ

Flow Range Note: flow ranges listed are for water separating applica-tions. Non-water separating designs will go higher.

Features

76 mm / 3.00" up to 30 gph / 114 lph Standard design, side mount, single port heads, spin-on filters

80 mm / 3.15" up to 60 gph / 227 lph Modular design, side mount, dual port heads, spin-on filters

93 mm / 3.54" up to 90 gph / 341 lph Modular design, side mount, dual port heads, spin-on filters

Standard design, top mount, single port heads, spin-on filters

up to 160 gph / 606 lph Standard design, side mount, single port head, spin-on filter (no water sep)

108 mm / 4.25" up to 180 gph / 881 lph Standard design, side mount, three port head, spin-on filters

118 mm / 4.65" up to 250 gph / 946 lph Standard design, side mount, single port heads, spin-on filters

Fuel Filtration System Application Matrix

How Donaldson Displays Filter Flow versus Pressure Loss Data

Performance Curve Notes

• Pressure loss was tested per the ISO 3968 standards.

• All flow measurements were made with Ultra Low Sulfur Diesel (ULSD at 80°F (26.6°C).

• Test conducted with a sample size of three filters.

• Filter performance curves will list an alpha reference (see circled areas on chart). These labels correspond with the filter choice tables.

Filter Assembly or Head Performance Reference

Fuel FiltrationFiltration Systems

Max Flow 15 gpm / 57 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

2.5

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.40

0.0 5.0 10.0 15.0 20.0 25.0 30.0 35.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel - Restriction76mm x M16 1.5 Fuel Restriction

© D

onal

dson

Com

pany

, Inc

.

Max Flow 30 gpm / 114 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

0

0.05

0.1

0.15

0.2

0.25

0.3

0 5 10 15 20 25 30 35

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

C

D

0 15 30 45 60 75 90

0

0.2

0.4

0.6

0.8

1

1.2

1.4

1.6

0.00

0.05

0.10

0.15

0.20

0.25

0.0 5.0 10.0 15.0 20.0 25.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

A

B

Example

Page 5: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

36 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Fuel FiltrationFilter Dia. 76 MM (3.0") x M16-1.5

Spin-on Fuel Filter

Spin-on Fuel Filter

Water Separator

Operating Pressure0-100 psi (690 kPa) without bowl

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 30 gph / 114 lph

See table for filter flow rates

Fuel Compatibility#1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Water Removal @ Recommended Flow Rate SAE J1488 Emulsified: 95% efficiency

SAE J1839 Free Water: 95% efficiency

Air Bleed VentBleed options available

Part No. P5603821/4"-18 NPT Ports (2)

Part No. P5622631/2"-20 UNF Ports (2)

Flow Range: up to 30 gph / 114 lph

Optional Clear Water Collection Bowl

Part No. P569758

Standard Twist&Drain Valve Twist&Drain Valve

1/2"-20 UNF Threaded Sensor Port

Part No. P550865Twist&Drain Valve with Passive Water-in-Fuel Sensor

Packard Terminal Part No. P570618

Deutsch Terminal Part No. P570619

Twist&Drain Valve with Digital Water-in-Fuel Sensor

Tyco/AMP Terminal Part No. P572227

Deutsch Terminal Part No. P570349

Page 6: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 37 www.donaldson.com

FUEL FILTRATIONFuel Filtration

Filter Dia. 76 MM (3.0") x M16-1.5

Two Mounting Holes .34" / 8.6 mm Bleed

Valve

Part No. P5603821/4”-18 NPT Ports (2)

Part No. P5622631/2"-20 UNF Ports (2)

Two Mounting Holes .34" / 8.6 mm

76 mm / 3.00"

Specification Illustrations

Page 7: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

38 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ON

Performance Curves

76 MM (3.0") x M16-1.5 Filter AssemblyMax Flow 25-30 gph / 95-114 lph

Fuel FiltrationFilter Dia. 76 MM (3.0") x M16-1.5

0

0.5

1

1.5

2

2.5

0 20 40 60 80 100 120

0.00

0.02

0.04

0.06

0.08

0.10

0.12

0.14

0.16

0.18

0.20

0.0 5.0 10.0 15.0 20.0

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Filters OnlyMax Flow 15 gpm /57 lph

© D

onal

dson

Com

pany

, Inc

.

A

B

0 20 40 60 80 100 120

0

0.5

1

1.5

2

2.5

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.40

0.0 5.0 10.0 15.0 20.0 25.0 30.0 35.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

Max Flow 30gpm /114 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

0

0.05

0.1

0.15

0.2

0.25

0.3

0 5 10 15 20 25 30 35

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

CD

76 MM (3.0") x M16-1.5 Filter AssemblyMax Flow 15 gph / 57 lphMax Flow 15 gpm / 57 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

2.5

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.40

0.0 5.0 10.0 15.0 20.0 25.0 30.0 35.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel - Restriction76mm x M16 1.5 Fuel Restriction

© D

onal

dson

Com

pany

, Inc

.

Max Flow 30 gpm / 114 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

0

0.05

0.1

0.15

0.2

0.25

0.3

0 5 10 15 20 25 30 35

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

C

D

0 15 30 45 60 75 90

0

0.2

0.4

0.6

0.8

1

1.2

1.4

1.6

0.00

0.05

0.10

0.15

0.20

0.25

0.0 5.0 10.0 15.0 20.0 25.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

A

B

76 MM (3.0") x M16-1.5 Heads OnlyMax Flow 30 gph / 114 lph

0

0.5

1

1.5

2

2.5

0 20 40 60 80 100 120

0.00

0.02

0.04

0.06

0.08

0.10

0.12

0.14

0.16

0.18

0.20

0.0 5.0 10.0 15.0 20.0

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Filters OnlyMax Flow 15 gpm /57 lph

© D

onal

dson

Com

pany

, Inc

.

A

B

0 20 40 60 80 100 120

0

0.5

1

1.5

2

2.5

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.40

0.0 5.0 10.0 15.0 20.0 25.0 30.0 35.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

Max Flow 30gpm /114 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

0

0.05

0.1

0.15

0.2

0.25

0.3

0 5 10 15 20 25 30 35

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

CD

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C) Filter Length* Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearance

gph lph in mm in mm

Standard Drain 15 57 4.01 102 Treated Cellulose 99% @ 15 No P551039 B

.93 24

30 114 5.81 148

Treated Cellulose 99% @ 11 No P550588 C

Synteq 99% @ 3 No P551615 N/A

Treated Cellulose 99% @ 15 Yes P550248 C

No Drain15 57 3.26 83

Cellulose 99% @ 16 No P550345 B

Cellulose 99% @ 9 No P555095 A

25 95 4.72 120Cellulose 99% @ 16 Yes P553004 C

Cellulose 99% @ 9 No P550943 C

30 114 4.72 120 Cellulose 99% @ 16 Yes P550440 D

* Water Collection Bowl (part no. P569758) adds 1.98" / 50 mm to filter length.

Page 8: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 39 www.donaldson.com

FUEL FILTRATIONOperating Pressure*0-14.5 psi (100 kPa) with hand pump

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 60 gph / 227 lphNote: Maximum flow rate may be exceeded

(up to 400 lph) for non water-separating applications

Fuel Compatibility#1 or #2 Diesel, KeroseneBiodiesel up to B100

MountingEngine or Chassis

Clean Pressure Drop (Restriction)At recommended flow rate without check-valve and priming pump

Water Removal SAE J1488 Emulsified: 95% efficiency

SAE J1839 Free Water: 95% efficiency

Air Bleed ValveAutomatic or manual

Electric Heating Options12V or 24V

Thermocouple heater rod, or PTC (Positive Temperature Coefficient) heater plate

Porting Size Options Custom port configuration options: 1/2 - 20 SAE 9/16 - 18 SAE M14x1.5 mm

Pump OptionsElectronic Transfer Pump: 12V or 24V brushed or brushless motor typesHand Priming Pump

Media OptionsCustom performance packaging with advanced Synteq XP media technology, Synteq or standard cellulose media* Dependent on application and configuration

Spin-on

Fuel Filter Water

Separator

Spin-on

Fuel Filter

Transparent, Non-Metal Fuel Filter

Water Separator

Basic Head

Fuel FiltrationFilter Dia. 80 MM (3.15") x M94-3

Flow Range: up to 60 gph / 227 lph

Head with Hand Priming Pump

Optional Heater Rod

Optional Clear Water Collection Bowl

Part No. P569758

Standard Twist&Drain Valve Twist&Drain Valve

1/2"-20 UNF Threaded Sensor Port

Part No. P550865Twist&Drain Valve with Passive Water-in-Fuel Sensor

Packard Terminal Part No. P570618

Deutsch Terminal Part No. P570619

Twist&Drain Valve with Digital Water-in-Fuel Sensor

Tyco/AMP Terminal Part No. P572227

Deutsch Terminal Part No. P570349

Page 9: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

40 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Lead Time NoteThis product is configured with the specifications and features of your choice.

Please contact your Donaldson representative for more details.

Fuel FiltrationFilter Dia. 80 MM (3.15") x M94-3

Specification Illustrations

MULTIPLE HOUSING STYLE OPTIONS - Metal Spin-On for Secondary Filtration - Metal Spin-On Fuel Filter Water Separator - Transparent Non-Metal Housing w/Cartridge Filter

MULTIPLE STYLE DRAIN VALVES AND WIFS OPTIONSCLEAR WATER COLLECTION BOWL AVAILABLE

MULTIPLE HOUSING STYLE OPTIONS - Metal Spin-On for Secondary Filtration - Metal Spin-On Fuel Filter Water Separator - Transparent Non-Metal Housing w/Cartridge Filter

MULTIPLE STYLE DRAIN VALVES AND WIFS OPTIONSCLEAR WATER COLLECTION BOWL AVAILABLE

MULTIPLE HOUSING STYLE OPTIONS - Metal Spin-On for Secondary Filtration - Metal Spin-On Fuel Filter Water Separator - Transparent Non-Metal Housing w/Cartridge Filter

MULTIPLE STYLE DRAIN VALVES AND WIFS OPTIONSCLEAR WATER COLLECTION BOWL AVAILABLE

Page 10: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 41 www.donaldson.com

FUEL FILTRATIONOperating PressureWithout Drain Bowl: -40 to 100 psi (-275 to 690 kPa)

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 90 gph / 341 lph

Fluid Compatibility #1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Water Removal @ Recommended Flow Rate SAE J1488 Emulsified: 95% efficiency SAE J1839 Free Water: 95% efficiency

Air Bleed VentBleed options available

Spin-on

Fuel Filter Water

Separator

Spin-on

Fuel Filter

Head with Priming Pump Part No. P566309

Head Part No. P566308

Fuel FiltrationFilter Dia. 93 MM (3.54") x M92-2.5

Flow Range: up to 90 gph / 341 lph

Optional Clear Water

Collection Bowl

Part No. P569758

Standard Twist&Drain Valve Twist&Drain Valve

1/2"-20 UNF Threaded Sensor Port

Part No. P550865Twist&Drain Valve with Passive Water-in-Fuel Sensor

Packard Terminal Part No. P570618

Deutsch Terminal Part No. P570619

Twist&Drain Valve with Digital Water-in-Fuel Sensor

Tyco/AMP Terminal Part No. P572227

Deutsch Terminal Part No. P570349

Page 11: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

42 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Part No. P566308Part No. P566309

93 mm / 3.54"

Fuel FiltrationFilter Dia. 93 MM (3.54") x M92-2.5

Specification Illustrations

Page 12: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 43 www.donaldson.com

FUEL FILTRATION

* Water Collection Bowl (part no. P569758) adds 1.98" / 50 mm to filter length.

Fuel FiltrationFilter Dia. 93 MM (3.54") x M92-2.5

Performance Curves

93 MM (3.54") x M92-2.5 Heads OnlyMax Flow 90 gph / 341 lph

93 MM (3.54") x M92-2.5 Filter AssemblyMax Flow 45-90 gph / 170-341 lph

0 20 40 60 80 100 120

0

0.5

1

1.5

2

0

0.05

0.1

0.15

0.2

0.25

0.3

0 5 10 15 20 25 30 35

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

76mm x M16-1.5 Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

0.5

1

1.5

2

2.5

3

0

0.05

0.1

0.15

0.2

0.25

0.3

0.35

0.4

0.45

0.0 20.0 40.0 60.0 80.0 100.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x M92-2.5 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

AB

C

Max Flow 90gpm / 340 lph

0

0.5

1

1.5

2

2.5

3

0 50 100 150 200 250 300 350

0

0.05

0.1

0.15

0.2

0.25

0.3

0.35

0.4

0.45

0.0 20.0 40.0 60.0 80.0 100.0

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x M92-2.5 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

0

0.5

1

1.5

2

0 50 100 150 200 250 300 350

0

0.05

0.1

0.15

0.2

0.25

0.3

0.35

0 20 40 60 80 100PR

ESSU

RE

DR

OP

(kPa

)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x M92-2.5 Fuel Head Only - Restriction

© D

onal

dson

Com

pany

, Inc

.

AB

C

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C) Filter Length* Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearance

gph lph in mm in mm

Standard Drain

90 341 6.88 175 Cellulose 99% @ 13 No P566312 C

1.50 38No Drain

45 170 6.1 155

Cellulose 99% @ 3 No P566310 A

Cellulose 99% @ 8 No P566311 B

Page 13: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

44 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Operating Pressure0-100 psi (690 kPa) without bowl

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 90 gph / 340 lph

See table for filter flow rates

Fuel Compatibility#1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Head Part No. P174785

Spin-on

Fuel Filter

Spin-on

Fuel Filter

Fuel FiltrationFilter Dia. 93 MM (3.54") x 13/16"-12

Flow Range: up to 90 gph / 340 lph

Page 14: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 45 www.donaldson.com

FUEL FILTRATION

93 mm / 3.54"

Fuel FiltrationFilter Dia. 93 MM (3.54") x 13/16"-12

Specification Illustrations

Page 15: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

46 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ON

Performance Curves

93 MM (3.54") x 13/16"-12 Head OnlyMax Flow 90 gph / 341 lph

93 MM (3.54") x 13/16"-12 Filter AssemblyMax Flow 45-90 gph / 170-341 lph

0 50 100 150 200 250 300 350

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.0 20.0 40.0 60.0 80.0 100.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 13/16" Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.0 20.0 40.0 60.0 80.0 100.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 13/16" Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

B

C

0 50 100 150 200 250 300 350

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.0 20.0 40.0 60.0 80.0 100.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 13/16" Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.0 20.0 40.0 60.0 80.0 100.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 13/16" Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

B

C

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C) Filter Length Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearance

gph lph in mm in mm

No Drain 45 170 4.21 107 Cellulose 99% @ 16 No P550928 B

.90 2390 341 6.85 174

Synteq 99% @ 5 No EFF7917 C

Cellulose 99% @ 9 No P556916 C

Cellulose 99% @ 3 No P556917 A

Fuel FiltrationFilter Dia. 93 MM (3.54") x 13/16"-12

Page 16: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 47 www.donaldson.com

FUEL FILTRATIONOperating Pressure0-100 psi (690 kPa) without bowl

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 160 gph / 606 lph

See table for filter flow rates

Fuel Compatibility#1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Water Removal @ Recommended Flow Rate SAE J1488 Emulsified: 95% efficiency

SAE J1839 Free Water: 95% efficiency

Head Part No. P562262

Head Part No. P562261

Spin-on

Fuel Filter Water

Separator

Spin-on

Fuel Filter

Fuel FiltrationFilter Dia. 93 MM (3.54") x 1"-14

Flow Range: up to 160 gph / 606 lph

Optional Clear Water Collection Bowl

Part No. P569758

Standard Twist&Drain Valve Twist&Drain Valve

1/2"-20 UNF Threaded Sensor Port

Part No. P550865Twist&Drain Valve with Passive Water-in-Fuel Sensor

Packard Terminal Part No. P570618

Deutsch Terminal Part No. P570619

Twist&Drain Valve with Digital Water-in-Fuel Sensor

Tyco/AMP Terminal Part No. P572227

Deutsch Terminal Part No. P570349

Page 17: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

48 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Head Part No. P562262Head Part No. P562261

93 mm / 3.54"

Fuel FiltrationFilter Dia. 93 MM (3.54") x 1"-14

Specification Illustrations

D

Page 18: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 49 www.donaldson.com

FUEL FILTRATIONFuel Filtration

Filter Dia. 93 MM (3.54") x 1"-14

* Water Collection Bowl (part no. P569758) adds 1.98" / 50 mm to filter length.

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C)Filter Length* Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearance

gph lph in mm in mm

Standard Drain

90 3417.38 187

Synteq 99% @ 10 No P550847 G

.87 22

Treated Cellulose 99% @ 15 No P558000 G

7.61 193 Treated Cellulose 99% @ 3 No P553203 G

100 379

7.68 195 Synteq 99% @ 10 Yes P551001 J

8.64 219

Synteq 99% @ 10 No P553201 J

Treated Cellulose 99% @ 35 No P553204 K

Treated Cellulose 99% @ 3 No P553207 I

120 4549.70 246 Synteq 99% @ 10 Yes P551000 N

9.71 247 Treated Cellulose 99% @ 7 Yes P550901 N

Drain Valve for Deutsch WIF Sensor

100 379 8.40 213 Synteq 99% @ 10 No P550848 K

120 454

9.01 229 Synteq 99% @ 10 Yes P551122 N

9.40 239 Synteq 99% @ 10 Yes P551103 N

Drain Valve for 1/2"-20 UNF Threaded Port Sensor

90 341

7.61 193 Treated Cellulose 99% @ 3 No P553213 E

8.64 219

Synteq 99% @ 10 No P553211 G

Treated Cellulose 99% @ 35 No P553214 H

Treated Cellulose 99% @ 3 No P553217 F

120 454 9.22 234 Synteq 99% @ 10 No P552032 N

No Drain 40 150 4.22 107 Cellulose 99% @ 25 No P550104 B

60 2275.35 136

Cellulose 99% @ 25 No P550105 C

Cellulose 99% @ 17 No P552251 C

5.78 147 Wire Mesh 95% @140 No P552203 C

80 303 6.85 174Cellulose 99% @ 25 No P553854 D

Cellulose 99% @ 9 No P557440 A

100 379

6.95 177 Cellulose 99% @ 3 No P551313 I

7.40 188 Cellulose 99% @ 25 No P550106 J

7.87 200 Cellulose 99% @ 9 No P555627 I

120 454 8.69 221 Cellulose 99% @ 15 No P552253 N

160 606 9.43 240Cellulose 99% @ 9 No P551712 M

Cellulose 99% @ 3 No P551311 L

Page 19: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

50 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ON

Performance Curves

93 MM (3.54") x 1"-14 Filter AssemblyMax Flow 90 gph / 341 lph

93 MM (3.54") x 1"-14 Filter AssemblyMax Flow 40-80 gph /151-303 lph

93 MM (3.54") x 1"-14 Filter AssemblyMax Flow 120-160 gph / 454-606 lph

93 MM (3.54") x 1"-14 Filter Heads OnlyMax Flow 160 gph / 606 lph

93 MM (3.54") x 1"-14 Filter AssemblyMax Flow 100 gph / 379 lph

Fuel FiltrationFilter Dia. 93 MM (3.54") x 1"-14

93mm x 1"-14 Fuel - Assembly Restriction 40-80 gpm

93mm x 1"-14 Fuel - Assembly Restriction 90 gpm

93mm x 1"-14 Fuel - Assembly Restriction 100 gpm

93mm x 1"-14 Fuel - Assembly Restriction 120 160 gpm

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

0

0.1

0.2

0.3

0.4

0.5

0.6

0.7

0.8

0.9

1

0 50 100 150 200

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 1"-14 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

0.5

1

1.5

2

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.00 20.00 40.00 60.00 80.00 100.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

B

A

C

D

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

EFG

H

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

IJK

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.00 50.00 100.00 150.00 200.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

N

LM

93mm x 1"-14 Fuel - Assembly Restriction 40-80 gpm

93mm x 1"-14 Fuel - Assembly Restriction 90 gpm

93mm x 1"-14 Fuel - Assembly Restriction 100 gpm

93mm x 1"-14 Fuel - Assembly Restriction 120 160 gpm

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

0

0.1

0.2

0.3

0.4

0.5

0.6

0.7

0.8

0.9

1

0 50 100 150 200

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 1"-14 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

0.5

1

1.5

2

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.00 20.00 40.00 60.00 80.00 100.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

B

A

C

D

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

EFG

H

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

IJK

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.00 50.00 100.00 150.00 200.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

N

LM

93mm x 1"-14 Fuel - Assembly Restriction 40-80 gpm

93mm x 1"-14 Fuel - Assembly Restriction 90 gpm

93mm x 1"-14 Fuel - Assembly Restriction 100 gpm

93mm x 1"-14 Fuel - Assembly Restriction 120 160 gpm

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

0

0.1

0.2

0.3

0.4

0.5

0.6

0.7

0.8

0.9

1

0 50 100 150 200

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 1"-14 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

0.5

1

1.5

2

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.00 20.00 40.00 60.00 80.00 100.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)©

Don

alds

on C

ompa

ny, I

nc.

B

A

C

D

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

EFG

H

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

IJK

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.00 50.00 100.00 150.00 200.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

N

LM

93mm x 1"-14 Fuel - Assembly Restriction 40-80 gpm

93mm x 1"-14 Fuel - Assembly Restriction 90 gpm

93mm x 1"-14 Fuel - Assembly Restriction 100 gpm

93mm x 1"-14 Fuel - Assembly Restriction 120 160 gpm

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

0

0.1

0.2

0.3

0.4

0.5

0.6

0.7

0.8

0.9

1

0 50 100 150 200

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 1"-14 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

0.5

1

1.5

2

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.00 20.00 40.00 60.00 80.00 100.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

B

A

C

D

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

EFG

H

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

IJK

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.00 50.00 100.00 150.00 200.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

N

LM

93mm x 1"-14 Fuel - Assembly Restriction 40-80 gpm

93mm x 1"-14 Fuel - Assembly Restriction 90 gpm

93mm x 1"-14 Fuel - Assembly Restriction 100 gpm

93mm x 1"-14 Fuel - Assembly Restriction 120 160 gpm

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

0

0.1

0.2

0.3

0.4

0.5

0.6

0.7

0.8

0.9

1

0 50 100 150 200

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

93mm x 1"-14 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0 50 100 150 200 250 300 350

0

0.5

1

1.5

2

0.00

0.05

0.10

0.15

0.20

0.25

0.30

0.35

0.00 20.00 40.00 60.00 80.00 100.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

B

A

C

D

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

EFG

H

0 100 200 300 400

0

0.5

1

1.5

2

2.5

3

3.5

4

0.00

0.10

0.20

0.30

0.40

0.50

0.60

0.00 20.00 40.00 60.00 80.00 100.00 120.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

IJK

0 100 200 300 400 500 600 700

0

1

2

3

4

5

6

7

8

0.00

0.20

0.40

0.60

0.80

1.00

1.20

0.00 50.00 100.00 150.00 200.00

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

© D

onal

dson

Com

pany

, Inc

.

N

LM

Page 20: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 51 www.donaldson.com

FUEL FILTRATIONOperating Pressure0-100 psi (690 kPa) without bowl

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 180 gph / 681 lph

See table for filter flow rates

Fuel Compatibility#1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Water Removal @ Recommended Flow Rate SAE J1488 Emulsified: 95% efficiency

SAE J1839 Free Water: 95% efficiency

Spin-on

Fuel Filter

Spin-on

Fuel Filter

Head Part No. P920682

Head has two inlet ports and two outlet ports and ships with two port plugs. Allows for flexible mounting depending on fuel source.

Fuel FiltrationFilter Dia. 108 MM (4.25") x 1 1/4"-12

Flow Range: up to 180 gph / 681 lph

Page 21: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

52 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ONFuel FiltrationFilter Dia. 108 MM (4.25") x 1 1/4"-12

108 mm / 4.25"

Performance Curves

108 MM (4.25") x 1 1/4"-12 Head OnlyMax Flow 180 gph / 681 lph

108 MM (4.25") x 1 1/4"-12 Filter AssemblyMax Flow 60-180 gph / 227-681 lph

0 150 300 450 600 750 900

0

2

4

6

8

10

12

0.00

0.20

0.40

0.60

0.80

1.00

1.20

1.40

1.60

1.80

2.00

0.0 50.0 100.0 150.0 200.0 250.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

108mm x 1 1/4"-12 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

0 150 300 450 600 750 900

0

2

4

6

8

10

12

0

0.2

0.4

0.6

0.8

1

1.2

1.4

1.6

1.8

2

0 50 100 150 200 250

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

108mm x 1 1/4"-12 Fuel Head - Restriction ©

Don

alds

on C

ompa

ny, I

nc.

A

B

0 150 300 450 600 750 900

0

2

4

6

8

10

12

0.00

0.20

0.40

0.60

0.80

1.00

1.20

1.40

1.60

1.80

2.00

0.0 50.0 100.0 150.0 200.0 250.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

108mm x 1 1/4"-12 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

0 150 300 450 600 750 900

0

2

4

6

8

10

12

0

0.2

0.4

0.6

0.8

1

1.2

1.4

1.6

1.8

2

0 50 100 150 200 250

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

108mm x 1 1/4"-12 Fuel Head - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

B

Specification Illustrations

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C) Filter Length* Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearance

gph lph in mm in mm

Standard Drain60 227 7.44 189 Treated Cellulose 99% @ 15 No P920711 A

1.03 26

180 681 11.75 298 Treated Cellulose 99% @ 15 No P920683 B

Page 22: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 53 www.donaldson.com

FUEL FILTRATIONOperating Pressure0-100 psi (690 kPa) without bowl

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 230 gph / 946 lph

See table for filter flow rates

Fuel Compatibility#1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Water Removal @ Recommended Flow Rate SAE J1488 Emulsified: 95% efficiency

SAE J1839 Free Water: 95% efficiency

Spin-on

Fuel Filter Spin-on

Fuel Filter Water

Separator

Head Part No. P174770

Fuel FiltrationFilter Dia. 118 MM (4.65") x 1 1/4"-12

Flow Range: up to 250 gph / 946 lph

Optional Clear Water Collection Bowl

Part No. P569758

Standard Twist&Drain Valve Twist&Drain Valve

1/2"-20 UNF Threaded Sensor Port

Part No. P550865Twist&Drain Valve with Passive Water-in-Fuel Sensor

Packard Terminal Part No. P570618

Deutsch Terminal Part No. P570619

Twist&Drain Valve with Digital Water-in-Fuel Sensor

Tyco/AMP Terminal Part No. P572227

Deutsch Terminal Part No. P570349

Page 23: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

54 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ON

* Considering Drain Bowl? Add 1.98" / 50 mm to filter length.

118 mm / 4.65"

Fuel FiltrationFilter Dia. 118 MM (4.65") x 1 1/4"-12

Performance Curves

118 MM (4.65") x 1 1/4"-12 Head OnlyMax Flow 250 gph / 946 lph

118 MM (4.25") x 1 1/4"-12 Filter AssemblyMax Flow 205-250 gph / 776-946 lph

0 200 400 600 800 1000

0

2

4

6

8

10

12

14

16

0.00

0.50

1.00

1.50

2.00

2.50

0.0 50.0 100.0 150.0 200.0 250.0 300.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/4"-12 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

B

0

2

4

6

8

10

12

14

16

0 200 400 600 800 1000

0

0.5

1

1.5

2

2.5

0 50 100 150 200 250 300

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/4"-12 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0 200 400 600 800 1000

0

2

4

6

8

10

12

14

16

0.00

0.50

1.00

1.50

2.00

2.50

0.0 50.0 100.0 150.0 200.0 250.0 300.0

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/4"-12 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

B

0

2

4

6

8

10

12

14

16

0 200 400 600 800 1000

0

0.5

1

1.5

2

2.5

0 50 100 150 200 250 300

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/4"-12 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

Specification Illustrations

* Water Collection Bowl (part no. P569758) adds 1.98" / 50 mm to filter length.

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C) Filter Length* Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearance

gph lph in mm in mm

Standard Drain

205 776 12.24 311

Treated Cellulose 99% @ 25 No P552216 B

1.57 40

Synteq 99% @ 9 No P550937 B

Synteq 99% @ 10 Yes P552006 B

No Drain

250 9468.94 227 Cellulose 99% @ 30 No P550958 A

10.24 260 Cellulose 99% @ 9 No P550202 A

112.1 mm [4.41"]

Head Part No. P174770

Page 24: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 55 www.donaldson.com

FUEL FILTRATION

Operating Pressure0-100 psi (690 kPa) without bowl

Temperature Range-40° to 250ºF (-40º to 121ºC)

Flow RateUp to 250 gph / 946 lph

See table for filter flow rates

Fuel Compatibility#1 or #2 Diesel, Kerosene, Biodiesel up to B20 and JP8

MountingEngine or Chassis

Head Part No. P174774

Fuel FiltrationFilter Dia. 118 MM (4.65") x 1 1/16"-16

Flow Range: up to 250 gph / 946 lph

Page 25: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

56 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ONFuel FiltrationFilter Dia. 118 MM (4.65") x 1 1/16"-16

Performance Curves

118 MM (4.65") x 1 1/16"-16 Head OnlyMax Flow 250 gph / 946 lph

118 MM (4.65") x 1 1/16"-16 Filter AssemblyMax Flow 250 gph / 946 lph

0

2

4

6

8

10

12

14

16

0 200 400 600 800 1000

0.00

0.50

1.00

1.50

2.00

2.50

0.0 50.0 100.0 150.0 200.0 250.0 300.0

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/16"-16 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

0 200 400 600 800 1000

0

2

4

6

8

10

12

14

16

0

0.5

1

1.5

2

2.5

0 50 100 150 200 250 300

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/16"-16 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

0

2

4

6

8

10

12

14

16

0 200 400 600 800 1000

0.00

0.50

1.00

1.50

2.00

2.50

0.0 50.0 100.0 150.0 200.0 250.0 300.0

PRES

SUR

E D

RO

P (k

Pa)

Flow Rate (lph)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/16"-16 Fuel - Restriction

© D

onal

dson

Com

pany

, Inc

.

A

0 200 400 600 800 1000

0

2

4

6

8

10

12

14

16

0

0.5

1

1.5

2

2.5

0 50 100 150 200 250 300

Flow Rate (lph)

PRES

SUR

E D

RO

P (k

Pa)

PRES

SUR

E D

RO

P (p

si)

Flow Rate (gph)

118mm x 1 1/16"-16 Fuel - Head Restriction

© D

onal

dson

Com

pany

, Inc

.

Specification Illustrations

Filter Selection Chart

Filter Style

Max. Recommended

Flow Rate

(C) Filter Length Media Type Efficiency

@ MicronStand Tube Part Number Performance

Curve

(D) Service

Clearancegph lph in mm in mm

No Drain

250 946 8.94 227Synteq 99% @ 5 No EFF0047 A

1.14 29Cellulose 99% @ 16 No P550959 A

D

Page 26: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 57 www.donaldson.com

FUEL FILTRATION

P572227Twist&Drain Valve with Digital Water-In-Fuel Sensor Tyco/AMP TerminalTyco/AMP terminal can add up to: 9.43" / 239.5 mm

For water drain flexibility, Donaldson Twist&Drain™spin-on filters have a connection that can accommodate multiple drain valve types and a clear water collection bowl (80ml capacity). All Twist&Drain filters ship with a specific drain valve and one seal. When purchasing a water collection bowl, one seal will be included. Drain valves can be ordered separately and will include a replacement seal. The water collection bowl is a separate add-on component.

Seal Replacement

1

2

Push seal down onto thread stem.

Ensure seal is fully seated.

Fuel FiltrationWater Management

Water Drain Valves, Sensors & Bowl

Standard Twist&Drain™ ValveIncluded with replacement filter

P570618Twist&Drain Valve with Passive Water-In-Fuel Sensor Packard TerminalPackard sensor adds: .35" / 8.8 mm

P570619 Twist&Drain Valve with Passive Water-In-Fuel Sensor Deutsch TerminalDeutsch sensor adds: .35" / 8.8 mm

P550865Twist&Drain Valve with 1/2"-20 UNF Threaded Port Sensor Threaded sensor port adds no length

P569758Water Collection Bowl Capacity: 80ml Bowl adds 1.98" / 50 mm to lengthDoes not include a drain valve

P570349Twist&Drain Valve with Digital Water-In-Fuel Sensor Deutsch TerminalDeutsch terminal can add up to: 10.16" / 258 mm

Installation Torque for Twist&Drain™ [M24 X 5] Threads

ComponentTIGHTENING TORQUE

LB-FT (in-lbs)

NEWTON-METERS(N-M)

Twist&Drain Valvewith or without WIF sensor With external lube applied 3.3 ± 0.8

(40 ± 9.6) 4.5 ± 1.1

Without external lube applied 4.2 ± 0.8(50.4 ± 9.6) 5.7 ± 1.1

Water Collection Bowl 6.0 ± 0.9(72 ± 10.8) (8.1 ± 1.2)

Replacement Seals

If seals show signs of wear or deterioration they should be replaced. The placement of the seals are between the threaded

connections of the filter, water collection bowl, and Twist&Drain valve. When purchasing a water collection bowl or a Twist&Drain valve, one seal will be included.

P570771 Replacement seal kits are available in packages of 12.

O.D. 1.38" / 35 mmID: .86" / 22 mmThickness: .13" / 3.2mm

1 2

Page 27: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

58 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ON

Water-In-Fuel (WIF) sensors are typically chosen and installed by the engine manufacturer.

The WIF sensors connect to the fuel filter and route to a display on the dashboard. A WIF sends an electrical signal to the in-cab display and alerts the operator when water is in the fuel and should be drained from the filter. WIF sensors are more common in newer common rail injection systems.

During filter service, WIF sensors are disconnected and reused on the new filter. Sensors are likely to be replaced if connectors are damaged or wires are frayed.

The most common WIF sensors are either Packard or Deutsch styles. Donaldson offers digital Tyco/AMP and Deutsch WIF sensors – as well as passive Packard or Deutsch WIF sensors that are integrated into the Twist&Drain valve.

Water-in-Fuel Sensors (WIFs)Most primary fuel filters have drains that allow the operator to drain the water that has been separated by the filter. The frequency with which the primary fuel filter needs to be drained is ultimately dependent on the quality of fuel that is being used. Most OEMs recommend draining your water separator daily. It is also recommended to pay attention to how much water is removed at each drain and adjust the frequency of servicing accordingly.

Why Remove Water in Fuel?Water in fuel can prematurely wear and oxidize the steel components within the fuel injectors, leading to:

• Rusting and corrosion of components

• Governor/metering component failure

• Sticky metering components (both pump and nozzle)

• Injection component wear and seizure

Free or emulsified water must be removed from the fuel to prevent corrosion and damage to the fuel system. Fuel additives may claim they remove water, when really they dissolve the water. Which in turn, will pass through the filter and enter fuel injectors.

Types of water contamination in diesel fuel:1) Emulsified water: water suspended in the fuel

2) Free water: water separated from the fuel and generally collected at the bottom of the fuel or the fuel storage tank

3) Dissolved water: water chemically dissolved in the fuel

Maintenance Recommendations & Guidelines

• Drain water from your primary filter daily when refueling

• Carry a spare set of fuel filters in case you receive a “bad” load of fuel

• Never switch to more open filter to get longer filter life, you are trading away fuel pump and injector life

• Never use fuel to lube the gasket. Fuel isn’t as slick as oil and if you use fuel it could cause gaskets to bunch or pinch when it is tightened, causing the filter to leak.

• If using biodiesel:• make sure your fuel supplier meets current fuel standards • make sure your engine is compatible with the concentration

(or percent) biodiesel you wish to use

• When using your own fuel storage tank, remember that removing contaminants before they reach the vehicle is the best practice. Ensure you have effective bulk storage tank filtration.

Water & Draining Fuel Filters

Twist&Drain™ Icons Installation & Water Drain

Filter will indicate if you should fill with fuel before installation.

Apply a thin film of clean motor oil to the new gasket. Do not use grease.

Line up the filter threads to the threaded port carefully. Screw on and tighten until gasket makes contact with base.

For final tightening of the filter, turn the can to the number of turns (+) indicated on the can.

Reconnect the WIF sensor.

Three easy steps with standard drain valve.

Installation

Water Draining

+ Number of turns

1 2 3

Turn to open drain valve

Let water drain

Retighten drain valve

Fuel FiltrationWater Management

Page 28: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 59 www.donaldson.com

FUEL FILTRATION

68 mm / 2.68" Diameter Family1-14 2.62 67 4.34 110 G P551751 FUEL PRIMARY 50% @ 10 REPLACES WIX 24104 1.00 25 0.80 20

76 mm / 3.00" Diameter Family7/8-14 3.05 77 5.83 148 G P550368 FUEL PRIMARY 50% @ 5 NAVISTAR 1820749C1 5.05 128 4.71 120

3/4-163.01 76 5.75 146 G P550410 FUEL PRIMARY 99% @ 17 KOMATSU 600-311-8220 2.75 70 2.37 60

3.01 76 3.46 88 G P553240 FUEL PRIMARY 99% @ 22 ISUZU 8-94414-796 2.50 64 2.16 55

7/16-20 3.03 77 4.87 124 G P550325 FUEL PRIMARY 50% @ 10 ONAN 122B325 3.02 77 1.75 44

M16 x 1.5 2.99 76 4.72 120 G P550526 FUEL PRIMARY 50% @ 10 VOLVO 2.81 71 2.48 63

3.02 77 2.49 63 G P550678 FUEL PRIMARY 99% @ 25 FORD E6HZ9365B 2.81 71 2.48 63

3.02 77 3.26 83 G P555095 FUEL PRIMARY 99% @ 9 FORD #E67HZ9365A (BRAZILIAN CAB FORWARD) 2.75 70 2.37 60

3.02 77 3.26 83 G P550345 FUEL PRIMARY 99% @ 16 DEUTZ 1174424, MANN WK712/2 2.83 72 2.40 61

3.02 77 4.01 102 A P551039 FUEL/WATER SEPARATOR 99% @ 20 BOBCAT 6667352, CNH 86504140 T&D VALVE 2.75 70 2.40 61

3.03 77 4.40 112 E P550690 FUEL/WATER SEPARATOR 99% @ 25 CASE J911213 2.83 72 2.46 62

3.03 77 4.51 115 E P550249 FUEL/WATER SEPARATOR 99% @ 25 CUMMINS 3912104 2.81 71 2.48 63

3.02 77 4.72 120 G P550943 FUEL SECONDARY 99% @ 9 GMC 6.2L 25011214 2.75 70 2.37 60

3.04 77 4.72 120 G P553004 FUEL PRIMARY 99% @ 16 VOLVO 243004 2.76 70 2.38 60 Yes

3.02 77 4.72 120 G P550440 FUEL SECONDARY 99% @ 16 CUMMINS 6C, 6CT SERIES 2.75 70 2.37 60 Yes

3.02 77 5.81 148 A P550588 FUEL/WATER SEPARATOR 99% @ 11 BOSCH 1457434056 2.76 70 2.40 61

3.02 77 5.81 148 A P550248 FUEL/WATER SEPARATOR 99% @ 15 CUMMINS 3903202 2.82 72 2.46 62 Yes

3.00 76 6.50 165 E P550587 FUEL/WATER SEPARATOR 99% @ 25 DEUTZ 2133558, 2133943 2.75 70 2.37 60

3.37 86 3.37 86 E P552374 FUEL/WATER SEPARATOR 50% @ 25 ONAN 149-2106; TORO 63-8300 2.74 70 2.37 60

M16 x 1.5 3.02 77 5.81 148 A P551615 FUEL/WATER SEPARATOR 99% @ 3 LOW FLOW ON AND OFF HIGHWAY 2.76 70 2.40 61

M18 x 1.5 3.00 76 2.37 60 E P551768 FUEL/WATER SEPARATOR 50% @ 15 RACOR R12P 2.70 69 2.50 63

M20 x 1.5 3.00 76 3.40 86 G P550127 FUEL PRIMARY 99% @ 17 KUBOTA 70000-43081 2.70 69 2.33 59

80 mm / 3.15" Diameter Family1-14 3.18 81 6.09 176 G P551740 FUEL PRIMARY 99% @ 9 CATERPILLAR 1R-0740 2.91 74 2.52 64

7/8-14 3.15 80 6.93 176 G P551315 FUEL PRIMARY 99% @ 3 CATERPILLAR 1R0759 2.89 74 2.50 64

3/4-16 3.11 79 5.59 142 E P550550 FUEL/WATER SEPARATOR 95% @ 20 KOMATSUP554477 2.76 70 2.48 63

3.15 80 3.31 84 G P502177 FUEL PRIMARY 50% @ 10 FSA FF2028, RYCO Z169A 2.48 63 1.76 45

3.15 80 4.50 114 G P502163 FUEL PRIMARY 50% @ 10 NISSAN 16403-Z9000, 16403-Z9005 2.50 64 2.11 54

3.15 80 6.89 175 G P502167 FUEL PRIMARY 50% @ 10 NISSAN 16405-01T70 2.59 66 2.00 51

3.18 81 3.39 86 G P550057 FUEL PRIMARY 99% @ 25 TOYOTA 23303-56301 2.52 64 2.13 54

3.31 84 3.94 100 G P550225 FUEL SECONDARY 50% @ 10 HINO 23401-1332, NISSAN 16403Z9003 2.48 63 2.08 53

M16 x 1.5 3.06 78 6.74 171 E P550688 FUEL/WATER SEPARATOR 99% @ 25 DEUTZ 2.81 71 2.46 62

3.14 80 4.88 124 G P550491 FUEL PRIMARY 50% @ 25 RVI, M&H WK727 2.80 71 2.44 62

3.15 80 5.98 152 F P550498 FUEL/WATER SEPARATOR 50% @ 15 M & H WDK724 2.81 71 2.46 62

3.18 81 6.93 176 G P550782 FUEL PRIMARY 99% @ 10 DAVCO 210 - M16 X 1.5 - 10 MICRON 2.81 71 2.52 64

3.18 81 6.93 176 G P550783 FUEL PRIMARY 99% @ 25 DAVCO 210 - M16 X 1.5 - 25 MICRON 2.91 74 2.52 64

M20 x 1.53.16 80 4.72 120 G P502142 FUEL PRIMARY 50% @ 10 MITSUBISHI MB433425, TCM

20801-02131 3.06 78 2.48 63

3.15 80 3.93 100 G P502143 FUEL PRIMARY 50% @ 10 MITSUBISHI 3446200300 2.76 70 2.52 64

A B1 B2 C D

Packard Deutsch Drain Valve with 1/2" x 20 thread

Sensor Port

Drain ValveSpin-on

GFE EE

Bowl to Fit Port

Knob Types

Water-in Fuel Sensors

Twist&Drain™ Valves

Plug

Other Drain Valve Styles

Fuel FiltrationSpin-On Filters

ThreadOD Length Drain

Type Part No. Part DescriptionEfficiency

% @ Micron

Primary ApplicationGSKT O.D. GSKT I.D. Stand

TubeIN MM IN MM IN MM IN MM

Spin-On Filters

Page 29: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

60 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

93 mm / 3.54" Diameter Family 1-12 3.66 93 5.35 136 G P550936 FUEL PRIMARY 99% @ 25 GMC 25011011, 8.2L 3.38 86 3.04 77

3.66 93 6.85 174 G P554347 FUEL PRIMARY 99% @ 25 BULK FUEL W/O DRAIN 2.81 71 2.42 61

3.66 93 8.64 219 A P553202 FUEL/WATER SEPARATOR 99% @ 35 RACOR S3202 T&D VALVE 3.39 86 3.05 78

3.66 93 8.64 219 c P553212 FUEL/WATER SEPARATOR 99% @ 35 RACOR S3202 T&D INTEGRATED 1/2"-20 SENSOR PORT THD 3.39 86 3.05 78

3.69 94 5.37 136 G P550115 FUEL PRIMARY 99% @ 45 FUEL DISPENSING PUMPS 2.84 72 2.47 63

3.69 94 5.37 136 G P550215 FUEL PRIMARY 99% @ 22 WATER ABSORBING, FUEL DISPENS-ING PUMPS 2.84 72 2.46 62

3.69 94 7.44 189 F P551915 FUEL PRIMARY 99% @ 22 BULK FUELTANKS WITH SEDIMENT DRAIN 2.84 72 2.47 63

3.81 97 4.25 108 G P550944 FUEL PRIMARY 50% @ 25 DETROIT DIESEL 8.2L ENG, FORD TRK & BUS 3.55 90 3.18 81

3.81 97 6.08 154 G P550944 FUEL PRIMARY 99% @ 38 GMC 6.2L 25011285 3.55 90 3.18 81

3.81 97 7.36 187 A P558010 FUEL/WATER SEPARATOR 99% @ 20 DETROIT DIESEL 23512317 T&D VALVE 3.55 90 3.18 81

3.81 97 7.97 202 G P556915 FUEL PRIMARY 99% @ 25 DET. DIESEL 23517471, AC T915D 3.38 86 3.04 77

1-14 3.66 93 5.35 136 G P550105 FUEL PRIMARY 99% @ 25 CUMMINS 154709 2.81 71 2.42 61

3.66 93 5.35 136 G P552251 FUEL PRIMARY 99% @ 17 IHC 702250C1 2.81 71 2.42 61

3.66 93 6.11 155 A P550828 FUEL/WATER SEPARATOR 99% @ 140 CUMMINS ENGINES 2.83 72 2.44 62

3.68 93 6.85 174 G P551178 FUEL PRIMARY 50% @ 10 NISSAN FL40399008 2.85 72 2.47 63

3.66 93 6.85 174 G P553854 FUEL PRIMARY 99% @ 25 CARRIER, IHC, THERMOKING 11.3854 2.81 71 2.42 61

3.66 93 6.85 174 G P557440 FUEL PRIMARY 99% @ 9 CATERPILLAR 1R-0711, 1P-2299, 6L-7440, KTSU 600-311-8290 2.81 71 2.42 61

3.68 93 6.95 177 G P551313 FUEL SECONDARY 99% @ 3 CATERPILLAR 1R-0750 2.83 72 2.46 62

3.66 93 7.40 188 A P558000 FUEL/WATER SEPARATOR 99% @ 20 CUMMINS 3308638 T&D VALVE 2.81 71 2.42 61

3.66 93 7.61 193 A P553203 FUEL/WATER SEPARATOR 99% @ 3 RACOR S3203 T&D VALVE 2.83 72 2.44 62

3.66 93 7.61 193 A P553205 FUEL/WATER SEPARATOR 99% @ 7 CATERPILLAR ENGINES T&D VALVE 3.39 86 3.05 78

3.66 93 7.61 193 C P553213 FUEL/WATER SEPARATOR 99% @ 3 RACOR S3203 T&D INTEGRATED 1/2"-20 SENSOR PORT THD 2.83 72 2.44 62

3.66 93 7.61 193 C P553215 FUEL/WATER SEPARATOR 99% @ 7 CATERPILLAR ENGINES T&D INTE-GRATED 1/2"-20 SENSOR PORT THD 3.39 86 3.05 78

3.66 93 7.87 200 C P555627 FUEL PRIMARY 99% @ 9 IHC 625627C1 2.81 71 2.42 61

3.68 93 7.98 203 A P551001 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS CELECT & QUANTUM ENGINE APPLICATIONS T&D VALVE 2.83 72 2.46 62 Yes

3.66 93 8.40 213 B2 P550848 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS ENGINES T&D INTE-GRATED WIF 2.83 72 2.44 62

3.66 93 8.64 219 A P553201 FUEL/WATER SEPARATOR 99% @ 10 RACOR S3201 T&D VALVE 2.83 72 2.44 62

3.66 93 8.64 219 A P553204 FUEL/WATER SEPARATOR 99% @ 35 ALLIANCE ABPN12232FRT04 T&D VALVE 2.83 72 2.44 62

3.66 93 8.64 219 A P553207 FUEL/WATER SEPARATOR 99% @ 3 ALLIANCE ABPN12232FRT03 T&D VALVE 2.83 72 2.44 62

3.66 93 8.64 219 C P553211 FUEL/WATER SEPARATOR 99% @ 10 RACOR S3201 T&D INTEGRATED 1/2"-20 SENSOR PORT THD 2.83 72 2.44 62

3.66 93 8.64 219 C P553214 FUEL/WATER SEPARATOR 99% @ 35ALLIANCE ABPN12232FRT04 T&D

INTEGRATED 1/2"-20 SENSOR PORT THD

2.83 72 2.44 62

3.66 93 8.64 219 C P553217 FUEL/WATER SEPARATOR 99% @ 33ALLIANCE ABPN12232FRT03 T&D

INTEGRATED 1/2"-20 SENSOR PORT THD

2.83 72 2.44 62

3.66 93 9.17 233 G P551319 FUEL PRIMARY 99% @ <4 CATERPILLAR ENGINES N/A N/A 2.44 62

3.66 93 9.22 234 Spec P552032 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS ISC, ISM ENGINES - CON-TAINS DRAIN AND SENSOR PORT 2.81 72 2.42 62

3.68 93 9.43 240 G P551311 FUEL PRIMARY 99% @ 3 CATERPILLAR 1R-0749 2.83 72 2.46 62

3.66 93 9.92 252 A P551000 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS CELECT & QUANTUM ENGINE APPLICATIONS T&D VALVE 2.81 71 2.42 61 Yes

3.66 93 9.92 252 A P550901 FUEL/WATER SEPARATOR 99% @ 7 CUMMINS ENGINES T&D VALVE 2.81 71 2.46 63

Fuel FiltrationSpin-On Filters

ThreadOD Length Drain

Type Part No. Part DescriptionEfficiency

% @ Micron

Primary ApplicationGSKT O.D. GSKT I.D. Stand

TubeIN MM IN MM IN MM IN MM

Spin-On Filters

Page 30: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 61 www.donaldson.com

FUEL FILTRATION

1-14 3.69 94 5.52 140 E P551744 FUEL/WATER SEPARATOR 50% @ 10 RACOR R24S 3.43 87 3.11 79

3.69 94 5.68 144 F P550108 FUEL PRIMARY 50% @ 25 JOHN DEERE AR45098, AR45097 2.84 72 2.47 63

3.69 94 5.85 149 E P550691 FUEL/WATER SEPARATOR 99% @ 25 CUMMINS 3843447 2.83 72 2.46 62

3.69 94 7.38 187 A P550847 FUEL/WATER SEPARATOR 99% @ 10 CATERPILLAR 1752949 2.81 71 2.45 62

3.69 94 8.69 221 G P552253 FUEL SECONDARY 99% @ 15 IHC 702253C1 2.84 72 2.47 63

3.69 94 9.38 238 B1 P551122 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS ENGINES T&D INTE-GRATED WIF 2.83 72 2.46 62 Yes

3.69 94 9.71 247 B2 P551103 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS ENGINES T&D INTE-GRATED WIF 3.69 94 2.83 72 Yes

3.70 94 10.75 273 G P550625 FUEL PRIMARY 99% @ 3 CATERPILLAR 1R0762 3.60 91 3.03 77

3.75 95 4.12 105 Bowl Thd P550088 FUEL/WATER SEPARATOR 50% @ 10 FORD 6.6L & 7.8L ENG #E7HZ-

4N184A, RACOR R26P 2.81 72 2.42 62

3.72 95 5.78 147 G P552203 FUEL PRIMARY 95% @ 140 CUMMINS 4010476, FLEETGUARD FF2203 2.83 72 2.46 62

3.72 95 9.43 240 G P551712 FUEL PRIMARY 99% @ 9 CATERPILLAR 1R-0712 2.81 71 2.42 61

3.79 96 6.22 158 E P550553 FUEL/WATER SEPARATOR 99% @ 40 1999 FORD LIGHT TRUCK, MOTOR-CRAFT FD4597 3.59 91 3.15 80

3.81 97 4.22 107 G P550104 FUEL PRIMARY 99% @ 25 CUMMINS 138627 2.81 71 2.42 61

3.81 97 5.70 145 G P550109 FUEL PRIMARY 50% @ 10 FORD D3HE9176AA 3.56 90 3.17 81

3.81 97 7.40 188 F P550106 FUEL PRIMARY 99% @ 25 CUMMINS D156172, 202893, FURN GSKT-P169192 2.81 71 2.42 61

3.82 97 7.88 200 G P551004 FUEL PRIMARY 99% @ 5 PACCAR 1655115 2.76 70 2.48 63

7/8-14 3.66 93 6.85 174 G P550774 FUEL PRIMARY 99% @ 3 CUMMINS 3959612, ISC, ISL ISM ENGINES 2.83 72 2.44 62

3.66 93 6.85 174 G P550879 FUEL PRIMARY 99% @ 5 CUMMINS 4940647 2.83 72 2.44 62

3.68 93 9.43 240 G P551312 FUEL PRIMARY 99% @ 3 CATERPILLAR 1R-0753 2.83 72 2.46 62

3.78 96 8.70 221 G P553855 FUEL SECONDARY 99% @ 20 IHC, THERMOKING 11.3855 2.84 72 2.46 62

3.81 97 5.22 133 G P553693 FUEL SECONDARY 99% @ 20 CARRIER, THERMOKING 11.3693 2.82 72 2.42 61

3/4-16 3.66 93 5.19 132 G P552405 FUEL PRIMARY 50% @ 10 NISSAN 1640305D00, FL40305D00 2.83 72 2.46 63

3.71 94 4.92 125 G P552564 FUEL PRIMARY 50% @ 10 ISUZU 1-13240-074-0, HITACHI 4206080 2.48 63 1.74 44

3.70 94 5.43 138 Spec P550385 FUEL PRIMARY 50% @ 10 TOYOTA 2330364010 2.48 63 2.20 56

3.85 98 5.47 139 G P551351 FUEL PRIMARY 50% @ 10 NISSAN 1640505E01 2.89 74 2.00 51

1 1/2-16 3.78 96 7.35 187 Spec P550735 FUEL PRIMARY 99% @ 25 NATURAL GAS FUELED CUMMINS ENGINES 3.47 88 2.99 76

1 3/8-12 3.67 93 7.50 190 G P551752 FUEL/WATER SEPARATOR 99% @ 40 AMACO AO8 2.73 69 2.42 61

13/16-12 3.66 93 4.21 107 G P550928 FUEL SECONDARY 99% @ 16 GMC 25010959 3.38 86 3.04 77

3.66 93 6.85 174 G EFF7917 FUEL SECONDARY 99% @ 5 DETROIT DIESEL 23530645 3.39 86 3.05 77

3.66 93 6.85 174 G P556916 FUEL SECONDARY 99% @ 9 DET. DIESEL 23518530, AC TP916D 3.39 86 3.05 77

3.66 93 6.85 174 G P556917 FUEL SECONDARY 99% @ 3 DETROIT DIESEL 23533726 3.39 86 3.05 77

13/16-18 3.66 93 5.67 144 G P558712 FUEL PRIMARY 99% @ 40 CASE IH A58712 2.81 71 2.42 61

3.76 96 6.01 153 A P551329 FUEL/WATER SEPARATOR 99% @ 13 CASE, CUMMINS T&D VALVE 2.85 72 2.46 62

3.81 97 4.50 114 G P550868 FUEL PRIMARY 99% @ 28 CASE A39868, DAVID BROWN 2.81 71 2.46 62

15/16-16 3.66 93 5.55 141 G P559100 FUEL PRIMARY 99% @ 23 CAT 9L-9100, 9L-8794 2.75 70 2.42 61

3.70 94 8.42 214 F P552432 FUEL/WATER SEPARATOR 99% @ 25 ALLIS CHALMERS 4321716, 4321716-5 2.83 72 2.46 63

3.81 97 4.75 121 G P550110 FUEL SECONDARY 99% @ 8 CASE A39867 2.82 72 2.42 61

3.81 97 5.61 142 G P551127 FUEL SECONDARY 99% @ 12 CASE A58713 2.85 72 2.46 62

M12 x 1.5 3.50 89 8.16 207 G P550473 FUEL PRIMARY 50% @ 25 MERCEDES-BENZ 10922201, 10922301 2.80 71 2.44 62

M14 x 1.5 3.82 97 7.60 193 G P550665 FUEL/WATER SEPARATOR 50% @ 20 IVECO 1907539 / NEW HOLLAND 1931061 2.85 72 2.46 62

Fuel FiltrationSpin-On Filters

ThreadOD Length Drain

Type Part No. Part DescriptionEfficiency

% @ Micron

Primary ApplicationGSKT O.D. GSKT I.D. Stand

TubeIN MM IN MM IN MM IN MM

A B1 B2 C D

Packard Deutsch Drain Valve with 1/2" x 20 thread

Sensor Port

Drain ValveSpin-on

GFE EE

Bowl to Fit Port

Knob Types

Water-in Fuel Sensors

Twist&Drain™ Valves

Plug

Other Drain Valve Styles

Page 31: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

62 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

93 mm / 3.54" Diameter Family, continued M16 x 1.5 3.77 96 5.66 144 G P550494 FUEL PRIMARY 50% @ 5 DAF 1318695 2.80 71 2.44 62

3.78 96 5.66 144 G P550496 FUEL PRIMARY 50% @ 10 RENAULT V.I. 5010359706 2.80 71 2.44 62

3.77 96 8.34 211 G P550472 FUEL PRIMARY 50% @ 3 DAF 1328177 2.80 71 2.44 62

3.82 97 5.47 139 G P554620 FUEL PRIMARY 99% @ 9 DEUTZ 1174422 2.81 71 2.42 61

3.82 97 8.27 210 G P559624 FUEL PRIMARY 50% @ 5 DAF 247138 2.80 71 2.44 62

3.68 93 4.25 108 G P550662 FUEL PRIMARY 99% @ 9 VOLVO CONSTRUCTION EQUIPMENT, 11708555 2.77 70 9 9

M18 x 1.5 3.71 94 8.13 207 G P550372 FUEL PRIMARY 99% @ 5 VOLVO 420799 2.81 71 2.46 62

3.78 96 5.59 142 G P550004 FUEL PRIMARY 50% @ 10 RENAULT 2.80 71 2.44 62

M20 x 1.5 3.68 93 3.94 100 G P550049 FUEL PRIMARY 99% @ 30 MITSUBISHI ME016823 2.54 65 2.28 58

3.66 93 6.30 160 G P550643 FUEL PRIMARY 99% @ 10YANMAR SV SERIE; VOLVO EC/EW SERIES; VOLVO EC55B; VOLVO ECR

AND ECR882,72 69 2.32 59

3.66 93 6.85 174 G P550880 FUEL PRIMARY 99% @ 5 CASE 87803200, CUMMINS 4897897 2.83 72 2.44 62

3.66 93 6.85 174 G P550881 FUEL PRIMARY 99% @ 5 CUMMINS 4897833, IVECO 2992241, DAF 1399760 2.83 72 2.44 62

3.66 93 7.96 202 B1 P550929 FUEL/WATER SEPARATOR 99% @ 5 CUMMINS 3991498 TIER 2 QSB & 2VE ENGINES 2.84 72 2.42 62

3.66 94 4.21 107 G P550932 FUEL PRIMARY 99% @ 30 MITSUBISHI ME035393, ME035829 3.43 87 2.42 62

3.66 93 5.50 140 Bowl Thd P550930 FUEL/WATER SEPARATOR CUMMINS 3942533 2.83 72 2.44 62

3.69 94 5.75 146 Bowl Thd P550930 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS 3942533 2.73 69 2.46 63

3.74 95 3.15 80 G P550048 FUEL PRIMARY 99% @ 30 MITSUBISHI ME006066 2.52 64 2.28 58

3.72 95 4.72 120 G P502157 FUEL PRIMARY 50% @ 10 MAZDA 2.81 71 1.97 50

3.72 95 5.17 131 G P502158 FUEL PRIMARY 50% @ 10 MAZDA 145623570A 3.62 92 2.81 71

3.78 96 4.65 118 Bowl Thd P550931 FUEL/WATER SEPARATOR 95% @ 20 DODGE LIGHT TRUCK WITH

CUMMINS DIESEL 2.83 72 2.46 62

3.90 99 5.43 138 G P502149 FUEL PRIMARY 50% @ 10 DAIHATSU 2330387308000 2.81 71 2.19 56

3.90 99 5.43 138 G P550390 FUEL PRIMARY 50% @ 10 MITSUBISHI MB220900 2.87 73 2.20 56

M24 x 1.5

3.66 93 6.77 172 G P550391 FUEL PRIMARY 99% @ 30 MITSUBISHI ME056280 3.54 90 2.66 68

3.70 94 5.59 142 G P550515 FUEL PRIMARY 85% @ 3-5 MANN & HUMMEL WK940/2, SCANIA 1411894 2.80 71 2.44 62

3.77 96 5.66 144 G P550495 FUEL PRIMARY 50% @ 3 SAAB-SCANIA 1361685, 1372444 2.80 71 2.44 62

3.78 96 7.00 178 G P550365 FUEL PRIMARY 99% @ 20 ROLLS ROYCE OE42873 2.84 72 2.46 63

M72 x 2 3.58 91 9.00 228 G P552200 FUEL SECONDARY 99% @ 8 CUMMINS 4088272, FLEETGUARD FF2200 3.74 95 3.10 79

Fuel FiltrationSpin-On Filters

ThreadOD Length Drain

Type Part No. Part DescriptionEfficiency

% @ Micron

Primary ApplicationGSKT O.D. GSKT I.D. Stand

TubeIN MM IN MM IN MM IN MM

Spin-On Filters

A B1 B2 C D

Packard Deutsch Drain Valve with 1/2" x 20 thread

Sensor Port

Drain ValveSpin-on

GFE EE

Bowl to Fit Port

Knob Types

Water-in Fuel Sensors

Twist&Drain™ Valves

Plug

Other Drain Valve Styles

Page 32: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 63 www.donaldson.com

FUEL FILTRATIONFuel Filtration

Spin-On Filters

ThreadOD Length Drain

Type Part No. Part DescriptionEfficiency

% @ Micron

Primary ApplicationGSKT O.D. GSKT I.D. Stand

TubeIN MM IN MM IN MM IN MM

108 mm / 4.25" Diameter Family1-12 4.24 108 8.90 226 G P550753 FUEL PRIMARY 50% @ 10 JOHN DEERE RE519608 3.57 91 3.15 80

4.24 108 9.61 244 A P551086 FUEL/WATER SEPARATOR 99% @ 12 DONALDSON TWIST&DRAIN 3.47 88 3.15 80

4.24 108 9.61 244 A P551087 FUEL/WATER SEPARATOR 99% @ 15 DONALDSON TWIST&DRAIN 3.47 88 3.15 80

4.24 108 10.38 264 Spec P550753 FUEL/WATER SEPARATOR 99% @ 5 JOHN DEERE RE509596, RE521818 4.00 102 3.56 90

1-14 4.23 107 5.80 147 A P551033 FUEL/WATER SEPARATOR 99% @ 9 RACOR R43, R50504 3.90 99 3.56 90

4.23 107 6.81 173 A P551034 FUEL/WATER SEPARATOR 99% @ 9 RACOR S3226 3.90 99 3.56 90

4.23 107 5.80 147 A P551055 FUEL/WATER SEPARATOR 99% @ 4 RACOR R60, S3225 3.51 89 3.17 81

4.23 107 5.80 147 A P551056 FUEL/WATER SEPARATOR 99% @ 9 RACOR R60T 3.51 89 3.17 81

4.23 107 5.80 147 A P551057 FUEL/WATER SEPARATOR 99% @ 25 RACOR R60P 3.51 89 3.17 81

4.23 107 3.82 173 A P551065 FUEL/WATER SEPARATOR 99%@4 RACOR R90S, ALLIANCE 3.51 89 3.17 81

4.23 107 6.82 173 A P551066 FUEL/WATER SEPARATOR 99%@9 RACOR R90T 3.51 89 3.17 81

4.23 107 6.82 173 A P551067 FUEL/WATER SEPARATOR 99% @ 25 RACOR R90P 3.51 89 3.17 81

4.23 107 9.60 244 A P551075 FUEL/WATER SEPARATOR 99%@4 RACOR R120S 3.51 89 3.17 81

4.23 107 9.60 245 A P551025 FUEL/WATER SEPARATOR 99% @ 4 RACOR B32006 2.83 72 2.44 62

4.23 107 9.60 245 A P551026 FUEL/WATER SEPARATOR 99% @ 9 MERCEDES 4771302, VOLVO 11110668 3.90 99 3.56 90

4.23 107 9.60 244 A P551076 FUEL/WATER SEPARATOR 99% @9 RACOR R120T 3.51 89 3.17 81

4.23 107 9.60 244 A P551077 FUEL/WATER SEPARATOR 99% @ 25 RACOR R120P 3.51 89 3.17 81

4.23 107 9.78 248 A P550900 FUEL/WATER SEPARATOR 99% @ 20 CATERPILLAR EQUIPMENT 3.86 98 3.55 90 Yes

4.25 108 3.50 89 Bowl Thd P550746 FUEL/WATER SEPARATOR 50% @ 3 RACOR R45 SERIES 3.77 96 3.50 89

4.26 108 5.79 147 E P551056 FUEL/WATER SEPARATOR 50% @ 5 NAVISTAR 1685159C1 3.60 91 3.20 81

4.26 108 5.90 150 G P559125 FUEL PRIMARY 99% @ 10 CARRIER 300109000 4.00 102 3.56 90

4.26 108 5.93 151 G P550448 FUEL PRIMARY 99% @ 10 CARRIER 300109001 3.54 90 3.16 80

4.25 108 7.91 201 G P551335 FUEL PRIMARY 99% @ 20 DAVCO 320120 3.98 101 3.58 91

4.25 108 10.31 262 G EFF9092 FUEL PRIMARY 99% @ 5 CAT ENGINES 2.82 72 2.42 61

4.25 108 11.88 302 Spec P559122 FUEL/WATER SEPARATOR 99% @ 10 JOHN DEERE RE522687 4.00 102 3.56 90

4.29 109 5.75 146 E P551034 FUEL/WATER SEPARATOR 50% @ 12 NAVISTAR 1685159C91 3.97 101 3.59 91

1-14 4.31 109 10.60 269 G P555823 FUEL PRIMARY 99% @ 9 CAT 4N-5823 2.82 72 2.42 61

4.36 111 5.04 128 G P550436 FUEL PRIMARY 50% @ 30 RACOR S3225P 4.00 102 3.56 90

4.36 111 5.05 128 Bowl Thd P550729 FUEL/WATER SEPARATOR 50% @ 10 NAVISTAR 1677004C91 4.00 102 3.56 90

4.36 111 5.10 130 Bowl Thd P550730 FUEL/WATER SEPARATOR 50% @ 10 FORD F1HZ9365A, CARRIER 30-01079 4.00 102 3.56 90

4.36 111 6.10 155 Bowl Thd P550747 FUEL/WATER SEPARATOR 50% @ 10 RACOR R90 SERIES 3.77 96 3.50 89

4.38 111 8.21 209 E P551767 FUEL/WATER SEPARATOR 99% @ 40 GM 23514654, JOHN DEERE 500186 3.77 96 3.50 89

4.38 111 8.50 216 Bowl Thd P550748 FUEL/WATER SEPARATOR 50% @ 10 RACOR R120 SERIES 4.00 102 3.56 90

4.23 107 10.36 263 B2 P551010 FUEL/WATER SEPARATOR 99% @ 20 CATERPILLAR EQUIPMENT 3.86 98 3.55 90 Yes

4.38 111 11.30 287 E P551746 FUEL/WATER SEPARATOR 99% @ 5 CATERPILLAR 1335673 3.50 89 3.18 81

4.39 112 4.02 102 Bowl Thd P553375 FUEL/WATER SEPARATOR 50% @ 10 FORD E8TZ-9N184-A 3.77 96 3.50 89

4.39 112 5.04 128 Bowl Thd P550913 FUEL/WATER SEPARATOR 50% @ 30 MACK 21017305 N/A N/A N/A N/A

7/8-14 4.23 107 4.23 107 A P551027 FUEL/WATER SEPARATOR 99% @ 4 JOHN DEERE RE522688 3.90 99 3.56 90

4.23 107 9.6 244 A P551031 FUEL/WATER SEPARATOR 99% @ 15 CASE 1808623C1 2.83 72 2.44 62

4.24 108 6.74 171 E P550669 FUEL/WATER SEPARATOR 99% @ 5 JOHN DEERE RE522688 3.93 100 3.55 90

4.24 108 7.14 181 G P551318 FUEL PRIMARY 99% @ 9 NAVISTAR 1822588C1 2.81 71 2.45 62

4.28 109 4.60 117 G P550811 FUEL SECONDARY 99% @ 10 FORD, IHC 6.9L 1804459C1 2.83 72 2.45 62

4.28 109 7.98 203 G P552603 FUEL SECONDARY 99% @ 9 IHC 672603C1 2.82 72 2.42 61

3/4-16 4.29 109 7.20 183 G P551605 FUEL PRIMARY 99% @ 3 IVECO 1901605 2.80 71 2.40 61

7/8-16 4.28 109 7.89 200 G P550218 FUEL SECONDARY 99% @ 17 MACK 483-GB-218B 2.82 72 2.42 61

1 1/16-16 4.28 109 10.31 262 G P550431 FUEL SECONDARY 99% @ 9 MACK 483-GB-431 3.89 99 3.55 90

1 1/4-12 4.38 111 11.75 298 A P920683 FUEL/WATER SEPARATOR 99% @ 15 3 GPM HIGH PERF FF/WS 4.32 110 3.85 98

4.38 111 7.44 189 A P920711 FUEL/WATER SEPARATOR 99% @ 15 1 GPM HIGH PERF FF/WS 4.32 110 3.85 98

13/16-18 4.23 107 9.60 244 A P551030 FUEL/WATER SEPARATOR 99% @ 17 MACK 483GB465 2.83 72 2.44 62

4.28 109 7.89 200 G P550219 FUEL PRIMARY 50% @ 14 MACK 483-GB-219A 2.82 72 2.42 61

Page 33: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

64 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Fuel FiltrationSpin-On Filters

Stanadyne FM100 System Fuel Filter Water SeparatorsStanadyne® is a registered trademark of Stanadyne Corporation

.90 23 3.15 80 5.31 135 P551423 FUEL/WATER SEPARATOR- STANDARD FLOW

99% @ 10 CAT, JOHN DEERE

.90 23 3.15 80 5.31 135 P551426 PRIMARY- STANDARD FLOW 99% @ 20 AGCO, CAT, JCB

.90 23 3.15 80 5.31 135 P551429 PRIMARY- STANDARD FLOW 99% @ 50 AGCO, CAT, PERKINS

.90 23 3.15 80 5.31 135 P551436 PRIMARY- REVERSE FLOW 99% @ 50 CAT

.90 23 3.15 80 6.05 154 P551421 FUEL/WATER SEPARATOR- STANDARD FLOW

99% @ 3 IR, JOHN DEERE, LIEBHERR

.90 23 3.15 80 6.05 154 P551424 FUEL/WATER SEPARATOR- STANDARD FLOW

99% @ 10 JOHN DEER, PERKINS, CAT

.90 23 3.15 80 6.05 154 P551427 PRIMARY- STANDARD FLOW 99% @ 20 CAT, JOHN DEERE, JCB

.90 23 3.15 80 6.05 154 P551430 PRIMARY- STANDARD FLOW 99% @ 50 JOHN DEERE, LIEBHERR, NEW HOLLAND

.90 23 3.15 80 6.05 154 P551432 FUEL/WATER SEPARATOR- REVERSE FLOW

99% @ 10 CNH, PERKINS, FORD

.90 23 3.15 80 6.05 154 P551434 PRIMARY- REVERSE FLOW 99% @ 20 JOHN DEERE, LIEBHERR, CASE, JCB

.90 23 3.15 80 6.05 154 P551437 PRIMARY- REVERSE FLOW 99% @ 50 JOHN DEERE, NEW HOLLAND

.90 23 3.15 80 7.71 196 P551422 FUEL/WATER SEPARATOR - STANDARD FLOW

99% @ 3 JOHN DEERE, LIEBHERR

.90 23 3.15 80 7.71 196 P551425 FUEL/WATER SEPARATOR - STANDARD FLOW

99% @ 10 CAT, CNH, JCB

I.D. OD LengthPart No. Part Description

Efficiency @ Micron

Primary ApplicationIN MM IN MM IN MM

ThreadOD Length Drain

Type Part No. Part DescriptionEfficiency

% @ Micron

Primary ApplicationGSKT O.D. GSKT I.D. Stand

TubeIN MM IN MM IN MM IN MM

Spin-On Filters

108 mm / 4.25" Diameter Family, continued15/16-16 4.26 108 8.96 228 F P552475 FUEL/WATER SEPARATOR 50% @ 10 LUBER-FINER LFP2100C 2.81 71 2.46 62

4.28 109 10.31 262 F P552370 FUEL/WATER SEPARATOR 50% @ 10 FORD E7HZ-9N184-B, E8HT-9J288-AA 2.85 72 2.48 63

M22 x 1.5 4.23 107 9.6 244 A P551028 FUEL/WATER SEPARATOR 99% @ 17 MACK 483GB472M 3.90 99 3.56 90

4.25 108 7.95 202 G P554470 FUEL PRIMARY 99% @ 25 MACK 483-GB-470M 3.88 99 3.54 90

4.25 108 10.40 264 E P554472 FUEL/WATER SEPARATOR 99% @ 25 MACK 483GB472M 3.98 101 3.58 91

M30 x 1.5 4.23 107 7.95 202 G P554476 FUEL SECONDARY 99% @ 9 MACK 483GB476M 3.90 99 3.54 90

4.23 107 9.6 244 A P551029 FUEL/WATER SEPARATOR 99% @ 4 MACK 483GB477M 3.9 99 3.56 90

4.25 108 8.34 212 E P554477 FUEL/WATER SEPARATOR 99% @ 5 MACK ASET 3.98 101 3.58 91

4.25 108 10.30 262 G P554471 FUEL SECONDARY 99% @ 9 MACK 483GB471M 3.88 99 3.54 90

M32 x 1.5 4.43 113 10.00 254 G P550529 FUEL PRIMARY 99% @ 5 VOLVO 20430751 4.09 104 3.66 93

4.43 113 10.31 262 G P554000 FUEL PRIMARY 99% @ 5 MTU ENGINE, MANN & HUMMEL WDK11102/10

4.09 104 3.66 93

4.25 108 10.24 260 G P551021 FUEL PRIMARY 99% @ 5 MTU 0020922801, 002092801 4.06 103 3.66 93

118 mm / 4.65" Diameter Family1 1/16-16 4.67 119 8.94 227 G EFF0047 FUEL SECONDARY 99% @ 5 DETROIT DIESEL ENGINES 4.32 110 3.85 98

4.67 119 8.94 227 G P550959 FUEL SECONDARY 99% @ 16 FORD, GMC 25011026 4.32 110 3.85 98

1 1/4-12 4.67 119 8.94 227 G P550958 FUEL PRIMARY 99% @ 30 DETROIT DIESEL 25011024 4.32 110 3.85 98

4.66 118 10.24 260 G P550202 FUEL PRIMARY 99% @ 9 CUMMINS 299202 4.32 110 3.85 98

4.66 118 12.24 311 A P552216 FUEL/WATER SEPARATOR 99% @ 17 CUMMINS 3309437 4.39 112 3.87 98

4.66 118 12.25 311 A P550937 FUEL/WATER SEPARATOR 99% @ 9 KOMATSU 4.33 110 3.86 98 Yes

4.74 120 12.32 313 A P552006 FUEL/WATER SEPARATOR 99% @ 10 CUMMINS 3089916 4.39 112 3.87 98

1 5/8 –12 4.66 118 11.73 2.98 G P553500 FUEL SECONDARY 99% @ 3 KOMATSU 4.33 110 3.86 98

2 1/4-12 4.65 118 10.38 264 G DBF5782 FUEL SECONDARY 99% @ 4 CUMMINS QSK19, QSK38, QSK50 4.68 119 4.00 102

M90 x 2 4.65 118 8.80 224 G P555776 FUEL SECONDARY 99% @ 5 CUMMINS ISX 4.69 119 4.02 102

4.65 118 11.68 297 G P555686 FUEL SECONDARY 99% @ 5 CUMMINS ISX 4.69 119 4.02 102

136 mm / 5.36" Diameter Family1 3/8-16 5.34 136 12.19 310 G P551316 FUEL PRIMARY 99% @ 3 CATERPILLAR 1R-0755 4.28 109 3.90 99

5.38 137 11.77 299 F P550348 FUEL/WATER SEPARATOR 99% @ 7 DETROIT DIESEL 23512631 4.29 109 3.92 100

5.38 137 12.13 308 G P553080 FUEL PRIMARY 99% @ 9 CAT 8N-3080, 3500 SERIES ENGINE 4.31 109 3.92 100

M39 x 1.5 5.35 136 12.05 306 G P765199 FUEL PRIMARY 99% @ 10 MTU 0020922101 4.29 109 4.33 110

Page 34: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 65 www.donaldson.com

FUEL FILTRATION

I.D. OD LengthPart No. Part Description

Efficiency @ Micron

Primary ApplicationIN MM IN MM IN MM

Fuel FiltrationCartridge Filters

.90 23 3.15 80 7.71 196 P551428 PRIMARY- STANDARD FLOW 99% @ 20 JOHN DEERE

.90 23 3.15 80 7.71 196 P551431 PRIMARY- STANDARD FLOW 99% @ 50 JOHN DEERE, MACK, RVI

.90 23 3.15 80 7.71 196 P551433 FUEL/WATER SEPARATOR- REVERSE FLOW

99% @ 10 CNH, FORD, CAT

.90 23 3.15 80 7.71 196 P551435 PRIMARY- REVERSE FLOW 99% @ 20 JOHN DEEERE, McCORMICK

Fuel Cartridge Filters0.20 5 0.70 18 2.01 51 P550559 FUEL PRIMARY GM 5651921

0.26 7 2.19 56 1.47 37 P550364 FUEL PRIMARY LISTER PETTER 20113112

0.35 9 3.28 83 3.00 76 P505973 FUEL PRIMARY TOYOTA HILUX

0.38 10 2.24 57 2.99 76 P552341 FUEL PRIMARY 99% @ 45 CAT 9M2341, FOR 9M2342 USE 2 P552341

0.43 11 1.38 35 2.44 62 P502134 FUEL PRIMARY 50% @ 16 YANMAR 10450055710

0.43 11 1.38 35 3.39 86 P502166 FUEL PRIMARY 50% @ 16 YANMAR 12455055700, KUBOTA 16271-43560

0.44 11 2.14 54 3.47 88 P550214 FUEL PRIMARY 99% @ 20 CLARK, GMC, IHC, AUTO, PICKUP

0.43 11 2.44 62 2.36 60 P550038 FUEL PRIMARY 99% @ 30 HINO 23401-1060

0.43 11 2.83 72 1.73 44 P502113 FUEL PRIMARY 99% @ 30 MITSUBISHI 3166201031

0.43 11 2.83 72 3.54 90 P550056 FUEL PRIMARY 99% @ 30 NISSAN 16444-29000

0.47 12 1.38 35 3.43 87 P502135 FUEL PRIMARY 50% @ 12 YANMAR 10599155710

0.47 12 1.38 35 3.81 97 P502133 FUEL PRIMARY 50% @ 12 YANMAR

0.49 12 1.42 36 3.54 90 P550645 FUEL PRIMARY YANMAR 11974055600

0.46 12 2.87 73 3.14 80 P550745 FUEL PRIMARY YANMAR 120324-55760

0.47 12 3.30 84 5.53 140 P550349 FUEL PRIMARY MERCEDES, MANN BF900X (FELT)

0.47 12 3.30 84 5.50 140 P550861 FUEL PRIMARY 99% @ 9 DEUTZ, MERCEDES, ATLAS-COPCO, IHC

0.52 13 1.14 29 2.27 58 P552378 FUEL PRIMARY FORD SBA360720020

0.51 13 1.14 29 3.35 85 P502138 FUEL PRIMARY 50% @ 12 KUBOTA 15231-43563, 15231-43560

0.50 13 1.39 35 1.88 48 P550007 FUEL PRIMARY 99% @ 22 IHC, DODGE, FORD, JEEP, MELROE

0.51 13 1.87 47 1.77 45 P551769 FUEL PRIMARY ISUZU 5878101970

0.53 13 2.22 56 4.49 114 P550860 FUEL PRIMARY DEUTZ 1160033 (FELT)

0.52 13 2.75 70 4.52 115 P550481 FUEL PRIMARY CLAAS, HANOMAG, LIEBHERR, MERCEDES, VOLVO

0.53 13 3.30 84 5.30 135 P550061 FUEL PRIMARY DEUTZ 1168469

0.52 13 3.36 85 5.70 145 P550489 FUEL PRIMARY CLAAS, DEMAG, LIEBHERR, MERCEDES

0.50 13 3.81 97 2.85 72 P550437 FUEL PRIMARY 95% @ 5 MOTORCRAFT FD4596, FORD F81Z-9N184-AA

0.55 14 2.60 66 4.30 109 P550060 FUEL PRIMARY 99% @ 9 DEUTZ, ATLAS COPCO (PLEATED PAPER)

0.55 14 4.86 123 3.55 90 P551081 FUEL PRIMARY 95% @ 5 FORD LIGHT TRUCK, INCLUDES SERVICE LID

0.55 14 4.86 123 4.54 115 P551082 FUEL PRIMARY 95% @ 5 FORD LIGHT TRUCK, INCLUDES SERVICE LID

0.56 14 3.56 90 3.99 101 P550966 FUEL/WATER SEPARATOR 50% @ 7 FORD NAVISTAR LIGHT TRUCK

0.57 14 2.83 72 3.35 85 P552563 FUEL PRIMARY 50% @ 20 ISUZU 5-878100500

0.57 14 3.53 90 5.31 135 P550040 FUEL PRIMARY 50% @ 5 HITACHI 4514801, ISUZU 1878100270

0.57 14 3.54 90 5.52 140 P550044 FUEL PRIMARY 99% @ 30 MITSUBISHI 30062-65011

0.57 14 4.00 102 6.32 161 P550042 FUEL PRIMARY 99% @ 30 ISUZU 1878102070

0.59 15 2.80 71 3.93 100 P550039 FUEL PRIMARY HITACHI 4020429

0.58 15 2.93 74 2.91 74 P551339 FUEL PRIMARY 99% @ 30 TOYOTA 0423468010

0.58 15 3.33 84 2.88 73 P552470 FUEL PRIMARY ALLIS CHALMERS 4512207-3CATERPILLAR 666-3172; CHRYSLER J0936407;

MASSEY FERGUSON 1069954-M91

0.53 13 3.30 84 5.30 135 P550061 FUEL PRIMARY DEUTZ 1168469

0.52 13 3.36 85 5.70 145 P550489 FUEL PRIMARY CLAAS, DEMAG, LIEBHERR, MERCEDES

0.50 13 3.81 97 2.85 72 P550437 FUEL PRIMARY 95% @ 5 MOTORCRAFT FD4596, FORD F81Z-9N184-AA

0.55 14 2.60 66 4.30 109 P550060 FUEL PRIMARY 99% @ 9 DEUTZ, ATLAS COPCO (PLEATED PAPER)

0.57 14 2.83 72 3.35 85 P552563 FUEL PRIMARY 50% @ 20 ISUZU 5-878100500

0.56 14 3.56 90 3.99 101 P550966 FUEL/WATER SEPARATOR 50% @ 7 FORD NAVISTAR LIGHT TRUCK

0.57 14 3.53 90 5.31 135 P550040 FUEL PRIMARY 50% @ 5 HITACHI 4514801, ISUZU 1878100270

0.59 15 3.58 91 5.43 138 P502116 FUEL PRIMARY 99% @ 30 MITSUBISHI ME971550, ME971553

0.59 15 3.60 91 6.38 162 P551338 FUEL PRIMARY 99% @ 30 NISSAN 16444Z9027

0.59 15 3.62 92 4.33 110 P550054 FUEL PRIMARY 99% @ 30 MITSUBISHI ME036478

0.59 15 3.61 92 5.28 134 P550055 FUEL PRIMARY 99% @ 30 NISSAN 16444-99128

0.59 15 3.62 92 5.31 135 P550023 FUEL PRIMARY 99% @ 30 NISSAN 16444-90127

0.59 15 4.09 104 4.09 104 P550392 FUEL PRIMARY 99% @ 30 HINO 234011090

Cartridge Filters

Page 35: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

66 • Engine Liquid Filtration www.donaldson.com

FUEL

FILT

RATI

ONFuel FiltrationCartridge Filters

I.D. OD LengthPart No. Part Description

Efficiency @ Micron

Primary ApplicationIN MM IN MM IN MM

Fuel Cartridge Filters0.59 15 4.37 111 5.51 140 P550028 FUEL PRIMARY 99% @ 30 NISSAN 16444-99028

0.62 16 2.59 66 4.47 114 P550120 FUEL PRIMARY 99% @ 20 MANN BF700X

0.62 16 2.93 74 2.20 56 P550673 FUEL PRIMARY 99% @ 25 IHC 478037C1

0.62 16 2.93 74 4.11 104 P550672 FUEL PRIMARY 99% @ 25 KOMATSU 600-311-8210

0.63 16 2.91 74 4.15 106 P550026 FUEL PRIMARY 99% @ 30 ISUZU 9-9885111940

0.63 16 2.95 75 2.60 66 P502118 FUEL PRIMARY 99% @ 30 TOYOTA 0423456010

0.63 16 3.50 89 6.42 163 P550366 FUEL/WATER SEPARATOR FORD 844F9176CAB

0.63 16 3.54 90 2.73 69 P552014 FUEL/WATER SEPARATOR 50% @ 30 RACOR 2010PM

0.63 16 3.54 90 2.73 69 P552013 FUEL/WATER SEPARATOR 50% @ 2 RACOR 2010SM

0.65 17 4.31 109 6.47 164 P550447 FUEL/WATER SEPARATOR 99% @ 20 FLEETGUARD FS1011 FOR OPTIGUARD SYSTEM

0.70 18 1.45 37 3.82 97 P552395 FUEL PRIMARY WHITE 163956AS

0.72 18 3.13 80 5.44 138 P552423 FUEL PRIMARY SERVICE ELEMENT FOR GRAVITY FLOW SERVICE TANKS

0.69 18 4.52 115 8.10 206 P551624 FUEL SECONDARY 99% @ 30 AC TP624 W/PLEATED PAPER

0.75 19 2.95 75 6.97 177 P502196 FUEL PRIMARY 50% @ 20 ISUZU 13240045

0.75 19 3.37 86 4.12 105 P551748 FUEL PRIMARY JOHN DEERE AR45678

0.74 19 3.41 87 2.80 71 P556245 FUEL PRIMARY 99% @ 14 CASE, JOHN DEERE, IHC, MF, ROOSAMASTER

0.75 19 3.44 87 3.41 87 P502169 FUEL PRIMARY 50% @ 10 LEYLAND ABU9642, MAZDA SL07-23570

0.75 19 3.50 89 2.76 70 P551168 FUEL PRIMARY PERKINS 31938

0.75 19 3.50 89 2.80 71 P557111 FUEL PRIMARY CAV FUEL SYSTEM APPLICATIONS

0.74 19 3.50 89 5.28 134 P550394 FUEL PRIMARY MASSEY FERGUSON, PERKINS

0.73 19 3.62 92 5.51 140 P502114 FUEL PRIMARY 99% @ 30 MITSUBISHI ME046010

0.77 19 3.98 101 4.78 121 P552473 FUEL PRIMARY ALLIS CHALMERS BM33761; CUMMINS BM33761; FORD EDL-9176-A; INTERNATIONAL 3054750-R91

0.75 19 4.23 107 4.34 110 P551310 FUEL/WATER SEPARATOR 99% @ 10 CHRYSLER 0488396AA

0.79 20 1.97 50 3.50 89 P502161 FUEL PRIMARY 50% @ 16 YANMAR 12910055650, KUBOTA 15521-43160

0.78 20 4.25 108 6.73 171 P502131 FUEL PRIMARY 50% @ 20 MANN B405C,

0.81 21 2.75 70 3.37 86 P551167 FUEL PRIMARY CHRYSLER 5037896

0.81 21 4.33 110 4.60 117 P552044 FUEL/WATER SEPARATOR 50% @ 30 RACOR 2040PM

0.81 21 4.33 110 4.60 117 P552043 FUEL/WATER SEPARATOR 50% @ 2 RACOR 2040SM

0.81 21 4.67 119 9.60 244 P552024 FUEL/WATER SEPARATOR 50% @ 30 RACOR 2020PM

0.81 21 4.67 119 9.60 244 P552023 FUEL/WATER SEPARATOR 50% @ 2 RACOR 2020SM

0.82 21 3.41 87 4.10 104 P550800 FUEL/WATER SEPARATOR DODGE LIGHT TRUCK, CHRYSLER 68001914AA

0.87 22 3.86 98 6.35 161 P502132 FUEL PRIMARY 99% @ 30 MANN EK405, P1018/1

0.87 22 4.64 118 8.39 213 P550125 FUEL PRIMARY 99% @ 20 CUMMINS 130909,299125

0.91 23 2.19 56 2.48 63 P550567 FUEL PRIMARY PETTER 20332470

0.98 25 3.70 94 7.19 183 P550347 FUEL PRIMARY 99% @ 28 FIAT GEOTECH 1909107

0.97 25 5.00 127 9.75 248 P558600 FUEL PRIMARY KOMATSU 6610-79-8600

0.98 25 5.83 148 8.07 205 P550316 FUEL/WATER SEPARATOR 99% @ 20 CAT, CUMMINS, GROVE

1.00 25 5.81 148 9.37 238 P550043 FUEL PRIMARY 99% @ 20 CUMMINS, HOUGH, MICH 139097, 256834

1.04 26 3.01 76 4.41 112 P550686 FUEL/WATER SEPARATOR 99% @ 25 FRAM CS1133PL SEPARATOR

1.02 26 3.00 76 6.00 152 P550522 FUEL SOCK 99% @ 40 GMC 21029

1.04 26 3.01 76 7.34 186 P550685 FUEL/WATER SEPARATOR 99% @ 25 FRAM CC1133PL COALESCER

1.03 26 2.98 76 7.81 198 P550540 FUEL SECONDARY 99% @ 22 CUMMINS, GMC 5573262

1.04 26 3.01 76 9.70 246 P551162 FUEL PRIMARY CONTINENTAL 12395HE

1.02 26 4.33 110 7.91 201 P551337 FUEL PRIMARY 99% @ 30 NISSAN 1644497001

1.08 27 2.99 76 7.95 202 P550627 FUEL PRIMARY MAN TGA

1.06 27 3.19 81 4.53 115 P550201 FUEL SECONDARY 99% @ 25 MACK 237-GB-28

1.07 27 3.74 95 3.72 95 P502226 FUEL PRIMARY 50% @ 20 ISUZU 1132401940

1.10 28 2.90 74 2.37 60 P550560 FUEL SOCK CASE A35863, A36557

1.10 28 3.40 86 3.27 83 P553261 FUEL SECONDARY 99% @ 20 GMC 5573261

1.12 28 3.37 86 6.50 165 P558792 FUEL PRIMARY 99% @ 10 CAT 4H-8792, 9H-4729, 6H-5932

1.12 28 4.00 102 8.75 222 P550541 FUEL SOCK 99% @ 40 GMC 5574980

1.12 28 4.81 122 9.13 232 P550547 FUEL/WATER SEPARATOR 50% @ 30 CIMTEK EHS30, 300-07

1.12 28 4.81 122 9.13 232 P550607 FUEL/WATER SEPARATOR 50% @ 10 FUEL DISPENCING PUMPS

Cartridge Filters

Page 36: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 67 www.donaldson.com

FUEL FILTRATIONFuel FiltrationCartridge Filters

1.24 31 2.95 75 8.38 213 P550552 FUEL SOCK GMC 5575032

1.32 34 3.48 88 4.80 122 P550501 FUEL PRIMARY 99% @ 9 PUROLATOR F70100 HOUSING

1.50 38 3.35 85 7.11 180 P550628 FUEL PRIMARY SCANIA 164 AND SCANIA MARINE ENGINES DI SERIES

1.53 39 3.46 88 4.45 113 P556287 FUEL PRIMARY C.A.V. 7111/792

1.61 41 3.90 99 9.23 234 P551317 FUEL PRIMARY 99% @ 3 CATERPILLAR 1R-0756

1.62 41 3.93 100 9.25 235 P559850 FUEL PRIMARY 99% @ 22 CATERPILLAR 8N9850, 1R0718

1.73 44 1.38 35 0.45 11 P502115 FUEL PRIMARY 99% @ 30 MITSUBISHI MA125373

1.81 46 3.74 95 6.79 173 P785373 FUEL PRIMARY 99% @ 5 MAN TGL SERIES 51125030061

1.81 46 4.13 105 8.06 205 P550631 FUEL PRIMARY CUMMINS 299631

2.22 56 2.40 61 1.97 50 P550404 FUEL PRIMARY 99% @ 30 TOYOTA 2330034100

2.46 62 5.50 140 10.00 254 P550032 FUEL SOCK 99% @ 40 DETROIT DIESEL

2.60 66 3.35 85 4.43 113 P550527 FUEL/WATER SEPARATOR FORD 3C3Z9N184CA F SERIES PICKUP

2.73 69 3.27 83 5.23 133 P550352 FUEL/WATER SEPARATOR 50% @ 5 GM 10154635, 6.2L DIESEL

3.39 86 3.58 91 3.94 100 P550808 FUEL MERCEDES 6460920501

6.47 164 4.62 117 0.65 17 P550752 FUEL/WATER SEPARATOR Fleetguard FS19559

G 8-36 NA 1.12 28 2.72 69 P502136 FUEL PRIMARY CAT 5S7645

DAVCO Fuel System FiltersDAVCO® and EleMax® are registered trademarks of DAVCO Technology, LLC.

0.66 17 3.45 88 4.44 113 P550460 FUEL/WATER SEPARATOR 99% @ 7 DAVCO 230/232 SERIES DETROIT DIESEL

0.66 17 3.82 97 6.74 171 P550463 FUEL/WATER SEPARATOR 98% @ 7 DAVCO 380/382 SERIES DETROIT DIESEL ENGINES

0.66 17 3.82 97 6.74 171 P550467 FUEL/WATER SEPARATOR 99% @ 7 DAVCO 380/382 SERIES ELEMAX FUEL PROCESSORS

0.66 17 3.82 97 7.00 178 P550736 FUEL/WATER SEPARATOR 98% @ 25 DAVCO 380/382 SERIES ELEMAX FUEL PROCESSORS

0.66 17 3.82 97 7.00 178 P550737 FUEL/WATER SEPARATOR 99% @ 50 DAVCO 380/382 SERIES ELEMAX FUEL PROCESSORS

0.66 17 3.82 97 7.00 178 P550757 FUEL PRIMARY 99% @ 16 DAVCO 230/232 SERIES DETROIT DIESEL

0.66 17 3.81 97 7.03 179 P551052 FUEL/WATER SEPARATOR 99% @ 10 DAVCO 380/382 and CUMMINS FH230 FUEL PRO

0.66 17 4.21 107 6.74 171 P550510 FUEL/WATER SEPARATOR 99% @ 7 DAVCO 102011, 102012

.66 17 4.21 107 7.04 179 P550849 FUEL/WATER SEPARATOR 98% @ 7 DAVCO PLUS SIZE ELEMAX 7 MICRON

.66 17 4.21 107 7.04 179 P550851 FUEL/WATER SEPARATOR 98% @ 25 DAVCO PLUS SIZE ELEMAX 25 MICRON

.66 17 4.21 107 7.04 179 P550853 FUEL/WATER SEPARATOR 99% @ 50 DAVCO PLUS SIZE ELEMAX 50 MICRON

1.04 26 5.83 148 7.61 193 P551011 FUEL/WATER SEPARATOR 98% @ 7 DAVCO 482 SERIES 7 MICRON

Metal-Free Fuel FiltersNA NA 3.54 90 6.22 158 P550908 FUEL PRIMARY CHRYSLER 68061633AA, CUMMINS 5257769

0.55 14 3.74 95 7.97 202 P550762 FUEL PRIMARY 99% @ 15 MERCEDES 5410900151

0.83 21 3.39 86 4.09 104 P550785 FUEL/WATER SEPARATOR 99% @ 10 CHRYSLER 5015581AD

0.82 21 3.74 95 5.59 142 P550657 FUEL/WATER SEPARATOR 99% @ 7 IH DT466 2004 ON

1.06 27 3.62 92 3.98 101 P550632 FUEL PRIMARY 99% @ 8 MERCEDES 0000901551

Racor Turbine System FiltersRacor® is a registered trademark of Parker Hannifin Corporation

0.50 13 1.78 45 2.68 68 P552000 FUEL/WATER SEPARATOR 99% @ 30 RACOR 2000 SERIES

0.63 16 3.25 83 2.44 62 P552010 FUEL/WATER SEPARATOR 99% @ 30 RACOR 2010 SERIES

0.81 21 4.28 109 9.63 245 P552020 FUEL/WATER SEPARATOR 99% @ 30 RACOR 2020 SERIES

0.81 21 4.28 109 4.63 118 P552040 FUEL/WATER SEPARATOR 99% @ 30 RACOR 2040 SERIES

I.D. OD LengthPart No. Part Description

Efficiency @ Micron

Primary ApplicationIN MM IN MM IN MM

Page 37: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

68 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Fuel FiltrationBox-Style Cartridge Filters

P556745 P559803

Width Length HeightPart No. Part Description

Efficiency @ Micron

Primary ApplicationIN MM IN MM IN MM

Box-Style Cartridge Filters2.64 67 4.38 111 2.59 66 P552387 FUEL BOX PRIMARY 99% @ 22 GMC 25010487

2.83 72 4.61 117 2.46 62 P550955 FUEL BOX PRIMARY 99% @ 22 GMC 6.2 DIESEL, STANADYNE 23775

2.83 72 4.62 117 2.46 62 P556285 FUEL BOX PRIMARY 99% @ 10 THERMOKING 116285

2.83 72 4.62 117 2.46 62 P556286 FUEL/WATER SEPARATOR BOX 99% @ 30 THERMOKING 116286

2.83 72 4.62 117 2.46 62 P557264 FUEL/WATER SEPARATOR BOX 99% @ 30 THERMOKING 117264

3.28 83 6.31 160 2.64 67 P551049 FUEL BOX PRIMARY 99% @ 22 GMC V8-379, STANADYNE 27611

3.46 88 3.46 88 2.00 51 P502392 FUEL BOX PRIMARY 99% @ 35 DEUTZ 0319822, VOLVO 14514238

3.71 94 4.95 126 3.15 80 P551130 FUEL BOX PRIMARY 99% @ 22 JOHN DEERE AR50041, STANADYNE 20014

3.71 94 5.04 128 3.28 83 P556745 FUEL BOX PRIMARY 99% @ 22 JOHN DEERE AR86745, STANADYNE 26667

3.71 94 4.95 126 3.34 85 P559803 FUEL BOX PRIMARY 99% @ 22 CAT 8N-9850, STANADYNE 21167

P550955 P550955 P556285

Box-Style Cartridge Filters

P556286

P557264 P551049 P551130P502392

Page 38: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 69 www.donaldson.com

FUEL FILTRATION

P550012PICKUPS AND CARS -- UNIVERSAL 5/16" 2 HOSES 4 CLAMPS

P550016FORD D7TE9155A, MOTORCRAFT FG778 (1 HOSE 2 CLAMPS INCLUDED)

P550090FORD, GMC -- 2 HOSES 4 CLAMPS INCLUDED

P550091FORD, MOTORCRAFT FG14 -- 1 HOSE 2 CLAMPS INCLUDED

P550094UNIVERSAL 1/4" O.D. LINES,

P550126FORD E3FZ9155C

P550209GM Light Truck

P550433CASE IH D145357

P550446JOHN DEERE AR103220, CUMMINS 3318919

P550454FORD D3FZ9155A, D2RY9155A -- 2 HOSES 4 CLAMPS INCLUDED

P550504GM LIGHT TRUCK, AC GF624, G580

P550508AC LIGHT DUTY, GF645, G645

In-Line FiltersP550012 PICKUPS AND CARS -- UNIVERSAL 5/16" 2 HOSES 4 CLAMPS 1.94 49 5/16 4.17 106 5/16 99% @ 40

P550016 FORD D7TE9155A, MOTORCRAFT FG778 (1 HOSE 2 CLAMPS INCLUDED) 1.33 34 5/16 2.71 69 1/8-27 99% @ 100

P550090 FORD, GMC -- 2 HOSES 4 CLAMPS INCLUDED 1.94 49 3/8 3.88 99 3/8 99% @ 22

P550091 FORD, MOTORCRAFT FG14 -- 1 HOSE 2 CLAMPS INCLUDED 1.06 27 5/16 2.86 73 1/8-27 99% @ 100

P550094 UNIVERSAL 1/4" O.D. LINES, 1.94 49 1/4 4.06 103 1/4 99% @ 22

P550126 FORD E3FZ9155C 2.90 74 5/16 5.82 148 5/16 50% @ 23

P550209 GM LIGHT TRUCK 2.17 55 M16 x 1.5 4.29 109 M16 x 1.5 50% @ 23

P550433 CASE IH D145357 1.94 49 3/8 3.88 99 3/8 99% @ 150

P550446 JOHN DEERE AR103220, CUMMINS 3318919 1.89 48 5/8-24 3.54 90 5/8-24 99% @ 150

P550454 FORD D3FZ9155A, D2RY9155A -- 2 HOSES 4 CLAMPS INCLUDED 0.94 24 5/16 2.87 73 5/16 99% @ 100

P550504 GM LIGHT TRUCK, AC GF624, G580 2.28 58 3/8 6.38 162 3/8 50% @ 23

P550508 AC LIGHT DUTY, GF645, G645 2.28 58 M16 x 1.5 5.35 136 3/8

Part No. Primary ApplicationOuter. Dia.

Inlet SizeLength Outlet

SizeEfficiency @

MicronIN MM IN MM

In-Line Filters

Fuel FiltrationIn-Line Filters

Page 39: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

70 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Fuel FiltrationIn-Line Filters

P550593FORD MOTORCRAFT FG19B

P550967FORD LIGHT TRUCK

P550974CUMMINS 3826094, CASE IH STX

P551759CHRYSLER 4554040

P551760ISUZU 825053640, 8251217780

P551770Komatsu 20704A1100

P551771GM 25055347

P551772FORD F89Z9155A

P552366GM 5651944

P552371GMC 25121293

P552376AMC 8933000076

P550556MOTORCRAFT FG1036

Part No. Primary ApplicationOuter. Dia.

Inlet SizeLength Outlet

SizeEfficiency @

MicronIN MM IN MM

P550556 MOTORCRAFT FG1036 2.22 56 3/8 7.00 178 3/8 50% @ 23

P550593 FORD MOTORCRAFT FG19B 0.78 20 5/16 2.17 55 7/8-20 99% @ 100

P550967 FORD LIGHT TRUCK 3.08 78 5/16 6.77 172 5/16 50% @ 23

P550974 CUMMINS 3826094, CASE IH STX 1.94 49 3/8 3.93 100 3/8 99% @ 150

P551759 CHRYSLER 4554040 2.16 55 3/8 6.37 162 5/16 50% @ 23

P551760 ISUZU 825053640, 8251217780 2.32 59 5/16 5.47 139 5/16 50% @ 23

P551770 KOMATSU 20704A1100 1.88 48 1/2 4.34 110 1/2 99% @ 150

P551771 GM 25055347 2.00 51 1/2 4.35 110 1/2 50% @ 23

P551772 FORD F89Z9155A 2.30 58 5/16 7.00 178 5/16

P552366 GM 5651944 2.28 58 5/8-18 4.75 121 3/8 50% @ 23

P552371 GMC 25121293 2.17 55 3/8 5.47 137 M16 x 1.5 50% @ 23

P552376 AMC 8933000076 3.07 78 3/8 6.06 154 5/16 50% @ 23

In-Line Filters

Page 40: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 71 www.donaldson.com

FUEL FILTRATIONFuel Filtration

In-Line Filters

Part No. Primary ApplicationOuter. Dia.

Inlet SizeLength Outlet

SizeEfficiency @

MicronIN MM IN MM

P552394GMC 25175542; Nissan 16400-D0100, Toyota

P552397GMC 25121472

P552398Mitsubishi MB504753, MB658689; Toyota 23030-74020, 23300-19045

P552399GMC 25010487

P552400Chrysler MB504732, MB504750; Suzuki 15410-61A00

P552401Mitsubishi MB433774

P552403Chrysler 4443452, 4443454, 4549712

P552437Nissan 16400-72L00

P552439Chrysler 4708317, 52019023, 52020016

P552442Audi 893133511; Ferrari 117792; Volkswagen 447133511; Volvo 13895628

P552448GMC 25121978

P552482JOHN DEERE RE38818

P552394 GMC 25175542; NISSAN 16400-D0100, TOYOTA 4.05 103 9/32 2.31 59 9/32 50% @ 23

P552397 GMC 25121472 2.28 58 3/8 6.47 164 3/8 50% @ 23

P552398 MITSUBISHI MB504753, MB658689; TOYOTA 23030-74020, 23300-19045 2.80 71 M14 x 1.5 4.37 111 M12 x 1.25 50% @ 23

P552399 GMC 25010487 2.05 52 5/16 2.11 54 5/16

P552400 CHRYSLER MB504732, MB504750; SUZUKI 15410-61A00 2.80 71 M12 x 1.25 5.04 128 M12 x 1.25 50% @ 12

P552401 MITSUBISHI MB433774 2.07 53 5/16 2.82 72 5/16

P552403 CHRYSLER 4443452, 4443454, 4549712 2.18 55 5/16 4.74 120 5/16 50% @ 11

P552437 NISSAN 16400-72L00 2.50 64 5/16 5.00 127 5/16 50% @ 23

P552439 CHRYSLER 4708317, 52019023, 52020016 2.15 55 5/16 6.22 158 5/16 50% @ 23

P552442 AUDI 893133511; FERRARI 117792; VOLKSWAGEN 447133511; VOLVO 13895628

3.46 88 M14 x 1.5 5.86 149 M12 x 1.5 50% @ 23

P552448 GMC 25121978 2.28 58 3/8 6.37 162 3/8 50% @ 23

P552482 JOHN DEERE RE38818 1.94 49 9/16-18 3.65 93 9/16-18 99% @ 150

Page 41: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

74 • Engine Liquid Filtration

FUEL

FILT

RATI

ON

www.donaldson.com

Diesel Fuel Filter Kits Available in Australia Only

Contaminated fuel can lead to equipment and vehicle downtime resulting in costly repairs.Donaldson's range of Diesel Fuel Filter Kits have you covered from overhead and portable tanks, light to medium trucks and common rail applications.

Bulk Fuel Tank Kit For low flow applications. Ideal solution for overhead and portable tanks

Features and Benefits• Simple spin-on design for ease of service

• Filtration efficiency 99.5% removal of particles 10 micron or larger (ß10=200)

• Water absorbing media

• T.R.A.P. breather included with kit to help remove moisture and airbourne contaminant, replaces desiccant and silica gel style breathers

• Kit includes adapters for head and breather to connect to connect to BSP fittings

Kit Part Number P902973

Chassis Mount Diesel Fuel Filter Kit For diesel platforms with flow rates up to 379LPH

Features and Benefits• Ideal for ligh to medium trucks

• Filtration efficiency 99% removal of particle 3 micron or larger (ß3=100)

• Water separating filter and drain bowl

• Includes additional filter element

Kit Part Number P903074

NoteProduct featured on this page is available in Australia. Contact Donaldson Australasia Customer Service on 1800 345 837 to find a distributor near you.Further information can be found on www.donaldsontoolbox.com.au

Fuel FiltrationFilter Kits

See pages 34 for additional diesel tank filtration kits.

Diesel Fuel Filter KitChassis Mount

DIESEL FUEL FILTER KITCHASSIS MOUNTFor Diesel Platforms with Flow Rates up to 379LPH

ADDEDPROTECTIONFOR COMMONRAIL ENGINES

IDEAL FOR

TRUCKS99% efficient at removing fine particles from your fuel*

95% efficient at removing water from your fuel†

Includes bonus filter!

www.donaldsonfilters.com.auDonaldson Australasia Pty Ltd PO Box 153, Wyong NSW 2259. Freecall: 1800 FILTER / 1800 345 837. Ph: +61 2 4350 2000

Donaldson New Zealand PO Box 14-770, Panmure 1741 Auckland. Ph: +64 9 579 2790

Part Number: P903074

Diesel Fuel Filter Kit Chassis Mount

www.buydonaldson.com

Kit Packaged in Australia

KIT INCLUDES EVERYTHING YOU NEED TO GET GOING!

Filter Head PLUS 3/8” fuel barbs (2 straight)PLUS 2 x 3 micron spin-on fuel water separator filtersPLUS Donaldson’s revolutionary new clear bowl option

Modern engines increasingly require better fuel filtration technology to ensure you are delivering the cleanest fuel to your vehicles fuel system. Donaldson’s Diesel Fuel Filter Kit Chassis Mount can be used in conjunction with the current filtration system as a pre-filter to help provide additional protection for your fuel delivery system or any application where the fuel pump delivery does not exceed 379 litres per hour.

Contaminated fuel can lead to vehicle downtime and costly repairs, especially to expensive common rail systems and components.

DID YOU KNOW?

+

+SPARE

+To attach bowl, simply unscrew the Twist and Drain valve, screw bowl on to filter, then screw the drain valve back on.

Necessary Mounting Dimensions:38mm

83mm

238mm

54mm

83mm

10mm

263mm

25mm

*Filter efficiency: Beta rating 3µ@ß100 (99% efficient at removing particles 3µm or larger)

†Water removal as per SAE J1488 Emulsified: 95% efficiency.

Water removal as per SAE J1839 Free Water: 95% efficiency

For diesel and bio-dieselblends up to B20

Ideal as an extrapre-filter for most trucks and all engines with fuel pump flow rates up to 379 litres per hour

Kit includes spare filter for next service

Added protection for common rail engines

D300126

Page 42: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Engine Liquid Filtration • 75 www.donaldson.com

FUEL FILTRATIONCommon Rail Diesel Fuel Filter Kit For diesel platforms with flow rates up to 114LPH

Features and Benefits• Ideal for many 4WD applications

• Filtration efficiency 99% removal of particle 11 micron or larger (ß11=100)

• Water separating filter and drain bowl

• Includes additional filter element

Kit Part Number P902976Diesel Fuel Filter KitPart Number: P902976

Necessary Mounting Dimensions:38mm

83mm

238mm

54mm

83mm

10mm

263mm

25mm

ADDEDPROTECTIONFOR COMMONRAIL ENGINES

IDEAL FOR

4WD’s99% efficient at removing fine particles from your fuel*

95% efficient at removing water from your fuel†

DIESEL FUEL FILTER KITFor Diesel Platforms with Flow Rates up to 114LPH

Includes bonus filter!

KIT INCLUDES EVERYTHING YOU NEED TO GET GOING!

+To attach bowl, simply unscrew the Twist and Drain valve, screw bowl on to filter, then screw the drain valve back on.

++ ++

+

++ SPARE

Filter Head

PLUS

3/8” fuel barbs (2 straight & 1 right-angle)

PLUS

2 x 11 micron spin-on fuel water separator filters

PLUS

Donaldson’s revolutionary new clear bowl option

Modern engines are increasingly requiring better fuel filtration technology to ensure you are delivering the cleanest fuel to your vehicles fuel system. Donaldson’s Diesel Fuel Filter Kit can be used in conjunction with the current filtration system as a pre-filter to help provide additional protection for your fuel delivery system or any application where the fuel pump delivery does not exceed 114 litres per hour.

Contaminated fuel can lead to vehicle downtime and costly repairs, especially to expensive common rail systems and components.

DID YOU KNOW?

www.donaldsonfilters.com.auDonaldson Australasia Pty Ltd PO Box 153, Wyong NSW 2259. Freecall: 1800 FILTER / 1800 345 837. Ph: +61 2 4350 2000

Donaldson New Zealand PO Box 14-770, Panmure 1741 Auckland. Ph: +64 9 579 2790

*Filter efficiency: Beta rating 11µm@ß100 (99% efficient at removing particles 11µm or larger)

†Water removal as per SAE J1488 Emulsified: 95% efficiency.

Water removal as per SAE J1839 Free Water: 95% efficiency

For diesel and bio-dieselblends up to B20

Ideal as an extrapre-filter for 4WDs and all engines with fuel pump flow rates not exceeding 114 litres per hour

Kit includes spare filter for next service

Added protection for common rail engines

Diesel Fuel Filter Kit

www.buydonaldson.com

Kit Packaged in Australia

D300126

High Efficiency Diesel Fuel Filter Kit For diesel platforms with flow rates up to 114LPH

Features and Benefits• Ideal for many 4WD applications

• Filtration efficiency 99% removal of particles 3 micron or larger (ß3=200)

• Water separating filter and drain bowl

• Includes additional filter element

Kit Part Number P903316

Clean and Dry Diesel Filter Kit For diesel fuel applications up to 189LPM

Features and Benefits• Ideal for service vehicles, mobile tanks, fixed bulk tanks

• Maxium working pressure 350 psi

• Includes single head (2), high efficiency diesel filter, water absoring filter, pressure gauge (2)

Kit Part Number P506073

Fuel FiltrationFilter Kits

Available in Australia Only

Page 43: Donaldson Engine Liquid Product Guide · - Patch testing to measure cleanliness - Changing filters Fuel Filtration Clean Fuel Carts. 34 • Engine Liquid Filtration FUEL FILTRATION

Liquid Filtration SolutionsFor Selective Catalytic Reduction (SCR) Systems

Bosch® Denoxtronics 1.0 Urea Injection SystemPrimary Application: DAF 1819795Overall Dimensons: 69mm OD, 75mm Long

In order to meet current and future Exhaust Emission Regulation, Selective Catalytic Reduction (SCR) are fitted with liquid AdBlue® (urea) injection systems which require high performance and reliable filtration.

Compressible devices in the Donaldson filter absorb urea volume expansion at low temperatures (≤-11°C/ 12°F), adapting to extreme freezing conditions.

• They will not wear down or deteriorate during the filter’s useful service life• They are compatible with AdBlue® liquid as well as diesel fuel and other types of engine liquids

NoteProduct featured on this page is available in Europe and Australia. For other regions, please contact your Donaldson representative for availability.

Denox 1.0 and 2.0 AdBlue® Filter KitsAvailable in Europe and Australia Only

Kit Part No. X770734 Competitive Cross References Name Part No.AGCO ........................ V837062993BALDWIN ........................ PE5271DEUTZ ............................ 2934622CUMMINS ...................... 3986767HENGST .................... E100UD160IVECO .............................. 2997594IVECO ............................ 42555073IVECO ............................ 42555548IVECO ............................ 42561605JURA FILTRATION ....... SN70318MANN & HUMMEL .... U630XKITNEW HOLLAND ........... 84254852RENAULT VI .............. 7420877950RENAULT VI ............. 7420877953RENAULT VI .............. 7421333098SF-Filter ........................... SAB541VOLVO ........................... 20876498VOLVO ........................... 20876502VOLVO ........................... 21333097VOLVO ........................... 21333097

Bosch® Denoxtronics 2.0 Urea Injection SystemPrimary Application: Volvo Truck FE, FH, FL, FM Series, 20876498Overall Dimensons: 68mm OD, 96mm Long

AdBlue® is a registered trademark of the Verband der Automobilindustrie e.V (VDA).Bosch® is a registered trademark of Robert Bosch GmbH

ADBL

UE ®

FILT

ER K

ITS

Kit Part No. X770733 Competitive Cross References Name Part No.BALDWIN ........................ PE5270BOSCH ..................... F00BH40012BOSCH ..................... F00BH40096CUMMINS ...................... 3967874DAF .................................. 1649425DAF .................................. 1674458DAF .................................. 1674485DAF .................................. 1789050DAF .................................. 1815766DAF .................................. 1819795DAF ................................ 18819795DAF ................................ 42553548DAF .................................... 649425HENGST .................... E101UD178IVECO ............................ 42553548IVECO ............................ 42561571IVECO ............................ 42562233JURA FILTRATION ........SN70332MAN ........................ 81154036015MAN ........................ 81154036089MANN & HUMMEL ................. U6202XKIT, U6202YKIT................. U6203YKIT, U6204XKITNEOPLAN ............... 81154036015NISSAN/UD ............ 20421NY00JSCANIA ........................... 1545482SCANIA ........................... 1761034SCANIA ........................... 1795459SCANIA ........................... 1852188SCANIA ........................... 1907422SF-Filter .................... SAB540SETSOLARIS BUS (PL) ... 0120322535SOLARIS BUS (PL) ..... 120322535VOLVO ............................ 20713630VOLVO ............................ 20713636

78 • Engine Liquid Filtration


Recommended