+ All Categories
Home > Documents > From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble...

From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble...

Date post: 26-Mar-2015
Category:
Upload: connor-napier
View: 219 times
Download: 3 times
Share this document with a friend
Popular Tags:
34
Transcript
Page 1: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.
Page 2: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

From the Box to Packing in 30 minutes

Page 3: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Pack-in-a-Box components

• Remove components and assemble bracket as shown

• Follow the instructions to pack your first column and learn how to use the system

Page 4: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Additional Equipment & Chemicals

• ¼” wrench• 5/8” wrench• 7/16” wrench• Phillips head screwdriver• 30ml beaker• Waste container• Methanol• Chloroform• Spatula• Balance• Computer• Ultrasonic bath

Page 5: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

• Pre assembled for supplied SSI column hardware.

Column Packer Assembly

Page 6: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Mounting Packing Stand to Pump

• Screw stand to side of pump using the two #6 screws provided.

Page 7: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Plumbing the Pump

Page 8: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Priming pumpsUse MeOH for this

column• Open prime purge

valve press prime button

• With prime purge valve open use the supplied syringe to draw solvent through the pump

• Prime pump

• When pump is primed close the prime purge valve

Page 9: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Packing Ring Seal Installation

• Place ring in adapter as shown

• Make sure ring is flat in bottom of adapter

Page 10: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Packer Mounted to Stand

• Mount packer to stand and tighten wing nuts

• No wrenches are required to seal reservoir

• Hand tighten end nuts

Page 11: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Column Assembly

• Assemble lower fitting of column and add frit to top end fitting and set aside to put on column after it is packed.

Page 12: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

System Assembled Correctly

• The use of the Quick-Set software is not required but gives the most flexibility and will be used for this example

Page 13: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Installing Quick Set

• Insert Disk• Run the Quick-Set “setup.exe”

program file & follow prompts.• Due to the many versions of

Windows in use, your PC may have newer files than the ones being loaded. You will be prompted for a course of action, when in doubt, “keep” your existing files or “ignore” other messages.

• Connect RS 232 Cable provided to the computer and pump

• Turn on pump

Page 14: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Click QuickSet

• Go to Start/Programs

• Click on Quick-Set

• The screen below appears with the information on the program

Page 15: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Automatic Set Up

Initial screen is for locating the SSI / LA pump

  If communication does not initialize or if the pump is not on this list: Click on the “Poll Com Port For Device” button.

This will scan 9 possible PC COM ports for the attached device.

When the device is found, click on the” Continue” button.

Page 16: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Getting To CP Screen

Page 17: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Setting Flow and Pressure

• Set to pressure limited ramp and click ‘send’

• Set upper pressure to 9999 psi; click ‘send’

• Set lower pressure to 0 psi; click ‘send’

• Set ramp speed to 100; click ‘send’

• Set max flow and pressure from table

Page 18: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Adding Steps

Page 19: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Packing program to load

Pressure Flow Rate Time

9000 24 1

9000 23 5

9000 22 30

Send to pump

Page 20: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Saving Your Packing Program

• Click on “Save Settings”

• Enter file name

• Save

Page 21: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Mounting Column

• Make sure packing ring seal is in adapter

• Hand tighten column in adapter

• Place plug in bottom of column

• Remove plug just prior to starting pump

Page 22: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Tighten Column on Packer

• Use a ¼” wrench and 5/8” or adjustable wrench to snug column to packer

• Do not over tighten ¼ turn past snug is fine

• Fill column with 3 mL MeOH

Page 23: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Setting up Graphing and Data Collection

Page 24: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Saving Packing Data

• Select Log data

• Give file a name

Page 25: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Making the Slurry

• Weigh 3 gm of silica into 30 mL beaker

• Add 20 ml of 50:50 Chloroform:Methanol (Straight MeOH can be used but is not as efficient)

• Use a spatula to break up packing• Place in ultrasonic bath until

uniformly dispersed• Pour in packing reservoir as soon as

possible and pack column

Page 26: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Adding Slurry

• Use 20 mL of silica slurry and pour carefully into reservoir

• Fill reservoir with washings of beaker and close

Page 27: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Is It Closed?

• Make sure the reservoir is full with slurry

• Remove silica from threads

• Hand tighten top nut

Page 28: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Make Sure You Are Ready

• Is the program loaded?• Is the pump primed?• Is there a waste collection

vessel below the column?• Did you tighten the fittings?• Is there slurry in the reservoir

and is the reservoir closed?• Are you set to graph the process

and save your data?• If so, proceed

Page 29: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Packing The Column

• To run program, click on “Pump;” or if program is loaded click on “Start”

Page 30: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Initial Packing Profile

Page 31: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Running a Column Packing Profile

Page 32: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Removing the Column

• Stop the pump and let the pressure drop to 0 psi

• Carefully unscrew the column, and using a flat spatula or razor blade, remove excess silica

• Remove silica from threads if present

• Place end fitting and frit on column and seal

Page 33: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Removing Excess Silica

• Work quickly with a spatula edge or razor blade

Page 34: From the Box to Packing in 30 minutes Pack-in-a-Box components Remove components and assemble bracket as shown Follow the instructions to pack your first.

Getting Ready to Pack Again

• Pump remaining silica from precolumn for reuse or disposal

• Empty reservoir

• Install next column and repeat steps


Recommended