7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 1/36
Date: April 27, 2013
To:
Managing Director
AGS Pharma & Medical Device !td"
Sub.: Suplly & Installation of HVAC System
Sir,
#e are pleaed to $%mit the ollo'ing ($otation
S/N QNT UNIT RATE US T!TA" US
1"0 AIR C!!"E SCRE# CHI""ER 2 et ))) *22,+00"00
2"0 Ai$ Han%lin Units 'ouble s(inne%) 10 et 7,000"00 70,000"00
Sin thicne: *0mm
Acceorie: Door Mo$nted vi%rating -olator
-n$lation material: P. minim$m *0mm thic
/oil ace velocit : Ma 00 PM"
an 4PM : Ma 1000
Po'er inp$t : *00561089, 0 ;, 3 Ph
Pre<lter: Grade G*
*RAN:Count$y of !$iin:
AHU+,-
Scre' compreion tpe air cooled 'ater chiller havingcapacit o 20 4T and to cool *+0 .S GPM o 'ater rom*= to **> at condener air entering temperat$re o?>" #ater ide o$ling actor ho$ld not eceed0"0002"
The 'ater ide pre$re drop o cooler hall not morethan 20 t o #"G" The $nit control panel hall havemicroproceor control tem and hall %e actor 'iredand teted"
The $nit hall %e complete 'ith panel mo$nted meteringdevice, rerigerant <lter 'ith ervice valve, m$ltiplecre' compreor, po'er panel 'ith incoming M//@,aet control, tardelta motor tarter, electronicepanion valve, oil heater, B6 control 'itch, Co''itch, pring iolator, all actor 'ired, completedpiping & teted" The $nit caing hall %e 'eather proo"
The $nit hall $e 413*a64*07/ a a rerigerant" Thepo'er $ppl hall %e *00E8F9 6 3Ph 6 0;"
Do$%le inned dra' /hilled 'ater tpe Air andling .nit'ith an ection, cooling coil ection, or'ard c$rvedcentri$gal an, in$lated loped drain pan, an motor, air<lter, an vi%ration iolator, Miing @o 'ith reh airand ret$rn air damper, etc" Air andling .nit hall %emod$lar tpe actor painted" General peci<cation are
a ollo' :
ntering 'ater temperat$re : 7o /
!eaving 'ater temperat$re : 12o/
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 2/36
o%el:
Tpe: ori;ontal arrangement hori;ontal dicharge
Air Co' /apacit : 2*000 /M
ternal tatic pre$re : 0 mm o #g"
/hilled 'ater Co' rate : 10+ .S GPM
Total cooling capacit : 0 Ton o 4erigeration
3"00 U 0it1 Hepa 2lte$ 2 et H+H"00 17,10"00
ilter Si;e: H00mm I H00mm
*"00 Spa$e Hepa ilte$ 12 et H+H"00 +,232"00
ilter Si;e: H00mm I H00mm
"00 UTI"IT3 AN + et 1*0"00 1,120"00
H"00 Toilet E41aust an 1 et 3"00 2"00
aF 1000 cm at 0 mm 'g"
Tpe : /entri$gal
%F 1200 cm at H mm 'g"
Tpe : /entri$gal
cF 1000 cm at H mm 'g"
Tpe : /entri$gal
dF ?00 cm at H mm 'g"
Tpe : /entri$gal
eF 700 cm at * mm 'g" Tpe : /entri$gal
F 1*0 cm at 3 mm 'g"
Tpe : /entri$gal
7"00 5I5E ACCESS!RIES
7"1 6ate Val7es 1 !T +,+00"00 +,+00"00200 mm dia @$tter C tpeF
*0 mm dia
/eiling mo$nted tpe ,vertical do'n dicharge hepa<lter mod$le hall %e complete 'ith hepa <lter o10mm thic ,epo painted heet teel caing aial Co'an $ita%le to tae tatic pre$re o dirt hepa <lter,anmotor ,dicharge grille,inlet Canged end tpe collaretc"complete in all repect "epa <lter hall have aneJcienc o ??"?78 to arret "3 micron o d$t"ilterhall %e erviceea%le rom %ottom 'itho$t damaging the
caing and hall %e 'ith DP teting acilit "
All the ventilation an hall %e actor teted, taticalland dnamicall %alanced complete 'ith an motor 'ith,mo$nting rame etc" Po'er $ppl hall %e *00963Phae6 * 'ire or 22096ingle phae6 3 'ire tem"
Toilet eha$t an hall have ollo'ing capacit & hall%e complete 'ith an motor, enclo$re etc"
Pipe acceorie hall %e $ita%le to 'ithtand a pre$reo 10 g6("cm" 9alve o H mm dia and a%ove hall %eo Canged end tpe complete 'ith companion Cange,gaet, n$t %olt etc" and valve le than H mm diahall %e %ron;e %od threaded end tpe"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 3/36
32 mm dia
2 mm dia
20 mm dia
7"2 6lobe Val7es
200 mm dia
*0 mm dia 32 mm dia
2 mm dia
20 mm dia
7"3 C1e8( 7al7e
200 mm dia
7"* 3+St$aine$
200 mm dia
*0 mm dia
32 mm dia
2 mm dia
20 mm dia 7" le4ible 9oint
200 mm dia
*0 mm dia
32 mm dia
2 mm dia
20 mm dia
7"H VENT VA"VE 10 et 30"00 3,00"00
20 mm dia
7"7 *A"" VA"VE *0 et 22"00 10,0+0"00
2 mm dia
20 mm dia
7"+ +0ay solenoi% 7al7e 0it1 $oom t1e$mostat 20 et +*0"00 1H,+00"00
*$an% : Honey0ell/aple/;IC!N
*0 mm dia
32 mm dia
2 mm dia
20 mm dia
7"? 5$essu$e *alan8in Val7e 10 et 322"00 3,220"00
A$tomatic vent valve hall %e ree Coating tpe havingtet coc, 20 mm threaded o$tlet to accept drain lineand threaded inlet connection" 9ent valve hall %e 20
mm i;e"
alaysia
lectric operated 2'a olenoid valve hall %e ingle
eated, traight thro$gh, glo%e %od, normall cloe tpepring loadedF, high lit pl$g, Canged end tpe 'ithcompanion Cange" The valve hall %e operated ontemperat$re ignal rom ret$rn air" The valve hall %ecomplete 'ith heav d$t on6oK motor, mo$nting etc"complete in all repect"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 4/36
3L dia"
+"00 "ININ6 ATERIA"S 0000 ST 10"0 2,000"00
*$an% : Ae$o=e4/#i%e
Count$y of !$iin : T1ailan% / C1ina
Thicne : 2 mm, Denit : +0 g6m ?"0 10 et 17"00 1,70"00
?"1 5$essu$e 6uae 12 et *"00 ,*H0"00
?"2 5ipe t1e$momete$ 1+ et 2+"00 0*"00
200mm B@, 0mm thic pipe in$lation
10"00 Supply an% Retu$n u8t 0000 ST +"*0 *20,000"00
11 AIR TERINA"S :
*$an%: 5RUENT AIRE
Count$y of !$iin: alaysia
S1ipment f$om: alaysia
11"1 Supply Ai$ Te$minals :
aF *0*0 /eiling mo$ntedF /6# @D *00 et 112"00 **,+00"00
11"2 "inea$ Supply 6$ille 0it1 insulate% C1ambe$:
lectrical operated 2'a pre$re %alancing valve hall%e ingle eated, traight thro$gh, glo%e %od, normallcloed , Cangeend tpe 'ith companion Cange" Thevalve 'ill %e complete 'ith ac$ator, pre$re enor,
progamma%le controller etc" complete in all repect"
D$ct lining material hall %e a per peci<cation andhall %e $ed inide d$ct 'or" !ining hall %e $edinide d$ct 'or or o$nd atten$ation" S$race o theliner hall %e complete 'ith perorated al$min$m oil$race liner" Denit o lining material hall not %e lethan +0 g6c$m
ETERIN6 EVICES
Metering device hall %e a per dra'ing and directionand hall %e complete 'ith all mo$nting acceorie"
Pre$re ga$ge or 'ater pipe line hall %e o dial tpe o100 mm dia $ita%le to read 0 to 10 Ng pre$re"Pre$re ga$ge hall %e complete 'ith pet coc, pre$reno%%er, nipple etc"
AdO$ta%le angle, direct reading, ind$trial tpe pipethermometer o 22 mm length hall %e complete 'iththermometer 'ell, ocet" Thermometer hall %e $ita%leto read 'ater temperat$re o range 0 to 0=/"
Air terminal hall %e contr$cted 'ith etr$dedal$min$m po'der coated complete 'ith nec vol$mecontrol damper, m$dging ring, *0 mm margin, <ingacceorie etc" complete" Pre$re drop acro theterminal hall not %e more than 1 mm 'g" Bec velocithall not %e more than 700 pm"
S$ppl air diK$er hall %e * 'a ($are tpe $ita%leor ceiling mo$nt" DiK$er hall have replacea%le core"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 5/36
aF 120010 /eiling mo$nted *0 et 23+"00 ?,20"00
%F ?0010 #all mo$ntedF *0 et 2+0"00 11,200"00
11"3 Ceilin Retu$n 6$ille :
aF ?00300 *00 et 23+"00 ?,200"00
12 5RE+INSU"ATE 5I5E:
*$an%: RIC#I" HI+6AR
Count$y of !$iin: alaysia
S1ipment f$om: alaysia
12"1 200mm dia, 0mm thic in$lation 1+0 4M 3"70 ?,HHH"00
12"2 10mm dia, *0mm thic in$lation 12H 4M 3H"0 *,??"00
12"3 12mm dia, *0mm thic in$lation 0 0
12"* 100mm dia, *0mm thic in$lation 122 4M 22"00 2,H+*"00
12" +0mm dia, 2mm thic in$lation 72 4M 17"1 1,23*"+0
12"H H mm dia, 2mm thic in$lation 0 4M 17"1
12"7 0mm dia, 2mm thic in$lation 13 4M ?"H 1 ,302"712"+ *0mm dia, 20mm thic in$lation 20 4M +"H0 2 ,10"00
12"? 32 mm dia, 20mm thic in$lation 0 4M 7"1
12"10 2mm dia, 20mm thic in$lation 2700 4M 7"0 20,20"00
12"11 20mm dia, 20mm thic in$lation 120 4M *"+ 7,372"00
/arrier Pipe: SM!S @l" /ar%on Steel Pipe to AP- ! Gr" @, Sch" *0"
4igid Pol$rethane oam o denit *g6m3, cc ree
Galvani;ed Steel piral o$tide loceamed 0"mm 112mmF
Galvani;ed Steel piral o$tide loceamed 0"Hmm 10+00mmF
13 5I5E/ INSU"ATI!N:
*$an%: S6/ #INCE""
Count$y of !$iin: C1ina
S1ipment f$om: C1ina
13"1 2 mm thic" 2300 S(m 1"3 3,10"00
1* 5I5E HAN6ER IS!"AT!R:
2lot 'ith Co' control damper hall %e 'ith 12mmmargin, <ing cre' complete"
3lot ?00 mm length 'ith Co' control damper hall %e'ith 12mm margin, <ing cre' complete
Prein$lated pipe hall %e %lac teel pipe 'ithin$lation and alvani;ed heet metal cladded vapor%arrier" Pipe hall %e $ita%le to 'ithtand a tet pre$reo 3H0pi" Pipe hall %e P in$lated" Pipe hall %e o
ollo'ing nominal dia"
-n$lation or $ppl, ret$rn and reh air d$ct<re proogla 'ool o treinorced al$min$m oil 'ith preadheive" Thermal cond$ctivit hall not %e more than0"2 @t$"in6r"= at 0= to ?0= mean temperat$re"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 6/36
*$an%: Toma1a0(
Count$y of !$iin: alaysia
S1ipment f$om: alaysia
1*"1 200mm dia 22 Bo" 32"20 70+"*0
1*"2 10mm dia 22 Bo" 2+"0 H27"00
1*"3 100mm dia H Bo" 1+"00 10+"00
Total >>>
Te$ms & Con%itions:
1" Ker 9alidit: H0 Da
3" Deliver time: 0H0 da ater receiving o 'or order
Thaning o$,
anain i$e8to$
4adiant -nternational
Pipe anger iolator hall %e neoprene r$%%er 'ithprStatic deCection hall not %e more than 2mm"anger hall %e $ita%le or ollo'ing dia o %lac teelpipe o ched$le *0SF" anger hall %e $e *,00mm"
complete o the 'or"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 7/36
Date: April 27, 2013
To:
Managing DirectorAGS Pharma & Medical Device !td"
Sub.: Suplly & Installation of HVAC System
Sir,
#e are pleaed to $%mit the ollo'ing ($otation
S/N QNT UNIT RATE US
1"0 AIR C!!"E SCRE# CHI""ER 1 et )))
2"0 Ai$ Han%lin Units 'ouble s(inne%) 10 et 13,00"00
Scre' compreion tpe air cooled 'aterchiller having capacit o 30 4T and tocool +*0 .S GPM o 'ater rom *= to**> at condener air enteringtemperat$re o ?>" #ater ide o$lingactor ho$ld not eceed 0"0002" The 'ater ide pre$re drop o coolerhall not more than 20 t o #"G" The $nitcontrol panel hall have microproceorcontrol tem and hall %e actor 'iredand teted" The $nit hall %e complete 'ith panelmo$nted metering device, rerigerant<lter 'ith ervice valve, m$ltiple cre'compreor, po'er panel 'ith incomingM//@, aet control, tardelta motortarter, electronic epanion valve, oilheater, B6 control 'itch, Co' 'itch,
pring iolator, all actor 'ired,completed piping & teted" The $nit cainghall %e 'eather proo" The $nit hall $e 413*a64*07/ a arerigerant" The po'er $ppl hall %e*00E8F9 6 3Ph 6 0;"
an, in$lated loped drain pan, an motor,air <lter, an vi%ration iolator, Miing @o'ith reh air and ret$rn air damper, etc"
Air andling .nit hall %e mod$lar tpeactor painted" General peci<cation area ollo' :
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 8/36
Sin thicne: *0mm
/oil ace velocit : Ma 00 PM"
an 4PM : Ma 1000
Pre<lter: Grade G*
*RAN: ?oolman
Count$y of !$iin: alaysia
AHU+,-
o%el:
Air Co' /apacit :1*000 /M
ternal tatic pre$re : 0 mm o #g"
/hilled 'ater Co' rate : 10+ .S GPM
3"00 U 0it1 Hepa 2lte$ 2 et +10"00
ilter Si;e: H00mm I H00mm
*"00 Spa$e Hepa ilte$ 12 et +10"00
ilter Si;e: H00mm I H00mm
"00 UTI"IT3 AN 10 et 17"00
H"00 Toilet E41aust an 1 et 2?"7
aF 1000 cm at 0 mm 'g"
-olator thic
ntering 'ater temperat$re : 7o /!eaving 'ater temperat$re : 12o/
dicharge
4erigeration
/eiling mo$nted tpe ,vertical do'ndicharge hepa <lter mod$le hall %ecomplete 'ith hepa <lter o 10mmthic ,epo painted heet teel caingaial Co' an $ita%le to tae tatic
pre$re o dirt hepa <lter,an motor,dicharge grille,inlet Canged end tpecollar etc"complete in all repect "epa<lter hall have an eJcienc o ??"?78 toarret "3 micron o d$t"ilter hall %eerviceea%le rom %ottom 'itho$tdamaging the caing and hall %e 'ithDP teting acilit "
All the ventilation an hall %e actorteted, taticall and dnamicall%alanced complete 'ith an motor 'ith,mo$nting rame etc" Po'er $ppl hall %e*00963 Phae6 * 'ire or 22096inglephae6 3 'ire tem"
Toilet eha$t an hall have ollo'ing
capacit & hall %e complete 'ith anmotor, enclo$re etc"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 9/36
Tpe : /entri$gal
%F 1200 cm at H mm 'g"
Tpe : /entri$gal
cF 1000 cm at H mm 'g"
Tpe : /entri$gal
dF ?00 cm at H mm 'g" Tpe : /entri$gal
eF 700 cm at * mm 'g"
Tpe : /entri$gal
F 1*0 cm at 3 mm 'g"
Tpe : /entri$gal
7"00 5I5E ACCESS!RIES
7"1 6ate Val7es 1 !T +,100"00
200 mm dia @$tter C tpeF
*0 mm dia
32 mm dia
2 mm dia
20 mm dia7"2 6lobe Val7es
200 mm dia
*0 mm dia
32 mm dia
2 mm dia
20 mm dia
7"3 C1e8( 7al7e
200 mm dia
7"* 3+St$aine$200 mm dia
*0 mm dia
32 mm dia
2 mm dia
20 mm dia
7" le4ible 9oint
200 mm dia
*0 mm dia
32 mm dia
2 mm dia
20 mm dia
Pipe acceorie hall %e $ita%le to'ithtand a pre$re o 10 g6("cm"
9alve o H mm dia and a%ove hall %e oCanged end tpe complete 'ithcompanion Cange, gaet, n$t %olt etc"and valve le than H mm dia hall %e%ron;e %od threaded end tpe"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 10/36
7"H VENT VA"VE 10 et 2?7"0
20 mm dia
7"7 *A"" VA"VE *0 et 21*"20
2 mm dia
20 mm dia
7"+ +0ay solenoi% 7al7e 0it1 $oom t1e$m 20 et 71*"00
*$an% : Honey0ell/aple/;IC!N
*0 mm dia
32 mm dia2 mm dia
20 mm dia
7"? 5$essu$e *alan8in Val7e 10 et 273"70
3L dia"
+"00 "ININ6 ATERIA"S H0000 ST +"?3
*$an% : Ae$o=e4/#i%e
Count$y of !$iin : T1ailan% / C1ina Thicne : 2 mm, Denit : +0 g6m
?"0 10 et 1*+"7
A$tomatic vent valve hall %e ree Coatingtpe having tet coc, 20 mm threadedo$tlet to accept drain line and threadedinlet connection" 9ent valve hall %e 20mm i;e"
Sinapo$e< alaysia
lectric operated 2'a olenoid valvehall %e ingle eated, traight thro$gh,glo%e %od, normall cloe tpe pringloadedF, high lit pl$g, Canged end tpe'ith companion Cange" The valve hall %eoperated on temperat$re ignal romret$rn air" The valve hall %e complete'ith heav d$t on6oK motor, mo$ntingetc" complete in all repect"
lectrical operated 2'a pre$re%alancing valve hall %e ingle eated,traight thro$gh, glo%e %od, normallcloed , Cangeend tpe 'ith companionCange" The valve 'ill %e complete 'ithac$ator, pre$re enor, progamma%lecontroller etc" complete in all repect"
"or o$nd atten$ation" S$race o the linerhall %e complete 'ith peroratedal$min$m oil $race liner" Denit olining material hall not %e le than +0g6c$m
ETERIN6 EVICES
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 11/36
?"1 5$essu$e 6uae 12 et 3+H"7
?"2 5ipe t1e$momete$ 1+ et 23"+0
200mm B@, 0mm thic pipe in$lation
10 Supply an% Retu$n u8t H0000 ST +"22
11 AIR TERINA"S :
*$an%: 5RUENT AIRE
Count$y of !$iin: alaysia
S1ipment f$om: alaysia
11"1 Supply Ai$ Te$minals :
aF *0*0 /eiling mo$ntedF /6# @D *00 et ?"20
11"2 "inea$ Supply 6$ille 0it1 insulate% C1ambe$:
aF 120010 /eiling mo$nted *0 et 202"30
%F ?0010 #all mo$ntedF *0 et 23+"00
11"3 Ceilin Retu$n 6$ille :
Metering device hall %e a per dra'ingand direction and hall %e complete 'ithall mo$nting acceorie"
Pre$re ga$ge or 'ater pipe line hall %eo dial tpe o 100 mm dia $ita%le to read0 to 10 Ng pre$re" Pre$re ga$ge hall%e complete 'ith pet coc, pre$reno%%er, nipple etc"
AdO$ta%le angle, direct reading, ind$trialtpe pipe thermometer o 22 mm lengthhall %e complete 'ith thermometer 'ell,ocet" Thermometer hall %e $ita%le to
read 'ater temperat$re o range 0 to0=/"
Air terminal hall %e contr$cted 'ithetr$ded al$min$m po'der coatedcomplete 'ith nec vol$me controldamper, m$dging ring, *0 mm margin,
<ing acceorie etc" complete" Pre$redrop acro the terminal hall not %e morethan 1 mm 'g" Bec velocit hall not %emore than 700 pm"
S$ppl air diK$er hall %e * 'a ($are
tpe $ita%le or ceiling mo$nt" DiK$erhall have replacea%le core"
2lot 'ith Co' control damper hall %e'ith 12mm margin, <ing cre' complete"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 12/36
aF ?00300 *00 et 202"30
12 5RE+INSU"ATE 5I5E:
*$an%: RIC#I" HI+6AR
Count$y of !$iin: alaysia
S1ipment f$om: alaysia
12"1 200mm dia, 0mm thic in$lation 200 4M *"H12"2 10mm dia, *0mm thic in$lation 1* 4M 31"03
12"3 12mm dia, *0mm thic in$lation 0 4M 23"H0
12"* 100mm dia, *0mm thic in$lation 1* 4M 1+"70
12" +0mm dia, 2mm thic in$lation ?2 4M 1*"+
12"H H mm dia, 2mm thic in$lation H0 4M 11"H0
12"7 0mm dia, 2mm thic in$lation 1 4M +"20
12"+ *0mm dia, 20mm thic in$lation H00 4M 7"31
12"? 32 mm dia, 20mm thic in$lation 100 4M H"?0
12"10 2mm dia, 20mm thic in$lation 2700 4M H"3+
12"11 20mm dia, 20mm thic in$lation 120 4M *"12/arrier Pipe: SM!S @l" /ar%on Steel Pipe to AP- ! Gr" @, Sch" *0"
4igid Pol$rethane oam o denit *g6m3, cc ree
Galvani;ed Steel piral o$tide loceamed 0"mm 112mmF
Galvani;ed Steel piral o$tide loceamed 0"Hmm 10+00mmF
13 5I5E/ INSU"ATI!N:
*$an%: S6/ #INCE""
Count$y of !$iin: C1ina
S1ipment f$om: C1ina
13"1 2 mm thic" 7H S(m 2"20
1* 5I5E HAN6ER IS!"AT!R:
3lot ?00 mm length 'ith Co' controldamper hall %e 'ith 12mm margin, <ingcre' complete
Prein$lated pipe hall %e %lac teel pipe'ith in$lation and alvani;ed heet metalcladded vapor %arrier" Pipe hall %e$ita%le to 'ithtand a tet pre$re o3H0pi" Pipe hall %e P in$lated" Pipehall %e o ollo'ing nominal dia"
-n$lation or $ppl, ret$rn and reh aird$ct<re proo gla 'ool o treinorcedal$min$m oil 'ith preadheive" Thermal
cond$ctivit hall not %e more than 0"2@t$"in6r"= at 0= to ?0= meantemperat$re"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 13/36
*$an%: Toma1a0(
Count$y of !$iin: alaysia
S1ipment f$om: alaysia
1*"1 200mm dia ** Bo" 27"37
1*"2 10mm dia ** Bo" 2*"23
1*"3 100mm dia 12 Bo" 1"30
/hiller -ntallation, !oading & .nloading 1 !ot *,000"00
A. -ntallation, !oading & .nloading 1 !ot *,000"00
Pipe -ntallation, !oading & .nloading 1 !ot 12,000"00
Total US
Te$ms & Con%itions:
1" Ker 9alidit: H0 Da
3" Deliver time: 0H0 da ater receiving o 'or order
Thaning o$,
anain i$e8to$
4adiant -nternational
Pipe anger iolator hall %e neoprener$%%er 'ith prStatic deCection hall not%e more than 2mm" anger hall %e$ita%le or ollo'ing dia o %lac teelpipe o ched$le *0SF" anger hall %e$e *,00mm"
'ithin 7 da ater complete o the 'or"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 14/36
T!TA" US
31,123"00
13,000"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 15/36
20,20"00
?,720"00
1,70"00
**H"2
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 16/36
+,100"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 17/36
2,?7"00
+,H+"00
1*,2+0"00
2,737"00
3,00"00
1,*+7"0
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 18/36
*,H*1"00
*2+"*0
*?3,200"00
3+,0+0"00
+,0?2"00
?,20"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 19/36
+0,?20"00
?,12?"00*,*?+"H3
1,1+0"00
2,711"0
1,3*1"13
H?H"00
1,271"3?
*,3+H"00
H?0"00
17,212"0
H,2HH"20
12,2H7"20
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 20/36
1,20*"2+
1,0H"?0
1+3"H0
*,000"00
*,000"00
12,000"00
-<@-,<-.B
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 21/36
Date: April 27, 2013
To:
Managing Director
AGS Pharma & Medical Device !td"
1#$, Dr" %dra'e'%hda (oad, Dhanmondi, Dha)a'120$
Sub.: Suplly & Installation of HVAC System
Sir,
*e are pleaed to +mit the ollo-ing .otation
S/N QNT UNIT RATE !"T#
1"0 AIR C$$%E" SCRE CHI%%ER 1 et 2$,$00,000"00
Scre- compreion t/pe air cooled -ater chiller having capacit/o 3$0 (T and to cool #0 S GPM o -ater rom $ to 4 at
condener air entering temperatre o 5$4" *ater ide olingactor hold not e6ceed 0"0002$"The -ater ide prere drop o cooler hall not more than 20 to *"G" The nit control panel hall have microproceor control/tem and hall +e actor/ -ired and teted"The nit hall +e complete -ith panel monted metering device,rerigerant ilter -ith ervice valve, mltiple cre- compreor,po-er panel -ith incoming M8, aet/ control, tar'deltamotor tarter, electronic e6panion valve, oil heater, 9;9control -itch, lo- -itch, pring iolator, all actor/ -ired,completed piping & teted" The nit caing hall +e -eatherproo"The nit hall e ('13a;('07 a a rerigerant" The po-erppl/ hall +e <00=$>?@ ; 3Ph ; $0B"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 22/36
2"0 Ai' Han(lin) Units "ouble s*inne(# 10 et 520,000"00
S)in thic)ne: 0mm
Acceorie: Door Monted vi+rating Colator
Cnlation material: P minimm 0mm thic)
oil ace velocit/ : Ma6 $00 PM"
an (PM : Ma6 1000
Po-er inpt : 00;'10>@, $0 B, 3 Ph
Preilter: Grade G
!RAN": +oolman
Count'y of $'i)in: ,alaysia
AHU-
,o(el:
T/pe: oriBontal arrangement horiBontal dicharge
Air lo- apacit/ :1000 M
E6ternal tatic prere : $0 mm o *g"
hilled -ater lo- rate : 10# S GPM
Total cooling capacit/ : $0 Ton o (erigeration
3"00 00U 1it2 Hepa filte' 2$ et $$,F00"00
Do+le )inned dra- hilled -ater t/pe Air andling nit -ithan ection, cooling coil ection, or-ard crved centrigal an,inlated loped drain pan, an motor, air ilter, an vi+rationiolator, Mi6ing 8o6 -ith reh air and retrn air damper, etc" Airandling nit hall +e modlar t/pe actor/ painted" Generalpeciication are a ollo- :
Entering -ater temperatre : 7o
!eaving -ater temperatre : 12o
eiling monted t/pe ,vertical do-n dicharge hepa iltermodle hall +e complete -ith hepa ilter o 1$0mm thic) ,epo6/painted heet teel caing a6ial lo- an ita+le to ta)e taticprere o dirt/ hepa ilter,an motor ,dicharge grille,inletlanged end t/pe collar etc"complete in all repect "epa ilterhall have an eicienc/ o 55"57> to arret "3 micron odt"ilter hall +e erviceea+le rom +ottom -ithot damagingthe caing and hall +e -ith D9P teting acilit/ "
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 23/36
ilter SiBe: F00mm F00mm
"00 Spa'e Hepa 0ilte' 12 et F0,300"00
ilter SiBe: F00mm F00mm
$"00 UTI%IT3 0AN 10 et 11,$00"00
F"00 Toilet E42aust 0an 1$ et 2,200"00
a? 1$000 cm at $0 mm -g"
T/pe : entrigal
+? 1200 cm at F mm -g"
T/pe : entrigal
c? 1000 cm at F mm -g"
T/pe : entrigal
d? 500 cm at F mm -g"
T/pe : entrigal e? 700 cm at mm -g"
T/pe : entrigal
? 10 cm at 3 mm -g"
T/pe : entrigal
7"00 5I5E ACCESS$RIES
7"1 6ate Val7es 1 !9T F1$,000"00
200 mm dia <8tter l/ t/pe?
0 mm dia
32 mm dia
2$ mm dia
All the ventilation an hall +e actor/ teted, taticall/ andd/namicall/ +alanced complete -ith an motor -ith, montingrame etc" Po-er ppl/ hall +e 00@;3 Phae; -ire or220@;ingle phae; 3 -ire /tem"
Toilet e6hat an hall have ollo-ing capacit/ & hall +ecomplete -ith an motor, enclore etc"
Pipe acceorie hall +e ita+le to -ithtand a prere o 10)g;."cm" @alve o F$ mm dia and a+ove hall +e o langed end
t/pe complete -ith companion lange, ga)et, nt +olt etc"and valve le than F$ mm dia hall +e +ronBe +od/ threadedend t/pe"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 24/36
20 mm dia
7"2 6lobe Val7es
200 mm dia
0 mm dia
32 mm dia
2$ mm dia
20 mm dia
7"3 C2e8* 7al7e
200 mm dia
7" 3-St'aine'
200 mm dia
0 mm dia
32 mm dia
2$ mm dia
20 mm dia
7"$ 0le4ible 9oint
200 mm dia
0 mm dia
32 mm dia
2$ mm dia
20 mm dia
7"F VENT VA%VE 10 et 21,$00"00
20 mm dia
7"7 !A%% VA%VE 0 et 13,200"00
2$ mm dia
20 mm dia
Atomatic vent valve hall +e ree loating t/pe having tet coc),20 mm threaded otlet to accept drain line and threaded inlet
connection" @ent valve hall +e 20 mm iBe"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 25/36
7"# -1ay solenoi( 7al7e 1it2 'oom t2e'mostat 20 et F,120"00
!'an( : Honey1ell/,aple/;IC$N
Count'y of $'i)in : U.S.A< S2ipment: Sin)apo'e< ,alaysia
0 mm dia
32 mm dia
2$ mm dia
20 mm dia
7"5 5'essu'e !alan8in) Val7e 10 et 20,35F"00
3H dia"
#"00 %ININ6 ,ATERIA%S F0000 ST 700"00
!'an( : Ae'ofle4/i(e
Count'y of $'i)in : T2ailan( / C2ina
Thic)ne : 2$ mm, Denit/ : #0 )g;mI
5"00 10 et 11,$00"00
Electric operated 2'-a/ olenoid valve hall +e ingle eated,
traight throgh, glo+e +od/, normall/ cloe t/pe <pring loaded?,high lit plg, langed end t/pe -ith companion lange" The valvehall +e operated on temperatre ignal rom retrn air" Thevalve hall +e complete -ith heav/ dt/ on;o motor, montingetc" complete in all repect"
Electrical operated 2'-a/ prere +alancing valve hall +eingle eated, traight throgh, glo+e +od/, normall/'cloed ,lange'end t/pe -ith companion lange" The valve -ill +ecomplete -ith acator, prere enor, progamma+le controlleretc" complete in all repect"
Dct lining material hall +e a per peciication and hall +eed inide dct -or)" !ining hall +e ed inide dct -or) or
ond attenation" Srace o the liner hall +e complete -ithperorated alminm oil race liner" Denit/ o lining materialhall not +e le than #0 )g;cm
,ETERIN6 "EVICES
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 26/36
5"1 5'essu'e 6ua)e 12 et 2#,$0"00
5"2 5ipe t2e'momete' 1# et 1,#00"00
200mm 8, $0mm thic) pipe inlation
10"00 Supply an( Retu'n "u8t F0000 ST F$1"F0
11"00 AIR TER,INA%S :
!'an(: 5RU"ENT AIRE
Count'y of $'i)in: ,alaysia
S2ipment f'om: ,alaysia
11"1 Supply Ai' Te'minals :
a? $06$0 <eiling monted? ;* 98D 00 et 7,30#"0011"2 %inea' Supply 6'ille 1it2 insulate( C2ambe':
a? 120061$0 <eiling monted 0 et 1$,17"00
+? 50061$0 < *all monted? 0 et 1#,030"00
11"3 Ceilin) Retu'n 6'ille :
Metering device hall +e a per dra-ing and direction and hall
+e complete -ith all monting acceorie"
Prere gage or -ater pipe line hall +e o dial t/pe o 100mm dia ita+le to read 0 to 10 %g prere" Prere gagehall +e complete -ith pet coc), prere no++er, nipple etc"
AdJta+le angle, direct reading, indtrial t/pe pipe thermometero 22$ mm length hall +e complete -ith thermometer -ell,
oc)et" Thermometer hall +e ita+le to read -ater temperatreo range 0 to $0"
Air terminal hall +e contrcted -ith e6trded alminmpo-der coated complete -ith nec) volme control damper,mdging ring, 0 mm margin, i6ing acceorie etc" complete"
Prere drop acro the terminal hall not +e more than 1 mm -g" ec) velocit/ hall not +e more than 700 pm"
Sppl/ air dier hall +e -a/ .are t/pe ita+le or ceilingmont" Dier hall have replacea+le core"
2'lot -ith lo- control damper hall +e -ith 12mm margin, i6ingcre- complete"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 27/36
a? 5006300 00 et 1,1F0"00
12"00 5RE-INSU%ATE" 5I5E:
!'an(: RICI% HI-6AR"
Count'y of $'i)in: ,alaysia
S2ipment f'om: ,alaysia 12"1 200mm dia, $0mm thic) inlation 200 (M 3,$1"F0
12"2 1$0mm dia, 0mm thic) inlation 1$ (M 2,3F2"00
12"3 12$mm dia, 0mm thic) inlation $0 (M 1,7##"00
12" 100mm dia, 0mm thic) inlation 1$ (M 1,37F"00
12"$ #0mm dia, 2$mm thic) inlation 52 (M 1,0FF"20
12"F F$ mm dia, 2$mm thic) inlation F0 (M 50#"3$
12"7 $0mm dia, 2$mm thic) inlation 1$$ (M F3F"2$
12"# 0mm dia, 20mm thic) inlation F00 (M $$7"#0
12"5 32 mm dia, 20mm thic) inlation 100 (M $3"3$
12"10 2$mm dia, 20mm thic) inlation 2700 (M 50"0012"11 20mm dia, 20mm thic) inlation 1$20 (M 31$"0
arrier Pipe: SM!S 8l)" ar+on Steel Pipe to APC $! Gr" 8, Sch" 0"
(igid Pol/rethane oam o denit/ $)g;m3, cc ree
GalvaniBed Steel piral otide loc)eamed 0"$mm <1$'12$mm?
GalvaniBed Steel piral otide loc)eamed 0"Fmm <1$0'#00mm?
13"00 5I5E/ INSU%ATI$N:
!'an(: S0,6/ INCE%%
Count'y of $'i)in: C2ina
S2ipment f'om: C2ina
13"1 2$ mm thic)" $$7F S.m 1$0"00
1"00 5I5E HAN6ER IS$%AT$R:
3'lot 500 mm length -ith lo- control damper hall +e -ith
12mm margin, i6ing cre- complete
Pre'inlated pipe hall +e +lac) teel pipe -ith inlation andalvaniBed heet metal cladded vapor +arrier" Pipe hall +eita+le to -ithtand a tet prere o 3F0pi" Pipe hall +e PEinlated" Pipe hall +e o ollo-ing nominal dia"
Cnlation or ppl/, retrn and reh air dctire proo gla -oolo treinorced alminm oil -ith pre'adheive" Thermal
condctivit/ hall not +e more than 0"2$ 8t"in;r" at $0 to50 mean temperatre"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 28/36
!'an(: Toma2a1*
Count'y of $'i)in: ,alaysia
S2ipment f'om: ,alaysia
1"1 200mm dia o" 1,507"00
1"2 1$0mm dia o" 1,717"00
1"3 100mm dia 12 o" 1,105"00
hiller Cntallation, !oading & nloading 1 !ot 2#0,000"00
A Cntallation, !oading & nloading 1 !ot 2#0,000"00
Pipe Cntallation, !oading & nloading 1 !ot 7F0,000"00
Total !"T
Te'ms & Con(itions:
1" 9er @alidit/: F0 Da/
2" Pa/ment Term: #0> Advance -ith valid -or) order, 10> dring Cntallation & ret 10> -ithin 7 da/ ater com
3" Deliver/ time: $0'F0 da/ ater receiving o -or) order
Than)ing /o,
,ana)in) "i'e8to'
(adiant Cnternational
Pipe anger iolator hall +e neoprene r++er -ith prStaticdelection hall not +e more than 2$mm" anger hall +e ita+leor ollo-ing dia o +lac) teel pipe o chedle 0<S?" angerhall +e e K ,$00mm"
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 29/36
T$TA% !"T#
2$,$00,000"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 30/36
5,200,000"00
1,350,000"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 31/36
723,F00"00
11$,000"00
33,000"00
F1$,000"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 32/36
21$,000"00
$2#,000"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 33/36
522,00"00
203,5F0"00
2,000,000"00
11$,000"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 34/36
32,#0"00
32,00"00
35,05F,000"00
2,523,200"00
F0F,5F0"00
721,200"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 35/36
$,FF,000"00
70#,320"00
32,50"00
#5,00"00
155,$20"00
5#,050"0
$,$01"00
5#,F1#"7$
33,F#0"00
$3,3$"00
1,323,000"0075,0#"00
#3F,00"00
7/24/2019 HVAC Quotation
http://slidepdf.com/reader/full/hvac-quotation 36/36
#3,50#"00
7$,$#"00
13,30#"00
2#0,000"00
2#0,000"00
7F0,000"00
=><?><@>.?
lete o the -or)"