G - CREATED -002 AND -003 CONFIGURATIONS 10/29/2018 - H - … · all equipment options shown for...

2. PREFERRED LIMITS AND FITS PER ANSI B4.1 (INCHES).1. DIMENSIONING & TOLERANCING PER ASME Y14.5M.

NOTES:

ALL EQUIPMENT OPTIONS SHOWN FOR CLAIRITY(GUAGES / MANIFOLDS / REVERSE CYCLE)

FLAGSHIP MARINE, INC.REV. ZONE DESCRIPTION DATE ENG APPROVAL

G - CREATED -002 AND -003 CONFIGURATIONS 10/29/2018 -

H - ADDED WATER IN/OUT TAGS 11/14/2018 -

J - ADDED WIRING, 30032-003 WAS 30032-001 2/20/2019 -

ITEM NO. QTY. PART NUMBER DESCRIPTION

55 2 80280-001 WELDMENT, MANIFOLD, CuNi, (1) SET, 48-72K CHILLERS54 1 80264-001 WELDMENT, BASE, CHILLER, FM24CW - FM84CW53 1 71000-001 TAG, PLATE, SERIAL NUMBER, ANODIZED, ETCHED52 1 70999-001 TAG, WATER IN, ANODIZED, ETCHED51 1 70998-001 TAG, WATER OUT, ANODIZED, ETCHED50 1 70952-001 TAG, MINERAL OIL, ETCHED "COMPRESSOR FILLED WITH MINERAL OIL"49 2 70657-001 FABRICATION, STRAP, FILTER DRIER, CHILLER, FM360CW48 1 70656-001 FABRICATION, BRACKET, LIQUID GAUGE & FILTER DRIER, CHILLER, FM48CW & FM60CW47 1 70655-001 FABRICATION, PANEL, LIQUID GAUGE & FILTER DRIER, CHILLER, FM48CW & FM60CW46 1 70654-001 FABRICATION, BRACKET, EVAPORATOR, CHILLER, FM60CW45 A/R 61000-001 INSULATION, 1/8" FOAM PEEL AND STICK44 A/R 60998-001 TAPE, CORK ROLL, 30"x2"43 1 60861-001 OIL, MINERAL, 1-GALLON42 2 60837-001 COUPLING, REDUCING, 1 1/4 X 1, BRONZE41 2 60836-001 COUPLING, REDUCING, 1 1/4 X 3/4, BRONZE40 3 60824-001 ELBOW, 90 DEG, 1 1/4 FEMALE X 1 1/4 FEMALE, 150 PSI, 304 SS39 1 60823-001 COUPLING, BANDED, 1-1/4, 304 SS38 1 60821-001 NIPPLE, 1-1/4 X 4-1/2, 304 SS37 2 60820-001 NIPPLE, 1-1/4 X CLOSE, 304 SS36 1 60809-001 PLUG, 1/2 SQ. HD. CORED, BRONZE35 2 60722-001 ANODE, ZINC, 3/4" NPT, 3.5" L, 3606K934 4 60560-001 WASHER, 3/8" FINISH 18-8 SS33 8 60539-001 NUT, 3/8-16 NYLON LOCK NUT 18-8 SS32 4 60534-001 WASHER, 3/8" X 1.25" , FLAT31 8 60531-001 RIVET, 3/16" DIA. .126-.250" GRIP RANGE TS, SS30 4 60526-001 NUT, #8-32 MACHINE SCREW NUT 18-8 SS29 10 60517-001 SCREW, #8-32 X 3/8" PAN HEAD MACHINE SCREW, #2 DRIVE PHILLIPS, 18-8 SS28 4 60511-001 WASHER, #8 X 7/16"OD SAE FLAT WASHER 18-8 SS27 A/R 60329-001 REFRIGERANT, NU-22B26 1 60263-001 COMPRESSOR, SCROLL, 230/1/60, ZR54, 53.5K BTU, 80 X 370 RUN CAP25 1 60205-001 EVAPORATOR, CHILLED WATER, 30 PLATE, FM48CW-FM72CW24 1 60124-001 FILTER DRIER, 48K-72K, 1/2", LIQUID LINE, TYPE LLD164S23 20 60070-001 WASHER, .385 ID X 1.406 OD X .25 THK, 60 DURO EPDM BLACK22 2 60069-001 SWITCH, PRESSURE, OPEN (400) CLOSE (300)21 1 60067-001 SWITCH, PRESSURE, OPEN (35) CLOSE (60)20 1 40131-001 FITTING, TEMP SENSOR WELL, CTRL.19 1 40121-001 GAUGE, LOW PRESSURE, NU22 (R22)18 1 40120-001 GAUGE, HI PRESSURE, NU22 (R22)17 1 40115-001 FITTING, TEE, 1-1/4, MNPT, 304 SS16 1 40114-001 FITTING, BUSHING, 1-1/4" MNPT X 1"FNPT, 304 SS13 2 40107-001 VALVE, ACTUATOR, 1/4" QC X 1/8" FPT, BRASS14 7 40102-001 VALVE, 1/4" STANDARD SERVICE, CAP W/RUBBER O-RING13 1 40095-001 VALVE, EXPANSION, CHARGE ELEMENT AND CAP TUBE, 2-6 TON, KT43VGA12 1 40085-001 VALVE, EXPANSION, EXT. BALANCED, 2-5 1/2-TON, R22/R410a, SBQEBODY3X411 1 40080-001 ORIFICE CARTIDGE, BALANCE PORT, WHITE, 3 1/4 - 5 1/2 TON (R22)/R410a10 1 40030-001 LIQUID FLOW SWITCH, (1)SPDT, NEMA4, 1" - 8" PIPES9 A/R 30230-001 LOOM, SPLIT-TYPE, BLUE TRACER, 1/2", 1100', M125-0120-A8 A/R 30157-001 CONDUIT, LIQUID TIGHT, 1/2", GREY, NON-METALIC7 1 30139-002 CONNECTOR, STRAIGHT PVC LIQUID-TIGHT, 1/2 NM TYPE B CONDUIT6 3 30139-001 CONNECTOR, 90 DEGREE PVC LIQUID-TIGHT, 1/2 NM TYPE B CONDUIT5 1 30032-001 WIRING, CHILLER, FM24CW-FM120CW, 230/1/604 1 20568-001 ASSEMBLY, BRACKET, HALF ROUND BAR, 3/4", FREEZE CONTROL MOUNTING3 2 20223-001 CONDENSER, LIQUID COOLED, 24K-84K SERIES2 1 20014-001 MONITOR, CHILLER, FLAGSHIP MARINE1 1 20012-001 ASSEMBLY,CONTROL BOX, CHILLER, SINGLE COMPRESSOR, 230/1/60, UNIVERSAL

D

C

B

AA

B

C

D

12345678

8 7 6 5 4 2 1

THIS DOCUMENT CONTAINS INFORMATIONPROPRIETARY TO FLAGSHIP

MARINE, INC. NO PART MAY BE REPRODUCED, USED IN ANY FORM,

OR STORED ELECTRONICALLYWITHOUT THE WRITTEN PERMISSION OF

FLAGSHIP MARINE, INC.

PROPRIETARY AND CONFIDENTIAL

NEXT ASSY USED ON

APPLICATION

FINISH

DRAWN

CHECKED

ENG APPR.

MFG APPR.

Q.A.

DATENAME TITLE:

SCALE: 1:4

UNLESS OTHERWISE SPECIFIED:

SWC

TCM

TCM

TCM

-

-

-

-

2/4/2011

SHEET 1 OF 6 DO NOT SCALE DRAWING

DIMENSIONS ARE IN INCHESTOLERANCES:FRACTIONS 1/32ANG: MACH 0 30' BEND 2DECIMALS .XX .01 .XXX .005HOLE .XX .005

INTERPRET GEOMETRICTOLERANCING PER: ASME Y14.5M

63

PERP .003/INSTRAIGHTNESS .005/INFLATNESS .005/INTHREADS: EXTERNAL - CLASS 2AINTERNAL - CLASS 2BMACHINED SURFACES: U.O.S

-

FLAGSHIP MARINE, INC.2427 SE DIXIE HIGHWAY

STUART |FLORIDA | 34996 | USA(772) 283-1609 | (800) 316-6426

FAX (772) 283-4611

-

--

--

- -

- -

--

PART NO. 20064-001

WGT: 432.37 LBS

EAS

ASSEMBLY, CHILLER, FM60CW, 230/1/60, 60K

BTU, (COOL ONLY)

MATERIAL

-J

SIZE DWG. NO. REV

B FM20064-OLD PART NO.

26

25 46 33 34

18

19

47

48

?

53 31

17

37

CHILLERMONITOR

ENCLOSURE

7.75

23

5.31

9.81 9.88

14.38

A

A

CHILLEDWATER IN

1/2" NPT DRAIN

CHILLEDWATER OUT

SEAWATER IN

SEAWATER OUT

15.50 MAX OVER ALL

9.75MOUNTING HOLES

23.25MOUNTING

HOLES 25.26

13.78

27 MAXOVERALL

SECTION A-A70654-001 REMOVED

FOR CLAIRITY

36 40

2 ?

3

54

2520

40 39

13

24 49 30 28

42 55 41

14

23?33

D

C

B

AA

B

C

D

12345678

8 7 6 5 4 2 1

SCALE: 1:8

-

- SHEET 2 OF 6

DRAWN

CHECKED

SIZE

BDRAWING NO.

ENG APPR.

REV-

WGT: 432.37 LBS

FM20064 J2427 SE DIXIE HIGHWAY | STUART |FLORIDA | 34996 | USA

(772) 283-1609 | (800) 316-6426 FAX (772) 283-4611



NOTES:

ITEM NO. QTY PART NUMBER DESCRIPTION

55 2 80280-001 WELDMENT, MANIFOLD, CuNi, (1) SET, 48-72K CHILLERS54 1 80264-001 WELDMENT, BASE, CHILLER, FM24CW - FM84CW53 1 71000-001 TAG, PLATE, SERIAL NUMBER, ANODIZED, ETCHED52 1 70999-001 TAG, WATER IN, ANODIZED, ETCHED51 1 70998-001 TAG, WATER OUT, ANODIZED, ETCHED50 1 70952-001 TAG, MINERAL OIL, ETCHED "COMPRESSOR FILLED WITH MINERAL OIL"49 2 70657-001 FABRICATION, STRAP, FILTER DRIER, CHILLER, FM360CW48 1 70656-001 FABRICATION, BRACKET, LIQUID GAUGE & FILTER DRIER, CHILLER, FM48CW & FM60CW47 1 70655-001 FABRICATION, PANEL, LIQUID GAUGE & FILTER DRIER, CHILLER, FM48CW & FM60CW46 1 70654-001 FABRICATION, BRACKET, EVAPORATOR, CHILLER, FM60CW45 1 61000-001 INSULATION, 1/8" FOAM PEEL AND STICK44 1 60998-001 TAPE, CORK ROLL, 30"x2"43 1 60861-001 OIL, MINERAL, 1-GALLON42 2 60837-001 COUPLING, REDUCING, 1 1/4 X 1, BRONZE41 2 60836-001 COUPLING, REDUCING, 1 1/4 X 3/4, BRONZE40 3 60824-001 ELBOW, 90 DEG, 1 1/4 FEMALE X 1 1/4 FEMALE, 150 PSI, 304 SS39 1 60823-001 COUPLING, BANDED, 1-1/4, 304 SS38 1 60821-001 NIPPLE, 1-1/4 X 4-1/2, 304 SS37 2 60820-001 NIPPLE, 1-1/4 X CLOSE, 304 SS36 1 60809-001 PLUG, 1/2 SQ. HD. CORED, BRONZE35 2 60722-001 ANODE, ZINC, 3/4" NPT, 3.5" L, 3606K934 4 60560-001 WASHER, 3/8" FINISH 18-8 SS33 8 60539-001 NUT, 3/8-16 NYLON LOCK NUT 18-8 SS32 4 60534-001 WASHER, 3/8" X 1.25" , FLAT31 8 60531-001 RIVET, 3/16" DIA. .126-.250" GRIP RANGE TS, SS30 4 60526-001 NUT, #8-32 MACHINE SCREW NUT 18-8 SS29 10 60517-001 SCREW, #8-32 X 3/8" PAN HEAD MACHINE SCREW, #2 DRIVE PHILLIPS, 18-8 SS28 4 60511-001 WASHER, #8 X 7/16"OD SAE FLAT WASHER 18-8 SS27 A/R 60329-001 REFRIGERANT, NU-22B26 1 60296-001 COMPRESSOR, SCROLL, 230/3/60, 53.5K BTU, R22, ZR5425 1 60205-001 EVAPORATOR, CHILLED WATER, 30 PLATE, FM48CW-FM72CW24 1 60124-001 FILTER DRIER, 48K-72K, 1/2", LIQUID LINE, TYPE LLD164S23 20 60070-001 WASHER, .385 ID X 1.406 OD X .25 THK, 60 DURO EPDM BLACK22 2 60069-001 SWITCH, PRESSURE, OPEN (400) CLOSE (300)21 1 60067-001 SWITCH, PRESSURE, OPEN (35) CLOSE (60)20 1 40131-001 FITTING, TEMP SENSOR WELL, CTRL.19 1 40121-001 GAUGE, LOW PRESSURE, NU22 (R22)18 1 40120-001 GAUGE, HI PRESSURE, NU22 (R22)17 1 40115-001 FITTING, TEE, 1-1/4, MNPT, 304 SS16 1 40114-001 FITTING, BUSHING, 1-1/4" MNPT X 1"FNPT, 304 SS15 2 40107-001 VALVE, ACTUATOR, 1/4" QC X 1/8" FPT, BRASS14 7 40102-001 VALVE, 1/4" STANDARD SERVICE, CAP W/RUBBER O-RING13 1 40095-001 VALVE, EXPANSION, CHARGE ELEMENT AND CAP TUBE, 2-6 TON, KT43VGA12 1 40085-001 VALVE, EXPANSION, EXT. BALANCED, 2-5 1/2-TON, R22/R410a, SBQEBODY3X411 1 40080-001 ORIFICE CARTIDGE, BALANCE PORT, WHITE, 3 1/4 - 5 1/2 TON (R22)/R410a10 1 40030-001 LIQUID FLOW SWITCH, (1)SPDT, NEMA4, 1" - 8" PIPES9 1 30230-001 LOOM, SPLIT-TYPE, BLUE TRACER, 1/2", 1100', M125-0120-A8 1 30157-001 CONDUIT, LIQUID TIGHT, 1/2", GREY, NON-METALIC7 1 30139-002 CONNECTOR, STRAIGHT PVC LIQUID-TIGHT, 1/2 NM TYPE B CONDUIT6 3 30139-001 CONNECTOR, 90 DEGREE PVC LIQUID-TIGHT, 1/2 NM TYPE B CONDUIT5 1 30032-003 WIRING, CHILLER, FM24CW- FM120CW, 230/460/3/604 1 20568-001 ASSEMBLY, BRACKET, HALF ROUND BAR, 3/4", FREEZE CONTROL MOUNTING3 2 20223-001 CONDENSER, LIQUID COOLED, 24K-84K SERIES2 1 20014-001 MONITOR, CHILLER, FLAGSHIP MARINE1 1 20012-002 ASSEMBLY,CONTROL BOX, CHILLER, SINGLE COMPRESSOR, 230-460/3/60, UNIVERSAL

D

C

B

AA

B

C

D

12345678

8 7 6 5 4 2 1






NEXT ASSY USED ON

APPLICATION

FINISH

DRAWN

CHECKED

ENG APPR.

MFG APPR.

Q.A.

DATENAME TITLE:

SCALE: 1:4


TJW

TCM

TCM

TCM

-

-

-

-

2/4/2011




63


-



FAX (772) 283-4611

-

--

--

- -

- -

--

PART NO. 20064-002

WGT: 431.39 LBS

EAS


BTU, (COOL ONLY)

MATERIAL

-J

SIZE DWG. NO. REV

B FM20064-NSN NO.

9.81

5.31

9.93

14.43

23.0

7.75

B

B

CHILLEDWATER IN

SEAWATER IN

CHILLEDWATER OUT

1/2" NPT DRAIN

SEAWATER OUT

26

53

25

17

18

46

40 36

37

40

47

48

?

23.25MOUNTING

HOLES 25.30 26.58

13.78 15.50

MAX OVER ALL

9.75MOUNTING HOLES

CHILLER MONITORENCLOSURE

SECTION B-B70654-001 REMOVED

FOR CLARITY

4036

3

54

2320 4

40

5433?

38

15 14

24 49 30

42

2

55

6

D

C

B

AA

B

C

D

12345678

8 7 6 5 4 2 1

SCALE: 1:8

-

- SHEET 4 OF 6

DRAWN

CHECKED

SIZE

BDRAWING NO.

ENG APPR.

REV-

WGT: 431.39 LBS


(772) 283-1609 | (800) 316-6426 FAX (772) 283-4611



NOTES:

ITEM NO. QTY PART NUMBER DESCRIPTION

55 2 80280-001 WELDMENT, MANIFOLD, CuNi, (1) SET, 48-72K CHILLERS

54 1 80264-001 WELDMENT, BASE, CHILLER, FM24CW - FM84CW

53 1 71000-001 TAG, PLATE, SERIAL NUMBER, ANODIZED, ETCHED

52 1 70999-001 TAG, WATER IN, ANODIZED, ETCHED

51 1 70998-001 TAG, WATER OUT, ANODIZED, ETCHED

50 1 70952-001 TAG, MINERAL OIL, ETCHED "COMPRESSOR FILLED WITH MINERAL OIL"

49 2 70657-001 FABRICATION, STRAP, FILTER DRIER, CHILLER, FM360CW

48 1 70656-001 FABRICATION, BRACKET, LIQUID GAUGE & FILTER DRIER, CHILLER, FM48CW & FM60CW

47 1 70655-001 FABRICATION, PANEL, LIQUID GAUGE & FILTER DRIER, CHILLER, FM48CW & FM60CW

46 1 70654-001 FABRICATION, BRACKET, EVAPORATOR, CHILLER, FM60CW

45 1 61000-001 INSULATION, 1/8" FOAM PEEL AND STICK

44 1 60998-001 TAPE, CORK ROLL, 30"x2"

43 1 60861-001 OIL, MINERAL, 1-GALLON

42 2 60837-001 COUPLING, REDUCING, 1 1/4 X 1, BRONZE

41 2 60836-001 COUPLING, REDUCING, 1 1/4 X 3/4, BRONZE

40 3 60824-001 ELBOW, 90 DEG, 1 1/4 FEMALE X 1 1/4 FEMALE, 150 PSI, 304 SS

39 1 60823-001 COUPLING, BANDED, 1-1/4, 304 SS

38 1 60821-001 NIPPLE, 1-1/4 X 4-1/2, 304 SS

37 2 60820-001 NIPPLE, 1-1/4 X CLOSE, 304 SS

36 1 60809-001 PLUG, 1/2 SQ. HD. CORED, BRONZE

35 2 60722-001 ANODE, ZINC, 3/4" NPT, 3.5" L, 3606K9

34 4 60560-001 WASHER, 3/8" FINISH 18-8 SS

33 8 60539-001 NUT, 3/8-16 NYLON LOCK NUT 18-8 SS

32 4 60534-001 WASHER, 3/8" X 1.25" , FLAT

31 8 60531-001 RIVET, 3/16" DIA. .126-.250" GRIP RANGE TS, SS

30 4 60526-001 NUT, #8-32 MACHINE SCREW NUT 18-8 SS

29 10 60517-001 SCREW, #8-32 X 3/8" PAN HEAD MACHINE SCREW, #2 DRIVE PHILLIPS, 18-8 SS

28 4 60511-001 WASHER, #8 X 7/16"OD SAE FLAT WASHER 18-8 SS

27 A/R 60329-001 REFRIGERANT, NU-22B

26 1 60264-001 COMPRESSOR, SCROLL, 460/3/60, 53.5K BTU, R22, ZR54

25 1 60205-001 EVAPORATOR, CHILLED WATER, 30 PLATE, FM48CW-FM72CW

24 1 60124-001 FILTER DRIER, 48K-72K, 1/2", LIQUID LINE, TYPE LLD164S

23 20 60070-001 WASHER, .385 ID X 1.406 OD X .25 THK, 60 DURO EPDM BLACK

22 2 60069-001 SWITCH, PRESSURE, OPEN (400) CLOSE (300)

21 1 60067-001 SWITCH, PRESSURE, OPEN (35) CLOSE (60)

20 1 40131-001 FITTING, TEMP SENSOR WELL, CTRL.

19 1 40121-001 GAUGE, LOW PRESSURE, NU22 (R22)

18 1 40120-001 GAUGE, HI PRESSURE, NU22 (R22)

17 1 40115-001 FITTING, TEE, 1-1/4, MNPT, 304 SS

16 1 40114-001 FITTING, BUSHING, 1-1/4" MNPT X 1"FNPT, 304 SS

15 2 40107-001 VALVE, ACTUATOR, 1/4" QC X 1/8" FPT, BRASS

14 7 40102-001 VALVE, 1/4" STANDARD SERVICE, CAP W/RUBBER O-RING

13 1 40095-001 VALVE, EXPANSION, CHARGE ELEMENT AND CAP TUBE, 2-6 TON, KT43VGA

12 1 40085-001 VALVE, EXPANSION, EXT. BALANCED, 2-5 1/2-TON, R22/R410a, SBQEBODY3X4

11 1 40080-001 ORIFICE CARTIDGE, BALANCE PORT, WHITE, 3 1/4 - 5 1/2 TON (R22)/R410a

10 1 40030-001 LIQUID FLOW SWITCH, (1)SPDT, NEMA4, 1" - 8" PIPES

9 1 30230-001 LOOM, SPLIT-TYPE, BLUE TRACER, 1/2", 1100', M125-0120-A

8 1 30157-001 CONDUIT, LIQUID TIGHT, 1/2", GREY, NON-METALIC

7 1 30139-002 CONNECTOR, STRAIGHT PVC LIQUID-TIGHT, 1/2 NM TYPE B CONDUIT

6 3 30139-001 CONNECTOR, 90 DEGREE PVC LIQUID-TIGHT, 1/2 NM TYPE B CONDUIT

5 1 30032-003 WIRING, CHILLER, FM24CW- FM120CW, 230/460/3/60

4 1 20568-001 ASSEMBLY, BRACKET, HALF ROUND BAR, 3/4", FREEZE CONTROL MOUNTING

3 2 20223-001 CONDENSER, LIQUID COOLED, 24K-84K SERIES

2 1 20014-001 MONITOR, CHILLER, FLAGSHIP MARINE

1 1 20012-002 ASSEMBLY,CONTROL BOX, CHILLER, SINGLE COMPRESSOR, 230-460/3/60, UNIVERSAL

D

C

B

AA

B

C

D

12345678

8 7 6 5 4 2 1






NEXT ASSY USED ON

APPLICATION

FINISH

DRAWN

CHECKED

ENG APPR.

MFG APPR.

Q.A.

DATENAME TITLE:

SCALE: 1:4


TJW

TCM

TCM

TCM

-

-

-

-

2/4/2011




63


-



FAX (772) 283-4611

-

--

--

- -

- -

--

PART NO. 20064-003

WGT: 431.39 LBS

EAS


BTU, (COOL ONLY)

MATERIAL

-J

SIZE DWG. NO. REV

B FM20064-NSN NO.

C

C

CHILLEDWATER IN

CHILLEDWATER OUT

SEAWATER OUT

SEAWATER IN

1/2" NPT DRAIN

25

18

17

26

53 31

46

15

47

?

37

38

39

23.25MOUNTING

HOLES 25.00

26.59

9.75MOUNTING HOLES

13.78 15.50

MAX OVER ALL

CHILLERMONITOR

ENCLOSURE

SECTION C-C70654-001 REMOVED

FOR CLARITY

3640

3

54

23 20 4

40

14

24

42

2 6

55 35

49

15

38

54?33

D

C

B

AA

B

C

D

12345678

8 7 6 5 4 2 1

SCALE: 1:8

-

- SHEET 6 OF 6

DRAWN

CHECKED

SIZE

BDRAWING NO.

ENG APPR.

REV-

WGT: 431.39 LBS


(772) 283-1609 | (800) 316-6426 FAX (772) 283-4611

Date post:	27-Jan-2020
Category:	Documents
Upload:	others
View:	0 times
Download:	0 times

G - CREATED -002 AND -003 CONFIGURATIONS 10/29/2018 - H - … · all equipment options shown for...

Documents