COLLECTIVE VENTILATION
03
400° C - 1/2 hCMV/Collective extraction units Flow rate 400 to 11400 m3/h
NOE®
RANGE
CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com P21
3
P22 CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com
COLLECTIVEVENTILATION3 NOE®C4 EXTRACTION UNIT
DESCRIPTION
Ventilation unitPULLEY/BELT TRANSMISSION
400 to 11400 m3/h
CTICM C4 - 400° C - 1/2 h approved Report no. 09-E-544
CSTB technical notification for Hygro A, Hygro B and Hygro Gas usage
CMV POWER selection software
APPLICATION• Intended mainly for air extraction in houses and public assembly
buildings requiring high flow rates.
• C4, 400°C 1/2 h certified 50 Hz and 60 Hz.
RANGE• Comprising 10 models, it covers flow rates from 400 to 11400 m3/h in
a number of configurations.
INSTALLATION• Can be installed internally or externally.
• Easy access to all internal parts.
• May be fully dismantled.
CONSTRUCTION• Housing: galvanized steel sheet. Amply dimensioned, it offers
powerful air handling and acoustic performance characteristics.
• Internal access via two removable panels.
• Bird protection grid on discharge.
• Circular nozzles with double lip seal for watertight networks(ATEC CSTB No. 13-224-V2).
• Local padlockable switch on front panel.
• Pressure switch factory-fitted in the unit and set to 80 Pa (Gas CMV).Time delay possible (see MISTRAL 30 S unit option).
• External pressure tap to check air flow.
• Vibration pads incorporated under the chassis of the motorised fan unit.
s SILENCE version 400°C 1/2 h certified. The insulation of the unitusing 25mm M0 mineral wool allows acoustic performancecharacteristics compliant with the requirements of the newregulations to be achieved.
MOTOR FAN• Transmission by pulley and belt, motor pulley variable when stopped.
• Three-phase one-speed motor, IP55 F, 230/400V-3, 50 Hz.
• Door opening sensor available for office ventilation.
• Centrifugal impulse turbine with double opening.
• Flexible connection from turbine to unit.
• Spare belt supplied.
The units are available in two versions:H: 1 horizontal intake Ø D1 + 1 horizontal discharge Ø D2 in-lineV: 1 horizontal intake Ø D1 + 1 horizontal intake Ø D2 + 1 vertical discharge LxL1
Reference to be given in the order:
NOE 3000 SILENCE H 1 2 3 41: Unit 400° C/1/2 h pulley belt transmission2: Maximum flow rate in use3: SILENCE version 400° C 1/2 h certified4: Installation configuration
H = in-line discharge / V = 1 or 2 horizontal intakes and vertical discharge
NOE 4800 - V 1 2 3 4
CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com P23
3NOE®DIMENSIONS CHARACTERISTICS
NOE®ELECTRICAL CHARACTERISTICS
NOE® A B H X Y A1 L1 L D2 H1 D1 H1 D2 H1 (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (mm) (kg) (kg) (kg)
2600-3000 900 585 580 940 470 370 330 271 400 320 400 320 315 320 55/57 60/62 5
3400-3800 1000 650 680 1040 520 380 360 298 450 360 450 360 400 360 72/74 78/80 6
4800-5600 1110 740 780 1150 575 400 420 355 500 375 500 375 450 375 86/88 93/95 7
6800-8000 1300 860 880 1340 670 450 500 407 630 455 630 455 500 455 119/122 129/132 10
10000-11400 1400 940 980 1440 720 410 585 490 710 485 710 485 630 485 154/159 165/170 12
Lenght Width Height Lenght Width Position Width Lenght Ø Floor centreline distance Ø Floor centreline distance Ø Floor centreline distance NOE® NOE® SILENCE tray
*Overall depth of LOBBY® unit
Reference
Motor power Current protection Rotation speed Power supply (kW) at 400 V (A) (rpm) (V/phases/Hz)
NOE® 2600 0,37 1,1 865 / 1100 230-400 / 3 / 50
NOE® 3000 0,55 1,4 975 / 1240 230-400 / 3 / 50
NOE® 3400 0,55 1,4 740 / 940 230-400 / 3 / 50
NOE® 3800 0,75 1,9 880 / 1120 230-400 / 3 / 50
NOE® 4800 0,75 1,9 650 / 830 230-400 / 3 / 50
NOE® 5600 1,10 2,6 720 / 940 230-400 / 3 / 50
NOE® 6800 1,10 2,6 540 / 700 230-400 / 3 / 50
NOE® 8000 1,50 3,5 600 / 780 230-400 / 3 / 50
NOE® 10000 1,50 3,5 470 / 580 230-400 / 3 / 50
NOE® 11400 2,20 4,8 530 / 655 230-400 / 3 / 50
Dim. unit Ground Discharge version V Discharge version H Intake versions H and V Intake version V on Weight Weight of Reference overall fixing from the top on side of local switch opposite local switch side of local switch condensate
P24 CALADAIR I 61 rue de Saint Véran I 71000 MÂCON LOCHÉ I Tél. 33 (0)3 85 36 82 00 – Fax 33 (0)3 85 36 82 01 I www.caladair.com
COLLECTIVEVENTILATION3 NOE®ACOUSTIC
CHARACTERISTICS
• The Lp4m dB(A) ( ) values shown on the curves relate to the average overall acoustic pressure level radiated in a free field on a reflecting plane,unit discharge not connected. These values also enable you to obtain the spectrum for NOE® SILENCE units.
• The Lw cond dB(A) ( ) values shown on the curves relate to the average overall acoustic pressure level radiated in the intake duct for a NOE®
device.
• To obtain the overall Lw cond dB(A) for a NOE® SILENCE, ôter 5 dB(A) subtract 5 dB(A) from the overall Lw cond dB(A) ( ) value shown on thecurves.
• To obtain the acoustic power spectrum radiated in the intake duct in dB(A) for a non-insulated NOE®, device, add the correction coefficientsfrom the table below to the Lw cond dB(A) ( ) value shown on the curves
• To obtain the acoustic power spectrum radiated in the intake duct in dB(A) for a NOE® SILENCE device, add the correction coefficients fromthe table below to the acoustic spectrum of a non-insulated device dB(A) obtained using the table above.
• To define the average overall acoustic pressure level radiated at a certain distance in dB(A) in free field on a reflecting plane, discharge unit notconnected, add the value from the table below to the Lp4m dB(A) ( ) value shown on the curves.
Lp weighting at various distances
Distance 2 m 3 m 4 m 5 m 7 m 10 m
Distance weighting 6 2 0 -2 -5 -8
Intake acoustic spectrum weighting for non-insulated NOE® as a function of the Lw cond dB(A) ( ) valuesshown on the curves
Frequency 63Hz 125Hz 250Hz 500Hz 1000Hz 2000Hz 4000Hz 8000Hz
NOE® 2600 and 3000 dB(A) weighting -35 -18 -16 -9 -5 -5 -9 -19
NOE® 3400 and 3800 dB(A) weighting -33 -18 -13 -9 -5 -5 -8 -17
NOE® 4800 and 5600 dB(A) weighting -30 -16 -14 -9 -5 -5 -9 -19
NOE® 6800 and 8000 dB(A) weighting -29 -19 -11 -8 -6 -5 -8 -17
NOE® 10000 and 11400 dB(A) weighting -27 -18 -12 -7 -6 -5 -9 -18
Tolerance: Overall values +/- 3 dB(A) Acoustic spectrum +/- 5 dB(A)
• Overall acoustic pressure level radiated rejection :Lw rejet dB(A) = Lp4m dB(A) ( ) + 20
NOTA : The curves are made with a suction and discharge nozzle connected sub-woofer is not connected (C configuration according to NF N 13141-4).
Intake acoustic spectrum weighting for NOE® SILENCE as a function of the intake acoustic spectrum for non-insulated NOE®
Frequency 63Hz 125Hz 250Hz 500Hz 1000Hz 2000Hz 4000Hz 8000Hz
Weighting pour NOE® SILENCE dB(A) 0 -1 -2 -4 -4 -6 -6 -8
P25
3NOE®SELECTIONCURVES
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 200
160 400
240 600
100
300
500
320 800
700
1000 2000 3000
Po
wer
co
nsu
mp
tio
n (
W)
hygro à 960 tr/minhygro à 960 tr/min
mini à 865 tr/minmini à 865 tr/min
maxi à 1100 tr/minmaxi à 1100 tr/min
72
49 51
74
5167
74
44
72
49
67
44S
tati
c p
ress
ure
(P
a)
Flow rate (m3/h)00
0
160
80
240
0
200
400
600
800
100
300
500
700
1000 2000 3000
Po
wer
co
nsu
mp
tio
n (
W)
320
1040 tr/min1040 tr/min
mini à 975 tr/minmini à 975 tr/min
maxi à 1240 tr/minmaxi à 1240 tr/min
69
46
69
75
52
75
5275
52
77
54
46
Flow rate (m3/h)00
0 0
80 200
160 400
240 600
320 800
100
300
500
700
20001000 3000 4000
Po
wer
co
nsu
mp
tio
n (
W)
hygro à 820 tr/minhygro à 820 tr/min
mini à 740 tr/minmini à 740 tr/min
maxi à 940 tr/minmaxi à 940 tr/min
Sta
tic
pre
ssu
re (
Pa)
73
50
77
54
67
44
71
48
73
50
69
46
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 200
160 400
240 600
320 800
400 1000
100
300
500
700
900
1000 2000 40003000
Po
wer
co
nsu
mp
tio
n (
W)
1000 tr/min1000 tr/min
mini à 880 tr/minmini à 880 tr/min
maxi à 1120 tr/minmaxi à 1120 tr/min
75
52
76
53
79
56
70
4779
56
74
51
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0
80
240
160
200
400
600
800
1000
300
500
700
900
2000 50001000 3000 4000
Po
wer
co
nsu
mp
tio
n (
W)
320
hygro à 710 tr/minhygro à 710 tr/min
mini à 650 tr/minmini à 650 tr/min
maxi à 830 tr/minmaxi à 830 tr/min
73
50
74
51
77
54
75
5270
47
68
45
NOE® 2600
NOE® 3000
NOE® 3400
NOE® 3800
NOE® 4800
P26
COLLECTIVEVENTILATION3 NOE®SELECTION
CURVES
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 400
200
160 800
600
240
1800
1600
1400
1200
1000
320
400 2000
2000 4000 6000
Po
wer
co
nsu
mp
tio
n (
W)
840 tr/min840 tr/min
mini à 720 tr/minmini à 720 tr/min
maxi à 940 tr/minmaxi à 940 tr/min
76
53
78
55
80
5770
4780
57
73
50
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 400
160 800
240 1200
320 1600
200
600
1200
1400
40002000 6000 8000
Po
wer
co
nsu
mp
tio
n (
W)
hygro à 590 tr/minhygro à 590 tr/min
mini à 530 tr/minmini à 530 tr/min
maxi à 700 tr/minmaxi à 700 tr/min
77
54
74
51
74
5174
51
71
4845
68
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 500
160 1000
240 1500
320 2000
250
750
1250
1750
2000 4000 80006000
Po
wer
co
nsu
mp
tio
n (
W)
700 tr/min700 tr/min
mini à 600 tr/minmini à 600 tr/min
maxi à 780 tr/minmaxi à 780 tr/min
78
55
71
48
59
75
77
54
82
52
80
57
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 500
160 1000
240 1500
320 2000
250
750
1250
1750
6000 800040002000 10000
Po
wer
co
nsu
mp
tio
n (
W)
hygro à 500 tr/minhygro à 500 tr/minmini à 470 tr/minmini à 470 tr/min
maxi à 580 tr/minmaxi à 580 tr/min
73
79
56
80
69
46
75
52 52
50
5775
Sta
tic
pre
ssu
re (
Pa)
Flow rate (m3/h)00
0 0
80 800
160 1600
240 2400
320 3200
400
1200
2000
2800
Po
wer
co
nsu
mp
tio
n (
W)
8000 120004000
600 tr/min600 tr/min
mini à 500 tr/minmini à 500 tr/min
maxi à 655 tr/minmaxi à 655 tr/min
77
54
83
60
71
48
80
57
83
60
75
52
NOE® 5600
NOE® 6800
NOE® 8000
NOE® 10000
NOE® 11400
